Download SERVICE MANUAL DV113S

SERVICE MANUAL
DV113S
CONTENTS
1.
SAFETY PRECAUTIONS
2.
PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO ELECTROSTATICALLY
1
SENSITIVE(ES)DEVICES
1
3.
CONTROL BUTTON LOCATIONS AND EXPLANATIONS
2
4.
PREVERTION OF STATIC ELECTRICITY DISCHARGE
3
5.
ASSEMBLING AND DISASSEMBLING THE MECHANISM UNIT
4
5.1
OPTICAL PICKUP UNIT EXPLOSED VIEW AND PART LIST
4
5.2
BRACKET EXPLOSED VIEW AND PART LIST
6
5.3
MISCELLANEOUS
7
6.
ELECTRICAL CONFIRMATION
8
6.1
VIDEO OUTPUT (LUMINANCE SIGNAL) CONFIRMATION
8
6.2
VIDEO OUTPUT(CHROMINANCE SIGNAL) CONFIRMATION
9
7.
MPEG BOARD CHECK WAVEFORM
10
8.
IC BLOCK DIAGRAM & DESCRIPTION
11
8.2
MT1389
19
8.3
U214 HY29F800
14
8.4
U203 SDRAM-HY57V1610D
17
9.
10.
SCHEMATIC & PCB WIRING DIAGRAM
SPARE PARTS LIST
19
32
1. SAFETY PREAUTIONS
1.1 GENERAL GUIDELINES
1. When servicing, observe the original lead dress. if a short circuit is found, replace all parts which have
been overheated or damaged by the short circuit.
2. After servicing, see to it that all the protective devices such as insulation barrier, insulation papers
shields are properly installed.
3. After servicing, make the following leakage current checks to prevent the customer from being exposed
to shock hazards.
2.PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO
ELECTROSTATICALLY SENSITIVE(ES)DEVICES
Some semiconductor(solid state)devices can be damaged easily by static electricity. Such components
commonly are called Electrostatically Sensitive(ES)Devices. Examples of typical ES devices are integrated
circuits and some field-effect transistors and semiconductor chip components. The following techniques
should be used to help reduce the incidence of component damage caused by electro static discharge(ESD).
1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain
off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially
availabel discharging ESD wrist strap, which should be removed for potential shock reasons prior to
applying power to the unit under test.
2. After removing an electrical assembly equipped with ES devices,place the assembly on a conductive
surface such as alminum foil, to prevent electrostatic charge buildup or exposure of the assembly.
3. Use only a grounded-tip soldering iron to solder or unsolder ES devices.
4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static
(ESD protected)can generate electrical charge sufficient to damage ES devices.
5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES
devices.
6. Do not remove a replacement ES device from its protective package until immediately before you are
ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by
conductive foam, alminum foil or comparable conductive material).
7. Immediately before removing the protective material from the leads of a replacement ES device, touch
the protective material to the chassis or circuit assembly into which the device will be installed.
Caution
Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.
8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion
such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can
generate static electricity(ESD).
notice (1885x323x2 tiff)
1
3.Control Button Locations and Explanations
Front Panel Illustration
3
2
4
2
3
5
7
6
8
POWER switch
4
OPEN/CLOSE button
7
MIC jack
Disc tray
5
PLAY/PAUSE button
8
MIC VOLUME button
6
STOP button
IR SENSOR button
2
4.PREVENTION OF STATIC ELECTRICITY DISCHARGE
The laser diode in the traverse unit (optical pickup)may brake down due to static electricity of clothes or human
body. Use due caution to electrostatic breakdown when servicing and handling the laser diode.
4.1.Grounding for electrostatic breakdown prevention
Some devices such as the DVD player use the optical pickup(laser diode)and the optical pickup will be damaged
by static electricity in the working environment.Proceed servicing works under the working environment where
grounding works is completed.
4.1.1. Worktable grounding
1. Put a conductive material(sheet)or iron sheet on the area where the optical pickup is placed,and ground the
sheet.
4.1.2.Human body grounding
1 Use the anti-static wrist strap to discharge the static electricity from your body.
safety_3 (1577x409x2 tiff)
4.1.3.Handling of optical pickup
1. To keep the good quality of the optical pickup maintenance parts during transportation and before
installation, the both ends of the laser diode are short-circuited.After replacing the parts with new ones,
remove the short circuit according to the correct procedure. (See this Technical Guide).
2. Do not use a tester to check the laser diode for the optical pickup .Failure to do so willdamage the laser
diode due to the power supply in the tester.
4.2. Handling precautions for Traverse Unit (Optical Pickup)
1. Do not give a considerable shock to the traverse unit(optical pickup)as it has an extremely high-precise
structure.
2. When replacing the optical pickup, install the flexible cable and cut is short land with a nipper. See the
optical pickup replacement procedure in this Technical Guide. Before replacing the traverse unit, remove
the short pin for preventingstatic electricity and install a new unit.Connect the connector as short times as
possible.
3. The flexible cable may be cut off if an excessive force is applied to it.Use caution when handling the cable.
4. The half-fixed resistor for laser power adjustment cannot be adjusted. Do not turn the resistor.
3
5. Assembling and disassembling the mechanism unit
5.1 Optical pickup Unit Explosed View and Part List
Pic (1)
4
Materials to Pic (1)
No.
PARTS CODE
PARTS NAME
Q ty
14692200
SF-HD60
1
1
1EA0311A06300
ASSY, CHASSIS, COMPLETE
1
2
1EA0M10A15500
ASSY, MOTOR, SLED
1
Or
1EA0M10A15501
ASSY, MOTOR, SLED
1
3
1EA2451A24700
HOLDER, SHAFT
3
4
1EA2511A29100
GEAR, RACK
1
5
1EA2511A29200
GEAR, DRIVE
1
6
1EA2511A29300
GEAR, MIDDLE, A
1
7
1EA2511A29400
GEAR, MIDDLE, B
1
8
1EA2744A03000
SHAFT, SLIDE
1
9
1EA2744A03100
SHAFT, SLIDE, SUB
1
10
1EA2812A15300
SPRING, COMP, TYOUSEI
3
11
1EA2812A15400
SPRING, COMP, RACK
1
21
1EA0B10B20100
ASSY, PWB
1
Or
1EA0B10B20200
ASSY, PWB
1
31
SEXEA25700---
SPECIAL SCREW BIN+-M2X11
3
32
SEXEA25900---
SPECIAL SCREW M1.7X2.2
2
33
SFBPN204R0SE-
SCR S-TPG PAN 2X4
2
34
SFSFN266R0SE-
SCR S-TPG FLT 2.6X6
1
35
SWXEA15400---
SPECIAL WASHER 1.8X4 X0.25
2
Note : This parts list is not for service parts supply.
5
5.2 Bracket Explosed View and Part List
Pic (2)
Materials to Pic(2)
1.bracket
2.belt
3.screw
4.belt wheel
5.gearwheel
6.iron chip
7. Immobility mechanism equipment
8. Magnet
9. Platen
10. Bridge bracket
11. screw
12. screw
13. Big bracket
14. front silicon rubber
15. Back silicon rubber
16. Pick-up
17. Pick-up
18. switch
19. Five-pin flat plug
20. screw
21. PCB
22. motor
23. Motor wheel
24. screw
25.tray
Before going process with disassembly and installation, please carefully both
peruse the chart and confirm the materials.
6
5.3 MISCELLANEOUS
5.3.1 Protection of the LD(Laser diode)
Short the parts of LD circuit pattern by soldering.
5.3.2 Cautions on assembly and adjustment
Make sure that the workbenches,jigs,tips,tips of soldering irons and measuring instruments are
grounded,and that personnel wear wrist straps for ground.
Open the LD short lands quickly with a soldering iron after a circuit is connected.
Keep the power source of the pick-up protected from internal and external sources of electrical
noise.
Refrain from operation and storage in atmospheres containing corrosive gases (such as H2S,SO2,
NO2 and Cl2)or toxic gases or in locations containing substances(especially from the organic silicon,cyan,
formalin and phenol groups)which emit toxic gases.It is particularly important to ensure that none of the
above substances are present inside the unit.Otherwise,the motor may no longer run.
7
6.Electrical Confirmation
6.1. Video Output (Luminance Signal) Confirmation
DO this confirmation after replacing a P.C.B.
Measurement point
Mode
Disc
Video output terminal
Color bar 75%
PLAY(Title 46):DVDT-S15
PLAY(Title 12):DVDT-S01
DVDT-S15
or
DVDT-S01
Measuring equipment,tools
Confirmation value
200mV/dir,10 sec/dir
1000mVp-p±30mV
Purpose:To maintain video signal output compatibility.
1.Connect the oscilloscope to the video output terminal and terminate at 75 ohms.
2.Confirm that luminance signal(Y+S)level is 1000mVp-p±30mV
8
6.2 Video Output(Chrominance Signal) Confirmation
Do the confirmation after replacing P.C.B.
Measurement point
Mode
Disc
Video output terminal
Color bar 75%
PLAY(Title 46):DVDT-S15
PLAY(Title 12):DVDT-S01
DVDT-S15
or
DVDT-S01
Measuring equipment,tools
Screwdriver,Oscilloscope
200mV/dir,10 sec/dir
Confirmation value
621mVp-p±30mV
Purpose:To maintain video signal output compatibility.
1.Connect the oscilloscope to the video output terminal and terminate at 75 ohme.
2.Confirm that the chrominance signal(C)level is 621 mVp-p±30mV
9
7.MPEG BOARD CHECK WAVEFORM
7.1 27MHz WAVEFORM
DIAGRAM
7.2 ICVIPER22 PIN.5 WAVEFORM DIAGRAM
10
MT1389
8.2 MT1389
Progressive-Scan DVD Player SOC
Specifications are subject to change without notice
MediaTek MT1389 is a DVD player system-on-chip (SOC) which incorporates advanced features like high
quality TV encoder and state-of-art de-interlace processing. The MT1389 enables consumer electronics
manufacturers to build high quality, cost-effective DVD players, portable DVD players or any other home
entertainment audio/video devices.
