Download Sony TRINITRON KV-T29SN81 User's Manual
Transcript
SERVICE MANUAL MODEL COMMANDER DEST. KV-T29SN81 CHASSIS NO. BG-1S CHASSIS MODEL COMMANDER DEST. CHASSIS NO. RM-870 New Zealand SCC-K37E-A TRINITRON ® COLOR TV KV-T29SN81 RM-870 SPECIFICATIONS Note Power requirements 110-240 V AC, 50/60 Hz Power consumption (W) Indicated on the rear of the TV Television system B/G Color system PAL, PAL 60, NTSC4.43, NTSC3.58 (AV IN) Stereo/Bilingual system NICAM Stereo/Bilingual B/G, A2 Stereo/Bilingual (German) B/G Teletext language English, German, Swedish, Italian, French, Spanish Channel coverage VHF: 1 to 11/UHF: E21 to E69/CATV: S01 to S03, S1 to S41 Audio output (speaker) 5W × 2 Inputs Antenna: 75 ohms VIDEO IN jacks: phono jacks Video: 1 Vp-p, 75 ohms Audio: 500 mVrms, high impedance Outputs Headphone jack: minijack MONITOR OUT jacks: phono jacks Video: 1 Vp-p, 75 ohms Audio: 500 mVrms Picture tube 29 in. Tube size (cm) 72 Measured diagonally Screen size (cm) 68 Measured diagonally Dimensions (w/h/d, mm) 686 × 617 × 537 Mass (kg) 43 Design and specifications are subject to change without notice. CAUTION SAFETY-RELATED COMPONENT WARNING!! SHORT CIRCUIT THE ANODE OF THE PICTURE TUBE AND THE ANODE CAP TO THE METAL CHASSIS, CRT SHIELD, OR CARBON PAINTED ON THE CRT, AFTER REMOVING THE ANODE. COMPONENTS IDENTIFIED BY SHADING AND MARK ! ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL TO SAFE OPERATION ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER CRITICAL COMPONENTS ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED. –2– KV-T29SN81 RM-870 TABLE OF CONTENTS Section Title Page SELF DIAGNOSIS REMOVAL ............................. 4 1. GENERAL .................................................................... 5 Section Rear Cover Removal ............................................ A Board Removal ................................................ F1 Board Removal ............................................... Service Position ................................................... Replacement of Parts ........................................... Demagnetization Coil Removal .......................... Picture Tube Removal .......................................... 11 11 11 11 12 12 13 5-1. 5-2. 5-3. (1) (2) (3) 5-4. Beam Landing ...................................................... Convergence ......................................................... Focus Adjustment ................................................ G2 (Screen) and White Balance Adjustments ..... 6-1. 4-4. Adjustments with Commander ............................ Adjustment Method ............................................. A Board Adjustment after IC003 (Memory) Replacement ......................................................... Picture Distortion Adjustment ............................. 25 29 33 38 45 49 Chassis .................................................................. 53 7. ELECTRICAL PARTS LIST ................................... 55 14 15 18 18 4. CIRCUIT ADJUSTMENTS 4-1. 4-2. 4-3. Block Diagram ...................................................... Circuit Boards Location ....................................... Schematic Diagrams and Printed Wiring Boards Schematic Diagram of A Board ........................... Schematic Diagrams of A3, F and V1 Boards ..... Schematic Diagrams of C and VM Boards .......... Semiconductors ..................................................... 6. EXPLODED VIEW 3. SET-UP ADJUSTMENTS 3-1. 3-2. 3-3. 3-4. Page 5. DIAGRAMS 2. DISASSEMBLY 2-1. 2-2. 2-3. 2-4. 2-5. 2-6. 2-7. Title 19 20 23 23 –3– KV-T29SN81 RM-870 SELF DIAGNOSIS FUNCTION If no acknowledgement is returned from a device which is turned "ON", the device has a problem. In this case, one of the LED's responding to the problem device will flicker a defined number of times. Flickering is operated by lighting the LED's for 60ss each time. The flickering frequency responding to each failed device is shown below. Device Flickering Frequency NONVOLATILE MEMORY — Y/C JUNGLE — — 1 — 3 — — All the devices are checked one after another from the left of the table. If an error is found, the responding LED will start flickering. So, if more than 1 device have failed, only the one on the left side will flicker. –4– AUDIO PROCESSOR (TDA8424) 6 SECTION 1 GENERAL The operating instructions mentioned here are partial abstracts from the Operating Instructions Manual. The page numbers of the Operating Instruction Manual remain as in this manual. AUTO PROGR AUTO PROGR –5– RM-870 3 KV-T29SN81 2 RM-870 Front of TV Connections Camcorder VIDEO 1 INPUT VIDEO AUDIO R L (MONO) to video and audio outputs : Signal flow Connecting a VHF antenna or a combination VHF/UHF antenna — 75-ohm coaxial cable (round) When using the video input jacks Do not connect video equipment to the video input jacks at the front and the rear (VIDEO IN 1 for this model) of your TV simultaneously; otherwise the picture will not be displayed properly on the screen. Attach an optional IEC antenna connector to the 75-ohm coaxial cable. Plug the connector into the (antenna) socket at the rear of the TV. Rear of TV Connecting audio/video equipment using MONITOR OUT jacks Rear of TV On a wall to antenna socket or Rear of TV AUDIO R 2 VIDEO IN 1 Connecting optional equipment Audio system VIDEO EN L (MONO) to antenna output VCR or MONITOR OUT –6– You can connect optional audio/video equipment to your TV such as a VCR, multi disc player, camcorder, video game or stereo system. MONITOR OUT to video and audio inputs : Signal flow Connecting video equipment using video input jacks to antenna socket : Signal flow Rear of TV AUDIO R 2 VIDEO IN 1 VIDEO L (MONO) to antenna output VCR When recording through the MONITOR OUT jacks If you change the channel or video input while recording with a VCR, the channel or video input you are recording also will be changed. CAUTION Do not connect the power cord until you have completed making all other connections; otherwise a minimum leakage current might flow through the antenna and other terminals to ground. MONITOR OUT VIDEO IN 1 or VIDEO IN 2 to video and audio outputs When connecting a monaural VCR Connect the yellow plug to VIDEO and the black plug to AUDIO-L (MONO). 4 Getting Started Getting Started 5 KV-T29SN81 Getting Started Operations Presetting channels Presetting channels manually Watching the TV To switch off the TV temporarily, press POWER on the remote commander. To change the channel for a particular program position or to receive a channel with a weak signal, preset the channel manually. 1 2 Presetting channels automatically 3 You can preset up to 80 TV channels in numerical sequence from program position 1. 2 4 1 Switching off the TV POWER Press MANUAL PROGR. Press PROGR +/– until the required program position appears on the screen. 1 To switch off the TV completely, press POWER on the TV. If the power on the TV is turned off in standby mode, the STANDBY indicator may remain alight for a while. Press POWER to turn the TV on. Press VOLUME +/– on the TV until the required channel picture appears on the screen. POWER POWER Press MANUAL PROGR. Front of TV Disabling program positions POWER COLOR SYSTEM –7– 1 SELECT TV SYSTEM MANUAL PROGR By disabling unused or unwanted program positions, you can skip those positions when you press PROGR +/–. AUTO PROGR 1 Press POWER. POWER When the TV is in standby mode after pressing POWER, press POWER on the remote commander. 2 Press AUTO PROGR. 1 2 3 4 2 3 Watching the video input Select the TV channel you want to watch. Press VIDEO/HOLD. VIDEO To select a channel directly Press a number button. Press PROGR +/– until the unused or unwanted program position appears on the screen. Press MANUAL PROGR. 1 2 4 5 6 7 8 9 HOLD 3 VIDEO 1 VIDEO 2 1 0 Press PIC MODE on the remote commander. To select a two-digit channel, press “-/- -” before the number buttons. For example: to select channel 25, press “-/- -,” and then “2” and “5.” Press MANUAL PROGR. To cancel the skip setting Preset the channel manually or automatically again. 2 When the TV is in standby mode after pressing POWER, press POWER on the remote commander. 2 1 To watch TV, press TV. TV 5 Muting the sound AUTO PROGR To scan through channels Press PROGR +/– until the channel you want appears. To start presetting channels automatically from the specified program position 1 Press MANUAL PROGR. 2 Press PROGR +/– to select the program position. 3 Press AUTO PROGR. Press MUTING. MUTING PROGR 3 Press VOL +/– to adjust the volume. MUTING Getting Started Operations 7 RM-870 KV-T29SN81 VOL 6 DISPLAY REVEAL Each time you press SELECT, the screen changes as follows: Adjusting the picture and sound PICTURE COLOR (Operative for KV-T29 only) BRIGHT (Operative for NTSC signal only) Setting the Sleep Timer HUE TILT CORRECTION + or – SELECT PIC MODE You can set the TV to turn off automatically after the period of time you want. 1 AUTO B/G STANDARD Press SLEEP. SLEEP SHARPNESS SURROUND Selecting the picture mode Setting the Wake Up Timer BALANCE SLEEP TIMER:30 You can set the TV to turn on automatically after the period of time you want. 1 After 30 minutes SLEEP TIMER:60 After 60 minutes SLEEP TIMER:OFF No sleep timer After 90 minutes –8– To cancel the Sleep Timer, press SLEEP repeatedly until “SLEEP TIMER: OFF” appears, or turn the TV off. Each time you press PIC MODE, the screen changes as follows: High contrast picture Changing the on-screen display language DYNAMIC WAKE UP TIMER:00H10M After 10 minutes 2 WAKE UP TIMER:OFF WAKE UP TIMER:12H00M No wake up timer After 12 hours If you want a particular TV program or video input to be displayed using the Wake Up Timer, select the TV program or video mode. If you prefer Chinese to English, you can change the on-screen display language. You can use buttons on both the remote commander and the TV. + or SELECT 1 Press SELECT until the screen appears as follows: Press POWER on the remote commander or set the Sleep Timer to turn off the TV in standby mode. Press + or – to adjust the item. SOFT STANDARD 3 To adjust other items, repeat steps 1 and 2. Note • You can also use VOLUME +/– on the TV to adjust the picture and sound settings. Note Adjusting the picture and sound settings If the color of the picture is abnormal Press COLOR SYSTEM or adjust the color setting until the color becomes normal. Note • Normally set COLOR SYSTEM to AUTO. Front of TV 2 LANGUAGE / Press + or – to select “ : ENGLISH ”. 1 Press SELECT until the item you want to adjust appears. SELECT To cancel the Wake Up Timer, press WAKE UP/INDEX repeatedly until “WAKE UP TIMER: OFF” appears, or turn off the main power of the TV. COLOR SYSTEM LANGUAGE / SELECT TV SYSTEM MANUAL PROGR AUTO PROGR : Note Notes • The Wake Up Timer starts immediately after the on-screen display disappears. 