1
Download SERVICE MANUAL
Transcript
SERVICE MANUAL DV514S CONTENTS 1. SAFETY PRECAUTIONS 2. PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO ELECTROSTATICALLY 1 SENSITIVE(ES)DEVICES 1 3. CONTROL BUTTON LOCATIONS AND EXPLANATIONS 2 4. PREVERTION OF STATIC ELECTRICITY DISCHARGE 3 5. ASSEMBLING AND DISASSEMBLING THE MECHANISM UNIT 4 5.1 OPTICAL PICKUP UNIT EXPLOSED VIEW AND PART LIST 4 5.2 BRACKET EXPLOSED VIEW AND PART LIST 6 5.3 MISCELLANEOUS 7 6. ELECTRICAL CONFIRMATION 8 6.1 VIDEO OUTPUT (LUMINANCE SIGNAL) CONFIRMATION 8 6.2 VIDEO OUTPUT(CHROMINANCE SIGNAL) CONFIRMATION 9 7. MPEG BOARD CHECK WAVEFORM 10 8. AM29LV160D 11 8.1 HY57V641620HG 16 8.2 MT1389 19 9. 10. SCHEMATIC & PCB WIRING DIAGRAM SPARE PARTS LIST 22 36 1. SAFETY PREAUTIONS 1.1 GENERAL GUIDELINES 1. When servicing, observe the original lead dress. if a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barrier, insulation papers shields are properly installed. 3. After servicing, make the following leakage current checks to prevent the customer from being exposed to shock hazards. 2.PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO ELECTROSTATICALLY SENSITIVE(ES)DEVICES Some semiconductor(solid state)devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive(ES)Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor chip components. The following techniques should be used to help reduce the incidence of component damage caused by electro static discharge(ESD). 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially availabel discharging ESD wrist strap, which should be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ES devices,place the assembly on a conductive surface such as alminum foil, to prevent electrostatic charge buildup or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static (ESD protected)can generate electrical charge sufficient to damage ES devices. 5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES devices. 6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, alminum foil or comparable conductive material). 7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed. Caution Be sure no power is applied to the chassis or circuit, and observe all other safety precautions. 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity(ESD). notice (1885x323x2 tiff) 1 Front Panel Illustration 2 3 4 8 POWER switch 6 PLAY/PAUSE button 2 Disc tray 7 STOP button 3 OPEN/CLOSE button 8 MIC 1 jack 4 IR SENSOR 9 MIC 2 jack 5 Display window 2 6 5 9 7 4.PREVENTION OF STATIC ELECTRICITY DISCHARGE The laser diode in the traverse unit (optical pickup)may brake down due to static electricity of clothes or human body. Use due caution to electrostatic breakdown when servicing and handling the laser diode. 4.1.Grounding for electrostatic breakdown prevention Some devices such as the DVD player use the optical pickup(laser diode)and the optical pickup will be damaged by static electricity in the working environment.Proceed servicing works under the working environment where grounding works is completed. 4.1.1. Worktable grounding 1. Put a conductive material(sheet)or iron sheet on the area where the optical pickup is placed,and ground the sheet. 4.1.2.Human body grounding 1 Use the anti-static wrist strap to discharge the static electricity from your body. safety_3 (1577x409x2 tiff) 4.1.3.Handling of optical pickup 1. To keep the good quality of the optical pickup maintenance parts during transportation and before installation, the both ends of the laser diode are short-circuited.After replacing the parts with new ones, remove the short circuit according to the correct procedure. (See this Technical Guide). 2. Do not use a tester to check the laser diode for the optical pickup .Failure to do so willdamage the laser diode due to the power supply in the tester. 4.2. Handling precautions for Traverse Unit (Optical Pickup) 1. Do not give a considerable shock to the traverse unit(optical pickup)as it has an extremely high-precise structure. 2. When replacing the optical pickup, install the flexible cable and cut is short land with a nipper. See the optical pickup replacement procedure in this Technical Guide. Before replacing the traverse unit, remove the short pin for preventingstatic electricity and install a new unit.Connect the connector as short times as possible. 3. The flexible cable may be cut off if an excessive force is applied to it.Use caution when handling the cable. 4. The half-fixed resistor for laser power adjustment cannot be adjusted. Do not turn the resistor. 3 5. Assembling and disassembling the mechanism unit 5.1 Optical pickup Unit Explosed View and Part List Pic (1) 4 Materials to Pic (1) No. PARTS CODE PARTS NAME Q ty 14692200 SF-HD60 1 1 1EA0311A06300 ASSY, CHASSIS, COMPLETE 1 2 1EA0M10A15500 ASSY, MOTOR, SLED 1 Or 1EA0M10A15501 ASSY, MOTOR, SLED 1 3 1EA2451A24700 HOLDER, SHAFT 3 4 1EA2511A29100 GEAR, RACK 1 5 1EA2511A29200 GEAR, DRIVE 1 6 1EA2511A29300 GEAR, MIDDLE, A 1 7 1EA2511A29400 GEAR, MIDDLE, B 1 8 1EA2744A03000 SHAFT, SLIDE 1 9 1EA2744A03100 SHAFT, SLIDE, SUB 1 10 1EA2812A15300 SPRING, COMP, TYOUSEI 3 11 1EA2812A15400 SPRING, COMP, RACK 1 21 1EA0B10B20100 ASSY, PWB 1 Or 1EA0B10B20200 ASSY, PWB 1 31 SEXEA25700--- SPECIAL SCREW BIN+-M2X11 3 32 SEXEA25900--- SPECIAL SCREW M1.7X2.2 2 33 SFBPN204R0SE- SCR S-TPG PAN 2X4 2 34 SFSFN266R0SE- SCR S-TPG FLT 2.6X6 1 35 SWXEA15400--- SPECIAL WASHER 1.8X4 X0.25 2 Note : This parts list is not for service parts supply. 5 5.2 Bracket Explosed View and Part List Pic (2) Materials to Pic(2) 1.bracket 2.belt 3.screw 4.belt wheel 5.gearwheel 6.iron chip 7. Immobility mechanism equipment 8. Magnet 9. Platen 10. Bridge bracket 11. screw 12. screw 13. Big bracket 14. front silicon rubber 15. Back silicon rubber 16. Pick-up 17. Pick-up 18. switch 19. Five-pin flat plug 20. screw 21. PCB 22. motor 23. Motor wheel 24. screw 25.tray Before going process with disassembly and installation, please carefully both peruse the chart and confirm the materials. 6 5.3 MISCELLANEOUS 5.3.1 Protection of the LD(Laser diode) Short the parts of LD circuit pattern by soldering. 5.3.2 Cautions on assembly and adjustment Make sure that the workbenches,jigs,tips,tips of soldering irons and measuring instruments are grounded,and that personnel wear wrist straps for ground. Open the LD short lands quickly with a soldering iron after a circuit is connected. Keep the power source of the pick-up protected from internal and external sources of electrical noise. Refrain from operation and storage in atmospheres containing corrosive gases (such as H2S,SO2, NO2 and Cl2)or toxic gases or in locations containing substances(especially from the organic silicon,cyan, formalin and phenol groups)which emit toxic gases.It is particularly important to ensure that none of the above substances are present inside the unit.Otherwise,the motor may no longer run. 7 6.Electrical Confirmation 6.1. Video Output (Luminance Signal) Confirmation DO this confirmation after replacing a P.C.B. Measurement point Mode Disc Video output terminal Color bar 75% PLAY(Title 46):DVDT-S15 PLAY(Title 12):DVDT-S01 DVDT-S15 or DVDT-S01 Measuring equipment,tools Confirmation value 200mV/dir,10 sec/dir 1000mVp-p±30mV Purpose:To maintain video signal output compatibility. 