Download ABS535T SERVICE MANUAL
Transcript
Principle and Maintenance of ABS535T CONTENTS Chapter I Overview of ABS535T 1、Description of Functions 2、Block Diagram of Player 3、Composition of IC for Player Chapter II Operating Principle of Servo Circuit 1、Processing Procedure of Digital Signal 2、Processing Procedure of Control Signal Chapter III Operating Principle of Decoding Circuit 1、Control Circuit of System 2、Audio and Video Output Circuit Chapter IV Operating Principle of Power Board 1、Block Diagram 2、Operating Principle of Circuits Chapter V Operating Principle of Panel 1. Operating Principle Chapter VI Troubleshooting Appendix: Functions of IC Pins Important prompt: This type player employs two kinds of decks, SF-HD62 and SF-HD60, and corresponding software of these two types of decks are different, therefore please pay special attention during deck changing in the maintenance. Corresponding decks should be changed with the same type of original ones, otherwise the player will be out of order. Identification of decks is shown as figures: SF-HD62 SF-HD60 Operating Principle Analysis of ABS535T Chapter I Overview of ABS535T ABS535T is a medium- low-grade model integrating with video disc and power amplifier, with the following major features: 1. The layer adopts “Sanyo loader+MT1389”solution; 2. The power amplifier adopts the digital power amplification circuit, with the power IC of TAS5112DFD; it has low distortion level; 3. The audio process adopts TAS5508 , with high integration and high performance and price ratio; 4. It has the function of radio reception, and the tuner adopts Sanzhenxing DTS-44K(CE)module; 5. The power supply adopts the switching power, with compactness, high efficiency and stable performance; 6. Equipped with SCART(CVBS/RGB)port; 7. Accessory channel input/output function; 8. Headphone output function; 9. Karaoke and automatic accompaniment function 10. “RDS”function; II. Block Diagram of ABS535T Complete Player and IC Function Table : Radio reception head composite 29LV160BE S terminal 16M ROM MT1389 Sany Power Audio D/A,power Refor load drive SDRAM Figure 1 Y/Cb/Cr 6-way HCU04 fiber, Progressive load MPEG decoder feed main Digital signal track BA5954 Servo drive focus 4340,7265 Digital servo deck status AV output circuit AT24C02 Panel Y/Pb/Pr VGA III. Function Table of ICs for ABS535T Circuit Board Deck Main Board Panel Power Board Amplifier board No Name Function Sanyo U201 MT1389 U202 AT24C02 Pick- up of disc signal RF signal processing, digital signal processing, servo processing, MPEG decoding, line scan, system control Series EEPROM, status memory U205 HCU04 Hex inverter U209 U211 LM1117MP-1.8 AE45164016 1.8v voltage-regulated power supply 64Mbit SDRAM U214 29LV160BE 16Mbit FLASH ROM U302 N102 D5954 SD16311 4-channel servo driver circuit Panel control, VFD display drive N103 REMOT Remote receptor U501 0380 Switching power circuit U502 HS817 Photo-electric coupler U503 HA17431 U11 LM7805 U505 0880 2.5V reference voltage comparator 5V 3-terminal voltage-regulated power supply Switching power circuit U506 U507 HS817 LM431 Photo-electric coupler 2.5V reference voltage comparator N12 5508 Digital signal processing N13/14 N8/9 N10/11 5112 TLV272 RC4580 Power amplification Operational amplification Digital signal amplification Chapter II Operating Principle of Servo Circuit I. Digital Signal Processing Procedure ABS535T adopts Sanyo double beam super error correction deck and MTK decoding solution, and its servo circuit mainly consists of preposition signal processing, digital servo processing, digital signal processing IC MT1389 and driver circuit BA5954. MT1389 is also a main part of the decoding circuit. The A, B, C, D, E, F, SA, SB and RFO signal transmitted from the deck are mainly inputted through the 2-13 pins of MT1389, and after amplifying treatment of built- in amplifier of MT 1389, the signals are treated in two parts within MT1389: After being processed by the internal digital servo signal circuit of MT1389, part of the signal forms into corresponding servo control signal, and output focus (FOSO), tracking (TRSO), main shaft (DMSO) and feed (FMSO) servo control signal from the P42, P41, P37 and P38 of MT1389 and send them to the driver circuit BA5954 to amplify the drive. After drive amplification, the signals will drive the focus coil, tracking coil, main shaft motor and feed motor. The focus and tracking servos will be used to adjust the object lens and enable laser beam to identify signal from compact disc correctly; the feed servo will be used to drive the laser head to move longitudinally, and scan the compact disc; the main shaft servo is used to control the main shaft motor to read the signals in constant linear speed and drive the disc to rotate. After being processed by the internal VGA voltage-controlled amplifier of MT1389 in amplification and balance frequency compensation; another part of the signals is converted into digital signal by the internal A/D converter. When the deck reads the CD/VCD signals, these signals will be EFM demodulated in MT1389, and after accomplishing CIRC error regulation in internal MT1389, output to the next grade to carry out audio and video decoding; when the deck reads the DVD signals, these signals will be ESM demodulated in MT1389, and after accomplishing RSPC error regulation in internal MT1389, output to the next grade to carry out audio and video decoding. II. Processing Procedure of Control Signal 1. Automatic control of laser power, with the circuit shown as the Figure II: Figure II MT1389 is integrated with APC (automatic light power control) circuit. Its Pin 20 is the pin for inputting VCD laser power rate detection signal, the Pin 21 is the pin for inputting DVD laser power rate detection signal, and the Pin 23 is the pin for outputting VCD laser power rate drive control. When the Pin 23 finds that the laser output power rate is too strong, the output voltage on Pin 23 will increase after the processing of internal circuit of MT1389, and then the conduction degree of V302 (2SB1132) and the voltage on its integration polar will decrease, which consequently lead to the decrease of voltage supplied to the laser tube, the weakening of laser head lighting, and thus achieve the automatic adjustment on laser output power. The Pin 22 is the pin for outputting DVD laser power drive control, with the specific control procedure similar to that of VCD. 2. The tray open/close control circuit is shown as the Figure III: Figure III Different from the circuit in former MTK solution, the MT1389 is integrated with preposition signal processing circuit, so the tray open/close control signals are accomplished by MT1389, that is to say, the close control signal is accomplished by the Pin 51 of MT1389, while the open control signal by Pin 39 of MT1389. When we press the open button, the Pin 51 of MT1389 is in high power level, while the Pin 39 is in low power level, and then the triode V308 will be on-state. Through resistor R323, the base of V306 will be made to be in low power level, and V306 will be on-state, with the current direction as the following figure: Power voltage VCC ? V306E-C junction ? motor negative terminal LOAD- ? motor positive Load +? V308 C-E junction ? grounding So the motor will rotate clockwise to accomplish the action of tray closing. When we press the open button, the Pin 51 of MT1389 is in low power level, while the Pin 39 is in high power level, and then the triode V307 will be conducted. Through resistor R324, the base of V309 will be made to be in low power level, and V309 will be conducted, with the current direction as the following figure: Power voltage VCC ? V309E-C junction ? motor negative terminal LOAD- ? motor positive Load +? V307 C-E junction? grounding So the motor will rotate anti-clockwise to accomplish the action of tray opening. 3. The main shaft motor braking circuit is as the Figure IV: To prolong the lifespan of motor and reduce the influence of start- up impact current, with the installation of disc, our R&D personnel design the main shaft motor to be in the state of constant operation, so that even if the STOP button is pressed, the disc will not be stopped. Therefore, when we press the OPEN button, a braking signal is required to stop the rotation of main shaft motor immediately to accomplish the opening action in a short time. Figure IV During playing, if we press the OPEN button, the main shaft drive signal will disappear, and because of inertia, the main shaft motor is still in operation. As the electromotive force generated in the operation of motor receives the induction voltage on sampling resistors R321 and R340, which, through the resistor R319 and R320, is added to the Pin 36 and Pin 35 of MT1389, and outputted from the Pin 34 after internal processing for amplification in MT1389, and delivered to Pin 47 of MT1389 through R318. After the internal A/D conversion and corresponding processing, an instant motor reversal braking signal will be outputted from the Pin 37 of MT1389 to stop the rotation of main shaft motor immediately, so as to ensure the standstill of the disc when opening the player. III. Servo drive circuit The servo drive of the playe r is accomplished through a piece of 4-channel dedicated drive circuit BA5954, with the circuit as Figure V: The 4 servo control signals generated in digital servo circuit processing of MT1389, i.e. focusing control FOSO, tracking control TRSO, feed control FMSO and main shaft control DMSO signals, are added to the pins 1, 26, 23 and 5 of BA5954 respectively, and after drive amplification of BA5954, the focusing and tracking drive signals will be outputted from the pins 13 and 14 and pins 15 and 16 of BA5954 respectively, and added to the focusing and tracking coils to drive the light head to accomplish the actions of focusing and tracking. The feed and main shaft drive signals will be outputted from the pins 17 and 18 and pins 11 and 12 of BA5954 respectively, and added to the feed motor and main shaft motor to drive the light head to move longitudinally and enable the disc to rotate in constant linear speed. The STBY on Pin 28 of BA5954 is an output-enabling signal, and only when the pin is in high power level, there will be output of drive voltage on the output terminal. Chapter III Operating Principle of Decoding Circuit The decoding circuit of the player mainly consists of decoding chips (including MT1389, SDRAM AE45164016 and FLASH ROM 29LV160BE) and audio DAC CS4360. I. Control Circuit of System 1. Reset circuit is as the Figure VI: Figure VI The reset circuit of the player consists of triode Q204 9014, reset capacitor TC217 100uF/16V and phase inverter U205 HCU04. In starting up, as the terminal voltage of capacitor cannot be changed suddenly, the basic of Q204 is in low power level. After the cut-off of Q204, its emission polar is in low power level, after secondary phase inversion by U205 and regulation, the low power level reset signal is outputted to the Pin 110 of MT1389 to reset MT 1389. When the recharging of TC217 is finished, the base of Q204 will be in high power level, Q204 will be conducted, and the emission polar is in high power level. After the secondary phase inversion and regulation by U205, a high power level is outputted and added to the Pin 110 of MT1389 to maintain high power level during its normal operation. 2. Clock circuit The crystal oscillator of X201 27MHz, C275/27PF, C276/27PF and phase inverter HCU04 form into clock oscillation circuit, and the clock signals generated are added to the pins 229 and 228 of MT1389 through R244 and 4248 to provide operating clock for MT1389. 3. Data communication circuit The data communication circuit of the player consis ts of decoding chip MT1389, SDRAM, AE45164016 and FLASH ROM 29LV160BE, as the Figure VII: MT1389 is a piece of super large integrated circuit, with the operation voltage of +3.3V and +1.8V. Its functions include: RF small signal preposition processing, digital servo, digital signal processing and accomplishing MPEG decoding and video coding. The built- in MCU of MT1389 is also the system control circuit of the whole player. AE45164016 is a piece of 4M*16bit large capacity SDRAM, with the operation voltage of +3.3 V. In DV971, the 6ns module is adopted, with high speed and the maximum operation frequency up to 166MHz. Its main function is for operation buffer storage of decoding chip MT1389 to store the audio and video data stream in decoding. 