Download MAINTENANCE INTERVALS - Safety

85
Maintenance Section
Maintenance Interval Schedule
i01649245
Every 50 Service Hours
Maintenance Interval Schedule
Idler Swing Link - Lubricate ................................ 115
SMCS Code: 7000
Every 50 Service Hours or Weekly
Note: All safety information, warnings, and
instructions must be read and understood before
you perform any operation or any maintenance
procedure.
Track Pins - Inspect ............................................. 122
Before each consecutive interval is performed, all
of the maintenance requirements from the previous
interval must also be performed.
When Required
Battery - Recycle .................................................. 90
Battery, Battery Cable or Battery Disconnect Switch Replace ............................................................... 90
Bucket Teeth and Cutting Edges - Inspect/
Replace ............................................................... 90
Cab Air Filter - Clean/Replace .............................. 91
Circuit Breakers - Reset ........................................ 92
Engine Air Filter Primary Element Clean/Replace .................................................... 96
Engine Air Filter Secondary Element - Replace ... 98
Engine Air Precleaner - Clean .............................. 98
Equalizer Bar Pins - Inspect ............................... 102
Ether Starting Aid Cylinder - Replace ................. 102
Fuel System - Prime ........................................... 104
Fuses - Replace .................................................. 108
Oil Filter - Inspect ................................................ 117
Radiator Core - Clean ......................................... 119
Radiator Pressure Cap - Clean/Replace ............ 119
Ripper Tip and Shank Protector - Inspect/
Replace ............................................................. 120
Window Washer Reservoir - Fill .......................... 125
Window Wipers - Inspect/Replace ...................... 126
Every 10 Service Hours or Daily
Every 100 Service Hours or 2 Weeks
Loader Linkage Pins - Lubricate ......................... 116
Multipurpose Bucket - Lubricate ......................... 116
Every 250 Service Hours or Monthly
Air Conditioner - Test ............................................ 87
Air Conditioner Belt - Inspect/Adjust/Replace ....... 87
Alternator and Fan Belts - Inspect/Adjust/
Replace ............................................................... 88
Battery - Inspect ................................................... 89
Cooling System Additive (DEAC) - Add ................ 92
Engine Oil and Filter - Change ........................... 100
Engine Valve Lash - Check ................................. 101
Equalizer Bar End Pins - Lubricate ..................... 101
Equalizer Bar Pins - Lubricate ............................ 102
Final Drive Oil Level - Check ............................... 104
Fuel System Secondary Filter - Replace ............ 106
Pivot Shaft Oil Level - Check .............................. 117
Recoil Piston - Lubricate ..................................... 119
Steering Linkage - Lubricate ............................... 120
Track Adjustment - Adjust ................................... 121
Water Pump Belt - Inspect/Adjust/Replace ......... 124
Every 500 Service Hours or 3 Months
Engine Crankcase Breather - Clean ..................... 99
Fuel System Primary Filter (Water Separator)
Element - Replace ............................................ 105
Fuel Tank Cap and Strainer - Clean ................... 107
Every 1000 Service Hours or 6 Months
Seat Belt - Inspect .............................................. 120
Hydraulic System Oil Filter - Replace ................. 110
Hydrostatic Transmission Oil Filter - Replace ..... 112
Every 10 Service Hours
Every 2000 Service Hours or 1 Year
Backup Alarm - Test .............................................. 89
Bucket Lower Pivot Pin - Lubricate ....................... 90
Cooling System Level - Check .............................. 95
Engine Oil Level - Check ...................................... 99
Final Drive - Inspect ............................................ 103
Fuel Tank Water and Sediment - Drain ............... 107
Hydraulic System Oil Level - Check .................... 111
Hydrostatic Transmission Gear Box Oil Level Check ................................................................ 114
Indicators and Gauges - Test .............................. 115
Pump Drive Oil Level - Check ............................. 118
Track Adjustment - Check ................................... 122
Walk-Around Inspection ...................................... 123
Windows - Clean ................................................. 125
Hydraulic System Oil - Change ........................... 109
Every 2000 Service Hours or 1 Year
Final Drive Oil - Change .....................................
Hydrostatic Transmission Gear Box Oil Change .............................................................
Pump Drive Oil - Change ....................................
Track Roller Frame - Inspect ...............................
103
113
117
123
Every 3000 Service Hours or 2 Years
Cooling System Coolant (DEAC) - Change .......... 93
Cooling System Extended Life Coolant Extender Add ...................................................................... 95