Download SERVICE MANUAL

SERVICE MANUAL
MODEL
COMMANDER DEST.
KV-G21MW3
KV-G21QW3
CHASSIS NO.
RM-869 ME
SCC-U07U-A
RM-869 ME
SCC-U07T-A
BG-2S CHASSIS
MODEL
COMMANDER DEST.
CHASSIS NO.
TRINITRON ® COLOR TV
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
SPECIFICATIONS
Note
Power requirements
110-240 V AC, 50/60 Hz
Power consumption (W) Indicated on the rear of the TV
Television system
B/G
B/G, I, D/K, M
KV-G21MW3
Color system
PAL, PAL 60, SECAM, NTSC4.43, NTSC3.58
KV-G21MW3
PAL, PAL 60, SECAM, NTSC4.43
KV-G21QW3
KV-G21QW3
Channel coverage
VHF: E2 to E12 / UHF: E21 to E69 / CATV: S01 to S03, S1 to S41
Audio output (speaker)
3W + 3W
Inputs
˘ (antenna): 75 ohms external terminal
… (video input) jacks: phono jacks
D (video): 1 Vp-p, 75 ohms
≥ (audio): 500 mVrms, high impedance
Outputs
A (earphone) jack: mini jack
Ú (monitor output) jacks: phono jacks
D (video): 1 Vp-p, 75 ohms
≥ (audio): 500 mVrms
Picture tube
21 in.
Tube size (cm)
54
Measured diagonally
Screen size (cm)
51
Measured diagonally
Dimensions (w/h/d, mm) 516 × 464 × 478
Mass (kg)
22
Design and specifications are subject to change without notice.
CAUTION
SAFETY-RELATED COMPONENT WARNING!!
SHORT CIRCUIT THE ANODE OF THE PICTURE TUBE AND
THE ANODE CAP TO THE METAL CHASSIS, CRT SHIELD, OR
CARBON PAINTED ON THE CRT, AFTER REMOVING THE
ANODE.
COMPONENTS IDENTIFIED BY SHADING AND MARK ! ON
THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE
PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE
THESE COMPONENTS WITH SONY PARTS WHOSE PART
NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY.
–2–
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
TABLE OF CONTENTS
Section
Title
Page
SELF DIAGNOSIS FUNCTION ..................................
4
1. GENERAL ....................................................................
5
Section
Rear Cover Removal ............................................
A Board Removal ................................................
Service Position ...................................................
Replacement of Parts ...........................................
2-4-1. Replacement of Multi Button ....................................
2-4-2. Replacement of Light Guide .....................................
2-5.
2-6.
2-7.
Terminal Board Bracket Removal .......................
Demagnetization Coil Removal ..........................
Picture Tube Removal ..........................................
10
10
10
11
11
11
11
11
12
5-1.
5-2.
5-3.
(1)
(2)
5-4.
Beam Landing ......................................................
Convergence .........................................................
Focus Adjustment ................................................
Remote Commander Adjustment ........................
G2 (Screen) and White Balance Adjustments .....
6-1.
4-4.
Adjustments with Commander ............................
Adjustment Method .............................................
A Board Adjustment after IC003 (Memory)
Replacement .........................................................
Picture Distortion Adjustment .............................
43
7. ELECTRICAL PARTS LIST ....................................
45
13
14
15
16
16
17
18
23
23
–3–
http://cxema.ru
25
28
28
33
37
41
Chassis ..................................................................
4. CIRCUIT ADJUSTMENTS
4-1.
4-2.
4-3.
Block Diagram ......................................................
Circuit Boards Location .......................................
Schematic Diagrams and Printed Wiring Boards
Schematic Diagram of A Board ...........................
Schematic Diagram of C Board ...........................
Semiconductors .....................................................
6. EXPLODED VIEW
3. SET-UP ADJUSTMENTS
3-1.
3-2.
3-3.
3-4.
3-5.
Page
5. DIAGRAMS
2. DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
Title
KV-G21MW3/G21QW3
RM-869
SELF DIAGNOSIS FUNCTION
If no acknowledgement is returned from a device which is turned "ON", the device has a problem.
In this case, one of the LED's responding to the problem device will flicker a defined number of times.
Flickering is operated by lighting the LED's for 60ss each time.
The flickering frequency responding to each failed device is shown below.
Board name
Ref. No.
Device
A Board
A Board
IC003
IC300
NONVOLATILE
MEMORY
Y/C JUNGLE
(TDA8374A)
(ST24C08FB6)
Flickering Frequency
1
3
All the devices are checked one after another from the left of the table.
If an error is found, the responding LED will start flickering.
So, if more than 1 device have failed, only the one on the left side will flicker.
–4–
http://cxema.ru
The operating instructions mentioned here are partial abstracts
from the Operating Instruction Manual. The page numbers of
the Operating Instruction Manual remain as in the manual.
http://cxema.ru
2
GENERAL
SECTION 1
SELECT
– PROGR +
SELECTTV/VIDEO
– VOLUME +
VHF
LOW
B/G
1
1
– PROGR +
3
KV-G21MW3/G21QW3
RM-869
–5–
http://cxema.ru
4 -EN
Getting Started
Plug the connector into the
Rear of TV
Rear of TV
or
(antenna) socket at the rear of the TV.
Attach an optional IEC antenna connector to the 75-ohm coaxial cable.
On a wall
Connecting a VHF antenna or a combination VHF/UHF antenna
— 75-ohm coaxial cable (round)
Connections
Getting Started
Connecting optional equipment
D
–6–
≥
≥ D
D (video) and
≥ (audio) inputs
to …
(video input)
Ú
…
to antenna socket
…
… (video input) jack
VCR
to video and
audio outputs
to antenna
output
to video
and audio
outputs
Camcorder
: Signal flow
: Signal flow
≥ D
to video
and audio
inputs
to antenna
output
: Signal flow
Getting Started
5 -EN
Do not change the channel or video input while recording with a VCR; otherwise the channel or video input you are recording also will be
changed.
VCR
Ú (monitor output) jack
Ú (monitor output) jack
≥ (audio) outputs
D (video) and
to Ú
(monitor output)
Ú
…
When recording through the
Rear of TV
to antenna socket
Connecting audio/video equipment using the
Do not connect video equipment to the … (video input) jacks at the front and the rear of your TV simultaneously; otherwise the picture
will not be displayed properly on the screen.
When connecting video equipment to the
Rear of TV
D (video) and
≥ (audio) inputs
to …
(video input)
Front of TV
Connecting video equipment using the … (video input) jack
You can connect optional audio/video equipment to your TV such as a VCR, multi disc player, camcorder, or video
game.
EN
KV-G21MW3/G21QW3
RM-869
http://cxema.ru
–7–
–
.
+
–
TV
PROGR
+
U
U to turn on the TV.
R
SELECT
+/–
U
PROGR +/–
Number
u
– PROGR +
Getting Started
SELECT
1
2
3
Press SELECT and PROGR + on the TV
simultaneously for one to two seconds.
1
When the TV is turned on in standby mode, press
u on the remote commander.
Press
6 -EN
2
1
Quick channel presetting
SELECT TV/VIDEO
Front of TV
Remote commander
You can preset TV channels quickly, automatically or
manually.
You can preset up to 100 TV channels in numerical
sequence from program position 1 using the buttons on
the remote commander or the TV.
Presetting channels
Press +/– on the remote commander or . +/– on
the TV until the picture and sound becomes
normal.
Press SELECT on the remote commander or the TV
until “TV SYSTEM” appears.
4
3
2
1
or
SELECT
TV SYSTEM
. +
B/G
I
D/K
M
or
SELECT
AUTO PROGRAM
or
–
. +
VHF
LOW
Press +/– on the remote commander or
. +/– on the TV.
SELECT
B/G
1
Press SELECT on the remote commander or
the TV until “AUTO PROGRAM” appears on
the screen.
or
–
Press +/– on the remote commander or
. +/– on the TV to select the TV system
(for KV-G21MW3 only).
SELECT
Press SELECT on the remote commander or
the TV until “TV SYSTEM” appears on the
screen (for KV-G21MW3 only).
Presetting channels automatically
• If you do not know your local TV system, consult your nearest
authorized service center or dealer.
• The setting of the “TV SYSTEM” is memorized for each
program position.
Notes
2
1
If the picture color is poor and/or the sound is
noisy (for KV-G21MW3 only)
Select the appropriate TV system as follows:
or
–
. +
1
2
3
Press +/– on the remote commander or
. +/– on the TV again.
1
or
0
5
8
4
7
÷
2
1
9
6
3
or
4
3
2
1
– PROGR +
or
SELECT
TV SYSTEM
–
. +
B/G
I
D/K
M
or
SELECT
MANUAL PROGRAM
or
–
. +
Press +/– on the remote commander or
. +/– on the TV.
SELECT
Press SELECT on the remote commander or
the TV until “MANUAL PROGRAM” appears
on the screen.
or
Press +/– on the remote commander or
. +/– on the TV to select the TV system (for
KV-G21MW3 only).
SELECT
Press SELECT on the remote commander or the
TV until “TV SYSTEM” appears on the screen
(for KV-G21MW3 only).
Presetting channels manually
PROGR
To start presetting channels automatically
from the specified program position
Press PROGR +/– or number buttons on the remote
commander or PROGR +/– on the TV until the
required program position appears on the screen after
step 4 of “Presetting channels automatically”.
5
0
÷
2
5
8
1
4
7
3
6
9
or
– .
+
VHF
LOW
B/G
SELECT
or
SELECT
Press SELECT on the remote commander or
the TV.
Press PIC MODE on the remote commander.
Press +/– on the remote commander or
. +/– on the TV.
Press SELECT on the remote commander or
the TV until “MANUAL PROGRAM” appears
on the screen.
Press PROGR +/– or number buttons on the
remote commander or PROGR +/– on the TV
until the unused or unwanted program
position appears on the screen.
1
Press SELECT on the remote commander or
the TV.
or
picture appears on the screen.
Getting Started
7 -EN
To preset the disabled program position again
Preset the channel quickly, automatically or manually.
5
4
3
2
1
– PROGR +
Press +/– on the remote commander or
or
. +/– on the TV until the required channel
PROGR
Press PROGR +/– or number buttons on the
remote commander or PROGR +/– on the TV
until the required program position
appears on the screen.
Disabling program positions
7
6
5
KV-G21MW3/G21QW3
RM-869
http://cxema.ru
–8–
U
U to turn on the TV.
8
3
9
6
2
5
.
. +/– to adjust the volume.
Operations
Press
PROGR
To scan through program positions
Press PROGR +/– until the program position you
want appears.
÷
To select a two-digit program position, press
“-/--” before the number buttons.
For example: to select program position 25, press
“-/--”, and then “2” and “5”.
0
7
÷
2
5
1
4
To select a program position directly
Press the number button.
Select the TV program you want to watch.
When the TV is turned on in standby mode, press
u on the remote commander.
Press
8 -EN
3
2
1
Watching the TV
Operations
… F.
VIDEO
Press
¤.
MUTING
Muting the sound
To watch TV
Press ;.
Press
¤
;
…F
Watching the video input
U
1
If the power on the TV is turned off in standby mode, the
u indicator on the TV may remain alight for a while.
To turn off the TV completely
Press U on the TV.
1
WAKE UP TIMER:10M
WAKE UP TIMER:12H00M
After 12 hours
Press u on the remote commander or set
the Sleep Timer to turn off the TV in
standby mode.
If you want a particular TV program or video
input to be displayed using the Wake Up Timer,
select the TV program or video input.
No wake up timer
WAKE UP TIMER:OFF
After 10 minutes
B ©
Press B © repeatedly to set the timer.
The on-screen display appears and the B indicator
on the TV lights up.
• The Wake Up Timer starts immediately after the on-screen
display disappears.
• The last TV program position or video input just before the TV
turns into standby mode will appear when the TV is turned on
using the Wake Up Timer.
Notes
To cancel the Wake Up Timer, press B © repeatedly
until “WAKE UP TIMER: OFF” appears, or turn off the
main power of the TV.
3
2
1
You can set the TV automatically turned on as you
program.
Setting the Wake Up Timer
AUTO
B/G
DYNAMIC
EG
Press E G.
The program position, local system, and TV settings are
displayed on the screen.
To turn off the TV temporarily
Press u on the remote commander. The u indicator
on the TV lights up.
u
Displaying on-screen information
Turning off the TV
SLEEP TIMER:90M
After 90 minutes
SLEEP TIMER:OFF
After 60 minutes
SLEEP TIMER:60M
CI
No sleep timer
After 30 minutes
SLEEP TIMER:30M
C I.
Press +/– to select “
SELECT
: LANGUAGE /
: ENGLISH
Operations
9 -EN-EN
• You can also use SELECT and . +/– on the TV to select the
on-screen display language.
”.
LANGUAGE /
Press SELECT until the screen appears as
follows:
Note
2
1
SELECT
+/–
You can use buttons on the remote commander or the
TV to change the on-screen display language.
Changing the on-screen display
language
To cancel the Sleep Timer, press C I repeatedly
until “SLEEP TIMER: OFF” appears, or turn off the TV.
Press
You can set the TV automatically turned off as you
program.
Setting the Sleep Timer
• If no buttons or controls are pressed for more than two hours
after the TV is turned on using the Wake Up Timer, the TV
automatically turns into standby mode. If you want to
continue watching the TV, press any button or control on the
TV or remote commander.
KV-G21MW3/G21QW3
RM-869
http://cxema.ru
÷
0
SELECT
PIC MODE
–9–
SOFT
STANDARD
Soft picture
(good for video Normal
games)
picture
Operations
SELECT
Press SELECT until the item you want to
adjust appears.
10 -EN
1
Adjusting the picture setting
• If you change the picture mode after the following
adjustments, the adjustment changes in accordance with the
picture mode.
Note
DYNAMIC
High contrast
picture
Each time you press PIC MODE, the screen changes as
follows:
PIC MODE
Press PIC MODE until the mode you want
appears.
Selecting the picture mode
+/–
SOUND
MODE
• The sound mode feature is unavailable for your TV. Thus, the
SOUND MODE button on the remote commander is not used
for your TV.
Note on the SOUND MODE button
Adjusting the
picture
SHARPNESS
COLOR
HUE
(Operative for
NTSC signal
only)
BRIGHT
To adjust other items, repeat steps 1 and 2.
Press +/– to adjust the item.
…
–
.
+
–
PROGR
+
If the sound is distorted or noisy when
receiving programs through the ˘ (antenna)
terminal
Change the “TV SYSTEM” setting (for KV-G21MW3
only) in the on-screen display until the sound becomes
clear.
• Normally set “COLOR SYSTEM” to “AUTO”.
Note
If the picture is abnormal when receiving
programs through the … (video input) jack
Change the “COLOR SYSTEM” setting or adjust the
“COLOR” level in the on-screen display until the color
becomes normal.
If the picture color is abnormal when receiving
programs through the ˘ (antenna) terminal
Change the “TV SYSTEM” (for KV-G21MW3 only) or
“COLOR SYSTEM” setting or adjust the “COLOR”
level in the on-screen display until the color becomes
normal.
SELECT
Front of TV
• You can also use SELECT and . +/– on the TV to adjust the
picture setting.
Note
3
2
PICTURE
Each time you press SELECT, the screen changes as
follows:
/ Check the TV SYSTEM setting (for
KV-G21MW3 only).
Good picture
Noisy sound
/ This may be caused by reflections from
nearby mountains or buildings. A highly
directional antenna may improve the
picture.
Double images or “ghosts”
/ This may be caused by local interference
(e.g. cars, neon signs and hair dryers).
Adjust the antenna for minimum interference.
Dotted lines or stripes
/ Check the antenna.
/ Check the antenna connection on the TV
and on the wall.
/ Check the TV SYSTEM setting (for
KV-G21MW3 only).
Snowy picture
Noisy sound
If you have any problems, read this manual again and
check the countermeasure for each of the symptoms
listed below.
If the problem persists after trying the methods below,
contact your nearest authorized service center or dealer.
Troubleshooting
Additional Information
Additional Information
11-EN
WARNING
Do not install the appliance in a confined space, such as
a bookcase or built-in cabinet.
• When you turn on the TV, you may hear the “boon” sound
that is caused by the demagnetization of the TV. This does not
indicate a malfunction.
• The picture color may become abnormal if you change the
direction of your TV. To obtain the normal picture color, press
U on the TV to turn off the TV for five minutes and then turn
it on again.
• Design and specifications are subject to change without notice.
• All contents in the instruction manual are subject to change
without notice.
Notes
• The supplied remote commander is used on several models of
the TV. If you do not find instructions for some controls that
are on the remote commander, that means your TV does not
employ the features of those controls, e.g. L and SOUND
MODE.
Note on the remote commander
TV cabinet creaks
/ Even if the picture or the sound is normal,
changes in the room temperature
sometimes make the TV cabinet expand or
contract, making a noise. This does not
indicate a malfunction.
/ Adjust the COLOR level in the on-screen
display.
/ Check the COLOR SYSTEM setting.
No color
/ Press . +.
/ Press ¤.
Good picture
No sound
/ Press U or u.
/ Check the antenna connection.
/ Check the VCR connections.
/ Check the power cord connection.
/ Check the standby mode.
No picture
No sound
KV-G21MW3/G21QW3
RM-869
http://cxema.ru
2-2.
2-1.
– 10 –
Lever
A BOARD REMOVAL
REAR COVER REMOVAL
Lever
2 Two screws
(BVTP 4×16)
1 Four screws
(BVTP 4×16)
2-3.
SERVICE POSITION
DISASSEMBLY
SECTION 2
A board
KV-G21MW3/G21QW3
RM-869
2-4.
REPLACEMENT OF PARTS
http://cxema.ru
Cut
Multi button
– 11 –
Cut
Cut
Light guide
Light guide
2-4-2. REPLACEMENT OF LIGHT GUIDE
Cut
Multi button
2-4-1. REPLACEMENT OF MULTI BUTTON
• SCREWING TORQUE
7±1 kg•cm
Two screws
(BVTP 3×12)
• SCREWING TORQUE
7±1 kg•cm
Three screws
(BVTP 3×12)
For replacement of the Multi Button and Light Guide, cut the welded portions
from them, exchange with the new parts, and fix them with screws (+BVTP) respectively.
2-6.
A board
Picture tube
A board
2
Tension spring
1 Demagnetization coil
DEMAGNETIZATION COIL REMOVAL
Two claws
Terminal board bracket
TERMINAL BOARD BRACKET REMOVAL
Terminal board bracket
2-5.
KV-G21MW3/G21QW3
RM-869
http://cxema.ru
5 Deflection yoke
– 12 –
Cushion
2 A board
a
1 Turn up one side of the rubber cap in the direction indicated by the arrow a.
a
• REMOVING PROCEDURES
NOTE : After removing the anode, short circuit the anode of the picture tube and the
anode cap to the metal chassis, CRT shield or carbon paint on the CRT.
