Download Philips 26PW9100D Specifications
Transcript
Colour Television Chassis L05.1U AA F_15060_000.eps 210305 Contents Page 1. Technical Specifications, Connections, and Chassis Overview 2 2. Safety Instructions, Warnings, and Notes 4 3. Directions for Use 6 4. Mechanical Instructions 7 5. Service Modes, Error Codes, and Fault Finding 8 6. Block Diagrams, Testpoint Overviews, and Waveforms Wiring Diagram 21 Block Diagram Supply and Deflection 22 Testpoint Overview Mono Carrier 23 Block Diagram Video 24 Testpoint Overview CRT Panel (Multi Board) 25 Block Diagram Audio 26 Block Diagram Control & I2C Overview 27 Supply Lines Overview 28 7. Circuit Diagrams and PWB Layouts Diagram Mono Carrier: Power Supply (A1) 29 Mono Carrier: Deflection (A2) 30 Mono Carrier: Tuner IF (A3) 31 Mono Carrier: Hercules (A4) 32 Mono Carrier: Features & Connectivities (A5) 33 Mono Carrier: Audio Amplifier (A7) 34 Mono Carrier: Rear I/O Cinch (A8) 35 Mono Carrier: Front Control (A9) 36 Mono Carrier: Diversity Tables A2 & A4 36 Mono Carrier: AUX Power Supply (A10) 37 CRT Panel (Multi Board) (B1) 44 CRT Panel: RGB Amplifier (Multi Board) (B2) 45 CRT Panel: Rot. & SCAVEM (Multi Board) (B3) 46 Side AV + HP Panel (PV2) (D) 48 Side AV + HP Panel (FL13) (D) 50 Top Control Panel (PV2) (E) 52 Top Control Panel (FL13) (P) 52 Contents 8. 9. 10. 11. Page Front Interface Panel (FL13) (J) 55 Front Interface Panel (PV2) (J) 55 Deflection Controller - ATSC (K1) 58 RGB Buffer- ATSC (K2) 59 Alignments 61 Circuit Descriptions, List of Abbreviations, and IC Data Sheets 66 Abbreviation List 68 IC Data Sheets 70 Spare Parts List 71 Revision List 72 56 57 60 60 PWB 38-43 38-43 38-43 38-43 38-43 38-43 38-43 38-43 38-43 38-43 47 47 47 49 51 53 54 © Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by BB 0563 TV Service Printed in the Netherlands Subject to modification EN 3122 785 15060 EN 2 1. Technical Specifications, Connections, and Chassis Overview L05.1U AA 1. Technical Specifications, Connections, and Chassis Overview 1.2 Index of this chapter: 1.1 Technical Specifications 1.2 Connections 1.3 Chassis Overview Note: The following connector color abbreviations are used (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow. Notes: • Described specifications are valid for the whole product range. • Figures below can deviate slightly from the actual situation, due to different set executions. 1.1 Technical Specifications 1.1.1 Reception Display type Screen size Tuning system Color systems Sound systems Channel selections IF picture carrier Aerial input A/V Connections : : : : : : : : : : : : 1.2.1 Top Control and Front / Side Connections FRONT I/O CRT-DV-SF 26”, 16:9 27”, 4:3 30”, 16:9 32”, 4:3 PLL NTSC BTSC 181, full cable 45.75 MHz 75 ohm, F-type NTSC M (3.58 - 4.5) LIGHT SENSOR IR RED LED (OPTIONAL) TOP CONTROL - VOL + MENU CH SIDE I/O Miscellaneous S-VIDEO : 2 x 10 W Power supply: - Mains voltage range - Mains frequency : 90 - 140 V_ac : 60 Hz Ambient conditions: - Temperature range - Maximum humidity Power consumption: - Normal operation - Standby VIDEO R AUDIO L F_15050_005.eps 110205 Figure 1-1 Top control and Front / Side connections : +5 to +45 °C : 90% R.H. : from 119 W : to 133 W : <1W 1.2.2 Hosiden: SVHS - In 1 - GND 2 - GND 3 -Y 4 -C Ground Ground 1 Vpp / 75 ohm 0.3 Vpp / 75 ohm Audio / Video In Ye - Video (CVBS) Wh - Audio - L Rd - Audio - R Bk - Headphone 1 V_pp / 75 ohm 0.2 V_rms / 10 kohm 0.2 V_rms / 10 kohm 8 - 600 Ohm / 4 mW H H j j jq jq jq ot Rear Connections 75 Ohm SPDIF Y L Pb AUDIO Pr R 1 2 Audio output: 19 18 1.1.2 Connections AV1 IN HDMI ComPair AV2 IN Y V Pb L L Pr R R COMPONENT VIDEO INPUT Figure 1-2 Rear connections V S-VIDEO F_15060_050.eps 210305 Technical Specifications, Connections, and Chassis Overview Aerial In - F-type 1.3 Coax, 75 ohm L05.1U AA 1. EN 3 Rd - Audio - R 0.5 V_rms / 10 kohm jq AV2 In (SVHS) 1 - Ground 2 - Ground 3 -Y 4 -C GND GND 1 V_pp / 75 ohm 0.3 V_pp / 75 ohm H H jq jq D Monitor Out Ye - Video (CVBS) Wh - Audio - L Rd - Audio - R 1 V_pp / 75 ohm 0.5 V_rms / 1 kohm 0.5 V_rms / 1 kohm kq kq kq YUV In Bu - U Rd - V Gn - Y 0.7 V_pp / 75 ohm 0.7 V_pp / 75 ohm 0.7 V_pp / 75 ohm jq jq jq AV1 In Ye - Video (CVBS) Wh - Audio - L Rd - Audio - R 1 V_pp / 75 ohm 0.5 V_rms / 10 kohm 0.5 V_rms / 10 kohm jq jq jq AV2 In Ye - Video (CVBS) Wh - Audio - L 1 V_pp / 75 ohm 0.5 V_rms / 10 kohm jq jq Chassis Overview B1 CRT SOCKET B2 RGB AMP B3 ROT & SCAVEM CRT PANEL TOP CONTROL PANEL D FRONT INTERFACE PANEL SIDE AV PANEL + HEADPHONE E/P J MULTI BOARD K1 K2 ATSC DEFLECTION CONTROLLER RGB BUFFER ATSC PANEL MONO CARRIER POWER SUPPLY A1 DEFLECTION A2 TUNER IF A3 HERCULES A4 FEATURES & CONNECTIVITIES A5 AUDIO AMPLIFIER A7 REAR I/O CINCH A8 A9 FRONT CONTROL AUXILIARY POWER SUPPLY A10 F_15060_006.eps 210305 Figure 1-3 PWB location EN 4 2. L05.1U AA Safety Instructions, Warnings, and Notes 2. Safety Instructions, Warnings, and Notes 2. Clean the power supply and deflection circuitry on the chassis. 3. Clean the picture tube panel and the neck of the picture tube. Index of this chapter: 2.1 Safety Instructions 2.2 Maintenance Instructions 2.3 Warnings 2.4 Notes 2.3 2.1 Warnings Safety Instructions • Safety regulations require that during a repair: • Connect the set to the Mains (AC Power) via an isolation transformer (> 800 VA). • Replace safety components, indicated by the symbol h, only by components identical to the original ones. Any other component substitution (other than original type) may increase risk of fire or electrical shock hazard. • Wear safety goggles when you replace the CRT. Safety regulations require that after a repair, the set must be returned in its original condition. Pay in particular attention to the following points: • General repair instruction: as a strict precaution, we advise you to re-solder the solder connections through which the horizontal deflection current is flowing. In particular this is valid for the: 1. Pins of the line output transformer (LOT). 2. Fly-back capacitor(s). 3. S-correction capacitor(s). 4. Line output transistor. 5. Pins of the connector with wires to the deflection coil. 6. Other components through which the deflection current flows. Note: This re-soldering is advised to prevent bad connections due to metal fatigue in solder connections, and is therefore only necessary for television sets more than two years old. • Route the wire trees and EHT cable correctly and secure them with the mounted cable clamps. • Check the insulation of the Mains (AC Power) lead for external damage. • Check the strain relief of the mains (AC Power) cord for proper function, to prevent the cord from touching the CRT, hot components, or heat sinks. • Check the electrical DC resistance between the Mains (AC Power) plug and the secondary side (only for sets which have a Mains (AC Power) isolated power supply): 1. Unplug the Mains (AC Power) cord and connect a wire between the two pins of the Mains (AC Power) plug. 2. Set the Mains (AC Power) switch to the "on" position (keep the Mains (AC Power) cord unplugged!). 3. Measure the resistance value between the pins of the Mains (AC Power) plug and the metal shielding of the tuner or the aerial connection on the set. The reading should be between 4.5 Mohm and 12 Mohm. 4. Switch "off" the set, and remove the wire between the two pins of the Mains (AC Power) plug. • Check the cabinet for defects, to avoid touching of any inner parts by the customer. 2.2 V E_06532_007.eps 250304 Figure 2-1 Discharge picture tube • • • • All ICs and many other semiconductors are susceptible to electrostatic discharges (ESD w). Careless handling during repair can reduce life drastically. Make sure that, during repair, you are connected with the same potential as the mass of the set by a wristband with resistance. Keep components and tools also at this same potential. Available ESD protection equipment: – Complete kit ESD3 (small tablemat, wristband, connection box, extension cable and earth cable) 4822 310 10671. – Wristband tester 4822 344 13999. Be careful during measurements in the high voltage section. Never replace modules or other components while the unit is switched "on". When you align the set, use plastic rather than metal tools. This will prevent any short circuits and the danger of a circuit becoming unstable. 2.4 Notes 2.4.1 General • Maintenance Instructions We recommend a maintenance inspection carried out by qualified service personnel. The interval depends on the usage conditions: • When a customer uses the set under normal circumstances, for example in a living room, the recommended interval is three to five years. • When a customer uses the set in an environment with higher dust, grease, or moisture levels, for example in a kitchen, the recommended interval is one year. • The maintenance inspection includes the following actions: 1. Perform the “general repair instruction” noted above. In order to prevent damage to ICs and transistors, avoid all high voltage flashovers. In order to prevent damage to the picture tube, use the method shown in figure “Discharge picture tube”, to discharge the picture tube. Use a high voltage probe and a multi-meter (position VDC). Discharge until the meter reading is 0 V (after approx. 30 s). • • Measure the voltages and waveforms with regard to the chassis (= tuner) ground (H), or hot ground (I), depending on the tested area of circuitry. The voltages and waveforms shown in the diagrams are indicative. Measure them in the Service Default Mode (see chapter 5) with a colour bar signal and stereo sound (L: 3 kHz, R: 1 kHz unless stated otherwise) and picture carrier at 475.25 MHz for PAL, or 61.25 MHz for NTSC (channel 3). Where necessary, measure the waveforms and voltages with (D) and without (E) aerial signal. Measure the voltages in the power supply section both in normal operation (G) and in stand-by (F). These values are indicated by means of the appropriate symbols. The semiconductors indicated in the circuit diagram and in the parts lists, are interchangeable per position with the semiconductors in the unit, irrespective of the type indication on these semiconductors. Safety Instructions, Warnings, and Notes • 2.4.2 Manufactured under license from Dolby Laboratories. “Dolby”, “Pro Logic” and the “double-D symbol”, are trademarks of Dolby Laboratories. 2.4.4 L05.1U AA 2. EN 5 Lead Free Solder Philips CE is producing lead-free sets (PBF) from 1.1.2005 onwards. Schematic Notes • • • • • • All resistor values are in ohms and the value multiplier is often used to indicate the decimal point location (e.g. 2K2 indicates 2.2 kohm). Resistor values with no multiplier may be indicated with either an "E" or an "R" (e.g. 220E or 220R indicates 220 ohm). All capacitor values are given in micro-farads (µ= x10-6), nano-farads (n= x10-9), or pico-farads (p= x10-12). Capacitor values may also use the value multiplier as the decimal point indication (e.g. 2p2 indicates 2.2 pF). An "asterisk" (*) indicates component usage varies. Refer to the diversity tables for the correct values. The correct component values are listed in the Spare Parts List. Therefore, always check this list when there is any doubt. Identification: The bottom line of a type plate gives a 14-digit serial number. Digits 5 and 6 refer to the production year, digits 7 and 8 refer to production week (in example below it is 1991 week 18). E_06532_024.eps 230205 Figure 2-2 Serial number example 2.4.3 Rework on BGA (Ball Grid Array) ICs General Although (LF)BGA assembly yields are very high, there may still be a requirement for component rework. By rework, we mean the process of removing the component from the PWB and replacing it with a new component. If an (LF)BGA is removed from a PWB, the solder balls of the component are deformed drastically so the removed (LF)BGA has to be discarded. Device Removal As is the case with any component that, it is essential when removing an (LF)BGA, the board, tracks, solder lands, or surrounding components are not damaged. To remove an (LF)BGA, the board must be uniformly heated to a temperature close to the reflow soldering temperature. A uniform temperature reduces the chance of warping the PWB. To do this, we recommend that the board is heated until it is certain that all the joints are molten. Then carefully pull the component off the board with a vacuum nozzle. For the appropriate temperature profiles, see the IC data sheet. Area Preparation When the component has been removed, the vacant IC area must be cleaned before replacing the (LF)BGA. Removing an IC often leaves varying amounts of solder on the mounting lands. This excessive solder can be removed with either a solder sucker or solder wick. The remaining flux can be removed with a brush and cleaning agent. After the board is properly cleaned and inspected, apply flux on the solder lands and on the connection balls of the (LF)BGA. Note: Do not apply solder paste, as this has shown to result in problems during re-soldering. Device Replacement The last step in the repair process is to solder the new component on the board. Ideally, the (LF)BGA should be aligned under a microscope or magnifying glass. If this is not possible, try to align the (LF)BGA with any board markers. So as not to damage neighbouring components, it may be necessary to reduce some temperatures and times. More Information For more information on how to handle BGA devices, visit this URL: www.atyourservice.ce.philips.com (needs subscription, not available for all regions). After login, select “Magazine”, then go to “Workshop Information”. Here you will find Information on how to deal with BGA-ICs. Regardless of the special lead-free logo (which is not always indicated), one must treat all sets from this date onwards according to the rules as described below. P b Figure 2-3 Lead-free logo Due to lead-free technology some rules have to be respected by the workshop during a repair: • Use only lead-free soldering tin Philips SAC305 with order code 0622 149 00106. If lead-free solder paste is required, please contact the manufacturer of your soldering equipment. In general, use of solder paste within workshops should be avoided because paste is not easy to store and to handle. • Use only adequate solder tools applicable for lead-free soldering tin. The solder tool must be able – To reach at least a solder-tip temperature of 400°C. – To stabilise the adjusted temperature at the solder-tip. – To exchange solder-tips for different applications. • Adjust your solder tool so that a temperature around 360°C - 380°C is reached and stabilised at the solder joint. Heating time of the solder-joint should not exceed ~ 4 sec. Avoid temperatures above 400°C, otherwise wear-out of tips will rise drastically and flux-fluid will be destroyed. To avoid wear-out of tips, switch “off” unused equipment or reduce heat. • Mix of lead-free soldering tin/parts with leaded soldering tin/parts is possible but PHILIPS recommends strongly to avoid mixed regimes. If not to avoid, clean carefully the solder-joint from old tin and re-solder with new tin. • Use only original spare-parts listed in the Service-Manuals. Not listed standard material (commodities) has to be purchased at external companies. • Special information for lead-free BGA ICs: these ICs will be delivered in so-called "dry-packaging" to protect the IC against moisture. This packaging may only be opened short before it is used (soldered). Otherwise the body of the IC gets "wet" inside and during the heating time the structure of the IC will be destroyed due to high (steam)pressure inside the body. If the packaging was opened before usage, the IC has to be heated up for some hours (around 90°C) for drying (think of ESD-protection!). Do not re-use BGAs at all! • For sets produced before 1.1.2005, containing leaded soldering tin and components, all needed spare parts will EN 6 3. L05.1U AA Directions for Use For additional questions please contact your local repair help desk. be available till the end of the service period. For the repair of such sets nothing changes. In case of doubt whether the board is lead-free or not (or with mixed technologies), you can use the following method: • Always use the highest temperature to solder, when using SAC305 (see also instructions below). • De-solder thoroughly (clean solder joints to avoid mix of two alloys). Caution: For BGA-ICs, you must use the correct temperatureprofile, which is coupled to the 12NC. For an overview of these profiles, visit the website www.atyourservice.ce.philips.com (needs subscription, but is not available for all regions) You will find this and more technical information within the "Magazine", chapter "Workshop information". 3. Directions for Use You can download this information from the following websites: http://www.philips.com/support http://www.p4c.philips.com 2.4.5 Practical Service Precautions • • It makes sense to avoid exposure to electrical shock. While some sources are expected to have a possible dangerous impact, others of quite high potential are of limited current and are sometimes held in less regard. Always respect voltages. While some may not be dangerous in themselves, they can cause unexpected reactions that are best avoided. Before reaching into a powered TV set, it is best to test the high voltage insulation. It is easy to do, and is a good service precaution. Mechanical Instructions L05.1U AA 4. EN 7 4. Mechanical Instructions 4.1.3 Index of this chapter: 4.1 Assy/Panel Removal 4.2 Set Re-assembly ATSC Panel Removal Notes: • Only the ATSC module and deflection controller panel disassembly are described. For other disassembly instructions, see the Service manual for L05U AA. • Figures below can deviate slightly from the actual situation, due to different set executions. 4.1 Assy/Panel Removal 4.1.1 ATSC Assy 1. Release the fixation clamp and pull the bracket backwards. 1 1 F_15060_042.eps 180305 Figure 4-2 ATSC Module Top Shield Removal 2 F_15060_041.eps 180305 Figure 4-1 ATSC bracket 4.1.2 ATSC Module Removal F_15060_043.eps 180305 1. Disconnect all cables that lead to the module. 2. Unlock the clip at the left side of the bracket and pull out the ATSC module. Figure 4-3 ATSC Panel Removal 1. Unscrew the shield mounting screws [1] and lift the top shield. 2. Unscrew the ATSC panel mounting screws [2] and take out the ATSC panel. 4.1.4 Deflection Control Panel 1. Remove all cables. 2. Pull the panel upwards out of the connectors. 4.2 Set Re-assembly To re-assemble the whole set, do all processes in reverse order. Note: before you mount the rear cover, perform the following checks: • Check whether the AC power cord is mounted correctly in its guiding brackets. • Check whether all cables are replaced in their original position EN 8 5. L05.1U AA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding • Index of this chapter: 5.1 Test Points 5.2 Service Modes 5.3 Problems and Solving Tips Related to CSM 5.4 ComPair 5.5 Error Codes 5.6 The Blinking LED Procedure 5.7 Protections 5.8 Fault Finding and Repair Tips 5.1 Test Points This chassis is equipped with test points in the service printing. In the schematics test points are identified with a rectangle box around Fxxx or Ixxx. These test points are specifically mentioned in the “Test Point Overview” as “half moons” with a dot in the center. Table 5-1 Test point overview Test point Circuit Diagr. F508, F535, F536, F537, F552, F561, F563, F573, F664, Power supply I513, I518, I519, I524, I531, I533, I546 A1 F401, F412, F413, F414, F418, F452, F453, F455, F456, Line & Frame F458, F459, F460, F461, I408, I416, I417, I420, I462, Deflection I468 A2 F003, F004, I001, I002 Tuner IF A3 F201, F203, F205, F206 Hercules A4 F240, F241, F242 Features & Connectivities A5 F952, F955, I951, I952 Audio Amplifier A7 F692 Front Control A9 F331, F332, F333, F338, F339, F341, F351, F353, F354 CRT Panel B1 F361, F362, F381, F382 B2 ECO Scavem Perform measurements under the following conditions: • Television set in Service Default Alignment Mode. • Video input: Color bar signal. • Audio input: 3 kHz left channel, 1 kHz right channel. 5.2 All service-unfriendly modes (if present) are disabled. The service unfriendly modes are: – Timer / Sleep timer. – Child / parental lock. – Blue mute. – Hotel / hospital mode. – Auto shut off (when no “IDENT” video signal is received for 15 minutes). – Skipping of non-favorite presets / channels. – Auto-storage of personal presets. – Auto user menu time-out. – Auto Volume Leveling (AVL). How to enter To enter SDM, use one of the following methods: • Press the following key sequence on the remote control transmitter: “062596” directly followed by the MENU button (do not allow the display to time out between entries while keying the sequence). • Short the jumper wire 9252 with a cold ground on the family board (for example the tuner casing) and apply AC power. Then press the power button (remove the short after startup). Caution: Entering SDM by shorting wire 9252 with ground will override the +8V-protection. Do this only for a short period. When doing this, the service-technician must know exactly what he is doing, as it could damage the television set. • Or via ComPair. After entering SDM, the following screen is visible, with SDM in the upper right corner of the screen to indicate that the television is in Service Default Mode. 00028 L05U 0.12 SDM ERR 0 0 0 0 0 OP 000 057 140 032 120 128 000 Service Modes Service Default mode (SDM) and Service Alignment Mode (SAM) offers several features for the service technician, while the Customer Service Mode (CSM) is used for communication between the call center and the customer. This chassis also offers the option of using ComPair, a hardware interface between a computer and the TV chassis. It offers the abilities of structured troubleshooting, error code reading, and software version readout for all chassis. Minimum requirements for ComPair: a Pentium processor, a Windows OS, and a CD-ROM drive (see also paragraph "ComPair"). F_15060_044.eps 210305 Figure 5-1 SDM menu 5.2.1 Service Default Mode (SDM) Purpose • To create a predefined setting for measurements to be made. • To override software protections. • To start the blinking LED procedure. Specifications • Tuning frequency: 61.25 MHz (channel 3). • Color system: NTSC M. • All picture settings at 50% (brightness, color contrast, hue). • Bass, treble and balance at 50 %; volume at 25 %. Service Modes, Error Codes, and Fault Finding How to navigate Use one of the following methods: • When you press the MENU button on the remote control, the set will switch on the normal user menu in the SDM mode. • On the TV, press and hold the VOLUME DOWN and press the CHANNEL DOWN for a few seconds, to switch from SDM to SAM and reverse. How to exit Switch the set to STANDBY by pressing the POWER button on the remote control transmitter or the television set. If you turn the television set off by removing the AC power (i.e., unplugging the television) without using the POWER button, the television set will remain in SDM when AC power is reapplied, and the error buffer is not cleared. 