29LV160BE is a piece of 16Mbit FLASH ROM, with the operation voltage of +3.3V, mainly for storing the user’ s information including OSD character information, operational microcode and LOGO in start- up. VD DMA0—DMA11 A0—A21 MT1389 RY/BY DQ0—DQ15 AD0—AD7 15 29LV160BE 26 28 11 DCE DRD DWR 77 79 66 47 BYTE 113 137 156 157 140 139 142 138 145 143 AE45164016 15 39 38 37 18 17 19 16 20 21 DQML DQMH CLK CKE RAS CAS CS WE BA1 BA0 GND Figure VII II. Audio and Video Output Circuit 1. Video output circuit ABS535T can not only output three types of alternating- line video signal (including CVBS composite video, S terminal Y-C signal and Y/Cb/Cr color difference signal), but also output two types of progressive line video signal (including Y/Pb/Pr progressive line color difference signal and VGA progressive line signal). The decoding chip MT1389 has built- in video encoding circuit for direct output of analogue composite video signal CVBS, S terminal, color difference signal and VGA signal. The CVBS composite video signal is outputted from the Pin 198 of MT1389, the S terminal signal Y-C is outputted from the pins 194 and 196 of MT1389, the color difference signal and the R-B-G signal of VGA port is outputted from the pins 203, 202 and 200 of MT1389, the row and field synchronization signals of VGA port are outputted from the pins 207 and 205 of MT1389 respectively. To mention specifically, the alternating- line color difference signal, the progressive line color difference signal and progressive line R-B-G signal are outputted from the same pin, therefore the signal output shall be selected according to the ports of TV, otherwise there will be only sound but without picture display. 2. Audio output circuit Audio signals processed by MT1389 output 5-track data signals through pin 217, pin 218 and pin 219 and 5-channel clock signals through pin 214 and pin 215. These signals after passing through IC 74HCT125 are transmitted to audio signal processing IC TAS5508 to be processed (specific IC data please refer to Attachment), then 10 groups of PWM signals are output, six of which are transmitted to power amplifying parts, two of which to headphone output and two of which to auxiliary channel output. Six groups of signals transmitted to power amplifying IC are processed by surrounding and super DBB sharing an N13 IC TAS5508, and by main sound channel and center sharing an N14 IC TAS5508. Signals are amplified here, for they are digital high frequency signals, they have high efficiency; meanwhile power IC has low colorific value. Amplified signals are still digital signals, in order that they can be output through loudspeaker, amplified digital signals still have to be processed before outputting. For PWM signals containing audio signals, since high frequency signals have high frequency and are beyond audibility range of human ears, we can ignore impacts of high frequency signals and reduce low frequency audio signals only during processing. TAS5508 is an 8-channel pulse width modulated high performance IC, and applicable in processing most digital audio signals. Between 20Hz and 20KHz, it has excellent noise factor and dynamic range. It has following features: 1、 2、 3、 4、 Automatically control clock speed and digital sampling speed; 8 groups of audio input channels; 8 groups of PWM output can be changed into 6-channel stereo line output or 8-channel line output; Line output is a different input open loop amplifier driven by a group of PWM signals. IC TAS5112 is a high performance audio power amplifier. Bridging with 6O loading, each channel can output 50W. It has 95DB dynamic range, low distortion degree and low rate of heat generation with power efficiency up to 90%. It also has functions of low-voltage protection, high-temperature protection, overflow protection, etc. At the same time, it has built- in driving power adjustment gate circuit. It is applicable in family video, DVD receiver, mini music center, etc. Detailed IC introduction see Attachment. When in normal disc reading, digital signals and clock signals from 1389 are transmitted to pin 26 to pin 31 of IC TAS5508 through IC 74HCT125 gating. If no headphone is inserted, PH-SEL is of high level, as well as when MUTE is normal. And pin 37 of TAS5508 is also of high level. All data lines and clock lines can be detected by oscilloscope. One group of signals from 5508 is transmitted to N8 and N9, then output through auxiliary channel. Another group is transmitted to headphone; other PWM signals are transmitted to amplifying parts of amplifier. When headphone is inserted, PH-SEL signal is forcibly shorted to earth, and turns to low level, meanwhile amplifier is muted. This amplifier has functions of radio reception, auxiliary channel output and karaoke. All external inputs after N3 CD4052 gating and N7 CS5340 analog-to-digital conversion are transmitted to MT1389. Rear processing and output is the same as the signal output flow in normal disc reading. When in disc reading, system defaults to gate karaoke input, therefore you can open karaoke when playing disc. This amplifier also has automatic accompaniment function, when playing VCD, system detects external input and automatically screen to human sound signal in the disc, while only saves sound accompaniment. ABS535T has the function of radio reception, and can also receive RDS signal. The radio head control lines CE, DI, CL and DO are controlled by 28 array lines connecting to MT1389 control. When any of the controlling lines is in abnormality, the radio reception will be in malfunction. The RDS signal received by radio head will be delivered to the dedicated IC SAA6588 for processing. Chapter IV Operating Principle of Power Board I. Block Diagram This amplifier has two groups of power supply; one is of low voltage for decoding board and low power ICS, the other is of higher voltage for power amplifying IC. But their design principles, we only draw one functional block diagram of them: II. Introduction of Circuit Principle 220V alternating current is loaded on D501-D504 integrated bridging rectification circuit through power plug, fuse tube, voltage dependent resistor R501 and common mode rejection BC501 and L501. Diode adopts IN4007 which ahs better PPR and higher withstand voltage value than IN4001. Output 311V direct current after being bridging rectified is loaded on two transformers through TC501 filtering and transmitted to DRAIN control pins of switch modules U501 and U502. Service voltage of power on IC after being directly rectified and filtered is divided by resistors to serve IC. Diode D508, capacitor C516 and resistor R516 form absorption circuit to provide discharge circuit of reverse electromotive force for 1-4 coils of transformers. Pin FB controlling IC is feedback control pin, so you should decide on/off time of pulse width according to current intensity on it to ensure stability of output voltage. There are 5 branch circuits coupled to sub-grade through transformer. 1. Voltage output from pin 11 and pin 13 of transformer T501 outputs a group of +28V voltage for power amplifying IC after being rectified and filtered. 2. Voltage output from pin 16 of transformer T501 outputs a group of +12V voltage after being rectified and filtered. +12V voltage is stabilized into a group of +5V voltage by IC LM7805. 3. Voltage output from pin 14 of transformer T501 outputs +5V voltage and provide voltage for one end of photo-electric coupler U502 after being rectified and filtered. 4. Voltage output from pin 12 of transformer T501 outputs +3.3V voltage and provide a group of stable voltage for CPU after being rectified and filtered. 5. Voltage output from pin 9 of transformer T501 outputs a group of 21V voltage for displaying driving IC after being rectified and filtered. Clamp ZD501 of -21V provide heater voltage for panel display screen. Grounding direct voltage of FL+ and FL- is about -16V. Operating principles of two groups of switch power are the same, therefore we will only analyze the group providing +3.3V voltage for CPU here: Feedback sampling of this group comes from 3.3V and supplies for photocupler HS817 through D516 and R506. At the same time, it is divided through R508 and R509 for reference voltage pin R of 2.5V comparator. When 3.3V becomes higher, pin KA of comparator is on; and the voltage is transmitted to pin 4 of switch IC 5L0380R after photoelectric coupling through HS817 to reduce on time of internal switch tube. And thus it reduces transformer coupling and decreases output of 3.3V voltage to achieve automatic adjustment and control, and vice verse. It has to be noted that in this switching power reference voltage comparator IC of two groups of switching power are different. For voltage of the group supplying power for amplifier is higher, it adopts LM431 which has better performance and higher withstand voltage. And voltage of the group supplying power for 3.3V is lower, it adopts 17431. For two ICs are different, you should pay special attention to distinguish them from each other. They cannot be used mixing. Chapter 5: Panel control and VFD display circuit The panel mainly consists of VFD screen, driver ICD16311, remote receptor HS0038A2 and button and indicator display circuit, mainly for accomplishing man-player dialogue and display of operation status. The structural drawing is as follows: Keystroke control VFD U401 display IC D16311 VFDST U201 VFDCK VFDAT MT1389 Panel indicator control Remote receiving Figure XI MT1389 will control the U401 IC D16311 to display the operation status of the player through the VFDST status, VFDCK clock and VFDAT data, under the control of CPU built in MT1389, receive the user control commands sent by D16311, and control the controlled circuit of the player to limit the player to operate in specified status. When the user operates the panel buttons, the control command is sent to the IC D16311 through keyboard-scanning circuit, and through internal decoding drive, the IC D16311 outputs the control data from the pins 5 and 6 (VFDAT) to the built- in CPU of MT1389, which will realize the control on the controlled circuit, and control the VFD through IC D16311. VFD401 is a vacuum fluorescence screen, and its biggest feature is its high brightness. Its operation principle is similar to the kinescope of TV. The pins 1, 2, 34 and 35 are for filament power supply; the pins 27-32 are GRID poles, each GRID has 16 different characters of display; the pins 4-19 are SEG poles, and the CPU control the SEG poles through its control on IC D16311, and display the characters of corresponding operation status on the screen. The remote reception circuit mainly consists of remote receptors HS0038A2, of which the pin 1 is for grounding, the pin 2 for power supply, the pin 3 for output of reception signal, and they are all connected directly to the CPU in MT1389 to control the corresponding circuit. This player has headphone output function. A pin in the headphone directly connects to TAS5508. When the headphone is inserted, detection line H-DET grounds and turns into low level. When pin 12 of TAS5508 turns into low level, parts of output of amplifier are muted. When in normal condition, this detection pin is of high level around 3.3V. Troubleshooting I. Voltage on key points of ABS535T Demoding circuit: Reset: 1. U205 (HC U04): 8 pins, around 5V; 2. MT1389: 110 pins, around 5V; 3. FLAHS ROM: 12 pins, around 5V Clock: 27MHZ crystal oscillator two ends: Around 0.77V. I2 C bus SDA: 3.3V I2 C bus SCL 3.3V Servo circuit: LD01: 3.3V;LD02:3.3V V301 and V302 electron collector LD voltage: 2.3V BA5954 pin 4 base voltage: 1.4V BA5954 pins 15 and 16 tracking drive output: Around 2.5V BA5954 pins 17 and 18 feed drive output: Around 2.5V BA5954 pins 13 and 14 focus drive signal output: Around 2.5V BA5954 pins 11 and 12 main shaft drive output: Around 2.5V BA5954 pin 1 focus control signal input: 1.4V BA5954 pin 5 main shaft control signal input: 1.4V BA5954 pin 26 tracking control signal input: 1.4V BA5954 pin 23 feed control signal input: 1.4V Amplifier circuit: TAS5508 pin 9 power supply pin 3.3V TAS5112 32、33、40、41、44、45、52、53, 28V。