• REMOVAL OF ANODE-CAP
1 Anode cap
4 C board
PICTURE TUBE REMOVAL
6 Four screws
(Tapping screws)
2-7.
b
HOW TO HANDLE AN ANODE-CAP
1 Do not damage the surface of anode-cap with sharp shaped objects.
2 Do not press the rubber too hard so as not to damage the inside of anode-cap.
A metal fitting called the shatter-hook terminal is built into the rubber.
3 Do not turn the foot of rubber over too hard.
The shatter-hook terminal will stick out or damage the rubber.
•
3 When one side of the rubber cap is separated from the anode button, the anode-cap
can be removed by turning up the rubber cap and pulling it up in the direction of the
arrow c.
Anode button
c
2 Using a thumb press down, then pull up the rubber cap firmly in the direction indicated
by the arrow b.
b
KV-G21MW3/G21QW3
RM-869
KV-G21MW3/G21QW3
RM-869
SECTION 3
SET-UP ADJUSTMENTS
•
The following adjustments should be made when a complete
realignment is required or a new picture tube is installed.
•
These adjustments should be performed with rated power
supply voltage unless otherwise noted.
Perform the adjustments in the following order:
1. Beam Landing
Controls and switch should be set as follows unless otherwise noted:
2. Convergence
3. Focus
4. White Balance
Note : Test Equipment Required:
1. Color-bar/Pattern Generator
2. Degausser
PICTURE control ........................................................... normal
BRIGHTNESS control ................................................... normal
3. Oscilloscope
..............................................................................................................................................................................................................................
Preparation :
•
In order to reduce the influence of geomagnetism on the set's
picture tube, face it east or west.
•
Switch on the power and degauss with the degausser.
Purity control
3-1. BEAM LANDING
1. Input a white signal with the pattern generator.
Contrast
Brightness
}
normal
Fig. 3-2
2. Set the pattern generator raster signal to green.
3. Move the deflection yoke to the rear and adjust with the purity
control so that the green is at the center and the blue and the red
take up equally sized areas on each side.
BLUE
(See Figures 3-1 through 3-3.)
4. Move the deflection yoke forward and adjust so that entire
RED
GREEN
screen is green. (See Figure 3-1.)
5. Switch the raster signal to blue, then to red and verify the
condition.
6. When the position of the deflection yoke has been decided,
fasten the deflection yoke with the screws.
7. If the beam does not land correctly in all the corners, use a
Fig. 3-3
Purity control corrects
this area.
magnet to adjust it. (See Figure 3-4.)
b
a
c
d
Disk magnets or rotatable
disk magnets correct
these areas (a-d).
Deflection yoke positioning
corrects these areas.
b
c
Fig. 3-1
a
d
Fig. 3-4
– 13 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
•
3-2. CONVERGENCE
Preparation :
• Before starting this adjustment, adjust the focus, horizontal size,
•
and vertical size.
Minimize the brightness setting.
•
Provide dot pattern.
Operation of V.STAT magnet.
If the V.STAT magnet is moved in the direction of the a and
b arrows, the red, green and blue dots move as shown below.
1
a
a
b
(1)
b
Horizontal and Vertical Static Convergence
b
B
B
G
G
R
R
Center dot
R
2
G
a
a
B
R
G
R
B
G
B
V.STAT Magnet
b
b
B
G
R
3
b
RV 701
SCREEN (G2)
C board
a
a
b
R
B
G
b
1. (Moving vertically), adjust the V.STAT magnet so that the red,
green and blue dots are on top of each other at the center of the
•
screen.
2. (Moving horizontally), adjust the H.STAT VR so that the red,
green and blue dots are on top of each other at the center of the
screen.
Purity
G
B
Operation of BMC (Hexapole) magnet.
If the blue or red dot does not converge with the other two dots,
perform following steps.
Move BMC magnet (a) to correct insufficient H.static
convergence.
Rotate BMC magnet (b) to correct insufficient V.static
convergence.
In either case, repeat Beam Landing Adjustment.
BMC magnet
a
V.STAT
b
– 14 –
http://cxema.ru
R
KV-G21MW3/G21QW3
RM-869
(2) Dynamic Convergence Adjustment
Preparation :
•
Before starting this adjustment, adjust the horizontal static
convergence and the vertical static convergence.
R
B
G
R
G
1. Slightly loosen the deflection yoke screws.
2. Remove the deflection yoke spacer.
B
G
R
G
B
B
R
3. Move the deflection yoke as shown in the figure below and
optimize the convergence.
B
4. Tighten the deflection yoke screws.
5. Install the deflection yoke spacer.
R
G
B
B
G
G
R
R
G
B
R
B
R
G
B
G
R
G
B
G
R
R
B
(3) Screen-corner Convergence
3-3. FOCUS ADJUSTMENT
a
b
Adjust FOCUS control on the flyback transformer for the best
focus.
a-d : screen-corner
misconvergence
c
d
Fix a Permalloy assy
corresponding to the
misconverged areas
b
a
FOCUS
SCREEN
(NOT USED)
Note: Screen VR is not used.
c
d
a to d : Permalloy assembly
– 15 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
3-4. REMOTE COMMANDER ADJUSTMENT
3-5. G2 (SCREEN) AND WHITE BALANCE
ADJUSTMENTS
a. AN ITEM OF ADJUSTMENT
Item
Adjustment
Initial DATA
number Item
1. G2 (SCREEN) ADJUSTMENT (RV701)
1) Set the PICTURE and BRIGHTNESS to normal.
Note
09
RDR
28
WHITE POINT R
0A
GDR
20
WHITE POINT G
2) Put to VIDEO input mode without signals.
3) Connect R, G and B of the C board cathode to the oscilloscope.
0B
BDR
20
WHITE POINT B
4) Adjust G2 (RV701) volume to the value below.
b. METHOD OF CANCELLATION FROM SERVICE
MODE
Set the standby condition (Press POWER button on the
commander) and then press POWER button again, hereupon it
177 ± 2 V DC
becomes TV mode.
0V
c. METHOD OF WRITE FOR MEMORY
1) Set to Service Mode.
2) Press 1 (UP) and 4 (DOWN) to select an item of adjustments.
3) Press MUTING button and it will indicate WRITE on screen.
4) Press - button to write into memory.
d. MEMORY WRITE CONFIRMATION METHOD
1) After adjustment, pull out the plug from AC outlet, and then
plug into AC outlet again.
2) Turn the power switch ON and set to Service Mode.
2. WHITE BALANCE ADJUSTMENTS
1) Set to Service Mode.
2) Input an entire white signal.
3) Set the PICTURE to maximum.
4) Select RDR(09) with 1 and 4 , and then set the level to 25
with 3 and 6 .
5) Select GDR(0A) and BDR(0B) with 1 and 4, and adjust
the level with 3 and 6 for the best white balance.
6) Write into the memory by pressing MUTING , then - .
3) Call the adjusted items again, confirm they were adjusted.
09 RDR 1 F
SERVICE
058S/ V3.2C 00
60
060S
PAL or
NTSC
German A2 Stereo
Software Version #
OEM CODE
09
RDR
1F
058S/ V3.2C
060S
WRITE
00
MUTING
60
Green
0
Executes the writing
09
RDR
1F
WRITE
0
Executes the writing
(bottom line disappears)
– 16 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
SECTION 4
CIRCUIT ADJUSTMENTS
4-1. ADJUSTMENTS WITH COMMANDER
Service adjustments are made with the RM-869 that comes with
this unit.
Entering service mode
With the unit on standby
1, 4
Raise/lower the service item number
3, 6
[MUTING]
Raise/lower the data
Writes
-
Executes the writing
7, -
All data becomes the values in memory
8, 5, -
All user control goes to the standard state
Service data initialization (Be sure not to use
2, -
usually.)
Write 50Hz adjustment data to 60Hz, or
↓
DISPLAY
↓
5
↓
VOL (+)
↓
POWER
The operation sequence puts the unit into service mode.
viceversa.
The screen display is :
1
Adjustment item
Item #
¤
EG
u
V
…F
;
00
1
2
3
4
5
6
8
9
7
HSF
058S/ V3.2C
060S
Data
Mode
08
SERVICE
00
50
Mode
Depends on the signals
PAL, SECAM : 50
NTSC
: 60
German A2 Stereo
Software Version #
OEM CODE
0
SOUND
MODE
A/B
.
PROGR
+
+
2
H
B©
CI
+
–
p
SELECT p
p
PIC MODE p
3D
OP0
00
SERVICE
0000
0000
00
50
TV
(Bit options adjustable)
RM-869
1, 4
Select the adjustment item.
↓
3, 6
Raise/lower the data.
↓
MUTING
↓
-
– 17 –
http://cxema.ru
Writes
Executes the writing.
KV-G21MW3/G21QW3
RM-869
4-2. ADJUSTMENT METHOD
Item Number 08
This explanation uses V-SHIFT as an example.
Use the same method for Items Number 00-40. Use 1 and 4 to
1. Select 08 V-SHIFT with the 1 and 4 buttons.
2. Raise/lower the data with the 3 and 6 buttons.
select the adjustment item, use 3 and 6 to adjust, write with
MUTING , then execute the write with -.
3. Select the optimum state. (The standard is 0F for PAL
reception.)
4. Write with the MUTING button.
5. Execute the writing with the - button. (The WRITE
display returns to green SERVICE.)
08
VSF
058S/ V3.2C
060S
0C
SERVICE
GREEN
50
00
Adjusted with 3 and 6 buttons
08
VSF
058S/ V3.2C
060S
0C
WRITE
00
GREEN
50
Written with MUTING
08
VSF
0C
WRITE
Blank
GREEN
The WRITE display
will change back to
SERVICE.
(2nd line disappear
when written)
Write executed with 0
– 18 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
Adjustment Item Table
No.
Item Data Range Initial
(OSD) Max. Min.
Data
00
01
02
03
04
05
06
07
08
09
0A
0B
0C
0D
0E
0F
10
11
12
13
14
15
16
17
18
19
1A
1B
1C
HSF
HSZ
PAP
CNP
TLT
VSL
VAP
SCR
VSF
RDR
GDR
BDR
FO
AGC
VSW
FOR
DL
POC
COR
VPX
PMX
PMI
SBR
SHU
SSH
SC1
SC2
AIP
VZM
3F
3F
3F
3F
3F
3F
3F
3F
3F
3F
3F
3F
03
3F
1
03
1
1
1
FF
3F
3F
7F
0F
03
3F
3F
7F
3F
00
00
00
00
00
00
00
00
00
00
00
00
00
00
0
00
0
0
0
00
00
00
00
00
00
00
00
00
00
0
0
0
0
0
0
0
0
0
28
20
20
0
0
0
03
0
0
0
00
27
04
4B
07
0
0
0
3C
19
H Shift [2C/33/31/38]
HSize [35/35/35/35]
Pin Amplitude [25/25]
Corner Pin [10/0C]
Tilt [20/2D]
V Slope [1F/1F]
V Amplitude [1C/1B]
S Correction [16/16]
V Shift [10/10]
R Drive
G Drive
B Drive
ø1 Time Constant [00/00/00]
AGC Take Over [28/28/28]
Video Mute Switch [0/1/0]
Forced Field Frequency
De-interlace
Fixed ø1 Synchro. mode
Noise Coring [01/00/00]
Extra Bits (see below)
Picture Maximum Data
Picture Minimum Data
Sub Brightness
Sub Hue
Sub Sharpness [01/03]
Sub Color Lower [26/29]
Sub Color Higher [0C/0D]
Adjustment IF-PLL
Vertical Zoom
1D
1E
1F
20
21
22
23
24
25
26
27
28
29
2A
2B
2C
2D
2E
2F
WST
WBT
WLL
ACG
CDB
FGP
FMP
FMH
FMM
WGP
NIP
SCP
SCV
CRM
ACO
WAC
NFT
DLG
DLN
FF
FF
FF
1
3F
7F
7F
7F
7F
7F
7F
7F
7F
1
1
0F
FF
FF
FF
00
00
00
0
00
00
00
00
00
00
00
00
00
0
0
00
00
00
00
15
EA
05
1
28
1B
32
36
65
2A
6D
3B
2A
0
1
00
50
30
20
W/G Stereo Threshold
W/G Bilingual Threshold
W/G Monaural Threshold
AGC Switch auto/constant
AGC Gain at Constant Mode
FM Prescale for B/G, I, D/K
FM Prescale for M
FM Prescale for HDEV (non-M)
FM Prescale for HDEV (M)
W/G Prescale
NICAM Prescale
SCART Input Prescale
SCART Output Prescale
Carrier Muting on/off
Audio Clock-out on/off
W/G Agreement Count
Auto FM Switch Threshold
W/G Search Delay
NICAM Search Delay
MSP3410D(80)
30
31
DLS
SMX
FF
7F
00
00
10
0
Stereo Status Read Delay
DFP Volume Maximum 72
MSP3410D(80)
32
33
ING
VOM
0F
3F
00
00
00
01
Input Gain [03/00/00]
Volume Output Gain
34
TXH
03
00
01
Teletext Horizontal Position
Function
Note for Different Data
50/60Hz/RGB50/RGB60
50/60Hz/RGB50/RGB60
50/60Hz
50/60Hz
50/60Hz
50/60Hz
50/60Hz
50/60Hz
50/60Hz
Register
No. (bit)
TDA8375(8A)
03 (5-0)
04 (5-0)
05 (5-0)
06 (5-0)
07 (5-0)
08 (5-0)
09 (5-0)
0A (5-0)
0B (5-0)
0C (5-0)
0D (5-0)
0E (5-0)
00 (3-2)
13 (5-0)
13 (6)
01 (7-6)
01 (5)
01 (3)
10 (6)
TV/Video/Teletext
TV/Video/Teletext
TV/Video/Teletext
TV/Video/Teletext
TV/Video/Teletext [28/28/28]
12 (5-0)
12 (5-0)
10 (6-0)
02 (3-0)
0F (1-0)
11 (5-0)
11 (5-0)
15 (6-0)
16 (5-0)
TV/Video
50/60Hz
50/60Hz
BB (7)
BB (6-1)
0E (7-0)
0E (7-0)
0E (7-0)
0E (7-0)
0E (7-0)
10 (7-0)
0D (7-0)
07 (7-0)
BB (9)
83 (5)
21 (10-3)
00 (14-8)
M system/non-M/Video
M system only
– 19 –
http://cxema.ru
Device/Category
(Slave Address)
TDA7438(88)
01 (3-0)
02 (5-0)
SAA5261(58)
16 (1-0)
KV-G21MW3/G21QW3
RM-869
Adjustment Item Table
No.
35
36
37
38
39
3A
3B
3C
3D
3E
3F
40
41
Item Data Range Initial
(OSD) Max. Min.
Data
BKP
ODL
OFR
OFM
OSH
DKS
MUT
ABL
SCM
FBT
OP0
OP1
OP2
3F
FF
0F
0F
3F
1
1
1
1
1
FF
FF
FF
00
00
00
00
00
0
0
0
0
0
00
00
00
00
10
00
00
0A
1
0
0
0
1
2F
0F
00
Function
Note for Different Data
Picture Data at Blanking OFF
Power ON Delay
RGB Output Time (STBY OFF)
RGB Output Time (AC OFF)
OSD H Position
D/K Stereo enable/disable
Muting on/off at No Sync
Bright ABL Switch
SECAM Trap active/ inactive
FBT L/S C /M Strict/plain
Optional Flags 0 (see below)
Optional Flags 1 (see below)
Optional Flags 2 (see below)
– 20 –
http://cxema.ru
Device/Category
(Slave Address)
Other Control
Register
No. (bit)
KV-G21MW3/G21QW3
RM-869
NOTE
• Note for Different Data
Those are the standard data values written on the microprocessor. Therefore, the data values of
the modes are stored respectively in the memory.
In case of a device replacement, adjustment by rewriting the data value is necessary for some
items.
• 50 .............. 50 Hz data
• 60 .............. 60 Hz data
• Note for Different Data listed on the adjustment item table are reference values, therefore it is different for every model.
Option Note
Item No 13 VPX
Item
HCO
EVG
SBL
PRD
–
–
–
VID
G21MW3
0
0
0
0
0
0
0
0
G21QW3
0
0
0
0
0
0
0
0
HCO
EVG
SBL
PRD
VID
EHT Tracking Mode
1 = on V and E–W.
Enable Vertical Guard
1 = enable.
Service Blanking
1 = active.
Over-voltage Protection Detection
Video Ident Mode
1 = not for ø1-loop
0 = only on V
0 = disable
0 = inactive
1 = enable.
0 = disable
0 = for ø1-loop
0A (7)
0A (6)
0B (7)
0B (6)
09 (7)
Item No. 3F OP0
Item
No TOP
AVMUT
B/G
I
D/K
M
G21MW3
0
0
AV input
1
0
1
1
1
1
G21QW3
0
0
1
0
1
0
0
0
SECAM
2nd Lang.
AV Input
0 0 no AV input model
0 1 1 AV input model
1 0 2 AV input model
1 1 2 AV input and RGB input model
No TOP (for teletext model)
1 = only FLOF available.
0 = both FLOF and TOP available
AV MUT 1 = AV multi is always muted if no signal input. 0 = not muted always
Other optional bits are effective if set to 1.
Item No. 40 OP1
Item
No NICAM
–
HDEV
1 V-Curve
XTAL SEL
G21MW3
0
0
0
0
1
1
1
1
G21QW3
0
0
0
0
0
0
1
1
XTAL SEL 0 0 only 4.43 XTAL
0 1 only 3.58 XTAL
1 0 (not used)
1 1 both 4.43 and 3.58 XTAL
1 V-Curve (for monaural model)
1 = using common volume curve for every mode and every TV system
0 = another volume curve available for video mode and M system
HDEV
1 = High Deviation Mode switch available. 0 = not available
No NICAM 1 = NICAM search is disabled in any TV system,
0 = NICAM search operates
Other optional bits are effevctive if set to 1.
Item No. 41 OP2
Item
–
–
No Bal.
TV Out
Hotel
VM
D.B.F.B.
Thai Bil.
G21MW3
0
0
0
0
0
0
0
0
G21QW3
0
0
0
0
0
0
0
0
No Bal. (for AV stereo model) 1 = no balance in analog select items.
0 = balance included
Other optional bits are effective if set to 1.
Hotel TV mode should be switched with remote commander from STBY condition as below.