5.2.2 Service Alignment Mode (SAM) Purpose • To change option settings. • To display / clear the error code buffer. • To perform alignments. Specifications • Operation hours counter (maximum five digits displayed). • Software version, Error codes, and Option settings display. • Error buffer clearing. • Option settings. • AKB switching. • Software alignments (Tuner, White Tone, Geometry & Audio). • NVM Editor. • ComPair Mode switching. How to enter To enter SAM, use one of the following methods: • Press the following key sequence on the remote control transmitter: “062596" directly followed by the OSD/ STATUS button (do not allow the display to time out between entries while keying the sequence). • Or via ComPair. After entering SAM, the following screen is visible, with SAM in the upper right corner of the screen to indicate that the television is in Service Alignment Mode. 00028 L05U 0.12 ERR 0 0 0 0 0 SAM OP 000 057 140 032 120 128 000 . Clear . Options . AKB . Tuner . White Tone . Geometry . Audio . NVM Editor . ComPair Clear ? On on F_15060_045.eps 180305 Figure 5-2 SAM menu L05.1U AA 5. EN 9 Menu explanation 1. LLLLL. This represents the run timer. The run timer counts normal operation hours, but does not count standby hours. 2. AAABCD-x.y. This is the software identification of the main microprocessor: – A= the project name (= L05). – B= the region: E= Europe, A= Asia Pacific, U= NAFTA, L= LATAM. – C= the software diversity: • Europe: T= 1 page TXT, F= Full TXT, V= Voice control. • LATAM and NAFTA: A= ATSC, N= Stereo nondBx, S= Stereo dBx. • Asian Pacific: T= TXT, N= non-TXT, C= NTSC. • ALL regions: M= mono, D= DVD, Q= Mk2. – D= the language cluster number. – x= the main software version number (updated with a major change that is incompatible with previous versions). – y= the sub software version number (updated with a minor change that is compatible with previous versions). 3. SAM. Indication of the Service Alignment Mode. 4. Error Buffer. Shows all errors detected since the last time the buffer was erased. Five errors possible. 5. Option Bytes. Used to set the option bytes. See “Options” in the Alignments section for a detailed description. Seven codes are possible. 6. Clear. Erases the contents of the error buffer. Select the CLEAR menu item and press the MENU RIGHT key. The content of the error buffer is cleared. 7. Options. Used to set the option bits. See “Options” in the Alignments section for a detailed description. 8. AKB. Used to disable (Off) or enable (On) the “black current loop” (AKB= Auto Kine Bias). 9. Tuner. Used to align the tuner. See “Tuner” in the Alignments section for a detailed description. 10. White Tone. Used to align the white tone. See “White Tone” in the Alignments section for a detailed description. 11. Geometry. Used to align the geometry settings of the television. See “Geometry” in the Alignments section for a detailed description. 12. Audio. No audio alignment is necessary for this television set. 13. NVM Editor. Can be used to change the NVM data in the television set. See table “NVM data” further on. 14. ComPair. Can be used to switch on the television to In System Programming (ISP) mode, for software uploading via ComPair. Caution: When this mode is selected without ComPair connected, the TV will be blocked. Remove the AC power to reset the TV. How to navigate • In SAM, select menu items with the MENU UP/DOWN keys on the remote control transmitter. The selected item will be highlighted. When not all menu items fit on the screen, use the MENU UP/DOWN keys to display the next / previous menu items. • With the MENU LEFT/RIGHT keys, it is possible to: – Activate the selected menu item. – Change the value of the selected menu item. – Activate the selected submenu. • In SAM, when you press the MENU button twice, the set will switch to the normal user menus (with the SAM mode still active in the background). To return to the SAM menu press the MENU or STATUS/EXIT button. • When you press the MENU key in while in a submenu, you will return to the previous menu. How to store SAM settings To store the settings changed in SAM mode, leave the top level SAM menu by using the POWER button on the remote control transmitter or the television set. EN 10 5. L05.1U AA Service Modes, Error Codes, and Fault Finding How to exit Switch the set to STANDBY by pressing the POWER button on the remote control transmitter or the television set. If you turn the television set “off” by removing the AC power (i.e., unplugging the television) without using the POWER button, the television set will remain in SAM when AC power is re-applied, and the error buffer is not cleared. 5.2.3 Customer Service Mode (CSM) Purpose The Customer Service Mode shows error codes and information on the TV’s operation settings. The call center can instruct the customer (by telephone) to enter CSM in order to identify the status of the set. This helps the call center to diagnose problems and failures in the TV set before making a service call. The CSM is a read-only mode; therefore, modifications are not possible in this mode. How to enter To enter CSM, press the following key sequence on the remote control transmitter: “123654” (do not allow the display to time out between entries while keying the sequence). • • 5.2.4 Press the MENU, STATUS/EXIT, or POWER button on the remote control transmitter. Press the POWER button on the television set. Digital Customer Service Mode (DCSM) Purpose The Digital Customer Service Mode shows error codes and information on the TV’s digital operation settings. The call center can instruct the customer (by telephone) to enter DCSM in order to identify the digital status of the set. This helps the call center to diagnose problems and failures with the ATSC part before making a service call. The DCSM is a read-only mode; therefore, modifications are not possible in this mode, with exception of the digital error buffer. This error buffer can be cleared in DCSM. How to enter To enter DCSM, the set has to be in digital mode. When the set is in digital mode, press the following key sequence on the remote control transmitter: “123654” (do not allow the display to time out between entries while keying the sequence). Upon entering the Digital Customer Service Mode, the following screen will appear: Upon entering the Customer Service Mode, the following screen will appear: 1 00028 L05U 0.12 CSM 2 CODES 0 0 0 0 0 3 OP 000 057 140 032 120 128 000 4 nnXXnnnn/nnX 5 P3C-1 6 NOT TUNED 7 NTSC 8 STEREO 9 CO 50 CL 50 BR 50 HU 0 0 AVL Off BS 50 F_15060_046.eps 180305 Figure 5-3 CSM menu Menu explanation 1. Indication of the decimal value of the operation hours counter, Software identification of the main microprocessor (see "Service Default or Alignment Mode" for an explanation), and the service mode (CSM= Customer Service Mode). 2. Displays the last five errors detected in the error code buffer. 3. Displays the option bytes. 4. Displays the type number version of the set. 5. Reserved item for P3C call centers. 6. Indicates the television is receiving an "IDENT" signal on the selected source. If no "IDENT" signal is detected, the display will read "NOT TUNED" 7. Displays the detected Color system (e.g. PAL/NTSC). 8. Displays the detected Audio (e.g. stereo/mono). 9. Displays the picture setting information. 10. Displays the sound setting information. How to exit To exit CSM, use one of the following methods: F_15060_047.eps 180305 Figure 5-4 DCSM menu Menu explanation 1. H/W version: Indication of the hardware version of the ATSC module. 2. S/W version: – D/D: The DST driver software version. – HW: The DST middleware version. – PODware: The CableCARD software version. – ATI lib: The ATI software version. – FE: Front End software version. – Kernel: Linux kernel software version. 3. CableCARD (POD): CableCard present or not. 4. Channel Information: – Input: Displays the input type. – Major.Minor: Displays the major and minor channel numbers. – RF: Displays the physical channel number. – UID: Displays the unique ID. 5. Video Information: – Source Format: Displays the format of the received signal. 6. Audio Information: – Dolby: Displays information on the received audio signal. 7. Signal Status (FDC): Not used in this version. 8. Signal Status (FAT): Displays the Forward Application status. – Status: Displays if the signal is locked. – Type: Displays the type of the received signal. – SQI: Signal Quality Index (0..100). – Equai_SNR: Equaliser Signal to Noise Ratio. Service Modes, Error Codes, and Fault Finding L05.1U AA 5. EN 11 Snowy picture Check CSM line 6. If this line reads “Not Tuned”, check the following: • Antenna not connected. Connect the antenna. • No antenna signal or bad antenna signal. Connect a proper antenna signal. • The tuner is faulty (in this case line 2, the Error Buffer line, will contain error number 10). Check the tuner and replace/ repair the tuner if necessary. – Tre_SNR: Trellis Signal to Noise Ratio. – RS Error Rate: Reed-Solomon error rate. 9. Error Status: Displays the error status for each device. How to clear the error buffer To clear the error buffer, press the LEFT key on the remote control. How to exit To exit DCSM, press the RIGHT key on the remote control. Black and white picture 5.3 Problems and Solving Tips Related to CSM 5.3.1 Picture Problems If: • The picture improves after you have pressed the AUTO PICTURE button on the remote control transmitter, Note: The problems described below are all related to the TV settings. The procedures used to change the value (or status) of the different settings are described. Then: 1. Press the AUTO PICTURE button on the remote control transmitter repeatedly (if necessary) to choose PERSONAL picture mode. 2. Press the MENU button on the remote control transmitter. This brings up the normal user menu. 3. In the normal user menu, use the MENU UP/DOWN keys to highlight the PICTURE sub menu. 4. Press the MENU LEFT/RIGHT keys to enter the PICTURE sub menu. 5. Use the MENU UP/DOWN keys to select COLOR. 6. Press the MENU RIGHT key to increase the COLOR value. 7. Press the MENU button on the remote control transmitter twice to exit the user menu. 8. The new PERSONAL preference value is automatically stored. Picture too dark or too bright If: • The picture improves when you have press the AUTO PICTURE button on the remote control transmitter, or • The picture improves when you enter the Customer Service Mode, Then: 1. Press the AUTO PICTURE button on the remote control transmitter repeatedly (if necessary) to choose PERSONAL picture mode. 2. Press the MENU button on the remote control transmitter. This brings up the normal user menu. 3. In the normal user menu, use the MENU UP/DOWN keys to highlight the PICTURE sub menu. 4. Press the MENU LEFT/RIGHT keys to enter the PICTURE sub menu. 5. Use the MENU UP/DOWN keys (if necessary) to select BRIGHTNESS. 6. Press the MENU LEFT/RIGHT keys to increase or decrease the BRIGHTNESS value. 7. Use the MENU UP/DOWN keys to select PICTURE. 8. Press the MENU LEFT/RIGHT keys to increase or decrease the PICTURE value. 9. Press the MENU button on the remote control transmitter twice to exit the user menu. 10. The new PERSONAL preference values are automatically stored. Menu text not sharp enough If: • The picture improves after you have pressed the AUTO PICTURE button on the remote control transmitter, Then: 1. Press the AUTO PICTURE button on the remote control transmitter repeatedly (if necessary) to choose PERSONAL picture mode. 2. Press the MENU button on the remote control transmitter. This brings up the normal user menu. 3. In the normal user menu, use the MENU UP/DOWN keys to highlight the PICTURE sub menu. 4. Press the MENU LEFT/RIGHT keys to enter the PICTURE sub menu. 5. Use the MENU UP/DOWN keys to select PICTURE. 6. Press the MENU LEFT key to decrease the PICTURE value. 7. Press the MENU button on the remote control transmitter twice to exit the user menu. 8. The new PERSONAL preference value is automatically stored. White line around picture elements and text If: The picture improves after you have pressed the AUTO PICTURE button on the remote control transmitter, Then: 1. Press the AUTO PICTURE button on the remote control transmitter repeatedly (if necessary) to choose PERSONAL picture mode. 2. Press the MENU button on the remote control transmitter. This brings up the normal user menu. 3. In the normal user menu, use the MENU UP/DOWN keys to highlight the PICTURE sub menu. 4. Press the MENU LEFT/RIGHT keys to enter the PICTURE sub menu. 5. Use the MENU UP/DOWN keys to select SHARPNESS. 6. Press the MENU LEFT key to decrease the SHARPNESS value. 7. Press the MENU button on the remote control transmitter twice to exit the user menu. 8. The new PERSONAL preference value is automatically stored. 5.4 ComPair 5.4.1 Introduction ComPair (Computer Aided Repair) is a service tool for Philips Consumer Electronics products. ComPair is a further development on the European DST (service remote control), which allows faster and more accurate diagnostics. ComPair has three big advantages: • ComPair helps you to quickly get an understanding on how to repair the chassis in a short time by guiding you systematically through the repair procedures. • ComPair allows very detailed diagnostics (on I2C level) and is therefore capable of accurately indicating problem areas. You do not have to know anything about I2C commands yourself because ComPair takes care of this. EN 12 • 5.4.2 5. L05.1U AA Service Modes, Error Codes, and Fault Finding ComPair speeds up the repair time since it can automatically communicate with the chassis (when the microprocessor is working) and all repair information is directly available. When ComPair is installed together with the Force/SearchMan electronic manual of the defective chassis, schematics and PWBs are only a mouse click away. 5.4.3 How To Connect This is described in the chassis fault finding database in ComPair. TO UART SERVICE CONNECTOR TO I2C SERVICE CONNECTOR Specifications ComPair consists of a Windows based fault finding program and an interface box between PC and the (defective) product. The ComPair interface box is connected to the PC via a serial (or RS232) cable. For this chassis, the ComPair interface box and the TV communicate via a bi-directional service cable via the service connector(s). The ComPair fault finding program is able to determine the problem of the defective television. ComPair can gather diagnostic information in two ways: • Automatic (by communication with the television): ComPair can automatically read out the contents of the entire error buffer. Diagnosis is done on I2C/UART level. ComPair can access the I2C/UART bus of the television. ComPair can send and receive I2C/UART commands to the micro controller of the television. In this way, it is possible for ComPair to communicate (read and write) to devices on the I2C/UART buses of the TV-set. • Manually (by asking questions to you): Automatic diagnosis is only possible if the micro controller of the television is working correctly and only to a certain extend. When this is not the case, ComPair will guide you through the fault finding tree by asking you questions (e.g. Does the screen give a picture? Click on the correct answer: YES / NO) and showing you examples (e.g. Measure test-point I7 and click on the correct oscillogram you see on the oscilloscope). You can answer by clicking on a link (e.g. text or a waveform picture) that will bring you to the next step in the fault finding process. By a combination of automatic diagnostics and an interactive question / answer procedure, ComPair will enable you to find most problems in a fast and effective way. Beside fault finding, ComPair provides some additional features like: • Up- or downloading of pre-sets. • Managing of pre-set lists. • Emulation of the (European) Dealer Service Tool (DST). • If both ComPair and Force/SearchMan (Electronic Service Manual) are installed, all the schematics and the PWBs of the set are available by clicking on the appropriate hyperlink. Example: Measure the DC-voltage on capacitor C2568 (Schematic/Panel) at the Mono-carrier. – Click on the “Panel” hyperlink to automatically show the PWB with a highlighted capacitor C2568. – Click on the “Schematic” hyperlink to automatically show the position of the highlighted capacitor. PC VCR Power 9V DC I2C E_06532_021.eps 180804 Figure 5-5 ComPair interface connection 5.4.4 How To Order ComPair order codes (US): • ComPair Software: ST4191. • ComPair Interface Box: 4822 727 21631. • AC Adapter: T405-ND. • ComPair Quick Start Guide: ST4190. • ComPair interface extension cable: 3139 131 03791. • ComPair UART interface cable: 3122 785 90630 Note: If you encounter any problems, contact your local support desk. 5.5 Error Codes The error code buffer contains all errors detected since the last time the buffer was erased. The buffer is written from left to right. When an error occurs that is not yet in the error code buffer, it is displayed at the left side and all other errors shift one position to the right. 5.5.1 How To Read The Error Buffer You can read the error buffer in 3 ways: • On screen via the SAM (if you have a picture). Examples: – ERROR: 0 0 0 0 0 : No errors detected – ERROR: 6 0 0 0 0 : Error code 6 is the last and only detected error – ERROR: 9 6 0 0 0 : Error code 6 was detected first and error code 9 is the last detected (newest) error • Via the blinking LED procedure (when you have no picture). See “The Blinking LED Procedure”. • Via ComPair. Service Modes, Error Codes, and Fault Finding 5.5.2 • How To Clear The Error Buffer The error code buffer is cleared in the following cases: • By using the CLEAR command in the SAM menu: – To enter SAM, press the following key sequence on the remote control transmitter: “062596” directly followed by the OSD/STATUS button (do not allow the display to time out between entries while keying the sequence). – Make sure the menu item CLEAR is highlighted. Use the MENU UP/DOWN buttons, if necessary. – Press the MENU RIGHT button to clear the error buffer. The text on the right side of the “CLEAR” line will change from “CLEAR?” to “CLEARED” L05.1U AA 5. EN 13 If the contents of the error buffer have not changed for 50 hours, the error buffer resets automatically. Note: If you exit SAM by disconnecting the AC power from the television set, the error buffer is not reset. 5.5.3 Error Codes In case of non-intermittent faults, write down the errors present in the error buffer and clear the error buffer before you begin the repair. This ensures that old error codes are no longer present. If possible, check the entire contents of the error buffer. In some situations, an error code is only the result of another error Table 5-2 Error code overview 5.6 Error Device Error description 0 Not applicable No Error Check item Diagram 1 Not applicable 2 Not applicable X-Ray/Over-voltage protection (US only) 2411, 2412, 2413, 6404, 6411, 6412 A2 High beam (BCI) protection 3412, 7405 3 Not applicable A2 Vertical guard protection 3466, 7451 A2 4 Not applicable - - - 5 Not applicable +5v protection 7604, 7605 A5 6 I2C bus General I2C error 7200, 3207, 3214 A4 7 Not applicable - - - 8 Not applicable - - - 9 24C16 I2C error while communicating with the EEPROM 7601, 3604, 3605 A5 10 Tuner I2C error while communicating with the PLL tuner 1000, 5001 A3 11 TDA6107/A Black current loop instability protection 7330, 3351, CRT B1 19 TDA1200x I2C error while communicating with sound decoder in Hercules IC 7200 A4 20 TDA1200x I2C error while communicating with video cosmic in Hercules IC 7200 A4 ATSC module 33 TA1360AFG I2C error while communicating with the ATSC PQ - 34 TA1317AFG I2C error while communicating with the ATSC deflection controller - ATSC module 35 SAA5565 I2C error while communicating with the ATSC uProcessor - ATSC module The Blinking LED Procedure Using this procedure, you can make the contents of the error buffer visible via the front LED. This is especially useful when there is no picture. • For a detailed mode description, see the relevant sections. 5.8 When the SDM is entered, the front LED will blink the contents of the error-buffer: • When all the error-codes are displayed, the sequence finishes with a LED blink of 1.5 seconds, • The sequence starts again. Example of error buffer: 12 9 6 0 0 After entering SDM, the following occurs: • 1 long blink of 5 seconds to start the sequence, • 12 short blinks followed by a pause of 1.5 seconds, • 9 short blinks followed by a pause of 1.5 seconds, • 6 short blinks followed by a pause of 1.5 seconds, • 1 long blink of 1.5 seconds to finish the sequence, • The sequence starts again at 12 short blinks. 