8 2 Soft picture (good for video games) • If you change the picture mode after the following adjustments, the adjustment changes in accordance with the picture mode. SELECT 3 • The earth's magnetic field may affect the tilt of the TV picture. You can adjust the picture tilt using TILT CORRECTION. SLEEP TIMER:90 WAKE UP INDEX WAKE UP TIMER:00H00M BASS Note on TILT CORRECTION (KV-T29 only) PIC MODE Press WAKE UP/INDEX repeatedly to set the timer. The on-screen display appears and the WAKE UP indicator lights up. TREBLE Press PIC MODE until the mode you want appears. Operations • You can also use VOLUME +/ – on the TV to select the onscreen display language. Operations 9 RM-870 Press DISPLAY/REVEAL. The program position, local system, and TV settings are displayed on the screen. • The last TV program position or video mode just before the TV turns into Standby mode will appear when the TV turns on using the Wake Up Timer. • If no buttons or controls are pressed for more than two hours after the TV is turned on using the Wake Up Timer, the TV automatically turns into standby mode. When you want to continue watching the TV, press any button or control on the TV or remote commander. KV-T29SN81 Displaying on-screen information Selecting a stereo or bilingual program System Receiving area Press the color button which corresponds to the colorcoded menu. The page is displayed after a few seconds. NICAM Hong Kong, Singapore, New Zealand, etc. Selecting a Teletext page A2 (German) Australia, Malaysia, Thailand, etc. Receiving area for NICAM and A2 (German) programs Viewing Teletext To input the three-digit page number of the Teletext page, press the number buttons. If you make a mistake, key in the correct page number again. Notes Press A/B/ENLARGE repeatedly until you receive the sound you want. The on-screen display changes corresponding to the selected sound and the WAKE UP/STEREO indicator also lights up. • If the signal is very weak, the sound becomes monaural automatically. • If the stereo sound is noisy, select “regular sound.” The sound becomes monaural, however, the noise will be reduced. To access the next or previous page, press PROGR +/–. DISPLAY/REVEAL TEXT VIDEO/HOLD TV Holding a Teletext page (subpage) Number Press VIDEO/HOLD. The HOLD symbol “j” is displayed at the top left corner of the screen. TEXT CLR FASTEXT A/B/ENLARGE WAKE UP/INDEX A/B ENLARGE PROGR +/– To resume normal Teletext operation, press VIDEO/ HOLD again or TEXT. Revealing concealed information Displaying Teletext When receiving a NICAM program –9– NICAM z(Stereo sound) NICAM stereo NICAM bilingual 1 Select a TV channel which carries the Teletext broadcast you want to watch. On-screen display (Selected sound) Broadcasting z NICAM monaural NICAM MAIN z (Main sound) z NICAM MAIN (Main sound) z Enlarging the Teletext display 2 Press TEXT to display the Teletext. NICAM z MONO (Regular sound) NICAM SUB z (Sub sound) NICAM MONO (Regular sound) NICAM MONO (Regular sound) A Teletext page is displayed (normally the index page). If there is no Teletext broadcast, 100 is displayed at the top left corner of the screen. Superimposing a Teletext page on the TV picture Press TEXT. Each time you press TEXT, the screen changes as follows: z Teletext and TV z TV When receiving a A2 (German) program A2 (German) stereo A2 (German) bilingual On-screen display (Selected sound) STEREO (Stereo sound) STEREO z MAIN (Main sound) STEREO z SUB (Sub sound) Press A/B/ENLARGE. Each time you press A/B/ENLARGE, the Teletext display changes as follows: z Enlarge upper half To cancel the Teletext display, press TV. z Teletext Broadcasting Press DISPLAY/REVEAL. To conceal the information, press DISPLAY/REVEAL again. z Enlarge lower half z Normal size Waiting for a Teletext page while watching a TV program (TEXT CLEAR) 1 Key in the page number of the Teletext that you want to refer, then press TEXT CLR. 2 When the page number is displayed on the screen, press TEXT to switch the Teletext on. Checking the contents of a Teletext service (INDEX) Press WAKE UP/INDEX to display an overview of the Teletext contents and page numbers. Using FASTEXT This feature allows you to quickly access a Teletext page that uses FASTEXT. When a FASTEXT page is broadcasted, a color-coded menu appears at the bottom of the screen. The colors of the menu correspond to the RED, GREEN, YELLOW, and CYAN buttons on the remote commander. Operations Operations 11 RM-870 KV-T29SN81 10 If you have any problems, read this manual again and check the countermeasure for each of the symptoms listed below. If the problem persists, contact your nearest authorized service center or dealer. No picture No sound / Press POWER. / Check the antenna connection. / Check the VCR connections. / Check the power cord connection. / Check the standby mode. Good picture No sound Snowy picture Noisy sound / Press VOLUME +. / Press MUTING. / Press A/B/ENLARGE – 10 – / Check the antenna. / Check the antenna connection on the TV and on the wall. No color Dotted lines or stripes / This may be caused by local interference (e.g. cars, neon signs and hair dryers). Adjust the antenna for minimum interference. Double images or “ghosts” / Adjust the COLOR level in the on-screen display. / Check the COLOR SYSTEM setting. TV cabinet creaks / Even if the picture or the sound is normal, changes in the room temperature sometimes make the TV cabinet expand or contract, making a noise. This does not indicate a malfunction. Note on the remote commander / This may be caused by reflections from nearby mountains or buildings. A highly directional antenna may improve the picture. Note on the TV SYSTEM button Notes • When you switch on the TV, you may hear the “boon” sound that is caused by the demagnetization of the TV. This does not indicate a malfunction. • The picture color may become abnormal if you change the direction of your TV. To obtain the normal picture color , press POWER on the TV to switch off the TV for five minutes and then switch it on again. 12 • The supplied remote commander is used on several models of the TV. If you do not find instructions for some controls that are on the remote commander, that means your TV does not employ the features of those controls, e.g. TEXT. Additional Information • The TV SYSTEM button is not used on your TV. WARNING Do not install the appliance in a confined space, such as a bookcase or built-in cabinet. RM-870 Troubleshooting KV-T29SN81 Additional Information SECTION 2 DISASSEMBLY 2-3. F1 BOARD REMOVAL 2-1. REAR COVER REMOVAL F1 board 2 Three screws (BVTP 4×16) 4 One screw (BVTP 3×16) – 11 – 1 Three screws (BVTP 4×16) 2-2. A BOARD REMOVAL 2-4. SERVICE POSITION A board Lever RM-870 A board KV-T29SN81 Lever RM-870 For replacement of the Multi Button, Power Button and Light Guide, cut the welded portions from them, exchange with the new parts, and fix them with screws (+BVTP) respectively. 2-5-1. REPLACEMENT OF MULTI BUTTON 2 DGC holder Remove the claw Two screws (BVTP 3×12) 3 Demagnetization coil 1 DGC band – 12 – 2-5-2. REPLACEMENT OF LIGHT GUIDE POWER BUTTON 4 Tension spring Light guide Cut Power button Two screws (BVTP 3×12) Picture tube KV-T29SN81 2-6. DEMAGNETIZATION COIL REMOVAL 2-5. REPLACEMENT OF PARTS 2-7. PICTURE TUBE REMOVAL NOTE : The picture tube for this model is upside-down and the position for the anode-cap and tension spring is changed accordingly b 3 F1 board b 4 C board 5 VM board 6 Deflection yoke 2 A board 7 Four screws (Tapping screws) 2 Using a thumb press down then pull up the rubber cap firmly in the direction indicated by the arrow b. c 1 Anode cap – 13 – Anode button Button Anode 3 When one side of the rubber cap is separated from the anode button, the anodecap can be removed by turning up the rubber cap and pulling it up in the direction of the arrow c. Cushion • •REMOVAL OF ANODE-CAP NOTE : After removing the anode, short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon paint on the CRT. •REMOVING PROCEDURES HOW TO HANDLE AN ANODE-CAP 1 Do not damage the surface of anode-caps with sharp shaped objects. 2 Do not press the rubber too hard so as not to damage the inside of anode-caps. A metal fitting called the shatter-hook terminal is built into the rubber. 3 Do not turn the foot of rubber over too hard. The shatter-hook terminal will stick out or damage the rubber. a a RM-870 KV-T29SN81 1 Turn up one side of the rubber cap in the direction indicated by the arrow a. KV-T29SN81 RM-870 SECTION 3 SET-UP ADJUSTMENTS • • The following adjustments should be made when a complete realignment is required or a new picture tube is installed. These adjustments should be performed with rated power supply voltage unless otherwise noted. Controls and switch should be set as follows unless otherwise noted: PICTURE control ........................................................... normal BRIGHTNESS control ................................................... normal Perform the adjustments in order as follows : 1. Beam Landing 2. Convergence 3. Focus 4. White Balance Note : Test Equipment Required. 1. Color-bar/Pattern Generator 2. Degausser 3. Oscilloscope ................................................................................................................................................................................................................................ Preparation : • In order to reduce the influence of geomagnetism on the set's picture tube face it east or west. • Switch on the set's power and degauss with the degausser. Purity control 3-1. BEAM LANDING 1. Input a white signal with the pattern generator. Contrast normal Brightness 2. Position neck assy as shown in Figure 3-1. 3. Set the pattern generator raster signal to green. 4. Move the deflection yoke to the rear and adjust with the purity control so that the green is at the center and the blue and the red take up equally sized areas on each side. (See Figures 3-1 through 3-3.) 5. Move the deflection yoke forward and adjust so that entire screen is green. (See Figure 3-1.) 6. Switch the raster signal to blue, then to red and verify the condition. 7. When the position of the deflection yoke has been decided, fasten the deflection yoke with the screws. 8. If the beam does not land correctly in all the corners, use a magnet to adjust it. (See Figure 3-4.) } Fig. 3-2 BLUE RED GREEN Fig. 3-3 Purity control corrects this area. Neck assy a b c d Disk magnets or rotatable disk magnets correct these areas (a-d). Deflection yoke positioning corrects these areas. a c G1 G2 G3 b Fig. 3-1 d – 14 – Fig. 3-4 KV-T29SN81 RM-870 • 3-2. CONVERGENCE Preparation : • Before starting this adjustment, adjust the focus, horizontal size, and vertical size. • Minimize the brightness setting. • Provide dot pattern. If the V.STAT magnet is moved in the direction of the a and b arrows, the red, green, and blue points move as shown below. 1 a a b (1) b Horizontal and Vertical Static Convergence Center dot b B B G G R R 2 R a a G B R G R B H.STAT V.STAT Magnet b G B b B G R 3 b RV 702 H.STAT a a b R B G b RV 701 SCREEN (G2) C board 1. (Moving vertically), adjust the V.STAT magnet so that the red, green, and blue points are on top of each other at the center of the screen. 2. (Moving horizontally), adjust the H.STAT VR magnet so that the red, green, and blue points are on top of each other at the center of the screen. – 15 – G B R KV-T29SN81 RM-870 • Operation of BMC (Hexapole) Magnet If the red, green and blue dots are not balanced or aligned, then use the BMC magnet to adjust in the manner described below. R G B R G B R G B • Y separation axis correction magnet adjustment. 1. Receive the cross-hatch signal and adjust [PICTURE] to “MIN” and [BRIGHTNESS] to “STANDARD” . 