Hotel TV on : push “display”. “8”. “vol +” and “power” sequentially
Hotel TV off : push “display”. “8”. “vol –” and “power” sequentially
– 21 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
Operation Guide
How to set up new NVM (or initialize already written one)
(1) AC On
(2) Enter Service Mode – describing below how to enter
(3) Push the commander button “5” and “0” sequentially (only set initial data into RAM, but not write them into
NVM yet)
(4) Push the commander button “2” and “0” sequentially (copy the data into all NVM area – all wide modes and
50/60Hz respectively)
(5) Push the commander button “8” and “0” sequentially (initialize user data, select program 1 and exit Service
Mode)
(6) Select TV system and execute Auto Preset
How to enter Service Mode
• At power ON, push the commander button “test” and “TV ON” sequentially
• At stand-by, push the commander button “display”, “5”, “vol +” and “power” sequently
How to exit Service Mode
Push the commander button “other ON” or power (AC) OFF
How to increment/decrement items and data
• Items
:
push the commander button “1”/”4”
• Data
:
push the commander button “3”/”6” (not write into NVM)
Other operations
• Write data into NVM - push the commander button “mute” and “0” sequentially
• Read data from NVM - push the commander button “7” and “0” sequentially
• Copy 50Hz data into 60Hz area - push the commander button “display” and “0” sequentially
Modification Note
[V3.2] • “4 S-Mode” optional bit was added in “OP2” for 4 sound modes available for ME market.
[V3.3] • “FBT” was added for the switch of strict and plain FBT layer short C/M operation.
[V3.4] • “4 S-Mode” optional bit in “OP2” was removed for 4 modes available for all destinations.
[V3.6] • “TXH” is now available in teletext mode and “TXV” was deleted due to no need.
[3.9] • “No NICAM” optional bit in “OP1” was added to disable NICAM search in A2 stereo area.
[V4.2] • “HSF” and “HSZ” for RGB input (50/60Hz) were made to be independent.
[V4.4] • “FMM” was added for FM prescale of high deviation forced monaural in M system.
[V4.7] • Initial data were changed for some service items.
– 22 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
4-3. A BOARD ADJUSTMENT AFTER IC003
4-4. PICTURE DISTORTION ADJUSTMENT
(MEMORY) REPLACEMENT
Item Number 00 – 08
1. Enter to Service Mode.
00
HSF (H SHIFT)
01
HSZ (H SIZE)
02
PAP (PIN AMPLITUDE)
03
CNP (CORNER PIN)
04
TLT (TILT)
05
VSL (V SLOPE)
06
VAP (V AMPLITUDE)
07
SCR (S CORRECTION)
08
VSF (V SHIFT)
2. Press commander buttons 5 and - (Data Initialize), and 2
and - (Data Copy) to initialize the data.
3. Call each item number, and check if the respective screen shows
the normal picture.
In case some items are not well-adjusted, give them fine
adjustment.
Write the data per each item number ( MUTING + -).
4. Select item numbers “3F” (OP0), “40” (OP1) and “41” (OP2)
and respectively set the bit per model with command buttons
3 and 6.
5. Press commander buttons 8 and - (Test Normal) to return
to the data that was set on shipment from the factory.
(= Cancel Service Mode.)
– 23 –
http://cxema.ru
http://cxema.ru
5-1. BLOCK DIAGRAM
VIDEO
IN 1
(REAR)
VIDEO
IN 1
(FRONT)
VIDEO
– 25 –
L (MONO)
VIDEO
L (MONO)
TU
A
L/H
Q110
7
VOL S904
SEL
S906
VOL +
S903
Q1209
BUFFER
NICAM
ST/BY
X101
TSW1 8
TSW0 7
SIRCS 26
HSYNC 47
HSYNC 25
IICLK1 55
IIDAT1 53
G 50
MUTE 11
54 IIDAT0 BRT ABL 42
56 IICLK0 VPULSE 17
VSYNC 48
HDSW 27
6
RESP/
NICAM
Q903
LED
DRIVE
34 XTAL
35 EXTAL
36 RESET
41 KEY1
40 KEY2
38 VC
59 L/H
60 U/V
3 TIMER
+5V
FILTER
IC001
SYSTEM CONTROLLER
SWF401
KV-G21DK2
ONLY
Q403, 404
5
3
IC1211
AUDIO SW
7
Q202
1
2
IC004 IR DET
6 CLK
5 DAT
IC003 MEMORY
G BUFFER
Q303
MUTE
+5V
+7V
L MUTE
BUFFER
Q1265
X443
4.43MHz
X358
3.58MHz
IC300
Y/C JUNGLE
IF OUT 6
CVBS IN EXT R 21
G 20
DE
LUMA IN
B 19
IF IN
IK 18
IF IN
AGC
8 SDA
7 SCL
33
40
45
46
47
39
38
ABL 22
EHTX-RAY 50
R-Y 32
B-Y 31
CVBS OUT
35 4.43/3.58
SECAM
HOR OUT
EAST/WEST
VERT POS
VERT NEG
BLK/STC
34 3.58
41 SSCP/FBT
CVBS IN INT 13
SIF IN 1
B-Y 30
R-Y 29
11
55
17
48
49
54
L SP MUTE
Q210
11 L IN
L OUT 5
IC203
AUDIO OUT
RM-869
RM-869
Q1207, 1208
KV-G21MW3/G21QW3
KV-G21MW3/G21QW3
LED
DRIVE
Q902
OUT 5
1 IN
RESET 4
IC002 +5V REG
VC AMP
Q109
BUFFER
Q108
IF BUFFER
Q402
BUFFER
Q1202
+5V D901
TIMER
+9V
VC FILTER
CH S902
AGC
IF
6
5
IC1210
TV/VIDEO
S905
CH +
S901
U/V
TU101 TUNER
BUFFER
Q1201
TUNER, IF, Y/C JUNGLE,
SECAM DECODER, H/V OUT
SYSTEM CONTROLLER, MEMORY
AUDIO/VIDEO IN/OUT, POWER SUPPLY
DIAGRAMS
SECTION 5
DK 7
3 A
4 B
D591
D1505
X RAY
Q561
V SAW
Q1513
+135V
– 26 –
SYNC 5
11 R-Y R-Y 16
12 B-Y B-Y 14
D561
B-Y 12
1 S REF
R-Y 11
19 SYNC
SYNC
FILTER
Q406, 408
B/G SW
Q417, 414
M SW
Q418, 416
I SW
Q415, 412
DK SW
Q413, 411
KV-G21MW3
only
IC351 1HDL
M 2
B/G 1
I 8
TV
SYSTEM
SELECTOR
SP
J251
EARPHONE
MONITOR
OUT
IC354 SECAM
CN103
IC401
R
G
B
IK
CN251
L (MONO)
J1201
VIDEO
KV-G21MW3
only
Q410
CT65,CF65
SYNC
FILTER
Q409
CT55,CF55
SYNC
FILTER
Q405
CT45,CF45
SYNC
FILTER
Q407
CT60,CF60
SYNC
FILTER
+9V
+B
+11V
+18V
+15V
–13V
+135V
+9V
REG
IC521
CN703
6
5
4
1
10
9
7
1
4
2
11
13
14
15
16
17
R
G
B
IK
T851 FBT
T601 SRT
7
8
5
4
3
13
6
11
5
HV
Q704
B AMP
Q710
G AMP
G DRIVE
B DRIVE
Q705
FV
Q706
R AMP
Q711
R DRIVE
Q712
C (RGB OUT)
H PROT
Q030
1
1
6
+
–
7
IC801 (1/2)
PIN CONT
5
Q707
IK LIMIT
IC801 (2/2)
PIN CONT
3
Q708
IK LIMIT
DRIVE
4
2
IC551 V OUT
PIN OUT
Q821
H DRIVE
Q801
2
IC602 ERROR AMP
2
1
Q709
IK LIMIT
L804
T801
5
H2
RV701
G2
6
8
9
S801
H SENT
H OUT
Q802
D801, 891
2
3
1
4
IC603 PHOTO COUPLER
OVP
IC601 REG SW
1 8
J701
DUMPER
7
OSC
LATCH
12
11
10
V+
V–
H–
H–
H+
H+
200V
1000V
H1
1000V
200V
H1
6
5
3
4
1
2
2
1
4
1
2
4
DY1
CN851
CN701
V+
V–
H+
H–
– 27 –
DY ASS'Y
V901
PICTURE TUBE
VDY
HDY
RM-869
KV-G21MW3/G21QW3
A
÷
«
»
Note:
• All capacitors are in µF unless otherwise noted.
• All electrolytic capacitors are rated at 50V unless otherwise noted.
• All resistors are in ohms.
kΩ = 1000Ω, MΩ = 1000kΩ
• Indication of resistance which does not have rating electrical
power is as follows.
Pitch: 5 mm
Rating electrical power 1/4W (CHIP: 1/10W)
•
: nonflammable resistor.
•
¢
: internal component.
•
: panel designation or adjustment for repair.
• All variable and adjustable resistors have characteristic curve B
unless otherwise noted.
• Readings are taken with a color-bar signal input.
no mark : PAL
(
) : SECAM
[
] : NTSC 3.58
: NTSC 4.43
• Readings are taken with a 10 MΩ digital multimeter.
• Voltage is dc with respect to ground unless otherwise noted.
• Voltage variations may be noted due to normal production
tolerances.
• All voltages are in V.
∗
: Cannot be measured.
•
• Circled numbers are waveform reference.
•
: B + bus.
•
: B – bus.
•
: signal path.
– 28 –
Note:
METAL FILM
SOLID
NONFLAMMABLE CARBON
NONFLAMMABLE FUSIBLE
NONFLAMMABLE METAL OXIDE
NONFLAMMABLE CEMENT
NONFLAMMABLE WIREWOUND
ADJUSTMENT RESISTOR
MICRO INDUCTOR
TANTALUM
STYROL
POLYPROPYLENE
MYLAR
METALIZED POLYESTER
METALIZED POLYPROPYLENE
BIPOLAR
HIGH TEMPERATURE
HIGH RIPPLE
The component identified by shading and
mark ! are critical for safety. Replace only
with part number specified.
Reference information
RESISTOR
: RN
: RC
: FPRD
: FUSE
: RS
: RB
: RW
:*
COIL
: LF-8L
CAPACITOR : TA
: PS
: PP
: PT
: MPS
: MPP
: ALB
: ALT
: ALR
5-3. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS
C
5-2. CIRCUIT BOARDS LOCATION
RM-869
KV-G21MW3/G21QW3
IC
D-11
E-10
E-10
I-13
E-10
E-7
E-7
B-7
B-10
B-4
D-8
D-7
B-7
E-8
J-6
J-8
H-7
H-7
G-6
A-2
B-3
Q001
Q002
Q030
Q031
Q108
Q109
Q110
Q201
Q202
Q207
Q208
Q209
Q210
Q212
Q300
Q301
Q302
Q303
Q401
Q402
Q403
Q404
Q405
Q406
Q407
Q408
Q409
Q410
Q411
Q412
Q413
Q414
Q415
Q416
Q417
Q418
Q561
Q601
Q801
Q802
F-7
C-10
C-12
C-8
D-2
E-12
E-3
B-10
C-9
B-10
B-10
B-9
B-9
B-11
C-10
C-7
D-7
D-7
D-2
D-4
E-4
E-4
C-6
B-7
B-6
C-7
C-6
B-6
C-6
C-5
B-5
C-5
B-5
B-5
B-6
B-5
I-6
G-11
D-2
F-1
TRANSISTOR
IC001
IC002
IC003
IC004
IC005
IC100
IC102
IC201
IC203
IC300
IC351
IC354
IC401
IC521
IC551
IC601
IC602
IC603
IC801
IC1210
IC1211
E-6
D-10
D-11
A-3
A-3
A-2
B-2
B-3
A-2
A-2
B-2
C-4
C-1
C-1
G-6
D001
D002
D003
D004
D005
D006
D007
D008
D101
D102
D103
D200
D201
D202
D251
D252
D253
D300
D301
D302
D304
D305
D306
D307
D308
D309
D310
D311
D312
D315
D351
D399
D401
D402
D403
D513
D551
D561
D562
D581
D582
D591
D600
D601
D602
D603
D604
D605
D-9
C-12
C-10
E-12
E-8
H-13
E-10
H-13
C-9
C-9
D-1
A-10
B-9
C-9
B-8
F-11
C-9
D-4
D-8
C-8
C-8
D-7
E-6
D-5
C-10
D-6
D-9
D-9
C-5
E-5
E-8
E-5
E-4
C-5
C-9
G-6
J-5
G-5
F-6
H-5
I-5
I-5
F-9
H-12
G-11
G-11
G-7
G-8
DIODE
Q821
Q902
Q903
Q1201
Q1202
Q1203
Q1204
Q1205
Q1206
Q1207
Q1208
Q1209
Q1264
Q1265
Q1513
D606
D607
D609
D610
D611
D613
D614
D615
D801
D802
D803
D820
D821
D851
D852
D853
D855
D857
D858
D860
D901
D1201
D1202
D1203
D1204
D1205
D1206
D1207
D1208
D1209
D1504
D1505
G-8
I-8
J-9
H-8
I-7
E-9
E-10
E-10
F-2
F-2
D-9
G-6
G-7
I-4
H-4
J-3
J-4
F-3
F-4
E-2
H-13
A-2
B-1
B-2
A-2
C-1
C-2
B-2
B-2
B-3
G-6
G-6
– 29 –
J
I
H
G
F
E
D
C
B
A
1
2
3
4
[SYSTEM CONTROLLER, Y/C JUNGLE, DEFLECTION,
TUVIF, FRONT AMP, POWER SUPPLY]
– A Board –
A
PRINTED WIRING BOARD
5
6
7
8
9
10
– 30 –
11
12
13
1.0Vp-p (H)
13 NTSC
1.0Vp-p (H)
11 NTSC
2.3Vp-p (H)
9 NTSC
1.0Vp-p (H)
149Vp-p
14
0.7Vp-p (H)
12 PAL
2.2Vp-p (H)
10 PAL
PAL : 2.7Vp-p (H)
SECAM : 2.9Vp-p (H)
1.0Vp-p (H)
7 PAL/SECAM
0.6Vp-p (H)
6 NTSC
2.7Vp-p
4 NTSC
5.0Vp-p
2
4 SECAM
1
A BOARD WAVEFORMS
1.5Vp-p (V)
16
1.3Vp-p (H)
12 NTSC
2.4Vp-p (H)
10 NTSC
PAL : 2.6Vp-p (H)
SECAM : 2.8Vp-p (H)
8 PAL/SECAM
1.5Vp-p (H)
5 NTSC
0.7Vp-p (H)
3 SECAM
0.5Vp-p (H)
13 PAL
0.9Vp-p (H)
11 PAL
2.7Vp-p (H)
8 NTSC
1.1Vp-p (H)
6 PAL
1.3Vp-p (H)
3 NTSC
– 31 –
NO TE:
The circuit indicated at left contains high voltage of over
600 Vp-p. Please pay attention when inspecting or repairing it to prevent an electric shock.
1030Vp-p
15
0.7Vp-p (H)
12 SECAM
2.2Vp-p (H)
10 SECAM
2.9Vp-p (H)
7 NTSC
PAL : 1.4Vp-p (H)
SECAM : 1.3Vp-p (H)
5 PAL/SECAM
0.7Vp-p (H)
3 PAL
0.6Vp-p (H)
13 SECAM
1.3Vp-p (H)
11 SECAM
2.5Vp-p (H)
9 PAL/SECAM
1.2Vp-p (H)
6 SECAM
0.5Vp-p (H)
4 PAL
IF-IN
TUNER
3
4
48
49
53
54
VIDEO IDENT
AFC
IDENT
AFC · S/H
VIF AMPLIFIER
· DEMODULATOR
POL
AGC FOR IF
· TUNER
T.D.P.
IC351 TDA8375A
sandcastle
pulse input
6
V P1
±(B-Y)
colour-difference
input signals
±(R-Y)
IC300 TDA46657-T
1
SIF-IN
5
9
14
16
SOUND
TRAP
13
CVBS
17
CVBS-SWITCH
SW
VIDEO MUTE
MUTE
VIDEO AMPL.
POL
55 56 2
15
7
SCL
8
SDA
12C-BUS
TRANSCEIVER
SW
BANDPASS
Chr Y
S-VHS
10 11
38
SVHS-SWITCH
TRAP
AUDIO
SWITCH
VOLUME
16
1
V P2
33
HUE
digital supply
LP
DIVIDER
BY 192
LINE
MEMORY
LINE
MEMORY
CONTROL DAC 's
17 x 6-BIT 's
2 x 4-BIT 's
FREQUENCY
PHASE
DETECTOR
pre-amplifiers
SOUND
OUTPUT
EXT AUDIO IN
GND1
10
SANDCASTLE
DETECTOR
analog supply
SIGNAL
CLAMPING
SIGNAL
CLAMPING
PRE-AMPL
FILTER
RM-869
KV-G21MW3/G21QW3
CVBS OUT
A BOARD
RM-869
SECAM REF.
KV-G21MW3/G21QW3
35
3.6
36
4.4
PAL / NTSC
DECODER
FILTER
TUNING
REF
BV
34
41
3
39
32 31
G-Y MATRIX ·
SAT. CONTROL
SAT
DELAY ·
PEAKING
H/V DIVIDER
2nd LOOP
· HOR. OUT
42
GND2
– 32 –
TDA 4661
30 29
addition
stages
TDA4665
LP
LP
DIVIDER
BY 2
5 12 37
REF
VERT. SYNC
SEPARATOR
SYNC SEP.
· 1st LOOP
VCO ·
CONTROL
44 14 9
5MHz
CCO
3MHz shifting clock
SAMPLEANDHOLD
SAMPLEANDHOLD
B-Y
RM-869
B-Y
KV-G21MW3/G21QW3
11
n.c.
n.c.
n.c.
n.c.
i.c.
6
13
15
7
OUT
Y
28
40
IN
27
HOR. DRIVE
4, 8
±(R-Y)
BACKCURRENT
STABILISER
VERTICAL
GEOMETRY
EWGEOMETRY
±(B-Y)
colour-difference
output signals
2
12
output
buffers
WHITE P.
RM-869
R-Y
R
G
B BL
23 24 25 26
RGB-INPUT
· SWITCH
RGB-MATRIX
· OUTPUT
BRI
KV-G21MW3/G21QW3
R-Y
CONTR
http://cxema.ru
19
20
21
22
18
52
51
47
46
50
45
B
G
R
BEAM DUPR.
BL. CURRENT
V-OUT NEG.
V-OUT POS.