5.7 Protections If a fault situation is detected, an error code will be generated; and, if necessary, the television set will go into protection mode. Blinking of the red LED at a frequency of 3 Hz indicates the protection mode. In some error cases, the microprocessor does not put the set in protection mode. The error codes of the error buffer and the blinking LED procedure can be read via the Service Default Menu (SDM), or via ComPair. To get a quick diagnosis the chassis has three service modes implemented: • The Customer Service Mode (CSM). • The Service Default Mode (SDM). • The Service Alignment Mode (SAM). The Digital Customer Service Mode (DCSM). Fault Finding and Repair Tips Notes: • It is assumed that the components are mounted correctly with correct values and no bad solder joints. • Before any fault finding actions, check if the correct options are set. 5.8.1 NVM Editor In some cases, it can be handy if one directly can change the NVM contents. This can be done with the “NVM Editor” in SAM mode. In the next table, the default NVM values are given. EN 14 5. Service Modes, Error Codes, and Fault Finding L05.1U AA Power Supply Set Not Working 32PT21705 27PT21714 30PW21709 Item 5.8.2 Default values (hex) 26PW21718 Address (dec) Table 5-3 NVM default values for NAFTA-region NVM Table Version 19 15 15 15 Option Table Version 20 70 70 70 70 EW (EW Width) 56 3C 66 3D 3C PW (EW Parabola Width) 57 0E 14 17 28 5E Check Power Supply Mains Switch 15 HS (Horizontal Shift) 58 58 56 5A HP (Horizontal Parallelogram) 59 08 08 08 07 HB (Horizontal Bow) 60 08 0A 09 05 UCP (EW Upper Corner Parabola) 61 10 16 10 10 LCP (EW Lower Corner Parabola) 62 0F 07 11 11 TC (EW Trapezium) 63 40 54 44 43 VS (Vertical Slope) 64 00 00 00 00 VA (Vertical Amplitude) 65 40 2F 33 3D VSC (S-Correction) 66 2C 23 32 35 VSH (Vertical Shift) 67 40 41 3F 42 VX (Vertical Zoom) 68 00 00 00 0F VSL (Vertical Scroll) 69 79 74 78 72 VL (Vertical Linearity) 70 10 12 11 12 EWS (EW S Correction) 71 10 00 10 10 EWC (EW Corner) 72 10 0C 12 16 AGC (AGC Takeover) 163 1D 1D 1D 1D OIF (IF-PLL Offset) 164 26 26 26 26 IFAGC, SBO 166 20 20 20 20 Hercules Default SOC & Brightness 211 1F 1F 1F 1F Hercules Default Color 212 10 10 10 10 Hercules Default Contrast 213 1F 1F 1F 1F Hercules Default Sharpness 214 0D 0D 0D 0D Hercules Default Hue 215 20 20 20 20 Hercules Default Base-Band Tint 216 20 20 20 20 Hercules Default White Point Red 217 20 20 20 20 Hercules Default White Point Green 218 20 20 20 20 Hercules Default White Point Blue 219 20 20 20 20 Hercules Default CL & PWL 220 DF DF DF DF Hercules Default RF & AV Y Delay 221 77 77 77 77 Hercules Default BLOR 222 20 20 20 20 Hercules Default BLOG 223 20 20 20 20 Last Brightness (VID PP others) 264 1E 1E 1E 1E Last Color (VID PP others) 265 44 44 44 44 Last Contrast (VID PP others) 266 64 64 64 64 Last Sharpness (VID PP others) 267 44 44 44 44 Last Hue (VID PP others) 268 32 32 32 32 Last Color Temperature (VID PP others) 269 01 01 01 01 White-D Cool Red 356 FA FA FA FA White-D Cool Blue 357 12 12 12 12 White-D Normal Red 358 52 52 52 52 White-D Normal Blue 359 4C 4C 4C 4C White-D Warm Red 360 0A 0A 0A 0A White-D Warm Blue 361 E8 E8 E8 E8 Bridge Rectifier circuit 6500 Check fusible resistor 1500 & circuit before it Not Ok Ok Check DC voltage at 2505/2507 Not Ok Ok Check fusible resistor 3535 Check 3536 Check IC7510 & IC7531 Ok Set able to start-up No Check other fusible resistor and capacitor in the circuit Yes End F_15050_004.eps 030205 Figure 5-6 Fault finding tree “Set not working” Set Does Not Start Up Set Unable to Start Software loaded? No Fuse Blown? Yes Yes Change Fuse Load Software Check voltage across 2552 Is Vbatt approximately 140V No Check Power Supply circuit Yes Check voltage 7545 No 3V3 Yes Check 8V across 7543 Yes Check 5V across 7544 Yes Set able to Start No Check Line Transistor 7405 Yes No Trident Yes End F_15050_003.eps 030205 Figure 5-7 Fault finding tree “Set does not start up” Service Modes, Error Codes, and Fault Finding 5.8.3 L05.1U AA 5. EN 15 Blank Screen Deflection One Thin Vertical Line Quick check: • Set in protection mode. • LED blinking with error “3”. Blank Screen Check Vg2 (fine tune) One Thin Vertical Line LED Blinking Ok Not Ok Check all connection and peripheral at Deflection Circuit in place Picture appears? Picture not appearing Check Beam Current Limit (voltage is 1.8V-2V when brightness and contrast is set to the maximum Not Ok Check deflection circuit Ok Check Line Transistor 7405 Check heater voltage (measure pin 9&10 at the CRT socket) Ok Picture not appearing Not Ok Is VBE between 200mV to 30mV & VCB approximately 500mV Yes Check video supply (2436) is approximately 180V Check Horizontal Deflection Circuitry Ok Picture appears? Replace transistor Ok E_14480_059.eps 170204 End F_15050_001.eps 030205 Figure 5-8 Fault finding tree “One thin vertical line” Figure 5-10 Fault finding tree “Blank screen” One Thin Horizontal Line Quick check: • Set in protection mode. • LED blinking with error “2”. 5.8.4 Set is not able to go into AV or any missing AV is encountered E.g. AV1 is available but not able to enter to AV1: Check if the option setting is correct. One Horizontal Thin Line LED Blinking Set is able to go to AV, but no audio is heard. 1. Check that continuity of signal is there from the SCART/ Cinch input to the input of the Hercules. 2. If continuity is there and still no audio, check that option settings are correct. 3. If logic setting is correct and still no audio, proceed to Audio Decoder/Processor troubleshooting section. Check all connection and peripheral at Deflection Circuit in place Check transistor (7451, 7523, 7543) at Vertical Deflection Circuitry Source Selection Set is able to go into AV but no video is available: 1. Check continuity from AV input to HERCULES depending on the input. 2. If continuity is available and yet no video, proceed to Video Processor troubleshooting section. Replace transistor Check Vertical Deflection Circuit E_14480_060.eps 170204 Figure 5-9 Fault finding tree “One thin horizontal line” EN 16 5.8.5 5. Service Modes, Error Codes, and Fault Finding L05.1U AA Picture Ok, No Sound Tuner and IF No Picture 1. Check that the Option settings are correct. 2. If correct, check that supply voltages are there. 3. If supply voltages are present, check whether picture is present in AV. 4. If picture is present in AV, check with the scope the Tuner IF output signal by manual storage to a known channel. 5. If IF output is present, Tuner is working fine. If no IF output, I2C data lines may be open, check continuity of I2C lines. If I2C lines are ok, Tuner may be defect, replaced Tuner. 6. If Tuner IF is present and yet still no picture in RF mode, go to Video Processing troubleshooting section. No Picture, No Sound Check AGC Voltage, pin 1 of tuner Check IF output of tuner, pin 11 CVBS present? Refer to fig. "Power Supply: Set not working" >30V & <35V No Replace SAW filter Check SAW filter output (pin 4&5) EU/AP/CH (QSS)- 1001 NA/LA/AP INT - 1002 No Yes Check VT Supply Section Output Ok? AGC voltage changes with different signal strength No Yes Check tuning supply voltage, pin 9 of tuner No Picture, No Sound, Raster Ok Picture Ok, No Sound Check supply voltage, pin 7 of tuner Yes 5V No No Check Power Supply Check other functional area E_14480_063.eps 170204 Yes Check AGC circuit section Figure 5-12 Fault finding tree “Picture ok, no sound” Check Tuner pin 4 & 5 I2C Bus Unable To Perform Tuning Ok No Check other functional area Unable to perform tuning Yes Enter SDM check optionbyte 1 Enter SDM and change to the appropriate byte Incorrect Replace Tuner E_14480_062.eps 170204 Figure 5-11 Fault finding tree “No picture, no sound” Correct Check if tuner Supply Voltage pin 7 5V No Check Power Supply Yes Check I2C circuit Replace Tuner No Check Tuner Supply Voltage 33V Yes Not Ok Check I2C at pin 4 & 5 and tuner Not Ok Not Ok Ok I2C Check other functional area Tuner Not Ok E_14480_064.eps 170204 Figure 5-13 Fault finding tree “Unable to perform tuning” Service Modes, Error Codes, and Fault Finding 5.8.6 5.8.8 Controller L05.1U AA 5. EN 17 Audio Processing No Sound Below are some guidelines for troubleshooting of the Micro Controller function. Normally Micro Controller should be checked when there is a problem of startup. 1. Check that both +3.3 V_dc and +1.8 V_dc are present. 2. Check that crystal oscillator is working. 3. Check that Power Good signal is at “high” logic, normal operation. 4. Check that HERCULES is not in standby mode. Pin 15 of HERCULES should be 0 V_dc. 5. Make sure H-drive pulse is there. This can be checked at resistor R3239. If H-drive does not exist, remove resistor R3239 to check if there is loading. Picture Ok, No Sound Tuner IF Ok Not Ok Check Tuner/IF Ok Check AUDOUTLSL & AUDOUTLSR pin at Hercules Note: When the set shuts down after a few second after power “on”, the main cause is that Vg2 not aligned properly, try adjusting Vg2 during the few seconds of power “on”. Not Ok Check Hercules IC Ok 5.8.7 Video Processing Check Audio Amplifier No Picture When “no picture in RF”, first check if the microprocessor is functioning ok in section “Controller”. If that is ok, follow the next steps. When “no picture in AV”, first check if the video source selection is functioning ok in section “Source Selection”. If that is ok, follow the next steps. Check Audio Amplifier Circuit and loud speaker Description Address (dec) Address (hex) Value (hex) SPR, WS 140 8C 00 VMA, SVM 141 8D 32 NVM_SOC_SMD 142 8E 03 Check Power Supply Not Ok Replace Audio Amplifier Ok Check NVM E_14480_065.eps 170204 Figure 5-14 Fault finding tree “No sound” No RF audio for QSS/Inter-Carrier stereo sets. 1. Check pin 99 and 100 for SIF signal (for QSS) or pin 104 and 105 for video with SIF (for Inter-Carrier) 2. If signal is not present, check for the QSS/FMI bit settings. Check also the NVM data. 3. If signals are present and still no audio, check the audio supply voltage +8V are present. 4. If still no audio signal at Hercules output, Hercules is faulty. For sets with TDA9178, follow steps below: 1. Put Option Byte 2 bit 4 to “0”; if video signal is not available, then check fault finding section “Controller”, Section “Source Selection”, and steps above. 2. If video is available but not correct, put Option Byte 2 bit 4 to “1”, then check if LTI panel is present. If not, put LTI panel in the main chassis (connector 1221). 3. If LTI panel is in main chassis, check cable between LTI panel and main chassis (position is 1206). If it is connected, then the LTI panel is faulty, replace it. Table 5-4 NVM default values for Scavem Check Audio Power Supply Ok 1. Check that normal operating conditions are met. 2. Check that there is video signal at pin 81. If no video, demodulator part of the HERCULES is faulty, replace with new HERCULES. 3. If video signal is available at pin 81, check pin 56, 57, and 58 for the RGB signal. 4. If signal is not available, try checking the BRIGHTNESS and/or CONTRAST control, and make sure it is not at zero. 5. If still with the correct settings and no video is available, proceed to the CRT/RGB amplifier diagram. For sets with Scavem, and Scavem does not work, follow steps below: 1. Check Scavem coil connector (position is 1361) if connected; if not, connect it. 2. If connected, check NVM “bit storage” byte 1 bit 7; if it is not “1”, set it to “1”. 3. If it is “1”, then check the data of the NVM addresses as in the next table. If the data is not correct, then set these addresses to diagram values. 4. If it still not works, track Scavem output from pin64 of HERCULES to CRT panel. Not Ok No AV audio. 1. Check troubleshooting methods in section “Source Selection”. 2. Check the output of the Hercules to see if there is signal available. If no, check the normal operating condition and also the NVM data. 3. If still no audio signal at Hercules output, Hercules is faulty. Note: If there is audio signal at Hercules output and no audio at loudspeaker, proceed to Audio Amplifier troubleshooting methods. 5.8.9 Audio Amplifier No RF as well as AV audio at the loudspeaker: 1. Check that the normal operation condition of the amplifier is met. 2. If normal operation conditions are met, check the continuity from Hercules output to input of the amplifier. 3. If continuity is there and still no audio, check speaker wire connections. If still no audio, amplifier IC might be faulty. EN 18 5. L05.1U AA Service Modes, Error Codes, and Fault Finding 5.8.10 ATSC No digital picture & Sound No picture, No sound, Raster OK. 1 GND 2 RED_IN 1.4Vpp(100IRE) 3 GND 0V Analog video 4 (P1254) 5 GND 0V BLUE_IN 1.4Vpp(100IRE) 6 Check tuning voltage, Pin 9 of Tuner Check Pin 1 of Tuner YES >30V & < 35V No Check VT Supply section Check Supply voltage, Pin 7 of Tuner AGC voltage change with difference signal strength No 5V Check Power Supply YES No GREEN_IN 1.4Vpp(100IRE) 7 HS_IN 5.0Vpp 8 VS_IN 5.0Vpp 1 AGC Voltage, 0V R_OUT 1.15Vrms Digital Audio 2 (P1219) 3 GND 0V L_OUT 1.15Vrms 4 GND 0V 1 Analog Audio (P1208) 2 3 R_IN 2Vrms L_IN 2Vrms GND 0V 1 Tx 2 GND 0V Rx 3.3V POD_DET# 3.3V 1206 control 3 (P1206) 4 3.3V 5 EXT_PWRON 3.3V 6 RESET# 3.3V Check ATSC module connector Check Tuner, Pin 4 & 5 I 2C Bus Check AGC circuit section No Check Wiring of ATSC module No Check ATSC (P1533) & (P1534) Power supply No Check Hercules UART O/P OK OK YES No 1 3_3V 3.3V 2 3_3V 3.3V 3 GND 0V 4 GND 0V 5 9V 9VA GND 0V 6 Power Supply ATSC (P1533) 7 STBY_EN GND 9 GND 0V 10 6V 6VA 11 6V 6VA 12 GND 0V 1 3_3V 3.3V 2 3_3V 3.3V 3 3_3V 3.3V 4 GND 0V GND 0V 6 GND 0V 7 6V 6VA 8 GND 0V Check supply voltage 6V & 3V3 OK OK POWER_DOWN GND 8 Power Supply ATSC (P1534) 5 Check YpbPr O/P (ATSC module) YES YES Check (K) Deflection controller Panel Check ATSC (P1206) UART Signal OK YES Replace ATSC module F_15060_048.eps 180305 Figure 5-15 Fault finding tree “ATSC part” Service Modes, Error Codes, and Fault Finding L05.1U AA 5. EN 19 5.8.11 Deflection Controller Check Deflection Controller Panel (ATSC set only) Check 10V supply from Main Chassis ok Check Power Supply Check RGB output ok Check CRT/RGB amplifier 1 CRT amp (P1404) RED_OUT 2.6Vpp(100IRE) 2 GREEN_OUT 2.6Vpp(100IRE) 3 BLUE_OUT 2.6Vpp(100IRE) 4 GND 0V 5 BC_INFO 0V5 Check CRT feedback on 1404 pin 5 ok Check signal at connector 1251 ok Check Deflection Circuit Replace Deflection Panel F_15060_049.eps 180305 Figure 5-16 Fault finding tree “Deflection Controller” EN 20 5. L05.1U AA Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 21 6. Block Diagrams, Testpoint Overviews, and Waveforms Wiring Diagram E (PV2) DEGAUSSING COIL P TOP CONTROL PANEL 1010 (PV2) 0345 (FL13) CRT 16:9 AQUADAG (FL13) EHT CRT 3P B FRAME ROTATION COIL CRT PANEL 1340 5P GREY ORANGE BLUE RIGHT SPEAKER LEFT SPEAKER (PV2) (FL13) 1336 1352 1335 SCAVEM COIL CRT SOCKET B RED BLACK 1361 3P BLACK RED (FL13)(PV2) 3P 1281 1693 6P 1252 8P (FL13) 3P LEFT (WHITE) 1504 1254 2P 5P RIGHT (RED) J 4P Ferrite core 1278 HEADPHONE A 5P 1280 3P 1405 MAINS SWITCH 1693 6P 6P 1403 8P P1534 6P 1257 1251 10P 1251 3P DEFLECTION CONTROLLER 10P K 4P P1219 1404 P1208 3P 7P 1208 12P 1207 3P 1404 7P 1250 2P 1401 1250 5P 8P P1254 1206 12P 6P P1206 Warning: Some models have tact switch. MONO CARRIER 1682 12P P1533 FRONT INTERFACE 3P Ferrite core 6P P1255 MAINS CORD To P14 ATSC 3P 1534 1533 1280 CVBS (YELLOW) 1505 2P 1535 12P SIDE A/V PANEL + HEADPHONE ATSC PANEL CRT PANEL 1381 3P 1351 5P 7P D 2P 1401 8P 4P 1400 3P LOT 1451 TUNER P14 TUNER 1219 1P ATSC BROWN To1546 A1 1005 3P ComPair CONNECTOR F_15060_035.eps 210305 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 22 Block Diagram Supply and Deflection SUPPLY AND DEFLECTION G SUPPLY J FRONT INTERFACE 1211 1 LINEARITY & PANORAMA 7460 ACTIVATING CIRCUIT ONLY FOR: 28"WSRF LA/NA 32" WSRF LA/NA 28" WS-SF LA 1231 7462 1212 1 2 2466 2 2464 2467 1404 4 MAINS SWITCH (not USA) 1461 4 LINEARITY AND PANORAMA CORRECTION 1 1 HOR. DEFL. COIL 2474 2475 1462 1 TO 1221 A1 POWER SUPPLY Degaussing Coil 4 2 3 1 1503 3 7463 I2SD/1 7541 ENERGIZING CIRCUIT (optional) 3523 2 Vbatt V_DG LINE 5500 : 5502 1500 6500 AC F508 5450 6481 +6V VDC T4E or CONNECTIONS 1463 +9V A2 LINE + FRAME DEFLECTION 1504 1 1505 A5 2 EHT 3 2505 DC 7404 5512 7404 5551 17 9 MAIN SUPPLY 5402 TO CRT B1 1 F552 5552 8 7405 BU4508DX Vbatt 18 OR F563 I513 7511 TEA1506T 3513 DRAIN 11 DRIVER I511 3514 I519 2 2511 6 Vcc 9 SENSE D 5 14 G +Vaudio S 3 7514 3522 FOCUS G2 -Vaudio F561 LINE OUTPUT CIRCUIT + E/W CORR. EW_DRIVE 5561 6562 10 +6V 2 1404 1 EHTinfo 10 2 HOR. DEFL. COIL 3516 CONTROL IC CTRL 13 I516 7512 14 4 5562 6563 7 DEMAG 3517 3571 11,12 7571 REFERENCE CIRCUIT 6511 4 1 3519 12 K2 RGB BUFFER - ATSC Stdby_Con STANDBY CIRCUIT VCC A4 5 6 8 COLD GROUND 1403 Filament 5457 3456 6453 3458 6461 3450 5458 3455 1 F_Y 3 F_Pb 7509 +6VA PANEL 5 F_Pr VDC VCC 6452 -14V F453 VideoSupply +12V_LOT 9 ATSC B 3485 11 TO P1255 AUXILIARY POWER SUPPLY 6467 I573 6573 HOT GROUND +14V 3401 VT_SUPPLY Vbatt 6545 1532 2 3536 7525 11 5 8 4 9 EW_DRIVE 7 7545 6544 +3V3A 5526 +3V HD 1401 7 SVM_ROT K1 DEFLECTION CONTROLLERS +3V3 10 6 +12V_LOT 6546 9 6 +6V 5527 7 6552 14 SUPPLY CONTROL 5504 6 7510 VideoSupply EHTinfo 2 7561 POWER_DOWN A5 A4 12 1 7404 TA1317AFG 1535 FEATURES & CONNECTIVITIES 7535 3560 7402 TA1360AFG F_Y 7542 3545 REFERENCE CIRCUIT 1 4 2 7543 F_Pb 67 F_Pr 66 VDRIVE SIGNAL AND SYNC PROC. EW_FD 7575 STANDBY CIRCUIT EWFILTER Stdby_con FBP_IN COLD GROUND 3410 Vguard 3470 1251 1 1251 1 Vguard H_OUT 37 FLYBACK GENERATOR 2 2 EHTinfo 5 VDRA 3 3 VDRA 3489 6 VDRB 4 4 VDRB 3478 EW_DRIVE 5 5 EW_DRIVE 6 6 13 6408 3470 7 F458 5 FRAME THERMAL PROTECTION 1451 1 3 F459 Vguard 3434 1 7403 14 77 39 7451 TDA8177F EHTinfo 7406/7416 A4 CRT +14V 7405 VSM_OUT HOT GROUND VDC +8V 3544 7516 TCET1103 68 7 EHT 3 +8VA 3542 3 V_NF +12VA 4 1 DEFLECTION PROCESSOR 5524 TO 1351 2 1 6539 5 3 Vbatt Filament 3429 A10 HFB 7 7573 2 3 3477 3576 +3V3 7513 TCET1103 3518 2477 3575 VM_MOD 7 7 SVM_ROT HFB 8 8 HFB H_DRV 9 9 HD VER. DEFL. COIL -14V 3471 F_15060_036.eps 210305 B1 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 23 Testpoint Overview Mono Carrier F001 F002 F003 F004 F005 F006 F007 F008 F009 A8 A7 A7 A7 A8 A6 A8 A8 A5 F010 F011 F101 F102 F103 F104 F105 F106 F107 A7 A7 B8 B8 B8 B8 B8 B8 B8 F108 F109 F110 F111 F112 F113 F115 F116 F117 3139 123 5933.1 B8 B8 C8 B8 C8 C8 C7 B7 B7 F122 F123 F138 F139 F140 F200 F201 F202 F203 B8 B8 B7 C8 B7 B4 C5 B5 B5 F207 F209 F210 F211 F212 F213 F214 F215 F216 B5 A5 A4 A4 A5 A5 B5 B6 C6 F217 F218 F219 F220 F221 F224 F225 F226 F227 C6 C6 C7 B7 C7 C6 C6 C6 A4 F228 F229 F230 F232 F233 F237 F238 F239 F243 C5 C5 B5 B5 B5 B5 B4 B5 C6 F247 F248 F249 F251 F252 F254 F270 F271 F401 A6 A6 A7 B5 C6 C6 B5 C5 C5 F402 F404 F416 F418 F419 F452 F453 F455 F456 D6 D7 E6 E6 E6 E8 C6 C6 E8 F457 F458 F459 F461 F462 F464 F465 F472 F475 D8 C8 C7 C7 D8 E5 D6 C5 C5 F476 F478 F481 F482 F483 F500 F501 F502 F503 C6 D8 D7 D7 E6 C2 C2 C2 E2 F504 F506 F507 F508 F509 F510 F534 F535 F537 E1 E2 E2 E3 E4 D5 C1 B3 C1 F541 F542 F552 F561 F562 F563 F564 F565 F573 C2 C2 D5 C4 D4 C4 C4 B3 C5 F577 F578 F580 F581 F582 F583 F584 F585 F586 C3 B2 B2 D3 B2 B2 B3 C4 B1 F691 F692 F693 F694 F695 F696 F697 F698 F950 B1 B1 B1 C1 C1 C1 B1 B1 B3 F951 F952 F953 F955 F956 I001 I002 I003 I004 B3 A3 A3 A3 A3 A8 A8 A7 A7 I005 I006 I007 I008 I009 I010 I011 I012 I014 A5 A5 A7 A5 A5 A5 A7 A7 A8 I015 I016 I017 I104 I105 I106 I107 I108 I109 A8 A7 B4 B7 B7 B7 B7 B7 B7 I110 I111 I112 I113 I114 I116 I117 I119 I120 A8 C7 B8 C7 C7 C7 A7 C8 C7 I122 I123 I124 I125 I201 I203 I204 I206 I207 B7 B7 B8 B7 A5 A5 A5 A5 B6 I208 I210 I211 I212 I213 I214 I215 I217 I218 B6 B6 C6 B6 A5 B6 A6 A6 B6 I219 I220 I221 I222 I224 I225 I226 I227 I228 B6 B6 B6 B5 B4 B5 B6 A5 B5 I229 I230 I231 I232 I233 I234 I235 I236 I237 C5 B5 B5 A7 B7 A4 B5 B5 B6 I238 I239 I240 I241 I242 I244 I280 I282 I283 B7 A5 A4 A4 C6 B7 B7 A5 A4 I410 I411 I412 I413 I414 I415 I416 I417 I418 E6 E6 D8 D5 D8 C6 D8 C6 E5 I419 I423 I424 I425 I426 I427 I428 I430 I431 E5 C6 E7 C7 D7 D7 D6 C7 C7 I432 I433 I434 I435 I436 I440 I453 I455 I456 D6 C5 C5 C6 C6 C6 E8 E7 E8 I457 I458 I459 I460 I461 I462 I463 I464 I465 D7 D7 D7 C8 D7 C7 E8 C8 D8 I466 I468 I469 I470 I471 I473 I475 I481 I482 F_15060_013.eps 210305 D7 D7 D7 D7 C7 D6 D7 C7 C6 I488 I489 I490 I492 I493 I494 I499 I501 I502 I505 I506 I507 I508 I509 I510 I511 I512 I513 I514 I515 I516 I517 I518 I519 I520 I521 I522 I523 I524 I525 I526 I527 I528 I529 I530 I531 I532 I533 I534 I536 I537 I538 I539 I540 I542 I543 I545 I547 I551 I552 I553 I554 I556 I557 I558 I560 I561 I562 I563 I564 I565 I568 I571 I572 I573 I574 I576 I578 I579 I580 I581 I582 I583 I584 I588 I589 I590 I592 I593 I594 I595 I596 I597 I599 I699 I950 I951 I952 I953 I954 I955 I956 I957 I958 I959 I960 I961 I964 I965 E5 E6 C6 D8 E8 D7 C6 E3 D2 D1 D3 C2 D1 D4 C4 E5 D4 E5 D4 E4 E4 E4 E5 E5 E5 E4 E1 D5 E5 D2 D3 E5 C4 C4 D3 D3 D3 C3 B1 D3 C3 C3 C3 C3 C2 C2 C2 B2 D5 D5 D3 D3 C3 D3 C3 D3 D4 D4 D4 C4 C4 C3 D5 C5 D5 D5 D5 D5 D4 D2 D2 D2 E3 E3 C3 B2 C3 C3 C4 C2 C3 B2 D4 D4 B1 B4 A3 A3 A3 A3 B3 A3 A3 B3 A4 B3 B3 A3 A4 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 24 Block Diagram Video VIDEO SSIF TO AUDIO PART See block diagram AUDIO A5 A4 HERCULES (CVBS I/O + FILTERS + COLOUR DECODING) 7200 (IF) K2 FEATURES & CONNECTIVITIES 1250 1250 4 4 Rout 44 RGB BUFFER - ATSC 1401 7490 Rout Rout_ADC 2 Gout_ADC 4 Bout_ADC 6 7491 A3 TUNER IF A2 9002 1000 6, 7 ATSC 1002 1003 10 F004 TUNER TO TUNER PHASE DISC F002 FM 5 4 OUTPUT SWITCH SWITCH VCO 105 VIF2 104 VIDEO IF Yint 1 SVHS 3 5 2 5 6 6 7 7 Bout 10 10 TO 1254 ATSC PANEL CVBS_OUT_SVP 65 8 Yint Uint CHROMA/CVBS PAL, NTSC SECAM DECODER Vint 50 49 51 SC1_RED_IN VIDEO IDENT SC1_BLUE_IN 1207 5 See block diagram AUDIO SC1_GREEN_IN 1252 AM 77 1277 AM SOUND DET. 70 A5 CONNECTION AUDIO IF QSS/AM SC2_CHROMA_IN 99 SIDE_CHROMA_IN 100 SIF2 78 SIF1 71 FILTER SELECTION Y 8 TO AUDIO PART 74 7001 VIDEO IN 8 FM/QSS SC1_CVBS_IN SOUND MIXER 1001 COMB FILTER &TRAP SWITCH C SC2_Y/CVBS_IN A4 SCL PLL SIDE_Y/CVBS_IN I001 TUNER IF AGC 81 31 SW_SC2_CVBS RF_AGC SIDE AV Bout CVBS/Y INPUT SWITCH I002 D 42 CVBS1 SOUND TRAP VIDEO DEMOD AGC 1 A4 SDA A4 SEL-LLPIM Gout PLL VIF1 IF 11 TV PANEL 6 7211 9 VT 6 SSIF 6001 BZX79-C33 5001 +5V Gout 7492 7003 VT_Supply 43 SIDE_CHROMA_IN MULTI BOARD C SIDE_Y/CVBS_IN 4 K2 RGB BUFFER - ATSC B3 ROTATION & SCAVEM B2 RGB AMPLIFIER K1 DEFLECTION CONTROLLER - ATSC FILAMENT 1251 SVM_ROT A8 REAR I/O CINCH 1381 1 ROTATION OUTPUT 2 ROTATION COIL 1224 AV2 SC2_Y/CVBS_IN 1 FILAMENT VSVM 3 1361 1 SC2_CHROMA_IN SVHS 5 2 SVM_ROT 4 SCAVEM OUTPUT 2 SCAVEM COIL 1223 SC1_CVBS_IN 7402 TA1360AFG A5 7606 MONITOR OUT V SC2_CVBS_OUT SW_SC2_CVBS TO P1255 ATSC PANEL 1 F_Y 68 2 F_Pb 67 3 F_Pr 66 Y1_IN +200VA CB1_PB1_IN 7409 CR1_PB1_IN B_OUT Y YUV U INPUT V B1 CRT SOCKET SIGNAL AND SYNC PROCESSOR 1340 14 B_OUT SC1_GREEN_IN SC1_BLUE_IN 1404 3 V13 1340 3 3 B 7410 G_OUT 13 7330/7340/7350 G_OUT 2 2 3334 8 7411 SC1_RED_IN R_OUT IK_IN 3 12 R_OUT 1 1 R 8 BEAM_INFO 5 5 CUT_OFF AQUADAG 11 3 G 1335 3332 8 V11 6 B 8 G 3336 8 10 9 V12 CRT R 5 7 1 5 25kV +141V 5352 FILAMENT EHT-INFO +200A 3351 +8V_12V