Download Samsung SGH-I560 Service manual
Transcript
GSM TELEPHONE SGH-i560V GSM TELEPHONE CONTENTS 1. Safety Precautions 2. Specification 3. Product Function 4. Array course control 5. Exploded View and Parts List 6. Main Electrical Parts List 7. Block Diagrams 8. PCB Diagrams 9. Flow Chart of Troubleshooting 10. Reference data 11. Disassembly and Assembly Instructions GSPN (Global Service Partner Network) Country North America Latin America CIS Europe China Asia Mideast & Africa Web Site service.samsungportal.com latin.samsungportal.com cis.samsungportal.com europe.samsungportal.com china.samsungportal.com asia.samsungportal.com mea.samsungportal.com This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law. ⓒ Samsung Electronics Co.,Ltd. 2007. 11 Rev.1.0 1. Safety Precautions 1-1. Repair Precaution ● Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because the specification of cellular phone is sensitive for surrounding interference(RF noise). ● Be careful to use a kind of magnetic object or tool, because performance of parts is damaged by the influence of magnetic force. ● Surely use a standard screwdriver when you disassemble this product, otherwise screw will be worn away. ● Use a thicken twisted wire when you measure level. A thicken twisted wire has low resistance, therefore error of measurement is few. ● Repair after separate Test Pack and Set because for short danger (for example an overcurrent and furious flames of parts etc) when you repair board in condition of connecting Test Pack and tuning on. ● Take specially care of soldering, because Land of PCB is small and weak in heat. ● Surely tune on/off while using AC power plug, because a repair of battery charger is dangerous when tuning ON/OFF PBA and Connector after disassembling charger. ● Don't use as you pleases after change other material than replacement registered on SEC System. Otherwise engineer in charge isn't charged with problem that you don't keep this rules. 1-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Safety Precautions 1-2. ESD(Electrostatically Sensitive Devices) Precaution Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD (Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below. You can prevent from ESD damage by static electricity. ● Remove static electricity remained your body before you touch semiconductor or parts with semiconductor. There are ways that you touch an earthed place or wear static electricity prevention string on wrist. ● Use earthed soldering steel when you connect or disconnect ESD. ● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by static electricity. ● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and aluminum plate to have conductive power,they are prevented from static electricity. ● You must maintain electric contact between ESD and place due to be set up until ESD is connected completely to the proper place or a circuit board. 1-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 2. Specification 2-1. GSM General Specification EGSM 900 DCS 18 00 PCS 190 0 WCDMA 2100 Fre q. Band[MHz] Uplink/Downlink 880~91 5 925~96 0 1 710~17 85 1 805~18 80 1 850~19 10 1 930~19 90 1 920~19 80 2 110~21 70 ARFCN r ange 0~124 & 9 75~102 3 512~88 5 512~81 0 UL:9 612~98 88 DL:10 562~10 838 Tx/Rx spa cing 10MHz 20MHz 20MHz 130MHz Mod. Bit rat e/ Bit Period 27 0.833 kbps 3.692 us 27 0.833 kbps 3.692 us 27 0.833 kbps 3.692 us 3. 84Mcps (chip ra te) T ime Slot Per iod/ Fra me Per iod 576.9 us 4. 615ms 576.9 us 4. 615ms 576.9 us 4. 615ms F rame l ength : 10ms Slot lengt h : 0. 667ms Modulation 0.3G M SK 0.3G MSK 0.3G M SK QPSK HPSK MS Powe r 33 dBm~5d Bm 30 dBm~0d Bm 30 dBm~0d Bm 2 4dBm~- 50dBm Power Class 4 (max +33dBm) 1 (max +30dBm) 1 (max +30dBm) Sensit ivit y -1 02dBm -1 00dBm -1 00dBm T DM A Mu x 8 8 8 Cell Radius 35Km 2Km 2Km 2-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 3 (max +24dBm) - 106.7 dBm 2Km Specification 2-2. GSM TX power class TX Power TX Power TX Power control level GSM850 GSM900 control level 5 33±2 dBm 0 30±3 dBm 0 30±3 dBm 6 31±2 dBm 1 28±3 dBm 1 28±3 dBm 7 29±2 dBm 2 26±3 dBm 2 26±3 dBm 8 27±2 dBm 3 24±3 dBm 3 24±3 dBm 9 25±2 dBm 4 22±3 dBm 4 22±3 dBm 10 23±2 dBm 5 20±3 dBm 5 20±3 dBm 11 21±2 dBm 6 18±3 dBm 6 18±3 dBm 12 19±2 dBm 7 16±3 dBm 7 16±3 dBm 13 17±2 dBm 8 14±3 dBm 8 14±3 dBm 14 15±2 dBm 9 12±4 dBm 9 12±4 dBm 15 13±2 dBm 10 10±4 dBm 10 10±4 dBm 16 11±3 dBm 11 8±4 dBm 11 8±4 dBm 17 9±3 dBm 12 6±4 dBm 12 6±4 dBm 18 7±3 dBm 13 4±4 dBm 13 4±4 dBm 19 5±3 dBm 14 2±5 dBm 14 2±5 dBm 15 0±5 dBm 15 0±5 dBm DCS1800 control level 2-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS1900 3. Product Function Main Function HSDPA/UMTS, EDGE, GPRS Bluetooth v2.0 + EDR USB v2.0 HS compatible Camera 3Mega x 9 Digital Zooming and camcorder FM Radio Instant Messaging capability E-mail Featured applications provide alarms, calendar, calculator, record audio, converter, timer, stopwatch, and world time. File viewer (MS office, PDF) Multimedia Message Service (MMS) Multimedia capability (with included Media player) Photo caller ID Speakerphone capability WEB/WAP browser (HTMS, xHTML, WML) 3-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Product Function 3-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 4. Array course control 4-1. Software Adjustments - There is 2 set to download the binary image into your device. [First set] 8 1. 2. 3. 4. 5. 6. 7. 8. JIG BOX (UMTS TEST JIG; GH80-03308A) USB Cable : JIG to PC Test Cable : JIG to SGH-i560 (GH39-00890A) Power Cable : JIG to power supply Serial Cable : SGH-i560 to PC Power Supply Rf Cable : SGH-i560 to Agilent 8960 or CMU200 (GH39-00397A) Test Cable : JIG to SGH-i560 (GH39-00886A) 4-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control [Second Set] USB Data Link Cable : SGH-i560 to PC (GH39-00922A) Standard Battery for SGH-i560 (GH43-02992A) 4-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2. Software Download 4-2-1. Pre-requisite for Download SGH - i560 Mobile Device Apollo v4.01.exe : Downloader Application for SGH-i560 USB Download Driver : SS60_Downloader_Driver.zip Rom Image : PDA(*.IMG), MODEM(*.BIN) images Equipment set for Download. 4-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-2. Concupts & cautions. You can download PDA or MODEM separately. But We are always recommended to download both at the same time using same version of rom image. To download an image, the phone need to be set to a proper download mode. There are 3 download modes. PDA download : Hold 1, 4 keys and power on -> Blue screen with some information. MODEM download : Hold 7, * keys and power on -> Blinking "MODEM DOWNLOAD" on blue screen All download : Hold 4, 7 keys and power on -> Blinking "ALL DOWNLOAD" on blue screen For PDA image download, the phone shows download progress on the screen For MODEM image download, the phone shows RGBW/B Screen. For All download mode, MODEM image is downloaded first and then PDA downloading starts. After downloading PDA, the phone will be reboot. Do NOT interrupt downloading process or the phone will be damaged. You would be unable to boot up the phone or to re-flash the phone. Let it finish downloading process even though you are flashing wrong images. 