2. Adjust the Y separation axis correction magnet on the neck assembly so that the horizontal lines at the top and bottom of the screen are straight. Red Blue Neck assy R G B R G B Neck assy G R B Red VM board • Then use the H.STAT VR to adjust the red, green, and blue dots so that they coincide at the center of screen. The respective dot position resulting from moving each magnet interact, so be sure to perform adjustment while tracking. BMC (Hexapole) Blue VM board Note: 1) The Red and Blue magnets should be equally far from the horizontal center line. 2) Do not separate the Red and Blue magnets too far. (Less than 8 mm) Purity V.STAT – 16 – KV-T29SN81 RM-870 (2) Dynamic Convergence Adjustment Preparation : • Before starting this adjustment, adjust the horizontal static convergence and the vertical static convergence. 1. Slightly loosen the deflection yoke screws. 2. Remove the deflection yoke spacer. 3. Move the deflection yoke as shown in the figure below and optimize the convergence. 4. Tighten the deflection yoke screws. 5. Install the deflection yoke spacer. R B B G R R G B G G B R B R G B B G G R R G B R B R R G B B G R G G R B (3) Screen-corner Convergence a b b a-d : screen-corner misconvergence c Fix a Permalloy assy corresponding to the misconverged areas a d c d Permalloy assembly – 17 – KV-T29SN81 RM-870 DATA 3-3. FOCUS ADJUSTMENT Adjust FOCUS control on the flyback transformer for the best focus. 09 RDR 1F SERVICE Adjustment Item Item number 09 RDR 1F WRITE MUTING 0 Executes the writing Focus 3-4. G2 (SCREEN) AND WHITE BALANCE ADJUSTMENTS Note: Screen VR is not use. 1. 1) 2) 3) 4) a. AN ITEM OF ADJUSTMENT Item number 09 0A 0B Adjustment Initial DATA item RDR 25 GDR 20 BDR 20 Note WHITE POINT R WHITE POINT G WHITE POINT B b. METHOD OF CANCELLATION FROM SERVICE MODE Set the standby condition (Press [POWER] button on the commander) and then press [POWER] button again, hereupon it becomes TV mode. G2 (SCREEN) ADJUSTMENT (RV701) Set the PICTURE and BRIGHTNESS to normal. Put to VIDEO input mode without signals. Connect R, G, and B of the C board cathode to the oscilloscope. Adjust G2 (RV701) volume to the value below. 177 V DC 180 ±V 2DC 0V c. 1) 2) 3) 4) METHOD OF WRITE FOR MEMORY Set to Service Mode. Press 1 (UP) and 4 (DOWN) to select an item of adjustments. Press [MUTING] button and it will indicate WRITE on screen. Press - button to write into memory. d. MEMORY WRITE CONFIRMATION METHOD 1) After adjustment, pull out the plug from AC outlet, and then plug into AC outlet again. 2) Turn the power switch ON and set to Service Mode. 3) Call the adjusted items again, confirm they were adjusted. 2. 1) 2) 3) 4) WHITE BALANCE ADJUSTMENTS Set the Service Mode. Input an entire white signal. Set the PICTURE to maximum. Select RDR(09) with 1 and 4 , and then set the level to 25 with 3 and 6 . 5) Select GDR(0A) and BDR(0B) with 1 and 4 and adjust the level with 3 and 6 for the best white balance. 6) Write into the memory by pressing [MUTING] → then - . – 18 – KV-T29SN81 RM-870 SECTION 4 CIRCUIT ADJUSTMENTS 4-1. ADJUSTMENTS WITH COMMANDER Service adjustments are made with the RM-870 that comes with this unit. Entering service mode With the unit on standby ↓ DISPLAY ↓ 5 ↓ VOL (+) [1], [4] [3], [6] [MUTING] [0] Raise/lower the service item number Raise/lower the data Writes Executes the writing [7], [0] [8], [0] [5], [0] The data all becomes the values in memory User control all goes to the standard state Service data initialization (Be sure not to use usually.) Write 50Hz adjustment data to 60Hz, or viceversa. [2], [0] ↓ POWER The operation sequence puts the unit into service mode. The screen display is : Adjustment item DATA MUTING TEXT DISPLAY REVEAL POWER VIDEO HOLD TV 1 2 3 4 5 6 7 8 9 ÷ 0 TEXT CLR + A/B ENLARGE WAKE UP INDEX 00 VOL PROGR 0000 1000 SERVICE 50 Mode Depends on the signals NTSC Item number [1], [4] ↓ [3], [6] ↓ [MUTING] ↓ [0] PIC MODE + 08 PAL, SECAM : 50 SELECT + RGB SLEEP RM-870 – 19 – Select the adjustment item. Raise/lower the data. Writes Executes the writing. : 60 KV-T29SN81 RM-870 4-2. ADJUSTMENT METHOD Item Number 08 This explanation uses V-SHIFT as an example. 1. Select 08 V-SHIFT with the [1] and [4] buttons. 2. Raise/lower the data with the [3] and [6] buttons. 3. Select the optimum state. (The standard is 0F for PAL reception.) 4. Write with the [MUTING] button. 5. Execute the writing with the [0] button. (The WRITE display returns to green SERVICE.) 08 VSF 0C SERVICE Use the same method for Items Number 00-4B. Use [1] and [4] to select the adjustment item, use [3] and [6] to adjust, write with [MUTING], then execute the write with [0]. GREEN 50 Adjust with the and buttons. Adjusted with “3”[3] and “6” [6] buttons 08 VSF 0C WRITE GREEN 50 Writtenwith with the “MUTING” Written [MUTING]. 08 VSF 0C WRITE 50 GREEN The WRITE WRITE display dispaly be changed will change back back to to SERVICE. SERVICE. Write executed “0”[0]. Write executedwith with – 20 – KV-T29SN81 RM-870 Adjustment Item Table Item Adjustment number Item Data range Initial data Standard data Note Device 00 01 02 03 04 05 06 07 08 HSF HSZ PAP CNP TLT VSL VAP SCR VSF 00–3F 00–3F 00–3F 00–3F 00–3F 00–3F 00–3F 00–3F 00–3F 2 23 21 29 20 20 1D 20 20 H SHIFT H SIZE PIN AMPLITUDE CORNER PIN TILT V SLOPE V AMPLITUDE S CORRECTION V SHIFT TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A 09 0A 0B RDR GDR BDR 00–3F 00–3F 00–3F 25 20 20 WHITE POINT R WHITE POINT G WHITE POINT B TDA8375A TDA8375A TDA8375A 0C 0D 0E FO AGC VSW 00–03 00–3F 00–01 00 30 00 PHI-1 TIME CONSTANT AGC TAKE OVER VIDEO MUTE TDA8375A TDA8375A TDA8375A 0F 10 11 FOR DL POC 00–03 00–01 00–01 00 00 00 FORCED FIELD FREQ. INTERLACE SYNCHRO MODE FIX TDA8375A TDA8375A TDA8375A 12 13 14 15 16 VID HCO EVG SBL PRD 00–01 00–01 00–01 00–01 00–01 00 00 00 00 00 VIDEO IDENT MODE EHT TRACKING MODE ENABLE V GUARD SERVICE BLANKING OVER-VOLTAGE INPUT TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A 17 18 19 1A 1B COR PMX PMI SBR SHU 00–01 00–3F 00–3F 00–7F 00–0F 00 27 05 4B 07 NOISE CORING PEAK PICTURE MAX DATA PICTURE MIN DATA SUB-BRIGHTNESS SUB-HUE TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A 1C 1D 1E 1F 20 SSH SC1 SC2 AIP VZM 00–03 00–3F 00–3F 00–7F 00–3F 01 1F 0B 3F 19 SUB-SHARPNESS SUB-COLOR LOWER SUB-COLOR HIGHER ADJUSTMENT IF PLL VERTICAL ZOOM TDA8375A TDA8375A TDA8375A TDA8375A TDA8375A 21 22 23 24 25 26 27 28 29 2A 2B 2C 2D 2E 2F 30 31 32 33 FAW CTM CTN WCD WST WTM WBT ACG CDB FGP FMP WGP NIP CRM CML ACO WAC DLY DLG 00–FF 00–FF 00–FF 00–FF 00–FF 00–FF 00–FF 00–01 00–3F 00–7F 00–7F 00–7F 00–7F 00–01 00–03 00–01 00–01 00–FF 00–FF 08 08 50 0A 15 50 EA 01 28 24 40 3C 7F 00 00 01 01 30 10 NICAM FAW THRESH NICAM ERROR BIT (MONO) NICAM ERROR BIT (NICAM) W. G. CHANGE DATA W. G. STEREO CUT POINT W. G. TIMER CHANGE W. G. BILINGUAL AGC AUTO/CONST. AGC GAIN CONST. FM (BG, I, DK) PRESCALE FM (M) PRESCALE W. G. PRESCALE NICAM PLESCALE CARRIER MUTE CARRIER MUTE LEVEL AUDIO CLOCK OUT W. G. AGREEMENT COUNT STEREO SEARCH DELAY INTERVAL OF ID CHECK MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 MSP3410 34 35 TXP MXP 00–0F 00–0F 09 0D TEXT PICTURE CONT. TEXT MIX MODE PICTURE SAA5281 SAA5281 – 21 – KV-T29SN81 RM-870 Adjustment Item Table Item number Adjustment Item Data range Initial data BKP HBL HBR VBH VBL ODL OFR OFM OSH DKS MUT DWZ ABL DTV SCM ROC ROS DVM FBT OP0 OP1 OP2 00–3F 00–3F 00–3F 00–7F 00–FF 00–FF 00–0F 00–0F 00–3F 00–01 00–01 00–01 00–01 00–01 00–01 00–0F 00–07 00–01 00–01 00–FF 00–FF 00–FF 00 25 20 00 FF 10 00 00 0A 00 01 00 01 00 00 07 03 00 00 40 07 00 36 37 38 39 3A 3B 3C 3D 3E 3F 40 41 42 43 44 45 46 47 48 49 4A 4B Standard data Note Device BLK OFF PICTURE H BLK LEFT WIDTH H BLK RIGHT WIDTH V BLK HIGHT WIDTH V BLK LOW WIDTH POWER ON DELAY STBY n ON RGB OUT MAIN POWER RGB OUT OSD POSITION H D/K NICAM NO SYNC. MUTE DISABLE WIDEZOOM BRIGHT ABL DISABLE TV SYSTEM KEY SECAM TRAP ACTIVE ROTATION CENTER ROTATION STEP WIDTH DISABLE VM MUTE C/M FOR FBT LAYER SHORT OPTION 0 OPTION 1 OPTION 2 u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON u.CON NOTE • Standard Data: • • • Those are the standard data values written on the microprocessor. Therefore, the data values of the modes are stored respectively in the memory. In case of a device replacement, adjustment by rewriting the data value is necessary for some items. 50 ...................... 50 Hz data 60 ...................... 60 Hz data Standard data listed on the adjustment item table are reference values, therefore it is different for every model. ITEM INFORMATION • 10. DL: TV/MIX Mode 0=Interlace 1=interlace, TEXT Mode 0=interlace 1=Interlace • 42. ABL: Bright ABL ON/OFF ON=1 OFF=0 • 49. OP0 • 4A. OP1 • 4B. OP2 Input data are different according to models. AV INPUT : 00 → NO MODEL, 01 → MONO, CXA1315, 10/11 → STEREO, TDA8424 TV System : 00 → Multi model, 01 → B/G, 10 → D/K.I, 11 → B/G D/K NTSC, SECAM, Chin Shrp : Dynamic Mode @ 1 → Sharpness 50%, 0 → Sharpness 70%. VM Operation : 0 → OFF, 1 → ON No. 49 OP0 * Input data are different according to models Item – AV Input Shrp 50% Remote preset Auto program Video Text KV-T29SN81 0 1 1 Item – Tilt – KV-T29SN81 0 1 0 1 0 Reserved 0 0 0 NTSC 3.58 SECAM Chinese 1 1 0 1 High Dev. 100 Prg. 4:3 Wide S Video 0 0 0 0 No. 4A OP1 TV System 0 No. 4B OP2 Item – KV-T29SN81 0 Sound Mode Child Lock Sound Effect 0 0 0 – 22 – KV-T29SN81 RM-870 4-3. A BOARD ADJUSTMENT AFTER IC003 (MEMORY) REPLACEMENT 4-4. PICTURE DISTORTION ADJUSTMENT Item Number 00 – 08 1. Enter to Service Mode. (H SHIFT) 0000 HSFHSF (H SHIFT) 2. Press commander buttons [5] and [0] (Data Initialize), and [2] and [0] (Data Copy) to initialize the data. 3. Call each item number, and check if the respective screen shows the normal picture. In case some items are not well-adjusted, give them fine adjustment. Write the data per each item number ([MUTING] + [0]). (H SIZE) 0101 HSZHSZ (H SIZE) AMP) 0202 PAPPAP (PIN(PIN AMPLITUDE) 4. Select item numbers “49” (OP0), “4A” (OP1) and "4B" (OP2) respectively set the bit per model with command buttons [3] and [6]. (CORNER PIN) 0303 CNPCNP (CORNER PIN) 5. Press commander buttons [8] and [0] (Test Normal) to return to the data that was set on the shipment from the factory. (= Cancel Service Mode.) 0404 TLTTLT (TILT) (TILT) 0505 VSLVSL (V SLOPE) (V SLOP) 0606 VAPVAP (V AMPLITUDE) (V ANP) (S CORRECTION) 0707 SCRSCR (S CORRECTION) (V SHIFT) 0808 VSFVSF (V SHIFT) – 23 – KV-T29SN81 RM-870 MEMO ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ – 24 – KV-T29SN81 KV-T29SN81 KV-T29SN81 RM-870 RM-870 RM-870 5-5. SEMICONDUCTORS DIODE TRANSISTOR D1NL20 EL1Z GP08D HZT33-02TE RGP02-17EL-6433 ERC06-15S S3L20UF4 ERD29-08J RU4DS CATHODE CATHODE CATHODE IC DTA114EKA-T146 DTC114EKA-T146 DTC143TKA-T146 DTC144EK TR DTC144EKA 2SA1037K-T-146-QR 2SA1162-G 2SC1623-L5L6 2SC2712-YG 2SC2669-0 E ANODE ANODE ST24C08FB (8PIN) CXA1110BS (30PIN) CXA1315P (16PIN) CXP85224A-072S (64PIN) NJM2903D (8PIN) NJM2904D (8PIN) P83C654FBP/540 (40PIN) SAA5281ZP/E (52PIN) TDA4665T/V5-118 (16PIN) TDA8366/N3D (56PIN) TDA8375A (56PIN) TDA8424 (20PIN) TDA9821 (16PIN) C B C ANODE 2SC4793 B LN4SB60 E RD3.6M-B2 RD5.6M-B2 STR-S6708N UPC574J MARKING SIDE VIEW 1 Zig-zag In -line Package Pin 6~99 ANODE CATHODE PQ09RA1 UPC4558G2 (8PIN) 2SA1091-0 2SC2551-0 1 TOP VIEW B 3 C Dual In-line Package Pin 6~98 E 2 1 1 2SC4927-01 3 12 TOP VIEW 34 NJM2234L L78LR05D-MA 2 LNK0220022G Single In -line Package Pin 6~98 E C B 1 NJM78L12A 2SA1175-HFE 2SC2410SN 2SC2785-HFE DA204K 1 D1 G1 S1 NC 3 2 1 G2 D2 2 LETTER SIDE 2 2SA1837 2SD2394-EF 2SD2394-F 1 3 2 4 1 3 2 8 S2 4 MSP3410D-PP-B4 PC123F2 1 4 1 1 2 3 3 DTZ9.1 MA113-TX RD13ES-B2 RD2.2ES-B2 RD3.6ES-B1 RD39ES-B2 RD4.7ES-B2 RD5.1ES-B1 1SS119-25 DAN202K 3 2 LA7845 E C B 1 2 2SC2958 2SC3209LK 2SC3733 2SD774-34 TOP VIEW B C E SBX1981-11 Quad Flat J-leaded Package Pin 20~996 1 3 TA7805S 2 ANODE 1 TA8223K CATHODE E C B DAP202K RD9.1ES-L2 SE135N 2SC2611 3 LETTER SIDE 1 2 1 3 15 2 1 E – 50 – C B – 51 – – 52 – KV-T29SN81 KV-T29SN81 RM-870 RM-870 SECTION 6 EXPLODED VIEW NOTE: • Items with no part number and no description are not stocked because they are seldom required for routine service. • The construction parts of an assembled part are indicated with a collation number in the remark column. • Items marked " * " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The components identified by shading and mark ! are critical for safety. Replace only with part number specified. 