Based on MediaTek’s world-leading DVD player SOC architecture, the MT1389 is the 3rd generation of the DVD
player SOC. It integrates the MediaTek 2nd generation front-end analog RF amplifier and the Servo/MPEG AV
decoder.
The progressive scan of the MT1389 utilized a proprietary advanced motion-adaptive de-interlace algorithm to
achieve the best movie/video playback. It can easily detect 3:2/2:2 pull down source and restore the correct
original pictures. It also supports a patent-pending edge-preserving algorithm to remove the saw-tooth effect.
Key Features
DVD
PUH
Module
CVBS, Y/C,
Component
MT1389L
Applications
FLASH
Front-panel
Remote
SDPIF
RF/Servo/MPEG Integration
High Performance Audio Processor
Motion-Adaptive, Edge-Preserving De-interlace
108MHz/12-bit, 6 CH TV Encoder
Audio DAC
DRAM
DVD Player System Diagram Using MT1389
11
Standard DVD Players
Portable DVD Players
MT1389
PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE
MTK CONFIDENTIAL, NO DISCLOSURE
General Feature List
Super Integration DVD player single chip
High performance analog RF amplifier
Servo controller and data channel processing
MPEG-1/MPEG-2/JPEG video
Dolby AC-3/DTS/DVD-Audio
Unified memory architecture
Versatile video scaling & quality
enhancement
OSD & Sub-picture
2-D graphic engine
Built-in clock generator
Built-in high quality TV encoder
Built-in progressive video processor
Audio effect post-processor
Audio input port
High Performance Analog RF Amplifier
Programmable fc
Dual automatic laser power control
Defect and blank detection
RF level signal generator
Speed Performance on Servo/Channel Decoding
DVD-ROM up to 4XS
CD-ROM up to 24XS
Channel Data Processor
Digital data slicer for small jitter capability
Built-in high performance data PLL for
channel data demodulation
EFM/EFM+ data demodulation
Enhanced channel data frame sync protection
& DVD-ROM sector sync protection
Servo Control and Spindle Motor Control
Programmable frequency error gain and
phase error gain of spindle PLL to control
spindle motor on CLV and CAV mode
Built-in ADCs and DACs for digital servo
control
Provide 2 general PWM
Tray control can be PWM output or digital
output
Embedded Micro controller
Built-in 8032 micro controller
Built-in internal 373 and 8-bit programmable
lower address port
12
1024-bytes on-chip RAM
Up to 4M bytes FLASH-programming
interface
Supports 5/3.3-Volt. FLASH interface
Supports power-down mode
Supports additional serial port
DVD-ROM/CD-ROM Decoding Logic
High-speed ECC logic capable of correcting
one error per each P-codeword or
Q-codeword
Automatic sector Mode and Form detection
Automatic sector Header verification
Decoder Error Notification Interrupt that
signals various decoder errors
Provide error correction acceleration
Buffer Memory Controller
Supports 16Mb/32Mb/64Mb/128Mb SDRAM
Supports 16-bit SDRAM data bus
Provide the self-refresh mode SDRAM
Block-based sector addressing
Support 3.3 Volt. DRAM Interface
Video Decode
Decodes MPEG1 video and MPEG2 main level,
main profile video (720/480 and 720x576)
Smooth digest view function with I, P and B
picture decoding
Baseline, extended-sequential and
progressive JPEG image decoding
Support CD-G titles
Video/OSD/SPU/HLI Processor
Arbitrary ratio vertical/horizontal scaling of
video, from 0.25X to 256X
65535/256/16/4/2-color bitmap format OSD,
256/16 color RLC format OSD
Automatic scrolling of OSD image
Slide show transition as DVD-Audio
Specification
2-D Graphic Engine
Support decode Text and Bitmap
Support line, rectangle and gradient fill
Support bitblt
Chroma key copy operation
Clip mask
MT1389
PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE
MTK CONFIDENTIAL, NO DISCLOSURE
Audio Effect Processing
Dolby Digital (AC-3)/EX decoding
DTS/DTS-ES decoding
MLP decoding for DVD-Audio
MPEG-1 layer 1/layer 2 audio decoding
MPEG-2 layer1/layer2 2-channel audio
High Definition Compatible Digital (HDCD)
Windows Media Audio (WMA)
Advanced Audio Coding (AAC)
Dolby ProLogic II
Concurrent multi-channel and downmix out
IEC 60958/61937 output
- PCM / bit stream / mute mode
- Custom IEC latency up to 2 frames
Pink noise and white noise generator
Karaoke functions
- Microphone echo
- Microphone tone control
- Vocal mute/vocal assistant
- Key shift up to +/- 8 keys
- Chorus/Flanger/Harmony/Reverb
Channel equalizer
3D surround processing include virtual
surround and speaker separation
13
TV Encoder
Six 108MHz/12bit DACs
Support NTSC, PAL-BDGHINM, PAL-60
Support 525p, 625p progressive TV format
Automatically turn off unconnected channels
Support PC monitor (VGA)
Support Macrovision 7.1 L1, Macrovision
525P and 625P
CGMS-A/WSS
Closed Caption
Progressive Output
Automatic detect film or video source
3:2 pull down source detection
Advanced Motion adaptive de-interlace
Edge Preserving
Minimum external memory requirement
Audio Input
Line-in/SPDIF-in for versatile audio
processing
Outline
256-pin LQFP package
3.3/1.8-Volt. Dual operating voltages
8.3 U214 HY29F800
KEY FEATURES
n 5 Volt Read, Program, and Erase
– Minimizes system-level power requirements
n High Performance
– Access times as fast as 55 ns
n Low Power Consumption
– 20 mA typical active read current in byte
mode, 28 mA typical in word mode
– 35 mA typical program/erase current
– 5 µA maximum CMOS standby current
n Compatible with JEDEC Standards
– Package, pinout and command-set
compatible with the single-supply Flash
device standard
– Provides superior inadvertent write
protection
n Sector Erase Architecture
– Boot sector architecture with top and
bottom boot block options available
– One 16 Kbyte, two 8 Kbyte, one 32 Kbyte
and fifteen 64 Kbyte sectors in byte mode
– One 8 Kword, two 4 Kword, one 16 Kword
and fifteen 32 Kword sectors in word mode
– A command can erase any combination of
sectors
– Supports full chip erase
n Erase Suspend/Resume
– Temporarily suspends a sector erase
operation to allow data to be read from, or
programmed into, any sector not being
erased
n Sector Protection
– Any combination of sectors may be
locked to prevent program or erase
operations within those sectors
n Temporary Sector Unprotect
– Allows changes in locked sectors
(requires high voltage on RESET# pin)
n Internal Erase Algorithm
– Automatically erases a sector, any
combination of sectors, or the entire chip
n Internal Programming Algorithm
– Automatically programs and verifies data
at a specified address
n Fast Program and Erase Times
– Byte programming time: 7 µs typical
– Sector erase time: 1.0 sec typical
– Chip erase time: 19 sec typical
n Data# Polling and Toggle Status Bits
– Provide software confirmation of
completion of program or erase
operations
n Ready/Busy# Output (RY/BY#)
– Provides hardware confirmation of
completion of program and erase
operations
n Minimum 100,000 Program/Erase Cycles
n Space Efficient Packaging
– Available in industry-standard 44-pin
PSOP and 48-pin TSOP and reverse
TSOP packages
19
8
DQ[7:0]
A[18:0]
7
CE#
DQ[14:8]
OE#
DQ[15]/A-1
WE#
RESET#
BYTE#
14
RY/BY#
BLOCK DIAGRAM
DQ[15:0]
A[18:0], A-1
STATE
CONTROL
ERASE VOLTAGE
GENERATOR AND
SECTOR SWITCHES
DQ[15:0]
WE#
CE#
I/O BUFFERS
COMMAND
REGISTER
I/O CONTROL
DATA LATCH
OE#
PROGRAM
VOLTAGE
GENERATOR
BYTE#
RESET#
V C C DETECTOR
A[18:0], A-1
TIMER
15
ADDRESS LATCH
RY/BY#
Y-DECODER
Y-GATING
X-DECODER
8 Mb FLASH
MEMORY
ARRAY
RY/BY#
A18
A17
A7
A6
A5
A4
A3
A2
A1
A0
CE#
V SS
OE#
DQ0
DQ8
DQ1
DQ9
DQ2
DQ10
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
DQ3
DQ11
21
22
PSOP44
PIN CONFIGURATIONS
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
RESET#
WE#
A8
A9
A10
A11
A12
A13
A14
A15
A16
BYTE#
V SS
DQ15/A-1
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
24
23
DQ4
V CC
A15
A14
A13
A12
A11
A10
A9
A8
NC
NC
WE#
RESET#
NC
NC
RY/BY#
A18
A17
A7
A6
A5
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
A16
BYTE#
V SS
DQ15/A-1
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
DQ4
V CC
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
A4
A3
A2
A1
21
22
23
24
28
27
26
25
OE#
V SS
CE#
A0
A16
BYTE#
V SS
DQ15/A-1
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
DQ4
V CC
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
A15
A14
A13
A12
A11
A10
A9
A8
NC
NC
WE#
RESET#
NC
NC
RY/BY#
A18
A17
A7
A6
A5
OE#
V SS
CE#
A0
21
22
23
24
28
27
26
25
A4
A3
A2
A1
16
Standard
TSOP48
Reverse
TSOP48
8.4 U203 SDRAM-HY57V1610D
DESCRIPTION
THE Hynix HY57V161610D is a 16,777,216-bits CMOS Synchronous DRAM, ideally suited for the Mobile applications
which require low power consumption and industrial temperature range. HY57V161610D is organized as 2banks of
524,288x16.
HY57V161610D is offering fully synchronous operation referenced to a positive edge clock. All inputs and outputs are
synchronized with the rising edge of the clock input. The data paths are internally pipelined to achieve very high bandwidth. All input and output voltage levels are compatible with LVTTL.
Programmable options include the length of pipeline (Read latency of 1,2 or 3), the number of consecutive read or
write cycles initiated by a single control command (Burst length of 1,2,4,8 or full page), and the burst count
sequence(sequential or interleave). A burst of read or write cycles in progress can be terminated by a burst terminate
command or can be interrupted and replaced by a new burst read or write command on any cycle. (This pipeline
design is not restricted by a `2N` rule.)