EHT V VG2 FOCUS DEFLECTION AV1 A2 FROM DEFLECTION 2313 1351 1 1351 2 3 4 to 1401 A2 DEFLECTION 5 6 7 F_15060_037.eps 210305 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 25 Testpoint Overview CRT Panel (Multi Board) F331 F332 F334 F335 F336 F337 F338 A5 E6 E5 E5 C6 E5 C5 F339 F340 F341 F342 F345 F347 F348 D5 B5 D5 D4 B4 D6 F4 F352 F354 F361 F362 F381 F382 F383 A6 C1 A1 A2 B6 B6 A5 3139 123 5946.1 F397 F398 F399 I302 I308 I309 I310 A5 C5 C5 E2 E2 F3 F6 I311 I313 I314 I315 I316 I317 I319 F4 F3 B2 C2 B3 A1 A6 I320 I321 I322 I323 I325 I326 I327 A2 A4 E5 D2 A4 A4 C6 I328 I329 I330 I331 I332 I333 I334 E2 E2 D2 D4 D3 D2 D4 I335 I336 I342 I344 I346 I347 I348 D4 B5 E3 F5 E2 E2 C3 I350 I351 I360 I361 I362 I364 I365 D5 D2 A3 B4 B3 A3 B3 I366 I367 I368 I369 I370 I371 I373 A2 B3 A2 B2 A4 B3 D5 I375 I377 I379 I380 I381 I382 I383 B3 D6 A5 B6 A6 E5 F5 I384 I386 I387 I389 I390 I391 I392 E5 B4 B6 E3 D4 E3 E4 I393 I394 I395 I396 I397 I398 I399 E2 D1 E2 F1 D2 E2 E6 Personal Notes: F_15060_051.eps 180305 E_06532_012.eps 131004 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 26 Block Diagram Audio AUDIO A3 TUNER IF A4 HERCULES 7003 7200 SSIF A2 VT_SUPPLY 6001 BZX79-C33 5001 9002 +5V 1000 6,7 ERR 10 9 VT TUNER FM FROM TUNER PHASE DISC VIF1 F004 TV PANEL 5 SSIF VCO AMPLI + MUTE FM DEM. FM/QSS AUDIO SOURCE SELECTION 105 DIGITAL SOUND PROCESSING DAC AUDIO SELECT SCART CINCH OUTPUT AUDIO SELECT HP OUTPUT 92 93 VIF2 104 RF_AGC 31 AM VIDEO IF VIDEO DEMOD To VIDEO PART see block diagram VIDEO DIGITAL STEREO SOUND DECODER AGC 1 4 ADC PLL 1002 1003 IF 11 ATSC AUDIO DIGITAL PART F003 10 IF 96 66 67 I002 PLL TUNER IF AGC ERR 19 A4 SCL AM SOUND DET. 80 75 76 INTF_R_IN INTF_L_IN 79 A7 AUDIO AMPLIFIER D A5 A5 A5 A5 A4 A4 A4 SC2_L_IN L F004 A4 F003 SC2_R_IN R 3 SC2_R_OUT 1280 ATSC PANEL 1 SC2_L_OUT A5 I002 A4 MAIN_OUTR SIDE AV 1254 1278 5 5 1 2 2 2 L 8 Ohm/15W F955 9 6 R 8 Ohm/15W 8 200mV / div AC 10ms / div I951 F201 F203 1V / div DC 20µs / div I952 1V / div DC 20µs / div F952 2 F955 2V / div DC 2V / div DC 5 7991 7992 -Vaudio A4 VOL_MUTE VOLUME + MUTE 7991 R 50mV / div AC 2ms / div 7104 TO 1240 1138 4 1 A4 L TO P1208 I001 MAIN_OUTL I952 0V (N.A.) MONITOR OUT 1207 50mV / div AC 2ms / div 500mV / div AC 2ms / div 500mV / div AC 2ms / div MUTING 7993, 7994 A4 Stby_Con A4 POWER_DOWN MUTE MUTING A5 1240 TO1138 A8 A5 CONNECTIVITIES SIDE AV 1252 R A7 A7 F952 AV2 L MAIN_OUTL 7 I951 D MAIN_OUTR 69 +Vaudio 7990 TDA2616Q A4 A4 SC1_R_IN R A4 A4 SC1_L_IN SIDE_L_IN AV1 SIDE_R_IN A8 REAR I/O CINCH L 68 AM 72 AUDIO IF QSS/AM 73 99 SC2_L_IN 100 SIF2 SC2_R_IN SIF1 94 FILTER SELECTION A4 SEL-LLPIM 95 1001 7001 LS OUTPUT SOUND MIXER SC1_L_IN I001 SC1_R_IN A4 SDA 1207 3 3 SIDE_L_IN A4 1 1 SIDE_R_IN A4 3 INTF_L_IN A4 1 INTF_R_IN 1219 TO P1219 ATSC PANEL A4 F_15060_038.eps 210305 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 27 Block Diagram Control & I2C Overview CONTROL E TOP CONTROL 1010 2 LOCAL KEYBOARD A4 HERCULES (CONTROL) (PV2 Styling) A5 FEATURES +3.3V 7601 P D TOP CONTROL 0345 2 LOCAL KEYBOARD J SIDE AV PANEL 7200-G (Control) TDA12001H1 1682 2 or or 22 or 1281 2 1280 2 I/O PORTS (FL13 Styling) A9 FRONT INTERFACE (PARTLY) IR_OUT 32 LED_OUT 30 LIGHT-SENSOR 14 +3.3V EEPROM 8 (NVM) 6 ERR 5 9 + 9 KEY_PROTN 7 WRITE_PROTECT 3202 IIC BUS TRANSCEIVER 20 21 3207 3605 3204 3604 SDA 3214 see IIC DIAGRAM SCL + FRONT CONTROL PWM OUTPUTS 6692 TSOP1836 IR 6691 1693 3 1693 3 IR_OUT 4 LED_OUT 4 + LED +3.3V KEYBOARD 5 5 KEY_PROTN 6 6 LIGHT_SENSOR A10 POWER_DOWN 31 VOL_MUTE 15 Stdby_Con A7 A1 A7 + ON/OFF USA only 18 CPU TELETEXT (close caption) LIGHT_SENSOR 6693 17 SVM_ROT 16 SEL_LLPIM 23 I2SD/1 24 Reset__5V 25 X_RAY A5 A3 + SERVICE JUMPER ROM RAM 119 A5 SDM A5 ERR 20 1205 24MHz 9252 A5 118 I2C BUS INTERCONNECTION DIAGRAM A4 HERCULES +3.3V A5 FEATURES & CONNECTIONS +3.3V A3 TUNER IF A5 K1 DEFLECTION CONTROLLER ERR 6 3202 7200 20 SET PROCESSOR 21 PART OF VIDEOPROCESSER (HERCULES) 3204 1275 3207 3214 6210 SDA SDA SCL SCL 3605 6211 +3.3V 5 3601 22 ERR 19,20 WRITE_PROTECT 7 3604 6 7601 PCF8511 EEPROM (NVM) ERR 9 3001 5 1 2 1 2 3486 UOC_SDA 3487 UOC_SCL 3000 4 16 1005 1000 TUNER ERR 10 1400 For COMPAIR only 1206 1 1 2 3 3 TO P1206 ATSC PANEL 17 28 30 7404 TA1317AFG DEFLECTION PROCESSOR 7202 TA1360AFG SIGNAL AND SYNC PROC. ERR XX ERR XX F_15060_039.eps 210305 Block Diagrams, Testpoint Overviews, and Waveforms L05.1U AA 6. 28 Supply Lines Overview SUPPLY LINES DIAGRAM Family Board B1 CRT A2 LINE + FRAME DEFLECTION A1 POWER SUPPLY 3 4 2 1 1503 7541 ENERGIZING CIRCUIT (optional) +Vaudio 5402 8 A5 A7 AUDIO_AMPLIFIER Vbatt 18 4 5562 6563 13 5 -Vaudio LINE OUTPUT CIRCUIT + E/W CORR. 5 7 +Vaudio AUDIO OUTPUT A5 EW_DRIVE 1404 1 HOR. DEFL. COIL EHTinfo 5 +200V VT_Supply 6 +12V_LOT 7 SVM_ROT To TUNER Pin 9 A2 3351 7 3456 6452 +200VA 6001 +12V_LOT Multi Board -14V B1 CRT SOCKET 6453 3458 VideoSupply 6 6467 3485 Filament Vbuffer DC_Filament A9 FRONT CONTROL +141V 3 +141V 4 EHT-INFO 5 +200V B3 6461 8 +6V 6456 9 1693 3450 3455 Vbuffer A5 1351 1 A4 3519 VCC Vbatt Vbatt 4 6 VT_Supply STDBY_CON STANDBY CIRCUIT To TUNER Pin 6.7 A5 Filament 3 2 3401 7573 2 5 or +5V 5001 A8 REAR I/O CINCH 5457 5 1 4 VideoSupply or 3575 3576 7513 TCET1103 4 A5 REFERENCE CIRCUIT 3 3 SVM_ROT 12 7571 Vbatt EHTinfo 2 Vbuffer 9002 +5V 10 3571 12 2 +12V_LOT FOCUS VG2 2 +6V 2 Filament B1 HD 5561 6562 10 TO CRT 1 7990 TDA2616Q -Vaudio +Vaudio 14 3 7405 7404 6551 5551 17 5552 SUPPLY PRIMARY SIDE EHT 3 Vbuffer A5 Vbatt 1351 1 1401 1 5450 5512 A3 TUNER IF SVM_ROT +12V_LOT VDC 9 B2 SCAVEM +Vbatt 3351 6 +8V_+12V 7 SVM_ROT +14V +200A +6V B3 +8V_+12V 3305 3690 1 A10 6694 +12V_SVM 5303 B3 +12A 5308 9309 B3 +12A1 B3 3325 +3V J B3 FRONT INTERFACE 1693 1 B2 RGB AMPLIFIER B3 +6V ROTATION & SCAVEM +3V B1 K1 DEFLECTION CONTROLLER - ATSC +12V B1 +12A1 B1 +12A B1 +10V 1 +12V_SVM B1 +200A B1 1405 SVM_ROT B1 A10 7423 +9V +141V B1 5402 HOT GROUND +6V COLD GROUND 3202 VT_Supply 5403 +6V A10 AUXILIARY POWER SUPPLY A10 A10 DAC_9V A5 FEATURES & CONNECTIVITIES A3,A5 RGB_VCC 3203 B A4 HERCULES VDC 7509 +6VA +3V +3V A10 1532 K2 DEFLECTION CONTROLLER - ATSC A10 +6V +6V 3210 +1.8V_A 6545 14 SUPPLY CONTROL 7525 11 5 8 4 9 6 7 7200 +3V3A 5526 HERCULES +3V A4 6546 PWM1 +3V3 10 9 7603 L78L33ACZ A1,A2 A4,A5 7545 6544 115 1 DECDIG 7561 A4 A10 Stdby_Con POWER_DOWN 15 31 7201-1 +5V +5V A2 3560 3545 REFERENCE CIRCUIT 4 6207 +8VA A4 7542 A5 +3.3V A5 Vbuffer S 7543 1 2 7604 RESET +5V D A4 G 3607 3609 S 2204 +8V 7575 STANDBY CIRCUIT 7209 D G +3.3V Vbuffer A10 3544 7516 TCET1103 VT_SUPPLY 3606 +12VA 3542 A3 A4 3295 A5 7210 3 7605 3608 K1 7535 +5V 7203 3208 1 5524 +5V +1.8V_B A1 1535 6539 +3.3V 16 3209 A4 +3.3V 7201-2 POWER_DOWN 12 1 3 3206 A4 2 +9V +6VS +6V 5527 7 6552 3536 4604 3211 5504 6 7510 2 +9V 7204 VCC +6V Stdby_con A10 A4 +8VA +8VA 9605 +6V 3217 Vbuffer A8,A3 A4 7202 A10 +8VA +8VA 1534 +3V3A 1 TO P1534 2 ATSC 3 ATSC PANEL 1533 +3V3A 1 2 +8V +5V HOT GROUND COLD GROUND +6VA TO P1533 5 ATSC 10 ATSC PANEL 11 F_15060_040.eps 180305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 29 7. Circuit Diagrams and PWB Layouts 5 6 7 8 9 Item 1500 1510 2505 2509 3506 3513 3523 3564 3574 5501 5564 6563 6564 9501 9503 9512 9513 A1 POWER SUPPLY A +Vaudio AC_IN I543 2503 2n2 3K3 15 5 14 13 8 11 AUDIO_GND1 9 10 AUDIO_GND2 5561 470p 2 2 8V2 5V 3 3511 4R7 F510 +16V AUDIO_GND2 I574 8V2 2K2 2571 I573 I576 7573 PDTC114ET F573 Stdby_Con 15n To P14 Of HOT 82K 3575 A4 15K 2574 F I578 3 4K7 * 3576 3574 10n 1 7513 TCET1103(G) MainSupplyGndA +Vaudio F 2.5A 3579 2518 1546 Provision For Lightning Protection I572 E F565 +6V 2 2512 100n 1K2 3512 MainSupplyGnd 1n0 1 1545 Provision For Lightning Protection 22u 9563 9577 9V3 15V6 4 3K3 For EMC 5563 F561 2562 3571 -16V AUDIO_GND1 470p 6562 I562 -Vaudio F 2.5A 2561 I571 F564 F562 1577 3518 VCC * 2570 470P 9572 1572 2563 2565 7571 TL431CZ-AP I527 F563 K 1u0 2552 160V 100u I561 I523 5513 I520 1N5062 3520 100p 2519 470p 2513 3517 330K 1n0 RGP10D 2517 I521 6575 1K0 3516 0R1 3515 47K 2516 * I579 12 I516 140V STPS10L60D 6563 5562 D 5552 Vbatt 6564 REF D 295V 3522 I519 100n 15K F552 2551 1n0 S 0V I518 3519 6551 1 A 2V3 G I515 4 5511 7512 I513 I524 2515 14 297V 13 12 11 2V2 10 9 0V 8 TUNER IF (For Lightning Protection) G AUDIO_GND1 27u 16 TO 1013 OF 6511 47K 6541 RES 2 2505 2504 3524 2V3 0V F I552 5551 I551 17 0V I517 VEE NC4 OUT_NEG NC3 CAR_IN_NEG NC2 CAR_IN_POS AUDIO_GND2 5512 2 I514 2514 I508 1510 Audio_Gnd I584 3513 3514 2511 22u 50V 3M3 3501 1n5 * * * F509 3521 2573 3M3 3500 * 3M3 2509 3506 E SIG_IN_POS GAIN_ADJ1 GAIN_ADJ2 SIG_IN_NEG BIAS OUT_POS NC1 9510 2542 2K2 7514 BC847B I522 1 3 15V5 2 4 5 0V 6 7 4 3 TEA1506T/N1 7511 I511 Vaux_GND1 18 * D I505 VDC 10n 3 9504 * 1507 1 2 C F542 "$" F508 * 1n5 V 2 DMF2405H60 9503 RES I581 F507 4 BAS316 470n 3505 2500 F504 Vaux_GND1 1 3509 1 3 9513 -T 2R0 5500 4 7511 2 DMF35 9502 -T 2R0 I507 9511 RES 1 9500 For ITV only 2 1 9501 RES 5501 100n 3510 * * F506 F541 7541 BC857B 3 * B 16V4 6500 RES T4E.250V I502 A 16V4 I501 3 2508 Front Interface Panel 1505 2 2502 * F503 1500 4 1M5 AC Main Plug Or From 1505 Of 1 2 9505 RES 3504 C 5506 3541 Rh 4R5 3503 1 A1 I542 5564 DMF2405H60 4 1 DSP-301N I580 8 2n2 I525 3502 4 1 For ITV Only 1502 PFC5000 * 5 47K 6514 1501 PFC5000 * 3 F500 5502 3523 2 9512 2507 1 1503 LKS1AF 4 3 * * 3 +T F501 RES 2501 F502 2 1 33n 220R Rs 4R5 1504 +t ZPB 3564 B I583 2541 2 DEGAUSSING COIL 2506 HD 4A 480mm 1000/200 1N5 3.3M 1K x 3R 100K 4mH 2.8A x x PBYR10100 x x Jumper Jumper BZX384-C12 9506 I582 11 47u 25V I506 3508 ATSC 6.3A 680mm 680/200V x x 2.2K 1R5 x 82K x 4mH 2.8A SB360 x Jumper Jumper x x 10 2572 4 3 3 1n0 3573 Mono Carrier: Power Supply 1 2 COLD G Panel FOR MAINS 120V AC 170V (177V) 220V AC 309V (317V) ..V.. Normal Operation (..V..) Standy Mode "$" HOT GROUND H COLD GROUND H FAMILY BOARD 11 NC : 3139_123_5932 MAIN CHASSIS 11 NC : 3139_123_5933 Cell 11NC : 8239_125_1084 ver6.0 (2004-12-03 - WK449.5) Function 11NC : 8239_125_1090 ver6.0 (2004-12-03 - WK449.5) F_15060_001.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1500 C2 1501 C2 1502 C3 1503 B7 1504 B1 1505 D1 1507 D5 1510 E1 1545 G6 1546 G6 1572 E10 1577 E10 2500 D3 2501 B3 2502 D4 2503 C6 2504 C6 2505 C6 2506 B5 2507 C6 2508 D5 2509 E1 2511 E2 2512 G2 2513 F5 2514 E6 2515 E6 2516 F5 2517 F2 2518 F6 2519 F5 2541 C8 2542 C7 2551 D8 2552 D9 2561 E8 2562 E9 2563 E9 2565 E8 2570 E7 2571 F9 2572 F10 2573 D4 2574 F9 3500 D1 3501 E1 3502 C3 3503 C4 3504 D4 3505 D3 3506 E1 3508 B5 3509 C5 3510 D5 3511 F6 3512 G2 3513 D6 3514 E5 3515 E5 3516 F5 3517 F2 3518 F5 3519 G1 3520 F6 3521 D6 3522 E5 3523 B4 3524 D5 3541 B8 3564 B4 3571 E8 3573 F9 3574 G9 3575 F9 3576 G9 3579 F9 5500 C4 5501 C3 5502 B6 5506 C4 5511 E6 5512 D7 5513 F5 5551 D8 5552 D10 5561 E8 5562 E8 5563 G5 5564 B5 6500 C6 6511 F1 6514 D6 6541 B8 6551 D9 6562 E8 6563 E8 6564 D8 6575 F6 7511 D3 7512 E5 7513 F7 7514 D5 7541 C7 7571 F8 7573 F10 9500 C2 9501 C3 9502 C4 9503 D3 9504 D4 9505 C5 9506 B5 9510 C8 9511 D5 9512 B6 9513 C5 9563 G5 9572 E10 9577 E10 F500 B7 F501 B2 F502 B2 F503 C2 F504 D2 F506 C3 F507 D3 F508 C6 F509 D6 F510 E6 F541 C8 F542 C8 F552 D9 F561 E10 F562 E9 F563 E10 F564 E11 F565 E11 F573 F10 I501 C6 I502 C5 I505 D1 I506 B5 I507 D5 I508 E1 I511 E2 I513 E5 I514 D6 I515 D6 I516 E6 I517 D5 I518 F5 I519 F5 I520 F4 I521 E6 I522 D1 I523 F6 I524 D6 I525 C4 I527 F2 I542 B7 I543 A8 I551 D8 I552 D8 I561 E8 I562 E8 I571 E7 I572 E9 I573 F8 I574 F10 I576 F9 I578 F9 I579 E8 I580 C3 I581 D3 I582 B5 I583 B6 I584 D6 Circuit Diagrams and PWB Layouts Mono Carrier: Deflection 1 2 L05.1U AA 3 7. 4 30 5 6 7 8 9 10 11 LINE + FRAME DEFLECTION F402 33K 3492 33K 3491 47u 3486 * * I440 6457 +14V I460 I431 1u0 250V BZX384-C8V2 1K5 6492 3477 15n 2478 B 0V 2471 * F482 CRT_GND GND_EW * FLYB F461 3471 2R7 3472 * -14V For ATSC only 1R5 VERTICAL DEFLECTION COIL I430 BZX384-C15 3432 3432 CRT_GND 1 2 3 * 6449 I481 * 220n 2470 3467 I464 100n 1451 * 2468 I463 2464 * GND_EW 100R * 3466 GND * 3463 CRT_GND -14V7 220n * 220n CRT_GND 4434 50V7 13V9 12V7 VSUPO VSUP 1n0 2432 F459 THERMAL PROTECTION 100n MainSupplyGnd GND_EW 2n2 2463 * 2465 10K 4 * E A4 F * 100R * 15n 22K 3439 10K 3n3 3461 BAS316 2473 * BAS316 3438 2n2 3488 I499 * V_PROTN * 10K F458 OUT 5 0V5 10R 6484 6483 POWER AMPLIFIER 3468 I435 0V6 7 IN+ 2462 100n 2495 10n I462 3478 3 CRT_GND 0V6 1 IN- 100R 9490 GND_EW I434 6 FLYBACK GENERATOR I471 2407 680K 3437 * 22K 2 9489 3489 GND_EW 100n I * A5 * * * * 2467 I436 A5 VDRB 2R2 * I415 100R 9440 * BZX384-C6V8 3436 100K 3418 * S 0V 3440 A2,A5 I433 3428 1M0 VDRA 10n 3427 * EHTinfo 6482 3426 2472 * 4418 G 4V6 2496 F476 680K EW_DRIVE A5 G I417 * 3499 * * 82K 3431 F * 14V9 D 7406 Vbatt 220K I423 RGP10D A4 * 7451 TDA8177F 3473 X_RAY 10R 3496 BYV27-200-TAP 6471 3435 E 0V GND_HOR I490 * * BZX384-C3V3 BZX384-C33 I482 ATSC 10K 10K 6458 * * * 4495 BAS316 Tri+ 1K 1K5 * 4401 A2,A5 3434 Vguard 1K0 * BZX384-C6V8 * 68K 22K 6442 18K 2477 100n 2436 6488 GND_DEF 100n 6M8 7407 PDTC144ET C 3V3 10K 6491 BYV27-200-TAP +14V 9435 F456 1R0 6434 F457 47u CRT_GND 3497 470p 6456 I475 2R2 2461 3455 I493 D F478 1K0 GND_EW 3480 2459 10u 9432 Vbatt RES I416 3493 RGP10D 2410 C F453 +12V_LOT CRT_GND CRT_GND 5458 1K0 560n 3481 I414 4R7 1R0 I461 I459 RGP10D 2424 470p 6403 A2 1u0 * 4R7 3443 BAS316 B 6V 7410 C 0V BC857B I465 GND_HOR 3451 Filament 3432 * 4R7 4R7 3433 CRT_GND 1R5 2499 5V7 E * I412 3419 2u2 * F452 5452 2u2 * 4R7 6485 I411 3415 5459 BZX384-C27 6464 * I410 3414 CRT_GND GND_DEF 3450 I492 6489 470p * BAS316 2458 2448 4R7 6490 E S 50V GND_HOR CRT_GND BAS316 2466 3408 330R 3441 A5 220p 3402 100K 2497 F475 HD D 100R 7V 7404 BSH103 I413 G 3V6 BYV29X-500 I470 470u 470p 6461 9 3 * 3485 I468 2u2 2491 -14V 470u 2412 1 2 6487 470p 6467 CRT_GND 6452 2454 2494 GND_HOR BAS316 3442 9442 GND_DEF 8 F419 2493 470p CRT_GND 2426 I427 I426 C 0V 11 * B VideoSupply 6453 RGP10G 470u 5408 * * 45V7 BZV85-C6V8 1R0 2449 A D * 0V 3458 I466 2460 3416 47R 2418 2417 1u 0V 3456 I456 I457 6 I432 * 2488 PSD10-204B 2419 I428 I473 5457 * * * CRT_GND I455 3 330p 6 4 3 * 5 2416 I419 7 1 * J 7405 BU2527DX 126V 10 12 2413 5 * 2 1 F418 5402 1 150R 33n 2423 I418 3490 K BAS316 22R I488 2409 6404 DMV1500M 6481 3421 6486 * BYD33D 2411 +6V GND_DEF I458 3 4 F465 3462 1406 2425 3459 G2 7408 BC857B E 42V4 680K 3460 F467 B GND_EW BZX384-C15 1403 1405 I494 CRT_GND FOCUS 1u0 6480 2 1R0 I425 COIL * F481 3469 RGP10D I469 CRT Socket C 2435 GND_DEF GND_DEF GND_DEF HFB A5 8n2 470p 6466 TO PICTURE TUBE 1404 1 CRT_GND 22K EHT * F464 F466 DEFLECTION 5409 2451 56K 3453 9402 5401 L.LIN 150R HORIZONTAL 2n2 3K9 2474 A2,A5 F472 150p 2469 I424 * 2431 I489 * 2492 6476 BZV85-C6V8 V CRT Panel CRT_GND Or TO 1351 OF * * 1402 From 5450 Of LOT (30PWXXXX Only) 5450 9476 TO 1351 OF F404 * * I453 B * * 3425 F455 3413 * 3474 F416 3412 * F462 GND_HOR 150R V * 4 * EHTinfo F483 2 7 Filament A2 1 NC 9 3424 GND_HOR 2433 F401 3401 47K VT_Supply * 5456 CD25405-00 5 * 2422 +12V_LOT VideoSupply EHTinfo 2421 A5,B1 9411 1401 7 6 5 4 3 2 1 SVM_ROT 2404 * A2 A +12V_LOT Vbatt CRT_GND A A2 BZV85-C6V8 A2 G Frame_FB CRT_GND * 2R7 GND_EW CRT_GND 9484 H MainSupplyGnd GND_EW GND_HOR CRT_GND CRT_GND H MainSupplyGnd GND_DEF Cell 11NC : 8239_125_1084 ver6.0 (2004-12-03 - WK449.5) Function 11NC : 8239_125_1091 ver6.0 (2004-12-03 - WK449.5) FAMILY BOARD 11NC : 3139_123_5932 MAIN CHASSIS 11NC : 3139_123_5933 F_15060_002.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1401 A2 1402 B4 1403 B8 1404 B6 1405 C8 1406 C8 1451 F10 2404 A6 2407 G6 2409 C2 2410 E7 2411 D4 2412 D5 2413 D5 2416 D5 2417 C6 2418 C6 2419 D6 2421 B3 2422 B3 2423 D2 2424 E7 2425 B11 2426 C10 2431 B6 2432 F7 2433 B3 2435 B9 2436 D10 2448 D8 2449 D8 2451 B9 2454 D9 2458 D9 2459 E8 2460 E8 2461 D9 2462 G7 2463 G7 2464 G8 2465 G7 2466 E9 2467 G7 2468 G9 2469 B9 2470 F10 2471 G1 2472 G3 2473 G2 2474 B10 2477 B10 2478 B10 2488 D2 2491 C11 2492 B8 2493 C9 2494 D8 2495 F5 2496 F4 2497 E2 2499 E10 3401 B2 3402 E2 3408 E2 3412 B5 3413 B6 3414 E3 3415 E4 3416 D4 3418 F3 3419 E4 3421 C1 3424 A3 3425 B3 3426 G1 3427 G1 3428 G2 3431 F3 3432 G11 3433 E5 3434 G11 3435 E11 3436 G2 3437 G2 3438 G5 3439 G5 3440 G4 3441 E3 3442 C8 3443 E4 3450 D8 3451 E6 3453 B8 3455 E8 3456 C8 3458 D8 3459 C9 3460 C10 3461 G6 3462 B9 3463 G7 3466 G9 3467 G10 3468 G10 3469 C9 3471 G6 3472 G6 3473 F5 3474 B10 3477 B10 3478 F6 3480 E5 3481 D6 3485 C10 3486 B8 3488 F4 3489 F6 3490 C3 3491 A8 3492 A8 3493 E7 3496 E11 3497 E11 3499 F3 4401 G11 4418 F3 4434 F10 4495 G11 5401 B6 5402 C3 5408 D6 5409 C5 5450 B7 5452 D10 5456 A4 5457 C8 5458 D8 5459 E6 6403 E7 6404 C5 6434 G11 6442 C9 6449 G10 6452 C9 6453 D8 6456 E8 6457 E7 6458 G10 6461 D8 6464 E3 6466 B8 6467 C10 6471 F4 6476 C9 6480 B9 6481 C2 6482 G2 6483 G2 6484 G5 6485 E3 6486 D4 6487 D6 6488 E9 6489 D9 6490 E9 6491 E11 6492 B10 7404 E2 7405 C4 7406 F4 7407 E10 7408 B9 7410 E3 7451 F8 9402 B6 9411 B5 9432 G11 9435 E11 9440 G4 9442 C8 9476 C9 9484 H4 9489 F6 9490 F6 F401 B1 F402 A1 F404 B2 F416 B6 F418 C4 F419 D4 F452 C10 F453 D10 F455 B1 F456 E9 F457 E7 F458 F9 F459 F9 F461 G6 F462 A9 F464 B6 F465 C6 F466 B6 F467 C6 F472 B10 F475 E1 F476 F1 F478 D10 F481 B9 F482 E10 F483 A5 I410 E4 I411 E4 I412 E5 I413 E2 I414 E6 I415 F4 I416 E7 I417 F5 I418 C3 I419 D2 I423 F5 I424 B3 I425 C9 I426 C10 I427 C10 I428 D6 I430 G10 I431 E9 I432 D6 I433 G2 I434 G2 I435 G2 I436 G1 I440 E9 I453 C9 I455 C7 I456 C8 I457 D8 I458 C8 I459 D8 I460 E8 I461 D7 I462 F7 I463 G8 I464 G9 I465 E5 I466 D8 I468 C10 I469 B8 I470 C9 I471 F7 I473 D5 I475 E8 I481 G10 I482 E10 I488 C2 I489 B6 I490 F4 I492 D8 I493 E8 I494 B10 I499 G4 Circuit Diagrams and PWB Layouts Mono Carrier: Tuner IF 1 2 7. 4 31 5 6 7 8 10 9 TUNER IF A3 F001 +5V TUNER RF IN FOR ITV ONLY 4.9V 4.3V 4.3V 34V5 CGND 1K5 100n 2007 3003 B 6002 +5V CGND RES CGND CGND 2014 I003 CGND I007 7003 3019 F009 3006 5V I006 1 2 0V 0V I IGND 3 F L05 ATSC 27VRF 30WSRF UV1336BE/A T SN-4 UV1336BE/A T SN-4 50V 22P 50V 22P --------25V 100U 25V 100U ------------390R 390R JMP JMP JMP JMP JMP JMP --------JMP JMP ------------100MHZ 120R 100MHZ 120R U56 coil U56 coil CGND A4 VIF1 A4 1013 1003 *1 GND_28 4 O1 5 O2 IN 10 ISWI 2 IGND *4004 3 8 CGND 6 7 NC * CGND *1001 I IGND O1 O2 SIF1 5 4 A4 GND 1u8 I010 1 2 5003 4002 4011 3 100n E 4013 GND_28 * * POWER SUPPLY (For Lightning Protection) GND_28 IFGND 2011 TO 1510 OF for EMC GND GND_28 100n 2012 D VIF2 GND_28 IFGND 4012 ITEM NO HD 30WSRF SIZE 27VRF 1000 V+U PLL F MN V+U PLL F MN 50V 22P 2001 50V 22P --2002 ----2003 --25V 100U 2008 25V 100U 3000 ----3001 ----3002 ----3010 390R 390R 4000 JMP JMP 4001 JMP JMP 4003 JMP JMP 4004 --------4005 JMP JMP 4006 4010 ----4011 ------4012 --5001 100MHZ 120R 100MHZ 120R 5002 U39 coil U39 coil CGND 5 4 O1 O2 GND I009 38M9 IFGND CGND 1002 I008 I005 5004 I017 2017 A4 SEL_LLP|M 3007 D I012 0V3 3018 3008 7001 PDTC124ET C SSIF A4 1V1 6004 CGND F010 5V 3009 F011 1012 2016 I004 * 4010 RES 3010 * CGND CGND 3014 * RF_AGC A4 3016 CGND * * 1 2 3 * * * 4006 F006 100R 2013 1005 RES 2002 2001 For Compair only 2004 * RES 3005 I011 2009 A4 * I002 CGND I015 F008 5002 SDA 4003 2003 * * 3001 4001 * 3002 RES F003 3004 I001 RES BZX79-C33 A4 BAS316 6003 2008 * * 3000 2005 I014 F007 47n SCL 6001 10u 50V CGND 4000 C A CGND CGND VT_Supply POWER SUPPLY 470u F004 FOR EMC ONLY 1011 * 5001 * 4005 RES F002 1 2 3 4 5 6 7 8 9 10 11 TO 0282 OF B 13 12 2006 14 15 AGC VT AS|CE SCL SDA NC1 VS ADC VST NC2 IF I016 F005 1010 6006 * Vbuffer 1000 9002 A E 11 BZX79-B8V2 A3 3 L05.1U AA SIF2 A4 GND_28 F IFGND 9010 CGND CGND G G FAMILY BOARD 11 NC : 3139_123_5932 MAIN CHASSIS 11 NC : 3139_123_5933 H H Cell 11NC : 8239_125_1092 ver6.0 (2004-12-03 - WK449.5) Function 11NC : 8239_125_1085 ver6.0 (2004-12-03 - WK449.5) F_15060_003.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1000 A4 1001 E9 1002 D9 1003 E9 1005 C3 1010 B3 1011 B3 1012 C10 1013 E10 2001 C4 2002 C5 2003 C6 2004 B6 2005 B6 2006 B7 2007 B7 2008 C7 2009 C9 2011 F7 2012 F7 2013 D10 2014 C9 2016 C10 2017 D9 3000 B4 3001 C4 3002 B7 3003 B7 3004 C7 3005 B8 3006 D4 3007 D8 3008 D8 3009 C5 3010 C8 3014 C9 3016 C9 3018 D9 3019 D9 4000 B4 4001 C4 4002 E8 4003 C6 4004 E8 4005 B9 4006 C7 4010 C8 4011 F8 4012 F8 4013 E10 5001 A9 5002 C6 5003 F9 5004 D9 6001 B6 6002 B7 6003 B7 6004 D6 6006 A9 7001 D5 7003 C10 9002 A9 9010 F7 F001 A6 F002 B6 F003 B6 F004 B6 F005 A4 F006 B10 F007 B4 F008 C4 F009 D4 F010 C10 F011 C3 I001 B4 I002 C4 I003 C9 I004 C10 I005 D5 I006 D6 I007 C9 I008 D8 I009 D8 I010 F8 I011 B8 I012 C10 I014 B3 I015 C3 I016 A6 I017 D3 Circuit Diagrams and PWB Layouts L05.1U AA 7. 