6-1. CHASSIS [: BVTP3 × 12 7-685-648-79 L: BVTP4 × 16 7-685-663-71 8: BVTP3 × 16 7-685-650-79 28 p 25 4 24 19 41 10 27 9 21 42 11 26 20 8 44 r 16 18 17 23 22 4 15 13 14 r 5 12 6 31 r 32 11 r 2 33 10 7 8 34 35 9 36 37 38 4 DESCRIPTION 1 2 3 4 5 4-053-733-11 4-048-540-01 ! X-4033-773-13 4-048-691-01 4-048-687-01 DOOR, CONTROL CUSHION, CRT BEZNET ASSY HANDLE BUTTON, MULTI 6 7 8 9 10 4-049-123-01 4-053-732-01 1-503-902-11 * 4-379-189-11 4-054-981-01 11 12 13 14 4-046-765-01 ! 8-733-868-05 ! 8-451-467-21 4-034-272-01 4-034-272-11 4-034-272-41 4-049-122-01 40 43 45 1 REF. NO. PART NO. 39 29 30 3 15 16 17 18 19 20 21 22 23 24 25 – 53 – REMARK REF. NO. PART NO. DESCRIPTION 2, 5-7, 43 26 27 28 29 30 4-049-416-01 ! X-4033-774-1 4-049-130-01 * 4-048-690-01 * 4-048-689-01 SHEET, BLIND REAR COVER ASSY CLAMPER, CORD RAIL (L), GUIDE RAIL (R), GUIDE GUIDE, LIGHT BUTTON, POWER SPEAKER (15X6.5 CM) CUSHION, SPEAKER SCREW, STEP TAPPING 31 32 33 34 35 * * * * ! A-1241-269-A 4-049-158-01 A-1347-103-A A-1297-523-A 8-598-323-50 F1 BOARD, MOUNTED BRACKET, F1 PC BOARD V1 BOARD, COMPLETE A3 BOARD, COMPLETE TUNER, VSS BT-AG401 SCREW, TAPPING 7+CROWN WASHER PICTURE TUBE (M68KZT71X) DEFLECTION YOKE (Y29GXA2-S) PLATE, CORRECTION, TLV PLATE, CORRECTION, TLV PLATE, CORRECTION, TLV RIVET 36 37 38 39 40 ! ! * ! ! 1-900-700-27 1-453-219-11 A-1298-958-A 4-389-778-11 1-574-358-51 LEAD ASSY, FOCUS TRANSFORMER ASSY, FLYBACK (NX-4002//M3J4) A BOARD, COMPLETE HOLDER, AC CORD CORD, POWER (WITH CONNECTOR) 7.5A/250V 1-452-762-31 NECK ASSEMBLY NA294 * A-1347-116-A VM BOARD, COMPLETE * A-1331-740-A C BOARD, MOUNTED * 4-045-290-11 CUSHION (50X290), DGC 4-046-600-11 SPACER, DY * 3-704-372-11 4-369-318-61 ! 1-403-672-12 1-900-700-10 * 4-043-036-01 41 42 43 44 45 HOLDER, HV CABLE SPRING, TENSION COIL, DEMAGNETIZATION DGC BAND HOLDER, DGC – 54 – 1-452-032-00 X-4387-214-3 4-047-464-01 1-452-278-22 1-452-278-32 * 4-053-736-01 MAGNET,DISC PERMALOY ASSY, CORRECTION CATCHER, PUSH MAGNET, PURITY MAGNET, PURITY LABEL, PROTECTION REMARK 26 KV-T29SN81 KV-T29SN81 RM-870 RM-870 SECTION 7 ELECTRICAL PARTS LIST NOTE: The components identified by shading and mark ! are critical for safety. Replace only with part number specified. • Items marked " ∗ " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. When indicating parts by reference number, please include the board name. • All variable and adjustable resistors have characteristic curve B, unless otherwise noted. REF.NO. PART NO. DESCRIPTION REMARK * A-1298-958-A A BOARD,COMPLETE ********************* * 1-580-798-11 * 4-049-131-01 4-352-844-01 4-382-854-11 7-682-950-01 CONNECTOR PIN (DY) 6P CASE (A), SHIELD PIN, LEAD, COATING SCREW (M3X10), P, SW (+) SCREW +PSW 3X12 <CAPACITOR> C001 C002 C004 C007 C008 1-163-011-11 1-126-965-11 1-126-961-11 1-126-959-11 1-163-117-00 CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP 0.0015MF 22MF 2.2MF 0.47MF 100PF 10% 20% 20% 20% 5% 50V 50V 50V 50V 50V C009 C010 C011 C013 C014 1-163-133-00 1-163-037-11 1-104-664-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 470PF 0.022MF 47MF 0.001MF 0.001MF 5% 10% 20% 10% 10% 50V 50V 16V 50V 50V C015 C016 C017 C018 C019 1-101-884-00 1-101-884-00 1-163-117-00 1-163-117-00 1-163-009-11 CERAMIC CERAMIC CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 56PF 56PF 100PF 100PF 0.001MF 5% 5% 5% 5% 10% 50V 50V 50V 50V 50V C020 C021 C022 C023 C024 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001MF 0.001MF 0.001MF 0.001MF 0.001MF 10% 10% 10% 10% 10% 50V 50V 50V 50V 50V C025 C026 C027 C028 C029 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001MF 0.001MF 0.001MF 0.001MF 0.001MF 10% 10% 10% 10% 10% 50V 50V 50V 50V 50V C034 C035 C036 C037 C038 1-164-004-11 1-163-009-11 1-163-009-11 1-163-117-00 1-163-117-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 0.001MF 0.001MF 100PF 100PF 10% 10% 10% 5% 5% 25V 50V 50V 50V 50V C040 C042 C044 C045 C046 1-163-117-00 1-163-117-00 1-163-117-00 1-163-117-00 1-163-117-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 100PF 100PF 100PF 5% 5% 5% 5% 5% 50V 50V 50V 50V 50V C047 C048 1-163-117-00 1-164-004-11 CERAMIC CHIP CERAMIC CHIP 100PF 0.1MF 5% 10% 50V 25V REF.NO. PART NO. A • All resistors are in ohms • F : nonflammable CAPACITORS • MF : µF, PF : µµF COILS • MMH : mH, UH : µH DESCRIPTION REMARK C049 C050 C051 1-164-004-11 1-126-960-11 1-163-117-00 CERAMIC CHIP ELECT CERAMIC CHIP 0.1MF 1MF 100PF 10% 20% 5% 25V 50V 50V C052 C053 C055 C056 C057 1-164-004-11 1-163-009-11 1-126-941-11 1-163-009-11 1-163-243-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 0.1MF 0.001MF 470MF 0.001MF 47PF 10% 10% 20% 10% 5% 25V 50V 16V 50V 50V C058 C059 C060 C061 C072 1-163-117-00 1-163-117-00 1-163-009-11 1-164-505-11 1-126-941-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 100PF 100PF 0.001MF 2.2MF 470MF 5% 5% 10% 50V 50V 50V 16V 16V C074 C101 C105 C106 C108 1-163-001-11 1-163-029-11 1-126-933-11 1-126-964-11 1-126-767-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT 220PF 0.0047MF 100MF 10MF 1000MF 20% 20% 20% 50V 50V 16V 50V 16V C109 C110 C111 C114 C115 1-163-017-00 1-136-165-00 1-163-009-11 1-163-117-00 1-163-093-00 CERAMIC CHIP FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0047MF 0.1MF 0.001MF 100PF 10PF 10% 5% 10% 5% 5% 50V 50V 50V 50V 50V C116 C117 C118 C119 C120 1-136-165-00 1-163-117-00 1-126-965-11 1-163-059-00 1-130-493-00 FILM CERAMIC CHIP ELECT CERAMIC CHIP MYLAR 0.1MF 100PF 22MF 0.01MF 0.068MF 5% 5% 20% 5% 50V 50V 50V 50V 50V C121 C122 C124 C125 C127 1-130-493-00 1-126-933-11 1-164-004-11 1-164-004-11 1-163-077-00 MYLAR ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.068MF 100MF 0.1MF 0.1MF 0.1MF 5% 20% 10% 10% 10% 50V 16V 25V 25V 25V C128 C131 C132 C201 C202 1-163-077-00 1-163-117-00 1-163-117-00 1-126-960-11 1-126-933-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT 0.1MF 100PF 100PF 1MF 100MF 10% 5% 5% 20% 20% 25V 50V 50V 50V 16V C203 C204 C205 C206 C207 1-126-960-11 1-126-933-11 1-163-989-11 1-163-018-00 1-126-961-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT 1MF 100MF 0.033MF 0.0056MF 2.2MF 20% 20% 10% 10% 20% 50V 16V 25V 50V 50V C208 C209 C210 C211 C233 1-126-961-11 1-163-018-00 1-163-989-11 1-164-004-11 1-104-664-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 2.2MF 0.0056MF 0.033MF 0.1MF 47MF 20% 10% 10% 10% 20% 50V 50V 25V 25V 16V – 55 – 20% 10% The components identified by shading and mark ! are critical for safety. Replace only with part number specified. A REF.NO. PART NO. DESCRIPTION REMARK C234 C235 C236 C237 C238 1-104-664-11 1-104-664-11 1-126-948-11 1-126-933-11 1-136-167-00 ELECT ELECT ELECT ELECT FILM 47MF 47MF 100MF 100MF 0.15MF 20% 20% 20% 20% 5% 16V 16V 35V 16V 50V C239 C240 C241 C242 C243 1-126-933-11 1-136-167-00 1-126-942-61 1-163-021-91 1-128-551-11 ELECT FILM ELECT CERAMIC CHIP ELECT 100MF 0.15MF 1000MF 0.01MF 22MF 20% 5% 20% 10% 20% 16V 50V 25V 50V 25V C244 C246 C247 C253 C254 1-126-942-61 1-128-551-11 1-126-942-61 1-126-933-11 1-163-017-00 ELECT ELECT ELECT ELECT CERAMIC CHIP 1000MF 22MF 1000MF 100MF 0.0047MF 20% 20% 20% 20% 10% 25V 25V 25V 16V 50V C255 C257 C258 C300 C304 1-163-017-00 1-130-494-11 1-130-494-11 1-104-664-11 1-164-004-11 CERAMIC CHIP MYLAR MYLAR ELECT CERAMIC CHIP 0.0047MF 0.082MF 0.082MF 47MF 0.1MF 10% 5% 5% 20% 10% 50V 50V 50V 16V 25V C305 C306 C307 C308 C309 1-164-004-11 1-216-295-91 1-164-004-11 1-164-004-11 1-164-004-11 CERAMIC CHIP SHORT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 0 0.1MF 0.1MF 0.1MF 10% 25V 10% 10% 10% 25V 25V 25V C310 C311 C312 C313 C314 1-164-004-11 1-163-231-11 1-163-231-11 1-126-933-11 1-164-161-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.1MF 15PF 15PF 100MF 0.0022MF 10% 5% 5% 20% 10% 25V 50V 50V 16V 50V C315 C316 C319 C320 C321 1-165-320-11 1-102-125-00 1-164-004-11 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47MF 0.0047MF 0.1MF 0.1MF 0.1MF 10% 10% 10% 10% 10% 16V 50V 25V 25V 25V C322 C323 C324 C326 C328 1-216-295-91 1-163-235-11 1-115-565-11 1-163-095-00 1-164-004-11 SHORT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0 22PF 2.2MF 12PF 0.1MF 5% 10% 5% 10% 50V 10V 50V 25V C329 C330 C331 C332 C333 1-163-016-00 1-164-004-11 1-126-964-11 1-136-165-00 1-164-004-11 CERAMIC CHIP CERAMIC CHIP ELECT FILM CERAMIC CHIP 0.0039MF 0.1MF 10MF 0.1MF 0.1MF 10% 10% 20% 5% 10% 50V 25V 50V 50V 25V C335 C337 C338 C339 C340 1-102-973-00 1-126-933-11 1-165-320-11 1-163-121-00 1-163-009-11 CERAMIC ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100MF 0.47MF 150PF 0.001MF 5% 20% 10% 5% 10% 50V 16V 16V 50V 50V C341 C342 C344 C349 C359 1-163-117-00 1-164-004-11 1-126-964-11 1-126-963-11 1-126-933-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT 100PF 0.1MF 10MF 4.7MF 100MF 5% 10% 20% 20% 20% 50V 25V 50V 50V 16V C361 C367 C802 1-163-009-11 1-164-004-11 1-107-364-11 CERAMIC CHIP CERAMIC CHIP MYLAR 0.001MF 0.1MF 0.01MF 10% 10% 10% 50V 25V 200V REF.NO. PART NO. DESCRIPTION REMARK C368 C369 C370 1-164-004-11 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 0.1MF 0.1MF 10% 10% 10% 25V 25V 25V C374 C375 C376 C401 C402 1-126-967-11 1-126-967-11 1-164-005-11 1-163-021-91 1-163-021-91 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47MF 47MF 0.47MF 0.01MF 0.01MF 20% 20% 10% 10% 50V 50V 25V 50V 50V C403 C404 C405 C406 C407 1-126-965-11 1-163-021-91 1-163-017-00 1-163-017-00 1-163-017-00 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 22MF 0.01MF 0.0047MF 0.0047MF 0.0047MF 20% 10% 10% 10% 10% 50V 50V 50V 50V 50V C408 C410 C411 C413 C415 1-163-017-00 1-163-103-00 1-163-113-00 1-126-933-11 1-163-017-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.0047MF 27PF 68PF 100MF 0.0047MF 10% 5% 5% 20% 10% 50V 50V 50V 16V 50V C420 C423 C425 C501 C523 1-104-664-11 1-163-129-00 1-163-021-91 1-102-228-00 1-126-933-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC ELECT 47MF 330PF 0.01MF 470PF 100MF 20% 5% 10% 10% 20% 16V 50V 50V 500V 16V C548 C551 C552 C554 C555 1-106-220-00 1-126-948-11 1-126-948-11 1-162-815-11 1-102-230-00 MYLAR ELECT ELECT CERAMIC CERAMIC 0.1MF 100MF 100MF 47PF 4PF 10% 100V 20% 35V 20% 35V 5% 500V 0.25PF 500V C562 C572 C601 C602 C603 1-126-933-11 1-163-021-91 1-162-318-11 1-161-830-00 1-161-830-00 ELECT CERAMIC CHIP CERAMIC CERAMIC CERAMIC 100MF 0.01MF 0.001MF 0.0047MF 0.0047MF 20% 10% 10% 99% 99% 16V 50V 500V 500V 500V C604 C605 C606 C607 C608 1-113-608-11 1-161-830-00 1-161-830-00 1-161-830-00 1-104-332-11 ELECT(BLOCK) CERAMIC CERAMIC CERAMIC CERAMIC 470MF 0.0047MF 0.0047MF 0.0047MF 470PF 20% 99% 99% 99% 10% 400V 500V 500V 500V 2KV C609 C610 C612 C613 C614 1-124-347-00 1-126-943-11 1-102-228-00 1-102-824-00 1-126-943-11 ELECT ELECT CERAMIC CERAMIC ELECT 100MF 2200MF 470PF 470PF 2200MF 20% 20% 10% 5% 20% 160V 25V 500V 50V 25V C615 ! 