\ II. Troubleshooting of main troubles No picture, no sound, no VFD display Check if power supply of MT1389 3.3V, 1.8V is right? NO Check the voltage of power board, and check if the decoding board is short circuit to the grounding. YES If the clock signal output XO and XI is right? Check if clock oscillating circuit 27M crystal oscillator, C275, C276, R224, R248 are damaged? NO YES Check if reset signal URST# is in 5V high level? YES Check if I2C bus, SDA, SCL 3.3V voltage is right? Check if SDRAM CLK, CS, RAS, CAS, WE communication signals are right? NO Check if the reset circuit which is comprised by HCU04 and Q204 etc. is in working order? Check if the AT24C16, CS4360, MT1389 SDA and SCL are short circuit to grounding, if R259 and R260 are in working order? Check if FLASH ROM, URST, DCE, DRD, DWR signals are right? Check if the connection between MT1389, FLASH, SDRAM is right? Check if the MT1389, SDRAM and FLASH are damaged? Do not read disc Check if the feed control input of BA5954 Pin 23 is 1.4V? laser head has feed action. Check if the Check if the connection from BA5954 to MT1389 is open circuit? NO YES Check if BA5954 pin 17,18 have 2.5V voltage output? Check feed motor and its connection. YES YES NO Check if BA5854 and the power supply 5V are in working order? Check if BA5954 pin 1 Check if laser head has focus action? has focus control voltage input of 1.4V. NO Check if the connection from BA5954 to MT1389 is open circuit? YES Check if the voltage output of BA5954 pin 13 and 14 are 2.5V? YES NO Check if BA5854 and 5V power supply are in working order? Check focus coil and its YES connection. Check if there is laser coming out from laser head? Check if the signal voltage of LD01, LD02 is 3.2V? NO Check MT1389 and its connection. YES YES Check if the main shaft rotates? Check if V301 and V302 electron collector voltage is 2.3V? Check if the control voltage of BA5954 pin 5 main shaft is 1.4V? YES Check if the laser head and its array line are right? NO Check if the connection from BA5954 to MT1389 is open circuit? YES Check if BA5954 pin 11 and 12 output is 2.5V? YES YES NO Check if MT1389 and its peripheral circuit is right? Check if BA5854 and 5V power supply are in working order? Check if BA5954 or main shaft motor is damaged? Attachment :Brief Introduction to IC Pins I. MT1389 MT1389 adopts the LQFP 256 pin packaging and 3.3V/1.8V double voltage operation mode. It is a piece of large-scale CD-ROM and DVD-ROM preposition processing CMOS integrated circuit with excellent performance, and a single chip dedicated to CD/VCD/DVD player. It contains focusing servo error amplification, tracking servo error amplification and RF level output servo control, including the following main functions: RF small signal preposition processing, mainly for carrying our corresponding processing and amplification on the RF signals transmitted from the light head part, adjusting the laser output power automatically, and identifying the VCD disc and DVD disc. Digital servo processing can generate focusing, tracking, feed and main shaft servo control signals; digital signal processing, accomplishing the EFM/EFM + demodulating of RF signals. MPEG-1/MPEG-2/MPEG4/JPEG Video decoding chip, which can not only realize the decoding of VCD and DVD, but also realize MPEG 4 network video decoding, being compatible to “network movie”disc, and decipher JPED pictures to realize the function of digital photo album play. On audio aspect, it can not only realize AC-3/DTS double decoding, decipher MP3, and is also compatible to DVD-Audio decoding to achieve high- resolution sound restoration in 1000 times higher than CD. By utilizing the 8032 microprocessor with built- in chip, MT1369E can also realize the system control function of player, which simplifies the circuit design substantially. The pin functions of MT1389 are as the following table: Pin Name Function 1 AGND Analogue grounding 2 DVDA DVD-RF high- frequency AC coupling signal A 3 DVDB DVD-RF high- frequency AC coupling signal B 4 DVDC DVD-RF high- frequency AC coupling signal C 5 DVDD DVD-RF high- frequency AC coupling signal D 6 DVDRFIP DVD-RF high- frequency AC coupling signal RFIP input 7 DVDRFIN DVD-RF high- frequency AC coupling signal RFIN input 8 MA DVD-RAM main light beam RF DC signal input A 9 MB DVD-RAM main light beam RF DC signal input B 10 MC DVD-RAM main light beam RF DC signal input C 11 MD DVD-RAM main light beam RF DC signal input D 12 SA DVD-RAM auxiliary light beam RF DC signal input A 13 SB DVD-RAM auxiliary light beam RF DC signal input B 14 SC DVD-RAM auxiliary light beam RF DC signal input C 15 SD DVD-RAM auxiliary light beam RF DC signal input D 16 CDFON CD focusing error phase inversion input 17 CDFOP CD focusing error phase input 18 TNI 3 light beam auxiliary PD signal phase inversion input 19 TPI 4 light beam auxiliary PD signal phase input 20 MDI1 Laser power monitoring input 1 21 MDI2 Laser power monitoring input 2 22 LDO2 Laser power monitoring output 2 23 LDO1 Laser power monitoring output 1 24 SVDD3 Servo 3.3V power supply 25 CSO/RFOP Main servo signal output/RF phase output 26 RFLVL/RFON RF level output/RF phase inversion output 27 SGND Servo grounding 28 V2REFO Reference voltage 2.8V 29 V20 Reference voltage 2.0V 30 VREFO Reference voltage 1.4V 31 FEO Focusing error signal output 32 TEO Tracking error signal output 33 TEZISLV Tracking zero crossover error input 34 OP_OUT Sensing signal amplification output 35 OP_INN Sensing signal phase inversion input 36 OP_INP Sensing signal non- inverting input 37 DMO Main shaft control signal output 38 FMO Feed control signal output 39 TROPEN PWM Tray Open signal output 40 PWMOUT1/ADIN9 First-route pulse width demodulating signal output/AD universal input 41 TRO Tracking control signal output 42 FOO Focusing control signal output 43 USB_VSS USB grounding 44 USBP USB data 45 USBM USB data 46 USB_VDD3 USB 3.3V power supply 47 FG/ADIN8 Motor sensing signal input/AD universal input 48 TDI/ADIN4 Open position detecting signal input/AD universal input 49 TMS/ADIN5 Close position detecting signal input/AD universal input 50 TCK/ADIN6 BA5954 enabling signal output/AD universal output 51 TDO/ADIN7 Tray close signal output/AD universal input 52、97、122、 152、173、221 DVDD18 Digital 1.8V power supply 53-58 IOA2-7 Micro-controller address bit 2-7 59 HIGHA0 Micro-controller address bit 0 60、61 IOA18-19 Micro-controller address 18-19 62、85、94、116、 119、134、144、 148、161、163、 175、216、223 DVSS Digital grounding 63 APLLCAP Analogue phase lock loop external capacitor capacitor 64 APLLVSS Analogue phase lock loop grounding 65 APLLVDD3 Analogue phase lock 3.3V power supply 66 IOWR FLASH read control signal 67-72 HIGHA3-7 Micro-controller address bit 3-7 73、80、108、 127、141、155、 167、182、204、 212 DVDD3 Digital 3.3V power supply 74、75 HIGHA1-2 Micro-controller address bit 1-2 76 IOA20 Micro-controller address bit 20 77 IOCS FLASH chip selection 78 IOA1 Micro-controller address bit 1 79 IOOE FLASH output enabling 81-84 AD0-3 Micro-controller address/data bit 0-3 86-88 AD4-6 Micro-controller address/data bit 4-6 89 IOA21/ADIN0 Micro-controller address bit 21/AD universal input 90 ALE Micro-controller address enabling 91 AD7 Micro-controller address/data bit 7 92 A17 FLASH address bit 17 93 IOA0 Micro-controller address bit 0 95 UWR Micro-processor reading operation 96 URD Micro-processor reading operation 98 UP1_2-1_7 Micro-processor port 104 UP3_0 Micro-processor port 105 UP3_1 Micro-processor port 106 UP3_4 Micro-processor port 107 UP3_5 Micro-processor port 109 ICE Micro-processor correction mode enabling 110 PRST Reset input 111 IR Remote control signal input 112 INT0 Micro-processor interruption 0 113 DQM0 DRAM input output shielding signal 114 DQS0 DRAM input output shielding signal 115 RD7 DRAM data 117-118 RD5-6 DRAM data 120-121 RD3-4 DRAM data 123-125 RD0-2 DRAM data 126 RD15 DRAM data 128-133 RD9-14 DRAM data 135 RD8 DRAM data 136 DQS1 DRAM input output shielding signal 137 DQM1 DRAM input output shielding signal 138 RWE DRAM writing enabling 139 CAS DRAM column address selection 140 RAS DRAM row address selection 142 RCS DRAM chip selection 143 BA0 DRAM section address 0 145 BA1 DRAM section address 1 146 RA10 DRAM address 147 RA0 DRAM address 149 RA1-3 DRAM address 153 RVREF/ADIN3 Reference voltage/AD universal input 154 RCLKB DRAM clock 156 RCLK DRAM clock 157 CKE DRAM clock enabling 158 RA11 DRAM address 159-160 RA8-9 DRAM address 162 RA7 DRAM address 164 RA4-6 DRAM address 168 RD13/ASDATA5 DRAM data/audio series data 169 RD27-30 DRAM data 174 RD26 DRAM data 176-177 RD24-25 DRAM data 178-179 DQM2-3 DRAM I/O shielding signal 180-181 RD22-23 DRAM data 183-188 RD16-21 DRAM data 189 DACVDDC D/A conversion 3.3V power supply 190 VREF Reference voltage 191 FS 192 YUV0/CIN 193 DACVSSC D/A conversion grounding 194 YUV1/Y Video signal YUV1 output/Y signal output 195 DACVDDB D/A conversion 3.3V power supply 196 YUV2/C Video signal YUV2 output/C signal output 197 DACVSSB D/A conversion grounding 198 YUV3/CVBS Video signal YUV3 output/CVBS signal output 199 DACVDDA D/A conversion 3.3V power supply 200 YUV4/G Video signal YUV4 output/G signal output 201 DACVSSA D/A conversion grounding 202 TUV5/B Video signal YUV5 output/B signal output 203 YUV6/R Video signal YUV6 output/R signal output 205 VSYNC/ADIN1 Field synchronization signal output/AD universal input 206 YUV7/ASDATA5 Video signal YUV7 output/audio series data 207 HSYNC/ADIN2 Row synchronization output/AD universal input 208 SPMCLK 209 SPDATA 210 SPLRCK 211 SPBCK/ASDATA5 213 ALRCK Audio left and right sound channel clock 214 ABCK Audio bit clock 215 ACLK Audio DAC external clock 217-220 ASDATA0-3 Audio series data 222 ASDATA4 Audio series data 224 MC_DATA Microphone digital audio input 225 SPDIF Digital audio signal output 226 RFGND18 RF signal grounding 227 RFVDD18 RF signal 1.8V power supply 228 XTALO Clock output 229 XTALI Clock input 230 JITFO RF small signal output 231 JITFN RF small signal phase inversion and amplification input 232 PLLVSS Phase lock loop grounding 233 IDACEXLP 234 PLLVDD3 Phase lock loop 3.3V power supply 235 LPFON Amplifier loop wave filtration output 236 LPFIP Amplifier loop wave filtration input 237 LPFIN Amplifier loop wave filtration input 238 LPFOP Amplifier loop wave filtration output 239 ADCVDD3 A/D conversion 3.3V power supply 240 S_VCM 241 ADCVSS 242 S_VREFP 243 S_VREFN 244 RFVDD3 RF 3.3V power supply 245 RFRPDC DC RF error signal input 246 RFRPAC AC RF error signal input 247 HRFZC High- frequency RF signal zero crossover checking A/D conversion grounding crossover checking 248 CRTPLP 249 RFGND 250 CEQP 251 CEQN 252 OSP 253 OSN 254 RFGC 255 IREF Reference current 256 AVDD3 Analogue 3.3V power supply RF grounding Ⅱ.BA5954 BA5954 is a piece of servo drive single-piece integrated circuit, with built- in 4-channel BTL drive circuit. It can receive directly the PWM control signal output by digital servo IC, and with internal wave filter and drive amplifier, it pushes the execution part in the servo mechanism to accomplish the focusing, tracking, feed and main shaft drives. BA5954 adopts the packaging of 28 pins. Note: The 28 pins of BA5954 are for outputting effective control signal, which is provided by the 50 pins of MT1389. When the signal is in high power level, BA5954 output is in validity, while the signal is in low power level, BA5954 will not be activated, and its output ports are in the state of cutoff. The functions of pins of BA5954 are as the following table: Pin Name Function 1 VINFC Focusing control signal input 2 CF1 External feedback loop 3 CF2 External feedback loop 4 VINSL+ Forward control input, connected to the reference voltage 5 VINSL- Main shaft control signal input 6 VOSL External feedback resistance 7 VINFFC Focusing feedback signal input 8 VCC 5V power supply 9 PVCC1 5V power supply 10 PGND Grounding 11 VOSL- Main shaft drive inverse voltage output 12 VO2+ Main shaft forward voltage output 13 VOFC- Focusing drive inverse voltage output 14 VOSC+ Focusing drive forward voltage output 15 VOTK+ Tracking drive forward voltage output 16 VOTK- Tracking drive inverse voltage output 17 VOLD+ Feed drive forward voltage output 18 VOLD- Feed drive inverse voltage output 19 PGND Grounding 20 VINFTK Tracking feedback signal input 21 PVCC2 5V voltage 22 PREGND Grounding 23 VINLD Feed control signal input 24 CTK2 External feedback loop 25 CTK1 External feedback loop 26 VINTK Tracking control signal input 27 BIAS 1.4 reference voltage input 28 STBY Enabling control signal III. 29LV160BE 29LV160BE is a type of 16Mbit FLASH memory manufactured via 0.23um technology, with 16 byte width DQ0-DQ15, memory capacity of 16M bit, operation voltage of 3.3V, and packaging method of 48 pins TSOP. The specific operation mode is as the following table: DQ8~DQ15 Operation status CE OE WE RESET A0~A19 DQ0~QD7 BYTE:high BYTE: Low level level Read L L H H Ain Dout Dout High resistance Write L H L H Ain Din Din High resistance Waiting H × × H × high high resistance high resistance resistance Output forbidden L H H H × High High resistance High resistance resistance Reset × × × L × High High resistance High resistance resistance The functions of pins of 29LV160BE are as the following table: Pin Name Function 15 RY/BY Ready/system is busy 1~9、16~25 、48 A0~A19 20-byte address bus 26 CE Chip enabling 27、46 VSS Grounding 28 OE Output enabling 29~36、38~44 DQ0~DQ14 15-byte data bus 37 VCC 5V power supply 45 DQ15/A-1 Character extension mode as the data line; byte expansion mode as the address line 47 BYTE Adopting 8-byte (in low level) or 16-byte output mode (in high level) 11 WE Write enabling 12 RESET Reset, valid in low level NC 10、13、14 Neutral pin IV. AE45164016 AE45164016 is a type of 64Mb (4Banks×1M×16bit) CMOS synchronization DRAM, featured with large memory and high speed. Its operation power voltage is 3.0V~3.6V, and it is packaged in 54-pin TSOP. The functions of pins of AE45164016 are as the following table: Pin Name Function 1、14、27 VDD +3.3V power supply 2、4、5、7、8、10、11、 13、42、44、45、47、48、 50、51、53 DQ[0~15] 16-byte data bus 3、9、43、49 VDDQ +3.3V power supply 6、12、46、52 VSSQ Grounding 28、41、54 VSS Grounding 15 LDQM Data I/O shielding signal 16 WE Write control signal 17 CAS Column address gate signal 18 RAS Row address gate signal 19 CS Chip selection signal 20 SD-BS0 Section address 0 gate signal 21 SD-BS1 Section address 1 gate signal 22~26、29~35 MA[0~11] 12-byte address bus 36、40 NC Neutral pin 37 CKE Clock enabling signal 38 CLK System clock input 39 UDQM Data I/O shielding signal V. Pin Functions of TAS5508 TAS5508 is a high performance audio signal processing IC provided by TI. It has 8-channel PWM processing function, perfect protective functions, low distortion degree and excellent dynamic characteristics. 