FEATURES
•
Single 3.0V to 3.6V power supply
•
•
Note1)
•
Auto refresh and self refresh
All device pins are compatible with LVTTL interface
•
4096 refresh cycles / 64ms
JEDEC standard 400mil 50pin TSOP-II with 0.8mm
•
Programmable Burst Length and Burst Type
of pin pitch
- 1, 2, 4, 8 and Full Page for Sequence Burst
•
All inputs and outputs referenced to positive edge of
- 1, 2, 4 and 8 for Interleave Burst
system clock
•
Data mask function by UDQM/LDQM
•
Internal two banks operation
•
Programmable C A S Latency ; 1, 2, 3 Clocks
ORDERING INFORMATION
Part No.
Clock Frequency
HY57V161610DTC-55I
183MHz
HY57V161610DTC-6I
166MHz
HY57V161610DTC-7I
143MHz
HY57V161610DTC-10I
100MHz
Organization
Interface
2Banks x 512Kbits x 16
LVTTL
Package
400mil
50pin TSOP II
This document is a general product description and is subject to chage without notice. Hyundai Electronics does not assume any
responsibility for use of circuits described. No patent licenses are implied
Rev. 0.2/Aug.01
17
PIN CONFIGURATION
VDD
1
50
VSS
DQ0
2
49
DQ15
DQ1
3
48
DQ14
V S S Q
4
47
V S S Q
DQ2
5
46
DQ13
DQ3
6
45
DQ12
VDDQ
7
44
VDDQ
DQ4
8
43
DQ11
DQ5
9
42
DQ10
V S S Q
10
41
V S S Q
DQ6
11
40
DQ9
DQ7
12
39
DQ8
VDDQ
13
38
VDDQ
LDQM
14
37
N C
W E
15
36
UDQM
CAS
16
35
CLK
RAS
17
34
CKE
C S
18
33
N C
A11
19
32
A9
A10
20
31
A8
A0
21
30
A7
A1
22
29
A6
A2
23
28
A5
A3
24
27
A4
VDD
25
26
VSS
50pin TSOP-II
400mil x 825mil
0.8mm pin pitch
PIN DESCRIPTION
PIN
PIN NAME
DESCRIPTION
The system clock input. All other inputs are referenced to the SDRAM on the
CLK
Clock
CKE
Clock Enable
CS
Chip Select
Command input enable or mask except CLK, CKE and DQM
BA
Bank Address
Select either one of banks during both R A S a n d C A S activity.
A0 ~ A10
Address
Row Address Strobe,
RAS, CAS, W E
Column Address Strobe,
Write Enable
rising edge of CLK.
Controls internal clock signal and when deactivated, the SDRAM will be one
of the states among power down, suspend or self refresh.
Row Address : RA0 ~ RA10, Column Address : CA0 ~ CA7
Auto-precharge flag : A10
R A S , C A S and W E define the operation.
Refer function truth table for details
LDQM, UDQM
Data Input/Output Mask
DQM control output buffer in read mode and mask input data in write mode
DQ0 ~ DQ15
Data Input/Output
Multiplexed data input / output pin
V D D /V S S
Power Supply/Ground
Power supply for internal circuit and input buffer
V D D Q /V S S Q
Data Output Power/Ground
Power supply for DQ
NC
No Connection
No connection
18
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
１
２
２
1
K A
19
2
Ａ
１
D401
IN4148
K403
K402
K401
DAT
DCK
DST
３
4.7K
4.7K
R418
4.7K
R417
R416
３
VCC
VCC
R415
100
IR
IR
VCC
GND
DST
DCK
DAT
104
C405
更改 数量 更改单号
设 计
审 核
标准化
批 准
４
1
2
3
4
5
6
XS401
XS06
U403
HS0038A2
TC407
100uF/16V
1
2
3
４
签 名
日期
DV1001RU
５
板号 : 4911S-0
主 面 板 电 路原 理 图
５
质量
共 １ 张
数量
版次：1.0
６
广东步步高电子工业有限公司ＡＶ厂
比例
第 １ 张
ＢＢＫ
６
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
Ａ
9. SCHEMATIC & PCB WIRING DIAGRAM
FRONT SCHEMATIC DIAGRAM
FRONT SCHEMATIC DIAGRAM
20
F
E
D
C
1
!
BCN502
SW-SPST
!
!
D501
1N4007
2
A K
!
D504
BCN501
~220V
2
!
R501
680K 2W
BC501
~275V 104
U501
VIPER22
TC501
47uF/400V
F501
T1.6A/250V
D503
1N4007
1N4007
BCN501
~220V
!
L501
1
D502
1N4007
2
FB
B
2
1
L503
5
6
7
8
VDD
FB
4
3
C503
101/1KV
R503
39K/2W
D
D
D
D
S
S
21
1
2
A
1
C506
473
R512
9.1K
C504
104
TC502
47uF/50V
R505
10ohm
D505
HER107
C502
103/1KV
3
D506
HER105
3
!
3
4
EEL19H
BC503
~400V 221
U502
2501
!
5
4
3
2
1
T501
!
6
9
8
10
7
2
1
D511
HER105
D510
D508
HER105
L507 10uH/2A
U503
LM431A
R506
330
TC512
47uF/50V
TC505
1000uF/10V
A
K
R
C515
104
R507
1K
R508
3.3K
C510
104
C508
104
签 名
R509
10K
TC506
1000uF/10V
TC504
470uF/16V
更改 数量 更改单号
设 计
审 核
标准化
批 准
4
SR560
L505
10uH/1A
TC503
470uF/16V
4
日期
D509
1N4007
+5V
5
D513
1N4007
5
6
广东步步高电子工业有限公司AV厂
数量
版次： 1.0
板号: 5501A-3
质量
共 1 张
比例
第 1 张
CN501
XS04
BBK
1
2
3
4
XS07
CN502
开关电源电原理图
GND
-9V
+9V
1
2
3
4
5
6
7
-9V
ZD502
9.1V/1W
DVD-VIPER22
R517
330R
+9V
-9V
GND
+5V
GND
+3.3V
GND
100uF/16V
TC513
R511
330R/1W
TC510
1000uF/10V
+3.3V
+5V
+9V
6
F
E
D
C
B
A
POWER SCHEMATIC DIAGRAM
POWER BOARD SCHEMATIC DIAGRAM
22
F
E
D
C
B
1
MIC602
DET
OK
AGND
+9V
-9V
+5V
DET
6
5
4
3
2
1
+5V
7
6
5
4
3
2
1
R623
4.7k
XS601
XS06
+9V
2
TC615
100U/16V
R633
10R1/6W
L602
FB
R601
22K
C603
103
R603
560R
22U/16V
C601
104
+9VA
TC601
4.7U/16V
2
R607
1K
1
-9V
R605
10K
3
2
101
30K
1
4558
3
U601A
TC616
100U/16V
R632
10R1/6W
+9VA
C605
R609
4
8
TC605
C602
104
-9VA
R619
1K
4.7U/16V
TC603
3
1
10K
VR602
2
TC608
22uF/16V
R608
20K
+5V
TC621
4.7uF/16V
+9VA
1
U602A
4558
561
C612
R618
15K
392
104
C613
R624
10K
C608
R61415K
4.7U/16V
TC613
104
C614
R621
10K
R615
10K
C623
104
签 名
C622
104
U603
PT2399
C615
392
R628
4.7K
4.7U/16V
TC611
更改 数量 更改单号
设 计
审 核
标准化
批 准
4
C609
TC609
104 47uF/16V
TC607
C610
4.7uF/16V 561
R610
30K
R612
10K
3
2
101
-9VA
C607
R613
30K
4
8
OK
R6224.7K
4
10K
R620
3
12
2
R61710K
1
15
R616 5.6K
16
LPF1-IN
VDD
14
LPF1-OUT
2
REF
3
LPF2-OUT
AGND
13
LPF2-IN
DGND
4
OP2-OUT
11
OP2-IN
VCO
6
CLKO
5
9
OP1-IN
CC1
10
OP1-OUT
CC2
7
23
8
A
1
C616
103
日期
5
6
C620
R629
27K
7
5
U602B
4558
101
5
C619
102
板号:6911-0
MIC板电原理图
DV939
TC610
R626
4.7uF/16V 1K
质量
共 1 张
数量
版次： 1.0
6
广东步步高电子工业有限公司AV厂
比例
第 1 张
BBK
6
F
E
D
C
B
A
OK BOARD SCHEMATIC DIAGRAM
OK BOARD SCHEMATIC DIAGRAMDIAGRAM
24
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
１
PDAT0
PDAT2
R704
4.7K
VCC
XS28
XS7011
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
R712
2.2K
2.2K
R710
330R
+10V
R709
AGNDVGND
LFE
+10V
CC
SR
SL
R
VIEDO
PDAT0
L
Pb
Y1
Pr
C
PDAT2
PDAT1
SPDIF
VCC
Y
AGND
V703
8050
R711
1K
A+10V
AGND
V702
8050
R708
33R
A+10V
２
VGND
R713 0R
R714 0R
R715 0R
VGND
AGND
C707
105
２
C
Y
VIEDO
Pr-
Y-
Pb-
L#
R#
VGND
C716
104
V701
8050
R705
75R
220uF/16V
R719 0R