1-113-900-51 C616 1-102-228-00 C618 1-163-005-11 C619 1-162-116-00 C621 ! 1-104-705-51 CERAMIC CERAMIC CERAMIC CHIP CERAMIC FILM 470PF 470PF 470PF 680PF 0.1MF 10% 10% 10% 10% 20% 250V 500V 50V 2KV 250V C622 C623 C624 C625 C627 MYLAR ELECT ELECT CERAMIC CERAMIC 0.047MF 220MF 1000MF 0.001MF 680PF 10% 20% 20% 10% 10% 200V 50V 16V 50V 2KV CERAMIC CERAMIC CERAMIC CERAMIC CHIP ELECT 470PF 0.0047MF 0.001MF 470PF 33MF 10% 99% 10% 10% 250V 500V 3KV 50V 160V 1-106-383-00 1-126-969-11 1-126-767-11 1-102-074-00 1-162-116-00 C630 ! 1-113-900-51 C631 1-161-830-00 C633 1-161-754-00 C634 1-163-005-11 C801 1-123-024-21 – 56 – KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. A DESCRIPTION REMARK REF. NO. PART NO. 1-107-364-11 1-163-009-11 1-102-244-00 1-126-960-11 1-136-597-11 MYLAR CERAMIC CHIP CERAMIC ELECT FILM 0.01MF 0.001MF 220PF 1MF 0.89MF 10% 10% 10% 20% 5% 200V 50V 500V 50V 200V C1230 C1513 C808 C809 C810 C811 C812 1-129-723-00 1-162-115-00 1-106-365-00 1-162-318-11 1-136-085-00 FILM CERAMIC MYLAR CERAMIC FILM 0.068MF 330PF 0.0082MF 0.001MF 0.016MF 5% 10% 99% 10% 3% 400V 2KV 200V 500V 2KV CN101 CN102 CN103 CN106 CN110 C816 C820 C821 C822 C823 1-107-636-11 1-162-116-00 1-104-999-11 1-136-111-00 1-163-017-00 ELECT CERAMIC MYLAR FILM CERAMIC CHIP 10MF 680PF 0.1MF 1MF 0.0047MF 20% 10% 10% 5% 10% 160V 2KV 200V 200V 50V CN111 * 1-564-505-11 CN112 * 1-508-784-00 CN251 * 1-564-507-11 CN601*!1-580-843-11 CN602 * 1-508-765-00 PLUG, CONNECTOR 2P PIN, CONNECTOR (5MM PITCH) 1P PLUG, CONNECTOR 4P PIN, CONNECTOR (POWER) PIN, CONNECTOR (5MM PITCH) 3P C825 C850 C852 C853 C854 1-107-364-11 1-126-941-11 1-104-574-11 1-162-318-11 1-126-941-11 MYLAR ELECT CERAMIC CERAMIC ELECT 0.01MF 470MF 0.0047MF 0.001MF 470MF 10% 20% 10% 10% 20% 200V 25V 2KV 500V 25V CN603 * 1-508-786-00 CN604 1-695-915-11 CN607 1-695-915-11 CN609 * 1-564-506-11 CN811 1-695-915-11 PIN, CONNECTOR (5MM PITCH) 2P TAB (CONTACT) TAB (CONTACT) PLUG, CONNECTOR 3P TAB (CONTACT) C855 C856 C857 C860 C861 4-352-844-01 1-162-318-11 1-136-495-11 1-102-228-00 1-107-654-11 PIN, LEAD, COATING CERAMIC 0.001MF FILM 0.068MF CERAMIC 470PF ELECT 33MF 10% 5% 10% 20% 500V 50V 500V 250V CN812 CN813 CN814 CN815 CN816 TAB (CONTACT) TAB (CONTACT) TAB (CONTACT) TAB (CONTACT) TAB (CONTACT) C875 C876 C891 C898 C901 1-128-562-11 1-107-369-11 1-163-007-11 1-136-169-00 1-163-133-00 ELECT MYLAR CERAMIC CHIP FILM CERAMIC CHIP 47MF 0.068MF 680PF 0.22MF 470PF 20% 10% 10% 5% 5% 100V 100V 50V 50V 50V CN817 1-695-915-11 CN818 1-695-915-11 CN851 * 1-508-766-00 CN852 * 1-508-784-00 CN853 * 1-564-506-11 C902 C1201 C1202 C1203 C1204 1-163-133-00 1-126-933-11 1-164-004-11 1-164-004-11 1-126-933-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT 470PF 100MF 0.1MF 0.1MF 100MF 5% 20% 10% 10% 20% 50V 16V 25V 25V 16V C1205 C1206 C1207 C1208 C1209 1-164-004-11 1-164-004-11 1-126-933-11 1-164-005-11 1-164-005-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 0.1MF 0.1MF 100MF 0.47MF 0.47MF 10% 10% 20% 25V 25V 16V 25V 25V C1210 C1212 C1213 C1214 C1215 1-126-933-11 1-126-960-11 1-126-960-11 1-126-964-11 1-163-021-91 ELECT ELECT ELECT ELECT CERAMIC CHIP 100MF 1MF 1MF 10MF 0.01MF 20% 20% 20% 20% 10% 16V 50V 50V 50V 50V C1216 C1217 C1218 C1219 C1221 1-164-005-11 1-126-933-11 1-163-123-00 1-126-933-11 1-164-005-11 CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP 0.47MF 100MF 180PF 100MF 0.47MF 20% 5% 20% 25V 16V 50V 16V 25V C1222 C1223 C1224 C1225 C1226 1-164-005-11 1-164-346-11 1-216-295-91 1-164-005-11 1-126-934-11 CERAMIC CHIP CERAMIC CHIP SHORT CERAMIC CHIP ELECT 0.47MF 1MF 0 0.47MF 220MF C1227 C1228 1-164-004-11 1-164-346-11 CERAMIC CHIP CERAMIC CHIP 0.1MF 1MF 20% 10% 25V 16V 25V 16V CERAMIC CHIP ELECT REMARK C802 C804 C805 C806 C807 25V 16V 1-164-004-11 1-126-968-11 DESCRIPTION 0.1MF 100MF 10% 20% 25V 50V <CONNECTOR> * * * * * 1-508-797-00 1-564-508-11 1-564-509-11 1-770-747-11 1-564-505-11 1-695-915-11 1-695-915-11 1-695-915-11 1-695-915-11 1-695-915-11 PIN, CONNECTOR 4P PLUG, CONNECTOR 5P PLUG, CONNECTOR 6P CONNECTOR, BOARD TO BOARD 12P PLUG, CONNECTOR 2P TAB (CONTACT) TAB (CONTACT) PIN, CONNECTOR (5MM PITCH) 4P PIN, CONNECTOR (5MM PITCH) 1P PLUG, CONNECTOR 3P <TRIMMER> CT55 1-404-801-11 TRAP, CERAMIC <DIODE> D001 D002 D003 D004 D005 8-719-109-81 8-719-911-19 8-719-041-97 8-719-109-84 8-719-109-84 DIODE RD4.7ESB2 DIODE 1SS119-25 DIODE MA113-(TX) DIODE RD5.1ESB1 DIODE RD5.1ESB1 D008 D103 D251 D252 D301 8-719-109-89 8-719-914-42 8-719-911-19 8-719-914-42 8-719-041-97 DIODE RD5.6ESB2 DIODE DA204K DIODE 1SS119-25 DIODE DA204K DIODE MA113-(TX) D305 D306 D307 D308 D310 8-719-041-97 8-719-911-19 8-719-911-19 8-719-109-54 8-719-041-97 DIODE MA113-(TX) DIODE 1SS119-25 DIODE 1SS119-25 DIODE RD2.2ESB2 DIODE MA113-(TX) D311 D312 D315 D351 D399 8-719-109-68 8-719-070-15 8-719-070-16 8-719-908-03 8-719-977-22 DIODE RD3.6ESB1 DIODE NNCD8.2A-T1 DIODE NNCD9.1A-T1 DIODE GP08D DIODE DTZ9.1 – 57 – KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. A REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. 8-759-708-12 8-759-336-30 8-759-365-26 8-759-565-20 8-759-054-12 DESCRIPTION REMARK D403 D513 D551 D561 D591 8-719-911-19 8-719-109-84 8-719-908-03 8-719-911-19 8-719-911-19 DIODE 1SS119-25 DIODE RD5.1ESB1 DIODE GP08D DIODE 1SS119-25 DIODE 1SS119-25 IC202 IC203 IC300 IC351 IC521 D601 D602 D603 D604 D605 8-719-052-84 8-719-108-18 8-719-110-36 8-719-301-64 8-719-510-73 DIODE LN4SB60 THYRISTOR 5P6M DIODE RD13ESB2 DIODE RU4DS DIODE S3L20UF4 IC551 8-759-280-35 IC601 8-749-014-01 IC602 8-749-920-61 IC603 ! 8-749-010-64 IC801 8-759-100-96 IC LA7845 IC STR-S6708N IC SE-135N PHOTO COUPLER PC123F2 IC UPC4558G2 D606 D607 D609 D610 D611 8-719-510-73 8-719-510-26 8-719-510-26 8-719-510-26 8-719-510-26 DIODE S3L20UF4 DIODE D1NL20-TA DIODE D1NL20-TA DIODE D1NL20-TA DIODE D1NL20-TA IC1201 IC1203 IC1210 IC1211 IC1212 IC UPC574J IC NJM7805FA IC UPC4558G2 IC NJM2234L IC NJM2234L D612 D801 D802 D851 D852 8-719-301-64 8-719-945-80 8-719-900-26 8-719-302-43 8-719-028-72 DIODE RU4DS DIODE ERC06-15S DIODE ERD29-08J DIODE EL1Z DIODE RGP02-17EL-6433 D853 D855 D857 D858 D860 8-719-302-43 8-719-302-43 8-719-908-03 8-719-908-03 8-719-911-19 DIODE EL1Z DIODE EL1Z DIODE GP08D DIODE GP08D DIODE 1SS119-25 D891 D901 D1201 D1202 D1203 8-719-945-80 8-719-054-60 8-719-070-16 8-719-070-16 8-719-070-16 DIODE ERC06-15S DIODE LNK0220022G DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 D1204 D1205 D1206 D1207 D1208 8-719-070-16 8-719-070-16 8-719-070-16 8-719-070-16 8-719-070-16 DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 DIODE NNCD9.1A-T1 D1209 D1504 D1505 8-719-070-16 8-719-911-19 8-719-109-81 DIODE NNCD9.1A-T1 DIODE 1SS119-25 DIODE RD4.7ESB2 8-759-157-40 8-759-701-75 8-759-100-96 8-759-711-23 8-759-711-23 IC NJM78L12A IC TA8223K IC TDA8375A IC TDA4665T/V5-118 IC PQ09RA1 <JACK> J251 J1201 J1202 1-770-786-11 1-770-659-11 1-695-585-11 JACK JACK BLOCK, PIN 9P JACK BLOCK, PIN (L TYPE) 3P <CHIP CONDUCTOR> JR051 JR101 JR103 JR107 JR108 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JR112 JR114 JR115 JR116 JR117 1-216-295-91 1-163-121-00 1-216-295-91 1-216-295-91 1-216-295-91 SHORT CERAMIC CHIP SHORT SHORT SHORT 0 150PF 0 0 0 5% 50V <COIL> <FERRITE BEAD> L001 L002 L003 L101 L301 1-408-397-00 1-410-509-11 1-408-605-31 1-410-470-11 1-408-602-31 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 1UH 10UH 15UH 10UH 8.2UH 1.2UH 12UH 6.8UH 2.2UH 15UH FB101 FB102 FB251 FB601 FB603 1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21 FERRITE FERRITE FERRITE FERRITE FERRITE 1.1UH 1.1UH 1.1UH 1.1UH 1.1UH L401 L402 L406 L410 L802 1-410-498-11 1-410-510-11 1-410-507-11 1-410-501-11 1-412-527-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR FB610 FB612 FB801 1-410-396-41 1-410-397-21 1-410-397-21 FERRITE FERRITE FERRITE 0UH 1.1UH 1.1UH L804 L805 L807 L808 L821 1-459-075-00 1-411-955-12 1-459-390-00 1-412-553-11 1-459-111-00 COIL,DYNAMIC CONVERSION CHOKE COIL, HORIZONTAL LINEARITY INDUCTOR 390UH INDUCTOR 3.3MMH INDUCTOR 10MMH L850 1-408-947-00 INDUCTOR <IC> IC001 IC002 IC003 IC004 IC201 8-752-886-04 8-759-805-37 8-759-370-34 8-742-041-12 8-759-090-21 IC CXP85224A-072S IC L78LR05D-MA IC ST24C08FB6 HYB IC SBX1981-11 IC TDA8424 2.2MMH <TRANSISTOR> Q030 Q108 – 58 – 8-729-120-28 8-729-120-28 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. A DESCRIPTION REMARK Q109 Q110 Q202 8-729-120-28 8-729-120-28 8-729-920-72 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SA1037K-T-146-QR Q207 Q208 Q209 Q210 Q301 8-729-920-72 1-801-806-11 8-729-027-56 8-729-027-56 8-729-027-43 TRANSISTOR 2SA1037K-T-146-QR TRANSISTOR DTC144EK-T146 TRANSISTOR DTC143TKA-T146 TRANSISTOR DTC143TKA-T146 TRANSISTOR DTC114EKA-T146 Q302 Q303 Q401 Q402 Q406 8-729-120-28 8-729-120-28 8-729-120-28 8-729-922-66 8-729-920-72 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC2410SN TRANSISTOR 2SA1037K-T-146-QR Q408 Q409 Q414 Q561 Q601 8-729-120-28 8-729-920-72 8-729-120-28 8-729-200-17 8-729-120-28 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SA1037K-T-146-QR TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SA1091-O TRANSISTOR 2SC1623-L5L6 Q801 Q802 Q821 Q902 Q903 8-729-140-50 8-729-016-32 8-729-018-99 1-801-806-11 1-801-806-11 TRANSISTOR 2SC3209LK TRANSISTOR 2SC4927-01 TRANSISTOR 2SD2394-F TRANSISTOR DTC144EK-T146 TRANSISTOR DTC144EK-T146 Q1201 Q1202 Q1203 Q1204 Q1205 8-729-120-28 8-729-120-28 8-729-120-28 8-729-920-72 8-729-920-72 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SA1037K-T-146-QR TRANSISTOR 2SA1037K-T-146-QR Q1206 Q1207 Q1208 Q1264 Q1265 8-729-120-28 8-729-120-28 8-729-120-28 8-729-027-56 8-729-027-56 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR DTC143TKA-T146 TRANSISTOR DTC143TKA-T146 Q1513 8-729-120-28 TRANSISTOR 2SC1623-L5L6 <RESISTOR> R001 R002 R003 R004 R007 1-216-065-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7K 4.7K 4.7K 4.7K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R008 R010 R012 R013 R015 1-216-049-91 1-216-049-91 1-216-017-91 1-216-049-91 1-216-043-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 1K 47 1K 560 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R016 R017 R018 R019 R020 1-216-049-91 1-216-057-00 1-216-033-00 1-216-101-00 1-216-025-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 2.2K 220 150K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R021 R025 R027 R028 R029 1-216-065-91 1-216-057-00 1-216-065-91 1-216-025-91 1-216-065-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7K 2.2K 4.7K 100 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W REF. NO. PART NO. DESCRIPTION REMARK R031 R032 R033 R035 R036 1-216-049-91 1-216-057-00 1-216-049-91 1-216-049-91 1-216-049-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 2.2K 1K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R037 R039 R041 R042 R045 1-216-049-91 1-216-049-91 1-216-025-91 1-216-039-00 1-216-057-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 1K 100 390 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R047 R048 R051 