4-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-3. USB Driver installation for PDA Execution Apollo.exe. SGH-i560 connect to the Host computer using download equipment set. Hold “1+4” key and insert power supplied test cable when use equipment set 1 or Hold “1+4” key and press power on key when use equipment set 2. Install PDA side driver. Follow New H/W Installation Manager. Select ‘IBootHostUSB.inf’file under ‘i560_Apollo_Drivers\PDA_driver’ folder when Windows asks for new h/w driver. It is safe to choose “Yes” for the waring window. Confirm “SAMSUNG BlueFin USB Downloader” Installed. Refer to Next Page. ** If Windows doesn’t ask for USB driver, it means USB driver installation was failed before. Open Hardware Manager then delete devices with?or!mark then try again. If it doesn’t work, you need to right click on the device then try Driver Update. After installing PDA driver, Apollo shows the connection status if it is installed properly. 4-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-4. USB Driver installation for MODEM Hold “7 + *” key and insert power supplied test cable when use equipment set 1 or Hold “7+ *” key and press power on key when use equipment set 2. Install Modem side driver. Execute ‘Setup.exe’file under ‘i560_Apollo_Drivers\PHONE_driver’ folder when Windows asks for new h/w driver. Confirm “SAMSUNG USB Composite Device” Installed. 4-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-5. USB Driver installation 4-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-6. Download the image using APOLLO Execution Apollo.exe. Select a Rom Image to download Check this field : 4. SGH-i560(Martini) 4-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control Select the proper check option . PDA stasus - Bootloader : Update PDA Bootloader section. - NV Clear : IMEI section erase. You can see following message when you click this option MODEM Status - Boot Update : Update Modem Bootloader section. 4-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control Make sure that phone and host computer connection, click proper download button. PDA download : Hold 1, 4 keys and power on -> Blue screen with some information. MODEM download : Hold 7, * keys and power on -> Blinking "MODEM DOWNLOAD" on blue screen All download : Hold 4, 7 keys and power on -> Blinking "ALL DOWNLOAD" on blue screen 4-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control Do NOT interrupt downloading process. - Pda download time: About 1 min. - Modem download time : About 2 min. - All download time: About 3 min. Confirm Download Complete. - SGH-i560 will be reboot when PDA download complete. 4-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-7. Troubleshooting Unable to install USB driver. Try another Download equipment Try another SGH-i560. Consult to R&D team. Download stops in the middle. Close and launch Apollo again then try again. Check the battery is charged enough. Download doesn’t start Check the connection between Apollo and a SGH-i560. Check the image that is not damaged. Select an image and download again. Phone doesn’t boot up after downloading. Check the release version of PDA and MODEM. They should be same. Make sure that rom image, and then try to download. 4-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 5. Exploded View and Parts List 5-1. Cellular phone Exploded View QRF03 QFR01 QMW02 QCR73 QSH01 QSH02 QSP05 QVO01 QCR12 QFU01 QCK01 QMP01 QAN11 QSC06 QCK02 QMI01 QAN03 QMO01 QCR72 QSC05 QCA01 QKP02 QAN02 QSP01 QAR01 QCR67 QCA10 QSD01 QLC01 QME02 QRE01 QPC01 QIF01 QFL02 QCR06 QCR12 QRF01 QCR06 QBA01 QFL01 QHI01 QBA00 5-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 5-2. Cellular phone Parts List Design LOC Description SEC CODE QAN02 INTENNA-SGHI560V GH42-01423A QAN03 INTENNA-SGHI560V BT FPCB GH42-01451A QAN11 ASSY-CUSHION-CUSHION RUBBER IN GH98-01077A QAR01 AUDIO-RECEIVER 3009-001300 QBA00 PMO COVER-BATT GH72-44575A QBA01 INNER BATTERY PACK-1200MAH , B GH43-02992A QCA01 CAMERA MODULE-1/4" 3.1M CMOS GH59-05024A QCA10 CAMERA MODULE-1/24" VT CMOS GH59-05022A QCK01 PMO KEY-CAMERA GH72-44572A QCK02 PMO KEY-POWER GH72-44573A QCR06 SCREW-MACHINE 6001-001155 QCR06 SCREW-MACHINE 6001-001155 QCR12 SCREW-MACHINE 6001-001530 QCR12 SCREW-MACHINE 6001-001530 QCR67 SCREW-MACHINE 6001-002083 QCR72 SCREW-MACHINE 6001-002051 QCR73 SCREW-MACHINE 6001-002102 QKP02 ASSY KEYPAD-SUB(VOD/BLK) GH98-06756A QLC01 LCD-SGHI560V GH07-01211A QME02 DOME SHEET-SGHI560V SUB 12KEY GH59-05042A QMI01 MICROPHONE-ASSY-SGHI560V GH30-00438A QMO01 MOTOR LINEAR VIBRATION-SGHI560 GH31-00384A QMP01 PBA MAIN-SGHI560V GH92-04151A QMW02 PMO WINDOW-MAIN(VOD) GH72-44581A QPC01 MEA-FPCBKIT GH97-08391A QRF01 TAPE-RF GH74-35878A QSH01 ASSY BRACKET-SHIELD CAN GH98-06755A QSH02 ICT BRACKET-SHIELD COVER GH70-03059A QSP01 ASSY ETC-SPEAKER MODULE GH59-05123A 5-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List Design LOC Description SEC CODE QVO01 PMO KEY-VOLUME GH72-44574A QFL01 ASSY CASE-LOWER GH98-06414A QFL02 ASSY CASE-SLIDE LOWER GH98-06754A QHI01 ASSY HINGE-SLIDE GH98-06412A ASSY CASE-FRONT GH98-06417A PMO COVER-EAR GH72-44576A ASSY CASE-UPPER(AL) GH98-07148A QSC05 ASSY RUBBER-SLIDE UP L GH98-06892A QSC06 ASSY RUBBER-SLIDE UP R GH98-06893A QSP05 ASSY DECO-SPK GH98-06757A ASSY CASE-REAR GH98-06416A QIF01 PMO COVER-IF GH72-44578A QSD01 PMO COVER-SD GH72-44579A QFR01 QRF03 QFU01 QRE01 5-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List Description SEC CODE BAG PE 6902-000634 CBF INTERFACE-DLC APCBS10BBE(S GH39-00922A ADAPTOR-ATADS10EBE,BLK,EU GH44-01702A S/W CD-SGHI560V SAMSUNG PC 7.0 GH46-00550A S/W CD-SGHI560V USER GUIDE 1.0 GH46-00560A EARPHONE-SGHE210,AAEP405MBE,A GH59-04535A LABEL(P)-UNIT SEAL GH68-00518B LABEL(R)-WATER SOAK GH68-09361A MANUAL USERS-VODA SPANISH QRG GH68-16620A LABEL(R)-MAIN(EU) GH68-16810A CUSHION-CASEVODA) GH69-06153A BOX-UNIT(EU) GH69-06183A TAPE-PBA GH74-35879A TAPE GASK-LCD CON GH74-36274A SPONGE-SPK STRUCTURE GH74-36280A TAPE-BB ABSORBER GH74-36305A TAPE ELEC-FRONT BB GH74-36306A TAPE ELEC-FRONT GH74-36307A VINYL-BOHO UPPER GH74-36310A TAPE INSU-SIM SOKET GH74-36385A TAPE INSU-LCD CON GH74-36393A TAPE-CK GH74-36394A TAPE INSU-FLASH FPCB GH74-36396A SPONGE-SUB SLIDE GH74-36491A VINYL-BOHO MAIN WINDOW GH74-36749A 