TC705
220uF/16V
TC701 220uF
R717
0R
AGND
R706
R718
0R
３
VGND
2.2R
TC706
L714 FCM
L713 FCM
VCC
３
VJS3921
FBSMT
L712
L711
FBSMT
VGND
VGND
A(B)OUT
A(B)IN
A(A)OUT
A-COM
RETURN
A(A)IN
BLUE I/O
FUNC SW
RETURN
CONT
GREEN I/O
NC
RETURN
RETURN
RED I/O
BLK I/O
RETURN
TRTURN
V-OUT
V-IN
GND
JK706
FBSMT
L710
21
19
17
15
13
11
9
7
5
3
1
20
18
16
14
12
10
8
6
4
2
1
2
6
5
S-VIDEO
JK703A
JK703B
S-OUT
VGND
104
C728
A+10V
AGND
7
3
25
4
Ａ
１
４
标准化
批 准
更改 数量 更改单号
设 计
审 核
４
Pr
Pb
Y1
TC704
220uF/16V
TC703
220uF/16V
R707 0R
R720 0R
TC702
1000uF/16V
５
VGND
AGND
R721 0R
C710
104
C706
102
C705
102
日期
L706
FB
L705
FB
SPDIF
签 名
R
L
５
91R
R702
Pr-
Pb-
Y-
LFDV965
FBSMT
L708
L707
FBSMT
L709
FBSMT
R701 330R
VGND
板号: 7969SB
AV 输出板原理图
R
B
G
R#
L#
5
2
RCA-407
6
4
3
1
JK701
质量
共 １ 张
数量
版次：1.0
６
广东步步高电子工业有限公司ＡＶ厂
比例 １：１
第 １ 张
ＢＢＫ
６
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
Ａ
OUTPUT BOARD SCHEMATIC
OUTPUT BOARD SCHEMATIC
26
Ｃ
Ｂ
Ｆ
Ｅ
Ｄ
XS302
5P2.0mm
6P2.0mm
XS303
C301
104
1
2
3
4
5
１
R329
10K
1
2
3
4
5
6
TC301
220uF/10V
C327
104
104 104
TRIN
LOADLOAD+
TROUT
R328
10K
R319
150K
C315 C314
DV33
1R
R322 1R(DNS)
R321
C313 104
R330 10K
R313 10K
TRSO
V1P4
STBY
22
23
24
25
26
27
28
30
15
16
17
18
19
20
21
104
C326
C307
222
TROPEN
C309
104
GND1
R331
0R
R327
2.2R\1/4W
R325
330R
R323
1K
TC308
47uF/10V
C310
222
C308
101(DNS)
U302
BA5954/ AT5665
PREGND
VINLD
CTK2
CTK1
VINTK
BIAS
STBY
GND2
VOFC+
VOFCVOSL+
VOSLPGND
PVCC1
VCC
F
B
A
RFO
IOA
D
C
TKTK+
FC+
FC-
V20
VINFFC
VOSL
VINSLVINSL+
CF2
CF1
VINFC
C312
104
VOTK+
VOTKVOLD+
VOLDPGND
VINFTK
PVCC2
R317
680K/1%
C329
104
R318
680K/1%
R320
150K
SP+
SP-
DV33
SL+
SLLIMIT
R312
20K
104
FMSO
C303
104
TK+
SL+
SL-
TK-
C302
R305 1R
C305
104
C311
104
0R
0R
0R
0R
FBSMT
0R
0R
FBSMT
FBSMT
FBSMT
FBSMT
0R
FBSMT
FBSMT
L310
L311
L313
L312
L314
L316
L317
L318
L319
L320
L321
L322
L323
L324
MDI
LD-CD
VR-DVD
VR-CD
FBSMT
FBSMT
10uH
FBSMT
FBSMT
L304
L305
L306
L307
L308
E
LD-DVD
FBSMT
10uH
L301
L303
R304 1R
C304
151
R340
0R TC304
47uF/10V
R341
0R(nc)
MO-VCC
C328
104
AVCC
24P0.5mm
XS301
24 GND-LD
23 LD-DVD
22
21 HFM
20 MD
19 LD-CD
18 VR-DVD
17 VR-CD
16
15 E
14 AVCC
13 Vref
12 GND-PD
11 F
10 B
9 A
8 RF
7 CD/DVD
6 D
5 C
4 TK3 TK+
2 FC+
1 FC-
AVCC
FC+
1
２
V307 V308
8050D 8050D
V309
8550D
R316
20K
R326
330R
R324
1K
C306
151
R332
10K
B
GND
E 2
TROPEN
CF1
V1P4
FC-
DMSO
TROPEN
TRCLOSE
FC-
LOAD-
MO-VCC
R311
R303
10K(DNS)
1
2
3
4
5
6
7
8
9
10
11
12
13
３
10K
V305
2N3904-S
R309
10K
VCC
XS203
2.5MM
３
LDO-V33
LOAD+
2N3904
C
3
TRCLOSE
1
R308
100K
S
R315
20K
TC309
47uF/10V
0R
0R(nc)
R343
R342
0R
10K
10K(nc)
10K(nc)
0R
0R(nc)
0R
0R(nc)
0R
FC-
1
2
V303
2SK3018-S
R344
10K
R314
R345
R346
R347
R348
V310
2N3904-S
CF2
FB1
SLIN2
FWD
REV
OUT5-
R349
OUT5+ R350
R351
R307 1R
R306 1R
1
D
3
2SK3018
G
LDO1
TC303
47uF/10V
LDO-V33
LDO2
TC302
47uF/10V
LDO-V33
R302
4.7R
V304
2SK3018-S
MO-VCC
REV
FWD
SLIN2
FB1
CF2
CF1
FOSO
GND
3
R301
4.7R
V301
2SB1132-S
E
V302
2SB1132-S
V306
8550D
V1P4
OPOP+
C
2SB1132
R310
100K
B
SPSP+
OUT5+
OUT5MO-VCC
ADIN
OPO
7
6
5
4
3
2
1
29
14
13
12
11
10
9
8
IOA
1
2
3
2
C
2
3
IOA
DVD: 0V
CD: +3.3V
R204
0R
L224
L223
L222
L220
L221
L218
L219
3.3V
2
L205
FB
FB
FB
FB
FB
FB
FB
FB
VCC
AVCC
MIC-DET
OKA
C271
104
3.3V
C270
104
VCC
C269
104
+12V
C268
104
-12V
４
3
OUT
C207
104
RFV33
C245
104
C345
104
2
R243
1.5K
R242
3.3K
C208
104
L208
FBSMT
C246
104
104
C229
C209
104
C214
104
C247
104
TC305
220uF/10V
LDO-V33
FBSMT
104
104
C211
签 名
TC209
220uF/10V
L215
FBSMT
C210
104
DV33
C250
104
C235
104
C237
104
C238
104
TC203
47uF/10V
L227
FBSMT
104
C239
104
SD33
104
TC245
220uF/10V
５
６
广东步步高电子工业有限公司ＡＶ厂
数量
版次： 2.0
TC210
1000uF/10V(DNS)
板号： 2967D-1
质量
共 ５ 张
C294
682
ADACVDD3
比例
第 １ 张
ＢＢＫ
C226
104
L207
10uH
C240
104
104
C2145
解码 &伺服电原理图
RFV18
104
C2144
C296
104
６
APLLVDD3
104
C2142 C2143
TC211
47uF/10V
L228
FBSMT
104
L234
FBSMT
C244
104
DACVDD3
C234
104
PLLVDD3
TC212
220uF/10V
C2141
TC237
47uF/10V
VD
+12V
-12V
VCC
MIC-DET
OKA
C2140
1
2
3
4
5
6
C273
104
L206
FBSMT
L204
FBSMT(DNS)
6P2.0mm
XS304
DV33
VCC
INTEL 4M(28F400): VCC
OTHER TPYE 8M：DV33
DV967(MTK1389D + SANYO)
C236
104
C252
104
５
TC214
100uF/10V
R206
4.7R
C213
104
C251
104
TC208
220uF/10V
A5V
日期
V18
C212
104
C221
222
RFVDD3
C215
103
C248
104
C249
SD33
C295
104
MO-VCC
TC207
220uF/10V
L302
FB
L209
更改 数量 更改单号
设 计
审 核
标准化
批 准
４
U209
LM1117MP-ADJ
IN
L229
FB
L233
FBSMT
L226
FB
L309
FBSMT
2967D-1 在2967D-0 的基础上加入了蓝色标识的电阻R204 、L205
1
２
GND
Ａ
27
1
１
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
Ａ
MIAN SCHEMATIC DIAGRAM
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
XS201
XS07
R253
0R(DNS)
R252
10K
V1P4
FOSO
TRSO
FMSO
DMSO
DCKE
DCLK
BA0
BA1
WE#
CAS#
RAS#
CS#
１
7
6
5
4
3
2
1
121
121
121
121
FBSMT
FBSMT
FBSMT
FBSMT
C264 C265 C266
L230
L231
L232
L217
C272
102
5
VSTB
VSCK
VSDA
LCDIN
IR
U205C
HCU04
SCL
SDA
R201 0R
R255
33R
SDAT0
SDAT1
SDAT2
RST#
SACLK
SBCLK
SLRCK
C243
104
TC205
47uF/10V
C242
104
C275
22pF
XI
URST#
U205A
HCU04
２
X201
27MHz
R245
0R R246
100K
1
C204
D
C206
101(DNS)
2
V1P4
C276
22pF
C274
104
4
XO
U205B
HCU04
DV33
C277
22pF(DNS)
XI
R222
0R
XTALI
R339
0R
(DNS)
STBY
R338
(DNS)
C320
104
R337
R248
0R(DNS)
R247
0R
3
(DNS)
C321
105
105
105
105
105
C241
104
RFVDD3
RFO C205
C203
C202
B
A
C201
C
TC206
47uF/10V
FEO: FOCUS ERROR MONITOR OUTPUT
TEO: TRACKING ERROR MONITOR OUTPUT
FOO: FOCUS SERVO OUTPUT
TRO: TRACKING SERVO OUTPUT
FMO: FEED MOTOR CONTROL
DMO: DISK MOTOR CONTROL
33R
33R
33R
R202 0R(DNS)
FOO
TRO
FMO
DMO
R294
R295
R296
6
33R
33R
33R
TC204
47uF/10V
R201: 5.1 声道
R202: 内置2 声道
R291
R292
R293
C267
221(DNS)
20K
18K
15K
10K
ASDAT0
ASDAT1
ASDAT2
AL
ACLK
ABCK
ALRCK
R230
10K(DNS) R229
4.7K
R254
1K
Q204
9015C-S
153
C316
C263
VCC
TC217
10uF/16V
VD201
1N4148
104
331
331
DV33
C317
SDCKE
SDCLK
DBA0
DBA1
R336
R335
R334
R333
C232
221(DNS)
DWE#
DCAS#
DRAS#
DCS#
C318