1.Connect the oscilloscope to the video output terminal and terminate at 75 ohms. 2.Confirm that luminance signal(Y+S)level is 1000mVp-p±30mV 8 6.2 Video Output(Chrominance Signal) Confirmation Do the confirmation after replacing P.C.B. Measurement point Mode Disc Video output terminal Color bar 75% PLAY(Title 46):DVDT-S15 PLAY(Title 12):DVDT-S01 DVDT-S15 or DVDT-S01 Measuring equipment,tools Screwdriver,Oscilloscope 200mV/dir,10 sec/dir Confirmation value 621mVp-p±30mV Purpose:To maintain video signal output compatibility. 1.Connect the oscilloscope to the video output terminal and terminate at 75 ohme. 2.Confirm that the chrominance signal(C)level is 621 mVp-p±30mV 9 7.MPEG BOARD CHECK WAVEFORM 7.1 27MHz WAVEFORM DIAGRAM 7.2 IC VIPER22 PIN.5 WAVEFORM DIAGRAM 10 8. Am29LV160D 16 Megabit (2 M x 8-Bit/1 M x 16-Bit) CMOS 3.0 Volt-only Boot Sector Flash Memory DISTINCTIVE CHARACTERISTICS ■ Single power supply operation ■ Embedded Algorithms — Full voltage range: 2.7 to 3.6 volt read and write operations for battery-powered applications — Regulated voltage range: 3.0 to 3.6 volt read and write operations and for compatibility with high performance 3.3 volt microprocessors ■ Manufactured on 0.23 µm process technology — Fully compatible with 0.32 µm Am29LV160B device — Embedded Erase algorithm automatically preprograms and erases the entire chip or any combination of designated sectors — Embedded Program algorithm automatically writes and verifies data at specified addresses ■ Minimum 1,000,000 write cycle guarantee per sector ■ 20-year data retention at 125°C ■ High performance — Reliable operation for the life of the system — Access times as fast as 70 ns ■ Ultra low power consumption (typical values at 5 MHz) ■ Package option — 48-ball FBGA — 200 nA Automatic Sleep mode current — 48-pin TSOP — 200 nA standby mode current — 44-pin SO ■ CFI (Common Flash Interface) compliant — 9 mA read current — 20 mA program/erase current ■ Flexible sector architecture — One 16 Kbyte, two 8 Kbyte, one 32 Kbyte, and thirty-one 64 Kbyte sectors (byte mode) — Provides device-specific information to the system, allowing host software to easily reconfigure for different Flash devices ■ Compatibility with JEDEC standards — One 8 Kword, two 4 Kword, one 16 Kword, and thirty-one 32 Kword sectors (word mode) — Pinout and software compatible with singlepower supply Flash — Supports full chip erase — Superior inadvertent write protection ■ Data# Polling and toggle bits — Sector Protection features: A hardware method of locking a sector to prevent any program or erase operations within that sector Sectors can be locked in-system or via programming equipment — Provides a software method of detecting program or erase operation completion ■ Ready/Busy# pin (RY/BY#) Temporary Sector Unprotect feature allows code changes in previously locked sectors ■ Unlock Bypass Program Command — Provides a hardware method of detecting program or erase cycle completion (not available on 44-pin SO) ■ Erase Suspend/Erase Resume — Reduces overall programming time when issuing multiple program command sequences ■ Top or bottom boot block configurations available — Suspends an erase operation to read data from, or program data to, a sector that is not being erased, then resumes the erase operation ■ Hardware reset pin (RESET#) — Hardware method to reset the device to reading array data This Data Sheet states AMD’s current technical specifications regarding the Product described herein. This Data Sheet may be revised by subsequent versions or modifications due to changes in technical specifications. 11 Publication# 22358 Rev: B Amendment/+3 Issue Date: November 10, 2000 PRODUCT SELECTOR GUIDE Family Part Number Am29LV160D Voltage Range: VCC = 2.7–3.6 V -70 -90 -120 Max access time, ns (tACC) 70 90 120 Max CE# access time, ns (tCE) 70 90 120 Max OE# access time, ns (tOE) 30 35 50 Speed Option Note: See “AC Characteristics” for full specifications. BLOCK DIAGRAM DQ0–DQ15 (A-1) RY/BY# VCC Sector Switches VSS Erase Voltage Generator RESET# WE# BYTE# Input/Output Buffers State Control Command Register PGM Voltage Generator Chip Enable Output Enable Logic CE# OE# VCC Detector Address Latch STB Timer A0–A19 Am29LV160D 12 STB Data Latch Y-Decoder Y-Gating X-Decoder Cell Matrix CONNECTION DIAGRAMS A15 A14 A13 A12 A11 A10 A9 A8 A19 NC WE# RESET# NC NC RY/BY# A18 A17 A7 A6 A5 A4 A3 A2 A1 A16 BYTE# VSS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 VCC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 OE# VSS CE# A0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Standard TSOP Reverse TSOP 13 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 A16 BYTE# VSS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 VCC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 OE# VSS CE# A0 A15 A14 A13 A12 A11 A10 A9 A8 A19 NC WE# RESET# NC NC RY/BY# A18 A17 A7 A6 A5 A4 A3 A2 A1 CONNECTION DIAGRAMS RESET# A18 A17 A7 A6 A5 A4 A3 A2 A1 A0 CE# VSS OE# DQ0 DQ8 DQ1 DQ9 DQ2 DQ10 DQ3 DQ11 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 SO WE# A19 A8 A9 A10 A11 A12 A13 A14 A15 A16 BYTE# VSS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 VCC FBGA Top View, Balls Facing Down A6 B6 C6 D6 E6 A13 A12 A14 A15 A16 A5 B5 C5 D5 E5 F5 G5 H5 A9 A8 A10 A11 DQ7 DQ14 DQ13 DQ6 A4 B4 C4 D4 E4 F4 G4 H4 WE# RESET# NC A19 DQ5 DQ12 VCC DQ4 A3 B3 C3 D3 E3 F3 G3 H3 RY/BY# NC A18 NC DQ2 DQ10 DQ11 DQ3 A2 B2 C2 D2 E2 F2 G2 H2 A7 A17 A6 A5 DQ0 DQ8 DQ9 DQ1 A1 B1 C1 D1 E1 F1 G1 H1 A3 A4 A2 A1 A0 CE# OE# VSS Special Handling Instructions Special handling is required for Flash Memory products in FBGA packages. A 14 F6 G6 BYTE# DQ15/A-1 H6 VSS Flash memory devices in FBGA packages may be damaged if exposed to ultrasonic cleaning methods. The package and/or data integrity may be compromised if the package body is exposed to temperatures above 150°C for prolonged periods of time. PIN CONFIGURATION A0–A19 LOGIC SYMBOL = 20 addresses 20 DQ0–DQ14 = 15 data inputs/outputs DQ15/A-1 A0–A19 = DQ15 (data input/output, word mode), A-1 (LSB address input, byte mode) 16 or 8 DQ0–DQ15 (A-1) BYTE# = Selects 8-bit or 16-bit mode CE# = Chip enable CE# OE# = Output enable OE# WE# = Write enable RESET# = Hardware reset pin RY/BY# = Ready/Busy output (N/A SO 044) WE# RESET# BYTE# VCC = 3.0 volt-only single power supply (see Product Selector Guide for speed options and voltage supply tolerances) VSS = Device ground NC = Pin not connected internally 15 RY/BY# (N/A SO 044) HY57V641620HG 4 Banks x 1M x 16Bit Synchronous DRAM 8.1 HY57V641620HG DESCRIPTION The Hyundai HY57V641620HG is a 67,108,864-bit CMOS Synchronous DRAM, ideally suited for the main memory applications which require large memory density and high bandwidth. HY57V641620HG is organized as 4banks of 1,048,576x16. HY57V641620HG is offering fully synchronous operation referenced to a positive edge of the clock. All inputs and outputs are synchronized with the rising edge of the clock input. The data paths are internally pipelined to achieve very high bandwidth. All input and output voltage levels are compatible with LVTTL. Programmable options include the length of pipeline (Read latency of 2 or 3), the number of consecutive read or write cycles initiated by a single control command (Burst length of 1,2,4,8 or Full page), and the burst count sequence(sequential or interleave). A burst of read or write cycles in progress can be terminated by a burst terminate command or can be interrupted and replaced by a new burst read or write command on any cycle. (This pipelined design is not restricted by a `2N` rule.) FEATURES • Single 3.3±0.3V power supply Note) • Auto refresh and self refresh • All device pins are compatible with LVTTL interface • 4096 refresh cycles / 64ms • JEDEC standard 400mil 54pin TSOP-II with 0.8mm of pin pitch • Programmable Burst Length and Burst Type • All inputs and outputs referenced to positive edge of system clock - 1, 2, 4, 8 or Full page for Sequential Burst • Data mask function by UDQM or LDQM • Internal four banks operation - 1, 2, 4 or 8 for Interleave Burst • . 