5-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 6. Main Electrical Parts List SEC Code Design LOC Description STATUS 0403-001547 0406-001150 0406-001197 0406-001208 0406-001208 0406-001208 0406-001231 0406-001231 0406-001231 0406-001231 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001256 0406-001256 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0407-000115 0407-001002 0407-001002 0407-001007 0504-001113 0504-001113 0504-001113 0505-001165 0801-002294 0801-002294 0801-002294 0801-002321 0801-003012 0801-003013 0801-003052 0801-003124 D502 ZD700 ZD708 ZD802 ZD808 ZD811 ZD600 ZD601 ZD602 ZD603 ZD200 ZD500 ZD505 ZD604 ZD803 ZD804 ZD805 ZD806 ZD807 ZD809 ZD810 ZD812 ZD501 ZD502 ZD1000 ZD1001 ZD1003 ZD1005 ZD1006 ZD300 ZD301 ZD701 ZD702 ZD703 ZD704 ZD705 ZD706 ZD707 D800 D500 D501 D503 TR500 TR501 TR503 TR502 U401 U513 U514 U1000 U511 U402 U400 U512 DIODE-ZENER DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-ARRAY DIODE-ARRAY DIODE-ARRAY DIODE-ARRAY TR-DIGITAL TR-DIGITAL TR-DIGITAL FET-SILICON IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC IC-CMOS LOGIC SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 0801-003205 0904-002295 1001-001336 1001-001362 1001-001401 1001-001436 1001-001461 1001-001483 1001-001483 1001-001483 1001-001483 1001-001483 1001-001483 1009-001027 1106-001511 1108-000127 1108-000135 1201-002180 1201-002233 1201-002531 1201-002570 1201-002581 1202-001068 1203-002716 1203-003643 1203-003643 1203-003737 1203-003737 1203-003737 1203-003978 1203-004430 1203-004464 1203-004607 1203-004621 1203-004778 1203-004838 1204-002746 1205-002767 1205-003169 1205-003281 1205-003297 1404-001221 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 1405-001138 U509 UCP900 U706 U603 U1004 U1002 U601 U800 U801 U802 U803 U804 U805 U702 UME1000 UME400 UCP900UP U1003 U605 U303 U202 F304 U1001 U510 U703 U705 U700 U704 U710 U707 U505 U515 U701 U602 U501 U500 U308 U504 MOD200 UCP400 U201 TH400 VR800 VR801 VR802 VR803 VR804 VR805 VR806 VR807 VR808 VR809 VR810 VR811 IC-CMOS LOGIC IC-DSP IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-ANALOG SWITCH IC-HALL EFFECT S/W IC-SRAM IC-MCP IC-MCP IC-AUDIO AMP IC-AUDIO AMP IC-POWER AMP IC-POWER AMP IC-RF AMP IC-VOLTAGE COMP. IC-VOL. DETECTOR IC-MULTI REG. IC-MULTI REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-DC/DC CONVERTER IC-VOL. DETECTOR IC-VOL. DETECTOR IC-MULTI REG. IC-POWER SUPERVISOR IC-POWER SUPERVISOR IC-BATTERY IC-TUNER IC-SWITCH IC-DATA COMM./GEN. IC-MODEM IC-TRANSCEIVER THERMISTOR-NTC VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-000137 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000140 2007-000148 2007-000148 2007-000148 2007-000148 2007-000148 2007-000157 2007-000159 2007-000161 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000164 2007-000165 2007-000165 2007-000169 2007-000170 2007-000170 2007-000170 2007-000170 2007-000170 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 R419 R1040 R1043 R310 R642 R643 R720 R722 R1032 R210 R405 R407 R412 R523 R530 R909 R305 R1004 R1007 R1019 R1021 R500 R510 R511 R527 R537 R602 R701 R716 R903 R700 R518 R639 R1029 R1026 R1027 R1028 R422 R519 R1002 R205 R211 R214 R221 R300 R301 R304 R311 R312 R313 R317 R319 R538 R922 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-001119 2007-001119 2007-001285 2007-001285 2007-001290 2007-001292 2007-001298 2007-001298 2007-001298 2007-001298 2007-001306 2007-001306 2007-001306 2007-001306 2007-001316 2007-001339 2007-001339 2007-007009 2007-007014 2007-007014 2007-007107 2007-007107 2007-007107 2007-007107 2007-007132 2007-007132 2007-007136 2007-007136 2007-007136 2007-007139 2007-007139 2007-007142 2007-007190 2007-007190 2007-007306 2007-007306 2007-007307 2007-007307 2007-007307 2007-007307 2007-007309 2007-007309 2007-007315 2007-007316 2007-007317 2007-007317 2007-007317 2007-007468 2007-007528 2007-007528 2007-007698 2007-007766 2007-007791 2007-008045 R603 R604 R207 R208 R418 R414 R209 R215 R303 R402 R212 R213 R216 R217 R517 R715 R806 R306 R506 R520 R220 R423 R425 R705 R1013 R1045 R625 R629 R923 R624 R626 R509 R902 R921 R302 R307 R1030 R1031 R721 R726 R202 R526 R516 R421 R539 R900 R901 R505 R610 R614 R508 R515 R704 R1044 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-008045 2007-008052 2007-008052 2007-008052 2007-008052 2007-008055 2007-008055 2007-008419 2007-008419 2007-008419 2007-008483 2007-008483 2007-008483 2007-008483 2007-008516 2007-008516 2007-008516 2007-008542 2007-008542 2007-008542 2007-008588 2007-008806 2007-008806 2007-008806 2007-008806 2007-008806 2007-008806 2007-008806 2007-008806 2007-008806 2007-009157 2007-009157 2007-009157 2007-009157 2007-009157 2007-009793 2007-009793 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000254 2203-000254 2203-000254 R749 R904 R905 R906 R907 R514 R601 R733 R734 R737 R521 R522 R524 R525 R314 R640 R641 R634 R735 R736 R218 R507 R528 R529 R532 R533 R534 R535 R541 R605 R1005 R1006 R1009 R1010 R738 R1011 R1012 C1014 C207 C209 C218 C220 C234 C239 C247 C256 C279 C325 C512 C513 C520 C225 C253 C276 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-000254 2203-000254 2203-000254 2203-000254 2203-000254 2203-000254 2203-000278 2203-000278 2203-000278 2203-000278 2203-000311 2203-000311 2203-000311 2203-000311 2203-000330 2203-000330 2203-000330 2203-000330 2203-000330 2203-000386 2203-000386 2203-000386 2203-000386 2203-000386 2203-000438 2203-000438 2203-000438 2203-000489 2203-000627 2203-000627 2203-000627 2203-000627 2203-000627 2203-000627 2203-000627 2203-000627 2203-000627 2203-000679 2203-000679 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 C315 C317 C321 C443 C656 C658 C600 C626 C633 C642 C200 C202 C203 C205 C268 C273 C282 C283 C304 C264 C306 C680 C681 C682 C259 C316 C464 C402 C217 C222 C224 C228 C230 C232 C233 C254 C260 C238 C244 C1012 C1013 C214 C236 C237 C241 C243 C255 C262 C275 C305 C320 C328 C330 C332 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SNA SNA SNA SNA SNA SNA SNA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-000995 2203-001153 2203-001153 2203-001259 2203-002668 2203-002668 2203-002709 2203-002709 2203-002709 2203-002709 2203-002968 2203-003054 2203-003054 2203-005053 2203-005053 2203-005056 2203-005234 2203-005281 2203-005281 2203-005281 2203-005395 2203-005480 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005682 2203-005682 C527 C528 C531 C627 C635 C643 C652 C653 C720 C1008 C1009 C300 C401 C469 C663 C664 C678 C751 C752 C201 C204 C601 C303 C334 C503 C506 C515 C517 C250 C1006 C1007 C272 C274 C291 C280 C263 C265 C322 C271 C463 C301 C312 C326 C336 C406 C413 C420 C444 C450 C461 C462 C941 C231 C329 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-005682 2203-005682 2203-005682 2203-005682 