EHT
EW-DRIVE
O
N
M
L
K
J
I
H
G
F
E
D
C
AGC
GND
5
6
I-KEY
II-KEY
7
2
DGCT
1
2
DGC
1
1
GND
50/60
HZ
AC IN
CN601
2P
WHT
:VH
2
1
AC IN
F#
GND
E-1
#
2P
CN602
DGC
CN603
1
12
7V
DGCT
11
VIDEO
9
HP
110-240V AC
OR
TO F1 BOARD
CN1602
DGC
6
10
VP
8
5
GND
4
SCL
3
B
BLK
SDA
2
G
TIMER
R606
#
5V
3
C602
#
2
R020
0
#
SCL
SDA
R910
560
S601
:PUB
2
JW132
#
– 33 –
JW032
#
C621
0.1
250V
:PP
JW134
10.0MM
C060
D006
#
R027
:CHIP
R093
#
1
3
4
R601
#
0.1
0.1
2
C009
470p
:CHIP
R604
#
3.3
#
#
D603
#
R621
R603
R620
C004
2.2
R019
150k
:CHIP
D002
1SS119
D602
#
3
T605
LFT
R029
4.7k
:CHIP
R012
47
:CHIP
C024
C023
C032
F:CHIP
C022
0.001
C042
C021
0.001
SW2
SW1
IC601
STR6707N
Q601
#
PC-SW
C601
#
R602
#
JW172
#
0
R024
#
:CHIP
:CHIP
100
R032
#
C607
4700p
500V
E
C605
4700p
500V
E
76.8
B
C
OCP
V-IN
4.6
INH
0.6
F/B
0.1
-0.2
DRIVE
0.5
SINK
0.1
-0.2
GND E
-12.3
C059
100p
:CHIP
C102
#
C900
470p
:CHIP
R034
#
C606
4700p
500V
E
O LOUDNESS
0
O TIMMER/ST
0
O-AVMULTI
0
0
V-PULSE
C633
1000p
3kV
FB612
1.1UH
R625
3.9k
R623
100
C626
#
R610
15k
3W
:RS
C634
470p
B:CHIP
D607
D1NL20
R624
2W :RS
C623
220
16V
0.5
R030
#
R617
15k
3W
:RS
C604
220
400V
R622
0.33
2W
:RW
GND
4.9
STBY
4.9
4.9
ITTRESET
4.4 (0)
SIRCS
0.1 (0.6)
HD SW
0.4 (0.6)
TV SYNC
0.4
H SYNC
0
SW1
0(4.9)
SW2
C030
#
MOMUTE
0
B-INT
4.8
SECAM TRAP
4.9
4.9
0
BLK
0
O-SPMUTE
0
4.9 (0)
AGC
0.5
TSW0
0.5
TSW1
D102
#
C109
0.0047
B:CHIP
9.0
L/H
0
B
0
G
0
R
0
YS
4.7
II DAT0
4.9
II DAT1
4.7
II CLK0
4.9
II CLK1
OFR
C031
#
470p
R608
#
R629
47
R058
#
:CHIP
220
R038
R018
220
R627
1k
4.2
C625
0.001
B
R626
1.8k
B
D610
D1NL20
C618
470p
B:CHIP
FB610
1.1UH
C632
470
250V
R044
#
1
9
8
7
5
4
3
2
T601
(SRT)
C010
0.022
:CHIP
R616
8.2M
1W
:RN
#
C050
1
R007
10k
:CHIP
5.9
5.0
92.7
C630
470
280V
:CHIP
R052
#
X101
CAS/4HG
:CHIP
C622
0.047
200V
:PT
FB600
#
#
C619
#
22k
#
C620
#
C613
470p
FB603
1.1UH
IN
GND
OUT
#
C612
#
D605
#
R614
1W
:RS
C608
470p
2kV
R
Q001
#
R005
#
C005
#
C609
33
160V
FB601
1.1UH
FB251
# C610
#
C614
2200
25V
JW170
JW(15)
R607
C034
0.1
25V
B:CHIP
2
IC005
#
C027
:ALI
L002
1
R605
3.9
3W
:RS
C617
470
25V
C052
0.1
25V
B:CHIP
3
0.001
7
4.9
6
5
3
R632
1
11V
JW600
#
D613
#
4
3
R076
100
:CHIP
I
3
4
2
11V
C043
#
O
4.8
1
2
CN609
#
115V
C523
100
16V
TO F3 BOARD
92.3
IC602
SE115N
ERROR-AMP
R046
#
C041
#
R017
2.2k
:CHIP
D615
#
R131
18k
2W
:RS
CN101
4P
GRY
:MICRO
K1
NC
1
3.4
L802
R355
10
:CHIP
K2
CN604
#
0
2.3
R350
#
– 34 –
6
5
4
3
0
N.C.
+5V
CN600
#
IC351
TDA4665T
1HDL
R-Y OUT
2.9
I.C.
B-Y OUT
2.9
N.C.
B-Y IN
1.4
GMD
I.C.
0.6
1.4
R-Y IN
SYNC
GND
C323
22p
CH:CHIP
I.C.
N.C.
L301
N.C.
+5V
R351
:CHIP
5V
C412
*
2.7
CT60
*
C132
#
L403
*
R420
390
:CHIP
:FLR50
R314
100
:CHIP
R418
#
C409
*
*
R071
330
:CHIP
D005
RD5.1ESB
10
C410
27p
:CHIP
7.4
R037
#
CN801
D308
RD2.2ESB
R419
1k
:CHIP
C411
68p
:CHIP
Q405
Q301
4.0
R415
*
:ALI
L402
C325
10p
:CHIP
9.0
#
Q407
9.0
R417
#
TO H BOARD
R356
1k
:CHIP
C375
47
C327
10p
:CHIP
Q303
2SD601A
C326
12p
:CHIP
9V
R414
470
:CHIP
NC
R416
220
:CHIP
Q406
2SB709A
2.7
3.4
3.4
9V
NC
JR115
#
R329
0
:CHIP
L404
*
3.3
L405
*
R422
*
R423
*
R421
:CHIP
CT45
*
220
Q408
2SD601A
G OUT
R327
0
:CHIP
C374
C368
0.1
25V
B:CHIP
C367
0.1
25V
B:CHIP
CN301
#
C369
0.1
25V
B:CHIP
C329
0.0039
B:CHIP
R OUT
6
D306
1SS119
C330
0.1
25V
B:CHIP
*
7
6.8
2.7
2.7
3.3
JW200
#
Q410
H.BLK
7
CN102
#
CN103
6P
1
CN703
4
C415
0.0047
B:CHIP
C350
47
16V
C357
#
C356
#
R805
22k
:CHIP
D860
1SS119
PROTECT
0.22
0.1
JR101
0
:CHIP
JR102
#
R331
680k
:CHIP
6
:ALI
3.3
*
9.0
R315
1.6
9.0
GND
14
C802
0.01
200V
:PT
R801
4.7k
3W
:RS
C804
0.001
B:CHIP
Q801
2SC3209LK
H-DRIVE
C352
16V
B:CHIP
(4.4)
R-Y OUT
(3.0)
1.8
B-Y OUT
1.7
(3.1)
N.C.
N.C.
+8V
IC354
TDA8395T
N.C.
N.C.
S IN
3.6
SYNC
4.3
#
JR106
9.0
:CHIP
C304
0.1
25V
B:CHIP
C805
220p
500V
B
4
5
12
C360
#
3
1
C259
#
C1260
0.0068
:CHIP
9V
C220
22
10
D803
#
R811
1.2
1W
:RS
Q302
#
JW104
#
R317
#
R319
1.2M
:CHIP
15
C303
#
#
R344
#
6.8
C424
#
JW165
20MM
X300
COIL
2.2
CN111
#
R808
5MM
R562
1.5k
:FPRD
R563
180k
1/2W
*
R436
*
D591
1SS119
R320
27k
:CHIP
0
R242
270
:CHIP
11
JW129
D402
*
CF45
*
CF55
FILTER
CF60
*
CF65
*
R553
22k
:CHIP
C556
#
FB801
JW(5)
-0.2
114.1
0
0
9
5
7
6
CN251
3P
8
JW069
20MM
JR113
:CHIP
8V
C334
3300p
B:CHIP
15
R828
3.9k
:CHIP
R812
12k
:CHIP
R834
4.7k
:CHIP
R569
150k
1/2W
R566
4.7k
:CHIP
C562
100
16V
C557
#
C336
10
D561
1SS119
Q802
2SD1877S
H.OUT
R858
1.2
2W
:RS
R565
56k
:CHIP
R564
56k
:CHIP
114.3
Q561
2SA1091R
X-RAY
D562
#
R570
0
:CHIP
R552
150k
:CHIP
R551
#
C324
16V
F:CHIP
C376
0.47
16V
B:CHIP
#
-0.4
9.0
*
Q418
JR112
#
C234
47
10V
JW005
#
R240
270
:CHIP
C233
47
16V
Q417
L411
*
13
10
IC203
TA8248K
AOUDIO OUT
17
12
14
R241
0.1
25V
:CHIP
JR107
0
:CHIP
JR116
JR171
#
R435
*
9.0
*
Q416 R437
*
J251
JACK
JW029
5MM
Q201
#
JW030
#
JW031
#
JR266
#
C423
330
:CHIP
R434
470
:CHIP
L410
R806
#
R334
#
R809
8.2k
1/2W
:FPRD
C811
2200p
500V
E
T801
HDT
13
C341
100p
:CHIP
R316
#
C355
#
9.0
R438
#
*
CN202
#
C1259
#
C257
0.068
:PT
R264
3.3k
:CHIP
R439
#
Q212
#
Q415
270
R433
22k
:CHIP
3.3
R431
*
R571
220
:CHIP
11
:CHIP
N.C.
0
N.C.
3.3
-0.4
C422
*
16
C256
#
R265
3.3k
:CHIP
R248
7.5k
:CHIP
C258
0.068
:PT
Q414
2SD601A
*
Q413
R266
10k
:CHIP
R245
8.2k
:CHIP
R250
15k
:CHIP
C300
47
16V
D315
RD9.1ES-T1B
C340
0.01
B:CHIP
R246
6.8k
C254
0.01
:CHIP
JW167
# R247
7.5k
:CHIP
C255
0.01
:CHIP
R249
15k
:CHIP
CN201
#
R432
*
R340
L409
*
0
TEST
0.6
S REF
9.0
R429
180
:CHIP
*
Q412
C418
*
R430
*
D403
1SS119
0
Q209
UN2216
C403
22
C338
0.47
16V
B:CHIP
1SS119
C351
25V
B:CHIP
C806
1
C317
2.2
16V
:CHIP
C306
0.1
25V
:CHIP
C348
#
D307
3.3
R339
:CHIP
C315
0.47
16V
B:CHIP
C420
47
L408
*
VAR L
Q210
UN2216
C419
*
9
JR114
4.7M
:CHIP
300
R428
*
CT55
TRAp
CERAMIC
R426
150
:CHIP
#
CT65
R333
15k
:CHIP
L406
*
L407
R427
*
8
7
JW201
C417
*
5
Q411
#
IC401
#
C339
150p
:CHIP
C416
*
0.5
C358
25V
B:CHIP
D351
GP08D
R804
1k
:CHIP
0.1
8V
9
C413
100
16V
R424
2.2k
:CHIP
3.3
2.7
Q409
2SB709A
8
JW300
#
9.0
R425
390
:CHIP
2
3
TO C BOARD
B/G
TO D1 BOARD
VAR R
15
3D MUTE
14
GND
13
C202
#
R336
2.2k
:CHIP
R560
0
:CHIP
R211
#
C201
#
15
16
C813
#
R810
#
R829
1.5k
:CHIP
C238
0.15
:MPS
17
C206
#
18
19
20
9
C214
#
10
#
4
0.6
5
R882
2.7k
:CHIP
0.4
R820
1.5k
:CHIP
JR052
0
:CHIP
JR051
#
R822
270
1W
:RS
9.9
7
C572
#
R881
#
2
0.6
-0.2
R826
2.7k
:CHIP
L804
#
C876
0.068
100V
:PT
1
12.1
8
#
C554
220p
500V
B
1
3
2
26
3
4
3
R802
#
16
R895
1
1W
:RS
JR111
:CHIP
R894
#
2.2k
JR203
#
R1224
#
R1223
#
R823
1k
1W
:RS
C809
330p
2kV
B
7
SG801
L805
HLC
C825
0.01
200V
:PT
S801
H CENT
C501
470p
500V
B
D551
GP08D
V.DRIVE
C552
100
35V
-0.8
D1505
RD4.7ESB
C1513
100
C1213
1
H.DY
1
2.9
C1225
0.47
25V
:CHIP
C1228
1
16V
:CHIP
C854
470
25V
:RS
V.DY
150
0.27
R1209
#
C850
470
25V
:PP
:RS
V.DY
L808
3.3mmH
R831
2W
C822
200V
D857
GP08D
H.CENT-1
120
4P
C856
0.001
500V
B
7
C580
#
:RS
C801
33
160V
D853
ELIZ
15V-RECT
C853
0.001
500V
B
8
0
R852
1k
:FPRD
3
11
R851
1.2
:FPRD
R582
#
D582
#
JR179
D852
#
R1227
39k
:CHIP
JR1207
#
4
5
C860
470p
500V
B
#
C852
#
TV
6
1
3
4
2
10
9
8
7
R860
220k
9V
7
Q1206
#
VIDEO BUFFER
JR105
#
V1
C1222
#
2
R1238
#
8
C1205
0.1
25V
:CHIP
R1205
82
:CHIP
D1201
RD9.1ESL2
D1202
RD9.1ESL2
C1206
#
R1206
47k
:CHIP
23
IC1211
NJM2234L
R1226
#
R1236
#
D851
ELIZ
200V-RECT
R854
0.47
:FPRD
R853
0.47
:FPRD
1
R1207
#
D1203
#
C1207
#
R581
#
V2
C855
#
9
JW176
#
5.6
C1227
#
R1237
#
D1204
#
R1225
#
R1208
#
REAR
1.1UH
D855
EL1Z
-13V-RECT
R598
#
R580
#
5
6
FB102
PM580
#
R821
3W
4
R1218
470
:CHIP
R1217
#
R1245
330
:CHIP
R1246
330
:CHIP
D1205
#
C1208
#
2SD601A-TX
D581
#
2
J1201
22
C1209
#
Q1203
JW006
12.5MM
JR110
#
2.5
D1206
#
C1226
220
16V
R1210
#
D858
GP08D
H.CENT-2
H.DY
C816
10
160V
330
C821
0.039
200V
:PT
R825
8.2
:FPRD
L821
10mmH
15V
-1V
C551
100
35V
JW1203
#
R824
2W
JR166
#
:CHIP
JW090
#
C1223
#
10k
R1243
100
:CHIP
R1220
1k
:CHIP
3.6
C1210
100
16V
3.1
R1252
:CHIP
R1221
0.1
0.2
R1249
470
:CHIP
D1504
1SS119
L807
HWC
R803
2.2k
:CHIP
6
2.4
1.8
R1211
68
:CHIP
R1216
470k
:CHIP
R1241
1k
:CHIP
D1207
RD9.1ESL2
R1248
1k
:CHIP
R1253
:CHIP
BOOST
CNDY1
JW195
7.5MM
C807
#
C810
0.0082
200V
:PT
C875
#
0
D891
#
5
1.2k
4.4
JW252
#
IC201
#
R1244
#
R1222
#
C560
#
R557
1.8k
:CHIP
4
V.OUT
D801
ERC06-15S
R817
JW(5)
R883
1M
:CHIP
C553
0.0068
B:CHIP
R556
1k
:CHIP
Q821
#
PIN-OUT
R832
2.2k
:CHIP
2
-11.4
C555
10p
500V
1
9V
2.1
JR1210
#
IC551
LA7830
V-OUT
Q1513
2SD601A
R1515
100
:CHIP
Q1204
R1247
470
:CHIP
21
JR109
#
R1212
1k
:CHIP
R1215
470k
:CHIP
Q1208
2SD601A-TX
C1212
#
3.1
R1242
#
R1214
#
2SB709A-TX
2SD601A-TX
2.7
JR108
#
R1213
#
D1208
RD9.1ESL2
R253
10k
:CHIP
C208
#
28
Q1209
27
1
C252
2.2
D802
RGP15J-60
C812
0.008
2kV
:PP
C808
15mm
C820
680p
2kV
:B
D820
D513
RD5.1ESB
R561
2.2k
C548
0.1
100V
:PT
R555
6.8k
R559
#
3.2
R1514
4.7k
:CHIP
R1513
10k
:CHIP
– 35 –
3
IC801
0.4
6
C337
100
16V
R338
0
:CHIP
JR050
0
:CHIP
R550
#
R554
#
R1251
820k
:CHIP
25
24
23
22
R1250
820k
:CHIP
C1230
0.1
25V
:CHIP
11V
21
6
C253
100
16V
R251
0
:CHIP
Q1205
#
D202
0
:CHIP
Q202
2SB709A
16.3
4
7
Q1264
#
Q1265
DTC143TKA
JW130
#
JW099
15MM
20
FB103
1.1UH
D251
C251
#
MAA113-TX
-0.9
C244
1000
25V
D252
DA204K
CN200
#
5
8
C218
#
D253
MA113-TX
D201
MA113-TX
R254
4.7
C891 R827
680p
82k
:CHIP :CHIP
C823
0.01
B:CHIP
C242
B:CHIP
C241
1000
25V
0.01
R252
330
C243
22
C240
15
:PT
11
R337
#
D821
#
C246
10
R255
4.7
19
12
D300
MA113-TX
C301
10
JW180
#
R256
330
R213
R302
3.9k
:CHIP
JR164
#
R301
10k
:CHIP
R212
#
C210
#
13
R210
#
14
C216
#
R244
:CHIP
Q208
UN2213
R243
10k
:CHIP
15.6
0
1
C247
1000
25V
16V
Q207
2SB709A
4.9
SP R
C239
100
16V
10k
16.3
2
3
4
18
SP L
12
GND
VCC 1
8.5
11
GND
R OUT
16.0
B.S.2
10
R049
#
IC521
PQ09RD08
JR213
#
1
R521
1k
:CHIP
R630
#
R631
#
G
Q031
#
G2
C057
47p
CH:CHIP