16 Programmable CAS Latency ; 2, 3 Clocks HY57V641620HG PIN CONFIGURATION VDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 VDD LDQM /WE /CAS /RAS /CS BA0 BA1 A10/AP A0 A1 A2 A3 VDD 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 54pin TSOP II 400mil x 875mil 0.8mm pin pitch VSS DQ15 VSSQ DQ14 DQ13 VDDQ DQ12 DQ11 VSSQ DQ10 DQ9 VDDQ DQ8 VSS NC UDQM CLK CKE NC A11 A9 A8 A7 A6 A5 A4 VSS PIN DESCRIPTION PIN PIN NAME DESCRIPTION CLK Clock The system clock input. All other inputs are registered to the SDRAM on the rising edge of CLK CKE Clock Enable Controls internal clock signal and when deactivated, the SDRAM will be one of the states among power down, suspend or self refresh CS Chip Select Enables or disables all inputs except CLK, CKE and DQM BA0,BA1 Bank Address Selects bank to be activated during RAS activity Selects bank to be read/written during CAS activity A0 ~ A11 Address Row Address : RA0 ~ RA11, Column Address : CA0 ~ CA7 Auto-precharge flag : A10 RAS, CAS, WE Row Address Strobe, Column Address Strobe, Write Enable RAS, CAS and WE define the operation Refer function truth table for details LDQM, UDQM Data Input/Output Mask Controls output buffers in read mode and masks input data in write mode DQ0 ~ DQ15 Data Input/Output Multiplexed data input / output pin VDD/VSS Power Supply/Ground Power supply for internal circuits and input buffers VDDQ/VSSQ Data Output Power/Ground Power supply for output buffers NC No Connection No connection 17 HY57V641620HG FUNCTIONAL BLOCK DIAGRAM 1Mbit x 4banks x 16 I/O Synchronous DRAM Self refresh logic & timer Internal Row counter 1Mx16 Bank 3 CLK Row active Column Pre Decoders UDQM Y decoders LDQM Bank Select A0 A1 Column Add Counter Address Registers Address buffers A11 BA0 BA1 Memory Cell Array Burst Counter Mode Registers CAS Latency 18 Data Out Control Pipe Line Control DQ0 I/O Buffer & Logic Column Active 1Mx16 Bank 0 Sense AMP & I/O Gate WE refresh 1Mx16 Bank 1 X decoders CAS 1Mx16 Bank 2 X decoders RAS State Machine CS Row Pre Decoders X decoders X decoders CKE DQ1 DQ14 DQ15 MT1389 8.2 MT1389 Progressive-Scan DVD Player SOC Specifications are subject to change without notice MediaTek MT1389 is a DVD player system-on-chip (SOC) which incorporates advanced features like high quality TV encoder and state-of-art de-interlace processing. The MT1389 enables consumer electronics manufacturers to build high quality, cost-effective DVD players, portable DVD players or any other home entertainment audio/video devices. Based on MediaTek’s world-leading DVD player SOC architecture, the MT1389 is the 3rd generation of the DVD player SOC. It integrates the MediaTek 2nd generation front-end analog RF amplifier and the Servo/MPEG AV decoder. The progressive scan of the MT1389 utilized a proprietary advanced motion-adaptive de-interlace algorithm to achieve the best movie/video playback. It can easily detect 3:2/2:2 pull down source and restore the correct original pictures. It also supports a patent-pending edge-preserving algorithm to remove the saw-tooth effect. Key Features DVD PUH Module CVBS, Y/C, Component MT1389L Applications FLASH Front-panel Remote SDPIF RF/Servo/MPEG Integration High Performance Audio Processor Motion-Adaptive, Edge-Preserving De-interlace 108MHz/12-bit, 6 CH TV Encoder Audio DAC DRAM DVD Player System Diagram Using MT1389 19 Standard DVD Players Portable DVD Players MT1389 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE General Feature List Super Integration DVD player single chip High performance analog RF amplifier Servo controller and data channel processing MPEG-1/MPEG-2/JPEG video Dolby AC-3/DTS/DVD-Audio Unified memory architecture Versatile video scaling & quality enhancement OSD & Sub-picture 2-D graphic engine Built-in clock generator Built-in high quality TV encoder Built-in progressive video processor Audio effect post-processor Audio input port High Performance Analog RF Amplifier Programmable fc Dual automatic laser power control Defect and blank detection RF level signal generator Speed Performance on Servo/Channel Decoding DVD-ROM up to 4XS CD-ROM up to 24XS Channel Data Processor Digital data slicer for small jitter capability Built-in high performance data PLL for channel data demodulation EFM/EFM+ data demodulation Enhanced channel data frame sync protection & DVD-ROM sector sync protection Servo Control and Spindle Motor Control Programmable frequency error gain and phase error gain of spindle PLL to control spindle motor on CLV and CAV mode Built-in ADCs and DACs for digital servo control Provide 2 general PWM Tray control can be PWM output or digital output Embedded Micro controller Built-in 8032 micro controller Built-in internal 373 and 8-bit programmable lower address port 20 1024-bytes on-chip RAM Up to 4M bytes FLASH-programming interface Supports 5/3.3-Volt. FLASH interface Supports power-down mode Supports additional serial port DVD-ROM/CD-ROM Decoding Logic High-speed ECC logic capable of correcting one error per each P-codeword or Q-codeword Automatic sector Mode and Form detection Automatic sector Header verification Decoder Error Notification Interrupt that signals various decoder errors Provide error correction acceleration Buffer Memory Controller Supports 16Mb/32Mb/64Mb/128Mb SDRAM Supports 16-bit SDRAM data bus Provide the self-refresh mode SDRAM Block-based sector addressing Support 3.3 Volt. DRAM Interface Video Decode Decodes MPEG1 video and MPEG2 main level, main profile video (720/480 and 720x576) Smooth digest view function with I, P and B picture decoding Baseline, extended-sequential and progressive JPEG image decoding Support CD-G titles Video/OSD/SPU/HLI Processor Arbitrary ratio vertical/horizontal scaling of video, from 0.25X to 256X 65535/256/16/4/2-color bitmap format OSD, 256/16 color RLC format OSD Automatic scrolling of OSD image Slide show transition as DVD-Audio Specification 2-D Graphic Engine Support decode Text and Bitmap Support line, rectangle and gradient fill Support bitblt Chroma key copy operation Clip mask MT1389 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Audio Effect Processing Dolby Digital (AC-3)/EX decoding DTS/DTS-ES decoding