1 2 VRA_PLL PLL_FLT_RET Provide 1.8V reference voltage for PLL PLL external filtering circuit 3 4 PLL_FLTM PLL_FLTP PLL inverted input pin PLL non-inverted output pin 5 6 AVSS AVSS Analog grounding Analog grounding 7 8 VRD_PLL AVSS_PLL Provide 1.8V reference voltage for PLL PLL analog grounding 9 10 11 AVDD_PLL VBGAP RESET PLL provides 3.3V voltage Provide 1.2 V reference voltage System reset signal, valid in low level 12 13 HP_SEL PDN Microphone input/output selection Switch-off voltage, valid in low level 14 MUTE 15 DVDD Software muting control, valid in low level 3.3V digital power supply 16 17 DVSS VR_DPLL Digital grounding pin Provide 1.8V reference voltage for PLL 18 19 20 OSC_CAP XTL_OUT XTL_IN Oscillation capacitance Crystal oscillation output pin Crystal oscillation input pin 21 22 RESERVED TBASE_SEL Connect to digital grounding Connect to digital grounding 23 RESERVED Connect to digital grounding 24 25 SDA SCL Digital signal Clock signal 26 27 LRCLK SCLK RF channel clock signal Audio clock signal 28 29 SDIN4 SDIN3 Audio data input pin Audio data input pin 30 31 SDIN2 SDIN1 Audio data input pin Audio data input pin 32 33 34 PSVC VR_DIG DVSS Control PWM signal output 1.8V reference voltage of digital core Digital grounding 35 36 DVSS DVDD Digital grounding 3.3Vdigital service voltage 37 BKND_ERR 38 DVSS Logic error control pin, valid in low level Digital grounding 39 VALID Output PWM signal is displayed normally, valid in high level 40 41 PWM_M_1 PWM_P_1 PWM signal output 1 PWM signal output 1 42 43 PWM_M_2 PWM_P_2 PWM signal output 2 PWM signal output 2 44 45 PWM_M_3 PWM_P_3 PWM signal output 3 PWM signal output 3 46 47 PWM_M_4 PWM_P_4 PWM signal output 4 PWM signal output 4 48 49 VR_PWM PWM_M_7 1.8V reference voltage of PWM core PWM signal output 7 50 51 52 PWM_P_7 PWM_M_8 PWM_P_8 PWM signal output 7 PWM signal output 8 PWM signal output 8 53 54 DVSS_PWM DVDD_PWM Digital grounding for PWM signal 3.3V voltage for PWM signal 55 56 PWM_M_5 PWM_P_5 PWM signal output 5 PWM signal output 5 57 58 PWM_M_6 PWM_P_6 PWM signal output 6 PWM signal output 6 59 60 PWM_HPML PWM_HPPL Headphone output PWM left channel Headphone output PWM left channel 61 62 PWM_HPMR PWM_HPPR Headphone output PWM right channel Headphone output PWM right channel 63 64 MCLK RESERVED 3.3V clock input Connect to digital grounding IV. IC TAS5112 IC TAS5112 is an audio power amplifier of high performance made by TI. Bridging with 6O loading, each channel can output 50W. It has 95DB dynamic range, low distortion degree and low rate of heat generation with power efficiency up to 90%. It also has functions of low-voltage protection, high-temperature protection, overflow protection, etc. At the same time, it has built- in driving power adjustment gate circuit. Basic functions of its pins are as shown in the following table: Pin 31 Name BST_A Function Auxiliary power 42 43 BST_B BST_C Auxiliary power Auxiliary power 54 23 BST_D DGND Auxiliary power Digital input output reference 16 DREG Digital service voltage adjustment circuit 12 DREG_RTN Digital service voltage adjustment circuit Input output reference 25 DVDD 1,2,22,24,28, GND 29,27,36,37, 48,49,56 Grounding 3,26 GREG Driving voltage adjustment of gate circuit 30,55 15 GVDD M1(TST0) Digital voltage adjustment Mode selection 14 13 M2 M2 Mode selection Mode selection 4 OTW 34,35 38,39 OUT_A OUT_B Protective pin in the high temperature Output pin A Output pin B 46,47 50,51 OUT_C OUT_D Output pin C Output pin D 32,33 40,41 PVDD_A PVDD_B Service voltage of half bridge A Service voltage of half bridge B 44,45 52,53 PVDD_C PVDD_D Service voltage of half bridge C Service voltage of half bridge D 20 21 PWM_AM PWM_AP Inverted input pin Non-inverted input pin 18 17 PWM_BM PWM_BP Inverted input pin Non-inverted input pin 10 11 PWM_CM PWM_CP Inverted input pin Non-inverted input pin 8 7 PWM_DM PWM_DP Inverted input pin Non-inverted input pin 19 RESET_AB Reset signal , valid in low level 9 6 RESET_CD SD_AB Reset signal , valid in low level Signal switch off control 5 SD_CD Signal switch off control IIV. IC SE5532 IC SE5532 is an amplified IC with dual channels and low noise. Compared to most other amplified ICs, it has lower noise, better output performance and power bandwidth. Its main features are: small-signal bandwidth; its direct voltage gain can be up to 50000 and alternating voltage gain can be up to 2200 under 10KHz; its power bandwidth can be up to 140KHz; relatively larger power supply range; fast slewing rate. Basic functions of its pins are as shown in the following table: Pin Name Function description 1 2 OUTPUT-A INVERTING INPUT-A Output channel A Inverted input A 3 4 NON-INVERTING INPUT-A V- Non-inverted input A Negative power supply 5 6 NON-INVERTING INPUT-B INVERTING INPUT-B Non-inverted input B Inverted input B 7 8 OUTPUT-B V+ Output channel B Positive power supply IIIV、CS 5340 CS 5340 is an IC of analog/digital conversion; it can be applied to sample, analog-to-digital conversion and filter. During continuous input, its sampling frequency can be up to 200KHz. Its main features are as follows: 24 bytes conversion; supported audio frequency can be up to 192KHz; under power of 5V, its dynamic range can be up to 101DB; it has high pass filter to filter direct current. Functions of its pins are as follows: Pins Name 1 M0 Function description Mode selection 16 2 M1 MCLK Mode selection Master clock signal 3 4 5,14 VL SDOUT Logic voltage power supply Audio data output 6 7 GND VD SCLK Grounding Digital power DRAM clock signal 8 9 LRCK RST RF clock signal Reset signal 10 12 AINL AINR Analog input Analog input 11 13 VQ VA Quiescent voltage Analog power 15 FILT+ Reference voltage F B A RFO IOA D C V302 2SB1132-S LDO-AV33 C241 104 MO_VCC VCC 22 23 24 25 26 27 28 20K 151 TRSO V1P4 STBY R313 10K R319 150K PREGND VINLD CTK2 CTK1 VINTK BIAS STBY VINFFC VOSL VINSLVINSL+ CF2 CF1 VINFC C307 2200pF R317 680K R320 150K R340 C242 104 TC205 47uF/16V C243 104 TC204 47uF/16V 14 13 12 11 10 9 8 7 6 5 4 3 2 1 R307 1R C209 C308 DNS 0R MDI1 MDI2 V1P4 DV33 C306 151 FOSO 0R R318 R322 680K ADIN OPOP+ C310 2200pF XS303 1 2 3 4 5 6 XS302 1 2 3 4 5 SL+ SLLIMIT SP+ XS05 XS06 C309 104 TRIN C345 C346 104 104 104 104 R212 0R 89V33 FB L236 FB TC309 47uF/16V TC248 47uF/16V V309 8550 C244 104 C245 C246 104 104 AVDD3 R326 2.2R\1/4W C215 1500pF C247 104 C248 104 C249 104 C250 104 C251 104 V310 9014-S R327 470R (TROPEN1) TRCLOSE R339 C252 104 Y1 Y2 Y3 Y4 Y6 Y5 ACLK ABCK ALRCK 89V33 SPBCK SPLRCK SPDATA V18 AMUTE ASDAT2 ASDAT1 ASDAT0 ASPDIF R268 ADC_DAT AUDIO_RST 0.47uF 100K MT1389 L202 FB A 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 TC201 10uF/16V V18 R214 FS C216 510R DTS_DO DTS_CL DTS_DI DTS_CE R261 33R J4 TUNER_ON B J3 RDS_DATA VDATA3 POWER_ON_RST RDSSYNC MUTE RDSID RDSCE AUIN_SL0 AUIN_SL1 J1 J2 DMA4 DMA5 DMA6 C DMA7 DMA8 DMA9 DMA11 DCKE DCLK DMA3 DMA2 DMA1 DMA0 DMA10 BA1 D BA0 CS# RAS# CAS# WE# DQM1 LIMIT DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 E R2164 10K DV33 LOAD+ V308 8050 YUV0/CIN FS VREF DACVDDC RD16 RD17 RD18 RD19 RD20 RD21 DVDD3 RD22 RD23 DQM2 DQM3 RD24 RD25 DVSS RD26 DVDD18 RD27 RD28 RD29 RD30 RD31/ASDATA5 DVDD3 RA4 RA5 RA6 DVSS RA7 DVSS RA8 RA9 RA11 CKE RCLK DVDD3 RCLKB RVREF/V_ADIN3 DVDD18 RA3 RA2 RA1 DVSS RA0 RA10 BA1 DVSS BA0 RCS DVDD3 RAS CAS RWE DQM1 DQS1 RD8 DVSS RD9 RD10 RD11 DR12 RD13 U201 DV33A LOADR325 470R C214 104 TDI TMS TCK TDO AGND DVDA DVDB DVDC DVDD DVDRFIP DVDRFIN MA MB MC MD SA SB SC SD CDFON CDFOP TNI TPI MDI1 MDI2 LDO2 LDO1 SVDD3 CSO/RFOP RFLVL/RFON SGND V2REFO V20 VREFO FEO TEO TEZISLV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1/V_ADIN9 TRO FOO USB_VSS USBP USBM USB_VDD3 FG/V_ADIN8 TDI/V_ADIN4 TMS/V_ADIN5 TCK/V_ADIN6 TDO/V_ADIN7 DVDD18 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 HIGHA0 IOA18 IOA19 DVSS APLLCAP APLLVSS L235 R324 1.5K V307 8050 USBVDD ADIN TROUT TRIN STBY TRCLOSE V18 A2 A3 A4 A5 A6 A7 A8 A18 A19 C212 330pF L201 FB C343 C344 DV33 V306 8550 R329 10K LOADLOAD+ TROUT TRO FOO C213 330pF C211 89V33 104 R328 10K 18K 20K R210 R211 C210 153pF V1P4 R316 20K 0R FEO 0R TEO TEZISLV OPO 104 OPOP+ 10K DMO 15K FMO TROPEN DMSO R208 FMSO R209 TRSO FOSO V1P4 SP- R323 1.5K V2P8 V20 V1P4 R2165 OPO TC308 47uF/16V 1 0R 0R 0R 0R R228 C207 R206 R315 20K VCC F DNS 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 LDO2 LDO1 RFSVDD3 ADIN SPSP+ DMSO 1R (TRCLOSE1) TROPEN C205 R201 R202 R203 R204 R2166 C208 U302 BA5954 R321 1R E 1uF E F TC206 47uF/16V 750K L203 DACVDD3 FB DV33 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 C304 C303 104 VOFC+ VOFCVO2+ VOSLPGND PVCC1 VCC 10K C302 104 VOTK+ VOTKVOLD+ VOLDPGND VNFTK PVCC2 R306 1R R314 15 16 17 18 19 20 21 GND GND R305 1R C305 104 1uF C204 C206 120p V1P4 29 30 D C203 D RFOP RFON L302 FB GND TC304 FMSO 47uF/16V R312 A LDO1 10R C SL+ SLMO_VCC 1uF TC303 47uF/16V R302 C312 104 R304 1R 1uF C202 C B A D DQS0 100pF JITFN C217 104 89V33 C253 104 TC247 C2175 47uF/16V 104 DQ14 R331 0R C201 B RFO V301 2SB1132-S V20 C311 104 C230 104 C DQ2 DQ1 DQ0 DQ15 0R FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT TC302 47uF/16V LDO2 E RFV18 R227 HSYNC# ADC_DAT VSYNC# SPMCK DQ4 DQ3 R303 L312 L314 L316 L317 L318 L319 L320 L321 L322 L323 L324 L234 FB DV33 V18 JITFO C233 DQ6 DQ5 FBSMT FBSMT L309 FB LDO-AV33 (DNS) (DNS) (DNS) (DNS) 1K DQM0 DQS0 DQ7 L310 L311 R301 10R MDI1 C237 104 FB URST# IR FBSMT FBSMT 10uH FBSMT FBSMT TC301 220uF/16V AD7 A17 A0 L304 L305 L306 L307 L308 C301 104 R220 (DNS) 6 R219 R218 R217 R216 R215 AVDD3 C229 104 AD4 AD5 AD6 A21 FBSMT 10uH L250 R205 B L301 L303 C236 104 RFSVDD3 L208 FB 100K AVCC R207 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 V304 2SK3018-S C239 104 C240 1uF AD0 AD1 AD2 AD3 V303 2SK3018-S C238 104 C235 104 RFVDD3 33R TC211 220uF/16V 5 R269 0R V18 OPT1 VFDCK VFDAT VFDST SCL SDA DAVNIN LRSWMUTE RXD TXD FB R310 XS301 24P0.5mm L207 FB C231 104 JITFN C218 JITFO XI XO RFV18 RFV33 L238 TC202 10uF/16V C221 1uF ADCVDD3 C220 0.047uF C219 0.047uF PLLVDD3 DV33 10K RFVDD3 VREFN VREFP IOA TC203 104 104 47uF/16V VREFN ADCVDD3 URST# V1P4 C222 C223 20pF 1000pF A10 A9 A20 PCE# A1 PRD# A R223 15K VREFP 4.7R C277 C234 L205 FB PWR# A16 A15 A14 A13 A12 A11 V305 3904-S 4 PLLVDD3 C228 104 C227 104 C226 104 C225 0.033uF C224 104 10K R311 L206 256 255 254 253 252 251 250 249 248 247 246 245 244 243 242 241 240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 100K 3 AVCC AVDD3 IREF RFGC OSN OSP CEQN CEQP RFGND CRTPLP HRFZC RFRPAC RFRPDC RFVDD3 S_VREFN S_VREFP ADCVSS S_VCM ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 IDACEXLP PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 SPDIF MC_DATA DVSS ASDATA4 DVDD18 ASDATA3 ASDATA2 ASDATA1 ASDATA0 DVSS ACLK ABCK ALRCK DVDD3 SPBCK/ASDATA5 SPLRCK SPDATA SPMCLK HSYNC/V_ADIN2 YUV7/ASDATA5 VSYNC/V_ADIN1 DVDD3 YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/C DACVDDB YUV1/Y DACVSSC R309 R224 2 R308 APLLVDD3 IOWR A16 HIGHA7 HIGHA6 HIGHA5 HIGHA4 HIGHA3 DVDD3 HIGHA2 HIGHA1 IOA20 IOCS IOA1 IOOE DVDD3 AD0 AD1 AD2 AD3 DVSS AD4 AD5 AD6 IOA21/V_ADIN0 ALE AD7 A17 IOA0 DVSS UWR URD DVDD18 UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 UP1_7 