4.9
C074
220p
B:CHIP
JW062
#
JW059
#
B:CHIP
2
C119
0.01
F:CHIP
C118
22
G1
O1
O2
I
B INT
2
B DAT
3
GND
1
IG
SI
SWF
SWF401
176766311
IC102
#
33V-REG
IC003
ST24C04FB6
8
R077
100
:CHIP
C055
470
10V
IC100
HZT33-02
*
Q404
R118
22k
:CHIP
0
D401
*
9
C117
100p
:CHIP
R413
*
C072
470
10V
:CHIP
C116
0.1
:MPS
1k
C002
22
1
R016
R021
4.7k
:CHIP
R054
10k
:CHIP
7.2
R117
22k
:CHIP
*
Q403
3.4
R412
*
R411
*
0.6
R120
330k
:CHIP
C121
0.068
:PT
R116
22k
:CHIP
0.4
R047
:CHIP
R051
100
D604
RU4AM
R612
#
R637
#
:CHIP
D606
S3L20UF4
#
#
R618
R006
#
R615
4.7
R613
0.1
:FUSE
C600
D600
5V
D007
IC002
L78LR05D-MA
5V-REG
REF
3.5
C120
0.068
:PT
D001
RD4.7ES-T1B
100p
R410
*
Q109
2SC1623
C408
0.0047
B:CHIP
R115
22k
:CHIP
3.2
Q110
2SD601A
100p
RESET
C046
94.5
R619
0.1
:FUSE
R600
#
IC603
PC123F2
10
11
12
13
14
15
16
17
18
C007
0.47
CH
C407
0.0047
B:CHIP
8
Q402
2SC2410S-TPN
(-0.3)
:ALI
L401
C037
:CHIP
#
C018
100p
R057
1k
:CHIP
:CHIP
#
R119
1.8k
:CHIP
C115
10p
:CHIP
C114
100p
:CHIP
-0.8
JW183
10.0MM
B:CHIP
B:CHIP
25V
R440
150
:CHIP
R409
100
:CHIP
JW035
:CHIP
25V
B:CHIP
100p
0.1
D004
100
0.1
0.001
C048
D611
D1NL20
0.1
C044
100p
:CHIP
56p
C016
56p
CH
R048
C049
C017
R053
0
:CHIP
C015
C026
:CHIP
:FLR50
:CHIP
:CHIP
390
2.2k
:CHIP
220
C051
:CHIP
R042
100p
:CHIP
R040
R045
B:CHIP
R408
1.8k
:CHIP
3.9
1k
:CHIP
0.001
B:CHIP
C029
0.001
B:CHIP
C028
0.001
B:CHIP
C047
100p
:CHIP
C045
100p
:CHIP
C038
100p
:CHIP
R036
C036
JW45
17.5MM
JW034
R114
470
:CHIP
R113
22k
:CHIP
C406
0.0047
B:CHIP
C405
0.0047
B:CHIP
JW44
17.5MM
:CHIP
0.001
C001
0.0015
B:CHIP
C035
#
1k
560
L001
R407
3.9k
:CHIP
R406
4.7k
:CHIP
R035
C122
100
16V
R441
#
C033
R015
C061
2.2
16V
F:CHIP
9V
C425
#
C404
#
7
L003
C616
500V
C624
1000
16V
D101
#
#
Q401
R103
#
R403
68
:CHIP
JW124
7.5MM
C611
470p
250V
C631
0.0047
500V
R611
0.1
1/2W
:FUSE
R043
#
R628
1k
R636
15k
3W
:RS
0
VC
RESET
2.2
EXTAL
2.4
XTAL
4.9
3.1
4.9
BINTRDY
0.1
JW033
#
2
4.9
XLC
0.1
BRT ABL
4.9
KEY1
4.9
KEY2
(0.7)
4.9
0
V SYNC
0.4
H SYNC
4.9
EXLC
1
GND
NC
VDD
MP
9.0
U/V
VM MUTE
0.1
0.1
C107
#
R404
#
R402
#
C402
0.01
B:CHIP
6
IC001
CXP85220A
052S
0
I AVMULTI
4.9
O 3DMUTE
0
O +BDROP
C628
470p
B:CHIP
18
0
0
D609
D1NL20
C627
680p
2kV
B
C603
4700p
500V
E
K2
K1
C108
1000
16V
CT100
#
C401
#
R401
#
R101
4.7k
:CHIP
IF1
0
O STBYLED/RSP
0
4.9
R090
:CHIP
D601
GBU4JL
:CHIP
#
100
R059
C058
100p
:CHIP
C025
0.001
B:CHIP
R028
R041
:CHIP
:CHIP
:CHIP
:CHIP
C064
0.001
:CHIP
1k
2.2k
220
220
#
R031
R026
R066
:CHIP
:CHIP
1k
:CHIP
:CHIP
L101
4.1
IF2/NC
:FLR50
R906
4.7k
:CHIP
10k
5V
C013
0.001
B:CHIP
330
PWM
C101
4700p
F:CHIP
R102
1k
:CHIP
C105
100
16V
C135
#
33V
Q108
2SD601A
R025
:CHIP
2.2k
:CHIP
2.2k
2.2k
:CHIP
B:CHIP
R061
R060
B:CHIP
R065
B:CHIP
B:CHIP
*
C003
R023
R022
*
*
C012
R014
#
*
R009
1k
C014
0.001
B:CHIP
R010
:CHIP
C006
0.001
:CHIP
U/V
R013
1k
B:CHIP
R062
R063
100p
0.001
0.001
C039
C019
0.001
B:CHIP
R055
#
R904
#
C901
470p
:CHIP
R902
4.7k
:CHIP
2.5
(3.4)
B:CHIP
C020
10W
TU
B:CHIP
C902
#
0.001
:CHIP
:CHIP
:CHIP
:CHIP
1000p
#
1000p
R906
4.7k
R200
C053
1000p
B:CHIP
0.01
S901
:PUB
AUTO
PROGR
R072
:CHIP
100p
C040
3.3k
100p
100
C008
2.2k
C056
R905
#
C106
10
PROG +
R068
R008
R908
2.7k
C127
0.1
25V
B:CHIP
IC004
SBX1981-51P
IR-DET
4.7k
Q030
2SD601A
JW204
#
1
R
S902
:PUB
MANUAL
PROGR
TIMER
C011
47
16V
4.9
L1/L2
C/T
R907
560
PROG -
C128
0.1
25V
B:CHIP
FB101
1.1UH
C103
0.001
5
TU101
BT-AG401
L/H
R104
#
4
+B
C111
1000p
B:CHIP
D103
DA204K
ON/OFF
R033
1k
:CHIP
R
TIMER
F601
T3.15A
JW136
7.5MM
1
THP601
R635
#
#
B
G
R
BLK
L1/L2
C/T
ON/OFF
JW004
#
Q903
UN2213
0
3.6
Q902
UN2213
D901
LED UNIT
JR103
D003
MA113-TX
1
R
CN106
#
ST-BY
CN01
TO V1 BOARD
4
3
L1/L2
2
C/T
1
8
ON/OFF
HP
CN105
#
SIRCS
7
4
GND
3
2
TIM/ST
1
5V
GND
2
1
3.5
R914
470
:CHIP
R913
470
:CHIP
NICAM
ST/BY
RESPONSE
R915
#
S903
:PUB
TVSYS
S904
:PUB
(WIDE)
SELECT
VOL +
R909
8.2k
S905
:PUB
VOL -
R911
2.7k
COL SYS
(DISPLAY)
TV/VIDEO
1
1
1
STBY/REP
CN010
#
GND
5V
CN011
#
#
GND
#
CN100
1P
3
AFT
B
2
4.4
SCL
AGC
B:CHIP
1000p
C054
:CHIP
C124
0.1
25V
:CHIP
D008
RD5.6ESB2
:CHIP
4.7k
R002
SDA
4
2
:CHIP
4.7k
R001
:CHIP
4.7k
R004
4.7k
R003
GND
DAT
L OUT
1
A
1
+16V
CLK
GND
2
(1) Schematic Diagram of A Board
5
3
1
#
D614
C125
0.1
25V
:CHIP
1
2
3
4
5
6
7
8
9
5V
:CHIP
220
R181
9V
3
B CLK
4
2
NC
#
:CHIP
1
+B
33
R609
:CHIP
220
R180
11V
2
R050
220
VM MUTE
9V
4
R182
GND
5
8
GND 3
ROTATION
3
#
6
7
22V OUT
2.8
7
6
1
2.8
5
2
0.1
0.5
B OUT
4
R
8
4
AUDIO GND
1.7
D304
MA113-TX
B:CHIP
25V
1.7
BLK
4.0
C322
0
:CHIP
(3.0)
:CHIP
220
R309
(3.1)
R330
560
:CHIP
#
0.1
B:CHIP
25V
0.1
C309
:CHIP
220
R308
4.0
-0.4
M
DBFB ON/OFF
1
GND
3
9V
1
GND
2
GND
1.6
#
8.7
R OUT
3
IK
1
B
:CHIP
25V
0.1
C321
3.4
:CHIP
25V
0.1
:CHIP
1.5k
R313
2
G
R328
0
:CHIP
C320
3.4
B:CHIP
25V
0.1
C310
3.2
0 :CHIP
MA113-(TX)
D301
:CHIP
2.6
C349
100p
10 C335
C344
25V
0.1
C319
5
2.6
MA113-(TX)
D310
4.8 (3.8)
:CHIP
100
R307
2.3
4.7 R325
2.5
15p
C312
3.4
R360
:CHIP
4.7M
X358
*
C311
*
CRYSTAL
OSCILLATOR
X443
RD3.6ES-T1B
#
C318 D311
16V
100
C313
MA113-TX
C414
#
B:CHIP
B:CHIP
25V
0.1
C308
#
:CHIP
25V
RD8.2ESB
L131
C370
3..4
#
:CHIP
100
D305
:CHIP
100
R312
7.4
R305
3.5
C236
220 25V
4
3.6
2
B:CHIP
25V
C345
R310
:CHIP
100k
4.1
C347
4.0
C307
25V B:CHIP
0.1
100
0.1
0.4
C346
2.4
3.6
D312
3.7
10
C331
0.6
:CHIP
10k
R335
0.8
:CHIP
220
R332
:CHIP
6.7
-0.4
D/K
4.0
B:CHIP
2200p
C314
4.7
D1209
#
5
16V
100
C359
0.5
0.1
C305
7.4
3.9
C316
4700p
B
:CHIP
100
R304
4.2
16.3
VCC 2
16V
47
C235
:CHIP
-0.4
I
:CHIP
3.9
:CHIP
12k
R311
D302
MA113-TX
3
1
32
2
10
3
31
1
11
10
2
30
12
9
GND
29
34
13
8
GND
28
35
14
7
GND
27
36
6
1
26
37
2
25
38
5
11
NC
39
GND 3
40
4
12
XTAL
4.2
4.7
-0.4
:CHIP
100
R303
1.8
R306
C333
24
27k
41
R322
23
22p
22
C362
21
42
3
13
4
20
43
2
14
3
19
44
15
15
4
16
16
GND
8V
B-Y OUT
17
0.1
45
1
18
1
18
46
19
51.9
47
20
2
17
R558
#
28
16
29
48
C361
0.001
B:CHIP
25V :CHIP
3.6
3.3
3.3
3.4
0.3 (0.6)
GND
16.0
B.S.1
16V
100
C237
GND
0.6
NF 2
0
R IN
4.0
8.4
L OUT
IC300
TDA8374A
#
16.4
0
L IN
0.6
NF 1
C328
0.01
:CHIP
4.2
3.6
3.0
R326
*
:CHIP
2.8
4.0
27
49
30
R-Y OUT
0.1
3.58
C342
R-Y IN
C332
:MPS
26
15
31
14
R341
:CHIP
25
50
32
B-Y IN
R318
:CHIP
VCC
D399
DTZ-TE-17-9.1B
PLL FIL
100k
GND
VM OUT
1
24
SECAMOUT
R321
:RN-CP
PHI1 FIL
0.1
SSCP/FBT
1k
IF IN
2
23
51
34
33
22
35
13
IF IN
39k
21
12
36
LUMA OUT
3.1
20
52
37
19
LUMA IN
38
53
BLK STC
39
IN SW
3.3M
18
IK
HOR.OUT
R324
17
B IN
40
CVBS IN EXT
3.8
16
G IN
41
15
R OUT
42
4.43/3.58
ABL
R IN
#
14
GND
43
CALDEC
C343
13
PHI2 FIL
AUDIO OUT
44
12
CVBS-IN INT
45
11
MAIN SUPPLY
46
LUMA IN 1
47
10
EAST-WEST
9
G OUT
DEEMP
5MM
VERT. POS
C IN 1
48
CVBS SW OUT
B OUT
AGC FIL
JW082
8
VERT. NEG
DECOUPLING
49
11
7
10
SDA
50
9
54
6
8
55
VERT. SAW
SCL
51
7
56
EHT/X-RAY
5
VERT. REF
PLL IF DEC
IF V OUT
52
6
57
4
5
58
VCO R FIL.
53
4
59
3
3
60
VCO R FIL.
54
2
61
2
1
62
EXT S IN
55
63
DEC SOUND
1
64
TU AGC OUT
S IF IN
R884
JW(5)
#
#
C217
+16V
#
C215
R257
MA113-(TX)
#
C213
#
C205
C209
B OUT(L)
R203
M OUT(L)
C203
B IN(L)
C204
C207
B OUT(R)
12.5MM
GND
JW073
M IN(L)
5
B IN(R)
TRE(L)
6
M OUT(R)
TRE(R)
4
GND
SCL
MON L
#
SDA
IN L
#
CREF
MON R
V-
IN R
M IN(R)
H-
R2
R204
9V
#
#
GND
V+
R OUT
#
L1
L2
0.3
4
L OUT
TVL
3
1
R1
2
3
2
TVR
H-
R3
#
(MONO)
H+
AUDIO R
7.5MM
7.5MM
V3
12.7
L3
JW143
VIDEO
JW146
AUDIO L
JW144
JW145
SW2
OUT
-11.6
L2
1
AUDIO IN 2 L
H+
MONITOR
Q1207
2SD601A-TX
R2
:CHIP
(MONO)
10k
AUDIO IN 2 R
:CHIP
R1
100k
V2
R1219
VIDEO IN 2
R1240
(MONO)
#
AUDIO IN 1 R
JR104
R1228
1k
:CHIP
C1204
100
16V
V1
SW1
L1
5.6
VIDEO IN 1
5.6
1.8
5.1
C062
(
C857
0.033
:PT
#
#
R898
2.2k
R816
47k
R857
82k
HV
DF
8
7
Y/C
JUNGLE,
H/V
OUT
INPUT/OUTPUT
R1239
4.7
:FPRD
1.4
)
R855
1k
1/2W
B-SSS10612-ME.-A..G21
AUDIO/VIDEO
R1233
2.2k
:CHIP
C1216
#
C898
0.033
100V
:PT
R1235
39k
:CHIP
C1217
100
16
:CHIP
1
4.8
R1234
#
4.5
2SD601A-TX
C1215
#
MON OUT L
MON OUT R
GND
SDA
SP OUT R
GND
GND
SP OUT L
L2 IN
200V
1000V
1
CN704
TO C BOARD
CN851
4P
WHT
:MINI
GND
3
H1
HV
TO CRT
R1 IN
L1 IN
2
4
17
16
R2 IN
GND
14
15
13
IF
11
12
10
9
8
9(V)
SCL
7
6
4
5
3
SIF/RESET
CN104
#
CN1201
TO A3 BOARD
CN1201
TO A1 BOARD
CN1200
#
GND
RIN
LIN
GND
VIDEO
2
1
5
4
3
2
1
25
Q1201
R1201
82
:CHIP
R1254
#
C1201
100
16V
R1202
1k
:CHIP
POWER SUPPLY, SECAM DECODER
IF,
FRONT
2
R856
10k
L850
2.2mmH
:EL0606
FV
13
12
11
JW161
17.5MM
C1218
180p
:CHIP
C1221
0.47
25V
:CHIP
1.0
C1214
100
16V
5.1
2P
SYS CONTROLLER, TU, MEMORY
C861
33
250V
T851
FBT
NX-1746
C063
JW1202
#
R1255
10k
:CHIP
C1219
100
16V
C1229
0.47
25V
:CHIP
5
6
5
2.4
3
6
R1232
3.9k
:CHIP
VIDEO-BUFF
R1203
47k
:CHIP
C1202
0.1
25V
:CHIP
R1230
10k
:CHIP
2.4
2.4
J1202
4
IC1210
2.4
R1229
470
:CHIP
Q1202
2SD601A-TX
C1203
#
R1204
#
24
(MONO)
4.9
AUDIO IN 1 L
R1231
1k
:CHIP
AUDIO IN 1 R
4.8
VIDEO IN 1
56
http://cxema.ru
AUDIO IN 1 L
9
26
28
KV-G21QW3
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
CXP85220A-058S
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
390 :CHIP
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
#
KV-G21MW3
100 :CHIP
100 :CHIP
15 :CHIP
47 :CHIP
68 :CHIP
100 :CHIP
100 :CHIP
390 :CHIP
100 :CHIP
330 :CHIP
FILTER, CERAMIC
FILTER CERAMIC
FILTER, CERAMIC
TRAP, CERAMIC
TRAP, CERAMIC
MA77-TX
ISS119-25TD
CXP85220A-060S
LA7910
12UH
8.2UH
8.2UH
15UH
1.8UH
2.2UH
2.7UH
UN2216
UN2216
2SA1162-G
2SA1162-G
2SD601A-Q
2SD601A-Q
UN2216
UN2216
2SD601A-Q
UN2216
UN2216
1K :CHIP
1K :CHIP
3.9K :CHIP
10K :CHIP
2.2K :CHIP
6.8K :CHIP
2.2K :CHIP
220 :CHIP
120 :CHIP
150 :CHIP
330 :CHIP
22K :CHIP
470 :CHIP
22K :CHIP
470 :CHIP
470 :CHIP
22K :CHIP
22K :CHIP
CRYSTAL
29
– 36 –
Note) The parts indicated as “#” in this circuit diagram
are not listed here, as they are not used for these
models.