R052 R053 1-216-025-91 1-216-025-91 1-216-085-00 1-216-089-91 1-216-057-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100 100 33K 47K 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R054 R056 R057 R058 R060 1-216-073-00 1-216-065-91 1-216-049-91 1-216-065-91 1-216-037-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 10K 4.7K 1K 4.7K 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R061 R062 R063 R065 R066 1-216-057-00 1-216-057-00 1-216-057-00 1-216-033-00 1-216-033-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 2.2K 2.2K 2.2K 220 220 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R067 R068 R071 R076 R077 1-216-033-00 1-216-025-91 1-216-037-00 1-216-025-91 1-216-025-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 220 100 330 100 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R090 R101 R102 R113 R114 1-216-073-00 1-216-065-91 1-216-049-91 1-216-081-00 1-216-041-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 10K 4.7K 1K 22K 470 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R115 R116 R117 R118 R119 1-216-081-00 1-216-081-00 1-216-081-00 1-216-081-00 1-216-055-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 22K 22K 22K 22K 1.8K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R120 R131 R180 R181 R182 1-216-109-00 1-216-464-11 1-216-033-00 1-216-033-00 1-216-033-00 RES,CHIP METAL OXIDE RES,CHIP RES,CHIP RES,CHIP 330K 18K 220 220 220 5% 5% 5% 5% 5% 1/10W 2W F 1/10W 1/10W 1/10W R203 R204 R241 R242 R243 1-216-033-00 1-216-033-00 1-216-031-00 1-216-031-00 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 220 220 180 180 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R244 R245 R246 R247 R248 1-216-073-00 1-216-069-00 1-216-069-00 1-216-053-00 1-216-053-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 10K 6.8K 6.8K 1.5K 1.5K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R249 R250 1-216-049-91 1-216-049-91 RES,CHIP RES,CHIP 1K 1K 5% 5% 1/10W 1/10W – 59 – KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. A REF. NO. PART NO. DESCRIPTION REMARK R251 R252 R253 1-216-295-91 1-249-411-11 1-216-073-00 SHORT CARBON RES,CHIP 0 330 10K R254 R255 R256 R257 R264 1-249-389-11 1-249-389-11 1-249-411-11 1-216-295-91 1-216-061-00 CARBON CARBON CARBON SHORT RES,CHIP R265 R266 R300 R302 R303 1-216-061-00 1-216-089-91 1-249-441-11 1-216-295-91 1-216-025-91 R304 R305 R306 R307 R308 5% 5% 1/4W 1/10W 4.7 4.7 330 0 3.3K 5% 5% 5% 1/4W 1/4W 1/4W 5% 1/10W RES,CHIP RES,CHIP CARBON SHORT RES,CHIP 3.3K 47K 100K 0 100 5% 5% 5% 1/10W 1/10W 1/4W 5% 1/10W 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-033-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100 100 100 100 220 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R309 R310 R311 R312 R313 1-216-033-00 1-216-097-91 1-216-075-00 1-216-025-91 1-216-089-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 220 100K 12K 100 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R314 R315 R316 R317 R318 1-216-025-91 1-216-295-91 1-216-065-91 1-216-049-91 1-216-099-00 RES,CHIP SHORT RES,CHIP RES,CHIP RES,CHIP 100 0 4.7K 1K 120K 5% 1/10W 5% 5% 5% 1/10W 1/10W 1/10W R319 R320 R321 R322 R324 1-216-113-00 1-216-083-00 1-216-689-11 1-216-083-00 1-208-291-11 RES,CHIP RES,CHIP METAL CHIP RES,CHIP RES,CHIP 470K 27K 39K 27K 4.7M 5% 5% 0.50% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R325 R326 R327 R328 R329 1-216-295-91 1-216-039-00 1-216-025-91 1-216-025-91 1-216-025-91 SHORT RES,CHIP RES,CHIP RES,CHIP RES,CHIP 0 390 100 100 100 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R330 R331 R332 R334 R335 1-216-043-91 1-216-117-00 1-216-033-00 1-216-041-00 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 560 680K 220 470 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R336 R338 R341 R342 R343 1-216-057-00 1-216-295-91 1-216-049-91 1-216-036-00 1-216-035-00 RES,CHIP SHORT RES,CHIP RES,CHIP RES,CHIP 2.2K 0 1K 300 270 5% 1/10W 5% 5% 5% 1/10W 1/10W 1/10W R345 R351 R355 R356 R357 1-259-880-11 1-216-001-00 1-216-001-00 1-216-049-91 1-216-107-00 CARBON RES,CHIP RES,CHIP RES,CHIP RES,CHIP 2.2M 10 10 1K 270K 5% 5% 5% 5% 5% 1/4W 1/10W 1/10W 1/10W 1/10W R360 R401 R402 R403 R404 1-208-291-11 1-216-085-00 1-216-081-00 1-216-021-00 1-216-035-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7M 33K 22K 68 270 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W REF. NO. PART NO. DESCRIPTION REMARK R406 R407 R408 R409 R414 1-216-065-91 1-216-063-91 1-216-055-00 1-216-025-91 1-216-041-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7K 3.9K 1.8K 100 470 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R416 R419 R420 R421 R424 1-216-033-00 1-216-049-91 1-216-039-00 1-216-033-00 1-216-057-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 220 1K 390 220 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R425 R426 R429 R433 R434 1-216-039-00 1-216-029-00 1-216-031-00 1-216-081-00 1-216-041-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 390 150 180 22K 470 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R440 R441 R521 R550 R552 1-216-029-00 1-216-021-00 1-216-049-91 1-216-049-91 1-216-109-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 150 68 1K 1K 330K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R553 R554 R555 R558 R559 1-216-295-91 1-216-113-00 1-249-429-11 1-216-061-00 1-216-073-00 SHORT RES,CHIP CARBON RES,CHIP RES,CHIP 0 470K 10K 3.3K 10K 5% 5% 5% 5% 1/10W 1/4W 1/10W 1/10W R560 R561 R562 R563 R564 1-216-073-00 1-249-421-11 1-249-420-11 1-247-885-00 1-216-091-00 RES,CHIP CARBON CARBON CARBON RES,CHIP 10K 2.2K 1.8K 180K 56K 5% 5% 5% 5% 5% 1/10W 1/4W 1/4W F 1/4W 1/10W R565 R566 R569 R570 R571 1-216-091-00 1-216-065-91 1-247-883-00 1-216-295-91 1-216-295-91 RES,CHIP RES,CHIP CARBON SHORT SHORT 56K 4.7K 150K 0 0 5% 5% 5% 1/10W 1/10W 1/4W R603 R604 R606 R609 R610 1-249-416-11 1-249-416-11 1-215-915-11 1-249-381-11 1-215-924-00 CARBON CARBON METAL OXIDE CARBON METAL OXIDE 820 820 470 1 15K 5% 5% 5% 5% 5% 1/4W 1/4W 3W 1/4W 3W R611 R613 R614 R615 R616 ! 1-202-933-61 1-219-134-11 1-215-877-11 1-249-389-11 1-218-265-91 FUSIBLE FUSIBLE METAL OXIDE CARBON METAL 0.1 0.1 22K 4.7 8.2M 10% 10% 5% 5% 5% 1/2W F 1/4W 1W F 1/4W 1W R617 R618 R619 R620 R622 1-215-924-00 1-532-845-21 1-219-134-11 1-202-962-11 1-217-191-21 METAL OXIDE LINK, IC FUSIBLE CEMENTED WIREWOUND 15K 5% 3W 0.1 3.3 0.18 10% 5% 10% 1/4W 10W 2W F R623 R624 R625 R626 R627 1-247-807-31 1-215-881-11 1-249-424-11 1-249-420-11 1-249-417-11 CARBON METAL OXIDE CARBON CARBON CARBON 100 15 3.9K 1.8K 1K 5% 5% 5% 5% 5% 1/4W 2W F 1/4W 1/4W 1/4W R628 R629 R635 1-249-417-11 1-249-399-11 1-215-882-00 CARBON CARBON METAL OXIDE 1K 33 22 5% 5% 5% 1/4W 1/4W 2W F – 60 – F F F F F KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. A DESCRIPTION REMARK R636 R801 1-215-924-00 1-215-945-11 METAL OXIDE METAL OXIDE 15K 3.3K 5% 5% 3W 5W F F R802 R803 R804 R805 R809 1-249-381-11 1-216-057-00 1-216-049-91 1-216-081-00 1-247-756-11 CARBON RES,CHIP RES,CHIP RES,CHIP CARBON 1 2.2K 1K 22K 2.2K 5% 5% 5% 5% 5% 1/4W F 1/10W 1/10W 1/10W 1/2W F R811 R812 R816 R821 R822 1-216-347-11 1-216-067-00 1-249-435-11 1-215-910-00 1-216-429-00 METAL OXIDE RES,CHIP CARBON METAL OXIDE METAL OXIDE 0.68 5.6K 33K 68 270 5% 5% 5% 5% 5% 1W F 1/10W 1/4W 3W F 1W F R823 R825 R826 R827 R828 1-249-931-11 1-249-392-11 1-216-059-00 1-216-097-91 1-216-063-91 CARBON CARBON RES,CHIP RES,CHIP RES,CHIP 2.2K 8.2 2.7K 100K 3.9K 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/10W 1/10W 1/10W R829 R831 R832 R834 R851 1-216-067-00 1-215-861-00 1-216-057-00 1-216-073-00 1-249-448-11 RES,CHIP METAL OXIDE RES,CHIP RES,CHIP CARBON 5.6K 47 2.2K 10K 1.2 5% 5% 5% 5% 5% 1/10W 1W F 1/10W 1/10W 1/4W F R852 R853 R854 R855 R856 1-217-778-11 1-249-377-11 1-249-377-11 1-202-818-00 1-249-431-11 FUSIBLE CARBON CARBON SOLID CARBON 1K 0.47 0.47 1K 15K 5% 5% 5% 20% 5% 1W F 1/4W F 1/4W F 1/2W 1/4W R857 R858 R860 R881 R882 1-249-439-11 1-216-370-11 1-247-887-00 1-216-041-00 1-216-059-00 CARBON METAL OXIDE CARBON RES,CHIP RES,CHIP 68K 1.2 220K 470 2.7K 5% 5% 5% 5% 5% 1/4W 2W F 1/4W 1/10W 1/10W R895 R896 R898 R902 R904 1-216-349-00 1-216-001-00 1-249-421-11 1-216-065-91 1-216-065-91 METAL OXIDE RES,CHIP CARBON RES,CHIP RES,CHIP 1 10 2.2K 4.7K 4.7K 5% 5% 5% 5% 5% 1W F 1/10W 1/4W 1/10W 1/10W R905 R906 R907 R908 R909 1-216-049-91 1-216-049-91 1-216-055-00 1-216-055-00 1-216-061-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 1K 1.8K 1.8K 3.3K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R910 R911 R913 R914 R915 1-216-061-00 1-216-071-00 1-216-041-00 1-216-041-00 1-216-071-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 3.3K 8.2K 470 470 8.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1201 R1202 R1203 R1204 R1205 1-216-023-00 1-216-049-91 1-216-089-91 1-216-089-91 1-216-023-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 82 1K 47K 47K 82 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1206 R1207 R1208 R1209 R1210 1-216-089-91 1-216-089-91 1-216-023-00 1-216-061-00 1-216-061-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 47K 47K 82 3.3K 3.3K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W REF. NO. PART NO. DESCRIPTION REMARK R1211 R1212 R1213 R1214 R1215 1-216-021-00 1-216-049-91 1-216-049-91 1-216-113-00 1-216-113-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 68 1K 1K 470K 470K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1216 R1218 R1219 R1220 R1221 1-216-113-00 1-216-041-00 1-216-073-00 1-216-049-91 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 470K 470 10K 1K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1222 R1223 R1224 R1225 R1226 1-216-049-91 1-216-073-00 1-216-073-00 1-216-025-91 1-216-689-11 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 10K 10K 100 39K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1227 R1228 R1229 R1230 R1231 1-216-689-11 1-216-049-91 1-216-041-00 1-216-073-00 1-216-049-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 39K 1K 470 10K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1232 R1233 R1234 R1235 R1236 1-216-063-91 1-216-057-00 1-216-689-11 1-216-689-11 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 3.9K 2.2K 39K 39K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1237 R1238 R1239 R1240 R1241 1-216-073-00 1-216-041-00 1-249-389-11 1-216-025-91 1-216-049-91 RES,CHIP RES,CHIP CARBON RES,CHIP RES,CHIP 10K 470 4.7 100 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W F 1/10W 1/10W R1242 R1243 R1244 R1245 R1246 1-216-049-91 1-216-025-91 1-216-025-91 1-216-037-00 1-216-037-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 100 100 330 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1247 R1248 R1249 R1513 R1514 1-216-041-00 1-216-051-00 1-216-041-00 1-216-073-00 1-216-065-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 470 1.2K 470 10K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1515 1-216-025-91 RES,CHIP 100 5% 1/10W <VARIABLE RESISTOR> RV301 RV302 1-241-769-11 1-237-525-21 RES, ADJ, CARBON 470K RES, ADJ, CARBON 2.2M <SWITCH> S601 ! 1-571-433-31 S801 1-572-707-11 S901 1-570-577-11 S902 1-570-577-11 S903 1-570-577-11 SWITCH, PUSH (AC POWER) SWITCH, LEVER SWITCH, PUSH SWITCH, PUSH SWITCH, PUSH S904 S905 SWITCH, PUSH SWITCH, PUSH – 61 – 1-570-577-11 1-570-577-11 KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. A3 A REF. NO. PART NO. DESCRIPTION REMARK <SPARK GAP> SG801 1-519-422-11 SAWF <TRANSFORMER> T601 ! 