32 Mono Carrier: Hercules A9 KEY_protn 10K 2295 +3.3V +3.3V I236 3280 4K7 F270 3283 4K7 I235 4K7 3279 2282 1n0 5V0 1V7 GND121 F202 D +5V 3206 I239 470u 16V D 7209 2V BSH103 GND_1 GND95 2V6 F I282 SERVICE JUMPER SDM 9252 4u7 10V 2V6 D 7210 BSH103 G S GND12 GND12 GND_1 GND_1 A3 A3 A3 A3 +3.3V G for ITV 1266 FAMILY BOARD 11 NC : 3139_123_5932 MAIN CHASSIS 11 NC : 3139_123_5933 c209 c208 c207 c211 c204 c210 c205 c202 H CGND GND1 CGND GND3 GND12 GND_28 GND68 GND89 GND92 GND95 GND121GND125 F_15060_004.eps 180305 3139 123 5933.2 2 3 E 7203 7204 2V9 I283 BC327-25 E 2V8 BC327-25 E 7201-2 IMX1 C B B 2V 2V B C C 2V 2V I224 2V 2V 2V6 +1.8V_A E E I225 F209 +1.8V_B for EMC Cell 11NC : 8239_125_1085 ver6.0 (2004-12-03 - WK449.5) Function 11NC : 8239_125_1093 ver6.0 (2004-12-03 - WK449.5) 1 1R0 3210 3208 B GND_1 I204 2227 220n 2290 * GND_1 I201 7201-1 IMX1 C 5K6 2226 GND1 S 5K6 3296 4u7 2269 39p 39p 2268 1u0 2278 2251 220n 5213 2229 VIF1 VIF2 100n 2217 2214 I203 GND89 HC-49/U 24M576 100n * 150n 100n 47u 25V 2223 I212 2218 1205 4201 6201 GND_1 22n 3203 150K * 0V F200 -1V 27K 5214 100R 3246 * +3.3V BAS316 BAS316 6207 +3V 3211 1K0 3285 5V GND_1 +3.3V GND_28 4207 101 0V0 15K 27K GND12 GND92 GND3 CGND GND1 For ITV only 3205 GND12 SIF1 SIF2 E A5 * 100R 2204 2242 GND1 CGND RES D A5 GND89 GND1 GND1 3265 100R * 100R 3266 GND95 105 0V0 104 0V0 121 0V0 123 3V3 120 3V3 124 3V3 122 1V6 38 0V0 40 3V3 39 4V0 103 1V6 119 1V6 118 1V5 58 1V5 59 1V5 57 2V0 56 116 39K 0V5 2V0 0V3 100 0V3 99 3241 GND1 3247 100n 390R 2239 220n 2266 2u2 CGND 3223 GND92 1u5 I206 3232 12K 2240 B A5,A10 C A5 G 2263 2235 GND1 100n 6n8 I213 100R I215 3231 10u 50V 2275 2274 2244 2241 GND1 RES 3263 100R 3264 3217 0V0 117 0V0 0V0 37 GNDA 48 0V0 GND3 89 0V0 GND2 111 0V0 GND1 GNDIF C A A5 * 100R 0V0 VSSADC 34 * 3262 7202 0V3 64 54 106 107 53 55 2V5 90 0V5 14 13 10 0V0 9 3V3 3V2 17 0V0 16 3V4 15 0V0 7 0V0 6 0V0 18 31 23 30 3 22 2 1 21 20 24 25 26 27 32 3V3 3V9 0V0 3V3 3V3 3V3 2V1 2V2 0V0 0V0 0V0 0V0 5V5 0V0 62 81 1V4 63 0V8 108 4K7 * A4 SC2_Y|CVBS_IN A8 SIDE_Y|CVBS_IN 100R 9262 CGND 2285 100n 2260 100n RES 2256 CGND 3274 22n 2291 GND3 100n 2261 RES 100R 9215 SC1_CVBS_IN A8 CGND c201 9203 4210 Vaux_GND VSSP2 128 0V0 1K0 9241 4296 Vaux_GND 2287 2283 CGND 3275 100R 3242 SIDE_CHROMA_IN A5 5218 9202 CGND B 3201 3281 I228 1R0 3212 1n0 3238 1K0 CVBS_OUT_SVP 4299 V_PROTN 3299 +3.3V 1230 for ITV only A2 A5 GND1 2292 4K7 3292 AUX_ON|ITV_MSG 3237 9291 10K 4K7 10u LIGHT_SENSOR +3.3V A8 A5,A9 A5 9260 3252 100R A3 +3.3V 3284 4K7 3291 SVM_ROT 10K Stdby_Con BAS316 6209 SEL_LLP|M 3298 100R BZX384-C5V6 6210 GND121 SDA VOL_MUTE 4219 3219 100R 10R 10R 6211 GND121 A1,A3,A7,A10 A7 POWER_DOWN A3,A5 A3,A5 +3.3V 3204 3214 100R 3216 3218 10R 3207 3215 1u0 100p 2280 100R BZX384-C5V6 IR 4K7 I2SCLK I2SWS 4K7 3261 F271 100R 3269 3260 3253 2279 100n SW_SC2_CVBS I2SD|1 Reset_+5V X_RAY 1685 100R I214 3230 POWER_DOWN LED WRITE_PROTECT SCL 3K3 3K3 3202 +3.3V A9 A10 A9 A5 A5 A5 A5 A5 A5 A5 A5 2201 3289 3235 I211 100R I208 3267 86 3V8 85 4V4 42 43 44 65 0V0 83 76 75 73 72 80 79 95 94 49 1V9 2V2 2V2 2V2 2V2 2V2 2V2 2V2 2V2 1V3 RES 2255 10n 2284 CGND 10n 2286 100n 2262 RES requested by Hock Aun requested by Rama Rao 9205 100R 9257 3270 SC1_RED_IN A8 A8 220n 220n 2208 2207 4297 A5 4212 A8 requested by Gozali SC2_CHROMA_IN A8 +6V 100R 9261 CGND 3278 3277 C IFGND 100R 9265 3288 Audio Amplifier (Power Down) 100n 2232 2237 100n 560p GND3 2264 3276 100u 16V I280 100R 220n 2203 1683TO 1282 OF 2231 5201 2206 GND121 +3V 220n I221 POWER_DOWN 4209 2u2 CGND 1K0 F203 requested by Leong 2213 3229 +1.8V_B 9292 9293 2267 SC1_GREEN_IN I226 I220 BAS316 390R 3221 220n 6203 GND3 F 220n GND92 To 1729 Of Rear I/O Scart 1684 2211 220n GND95 2225 SC1_BLUE_IN 100n 3220 180R 2273 100u 10V 2272 GND89 CGND H VCC8V c203 7V0 VDDA_1.8 5216 +3.3V SIDE AV PANEL+HP PANEL(FL13) 1234 for ITV only 3287 VSSA1 1V5 71 84 2216 VDDA1 OR GND1 VSSCOMB 61 0V0 GND68 127 VSSC4 0V0 GND125 VSSC3 4 0V0 VSSC2 28 0V0 VSSC1|P 8 GND121 1V4 78 2V3 109 2V8 115 2V3 91 2V0 11 1V7 97 0V0 52 2V0 102 2V3 112 4V0 113 2V0 88 2V3 110 1V5 87 36 2V0 220n I217 3V3 5206 +1.8V_A 2212 41 TOP CONTROL PANEL To 1280 of 100R 7200 * TDA12001H1 2u2 GND92 VDDADC_1.8 125 VDDA3_3.3 35 VDDA2_3.3 3V3 2215 3V3 220n 2210 VDDC4 VDDC3 VDDC2 VDDC1 3V4 46 3V2 45 1V6 70 1V6 77 1V4 74 5205 +3.3V 120R 3254 98 4V5 67 3V8 66 3V6 69 3V3 68 3V3 93 3V6 92 3V6 96 0V0 220n +3.3V 220n 5215 1 2 3 KEY_protn * CGND VDDCOMB INTF_L_IN INTF_R_IN SC2_L_IN SC2_R_IN SIDE_L_IN SIDE_R_IN SC1_L_IN SC1_R_IN 6204 5211 2V0 126 5 2V0 2V0 29 12 2V0 2V0 33 2205 F207 +1.8V_B * To 1010 or 1682 of 1682 1n0 2294 3n3 VDDP_3.3 16V 100n 5203 5207 F201 60 10u GND68 5V0 1V3 51 +1.8V_A (+8V) 100u 25V 2249 SS14 Vbuffer GND68 GND125 G GND1 220n 100u 10V 2250 19 1V3 50 5210 E 2238 VIDEO SIGNAL PROCESSOR 5209 2224 +5V A4 5n6 2257 11 * 4K7 3282 I222 Φ +5V D 3V3 47 5V1 VP3 82 5V1 VP2 5V1 114 VP1 100n GND1 * 10R 3293 10 A * * * 2293 AGC2SIF AUDIOIN2L AUDIOIN2R AUDIOIN3L AUDIOIN3R AUDIOIN4L AUDIOIN4R AUDIOIN5L AUDIOIN5R B PBIN3 G YIN3 R PRIN3 BCLIN BLKIN C2 C3 C4 CVBS2 Y2 CVBS3 Y3 CVBS4 Y4 DECBG DECDIG DECSDEM DECV1V8 EHTO INSSW3 IREF PH1LF PH2LF PLLIF SECPLL SIFAGC DVBAGC SIFIN1 DVBIN1 SIFIN2 DVBIN2 VGUARD SWIO VIFIN1 VIFIN2 VREF_NEG_HPL+HPR VREF_NEG_LSL+HPL VREF_POS_HPR VREF_POS_LSL VREF_POS_LSR+HPR VREFAD VREFAD_NEG VREFAD_POS VSC XTALIN XTALOUT UIN VIN YIN YSYNC 100u 10V +3.3V AGCOUT AUDOUTHPL AUDOUTHPR AUDOUTLSL AUDOUTLSR AUDOUTSL AUDOUTSR AVL SWO SSIF REFO REFIN BO GO RO CVBSO PIP DVBO FMRO DVBO IFVO FMRO EWD AVL FBISO CSY HOUT IFVO SVO CVBSI I2SDI1 O I2SDO1 I2SDO2 I2SCLK I2SWS INT0 P0<0:5> INT1 T0 INT2 T1 RX TX SCL SDA P1<0:7> TPWM PWM0 PWM1 PWM2 PWM3 PWM4 P2<0:5> ADC0 ADC1 ADC2 ADC3 P3<0:3> QSSO AMOUT AUDEEM SVM UOUT VDRA VDRB VOUT YOUT 220n 100u 25V 2233 GND3 GND121 A5 A5 A8 A8 A5 A5 A8 A8 100n 2265 CGND * 9 +3.3V 2209 100R 9266 C B 1V4 8 3209 5202 I210 2234 +3.3V c206 5208 7212 BC857B C E +5V 2276 7 100R 5212 +5V CVBS_TXT_CC 270R 470R Bout Gout Rout 3227 3228 10n 2V 100R 680R 2271 3226 2253 I218 100R A3 100R 100R 3256 100R CGND 7211 BC857B E C 100R 3258 I238 100R 6 +8VA CGND 100n 3249 1 2 3 5 B 1V4 CGND 100R * I207 2V 2270 100n 3257 100R 3248 9288 I237 1208 Panel I219 To P1208 Of 9216 GND68 820R 3272 0V7 B +8VA 3222 RF_AGC SSIF A3 A7 3255 * 7207 BC847B C 4298 1K0 4295 MAIN_OUTL * 9601 * 9602 +5V 0V6 E 3273 MAIN_OUTR A8 A8 SC2_L_OUT SC2_R_OUT SANDCASTLE A5 A A7 HERCULES A4 B 4 A5 A5 A5 3 3290 75R 2 3236 470R CVBS_OUT_SVP A5 1 4 5 6 7 8 9 10 11 1205 E8 1208 B2 1230 A8 1234 B10 1266 G6 1682 B11 1683 G1 1684 F1 1685 B5 2201 A5 2203 F2 2204 E10 2205 D2 2206 F1 2207 H1 2208 H1 2209 C2 2210 D2 2211 E2 2212 E2 2213 E3 2214 E9 2215 D3 2216 E3 2217 E9 2218 F7 2223 F7 2224 C2 2225 E3 2226 F9 2227 F9 2229 F7 2231 F2 2232 F2 2233 C2 2234 C2 2235 F6 2237 F3 2238 C3 2239 F6 2240 G6 2241 F5 2242 F8 2244 F5 2249 D2 2250 D2 2251 F7 2253 B3 2255 F3 2256 F4 2257 B8 2260 F5 2261 F4 2262 F3 2263 F6 2264 F2 2265 C1 2266 F6 2267 E3 2268 F8 2269 F9 2270 B3 2271 B4 2272 E1 2273 E1 2274 F5 2275 F5 2276 C1 2278 F7 2279 B6 2280 B6 2282 C9 2283 F4 2284 F3 2285 G5 2286 F3 2287 F4 2290 F9 2291 E4 2292 B8 2293 B9 2294 B9 2295 B9 3201 B10 3202 B6 3203 E10 3204 B6 3205 D9 3206 F9 3207 B7 3208 E10 3209 E10 3210 E11 3211 E11 3212 B7 3214 B6 3215 B6 3216 B6 3217 D9 3218 B6 3219 B7 3220 E1 3221 F1 3222 A4 3223 G6 3226 B4 3227 B4 3228 C4 3229 E2 3230 B5 3231 F6 3232 F6 3235 B5 3236 A4 3237 A8 3238 A9 3241 F6 3242 G3 3246 E9 3247 F6 3248 B3 3249 B3 3252 B7 3253 C5 3254 E1 3255 B3 3256 B3 3257 B2 3258 B2 3260 B5 3261 B6 3262 C10 3263 C10 3264 C10 3265 D10 3266 D10 3267 C5 3269 B6 3270 G3 3272 B1 3273 B1 3274 G4 3275 G4 3276 G2 3277 G2 3278 G3 3279 C10 3280 C10 3281 B10 3282 C10 3283 C10 3284 B7 3285 D9 3287 B9 3288 G2 3289 B5 3290 A4 3291 A7 3292 B7 3293 B8 3296 F9 3298 B7 3299 A8 4201 E11 4207 E9 4209 G1 4210 H3 4212 H1 4219 B7 4295 B1 4296 H1 4297 H1 4298 B1 4299 A9 5201 F1 5202 C2 5203 D2 5205 D2 5206 E3 5207 D2 5208 C2 5209 C2 5210 D2 5211 E1 5212 C1 5213 F7 5214 E9 5215 E2 5216 E2 5218 H3 6201 E11 6203 E2 6204 D1 6207 E9 6209 A7 6210 B7 6211 B6 7200 D6 7201-1 E10 7201-2 E10 7202 D10 7203 E10 7204 E11 7207 B1 7209 F9 7210 F10 7211 A4 7212 B5 9202 H2 9203 H4 9205 H2 9215 G4 9216 B2 9241 H4 9257 G3 9260 B7 9261 G3 9262 G5 9265 G3 9266 G2 9288 B2 9291 A7 9292 F1 9293 F1 9601 A3 9602 A3 F200 E10 F201 D2 F202 C9 F203 F2 F207 D2 F209 F11 F270 C10 F271 B6 I201 E10 I203 E7 I204 F9 I206 G6 I207 B4 I208 B5 I210 C2 I211 B5 I212 E7 I213 F6 I214 B5 I215 E5 I217 E1 I218 C1 I219 B1 I220 E2 I221 F2 I222 C10 I224 F11 I225 F11 I226 E1 I228 B10 I235 C10 I236 B10 I237 B2 I238 B2 I239 F9 I280 F2 I282 F10 I283 E11 c201 H4 c202 H4 c203 H5 c204 H5 c205 H5 c206 H6 c207 H6 c208 H6 c209 H6 c210 H5 c211 H6 Circuit Diagrams and PWB Layouts Mono Carrier: Features & Connectivities 1 2 3 A5 L05.1U AA 4 7. 33 5 6 7 8 9 10 11 FEATURES & CONNECTIVITIES A5 A SDA * 7608 PMBT2369 C 7603 L78L33ACZ +6VS F211 +6V 1 IN IN B * * SANDCASTLE GND_1 C F233 Φ F212 WRITE_PROTECT +8VB Vbuffer (2Kx8) EEPROM F214 A4 I232 1 2 3 1n0 9605 2601 100u 10V I240 0 1 2 33K 3654 6n8 1 2 3 4 5 6 7 To 1250 of 4616 F238 OR 3648 Source Select + Microcontroller 1250 2K2 15 16 For ITV Only 1273 13 14 I242 12 CVBS_TXT_CC 11 1254 F243 CVBS_OUT_SVP 10 8 7 9 F254 Bout 6 8 F226 7 5 Gout F252 6 4 F225 5 3 4 2 Rout F224 3 1 2 1 RES WC SCL ADR SDA 7 A4 6 A4 5 A4 3V3 3V 3V 4 F215 GND_1 GND_1 100R 3605 100R 3604 A4 A4 A4 Belongs to Audio Amp 2999 To 1250 Of 100n 1251 A2 A2 A2 A2 A2 A2 A2 A2 HD HFB SVM_ROT EW_DRIVE VDRB VDRA F216 F217 EHTinfo Vguard F218 INTF_R_IN A4 4u7 SC2_CVBS_OUT GND_1 GND_1 22u 50V 2615 C * * 3614 9235 RES 5602 100R 4u7 4614 3653 SDA 7V I244 3V6 7606 E BC847B 3V3 1 2 3 A4 5601 9608 MUTING 1240 A7 2630 1270 RES (FOR CINCH) 1n0 1271 RES TO 1138 OF / TO 1763 & 1764 OF AV Panel / To 1252 of Side AV PaneL + HP Panel CGND F248 E SIDE_CHROMA_IN F249 I229 A4 3626 I2SCLK F251 3625 10R F229 I2SD|1 I231 10R 3628 A4 GND_1 To 1252 of A4 1213 F228 1 2 3 4 5 6 7 F232 10R I2S RES 1221 +8VA I2SD|1 9280 A4 (FOR SCART) * CGND A4 I2SWS RES For ITV Only 1243 CGND CGND 100K A4 A4 1 2 3 F227 100K 3623 1K0 3634 2622 A4 F Deflection Controller - ATSC +8VA CGND F247 SIDE_Y|CVBS_IN 1220 3622 Reset_+5V To 1400 Of +6VS A5,A8 GND_1 1207 1 2 3 4 5 6 7 A4 1257 A4 GND_1 GND_1 GND_1 D Panel SIDE_R_IN RES F220 Deflection Controller - ATSC To P1219 Of 2u2 SC2_CVBS_OUT I233 B 2617 100u 10V SW_SC2_CVBS F221 SCL 33p I234 K 3637 2631 +5V AK 3609 27K CGND 5V F213 100n 2624 C 2623 7604 BC847B 0V5 A5 RES 4653 SIDE_L_IN 47R 33K Vbuffer F219 1 2 3 4 5 100n B 5V4 470R 6602 BAV99 A 2u2 3607 27K 3608 I227 3606 150K I241 E 2625 47K Vbuffer C 5V B E 3647 C RES To 1251 of Source Select + Microcontroller 1219 3652 2634 A4 3635 2633 2u2 INTF_L_IN +6V E 6V 1255 10 9 8 7 6 5 4 3 2 1 / 4253 A4 VT_Supply 7605 BC327-25 14 12 To 1251 of A4 D 13 11 10 9 8 7 6 5 4 3 2 1 Deflection Controller - ATSC 4609 16V 100u Panel B A4 SDA A7 / Source Select + Microcontroller To P1206 Of 2613 SCL MUTE_A To 1206 of F237 A +5V 7601 PCF85116 8 3V3 4K7 3601 +3.3V 100n 2621 F239 A4 3651 3K3 2620 D B 47u 16V 1206 A4 A4 A4 C 1K0 2632 +3.3V 2611 4612 9606 F230 E A4 1252 For ITV Only GND_1 +8VA E I230 3 OUT OUT COM GND 2 4604 SCL A4 B 3650 6603 F210 BZX384-C2V7 3649 470R A 9607 A4 1241 for ITV only 9609 1 2 3 To 1462 of F LIGHT_SENSOR A4 C Linearity & Panorama Panel A4 Stdby_Con A4 CGND CGND CGND 1272 RES 4617 CGND G REGION SIZE 3614 3648 4609 4614 4616 G NAFTA 27VRF-HD 30WSRF-HD 470R 470R 2K2 2K2 ------------- FAMILY BOARD 11 NC : 3139_123_5932 MAIN CHASSIS 11 NC : 3139_123_5933 H H F_15060_005.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1206 A10 1207 D10 1213 E10 1219 D8 1220 E8 1221 F8 1240 F5 1241 F7 1243 F7 1250 B8 1251 B10 1252 B8 1254 C8 1255 C10 1257 E8 1270 F1 1271 F1 1272 G1 1273 C7 2601 C4 2611 B3 2613 B9 2615 E4 2617 E6 2620 C3 2621 C3 2622 F5 2623 E3 2624 E3 2625 E1 2630 F3 2631 E4 2632 A7 2633 D7 2634 D7 2999 D5 3601 C4 3604 C6 3605 C6 3606 D2 3607 E2 3608 D2 3609 E3 3614 E5 3622 E7 3623 F7 3625 F9 3626 E10 3628 F10 3634 F6 3635 D5 3637 E6 3647 D6 3648 B7 3649 A7 3650 A7 3651 B7 3652 D8 3653 D8 3654 A8 4253 D8 4604 B2 4609 D9 4612 C2 4614 E5 4616 B7 4617 G3 4653 D8 5601 F3 5602 E5 6602 E2 6603 B7 7601 B5 7603 B2 7604 E2 7605 D2 7606 E5 7608 A7 9235 E5 9280 F7 9605 C3 9606 A9 9607 A9 9608 F3 9609 F3 F210 B2 F211 B2 F212 C3 F213 E3 F214 C5 F215 C5 F216 C9 F217 C9 F218 C9 F219 D8 F220 D7 F221 D7 F224 C8 F225 C8 F226 C7 F227 E8 F228 E10 F229 F10 F230 A9 F232 F10 F233 B9 F237 B9 F238 B9 F239 B9 F243 C8 F247 E9 F248 E10 F249 E10 F251 F9 F252 C7 F254 C7 I227 E2 I229 E9 I230 B3 I231 F9 I232 C3 I233 E5 I234 E3 I240 C2 I241 E1 I242 C8 I244 E6 Circuit Diagrams and PWB Layouts Mono Carrier: Audio Amplifier 1 2 A7 L05.1U AA 3 7. 4 34 5 6 7 8 9 10 11 AUDIO AMPLIFIER A7 A A 100n 2986 100n 2987 +Vaudio To 1254 Of 2985 2 MUTE +16V 3 V|GND 9 3997 I961 1282 2917 6991 * *BAS316 BAS316 4991 Hercules I959 6990 100u 6.3V TO 1683 OF * * * 3996 F953 F955 2996 10R 1281 5 4 3 2 1 5 4 3 2 1 2995 INV12 22n I957 *4993 2998 Audio_Gnd 10R 2u2 3982 47K 3983 100n C +Vaudio F956 -Vaudio 2988 Audio_Gnd 3993 2997 VP- 47K 3995 2916 AmpOutR 6 Audio_Gnd E D * 7993 BC847B C B 0V7 Audio_Gnd E 3999 A5 100K E MUTE_A VOL_CTRL 0V7 B 27K 56K D B I958 3986 A4 7992 BC847B C 680K * 9984 3984 I960 F952 -16V 5 4u7 68K 8 I955 7991 BC847B C 16V +Vaudio 3989 INV2- 1u0 * VOL_MUTE 22n OUT2 3994 I956 Audio_Gnd I952 * 2992 10K 3992 C I954 1n0 * 2993 A4 RES 3991 2K4 F951 2994 47n * Side AV Panel + HP Panel 1280 AmpOutL 4 INV1- 47n 2K4 OUT1 1 2991 MAIN_OUTR B 1u0 Not In Use I951 2989 3K9 * VP+ I953 10K 1n0 * 3988 A4 2990 F950 MAIN_OUTL B Side AV Panel Or To 1254 Of 7990 TDA2616Q +16V 7 RES 3985 I964 A4 10K B 0V7 * 7994 BC847B E * MUTING 1222 1 2 3 +Vaudio 4992 * I965 BZX384-C5V1 A4 3998 4u7 6992 Stdby_Con I950 for ITV only E 0V7 C 2918 E Audio_Gnd A5 F G F REGION SIZE 6991 6992 9984 3998 7994 6990 2917 3997 7993 3996 3985 3991 3988 3992 2989 2992 4993 26WSRF-ATSC --------------------22K 22K 5K6 5K6 2U2 2U2 JMP NAFTA 30WSRF-ATSC 27VSRF-ATSC ----------------------------------------22K 22K 22K 22K 5K6 5K6 5K6 5K6 2U2 2U2 2U2 2U2 JMP JMP 32VSRF-ATSC --------------------22K 22K 5K6 5K6 2U2 2U2 JMP FAMILY BOARD 11NC : 3139_123_5932 MAIN CHASSIS 11NC : 3139_123_5933 G F_15060_007.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1222 E10 1280 B10 1281 B10 1282 D3 2916 D6 2917 E4 2918 E5 2985 B4 2986 A8 2987 A7 2988 D7 2989 B5 2990 B6 2991 C4 2992 C5 2993 C6 2994 B8 2995 C8 2996 C9 2997 C9 2998 C10 3982 C10 3983 D10 3984 D3 3985 B4 3986 D4 3988 B5 3989 B9 3991 C4 3992 C5 3993 C9 3994 C5 3995 C6 3996 D6 3997 D5 3998 E3 3999 E5 4991 E2 4992 E6 4993 C10 6990 D3 6991 E2 6992 E5 7990 B7 7991 C6 7992 D5 7993 D5 7994 E4 9984 D3 F950 B4 F951 C4 F952 B9 F953 B10 F955 C9 F956 C10 I950 E6 I951 B6 I952 C6 I953 B5 I954 C5 I955 C6 I956 B9 I957 C9 I958 D4 I959 D4 I960 D2 I961 D3 I964 E3 I965 E3 Circuit Diagrams and PWB Layouts Mono Carrier: Rear I/O Cinch 1 2 4 7. 35 5 REAR I/O CINCH 6 7 8 9 10 11 A8 1236 ITV RES 1 2 3 A8 3 L05.1U AA A A I117 3101 F101 1101 68R 0V A5 7104-1 0V IMX1 C 7104-2 IMX1 I124 B 0V2 3173 I122 3174 4K7 4K7 I125 B 0V2 E E MONITOR OUTPUT 1138 From 1240 OF 220K RES 75R 4130 AV2 2134 I114 I120 50V 2u2 390p 1111 2136 F110 4104 RES * 3131 150R D 1224 14 R I119 13 16 3133 V F111 150R E 11 3121 75R 47K 3124 330p SC1_L_IN A4 F for ITV only 47K 3126 390p 150R 2127 1109 2123 2u2 50V I123 I112 3125 F109 330p 12 F123 2124 V 150R 390p 9 4105 RES 1108 R F I111 3123 F108 10 2126 4145 1223-3 L A4 2122 AV1 F140 BZX284-C6V8 1107 F107 6106 SC1_CVBS_IN 1155 1153 3129 390p 1112 A4 1154 For ITV C L 2137 SC2_R_IN 1 2 3 4 5 6 Source Select + Microcontroller 1113 I113 330p 2132 50V 2u2 330p I116 2131 SC2_L_IN A4 2133 A4 9116 4113 75R 3168 1106 SC1_RED_IN 47K I106 RES 1228 To 1228 Of 75R * 15 47K F106 E 75R A4 3130 3116 F122 1137 4116 9114 F113 SC2_Y|CVBS_IN 6132 75R 3167 A4 1105 5 SC1_BLUE_IN 1110 I105 RES V 8 F139 3114 F105 Y A4 A4 9112 U 6 6 1 2 3 4 5 F112 3135 75R RES 7 1229 SC2_CHROMA_IN 3132 1223-2 3 2 1 F116 F115 2108 F104 for ITV A4 I104 SC1_GREEN_IN YUV INPUT D 10u SC2_R_OUT 3134 47K 3172 3171 I107 3112 100u 10V 7105 BC847B E 2138 3169 2V I110 1104 B 8V2 1K0 C 47K 3170 8V2 C 390p 150R 1103 Vbuffer A4 10u 2106 3105 F103 B SC2_L_OUT for ITV 220K 4 I108 F117 1227 1 V 390p 2107 1102 150R 330p 3104 2 R 2105 3103 1 2 3 Features & Connectivities 2103 L F102 330p 3106 3 2104 1223-1 B SC2_CVBS_OUT 2125 1262 SC1_R_IN A4 2u2 50V I109 AUX_ON|ITV_MSG F138 1 2 3 4 5 6 7 A4 9170 G G 9171 9172 9173 CGND CGND MainSupplyGnd H H F_15060_008.eps 180305 3139 123 5933.2 1 2 3 4 5 6 7 8 9 10 11 1101 A3 1102 B3 1103 C3 1104 C3 1105 D3 1106 D3 1107 F3 1108 F3 1109 G3 1110 D9 1111 D9 1112 E9 1113 C9 1137 C10 1138 B4 1153 E2 1154 E2 1155 E2 1223-1 B2 1223-2 C2 1223-3 F2 1227 B7 1228 E1 1229 C8 1236 A5 1262 F8 2103 B5 2104 C5 2105 B5 2106 C5 2107 B4 2108 C4 2122 F4 2123 F6 2124 G4 2125 F6 2126 F4 2127 G4 2131 D8 2132 D7 2133 E8 2134 E7 2136 E9 2137 E9 2138 C2 3101 A3 3103 B4 3104 B5 3105 C4 3106 C5 3112 C5 3114 D5 3116 D5 3121 F4 3123 F4 3124 F5 3125 F4 3126 G5 3129 D10 3130 D9 3131 D8 3132 D8 3133 E8 3134 E8 3135 C8 3167 D4 3168 D4 3169 C4 3170 C2 3171 D2 3172 D1 3173 B4 3174 B4 4104 E8 4105 F3 4113 E7 4116 C10 4130 D9 4145 F2 6106 F3 6132 D8 7104-1 A5 7104-2 A4 7105 C2 9112 C5 9114 D5 9116 D5 9170 G1 9171 G1 9172 G1 9173 H1 F101 A3 F102 B3 F103 C3 F104 C3 F105 D3 F106 D3 F107 E3 F108 F3 F109 F3 F110 D9 F111 E9 F112 C9 F113 D9 F115 C7 F116 C6 F117 B6 F122 D3 F123 F3 F138 G7 F139 C9 F140 F1 I104 C6 I105 D6 I106 D6 I107 C5 I108 B5 I109 F6 I110 C2 I111 F5 I112 F5 I113 D8 I114 E8 I116 D7 I117 A5 I119 D10 I120 E7 I122 B4 I123 F6 I124 B4 I125 B5 Circuit Diagrams and PWB Layouts Mono Carrier: Front Control 1 2 A9 L05.1U AA 7. 36 Mono Carrier: Diversity Tables A2 & A4 3 4 5 FRONT CONTROL DIVERSITY TABLE FOR A9 A A 3690 3695 RES LED A4 B 4692 220R +6V B F693 F691 IR A4 4691 F692 100u 6694 2691 I699 IR_OUT BZX384-C5V1 3693 220R F696 IR C C LED_OUT for ITV only For Engg Purpose Only 1692 F694 4694 F695 3698 4K7 1 2 3 4 5 6 7 F697 D 1693 1 2 3 4 5 6 D To 1693 Of F698 LIGHT_SENSOR A4 KEY_PROTN A4 Front Interface Panel E E 1692 C4 1693 C4 2691 C4 3690 B4 3693 B4 3695 B2 3698 D3 4691 C3 4692 B2 4694 D2 6694 C4 F691 C2 F692 C3 F693 B2 F694 D1 F695 D2 F696 B2 F697 D4 F698 D3 I699 B4 Item No 2407 2411 2412 2413 2416 2417 2418 2419 2421 2422 2433 2435 2451 2458 2470 2471 2473 2474 2495 2499 3412 3413 3414 3415 3418 3419 3421 3424 3425 3426 3427 3428 3432 3433 3434 3435 3436 3437 3440 3442 3451 3459 3461 3463 3467 3468 3471 3472 3478 3480 3485 3488 3489 3491 3492 3496 3497 3499 4401 4418 4495 5401 5408 5450 5456 6442 6449 6476 6482 6483 6491 9402 9411 9432 9435 9440 9442 9476 9489 9490 27RF HD --2KV 820P 1K6 12N 630V 27N ----250V 390N 250V 560N --------100V 220N 250V 100N 100V 100N 16V 100N 50V 15N 50V 150P 50V 100N ----1K 4R7 4R7 100R 4R7 22R ----100K 680K 22K --4R7 5K6 --680K 22K 2R2 --4R7 820K 1K5 1K5 220R 220R 1R 1R2 100R 4M7 0R47 220K 100R 12K 18K ----1M ----JMP 3U9 W7132-004 JF0101-85039 ----BZX384-C15 BZV85-C6V8 BZX384-C6V8 BAS316 ----JMP --JMP --JMP ------- 30WSRF-HD --2KV 220P 1K6 12N 630V 27N ----250V 330N 250V 1U2 2KV 220P 2KV 220P ----100V 100N 250V 100N 250V 47N 16V 100N 50V 15N 50V 150P 50V 100N ----1K 4R7 4R7 100R 4R7 22R 1mA612V 1mA612V 100K 680K 22K --4R7 3K9 --680K 22K 2R2 --4R7 470K 1K5 1K5 220R 220R 2R2 1R5 100R 4M7 0R47 220K 100R 12K 18K ----1M ----JMP 3U9 W7131-001 JF0101-85038 SD20417-07 --BZX384-C15 BZV85-C6V8 BZX384-C6V8 BAS316 --------JMP --JMP ------- A2 LINE + FRAME DEFLECTION 27RF ATSC 32RF ATSC 30WS ATSC 50V 330P 50V 330P 50V 330P 2KV 330P 2KV 220P 2KV 820P 1K6 12N 1K6 12N 1K6 12N 630V 33N 630V 27N 630V 27N ------------250V 330N 250V 390N 250V 330N 250V 1U2 250V 560N 250V 560N 2KV 220P ----2KV 220P ----------------250V 68N 250V 68N 250V 68N ------100V 100N 100V 100N 100V 100N ------------------------16V 2U2 16V 2U2 16V 2U2 ------1K 1K 1K 4R7 4R7 6R8 4R7 6R8 4R7 ------4R7 4R7 6R8 4R7 4R7 4R7 --1mA612V ----1mA612V --------------------------4R7 4R7 10R ------------------------2R2 2R2 2R2 ------4R7 10R 4R7 820K 680K 470K 27K 27K 27K 3K3 3K3 3K3 100R 100R 100R 100R 100R 100R 2R2 2R2 1R 1R2 1R2 1R5 33K 33K 33K ------0R47 0R47 1R ------10K 10K 10K 8K2 10K 8K2 22K 47K 12K 100K 100K 100K 56K 56K 56K 470K 470K 470K JMP JMP JMP JMP JMP JMP ------3U9 3U9 5U5 W7131-001 W7132-004 W7132-004 JF0101-85038 JF0101-85039 JF0101-85040 ----SD20417-07 BZV85-C10 BZV85-C10 BZV85-C10 BZX384-C12 BZX384-C12 BZX384-C12 BZV85-C6V8 BZV85-C6V8 BZV85-C6V8 ------------BZX384-C3V3 BZX384-C3V3 BZX384-C3V3 --------JMP JMP JMP JMP JMP JMP JMP JMP ------------------------------- 26WS ATSC 50V 330P 2KV 1N 1K6 12N 630V 27N ----250V 330N 250V 560N --------250V 68N --100V 100N --------16V 2U2 --1K 4R7 4R7 --4R7 4R7 ------------4R7 --------2R2 --4R7 820K 27K 3K3 100R 100R 2R2 1R2 33K --0R47 --10K 10K 22K 100K 56K 470K JMP JMP --5U5 W7132-004 JF0101-85039 --BZV85-C10 BZX384-C12 BZV85-C6V8 ----BZX384-C3V3 --JMP JMP JMP ----------- DIVERSITY TABLE FOR 2251 2293 2294 2295 3238 3246 3252 3262 3265 3266 3279 3280 3282 3291 4201 4299 5214 HD set 150n 1n 5n6 1n A4 HERCULES ATSC set 10n 470p 10K 100R 10K 100R 100R 100R 4K7 4K7 4K7 4K7 0R 0R 100MHz, 120R Region: NAFTA HD L05 ATSC Size 27V RF 30WSRF 27V RF 27V RF 2251 50V 150N 50V 150N 50V 10N 50V 10N 50V 470N 50V 470N 2293 25V 1N 25V 1N Region Size 3246 3255 3256 9601 9602 26WSRF-ATSC 100R --------- NAFTA 30WSRF-ATSC 27VRF-ATSC 100R 100R ----------------- 32VRF-ATSC 100R --------- F_15060_031.eps 180305 F F Cell 11NC : 8239_125_1087 ver4.1 (2004-10-11 - WK442) Function 11NC : 8239_125_1095 ver4.1 (2004-10-11 - WK442) G FAMILY BOARD 11NC : 3139_123_5932 MAIN CHASSIS 11NC : 3139_123_5933 G F_15060_009.eps 180305 3139 123 5933.2 1 2 3 4 5 Circuit Diagrams and PWB Layouts L05.1U AA 7. 