C003
C012
C311
C409
C412
C416
C417
C418
C419
C422
CF45
CF60
CF65
CT45
CT60
D401
D402
IC001
IC401
L403
L404
L405
L407
L408
L409
L411
Q403
Q404
Q405
Q410
Q411
Q412
Q413
Q415
Q416
Q417
Q418
R009
R014
R326
R410
R411
R412
R413
R415
R422
R423
R427
R428
R430
R431
R432
R435
R436
R437
X358
A BOARD ✽ MARK LIST
27
30
Schematic diagram
? A board
O
N
M
L
K
J
I
H
G
F
E
D
L706
JW(5)
R714
6.8k
3W
:RS
– 37 –
C716
100
R
200V
R733
33
C714
680
D709
1SS119
Q712
2SC2785
R DRIVE
9V
8.5
133.1
131.5
R734
100
1/2W
C702
0.001
R730
180
2.3
2.7
8.5
C710
470p
B
9.0
Q706
2SC2611
R AMP
C703
4.7
250V
FOCUS
4
R757
1.2k
R727
1.5k
R723
270k
:RN
R724
1k
:FPRD
Q709
2SA1091
IK LIMIT
D703
1SS119
C746
470p
R
L707
JW(5.0mm)
R715
6.8k
1/2W
5
G
R713
8.2k
1/2W
L704
JW(5)
9.0
8.5
R729
180
2.3
8.5
C709
470p
B
9
6
8
7
D702
1SS119
C board /
L702
JW(5)
R710
6.8k
3W
:RS
9.0
8.6
Q704
2SC2611
B AMP
2.6
B
1
R705
2.2
3W
:RS
8
L703
JW(5.0mm)
131.7
D716
1SS119
Schematic diagram
D717
RD9.1ESB
R732
33
R756
1.2k
R726
1.5k
R721
680k
:RN
R722
1k
:FPRD
134.0
C713
680
C736
470p
G
R711
8.2k
1/2W
G1-2
H2
H1
G1-1
SCREEN
MIN-MAX
220-756
R702
#
Q708
2SA1091
IK LIMIT
KB
D708
1SS119
Q711
2SC2785
G DRIVE
132.1
2
KG
10
12
11
5
3
G2
7
R703
100k
1/2W
G2
RV701
#
J701
SOCKET
R701
#
L705
JW(5.0mm)
R712
6.8k
3W
:RS
3
KR
13
G4
1
6
Q705
2SC2611
G AMP
2.6
131.3
4
G1-3
CV
C701
0.0047
2kV
E
R762
JW(5MM)
C
FV
3
D712
1SS119
R761
JW(5MM)
B
2
100
100
100
R738
R739
R740
B
D701
1SS119
C737
470p
R725
1.5k
R719
300k
:RN
R720
1k
:FPRD
7.9
Q707
2SA1091
IK LIMIT
R760
JW(5MM)
R731
33
C712
680
Q710
2SC2785
B DRIVE
D707
1SS119
139.8
137.3
L701
C704
0.022
400V
:PP
:EL0607
9
B-SSS10612-ME.-C..G21
R728
150
2.1
8.5
C708
470p
B
D711
1SS119
A
1
4
3
2
1
CN701
4P
WHT
:MINI
9V
6
5
CN103
TO A BOARD
R IN
G IN
B IN
GND
4
3
IK
CN703
6P
WHT
:S-MICRO
CN704
TAB(CONTACT)
GND
CN851
TO A BOARD
H1
GND
200V
1000V
10
2
1
R755
1.2k
1
136.5
(2) Schematic Diagram of C Board
1SS119
D710
http://cxema.ru
H
11
KR G1
– 38 –
TO A BOARD FBT
CV
13
G4 HV
KG KB G2
12
14
15
16
18
C
– C Board –
[RGB OUT]
PRINTED WIRING BOARD
17
– 39 –
19
20
21
22
23
24
25
27
99Vp-p (H)
4 NTSC
82Vp-p (H)
– 40 –
PAL : 92Vp-p (H)
SECAM : 95Vp-p (H)
84Vp-p (H)
4 PAL/SECAM
87Vp-p (H)
3 NTSC
PAL : 93Vp-p (H)
SECAM : 91Vp-p (H)
3 PAL/SECAM
22Vp-p (H)
2 PAL/SECAM
2 NTSC
1
C BOARD WAVEFORMS
26
28
29
30
http://cxema.ru
2
2
1
1
DA204K
ANODE
DTZ9-1
MA113-TX
3
3
CATHODE
ANODE
CATHODE
ERC06-15S
S3L20UF4
D4SB60L
ANODE
CATHODE
DINL20-TA
EL1Z
EGP20G
NNCD8.2A-T1
NNCD9.1A-T1
DIODE
5-4. SEMICONDUCTORS
CATHODE
ANODE
– 41 –
CATHODE
ANODE
(GRN)
ANODE
(GRN)
SPB-26MVWF
LED
ANODE
CATHODE
CATHODE
ANODE
MA77
RU4DS
HZS9.1NB2
RD2.2ES-B2
RD5.1ES-B1
RD4.7ESB2
RD5.6ESB2
1SS119-25
E
2
3
E C
B
2SA1091-0
E C
B
LETTER SIDE
2SC2785-HFE
2SC2410SN
1
2SD1878-CA
B
C
UN2211
UN2213
UN2216
2SA1162-G
2SD601A-Q
C E
C B
TOP VIEW
TOP VIEW
Single In -line Package
Pin 6~98
1
TDA8375T/N3 (20PIN)
µPC4558G2 (8PIN)
Dual In-line Package
Pin 6~98
1
CXP85220A-058S (64PIN)
CXP85220A-060S (64PIN)
ST24C04FB6 (8 PIN)
TDA4665T/V5-118
TDA8375A
IC
E
LETTER SIDE
2SC2611
B
2SD2012
RM-869
RM-869
TRANSISTOR
KV-G21MW3/G21QW3
KV-G21MW3/G21QW3
45
67
– 42 –
1
Zig-zag In -line Package
Pin 6~99
MARKING SIDE VIEW
STR-S60707N
SBX3081-01(30)
SE-115
12
3
LA7830
L78LR05D-MA
CATHODE
n
12
2
1
PQ09RD08
LA7910
3
3
4
1
Zig-zag In -line Package
Pin 6~99
MARKING SIDE VIEW
NJM2234L
ANODE
µPC574J
1
TA8248K
http://cxema.ru
L : BVTP4 × 16 7-685-663-71
8 : BVTP3 × 12 7-685-648-79
6-1. CHASSIS
NOTE:
• Items with no part number and no
description are not stocked because
they are seldom required for routine
service.
• The construction parts of an assembled
part are indicated with a collation
number in the remark column.
4
•
26
25
2
4
6
1
27
4
– 43 –
5
3
4
7
Items marked " ∗ " are not stocked since
they are seldom required for routine
ser vice. Some delay should be
anticipated when ordering these items.
EXPLODED VIEW
SECTION 6
7
8
16
10
11
9
18
17
12
13
19
20
14
23
22
21
p
24
15
p
RM-869
RM-869
The components identified by
shading and mark ! are critical
for safety.
Replace only with part number
specified.
KV-G21MW3/G21QW3
KV-G21MW3/G21QW3
26
27
23
24
25
21
22
16
17
18
19
20
11
12
13
14
15
6
7
8
9
10
2
3
4
5
– 44 –
4-051-736-41
4-302-404-03
PIECE A(90), CONV. CORRECT
SCREW (WASHER HEAD) (+P 4X16)
TRANSFORMER ASSY, FLYBACK (NX-1746//M3A)
A BOARD, COMPLETE (KV-G21QW3)
A BOARD, COMPLETE (KV-G21MW3)
HOLDER, AC CORD
CORD, POWER (WITH CONNECTOR) 2.5A/250V
MAGNET, DISC
!
*
*
!
!
1-453-250-11
A-1298-258-A
A-1298-259-A
4-022-115-00
1-574-062-61
4-051-736-41
RAIL (R), GUIDE
RAIL (L), GUIDE
HOLDER, HV CABLE
TUNER, VSS BT-AG401
BRACKET, TERMINAL BOARD
* 4-055-840-01
* 4-055-841-01
* 3-704-372-11
8-598-323-50
4-059-710-01
8-451-280-33 DEFLECTION YOKE (Y21PXA2)
1-452-277-01 MAGNET, BMC
* A-1331-688-A C BOARD, COMPLETE
! 1-409-942-11 COIL, DEMAGNETIZATION
! 4-049-740-21 COVER, REAR
4-072-569-21
4-365-808-12
3-703-961-01
4-369-318-61
! 8-738-774-05
2-3
REMARK
SHEET, BLOTTING
SCREW (5), TAPPING
SPACER, DY
SPRING, TENSION
PICUTRE TUBE (21PXD (SDS)(SD-169/1BR))
DESCRIPTION
BEZNET ASSY (KV-G21QW3)
BEZNET ASSY (KV-G21MW3)
BUTTON, MULTI
PLATE, GUIDE LIGHT
SPEAKER (5X9CM)
CUSHION, SPEAKER
1
X-4037-882-1
X-4037-883-1
4-056-187-01
4-056-188-01
1-505-740-11
3-947-764-11
REF.NO. PART NO.
KV-G21MW3/G21QW3
REF. NO. PART NO.
NOTE:
RM-869
SECTION 7
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
ELECTRICAL PARTS LIST
DESCRIPTION
REMARK
REF. NO. PART NO.
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
• Items marked " ∗ " are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
When indicating par ts by reference
number, please include the board name.
• All variable and adjustable resistors have
characteristic curve B, unless otherwise
noted.
REF. NO. PART NO.
DESCRIPTION
DESCRIPTION
REMARK
• All resistors are in ohms
• F : nonflammable
CAPACITORS
• MF : µF, PF : µµF
COILS
• MMH : mH, UH : µH
REF. NO. PART NO.
DESCRIPTION
* A-1299-259-A A BOARD COMPLETE (KV-G21MW3)
* A-1299-258-A A BOARD COMPLETE (KV-G21QW3)
********************
C046
C047
C048
1-163-117-00
1-163-117-00
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.1UF
5.00% 50V
5.00% 50V
10.00%25V
1-533-223-11
* 4-059-711-01
7-685-648-79
3X12 TYPE2 IT-3
C049
C050
C051
C052
C053
1-164-004-11
1-126-960-11
1-163-117-00
1-164-004-11
1-163-009-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1UF
1UF
100PF
0.1UF
0.001UF
10.00%25V
20.00%50V
5.00% 50V
10.00%25V
10.00%50V
C054
C055
C056
C057
C058
1-163-009-11
1-126-925-11
1-163-009-11
1-163-243-11
1-163-117-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001UF
470UF
0.001UF
47PF
100PF
10.00%50V
20.00%10V
10.00%50V
5.00% 50V
5.00% 50V
C059
C060
C061
C064
C072
1-163-117-00
1-163-009-11
1-164-505-11
1-163-009-11
1-126-925-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
0.001UF
2.2UF
0.001UF
470UF
5.00% 50V
10.00%50V
16V
10.00%50V
20.00%10V
C074
C101
C103
C105
C106
1-163-001-11
1-163-017-00
1-163-009-11
1-104-665-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
220PF
0.0047UF
0.001UF
100UF
10UF
10.00%50V
10.00%50V
10.00%50V
20.00%16V
20.00%50V
C108
C109
C111
C114
C115
1-126-767-11
1-163-017-00
1-163-009-11
1-163-117-00
1-163-093-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1000UF
0.0047UF
0.001UF
100PF
10PF
20.00%16V
10.00%50V
10.00%50V
5.00% 50V
5.00% 50V
C116
C117
C118
C119
C120
1-136-165-00
1-163-117-00
1-126-965-11
1-163-021-91
1-130-493-00
MYLAR
CERAMIC CHIP
ELECT
CERAMIC CHIP
MYLAR
0.1UF
100PF
22UF
0.01UF
0.068UF
5.00% 50V
5.00% 50V
20.00%50V
10.00%50V
5.00% 50V
C121
C122
C124
C125
C127
1-130-493-00
1-104-665-11
1-164-004-11
1-164-004-11
1-164-004-11
MYLAR
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.068UF
100UF
0.1UF
0.1UF
0.1UF
5.00% 50V
20.00%16V
10.00%25V
10.00%25V
10.00%25V
C128
C220
C233
C234
C235
1-164-004-11
1-126-965-11
1-104-664-11
1-104-664-11
1-104-665-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
0.1UF
22UF
47UF
47UF
100UF
10.00%25V
20.00%50V
20.00%16V
20.00%16V
20.00%16V
C236
C237
C238
C239
C240
1-104-666-11
1-104-665-11
1-136-167-00
1-104-665-11
1-136-167-00
ELECT
ELECT
MYLAR
ELECT
MYLAR
220UF
100UF
0.15UF
100UF
0.15UF
20.00%25V
20.00%16V
5.00% 50V
20.00%16V
5.00% 50V
CLIP, FUSE
HOLDER, FBT
SCREW +BVTP
REMARK
A
REMARK
<CAPACITOR>
C001
C002
C003
1-163-011-11
1-126-965-11
1-163-117-00
0.0015UF
22UF
100PF
10.00%50V
20.00%50V
5.00% 50V
1-126-961-11
1-163-009-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
(KV-G21MW3)
ELECT
CERAMIC CHIP
C004
C006
2.2UF
0.001UF
20.00%50V
10.00%50V
C007
C008
C009
C010
C011
1-126-959-11
1-163-117-00
1-163-133-00
1-163-037-11
1-104-664-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.47UF
100PF
470PF
0.022UF
47UF
20.00%50V
5.00% 50V
5.00% 50V
10.00%50V
20.00%16V
C012
1-163-117-00
100PF
5.00% 50V
C013
C014
C015
C016
1-163-009-11
1-163-009-11
1-101-884-00
1-101-884-00
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
CERAMIC
0.001UF
0.001UF
56PF
56PF
10.00%50V
10.00%50V
5.00% 50V
5.00% 50V
C017
C018
C019
C020
C021
1-163-117-00
1-163-117-00
1-163-009-11
1-163-009-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.001UF
0.001UF
0.001UF
5.00% 50V
5.00% 50V
10.00%50V
10.00%50V
10.00%50V
C022
C023
C024
C025
C026
1-163-009-11
1-163-009-11
1-163-009-11
1-163-009-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001UF
0.001UF
0.001UF
0.001UF
0.001UF
10.00%50V
10.00%50V
10.00%50V
10.00%50V
10.00%50V
C027
C028
C029
C034
C035
1-163-009-11
1-163-009-11
1-163-009-11
1-164-004-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001UF
0.001UF
0.001UF
0.1UF
0.001UF
10.00%50V
10.00%50V
10.00%50V
10.00%25V
10.00%50V
C036
C037
C038
C040
C042
1-163-009-11
1-163-117-00
1-163-117-00
1-163-117-00
1-163-117-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001UF
100PF
100PF
100PF
100PF
10.00%50V
5.00% 50V
5.00% 50V
5.00% 50V
5.00% 50V
C044
C045
1-163-117-00
1-163-117-00
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
5.00% 50V
5.00% 50V
– 45 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A
REF. NO. PART NO.
DESCRIPTION
REMARK
C241
C242
C243
C244
C246
1-126-942-61
1-163-021-91
1-126-964-11
1-126-942-61
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
ELECT
ELECT
1000UF
0.01UF
10UF
1000UF
10UF
20.00%25V
10.00%50V
20.00%50V
20.00%25V
20.00%50V
C247
C252
C253
C254
C255
1-126-942-61
1-126-961-11
1-104-665-11
1-163-037-11
1-163-037-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
1000UF
2.2UF
100UF
0.022UF
0.022UF
20.00%25V
20.00%50V
20.00%16V
10.00%50V
10.00%50V
C257
C258
C300
C301
C304
1-136-167-00
1-136-167-00
1-104-664-11
1-126-964-11
1-164-004-11
MYLAR
MYLAR
ELECT
ELECT
CERAMIC CHIP
0.15UF
0.15UF
47UF
10UF
0.1UF
5.00% 50V
5.00% 50V
20.00%16V
20.00%50V
10.00%25V
C305
C306
C307
C308
C309
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1UF
0.1UF
0.1UF
0.1UF
0.1UF
10.00%25V
10.00%25V
10.00%25V
10.00%25V
10.00%25V
C310
C311
1-164-004-11
1-163-231-11
0.1UF
15PF
10.00%25V
5.00% 50V
C312
C313
C314
1-163-231-11
1-104-665-11
1-164-161-11
CERAMIC CHIP
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
ELECT
CERAMIC CHIP
15PF
100UF
0.0022UF
5.00% 50V
20.00%16V
10.00%50V
C315
C316
C317
C319
C320
1-107-823-11
1-102-125-00
1-164-505-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47UF
0.0047UF
2.2UF
0.1UF
0.1UF
10.00%16V
10.00%50V
16V
10.00%25V
10.00%25V
C321
C322
C323
C324
C325
1-164-004-11
1-216-295-91
1-163-235-11
1-164-505-11
1-163-093-00
CERAMIC CHIP
SHORT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1UF
0
22PF
2.2UF
10PF
C326
C327
C328
C329
C330
1-163-095-00
1-163-093-00
1-163-021-91
1-163-016-00
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
12PF
10PF
0.01UF
0.0039UF
0.1UF
5.00% 50V
5.00% 50V
10.00%50V
10.00%50V
10.00%25V
C331
C332
C333
C334
C335
1-126-964-11
1-136-165-00
1-164-004-11
1-164-182-11
1-102-973-00
ELECT
MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
10UF
0.1UF
0.1UF
0.0033UF
100PF
20.00%50V
5.00% 50V
10.00%25V
10.00%50V
5.00% 50V
C336
C337
C338
C339
C340
1-126-964-11
1-104-665-11
1-107-823-11
1-163-121-00
1-163-021-91
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10UF
100UF
0.47UF
150PF
0.01UF
20.00%50V
20.00%16V
10.00%16V
5.00% 50V
10.00%50V
C341
C342
C344
C349
C350
1-163-117-00
1-164-004-11
1-126-964-11
1-126-964-11
1-104-664-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
100PF
0.1UF
10UF
10UF
47UF
5.00% 50V
10.00%25V
20.00%50V
20.00%50V
20.00%16V
C351
C352
1-164-004-11
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
0.1UF
0.22UF
10.00%25V
10.00%16V
REF. NO. PART NO.
REMARK
C358
C359
C361
1-164-004-11
1-104-665-11
1-163-009-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1UF
100UF
0.001UF
10.00%25V
20.00%16V
10.00%50V
C362
C367
C368
C369
C370
1-163-235-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
0.1UF
0.1UF
0.1UF
0.1UF
5.00% 50V
10.00%25V
10.00%25V
10.00%25V
10.00%25V
C374
C375
C376
C402
C403
1-104-664-11
1-104-664-11
1-107-823-11
1-163-021-91
1-126-965-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
47UF
47UF
0.47UF
0.01UF
22UF
20.00%10V
20.00%10V
10.00%16V
10.00%50V
20.00%50V
C405
C406
C407
C408
C409
1-163-017-00
1-163-017-00
1-163-017-00
1-163-017-00
1-163-109-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
(KV-G21MW3)
0.0047UF
0.0047UF
0.0047UF
0.0047UF
47PF
10.00%50V
10.00%50V
10.00%50V
10.00%50V
5.00% 50V
C410
C411
C412
1-163-103-00
1-163-113-00
1-163-113-00
27PF
68PF
68PF
5.00% 50V
5.00% 50V
5.00% 50V
C413
C414
1-104-665-11
1-163-117-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
(KV-G21MW3)
ELECT
CERAMIC CHIP
100UF
100PF
20.00%16V
5.00% 50V
C415
C416
1-163-017-00
1-163-117-00
0.0047UF
100PF
10.00%50V
5.00% 50V
C417
1-163-117-00
100PF
5.00% 50V
C418
1-163-131-00
390PF
5.00% 50V
10.00%25V
C419
1-163-117-00
CERAMIC CHIP
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
(KV-G21MW3)
100PF
5.00% 50V
5.00% 50V
16V
5.00% 50V
C420
C422
1-104-664-11
1-163-129-00
47UF
330PF
20.00%16V
5.00% 50V
C423
C424
C501
1-163-129-00
1-163-133-00
1-102-228-00
ELECT
CERAMIC CHIP
(KV-G21MW3)
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
330PF
470PF
470PF
5.00% 50V
5.00% 50V
10.00%500V
C523
C548
C551
C552
C553
1-104-665-11
1-106-220-00
1-126-968-11
1-126-968-11
1-163-019-00
ELECT
MYLAR
ELECT
ELECT
CERAMIC CHIP
100UF
0.1UF
100UF
100UF
0.0068UF
20.00%16V
10.00%100V
20.00%35V
20.00%35V
10.00%50V
C554
C555
C562
C602
C603
1-102-244-00
1-101-804-00
1-104-665-11
1-161-830-00
1-161-830-00
CERAMIC
CERAMIC
ELECT
CERAMIC
CERAMIC
220PF
10PF
100UF
0.0047UF
0.0047UF
10.00%500V
5.00% 500V
20.00%16V
99% 500V
99% 500V
C604
C605
C606
C607
C608
1-117-752-11
1-161-830-00
1-161-830-00
1-161-830-00
1-104-332-11
ELECT(BLOCK)
CERAMIC
CERAMIC
CERAMIC
CERAMIC
330UF
0.0047UF
0.0047UF
0.0047UF
470PF
20.00%450V
99% 500V
99% 500V
99% 500V
10.00%2KV
ELECT
CERAMIC
CERAMIC
33UF
470PF
470PF
160V
10.00%250V
5.00% 50V
C609
1-123-024-21
C611 ! 1-113-900-11
C613
1-102-824-00
– 46 –
http://cxema.ru
DESCRIPTION
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A
REF. NO. PART NO.