UP3_0 UP3_1 UP3_4 UP3_5 DVDD3 ICE PRST IR INT0 DQM0 DQS0 RD7 DVSS RD6 RD5 DVSS RD4 RD3 DVDD18 RD2 RD1 RD0 RD15 DVDD3 RD14 1 R213 1K V18 C2167 104 (TRCLOSE1) TROPEN C254 104 C2174 104 C256 104 C257 104 C258 104 10K 2 3 PWR# PCE# PRD# R297 R298 R299 0R 0R 0R DWR# DCE# DRD# 更改 数量 更改单号 设 计 审 核 标准化 批 准 4 签 名 日期 ABS535T(1389+SANYO) 解码&伺服电原理图 板号:通用 5 BBK 比例 第 1 张 质量 共 3 张 数量 版次: 1.0 广东步步高电子工业有限公司AV厂 6 F A B C D E F 更 改 设 A+9V R109 计 1 数 量 审 VGND CVBS 1 2 3 4 5 6 7 8 9 10 V101 VDATA3 8050 XS101 R111 330 33R VGND AUXL AUXR AGND LINE L AGND LIN R SWO R112 4.7K R101 HSYNC# V102 8050 2.2K CON10 7 6 5 4 3 2 1 签 名 10U/16V VCC R113 日 批 SPDIF SPDIF 1 104 2 68 102 102 L109 AGND L AGNDL110 LINE_L L 102 GND AGND VCC XC101B FR 4 L 5 L116 LINE_R AGND FL L 6 R 3 AV4 C123 C124 AVG-2 O 期 准 V100 VSYNC# R AV4 SWO XC102A C113 3 L C120 C122 C121 TC100 L115 AUX_R CON6 R102 75R L 2 VGND VCC 1 L R110 VCC XC101A L114 AUX_L +12V 8050 C120 R121 220R 104 R122 100K 2 2 标 准 化 更改单号 核 FL B/U A+9V G/Y R/V 2.2K 1 1K R100 XS111 FR 102 XC102B AVG-2 O 102 AGND 3 3 C100 104 Y4 L100 Y4 R103 75 1.8uH C101 47P VGND VGND 0 C102 47P VGND R106 75 L106 R114 VD100 D2 L G/Y 3 C114 2 20P VGND VGND XC100A AV4 VGND Y1 Y5 Y5 R104 75 1.8uH C103 47P 第 0 C104 47P VGND L VD101 D2 共 R105 75 1.8uH C105 47P C115 L104 Y1 VGND L X101 VGND VCC VGND L112 R119 L 0 C111 47P SV_Y 1 2 3 4 5 6 7 C118 VD105 D2 20P VGND DASW-02 VGND VCC R Y2 R108 75 1.8uH C109 47P L113 R120 SV_C L 0 C112 47P VD106 D2 C119 20P L AV4 R/V L105 Y2 VGND VGND VGND C116 VGND VGND VCC VGND VGND 20P VD103 D2 VGND VCC VGND VGND R117 0 VGND 6 6 张 版次: VGND VGND 0 C106 47P 1.8uH C108 47P XC100B 6 VGND L108 R116 20P VD104 D2 5 L102 VGND VGND VGND 4 Y6 C117 B/U 5 Y6 CVBS L 0 C110 47P 20P VGND VCC BBK 张 5 广东步步高电子工业有限公司 VGND VGND L107 R115 L111 R118 L R107 75 L101 1.8uH C107 47P R SWO 1 VGND VCC L103 Y3 4 4 ABS535T 解 码 板 原 理 图 Y3 VGND A B C D E F A B C D E F 1 更 设 1 改 计 数 C517 103/1KV R521 C520 T502 BCK-40-0726 4 13 D511 BYW29E200 R527 1.5K C522 ! 102 U506 R526 R522 C519 101 H-GND 8 10 D509 H-GND 104 TC517 2200uF/50V TC516 2200uF/50V U507 HS817 TL431 R525 2.2K H-GND R520 H-GND TC515 HER105 47uF/50V C518 104 C524 472 47K 33R/1W TC514 1uF/50V R518 68K/2W P+28V R524 24K C521 473 C523 11 FB SYNC GND 3 HER207 BYW29E200 6 4 5 VCC 2 3 D-IN D508 D510 R523 1K/3W 2 更改单号 签 名 标 准 化 核 2 1 14 L506 2 U505 KAIM0880 TC518 470uF/50V 101 33R/1W 10uH/5A 量 审 ! R519 47K/2W 47R R507(DNS) 10R/1W A+12V TC505 470uF/16V ZD502(DNS) H-GND C506 472 批 R517 47K/2W D503 HER105 L503 10uH/2A TC504 1 NTC103 2 V+ KBL04 TC501 330uF/400V 期 准 BD501 AC 3 R504 75K/2W R502 68K/2W 101 470uF/25V C508 D501 HER107 4 L502 XC502 104X2 2 14 3 15 13 6 12 11 D502 7 10 FB RH357508 R505 L501 JBL2822 30mH L504 10uH/2A TC507 2200uF/16V C510 TC508 1000uF/16V C509 472 ! L505 10uH/1A 9 D+3V3 1N4148 TC509 2200uF/16V T501 SE2135 TC510 1000uF/16V C512 4.7R/1W FL+ TC511 220uF/16V GND 1 C503 223 C513 101 R511 10K TC513 220uF/35V ! U502 D+5V DGND D+3V3 AGND A+5V A+9V R513 3.3K FL+ FL-27V DGND D+5V ZD501 5.1V/0.5W D+5V D-gnd D+3V3 A-gnd A+5V A+9V 1 2 3 4 5 6 XS108 -27V R516 270R H-GND XS107 ~220V 1 2 3 4 5 6 FL+ FL-27V D-gnd D+5V C515 102 1 2 3 4 5 5 BBK 第 5 R512 张 47K HS817 共 ! YC501 ~400V /102 C516 104 R514 10K R515 5.6K U503 TL431 DCVPP 张 6 版次: 6 东莞市步步高视听电子工业有限公司 U501 5L0380R D507 HER105 4 D+5V D-gnd A+5V A-12V A-gnd A+12V XP109 FL- FB ! 2 1 101 D+5V DGND A+5V A-12V AGND A+12V C511 472 D506 HER105 H-GND A-12V C514 472 R510 330R/1W 2 3 H-GND D 680K/1W TC502 47uF/50V TC512 470uF/16V 101 D505 SR560 1 2 3 4 XP102 ZD503 C12V R509 VCC R501 C502 R506 104 1M XC501 104X2 RV501 07D471 F501 T3.15A/250V ! XP100 P+28V P+28V P+28V P+28V Pgnd PGND Pgnd PGND 820R D+5V D504 SR560 75R 4 ! C507 472 R508 101 4 H-GND 2 A+5V TC506 470uF/16V 333 3 ! 3 Vout GND 2 16 R503 75K/2W 1 C504 Vin 15 C505 ! H-GND ! C501 103/1KV TC503 1000uF/25V U504 LM7805 1 4 4 ABS535T电源板原理图 V- AC R528 3 日 3 DCVPP C9V1/1W ! RT501 A B C D E F 1 2 3 4 5 6 7 8 9 10 11 12 N5 AUX(2) TUNER(3) TU_L XS104 R 7 74 . 7 K OK AUIN_SL0 A+5V -9V 9 B PWM_H_PL VSS VEE 10 8 C75 104 C74 7 104 A PWM_H_ML PWM_H_ML PWM_RR+ P W M _ R R - PWM_RR+ A+5V PWM_RL+ PWM_RLPWM_SW+ CD4052 -9V +9V PWM_CEN- R 7 94 . 7 K AVDD 3.3V CON5 +9V +5V C58 1N4148 TU+5V V5S8050 TU+9V L 5 F B+ 9 V R42 4.7K C199 104 RDS_MPX C200 104 R84 R85 R86 10K 10K 10K C85 C88 220u/16V104 2 8 9 10 11 13 20 18 19 C 1 1 75 6 1 1 5 DAVNIN SDA SCL C62 R91 R 8 91 0 16 14 7 17 3 MPTH MPXIN DAVN VDDA SDA VDDD SCL Vref PSWN TCON AFIN LVIN SCOUT MAD CIN VSSD MRO V S S A OSC1 OSCO AVSS 47u/16V 10V 150/0.5W 3.3V TU+5V R139 4.7K R 1 3 71 0 12 6 15 4 C125 C126 4 . 7 u / 1 61V0 4 VD3 5.1V C 1 2 7C 1 2 8 10447u/16V C48 104 R585.1K R134 8.7K V6 9014 R64 200 RST RST 3.3V C50 103 R66 200 C52 104 C53 103 C113 4.7u/16V PH_SEL HDET R133 C202 R57 104 10K C124 15p R61 10K R54 R55 10K 10K R104 1M R9 A+5V 120/0.5W 3.3V RST FROM MAIN BOARD C R 5 64 7 R 5 94 7 74HCT125 MUTE STBY DTS DO R 6 94 7 SCL SDA MUTE 5.1V R224 57 SCLK N4C LRCK 74HCT125 LRCK SDA SCL LRCK SCLK SDA_CSW SDA_AD SDA_SLSR SDA_LR R94 R95 47 47 R96 R97 47 47 R98 R99 R100 47 47 47 R101 47 L 6F B R83 4.7K 3.3V 1 2 3 4 5 6 7 8 3.3V 3.3V SCLK LRCK 3.3V R8710K +28.5V R81 4.7K PWM_SL- R 2 0 90 R PWM_SL- PGND M0 MCLK VL SDA GND VD SCLK LRCK 16 15 14 13 12 11 10 9 M1 FILT+ RGND VA AINR VQ AINL RST C79 C83 4 7 u / 1 6 V1 0 4 SD C86 10u/16V VALID SD VALID R2510 C 9 14 . 7 u / 1 6 V PWM_SRPWM_SR+ RST C 9 24 . 7 u / 1 6 V C82 104 C87 C84 4 . 7 u / 1 64V. 7 u / 1 6 V C76 101 R82 2.2K C77 101 R 2 1 00 R PWM_SR- R 2 1 10 R PWM_SR+ R80 2.2K R 2 41 0 PWM_FL+ PWM_FL+ C 2 41 0 4 R 2 1 20 R TU+5V PWM_FL- XS106 10K 10K 10K 10K 0R R20 27K R4 681 101 R 1 31 2 K PGND R2 4.7K TLV272 1 R11 10K R7 22K N1B TLV272 6 3 MUTE1 LGND R12 220 K R 1 5 21 K C5 105 LGND V4 8050 R 1 0 72 7 K SD N8A TLV272 1 R 1 6 61 0 K R 1 6 52 2 K R111 4.7K C160 105 LGND R114 47K PWM_FR+ PWM_FR- LGND LGND 1 2 3 4 5 6 7 R 1 81 2 K R 1 5 72 7 K 1 R16 10K R 1 72 2 K N9B TLV272 6 3 C198 102 R141 7K V8 8050 R19 220 LGND K C156 101 C197 105 LGND R 2 0 70 R SWO RO AGND LO AGND R 1 2 25 1 SWO RO PGND LGND R92 5 4 0 1 MUTE1 R149 1K 5401 M5V R 1 6 31 0 K +28.5V R169 R153 LO LGND R176 20K MUTE C38 C36 102 1000u/35V PGND C 3 33 3 3 R 3 21 XC100D SROUT R40 3.3 220 R90 5.1K C90 R93 0.47u 1 PGND PGND C65 103 C10 WP12 C93 103 C 1 2 93 3 3R 1 3 11 PGND PGND C 1 2 01 0 4R 1 3 41 . 5 PGND L9 10uH +28.5V R144 C137 103 C 1 2 11 0 4R 1 3 61 . 5 C133 PGND C 1 3 03 3 3R 1 3 21 C135 102 1000u/35V R142 10K C140 0.1u C66 1 103 XC100A C143 R140 3.3 VCC28A C139 103 0.47u C142 C26 104 FL+ PGND R143 10K FL- 103 C141 0.1u R145 WP12 C71 1 103 L 1 01 0 u H R191 4.7K PGND PGND 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 GND GND GREG /OTW /SD_CD /SD_AB PWM_DP PWM_DM /RESET_CD PWM_CM PWM_CP DREG_RTN M3 M2 M1 DREG PWM_BP PWM_BM /RESET_AB PWM_AM PWM_AP GND DGND GND DVDD GREG GND GND GND GVDD BST_D PVDD_D PVDD_D OUT_D OUT_D GND GND OUT_C OUT_C PVDD_C PVDD_C BST_C BST_B PVDD_B PVDD_B OUT_B OUT_B GND GND OUT_A OUT_A PVDD_A PVDD_A BST_A GVDD GND R195 DNS XC100B L 1 11 0 u H C119 104 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 CEN+ VCC28B R192 5.1K C 1 8 33 3 3R 1 8 1 5 C184 R197 0.47u 1 C68 103 CEN- 104 PGND C 1 2 31 0 4R 1 8 61 . 5 C11 WP12 C188 103 PGND +28.5V C138 PGND B PGND 103 C121 2 0 4R 1 3 51 . 5 C136 C134 102 1000u/35V PGND C 1 3 13 3 3R 1 3 01 R141 3.3 C 3 43 3 3 R 3 01 PGND PGND C 3 01 0 4 R 3 51 . 5 PGND L3 10uH FR+ +28.5V C41 103 C 3 11 0 4 R 3 71 . 5 C39 C37 1 0 0 0 u / 3 5 V1 0 2 PGND C 3 53 3 3 R 3 31 R43 10K C42 0.1u R41 3.3 R51 1 C12 103 C46 103 XC100F VCC28B C179 104 C69 0.47u PGND PGND C47 103 PGND PGND C45 0.1u WP12 R53 1 C70 103 FR- R180 20K +28.5V C176 470u/35V R193 20K +28.5V C173 R178 470u/35V 1 SR- R181 20K C177 R182 470u/35V 1 C185 470u/35V R188 47/0.5W CEN- R194 20K C178 103 C186 R196 470u/35V 1 R190 10 C187 103 R189 10 PGND C162 47p PGND PGND PGND PGND PGND C 1 6 63 3 0 u / 1 0 V 2 3 6 5 R 1 6 41 0 K C158 471 SR- 104 R161 70K 47p 10K 1 IN1 IN+ 2 IN2 IN+ 1 OUT 2 OUT +V V- 1 7 8 4 A H-R +9V -9V N 1 1R C 4 5 8 0 HGND C189 C171 10u/16V221 H-L C 1 6 73 3 0 u / 1 0 V R170 R171 10K 10K HGND HGND C190 C73 10u/16V221 R 2 0 10 R 0R -9V HGND R 2 0 00 R R199 R161 80K C146 100U LGND C 2 91 0 4 R 3 61 . 5 PGND PGND PGND +28.5V C172 470u/35V C174 103 +9V R 1 5 98 . 2 K R39 DNS L1 10uH 47K C161 22K R148 PGND SL- HGND R150 10K 4.7K +28.5V C40 103 VCC28B R 1 6 08 . 2 K 471 V2 R38 PGND VCC28A RO C157 V3 PGND C 2 81 0 4 R 3 4 1 . 5 R49 10K LGND A R1510K +28.5V C 3 23 3 3 R 3 11 AUXR AUXL R177 20K 5401 C175 105 C114 104 LO C162 321 V1 C RO 5 MUTE1 R 1 5 82 7 K R 1 6 22 7 K WP12 C161 50u/16V R211 8K 7 681 +5V LGND 104 L2 10uH N9A TLV272 2 C155 SL- PGND LGND PWM_RR+ +5V C64 1 0 3 C9 R52 1 VCC28A CON7 C138 22p R 1 5 64 . 7 K C43 0.47u C44 103 PGND C27 104 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 R 1 6 12 7 K LGND C107 104 C 1 1 61 0 4 PWM_FR- XP101 LGND C 1 0 11 0 1 R 1 0 54 . 7 K PWM_FR+ R 2 0 60 R C104 C103 10u/16V 104 C154 681 LGND V7 R141 6K 8050 PWM_RR- LGND R 1 7 51 0 MUTE1 C100 101 +5V VALID LO LGND R15 220 K XS102 CON6 C106 104 SD C101 80u/16V R211 7K 7 5 C159 102 +5V 1N4004 1N4004 DGND +5V N8B TLV272 6 3 R 1 0 92 7 K C63 47u/16V C 1 1 51 0 5 R 1 1 61 0 R 1 0 62 7 K +5V +5V PGND R 1 41 2 K 681 PWM_RL+ LGND R 2 0 20 R PWM_CEN- LGND 2 C98 R 1 0 24 . 7 K LGND LGND PWM_CEN+ C 1 48 2 p LGND R110 4.7K GND GVDD BST_D PVDD_D PVDD_D OUT_D OUT_D GND GND OUT_C OUT_C PVDD_C PVDD_C BST_C BST_B PVDD_B PVDD_B OUT_B OUT_B GND GND OUT_A OUT_A PVDD_A PVDD_A BST_A GVDD GND PGND R 1 0 82 7 K C97 681 +5V PGND R 2 0 30 R LGND C 1 0 21 0 1 R 1 0 34 . 7 K DGND +5V -9V AGND +9V XC100C SLOUT TAS5112DFD PWM_CEN- LGND LGND PWM_RL- +9V GND GND GREG /OTW /SD_CD /SD_AB PWM_DP PWM_DM /RESET_CD PWM_CM PWM_CP DREG_RTN M3 M2 M1 DREG PWM_BP PWM_BM /RESET_AB PWM_AM PWM_AP GND DGND GND DVDD GREG GND GND R48 47K VALID +5V -9V AGND C25 105 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 N14 B D+3.3V R47 DNS SWO PWM_CEN+ D+3.3V C194C195 C196 101 101 101 C1310u/16V R501K 7 5 C4 473 +5V C3 101 VD10 C193 101 +28.5V N1A 2 C2 681 R21 27K VD9 C22 104 27K R10 27K L 1 31 0 0 u H PWM_FL- C7 8 2 2 PWM_SW+ 1 2 3 4 5 6 101 LGND LGND RDS_MPX AGND CON11 D+5V DGND A5V -9V AGND +9V C192 101 PGND 4.7K C1 L 1 41 0 0 u H R2751 R 2 1 30 R C6 R1 PWM_SW- TU+9V TU_R R223 C191 PGND PGND N13 TAS5112DFD R 2 0 80 R PWM_SL+ C 2 31 0 5 C78 104 C80 104 CON28 R119 R120 R121 CON4 PGND R44 4.7K R 8 85 . 1 R221 20K R117 PGND VD8 5.6V L4 10uH PWM_SL+ R6 10K 1 2 3 4 PGND +9V FB R2210K 220 220 220 XS100 +28.5V 1K/3W 3.3V L12 N4B SCLK 74HCT125 N4D SDA_AD SDA_AD 74HCT125 HDET 220 +28.5V M5V 3.3V R45 5.1K N7CS5340 R126 DTS_CE1 DTS_DI1 R125 DTS_CL1 R124 R123 DTS_DO1 R224 0 R DGND TU_L R230 4.7K VD7 1N4148 C5747u/16V C 1 94 7 u / 1 6 V DTS CE TUNER_ON DAVNIN 11 10 9 8 7 6 5 4 3 2 1 SD VD11 N 4 1 4 8 C201 104 SDA_CSW L 7F B M0 R5 4 7 C110 R113 10u/16V 1 C61104 VD2 DTS CL DTS DI M1 PH_SEL SD D3.3V C109 104 C105 104 N4A 74HCT125 R 6 34 7 AUIN_SL1 SCL SDA PWM_SR+ PWM_SRPWM_SL+ PWM_SLPWM_FR+ PWM_FRPWM_FL+ PWM_FLVALID N 3 DS D A _ C S W R 6 24 7 AUIN_SL0 C 5 9 1 0 4 C 2 0 1 0 2 C 6 0 1 0 4 C 2 11 0 2C 2 0 41 0 4 N 3 CS D A _ S L S R SDA_SLSR 74HCT125 RST PWM_FL+ PWM_FLVALID 11 硬件复位信号 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 PWM_SLPWM_FR+ PWM_FR- R3 1K 74HCT125 XS103 PWM_SRPWM_SL+ C 9 91 0 4 Y1 13.5M N3A SDA_LR PWM_SR+ C 9 61 5 p 15p N 3 BS D A _ L R 74HCT125 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 DGND SDA SCL LRCK SCLK SDA_CSW SDA_AD SDA_SLSR SDA_LR C18 R 2 94 7 C72 104 VR_PWM PWM_P_4 PWM_M_4 PWM_P_3 PWM_M_3 PWM_P_2 PWM_M_2 PWM_P_1 PWM_M_1 VALID DVSS /BKND_ERR DVDD DVSS DVSS VR_DIG N12 TAS5508PAG 10u/16V R198 4 +9V Y 31 2 . 2 8 8 M H z 224 C 9 51 5 p MCLK 15p C51 104 3.3V DGND R8 1 M C17 VRA_PLL PLL_FLT_RET PLL_FLTM PLL_FLTP AVSS AVSS_GR VRD_PLL AVSS_PLL AVDD_PLL VBGAP /RESET /HP_SEL /PDA /MUTE DVDD DVSS D R112 52 C112 C111 L 8 FB N 2 AS N 7 4 L V C 2 G 0 4 D BNV2RBS N 7 4 L V C 2 G 0 4 D B V R 3 R651 C54 10u/16V C203 104 D+3.3V 6 DVDD 3.3V 1K Y24.332MHz R60 10K 3.3V MUTE MUTE C118 15p C67 104 C55 104 O 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 C49 104 R 7 04 7 MCLK MCLK 3.3V AVSS C56 104 R673.3 100u/16V DNS VD4 10u/16V C94 R46 C89 102 C81 331 N6 SAA6588 -9V 1 PWM_3.3V R682.2 VD5 HGND PWM_RRPWM_RL+ PWM_RLPWM_SW+ P W M _ S W - PWM_SWPWM_CEN+ P W M _ C E N - PWM_CEN+ R 7 84 . 7 K 12 H-L AUIN_SL1 16 3 H-R D R 7 64 . 