33R
33R
33R
33R
33R
33R
33R
33R
C319
R264
R263
R262
R261
R268
R267
R266
R265
8
7
6
5
A3
A4
A5
A6
A7
A8
A2
TRO
FOO
ADIN
VSYNC
HSYNC
３
V2P8
V20
V1P4
FEO
TEO
TEZISLV
OPO
OPOP+
DMO
FMO
TROPEN
RFOP
RFON
LDO2
LDO1
E
F
MDI
C
B
A
D
SUBA
SUBB
SUBC
SUBD
V18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
AGND
DVDA
DVDB
DVDC
DVDD
DVDRFIP
DVDRFIN
MA
MB
MC
MD
SA
SB
SC
SD
CDFON
CDFOP
TNI
TPI
MDI1
MDI2
LDO2
LDO1
SVDD3
CSO/RFOP
RFLVL/RFON
SGND
V2REFO
V20
VREFO
FEO
TEO
TEZISLV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
PWMOUT1/ADIN0
TRO
FOO
FG/ADIN1
GPIO0
GPIO1
GPIO2
IOA2
DVDD18
IOA3
IOA4
IOA5
IOA6
IOA7
HIGHA0
XS202
XS04(DNS)
DV33
RFVDD3
R223 15K
A18
DC/NC
VCC
RST_/NC RST/WP
WP/RST_
SCL
VSS
SDA
1
2
3
4
A19
1
2
3
4
C228 104
C227 104
C225 333
DV33
RXD
TXD
GND
PWR#
A16
Ａ
C223 102
C224 104
V2P8
V1P4
C222
22pF
R224 100K
V20
PLLVDD3
C218
0.47(DNS)
TC202
10uF/16V
RFV18
JITFN
JITFO
XI
XO
V1P4
C220 473
MT1389D
U201
MT1389D SMD LQFP-216_0
设 计
审 核
标准化
批 准
４
更改 数量 更改单号
A15
A14
A13
A12
A11
A10
A9
A20
PCE#
R260
1K
C219 473
A1
PRD#
R259
C230 1K
104
AL
APLLVDD3
TC201
10uF/16V
ADACVDD3
签 名
AD0
AD1
AD2
AD3
AD4
AD5
AD6
FS1
ALE
U202
AT24C02/X4050
AR
４
AD7
A17
３
Y6
Y5
２
R281
2.2M
DACVDD3
C217
152
Y4
DV33
R244
0R(DNS)
Y3
日期
A0
UWR#
URD#
LCDIN
VSCK
IOA
VSTB
VSDA
SCL
１
14
7
５
FS0
ASDAT2
ASDAT1
ASDAT0
ALRCK
ASPDIF
MCDATA
216
215
214
213
212
211
210
209
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
AVDD3
IREF
RFGC
OSN
OSP
RFGND
CRTPLP
HRFZC
RFRPAC
RFRPDC
RFVDD3
ADCVSS
ADCVDD3
LPFOP
LPFIN
LPFIP
LPFON
PLLVDD3
IDACEXLP
PLLVSS
JITFN
JITFO
XTALI
XTALO
RFVDD18
RFGND18
ADACGND
AL
VCM
AR
ADACVDD3
APLLVSS
APLLCAP
APLLVDD3
R
B
DACVSSA
G
DACVDDA
DACVSSB
DACVDDB
CVBS
DACVSSC
FS
VREF
DACVDDC
SPDIF
MC_DATA
DVDD3
ASDATA3
ASDATA2
ASDATA1
ASDATA0
ALRCK
IOA18
DVSS
IOA19
DVDD3
IOWR#
A16
DVDD3
HIGHA7
HIGHA6
HIGHA5
HIGHA4
HIGHA3
HIGHA2
HIGHA1
IOA20
IOCS#
DVSS
IOA1
IOOE#
DVSS
AD0
AD1
AD2
AD3
AD4
AD5
AD6
IOA21
ALE
DVDD18
AD7
A17
DVDD3
IOA0
UWR#
URD#
UP1_2
UP1_3
GPIO6
UP1_4
UP1_5
UP1_6
DVSS
UP1_7
UP3_0
UP3_1
UP3_4
UP3_5
GPIO7
ICE
PRST#
IR
INT0#
DVDD3
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
５
DQ3
DQ4
DQ5
DQ6
DQ7
DQM0
DQ15
DQ0
DQ1
DQ2
DQ13
DQ14
DQM1
DQ8
DQ9
DQ10
DQ11
DQ12
CAS#
WE#
BA1
BA0
CS#
RAS#
MA2
MA1
MA0
MA10
MA3
MA8
MA9
MA11
DCKE
DCLK
MA4
MA5
MA6
MA7
TROUT
TRIN
LIMIT
ACLK
ABCK
R205
0R
R274
10K(NC)
MIC-DET
JITFN
V18
R227
750K/1%
C233
391
DV33
MIC-DET-IN
DV33
JITFO
６
质量
共 ５ 张
数量
版次： 2.0
６
广东步步高电子工业有限公司ＡＶ厂
比例
第 ２ 张
ＢＢＫ
2967D-1 在2967D-0 的基础上加入了蓝色标识的电阻R281 、R205 、R274
解码 &伺服电原理图
板号： 2967D-1
162
161
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
R216
4.7K
LQFP216/SMD
ACLK
ABCK
DVSS
GPIO5
GPIO4
GPIO3
DVDD18
RA4
RA5
RA6
RA7
DVDD3
RA8
RA9
RA11
CKE
RCLK
DVSS
RA3
DVSS
RA2
RA1
RA0
RA10
DVDD3
BA1
BA0
RCS#
RAS#
DVDD18
CAS#
RWE#
DVSS
DQM1
RD8
RD9
RD10
RD11
RD12
DVDD3
RD13
RD14
DVSS
RD15
RD0
RD1
RD2
DVSS
RD3
RD4
RD5
RD6
RD7
DQM0
C216 104
R215 1K
510R
R214 2K(NC)
DV967(1389D)
SDA
MIC-DET-IN
MUTE-DAC
RXD
TXD
TRCLOSE
ICE
URST#
IR
INT0#
28
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
Ａ
Ｃ
Ｂ
Ｆ
Ｅ
Ｄ
１
15
39
DQM0
DQM1
21
22
23
24
27
28
29
30
31
32
20
19
19
18
17
16
DCS#
DRAS#
DCAS#
DWE#
15
14
36
DWE#
DQM0
DQM1
33
37
16
DCAS#
18
DCS#
17
34
SDCKE
DRAS#
35
SDCLK
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
MA9
MA10
DBA0
38
37
SDCLK
SDCKE
54
41
28
36
40
23
24
25
26
29
30
31
32
33
34
22
35
20
21
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
MA9
MA10
MA11
DBA0
DBA1
VSSQ
VSSQ
VSSQ
VSSQ
VCCQ
VCCQ
VCCQ
VCCQ
VCC
VCC
VCC
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
NC
NC
DQMH
DQML
WE
CAS
RAS
CS
CKE
CLK
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
BA/A11
VSS
VSS
VSSQ
VSSQ
VSSQ
VSSQ
VCCQ
VCCQ
VCCQ
VCCQ
VCC
VCC
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
U203
SDRAM 1Mb*16(SOP50)
VSS
VSS
VSS
NC
NC
DQML
DQMH
/CS
/RAS
/CAS
/WE
CLK
CKE
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10/AP
A11
BA0/A13
BA1/A12
6
12
46
52
3
9
43
49
1
14
27
2
4
5
7
8
10
11
13
42
44
45
47
48
50
51
53
26
50
4
10
41
47
7
13
38
44
1
25
2
3
5
6
8
9
11
12
39
40
42
43
45
46
48
49
A11
A9
A8
A13
A14
A17
PWR#
VD
A18
A16
A15
A12
A7
A6
A5
A4
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
SD33
SD33
SD33
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
VD
２
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
２
R241
4.7K(DNS)
C297
27pF
A11
A9
A8
A13
A14
A17
WE
Vcc
A18
A16
A15
A12
A7
A6
A5
A4
18
17
DBA1
DRAS#
A16
BYTE
Vss
D15/A-1
D7
D14
D6
D13
D5
D12
D4
Vcc
D11
D3
D10
D2
D9
D1
D8
D0
OE
Vss
CE
A0
U211
NC
NC
DQMH
DQML
WE
CAS
RAS
CS
CKE
CLK
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
BA/A11
4M: A0 ~ A18
8M: A0 ~ A19 16M: A0 ~ A20
VSS
VSS
VSSQ
VSSQ
VSSQ
VSSQ
VCCQ
VCCQ
VCCQ
VCCQ
VCC
VCC
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
AD1
AD2
AD3
AD4
VD
AD5
AD6
GND
A0
AD7
A17
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
SD33
３
10
AD0
PRD#
GND
PCE#
A1
U205E
HCU04
３
OE
A10
CE
DQ7
DQ6
DQ5
DQ4
DQ3
Vss
DQ2
DQ1
DQ0
A0
A1
A2
A3
26
50
4
10
41
47
7
13
38
44
1
25
2
3
5
6
8
9
11
12
39
40
42
43
45
46
48
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
0R(DNS)
R250
11
U204
SDRAM 1Mb*16(SOP50)
A15
A14
A13
A12
A11
A10
A9
A8
A19
A20
WE
RESET
VPP
WP/ACC
RY/BY
A18
A17
A7
A6
A5
A4
A3
A2
A1
4Mb FLASH(TSOP32)
33
37
36
14
15
U205F
HCU04
12
U214
8/16Mb_FLASH(TSOP48)
13
只考虑4M/8M/16MFLASH的封装，32M不考虑
DQM1
DQM0
DWE#
16
34
SDCKE
DCAS#
35
21
22
23
24
27
28
29
30
31
32
20
19
SDCLK
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
MA9
MA10
DBA0
A19
A18
A8
A7
A6
A5
A4
A3
A2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
R249
0R
PWR#
URST#
VP
UNLOCK
A16
A15
A14
A13
A12
A11
A10
A9
ASPDIF
16Mb FLASH
U206
SDRAM 64Mb(TSOP54)
4.7K
4.7K
R238
R239
Ａ
１
4.7K
0R A20
R240
R203
1
2