MLP decoding for DVD-Audio MPEG-1 layer 1/layer 2 audio decoding MPEG-2 layer1/layer2 2-channel audio High Definition Compatible Digital (HDCD) Windows Media Audio (WMA) Advanced Audio Coding (AAC) Dolby ProLogic II Concurrent multi-channel and downmix out IEC 60958/61937 output - PCM / bit stream / mute mode - Custom IEC latency up to 2 frames Pink noise and white noise generator Karaoke functions - Microphone echo - Microphone tone control - Vocal mute/vocal assistant - Key shift up to +/- 8 keys - Chorus/Flanger/Harmony/Reverb Channel equalizer 3D surround processing include virtual surround and speaker separation 21 TV Encoder Six 108MHz/12bit DACs Support NTSC, PAL-BDGHINM, PAL-60 Support 525p, 625p progressive TV format Automatically turn off unconnected channels Support PC monitor (VGA) Support Macrovision 7.1 L1, Macrovision 525P and 625P CGMS-A/WSS Closed Caption Progressive Output Automatic detect film or video source 3:2 pull down source detection Advanced Motion adaptive de-interlace Edge Preserving Minimum external memory requirement Audio Input Line-in/SPDIF-in for versatile audio processing Outline 256-pin LQFP package 3.3/1.8-Volt. Dual operating voltages A B C D E F From MPEG Board 1 1 2 3 4 5 XS401 1 2 3 4 5 6 7 7PIN/2.0 XS402 5PIN/2.0 2PIN/2.0 C409 101 IR BEAD1 STB CLOCK DATE LED_B L402 BEAD1 L401 D402 C410 IN4148 C411 102 101 VCC 2 1K R410 R412 10K VCC POWER_LED Seg2 KEY1 D401 LED VCC V401 8050D R409 33R(1/4W) O/C K401 Stop K402 LED403 LED C405 104 3 Seg4 Seg5 Seg6 Seg1 Seg2 Seg3 DATE CLOCK STB KEY1 KEY2 KEY3 51K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 R405 3 U401 PT6961 LED402 LED_MODULE_ZDC6-2004YRGB-A 4 日期 6.24 4 OSC GND DOUT GR1 DIN GR2 CLK GND STB GR3 K1 GR4 K2 GND K3 VDD VDD GR5 SEG1/KS1 GR6 SEG2/KS2 SEG12/GR7 SEG3/KS3 SEG11 NC SEG10/KS10 SEG4/KS4 SEG9/KS9 SEG5/KS5 SEG8/KS8 SEG6/KS6 SEG7/KS7 更改 数量 更改单号 签 名 设 计 Zhiyong Deng 审 核 标准化 批 准 R414 220 LED404 LED VCC R413 220 R408 0R/NC IN4148 LED401 LED(backgroud) 470 R411 Seg1 Play 1 2 VCC DATE CLOCK K403 C403 101 C402 101 C401 101 STB XS403 10K R403 10K R402 10K R401 2 Grid1 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 5 板号: 4975-0 5 主面板电原理图 C408 104 VCC U402 HS0038B3V IR 质量 共 １ 张 C407 101 6 数量 版次：1.0 6 广东步步高电子工业有限公司ＡＶ厂 比例 第 １ 张 ＢＢＫ 10K DZ401 3.3V/0.5W/option R406 C406 104 100 TC401 100uF/16V R407 DV975 VCC Seg9 Seg8 Seg7 Grid5 Grid6 Grid7 LED Grid3 Grid4 Grid1 Grid2 1 Grid1 Grid2 2 Grid2 TC402 VCC 1 2 Grid3 3 Grid3 Grid4 4 Grid4 Grid5 5 Grid5 Grid6 6 Grid6 Grid7 7 Grid7 Seg1/ks1 8 Seg1 Seg2/ks2 9 Seg2 Seg3/ks3 10 Seg3 Seg4/ks4 11 Seg4 Seg5/ks5 12 Seg5 Seg6/ks6 13 Seg6 Seg7/ks7 14 Seg7 Seg8/ks8 15 Seg8 Seg9/ks9 16 100uF/16V Seg9 3 22 1 2 1 A B C D E F 9.0 SCHEMATIC & PCB WIRING DIAGRAM FRONT SCHEMATIC DIAGRAM FRONT SCHEMATIC DIAGRAM 23 24 A B C D 1 1 24 XS901 5PIN/2.0 1 2 3 4 5 XS902 2PIN/2.0 1 2 LED901 LED(backgroud) 2 日期 K901 STANDBY 更改 数量 更改单号 签 名 设 计 Zhiyong Deng 审 核 标准化 批 准 2 DV975A 3 板号 : 4975A-0 主面板电原理图 3 质量 共 １ 张 数量 版次：1.0 4 广东步步高电子工业有限公司ＡＶ厂 比例 第 １ 张 ＢＢＫ 4 A B C D SUBSIDIART BOARD SCHEMATIC DIAGRAM SUBSIDIART BOARD SCHEMATIC DIAGRAM 25 F E D C B 1 F502 ! BCN502 SW-SPST T1.6AL250V ! ! ! ! D501 1N4007 ! 1 ! F501 T1.6AL250V 1 2 L501 4 BCN501 ~220V BCN503 ~220V 2 1 3 2 U501 VIPER22 R501 680K 1/2W L503 FB TC501 47uF/400V BC501 ~275V 104 D504 1N4007 D503 1N4007 2 5 6 7 8 2 VDD FB D D D D S S D502 1N4007 2 1 2 1 26 1 2 A 1 4 3 C503 101/1KV R503 39K/2W C506 473 C504 104 R512 9.1K TC502 47uF/50V R505 33R D505 HER107 C502 103/1KV ! 3 4 U502 PH817 2 1 BC505 ~275V 221 2 BC504 ~275V 221 1 T501 10 7 3 BCK-28-519S 11 6 BC503 ~275V 221 ! D506 HER105 12 4 15 13 9 16 3 2 ! 3 14 2 1 R506 330 1K(NC) R517 R507 1K(NC) D511 HER105 D512 HER105 C519 104 HER303 C516 104 R5161K(NC) D513 SR303 C518 104 D510 JP504 0R(NC) D507 HER105 D508 HER105 U503 LM431A TC512 47uF/50V TC511 100uF/16V A K JP501 0R R502 0R C515 104 R509 10K/1% R508 3.3K/1% JP502 0R 更改 数量 更改单号 设 计 审 核 标准化 批 准 4 C517 104 JP506 0R(NC) FL- FL+ C511 104 TC508 470uF/10V(nc) L509 10uH/1A(option) C508 104 C510 104 TC506 1000uF/10V 0R(NC) JP505 TC504 470uF/16V TC510 1000uF/10V 2.5V R 0R(NC) JP519 JP508 0R(NC) TC514 1000uF/10V L508 10uH/2A TC505 1000uF/10V L507 10uH/2A TC515 1000uF/10V LED+5V TC503 470uF/16V L505 10uH/1A 4 签 名 ZD502 10V/0.5W R511 1.5K +3.3V +5V SA+5V 日期 2004.4.16 Q501 8550D R515 220R/1/4W ZD501 5.1V/0.5W R514 220 R513 1K +9V 5 TC507 47uF/16V JP507 0R(NC) -21V 5 数量 版次： 1.0 6 广东步步高电子工业有限公司AV厂 质量 共 1 张 板号: 5977SB BBK To Microphone Board CN501 13P2.0mm CN503 2P2.0mm CN502 11P2.0mm To Mpeg Board 比例 第 1 张 DV977 1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 1 2 3 4 5 6 7 8 9 10 11 开关电源电原理图 C512 104 -9V AGND MIC-DET OKA AGND +9V -9V GND +5V GND +3.3V FL+ FL-21V LED+5V GND MIC-DET OKA AGND +9V -9V GND +5V GND +3.3V GND SA+5V 6 F E D C B A POWER BOARD SCHEMATIC DIAGRAM POWER BOARD SCHEMATIC DIAGRAM 27 28 A B C CK3-6.35-24 MIC601 MIC602 4 3 2 1 CK3-6.35-24 1 BEAD L604 L601 BEAD BEAD L603 L602 BEAD C603 103 R604 560R C604 103 TC602 4.7uF/16V R602 22K R608 1K R607 1K R603 560R TC606 22uF/16V R601 22K TC601 4.7uF/16V TC605 22uF/16V R606 10K 5 6 R605 10k 3 2 C605 100p 4 8 1 -9VA GND602 GND TC604 4.7uF/16V GND601 GND 7 TC603 4.7uF/16V R618 10K R623 10K R611 5.1K R612 5.1K 2 更改 数量 更改单号 签 名 设 计 Z.Y.Deng 审 核 标准化 批 准 U601B 4558 C606 100p R610 10K +9VA 4558 U601A R609 10K 2 R616 330 R615 100K 日期 +5V 3 2 C607 R613 5.1K 4 8 D 1 5 6 100P 1 +9VA U602B 4558 7 DV975 100 R619 C608 102 4.7uF/16V TC613 3 板号 : 6975A-0 C601 104 +9VA C602 104 -9VA 6P2.0mm 1 2 3 4 5 6 XS601 +5V -9V +9V AGND OK DET 比例 第 １ 张 质量 共 １ 张 数量 版次： 1.0 ＢＢＫ ＡＶ ＲＤ３ R620 1K DET TC615 47uF/16V R621 10ohm 1/6W TC616 47uF/16V R622 10ohm 1/6W 4 4 广东步步高电子工业有限公司ＡＶ厂 +9V -9V VD602TC611 IN414847uF/16V IN4148 VD603 VD601 IN4148 +5V R617 100K OK MIC板电原理图 U602A 4558 -9VA 3 A B C D OK SCHEMATIC DIAGRAM OK SCHEMATIC DIAGRAM 29 F E D C B 1 XS03 XS702 3 2 1 L AGND R PDAT0 PDAT2 R704 4.7K VCC VGND XS28 XS701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 IN4148 IN4148 D701 D702 2 R714 2.2K VGND R713 0R R715 0R VGND AGND AGND LFE +10V CC SR SL R VIEDO PDAT0 L Pb Y1 Pr C C707 105 R705 75R PDAT2 PDAT1 SPDIF VCC Y AGND V703 8050 R711 1K A+10V AGND C723 102 V702 8050 R708 33R A+10V AGND VGND C724 102 R712 2.2K 2.2K R710 330R +10V R709 C727 102 V701 8050 C Y C719 TC706 TC705 C718 VIEDO AGND VGND L711 FBSMT 104 104 FBSMT 220uF/16V L712 220uF/16V 104 C721 2.2R R706 3 VGND 5.1V/0.5W ZD703 5.1V/0.5W ZD702 5.1V/0.5W ZD701 ZD704 5.1V/0.5W AGND L714 FCM C726 AGND 104 L713 FCM TC701 220uF R715 47K C716 102 VCC 3 VJS3921 2 VGND 105 105 1 2 6 5 VGND C713 20 18 16 14 12 10 8 6 4 C712 L715 FBSMT L716 FBSMT VGND 68R R703 A(B)OUT A(B)IN A(A)OUT A-COM RETURN A(A)IN BLUE I/O FUNC SW RETURN CONT GREEN I/O NC RETURN RETURN RED I/O BLK I/O RETURN TRTURN V-OUT V-IN GND JK706 FBSMT L710 SPDIF 21 19 17 15 13 11 9 7 5 3 1 104 C725 C711 104 AGND S-VIDEO JK703A JK703B S-OUT VCC VGND C728 104 A+10V 7 2 3 30 4 A 1 3 2 更改 数量 更改单号 设 计 审 核 标准化 批 准 4 GND VCC JK705 OPTICAL 1 VIN 4 签 名 Pr Pb SPDIF Y1 日期 FBSMT 5 VGND LFDV965 FBSMT L708 FBSMT L707 AGND 板号: 7969BSB AV 输出板原理图 220uF/16V R C722 104 TC704 C706 102 C705 102 C704 102 C703 102 C702 102 C701 102 L709 R702 100R 220R R701 G FB L706 FB L705 FB L704 FB