1-429-139-21 T605 ! 1-424-461-11 T801 1-437-195-11 T851 ! 1-453-219-11 TRANSFORMER, CONVERTER (SRT) TRANSFORMER, LINE FILTER TRANSFORMER, HORIZONTAL DRIVE TRANSFORMER ASSY, FLYBACK(NX-4002//M3J4) <THERMISTOR> THP601!1-810-961-11 VSS TUNER BT-AG401 <CRYSTAL> X101 X300 X358 X443 1-577-082-11 1-411-752-11 1-567-505-11 1-567-504-11 REMARK C1222 C1223 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP 0.1MF 0.1MF 10% 10% 25V 25V C1224 C1225 C1226 C1227 C1228 1-164-004-11 1-163-093-00 1-163-009-11 1-163-131-00 1-163-131-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 10PF 0.001MF 390PF 390PF 10% 5% 10% 5% 5% 25V 50V 50V 50V 50V C1229 C1231 C1232 C1233 C1234 1-126-157-11 1-126-157-11 1-124-234-00 1-126-162-11 1-164-004-11 ELECT ELECT ELECT ELECT CERAMIC CHIP 10MF 10MF 22MF 3.3MF 0.1MF 20% 20% 20% 20% 10% 16V 16V 16V 50V 25V C1235 C1236 C1237 C1238 C1239 1-163-005-11 1-163-005-11 1-163-009-11 1-164-004-11 1-126-157-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 470PF 470PF 0.001MF 0.1MF 10MF 10% 10% 10% 10% 20% 50V 50V 50V 25V 16V C1240 C1241 C1242 C1243 C1244 1-164-222-11 1-124-589-11 1-104-760-11 1-163-021-91 1-163-021-91 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.22MF 47MF 0.047MF 0.01MF 0.01MF 20% 10% 10% 10% 25V 16V 50V 50V 50V C1245 C1246 C1247 C1248 C1250 1-163-021-91 1-163-231-11 1-163-229-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01MF 15PF 12PF 0.001MF 0.001MF 10% 5% 5% 10% 10% 50V 50V 50V 50V 50V C1252 C1253 C1254 C1255 C1256 1-216-295-91 1-216-295-91 1-124-234-00 1-124-584-00 1-164-005-11 SHORT SHORT ELECT ELECT CERAMIC CHIP 0 0 22MF 100MF 0.47MF 20% 20% 16V 10V 25V C1257 C1258 C1260 C1262 C1263 1-164-222-11 1-163-033-91 1-163-251-11 1-163-251-11 1-163-137-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.22MF 0.022MF 100PF 100PF 680PF 5% 5% 5% 25V 50V 50V 50V 50V C1264 C1265 C1266 C1267 C1268 1-163-251-11 1-124-234-00 1-124-589-11 1-164-004-11 1-124-584-00 CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT 100PF 22MF 47MF 0.1MF 100MF 5% 20% 20% 10% 20% 50V 16V 16V 25V 10V THERMISTOR, POSITIVE <TUNER> TU101 ! 8-598-323-50 DESCRIPTION GAP, SPARK <SURFACE WAVE FILTER> SWF401 1-577-169-12 REF. NO. PART NO. VIBRATOR, CERAMIC COIL OSCILLATOR, CRYSTAL OSCILLATOR, CRYSTAL **************************************************************************** * A-1297-523-A A3 BOARD, COMPLETE ********************** <CAPACITOR> C1201 C1202 C1205 C1206 C1207 1-163-021-91 1-164-004-11 1-163-017-00 1-163-017-00 1-163-021-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01MF 0.1MF 0.0047MF 0.0047MF 0.01MF 10% 10% 10% 10% 10% 50V 25V 50V 50V 50V C1208 C1209 C1210 C1211 C1212 1-163-083-00 1-163-109-00 1-163-017-00 1-124-584-00 1-163-017-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 1PF 47PF 0.0047MF 100MF 0.0047MF 0.25PF 50V 5% 50V 10% 50V 20% 10V 10% 50V C1213 C1214 C1215 C1216 C1217 1-126-151-11 1-163-017-00 1-163-123-00 1-124-465-00 1-163-033-91 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 4.7MF 0.0047MF 180PF 0.47MF 0.022MF 20% 10% 5% 20% C1218 C1219 C1221 1-163-021-91 1-124-584-00 1-164-004-11 CERAMIC CHIP ELECT CERAMIC CHIP 0.01MF 100MF 0.1MF 10% 20% 10% <CONNECTOR> CN1201 1-691-109-11 <DIODE> D1201 16V 50V 50V 50V 50V 50V 10V 25V PLUG (L TYPE) 12P 8-719-908-03 DIODE GP08D <FERRITE BEAD> FB1201 FB1202 FB1203 FB1204 – 62 – 1-412-911-11 1-412-911-11 1-412-911-11 1-412-911-11 FERRITE FERRITE FERRITE FERRITE 0UH 0UH 0UH 0UH KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. A3 C DESCRIPTION REMARK FB1205 1-412-911-11 FERRITE 0UH FB1206 1-412-911-11 FERRITE 0UH <FILTER> FL1201 1-239-803-11 ENCAPSULATED COMPONENT <IC> IC1201 IC1202 IC1203 8-752-059-57 8-759-493-49 8-759-231-53 IC CXA1110BS IC MSP3410D-PP-B4 IC TA7805S <CHIP CONDUCTOR> JR1 JR2 JR3 JR4 JR5 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JR6 JR7 JR8 JR9 JR10 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JR11 1-216-295-91 SHORT 0 REF. NO. PART NO. DESCRIPTION REMARK R1211 R1212 1-216-015-00 1-216-097-91 RES,CHIP RES,CHIP 39 100K 5% 5% 1/10W 1/10W R1213 R1214 R1217 R1218 R1219 1-216-097-91 1-216-033-00 1-216-073-00 1-216-049-91 1-216-047-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100K 220 10K 1K 820 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1220 R1223 R1224 R1225 R1226 1-216-049-91 1-216-051-00 1-216-059-00 1-216-059-00 1-216-295-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP SHORT 1K 1.2K 2.7K 2.7K 0 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R1227 R1228 R1229 R1230 R1231 1-216-295-91 1-216-049-91 1-216-069-00 1-216-069-00 1-216-049-91 SHORT RES,CHIP RES,CHIP RES,CHIP RES,CHIP 0 1K 6.8K 6.8K 1K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R1232 R1233 R1234 R1240 R1241 1-216-027-00 1-216-045-00 1-216-045-00 1-216-041-00 1-216-075-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 120 680 680 470 12K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1242 R1243 R1244 R1245 R1246 1-216-027-00 1-216-037-00 1-216-059-00 1-216-057-00 1-260-306-51 RES,CHIP RES,CHIP RES,CHIP RES,CHIP CARBON 120 330 2.7K 2.2K 15 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/2W <COIL> <SWITCH> L1201 L1202 L1203 L1204 L1205 1-408-593-31 1-412-010-41 1-408-602-31 1-408-591-11 1-408-602-31 INDUCTOR INDUCTOR CHIP INDUCTOR INDUCTOR INDUCTOR 1.5UH 22UH 8.2UH 1UH 8.2UH SW1201 1-579-560-11 SW1202 1-579-559-11 L1206 L1207 1-412-951-11 1-412-951-11 INDUCTOR INDUCTOR 10UH 10UH T1202 FILTER, SAWTOOTH WAVE FILTER, SAWTOOTH WAVE <TRANSFORMER> 1-416-000-11 COIL <CRYSTAL> <TRANSISTOR> X1201 Q1201 Q1203 Q1205 Q1206 Q1207 8-729-230-49 8-729-266-92 8-729-216-22 8-729-216-22 8-729-230-49 TRANSISTOR 2SC2712-YG TRANSISTOR 2SC2669-O TRANSISTOR 2SA1162-G TRANSISTOR 2SA1162-G TRANSISTOR 2SC2712-YG Q1211 Q1212 8-729-230-49 8-729-230-49 TRANSISTOR 2SC2712-YG TRANSISTOR 2SC2712-YG 1-760-094-11 VIBRATOR, CRYSTAL **************************************************************************** * A-1331-740-A C BOARD, MOUNTED ******************** <RESISTOR> R1201 R1202 R1203 R1204 R1205 1-216-022-00 1-216-085-00 1-216-081-00 1-216-035-00 1-216-027-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 75 33K 22K 270 120 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1207 R1209 R1210 1-216-053-00 1-216-035-00 1-216-041-00 RES,CHIP RES,CHIP RES,CHIP 1.5K 270 470 5% 5% 5% 1/10W 1/10W 1/10W <CAPACITOR> C701 C702 C704 C708 C709 – 63 – 1-162-114-00 1-102-074-00 1-130-202-00 1-102-114-00 1-102-114-00 CERAMIC CERAMIC FILM CERAMIC CERAMIC 0.0047MF 0.001MF 0.022MF 470PF 470PF 10% 5% 10% 10% 2KV 50V 400V 50V 50V KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. C REF. NO. PART NO. C710 C712 C713 C714 C716 1-102-114-00 1-102-107-00 1-102-107-00 1-102-107-00 1-126-968-11 DESCRIPTION CERAMIC CERAMIC CERAMIC CERAMIC ELECT REMARK 470PF 120PF 120PF 120PF 100MF 10% 10% 10% 10% 20% 50V 50V 50V 50V 50V REF. NO. PART NO. DESCRIPTION REMARK <RESISTOR> R701 R702 R703 R705 R710 1-244-941-00 1-249-496-11 1-249-496-11 1-216-345-11 1-215-899-11 CARBON CARBON CARBON METAL OXIDE METAL OXIDE 680K 100K 100K 0.47 15K 5% 5% 5% 5% 5% 1/2W 1/2W 1/2W 1W F 2W F R711 R712 R713 R714 R715 1-247-760-11 1-215-899-11 1-247-760-11 1-215-899-11 1-247-760-11 CARBON METAL OXIDE CARBON METAL OXIDE CARBON 4.7K 15K 4.7K 15K 4.7K 5% 5% 5% 5% 5% 1/2W 2W F 1/2W 2W F 1/2W R716 R717 R718 R719 R720 1-249-405-11 1-249-405-11 1-249-405-11 1-215-485-00 1-249-417-11 CARBON CARBON CARBON METAL CARBON 100 100 100 470K 1K 5% 5% 5% 1% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R721 R722 R723 R724 R725 1-215-491-00 1-249-923-11 1-215-479-00 1-249-417-11 1-249-422-11 METAL CARBON METAL CARBON CARBON 820K 1K 270K 1K 2.7K 1% 5% 1% 5% 5% 1/4W 1/4W F 1/4W 1/4W F 1/4W R726 R727 R728 R729 R730 1-249-422-11 1-249-422-11 1-249-412-11 1-249-412-11 1-249-412-11 CARBON CARBON CARBON CARBON CARBON 2.7K 2.7K 390 390 390 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R731 R732 R733 R734 R738 1-247-807-31 1-247-807-31 1-247-807-31 1-247-739-11 1-247-807-31 CARBON CARBON CARBON CARBON CARBON 100 100 100 100 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/2W 1/4W R739 R740 R747 R749 R751 1-247-807-31 1-247-807-31 1-216-489-11 1-216-490-11 1-215-926-00 CARBON CARBON METAL OXIDE METAL OXIDE METAL OXIDE 100 100 27K 39K 33K 5% 5% 5% 5% 5% 1/4W 1/4W 3W F 3W F 3W F R753 R755 R756 R757 R758 1-249-429-11 1-249-427-11 1-249-427-11 1-249-427-11 1-249-419-11 CARBON CARBON CARBON CARBON CARBON 10K 6.8K 6.8K 6.8K 1.5K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R759 R760 1-249-419-11 1-249-419-11 CARBON CARBON 1.5K 1.5K 5% 5% 1/4W 1/4W F <CONNECTOR> CN701 1-508-766-00 CN703 * 1-564-509-11 CN704 1-695-915-11 PIN, CONNECTOR (5MM PITCH) 4P PLUG, CONNECTOR 6P TAB (CONTACT) <DIODE> D701 D702 D703 D704 D705 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 D706 D707 D708 D709 D710 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 D711 D712 D716 D717 8-719-911-19 8-719-911-19 8-719-911-19 8-719-121-26 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE RD9.1ESL2 <JACK> J701 ! 1-251-595-11 SOCKET, CRT <COIL> L701 L703 L705 L707 1-410-667-31 1-408-615-31 1-408-615-31 1-408-615-31 INDUCTOR INDUCTOR INDUCTOR INDUCTOR 22UH 100UH 100UH 100UH <TRANSISTOR> Q701 Q702 Q703 Q704 Q705 8-729-326-11 8-729-326-11 8-729-326-11 8-729-326-11 8-729-326-11 TRANSISTOR 2SC2611 TRANSISTOR 2SC2611 TRANSISTOR 2SC2611 TRANSISTOR 2SC2611 TRANSISTOR 2SC2611 Q706 Q707 Q708 Q709 Q710 8-729-326-11 8-729-200-17 8-729-200-17 8-729-200-17 8-729-119-78 TRANSISTOR 2SC2611 TRANSISTOR 2SA1091-O TRANSISTOR 2SA1091-O TRANSISTOR 2SA1091-O TRANSISTOR 2SC2785-HFE Q711 Q712 Q714 8-729-119-78 8-729-119-78 8-729-255-12 TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2551-O F F F F <VARIABLE RESISTOR> RV701 RV702 1-230-641-11 1-241-656-21 RES, ADJ, METAL GLAZE 2.2M RES, ADJ, METAL FILM 110M **************************************************************************** – 64 – KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. F1 V1 DESCRIPTION REMARK * A-1241-269-A F1 BOARD, MOUNTED ********************* 1-533-223-11 CLIP, FUSE <CAPACITOR> C1601 ! 1-104-706-51 FILM 0.22MF 20% DESCRIPTION REMARK C20 C22 1-163-117-00 1-126-791-11 CERAMIC CHIP ELECT 100PF 10MF 5% 20% 50V 16V C23 C24 C25 C26 C27 1-163-038-91 1-163-117-00 1-126-791-11 1-104-665-11 1-104-665-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT 0.1MF 100PF 10MF 100MF 100MF 5% 20% 20% 20% 25V 50V 16V 10V 16V C28 C29 C30 C31 C32 1-163-099-00 1-163-099-00 1-163-099-00 1-163-099-00 1-104-665-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 18PF 18PF 18PF 18PF 100MF 5% 5% 5% 5% 20% 50V 50V 50V 50V 10V 250V <CONNECTOR> CN1601 * 1-580-843-11 CN1602 * 1-580-843-11 REF. NO. PART NO. PIN, CONNECTOR (POWER) PIN, CONNECTOR (POWER) <CONNECTOR> <FUSE> CN01 * 1-770-748-11 F1601 ! 1-532-350-11 CONNECTOR, BOARD TO BOARD 12P FUSE, TIME-LAG 4A/250V <DIODE> <RESISTOR> R1601 ! 1-202-916-91 SOLID 5.6M 20% D01 D03 D04 D05 D06 1/2W <TRANSFORMER> T1601 ! 1-424-436-11 T1602 ! 