2203-005683 2203-005725 2203-005725 2203-005727 2203-005729 2203-005732 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005806 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006137 2203-006194 2203-006194 2203-006194 2203-006194 2203-006208 2203-006208 2203-006208 2203-006261 2203-006324 2203-006324 2203-006324 2203-006324 2203-006324 2203-006324 2203-006324 2203-006348 2203-006348 2203-006377 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 2203-006399 C611 C631 C637 C644 C1025 C211 C212 C510 C508 C266 C213 C816 C817 C818 C819 C226 C277 C278 C538 C700 C701 C313 C439 C447 C466 C468 C509 C516 C519 C339 C465 C500 C521 C650 C736 C737 C738 C535 C536 C719 C1017 C284 C285 C286 C287 C288 C407 C408 C409 C410 C418 C617 C623 C625 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006399 2203-006399 2203-006399 2203-006399 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006474 2203-006474 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 C740 C805 C960 C963 C1002 C1003 C1004 C1005 C327 C417 C419 C436 C440 C451 C452 C539 C610 C612 C674 C741 C900 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C919 C920 C921 C922 C923 C924 C925 C926 C955 C961 C962 C522 C541 C1000 C1001 C1011 C1018 C1019 C1020 C1021 C1022 C1023 C314 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006585 2203-006585 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 C400 C432 C433 C434 C435 C438 C442 C467 C507 C511 C540 C603 C604 C605 C606 C607 C608 C609 C613 C615 C616 C622 C647 C648 C649 C659 C662 C666 C667 C668 C702 C705 C706 C709 C715 C716 C729 C745 C750 C810 C812 C813 C814 C911 C912 C927 C928 C630 C636 C206 C208 C210 C215 C216 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006712 2203-006712 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006825 2203-006825 2203-006825 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006838 2203-006841 2203-006841 2203-006841 2203-006890 2203-006890 2203-006890 2203-006890 2404-001339 2404-001339 2404-001377 2404-001381 2404-001381 2404-001381 2404-001381 2404-001381 2404-001381 2404-001474 2404-001492 2404-001492 2404-001497 2703-001180 2703-001231 2703-001513 2703-001722 C223 C227 C229 C235 C240 C248 C257 C261 C318 C654 C657 C660 C504 C505 C524 C703 C704 C671 C672 C673 C1026 C514 C518 C523 C545 C746 C747 C748 C913 C929 C529 C530 C958 C707 C708 C710 C711 TA201 TA611 TA609 TA300 TA600 TA604 TA608 TA700 TA808 TA200 TA500 TA502 TA602 L205 L702 L1004 L208 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SA SA 6-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2703-001749 2703-001750 2703-002170 2703-002170 2703-002170 2703-002203 2703-002204 2703-002207 2703-002208 2703-002314 2703-002314 2703-002314 2703-002365 2703-002367 2703-002369 2703-002506 2703-002596 2703-002782 2703-002782 2703-002782 2703-002906 2703-002918 2703-003103 2703-003298 2703-003298 2801-004339 2801-004455 2801-004466 2804-001748 2809-001324 2901-001337 2901-001337 2901-001389 2901-001389 2901-001389 2904-001609 2904-001635 2904-001665 2904-001702 2904-001703 2904-001719 2904-001759 2910-000031 3301-001342 3301-001534 3301-001534 3301-001534 3301-001729 3301-001729 3301-001729 3301-001729 3301-001756 3301-001756 3301-001756 L218 L315 L220 L221 L308 L206 L201 L303 L312 L202 L203 L316 L304 L219 L215 L310 L210 L500 L501 L502 L200 L306 L212 L600 L608 OSC500 OSC200 OSC600 OSC601 OSC602 F801 F804 F800 F802 F803 F205 F206 F300 F200 F201 F202 F303 DUF300 L700 L607 L609 L610 L1000 L1001 L701 L703 L307 L601 L602 INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD CRYSTAL-SMD CRYSTAL-SMD CRYSTAL-SMD OSCILLATOR-CLOCK OSCILLATOR-VCTCXO FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW DUPLEXER-SAW BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 3301-001756 3301-001756 3404-001152 3404-001152 3404-001152 3404-001152 3705-001358 3709-001453 3710-002081 3710-002568 3711-005643 3711-005945 3711-005976 3711-006025 3722-002609 4302-001181 4709-001338 4709-001399 GH71-06262A GH71-07941A L603 L604 TAC500 TAC800 TAC801 TAC802 RFS200 CD500 SPK600 IFC700 HEA700 HEA801 HEA800 BTC500 EAR1000 BAT501 F204 F301 ANT301 SC300 BEAD-SMD BEAD-SMD SWITCH-TACT SWITCH-TACT SWITCH-TACT SWITCH-TACT CONNECTOR-COAXIAL CONNECTOR-CARD EDGE SOCKET-BOARD TO BOARD SOCKET-INTERFACE HEADER-BOARD TO BOARD HEADER-BOARD TO BOARD HEADER-BOARD TO BOARD HEADER-BATTERY JACK-EAR PHONE BATTERY-LI(2ND) BALUN COUPLER-DIRECTION NPR-ANTENNA CONTACT V2 NPR SHIELD-FRAME SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA Please consult the GSPN website (Samsung Portal) for the most recent version of the product's part list. 6-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List 6-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 7. Block Diagrams 7-1. Main Block Diagram 7-1 Block Diagrams 7-2. RF Solution Block Diagram 7-2 8. PCB Diagrams Main top view 8-1 PCB Diagrams Main bottom view 8-2 9. Flow Chart of TroubleShooting 9-1. Logic Section 9-1-1 : No Power Press PWR KEY U514 pin4 NO Check pin #1 and #2 if One of them is low, output high? replace board YES TR502 pin1 NO output higher 3.5V? Check TR502, TR503, and neighboring circuits Replace board if required YES END 9-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting V_BAT V_EXT VIO VREG_TCXO_2.85V TR502 D501 1 5 PS_HOLD_PU 1 3 3 ON_SW 3 D502 1 2 SYSEN TA502 D503 U514 4 2 4 ZD500 2 IF_CON_SENSE VBAT 1 3 4 TR503 2 5 9-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization R519 G3 6 5 2 1 TA500 Flow Chart of Troubleshooting 9-1-2 : Abnormal initial operation (Normal +4.0V voltage source) Press PWR KEY 32KOUT is NO Check OSC600 and neighboring circuits exit? YES C671 voltage level NO Check L600 and neighboring circuits = 1.1~1.3V? YES NO C673 voltage level Check L608 and = 1.8V? neighboring circuits YES NO TR501 pin3 Check TR501 output is aserted? and neighboring circuits YES NO U401 pin4 Check U401 output is aserted? and neighboring circuits YES END 9-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 32KCLKOUT VBAT C600 2 1 C601 C650 OSC600 TA604 CLKEN CLK256FS P16 32KXIN P15 32KXOUT N10 32KCLKOUT 32KOUT T6 T7 R6 R7 N7 P2 P6 P1 CP_CAPM CP_CAPP CP_GND CP_IN ICTLAC1 ICTLAC2 ICTLUSB1 ICTLUSB2 C6 CLKEN D7 CLKEN2 G10 CLKREQ D13 CLK256FS 9-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization VHSMIC_OUT VSIM_OUT VMODE1 VMODE2|I2C_SR_SCL VIO_L VIO_IN VIO_GND K2 F8 D6 T4 R4 T3 VMODE SYS_VMODE VIO_IN VBAT1 VDD1_L Flow Chart of Troubleshooting VDD1 VIO_L D15 VDD1_L E14 VDD1_IN C15 VDD1_GND C671 VDD1_L DD2_L DD2_I N DD2_GND C C14 VDD1_L D14 VDD1_IN B15 VDD1_GND VDD1_OUT L600 9-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization ZD604 Flow Chart of Troubleshooting VIO L608 V1DD8 C673 VIO_L 9-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting L4 C10 