L703 FB L702 FB L701 220uF/16V B VGND C717 104 TC703 C710 104 TC702 1000uF/10V C720 104 R L SR SL LFE CC 5 12 10 3 11 8 5 2 5 2 RED WHITE JK701 AV8 质量 共 1 张 数量 版次：1.0 6 广东步步高电子工业有限公司AV厂 RED BLUE BLACK GREEN 比例 1:1 第 1 张 BBK RCA-407 6 4 3 1 JK702 9 7 6 4 1 6 F E D C B A OUTPUT BOARD SCHEMATIC DIAGRAM OUTPUT BOARD SCHEMATIC DIAGRAM 31 Ｆ Ｅ Ｄ Ｃ Ｂ Ａ R319 150K C305 104 C303 104 １ AGND 22 23 24 25 26 27 28 V307 8050D V306 8550D VGND 2.2R\1/4W R326 R325 (TRCLOSE1) 510R TROPEN LOAD- R323 1.5K R340 1R(DNS) TC308 47uF/16V 222 680K R320 150K C308 101(DNS) R317 C307 TRSO V1P4 STBY 20K 151 R313 10K R321 1R C304 GND FMSO R312 SL+ SLVCC C302 104 C312 104 C311 104 VCC V310 9014-S R327 510R R324 1.5K V1P4 SP- C310 222 ADIN OPOP+ OPO VINFFC VOSL VINSLVINSL+ CF2 CF1 VINFC V309 8550D V308 8050D R322 680K R318 0R U302 BA5954 PREGND VINLD CTK2 CTK1 VINTK BIAS STBY VOFC+ VOFCVO2+ VOSLPGND PVCC1 VCC F B A RFO IOA D C V20 E MDI1 C301 104 100K AVCC R310 VOTK+ VOTKVOLD+ VOLDPGND VNFTK PVCC2 R303 L312 L314 L316 L317 L318 L319 L320 L321 L322 L323 L324 15 16 17 18 19 20 21 0R FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT L310 L311 R304 1R FBSMT FBSMT L304 L305 L306 L307 L308 FBSMT 4.7uH FBSMT FBSMT 4.7uH FBSMT FBSMT L301 L303 V304 2SK3018-S 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 V303 XS301 2SK3018-S 24P0.5mm R305 1R V305 3904-S IOA 10K R339 (TRCLOSE1) TROPEN (TROPEN1) TRCLOSE LOAD+ V18 C306 151 L235 FBSMT 89V33 ２ DV33 R330 10K R329 10K 102 C253 104 TRO FOO 105 C333 102 C255 C250 104 TDI TMS TCK TDO ３ 105 C330 GND C249 104 C215 152 USBVDD ADIN TROUT TRIN STBY TRCLOSE V18 A2 A3 A4 A5 A6 A7 A8 A18 A19 18K 20K L202 33R 105 C331 MDI1 MDI2 FEO TEO TEZISLV OPO OPOP+ 10K DMO 15K FMO TROPEN RFOP RFON 0R(DNS) 0R 0R 0R 0R 0R R221 330R TROUT R277 330R TRIN C252 104 89V33 C240 105 105(DNS) 105 105 105 105 C229 104 C238 104 R228 C248 104 C258 104 C214 104 C213 331 C247 104 R212 0R C257 104 C246 104 C294 C251 104 C245 104 C309 104 C244 104 AVDD3 L236 FBSMT DV33 C256 104 L201 FBSMT C212 331 R210 R211 DMSO R208 FMSO R209 C207 104 R2165 V2P8 V20 V1P4 LDO2 LDO1 DV33 E F R201 R202 R203 R204 C205 C204 D C206 101 C203 C202 B A C201 C C B A D SUBA SUBB SUBC SUBD RFO R2166 0R(DNS) C211 89V33 104 C210 153 V1P4 C2174 104 XS302 5P2.0mm 1 LOAD2 LOAD+ 3 4 GND 5 C297 102 LIMIT C254 104 105 C322 TRSO FOSO 105 C321 105 C318 C317 105 105 105 C320 C319 C230 104 L234 RFV18 FBSMT 104 C237 104 C243 104 R281 330R C2167 104 R316 20K R315 20K SPSP+ DMSO R306 1R 104 C236 C241 C242 104 R307 1R TC303 47uF/16V LDO-AV33 R2164 10K GND SP+ SL+ SL- FOSO V1P4 TC309 47uF/16V 1 2 3 4 5 6 XS303 XS06 7 6 5 4 3 2 1 14 13 12 11 10 9 8 DQS0 V302 2SB1132-S LDO1 V301 2SB1132-S R331 0R 104 C235 L309 DV33V18 FBSMT 104 C234 TC302 47uF/16V LDO2 LDO-AV33 VCC R302 10R R301 10R TC301 220uF/16V 104 C231 DV33 VREFN PWR# PCE# PRD# 105 C332 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 C239 104 AVDD3 AGND DVDA DVDB DVDC DVDD DVDRFIP DVDRFIN MA MB MC MD SA SB SC SD CDFON CDFOP TNI TPI MDI1 MDI2 LDO2 LDO1 SVDD3 CSO/RFOP RFLVL/RFON SGND V2REFO V20 VREFO FEO TEO TEZISLV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1/V_ADIN9 TRO FOO USB_VSS USBP USBM USB_VDD3 FG/V_ADIN8 TDI/V_ADIN4 TMS/V_ADIN5 TCK/V_ADIN6 TDO/V_ADIN7 DVDD18 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 HIGHA0 IOA18 IOA19 DVSS APLLCAP APLLVSS R297 R298 R299 104 C2175 C2175 104 R224 C228 104 C227 104 C226 104 C225 333 C224 104 0R 0R 0R DWR# DCE# DRD# PWR# A16 A15 A14 A13 A12 A11 10K 100K ４ V1P4 C222 C223 20pF 102 DV33 VREFN VREFP A10 A9 A20 PCE# A1 PRD# R223 15K VREFP TC202 10uF/16V C220 473 C219 473 C221 105 DV33 AD0 AD1 AD2 AD3 ３ DV33 AD4 AD5 AD6 A21 ２ JITFN C218 474 JITFO XI XO RFV18 MT1389 U201 AD7 A17 A0 AVCC ASPDIF AMDAT V18 10K R311 RESET# V18 MUTE_DAC ASDAT2 ASDAT1 ASDAT0 VSCK VSDA VSTB SCL SDA R309 ５ ACLK ABCK ALRCK 89V33 RXD TXD 100K R215 1K FS0 FS1 URST# IR R308 DQM0 DQS0 DQ7 １ Y6 Y5 DQ6 DQ5 29 30 Y4 DQ4 DQ3 GND GND R227 JITFO C233 Y2 Y3 ６ JITFN R213 1K 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 Y0 510R DMA8 DMA9 DMA11 DCKE DCLK DMA7 DMA4 DMA5 DMA6 DQ27 DQ28 DQ29 DQ30 DQ31 DQ26 DQ22 DQ23 DQM2 DQM3 DQ24 DQ25 DQ17 DQ18 DQ19 DQ20 DQ21 DQ9 DQ10 DQ11 DQ12 DQ13 RAS# CAS# WE# DQM1 LIMIT DQ8 BA0 CS# DMA0 DMA10 BA1 DMA3 DMA2 DMA1 DCLKB DQ16 R214 FS C216 105 C329 104 105 104 89V33 V18 C328 C217 L203 DACVDD3 FBSMTDV33 VOICE-DET R2160 0R(DNS) HSYNC# VSYNC# 750K 101 YUV0/CIN FS VREF DACVDDC RD16 RD17 RD18 RD19 RD20 RD21 DVDD3 RD22 RD23 DQM2 DQM3 RD24 RD25 DVSS RD26 DVDD18 RD27 RD28 RD29 RD30 RD31/ASDATA5 DVDD3 RA4 RA5 RA6 DVSS RA7 DVSS RA8 RA9 RA11 CKE RCLK DVDD3 RCLKB RVREF/V_ADIN3 DVDD18 RA3 RA2 RA1 DVSS RA0 RA10 BA1 DVSS BA0 RCS DVDD3 RAS CAS RWE DQM1 DQS1 RD8 DVSS RD9 RD10 RD11 DR12 RD13 DQ2 DQ1 DQ0 DQ15 R314 10K Y1 256 255 254 253 252 251 250 249 248 247 246 245 244 243 242 241 240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 AVDD3 IREF RFGC OSN OSP CEQN CEQP RFGND CRTPLP HRFZC RFRPAC RFRPDC RFVDD3 S_VREFN S_VREFP ADCVSS S_VCM ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 IDACEXLP PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 SPDIF MC_DATA DVSS ASDATA4 DVDD18 ASDATA3 ASDATA2 ASDATA1 ASDATA0 DVSS ACLK ABCK ALRCK DVDD3 SPBCK/ASDATA5 SPLRCK SPDATA SPMCLK HSYNC/V_ADIN2 YUV7/ASDATA5 VSYNC/V_ADIN1 DVDD3 YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/C DACVDDB YUV1/Y DACVSSC APLLVDD3 IOWR A16 HIGHA7 HIGHA6 HIGHA5 HIGHA4 HIGHA3 DVDD3 HIGHA2 HIGHA1 IOA20 IOCS IOA1 IOOE DVDD3 AD0 AD1 AD2 AD3 DVSS AD4 AD5 AD6 IOA21/V_ADIN0 ALE AD7 A17 IOA0 DVSS UWR URD DVDD18 UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 UP1_7 UP3_0 UP3_1 UP3_4 UP3_5 DVDD3 ICE PRST IR INT0 DQM0 DQS0 RD7 DVSS RD6 RD5 DVSS RD4 RD3 DVDD18 RD2 RD1 RD0 RD15 DVDD3 RD14 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 DQ14 32 Ｆ Ｅ Ｄ Ｃ Ｂ Ａ Ｂ Ｆ Ｅ Ｄ Ｃ XS201 7 6 5 4 3 2 1 Ａ AGND FS1 1 2 3 4 DV33 75R R233 1 2 3 4 5 6 7 8 9 10 11 12 13 １ AGND +9V DV33 RXD TXD GND L225 1K(DNS) C324 R237 0R 0R(DNS) R236 102 VIDEO_COMP R234 75R VIDEO_U VIDEO_Y1 VIDEO_V VIDEO_C VCC VIDEO_Y HSYNC# VSYNC# ASTB VGND AGND LFE Cc SR SL Rt Lt NC NC DQMH DQML WE CAS RAS CS CKE CLK A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 BA/A11 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 XS28 XS204 R252 100K 104 104 VSS VSS VSSQ VSSQ VSSQ VSSQ VCCQ VCCQ VCCQ VCCQ VCC VCC DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 C325 105 ２ R2184 10K VD201 1N4148 DV33 104 C271 DV33 C2166 104 26 50 4 10 41 47 7 13 38 44 1 25 104 R254 1K Q204 9015-S C278 102 5 C2145 104(DNS) R271 0R(DNS) 0R R251 U205C HCU04 R205 510R VD IEC958 C272 104 6 R21820R(DNS) ３ DDQM3 DDQM2 DWE# DCAS# DRAS# DDBA1 10 DCE# DRD# DWR# URST# A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 12 HCU04 U205F 13 C2173 104 NC NC DQMH DQML WE CAS RAS CS CKE CLK A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 BA/A11 /CE /OE /WE /RESET A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 NC ３ C279 104 GND1 GND2 AD0 AD1 AD2 AD3 AD4 AD5 AD6 AD7 R272 0R(DNS) A19 ASPDIF TC204 47uF/16V C273 104 13 32 VCC DV33 L204 FB(DNS) 0R R255 C2146 104(DNS) RN205 RN206 RN207 RN208 C323 104 VD XI ４ CS# RAS# CAS# WE# 4 3 2 1 C2158 27pF(DNS) L249 2.7uH(DNS) R244 0R(DNS) R243 91R/1% R242 200R/1% R241 4.7K(DNS) 1 A19 