1-424-436-11 8-719-105-52 8-719-914-43 8-719-105-91 8-719-914-44 8-719-914-43 TRANSFORMER, LINE FILTER TRANSFORMER, LINE FILTER <FERRITE BEAD> FB01 1-410-397-21 *************************************************************************** FERRITE 1.1UH <IC> IC01 IC02 * A-1347-103-A V1 BOARD, COMPLETE ********************** 4-049-406-01 4-049-407-01 DIODE RD3.6M-B2 DIODE DAN202K DIODE RD5.6M-B2 DIODE DAP202K DIODE DAN202K 8-759-324-28 8-759-298-63 CASE (BOTTOM LID), SHIELD CASE (UPPER LID), SHIELD IC P83C654FBP/540 IC SAA5281ZP/E <CHIP CONDUCTOR> <CAPACITOR> C01 C02 C03 C04 C05 1-163-037-11 1-124-907-11 1-163-037-11 1-164-004-11 1-124-907-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT 0.022MF 10MF 0.022MF 0.1MF 10MF 10% 20% 10% 10% 20% 50V 50V 50V 25V 50V C06 C07 C08 C09 C10 1-163-227-11 1-163-009-11 1-163-231-11 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10PF 0.001MF 15PF 0.1MF 0.1MF 0.5PF 10% 5% 10% 10% 50V 50V 50V 25V 25V C11 C12 C13 C14 C15 1-164-004-11 1-164-004-11 1-163-009-11 1-216-295-91 1-104-668-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP SHORT ELECT 0.1MF 0.1MF 0.001MF 0 33MF 10% 10% 10% 25V 25V 50V 20% 35V C16 C17 C19 1-126-963-11 1-164-004-11 1-164-004-11 ELECT CERAMIC CHIP CERAMIC CHIP 4.7MF 0.1MF 0.1MF 20% 10% 10% 50V 25V 25V JR02 JR03 JR04 JR07 JR08 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JR09 1-216-295-91 SHORT 0 <COIL> L01 L03 L04 L05 L06 1-410-464-11 1-410-464-11 1-410-464-11 1-410-464-11 1-410-464-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 3.3UH 3.3UH 3.3UH 3.3UH 3.3UH <TRANSISTOR> Q01 Q02 Q03 Q04 Q05 – 65 – 8-729-120-28 8-729-027-43 8-729-120-28 8-729-120-28 8-729-920-72 TRANSISTOR 2SC1623-L5L6 TRANSISTOR DTC114EKA-T146 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SA1037K-T-146-QR KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. VM V1 REF. NO. PART NO. Q06 Q07 Q08 Q09 8-729-120-28 8-729-019-01 8-729-140-96 8-729-027-23 DESCRIPTION REMARK TRANSISTOR 2SC1623-L5L6 TRANSISTOR 2SD2394-EF TRANSISTOR 2SD774-34 TRANSISTOR DTA114EKA-T146 REF. NO. PART NO. * A-1347-116-A VM BOARD, COMPLETE ********************** 4-382-854-11 R01 R02 R03 R04 R05 1-216-061-00 1-216-057-00 1-216-085-00 1-216-025-91 1-216-057-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 3.3K 2.2K 33K 100 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R06 R07 R08 R09 R10 1-216-075-00 1-216-025-91 1-216-025-91 1-216-057-00 1-216-083-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 12K 100 100 2.2K 27K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R11 R12 R13 R14 R16 1-216-069-00 1-216-057-00 1-216-061-00 1-164-004-11 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP CERAMIC CHIP RES,CHIP 6.8K 2.2K 3.3K 0.1MF 10K 5% 5% 5% 10% 5% 1/10W 1/10W 1/10W 25V 1/10W R17 R18 R19 R20 R21 1-216-065-91 1-216-059-00 1-216-049-91 1-216-049-91 1-216-065-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7K 2.7K 1K 1K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R22 R24 R25 R26 R27 1-216-041-00 1-216-025-91 1-216-025-91 1-216-049-91 1-216-071-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 470 100 100 1K 8.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R28 R29 R30 R31 R32 1-216-025-91 1-216-025-91 1-216-071-00 1-216-025-91 1-216-071-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100 100 8.2K 100 8.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R33 R34 R35 R36 R37 1-216-065-91 1-216-065-91 1-216-065-91 1-216-025-91 1-216-049-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7K 4.7K 4.7K 100 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R38 R41 R42 R43 R44 1-260-095-11 1-216-063-91 1-216-077-00 1-216-295-91 1-216-083-00 CARBON RES,CHIP RES,CHIP SHORT RES,CHIP 470 3.9K 15K 0 27K 5% 5% 5% 1/2W 1/10W 1/10W 5% 1/10W R45 R46 R47 R48 R49 1-216-021-00 1-216-021-00 1-216-021-00 1-216-049-91 1-216-049-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 68 68 68 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W CN1701* CN1702* CN1703* CN1704* CN1705 R50 1-216-049-91 RES,CHIP 1K 5% 1/10W CN1901* 1-508-784-00 CN1902* 1-564-506-11 SCREW (M3X10), P, SW (+) <CAPACITOR> C1721 C1722 C1723 C1724 C1751 1-126-964-11 1-102-114-00 1-102-951-00 1-101-888-00 1-136-153-00 ELECT CERAMIC CERAMIC CERAMIC FILM 10MF 470PF 15PF 68PF 0.01MF 20% 10% 5% 5% 5% 50V 50V 50V 50V 50V C1761 C1762 C1763 C1764 C1768 1-161-830-00 1-102-951-00 1-107-638-11 1-126-933-11 1-106-383-00 CERAMIC CERAMIC ELECT ELECT MYLAR 0.0047MF 15PF 33MF 100MF 0.047MF 5% 20% 20% 10% 500V 50V 160V 16V 200V C1769 C1770 C1771 C1772 C1773 1-107-667-11 1-104-999-11 1-126-964-11 1-126-933-11 1-106-383-00 ELECT MYLAR ELECT ELECT MYLAR 2.2MF 0.1MF 10MF 100MF 0.047MF 20% 10% 20% 20% 10% 160V 200V 50V 16V 200V C1774 C1775 C1776 C1777 C1778 1-102-959-91 1-126-933-11 1-126-964-11 1-101-888-00 1-130-471-00 CERAMIC ELECT ELECT CERAMIC MYLAR 22PF 100MF 10MF 68PF 0.001MF 5% 20% 20% 5% 5% 50V 16V 50V 50V 50V C1779 C1780 C1781 C1782 C1783 1-130-471-00 1-126-964-11 1-107-714-11 1-136-153-00 1-136-153-00 MYLAR ELECT ELECT FILM FILM 0.001MF 10MF 10MF 0.01MF 0.01MF 5% 20% 20% 5% 5% 50V 50V 16V 50V 50V C1784 C1788 C1789 C1790 C1791 1-102-244-00 1-136-153-00 1-107-714-11 1-126-964-11 1-126-964-11 CERAMIC FILM ELECT ELECT ELECT 220PF 0.01MF 10MF 10MF 10MF 10% 5% 20% 20% 20% 500V 50V 16V 50V 50V C1841 C1844 C1845 C1846 C1901 1-136-155-00 1-108-700-11 1-137-194-81 1-126-964-11 1-136-060-00 FILM MYLAR FILM ELECT FILM 0.015MF 0.047MF 0.47MF 10MF 0.047MF 5% 10% 5% 20% 5% 50V 200V 50V 50V 400V <CONNECTOR> <CRYSTAL> 1-579-266-31 REMARK **************************************************************************** <RESISTOR> X01 DESCRIPTION CRYSTAL VIBRATOR – 66 – 1-564-509-11 1-564-510-11 1-564-506-11 1-564-506-11 4-352-844-01 PLUG, CONNECTOR 6P PLUG, CONNECTOR 7P PLUG, CONNECTOR 3P PLUG, CONNECTOR 3P PIN, LEAD, COATING PIN, CONNECTOR (5MM PITCH) 1P PLUG, CONNECTOR 3P KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. VM DESCRIPTION REMARK <DIODE> D1761 D1763 D1764 D1767 D1768 8-719-911-19 8-719-911-19 8-719-911-19 8-719-110-88 8-719-110-88 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE RD39ESB2 DIODE RD39ESB2 D1769 D1770 D1774 D1775 D1840 8-719-911-19 8-719-911-19 8-719-109-84 8-719-109-84 8-719-302-43 DIODE 1SS119-25 DIODE 1SS119-25 DIODE RD5.1ESB1 DIODE RD5.1ESB1 DIODE EL1Z D1841 D1842 8-719-911-19 8-719-109-84 DIODE 1SS119-25 DIODE RD5.1ESB1 <IC> IC1701 IC1702 8-759-729-03 8-759-700-42 IC NJM2903D IC NJM2904D <COIL> L1721 L1722 L1723 L1761 L1762 1-408-617-31 1-408-617-31 1-410-468-11 1-410-478-11 1-408-610-31 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 150UH 180UH 6.8UH 47UH 39UH L1841 L1843 L1901 1-459-075-00 1-459-104-00 1-459-104-00 COIL,DYNAMIC CONVERSION CHOKE COIL, WITH CORE COIL, WITH CORE <TRANSISTOR> Q1721 Q1722 Q1723 Q1756 Q1761 8-729-119-78 8-729-119-78 8-729-119-78 8-729-119-78 8-729-119-78 TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2785-HFE Q1762 Q1763 Q1764 Q1765 Q1766 8-729-119-76 8-729-017-05 8-729-119-78 8-729-017-06 8-729-119-78 TRANSISTOR 2SA1175-HFE TRANSISTOR 2SA1837 TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC4793 TRANSISTOR 2SC2785-HFE Q1767 Q1768 Q1769 Q1770 Q1771 8-729-142-86 8-729-119-78 8-729-119-76 8-729-119-78 8-729-119-76 TRANSISTOR 2SC3733 TRANSISTOR 2SC2785-HFE TRANSISTOR 2SA1175-HFE TRANSISTOR 2SC2785-HFE TRANSISTOR 2SA1175-HFE Q1777 Q1840 Q1841 8-729-326-11 8-729-119-78 8-729-195-82 TRANSISTOR 2SC2611 TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2958-L <RESISTOR> R1721 R1722 R1723 R1724 R1725 1-249-413-11 1-249-411-11 1-249-406-11 1-247-815-91 1-249-408-11 CARBON CARBON CARBON CARBON CARBON 470 330 120 220 180 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W REF. NO. PART NO. DESCRIPTION REMARK R1726 R1727 R1728 R1729 R1730 1-247-815-91 1-249-419-11 1-249-417-11 1-249-437-11 1-249-438-11 CARBON CARBON CARBON CARBON CARBON 220 1.5K 1K 47K 56K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R1731 R1732 R1736 R1753 R1762 1-247-815-91 1-249-419-11 1-249-419-11 1-249-425-11 1-247-815-91 CARBON CARBON CARBON CARBON CARBON 220 1.5K 1.5K 4.7K 220 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R1764 R1765 R1766 R1768 R1769 1-247-734-11 1-249-414-11 1-249-418-11 1-249-418-11 1-249-387-11 CARBON CARBON CARBON CARBON CARBON 39 560 1.2K 1.2K 3.3 5% 5% 5% 5% 5% 1/2W F 1/4W F 1/4W 1/4W 1/4W F R1770 R1772 R1774 R1775 R1776 1-249-435-11 1-249-432-11 1-215-912-11 1-249-417-11 1-249-432-11 CARBON CARBON METAL OXIDE CARBON CARBON 33K 18K 150 1K 18K 5% 5% 5% 5% 5% 1/4W 1/4W 3W F 1/4W F 1/4W R1777 R1778 R1779 R1780 R1781 1-249-438-11 1-249-430-11 1-249-414-11 1-249-420-11 1-249-410-11 CARBON CARBON CARBON CARBON CARBON 56K 12K 560 1.8K 270 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R1782 R1784 R1785 R1786 R1787 1-249-387-11 1-247-807-31 1-249-400-11 1-249-435-11 1-249-428-11 CARBON CARBON CARBON CARBON CARBON 3.3 100 39 33K 8.2K 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W F 1/4W 1/4W R1788 R1789 R1790 R1791 R1793 1-249-419-11 1-249-413-11 1-216-451-11 1-249-411-11 1-249-429-11 CARBON CARBON METAL OXIDE CARBON CARBON 1.5K 470 120 330 10K 5% 5% 5% 5% 5% 1/4W 1/4W 2W F 1/4W 1/4W R1794 R1795 R1796 R1797 R1800 1-215-892-11 1-249-389-11 1-249-377-11 1-215-862-11 1-249-429-11 METAL OXIDE CARBON CARBON METAL OXIDE CARBON 1K 4.7 0.47 68 10K 5% 5% 5% 5% 5% 2W 1/4W 1/4W 1W 1/4W R1801 R1805 R1806 R1812 R1816 1-249-437-11 1-249-429-11 1-249-429-11 1-249-425-11 1-249-415-11 CARBON CARBON CARBON CARBON CARBON 47K 10K 10K 4.7K 680 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R1817 R1818 R1819 R1820 R1841 1-249-429-11 1-249-429-11 1-249-403-11 1-249-417-11 1-249-435-11 CARBON CARBON CARBON CARBON CARBON 10K 10K 68 1K 33K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R1842 R1843 R1844 R1847 R1848 1-260-111-11 1-249-421-11 1-249-421-11 1-249-399-11 1-216-434-11 CARBON CARBON CARBON CARBON METAL OXIDE 10K 2.2K 2.2K 33 1.8K 5% 5% 5% 5% 5% 1/2W 1/4W 1/4W 1/4W F 1W F R1849 R1850 1-260-111-11 1-249-417-11 CARBON CARBON 10K 1K 5% 5% 1/2W 1/4W – 67 – F F F F KV-T29SN81 RM-870 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. VM REF. NO. PART NO. R1851 R1901 1-249-393-11 1-249-399-11 DESCRIPTION CARBON CARBON REMARK 10 33 5% 5% REF. NO. PART NO. 1/4W 1/4W F RES, ADJ, CARBON 10K <TRANSFORMER> T1901 1-413-059-00 REMARK ACCESSORIES AND PACKING MATERIALS ********************************* <VARIABLE RESISTOR> RV1814 1-241-764-11 DESCRIPTION TRANSFORMER, FERRITE (DFT) 3-701-910-00 3-861-432-62 * 4-029-168-01 * 4-053-737-01 * 4-053-740-01 SCREW, SPECIAL (DIA. 3.8X20) MANUAL, INSTRUCTION BAG, PROTECTION CUSHION (UPPER)(ASSY) CUSHION (LOWER)(ASSY) * 4-053-743-01 * 4-053-744-01 4-065-210-01 4-392-003-11 4-392-004-11 INDIVIDUAL CARTON TRAY JOINT BAND, HOLD CLIP **************************************************************************** **************************************************************************** MISCELLANEOUS ************* REMOTE COMMANDER **************** ! 1-403-672-12 1-452-032-00 1-452-278-22 1-452-278-32 1-452-762-31 COIL, DEMAGNETIZATION MAGNET,DISC MAGNET, PURITY MAGNET, PURITY NECK ASSEMBLY NA294 1-503-902-11 ! 1-574-358-51 1-900-700-10 ! 1-900-700-27 ! 8-451-467-21 SPEAKER (15X6.5 CM) CORD, POWER (WITH CONNECTOR) 7.5A/250V DGC BAND LEAD ASSY, FOCUS DEFLECTION YOKE (Y29GXA2-S) ! 8-733-868-05 PICTURE TUBE (M68KZT71X) 1-473-323-11 9-902-546-01 REMOTE COMMANDER (RM-870) BATTERY COVER, REMOTE COMMANDER **************************************************************************** Sony Corporation 9-965-741-01 SONY TV Industries (M) Sdn. Bhd. TV Business of General Area – 68 – English 99EG70068-1 Printed in Malaysia 1999. 5