37 Mono Carrier: AUX Power Supply 1534 1535 2510 2526 2536 2555 2556 2557 2558 2575 2576 2577 2579 2580 8P 3P 47U 100N 2200U x x x x 10N 100N 100U 100N 15N 3533 3534 3537 3538 3546 3547 3551 3553 3561 1R 33R x 1R 68K x 4R7 39K x x x 22U x 1000U 47U 47U 47U 47U x x x x x 1R2 68R 68K x 100K x 27K 220R x 27K 22K 5K6 56K 5K6 2K2 82K 18K 68K 3K3 100K x Jumper SS28411 BZX384-C18 x BZX384-C6V8 BAW56 SARS03 STPS10L25D x x x STP6NK60ZFP TL431ACZ x 3565 3581 3583 3585 3586 3587 3590 3591 3592 3596 3598 4551 4567 5504 6512 6545 6547 6548 6550 6552 6553 6554 7509 7525 7542 7543 HD 220R 100K x x x x x x x x 10K 330K Jumper x SS28412 x SB360 x x x x BAS316 BAS316 Si2307DS STP5NK80ZFP TL431ACZ L78L08ACZ Item 7544 7545 7575 7576 7577 7583 7584 9515 9523 9524 9536 ATSC x x PDTC143ZT BC847BW BC847BW BC847BW BC847BW Jumper Jumper Jumper Jumper Vaux_GND MainSupplyGndA 100n 9530 2556 2 2555 220R 3562 3561 220R 47u 16V 68K 3546 470u 2584 2K2 3545 4m7 6V3 47u 16V 2534 470u 16V 2564 1m0 2536 0V 7545 SI2305DS D 2579 2576 68K 6553 BAS316 E 4566 3566 68K 2557 2 Vaux_GND1 Vaux_GND 47u 16V OUT 3 100u 25V 2537 +6V F586 +5V COM 47u 16V 68K 5K6 3585 IN Vaux_GND1 F Vaux_GND1 B 0V7 E Vaux_GND 6548 BAW56W Vaux_GND A4 F537 +6VA Vaux_GND 1 100n 0V 7577 BC847BW C 10n E 3548 4548 68K 6554 7509 SI2307DS Vaux_GND B 0V7 7576 BC847BW 6V 3586 3583 C B E 7544 L78L33ACZ 82K 2 0V I596 B 2V 0V 27K 3544 I593 A REF K 3 2V5 7547 C PDTC143ZT F585 2K2 B 0V 2u2 1n0 7575 E 0V PDTC143ZT Vaux_GND Vaux_GND 9515 100n 3540 4540 I545 470u 2587 10V 2590 3m3 10K 2578 3553 C 9V HD LE50CZ Si23333DS x x x x x x x x x 2543 BZX384-C6V8 3590 ATSC 2K2 22K 3587 Item 3562 10n x 2575 HD H/S 3543 Vaux_GND * ATSC * H Item 0083 7542 TL431CZ-AP 2588 * G I592 Vaux_GND 3594 10K 3596 10u 2583 E * 5V7 10K 8V F580 +3V3A 3 I547 68K 2589 680R 6547 1V5 9524 3537 Vaux_GND1 3591 2 1K0 3539 3 B E I590 9V 1K2 47n 3529 2521 7549-1 IMX1 C 0V6 10K I597 I529 270R 3593 B 0V6 7549-2 IMX1 100K 3595 C 15V8 3549 STPS10L60D Vaux_GND1 3542 1 20V I512 1n0 6552 5K6 6537 3533 3532 3538 1K0 BAV21WS 7516 TCET1103(G) +3V 68K BAS316 2n2 33K 2544 10n 3592 1n0 2523 2535 47K 4 470U 2591 * BAV21WS 5527 I594 1 8V1 330K 3568 BAS316 3531 SB340L-7010 I539 6538 3547 2546 I589 2558 Panel To P1534 Of 4R7 T 1000mA 3535 1532 2592 2580 3567 BAS316 3588 470K 6534 10K 3K3 3534 4585 3589 22u 2510 100n 100n 1u0 2582 6512 BAS316 4M7 6531 470n 3528 3598 3527 6536 * C 2u2 * 47K 100n Vaux_GND1 +3V3 2 6545 * 47K I531 +8V 3 F583 OUT COM Vaux_GND1 Vaux_GND 2 IN Vaux_GND1Vaux_GND1 Vaux_GND C BC847BW 7583 7584 B C BC847BW 10V7 B E 0V * 3597 1 * F584 470U Vaux_GND Vaux_GND 56K 2520 5526 1 I532 3530 E 1n0 * 2585 68p 2 S 470p 0083 HEATSINK 0088 HEATSINK 9507 STPS10L60D 2538 F535 I540 * 2525 Vaux_GND SS28411-00 D 0V 12 * D 1 1 SB340L-7010 6546 11 * BZX384-C15 2 1 * * * 6549 2522 2 7543 L78L33ACZ 3581 22K 2577 9529 Stdby_con A4 AUX_ON|ITV_MSG A4 1 Vaux_GND Vaux_GND E Vaux_GND H FAMILY BOARD 11NC : 3139_123_5932 MAIN CHASSIS 11NC : 3139_123_5933 CELL 11NC : 8239_125_1089 ver6.0 (2004-12-03 - WK449.5) FUNCTION 11NC : 8239_125_1097 ver6.0 (2004-12-03 - WK449.5) 2 G 100u x Layout Jumper 3139 123 5933.2 B Deflection Controller 1535 1 2 3 +12VA * I509 10 7525 158V G 3V4 6544 * I554 I533 Vaux_GND * I526 I530 9 Vaux_GND1 Vaux_GND1 +8VA 33R F582 10u * * 4 I537 F578 To 1405 Of 3560 9534 7535 SI2307DS * 5521 I536 470p 3526 C 0V I599 Vaux_GND E 15K 5524 0086 HEATSINK A4 * C 3V4 7567 BC847B 8 BAS316 POWER_DOWN 7561 PDTC143ZT B 0V * 14 158V 13 12 11 10 3V4 9 8 0V 7 5 6543 * B 15V8 B 0V1 VEE NC4 OUT_NEG NC3 CAR_IN_NEG NC2 CAR_IN_POS 5504 6 BZX384-C12 3565 I564 SB340L-7010 * 7532 E BC857B 15V8 SIG_IN_POS GAIN_ADJ1 GAIN_ADJ2 SIG_IN_NEG BIAS OUT_POS NC1 2K2 5523 4523 6542 Vaux_GND1 470p 6539 F577 I588 * * 7510 TEA1507 1 3 2 15V9 4 5 6 1V3 7 BAS316 * 3550 220K I568 3536 E F534 I534 3V2 C * I556 * C I558 SARS03 F581 220R 2539 1M5 * 6540 300K 6550 +5V +6VA * BZX384-C18 2526 I595 I528 3563 * RGP10D * 3525 I563 C 3V7 I538 MAINSUPPLYGND Vaux_GND Vaux_GND1 * 6533 B 4V5 Vaux_GND1 A 9509 * * 7585 BC857B * * 1n0 4R7 * 3599 E 0V 2524 * * * * AC_IN I553 I510 * B 4551 3551 * I560 Panel * BAV21WS Vaux_GND Vaux_GND1 Vaux_GND S3B-EH * I557 Source Select + Microcontroller Or To P1533 Of 9999 1 2 3 * 330p 6532 1 2 3 4 5 6 7 8 +3V3A 1 +8V 2 3 4 5 Vaux_GND 6 Vaux_GND1 9554 7 4567 8 9 10 9536 11 12 9523 * 2586 1533 +3V3A 1534 11 * * I565 VCC 10 1 To 1533 Of VDC A F 9 AUXILIARY POWER SUPPLY A10 2528 8 * 7 * 6 * 5 * 4 * 3 * 2 * 1 3 4 5 6 F_15060_010.eps 180305 7 8 9 10 11 0083 C8 0086 B9 0088 D7 1532 A6 1533 A9 1534 A7 1535 B11 2510 B3 2520 D6 2521 E3 2522 C6 2523 D6 2524 B3 2525 D5 2526 B2 2528 C1 2534 C9 2535 D9 2536 C8 2537 E11 2538 C9 2539 B8 2543 E9 2544 B7 2546 D10 2555 C10 2556 C11 2557 F11 2558 F10 2564 B9 2575 F7 2576 F9 2577 G10 2578 E8 2579 F9 2580 B6 2582 B1 2583 F1 2584 D10 2585 B1 2586 A2 2587 D9 2588 E7 2589 E10 2590 D8 2591 D8 2592 B4 3525 B6 3526 D5 3527 C1 3528 C1 3529 E3 3530 D6 3531 D6 3532 D6 3533 D6 3534 B6 3535 A6 3536 C6 3537 D10 3538 D6 3539 E8 3540 D10 3542 E8 3543 E8 3544 F9 3545 D9 3546 C9 3547 D10 3548 D10 3549 E6 3550 C1 3551 B2 3553 E9 3560 B11 3561 D10 3562 D10 3563 B8 3565 B9 3566 E10 3567 B6 3568 C5 3581 G10 3583 F8 3585 F10 3586 F9 3587 F7 3588 B5 3589 B4 3590 F9 3591 F9 3592 B6 3593 E3 3594 F3 3595 E2 3596 F2 3597 D2 3598 C1 3599 B1 4523 B8 4540 D10 4548 D10 4551 B2 4566 E10 4567 A9 4585 B3 5504 B7 5521 C6 5523 B8 5524 B9 5526 C9 5527 D9 6512 B2 6531 C1 6532 A2 6533 B3 6534 B5 6536 C6 6537 D7 6538 D7 6539 B8 6540 B9 6542 B9 6543 B10 6544 C9 6545 D8 6546 C9 6547 F9 6548 G9 6549 C2 6550 B6 6552 E8 6553 D11 6554 E10 7509 E10 7510 C3 7516 E7 7525 C6 7532 C1 7535 B10 7542 E8 7543 C10 7544 E10 7545 D11 7547 E10 7549-1 E2 7549-2 E1 7561 B10 7567 C5 7575 F8 7576 G8 7577 F9 7583 G10 7584 G10 7585 B3 9507 C9 9509 A11 9515 E9 9523 B9 9524 D11 9529 G11 9530 C11 9534 B10 9536 A10 9554 A10 9999 A10 F534 B10 F535 C9 F537 E11 F577 B9 F578 B9 F580 D11 F581 C3 F582 B10 F583 C11 F584 C10 F585 E9 F586 F11 I509 C1 I510 B3 I512 E3 I526 D5 I528 B6 I529 E6 I530 D5 I531 D6 I532 D6 I533 C6 I534 B11 I536 C6 I537 C7 I538 B8 I539 D8 I540 C8 I545 E9 I547 E10 I553 B1 I554 D1 I556 B7 I557 A6 I558 B8 I560 B2 I563 B5 I564 B8 I565 A2 I568 B6 I588 B9 I589 D10 I590 E7 I592 E8 I593 E9 I594 D8 I595 B6 I596 E11 I597 E1 I599 C6 Circuit Diagrams and PWB Layouts L05.1U AA 7. 38 Layout Mono Carrier: (Top Side) 0083 0086 0088 1000 1001 1002 1003 1005 1010 1011 1012 C2 C3 B3 E8 E6 E5 E5 E8 E7 E7 E6 1013 1137 1138 1205 1206 1207 1208 1213 1219 1220 1221 E8 C8 D7 D5 D5 E7 D7 C5 C7 E4 C5 1222 1223 1227 1228 1229 1230 1234 1236 1240 1241 1243 3139 123 5933.1 D3 D8 D7 D7 C8 D5 D5 D8 D4 D5 C5 1250 1251 1252 1254 1255 1257 1262 1266 1270 1271 1272 C7 C6 D6 C6 C6 E5 D7 D6 D6 E7 C7 1273 1280 1281 1282 1401 1402 1404 1451 1500 1501 1502 E5 E3 E3 D3 C6 A7 B5 C7 A2 A2 A2 1503 1504 1505 1507 1510 1532 1533 1534 1535 1545 1546 C2 C2 A1 B2 B1 B3 D2 D2 C1 B4 B4 1572 1577 1682 1683 1684 1685 1692 1693 2005 2006 2008 C4 D3 D4 C5 D6 D6 D1 D1 E5 E7 E7 2105 2106 2123 2125 2132 2134 2138 2203 2217 2218 2224 D7 D7 D7 D8 C7 C7 D8 D5 E5 D6 E5 2234 2240 2250 2251 2265 2273 2275 2291 2404 2411 2412 D6 E5 D6 E5 E6 E6 E6 D6 B6 A6 A6 2413 2416 2417 2418 2419 2421 2422 2431 2433 2435 2436 B6 B6 B6 A6 B6 A7 A7 A6 A7 A8 B7 2449 2451 2454 2458 2460 2461 2468 2469 2488 2500 2501 C8 A8 A8 B7 A8 C7 C8 B7 B5 A2 C2 2502 2503 2504 2505 2506 2507 2508 2509 2510 2511 2514 C2 A3 A4 A4 B2 A4 C2 B1 C3 A5 A4 2523 2528 2534 2535 2536 2539 2541 2542 2544 2551 2552 B3 B3 C4 D3 D3 C3 C2 B4 B3 B5 C5 2555 2556 2557 2558 2561 2562 2563 2570 2577 2580 2584 C1 D2 C1 C1 B4 C4 C4 B4 C4 C3 D3 2587 2588 2590 2611 2621 2624 2631 2691 2999 3101 3103 C2 C3 C2 E4 E5 E5 D7 D1 D4 E8 D8 3105 3112 3114 3116 3123 3125 3131 3133 3201 3215 3230 E8 D8 D8 D8 D8 D8 C8 C8 D5 D5 D6 3241 3252 3260 3270 3274 3275 3276 3277 3278 3291 3293 E5 D5 D5 E7 E7 E7 D7 D7 D7 C5 D4 3401 3402 3412 3413 3414 3415 3419 3421 3424 3425 3431 B5 B5 A6 A6 A6 A6 B8 B5 A7 A7 C6 3432 3433 3435 3440 3442 3450 3451 3455 3456 3458 3466 C7 B8 C5 C6 C7 B8 B8 A8 A8 B7 C8 3467 3468 3469 3471 3472 3473 3477 3478 3481 3485 3486 C7 C7 C7 C7 C7 B6 B7 C6 C6 B7 B7 3488 3489 3490 3493 3499 3500 3501 3502 3503 3504 3505 C6 C6 A5 B8 C6 B1 C1 B2 B2 B2 A2 3506 3508 3509 3510 3511 3513 3514 3515 3516 3519 3520 B1 B3 B2 B3 B5 A5 A5 A5 A4 B4 A4 3521 3523 3525 3531 3534 3535 3536 3549 3560 3563 3575 A5 C2 C4 B3 C3 B3 C3 B4 D3 C3 B5 3592 3598 3599 3606 3984 5201 5208 5216 5401 5402 5408 B3 B3 B3 E4 D3 D5 D6 D6 A5 A5 B6 5409 5450 5452 5456 5459 5500 5501 5502 5504 5506 5511 B6 B7 C6 A6 B6 B2 B2 A3 C3 B2 A4 5512 B4 5512C B4 5512D B4 5521 B3 5524 D3 5526 D3 5527 C2 5551 B5 5552 B5 5561 B4 5562 B4 5563 5564 5602 6001 6006 6403 6404 6442 6452 6453 6456 F_15060_011.eps 140305 C5 A3 D7 E8 E7 B8 B6 C7 A8 B7 A8 6457 6461 6466 6467 6471 6476 6486 6500 6511 6533 6539 6544 6545 6546 6550 6551 6552 6562 6563 6564 6575 7203 7204 7405 7406 7451 7512 7513 7516 7525 7542 7543 7544 7571 7601 7603 7605 7990 9002 9010 9112 9114 9116 9120 9121 9122 9124 9129 9170 9171 9172 9173 9201 9202 9203 9204 9205 9206 9207 9208 9209 9210 9213 9214 9215 9216 9217 9218 9219 9220 9221 9222 9223 9224 9225 9226 9227 9228 9229 9230 9231 9232 9233 9234 9235 9236 9237 9238 9239 9240 9241 9242 9243 9244 9245 9246 9247 C8 B8 B7 B7 C6 B7 B6 A3 A5 C4 C3 C3 C2 C3 C3 C5 C2 C4 B4 C4 A4 E5 E5 A6 C6 C7 A4 B5 C4 B3 C4 C2 D1 B5 D5 E4 E5 E3 E7 E7 D8 D8 D8 D8 D8 D8 D7 D7 D7 D7 D7 C7 C6 E4 E6 E7 D4 D4 D4 D4 C5 E7 D7 D4 E7 D7 D6 E6 D6 D5 D5 E5 E6 D5 D4 D4 D5 D4 D5 D5 E6 E5 E6 E7 D7 E7 D6 D7 E6 E5 D7 D4 C4 E6 E4 E6 E4 9248 9249 9250 9251 9252 9253 9254 9255 9257 9260 9261 9262 9263 9265 9266 9267 9269 9271 9272 9273 9274 9275 9276 9278 9279 9280 9288 9290 9291 9292 9293 9294 9296 9297 9298 9299 9402 9411 9429 9432 9435 9440 9442 9450 9451 9465 9473 9476 9480 9482 9483 9484 9485 9486 9487 9488 9489 9490 9491 9492 9493 9494 9495 9497 9498 9500 9501 9502 9503 9504 9505 9506 9509 9510 9511 9512 9513 9515 9523 9524 9526 9527 9528 9529 9530 9531 9532 9534 9535 9536 9537 9539 9541 9542 9544 9545 9546 E6 C4 E6 E5 C5 D5 C7 C5 E7 D5 D7 E7 D7 D7 D7 D7 C4 E5 D4 D4 D4 C5 D5 D4 D4 D5 D7 E6 C5 C4 E4 C6 C5 C4 C5 C5 A5 A6 A6 C7 C5 C6 C7 C7 C7 C6 C5 C7 C6 C6 B6 C6 B6 C6 C5 C6 C6 C6 C6 C6 C6 C8 C7 C5 B5 A2 B2 B2 B2 B2 B2 A3 D4 C4 B3 A3 B3 C1 D1 D2 D4 D4 D4 D3 D2 C3 D3 D2 D3 D1 C3 B3 D2 D4 C1 D2 C2 9547 9548 9549 9550 9551 9552 9553 9554 9563 9570 9572 9576 9577 9580 9583 9585 9586 9587 9588 9589 9590 9601 9602 9605 9606 9607 9608 9609 9631 9637 9639 9642 9643 9653 9660 9661 9666 9688 9689 9694 9695 9696 9697 9698 9699 9920 9921 9922 9942 9943 9984 D2 D2 D2 C1 C3 C4 D1 D2 C5 A3 C4 A4 D3 C5 C4 A4 C4 B4 C5 A4 C4 D7 D7 E6 D4 D4 C7 C7 C6 E7 E4 C7 D5 D4 D1 D1 D1 E4 E4 E6 E4 D4 D4 D6 C6 D3 D3 D3 D3 D3 D3 Circuit Diagrams and PWB Layouts L05.1U AA 7. 39 Layout Mono Carrier (Overview Bottom Side) 2001 2002 2003 2004 2007 2009 2011 2012 2013 2014 2016 2103 A8 A8 A7 A7 A7 A7 A6 A6 A7 A7 A7 A8 2104 2107 2108 2122 2124 2126 2127 2131 2133 2136 2137 2201 A7 B8 B8 B8 B8 B8 B8 C7 C7 C8 B8 B6 2204 2205 2206 2207 2208 2209 2210 2211 2212 2213 2214 2215 A5 B5 B5 A4 A4 B5 B5 B6 B5 B5 A5 B6 2216 2223 2225 2226 2227 2229 2231 2232 2233 2235 2237 2238 B6 B6 B6 A5 A5 B6 B6 B6 B6 A5 B6 A5 2239 2241 2242 2244 2246 2249 2253 2255 2256 2257 2260 2261 A5 A5 B6 A5 A5 B6 A6 A7 A6 A6 A6 A6 2262 2263 2264 2266 2267 2268 2269 2270 2271 2272 2274 2276 B6 A6 B6 A6 A6 A5 A5 A6 A6 A6 A6 A6 2278 2279 2280 2282 2283 2284 2285 2286 2287 2290 2292 2293 A5 B5 B5 B5 A6 A6 A6 B6 B6 A5 B5 A5 2294 2295 2407 2409 2410 2423 2424 2425 2426 2432 2448 2459 A5 A5 C7 E5 D8 D5 D8 C6 D7 C7 D8 E8 2462 2463 2464 2465 2466 2467 2470 2471 2472 2473 2474 2477 C7 C7 D8 C7 C7 C7 C7 C5 C6 C6 D6 D7 2478 2491 2492 2493 2494 2495 2496 2497 2499 2512 2513 2515 D7 C6 D7 E8 D7 C6 C6 D5 C5 E5 E5 D5 2516 2517 2518 2519 2520 2521 2522 2524 2525 2526 2538 2543 E5 E5 E5 E5 D3 D3 C3 C4 D3 D4 C3 C4 2546 2564 2565 2571 2572 2574 2575 2576 2578 2579 2582 2583 B2 C3 C4 D5 C5 D5 C4 C4 C4 C4 C3 D4 2585 2586 2589 2591 2592 2601 2613 2615 2617 2620 2622 2623 C3 C4 B2 C2 C3 B5 B5 B7 B7 A5 B7 A5 2625 2630 2632 2633 2634 2916 2917 2918 2985 2986 2987 2988 A4 C7 B7 B6 B6 B3 A4 B4 B3 A3 A3 A3 2989 2990 2991 2992 2993 2994 2995 2996 2997 2998 3000 3001 B3 A3 A3 A3 A3 A3 A3 A3 A3 A3 A8 A8 3002 3003 3004 3005 3006 3007 3008 3009 3010 3014 3016 3018 A8 A7 A8 A7 A5 A5 A7 A5 A7 A7 A7 A7 3019 3104 3106 3121 3124 3126 3129 3130 3132 3134 3135 3167 A7 A7 A7 B8 B8 B8 C8 C8 C7 C7 C8 B8 3168 3169 3170 3171 3172 3173 3174 3202 3203 3204 3205 3206 B8 B8 A8 A8 A8 B8 B7 B5 A5 B5 A5 A5 3207 3208 3209 3210 3211 3212 3214 3216 3217 3218 3219 3220 B5 A4 A4 A4 A4 B5 B5 B6 A5 B5 B5 B6 3221 3222 3223 3226 3227 3228 3229 3231 3232 3235 3236 3237 B6 A6 A5 B6 B6 B6 B6 B6 A5 C6 B6 B5 3238 3242 3247 3248 3249 3253 3254 3255 3256 3257 3258 3261 C6 A7 A6 B7 B6 A6 A6 A6 A6 B7 B7 B4 3262 3263 3264 3265 3266 3267 3269 3272 3273 3279 3280 3281 B5 B5 B5 B5 B5 B6 B5 B6 B6 B5 B5 B5 3282 3283 3284 3285 3287 3288 3289 3290 3292 3296 3298 3299 B5 B5 B5 A4 B5 B5 C6 B6 B5 A5 B5 B4 3408 3416 3418 3426 3427 3428 3434 3436 3437 3438 3439 3441 D5 E6 C6 C6 C6 C5 C7 C5 C5 C6 C6 D5 3443 3453 3459 3460 3461 3462 3463 3474 3480 3491 3492 3496 C6 E8 C7 C7 C7 C7 C7 D6 C6 C6 C6 C5 3497 3512 3517 3518 3522 3524 3526 3527 3528 3529 3530 3532 C5 E5 E5 E5 E5 E5 D3 D4 D3 D3 D4 D3 3533 3537 3538 3539 3540 3541 3542 3543 3544 3545 3546 3547 D3 B2 D3 C3 B2 C2 C3 C4 C4 C4 B2 B2 Part 2 F_15060_012b.eps Part 1 F_15060_012a.eps Part 3 F_15060_012c.eps 3139 123 5933.1 Part 4 F_15060_012d.eps F_15060_012.eps 140305 3548 3550 3551 3553 3561 3562 3565 3566 3567 3568 3571 3573 3574 3576 3579 3581 3583 3585 3586 3587 3588 3589 3590 3591 3593 3594 3595 3596 3597 3601 3604 3605 3607 3608 3609 3614 3622 3623 3625 3626 3628 3634 3635 3637 3647 3648 3649 3650 3651 3652 3653 3690 3693 3695 3698 3982 3983 3985 3986 3988 3989 3991 3992 3993 3994 3995 3996 3997 3998 3999 4000 4001 4002 4003 4004 4005 4006 4010 4011 4012 4013 4015 4104 4105 4113 4116 4130 4145 4160 4201 4207 4209 4210 4212 4219 4221 4222 4223 4224 B2 D4 D4 C4 B2 B3 C3 B2 C4 D3 D5 D5 D5 D5 D5 C4 C4 C4 C4 C4 D4 C3 C4 C4 D3 D3 D4 D4 D4 B5 B5 B5 A4 A5 A4 B7 A4 A4 B5 B5 B5 A7 B7 B7 B7 B6 B6 B7 A5 C7 C7 B1 B1 B1 B1 A3 A3 B3 B3 A3 A3 A3 A3 A3 B3 A3 B4 B4 A4 A4 A8 A8 A5 A7 A5 A7 A8 A7 A6 A6 A6 A8 B8 B8 B7 C8 C8 B7 C8 A4 A5 A6 B6 B5 B5 B5 A5 A6 A5 4226 4227 4251 4253 4254 4295 4296 4297 4298 4299 4401 4418 4434 4470 4495 4523 4527 4533 4540 4548 4551 4566 4567 4585 4586 4604 4609 4612 4614 4616 4617 4642 4644 4646 4649 4653 4691 4692 4694 4991 4992 4993 5001 5002 5003 5202 5203 5205 5206 5207 5209 5210 5211 5212 5213 5215 5218 5457 5458 5513 5523 5601 6002 6003 6004 6106 6132 6201 6203 6204 6207 6209 6210 6211 6434 6449 6458 6464 6480 6481 6482 6483 6484 6485 6487 6488 6489 6490 6491 6492 6512 6514 6531 6532 6534 6536 6537 6538 6540 A5 A6 B6 C7 C5 B6 B6 C6 B6 A5 C7 C6 C7 D6 C7 C3 C3 E5 B2 B2 D4 B2 B2 C3 D3 A4 A6 A5 B7 B6 A7 A7 A7 B5 A4 C7 C1 B1 C1 B3 B4 A3 A7 A7 A5 B5 B5 B6 B5 B5 A5 B6 A6 A6 B6 B5 B6 E7 D7 D5 C3 C7 A8 A8 A5 B8 C8 A4 B6 A6 A5 C4 B5 B5 C7 C7 C7 D5 C7 D5 C6 C6 C6 C6 D6 C7 C7 C6 C5 C5 D4 E5 D3 C4 D4 D3 D3 D3 C3 6541 6542 6543 6547 6548 6549 6553 6554 6602 6603 6694 6990 6991 6992 7001 7003 7104 7105 7200 7201 7202 7207 7209 7210 7211 7212 7404 7407 7408 7410 7509 7510 7511 7514 7532 7535 7541 7545 7547 7549 7561 7567 7573 7575 7576 7577 7583 7584 7585 7604 7606 7608 7991 7992 7993 7994 C2 C3 C3 C4 C4 D4 B2 B2 A4 B6 B1 B4 B3 B4 A5 A7 B7 A8 B6 A5 A5 B6 A5 A5 B6 B6 D5 C7 C7 C6 B2 D3 E5 E5 D4 B2 C2 B2 B2 D4 C3 D3 C5 C4 C4 C4 C4 C4 C3 A4 B7 B6 B3 B3 A4 A4 Circuit Diagrams and PWB Layouts L05.1U AA 7. 40 Layout Mono Carrier (Part 1 Bottom Side) Part 1 F_15060_012a.eps 210305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 41 Layout Mono Carrier (Part 2 Bottom Side) Part 2 F_15060_012b.eps 210305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 42 Layout Mono Carrier (Part 3 Bottom Side) Part 3 F_15060_012c.eps 210305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 43 Layout Mono Carrier (Part 4 Bottom Side) Part 4 F_15060_012d.eps 210305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 44 CRT Panel (Multi Board) 1 2 3 4 5 6 7 8 9 10 11 CRT SOCKET B1 B1 A F345 1335 AQUADAG WIRE A +200A 6331 BAV21WS CRT SOCKET 1354 1 5 6 7 8 9 10 11 12 1K0 B2 100R C I332 B 1K0 I335 3331 B2 GND_LS1 Red F341 3332 1K0 100R CRT Green F339 3336 C 3R3 D 9306 F383 5304 3R3 V E 3357 GND_RGB GND_LS1 GND_LS1 GND_RGB A2,B3 FOCUS 9310 V 3391 10n 2313 * I322 SVM_ROT TO CRT SOCKET 10n 2319 33R 150R GND_LS1 E EHT I373 I351 I323 +200A F331 9328 I348 3345 V 3351 F354 D I350 3306 F340 2321 Line + Frame Deflection I327 1 F352 DC_Filament 2 3 +141V 4 EHT-INFO 5 200V 6 +8V_+12V 7 3390 From 1401 of 47u 1351 VG2 VG1 3307 DYN FOCUS I334 3335 TO CRT SOCKET I331 F338 3334 B Blue STATIC FOCUS I333 100R R 1K0 GND_RGB 3333 B2 1 5 6 7 8 9 10 11 12 3308 BAV21WS 6333 6332 I330 G BAV21WS 9308 B GND_LS1 FROM LOT, MAIN CHASSIS GND_RGB LINE + FRAME DEFLECTION I377 F347 3347 1336 VG2 F 4n7 RES 820p +12A1 2317 2324 1K5 Item No. 3390 6325 HD --BZX79-2V7 ATSC 30PW BZX79-3V3 F F342 9309 GND_LS1 5308 +12A F398 I336 5u6 3999 F399 G F397 470u 2347 1K2 5324 3305 I379 1R0 GND_LS1 10n 10n I308 3325 2357 +3V H GND_LS1 BZX79-C3V3 * 6325 1K8 2320 +12V_SVM 5u6 I302 MULTIPLE BOARD 11NC : 3139_123_5945 SINGLE BOARD 11NC : 3139_123_5946 GND_RGB 5303 +12A1 G 9324 +8V_+12V GND_RGB H GND_RGB F_15060_032.eps 180305 3139 123 5946.1 1 2 3 4 5 6 7 8 9 10 11 1335 A7 1336 F11 1351 D1 1354 B6 2313 E3 2317 F7 2319 E5 2320 G5 2321 E4 2324 F7 2347 G2 2357 H5 3305 G1 3306 D4 3307 D4 3308 B4 3325 H1 3331 C2 3332 C3 3333 B2 3334 B3 3335 C2 3336 C3 3345 E4 3347 E7 3351 E3 3357 E5 3390 E4 3391 E5 3999 G5 5303 G2 5304 D5 5308 F2 5324 G5 6325 H2 6331 A3 6332 B2 6333 B3 9306 D4 9308 B4 9309 F3 9310 E5 9324 G5 9328 D5 F331 E2 F338 B4 F339 C4 F340 D3 F341 C4 F342 F7 F345 A7 F347 E7 F352 D2 F354 E3 F383 D3 F397 G1 F398 G5 F399 G5 I302 H1 I308 H2 I322 E3 I323 E3 I327 D2 I330 B2 I331 C2 I332 C2 I333 B3 I334 C3 I335 C3 I336 G3 I348 E4 I350 D4 I351 E3 I373 D6 I377 E6 I379 G2 L05.1U AA 4 5 6 I389 +12A I309 * E 3V6 3320 22p 2355 6 200V 9302 GND_RGB MIRROR GND_RGB I392 3340 9301 3V3 3 VIN 3V3 1 VIP I391 DIFFERENTIAL STAGE 4n7 B B1 MIRROR 6308 VDDL 4 2 BAS316 3317 MIRROR CURRENT SOURCE GND 2332 +12A R I342 IOM 5 5V GND_RGB GND_RGB 680p VOC 8 158V5 1K0 CUT_OFF 2333 VCN 7 128V7 V BIAS +3V B2 A GND_RGB MIRROR 2K2 * B R - AMPLIFIER 8p2 3338 GND_RGB GND_RGB 9 127V8 VDDH * 7351 BC847B B 3V6 100R B2 +200A 2335 3339 I399 220R I310 11 2K7 3322 10 0069 7330 TDA6111Q GND_RGB 470R 3321 F332 9 120K 100n C 8 I390 3337 2330 A 7 2338 RGB AMPLIFIER B2 45 VFB CRT Panel: RGB Amplifier (Multi Board) 1 2 3 7. 100n Circuit Diagrams and PWB Layouts * CUT_OFF B2 1K0 2369 330p +12A 2331 6307 GND_RGB +12A1 B 7352 BC847B 3V4 100R 220R I311 E 3V4 F337 3323 GND_RGB GND_RGB 2337 4311 8p2 3343 I395 7340 TDA6111Q 9303 3327 120K 9 128V4 6 G - AMPLIFIER GND_RGB * 220R D +200A 0078 I393 3341 2K2 C GND_RGB GND_RGB GND_RGB MIRROR GND_RGB GND_RGB 2360 I384 GND_RGB I396 3344 DIFFERENTIAL STAGE 2344 I346 MIRROR CURRENT SOURCE E 3352 2 4313 7350 TDA6111Q VFB 2K7 GND_RGB MIRROR MIRROR I328 +3V 3V3 3 VIN 3V3 1 VIP DIFFERENTIAL STAGE GND_RGB H 7 140V VOC 8 162V IOM 5 13V3 B1 G I347 +12A1 12V7 33n VDDL 2 2356 4 4315 GND_RGB VCN B 680p MIRROR CURRENT SOURCE GND 4n7 1K0 MIRROR I398 GND_RGB V BIAS 2352 F GND_RGB 2353 GND_RGB 3355 +200A 4314 * GND_RGB GND_RGB 0077 B - AMPLIFIER 9 139V 6 VDDH 2K2 33n GND_RGB 2340 I329 +12A1 2346 I397 120K 8p2 3353 3354 3329 4 2341 470R * * VDDL GND_RGB GND B G G B1 MIRROR GND_RGB E 3V4 I313 F 680p IOM 5 5V 3V4 ATSC 12P 12P 12P 2K7 3K3 3K3 2K7 2K7 3K3 2343 VOC 8 158V5 1K0 100n I344 3V3 1 VIP 4n7 3328 100R 9304 +3V +12A 7353 BC847B C HD 10P 10P 10P 330P 2K2 2K7 2K7 2K2 2K2 2K7 I394 3V3 3 VIN 2334 Item No. 2335 2337 2341 2369 3338 3339 3342 3343 3353 3354 VCN 7129V V BIAS 22p E D 4312 MIRROR 100n Deflection Controller - ATSC * * 100n I383 2339 F335 3326 I382 VFB 3324 VDDH F334 2K7 R-CRT G-CRT B-CRT F336 CUT OFF 22p Deflection Controller of Trident Panel Or To 1404 Of C 1 2 3 4 5 2336 33n GND_RGB GND_RGB 3342 1340 470R From 1202 of 2358 C 100n H F348 MULTIPLE BOARD 11NC : 3139_123_5945 SINGLE BOARD 11NC : 3139_123_5946 GND_RGB F_15060_033.eps 180305 3139 123 5946.1 1 2 3 4 5 6 7 8 9 10 11 0069 A9 0077 F7 0078 C9 1340 C1 2330 A4 2331 C4 2332 B5 2333 B9 2334 E2 2335 A5 2336 C8 2337 C5 2338 A9 2339 C9 2340 F9 2341 F3 2343 D9 2344 E5 2346 E8 2352 G3 2353 F8 2355 A3 2356 H5 2358 D3 2360 D2 2369 B9 3317 B9 3320 B4 3321 A3 3322 A3 3323 D4 3324 C3 3326 C3 3327 D2 3328 E2 3329 F2 3337 A6 3338 A5 3339 B5 3340 B4 3341 C6 3342 D5 3343 C5 3344 E4 3352 F4 3353 F3 3354 F3 3355 G3 4311 C8 4312 D9 4313 F8 4314 F8 4315 H5 6307 C9 6308 B9 7330 A5 7340 D5 7350 F3 7351 A4 7352 C4 7353 E2 9301 B9 9302 B3 9303 D3 9304 E1 F332 A2 F334 C2 F335 C2 F336 C2 F337 D2 F348 H5 I309 A4 I310 A3 I311 C4 I313 E2 I328 G3 I329 F3 I342 B9 I344 E2 I346 E9 I347 G9 I382 C3 I383 C3 I384 D2 I389 A5 I390 A6 I391 B9 I392 B5 I393 C7 I394 D9 I395 C5 I396 E5 I397 F4 I398 F7 I399 A3 46 5 6 7 8 9 10 ROTATION & SCAVEM I360 0087 HEATSINK 3364 560R 100n 3363 2384 200V 47u 2363 1K5 4362 E 7332 125V BC327-40 I386 I367 3365 4K7 125V B 100n B 22R 120V3 270R 3374 5K1 B 0V3 7333 BC337-40 3370 560R E 0V ROTATION 10u +12V_SVM I315 I371 3368 E 3396 I387 +12V_SVM 1K8 6334 GND_RGB * * 10R GND_RGB D 3369 150K I316 7366 TDA8941 1 VCC 3384 330K 3380 OUT- 7 8V1 I380 4V 5 IN- 33K F381 18K GND_RGB BZX384-C3V3 GND_RGB GND_RGB 3381 C 5V3 * 220p 7364 KTD600K E 2V8 2390 120K B 3V1 I320 0V8 B 3399 3392 3367 22R 470p 7365 BC847B C C 52V2 3311 100n 150R 2365 2370 E * 1362 3 2 1 10n * 0V 2387 100n 3378 1K0 3383 47K 220p 3379 E 7V4 2393 I325 2391 1K8 B 6V4 4n7 GND_RGB 3377 3309 GND_RGB 220R 47K I326 I364 7331 BC847B C For ATSC * F362 C 2V8 3398 2392 * I365 100n 3394 C D * 5V3 B 2385 I370 100n 9393 1 2 3 I317 56R 7362 5V1 E BC857B +12V_SVM 120K 3366 10R * I369 3393 2368 1N4148 6362 9322 For HD 1361 * * F361 9323 * I375 A C 52V2 470p 2364 6361 BAV99 C B3 ATSC 4n7 4n7 680P 220p(30PW) 68k 68k 2K2 4K7 330R 22K 33K Jmp HD 470P 470P 220p 120k 120k 560R 1K5 68R 33K 18K 330K 4K7 56R - B 5361 GND_RGB GND_RGB E 5V2 I362 3362 6363 BAV99 4K7 3395 7361 BC847B 6V B C 121V I314 11 7363 KTB631K 3310 I366 13V C I361 E 121V 270R 2361 2381 B 47n 50V 3397 3361 560R 8K2 3382 For ATSC Only 100n 2382 1u0 I368 2383 5362 +12V_SVM 3371 A Item No. 2364 2365 2383 2393 3366 3367 3371 3373 3378 3380 3381 3384 3385 3393 9393 SCAVEM 560R +141V 3373 2R7 * I321 3R3 B3 4 7. 3V9 3 IN+ F382 OUT+ 2 4V1 * GND_RGB GND_RGB 1381 1 2 3 TO ROTATION COIL CRT Panel: Rot. & SCAVEM (Multi Board) 1 2 3 L05.1U AA TO SCAVEM COIL Circuit Diagrams and PWB Layouts E GND_RGB Vcc F 4 MODE F STANDBY/ MUTE LOGIC 20K I319 SVM_ROT 4363 GND_RGB G GND_RGB 100n 2367 4K7 GND 8 3372 150K GND_RGB GND_RGB 20K * 9325 SHORT CIRCUIT AND TEMPERATURE PROTECTION SVR I381 6K8 3385 G 3350 B1 5V5 6 100n 2389 GND_RGB GND_RGB GND_RGB GND_RGB GND_RGB H H F_15060_034.eps 180305 3139 123 5946.1 1 2 3 4 5 6 7 8 9 10 11 0087 A8 1361 C11 1362 C11 1381 E11 2361 B6 2363 A6 2364 B6 2365 D6 2367 G6 2368 C6 2370 E7 2381 B5 2382 B3 2383 C9 2384 A7 2385 D7 2387 E4 2389 G7 2390 D9 2391 D3 2392 D2 2393 E2 3309 D3 3310 B7 3311 C7 3350 G5 3361 B4 3362 C5 3363 A7 3364 A7 3365 B7 3366 C7 3367 C7 3368 D7 3369 D8 3370 D7 3371 C8 3372 G8 3373 A4 3374 C10 3377 E4 3378 D3 3379 E2 3380 E6 3381 E6 3382 B4 3383 E2 3384 E6 3385 G5 3392 C8 3393 C5 3394 D7 3395 B2 3396 E5 3397 B5 3398 D2 3399 C9 4362 A2 4363 G2 5361 B8 5362 B2 6334 E5 6361 B3 6362 C4 6363 B2 7331 D2 7332 A7 7333 D8 7361 B5 7362 C4 7363 B8 7364 C8 7365 D4 7366 D8 9322 C2 9323 B8 9325 G3 9393 C5 F361 B8 F362 C8 F381 E10 F382 E10 I314 B8 I315 D8 I316 D8 I317 C9 I319 F8 I320 D7 I321 A4 I325 D3 I326 D2 I360 A7 I361 B4 I362 C5 I364 D6 I365 C7 I366 B7 I367 B6 I368 A8 I369 C7 I370 D4 I371 D7 I375 C5 I380 E7 I381 G6 I386 B4 I387 E6 Circuit Diagrams and PWB Layouts L05.1U AA 7. 47 Layout CRT Panel (Top Side) (Multi Board) 0069 0077 0078 0087 1335 1336 1340 D3 F5 E6 B5 C4 E1 E2 1351 1354 1355 1361 1362 1381 2313 A2 D2 C2 A6 A6 B1 D5 2317 2319 2320 2321 2324 2338 2339 3139 123 5946.1 D1 D4 C4 C4 D1 E5 E4 2340 2347 2363 2368 2381 2390 3305 E3 E3 A4 A5 B3 B1 A2 3306 3307 3308 3317 3331 3332 3333 A2 A1 C1 E3 D4 D3 D5 3334 3335 3336 3337 3341 3344 3345 D4 E3 D3 E4 E5 F5 C4 3347 3350 3351 3352 3362 3367 3371 D1 A2 C5 E5 B4 B4 A6 3373 3374 3391 3393 3399 5303 5304 Layout CRT Panel (Bottom Side) (Multi Board) A3 B1 C1 A4 A5 B2 C4 5308 5324 5361 6325 7330 7332 7333 B2 C4 B5 F4 E3 B5 B4 7340 7350 7363 7364 7366 9301 9302 E5 E4 B5 B5 A1 E4 F1 9303 9304 9306 9308 9309 9310 9322 F2 E3 A2 C1 F3 D3 A3 9323 9324 9325 9328 9330 9331 9332 B5 B4 C5 C4 B2 A2 A2 9333 9334 9335 9336 9337 9393 F3 F2 C1 F4 F4 A4 F_15050_032.eps 140305 2330 2331 2332 2333 2334 2335 2336 2337 F5 F5 E3 D3 F4 E3 E4 F2 2341 2343 2344 2346 2352 2353 2355 2356 E3 D2 E1 E2 E2 E3 E5 E3 2357 2358 2360 2361 2364 2365 2367 2369 C2 F5 E5 B4 B3 B3 A6 E3 3139 123 5946.1 2370 2382 2383 2384 2385 2387 2389 2391 A6 B4 A1 A3 B2 A4 A6 B4 2392 2393 3309 3310 3311 3320 3321 3322 A4 A4 B4 A2 B2 F5 E5 F6 3323 3324 3325 3326 3327 3328 3329 3338 F5 E5 E3 F5 E5 F5 F4 E3 3339 3340 3342 3343 3353 3354 3355 3357 E3 E3 E1 F2 E3 E2 E2 C6 3361 3363 3364 3365 3366 3368 3369 3370 B4 A3 A3 A3 A3 B3 A6 B3 3372 3377 3378 3379 3380 3381 3382 3383 B6 A4 A4 A4 B6 A6 A4 B4 3384 3385 3390 3392 3394 3395 3396 3397 B6 A5 D3 A2 B2 B3 B5 B4 3398 3999 4311 4312 4313 4314 4315 4321 A4 C5 E4 D1 E2 D3 E3 E3 4362 4363 5362 6307 6308 6331 6332 6333 B4 E5 B4 E4 E4 D3 E4 D2 6334 6361 6362 6363 7331 7351 7352 7353 B6 B3 B4 B3 B4 F5 F5 F4 7361 B4 7362 A4 7365 A4 F_15050_033.eps 210305 Circuit Diagrams and PWB Layouts L05.1U AA 7. 