A18 A8 A7 A6 A5 A4 A3 A2 A16 A15 A14 A13 A12 A11 A10 A9 AA20 AA21 DWR# URST# VP UPA[20..0] UPD[15..0] 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 C275 X201 27pF 27MHz R245 0R R246 100K U205A HCU04 DV33 5 6 7 8 33R 33R 23 24 25 26 29 30 31 32 33 34 22 35 20 21 2 3 54 41 28 36 40 15 39 19 18 17 16 R247 0R A15 A14 A13 A12 A11 A10 A9 A8 A19 NC WE RESET NC NC RY/BY A18 A17 A7 A6 A5 A4 A3 A2 A1 U214 0R(DNS) C276 27pF R248 DQM0 DQM1 DCS# DRAS# DCAS# DWE# SDCLK 38 SDCKE 37 DMA0 DMA1 DMA2 DMA3 DMA4 DMA5 DMA6 DMA7 R232 DMA8 33R DMA9 DMA10 MA11 BA0 #BA1 RN209 33R R231 33R DCLK R263 DCKE R264 DQ16 DQ17 DQ18 DQ19 DQ20 DQ21 DQ22 DQ23 DQ24 DQ25 DQ26 DQ27 DQ28 DQ29 DQ30 DQ31 DMA11 U209 LM1117MP-1.8(DNS) C232 20pF 0R(DNS) 0R(DNS) 0R(DNS) 0R(DNS) TC209 220uF/16V SD33 DDQ0 DDQ1 DDQ2 DDQ3 DDQ4 DDQ5 DDQ6 DDQ7 DDQ8 DDQ9 DDQ10 DDQ11 DDQ12 DDQ13 DDQ14 DDQ15 L228 FBSMT 26 50 4 10 41 47 7 13 38 44 1 25 2 3 5 6 8 9 11 12 39 40 42 43 45 46 48 49 2 A18-U220 R275 A18 0R(DNS) 33 VD 23 15 17 19 21 24 26 28 30 16 18 20 22 25 27 29 31 TC237 47uF/16V VD VCC /BYTE A18 D0 D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14 D15 0R R2159 TC246 47uF/16V V18 VSS VSS VSSQ VSSQ VSSQ VSSQ VCCQ VCCQ VCCQ VCCQ VCC VCC DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 U204 SDRAM 512*16*2 U215 AM29F800BT-120SC(SOP)(DNS) 11 URST# R256 33R 12 14 43 44 11 10 9 8 7 6 5 4 42 41 40 39 38 37 36 35 34 3 1 U205E VCC C2172 104 R250 0R(DNS) L205 C2171 104 AVCC HCU04 C2170 104 DCS# R262 0R(DNS) 33 37 36 14 15 16 17 18 SDCKE 34 SDCLK 35 DMA0 21 DMA1 22 DMA2 23 DMA3 24 DMA4 27 DMA5 28 DMA6 29 DMA7 30 DMA8 31 DMA9 32 DMA1020 BA0 19 BA1 R2183 0R(DNS) DDBA1 DQM3 DDQ0 DDQ1 DDQ2 DDQ3 DDQ4 DDQ5 DDQ6 DDQ7 DDQ8 DDQ9 DDQ10 DDQ11 DDQ12 DDQ13 DDQ14 DDQ15 R21810R(DNS) 0R(DNS) 0R(DNS) 0R(DNS) 0R(DNS) DQM2 RN201 RN202 RN203 RN204 SD33 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 C2169 TC210 47uF/16V C2168 104 104 TC208 TC207 220uF/16V 220uF/16V C2164 104 C270 VCC C269 +9V VOICE-DET C2163 104 C268 -9V C291 102(DNS) R283 330R(DNS) C283 C2162 104(DNS) 104 OKA GND C267 104 R290 0R(DNS) 33 37 DQM1 36 DQM0 14 DWE# 15 DCAS# 16 DRAS# 17 DCS# 18 SDCKE 34 SDCLK 35 R287 0R(DNS) C261 102(DNS) R260 680R 2 3 5 6 8 9 11 12 39 40 42 43 45 46 48 49 casecade:use RN201,RN202,RN203,RN204,R287,R290,R2183 NC RN205,RN206,RN207,RN208,R262,R2181,R2182 normal mode : use RN205,RN206,RN207,RN208,R262,R2181,R2182 NC RN201,RN202,RN203,RN204,R287,R290,R2183 修改日期：2004-6-10 GND AVCC MUTE_DAC MUTEA FBSMT(DNS) C282 104 SD33 C266 47pF DDQM3 DDQM2 VCC GND VSTB VSCK VSDA FS0 R230 10K(DNS) IR C260 102(DNS) L224 FBSMT(DNS) L219 R259 C259 680R 104 SCL SDA FBSMT FBSMT FBSMT FBSMT C281 104 C265 47pF R229 10K 8 7 6 5 L218 FBSMT(DNS) C280 104 C264 47pF L230 L231 L232 L233 L229 FBSMT C262 47pF DC/NC VCC RST_/NC RST/WP WP/RST_ SCL VSS SDA L226 FB R332 330R(DNS) IEC958 XS202 XS04(DNS) XS203 XS13 DV33 C263 47pF XS07 1 2 3 4 U202 AT24C02 ２ U203 SDRAM 512*16*2 4.7K 4.7K R238 R239 DMA0 21 DMA1 22 DMA2 23 DMA3 24 DMA4 27 DMA5 28 DMA6 29 DMA7 30 DMA8 31 DMA9 32 DMA1020 BA0 19 R258 0R DV33 4.7K R240 BA1 GND OUT IN １ 4.7K R2140 A21 A20 VSS VSS VSS 4 0R R222 GND A0 AD7 AD14 AD6 AD13 AD5 AD12 AD4 VD AD11 AD3 AD10 AD2 AD9 AD1 AD8 AD0 DRD# GND DCE# A1 A17 C277 10pF(DNS) XI Y4 Y1 Y2 Y3 C2160 104 SD33 SD33 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 XTALI 6 12 46 52 3 9 43 49 1 14 27 2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53 ５ R249 10R(DNS) 8M_FLASH(TSOP) 48 A16 47 BYTE 46 Vss 45 DQ15/A-1 44 DQ7 43 DQ14 42 DQ6 41 DQ13 40 DQ5 39 DQ12 38 DQ4 37 Vcc 36 DQ11 35 DQ3 34 DQ10 33 DQ2 32 DQ9 31 DQ1 30 DQ8 29 DQ0 28 OE 27 Vss 26 CE 25 A0 XO U205B HCU04 C274 104 VSSQ VSSQ VSSQ VSSQ VCCQ VCCQ VCCQ VCCQ DQML DQMH NC NC VCC VCC VCC /CS /RAS /CAS /WE CLK CKE DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 U211 SDRAM 64M A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 BA0/A13 BA1/A12 DV33 14 7 1 2 3 R257 0R 33 VGND 75R R276 VGND R280 75R Y6 Y5 VGND R273 75R VGND R270 75R VGND R274 75R VGND R261 75R VGND C2152 104 VCC C2104 47pF C2101 47pF C298 47pF C295 47pF C292 47pF C289 47pF C2151 104 1.8UH L248 1.8UH L247 1.8UH L246 1.8UH L245 1.8UH L244 1.8UH L243 C2150 104 C2105 47pF C2102 47pF C299 47pF C296 47pF C293 47pF C290 47pF ６ VD211 1N4148 VD213 1N4148 VD215 1N4148 VD217 1N4148 VD219 1N4148 VIDEO_U VD218 1N4148 VGND VD221 1N4148 VIDEO_V VD220 1N4148 VGND VCC VIDEO_Y1 VD216 1N4148 VGND VCC VIDEO_COMP VD214 1N4148 VGND VCC VCC VIDEO_Y VD212 1N4148 VGND VCC VIDEO_C VD210 1N4148 VGND VCC Ｅ Ｄ Ｃ Ｂ Ａ Ｆ Ｅ Ｄ Ｃ Ｂ DV33 C2142 104 C2139 104 １ C284 104(DNS) SLRCK SACLK SBCLK AMDAT R289 R288 4.7K(DNS) 47K(DNS) DV33 AGND C2141 104 -9V AGND C2138 104 +9V C287 104(DNS) 1 2 3 4 5 6 7 8 R268 0R(DNS) R269 0R(DNS) DV33 C2143 104 C2140 104 R284 0R(DNS) R285 Ａ 0R(DNS) R2113 100K R2112 100K R2111 100K R2116 100K R2115 100K U210 CS5333(16)(DNS) RST VQ AINL AINR REF_G FILT+ TST DIF R278 0R(DNS) 16 15 14 13 12 11 10 9 AGND AGND 16 15 14 13 12 11 10 9 R2117 ２ C288 102(DNS) R2180 105(DNS) 150R(DNS) C286 C327 105(DNS) 105(DNS) CH-R MUTE1 LL AVCC AGND RR AGND VQ# FILT+ C285 C326 105(DNS) R2128 1K Q210 2SC1815-YS R2127 1K Q209 2SC1815-YS 1K 1K R2126 1K R2125 1K Q208 2SC1815-YS R2124 R2123 1K Q207 2SC1815-YS 1K R2122 R2121 1K Q206 R2120 2SC1815-YS 1K R2119 1K 1K Q205 2SC1815-YS R2118 MUTEC AOUTA VA AGND AOUTB REF-GND VQ FILT+ U206 CS4340(DNS) RST SDA SCLK LRCK MCLK DIF1 DIF0 DEM0 R2114 100K R279 0R(DNS) VL MCLK SCLK SDATA VA GND LRCK DIN Cc LFE SL AGND SR Lt Rt R286 0R(DNS) 1 2 3 4 5 6 7 8 OKA RESET# CH-C CH-SW CH-SL ASDAT0 ASDAT1 ACLK ALRCK ABCK ASDAT2 10uF/16V TC224 10uF/16V TC223 10uF/16V TC222 10uF/16V TC221 10uF/16V TC241 MUTE-1 CH-SR CH-L 10uF/16V TC240 ３ R294 R295 8 7 6 5 RN210 33R 1 2 3 4 7 33R 33R 1 7 U220A 4580 3 2 101 24K U219B 4580 5 6 101 24K 3 U221A 4580 2 C2123 101 4580 U221B 5 SDATA0 SDATA1 4.7K 4.7K 4.7K 4.7K AGND C2127 102 R2151 R2150 AGND C2124 102 R2147 AGND C2133 122 R2153 6.8K C2136 122 R2155 6.8K C2135 122 R2154 6.8K C2121 102 R2143 MUTE3 MUTE2 SL# R207 0R VD209 1N4148 VD208 1N4148 VD207 1N4148 /C SW R206 0R L R MUTE1 C208 102(DNS) OKA AGND R2152 6.8K C2130 122 24K(DNS) R226 4.7K AGND C2118 102 4.7K C2129 122 OKA C2116 102(DNS) AGND R2148 6.8K 24K(DNS) R2156 C2122 122 R2136 6.8K 24K(DNS) R2132 ４ 24K(DNS) R225 R2139 AGND R2142 4.7K R2138 4.7K 4.7K C2115 102 R2135 R2134 AGND 4.7K C2126 101 6 4.7K 4.7K C2112 102 R2131 R2130 R2146 101 R2145 24K 5 U220B 4580 6 C2120 R2141 24K SACLK SLRCK SBCLK SDATA2 -9V 3 2 U219A 4580 R2149 24K +9V -9V +9V -9V -9V +9V C2117 R2137 -9V +9V C2114 -9V R2133 +9V 1 7 1 101 24K C2111 +9V R2129 8 4 8 4 8 4 RESET# SDATA0 SBCLK SLRCK SACLK ３ 8 4 8 4 ２ 8 4 １ R2102 1K R2101 10K SR# R282 0R RESET# SCL SDA -9V 2 Q211 1015-S TC238 100uF/10V TC230 10uF/16V TC229 10uF/16V TC228 10uF/16V VLS SDIN1 SDIN2 SDIN3 SCLK LRCK MCLK VD GND RST SCL SDA CS VLC 10K R2105 R2104 1K 1K 1 R2103 MUTEA +9V 10uF/16V TC227 10uF/16V TC226 1 2 3 4 5 6 7 8 9 10 11 12 13 14 10uF/16V C2154 104 TC225 VCC C2153 104 SDATA0 SDATA1 SDATA2 SBCLK SLRCK SACLK DV33 ５ 2 1 34 R2106 10K U207 CS4360 C# LFE# LS RS LL RR AGND AGND 2 R2108 10K VD205 1N4148 Q218 1015-S Q219 1015-S TC232 10uF/16V MUTE-1 1 AVCC TC233 10uF/16V VOICE-DET C2157 104 C2156 104 FILT+ C# LFE# MUTE3 