7 K A+5V C8 10u/16V 5 OK_A 4 -9V 3 AGND 2 +9V 1 P W M _ H _ P RPWM_H_PR PWM_H_MR P W M _ H _ P LPWM_H_MR 3 VDD 4 CON4 AUXL MIC(1) Y 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 0 1 13 X Y0 Y1 Y2 Y3 INH 1 1 1 X0 X1 X2 X3 1 5 2 4 6 2 OUTPUT 7 AUIN_SL0 0 1 8 AUIN_SL1 0 0 5 H-L H-R H-DET 4 3 2 1 6 HGND 12 14 15 11 RESERVED MCLK PWM_HPPR PWM_HPMR PWM_HPPL PWM_HPML PWM_P_6 PWM_M_6 PWM_P_5 PWM_M_5 DVDD_PWM DVSS_PWM PWM_P_8 PWM_M_8 PWM_P_7 PWM_M_7 AUXR TU_R VR_DPLL OSD_CAP XTL_OUT XTL_IN RESERVED RESEVRED RESERVED SDA SCL LRCK SCLK SDIN4 SDIN3 SDIN2 SDIN1 PSVC OK XS105 C162 421 LGND GND PGND GND LGND GND GND HGND LGND BBK HGND 更改 设 计 数量 更改单号 签 名 日 期 审 核 标 准 化 批 准 ABS535T功放板电原理图 第 1张 共 1张 版次: 东莞市步步高视听电子有限公司 11-Mar-2006 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 U211 C281 104 A TC210 47uF/16V C2162 104 C2163 104 C2168 104 C2170 104 C2171 104 C2173 104 R231 33R DV33 XS110 XS202 1 2 3 4 DV33 RXD TXD GND C267 104 XS04(DNS) J4 J3 J2 J1 GND VFDDA VFDCK VFDST GND IR B U202 AT24C16X4050 J4 J3 J2 J1 10 9 8 7 6 5 4 3 2 1 L230 L232 L231 FBSMT FBSMT FBSMT L233 FBSMT 1 2 3 4 VFDAT VFDST VFDCK R259 680R 8 7 6 5 DC/NC VCC RST_/NC RST/WP WP/RST_ SCL VSS SDA R260 680R C259 104 DCLK R263 DCKE R264 SCL SDA C260 102(DNS) IR CS# RAS# CAS# WE# C261 102(DNS) 33R 33R R265 R266 R267 R2162 33R 33R 33R 33R R230 4.7K CON10 C263 C264 C265 C266 47pF 47pF 47pF 47pF DCS# DRAS# DCAS# DWE# 19 18 17 16 DQM0 DQM1 15 39 1 2 3 4 5 6 L222 FB L223 FB L209 FB 0R 0R 4.7K 4.7K A16 A15 A14 A13 A12 A11 A10 A9 AA20 AA21 DWR# URST# VP AVCC C270 104 CON6 +9V C271 VD119 D A19 A18 A8 A7 A6 A5 A4 A3 A2 R241 4.7K(DNS) 104 TC208 TC207 220uF/16V 220uF/16V 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 A15 A14 A13 A12 A11 A10 A9 A8 A19 NC WE RESET NC NC RY/BY A18 A17 A7 A6 A5 A4 A3 A2 A1 8M_FLASH(TSOP) 48 A16 47 BYTE 46 Vss 45 DQ15/A-1 44 DQ7 43 DQ14 42 DQ6 41 DQ13 40 DQ5 39 DQ12 38 DQ4 37 Vcc 36 DQ11 35 DQ3 34 DQ10 33 DQ2 32 DQ9 31 DQ1 30 DQ8 29 DQ0 28 OE 27 Vss 26 CE 25 A0 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 DQML DQMH NC NC 1 14 27 VCC VCC VCC SD33 3 9 43 49 VCCQ VCCQ VCCQ VCCQ VSS VSS VSS C2160 104 6 12 46 52 VSSQ VSSQ VSSQ VSSQ ADC_DAT Y1 Y2 A17 Y3 GND A0 AD7 Y4 Y5 Y6 HSYNC# VSYNC# VDATA3 AD6 AD5 IEC958 AD4 VD XS207 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 XS28 A B Y1 Y2 SDRAM 64M Y3 Y4 Y5 Y6 HSYNC# VSYNC# VDATD3 VGND SPDIF SPDIF R233 C 75R R250 0R(DNS) VGND AD3 DV33 C274 AD2 AD1 U205E AD0 DRD# GND DCE# A1 R251 IEC958 10 11 0R HCU04 12 104 13 U205F HCU04 R2159 ASPDIF 0R VD202 VD203 1N4004(DNS) 1N4004(DNS) DV33 1N4148 VD200 BT 1N6263 AUDIO_RST SDATA0 SDATA1 SDATA2 GND SACLK GND SBCLK SLRCK AUIN_SL0 AUIN_SL1 VCC SCL R234 SDA 4.7K MUTE LRSWMUTE DTS_DO R235 DTS_CL 4.7K DTS_DI VCC DTS_CE TUNER_ON R249 DAVNIN GND 4.7K RDSSYNC RDSID RDSCE POWER_ON_RST OPT1 0 R225 0 R226(dns) 14 XS203 R258 R257 TC213 220uF/16V R238 R239 C C272 104 R2140 4.7K 4.7K DV33A L227 FB R240 DV33 U214 2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 SD33 /CS /RAS /CAS /WE 54 41 28 A21 A20 IN GND OUT 1 2 3 VCC CLK CKE 36 40 VCC VD DV33 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 BA0/A13 BA1/A12 SDCLK 38 SDCKE 37 U208 BA033FP(DNS) VCC 23 24 25 26 29 30 31 32 33 34 22 35 20 21 7 SD33 FB DMA11 L226 BA1 DV33 DMA0 DMA1 DMA2 DMA3 DMA4 DMA5 DMA6 DMA7 R232 DMA8 33R DMA9 DMA10 MA11 BA0 #BA1 VCC D N106 1 2 3 4 BT1 G101 32.768K VCC SQW SCL SDA 8 7 6 5 R193 4.7K SCL SDA U209 LM1117MP-1.8 DV33 VD C186 C187 20P 20P R252 10K VD201 1N4148 Q204 9016 0R L204 C279 104 R253 R246 100K R255 5 GND OUT IN M41T81 DV33 VCC 1 2 3 C191 DNS BATTERY X1 X2 INT GND L228 V18 TC237 FB(DNS) 47uF/16V 6 C273 104 0R(DNS) E XI ACLK ABCK ALRCK ASDAT0 ASDAT1 ASDAT2 R291 R292 R293 R294 R295 R296 33R 33R 33R 33R 33R 33R R244 R248 0R 0R L249 2.7uH(DNS) SACLK SBCLK SLRCK SDATA0 SDATA1 SDATA2 C275 X201 27pF 27MHz TC217 100uF/16V R254 1K C278 102 U205C HCU04 R256 33R R242 3.3K E TC209 220uF/16V C276 27pF R243 1.2K URST# C2158 27pF(DNS) F 1 XO FB 2 3 更改 数量 更改单号 设 计 审 核 标准化 批 准 4 签 名 ABS535T 日期 解码&伺服电原理图 板号:2535-0 5 BBK 比例 第 2 张 质量 共 3 张 数量 版次: 1.0 广东步步高电子工业有限公司AV厂 6 F A B C D E F 更 设 改 计 1 1 -27V CPU+5V C1 104 GRID10 GRID9 GRID8 GRID7 GRID6 C2 104 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 VDD SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 VDD VEE SEG19 SEG20 G8 G7 G6 33K 33K 33K 33K R1 R2 R3 R4 R5 33K LED4 LED3 LED2 LED1 GRID5 GRID4 GRID3 GRID2 GRID1 FB1 FB FB2 FB FIL- R6 33K R7 33K R8 33K R26 XS1 10P2.0 100 IR 220 220 220 R32 R33 R34 1 2 3 4 5 6 7 8 9 10 VSTB VSCK VSDA J11 J12 J21 J22 R13 R14 R15 CPU+5V R11 51K CPU+5V KEY4 KEY3 KEY2 KEY1 FIL+ 10K 10K 10K C5 C6 open open C7 open 3 C4 100uF/16V FILR10 D4 1N4148 LED11 LED blue K5 K7 K11 K2 K6 K8 K12 R17 10K VR1 RVP D5 1N4148 B KEY1 R18 10K R20 10K R21 10K C 1 2 VOL1- VOL2- VOL1+ VOL2+ 1 2 3 3 C8 104 C9 104 C10 104 K9 K4 K10 A B C C11 104 KEY2 K3 VR2 RVP A DVCC K1 CPU+5V LED12 LED blue 1 red 1 LED10 LED red 2 2 2 2 D3 1N4148 LED9 LED CPU+5V 4 4 ABS530T 面控板原理图 D2 1N4148 R9 330R R36 330R 330 R37 330 1 C15 104 VFD1 HNVC10SM25 1 期 准 3 C3 104 2 1 SEG1 13 12 11 10 9 8 7 6 5 4 3 2 1 KEY4 KEY3 KEY2 KEY1 STB CLK IC DI DO SW4 SW3 SW2 SW1 40 41 42 43 44 45 46 47 48 49 50 51 52 C16 47uF/50V SEG4 日 批 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 27 28 29 30 31 32 33 34 35 36 37 38 39 1 2 3 4 5 -27V G5 G4 G3 G2 G1 VDD LED5 LED4 LED3 LED2 LED1 VSS OSV SEG13 SEG14 SEG15 SEG16 XS2 5P2.0 CPU+5V U1 16311 26 25 24 23 22 21 20 19 18 17 16 15 14 GRID1 GRID2 GRID3 GRID4 GRID5 GRID6 GRID7 GRID8 GRID9 GRID10 CPU+5V SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 C14 104 2 更 改 单 号 签 名 核 标 准 化 2 FF- 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 FIL+ SEG3 数 量 审 1G 2G 3G 4G 5G 6G 7G 8G 9G 10G NC NC NC NC NC P16 P15 P14 P13 P12 P11 P10 P9 P8 P7 P6 P5 P4 P3 P2 P1 39 38 SEG2 F+ F+ K13 KEY3 KEY4 CPU+5V CPU+5V CPU+5V U2 IR IR 第 XS3 1 PHONE_L 2 PHONE_R 4 PHONE_SW 5 R22 LED3 R24 V1 8550 3.3K LED4 R35 10K IR V2 8550 3.3K + C12 47u 1 VDD GND C13 104 AGND 共 R16 330 7.5MM C17 104 AGND 2 10R R23 4P2.0 PHONE 3 5 1 2 3 4 3 张 R19 330 7.5MM R25 330 7.5MM R27 330 7.5MM R29 330 7.5MM R30 330 7.5MM R31 330 7.5MM R28 330 7.5MM CPU+5V 1 1 LED8 LED 2 2 2 LED7 LED 2 1 1 LED6 LED LED5 LED 2 LED4 LED 6 6 版次: 2 LED3 LED 2 张 LED2 LED LED1 LED 1 1 1 1 AGND 2 5 东莞市步步高视听电子有限公司 BBK JK1 A B C D E F 2535-1 2005 08 08 BT1 1 C186 N106 G101 XS203 R193 24 XS303 LIMIT C208 TC308 C346 C309 L302 R339 R327 R325 C187 1 XS301 V310 V309 L204 X201 R298 R299 TC237 R226 R225 R261 C281 U211 C266 R257 TC247 R326 GN TX RX DV D D D 33 1 C267 R241 R240 R239 R238 R255 R258 V306 R323 R297 R328 C344 C343 R329 TC309 C279 R312 C304 C305 R313 C274 SP- R306 R307 R315 R314 R316 C306 R208 R209 R210 R206R211 R207C209 TC210 R234 R292 R235 R249 28 GND SP+ L323 TC204 C206R331 C212 R232 R264 R263 R214 R295 R296 R291 R293 XS207 SL- TC301 L226 C216 TC201 R259 C260 R294 R260 C261 A1 A6 R117 C112 R120 SL+ R309R308 C303 C302 TC304 TC303 C204 C201 X101 C310 L317C205 R322C308 C211 R201 R202 R203 R204 TC206 R319 R320 R340 R321 OP1 C202 C203 TC302 V305 C224 C226 C227 L228 TC213 TC248 C259 L322 VD203 C240 U202 V303 TC209 R246 R250R253 R269 R268 R111R252 R216 R217 R2159 U201 R248 R244 L305 L307 L310 L312 L314 L316 L319 L320 C223 C238 R227 C233 R102 L114 L115 L110 L116 L109 L102 L101L100 L103 L104 L105 C105C103C101C107C108C109 R105R104R103R106R107R108 C100 R101 R112 L301 TC202 L250 TC207 R251 U205 L223 L208 L207 R233 L209 TC208 VD201TC217 TC205 VD119 L203 R254 L222 G C234 TC203 C278 C280 R256 XC100 V100 +9V TC211 V101 GND AVCC U209 G L206 L205 L236 VD106VD105VD104 V102 DV33 VD200 R121 VD202 R109 R110 GND R122 U208 L111 L108 L107 L106 R114 C104 R115 C106 R116 VCC TC100 I C191 R113 C125 L112 L113 C102 28 VD100 VD101VD103 C111 R119 C110 R118 54 XC101 27 XS101 1 R100 I O XS111 O C113 Surface layer of MPEG&SERVO Board XS202 R230 C265 L233 L232 C264 L231 C263 L230 GND J1 Q204 U214 XS110 J3 J4 J2 R2140 V308 V307 R324 U302 XS302 Bottom layer of MPEG&SERVO Board C121 C115 C307 R228 R317 C2175 L201 L202 C251 C254 C237 C231 R242 C118 C119 C117 C270 V301 L303 V304 C273 V302 R243 L309 C271 R301 L318 L324 C345 C242 L306 L308 L321 R302 R311 R310 C239 C225 R223 C228 C241 C210 C243 C2158 L227 C272 C213 R205 C276 C275 L238 C215 C219 C220 C221 C222 R224 C229 L249 C114 R2165 C312 C301 L304 L311 C311 R303 C116 R2166 R220 C277 C235C236 L234 C252 R318 C207 C217 C218 R219 C249 C230 R304 R305 C123 C246 C2174 C247 C258 C248 C250 C244 L235 C245 R215 R218 C2167 C256 C214 R212 C124 C2160 C2170 C2168 R213 C253 C122 C120 R231 R265 R266 R267 R2162 C2162 C2171 C2173 C2163 R2164 C257 Surface layer of audio power amplifying Board XC100 SRC178 R- SW- R182 SR+ SW+ R+ R181 C46 C188 C187 C186 C172 C173 C124 R133 C118 C126 R137 R86 R85 C157 C161 R160 C73 C116 R122 VD6 V5 R170 V2 C15 C77 R80 N5 C8 C175 C86 Y3 N7 C79 R76 R77 R79 VD2 XS103 SOL AUIN_SL1 AUIN_SL0 DAVNIN 2005 08 08 TUNER_ON DTS CE DIS DI DTS CL DIS DO SCLK MUTE SCA SCL R69 R139 R57 R55 R54 R6 R222 R61 R221 C21 R81 R82 R78 R83 R9 C76 C74 C61 RST C18 C91 C87 C92 C57 N4 4535-1 C203 C144 L12 C82 C83 M0 PH_SEL M1 GND C96 R104 C95 R98 C192 R97 C191 R96 R95 R94 N3 R88 C80 L7 L6 N2 R63 C99 C54 R8 C17 R56 R59 R62 C67 C113 R65 C56 R68 C58 C60 R201 C20 R29 C109 C1 N1 11 2 R67 Y1 C195 C194 R99 C193 C51 C202 V3 C55 C52 R60 C197 C106 N9 R16 C198 R17 C132 R18 C101R161 C156 R158 R157 C50 C201 R113 R101 C196 R100 C105 C155 C49 R58 R162 N1 C13 C84 R175 R206 R207 R116 C114 C115 R202 R203 VD1 R230 R5 VD7 R24 C22 R212 R213 R27 C24 C25 R70 C104 R66 C53 R64 C154 R153 R150 R149 R151 V7 R147R146 C165 R218 R169 R19 R22 R25 R210 R211 C110 C63 R111 R110 C103 R200 N14 R2 R21 C2 R10 C1 C3 R20 R4 R1 C6 R12 C112 R115 C98 C97 R102 R103 R105 R156 C107 R166 C5 C199 C200 C179 C59 R15 C4 R11 R7 R13 C7 R48 R50 C78 R87 C145 R225 C48 1 N8 R217 R114 XS104 C75 C119 C34 C131 R30 C35 C183 C130 V4 R35 C33 R33 2 C7 C100 R106 R107 C102 R108 C19 R109 V8 R185 R130 C166 C28 C120 R134 C137 C23 R208 R209 C204 R3 VD10 RO SWO C160 C159 R165 C14 R14 C123 R132 C26 L8 LGND C108 C32 VD8 XS102 XP101 LO R131 R34 N13 L13 LGND R32 R141 C138 R186 C27 VD9 AUXR C30 C129 C29 R31 R140 R190 +5V L14 -9V AUXL R135 C122 C190 R152 R92 C146 R148 28 R189 L10 XS105 C167 R171 C163 R163 L3 C89 R159 N11 C158 V1 C39 C41 C38 R136 C121 V6 C31 R188 L2 L11 R36 C85 C62 C88 C189 L9 AGND R91 R138 R199 C171 R167 L4 D+3.3V C128 1 R37 C135 R41 L1 GND N6 VD4 C134 R40 +9V VD3 R84 VD5 C94 C164 R164 C40 C136 C37 C36 C133 +28V C45 C139 L5 GND C140 C141 C90 C42 C184 C69 XS106 11 C43 C117 C81 C127 R89 C185 R142 R143 XS100 R223 R224 R121 R123 R120 R124 R119 R125 R117 R126 C125 C162 R168 R198 C176 Y2 R42 C177 R196 R194 R193 R51 R43 R46 C44 C93 R93 R90 R39 R38 R49 R53 C47 R197 R192 R195 R191 1 R44 R52 R47 R45 C143R144 C142 R145 R176 R180 LL+ C+ C174 R178 C- SL- SL+ R177 Bottom layer of audio power amplifying Board C10 C70 C12 C71 C65 C11 C66 C68 C9 C64 T502 TC517 1 16 L506 R521 C520 R519 R517 R518 TC501 D508 C517 Power Board W2 C521 R528 TC505 D504 XC502 XP100 U504 O TC509 C507 C510 TC507 1 C501 D501 G C508 C506 L503 L501 R504 W13 1 W18 W12 W20 D506 W5 R513 R514 2005 08 08 U503 1 C515 FL FL -27 DGN D5 + - V D V C514 W14 W15 ZD503 C509 C516 XP109 TC508 R512 R511 @5535-1 UL TC513 R510 D507 TC510 R516 W16 R509 ZD501 C503 D502 R505 L502 R506 U501 ~220V L505 U502 C513 TC502 C502 L504 R508 1 XS107 C511 W17 R501 R503 F501 RV501 T3.15A/250V XC501 XP102 W9 TC506 C512 R502 D505 D A A D5 GND A+5 A-9 GN +9V V V V D D503 A D D5 GN D3.3 GND A5V A9 V V D V R507 ZD502 YC501 1 R527 C504 T501 +28V PGND C505 W19 W7 W3 W4 D509 - R524 I ~ R520 ~ U506 R525 C522 C523 TC504 R526 R522 TC503 C524 RT501 + BD501 9 U507 8 C519 W1 R523 TC515 C518 TC514 TC516 D511 U505 W6 D510 TC518 R515 TC512 TC511 XS108 C104 C100C103 R103 R108 R101 R102 VD100 XP104 R106 C101 R105 C105 N100 R107 R100 V100 2004 09 11 9530-2 C102 VD101 R104 R109 VD102 MIC100 BOM list MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION DECODE BOARD 0000375 CARBON FILM RESISTOR 1/4W2.2O±5% R326 0260196 CD CD11C 16V10U±20%4×7 1.5 TC202,TC100 0260613 CD CD11C 16V220U±20% 8×7 3.5 TC207~TC209,TC211,TC213,TC301 0260200 CD CD11C 16V47U±20%5×7 2 TC201,TC302,TC303,TC205,TC206,TC203 ~TC204,TC210,TC247,TC248,TC237,TC30 4,TC308,TC309 0260201 CD CD11C 16V100U±20%6×7 2.5 TC217 0390057 MAGNETIC BEADS INDUCTOR RH354708 L209,L222,L223,L302,L250,L106~L116 0960020 CRYSTAL OSCILLATOR 27.00MHz 49-S X201 1940140 CABLE SOCKET 14P 1.0mm STRAIGHT DUAL LINE PLUG XS207 0680062 SCHOTTKY DIODE 1N6263 VD200 1480017 FASTENER BATTERY CR2032A 3630281 BATTEMETAL OXIDE FILM RESISTOR HOLDER 1403G7-GBK4B BT1 0960017 CRYSTAL OSCILLATOR 32.768KHz 3×9 G101 1940046 SOCKET 10P 2.0mm XS111,XS110 1940160 5P 2.0mm STRAIGHT FLEX XS302 1940005 SOCKET 6P 2.0mm XS303 1940007 SOCKET 7P 2.5mm XS101 1910225 TERMINAL SOCKET AV4-8.4-13/PB-1 XC101 1910176 TERMINAL SOCKET AV4-8.4-13/PB-23 XC100 1910159 TERMINAL SOCKET CS TERMINAL DASW-02 X101 TX179AT-2 OP1 1910195 TERMINAL SOCKET AVG-2-07 BLACK OP1 2121903 FLAT CABLE 6P 360 2.0/2.5 2 PIN,WITH NEEDLE,THE SAME DIRECTION XS203 5446913 PCB SEMI-FINISHED PRODUCT 2535-0-SMD ABS535T 1090077 SOCKET ELECTRO-OPTIC