48 Side AV + HP Panel (PV2) 1 2 3 4 5 6 1 2 3 4 5 8 9 10 Video_Gnd 3159 75R 1 2175 1250-C * I155 4 1277-B * * 2178 470pF 1279 I162 2176 3 3157 470pF for 2X10W from 1902 B 2 I163 * 7 3 2 1 I171 8 9 C 1250-B 330p 2171 150R 2u2 50 47K 2180 * F150 D 9180 F151 E_14480_037.eps 040305 3139 123 5718.1 1 TO ECO SUB I169 * 3151 3150 RES 2174 SG03 5 6 * 2172 RES I152 LEFT D 2173 SG04 7 9152 1250-A 4 RES 9 9175 * F154 TO SPEAKERS 3153 8 3152 RIGHT * for 2X5W from 1280 2u2 Video_Gnd C F152 5 2181 * SG11 SG09 1 1277-A SG10 Video_Gnd Video_Gnd I168 1u 3 Video_Gnd 3156 4 3 2 1 I170 6 39K 2 SG08 VIDEO IN BZX79-C6V8 SG02 Video_Gnd 6161 B 7 6 5 4 3 2 1 F153 5 4 3 2 1 1278 1232 I166 1254 from Main Chassis 1252 3160 100R Features & Connectivities I157 From Main Chassis 1207 75R Video_Gnd 3161 SG01 75R 9181 3155 4180 * A HEADPHONE 100R 1251 LAP5100-1411F 3154 D 3158 A * 7 SIDE AV PANEL + HP PANEL D * 6 2 3 4 5 6 7 8 9 10 1232 A9 1250-A C1 1250-B D1 1250-C C1 1251 A2 1252 B5 1254 B6 1277-A C1 1277-B D1 1278 A10 1279 B10 2171 D4 2172 C4 2173 C3 2174 D3 2175 C4 2176 B8 2178 B8 2180 D4 2181 C8 3150 D3 3151 D3 3152 C3 3153 C3 3154 B2 3155 A2 3156 B8 3157 B8 3158 A3 3159 A4 3160 B4 3161 C8 4180 A2 6161 B3 9152 D3 9175 C4 9180 D4 9181 A3 F150 D4 F151 D4 F152 C4 F153 B4 F154 B7 I152 D3 I155 C3 I157 B3 I162 B7 I163 C8 I166 B7 I168 B8 I169 C8 I170 B10 I171 B10 SG01 A3 SG02 B3 SG03 D3 SG04 C3 SG08 B4 SG09 B4 SG10 B4 SG11 B4 Circuit Diagrams and PWB Layouts L05.1U AA 7. 49 Layout Side AV + HP Panel (PV2) (Top Side) 1232 1250 1251 1252 A4 A3 A2 A1 1254 1277 1278 1279 A3 A2 A4 A4 2171 2172 2173 2174 A1 A2 A3 A2 2175 2180 3150 3151 A2 A1 A2 A2 3152 3153 3154 3155 A3 A3 A1 A1 3156 3157 3158 3159 A4 A4 A1 A1 3160 6161 9152 9175 A1 A1 A3 A2 9180 A1 9181 A1 E_14480_038.eps 100204 3139 123 5718.1 Layout Side AV + HP Panel (PV2) (Bottom Side) 2176 A1 2178 A1 2181 A2 3161 A2 4180 A3 2181 3139 123 5718.1 E_14480_039.eps 100204 Circuit Diagrams and PWB Layouts Side AV + HP Panel (FL13) 1 2 D L05.1U AA 3 4 7. 50 5 6 7 8 9 10 11 SIDE AV PANEL + HP PANEL (FL13) D A AUDIO_AMPLIFIER A 1251 YKF51-5304 1 3159 4 100R 75R 3158 SG01 B 3 HEADPHONE B 2 * RIGHT I155 SG11 470p F154 2178 5 4 3 2 1 TO SPEAKER 4 2 1279 3157 2176 I162 100n 3 7 C TO ECO SUB 8 I163 820R I171 3 2 1 9 I169 9175 RES D 3153 8 330p 47K 2172 330p 2173 SG04 22K 9 1280 9152 To Main Chassis 1682 1 2 3 7 RES 1250-A F152 2u2 * Video_Gnd * 2175 I168 2181 * * 1250-C 3152 D 1277-A SG10 SG08 SG09 Video_Gnd Video_Gnd 1 I170 39K 3 Video_Gnd 7 6 5 4 3 2 1 3156 820R 3161 2 BZX79-C6V8 6161 SG02 VIDEO IN F153 5 4 3 2 1 1278 1232 6 1u 1252 100R Features & Connectivities 3160 I166 1254 from Main Chassis 75R I157 Video_Gnd from Main Chassis 1207 OF C for 2X5W from 1280 Video_Gnd for 2X10W from 1902 1 Video_Gnd 5 3154 7 4180 6 E E 1281 I152 LEFT 5 * 1 2 3 F150 330p 47K 2171 1250-B * From 0345 of Top Control (FL13) 2u2 50 3150 330p 2174 SG03 4 1277-B 2180 22K 6 * * 3151 9180 RES F151 F F F_15050_056.eps 160205 3139 123 5823.1 1 2 3 4 5 6 7 8 9 10 11 1232 B10 1250-A E2 1250-B F2 1250-C D2 1251 B1 1252 C6 1254 B7 1277-A D1 1277-B F1 1278 B11 1279 C11 1280 E10 1281 E10 2171 F4 2172 E4 2173 E3 2174 F3 2175 D4 2176 C9 2178 C9 2180 E4 2181 D9 3150 F4 3151 E4 3152 E4 3153 D4 3154 C3 3156 B8 3157 C8 3158 B4 3159 B4 3160 C4 3161 D9 4180 C3 6161 C3 9152 E3 9175 D4 9180 F4 F150 E5 F151 F4 F152 D5 F153 C5 F154 C7 I152 E3 I155 D3 I157 C3 I162 C8 I163 C9 I166 B7 I168 B9 I169 D9 I170 B10 I171 C10 SG01 B3 SG02 C3 SG03 F3 SG04 E3 SG08 C4 SG09 C4 SG10 C4 SG11 C5 Circuit Diagrams and PWB Layouts L05.1U AA 7. Layout Side AV + HP Panel (FL13) (Top Side) 51 Layout Side AV + HP Panel (FL13) (Bottom Side) 1232 1250 1251 1252 1254 1277 1278 1279 1280 1281 2171 2172 2173 2174 2175 2180 3150 3151 3152 3153 3154 3156 3157 3158 3159 3160 6161 9152 9175 9180 B2 D2 E2 E1 B2 D2 A1 A2 A1 A2 D1 C1 C1 D2 C1 D1 D1 D1 C1 C1 E2 B2 C2 E1 E1 E1 E1 C1 D1 D1 2176 2178 2181 3161 4180 2181 3139 123 5823.1 F_15050_057.eps 160205 3139 123 5823.1 F_15050_058.eps 160205 C2 B1 C2 C2 E1 Circuit Diagrams and PWB Layouts L05.1U AA 7. 52 Top Control Panel (PV2) 1010 A1 1011 B3 1012 B3 3011 A2 3012 A2 3013 A3 1013 B2 1014 B2 3010 A2 Top Control Panel (FL13) 3014 B3 3015 A3 3016 B3 1 E 0345 A4 1701 B1 1702 B1 I013 A3 I017 B3 I018 A3 F011 A2 F012 A3 I011 A2 1703 B2 1704 B2 1705 B2 3008 B2 3010 B2 3011 B1 3013 B1 3014 B1 3999 C3 9000 C3 9001 C3 9002 C4 1 2 3 TOP CONTROL (PV2) F007 C4 I103 A3 I105 B1 2 I109 B1 I106 B2 I107 B2 I108 B2 3 4 TOP CONTROL (FL13) P E F001 A3 F002 A3 F006 C3 P 0345 S3B-EH F001 1 2 3 I103 F002 A KEYBOARD TO LSP From 1281 Of A 1010 1 Side AV Panel + HP Panel (FL13) F011 1704 1703 I109 I108 I106 I107 910R 3008 B B C I017 1K5 3010 2K 3011 3014 * SKQNAB volume- 3K3 3015 3016 I105 * B I018 1012 * SKQNAB volume+ 3014 F012 1011 SKQNAB 150R 390R 1K8 JMP 820R JMP 200R 430R 2K2 200R 820R 120R 1014 3011 3012 3013 3014 3015 3016 SKQNAB L04 1013 B ITEM L03SS * 3013 * I013 channel- 3012 * I011 channel+ 3011 RES 3010 HERCULES 1705 A 3 1702 KEY_PROTN 3013 2 5K1 A OF 1701 FROM 1682 9000 9001 C 9002 GNDESD F006 F_15050_040.eps 160205 3139 123 5714.1 1 2 3 F007 2K2 3139 123 6066.1 1 3999 2 3 F_15050_034.eps 150205 4 Circuit Diagrams and PWB Layouts Layout Top Control Panel (PV2) (Top Side) F_15050_041.eps 150205 7. 53 Layout Top Control Panel (PV2) (Bottom Side) 1010 1011 1012 1013 1014 3139 123 5714.1 L05.1U AA 3010 3011 3012 3013 3014 3015 3016 A1 B1 C1 A1 A1 3139 123 5714.1 F_15050_042.eps 150205 A1 A1 A1 B1 B1 B1 C1 Circuit Diagrams and PWB Layouts L05.1U AA 7. 54 Layout Top Control Panel (FL13) (Top Side) 0345 A7 1701 A1 1702 A3 1703 A7 1704 A5 1705 A4 F_15050_035.eps 150205 3139 123 6066.1 Layout Top Control Panel (FL13) (BottomSide) 3008 A1 3010 A3 3139 123 6066.1 3011 A4 3013 A6 3014 A7 3999 A6 9000 A4 9001 A4 9002 A3 F_15050_036.eps 150205 Circuit Diagrams and PWB Layouts L05.1U AA 7. 55 Front Interface Panel (FL13) 1 4 J * 3 1 4K7 FRONT CONTROL * I121 6101 * FOR ITV ONLY 3112 OUT GND I112 220R * I111 A 100n I109 I110 9111 B 1K2 1 2 I108 3 4 5 6 3111 FROM 1693 OF * 220u 25V 2103 I107 1693 2101 3113 2 6102 TSOP34836 VS B * LTL-10234WHCR I120 3 FRONT INTERFACE PANEL LATAM 100V - 250V NAFTA 110V EUROPE 220V - 240V AC MAINS INPUT RES 1231 T4.0AE 5 1211 A I012 1 2 I001 110V/220V 2 4 1 2 4 I013 1 3 I014 1505 1 2 From 1505 OF POWER SUPPLY I002 9002 RES 4001 B B +6V C 6692 TSOP1836 3 1 3115 +6V 4 4 OR FROM 1693 OF FRONT CONTROL 5 6 GND I009 220R 6691 I008 1 2 C 100n FOR ITV ONLY 2691 9695 I004 330R 3691 I006 10u 50V 2698 3 3 VS OUT I007 LTL-10224WHCR I010 L01 USA ONLY I015 I011 7691 RES 1606 POWER I016 D 4601 D 47n 2 2 2 3693 3696 3139 123 5982.1 C 1 680K 2692 F_15050_043.eps 150205 FROM 1693 OF FRONT CONTROL I005 LTR-301 1693 6693 10K 1 A SDKVE30100 3694 3 5 6 I003 1u0 6103 LTR-301 680K 2102 9112 3114 C I119 6 J 9001 1109 7101 BC547B 4 RES A J 2 3M3 FRONT INTERFACE PANEL (FL13) 1109 B3 1693 B1 2101 B4 2102 C2 2103 B4 3111 B3 3112 B3 3113 A3 3114 C2 3115 C2 6101 B2 6102 A4 6103 C2 7101 C2 9111 B3 9112 C2 I107 B2 I108 B1 I109 B2 I110 B2 I111 B3 I112 B4 I119 C2 I120 B2 I121 B2 3M3 3 3500 J 2 3501 1 Front Interface Panel (PV2) 3697 10K F_15050_046.eps 150205 3139 123 5722.1 1 2 3 4 1211 A1 1231 A3 1505 A4 1606 D3 1693 C1 2691 C4 2692 D2 2698 C4 3500 A2 3501 B2 3691 C3 3693 C3 3694 B4 3696 D2 3697 D2 4001 B3 4601 D2 6691 C3 6692 B4 6693 D2 7691 D2 9001 A3 9002 B3 9695 C3 I001 A2 I002 A3 I003 B3 I004 C1 I005 C1 I006 C1 I007 C3 I008 C1 I009 C4 I010 C1 I011 D3 I012 A2 I013 A4 I014 A4 I015 D1 I016 D2 Circuit Diagrams and PWB Layouts L05.1U AA 7. 56 Layout Front Interface Panel (FL13) (Top Side) Layout Front Interface Panel (FL13) (Bottom Side) 1109 1693 2101 2102 2103 3111 3112 3113 3114 3115 6101 6102 6103 7101 9111 9112 9162 9163 B1 A2 A1 A2 A1 A1 A1 A1 A2 A2 A1 A1 A1 A1 A1 A1 A1 A2 I107 I108 I109 I110 I111 I112 I119 I120 I121 3139 123 5982.1 3139 123 5982.1 F_15050_044.eps 150205 F_15050_045.eps 150205 A2 A2 A2 A2 A2 A2 A2 A1 A1 Circuit Diagrams and PWB Layouts L05.1U AA 7. 6693 A4 9001 C1 9695 B3 9696 A3 57 Layout Front Interface Panel (PV2) (Top Side) 1211 D1 1231 C3 1505 A1 1606 D4 3139 123 5722.1 1693 A3 2691 A4 2698 A3 3500 B2 3501 B3 3691 B3 3693 B3 3694 B3 Layout Front Interface Panel (PV2) (Bottom Side) 6691 B4 6692 B4 9002 D2 9685 B3 F_15050_047.eps 150205 2692 A2 3696 A2 3139 123 5722.1 3697 A2 4001 A1 4601 A2 7691 A2 F_15050_048.eps 150205 Circuit Diagrams and PWB Layouts L05.1U AA 7. 58 Deflection Controller - ATSC 5 6 7 8 9 10 11 DEFLECTION CONTROLLER - ATSC K1 7423 LM2941SX F_Pb 3456 100R 3 3409 120K 24K 3501 24K 2K0 3502 24K 3500 3482 2466 3483 10K 1n0 10n 2431 8 47n 150K 2418 3429 2430 C 11 100n 100n 2437 FBP EWFILTER LVP CENTER 10 14 F449 23 D DAC_9V 22 20 VREF DAC 7417 BC847B 2 3473 3440 F432 2K0 7407 BC857B GNDA F433 GNDD 11 1K0 100n 3435 7405 BC847B 2448 CENTER_OUT BEAM_INFO VP_OUT 33K 3474 6K8 E EW_DRIVE F447 7408 BC847B VM_MOD 2445 1 I439 1K0 6 7414 BC857B 7413-2 IMX1 10K 3432 10K 6404 DAC_9V BZX384-C9V1 I446 270R 6403 3417 2K2 3K3 100R F418 F 3463 68K 3468 3466 4 100R 6 IMT1A 7420-1 4 68K 6 BC857B 7418 2 5 1 2 G 3 6 3 5 3467 7413-1 IMX1 5 2 1 +9V 7421-1 IMX1 3 6 2 68K I440 7412-2 IMX1 I442 3489 BZX384-C8V2 2 IMT1A 7419-2 100n 3488 4 3 2447 5 1 3485 1u0 1K0 3459 I451 3 5 7420-2 IMT1A 100R 3457 7412-1 IMX1 3476 RGB Amplifier 1404 1 2 3 4 5 4 IMT1A 7419-1 100R 20K 6410 +9V I437 +9V 20K To 1340 Of BZX384-C9V1 100n 3434 4 7421-2 IMX1 1 I464 F_15060_014.eps 140305 3139 123 5976.1 1 2K0 3503 2461 10R 100n 470u 16V 2408 2407 47u 16V 5401 3201 330K 2405 22uF 16V 3461 2K2 3401 1u0 BZX384-C8V2 2402 3411 82K 6400 F441 VDRA 4 9 12 19 25 27 1 2 3 4 5 6 7 HFB 8 9 10 F437 12 F445 SCL SDA 1 F434 1u0 6 3469 3408 390K EHT_info 100n 100n 2426 100n 2425 1u0 2424 100n 2436 EW_PWM H_DF 17 16 1K0 I426 F430 2458 10p 2459 10K 21 DAC_9V F421 2446 RGB_VCC 3458 EW_FD 15 10K FBP 3481 3455 13 V_DF DAC_9V F431 1u0 1K0 2457 10p 2456 10K 3453 1K0 3454 220R AGC F450 2K0 68K 1u0 2455 3452 RGB_VCC G F448 BAS316 3484 3431 3477 F428 I427 I429 NC 5 1251 F444 VDRB F426 1K0 3449 BC857B 7411 6408 EW_FB I454 K2 3478 3451 100R 30 6 Features & Connectivities F443 BLK_OUT 18 100n I425 3447 10p 2454 3448 10K 3450 220K 2423 31 75 I2L_VDD F425 1K0 220R VRAMP 24 10n I424 BC857B 7410 VDRIVE 1u0 K2 100n 55 41 RGB_VCC F VDC TC 29 To 1251 Of 4K7 33K 3446 100R F422 20K BLK 3K9 100n 2444 1K0 3422 I450 1u0 2432 4K7 F_Pr 2429 22n 3420 F435 3427 2442 Φ DEFLECTION PROCESSOR 100n 2443 3479 3445 220R 100R F436 7404 TA1317AFG VIN 28 B VGUARD 10K V_NF 26 I453 3475 BC857B 7409 2460 7403 BC847B 7 2n2 4400 I433 75R F423 2428 3421 20K 3471 3430 VP_IN EHT F442 3424 3472 2441 3480 3460 220R I432 470n 3415 100n 2422 R_SH G_SH B_SH F451 F452 F453 I452 100R R2_IN G2_IN B2_IN R1_IN G1_IN B1_IN 2435 4 6 7 3416 DAC_9V I415 I431 7416 BC847B 3 2419 18 19 21 58 49 39 40 50 8 52 I463 I418 I419 I420 I421 I422 I403 I449 3410 VCC 3414 100n 470n 2421 3418 100K 2427 24 25 26 53 F440 220K 2u2 F455 100R 3470 EW_FLT 38 10 +9V COLOUR_LIMITER SCP_IN FBP_IN H_CURVE_CORR HD_IN IK_IN VD_IN DAC_9V 120K 1u0 3437 DEF_DAC_GND RGB_GND 470R 3439 180R 3436 Y_C_VCC 45 RGB_VCC 7406 BC847B I430 E H_FREQ_SW1 H_FREQ_SW2 2414 3464 33K I462 3K3 A F419 +9V BAS316 I410 70 64 71 66 67 60 61 3413 3462 150K CR1_PB1_IN CB1_PB1_IN CR2_PR2_IN CB2_PB2_IN F410 2416 1 ON_|OFF ADJ GND 3412 DAC_9V 2415 2 F404 5 OUT DAC_9V F438 Features & Connectivities 2u2 10n 3442 VSM_FILTER VSM_OUT CP_OUT HVCO VP_OUT 1 2 3 To 1257 Of K2 AFC_FIL I409 1400 100R 100n 78 44 74 F406 F408 2u2 2433 3441 1K2 3433 +9V 57 77 47 42 35 F415 80 1 2 100R 3487 F_Y 2u2 2434 100n 2453 I461 1402 3K3 D R_SH G_SH B_SH 100n 2412 F407 33K 10K I460 2438 3426 SYNC_OUT DAC1 DAC2 ABC_PULSE I408 ABL 2439 2K7 23 100n 2410 330p 3444 10K 3425 34 ANA_OSD_R ANA_OSD_G ANA_OSD_B I407 I467 3486 VIN 6406 I466 I468 BZX384-C6V8 2452 I458 R_OUT G_OUT B_OUT H_OUT 68 63 2409 UOC_SCL UOC_SDA 68K 3423 DAC_9V 3419 16 12 13 14 37 I411 I412 I413 I414 ANA_R ANA_G ANA_B SYNC_IN 10K 1K0 6405 R_OUT G_OUT B_OUT H_DRV BHP_FILTER LIGHT_AREA_DET_FIL DARK_AREA_DET_FIL 3404 100n 3443 C ABCL_IN AFC_FILTER APL_FILTER 10K 3407 I406 1u0 2451 10n 2420 1m0 16V 2465 10R NC 79 100n 2450 3203 YS1 YS2 YS3 BAS316 10K 30 28 2449 +9V Y1_IN Y2_IN I2L_GND 5403 YM P_MUTE BLK Y_C_GND 2413 10R 10n B 470u 16V 2464 3202 SCL SDA 6402 F454 3403 7402 TA1360AFG-EL 27 +9V Φ 65 5402 3 5 9 11 15 17 20 22 29 32 33 36 43 46 48 51 54 56 59 62 69 72 73 76 DEP_DAC_VCC 10n 2406 10R 470u 16V 2463 3200 565K7 +9V F405 5400 100n F403 I402 I401 4402 4 +10V 1 2 3 Auxiliary Power Supply 220K 2K2 DAC_9V 2403 2.0V 6407 BZX79-C2V7 6409 A BZT52C2V7S 6401 F439 RGB_VCC 3438 270R DAC_9V 7415 BC857B 1405 To 1535 Of DAC_9V 3402 3428 270R F400 2K7 270R 3405 4K7 270R 3400 DAC_9V 20K 3406 3465 3507 24K 4 2462 47u 16V 3 6K8 K1 2 10u 16V 1 2 3 4 5 6 7 8 9 10 11 1251 C11 1400 A7 1402 D2 1404 F4 1405 A9 2402 A8 2403 A4 2405 A8 2406 A2 2407 B9 2408 B9 2409 B4 2410 B4 2412 B4 2413 B2 2414 B6 2415 B4 2416 B5 2418 B8 2419 C8 2420 C2 2421 C5 2422 C5 2423 C5 2424 C5 2425 C6 2426 C6 2427 C4 2428 C8 2429 C8 2430 C10 2431 C10 2432 C8 2433 G6 2434 G5 2435 D5 2436 D6 2437 D6 2438 D2 2439 G5 2441 D4 2442 D5 2443 D4 2444 D5 2445 F10 2446 E4 2447 F8 2448 E8 2449 E4 2450 E4 2451 E4 2452 E5 2453 D2 2454 F2 2455 F3 2456 G2 2457 G3 2458 G3 2459 G2 2460 E3 2461 A10 2462 A11 2463 A2 2464 B2 2465 C2 2466 B11 3200 A2 3201 A9 3202 B2 3203 C2 3400 A1 3401 B8 3402 A6 3403 A4 3404 A5 3405 A1 3406 A1 3407 A4 3408 A7 3409 A8 3410 B8 3411 A7 3412 B8 3413 B5 3414 B8 3415 C5 3416 C7 3417 F9 3418 C4 3419 D1 3420 C8 3421 C7 3422 C7 3423 C2 3424 B10 3425 D2 3426 D1 3427 D6 3428 D7 3429 B10 3430 E3 3431 D4 3432 F10 3433 D1 3434 F10 3435 E8 3436 E2 3437 E7 3438 E7 3439 E2 3440 E7 3441 D2 3442 D2 3443 E4 3444 E5 3445 F2 3446 F2 3447 F3 3448 F1 3449 F3 3450 G2 3451 G2 3452 G3 3453 G1 3454 G3 3455 G2 3456 G2 3457 G3 3458 G1 3459 G3 3460 E2 3461 A8 3462 G6 3463 F7 3464 F6 3465 F7 3466 G7 3467 F7 3468 G8 3469 A7 3470 B7 3471 E2 3472 D10 3473 E10 3474 E10 3475 F8 3476 F8 3477 F5 3478 G5 3479 F4 3480 G4 3481 G4 3482 A10 3483 B10 3484 D8 3485 G4 3486 A6 3487 A6 3488 F9 3489 F9 3500 A11 3501 A11 3502 A11 3503 B11 3507 A1 4400 F8 4402 A6 5400 A2 5401 A9 5402 B2 5403 B2 6400 A8 6401 A2 6402 A7 6403 F10 6404 F11 6405 E5 6406 A8 6407 A2 6408 D8 6409 A2 6410 F9 7402 A3 7403 C7 7404 B9 7405 E7 7406 E2 7407 E7 7408 E8 7409 F2 7410 F2 7411 G2 7412-1 F6 7412-2 F6 7413-1 F7 7413-2 G6 7414 F7 7415 A7 7416 E2 7417 D10 7418 G8 7419-1 F5 7419-2 F5 7420-1 G5 7420-2 F5 7421-1 G4 7421-2 G5 7423 A10 F400 A3 F403 A3 F404 A9 F405 A2 F406 A7 F407 A7 F408 B6 F410 B5 F415 D2 F418 F11 F419 A11 F421 E5 F422 E3 F423 E3 F425 F3 F426 F4 F428 F3 F430 G3 F431 G4 F432 E7 F433 E8 F434 D8 F435 C7 F436 C7 F437 C11 F438 B7 F439 A6 F440 A9 F441 B9 F442 B10 F443 B10 F444 C10 F445 C10 F447 E11 F448 D8 F449 D10 F450 D8 F451 D4 F452 D4 F453 D4 F454 A7 F455 A9 I401 A2 I402 A3 I403 A10 I406 B4 I407 B4 I408 B4 I409 B4 I410 C4 I411 C2 I412 C2 I413 C2 I414 C2 I415 C5 I418 C5 I419 C5 I420 C5 I421 C5 I422 C5 I424 F2 I425 D4 I426 E4 I427 F2 I429 G2 I430 E2 I431 E2 I432 E3 I433 E3 I437 F5 I439 G5 I440 G4 I442 F6 I446 F10 I449 B10 I450 C8 I451 F8 I452 C8 I453 C8 I454 D7 I458 C2 I460 D2 I461 D2 I462 B6 I463 C5 I464 G6 I466 A8 I467 A6 I468 B6 Circuit Diagrams and PWB Layouts L05.1U AA 7. 59 RGB Buffer- ATSC 1 K2 2 3 4 5 6 7 8 RGB BUFFER - ATSC K2 1250 1401 A F480 1 2 Rout_ADC 3 4 Gout_ADC 5 6 Bout_ADC 7 8 To P1254 Of Panel F482 F481 F488 F489 F483 F484 F486 F485 F490 2491 RES 5490 RES 4490 3290 RES 2493 RES 5492 RES 4492 3292 RES 2495 RES 5494 RES 4494 3294 RES RES 5491 RES 4491 3291 RES 2494 RES 5493 RES 4493 3293 RES 2496 RES 5495 RES 4495 3295 RES B 2492 F487 10u 16V 4499 RES 3499 4489 RES 3498 47R 2490 C 4488 A Features & Connectivities 13 I480 3490 RES To 1250 Of B +9V 3497 1 2 3 Rout 4 5 Gout 6 7 Bout 8 9 10 11 12 14 C 7490 BC847B I481 3491 100R I484 D I482 1K0 3494 7491 BC847B 3492 D 100R I485 1K0 3495 7492 BC847B I483 3493 100R I486 5496 F_Y 2487 47p 47p F417 2488 47p RES 2497 75R 3296 3504 1K0 3496 E F409 470n 4496 RES K1 F416 F420 1403 1 2 3 4 5 6 To P1255 Of E Panel 5497 F_Pb 470n 4497 RES F 47p RES 2498 3297 75R 3505 K1 F 5498 F_Pr 47p 47p RES 2499 3298 75R 3506 K1 2489 470n 4498 RES F_15060_015.eps 140305 3139 123 5976.1 1 2 3 4 5 6 7 8 1250 A8 1401 A1 1403 E8 2487 E6 2488 F6 2489 F6 2490 C6 2491 B1 2492 C1 2493 B2 2494 C2 2495 B3 2496 C3 2497 E5 2498 F5 2499 F5 3290 B2 3291 C2 3292 B3 3293 C3 3294 B4 3295 C4 3296 E5 3297 F5 3298 F5 3490 C6 3491 C7 3492 D7 3493 D7 3494 D2 3495 D3 3496 E4 3497 C2 3498 C3 3499 C4 3504 E5 3505 F5 3506 F5 4488 C2 4489 C3 4490 B2 4491 C2 4492 B3 4493 C3 4494 B4 4495 C4 4496 E6 4497 F6 4498 F6 4499 C4 5490 B2 5491 C2 5492 B3 5493 C3 5494 B4 5495 C4 5496 E6 5497 E6 5498 F6 7490 C7 7491 D7 7492 D6 F409 E8 F416 E8 F417 E8 F420 E8 F480 A6 F481 A6 F482 A2 F483 A6 F484 A3 F485 A4 F486 A6 F487 A6 F488 A7 F489 A7 F490 A8 I480 C6 I481 C7 I482 D7 I483 D7 I484 D2 I485 D3 I486 E4 Circuit Diagrams and PWB Layouts L05.1U AA 7. 60 Layout Deflection Controller (Top Side) 1250 1251 1400 1401 1402 1403 1404 1405 2402 2405 2406 2407 C2 C3 B1 C1 C3 C5 A2 B5 C1 C1 B4 C2 2408 2409 2410 2412 2413 2414 2416 2418 2419 2420 2421 2422 B1 B4 B4 B3 C3 C3 B3 B1 B1 A3 B4 B4 2424 2425 2426 2427 2428 2429 2430 2431 2432 2435 2436 2438 A2 B2 B2 B4 B1 B1 B1 B1 B1 A2 A2 B3 3139 123 5976.1 2441 2442 2443 2444 2445 2447 2448 2450 2451 2454 2455 2456 B3 B4 B4 B4 B3 B1 B2 B3 B2 A3 A2 A3 2457 2458 2459 2461 2462 2463 2464 2465 2466 2487 2488 2489 A2 A2 A3 B4 B4 B4 C3 A2 B4 C4 C4 C4 2490 2497 2498 2499 3201 3296 3297 3298 3400 3401 3403 3404 C1 C4 C4 C4 C2 C4 C4 C4 B2 C1 B4 A3 3405 3407 3408 3410 3411 3412 3413 3414 3418 3419 3421 3422 B2 A3 B1 B1 C1 B1 B3 B1 B4 B2 B2 B2 3423 3424 3425 3426 3427 3428 3429 3430 3431 3432 3434 3435 Layout Deflection Controller (Bottom Side) B2 C2 A2 B2 B2 B2 C2 B2 B2 B2 B2 B2 3443 3445 3446 3447 3449 3450 3451 3452 3454 3455 3456 3457 B3 A3 A3 A2 A2 A3 A3 A2 A2 A3 A3 A2 3459 3462 3463 3464 3465 3466 3467 3468 3469 3470 3472 3473 A2 A3 A4 A4 A4 A4 A4 A4 C1 B1 B2 B2 3474 3475 3476 3477 3478 3479 3480 3481 3482 3483 3484 3485 B2 A4 A4 A4 A4 B4 A4 A4 B4 B4 B2 A4 3486 3487 3488 3490 3504 3505 3506 4400 4496 4497 4498 5401 B1 B1 B1 C1 C4 C4 C4 A4 C4 C4 C4 C2 5496 5497 5498 6400 6402 6403 6404 6407 6408 6409 7402 7403 C4 C4 C4 C1 C1 B2 B3 B2 B2 B2 B3 B2 7404 7405 7409 7410 7411 7412 7413 7414 7417 7418 7419 7420 B1 B2 A3 A2 A2 A3 A4 A4 B2 A4 A4 A4 7421 A4 7423 B5 F_15060_016.eps 140305 2403 2415 2423 2433 2434 2437 2439 B3 B2 B3 A3 B3 B3 B3 2446 2449 2452 2453 2460 2491 2492 B3 B3 A3 B2 A2 C4 C4 2493 2494 2495 2496 3200 3202 3203 C5 C5 C5 B5 B2 C3 A3 3139 123 5976.1 3290 3291 3292 3293 3294 3295 3402 C4 C4 C5 C5 C5 C5 B5 3406 3409 3415 3416 3417 3420 3433 B4 B5 B3 B4 B5 B5 B2 3436 3437 3438 3439 3440 3441 3442 A2 C2 C2 C3 B2 B2 B2 3444 3448 3453 3458 3460 3461 3471 A3 B3 B3 B3 A2 B5 A2 3489 3491 3492 3493 3494 3495 3496 B5 C4 C5 C5 C4 C5 C5 3497 3498 3499 3500 3501 3502 3503 C4 C5 C5 B2 B2 B2 B2 3507 4402 4488 4489 4490 4491 4492 B4 B5 C4 C5 C4 C4 C5 4493 4494 4495 4499 5400 5402 5403 C5 C5 C5 C5 B2 C3 A3 5490 5491 5492 5493 5494 5495 6401 C4 C4 C5 C5 C5 C5 B4 6405 6406 6410 7406 7407 7408 7415 A3 B5 B5 A2 C2 C2 B5 7416 7490 7491 7492 A2 C4 C5 C5 F_15060_017.eps 140305 3 2 AD13 CBEb1 PAR STOPb DEVSELb FRAMEb CBEb2 AD18 AD19 AD20 AD21 AD23 AD26 AD27 AD30 AD31 GNTb0 PCICLKOUT1 C R203 10K 0603 5% 5 D ROMSCK 6 C FCEb0 1 S AD0 BootROM_WP# AD4 AD3 CBEb0 disable(default) R204 10K* 0603 DNS 5% AD7 AD11 ROMSO_NFWE# 2 Q 0603 7 HOLD 3 W 8 VCC 10 DAC_Pr DAC_Y DAC_Pb 4 VSS M25P80-VMN6T SO8_wide STBY_3.3V AD10 AD15 X_DAC0 R205 0603 OSD_R OSD_G OSD_B Note: If NAND flash as the bootrom is used, Be careful FCEb0 state. AD14 PERRb UOC_RX UOC_TX STBY_3.3V R207 3.3K 0603 SERRb IRDYb U203 TRDYb NFCLE NFALE ROMSO_NFWE# BootROM_WP# AD17 AD16 CBEb3 FAD0 FAD1 FAD2 FAD3 AD22 AD25 AD24 16 17 18 19 CLE ALE WE WP 29 30 31 32 IO0 IO1 IO2 IO3 13 36 AD28 AD29 REQb0 CE RE R/B SE/GND VSS VSS CS_NF# ROMSI_NFRE# FLASH_READY# 9 8 7 6 R212 2.2K 0603 I2SSCK_OUTA I2SWS_OUTA I2SSD_OUTA I2SMCLK 10 10 10 R213 2.2K 0603 R206 715 0603 5% RP202 33 1 8 2 7 3 6 4 5 44 43 42 41 VCC VCC 12 37 FAD7 FAD6 FAD5 FAD4 R214 10K 0603 5% C204 .1UF 0603 VCXO_INB PWMB AE1 AF1 AE2 AF3 AF2 R/DAC0 G/DAC1 B/DAC2 COMP/DAC3 RSET AD1 AC2 AC1 AD2 C_R/DAC4 Y_G/DAC5 COMP_B/DAC6 R2SET J3 J4 J5 H4 I2SSCK_OUTA I2SWS_OUTA I2SSD_OUTA I2SSOSCK_OUTA I2CCLKA I2CDATA SCL_B SDA_B K2 J2 I2CCLKB I2CDATAB P2 P1 R5 R4 P3 N1 P4 ACSYNC ACBIT_CLK ACDATA_OUT ACDATAI_N1 ACDATA_IN0 ACRESETb ACXTAL_OUT C205 .1UF 0603 I2SSCK_IND I2SSD_IND I2SWS_IND DNS NFCE1# R215 10K* open: 0603 serial flash 5% R216 0603 STBY_3.3V C225 .1UF 0603 10K 5% R240 100 0603 C9 FCLK FAD15 FAD14 FAD13 FAD12 FAD11 FAD10 FAD9 FAD8 FAD7 FAD6 FAD5 FAD4 FAD3 FAD2 FAD1 FAD0 A6 B7 C8 D9 E10 A5 B6 C7 D8 E9 A4 B5 C6 D7 E8 A3 FAD15 FAD14 FAD13 FAD12 FAD11 FAD10 FAD9 FAD8 FAD7 FAD6 FAD5 FAD4 FAD3 FAD2 FAD1 FAD0 FLASH_READY# NFCLE B4 C5 D6 E7 A2 B3 C4 D5 E6 A1 B2 C3 D4 E5 A7 B8 FBE1 FBE0 FALE1 FALE0 FSTB FRDYb FRD FWE FCEb5 FCEb4 FCEb3 FCEb2 FCEb1 FCEb0 FREQb FGNTb C223 5PF* 0603 NFCE1# R248 10K DNS R243 10K 4 A 6 2 S GND DST #1 Molex #2 VCC B0 5 3 ROMSCK B1 1 CS_NF# NC7SB3157P6X_NL 6P_SC70 FAD[15:0] STBY_3.3V Note: If another bus is selected, B0(ROMSCK) must be selected and FCEb0 must maintain high state. FBE1 FBE0 C206 .1UF 0603 U205 X_DAC0 R238 R218 10K 0603 5% 33 0603 1 2 3 4 DST #55 Molex #110 A0 A1 A2 VSS SDA SCL WP VCC NFALE ALE0 5 6 7 8 FRDYb FRD FWE SDA_A SCL_A ROMSI_NFRE# ROMSO_NFWE# CS_POD 55952 CONNECTOR Pin Configuration I2C addres: A0h FCEb0 CAT24FC32W-TE13 8P_SOIC B C207 C208 C209 C210 C211 .1UF 0603 .1UF 0603 .1UF 0603 .1UF 0603 .01UF 0603 RESETb RESETOUTb