VQ# MUTE1 LL RR MUTE2 LS RS R2107 0R(DNS) 28 27 26 25 24 23 22 21 20 19 18 17 16 15 Q212 2SC1815-YS MUTEC1 AOUTA1 AOUTB1 MUTEC2 AOUTA2 AOUTB2 VA GND AOUTA3 AOUTB3 MUTEC3 VQ FILT+ M2 C2155 104 ６ R2109 10K AGND VCC TC235 100uF/10V VD206 1N4148 TC236 10uF/16V(DNS) Ｅ Ｄ Ｃ Ｂ Ａ 35 10. SPARE PARTS LIST DV514S MATERIAL LIST 1. MAIN PANEL MATERIAL CODE MATERIAL NAME RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR MAGNETIC BEADS CAPACITOR SPECIFICATIONS 1/16W 0Ω ±5% 0603 1/16W 100Ω ±5% 0603 1/16W 470Ω ±5% 0603 1/16W 10K ±5% 0603 90001 0090181 0090011 0090023 0090192 390095 0310084 SMD SMD SMD SMD SMD SMD SMD 0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 0700007 0700001 0700002 1631786 2360026 0260201 881426 1200621 SMD DIODE SMD DIODE SMD DIODE PCB RECEIVING HEAD CD IC LED SCREEN 2120766 FLAT CABLE 2150184 SCREEN-SHIELDED LINE 1N4148 LS4148 LL4148 4975-1 AT138BV3 LENGTH 27mm CD11C 16V100U±20%6×7 2.5 PT6961 SOP TOS-2701BG-B29 7P80 2.0 2PLUG WITH L NEEDLE THE SAME DIRECTION 28# 215 4P SCREEN-SHIELDED WHITE, RED, YELLOW AND BLACK 1340003 LIGHT TOUCH RESTORE SWITCH 5233018 1/16W 51K ±5% 0603 FCM1608K-221T05 50V 104 +80%-20% 0603 UNITUANTIT LOCATION 1 PCS L402 1 PCS R407 1 R411 PCS 4 R401,R402,R403,R406 PCS 1 R405 PCS 1 L401 PCS 3 C405,C406,C408 PCS C401,C402,C403,C407,C409, 6 PCS C410 2 D401,D402 PCS 2 D401,D402 PCS 2 D401,D402 PCS 1 PCS 1 U402 PCS 2 TC401,TC402 PCS 1 PCS U401 1 PCS LED402 PCS 1 XS401 PCS 1 XS402 HORIZONTAL 6×6×1 PCS 3 K401～K403 SOFT SPONGE SPACER 10×6×16 DOUBLE-FACED HARD PCS 2 5232926 ALUMINUM FOIL STICKER 150×6×0.1 SIGNLE-SIDED WITH GLUE IN REAR SIDE PCS 1 5232919 SOFT SPONGE SPACER 7×7×10 DOUBLE-FACED HARD PCS 2 2. AV BOARD MATERIAL CODE MATERIAL NAME 0090181 SMD RESISTOR 0090002 SMD RESISTOR SPECIFICATIONS 1/16W 100Ω ±5% 0603 1/16W 2.2Ω ±5% 0603 CONNECT VFD SCREEN AND FRONT PANEL PCB BETWEEN LED AND RADIATION SCREEN CONNECT IR SENSOR AND FRONT PANEL PCB UNITUANTIT 1 R702 PCS 1 R706 PCS LOCATION 0310066 SMD CAPACITOR 50V 102 ±10% 0603 PCS 13 C701~C706,C716,C723~C728 310222 0310207 0310543 SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR 25V 104 ±20% X7R 0603 50V 104 ±20% X7R 0603 50V 104 ±10% X7R 0603 PCS PCS PCS 1 1 1 0390095 SMD MAGNETIC BEADS FCM1608K-221T05 PCS 8 0310085 90019 0090029 0090017 0310234 0090001 0700007 0700001 0700002 50V 20P ±5% NPO 0603 1/16W 4.7K ±5% 0603 1/16W 47K ±5% 0603 1/16W 2.2K ±5% 0603 16V 105 +80%-20% 0603 1/16W 0Ω ±5% 0603 1N4148 LS4148 LL4148 PCS PCS PCS PCS PCS PCS PCS PCS PCS 1 1 1 1 2 8 2 2 2 5.1V ±5% 1/2W PCS 4 ZD701~ZD704 1563628 0000171 0000181 0000286 0000132 436 0000133 SMD CAPACITOR SMD RESISTOR SMD RESISTOR SMD RESISTOR SMD CAPACITOR SMD RESISTOR SMD DIODE SMD DIODE SMD DIODE SMD VOLTAGE REGULATOR DIODE PCB CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR C710 C710 C710 L701~L704,L706,L708,L715, L716 C713 R704 R715 R710 C707,C711 L711,L712,C717~C722 D701,D702 D701,D702 D701,D702 7514S-0 1/4W68Ω±5% 1/4W220Ω±5% 1/4W2.2K±5% SHAPED 10 1/6W2.2K±5% SHAPED 7.5 1/4W2K±5% SHAPED 10 1/6W4.7K±5% SHAPED 7.5 PCS PCS PCS PCS PCS PCS PCS 1 1 1 1 2 1 1 0390057 MAGNETIC BEADS INDUCTOR RH354708 PCS 6 1090045 ELECTRO-OPTIC TRANSFORMER TX179ATW PCS 1 JK705 1090024 ELECTRO-OPTIC TRANSFORMER TX179AT PCS 1 JK705 1910078 TERMINAL SOCKET PCS 1 JK702 1910129 TERMINAL SOCKET PCS 1 JK703 1910079 TERMINAL SOCKET AV4-8.4-6G-3 SA-001-012 BLACK IRON PIECE SCREEN-SHIELDED AV8-8.4-6G-3 PCS 1 JK701 0700004 36 R703 R701 R711 R712,R714 R709 R705 L705,L707,L709,L710,L713, L714 1940140 CABLE SOCKET 14P 1.0mm STRAIGHT DUAL LINE PLUG PCS 1 XS701 2100010 CONNECTION CORDS Φ0.6 SHAPED 5mm PCS 9 JP701,JP704,JP710~JP712,J P721~JP724 2100003 CONNECTION CORDS Φ0.6 SHAPED 7.5mm PCS 8 JP703,JP713~JP718,JP720 2100004 2100006 1860029 0200031 780050 0000167 CONNECTION CORDS CONNECTION CORDS SCART SOCKET PORCELAIN CAPACITOR TRIODE CARBON FILM RESISTOR Φ0.6 SHAPED 10mm Φ0.6 SHAPED 12.5mm SCART-01 PCS PCS PCS PCS PCS PCS 3 1 1 1 3 1 JP705,JP709,JP719 JP702 JK706 C712 V701~V703 R708 3. OK BOARD MATERIAL CODE 0090181 0090009 0090012 0090014 0090020 MATERIAL NAME SMD SMD SMD SMD SMD RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR 50V 20P ±10% NPO 5mm S8050D 1/4W33Ω±5% SPECIFICATIONS 1/16W 100Ω ±5% 0603 1/16W 330Ω ±5% 0603 1/16W 560Ω ±5% 0603 1/16W 1K ±5% 0603 1/16W 5.1K ±5% 0603 UNITUANTIT LOCATION 1 R619 PCS 1 R616 PCS 2 R603,R604 PCS 3 R607,R608,R620 PCS 3 R611,R612,R613 PCS R605,R606,R609,R610,R617, 7 PCS R618,R623 2 PCS R601,R602 2 PCS R621,R622 1 R615 PCS 3 C605,C606,C607 PCS 2 C603,C604 PCS 2 C601,C602 PCS 1 C608 PCS 2 L603,L604 PCS 0090023 SMD RESISTOR 1/16W 10K ±5% 0603 90026 0000118 0090034 0310047 0310072 310207 0310066 0390095 SMD RESISTOR CARBON FILM RESISTOR SMD RESISTOR SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR SMD MAGNETIC BEADS 1/16W 22K ±5% 0603 1/6W10Ω±5% SHAPED 7.5 1/16W 100K ±5% 0603 50V 101 ±5% NPO 0603 50V 103 ±10% 0603 50V104 ±20% 0603 50V 102 ±10% 0603 FCM1608K-221T05 0390057 MAGNETIC BEADS INDUCTOR RH354708 PCS 2 L601,L602 0260199 0260200 0260241 0880185 0880562 0880361 CD CD CD IC IC IC PCB SOCKET MIC SOCKET SMD DIODE SMD DIODE SMD DIODE CONNECTION CORDS CONNECTION CORDS CONNECTION CORDS CD11C 16V22U±20%4×7 1.5 CD11C 16V47U±20%5×7 2 CD11C 16V4.7U±20%4×7 1.5 NJM4558M SOP 4580 SOP 4558 SOP 6975-0 6P 2.0mm CK3-6.35-24 1N4148 PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS 2 3 5 2 2 2 1 1 2 3 3 3 4 2 2 TC605,TC606 TC611,TC615,TC616 TC601~TC604,TC613 U601,U602 U601,U602 U601,U602 1563281 1940005 1980018 0700007 0700001 700002 2100010 2100003 2100004 4. SUBSIDIART BOARD MATERIAL CODE MATERIAL NAME LIGHT TOUCH RESTORE 1340003 SWITCH 1940024 SOCKET 0620002 RADIATION DIODE 1631740 PCB 1. POWER BOARD MATERIAL CODE MATERIAL NAME 2100010 CONNECTION CORDS LS4148 LL4148 Φ0.6 SHAPED 5mm Φ0.6 SHAPED 7.5mm Φ0.6 SHAPED 10mm SPECIFICATIONS XS601 MIC601,MIC602 VD601,VD602,VD603 VD601,VD602,VD603 VD601,VD602,VD603 JP602,JP603,JP605,JP608 JP606,JP607 JP601,JP604 UNITUANTIT HORIZONTAL 6×6×1 PCS 1 K901 5P 2.0mm Φ3 RED 9975-0 PCS PCS PCS 1 1 1 XS901 LED901 SPECIFICATIONS Φ0.6 SHAPED 5mm 2100003 CONNECTION CORDS Φ0.6 SHAPED 7.5mm 2100004 0000273 0000362 0000278 0000279 0000284 0000461 0000283 0010115 CONNECTION CORDS CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR METAL FILM RESISTOR Φ0.6 SHAPED 10mm 1/4W33Ω±5% SHAPED 10 1/4W220Ω±5% SHAPED 10 1/4W330Ω±5% SHAPED 10 1/4W470Ω±5% SHAPED 10 1/4W1.5K±5% SHAPED 10 1/4W9.1K±5% SHAPED 10 1/4W1K±5% SHAPED 10 1/4W3.3K±1% SHAPED 10 37 LOCATION UNITUANTIT LOCATION 4 JP502,JP510,JP519,JP520 PCS JP501,JP509,JP514,JP516,JP 5 PCS 518 1 JP511 PCS 1 R505 PCS 1 R515 PCS 1 R506 PCS 1 R514 PCS 1 R511 PCS 1 R512 PCS 1 R502 PCS 1 R508 PCS METAL FILM RESISTOR 1/4W10K±1% SHAPED 10 PCS 1 R509 0010159 METAL OXIDE FILM RESISTOR 2W39K±5% SHAPED FLAT 15×7 PCS 1 R503 0070001 HIGH VOLTAGE RESISTOR 1/2W680K±5% PCS 1 R501 0200136 PORCELAIN CAPACITOR 50V 473 ±20% 5mm PCS 1 C506 0200138 PORCELAIN CAPACITOR 50V 104 ±20% 5mm PCS 6 C504,C508,C510~C512,C515 200268 0200267 0200223 0200228 0200224 CERAMIC CAPACITOR CERAMIC CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR ANTI-DISTURBANCE CAPACITOR TERYLENE CAPACITOR TERYLENE CAPACITOR CD CD CD CT81 250VAC221±10% 10mm CT81 250VAC221±20% 