G10 F10 K9 TR501 PM_INT_N PON_RESET_N MSM_PSHOLD SLEEP_CLK D11 1 2 DNC NC NC KPD_PWR_N MSM_INT_N PON_RESET_N PS_HOLD SLEEP_CLK 3 1 FONE_ON30 2 V2DD6 5 PON_RESET_N U401 1 R414 4 nMSM_RST FONE_RST 2 3 9-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-3 : Abnormal Camera operation Drive Camera U705 pin5, 6 & NO Check U705 and U703 U703 pin5, 6 EN#(high?) output Exist? and neighboring circuit YES NO C731 Check UCP900 output=48MHz? YES R800, R801 NO Check UCP900 I2C Clk, Data output = exist? END 9-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VCAM_18IO VCAM_28ISP VCAM_18C VBAT U703 U705 3 6 2 VIN VOUT1 5 EN1 VSS 3 4 EN2 VOUT2 VIN VOUT1 EN1 GND 2 1 EN2 VOUT2 GND 1 VCAM_28A VSS 6 5 4 7 7 C707 C708 C709 9-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C710 C711 Flow Chart of Troubleshooting VCAM_18IO HEA700 1 3 5 7 9 11 13 15 17 19 21 23 SCL1 PIXEL_VSYNC PIXEL_MCLK CAM_D7 CAM_D5 CAM_D3 CAM_D2 CAM_D0 FLASH_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 NC NC 2 4 6 8 10 12 14 16 18 20 22 24 25 26 ZD702 C731 C748 9-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C Flow Chart of Troubleshooting VIO R901 CAM_D0 CAM_D1 R900 SCL1 LCD_D(0) LCD_D(1) LCD_D(2) LCD_D(3) LCD_D(4) LCDD (5) V8 W1 U8 U4 V3 AA4 CAM_D0|ETK_D2 CAM_D1|ETK_D3 CAM_D2|ETK_D4 CAM_D3|ETK_D5 CAM_D4|ETK_D6 CAM_D5|ETK_D7 T8 T4 R2 U3 U2 V1 T3 SDA1 DSS_DATA0|RFBI_DA0 DSS_DATA1|RFBI_DA1 DSS_DATA2|RFBI_DA2 DSS_DATA3|RFBI_DA3 DSS_DATA4|RFBI_DA4 DSS DATA5|RFBI DA5 9-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-4 : Abnormal 3X4 KEY operation Press the key KBR# level Check idle state level NO goes high to low? and neighboring circuit YES NO KBC# level Check idle state level and neighboring circuit goes low to high? END VCC_KEY_3.3V HEA800 2 KBR0 KBR1 KBR2 KBR3 6 C819 C818 C817 C816 3 2 3 2 1 4 6 14 16 5 10 12 1 2 4 6 8 10 12 14 16 ZD802 4 5 ZD808 6 KBC0 KBC1 KBC2 17 NC 18 NC 1 1 34 3 5 5 78 7 9 9 11 11 13 13 15 15 9-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-5 : Abnormal LCD operation Press Power key abnormal Check LCD Reconnect LCD Connector connector Normal NO IC2(LCD PBA) Check IC2(LCD) pin 1 pin5,6 is high? and neighboring circuit YES NO Check F802 pin3 signal = 8MHz Check UCP900 YES and neighboring circuit YES Change LCD Module END 9-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting F802 _D4 DISPLAY_VSYNC 1 IN1 OUT1 _D5 DISPLAY_MCLK 2 IN2 OUT2 _D6 LCD_D(0) 3 IN3 OUT3 _D7 LCD_D(1) 4 IN4 OUT4 _D8 LCD_D(2) 5 IN5 OUT5 _D9 LCD_D(3) 12 11 10 9 8 7 6 IN6 OUT6 GND GND DISPLAY_VSYNC_F DISPLAY_MCLK_F LCD_D0 LCD_D1 LCD_D2 LCD_D3 13 14 9-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-6 : Abnormal Speaker operation No sound on playing MP3, Key Tone, Ring Tone U605 enable pin NO level is high? Check UCP900 neighboring circuit YES L610 voltage level NO = 3.5 ~ 4.2V Change or Resolder L610 YES NO R626 Check C658, R626 input exist? and neighboring circuit YES L607 & L609 NO Resolder L607, L609 and check U605 output exist? YES SPK600 1,2 pin NO output exist? Check Speker Conector YES Is Speaker NO Change Speaker module assay OK? YES END 9-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization ZD60 3 C65 7 L60 7 L60 9 C66 0 ZD60 2 C732 C740 C731 C747 C746 C748 ZD706 R64 0 R64 1 L610 C65 6 ZD702 SPK600 R624 U70 7 C738C736 R704 R705 R639 HEA7 Flow Chart of Troubleshooting U60 5 C65 9 R62 6 C65 4 C65 8 9-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-7 : Abnormal Voice Call operation No sound on calling C635 Both side NO Check U603 or MICBIAS Voltage, neighboring output exist? circuit YES NO Is MIC Resolder or Replace MIC Fpcb OK? YES PCM CLK, SYNC, NO Check U601, U602 and neighboring circuit DOUT output=exist? YES C652, C653 NO Check U602 output=exist ? YES Is Receiver NO Check Fpcb or Resolder Receiver, Replace OK? Receiver YES END 9-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting TA61 1 C672 L60 8 C635 VR801 C1026 C1022 U1003 C1021 PHONE_ACTIV C1020 R1045 R643 U603 ZD701 C666 VR800 TA602 C673 U804 R603 C678 C604C662C664 TA609 C663R604C667 C643R614C668 C636 C630 C627 R610 C648 L702 TA604 C650 C649 C605 C1019 R1013 C524 E PCM_DI N PCM_DOU T PCM_SYNC C1000 U504 R405 C406 PCM_CLK R408 R 9-24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting R1011 R1012 C651 C653 C652 U1002 L703 L70 C1007C1006 C1025 R1019C1017R1040 C633 C681 MI C600 C680 ZD600 L60 1 L60 3 C682 ZD601 C626 C642 9-25 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-8 : Abnormal micro-SD operation Insert the card NO R527 level card insertion retry and check neighboring circuit low? YES NO C530 level is 3.0V? Check UCP900 and neighboring circuit YES Check NO R521~R525 Check UCP900 and neighboring circuit END 9-26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VREG_USIM_2.85V VTF_3.0V VTF_3.0V R525 R523 R522 R521 CD500 R524 R527 R526 R528 R529 R532 1 2 3 4 5 6 7 R534 R535 R541 TF_DAT2 TF_DAT3 TF_CMD TF_CLK TF_DAT0 TF_DAT1 TF_DETECT SIM_RST 5V IO 4 GND 5 IO ZD501 NC 7 3I O 2 1 IO 7 3I OI O4 GND 5 6 IO 5V NC IO 1 2 C528 C530 C544 C531 6 SIM_CLK SIM_IO C529 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 R533 C527 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 NC NC NC NC NC NC NC NC NC NC NC NC V1DD8 ZD502 9-27 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-9 : Abnormal Vibrator operation Drive vibrator U710 pin3 NO Check output = high? U710,C805,D800,TA808 YES NO MOT800 Pin1 Check output=high? C805,D800,TA808 YES NO Replace Check motor Motor END V_BAT V_MOTOR33 U710 MOTOR_EN 6 5 4 CE VDD GND GND NC VOUT 1 2 3 C716 C750 9-28 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting V_MOTOR33 MOT800 11 KBR0 KBR1 KBR2 KBR3 TA808 1 2 D800 C805 3 2 2 9-29 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization B Flow Chart of Troubleshooting 9-2. RF Section 9-2-1. Abnormal Bluetooth Operation Operate BT NO Check TP200 Check UCP900 level = 1.8V? Normal NO Check OSC200 Change the OSC200 Output = 26MHz? and neighboring circuit YES Check RF line NO (BT Ant & F204) Check neighboring circuit YES END 9-30 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting V_BAT VIO ZD200 C277 C278 V_RFIO TP200 BT_nSHUTDOWN 32KCLKOUT C3 E6 L218 B5 D4 BT_RXD BT_TXD BT_RTS BT_CTS BT_RXD BT_TXD E5 E4 E8 E7 E2 E1 2 BTPCM_IN C7 B6 H8 H6 B3 D6 G5 C2 D8 F1 A3 F5 H3 G7 MOD200 D7 C6 B7 D5 A6 C4 C8 B4 F7 A1 G4 F2 G3 D2 H5 A4 F8 1 2 F4 F3 G1 G2 D1 H4 A2 B8 G8 A5 B1 C283 H7 1 C1 4 A7 IO0|EXT_CLK_REQ_OUT IO1 IO2 IO3|SDA IO4 IO5 IO7|SDIO_CLK IO14 IO15|EXT_CLK_REQ_IN IO16 IO17|SCL RFIO_LDO_OUT OSC_LDO_OUT ANA_OUT FLDO_OUT BB_LDO_OUT BB_LDO_OUT NC NC TX_DBG PMTEST ANATEST1 ANATEST2 BGAP_V|I VSS VSS VSS VSS VSS VSSA VSSA VSSA VSSA VSSA VSS_HVM C282 BTPCM_OUT C5 PCMOUT_BT AUX_PCM_SYNC PCMIN_BT AUX_PCM_CLK A8 OSC200 3 RFP RFM JTAG_TDI JTAG_TDO