DESCRIPTION
C614
C616
ELECT
CERAMIC
2200UF
470PF
20.00%25V
10.00%500V
C617
1-126-941-11
C618
1-163-005-11
C619
1-162-116-00
C621 ! 1-104-705-11
C622
1-106-383-00
ELECT
CERAMIC CHIP
CERAMIC
MYLAR
MYLAR
470UF
470PF
680PF
0.1UF
0.047UF
20.00%25V
10.00%50V
10.00%2KV
20.00%250V
10.00%200V
C623
C624
C625
C627
C628
1-126-934-11
1-107-884-11
1-102-074-00
1-162-116-00
1-163-133-00
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC CHIP
220UF
1000UF
0.001UF
680PF
470PF
20.00%16V
20.00%16V
10.00%50V
10.00%2KV
5.00% 50V
C630 ! 1-113-900-11
C631
1-161-830-00
C632
1-113-900-11
C633
1-161-754-00
C634
1-163-005-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC CHIP
470PF
0.0047UF
470PF
0.001UF
470PF
10.00%250V
99% 500V
10.00%250V
10.00%3KV
10.00%50V
C801
C802
C804
C805
C806
1-123-024-21
1-107-364-11
1-163-009-11
1-102-244-00
1-126-960-11
ELECT
MYLAR
CERAMIC CHIP
CERAMIC
ELECT
33UF
0.01UF
0.001UF
220PF
1UF
160V
10.00%200V
10.00%50V
10.00%500V
20.00%50V
C807
C808
C809
C810
C811
1-136-569-11
1-129-746-00
1-162-115-00
1-106-365-00
1-162-318-11
FILM
FILM
CERAMIC
MYLAR
CERAMIC
1.2UF
0.039UF
330PF
0.0082UF
0.001UF
5.00% 200V
5.00% 400V
10.00%2KV
99% 200V
10.00%500V
C812
C816
C820
C821
C822
1-117-646-11
1-107-943-11
1-161-754-00
1-104-999-11
1-136-111-00
FILM
ELECT
CERAMIC
MYLAR
FILM
12000PF
10UF
0.001UF
0.1UF
1UF
3.00% 1.2KV
20.00%160V
10.00%2KV
10.00%200V
5.00% 200V
C823
C825
C850
C853
C854
1-163-021-91
1-107-364-11
1-124-480-11
1-162-318-11
1-124-480-11
CERAMIC CHIP
MYLAR
ELECT
CERAMIC
ELECT
0.01UF
0.01UF
470UF
0.001UF
470UF
10.00%50V
10.00%200V
20.00%25V
10.00%500V
20.00%25V
C856
C857
C860
C861
C875
1-162-318-11
1-136-159-00
1-102-228-00
1-107-654-11
1-128-562-11
CERAMIC
MYLAR
CERAMIC
ELECT
ELECT
0.001UF
0.033UF
470PF
33UF
47UF
10.00%500V
5.00% 50V
10.00%500V
20.00%250V
20.00%100V
C876
C891
C898
C900
C901
1-107-369-11
1-163-007-11
1-137-150-11
1-163-133-00
1-163-133-00
MYLAR
CERAMIC CHIP
MYLAR
CERAMIC CHIP
CERAMIC CHIP
0.068UF
680PF
0.01UF
470PF
470PF
10.00%100V
10.00%50V
10.00%100V
5.00% 50V
5.00% 50V
C1201
C1202
C1204
C1205
C1210
1-104-665-11
1-164-004-11
1-104-665-11
1-164-004-11
1-104-665-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100UF
0.1UF
100UF
0.1UF
100UF
20.00%16V
10.00%25V
20.00%16V
10.00%25V
20.00%16V
C1213
C1214
C1217
C1218
C1219
1-126-960-11
1-104-665-11
1-104-665-11
1-163-123-00
1-104-665-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
1UF
100UF
100UF
180PF
100UF
20.00%50V
20.00%16V
20.00%16V
5.00% 50V
20.00%16V
1-126-943-11
1-102-228-00
REMARK
REF. NO. PART NO.
DESCRIPTION
C1221
C1225
C1226
C1228
C1229
1-164-005-11
1-164-005-11
1-126-934-11
1-164-346-11
1-164-005-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.47UF
0.47UF
220UF
1UF
0.47UF
25V
25V
20.00%16V
16V
25V
C1230
C1259
C1260
C1513
1-164-004-11
1-164-161-11
1-164-161-11
1-126-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1UF
0.0022UF
0.0022UF
100UF
10.00%25V
10.00%50V
10.00%50V
20.00%50V
<FILTER>
CF45
CF55
CF60
CF65
1-527-943-00
1-567-099-00
1-567-100-00
1-567-101-11
FILTER, CERAMIC (KV-G21MW3)
FILTER, CERAMIC
FILTER, CERAMIC (KV-G21MW3)
FILTER, CERAMIC (KV-G21MW3)
<CONNECTOR>
CN100
CN101
CN103
CN251
CN601
1-508-784-00
1-508-797-00
1-564-509-11
1-564-507-11
1-580-843-11
PIN, CONNECTOR (5MM PITCH) 1P
PIN, CONNECTOR 4P
PLUG, CONNECTOR 6P
PLUG, CONNECTOR 4P
PIN, CONNECTOR (POWER)
CN602 * 1-508-786-00
CN603 * 1-508-786-00
CN851 1-508-766-00
PIN, CONNECTOR (5MM PITCH) 2P
PIN, CONNECTOR (5MM PITCH) 2P
PIN, CONNECTOR (5MM PITCH) 4P
*
*
*
*
*
<TRIMMER>
CT45
CT55
CT60
CT65
1-579-690-11
1-404-801-11
1-767-918-21
1-767-917-21
TRAP, CERAMIC (KV-G21MW3)
TRAP, CERAMIC
TRAP, CERAMIC (KV-G21MW3)
TRAP, CERAMIC
<DIODE>
D001
D002
D003
D005
D008
8-719-109-81
8-719-911-19
8-719-041-97
8-719-109-84
8-719-109-89
DIODE RD4.7ES-T1B
DIODE 1SS119-25TD
DIODE MA113-(TX)
DIODE RD5.1ES-T1B
DIODE RD5.6ES-T1B2
D103
D201
D202
D251
D252
8-719-914-49
8-719-041-97
1-216-295-91
8-719-041-97
8-719-914-49
DIODE DA204K
DIODE MA113-(TX)
SHORT
0
DIODE MA113-(TX)
DIODE DA204K
D253
D300
D301
D305
D306
8-719-041-97
8-719-041-97
8-719-041-97
8-719-041-97
8-719-911-19
DIODE MA113-(TX)
DIODE MA113-(TX)
DIODE MA113-(TX)
DIODE MA113-(TX)
DIODE 1SS119-25TD
D307
D308
D310
D311
D312
8-719-911-19
8-719-109-54
8-719-041-97
8-719-109-54
8-719-070-15
DIODE 1SS119-25TD
DIODE RD2.2ES-T1B
DIODE MA113-(TX)
DIODE RD2.2ES-T1B
DIODE NNCD8.2A-T1
D315
D351
8-719-070-16
8-719-908-03
DIODE NNCD9.1A-T1
DIODE GP08DPKG23
– 47 –
http://cxema.ru
REMARK
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A
REF. NO. PART NO.
DESCRIPTION
REMARK
D399
D401
D402
8-719-056-86
8-719-421-40
8-719-911-19
DIODE DTZ9.1
DIODE MA77-TX (KV-G21MW3)
DIODE 1SS119-25TD (KV-G21MW3)
D403
D513
D551
D561
D591
8-719-911-19
8-719-109-84
8-719-908-03
8-719-911-19
8-719-911-19
DIODE 1SS119-25TD
DIODE RD5.1ES-T1B
DIODE GP08DPKG23
DIODE 1SS119-25TD
DIODE 1SS119-25TD
D601
D604
D606
D607
D609
8-719-305-07
8-719-053-31
8-719-052-52
8-719-076-08
8-719-076-08
DIODE D4SB60L
DIODE RU4DS
DIODE S3L20UF4
DIODE D1NL20-TA
DIODE D1NL20-TA
D610
D611
D801
D802
D851
8-719-076-08
8-719-076-08
8-719-945-80
8-719-979-85
8-719-302-43
DIODE D1NL20-TA
DIODE D1NL20-TA
DIODE ERC06-15STP11
DIODE RGP15J-6040G23
DIODE RGP10GPKG23
D853
D855
D857
D858
D860
8-719-302-43
8-719-302-43
8-719-908-03
8-719-908-03
8-719-911-19
DIODE RGP10GPKG23
DIODE RGP10GPKG23
DIODE GP08DPKG23
DIODE GP08DPKG23
DIODE 1SS119-25TD
D901
D1201
D1202
D1207
D1208
1-810-039-11
8-719-070-16
8-719-070-16
8-719-070-16
8-719-070-16
LED UNIT
DIODE NNCD9.1A-T1
DIODE NNCD9.1A-T1
DIODE NNCD9.1A-T1
DIODE NNCD9.1A-T1
D1504
D1505
8-719-911-19
8-719-109-81
DIODE 1SS119-25TD
DIODE RD4.7ES-T1B
REF. NO. PART NO.
DESCRIPTION
REMARK
IC354
IC401
8-759-430-79
8-759-800-65
IC TDA8395T
IC LA7910 (KV-G21MW3)
IC521
IC551
IC601
IC602
IC603 !
8-759-650-98
8-759-801-98
8-749-014-00
8-749-921-89
8-749-010-64
IC PQ09RD08
IC LA7830
IC STR-S6707N
IC SE115N
PHOTO COUPLER PC123F2
IC801
IC1210
IC1211
8-759-151-08
8-759-151-08
8-759-711-23
IC UPC4558G2
IC UPC4558G2
IC NJM2234L
<JACK>
J251
J1201
J1202
1-770-786-21
1-779-849-11
1-779-205-11
JACK
JACK BLOCK, PIN 4P
JACK, PIN 2P
<CHIP CONDUCTOR>
JR050
JR052
JR101
JR112
JR113
1-216-295-91
1-216-295-91
1-216-295-91
8-719-041-97
1-216-295-91
SHORT
0
SHORT
0
SHORT
0
DIODE MA113-(TX)
SHORT
0
JR115
JR116
JR117
JR118
JR124
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR125
JR126
JR251
1-216-295-91
1-216-295-91
1-216-295-91
SHORT
SHORT
SHORT
0
0
0
<FUSE>
F601
1-532-237-00
FUSE, TIME-LAG (BET) 3.15A/250V
<FERRITE BEAD>
FB101
FB102
FB103
FB601
FB603
1-410-397-21
1-410-397-21
1-410-397-21
1-410-397-21
1-410-397-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
1.1UH
1.1UH
1.1UH
1.1UH
1.1UH
FB610
FB612
FB801
1-410-397-21
1-410-397-21
1-410-397-21
FERRITE
FERRITE
FERRITE
1.1UH
1.1UH
1.1UH
<IC>
IC001
IC001
IC003
IC004
IC100
8-752-891-61
8-752-891-28
8-759-380-51
8-759-180-30
8-759-157-40
IC CXP85220A-060S (KV-G21MW3)
IC CXP85220A-058S (KV-G21QW3)
IC ST24C04FB6
HYB IC SBX3081-51(30)
DIODE HZT33-02TE
IC203
IC300
IC351
8-759-339-60
8-759-365-26
8-759-565-20
IC TA8248K
IC TDA8375A
IC TDA4665T/V5-118
<COIL>
L001
L002
L003
L101
L301
1-408-591-11
1-410-509-11
1-408-605-31
1-410-470-11
1-408-602-31
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1UH
10UH
15UH
10UH
8.2UH
L401
L402
L403
L404
L405
1-410-498-11
1-410-510-11
1-410-510-11
1-410-508-11
1-410-508-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1.2UH
12UH
12UH (KV-G21MW3)
8.2UH (KV-G21MW3)
8.2UH (KV-G21MW3)
L406
L407
L408
L409
L410
1-410-507-11
1-410-511-11
1-410-500-11
1-410-501-11
1-410-501-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
6.8UH
15UH (KV-G21MW3)
1.8UH (KV-G21MW3)
2.2UH (KV-G21MW3)
2.2UH
L411
L802
L804
L805
L807
1-410-502-11
1-412-527-11
1-459-075-11
1-459-769-13
1-459-390-00
INDUCTOR
2.7UH (KV-G21MW3)
INDUCTOR
15UH
COIL,DYNAMIC CONVERSION CHOKE
COIL, HORIZONTAL LINEARITY
INDUCTOR
390UH
L808
L821
L850
1-412-552-11
1-459-111-00
1-408-947-00
INDUCTOR
INDUCTOR
INDUCTOR
– 48 –
http://cxema.ru
2.2MH
10MH
2.2MH
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
REF. NO. PART NO.
A
DESCRIPTION
REMARK
REF. NO. PART NO.
DESCRIPTION
<TRANSISTOR>
R014
1-216-049-91
1K
5%
1/10W
R015
R016
R017
R018
1-216-043-91
1-216-049-91
1-216-057-00
1-216-033-00
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
560
1K
2.2K
220
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R019
R021
R022
R025
R026
1-216-101-00
1-216-065-91
1-216-295-91
1-216-057-00
1-216-057-00
RES-CHIP
RES-CHIP
SHORT
RES-CHIP
RES-CHIP
150K
4.7K
0
2.2K
2.2K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R027
R028
R029
R031
R033
1-216-065-91
1-216-025-91
1-216-065-91
1-216-049-91
1-216-049-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
100
4.7K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R035
R036
R038
R040
R041
1-216-049-91
1-216-049-91
1-216-033-00
1-216-033-00
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
220
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R042
R045
R047
R048
R053
1-216-039-00
1-216-057-00
1-216-025-91
1-216-025-91
1-216-057-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
390
2.2K
100
100
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R054
R057
R060
R061
R062
1-216-073-00
1-216-049-91
1-216-037-00
1-216-049-91
1-216-057-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
1K
330
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R063
R065
R066
R068
R071
1-216-057-00
1-216-033-00
1-216-033-00
1-216-025-91
1-216-037-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
220
220
100
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R072
R076
R077
R090
R101
1-216-061-00
1-216-025-91
1-216-025-91
1-216-073-00
1-216-065-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
100
100
10K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R102
R113
R114
R115
R116
1-216-049-91
1-216-081-00
1-216-041-00
1-216-081-00
1-216-081-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
22K
470
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R117
R118
R119
R120
R131
1-216-081-00
1-216-081-00
1-216-055-00
1-216-109-00
1-216-464-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL OXIDE
22K
22K
1.8K
330K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
2W
R180
R181
R182
R240
R242
1-216-033-00
1-216-033-00
1-216-033-00
1-216-035-00
1-216-035-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
220
220
220
270
270
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R243
R244
1-216-073-00
1-216-073-00
RES-CHIP
RES-CHIP
10K
10K
5%
5%
1/10W
1/10W
Q030
Q108
Q109
Q110
Q202
8-729-422-26
8-729-422-26
8-729-422-26
8-729-422-26
8-729-424-02
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SA1162-G
Q207
Q208
Q209
Q210
Q301
8-729-424-02
8-729-421-17
8-729-424-69
8-729-424-69
8-729-421-20
TRANSISTOR 2SA1162-G
TRANSISTOR UN2213
TRANSISTOR UN2216
TRANSISTOR UN2216
TRANSISTOR UN2211
Q303
Q402
Q403
Q404
Q405
8-729-422-26
8-729-922-66
8-729-424-69
8-729-424-69
8-729-424-02
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SC2410S-TPN
TRANSISTOR UN2216 (KV-G21MW3)
TRANSISTOR UN2216 (KV-G21MW3)
TRANSISTOR 2SA1162-G (KV-G21MW3)
Q406
Q407
Q408
Q409
Q410
8-729-424-02
8-729-404-02
8-729-422-26
8-729-424-02
8-729-424-02
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G (KV-G21MW3)
Q411
Q412
Q413
Q414
Q415
8-729-422-26
8-729-422-26
8-729-424-69
8-729-422-26
8-729-424-69
TRANSISTOR 2SD601A-Q (KV-G21MW3)
TRANSISTOR 2SD601A-Q (KV-G21MW3)
TRANSISTOR UN2216 (KV-G21MW3)
TRANSISTOR 2SD601A-Q
TRANSISTOR UN2216 (KV-G21MW3)F
Q416
Q417
Q418
Q561
Q801
8-729-422-26
8-729-424-69
8-729-424-69
8-729-200-17
8-729-140-50
TRANSISTOR 2SD601A-Q (KV-G21MW3)
TRANSISTOR UN2216 (KV-G21MW3)
TRANSISTOR UN2216 (KV-G21MW3)
TRANSISTOR 2SA1091R-TPE2
TRANSISTOR 2SC3209LK-TP
Q802
Q821
Q902
Q903
Q1201
8-729-821-87
8-729-906-96
8-729-421-17
8-729-421-17
8-729-422-26
TRANSISTOR 2SD1878-CA
TRANSISTOR 2SD2012
TRANSISTOR UN2213
TRANSISTOR UN2213
TRANSISTOR 2SD601A-Q
Q1202
Q1203
Q1204
Q1207
Q1208
8-729-422-26
8-729-422-26
8-729-424-02
8-729-422-26
8-729-422-26
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SA1162-G
TRANSISTOR 2SD601A-Q
TRANSISTOR 2SD601A-Q
Q1209
Q1265
Q1513
8-729-422-26
8-729-424-69
8-729-422-26
TRANSISTOR 2SD601A-Q
TRANSISTOR UN2216
TRANSISTOR 2SD601A-Q
<RESISTOR>
R001
R002
R003
R004
R007
1-216-065-91
1-216-065-91
1-216-065-91
1-216-065-91
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
4.7K
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R008
R009
1-216-057-00
1-216-049-91
2.2K
1K
5%
5%
1/10W
1/10W
R010
R012
R013
1-216-049-91
1-216-017-91
1-216-049-91
RES-CHIP
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
RES-CHIP
1K
47
1K
5%
5%
5%
1/10W
1/10W
1/10W
– 49 –
http://cxema.ru
REMARK
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A
REF. NO. PART NO.
DESCRIPTION
REMARK
REF. NO. PART NO.