PRD#
A10
PCE#
AD7
AD6
AD5
AD4
AD3
GND
AD2
AD1
AD0
A0
A1
A2
A3
R251
0R
R233
75R
+12V
FS1
FS0
A7
A6
A5
A4
A3
A2
A1
A0
AD0
5
6
7
8
9
10
11
12
13
R236
0R(DNS)
AGND
R237
0R
AGND
C231
102
CVBS
B/U/SC
G/Y/SY
R/V/SY
B/U/SC
VCC
G/Y/SY
HSYNC
VSYNC
A7
A6
A5
A4
A3
A2
A1
A0
DQ0
VGND
FLASH/4M
29
28
27
26
25
24
23
22
21
U212
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
签 名
A14
A13
A8
A9
A11
PRD#
A10
PCE#
AD7
VGND AGND
AGND
A14
A13
A8
A9
A11
OE
A10
CE
DQ7
SUB
Cc
SR
SL
Rt
Lt
更改 数量 更改单号
设 计
审 核
标准化
批 准
４
R235
0R(DNS)
R234
150R
R282
0R(DNS)
2967D-0: PIN5 接R/V/SY（PIN9 ）
2967D-1: PIN5 接G/Y/SY（PIN11 ）
IEC60958
４
A12
A15
A16
A18
VD
PWR#
A17
4
3
2
1
32
31
30
A12
A15
A16
A18
VCC
WE
A17
DQ1
DQ2
VSS
DQ3
DQ4
DQ5
DQ6
14
15
16
17
18
19
20
AD1
AD2
GND
AD3
AD4
AD5
AD6
29
日期
XS28
XS204
R217
75R/1%
150R/1%(NC)
B
L235
0R
2N3906
1
2
C
E
3
Y6
Y5
Y4
Y3
L239
0R
L238
0R
L237
0R
５
板号： 2967D-1
VGND
C261
47pF
L214
1.8uH
C259
47pF
L213
1.8uH
C257
47pF
L212
1.8uH
VGND
VGND
VGND
VGND
C255
47pF(NC)
L211
1.8uH(NC)
解码 &伺服电原理图
DV967(1389D)
R221
75R/1%
150R/1%(NC)
R220
75R/1%
150R/1%(NC)
R219
75R/1%
150R/1%(NC)
R218
75R/1%(NC)
150R/1%(NC)
L236
0R(NC)
L210
1.8uH
C253
47pF
此输出暂时未用到, 但PCB有位号
Y3
５
R270
75R/1%(DNS)
A5V
A5V
A5V
VD219
1N4148
VD218
1N4148
VD217
1N4148
VD216
1N4148
VD215
1N4148
数量
版次：2.0
R/V/SY
B/U/SC
G/Y/SY
６
广东步步高电子工业有限公司ＡＶ厂
比例
第 ３ 张
VD213
1N4148(NC)
VD214
1N4148
CVBS
CVBS-ST
VD212
1N4148(NC)
VD211
1N4148
VD210
1N4148
质量
共 ５ 张
Q217
3906-S(DNS)
R273
75R/1%(DNS)
A5V
Q216
3906-S(DNS)
R272
75R/1%(DNS)
A5V
Q215
3906-S(DNS)
75R/1%(DNS)
R271
A5V
Q214
3906-S(DNS)
A5V
ＢＢＫ
C262
47pF
R213
0R
C260
47pF
R212
0R
C258
47pF
R211
0R
R269
75R/1%(DNS)
A5V
Q213
3906-S(DNS)
A5V
C256
47pF(NC)
R210
0R(NC)
C254
47pF
R209
0R
A5V
６
Ｆ
Ｅ
Ｄ
Ｃ
Ａ
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
１
Cc
DV33
R2116
100K
R2115
100K
R207
47K(NC)
SACLK
SBCLK
MCDATA
AGND
AGND
AGND
C280
104
SLRCK
C281
104
-12V
R2118 1K
R2117 1K
AGND
1
2
3
4
5
6
7
8
C282
104
CH-C
CH-SW
CH-SL
MUTE-OUT
CH-SR
CH-L
CH-R
C283
104
RST
VQ
AINL
AINR
REF_G
FILT+
TST
DIF
２
SDATA: 47K 接地：slave mode
接VL: master mode
VL
MCLK
SCLK
SDATA
VA
GND
LRCK
DIN
U210
CS5333(16)(NC)
16
15
14
13
12
11
10
9
使用内置MICROPHONE功能时选装此功能
Q210
2SC1815Y-S R2128 1K
R2127 1K
Q209
2SC1815Y-S
R2126 1K
R2125 1K
Q208
2SC1815Y-S R2124 1K
R2123 1K
Q207
2SC1815Y-S
R2122 1K
R2121 1K
Q206
2SC1815Y-S R2120 1K
R2119 1K
Q205
2SC1815Y-S
TC215
100uF/25V
C284 TC244
104(NC)
10uF/16V(NC)
R2113
100K
R2112
100K
R2111
100K
C279
104
R2114
100K
R208
47K(DNS)
C287
104(NC)
SUB
SL
SR
Lt
Rt
AGND
C278
104
+12V
105(NC)
105(NC)
C286
TC242
10uF/16V(NC)
1
7
7
C288
102(NC)
R258
150R(NC)
OKA
C285
TC243
10uF/16V(NC)
RST#
TC224
10uF/16V
TC223
10uF/16V
TC222
10uF/16V
TC221
10uF/16V
TC241
10uF/16V
TC240
10uF/16V
TC216
100uF/25V
DV33
３
R231
0R(NC)
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
R256
0R(DNS)
R257
0R(NC)
AGND
C2127
102
R2151
R2150
AGND
C2124
102
R2147
AGND
C2121
102
R2143
R2142
AGND
C2118
102
R2139
R2138
AGND
C2115
102
R2135
R2134
AGND
4.7K
U221B
4580
5
6
101
R2149 24K
3
U221A
4580
2
101
4.7K
C2112
102
R2131
4.7K
R2132
20K
C2136
122
R2155 6.8K
C2135
122
R2154 6.8K
C2133
122
R2153 6.8K
C2130
122
R2152 6.8K
C2129
122
R2148 6.8K
R2156
20K
C2122
122
R2136 6.8K
C2116
102
AGND
R2130
OKA
R2146
101
R2145 24K
R232
0R(DNS)
-12V
6
5
U220B
4580
C2123
+12V
3
U220A
4580
2
101
R2141 24K
C2120
-12V
+12V
U219B
4580
5
6
101
R2137 24K
C2117
-12V
C2126
-12V
C2114
+12V
+12V
-12V
U219A
4580
3
2
101
R2133 24K
-12V
+12V
+12V
1
7
1
C2111
R2129 24K
３
8
２
R225
0R
/C
TC230
TC229
TC228
TC227
TC226
VD209
1N4148
VD208
1N4148
使用AL、AR时有效
R2159
1K(DNS)
签 名
1
2
3
4
5
6
7
8
9
10
11
12
13
14
VLS
SDIN1
SDIN2
SDIN3
SCLK
LRCK
MCLK
VD
GND
RST
SCL
SDA
CS
VLC
５
MUTEC1
AOUTA1
AOUTB1
MUTEC2
AOUTA2
AOUTB2
VA
GND
AOUTA3
AOUTB3
MUTEC3
VQ
FILT+
M2
U207
CS4360
28
27
26
25
24
23
22
21
20
19
18
17
16
15
LL
RR
AGND
TC232
10uF/16V
C289
104
TC238
47uF/10V
DV967(1389D)
-12V
R2106
10K
R2108
10K
５
板号： 2967D-1
AGND
Q212
2SC1815Y-S
R2107 0R(DNS)
R2103 1K
R2104 3.3K
+12V
MIC-DET
CENT
LFE
LS
RS
解码 &伺服电原理图
AGND
R228
4.7R
R2109
10K
质量
共 ５ 张
AGND
TC235
220uF/16V
VD206
1N4148
数量
版次：2.0
R2161
0R
VCC
R2160
0R(DNS)
+12V
６
广东步步高电子工业有限公司ＡＶ厂
比例
第 ４ 张
ＢＢＫ
VD205
1N4148
MUTE-OUT
VCC
６
Q219
2SA1015Y-S
TC236
220uF/10V
Q218
2SA1015Y-S
TC233
10uF/16V
C291
104
C290
104
CENT
LFE
MUTE3
MUTE1
LL
RR
MUTE2
LS
RS
R277
R278
180K(DNS)
180K(DNS)使用AL、AR时有效
R275
R276
1K(DNS) 1K(DNS)
Q211
2SA1015Y-S
日期
R2101
100K
VCC
10uF/16V
10uF/16V
10uF/16V
10uF/16V
10uF/16V
10uF/16V
R2102
10K
R279
0R
TC225
VD207
1N4148
MUTE-DAC
MUTE3
MUTE2
MUTE1
683(DNS)
C292
104
DV33
R280
0R(DNS)
AGND
更改 数量 更改单号
设 计
审 核
标准化
批 准
４
C2128
C2134
SW
SL#
SR#
L
R
RST#
SCL
SDA
683(DNS)
0R
C2131
C2138
0R
0R
R226
TC231
100uF/10V
SDAT0
SDAT1
SDAT2
SBCLK
SLRCK
SACLK
683(DNS)
C293
104
0R(DNS)
C2119
C2132
VCC
４
AL
4
8
4
8
4
AR
Ａ
１
8
4
8
4
8
4
30
Ｆ
Ｅ
Ｄ
Ｃ
Ｂ
Ａ
31
DV113S MATERIAL LIST
1. POWER BOARD
MATERIAL CODE
MATERIAL NAME
294
CARBON FILM RESISTOR
0010064
METAL FILM RESISTOR
0000461
CARBON FILM RESISTOR
0010256
METAL FILM RESISTOR
0000431
CARBON FILM RESISTOR
METAL OXIDE FILM
10135
RESISTOR
0000278
CARBON FILM RESISTOR
0000380
CARBON FILM RESISTOR
HIGH VOLTAGE
0070001
RESISTOR
VOLTAGE REGULATOR
0580054
DIODE
METAL OXIDE FILM
10250
RESISTOR
0570005
DIODE
0570011
DIODE
0200138
PORCELAIN CAPACITOR
0200224
PORCELAIN CAPACITOR
0200223
PORCELAIN CAPACITOR
0200228
PORCELAIN CAPACITOR
210191
TERYLENE CAPACITOR
0260559
CD
0260563
CD
260557
CD
0260594
CD
0260560
CD
MAGNETIC BEADS
0390057
INDUCTOR
0410010
CHOKE COIL
0410011
CHOKE COIL
PHOTOELECTRIC
1080011
COUPLER
0570013
DIODE
570014
DIODE
0680010
SCHOTTKY DIODE
0880553
IC
0880581
IC
0880800
IC
0210066
TERYLENE CAPACITOR
0210070
TERYLENE CAPACITOR
200267
CERAMIC CAPACITOR
0200268