JTAG_TMS JTAG_TCK HCI_TX|SDIO_DATA HCI_RX|SDIO_CMD HCI_CTS HCI_RTS|SDIO_IRQ XTALP|FAST_CLK_IN XTALM AUD_IN AUD_FSYNC AUD_OUT AUD_CLK BT_TXDG 9-31 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C287 H2 C285 H1 C280 C286 BLANCE 4 DC G G 2 56 L217 F6 3 C284 BLANCE B2 L202 1 IN G6 C271 V_RFIO L215 E3 F204 SLOW_CLK_IN nSHUT_DOWN VDD_IN_BB VDD_IN_OSC VDD_IN_RFIO VDD_IO VDD_IO VDD_IO VDD_DAC PA_CTRL CLK_MODE_SEL NC NC NC C279 C288 TP810 TP809 Flow Chart of Troubleshooting SQ3D02600B2IBA OSC200 C2 7 8 C2 8 8 C283 C282 C286 L2 1 8 BRF6300CZSLR L2 1 5 TP200 C280 D BF7 1 B0 0 1 - T 3 2 K O UT F2 0 4 MOD200 C2 8 4 C2 7 1 L2 1 7 C279 BT_RXD BTPCM _ I N L2 0 2 TP810 BT_TXD C287 C285 ZD200 TP809 9-32 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C277 BTPCM_OUT Flow Chart of Troubleshooting 9-2-2. Abnormal WCDMA Tx Operation TX ON Target PWR=23dBm Check TX Module Output U202 PIN8 YES L203,C236,L219 ≥ 10dBm Check TX Module Input Resolder RFS200, Check Antenna Switch Control NO U202 PIN10 YES Check U202 PIN28=H, PIN27=L ≥ 8dBm PIN1=L YES Check Duplexer Input DUF300 PIN1 U202 YES Resolder DUF300, L312, C303,C332 ≥ 5dBm Check Coupler Input Resolder or Change NO NO F301 PIN2 YES ≥ 5dBm Resolder or change F301, R317, R302, R303, R306, R307 NO Check PAM Input U303 PIN8 YES U303, L310, C339 ≥ -15dBm Check Transceiver Input Resolder or Change NO U201 PIN59 ≥ -20dBm YES Resolder or Change C211, L303, C322, F300, R313, C304 NO Check U201, UCP400 END 9-33 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 C G G 4 3 1 JTAG_ANT A RFS200 ANT102 TP 2 ANT101 TP R205 C291 C236 L201 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 10 21 23 UMTS_TRX 27 28 R213 R211 C255 ANT 4 5 6 7 RX4 RX3 RX2 RX1 MODE RSVD _TXEN VAPC BS2 BS1 R210 2 3 1 25 29 GND 9 11 12 13 14 15 16 17 18 19 20 22 24 GSM_ANT_SEL1_N 8 WCDMA1 DCS|PCS_IN GSM_IN GND GND GND GND GND GND GND GND GND GND GND GND GND R212 VBATT F201 R215 1 GSM_TX OUT IN 4 GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL 2 3 5 R217 R218 C266 F202 C264 1 OUT IN OUT GG L206 2 C263 L208 5 1 OUT IN GSM_ANT_SEL2_N G GOUT L220 DCS_RXM L210 3 4 DCS_RXP L221 25 C273 R220 GSM_RXP C265 F205 C268 R221 GSM_RXM 3 4 F206 C276 C275 L213 1 L214 OUT IN OUT GG 2 3 C272 PCS_RXM L212 4 5 PCS_RXP C274 C332 UMTS_TRX C333 V_BAT C300 C301 TA300 U303 F300 L303 R313 1 UMTS_TX_2100 IN 3 OUT GND1 C322 1 2 GND2 C304 L302 4 VBATT C303 GND 9 2 RFIN L312 VCC 10 3 VMODE2 RFOUT 8 4 VMODE1 GND 7 5 VENA GND 6 F301 L310 R317 TX 2 OUT IN 1 50OHM COUP C307 34 C339 C309 GND 11 R300 1 ANT 3 C310 DUF300 RX R303 PA_R0 R301 PA_R1 R304 R302 PA_ON_U2100 C306 C305 UMTS_RX_2100 2 GND 4 R306 C312 R307 PWR_DET 9-34 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization L304 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-35 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-3. Abnormal WCDMA Rx Operation RX ON AMP=-50dBm U202 PIN8 YES Resolder RFS200, L203,C236,L219 ≥ -65dBm Check Antenna Switch Control NO U202 PIN10 YES Check U202 PIN28=H, PIN27=L ≥ -70dBm PIN1=L YES NO DUF300 PIN3 U202 YES Resolder DUF300, L312,C303,C332 ≥ -75dBm NO U201 PIN36 YES ≥ -75dBm Resolder or change C305, C306, L304 NO U201 PIN34 YES Resolder or Change U201 ≥ -75dBm NO F200 PIN3,4 ≥ -75dBm Resolder or Change YES Resolder or Change F200, C241, C237, C243, C238, C244, L205 NO Check U201, UCP400 END 9-36 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G C 3 1 JTAG_ANT A RFS200 ANT102 TP 2 ANT101 TP R205 C291 C236 L201 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 21 23 UMTS_TRX R211 C255 4 5 6 7 RX4 RX3 RX2 RX1 MODE RSVD _TXEN VAPC BS2 BS1 29 GND R210 2 3 1 25 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N ANT WCDMA1 DCS|PCS_IN GSM_IN 27 28 R213 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL 2 3 5 R217 R218 C266 F202 C264 1 OUT IN OUT GG L206 2 C263 L208 5 1 OUT IN GSM_ANT_SEL2_N L220 G DCS_RXM L210 3 4 GOUT DCS_RXP L221 25 C273 R220 GSM_RXP C265 F205 C268 R221 GSM_RXM 3 4 F206 C276 C275 L213 1 L214 OUT IN 3 C272 PCS_RXM L212 OUT 4 GG 2 5 PCS_RXP C274 C332 UMTS_TRX C333 V_BAT C300 C301 TA300 U303 F300 L303 R313 1 UMTS_TX_2100 3 OUT IN GND1 C322 1 2 GND2 C304 L302 4 VBATT C303 3 VMODE2 RFOUT 8 4 VMODE1 GND 7 5 VENA L312 VCC 10 GND 9 2 RFIN GND 6 F301 L310 R317 TX 2 OUT IN 1 50OHM COUP C307 34 C339 GND 11 R300 1 ANT 3 C309 C310 DUF300 RX R303 PA_R0 R301 PA_R1 R304 R302 PA_ON_U2100 C306 C305 UMTS_RX_2100 2 GND 4 R306 C312 R307 PWR_DET 9-37 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization L304 Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP U201 C222 C224 C223 GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R 51 50 49 48 47 46 45 44 43 42 41 40 C231 39 38 37 36 35 WPRXSE1_OUT GCELL_INN GCELL_INP EGSM_INN EGSM_INP DCS_INN DCS_INP GPCS_INN GPCS_INP VDDA2 GPS_IN WDRXLB WDRXHB1 WDRXHB2 WPRXSE1 VDDA2 WPRXSE2 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 PDET_IN C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-38 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-39 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-4. Abnormal EGSM Tx Operation TX ON(5 level) U202 PIN8 YES ≥ -5dBm Resolder RFS200, L203,C236,L219 Check Antenna Switch Control NO F201 PIN4 YES Check U202 PIN28=H, PIN27=L ≥ -15dBm PIN1=L YES NO U201 PIN55 U202 YES Resolder F201, R215, R216 ≥ -15dBm R217, C213 NO Check U201, UCP400 END Resolder or Change PIN28 PIN27 PIN1 9-40 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G 1 JTAG_ANT 3 C RFS200 ANT102 TP 2 A ANT101 TP R205 C291 L201 C236 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN UMTS_TRX 27 BS2 28 BS1 R213 R211 C255 29 GND ANT RX4 RX3 RX2 RX1 4 5 6 7 R210 2 MODE 3 RSVD 1 _TXEN 25 VAPC 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL R217 2 3 5 R218 C266 F202 C264 PIN28 : LOW 1 OUT IN OUT GG L206 2 PIN27 : HIGH C263 GSM_RXM 3 L208 4 5 GSM_RXP C265 PIN1 : LOW L220 F205 C268 1 R221 OUT IN GSM_ANT_SEL2_N G R220 4 GOUT DCS_RXP L221 25 C273 DCS_RXM L210 3 F206 C276 C275 L213 L214 1 OUT IN 2 3 C272 5 C274 9-41 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS_RXM L212 OUT 4 GG PCS_RXP Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 51 GCELL_INN 50 GCELL_INP 49 EGSM_INN 48 EGSM_INP 47 DCS_INN 46 DCS_INP 45 GPCS_INN 44 GPCS_INP 43 VDDA2 42 GPS_IN 41 WDRXLB 40 WDRXHB1 39 WDRXHB2 38 WPRXSE1 37 VDDA2 36 WPRXSE2 35 WPRXSE1_OUT U201 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C231 C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R C223 C222 C224 C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-42 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-43 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-5. Abnormal DCS/PCS Tx Operation TX ON(0 level) U202 PIN8 YES Resolder RFS200, ≥ 0dBm L203,C236,L219 Check Antenna