TRANSFORMER DECODE BOARD-SMD 0090001 SMD RESISTOR 1/16W 0O ±5% 0603 R201~R204,R244,R248,R251,R255,R297, R298,R299,R331,R212,R228,R303,R318, R2165,R2166,R226,R257,R258,R2159,R1 14~R116,R118~R120 0090006 SMD RESISTOR 1/16W 75O ±5% 0603 R233,R102~R108 0090272 SMD RESISTOR 1/16W1O±5% 0603 R304~R307,R321,R340 0090003 SMD RESISTOR 1/16W 10O ±5% 0603 R301,R302 MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0090005 SMD RESISTOR 1/16W 33O ±5% 0603 R232,R256,R261,R263,R264,R268,R292~ R296,R231,R265~R267,R2162,R111,R22 0 0090238 SMD RESISTOR 1/16W 68O ±5% 0603 R113 0090181 SMD RESISTOR 1/16W 100O ±5% 0603 R291 0090008 SMD RESISTOR 1/16W 220O ±5% R121 0090009 SMD RESISTOR 1/16W 330O ±5% 0603 R110 0090011 SMD RESISTOR 1/16W 470O ±5% 0603 R325,R327 0090014 SMD RESISTOR 1/16W 1K ±5% 0603 R213,R215,R254,R109 0090016 SMD RESISTOR 1/16W 1.5K ±5% 0603 R323,R324,R243 0090123 SMD RESISTOR 1/10W 33O ±5% 0805 L202 0090249 SMD RESISTOR 1/16W 510O ±5% 0603 R214 0090017 SMD RESISTOR 1/16W 2.2K ±5% 0603 R100,R101 0090018 SMD RESISTOR 1/16W 3.3K ±5% 0603 R242 0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 R238~R240,R234,R249,R230,R2140,R11 2,R193 0090023 SMD RESISTOR 1/16W 10K ±5% 0603 R208,R252,R309,R311,R313,R314,R339, R2164 ,R328,R329,R259,R260 0090024 SMD RESISTOR 1/16W 15K ±5% 0603 R209,R223 0090025 SMD RESISTOR 1/16W 20K ±5% 0603 R211,R312,R315,R316 0090188 SMD RESISTOR 1/16W 18K ±5% 0603 R210 0090197 SMD RESISTOR 1/16W 150K ±5% 0603 R319,R320 0090231 PRECISION SMD RESISTOR 1/16W 680K ±1% 0603 R317,R322 0090319 PRECISION SMD RESISTOR 1/16W 750K ±1% 0603 R227 0090034 SMD RESISTOR 1/16W 100K ±5% 0603 R224,R308,R310,R246,R122 0090111 SMD RESISTOR 1/10W 4.7O ±5% 0805 L206 0310085 SMD CAPACITOR 50V 20P ±5% NPO 0603 C222,C114~C119,C186,C187 0310190 SMD CAPACITOR 50V 27P ±5% NPO 0603 C275,C276 0310045 SMD CAPACITOR 50V 47P ±5% NPO 0603 C263~C266,C101~C112 0310051 SMD CAPACITOR 50V 331 ±5% NPO 0603 C212,C213 0310048 SMD CAPACITOR 50V 151 ±5% NPO 0603 C304,C306 50V 104 +80%-20% 0603 C207,C211,C214,C216,C217,C224,C226~ C231,C234~C239,C241~C254,C256~C25 9,C267,C270~C274,C279,C281,C301~C3 03,C305,C309,C311,C312,C2160,C2162, C2163,C2167,C2168,C2170,C2171,C2173 ~C2175,C277,C343~C345,C280,C100,C1 13,C125 0310084 SMD CAPACITOR MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0310058 SMD CAPACITOR 25V 104 +80%-20% 0603 C207,C211,C214,C216,C217,C224,C226~ C231,C234~C239,C241~C254,C256~C25 9,C267,C270~C274,C279,C281,C301~C3 03,C305,C309,C311,C312,C2160,C2162, C2163,C2167,C2168,C2170,C2171,C2173 ~C2175,C277,C343~C345,C280,C100,C1 13,C125 0310234 SMD CAPACITOR 16V 105 +80%-20% 0603 C201~C204,C221,C240 0310066 SMD CAPACITOR 50V 102 ±10% 0603 C278,C223,C120~C124 0310067 SMD CAPACITOR 50V 152 ±10% 0603 C215 0310068 SMD CAPACITOR 50V 222 ±10% 0603 C307,C310 0310201 SMD CAPACITOR 50V 153 ±10% 0603 C210 0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 C233 0310055 SMD CAPACITOR 16V 333 ±10% 0603 C225 0310056 SMD CAPACITOR 16V 473 ±10% 0603 C219,C220 0310362 SMD CAPACITOR 16V474 +80%-20% 0603 C218 0390044 SMD INDUCTOR 10UH ±10% 2012 L303,L306 0310245 SMD CAPACITOR 50V 121 ±10% X7R 0603 C206 0390163 SMD INDUCTOR 3.3uH ±10% 1608 L249 0390096 SMD INDUCTOR 1.8UH ±10% 1608 L100~L105 L309,L228,L236,L230~L233,L301,L305,L 307,L310,L312,L314,L316,L317,L319,L32 0,L304,L308,L318,L322,L324,L311,L321, L323 L201,L203,L205,L207,L208,L226,L227,L2 34,L235、L238 0390095 SMD MAGNETIC BEADS FCM1608K-221T05 0390087 SMD MAGNETIC BEADS FCM2012V-221T07 0700007 SMD DIODE 1N4148 VD201,VD119 0700001 SMD DIODE LS4148 VD201 0700002 SMD DIODE LL4148 VD201 0780062 SMD TRIODE 9014C V310 0780040 SMD TRIODE 3904(100-300) SOT-23 V305 0780193 SMD TRIODE 2SK3018 V303,V304 0780115 SMD TRIODE 2SB1132 V301,V302 0780085 SMD TRIODE 8050D V100~V102,V307,V308 0780063 SMD TRIODE 9015C Q204 0780129 SMD TRIODE 8550D V306,V309 0700056 SMD DOUBLE DIODE MMBD4148SE SOT-23 VD100,VD101,VD103~VD106 0880165 74HCU04D SOP U205 0880322 IC MM74HCU04M SOP U205 0880513 IC HCU04 SOP U205 IC MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0881157 IC HY57V641620HGT-H TSOP U211 0881661 IC IC42S16400-7T TSOP U211 0881969 IC IP1117-ADJ SOT-223 U209 0881182 IC LM1117MP-ADJ SOT-223 U209 0881031 IC 24C02N SOP U202 0881990 MT1389FE/B(B)QFP U201 0881897 IC MT1389EE QFP U201 0881459 D5954 SOP U302 0881378 IC BA5954FP HSOP U302 0881968 M41T81 SOP N106 1940094 CABLE SOCKET 24P 0.5mm SMD WITH CLASP XS301 1632563 PCB 2535-1 IC IC IC INPUT BOARD 0200167 PORCELAIN CAPACITOR 50V 20P ±10% NPO 2.5mm C100~C105 1860064 SC107 XC100 2121601 SOFT FLAT CABLE 10P160 2.0/2.5 2 PIN,WITH NEEDLE,THE SAME DIRECTION XP101 1563412 1530-1 SCART SOCKET PCB POWER BOARD 2100003 CONNECTED CORDS F0.6 SHAPED 7.5mm W1,W2,W3,W4,W5,W6,W14,W20 2100004 CONNECTED CORDS F0.6 SHAPED 10mm W7,W15,W18,W19,W12,W17 2100006 CONNECTION CORDS F0.6 SHAPED 12.5mm R507,W9 2100007 CONNECTION CORDS F0.6 SHAPEN 15mm W16,W13 0000274 CARBON FILM RESISTOR 1/4W47O±5% SHAPED 10 R520 0000431 CARBON FILM RESISTOR 1/4W75O±5% SHAPED 10 R505 0000433 CARBON FILM RESISTOR 1/4W270O±5% SHAPED 10 R516 0000282 CARBON FILM RESISTOR 1/4W820O±5% SHAPED 10 R508 0000284 CARBON FILM RESISTOR 1/4W1.5K±5% SHAPED 10 R527 0000291 CARBON FILM RESISTOR 1/4W5.6K±5% SHAPED 10 R515 0000294 CARBON FILM RESISTOR 1/4W10K±5% SHAPED 10 R511 0000301 CARBON FILM RESISTOR 1/4W47K±5% SHAPED 10 R512,R526 0000310 CARBON FILM RESISTOR 1/4W1MO±5% SHAPED 10 R506 0010134 METAL OXIDE FILM RESISTOR 1W330O±5%SHAPED R 15×8 R510 0000615 CARBON FILM RESISTOR 1W15O±5% SHAPED VERTICAL 5 R528 0010062 METAL FILM RESISTOR 1/4W2.2K±1% SHAPED 10 R525 MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0010063 METAL FILM RESISTOR 1/4W4.7K±1% SHAPED 10 R513 0010101 METAL FILM RESISTOR 1/4W12K±1% SHAPED 10 R514 0010273 METAL FILM RESISTOR 1/4W24K±1% SHAPED 10 R524 0010306 METAL OXIDE FILM RESISTOR @1W680K±5% SHAPED 15 UL R501 0010274 METAL FILM RESISTOR 1W10O±1% SHAPED 12.5 R509 0010275 METAL OXIDE FILM RESISTOR 1W33O±5% SHAPED VERTICAL 7.5 R521,R522 0010147 METAL OXIDE FILM RESISTOR 2W47K±5% SHAPED FLAT 15×7 R517,R519 0010157 METAL OXIDE FILM RESISTOR 2W68K±5%SHAPED FLAT 15×7 R502,R518 0010263 METAL OXIDE FILM RESISTOR 2W75K±5% SHAPED FLAT 15×7 R503,R504 0010281 METAL OXIDE FILM RESISTOR 3W1K±5% SHAPED VERTICAL 7.5 R523 0200105 PORCELAIN CAPACITOR 50V 100P ±10% 5mm C504,C508,C510,C512,C513,C519,C520 0200123 PORCELAIN CAPACITOR 50V 102 ±10% 5mm C515,C522 0200134 PORCELAIN CAPACITOR 50V 223 ±20% 5mm C503 0200138 PORCELAIN CAPACITOR 50V 104 ±20% 5mm C502,C516,C518,C523 0200224 PORCELAIN CAPACITOR 1000V 103 +80%-20% 7.5mm C501,C517 0210158 TERYLENE CAPACITOR 100V 472±10% SHAPED 5mm C506,C507,C509,C511,C514 0210024 TERYLENE CAPACITOR 100V 333 ±10% 5mm C505 0210148 TERYLENE CAPACITOR 100V 473 ±10% SHAPED 5mm C521,C524 0210204 ANTI-JAMMING CAPACITOR @MKP61 X2 275VAC 104M 15 UL XC501,XC502 0200353 CERAMIC CAPACITOR @Y1 400VAC 102±10% 10mm UL YC501 0260614 CD EZ 400V330U±20% 35×35 10 TC501 0260664 CD CD11K 16V220U±20% 6.3×11 2.5 TC511 0260653 CD CD11K 16V470U±20%8×14 3.5 TC505,TC506,TC512 0260661 CD CD288H 16V2200U±20%13×20 5 TC507,TC509 0260597 CD CD11 105℃ 16V1000U±20%10×20 5 TC508,TC510 0260558 CD CD11T 25V470u±20%10×16 5 TC504 0260665 CD CD11K 25V1000U±20% 13×20 5 TC503 0260667 CD CD11K 50V1U±20% 5×11 2 TC514 0260663 CD CD11K 35V220U±20% 8×12 3.5 TC513 0260666 CD CD11K 50V47U±20% 6.3×11 2.5 TC515 0260601 CD CD11C 105℃ 50V22U±20%6×7 2.5 TC502 0260668 CD CD11K 50V470U±20% 13×20 5 TC518 0260677 CD CD11K 50V2200U±20% 16×30 7.5 TC516,TC517 RH-357508 L502 0390154 MAGNETIC BEADS INDUCTOR MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0390340 VERTICAL INDUCTOR 10uH ±10% 5A 12.5×26.5 10mm L506 0410010 CHOKE COIL VERTICAL 10UH 1A 5mm L505 0410011 CHOKE COIL VERTICAL 10UH 2A 5mm L503,L504 @SE2135 UL T501 BCK-40-0726 T502 0680065 SCHOTTKY DIODE SR560 DO-27 SHAPED 20mm D504,D505 0570006 DIODE 1N4148 D502 0570013 DIODE HER105 D503,D506,D507,D509 0570014 DIODE HER107 D501 0570042 DIODE HER207 SHAPED 12.5mm D508 0570045 DIODE BYW29E-200 TO-220 D510,D511 05800069 VOLTAGE REGULATOR DIODE 5.1V ±5% 1/2W BELT ZD501 0580022 VOLTAGE REGULATOR DIODE 12V ±5% 1W ZD503 0670013 KBL04 BD501 SWITCH POWER TRANSFORMER SWITCH POWER 0460441 TRANSFORMER 0460533 SILICON BRIDGE 1570146 PCB @5535-1 UL 0880379 IC LM7805 GOLD SEALED TO-220 U504 0880247 IC MC7805CT GOLD SEALED TO-220 U504 0880499 IC L7805CV GOLD SEALED TO-220 U504 0880863 IC HA17431VP TO-92 U503 0882462 IC AZ431AZ-A TO-92 U503 0880553 IC LM431ACZ TO-92 U507 0882462 AZ431AZ-A TO-92 U507 0880765 IC 5L0380R YDTU U501 0881500 KA1M0880BTU TO-3P-5L U505 1030007 PRESS SENSITIVITY RESISTOR 7D 471 ±10% 5mm RV501 1050002 HEAT SENSITIVITY RESISTOR NTC SCK-104MS±20% RT501 1080032 PHOTOELECTRIC COUPLER @HS817 VDE U502,U506 1000010 POWER GRID FILTER JBL2822 30mH±20% L501 2121574 FLAT CABLE 4P150 2.5 2 PIN,WITH NEEDLE,THE SAME DIRECTION 22# CORD XP100 1940004 SOCKET 5P 2.5mm XS108 1940006 SOCKET 6P 2.5mm XP109 1940074 SOCKET 2P 7.92mm XS107 2120886 FLAT CABLE 6P120 2.5 2 PIN,WITH NEEDLE,THE SAME DIRECTION XP102 IC IC MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 2300033 FUSE @T3.15AL 250V VDE F501 3020402 FUSE HOLDER BLX-2 F501 3580086 HEAT RADIATION BOARD 11×15×25 BLACK SINGLE HOLE D510,D511 3580091 HEAT RADIATION BOARD 11×15×31 LFDR9905 U504 3580156 HEAT RADIATION BOARD 40×20×35 DVR938-2 U505 4000453 SELF-TAPPING SCREW BT 3×8H WHITE NICKEL D510,D511,U504 4000564 SELF-TAPPING SCREW PWT 3×12×7H WHITE NICKEL U505 4000627 SELF-TAPPING SCREW PWT 2.6×6×5H BLACK ZINC U505 POWER SUPPLY SWITCH BOARD 1780019 SWITCH DOWN-LEAD 2P 390mm XP106 0200230 CERAMIC CAPACITOR 400VAC 102 ±10% 10mm C100 1563413 A530-1 PCB AMPLIFIER BOARD 2100006 CONNECTION CORDS F0.6 SHAPED 12.5mm R42 0000540 CARBON FILM RESISTOR 1/2W150O±5% SHAPED 12.5 R91,R9 0010233 METAL OXIDE FILM RESISTOR 1/2W47O±5% SHAPED 12.5 R188,R46 0210145 METAL POLYESTER FILM CAPACITOR CL21X 100V 104K C5 C140,C141,C42,C45 0210165 METAL POLYESTER FILM CAPACITOR CL23X 63V 474 ±5% 5 C43,C90,C139,C184,C69 0010282 METAL OXIDE FILM RESISTOR 3W1K±5% SHAPED R 20×8 R198 0260127 CD CD11 16V4.7U±20%5×11 2 C84,C87,C91,C92,C113,C125 0260019 CD CD11 16V10U±20%5×11 2 C8,C13,C54,C58,C86,C104,C108,C110,C1 12,C165 0260025 CD CD11 16V47U±20%5×11 2 C19,C57,C63,C79,C128,C62 0260028 CD CD11 16V220U±20%6×12 2.5 C189,C190,C94,C85,C146,C15 0260618 CD CD11 10V330U±20%6.3×11 2.5 C166,C167 0260048 CD CD11 35V470U±20%10×20 5 C172,C173,C176,C177,C185,C186 0260491 CD CD11K 35V680U±20% 13×20 5 C36,C37,C133,C134 0390057 MAGNETIC BEADS INDUCTOR RH354708 L5 0390168 INDUCTOR 100UH±10% 0410 SHAPED 12.5mm L14 10uH ±10% 4A 5mm L1~L4,L9~L11 0570004 DIODE 1N4004 VD9,VD10 0570006 DIODE 1N4148 VD6 05800069 VOLTAGE REGULATOR DIODE 5.1V ±5% 1/2W BELT VD3,VD2 00580009 VOLTAGE REGULATOR DIODE 9.1V ±5% 1/2W VD8,VD4 0410176 VERTICAL SCREEN SHIELD FILTERING INDUCTOR MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0780032 TRIODE 9014C V6 0780029 TRIODE C8050 V4,V5,V7,V8 0780138 TRIODE 8050D V4,V5,V7,V8 0780025 TRIODE 2N5401 V1~V3 0960226 CRYSTAL OSCILLATOR 4.332MHz 49-s Y2 0960182 CRYSTAL OSCILLATOR 12.288MHz 49-S Y3 0960171 CRYSTAL OSCILLATOR 13.50MHZ 49-S Y1 0881429 IC CD4052BE DIP N5 0880443 IC CD4052BCN DIP N5 0882375 IC RC4580 DIP N11 0881743 IC F4558 DIP N11 0882351 IC NE4580 DIP N11 1940003 SOCKET 4P 2.5mm XS100,XS105 2150246 FLAT CABLE 7P290 2.5 T2 2/3P SHIELD,WITH NEEDLE,THE SAME DIRECTION XP101 1940140 CABLE SOCKET 14P 1.0mm STRAIGHT DUAL LINE PLUG XS103 1940033 CABLE SOCKET 11P 1.25mm STRAIGHT DUAL LINE PLUG XS106 1940006 SOCKET 6P 2.5mm XS102 1990038 5PZ-7A XC100 1940004 SOCKET 5P 2.5mm XS104 3580186 RADIATOR 78×49×30 DVR938 NOT OXIDATION 5230707 SOFT SPONGE SPACER 10×10×2 SINGLE-FACED,HARD 4490001 SPRING PAD F3 4450012 F3×7.2×0.5 OUTER CONNECTION SOCKET BOLT PAD 4210005 MACHINE-TAPPING SCREW PM 3×8 BLACK 5233174 9×9×1 SINGLE-FACED WITH GLUE IN REAR SIDE,CENTER HOLE f 3 RUBBER SPACER 5446915 PCB SEMI-FINISHED PRODUCT 4535-0-SMD AMPLIFIER BOARD-SMD R199,R200,R202,R203,R206~R213,R223, R224 R51~R53,R65,R93,R113,R144,R145,R178 ,R182,R196,R197 0090001 SMD RESISTOR 1/16W 0O ±5% 0603 0090272 SMD RESISTOR 1/16W1O±5% 0603 0090540 SMD RESISTOR 1/16W1.5O±5% 0603 R34~R37,R134~R136,R186 0090002 SMD RESISTOR 1/16W 2.2O ±5% R68 0090616 SMD RESISTOR 1/16W 3.3O±5% 0603 R40,R41,R67,R140,R141 0090314 SMD RESISTOR 1/16W 5.1O ±5% 0603 R88 MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0090003 SMD RESISTOR 1/16W 10O ±5% 0603 R24,R25,R89,R116,R137,R175 0090004 SMD RESISTOR 1/16W 22O ±5% 0603 R115 0090230 SMD RESISTOR 1/16W 47O ±5% 0603 R29,R56,R59,R62,R63,R69,R70,R94~R10 1,R225,R5 0090220 SMD RESISTOR 1/16W 51O ±5% 0603 R27,R122 0090239 SMD RESISTOR 1/16W 200O ±5% 0603 R64,R66 0090008 SMD RESISTOR 1/16W 