DESCRIPTION
R245
R246
R247
1-216-069-00
1-216-069-00
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
6.8K
6.8K
10K
R248
R249
R250
R251
R252
1-216-073-00
1-216-077-91
1-216-077-91
1-216-295-91
1-249-411-11
RES-CHIP
RES-CHIP
RES-CHIP
SHORT
CARBON
R253
R254
R255
R256
R257
5%
5%
5%
1/10W
1/10W
1/10W
R403
R406
R407
1-216-021-00
1-216-065-91
1-216-063-91
RES-CHIP
RES-CHIP
RES-CHIP
68
4.7K
3.9K
5%
5%
5%
1/10W
1/10W
1/10W
10K
15K
15K
0
330
5%
5%
5%
1/10W
1/10W
1/10W
R408
R409
R410
1-216-055-00
1-216-025-91
1-216-073-00
1.8K
100
10K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/4W
R411
1-216-057-00
2.2K
5%
1/10W
1-216-073-00
1-249-389-11
1-249-389-11
1-249-411-11
8-719-041-97
RES-CHIP
10K
CARBON
4.7
CARBON
4.7
CARBON
330
DIODE MA113-(TX)
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
R412
1-216-069-00
RES-CHIP
RES-CHIP
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
6.8K
5%
1/10W
R413
1-216-057-00
2.2K
5%
1/10W
R264
R265
R266
R301
R302
1-216-065-91
1-216-065-91
1-216-073-00
1-216-073-00
1-216-063-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
4.7K
10K
10K
3.9K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R414
R415
1-216-041-00
1-216-033-00
470
220
5%
5%
1/10W
1/10W
R416
R417
1-216-033-00
1-216-033-00
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
220
220
5%
5%
1/10W
1/10W
R303
R304
R305
R306
R307
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R418
R419
R420
R421
R422
1-216-045-00
1-216-049-91
1-216-039-00
1-216-033-00
1-216-027-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
(KV-G21MW3)
680
1K
390
220
120
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R308
R309
R310
R311
R312
1-216-033-00
1-216-033-00
1-216-097-91
1-216-075-00
1-216-025-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
220
220
100K
12K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R423
1-216-029-00
150
5%
1/10W
R424
R425
R426
R427
1-216-057-00
1-216-039-00
1-216-029-00
1-216-037-00
2.2K
390
150
330
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R313
R314
R315
R318
R319
1-216-061-00
1-216-025-91
1-216-295-91
1-216-099-00
1-216-123-11
RES-CHIP
RES-CHIP
SHORT
RES-CHIP
RES-CHIP
3.3K
100
0
120K
1.2M
5%
5%
1/10W
1/10W
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
(KV-G21MW3)
R428
1-216-081-00
5%
1/10W
1/10W
1/10W
R429
R430
1-216-031-00
1-216-041-00
180
470
5%
5%
1/10W
1/10W
R320
R321
R322
R325
R326
1-216-083-00
1-208-820-11
1-216-083-00
1-216-295-91
1-216-039-00
27K
39K
27K
0
390
5%
1/10W
0.5% 1/10W
5%
1/10W
R431
1-216-081-00
22K
5%
1/10W
R432
1-216-041-00
470
5%
1/10W
5%
1/10W
R326
1-216-063-91
RES-CHIP
METAL CHIP
RES-CHIP
SHORT
RES-CHIP
(KV-G21QW3)
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
RES-CHIP
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
22K
5%
5%
3.9K
5%
1/10W
R433
R434
R435
1-216-081-00
1-216-041-00
1-216-041-00
22K
470
470
5%
5%
5%
1/10W
1/10W
1/10W
R327
R328
R329
R330
R331
1-216-295-91
1-216-295-91
1-216-295-91
1-216-043-91
1-216-117-00
SHORT
SHORT
SHORT
RES-CHIP
RES-CHIP
0
0
0
560
680K
R436
1-216-081-00
RES-CHIP
RES-CHIP
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
RES-CHIP
(KV-G21MW3)
22K
5%
1/10W
22K
5%
1/10W
R332
R333
R335
R336
R338
1-216-033-00
1-216-077-91
1-216-073-00
1-216-057-00
1-216-295-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT
R339
R340
R341
R351
R355
1-216-036-00
1-216-035-00
1-216-049-91
1-216-001-00
1-216-001-00
R356
R360
1-216-049-91
1-208-291-11
5%
5%
1/10W
1/10W
R437
1-216-081-00
220
15K
10K
2.2K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R440
R521
R552
R553
R554
1-216-029-00
1-216-049-91
1-216-101-00
1-216-081-00
1-163-009-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
CERAMIC CHIP
150
1K
150K
22K
0.001UF
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
10.00%50V
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
300
270
1K
10
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R555
R556
R557
R560
R561
1-249-429-11
1-216-049-91
1-216-055-00
1-216-295-91
1-249-421-11
CARBON
RES-CHIP
RES-CHIP
SHORT
CARBON
10K
1K
1.8K
0
2.2K
5%
5%
5%
1/4W
1/10W
1/10W
5%
1/4W
RES-CHIP
RES-CHIP
1K
4.7M
5%
5%
1/10W
1/10W
R562
R563
1-249-419-11
1-260-126-11
CARBON
CARBON
1.5K
180K
5%
5%
1/4W
1/2W
– 50 –
http://cxema.ru
REMARK
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A
REF. NO. PART NO.
DESCRIPTION
REMARK
REF. NO. PART NO.
DESCRIPTION
R564
R565
R566
1-216-091-00
1-216-091-00
1-216-065-91
RES-CHIP
RES-CHIP
RES-CHIP
56K
56K
4.7K
R569
R570
R571
R601
R602
1-260-125-11
1-216-295-91
1-216-033-00
1-202-961-11
1-202-961-11
CARBON
SHORT
RES-CHIP
CEMENTED
CEMENTED
150K
0
220
1.8
1.8
R605
R606
R610
R611
R613
1-216-396-11
1-215-915-11
1-215-924-00
1-202-933-61
1-219-134-11
METAL OXIDE
METAL OXIDE
METAL OXIDE
FUSIBLE
FUSIBLE
R614
1-215-877-11
R615
1-249-389-11
R616 ! 1-218-265-11
R617
1-215-924-00
R619
1-219-134-11
R622
R623
R624
R625
R626
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/2W
R882
R883
R895
R898
R902
1-216-059-00
1-216-121-91
1-216-349-00
1-249-421-11
1-216-065-91
RES-CHIP
RES-CHIP
METAL OXIDE
CARBON
RES-CHIP
2.7K
1M
1
2.2K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1W
1/4W
1/10W
5%
5%
5%
1/10W
10W
10W
3.9
470
15K
0.1
0.1
5%
5%
5%
10%
10%
3W
3W
3W
1/2W
1/4W
R906
R907
R908
R909
R910
1-216-065-91
1-216-043-91
1-216-059-00
1-216-071-00
1-216-043-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
560
2.7K
8.2K
560
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL OXIDE
CARBON
METAL
METAL OXIDE
FUSIBLE
22K
4.7
8.2M
15K
0.1
5%
5%
5%
5%
10%
1W
1/4W
1W
3W
1/4W
R911
R912
R913
R914
R1201
1-216-059-00
1-216-071-00
1-216-041-00
1-216-041-00
1-216-023-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.7K
8.2K
470
470
82
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-217-192-21
1-247-807-31
1-216-446-00
1-249-424-11
1-249-420-11
WIREWOUND
CARBON
METAL OXIDE
CARBON
CARBON
0.22
100
18
3.9K
1.8K
10%
5%
5%
5%
5%
2W
1/4W
2W
1/4W
1/4W
R1202
R1203
R1205
R1206
R1211
1-216-049-91
1-216-089-91
1-216-023-00
1-216-089-91
1-216-021-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
47K
82
47K
68
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R627
1-249-417-11
R628
1-249-417-11
R629
1-249-399-11
R632 ! 1-249-381-11
R636
1-215-924-00
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
1K
1K
33
1
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
3W
R1212
R1215
R1216
R1218
R1219
1-216-049-91
1-216-113-00
1-216-113-00
1-216-041-00
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
470K
470K
470
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R801
R802
R803
R804
R805
1-215-920-11
1-249-385-11
1-216-057-00
1-216-049-91
1-216-081-00
METAL OXIDE
CARBON
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
2.2
2.2K
1K
22K
5%
5%
5%
5%
5%
3W
1/4W
1/10W
1/10W
1/10W
R1220
R1221
R1227
R1228
R1229
1-216-049-91
1-216-073-00
1-216-689-11
1-216-049-91
1-216-041-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
10K
39K
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R809
R811
R812
R816
R820
1-247-756-11
1-216-343-00
1-216-075-00
1-249-435-11
1-216-655-11
CARBON
METAL OXIDE
RES-CHIP
CARBON
METAL CHIP
2.2K
0.33
12K
33K
1.5K
5%
5%
5%
5%
0.5%
1/2W
1W
1/10W
1/4W
1/10W
R1230
R1231
R1232
R1233
R1235
1-216-073-00
1-216-049-91
1-216-063-91
1-216-057-00
1-216-689-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
1K
3.9K
2.2K
39K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R821
R822
R823
R825
R826
1-215-911-11
1-216-429-00
1-249-931-11
1-249-392-11
1-216-059-00
METAL OXIDE
METAL OXIDE
CARBON
CARBON
RES-CHIP
100
270
2.2K
8.2
2.7K
5%
5%
5%
5%
5%
3W
1W
1/4W
1/4W
1/10W
R1239
R1240
R1241
R1243
R1245
1-249-389-11
1-216-025-91
1-216-049-91
1-216-025-91
1-216-037-00
CARBON
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7
100
1K
100
330
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R827
R828
R829
R831
R832
1-216-095-00
1-216-063-91
1-216-053-00
1-215-886-11
1-216-057-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL OXIDE
RES-CHIP
82K
3.9K
1.5K
100
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
2W
1/10W
R1246
R1247
R1248
R1249
R1250
1-216-037-00
1-216-041-00
1-216-051-00
1-216-041-00
1-216-119-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
330
470
1.2K
470
820K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R834
R851
R853
R854
R855
1-216-073-00
1-249-382-11
1-249-377-11
1-249-377-11
1-202-818-00
RES-CHIP
CARBON
CARBON
CARBON
SOLID
10K
1.2
0.47
0.47
1K
5%
5%
5%
5%
20%
1/10W
1/4W
1/4W
1/4W
1/2W
R1251
R1252
R1253
R1255
R1513
1-216-119-00
1-216-057-00
1-216-051-00
1-216-073-00
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
820K
2.2K
1.2K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1514
R1515
1-216-065-91
1-216-025-91
RES-CHIP
RES-CHIP
4.7K
100
5%
5%
1/10W
1/10W
R856
R857
R858
R860
R881
1-249-429-11
1-249-438-11
1-216-370-11
1-247-887-00
1-216-043-91
CARBON
CARBON
METAL OXIDE
CARBON
RES-CHIP
10K
56K
1.2
220K
560
5%
5%
5%
5%
5%
1/4W
1/4W
2W
1/4W
1/10W
<SWITCH>
S601 ! 1-571-433-21
S801
1-572-707-11
S901
1-571-532-21
– 51 –
http://cxema.ru
REMARK
SWITCH, PUSH (AC POWER)
SWITCH, LEVER
SWITCH, TACTIL
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
A C
REF. NO. PART NO.
DESCRIPTION
S902
S903
1-571-532-21
1-571-532-21
SWITCH, TACTIL
SWITCH, TACTIL
S904
S905
S906
1-571-532-21
1-571-532-21
1-571-532-21
SWITCH, TACTIL
SWITCH, TACTIL
SWITCH, TACTIL
REMARK
1-519-422-11
DESCRIPTION
C737
C746
CERAMIC
CERAMIC
1-102-114-00
1-102-114-00
REMARK
470PF
470PF
10.00%50V
10.00%50V
<CONNECTOR>
CN701 1-508-766-00
CN703 * 1-564-509-11
CN704 1-695-915-11
<SPARK GAP>
SG801
REF. NO. PART NO.
PIN, CONNECTOR (5MM PITCH) 4P
PLUG, CONNECTOR 6P
TAB (CONTACT)
GAP, SPARK
<DIODE>
<#########>
SWF401 1-760-771-11
FILTER, SURFACE WAVE
D701
D702
D703
D707
D708
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
D709
D710
D711
D712
D716
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
DIODE 1SS119-25TD
D717
8-719-929-15
DIODE RD9.1ES-T1B
<TRANSFORMER>
T601 ! 1-429-137-21
T605 ! 1-424-682-11
T801
1-437-195-11
T851 ! 1-453-250-11
TRANSFORMER, CONVERTER (SRT)
TRANSFORMER, LINE FILTER
TRANSFORMER, HORIZONTAL DRIVE
TRANSFORMER ASSY, FLYBACK (NX-1746//M3A)
<THERMISTOR>
THP601!1-808-059-31
<JACK>
THERMISTOR, POSITIVE
J701
! 1-251-732-11
SOCKET, CRT
<TUNER>
TU101 ! 8-598-323-50
<COIL>
VSS TUNER BT-AG401
L701
1-410-667-31
INDUCTOR
22UH
<CRYSTAL>
X101
X300
X358
X443
1-577-358-21
1-411-752-11
1-567-505-11
1-567-504-11
<TRANSISTOR>
VIBRATOR, CERAMIC
COIL
OSCILLATOR, CRYSTAL (KV-G21MW3)
OSCILLATOR, CRYSTAL
*******************************************************************
* A-1331-688-A C BOARD MOUNTED
*******************
Q704
Q705
Q706
Q707
Q708
8-729-326-11
8-729-326-11
8-729-326-11
8-729-200-17
8-729-200-17
TRANSISTOR 2SC2611
TRANSISTOR 2SC2611
TRANSISTOR 2SC2611
TRANSISTOR 2SA1091O-TPE2
TRANSISTOR 2SA1091O-TPE2
Q709
Q710
Q711
Q712
8-729-200-17
8-729-119-78
8-729-119-78
8-729-119-78
TRANSISTOR 2SA1091O-TPE2
TRANSISTOR 2SC2785TP-HFE
TRANSISTOR 2SC2785TP-HFE
TRANSISTOR 2SC2785TP-HFE
<CAPACITOR>
<RESISTOR>
C701
C702
C703
C704
C708
1-162-114-00
1-102-074-00
1-107-651-11
1-130-202-00
1-102-114-00
CERAMIC
CERAMIC
ELECT
FILM
CERAMIC
0.0047UF
0.001UF
4.7UF
0.022UF
470PF
2KV
10.00%50V
20.00%250V
5.00% 400V
10.00%50V
R703
R705
R710
R711
R712
1-249-496-11
1-216-393-00
1-215-922-11
1-247-762-11
1-215-922-11
CARBON
METAL OXIDE
METAL OXIDE
CARBON
METAL OXIDE
100K
2.2
6.8K
6.8K
6.8K
5%
5%
5%
5%
5%
1/2W
3W
3W
1/2W
3W
C709
C710
C712
C713
C714
1-102-114-00
1-102-114-00
1-102-116-00
1-102-116-00
1-102-116-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
470PF
470PF
680PF
680PF
680PF
10.00%50V
10.00%50V
10.00%50V
10.00%50V
10.00%50V
R713
R714
R715
R719
R720
1-247-762-11
1-215-922-11
1-247-762-11
1-215-480-00
1-249-923-11
CARBON
METAL OXIDE
CARBON
METAL
CARBON
6.8K
6.8K
6.8K
300K
1K
5%
5%
5%
1%
5%
1/2W
3W
1/2W
1/4W
1/4W
C716
C717
C736
1-126-933-11
1-101-880-00
1-102-114-00
ELECT
CERAMIC
CERAMIC
100UF
47PF
470PF
20.00%16V
5.00% 50V
10.00%50V
R721
R722
1-215-489-00
1-249-923-11
METAL
CARBON
680K
1K
1%
5%
1/4W
1/4W
– 52 –
http://cxema.ru
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
C
REF. NO. PART NO.
DESCRIPTION
REMARK
R723
R724
R725
1-215-479-00
1-249-923-11
1-249-419-11
METAL
CARBON
CARBON
270K
1K
1.5K
1%
5%
5%
1/4W
1/4W
1/4W
R726
R727
R728
R729
R730
1-249-419-11
1-249-419-11
1-249-407-11
1-249-408-11
1-249-408-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
1.5K
150
180
180
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R731
R732
R733
R734
R738
1-249-399-11
1-249-399-11
1-249-399-11
1-247-739-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
33
33
33
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/2W
1/4W
R739
R740
R755
R756
1-247-807-31
1-247-807-31
1-249-418-11
1-249-418-11
CARBON
CARBON
CARBON
CARBON
100
100
1.2K
1.2K
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
R757
1-249-418-11
CARBON
1.2K
5%
1/4W
REF. NO. PART NO.
1-501-372-81
! 8-451-280-33
! 8-738-774-05
REMARK
ANTENNA, TELESCOPIC
DEFLECTION YOKE (Y21PXA2)
PICTURE TUBE (21PXD(SDS)(SD-169/IBR))
*****************************************************************
ACCESSORIES AND PACKING MATERIALS
***************************************
A-1028-509-A
A-1028-508-A
3-701-910-00
* 4-063-809-01
* 4-063-798-01
PACKING GROUP (SET) (KV-G21MW3)
PACKING GROUP (SET) (KV-G21QW3)
SCREW, SPECIAL (DIA. 3.8X20)
INDIVIDUAL CARTON
CUSHION (UPPER) (ASSY)
*
*
*
*
*
CUSHION (LEFT UPPER)
CUSHION (RIGHT UPPER)
CUSHION (LOWER) (ASSY)
CUSHION (RIGHT LOWER)
CUSHION (LEFT LOWER)
4-063-804-01
4-063-805-01
4-063-799-01
4-063-797-01
4-063-806-01
* 4-395-957-01
4-076-975-11
4-392-003-11
4-392-004-11
******************************************************************
MISCELLANEOUS
*****************
! 1-409-942-11
1-452-032-00
1-452-277-00
1-505-740-11
1-473-159-21
COIL, DEMAGNETIZATION
MAGNET,DISC
MAGNET, BMC
SPEAKER (5X9CM)
CAP ASSY, HIGH-VOLTAGE
! 1-574-062-11
1-900-212-58
CORD, POWER (WITH CONNECTOR) 2.5A/250V
LEAD ASSY, FOCUS
BAG, PROTECTION
MANUAL, INSTRUCTION
BAND, HOLD
CLIP
*****************************************************************
REMOTE COMMANDER
**********************
– 53 –
http://cxema.ru
DESCRIPTION
1-475-358-11
9-939-697-01
REMOTE COMMANDER (RM-869)
BATTERY COVER, REMOTE COMMANDER
KV-G21MW3/G21QW3
RM-869
The components identified by shading
and mark ! are critical for safety.
Replace only with part number specified.
REF. NO. PART NO.
DESCRIPTION
REMARK
REF. NO. PART NO.
Sony Corporation
9-872-206-01
Sony Technology Malaysia Sdn. Bhd.
TV Business of General Area
– 54 –
http://cxema.ru
DESCRIPTION
REMARK
English
2000DS70176-1
Printed in Malaysia
 2000. 4