Switch Control NO U202 PIN21 YES Check U202 PIN28=H, PIN27=H ≥ -15dBm PIN1=L YES NO U201 PIN56 U202 YES Resolder or Change C212, R209, R212, ≥ -15dBm R213 NO Check U201, UCP400 END Resolder or Change PIN28 PIN27 PIN1 9-44 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G C 3 2 1 JTAG_ANT A RFS200 ANT102 TP ANT101 TP R205 C291 L201 C236 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN UMTS_TRX 27 BS2 28 BS1 R213 R211 C255 29 GND ANT RX4 RX3 RX2 RX1 4 5 6 7 R210 2 MODE 3 RSVD 1 _TXEN 25 VAPC 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL R217 2 3 5 R218 C266 PIN28 : HIGH F202 C264 1 PIN27 : HIGH OUT IN OUT GG L206 2 C263 L208 4 5 L220 F205 1 R221 OUT IN GSM_ANT_SEL2_N G R220 4 GOUT DCS_RXM L210 3 25 C273 GSM_RXP C265 PIN1 : LOW C268 GSM_RXM 3 DCS_RXP L221 F206 C276 C275 L213 L214 1 OUT IN 2 3 C272 5 C274 9-45 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS_RXM L212 OUT 4 GG PCS_RXP Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 51 GCELL_INN 50 GCELL_INP 49 EGSM_INN 48 EGSM_INP 47 DCS_INN 46 DCS_INP 45 GPCS_INN 44 GPCS_INP 43 VDDA2 42 GPS_IN 41 WDRXLB 40 WDRXHB1 39 WDRXHB2 38 WPRXSE1 37 VDDA2 36 WPRXSE2 35 WPRXSE1_OUT U201 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C231 C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R C223 C222 C224 C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-46 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-47 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-6. Abnormal EGSM Rx Operation RX ON AMP--50dBm U202 PIN8 YES ≥ -60dBm Resolder RFS200, L203,C236,L219 Check Antenna Switch Control NO U202 PIN4 YES Check U202 PIN28=H, PIN27=L ≥ -70dBm PIN1=H YES NO U202 PIN3,4 U202 YES ≥ -75dBm Resolder or Change F202,C264,L206 NO U201 PIN48, 49 ≥ -75dBm YES Resolder or Change C263,C265,L208 NO Check U201, UCP400 Resolder or Change PIN28 PIN27 PIN1 END 9-48 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G C 3 2 1 JTAG_ANT A RFS200 ANT102 TP ANT101 TP R205 C291 L201 C236 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN UMTS_TRX 27 BS2 28 BS1 R213 R211 C255 29 GND ANT RX4 RX3 RX2 RX1 4 5 6 7 R210 2 MODE 3 RSVD 1 _TXEN 25 VAPC 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL R217 2 3 5 R218 C266 F202 C264 1 OUT IN OUT GG L206 2 C263 L208 4 5 1 R221 OUT IN GSM_ANT_SEL2_N L220 G R220 4 GOUT DCS_RXM L210 3 25 C273 GSM_RXP C265 F205 C268 GSM_RXM 3 DCS_RXP L221 F206 C276 C275 L213 L214 1 OUT IN 2 3 C272 5 C274 9-49 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS_RXM L212 OUT 4 GG PCS_RXP Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 51 GCELL_INN 50 GCELL_INP 49 EGSM_INN 48 EGSM_INP 47 DCS_INN 46 DCS_INP 45 GPCS_INN 44 GPCS_INP 43 VDDA2 42 GPS_IN 41 WDRXLB 40 WDRXHB1 39 WDRXHB2 38 WPRXSE1 37 VDDA2 36 WPRXSE2 35 WPRXSE1_OUT U201 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C231 C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R C223 C222 C224 C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-50 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-51 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-7. Abnormal DCS Rx Operation RX ON AMP--50dBm U202 PIN8 YES ≥ -65dBm Resolder RFS200, L203,C236,L219 Check Antenna Switch Control NO U202 PIN5 YES Check U202 PIN28=H, PIN27=H ≥ -70dBm PIN1=H YES NO F205 PIN3,4 U202 YES Resolder or Change ≥ -75dBm C268,F205 NO U201 PIN46, 47≥-75dBm YES Resolder or Change L210,L220,L221 NO Check U201, UCP400 Resolder or Change PIN28 PIN27 PIN1 END 9-52 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G C 3 2 1 JTAG_ANT A RFS200 ANT102 TP ANT101 TP R205 C291 L201 C236 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN UMTS_TRX 27 BS2 28 BS1 R213 R211 C255 29 GND ANT RX4 RX3 RX2 RX1 4 5 6 7 R210 2 MODE 3 RSVD 1 _TXEN 25 VAPC 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL R217 2 3 5 R218 C266 F202 C264 1 OUT IN OUT GG L206 2 C263 L208 4 5 1 R221 OUT IN GSM_ANT_SEL2_N L220 G R220 4 GOUT DCS_RXM L210 3 25 C273 GSM_RXP C265 F205 C268 GSM_RXM 3 DCS_RXP L221 F206 C276 C275 L213 L214 1 OUT IN 2 3 C272 5 C274 9-53 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS_RXM L212 OUT 4 GG PCS_RXP Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 51 GCELL_INN 50 GCELL_INP 49 EGSM_INN 48 EGSM_INP 47 DCS_INN 46 DCS_INP 45 GPCS_INN 44 GPCS_INP 43 VDDA2 42 GPS_IN 41 WDRXLB 40 WDRXHB1 39 WDRXHB2 38 WPRXSE1 37 VDDA2 36 WPRXSE2 35 WPRXSE1_OUT U201 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C231 C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R C223 C222 C224 C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-54 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-55 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-8. Abnormal PCS Rx Operation RX ON AMP--50dBm U202 PIN8 YES ≥ -65dBm Resolder RFS200, L203,C236,L219 Check Antenna Switch Control NO U202 PIN6 YES Check U202 PIN28=L, PIN27=H ≥ -70dBm PIN1=H YES NO F206 PIN3,4 U202 YES Resolder or Change ≥ -75dBm C273,F206 NO U201 PIN44, 45≥-75dBm YES Resolder or Change C272,C274,L212 NO Check U201, UCP400 Resolder or Change PIN28 PIN27 PIN1 END 9-56 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 G 4 G C 3 2 1 JTAG_ANT A RFS200 ANT102 TP ANT101 TP R205 C291 L201 C236 L219 L203 C289 R201 V_BAT C250 TA200 U202 26 DCS1800_PCS1900_TX R209 R212 VBATT 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN UMTS_TRX 27 BS2 28 BS1 R213 R211 C255 29 GND ANT RX4 RX3 RX2 RX1 4 5 6 7 R210 2 MODE 3 RSVD 1 _TXEN 25 VAPC 9 11 12 13 14 15 16 17 18 19 20 22 24 GND GND GND GND GND GND GND GND GND GND GND GND GND GSM_ANT_SEL1_N 8 F201 R215 1 GSM_TX OUT 4 IN GSM_ANT_SEL0_N R214 C262 G GG R216 GSM_PA_PWR_CTL R217 2 3 5 R218 C266 F202 C264 1 OUT IN OUT GG L206 2 C263 L208 4 5 1 R221 OUT IN GSM_ANT_SEL2_N L220 G R220 4 GOUT DCS_RXM L210 3 25 C273 GSM_RXP C265 F205 C268 GSM_RXM 3 DCS_RXP L221 F206 C276 C275 L213 L214 1 OUT IN 2 3 C272 5 C274 9-57 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCS_RXM L212 OUT 4 GG PCS_RXP Flow Chart of Troubleshooting TX_IP C200 C201 C204 VREG_RFRX1_2.1V C203 TX_IM C206 C207 C208 C209 C210 C211 UMTS_TX_2100 DCS1800_PCS1900_TX VREG_RFRX2_2.7V GSM_TX C212 C213 R202 C214 P M M P P M P M VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 51 GCELL_INN 50 GCELL_INP 49 EGSM_INN 48 EGSM_INP 47 DCS_INN 46 DCS_INP 45 GPCS_INN 44 GPCS_INP 43 VDDA2 42 GPS_IN 41 WDRXLB 40 WDRXHB1 39 WDRXHB2 38 WPRXSE1 37 VDDA2 36 WPRXSE2 35 WPRXSE1_OUT U201 DRX_IN N|C SBDT VDDA2 VDDA1 VDDM VTUNE2 VDDA2 RF_ON VDDA2 WB_MX_INP WB_MX_INM WPRXLBP WPRXLBM WPRXHBP WPRXHBM WPRXSE2_OUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SLUG TX_RBIAS DAC_IREF TX_QP TX_QN TX_IP TX_IN VDDA2 VDDA2 VDDA2 HB_RF_OUT3 HB_RF_OUT2 LB_RF_OUT2 HB_RF_OUT1 LB_RF_OUT1 VDDA2 VDDA1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET GSM_RXM GSM_RXP DCS_RXM DCS_RXP PCS_RXM PCS_RXP VREG_RFRX1_2.1V RX_GPS C231 C234 C235 C232 C233 UMTS_RX_2100 C240 C239 L200 C238 UMTS_RXM_2100 F200 1 R207 OUT IN G C241 C245 C237 R206 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 R C223 C222 C224 C246 25 L204 R208 GOUT 3 L205 4 C243 C244 UMTS_RXM_2100 UMTS_RXP_2100 RF_ON_TX_ON C253 VREG_MSMP_2.6V C254 59 C260 C256 C257 C261 9-58 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization UMTS_RXP_2100 TA 3 0 0 U3 0 3 R3 0 7 R3 0 3 F201 F2 0 2 F2 0 5 F2 0 6 C3 1 7 C3 0 4 L3 0 2 AW T6 2 7 9 RM2 0 P8 R2 1 3 R2 0 1 L2 0 3 L2 0 1 SAMSUNG Proprietary-Contents may change without notice F3 0 0 B9 0 3 1 R3 0 0 R3 0 1 R2 1 7 U2 0 2 C3 3 2 9-59 C3 1 6 C3 2 1 R3 1 2 R3 0 4 R2 2 1 C2 5 0 R306 SKY7 7 5 1 9 - 1 1 L3 1 2 C3 3 3 RTR6285 U201 C3 0 9 R3 1 7 RFS200 C3 1 8 C3 2 0 OSC6 0 2 C2 3 5 C3 1 2 C2 2 2 C2 3 4 L3 0 3 C2 0 6 C2 2 3 R2 2 0 L2 0 6 C2 6 4 L2 1 4 C2 6 8 C2 7 3 L2 1 3 C3 0 3 D UF3 0 0 SFXG5 0 PR5 0 1 This Document can not be used without Samsung's authorization F301 C339 L310 C307 C300 C262 R302 R216 C3 3 8 C2 0 7 C2 0 9 C2 1 0 C2 0 8 C2 1 4 R2 1 0 C2 6 3 C2 6 5 L2 2 0 L2 2 1 C2 7 2 C3 0 6 C2 3 2 C2 7 4 C2 3 3 C2 4 6 C2 4 5 R212 R209 R211 C276 R215 C301 R214 R3 1 0 C2 0 1 L2 0 0 L2 0 4 R2 0 6 SC300 TG- 5 0 1 0 LH - 3 1 A C2 0 4 C2 5 6 C2 5 7 C211 C3 1 5 C2 1 7 C2 2 7 C2 2 8 C2 2 5 C2 3 0 C2 2 9 C2 1 8 C2 2 0 C2 6 0 C2 2 6 R2 0 7 C2 5 9 C212 L2 0 5 C244 C255 R218 C266 TA200 C3 1 0 C291 C289 L219 C236 C275 C231 C305 C2 1 5 C2 4 8 C2 5 4 C2 4 3 L304 C239 C224 L208 L210 L212 C240 C203 C200 C2 6 1 R208 R311 C2 4 7 TA2 0 1 C237 R202 C322 C213 C238 C202 C205 C253 C216 R313 C241 F2 0 0 Flow Chart of Troubleshooting Flow Chart of Troubleshooting 9-2-9. Abnormal GPS Rx Operation Opreate Signal = -50dBm @C328 Check F303 NO Change or Resolder C329≥-52dBm F303 YES Check F304 NO Check or Resolder GLNA_ON=2.7 UCP400 YES C330≥- BO Change or Resolder 53dBm F304 RX ON AMP--50dBm 9-60 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting ANT301 1 1 2 2 3 3 4 4 5 5 6 6 GLNA_ON VREG_RFRX2_2.7V L307 L306 C327 R314 1 C329 L308 1 OUT 4 IN S|D C328 RF_IN 5 VDD 2 F304 F303 FILT_OUT C330 L315 4 RX_GPS 3 GND C334 6 L316 L314 GND G GG 2 3 5 L3 1 4 L3 0 8 F3 0 3 C329 F304 L3 1 5 L3 0 6 C3 2 7 R3 1 4 L307 C330 C334 C3 2 8 ANT301 L3 1 6 9-61 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-62 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 10. Reference data Reference Abbreviate - AAC: Advanced Audio Coding. - AVC : Advanced Video Coding. - BER : Bit Error Rate - BPSK: Binary Phase Shift Keying - CA : Conditional Access - CDM : Code Division Multiplexing - C/I : Carrier to Interference - DMB : Digital Multimedia Broadcasting - EN : European Standard - ES : Elementary Stream - ETSI: European Telecommunications Standards Institute - MPEG: Moving Picture Experts Group - PN : Pseudo-random Noise - PS : Pilot Symbol - QPSK: Quadrature Phase Shift Keying - RS : Reed-Solomon - SI : Service Information - TDM : Time Division Multiplexing - TS : Transport Stream 10-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Reference data 10-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 11. Disassembly and Assembly Instructions 11-1. Disassembly Instructions 1 1) Unscrew at the four points and seperate 2 the rear frame and the upper parts. 1) Handle with care not to have scratches and not to be damaged. 3 1) Handle with care not to have scratches and not to damage the molds. 2) Watch out the rear frame not to have strains when disassembled. 3) Use the disassembling tool by all means. 1) Detach BT antenna from the rib. 2) Detach Key FPCB and LCD Connector from Upper slide parts. 1) Handle with care the FPCB not to be torn or damaged. 1) Press the side parts using disassembling tool and unlock the hook. 4 1) Unscrew at the four points. 2) Detach the speaker connector from the header. 3) Take off the camera LED and seperate the shieldCAN. 1) Do not damage the chip. 2) Do not damage the speaker connector. 3) Do not damage the camera LED FPCB. 11-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 1) Remove the absorber tape and detach the 5 6 motor from speaker. 1) Remove the three electric conduction tape 2) Unscrew at one point then seperate the SPK from the PBA. 1) Take care not to be torn of the tape 1) Do not damage the chip. 2) Handle with care the FPCB not to be torn or damaged. 1) Unscrew at the six points and seperate 7 1) Unscrew at the four points and seperate the Front frame from the upper parts. 1) Handle with care not to have scratches and not to damage the molds. 2) Handle with care the FPCB not to be torn or damaged. 8 the Lower frame from the upper parts. 1) Handle with care not to have scratches and not to damage the molds. 2) Handle with care the FPCB not to be torn or damaged. 11-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 11-2. Assembly Instructions 1 1) Fit the lower frame to the Upper parts. 2 2) Screw down the lower frame. 1) Handle with care not to have scratches and not to damage the molds. 2) Handle with care the FPCB not to be torn or damaged. 3 1) Handle with care not to have scratches and not to damage the molds. 2) Handle with care the FPCB not to be torn or damaged. 1) Attach the three electric conduction 4 tape as below. 1) Handle with care the FPCB not to be torn or damaged. 1) Assemble the upper parts and the front frame 2) Screw down the front frame at six points. 1) Fit the Power key to be right part higher. 2) Assemble the SPK box the right hooker first. 3) Fit the motor to speaker box, and screw down in one point. 4) Attach the absorber tape. 1) Assemble the SPK box fit firmly. 2) Before fitting the motor, twist the wire twice. 3) The wire of the motor should not be above the gold line. 4) Handle with care not to damage the camera FPCB and the chip. 5) Attach the absorber tape as guided in the picture. 11-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions Attach the camera LED at guide hole. 2) Attach the insulation tape and fit the SPK Connector to header. 3) Put the SHIELDCAN at right position and screw down at four points. 5 6 1) Slide up a little bit and connect the LCD connector first,Key FPCB connector and BT antenna between rib. 1) Watch out not to damage the chip and BT ant. 1) Watch out not to damage the chip. 2) Watch out the connectorto fit firmly. 3) Handle with care the FPCB not to be torn or damaged. 1) Set the PBA on the slide upper parts. 7 8 2) Assemble the Rear frame from the top. 1) Handle with care not to have scratches and not to damage the molds. 1) Screw down at four points. 1) Handle with care not to have scratches and not to damage the molds. 11-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization