Download Usermanual

OUT 4 - Relay output 4 (terminals 19, 20, 21): 7KHRXWSXWFDQEH
VHWLQRQHRIWKHIXQFWLRQVGHVFULEHGLQ$GYDQFHG&RQILJXUDWLRQSDU
4.1.2 Connecting BUS photocells
Up to 8 pairs of photocells can be connected to the E680 control board
XVLQJ %86 WHFKQRORJ\ 7KH FRQQHFWLRQ PXVW EH PDGH LQ SDUDOOHO 7KH GHIDXOW YDOXH LV
RQWHUPLQDOERDUG-XVLQJDVLQJOHSRZHUFRPPXQLFDWLRQOLQHDV load: 24 VDC with 800 mA.
VKRZQLQ)LJ
01
4.3 7HUPLQDOERDUG-H[WHUQDOÀDVKLQJODPS
BUS photocells do not require a matching polarity
connection.
ENGLISH
- BEAM ILLUMINATION. Maximum
7KHSDLUVRISKRWRFHOOVIHDWXUHWKHIROORZLQJIXQFWLRQV
3DLUVRIFORVLQJSKRWRFHOOV PD[
3DLUVRI23(1SXOVHSKRWRFHOOV
PD[
$IWHU SRVLWLRQLQJ WKH %86 WHFKQRORJ\ SKRWRFHOOV LW LV QHFHVVDU\
WR SURFHHG ZLWK VHOHFWLQJ WKH DGGUHVV IRU HDFK SDLU XVLQJ YDULRXV
combinations of the ',36:,7&+(6 located on each photocell.
Set the SAME DIP-SWITCH ADDRESS chosen both on
the transmitter and receiver of the same pair.
LAMP: WR WKHVH WHUPLQDOV \RX FDQ FRQQHFW D 9'& )$$&/('
H[WHUQDOIODVKLQJODPSThe integrated flashing traffic light must be
connected independently to connector J15.
The 24V FAACLIGHT with incandescent lamp cannot be
connected to the J3 connector
4.4 Terminal board J4 (loop detector)
LOOP 1: PDJQHWLF ORRS /223 23(1 WHUPLQDOV IRU
OPENING.
LOOP 2: PDJQHWLFORRS/2236$)(7<&/26(WHUPLQDOV
for SAFETY/CLOSING.
Ensure that two or more pairs of photocells do not have
the same address. If no BUS accessories are used, leave
terminals 1 and 2 free.
4.5 Connector J5 (Motor)
7KH IROORZLQJ WDEOH GHVFULEHV KRZ WR VHW WKH GLSVZLWFKHV ORFDWHG
inside the transmitter and receiver of the BUS photocells.
5DSLGFRQQHFWRUIRUFRQQHFWLQJWKHPRWRU
Addressing BUS photocell PAIRS
4.6 Connector J7 (Encoder)
',36:,7&+
TX
',36:,7&+
RX
SAME
ADDRESS
Dip 1 Dip 2 Dip 3 Dip 4
7KH%+EDUULHULVHTXLSSHGZLWKDGHYLFHIRUGHWHFWLQJWKHRSHQLQJ
DQJOHEDUSRVLWLRQWRHQVXUHJUHDWHUDQWLFUXVKLQJVDIHW\WKDQNVWR
WKHSRVVLELOLW\RIUHYHUVLQJWKHGLUHFWLRQRIPRYHPHQWWKHPRPHQWLQ
which an obstacle is detected. This device interfaces with the board
WKURXJKFRQQHFWRU-
Pair
no.
ON
OFF
OFF
OFF
ƒ3DLU
ON
OFF
OFF
ON
ƒ3DLU
ON
OFF
ON
OFF
ƒ3DLU
ON
OFF
ON
ON
ƒ3DLU
ON
ON
OFF
OFF
ƒ3DLU
ON
ON
OFF
ON
ƒ3DLU
ON
ON
ON
OFF
ƒ3DLU
ON
ON
ON
ON
6LQJOH
Type
4.7 Connector J10 (Radio)
8VHGIRUWKHUDSLGFRQQHFWLRQRIWKH0LQLGHF'HFRGHUDQG5353
5HFHLYHUVVHH)LJ,IDFKDQQHOUHFHLYHULVXVHGOLNHWKH53
LWZLOOEHSRVVLEOHWRGLUHFWO\FRPPDQGDXWRPDWHGV\VWHP23(1DQG
&/26(IURPDFKDQQHOUDGLRFRQWURO,IDFKDQQHOUHFHLYHULVXVHG
OLNHWKH53LWZLOORQO\EHSRVVLEOHWRFRPPDQG23(1
&RQQHFW WKH DFFHVVRU\ ZLWK WKH FRPSRQHQWV VLGH IDFLQJ WKH PDLQ
strip of the board.
CLOSE
photocells
Boards should be inserted and removed ONLY after
having cut off electrical power
4.8 Connector J11 (Beam break-out sensor)
'HVLJQHGIRUFRQQHFWLQJWKHEUHDNRXWVHQVRUIRUWKHSLYRWLQJEHDP
LISUHVHQW7KHVHQVRULVRSWLRQDO,ILWLVQRWSUHVHQWdo not remove
WKHLQVWDOOHGMXPSHU
OPEN
PULSE
4.9 Connector J12 (Emergency battery)
7KLV FRQQHFWRU LV IRU FRQQHFWLQJ D EDWWHU\ RSWLRQDO IRU HQVXULQJ
DXWRPDWHGV\VWHPRSHUDWLRQLQFDVHRIWHPSRUDU\FXWRIIRIWKHPDLQ
SRZHUVXSSO\
To allow operation of the installed BUS accessories,
store them on the board as described in paragraph 5.3.
4.2 Terminal board J2 (outputs)
4.10 Connector J13 (36VDC Power Supply)
OUT 1 - Output 1 open-collector GND (terminal 13):7KHRXWSXWFDQ 7KLVIDFWRU\ZLUHGFRQQHFWRUSRZHUVWKH(ERDUG
EHVHWLQRQHRIWKHIXQFWLRQVGHVFULEHGLQWKH$GYDQFHG&RQILJXUDWLRQ
04
SDU 7KH GHIDXOW YDOXH LV
- Beam OPEN or in PAUSE.
Maximum load: 24 VDC with 100 mA.
4.11 &RQQHFWRU-ÀDVKLQJWUDI¿FOLJKW
7KLV FRQQHFWRU LV IRU FRQQHFWLQJ WKH IODVKLQJ WUDIILF OLJKW EXLOW LQWR
WKH EDUULHU KHDG 7KH IODVKLQJ WUDIILF OLJKW YLVXDOO\ VLJQDOV EDUULHU
OUT 2 - Output 2 open-collector GND (terminal 15):7KHRXWSXWFDQ PRYHPHQW DQG LI QHHGHG UHJXODWH DFFHVV WR WKH SURSHUW\ XVLQJ
EHVHWLQRQHRIWKHIXQFWLRQVGHVFULEHGLQWKH$GYDQFHG&RQILJXUDWLRQ WUDIILFOLJKWVLJQDOV
03 - CLOSED BEAM. Maximum load:
SDU7KHGHIDXOWYDOXHLV
24 VDC with 100 mA.
5. PROGRAMMING
7KH(ERDUGIHDWXUHVSURJUDPPLQJOHYHOVWKDWPDNHLWHQWLUHO\
OUT 3 - Output 3 open-collector GND (terminal 17): 7KHRXWSXWFDQ FRQILJXUDEOHDQGDOORZLWWRDGDSWWKHORJLFVWRDQ\XVH
EHVHWLQRQHRIWKHIXQFWLRQVGHVFULEHGLQWKH$GYDQFHG&RQILJXUDWLRQ (DFK RI WKH WKUHH OHYHOV FDQ EH DFFHVVHG WKURXJK D VSHFLILF NH\
SDU7KHGHIDXOWYDOXHLV
:$51,1*/$03Maximum load: combination.
24 VDC with 100 mA.
19
8