CERAMIC CAPACITOR
SWITCHING POWER
0460394
TRANSFORMER
1000004
POWER GRID FILTER
1563407
PCB
2100003
CONNECTION CORDS
2100010
CONNECTION CORDS
2300021
FUSE
1940045
SOCKET
1940023
SOCKET
1940027
SOCKET
0881933
IC
GROUND CHIP OF
3870115
POWER BOARD
2. MAIN PANEL
MATERIAL CODE
5232805
9
0090023
0570006
1340003
0200139
0260206
2360002
MATERIAL NAME
SOFT SPONGE SPACER
CARBON FILM RESISTOR
SMD RESISTOR
DIODE
LIGHT TOUCH RESTORE
SWITCH
PORCELAIN CAPACITOR
CD
IR SENSOR
SPECIFICATIONS
1/4W10K±5% SHAPED 10
1/4W10K±1% SHAPED 10
1/4W9.1K±5% SHAPED 10
1/4W3.6K±1% SHAPED 10
1/4W75Ω±5% SHAPED 10
UNIT QUANTITY
PCS
1
R507
PCS
1
R509
PCS
1
R512
PCS
1
R508
PCS
1
R505
2W39K±5% SHAPED FLAT 15×9
PCS
1
R503
1/4W330Ω±5% SHAPED 10
1/4W510Ω±5% SHAPED 10
PCS
PCS
1
1
R517
R506
1/2W680K±5%
PCS
1
R501
9.1V 1W
PCS
1
ZD502
1W22Ω±5％ SHAPED R 15×8
PCS
1
R511
1N4007
RL202
50V 104 ±20% 5mm
1000V 103 +80%-20% 7.5mm
1000V 101 +80%-20% 7.5mm
1000V 101 ±10% 7.5mm
50V 222 ±10% 5mm
CD11T 50V47U±20%6×12 2.5
KM 400V47U±20%18×20 7.5
CD11T 16V100U±20%6×12 2.5
CD11T 25V220U±20%8×12 3.5
CD11T 10V1000U±20%8×16 3.5
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
4
2
4
1
1
1
1
2
1
1
2
3
D501~D504
D509,D513
C504,C508,C510,C515
C502
C503
C503
C506
TC502,TC512
TC501
TC513
TC503,TC504
TC505,TC506,TC510
RH354708
PCS
1
L503
VERTICAL 10UH 1A 5mm
VERTICAL 10UH 2A 5mm
PCS
PCS
1
1
L505
L507
HS817
PCS
1
U502
HER105
HER107
SR560 DO-27
LM431ACZ TO-92
TL431C TO-226AA(LP)
431L TO-92
275V 104 ±20% 15mm
275V 104 ±10% 15mm
CT81 250VAC221±20% 10mm
CT81 250VAC221±10% 10mm
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
3
1
1
1
1
1
1
1
1
1
D506,D508,D511
D505
D510
U503
U503
U503
BC501
BC501
BC503
BC503
BCK-19-0179
PCS
1
T501
UT-20 40mH ±20% 10×13
5501A-4
Φ0.6 SHAPED 7.5mm
Φ0.6 SHAPED 5mm
T1.6AL 250V
2P 8.0mm 2#
7P 2.0mm
2P 2.0mm
VIPER22A DIP8
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
1
1
2
1
1
2
1
1
1
L501
JP501,JP503
JP502
F501
BCN501,BCN502
CN502
CN501
U501
AB903
PCS
2
G501,G502
LOCATION
SPECIFICATIONS
UNIT QUANTITY
LOCATION
6×6×2.5 DOUBLE-FACED HARD PCS
1
1PC FOR IR SENSOR
1/6W100Ω±5%
PCS
1
R415
1/16W 10K ±5%
PCS
3
R416,R417,R418
1N4148
PCS
1
D401
HORIZONTAL 6×6×1
PCS
3
K401~K403
50V 104 +80%-20% 5mm
CD11C 10V100U±20%5×7 2
HS0038B
PCS
PCS
PCS
1
1
1
C405
TC407
U403
32
2100010
CONNECTION CORDS
2121370
FLAT CABLE
1563482
3. AV BOARD
MATERIAL CODE
362
0000123
0090005
0090181
0090002
0090019
0000129
0090017
0090006
310066
0310207
0310543
0310222
0090001
780050
PCB
Φ0.6 SHAPED 5mm
6P170 2.0 2PLUG WITH L
NEEDLE REVERSE
4911S-1
PCS
1
JP401
PCS
1
XS401
PCS
1
MATERIAL NAME
CARBON FILM RESISTOR
CARBON FILM RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
CARBON FILM RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD RESISTOR
SPECIFICATIONS
1/4W220Ω±5% SHAPED 10
1/6W330Ω±5% SHAPED 7.5
1/16W 33Ω ±5% 0603
1/16W 100Ω ±5% 0603
1/16W 2.2Ω ±5% 0603
1/16W 4.7K ±5% 0603
1/6W1K±5% SHAPED 7.5
1/16W 2.2K ±5% 0603
1/16W 75Ω ±5% 0603
50V 102 ±10% 0603
50V 104 ±20% X7R 0603
50V 104 ±10% X7R 0603
25V 104 ±20% X7R 0603
1/16W 0Ω ±5% 0603
UNIT QUANTITY
LOCATION
PCS
1
R701
PCS
1
R709
PCS
1
R708
PCS
1
R702
PCS
1
R706
PCS
1
R704
PCS
1
R711
PCS
2
R710,R712
PCS
1
R705
PCS
2
C705,C706
PCS
3
C707,C710,C716
PCS
3
C707,C710,C716
PCS
3
C707,C710,C716
PCS
6
R717~R721,R707
TRIODE
S8050D
PCS
3
V701~V703
RH354708
PCS
10
L705~L714
PCS
1
JK701
PCS
1
JK703
PCS
1
XS701
PCS
PCS
PCS
PCS
PCS
3
5
3
1
1
JP704,JP710,JP711
JP705~JP709
JP701~JP703
JK706
1910140
MAGNETIC BEADS
INDUCTOR
TERMINAL SOCKET
1910129
TERMINAL SOCKET
1940140
CABLE SOCKET
2100010
2100003
2100004
1860029
1563648
CONNECTION CORDS
CONNECTION CORDS
CONNECTION CORDS
SCART SOCKET
PCB
AV4-8.4-5G-5 BLACK
SA-001-012 BLACK IRON PIECE
SCREEN-SHIELDED
14P 1.0mm STRAIGHT DUAL
LINE PLUG
Φ0.6 SHAPED 5mm
Φ0.6 SHAPED 7.5mm
Φ0.6 SHAPED 10mm
SCART-01
7112S-0
MATERIAL NAME
CARBON FILM RESISTOR
CARBON FILM RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
SPECIFICATIONS
1/6W560Ω±5% SHAPED 7.5
1/6W1K±5% SHAPED 7.5
1/16W 1K ±5% 0603
1/16W 22K ±5% 0603
1/16W 4.7K ±5% 0603
1/16W 5.1K ±5% 0603
SMD RESISTOR
1/16W 10K ±5% 0603
1/6W10K±5% SHAPED 7.5
RH354708
PCS
1
L602
0000118
0090024
0000338
90188
0000144
0090027
0090028
0090018
CARBON FILM RESISTOR
MAGNETIC BEADS
INDUCTOR
CARBON FILM RESISTOR
SMD RESISTOR
CARBON FILM RESISTOR
SMD RESISTOR
CARBON FILM RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
1/6W10Ω±5% SHAPED 7.5
1/16W 15K ±5% 0603
1/6W15K±5% SHAPED 7.5
1/16W 18K ±5% 0603
1/6W47K±5% SHAPED 7.5
1/16W 27K ±5% 0603
1/16W 33K ±5% 0603
1/16W 3.3K ±5% 0603
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
2
1
1
1
1
1
2
1
0260127
CD
CD11 16V4.7U±20%5×11 2
PCS
7
260021
0260200
0260040
0310047
0310066
0310072
CD
CD
CD
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
CD11 16V22U±20%5×11 2
CD11C 16V47U±20%5×7 2
CD11 25V100U±20%6×12 2.5
50V 101 ±5% NPO 0603
50V 102 ±10% 0603
50V 103 ±10% 0603
PCS
PCS
PCS
PCS
PCS
PCS
1
2
2
3
3
2
0310084
SMD CAPACITOR
50V 104 +80%-20% 0603
PCS
8
0310058
SMD CAPACITOR
25V 104 +80%-20% 0603
PCS
8
0310323
SMD CAPACITOR
50V 392 ±10% 0603
PCS
2
R632,R633
R618
R614
R615
R610
R629
R609,R613
R608
TC601,TC603,TC607,TC61
0,TC611,
TC613,TC621
TC605
TC608,TC609
TC615,TC616
C605,C607,C620
C619,C625,C606
C603,C616
C602,C609,C613,C614,C62
2,C623,C601,C604
C602,C609,C613,C614,C62
2,C623,C601,C604
C615,C608
390057
4. OKV BOARD
MATERIAL CODE
0000126
0000129
90014
0090026
0090019
0090020
0090023
137
0390057
LOCATION
UNIT QUANTITY
PCS
1
R603
PCS
1
R607
PCS
2
R619,R626
PCS
1
R601
PCS
3
R622,R628,R623
PCS
1
R616
R605,R617,R620,R621,R62
PCS
5
4
PCS
1
R612
0310197
0390095
0880124
SMD CAPACITOR
SMD MAGNETIC BEADS
IC
PCS
PCS
PCS
2
2
2
C610,C612
L601,L603
U601,U602
PCS
1
XS601
CONNECTION CORDS
50V 561 ±10% 0603
FCM1608K-221T05
NJM4558D DIP
6P200 2.0 2PLUG WITH L
NEEDLE REVERSE
Φ0.6 SHAPED 5mm
2121509
FLAT CABLE
2100010
PCS
2
2100003
CONNECTION CORDS
Φ0.6 SHAPED 7.5mm
PCS
5
1980048
MIC SOCKET
ROTATED
POTENTIOMETER
PCB
IC
ST-403-070-100
PCS
1
JP603,JP605
JP601,JP602,JP604,JP606,J
P607
MIC602
WH09JTC1Z11-A10K-F30
PCS
1
VR602
6911S-1
PT2399 DIP
PCS
PCS
1
1
U603
0160184
1563776
880230
5. OKV BOARD
MATERIAL CODE
MATERIAL NAME
SPECIFICATIONS
UNIT QUANTITY
LOCATION
L235,L237~L239,L310,L31
2,L314,L316,L317,L319,L3
20,R201,R203,R209,R211~
R213,R222,R226,R236,R24
5,R247,R249,R251,R279,R3
31,R339,R340,R342,R344,R
347,R349,R351,R2161,R282
0090001
SMD RESISTOR
1/16W 0Ω ±5% 0603
PCS
35
0090214
0090272
0090106
0090006
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
1/16W 2.2MΩ ±5% 0603
1/16W1Ω±5% 0603
1/16W 4.7Ω ±5% 0603
1/16W 75Ω ±5% 0603
PCS
PCS
PCS
PCS
1
5
4
5
0090005
SMD RESISTOR
1/16W 33Ω ±5% 0603
PCS
15
0090009
SMD RESISTOR
1/16W 330Ω ±5% 0603
PCS
2
0090014
SMD RESISTOR
1/16W 1K ±5% 0603
PCS
12
0090016
0090249
0090018
SMD RESISTOR
SMD RESISTOR
SMD RESISTOR
1/16W 1.5K ±5% 0603
1/16W 510Ω ±5% 0603
1/16W 3.3K ±5% 0603
PCS
PCS
PCS
1
1
2
0090019
SMD RESISTOR
1/16W 4.7K ±5% 0603
PCS
8
90021
SMD RESISTOR
1/16W 6.8K ±5% 0603
PCS
2
0090023
SMD RESISTOR
1/16W 10K ±5% 0603
PCS
15
0090024
0090188
SMD RESISTOR
SMD RESISTOR
1/16W 15K ±5% 0603
1/16W 18K ±5% 0603
PCS
PCS
2
1
0090025
SMD RESISTOR
1/16W 20K ±5% 0603
PCS
6
90255
SMD RESISTOR
1/16W24K±5% 0603
PCS
2
0090034
SMD RESISTOR
1/16W 100K ±5% 0603
PCS
7
0090197
SMD RESISTOR
PRECISION SMD
RESISTOR
PRECISION SMD
RESISTOR
CARBON FILM RESISTOR
1/16W 150K ±5% 0603
PCS
2
R281
R304~R307,R321
R206,R228,R301,R302
R233,R217,R219~R221
R255,R261~R268,R291~R2
96
R325,R326
R215,R254,R259,R260,R32
3,R324,R2103,R2117~R212
0,R205
R243
R214
R242,R2104
R216,R238~R240,R2130,R2
131,R2134,R2135
R2136,R2148
R252,R309,R311,R313,R31
4,R328~R330,R332,R333,R
2102,R2106,R2108,R2109,R
274
R223,R334
R335
R312,R315,R316,R336,R21
32,R2156
R2129,R2133
R224,R246,R308,R310,R21
01,R2111~R2112
R319,R320
1/16W 680K ±1% 0603
PCS
2
R317,R318
1/16W 750K ±1% 0603
PCS
1
R227
1/4W2.2Ω±5%
PCS
1
0260019
CD
CD11 16V10U±20%5×11 2
PCS
9
0260009
CD
CD11 10V47U±20%5×11 2
PCS
12
0260012
0260040
CD
CD
CD11 10V100U±20%5×11 2
CD11 25V100U±20%6×12 2.5
PCS
PCS
2
2
0260013
CD
CD11 10V220U±20%6×12 2.5
PCS
8
0260028
0310043
CD
SMD CAPACITOR
CD11 16V220U±20%6×12 2.5
50V 22P ±5% NPO 0603
PCS
PCS
1
3
0310045
SMD CAPACITOR
50V 47P ±5% NPO 0603
PCS
8
0310047
SMD CAPACITOR
50V 101 ±5% NPO 0603
PCS
2
R327
TC201,TC202,TC217,TC22
5~TC226,TC232,TC233,TC
240,TC241
TC203~TC206,TC211,TC2
37,TC238,TC302~TC304,T
C308,TC309
TC214,TC231
TC215,TC216
TC207~TC209,TC212,TC2
36,TC245,TC301,TC305
TC235
C222,C275,C276
C253,C254,C257,C258,C25
9~C262
C2111,C2114
0090231
0090319
375
34
0310596
0310048
0310051
0310052
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
50V 121±20% 0603
50V 151 ±5% NPO 0603
50V 331 ±5% NPO 0603
50V 391 ±5% NPO 0603
PCS
PCS
PCS
PCS
4
2
2
1
0310066
SMD CAPACITOR
50V 102 ±10% 0603
PCS
6
0310231
310067
0310068
0310071
0310072
0310201
310055
0310056
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
SMD CAPACITOR
50V 122 ±10% 0603
50V 152 ±10% 0603
50V 222 ±10% 0603
50V 682 ±10% 0603
50V 103 ±10% 0603
50V 153 ±10% 0603
16V 333 ±10% 0603
16V 473 ±10% 0603
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
2
1
3
1
1
1
1
2
0310084
SMD CAPACITOR
50V 104 +80%-20% 0603
PCS
C263~C266
C304,C306
C318,C319
C233
C223,C231,C272,C2112,C2
115,C2116
C2122,C2129
C217
C221,C307,C310
C294
C215
C316
C225
C219,C220
76
C207~C214,C216,C224,C22
6~C230,C234~C252,C268~
C271,C273,C274,C278~C28
3,C289~C293,C295,C296,C
301~C303,C305,C309,C311
~C315,C317,C320,C326~C3
29,C345,C2140~C2145
C207~C214,C216,C224,C22
6~C230,C234~C252,C268~
C271,C273,C274,C278~C28
3,C289~C293,C295,C296,C
301~C303,C305,C309,C311
~C315,C317,C320,C326~C3
29,C345,C2140~C2145
0310058
SMD CAPACITOR
25V 104 +80%-20% 0603
PCS
76
0310234
0390044
0390096
SMD CAPACITOR
SMD INDUCTOR
SMD INDUCTOR
MAGNETIC BEADS
INDUCTOR
16V 105 +80%-20% 0603
10UH ±10% 2012
1.8UH ±10% 1608
PCS
PCS
PCS
5
3
4
RH354708
PCS
10
0390095
SMD MAGNETIC BEADS
FCM1608K-221T05
PCS
26
0700007
SMD DIODE
1N4148
PCS
14
0700001
SMD DIODE
LS4148
PCS
14
0700002
SMD DIODE
LL4148
PCS
14
0780050
0780049
0780063
0780197
0780198
0780040
0780193
0780115
880185
0880562
0880361
0880322
0880513
882104
0881275
0881182
0881057
0881031
0882293
0881378
0960020
TRIODE
TRIODE
SMD TRIODE
SMD TRIODE
SMD TRIODE
SMD TRIODE
SMD TRIODE
SMD TRIODE
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
CRYSTAL OSCILLATOR
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
2
2
1
3
3
2
2
2
1
1
1
1
1
2
2
1
1
1
1
1
1
1940140
CABLE SOCKET
PCS
1
XS204
1632274
1940007
1940094
PCB
SOCKET
CABLE SOCKET
S8050D
S8550D
9015C
C1815
2SA1015
3904 SOT-23
2SK3018
2SB1132
NJM4558M SOP
4580 SOP
4558 SOP
MM74HCU04M SOP
HCU04 SOP
HY57V161610ET-7 TSOP
IC42S16100-7T SOP
LM1117MP-ADJ SOT-223
CS4360 SSOP
24C02N SOP
MT1389XE(D VERSION) QFP
BA5954FP HSOP
27.00MHz 49-S
14P 1.0mm STRAIGHT DUAL
LINE PLUG
2967D-5
7P 2.5mm
24P 0.5mm SMD WITH CLASP
C201~C205
L207,L303,L306
L210, L212~L214
L218~L223,L226,L229,L30
2,L205
L206,L208,L209,L215,L217
,L227,L228,L230~L234,L30
1,L304,L305,L307~L309,L3
11,L318,L321~L324,R229,L
313
VD201,VD205~VD211,VD2
14~VD219
VD201,VD205~VD211,VD2
14~VD219
VD201,VD205~VD211,VD2
14~VD219
V307,V308
V306,V309
Q204
Q205~Q206,Q212
Q211,Q218,Q219
V305,V310
V303,V304
V301,V302
U219
U219
U219
U205
U205
U203,U204
U203,U204
U209
U207
U202
U201
U302
X201
PCS
PCS
PCS
1
1
1
XS203
XS301
0390057
35
1940024
1940005
SOCKET
SOCKET
5P 2.0mm
6P 2.0mm
36
PCS
PCS
1
3
XS302
XS303,XS201,XS304