10mm 1000V 101 +80%-20% 7.5mm 1000V 101 ±10% 7.5mm 1000V 103 +80%-20% 7.5mm PCS PCS PCS PCS PCS 2 2 1 1 1 BC503,BC505 BC503,BC505 C503 C503 C502 MKP61 X2 275VAC 104±20%15 PCS 1 BC501 275V 104 ±20% 15mm 275V 104 ±10% 15mm CD11T 16V100u±20%6×12 2.5 CD11T 25V470u±20%10×16 5 CD11T 50V47u±20%6×12 2.5 PCS PCS PCS PCS PCS 1 1 1 2 2 BC501 BC501 TC507 TC503,TC504 TC502,TC512 CD11T 10V1000u±20%8×16 3.5 PCS 4 TC505,TC506,TC510,TC514 KM 400V47U±20%16×25 7.5 VERTICAL 10UH 1A 5mm 1 2 2 3 2 1 4 TC501 L505,L509 L507,L508 D506,508,D511 D510, D513 D505 D501~D504 10064 0210116 0210066 0210070 0260557 0260558 260559 0260560 CD 0260605 0410010 0410011 570013 0570018 0570014 0570005 CD CHOKE COIL CHOKE COIL DIODE DIODE DIODE DIODE VERTICAL 10UH 2A 5mm HER105 HER303 SHAPED R 17.5×8mm HER107 1N4007 PCS PCS PCS PCS PCS PCS PCS 0580006 VOLTAGE REGULATOR DIODE 5.1V ±5% 1/2W PCS 1 ZD501 0580032 VOLTAGE REGULATOR DIODE 10V ±5% 1/2W PCS 1 ZD502 VIPER22A DIP8 LM431ACZ TO-92 TL431C TO-226AA(LP) 431L TO-92 MIK431C TO-92 PCS PCS PCS PCS PCS 1 1 1 1 1 U501 U503 U503 U503 U503 0881933 0880553 0880581 880800 0882041 IC IC IC IC IC 0390057 MAGNETIC BEADS INDUCTOR RH354708 PCS 1 L503 1080011 PHOTOELECTRIC COUPLER HS817 PCS 1 U502 1080006 PHOTOELECTRIC COUPLER PC817 PCS 1 U502 780049 1000022 TRIODE POWER GRID FILTER SWITCHING POWER TRANSFORMER SOCKET SOCKET SOCKET FUSE FUSE GROUND CHIP OF POWER BOARD PCB S8550D JLB1153 33uH +∞-0% PCS PCS 1 1 Q501 L501 BCK-28-519S PCS 1 T501 11P 2.0mm 2P 8.0mm 2# 7P 2.0mm T1.6AL 250V T1.6AL 250V PCS PCS PCS PCS PCS 1 1 1 1 1 CN502 BCN501 CN501 F501 F502 AB903 PCS 2 G501,G505 5977K-4 PCS 1 0460422 1940077 1940045 1940023 2300021 2300028 3870115 1563812 5. DECODE BOARD MATERIAL CODE MATERIAL NAME SPECIFICATIONS 0090001 SMD RESISTOR 1/16W 0Ω ±5% 0603 0090006 SMD RESISTOR 1/16W 75Ω ±5% 0603 0090272 90003 SMD RESISTOR SMD RESISTOR 1/16W1Ω±5% 0603 1/16W 10Ω ±5% 0603 0090005 SMD RESISTOR 1/16W 33Ω ±5% 0603 0090232 SMD RESISTOR 1/16W 150Ω ±5% 0603 38 UNITUANTIT LOCATION R201~R204,R212,R222,R228, R236,R245,R247,R251,R255, 25 R257,R258,R282,R297~R299, PCS R303,R318,R331,R2159,R234 ,R268,R279 R233,R261,R270,R273,R274, 7 PCS R276,R280 5 R304~R307,R321 PCS 2 R301,R302 PCS R231,R232,R256,R263,R264, 8 PCS R294,R295,L202 1 R2180 PCS 0090009 0090013 SMD RESISTOR SMD RESISTOR 1/16W 330Ω ±5% 0603 1/16W 680Ω ±5% 0603 PCS PCS 3 2 R221,R277,R281 R259,R260 R213,R215,R254,R2102~R21 04,R2117~R2128 R323,R324 R205,R214,R325,R327 R238~R240,R2130,R2131,R2 134,R2135,R2138~R2140,R21 42,R2143,R2146,R2147,R215 0,R2151 0090014 SMD RESISTOR 1/16W 1K ±5% 0603 PCS 18 0090016 0090249 SMD RESISTOR SMD RESISTOR 1/16W 1.5K ±5% 0603 1/16W 510Ω ±5% 0603 PCS PCS 2 4 0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 PCS 16 90021 SMD RESISTOR 1/16W 6.8K ±5% 0603 PCS 6 R2136,R2148,R2152~R2155 R208,R229,R309,R311,R313 ,R314,R329,R330,R339,R21 01,R2106,R2108,R2109,R21 64,R2184,R2105 0090023 SMD RESISTOR 1/16W 10K ±5% 0603 PCS 16 0090024 0090025 SMD RESISTOR SMD RESISTOR 1/16W 15K ±5% 0603 1/16W 20K ±5% 0603 PCS PCS 2 4 0090255 SMD RESISTOR 1/16W24K±5% 0603 PCS 6 90188 0090029 0090197 0090211 SMD SMD SMD SMD 1/16W 18K ±5% 0603 1/16W 47K ±5% 0603 1/16W 150K ±5% 0603 1/16W 680K ±5% 0603 PCS PCS PCS PCS 1 1 2 2 R209,R223 R211,R312,R315,R316 R2129,R2133,R2137,R2141,R 2145,R2149 R210 R289 R319,R320 R317,R322 0090609 PRECISION SMD RESISTOR 1/16W 100Ω ±1% 0603 PCS 1 R243 0090626 PRECISION SMD RESISTOR 1/16W 200Ω±1% 0603 PCS 1 R242 90319 PRECISION SMD RESISTOR 1/16W 750K ±1% 0603 PCS 1 R227 0090034 SMD RESISTOR 1/16W 100K ±5% 0603 PCS 11 R224,R246,R252,R308,R310 ,R2111~R2116 0100019 SMD RESISTOR NETWORKS 1/16W33Ω ±5% 8P PCS 2 RN209,RN210 0003759 CARBON FILM RESISTOR 1/4W2.2Ω±5% PCS 1 2604379 CD CD11 16V10U±20%5×11C5 PCS 15 2601819 CD CD11 16V220U±20%6×12 C5 PCS 4 R326 TC202,TC221~TC230,TC232 ,TC233,TC240,TC241 TC207~TC209,TC301 2600029 CD CD11 16V47U±20%5×11 C5 PCS 8 TC204,TC210,TC237,TC246, TC302,TC303,TC308,TC309 2601889 0310085 0310190 CD SMD CAPACITOR SMD CAPACITOR CD11 16V100U±20%6×12 C5 50V 20P ±5% NPO 0603 50V 27P ±5% NPO 0603 PCS PCS PCS 2 2 2 TC235,TC238 C222,C232 C275,C276 0310045 SMD CAPACITOR 50V 47P ±5% NPO 0603 PCS 17 C262~C266,C289,C290,C292, C293,C295,C296,C298,C299, C2101,C2102,C2104,C2105 0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 PCS 8 0310051 0310048 SMD CAPACITOR SMD CAPACITOR 50V 331 ±5% NPO 0603 50V 151 ±5% NPO 0603 PCS PCS 2 2 0310084 0310058 RESISTOR RESISTOR RESISTOR RESISTOR SMD CAPACITOR SMD CAPACITOR 50V 104 +80%-20% 0603 25V 104 +80%-20% 0603 PCS PCS C206 ,C233,C2111,C2114,C2117,C 2120,C2123,C2126 C212,C213 C304,C306 86 C207,C211,C214,C216,C217, C224,C226~C231,C234~C239 ,C241~C254,C256~C259,C26 7~C274,C279~C282,C301~C3 03,C305,C309,C311,C312,C3 23,C2138~C2143,C2150~C21 57,C2160,C2162~C2164,C216 6~C2175,C284,C287 86 C207,C211,C214,C216,C217, C224,C226~C231,C234~C239 ,C241~C254,C256~C259,C26 7~C274,C279~C282,C301~C3 03,C305,C309,C311,C312,C3 23,C2138~C2143,C2150~C21 57,C2160,C2162~C2164,C216 6~C2175,C284,C287 C201~C204,C221,C240,C317 ~C322,C325,C328~C333,C32 6,C327,C285,C286 C223,C255,C278,C294,C297, C2112,C2115,C2118,C2121,C 2124,C2127,C288 C2122,C2129,C2130,C2133,C 2135,C2136 C215 C307,C310 C210 C225 C219,C220 C218 0310234 SMD CAPACITOR 16V 105 +80%-20% 0603 PCS 23 0310066 SMD CAPACITOR 50V 102 ±10% 0603 PCS 12 0310231 SMD CAPACITOR 50V 122 ±10% 0603 PCS 6 0310067 0310068 0310201 0310055 310056 0310362 50V 152 ±10% 0603 390355 0390096 SMD SMD SMD SMD SMD SMD SMD SMD 50V 222 ±10% 0603 50V 153 ±10% 0603 16V 333 ±10% 0603 16V 473 ±10% 0603 16V474 +80%-20% 0603 4.7UH ±10% 1608 1.8UH ±10% 1608 PCS PCS PCS PCS PCS PCS PCS PCS 1 2 1 1 2 1 2 6 L303,L306 L243~L248 3900579 MAGNETIC BEADS INDUCTOR RH354708 PCS 1 L226 0390095 SMD MAGNETIC BEADS FCM1608K-221T05 PCS 31 0960020 1632287 0700007 0700001 0700002 7800509 7800499 0780062 0780063 0780197 0780198 0780040 0780193 780115 0880185 0880562 0880361 0880322 880513 0881415 0881872 0881182 0881057 0881059 0881031 0882257 0881378 CRYSTAL OSCILLATOR PCB SMD DIODE SMD DIODE SMD DIODE TRIODE TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE IC IC IC IC IC IC IC IC IC IC IC IC IC 27.00MHz 49-S 2967B-5 1N4148 LS4148 LL4148 S8050D S8550D 9014C 9015C C1815 2SA1015 3904 SOT-23 2SK3018 2SB1132 NJM4558M SOP 4580 SOP 4558 SOP PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS 1 1 18 18 18 2 2 1 1 7 3 1 2 2 3 3 3 1 1 1 1 1 1 1 1 1 1 V301,V302 U219,U220,U221 U219,U220,U221 U219,U220,U221 U205 U205 U211 U211 U209 U207 U210 U202 U201 U302 1940140 CABLE SOCKET PCS 1 XS204 1940024 SOCKET SOCKET SOCKET SOCKET CABLE SOCKET PCS PCS PCS PCS PCS 1 1 1 1 1 XS302 1940005 1940171 1940023 1940094 CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR INDUCTOR INDUCTOR MM74HCU04M SOP HCU04 SOP HY57V641620HGT-7 TSOP KSV464P4JA-70 TSOP LM1117MP-ADJ SOT-223 CS4360 SSOP CS5333 SSOP 24C02N SOP MT1389FE/C (C VERSION) QFP BA5954FP HSOP 14P 1.0mm STRAIGHT DUAL LINE PLUG 5P 2.0mm 6P 2.0mm 13P 2.5mm 7P 2.0mm 24P 0.5mm SMD WITH CLASP 40 L201,L203,L228~L236,L301, L304,L305,L307~L312,L314, L316~L324,L219 X201 VD201,VD205~VD221 VD201,VD205~VD221 VD201,VD205~VD221 V307,V308 V306,V309 V310 Q204 Q205~Q210,Q212 Q211,Q218,Q219 V305 V303,V304 XS303 XS203 XS201 XS301