220O ±5% R123~R126,R148 0090014 SMD RESISTOR 1/16W 1K ±5% 0603 0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 0090020 SMD RESISTOR 1/16W 5.1K ±5% 0603 R58,R45,R90,R192 0090225 SMD RESISTOR 1/16W 5.6K ±5% 0603 R78 0090022 SMD RESISTOR 1/16W 8.2K ±5% R79 0090023 SMD RESISTOR 1/16W 10K ±5% 0603 R6,R11,R16,R43,R49,R54,R55,R57,R60,R 61, 0090187 SMD RESISTOR 1/16W 12K ±5% R13,R14,R18 0090025 SMD RESISTOR 1/16W 20K ±5% 0603 R176,R180,R193,R177,R181,R194 0090026 SMD RESISTOR 1/16W 22K ±5% 0603 R7,R17,R165,R92 0090027 SMD RESISTOR 1/16W 27K ±5% 0603 R106~R108,R157,R158,R161,R4, R10, R20,R21 0090028 SMD RESISTOR 1/16W 33K ±5% 0603 R109,R162 0090029 SMD RESISTOR 1/16W 47K ±5% 0603 R114,R169,R48 0090030 SMD RESISTOR 1/16W 56K ±5% 0603 R22 0090201 SMD RESISTOR 1/16W 220K ±5% 0603 R15,R19,R12 0090109 SMD RESISTOR 1/16W 1MO ±5% 0603 R8,R104 0090147 SMD RESISTOR 1/10W 1O ±5% 0805 R30,R31,R32,R33,R130,R131,R132,R185 0090039 SMD RESISTOR 1/10W 10O ±5% 0805 R189,R190 0310046 SMD CAPACITOR 50V 82P ±5% NPO 0603 C14,C132 0310045 SMD CAPACITOR 50V 47P ±5% NPO 0603 C161,C162 0310042 SMD CAPACITOR 50V 15P ±5% NPO 0603 C17,C18,C95,C96,C118,C124 0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 C3,C6,C76,C77,C100~C102,C156,C191~C 196 0310049 SMD CAPACITOR 50V 221 ±5% NPO 0603 C73,C163,C164,C171 0310051 SMD CAPACITOR 50V 331 ±5% NPO 0603 C81 0310196 SMD CAPACITOR 50V 471 ±10% 0603 0310471 SMD CAPACITOR 50V 561±5% NPO 0603 C117 0310054 SMD CAPACITOR 50V 681 ±5% NPO 0603 C1,C2C97,C98,C154,C155 0310066 SMD CAPACITOR 50V 102 ±10% 0603 C20,C21,C38,C39,C89,C135,C136, R3,R50,R133,R217,R218,R146,R147,R14 9, R150~R152 R76~R77,R80,R82,R102,R103,R105,R110 ,R111,R139,R156,R230,R1,R2,R38,R44,R 191 MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0310067 SMD CAPACITOR 50V 152 ±10% 0603 C159,C198 0310072 SMD CAPACITOR 50V 103 ±10% 0603 C40,C41,C44,C46,C47,C50,C53,C64~C66, C68,C70~C71,C93,C137,C138,C142,C143 ,C174,C178,C187,C188,C12 0310084 SMD CAPACITOR 50V 104 +80%-20% 0603 C9~C11,C22,C24,C26~C31,C48,C49,C51, C52,C55,C56,C59~C61,C67,C72,C74,C75, C78,C80,C82,C83,C88,C99,C103,C105~C 107,C109,C114,C116,C119~C123,C126,C 127,C179,C199,C200,C201,C202,C203,C 204,C144,C145,R201 0310112 SMD CAPACITOR 16V 224 ±10% 0603 C111 0310234 SMD CAPACITOR 16V 105 +80%-20% 0603 C160,C197,C5 0310673 SMD CAPACITOR 50V 333 ±5% X7R 0603 C32~C35,C129,C130,C131,C183 0310368 SMD CAPACITOR 25V 105 +80%-20% Y5V 0805 C23,C25,C115,C175 0310056 SMD CAPACITOR 16V 473 ±10% 0603 C4 0310201 SMD CAPACITOR 50V 153 ±10% 0603 C7 0390095 SMD MAGNETIC BEADS FCM1608K-221T05 L6,L8,L12,R160,R159 0700007 SMD DIODE 1N4148 VD1,VD7 0882353 IC CS5340 TSSOP N7 0881456 IC SAA6588 SO20 N6 0882349 IC TAS5112 TSSOP N13,N14 0882350 IC TAS5508 TQFP N12 0882352 IC TLV272 SOP N8,N9,N1 0882372 IC 74HCT125 TSSOP N3,N4 0882373 IC SN74LVC2G04DBVR SOT-23 N2 1632564 PCB 4535-1 MICROPHONE HOLDER BOARD 0000133 CARBON FILM RESISTOR 1/6W4.7K±5% SHAPED 7.5 R104,R103,R109 0000148 CARBON FILM RESISTOR 1/6W200K±5% SHAPED 7.5 R101 0000379 CARBON FILM RESISTOR 1/6W2K±5% SHAPED 7.5 R100 0000589 CARBON FILM RESISTOR 1/6W82K±5% BELT R107 0000146 CARBON FILM RESISTOR 1/6W100K±5% SHAPED 7.5 R108 0200305 POLYPROPYLENE CAPACITOR 50V 22P±10% SHAPED 5mm C103 0200308 POLYPROPYLENE CAPACITOR 50V 221±10% SHAPED 5mm C102 0260057 CD CD11 50V0.47U±20%5×11 2 C100 0260200 CD CD11C 16V47U±20%5×7 2 C105,C104 0570006 DIODE 1N4148 VD101,VD102 0881227 RC4558P DIP N100 IC MATERIAL CODE MATERIAL NAME SPECIFICATIONS LOCATION 0880445 IC 4558C DIP N100 0881743 IC F4558 DIP N100 1980030 MICROPHONE SOCKET CK3-6.35-19 MIC100 2150259 FLAT CABLE 5P280 2.5 2 PIN 3P SHIELD,WITH L NEEDLE,THE SAME DIRECTION XP104 1563411 9530-2 PCB SURFACE CONTROL BOARD 2100003 CONNECTED CORDS F0.6 SHAPED 7.5mm J5,J6,J7 2100004 CONNECTED CORDS F0.6 SHAPED 10mm J8,J9,J10,J14,J16,J17,J18,J19,J20,J22 2100006 CONNECTION CORDS F0.6 SHAPED 12.5mm J1,J2,J3,J4 0000122 CARBON FILM RESISTOR 1/6W100O±5% SHAPED 7.5 R32~R34,R12 0000123 CARBON FILM RESISTOR 1/6W330O±5% SHAPED 7.5 R9,R10,R16,R19,R25,R27,R28,R29,R30,R 31,R36,R37 0000137 CARBON FILM RESISTOR 1/6W10K±5% SHAPED 7.5 R35 0000270 CARBON FILM RESISTOR 1/4W10O±5% SHAPED 10 R22 0000287 CARBON FILM RESISTOR 1/4W3.3K±5% SHAPED 10 R23,R24 0000294 CARBON FILM RESISTOR 1/4W10K±5% SHAPED 10 R13,R14,R15,R17,R18,R20,R21,R26 0000300 CARBON FILM RESISTOR 1/4W33K±5% SHAPED 10 R1,R2,R3,R4,R5,R6,R7,R8 0000302 CARBON FILM RESISTOR 1/4W51K±5% SHAPED 10 R11 0200138 PORCELAIN CAPACITOR 50V 104 ±20% 5mm C1~C4,C8,C9,C10,C11,C13,C14,C15,C17 0200307 POLYPROPYLENE CAPACITOR 50V 101±10% SHAPED 5mm C5~C7 0260025 CD CD11 16V47U±20%5×11 2 TC12 0260027 CD CD11 16V100U±20%6×12 2.5 TC4 0260163 CD CD11 50V47U±20%6×12 2.5 TC16 0390057 MAGNETIC BEADS INDUCTOR RH354708 FB1,FB2 0570006 DIODE 1N4148 D2,D3,D4,D5 0620040 RADIATION DIODE 3B 4SC WHITE ISSUE BLUE LED1,LED2,LED3,LED4,LED5,LED6,LED7, LED8,LED11,LED12 0620092 RADIATION DIODE 3R 2HD RED LED9,LED10 0780030 TRIODE 8550C V1,V2 0780151 TRIODE 8550D V1,V2 0880251 IC D16311GC QFP U1 0881563 IC S0791GC QFP U1 HNVC10SM25 VFD1 AB903 VG2,VG3 HORIZONTAL 6×6×1 K1~K13 1200356 DISPLAY SCREEN GROUND CHIP OF POWER BOARD LIGHT TOUCH RESTORE 1340003 SWITCH 3870115 MATERIAL CODE 1980028 MATERIAL NAME EARPHONE SOCKET 2121979 FLAT CABLE 2121980 FLAT CABLE 2150266 FLAT CABLE SPECIFICATIONS CKX-3.5-241 HS0038A2 5230143 10×10×6 1563896 PCB JK1 10P210 2.0 2 PIN,WITH L NEEDLE,THE SAME XP103 DIRECTION 5P205 2.5/2.0 2 PIN,WITH L XP101 NEEDLE,REVERSE 4P220 2.0/2.5 T2 2P SHIELD,WITH L XP102 NEEDLE,THE SAME DIRECTION 2360011 IR SENSOR VFD SPONGE SPACER LOCATION U2 6530-4 REMOTE CONEROLLER 0090272 SMD RESISTOR 1/16W1O±5% 0603 R801 0310048 SMD CAPACITOR 50V 151 ±5% NPO 0603 C802,C803 0630009 EMISSION PIPE TSAL4400 LED801 0700007 SMD DIODE 1N4148 D801~D803 0700001 SMD DIODE LS4148 D801~D803 0700002 SMD DIODE LL4148 D801~D803 0780130 SMD TRIODE STC3265 Q801 0880220 PT2222 SOP U801 0970003 CERAMIC RESONATOR 455E X801 1563233 8965-4 IC PCB SURFACE CASING OF REMOTE RC019-01 GREY CONTROL REMOTE CONTROL BOTTOM 3040813 RC019-01 GREY CASING BATTEMETAL OXIDE FILM 3050701 RC019-01 GREY RESISTOR CASE DOOR OF 3031118 3850063 ANODE SPRING RC019-01 3# 3850064 CATHODE SPRING RC019-01 3# 3850065 ANODE CATHODE SPRING RC019-01 3# CONDUCT GLUE OF REMOTE ABS535T(RU) CONTROL GLUE BAG FOR 5070809 70×230×0.05 PE ENVIRONMENTAL PROTECTION SURFACE STICKER OF REMOTE 5155307 ABS535T(RU) CONTROL 4630900 5154411 BOTTOM CASING LABEL ABS530T(RU) MATERIAL CODE MATERIAL NAME SPECIFICATIONS PANEL UNITS 0160188 DIGITAL POTENTIOMETER EC12P24L15F 3001915 PANEL HF830 SILVER WHITE,SPRAY PAINT 3025708 POWER BUTTON GUIDING LIGHE LOOP HF830 TRANSPARENCE 3025709 BIG KNOB GUIDING LIGHT RING HF830 TRANSPARENCE 3025711 LEFT DECORATIVE STRIP HF830 SILVER WHITE,PLATING 3025712 RIGHT DECORATIVE STRIP HF830 SILVER WHITE,PLATING 3025713 EJECT BUTTON HF830 SILVER WHITE,PLATING 3025714 5-DIRECTION BUTTON HF830 SILVER WHITE,PLATING 3025715 LEFT 3-DIRECTION BUTTON HF830 SILVER WHITE,PLATING 3025716 RIGHT 3-DIRECTION BUTTON HF830 SILVER WHITE,PLATING 3029379 POWER BUTTON ABS530T SILVER WHITE,PLATING 3025721 KNOB HF830 SILVER WHITE, PLATING 3110481 ALUMINUM ALLOY PANEL ABS535T(RU) SILVER WHITE 3070711 UPPER GLASS ABS535T(RU) LENS COVER 3070710 LOWER GLASS ABS535T(RU) LENS COVER 3025725 DISPLAY WINDOW GLASS HF830 GRAMAMETAL OXIDE FILM RESISTOR LENS 4000048 SELF-TAPPING SCREW PB 3×8 COLOR ZINC 4000120 SELF-TAPPING SCREW PB 3×10 COLOR ZINC 3871118 MICROPHONE PRESSING PIECE ABS530T SILVER GREY 3810070 GROUNDING SPRING F8×7 F0.3 2110552 LEAD 22# 140/140mm BLACK,WITH F3.2 WELD PIECE 2110553 LEAD 22# 140/170mm BLACK,WITH F3.2 WELD PIECE 5446917 PCB SEMI-FINISHED PRODUCT 9530-2 ABS535T 5447378 PCB SEMI-FINISHED PRODUCT 6530-3 ABS535T NET COVER 4650214 NET CLOTH RC-801K31 ASSEMBLY 2250190 FLAT CABLE CORD 11P 110mm 1.25mm THE SAME DIRECTION 1020037 DIGITAL RECEIVE TUNER TAF-11MFR 2250177 FLAT CABLE CORD 28P 150mm 1.0mm REVERSE 1350066 POWER SUPPLY SWITCH PS8-11-C-048B/BH 1710038 MAGNETISM RING L361 UH16×28×9 WITH CLASP 1870041 8 GRAPHEMIC POWER SUPPLY SOCKET RF-180-BB MATERIAL CODE MATERIAL NAME SPECIFICATIONS 2121324 SOFT FLAT CABLE 6P180 2.0 2 PIN,THE SAME DIRECTION 2121668 FLAT CABLE 5P140 2.0 2 PIN,THE SAME DIRECTION 5233636 PVC PIECE 55×55×0.25 SILVER GREY,SINGLE-FACED WITH GLUE IN REAR SIDE 2140116 POWER CORD 2P 1.5m 2.5A RVVB CIRCLE HEAD(VD) 2250144 FLAT CABLE CORD 24P 230mm 0.5mm REVERSE 2380245 DVD LOADER COSMIC DV342S 2380245 DVD LOADER COSMIC DV342S 3022336 PLASTIC BRACKET 10mm WITH CLASP 3025710 FOOT HF830 SILVER WHITE,OIL-SPRAYED 3025718 DOOR(SANYO) HF830 SILVER WHITE,SPRAY PAINT 3070712 GLASS OF GATE ABS535T(RU) LENS COVER 3029130 PROTECT COVER OF POWER ABS530T BLACK 3060222 DVD LOADER ASA8110(WITHOUT SERVO /PICKUP) 3060240 SANYO LOADER BRACKET (LEFT) HF830 3060241 SANYO LOADER BRACKET (RIGHT) HF830 3101945 UPPER COVER ABS535T(RU) SILVER WHITE 3100792 LOWER COVER HF830 GREY 3871507 REAR BOARD ABS535T(RU) 3870610 MIDDLE BRACKET HF830 GREY 3871532 LEFT BRACKET ABS535T(RU) 3871533 RIGHT BRACKET ABS535T(RU) 5234130 PVC PIECE @156×115.1×0.3 UL 4000515 SELF-TAPPING SCREW PWT 3×16×7H WHITE NICKEL,TOOTH LONGTH 9 4000452 SELF-TAPPING SCREW PWT 3×6×7H WHITE NICKEL 4000453 SELF-TAPPING SCREW BT 3×8H WHITE NICKEL 4000462 SELF-TAPPING SCREW BT 3×6H WHITE NICKEL 4000463 SELF-TAPPING SCREW CB 3×6H WHITE NICKEL 4000618 SELF-TAPPING SCREW PB 3×12 BLACK 4040051 SELF-TAPPING SCREW FB 3×6H BLACK 4210169 MACHINE-TAPPING SCREW PWM3×8×7 BLACK 4330026 SELF-TAPPING SCREW HA3×6 WHITE NICKEL 5233093 NYLON BANDAGE 120mm 5233125 FOOT SPACER(BEHIND) f 15.5×3 SPONGE(RIGIDITY 65) 5233126 FOOT SPACER(FRONT) f 20.5×3 SPONGE(RIGIDITY 65) MATERIAL CODE MATERIAL NAME SPECIFICATIONS 5446912 PCB SEMI-FINISHED PRODUCT 2535-0 ABS535T 5446919 PCB SEMI-FINISHED PRODUCT A530-0 ABS535T 5446918 PCB SEMI-FINISHED PRODUCT 5535-0 ABS535T 5445586 PCB SEMI-FINISHED PRODUCT 1530-0 ABS530T 5446914 PCB SEMI-FINISHED PRODUCT 4535-0 ABS535T 5462014 PANEL UNITS ABS535T SILVER WHITE SPEAKER BODY-L 5233946 PVC PEEL SF00859-HLPC 5233951 PVC PEEL P21010-01 5233947 RUBBER FEMALE CLASP DK-009 BLACK 4660086 INVERTED TUBE DJ-214 WITH 150mm INSIDE BLACK PAPER DUCT AND NET CLOTH SPEAKER BODY-R 5233946 PVC PEEL SF00859-HLPC 5233951 PVC PEEL P21010-01 5233947 RUBBER FEMALE CLASP DK-009 BLACK 4660086 INVERTED TUBE DJ-214 WITH 150mm INSIDE BLACK PAPER DUCT AND NET CLOTH PACKAGE MATERIAL 1440002 BATTERY 7# AAA 2160136 AV CORD 1.2M AUDIO 2160017 AV CORD 1m AUDIO,DUAL-HEAD WITH F3.5 EARPHONE PLUG 2160130 SPEAKER CORD f 0.15/17 2M TRANSPARENCE,WITH LINE NIP 2160131 SPEAKER CORD f 0.15/17 5M TRANSPARENCE,WITH LINE NIP 2170021 AV CORD 1.2M VIDEO 2180029 FM ANTENNA 1.5m WITH CATV FEMALE SLUG 2# 2180030 AM ANTENNA FRAME WITH BRACKET 15uH±20% 5013086 GIFT BOX ABS535T 5180014 SEALING STICKER OF CARTON BOX 0 5040923 FOAM FM-015303 2# 5040924 FOAM FM-025303 2# 5070443 HANDLED DRAW 32.5×85.5×8 WHITE 5070320 PLASTIC BAG FOR ENVIRONMENTAL PROTECTION (WITH WARNING WORDS) 195×260 ×0.023 PO 5070322 SELF-SEALED GLUE BAG(WORNING) 230×335 5071113 PEARL COTTON BAG FOR ENVIRONMENTAL PROTECTION (WITH HOLE) 390×530×0.5 PE MATERIAL CODE MATERIAL NAME SPECIFICATIONS 5071032 GLUE BAG FOR ENVIRONMENTAL PROTECTION (WITH HOLE) 1100×740×0.05 PE ENGLISH 5142076 SN LABEL CURRENCY FOR RUSSIA 5180181 STICKER BBK ENGLISH 25×10 2# 5193737 USER MANUAL ABS535T(RU) ENGLISH/RUSSIA 5210336 WARRANTY CARD CURRENCY FOR RUSSIA 3# 5231504 MICROPHONE SPONGE 226×90×56 5455905 SATELLITE SPEAKER INDIVIDUAL 1 ABS535T SILVER WHITE 5455906 SATELLITE SPEAKER INDIVIDUAL 2 ABS535T SILVER WHITE 5471389 REMOTE CONTROL ABS535T(RU) 5680228 PACKED DVD DISC(RU) BBK 3# 2160174 MICROPHONE CORD 2.5m WITHOUT SHIELD(P0.08×12) 5456123 UNPACKED MICROPHONE DM-998(WITHOUT DOWN-LEAD) 5500407 UNPACKED SPEAKER ABS535T SILVER GREY 5231424 FOOT SPACER f 15×2 SPONGE SOFEWARE PROGRAM 0881998 IC AT49BV162A 70TI TSOP 0881754 IC 29LV160BE-70NC TSOP SUPPLEMENT MODULE 2100002 CONNECTION CORDS F0.6 5110002 ELECTRO WELDING WIRE F1.0 5110003 ELECTRO WELDING WIRE 5110004 ADHESIVE TAPE 5110018 ELECTRO WELDING WIRE 5120001 THINNER 5120004 SOLDERING FLUX 5120011 WIPING WATER 5120012 RED GLUEWATER 5120013 YELLOW GLUEWATER 5120067 GLUEWATER 5120096 PEANUT OIL 5120209 PVC GLUE 5120332 SILICONE GREASE HEAT CONDUCT OIL GB-304 5180452 QA ENVELOP CASE STICKER QA PASS 110×45 5230021 SCOTCH TAPE 12mm f 2.0 502 MATERIAL CODE MATERIAL NAME SPECIFICATIONS 5230022 SEALING PAPER COLORLESS 5230452 FIBRE ADHESIVE TAPE 18mm 5231454 HIGH TEMPERATURE MASKING PAPER LENGTH:15 YARD WIDTH:6mm 5231455 HIGH TEMPERATURE MASKING PAPER LENGTH:15 YARD WIDTH:12mm 5231456 HIGH TEMPERATURE MASKING PAPER LENGTH:15 YARD WIDTH:24mm 5231514 HIGH TEMPERATURE MASKING PAPER LENGTH:15 YARD WIDTH:20mm