AG9 AF11 RESETb RESETOUTb PCICLK PCICLKOUT0 PCICLKOUT1 AJ9 AJ10 AH10 R253 R255 AD31 AD30 AD29 AD28 AD27 AD26 AD25 AD24 AD23 AD22 AD21 AD20 AD19 AD18 AD17 AD16 AD15 AD14 AD13 AD12 AD11 AD10 AD9 AD8 AD7 AD6 AD5 AD4 AD3 AD2 AD1 AD0 AH12 AJ12 AG13 AF13 AH13 AJ13 AF14 AG14 AJ14 AG15 AH15 AJ15 AJ16 AH16 AG16 AF16 AG19 AF19 AJ20 AH20 AG20 AG21 AJ21 AF21 AH21 AJ22 AH22 AG22 AF22 AJ23 AH23 AG23 AD31 AD30 AD29 AD28 AD27 AD26 AD25 AD24 AD23 AD22 AD21 AD20 AD19 AD18 AD17 AD16 AD15 AD14 AD13 AD12 AD11 AD10 AD9 AD8 AD7 AD6 AD5 AD4 AD3 AD2 AD1 AD0 CBEb3 CBEb2 CBEb1 CBEb0 FRAMEb IRDYb TRDYb DEVSELb STOPb PAR INTROUTb INTRb2 INTRb1 INTRb0 AF15 AJ17 AH19 AF20 AH17 AG17 AF17 AJ18 AH18 AJ19 AF9 AH8 AJ8 AG8 CBEb3 CBEb2 CBEb1 CBEb0 FRAMEb IRDYb TRDYb DEVSELb STOPb PAR REQb2 REQb1 REQb0 IDSEL SERRb PERRb X210VC I2SSCK_IN I2SWS_IN I2SSD_IN TEST_I2S_MCLK INTRb0 GPIOA2 +5V VCXO_INA PWMA F2 K5 K1 J1 U204 DST #56 Molex #109 G2 G4 SCL_A SDA_A STBY_3.3V 55952-1131 110P_0.635mm Pitch DST #110 Molex #1 XTALIN XTAL_OUT H1 H2 H3 M26 I2SSCK_IN I2SWS_IN I2SSD_IN TP1 T_I2S_MCLK IO7 IO6 IO5 IO4 128Mbit NAND Flash K9F2808UOC-PCB0 48P_TSOP1 RESETOUTb R211 Enable 10K* the access to 0603 the spare area 5% DNS R210 10K 0603 5% R208 3.3K 0603 715 5% F1 G1 XTAL & PLL R201 10K 0603 5% PCI Interface AD8 AD9 AD12 ROMSI_NFRE# C201 .1UF 0603 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 GNTb2 GNTb1 GNTb0 PCICLKOUT3 PCICLKOUT2 USBPA USBNA USBPB USBNB USB_OVRCUR USB AD5 AD6 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 TESTEN UART AD1 AD2 D 110 109 108 107 106 105 104 103 102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 U201A FlexBus +5V STBY_3.3V U202 110 109 108 107 106 105 104 103 102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 R241 R202 100 1M 0603 0603 R258 5% 4.7 0603 Display DAC Y201 26.1621MHz SX-1 C203 12PF I2S P1 12PF 0603 STBY_3.3V 1 The loopback clock line has to be matching length with the length go to other PCI devices I2C +5V C202 STBY_3.3V ATSC1 4 AC-Link 5 TDB RDB FAD4: 0: ROM enable, 1: ROM disable(default) Boot vector FAD(6:5) 00 - MIPS (Default), 01 - X86 Family 10 - SH Family, 11-Strong ARM Family STBY_3.3V C212 C213 C214 C215 C216 .1UF 0603 .1UF 0603 .1UF 0603 .1UF 0603 .01UF 0603 10 RESET# 10 SELF_RST# R256 0603 R250 0603 100 C220 .1UF 0603 X7R,K U206 2 7 1 3 0* DNS C221 .1UF X7R,K 0603 R235 1K 0603 1% RESIN SENSE REF CT VDD RESET RESET GND 8 6 5 4 R219 FAD5 R221 FAD6 R242 FAD7 R223 FAD8 R225 FALE0 FALE0 FBE0 FCEb0 FAD3 NAND_flash 0 1 0 0 M25P80 0 1 1 1 M25P40 1 1 0 1 NFALE R227 DNS FBE0 FBE0 R229 FCEb0 FCEb0 R230 FAD3 FAD3 R233 10K* 0603 10K 0603 10K 0603 10K 0603 2 RP201 1 2 3 4 10K 8 IDSEL 7 GNTb0 6 REQb0 5 RP205 USBPB USBNB USBNA USBPA 1 2 3 4 10K 8 7 6 5 FRAMEb INTRb0 PERRb STOPb 10K 8 7 6 5 R244 10K 0603 R231 10K* 0603 10K* 0603 R234 DNS U207 1 2 3 4 C217 .1UF 0603 X7R,K X_IEC958 R254 RP204 C INTRb0 HDMI_CbCr2 HDMI_CbCr3 AJ11 AF12 AG12 REQb0 HDMI_CbCr6 HDMI_CbCr7 AH14 AF18 AG18 IDSEL SERRb PERRb AF10 AG11 AH11 GNTb0 X_IEC958 AH9 33 AG10R257 R1 R2 R3 T4 T1 SERRb DEVSELb IRDYb TRDYb HDMI_CbCr4 HDMI_CbCr5 0603 VSYNC_DEC USBPA USBNA USBPB USBNB L5 AA3 AA4 PC_TXD PC_RXD FAD13 R220 FAD11 R222 FAD10 R224 FAD9 R226 FAD15 R228 10K 0603 10K 0603 10K 0603 10K* 0603 10K* 0603 DNS B R209 10K 0603 R239 10K 0603 STRAP_ID(4:0) {FAD13, FAD11, FAD10, FAD9, FAD15} 00000 - Reserved 00100 - X210V 00111 - X210VC 33 0603 VDD RO DI GND RI+ RICO+ CO- SN75179B 8P_SOIC 8 7 6 5 R236 1% C218 .1UF 0603 300 X7R,K 0603 R237 100 1% 0603 A MAC LAYERS 200mA,0.4RDC,120R@100M MLB-160808-0120A-N2 FB201 0603 25% SPDIF C219 47PF 0603 RV201 CT0402S14AHSG 0402 F_15060_019.eps 150305 xxxx xxx xxxx.x 5 D DNS 15K 8 7 6 5 +5V RP203 1 2 3 4 HSYNC_DEC C224 5PF* 0603 STBY_3.3V 10K 0603 10K 0603 10K 0603 10K 0603 10K 0603 RESETb LD201 LED_RED 1206 STBY_3.3V 1 2 3 4 SYS CFG FAD(8:7) 00 - SOLO (Default), 01 - Reserved 10 - PEER, 11 - PEER+ FAD4 BootROM Device Selects TL7705BC 8P_SOIC C222 10UF 1206 A R246 10K 0603 5% R249 10K 0603 5% 1 STBY_3.3V PCICLKOUT1 R217 1K 0603 STBY_3.3V +5V R232 5.1K 1% 0603 0603 0603 X210VC 633P_BGA In a Basic module, X210V will be used RESET GENERATOR STBY_3.3V 33 33 4 3 2 1 5 4 3 2 ATSC2 C307 .1UF X7R,K 0603 FB301 0603 MLB-160808-0120P-N2* C319 .1UF* 0603 C322 FDC_IFP C323 FDC_IFN OSC_XTAL_IN C20 OSC_XTAL_O D20 C308 1000PF X7R,K 0603 R303 R319 10K* 0603 R331 C311 X7R,K U301 1000PF* 0603 1 2 3 4 1000PF* 0603 R320 2K* 0603 VCC IF_IN1 IF_IN2 AGC_IN GND IF_O1 IF_O2 SW 8 7 6 5 C313 X7R,K C309 1000PF* X7R,K 0603 .1UF* 0603 .1UF* 0603 R304 200* 0603 R305 200* 0603 LA7795T* 8P_MSOP C315 .1UF* X7R,K 0603 DNS in a BASIC C316 1000PF* X7R,K 0603 715 0603 33 0603 TEST_MODE_M27 XFDC_AGC FDC_CRX FDC_DRX DNS in a BASIC MPEG_D[7:0] RP301 MPEG_D7 MPEG_D6 MPEG_D5 MPEG_D4 MPEG_D3 MPEG_D2 MPEG_D1 MPEG_D0 C FDC_AGC FB1222 MLB-160808-0120A-N2 R306 0603 MPG_CLK MPG_SYNC MPG_DATA_EN XFDC_AGC 1K* 0603 RP302 1 2 3 4 33* 8 7 6 5 1 2 3 4 33* 8 7 6 5 R324 R323 R322 33* 33* 33* TP_ERR DNS in a BASIC C318 .1UF X7R,K 0603 TCLKA TDATA[7:0] DNS in a BASIC STBY_3.3V HW_BIT3 DNS R307 5% 0* 0603 R308 5% 0 0603 HW_BIT2 R309 5% 0 0603 R310 5% 0* 0603 HW_BIT1 B 0* 0603 R312 5% HW_BIT0 0 0603 R313 5% 0* 0603 R314 5% STEP 0 0603 R315 5% 0* 0603 R316 5% 0 0603 DNS in BASIC Schematic H/W BIT R0.7 0.7X 0011 R0.8 0.8X 0100 TSTRTA TVLDA DNS R311 5% DNS Board ADC0_INP ADC0_INN ADC0_REFP ADC0_REFN ADC0_VCM TDATA7 TDATA6 TDATA5 TDATA4 TDATA3 TDATA2 TDATA1 TDATA0 TERA is internal pull-down OSC_XTAL_IN OSC_XTAL_O D19 O_OSC_CLK E12 D13 DAC0_RSET DAC0_OUT M27 E17 B20 TEST_MODE_M27 I2CSLVADDR1 I2CSLVADDR0 E24 E22 H26 H25 E23 ADC1_INP ADC1_INN ADC1_REFP ADC1_REFN ADC1_VCM A19 A18 A20 A17 B17 FS_OUTP FS_OUTN FDC_AGC FDC_CRX FDC_DRX B13 A13 A15 C16 C15 B15 B16 A16 A14 C14 C13 B14 MPEG_D7 MPEG_D6 MPEG_D5 MPEG_D4 MPEG_D3 MPEG_D2 MPEG_D1 MPEG_D0 MPEG_CLK MPEG_SYNC MPEG_DATA_EN MPEG_ERR B1 C1 C2 D1 D2 D3 E1 E2 E3 TCLKA TDATA7 TDATA6 TDATA5 TDATA4 TDATA3 TDATA2 TDATA1 TDATA0 E4 F5 F4 TSTRTA TVLDA TERA D17 C17 P25 NC_D17 NC_C17 NC_P25 P26 P27 P28 P29 SMCLKA SMRSTA SMDETECTA SMDATA GPIOB Group +5V F26 E25 K25 K26 F25 X210VC GPIOC Group 200 0603 AGC_SDMX AGC_SDM1 AGC_SDM2 IR R302 IF_N 200 0603 A21 A22 A23 IDE Interface .1UF 0603 R301 1 LD301 LED_RED 0603 2 R326 220 0603 AGC_SDM1 FAT Interface C305 X7R,K IF_P TP_ERR C302 1000PF 0603 CVBS .1UF 0603 Tuner C301 X7R,K SMVCCA SMRSTS NRSSCLKA POD interface INT_POD R325 1K 0603 TDA RDA R25 T25 M29 TP Pins STBY_3.3V AF7 AG7 GPIOA Group U201B HDMI_DE D 1 GPIOA0 GPIOA1 GPIOA2 GPIOA3 GPIOA4 GPIOA5 GPIOA6 GPIOA7 GPIOA8 GPIOA9 GPIOA10 GPIOA11 GPIOA12 GPIOA13 N2 N3 N4 N5 M1 M2 M3 M4 L1 L2 L3 L4 K3 K4 GPIOB0 GPIOB1 GPIOB2 GPIOB3 GPIOB4 GPIOB5 GPIOB6 GPIOB7 GPIOB8 GPIOB9 GPIOB10 GPIOB11 GPIOB12 GPIOB13 GPIOB14 GPIOB15 GPIOB16 GPIOB17 GPIOB18 GPIOB19 AJ4 AJ6 AJ5 AJ7 AG4 AG3 AH6 AH5 AG5 AJ3 AJ2 AJ1 AH4 AH3 AH2 AH1 AG6 AH7 AG2 AG1 GPIOC0 GPIOC1 GPIOC2 GPIOC3 GPIOC4 GPIOC5 GPIOC6 GPIOC7 GPIOC8 GPIOC9 GPIOC10 GPIOC11 GPIOC12 GPIOC13 GPIOC14 GPIOC15 B21 B22 L27 L28 R334 4.7K L29 B25 H27 L26 H28 H29 D27 C25 C26 B26 B24 B23 IRTXD IRRXD N28 N29 IDE_DMARQ IDE_IORDY Y5 AB1 IDE_DD0 IDE_DD1 IDE_DD2 IDE_DD3 IDE_DD4 IDE_DD5 IDE_DD6 IDE_DD7 IDE_DD8 IDE_DD9 IDE_DD10 IDE_DD11 IDE_DD12 IDE_DD13 IDE_DD14 IDE_DD15 AA2 Y4 AA1 W4 Y3 Y2 Y1 V4 W3 W2 W1 U4 V3 U5 V1 V2 IDE_CSb0 IDE_CSb1 IDE_DA0 IDE_DA1 IDE_DA2 U3 U2 U1 T3 T2 OOB_EN POD_PS GPIOA2 A_SEL HDMI_PD AVIDEO_PD AIN_RST# HDMI_INT PWR_DN TP72 D HDMI_P_CLK HDMI_CbCr0 HDMI_CbCr1 HDMI_Y[7:0] TP52PROBE_CLK HDMI_Y0 HDMI_Y1 HDMI_Y2 HDMI_Y3 HDMI_Y6 HDMI_HSYNC SELF_PWR# CIMAX_RESET P0_HRRMV P1_HRRMV SELF_RST# HDMI_Y7 HDMI_VSYNC HDMI_Y4 HDMI_Y5 TUN_SDA TUN_SCL H_SCDT OSD_Y1 OSD_Y2 0603 EXT_PWRON OVERCURRENT HW_BIT0 HW_BIT1 HW_BIT2 HW_BIT3 STEP C B X210VC 633P_BGA DNS in STEP STBY_3.3V DNS R332 5% 10K* 0603 R333 5% 10K 0603 TEST_MODE_M27 R318 IF_AGC 1K 0603 AGC_SDM1 C321 .1UF 0603 C325 33PF OSC_XTAL_IN 0603 A C326 33PF Y301 25.14MHz SX-1 +/-20PPM R321 100 0603 A OSC_XTAL_O 0603 R335 4.7 0603 F_15060_020.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 5 4 ATSC3 STBY_3.3V FB420 0603 MLB-160808-0220P-N2 3 X_3.3V IO_1.8V C403 .1UF 0603 C405 .1UF 0603 C406 .1UF 0603 C408 .1UF 0603 C409 .1UF 0603 2 +1.1V C476 .1UF 0603 C477 .1UF 0603 C478 .1UF 0603 C479 1UF 0805 C411 .1UF 0603 1 +1.1V C412 .1UF 0603 C413 .1UF 0603 C414 .1UF 0603 C489 .1UF 0603 C490 .1UF 0603 C491 .1UF 0603 C492 .1UF 0603 C493 .1UF 0603 C494 .1UF 0603 C0411 22UF 1206 +1.5V C401 .1UF 0603 D C402 .1UF 0603 D U201C 633P_BGA X_3.3V C424 .1UF 0603 C425 .1UF 0603 C426 .1UF 0603 C435 1UF 0805 C436 1UF 0805 C437 .1UF 0603 C438 .1UF 0603 C439 .1UF 0603 C440 .1UF 0603 C441 .01UF 0603 +1.5V FB419 0603 MLB-160808-0220P-N2 + C485 + C486 68UF_4V 68UF_4V TANT_B TANT_B C487 .1UF 0603 C488 .01UF 0603 C434 1UF 0805 L6 K6 H24 G24 G6 F22 F21 F18 F17 F14 F13 F10 F9 F6 VDD1_L6 VDD1_K6 VDD1_H24 VDD1_G24 VDD1_G6 VDD1_F22 VDD1_F21 VDD1_F18 VDD1_F17 VDD1_F14 VDD1_F13 VDD1_F10 VDD1_F9 VDD1_F6 CORE 1.1VDC +1.8V C423 .1UF 0603 PCI 3.3VDC +1.1V FB403 0603 MLB-160808-0220P-N2 + C480 68UF_4V TANT_B C450 .1UF 0603 +1.8V FB404 0603 MLB-160808-0060P-N2 C484 .1UF 0603 C451 .1UF 0603 X_3.3V FB407 FB408 C456 .1UF 0603 +1.8V FB409 MLB-160808-0120P-N2 MLB-160808-0120P-N2 0603 C457 .1UF 0603 C458 2.2UF 1206 0603 0603 C459 .1UF 0603 C460 1000PF 0603 MLB-160808-0120P-N2 C465 .1UF 0603 C466 .1UF 0603 +1.8V B FB411 0603 MLB-160808-0120P-N2 +1.8V C468 .1UF 0603 X210VC D26 F27 D25 E26 ADC0_AVDD1 ADC0_AVDD2 ADC0_AVSS1 ADC0_AVSS2 D18 D21 E20 E19 N26 N25 OSC_AVDD OSC_AVSS PLL_AVDD PLL_AVSS ACS_AVDD ACS_AVSS E15 E14 D14 D12 E13 DAC0_3P3_VDD_E15 DAC0_3P3_VDD_E14 DAC0_BG_VSS DAC0_3P3_VSS DAC0_AVSS C23 D23 C22 D22 ADC1_AVDD1 ADC1_AVDD2 ADC1_AVSS1 ADC1_AVSS2 B19 C19 B18 C18 FS_DVDD FS_DVSS FS_AVDD FS_AVSS FB412 0603 MLB-160808-0120P-N2 C469 .1UF 0603 +1.8V FB415 0603 MLB-160808-0120P-N2 C475 .1UF 0603 E21 L25 E18 M25 ACORE_VDD1 ACORE_VDD2 ACORE_VSS1 ACORE_VSS2 VDDR3_E16 VDDR3_F7 VDDR3_F8 VDDR3_F11 VDDR3_F12 VDDR3_F16 VDDR3_F19 VDDR3_F20 VDDR3_F23 VDDR3_F24 VDDR3_H6 VDDR3_J6 VDDR3_J24 VDDR3_K24 VDDR3_M6 VDDR3_N6 VDDR3_N24 VDDR3_P24 VDDR3_R6 VDDR3_T6 VDDR3_W5 VDDR3_W6 VDDR3_AC6 VDDR3_AD6 E16 F7 F8 F11 F12 F16 F19 F20 F23 F24 H6 J6 J24 K24 M6 N6 N24 P24 R6 T6 W5 W6 AC6 AD6 VDDR1_V24 VDDR1_W24 VDDR1_AB24 VDDR1_AC24 VDDR1_AC25 VDDR1_AD23 VDDR1_AD24 VDDR1_AE23 V24 W24 AB24 AC24 AC25 AD23 AD24 AE23 C416 .1UF 0603 C417 .1UF 0603 C418 .1UF 0603 C419 .1UF 0603 C420 .1UF 0603 C421 .1UF 0603 C422 .1UF 0603 X_3.3V C427 .1UF 0603 C428 .1UF 0603 C429 .1UF 0603 C430 .1UF 0603 C431 .1UF 0603 C432 .1UF 0603 C433 .1UF 0603 DDR_2.6V C443 .1UF 0603 C444 .1UF 0603 C445 .1UF 0603 C446 .1UF 0603 C447 .1UF 0603 C448 .1UF 0603 C449 .1UF 0603 C0412 22UF 1206 C +2.6V L401 MEM I/O 2.6VDC 4.7 DAC1.8V R401 0603 DAC 2.5V +1.8V I/O 1.8V C442 .1UF 0603 PLL 1.8V + C483 68UF_4V TANT_B CORE 1.5VDC 4.7 FB402 0603 MLB-160808-0220P-N2 FAT R402 0603 C VDDC_AE20 VDDC_AE14 VDDC_AE10 VDDC_AD20 VDDC_AD19 VDDC_AD14 VDDC_AD13 VDDC_AD10 VDDC_AD9 VDDC_AB6 VDDC_AA24 VDDC_AA6 VDDC_Y25 VDDC_Y24 VDDC_V6 VDDC_V5 VDDC_U25 VDDC_U24 VDDC_U6 VDDC_T24 VDDC_P6 VDDC_P5 VDDC_M24 VDDC_L24 1.8V +1.8V AE20 AE14 AE10 AD20 AD19 AD14 AD13 AD10 AD9 AB6 AA24 AA6 Y25 Y24 V6 V5 U25 U24 U6 T24 P6 P5 M24 L24 DAC 3.3V + C481 68UF_4V TANT_B FDC FB401 0603 MLB-160808-0220P-N2 + C482 68UF_4V TANT_B MM I/O 3.3V DC +1.8V VDDP_AD7 VDDP_AD8 VDDP_AD11 VDDP_AD12 VDDP_AD16 VDDP_AD17 VDDP_AD18 VDDP_AD21 VDDP_AD22 AD7 AD8 AD11 AD12 AD16 AD17 AD18 AD21 AD22 AVDD_AE4 AVDD_AF4 AVSSN_AE5 AVSSN_AE6 AE4 AF4 AE5 AE6 A2VDD_AC3 A2VDD_AD4 A2VSSN_AC5 A2VSSN_AD5 AC3 AD4 AC5 AD5 VDDC18_TOP_F15 VDDC18_BOTTOM_AD15 VDDC18_RIGHT VDDC18_LEFT F15 AD15 R24 Y6 XMVDD XMVSS R29 T29 PMIVDD PMIVSS AB2 AB3 APVDD APVSS F3 G3 VDDDI_AF5 AVDDQ_AD3 VSSDI_AF6 AVSSQ_AE3 AF5 AD3 AF6 AE3 VDD2DI A2VDDQ VSS2DI_AA5 A2VSSQ_AC4 AB4 AB5 AA5 AC4 FB405 0603 MLB-160808-0120P-N2 C452 1UF 0805 C453 .1UF 0603 2012F HFC-2012F-3R3-K FB406 0603 MLB-160808-0120P-N2 C454 1UF 0805 C455 .1UF 0603 +1.8V MLB-160808-0120P-N2 FB413 0603 +1.8V C461 .1UF 0603 C462 .1UF 0603 IO_1.8V MLB-160808-0120P-N2 FB418 0603 FB414 0603 MLB-160808-0120P-N2 C463 C464 .1UF .1UF 0603 0603 MLB-160808-0120P-N2 FB410 0603 C467 .1UF 0603 C474 .1UF 0603 B +1.8V MLB-160808-0120P-N2 FB416 0603 C470 .1UF 0603 C471 .1UF 0603 +1.8V MLB-160808-0120P-N2 FB417 0603 C472 .1UF 0603 X210VC C473 .1UF 0603 +1.5V C495 .1UF 0603 C496 .1UF 0603 C497 .1UF 0603 C498 .1UF 0603 C499 .1UF 0603 C0401 .1UF 0603 C0402 .1UF 0603 C0403 .1UF 0603 C0404 .1UF 0603 C0405 .1UF 0603 C0406 .1UF 0603 C0407 .1UF 0603 C0408 .1UF 0603 C0409 .1UF 0603 C0410 22UF 1206 A A F_15060_021.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 5 4 3 2 1 ATSC4 B X210VC Memory Interface C NC_A8 NC_A9 NC_A10 NC_A11 NC_A12 NC_A24 NC_A25 NC_A26 NC_A27 NC_A28 NC_A29 NC_B9 NC_B10 NC_B11 NC_B12 NC_B28 NC_B27 NC_B29 NC_C10 NC_C11 NC_C12 NC_C21 NC_C24 NC_C28 NC_C27 NC_C29 NC_D10 NC_D11 NC_D15 NC_D16 NC_D24 NC_D28 NC_D29 NC_E11 NC_E28 NC_E27 NC_E29 NC_F28 NC_F29 NC_G5 NC_G25 NC_G26 NC_G27 NC_G28 NC_G29 NC_H5 NC_J25 NC_J26 NC_J27 NC_J28 NC_J29 NC_K27 NC_K28 NC_K29 NC_M5 NC_M28 NC_N27 NC_T5 NC_V25 NC_W25 NC_AA25 NC_AB25 NC_AD25 NC_AE7 NC_AE8 NC_AE9 NC_AE11 NC_AE12 NC_AE13 NC_AE15 NC_AE16 NC_AE17 NC_AE18 NC_AE19 NC_AE21 NC_AE22 NC_AE24 NC_AE25 NC_AF8 NC Pins D A8 A9 A10 A11 A12 A24 A25 A26 A27 A28 A29 B9 B10 B11 B12 B28 B27 B29 C10 C11 C12 C21 C24 C28 C27 C29 D10 D11 D15 D16 D24 D28 D29 E11 E28 E27 E29 F28 F29 G5 G25 G26 G27 G28 G29 H5 J25 J26 J27 J28 J29 K27 K28 K29 M5 M28 N27 T5 V25 W25 AA25 AB25 AD25 AE7 AE8 AE9 AE11 AE12 AE13 AE15 AE16 AE17 AE18 AE19 AE21 AE22 AE24 AE25 AF8 64MByte Memory Bank using 256Mbit (x 16) components. (wired for larger parts) DQ[31:0] X210VC 633P_BGA DQA0 DQA1 DQA2 DQA3 DQA4 DQA5 DQA6 DQA7 DQA8 DQA9 DQA10 DQA11 DQA12 DQA13 DQA14 DQA15 DQA16 DQA17 DQA18 DQA19 DQA20 DQA21 DQA22 DQA23 DQA24 DQA25 DQA26 DQA27 DQA28 DQA29 DQA30 DQA31 AF23 AJ24 AH24 AG24 AH25 AG25 AF25 AJ26 AH26 AG26 AF26 AJ27 AJ28 AH28 AJ29 AH29 AB29 Y26 Y27 Y28 W27 W28 Y29 V26 V27 V28 W29 U27 V29 U26 T27 T28 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 DQ16 DQ17 DQ18 DQ19 DQ20 DQ21 DQ22 DQ23 DQ24 DQ25 DQ26 DQ27 DQ28 DQ29 DQ30 DQ31 DQMAb0 DQMAb1 DQMAb2 DQMAb3 AF24 AG27 AA29 U28 MDQM0 MDQM1 MDQM2 MDQM3 QSA0 QSA1 QSA2 QSA3 AJ25 AH27 W26 U29 MDQS0 MDQS1 MDQS2 MDQS3 AA0 AA1 AA2 AA3 AA4 AA5 AA6 AA7 AA8 AA9 AA10 AA11 AA12 AA13 AA14 DDR_2.6V C501 C502 C503 C504 C505 C506 C507 C508 .1UF 0603 .1UF .1UF .1UF .1UF .1UF .1UF .1UF 0603 0603 0603 0603 0603 0603 0603 U502 AG28 AG29 AF27 AF28 AF29 AE26 AE27 AE28 AE29 AD26 AC26 AC27 AC28 AD29 AB26 MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 MA12 MA13 MA14 RASAb CASAb AA26 AA27 RASAbRA5B CASAbRA5F 24 X 8 24 X 8 RAS CAS WEAb AA28 RA5E 24 X 8 WE CSAb0 CSAb1 AB28 AC29 RA5C 24 X 8 CS CKEA AB27 RA5D 24 X 8 CKEN CLKA CLKAb AD27 AD28 RA4F RA4E 24 X 8 24 X 8 CK CK# R27 R26 T26 VREF 49 VREF 29 30 31 32 35 36 37 38 39 40 28 41 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 CK CK# CKEN 45 46 44 CK CK CKE CS RAS CAS WE 24 23 22 21 CS RAS CAS WE 16 51 LDQS UDQS MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 24 X 8 MEMTEST MEMVMODE MEMVMODE0 MA14 MA13 LDM UDM 26 27 BA0 BA1 2 4 5 7 8 10 11 13 54 56 57 59 60 62 63 65 NC NC NC NC NC NC NC NC 14 17 19 25 42 43 50 53 VDD VDD VDD VDDQ VDDQ VDDQ VDDQ VDDQ 1 18 33 3 9 15 55 61 VSS VSS VSS VSSQ VSSQ VSSQ VSSQ VSSQ 34 48 66 6 12 52 58 64 MDQ0 MDQ1 MDQ2 MDQ3 MDQ4 MDQ5 MDQ6 MDQ7 MDQ8 MDQ9 MDQ10 MDQ11 MDQ12 MDQ13 MDQ14 MDQ15 RA1A RA1C RA1B RA1D RA1E RA1F RA1G RA1H RA2A RA2B RA2D RA2C RA2E RA2F RA2G RA2H 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 MA12 RESISTOR ARRAY - RA? - DDR_2.6V 1 3 5 MDQS1 MDQM0 VREF R509 1% R510 5% MDQM1 +1.8V 44.2 0603 4.7K 0603 9 7 11 13 15 12 14 16 C A side B side 2 6 4 8 10 TOP VIEW RESISTOR NETWORK TYPE R - RN? 1 10 MDQS0 R501 56 R503 56 1% 0603 1% 0603 R505 56 R507 56 1% 0603 1% 0603 2 3 4 5 9 8 7 6 TOP VIEW U503 VREF Place close to Xilleon on Memory side C518 22UF X5R,K 1206 20 47 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 K4H561638F-UCCC0000 66P_TSOPII U201D DDR_2.6V D DQ[31:0] MA[14:0] RA3A RA3B RA3C RA3D RA3E RA3H RA3F RA3G RA4A RA4B RA4C RA4H RA4G RA4D RA5A R28 +2.6V FB502 0603 MLB-160808-0220P-N2 AA0 AA1 AA2 AA3 AA4 AA5 AA6 AA7 AA8 AA9 AA10 AA11 AA12 AA13 AA14 VREF The CTSCorp ClearOne DDR SRAM Terminators provide high performance resistor termination as follows: a.) 25R series resistor provides the series termination for data flow from the DDR SRAM to the X210VC. b.) 50R resistor provides the Thevenin termination for data flow from the X210VC to the DDR SRAM. c.) VTT = VDDQ/2 DDR_2.6V C519 22UF X5R,K 1206 DDR_2.6V C520 22UF X5R,K 1206 DDR_2.6V DDR_2.6V C521 22UF X5R,K 1206 DDR_2.6V C522 22UF X5R,K 1206 C523 22UF X5R,K 1206 MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 DDR_2.6V VREF A R520 10K 0603 VREF 29 30 31 32 35 36 37 38 39 40 28 41 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 CK CK# CKEN 45 46 44 CS RAS CAS WE 24 23 22 21 CS RAS CAS WE 16 51 LDQS UDQS 20 47 LDM UDM R519 10K 0603 C540 .1UF X7R,K 0603 49 MA14 MA13 26 27 CK CK CKE BA0 BA1 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 2 4 5 7 8 10 11 13 54 56 57 59 60 62 63 65 NC NC NC NC NC NC NC NC 14 17 19 25 42 43 50 53 VDD VDD VDD VDDQ VDDQ VDDQ VDDQ VDDQ 1 18 33 3 9 15 55 61 VSS VSS VSS VSSQ VSSQ VSSQ VSSQ VSSQ 34 48 66 6 12 52 58 64 MDQ16 MDQ17 MDQ18 MDQ19 MDQ20 MDQ21 MDQ22 MDQ23 MDQ24 MDQ25 MDQ26 MDQ27 MDQ28 MDQ29 MDQ30 MDQ31 RA6A RA6B RA6C RA6D RA6E RA6F RA6G RA6H RA7A RA7C RA7B RA7E RA7D RA7F RA7H RA7G 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 56 X 8 DQ16 DQ17 DQ18 DQ19 DQ20 DQ21 DQ22 DQ23 DQ24 DQ25 DQ26 DQ27 DQ28 DQ29 DQ30 DQ31 B DDR_2.6V MA12 DDR_2.6V C527 C528 C529 C530 C531 C532 C533 C534 .1UF .1UF .1UF .1UF .1UF .1UF .1UF .1UF 0603 0603 0603 0603 0603 0603 0603 0603 C541 C542 C543 C544 C545 C546 C547 C548 .1UF .1UF .1UF .1UF .1UF .1UF .1UF .1UF 0603 0603 0603 0603 0603 0603 0603 0603 DDR_2.6V A K4H561638F-UCCC0000 66P_TSOPII MDQS2 DDR-SDRAM TERMINATION & REFERENCE VOLTAGE GENERATOR MDQS3 MDQM2 MDQM3 xxxx xxx xxxx.x 5 4 R511 56 R513 56 1% 0603 1% 0603 R515 56 R517 56 1% 0603 1% 0603 3 F_15060_022.eps 150305 2 1 3 FB602 MLB-160808-0220P-N2 0603 25% D R602 CDET1A# CD1A# POD_3.3V SOT-23 SCHOTTKY Vr:40V,Ir:0.75A,Vf:0.48V C610 .1UF 0603 X5R,K C611 .1UF 0603 X5R,K C612 .1UF 0603 X5R,K C613 .1UF 0603 X5R,K C614 .1UF 0603 X5R,K C615 .1UF 0603 X5R,K C602 .01UF 0603 X7R,K D602 BAT754 0 5% SOT-23 SCHOTTKY Vr:40V,Ir:0.75A,Vf:0.48V POD_DATA0 POD_DATA1 POD_DATA2 POD_DATA3 POD_DATA4 POD_DATA5 POD_DATA6 POD_DATA7 0603 POD card detect o Active LOW oTV must be PULL-UP R603 CDET2A# CD2A# 0* 5% U602 POD_DATA[7:0] POD_DET# 2 3 4 5 6 7 8 9 A0 A1 A2 A3 A4 A5 A6 A7 1 19 DIR OE 0603 DATDIR DATOE# B0 B1 B2 B3 B4 B5 B6 B7 FAD0 FAD1 FAD2 FAD3 FAD4 FAD5 FAD6 FAD7 18 17 16 15 14 13 12 11 D 74LVC245APW TSSOP 20P 10 DNS FAD[15:0] 20 D601 BAT754 STBY_3.3V 1 VCC ATSC5 2 POD_3.3V 4 GND 5 POD_3.3V RESET CLK 31 30 SCL SDA DEVICE ID: 80h POD_3.3V R604 10K* 0603 DNS in a STEP CS_POD FRD FWE FRDYb INT_POD to POD Buffer B DATOE# DATDIR ADOE# ADLE I2C addr : 0x80 INTEL 8bits LOCAL BUS CIMaX - SIGNAL - X210VC o RD/DIR - FRD - FRD o WR/STR - FWE - FWE o CS - CS_POD - CS_POD o WAIT/ACK - FRDYb - FRDYb REG# OE# WE# IORD# IOWR# 123 88 97 89 90 33 32 SA1 SA0 29 28 27 26 25 24 23 22 21 20 19 MICLKB MISTRTB MIVALB MDIB7 MDIB6 MDIB5 MDIB4 MDIB3 MDIB2 MDIB1 MDIB0 108 91 104 115 113 111 106 102 98 95 93 A25 A24 A23 A22 A21 A20 A19 A18 A17 A16 A15 MOCLKB MOSTRTB MOVALB MDOB7 MDOB6 MDOB5 MDOB4 MDOB3 MDOB2 MDOB1 MDOB0 117 126 124 83 79 77 75 73 4 2 128 18 17 16 15 14 CS RD/DIR WR/STR WAIT/ACK INT 13 12 EXTCS EXTINT 69 68 67 66 DATOE# DATDIR ADOE# ADLE RSTB CD1B# CD2B# CE1B# CE2B# RDY/IRQB# WAITB# 119 71 6 81 85 100 121 37 9 39 52 8 86 10 GND_CORE GND_PROC GND_TSI GND_TSO GND_DVB1 GND_DVB2 NC1 VCCEN 70 NC2 11 RSTA CD1A# CD2A# REG# REG# CD1# CE1# CD2# CE2# OE# VS1# WE# VS2# IORD# WAIT# IOWR# IOIS16# INPACK# IREQ# VPP1 VPP2 36 67 CDET1A# CDET2A# IRQA# WAIT# 43 57 59 33 VS1# REG# IRQA# 1 35 34 68 69 70 GND1 GND2 GND3 GND4 GND5 GND6 58 STBY_3.3V R610 5% 10K 0603 1OE 2OE 3OE 4OE 1 4 10 13 PC_VPP RSTA R607 10K 5% 0603 STBY_3.3V POD_A2 POD_A3 POD_A10 POD_A11 POD_A12 POD_A13 2 3 5 6 8 9 11 12 1Q1 1Q2 1Q3 1Q4 1Q5 1Q6 1Q7 1Q8 13 14 16 17 19 20 22 23 2Q1 2Q2 2Q3 2Q4 2Q5 2Q6 2Q7 2Q8 74LVC16373ADGG TSSOP 48P FB601 MLB-160808-0120P-N2 C606 .1UF 0603 X5R,K 0603 RP601 1 2 3 4 RPACK 2X4 10K 8 7 6 5 STBY_3.3V POD_3.3V C601 .1UF 0603 X5R,K C608 10UF 1206 X5R,K VDD 2 GND OUT 3 R614 C624 5PF 0603 VO_27MHZ SCO-103 A VS1# R623 5% 10K 0603 MOCLK R616 5% 100K 0603 RP602 POD_A2 1 POD_A3 2 POD_A5 3 POD_A6 4 10K 8 7 6 5 RPACK 2X4 RP603 POD_A7 1 POD_A10 2 POD_A11 3 POD_A12 4 5% 10K 8 7 6 5 RPACK 2X4 POD_A13 R617 5% 5% 47 46 44 43 41 40 38 37 2D1 2D2 2D3 2D4 2D5 2D6 2D7 2D8 36 35 33 32 30 29 27 26 1LE 2LE 48 25 1OE 2OE 1 24 LADD4 LADD5 LADD6 LADD7 LADD8 LADD9 R624 5% 10K 1 0603 POD_3.3V C603 .01UF 0603 X7R,K LADD2 LADD3 LADD10 LADD11 LADD12 LADD13 C604 .01UF 0603 X7R,K C617 .1UF 0603 X5R,K C618 .1UF 0603 X5R,K LAYOUT NOTE o closed placement to 74LVC16373ADGG Power Pins ADLE POD_3.3V ADOE# C605 .01UF 0603 X7R,K C607 10UF 1206 X5R,K Y A B U606 SN74LVC1G32GW 5P_DCK ADOE# 1 2 OOB_EN OOB_EN TP50 OR gate B R612 10K 5% 0603 Q601 BC847ALT1G SOT23 PC_VPP 12V 3 4 3.3V 3.3V AVCC AVCC AVCC 13 12 11 5 6 5V 5V AVPP 10 16 SHDN 1 2 15 14 VCCD0 VCCD1 VPPD0 VPPD1 OC 8 GND 7 FAD[15:0] C609 .1UF 0603 X5R,K OVERCURRENT TPS2211AIDBR 16P_PSOP ALE0 FAD0 FAD1 FAD2 FAD3 FAD4 FAD5 FAD6 FAD7 47 46 44 43 41 40 38 37 1D1 1D2 1D3 1D4 1D5 1D6 1D7 1D8 FAD8 FAD9 FAD10 FAD11 FAD12 FAD13 FAD14 FAD15 36 35 33 32 30 29 27 26 2D1 2D2 2D3 2D4 2D5 2D6 2D7 2D8 48 25 1LE 2LE 1 24 1OE 2OE U608 LADD[13:2] 1Q1 1Q2 1Q3 1Q4 1Q5 1Q6 1Q7 1Q8 2 3 5 6 8 9 11 12 2Q1 2Q2 2Q3 2Q4 2Q5 2Q6 2Q7 2Q8 13 14 16 17 19 20 22 23 LADD2 LADD3 LADD4 LADD5 LADD6 LADD7 LADD8 LADD9 LADD10 LADD11 LADD12 LADD13 POD_3.3V C619 .01UF 0603 X7R,K C620 .01UF 0603 X7R,K C621 .1UF 0603 X5R,K C622 .1UF 0603 X5R,K 74LVC16373ADGG TSSOP 48P A All parts in this page do not stuff in a BASIC model 10K 0603 F_15060_023.eps 150305 xxxx xxx xxxx.x 5 C POD_3.3V 3 CIMAX_27M 100 0603 1D1 1D2 1D3 1D4 1D5 1D6 1D7 1D8 U607 9 R611 10K 5% 0603 o When OOB_EN set High, Buffer is disable. o When ADOE# set High, Buffer is disable. o When no OOB mode and ADEN# is Low, Address Buffer is enable LADD[13:2] 4 10 15 21 28 34 39 45 VC 4 R606 10K 5% 0603 Buffer Control U609 1 OOB_EN R619 0 5% 4 R613 10K 5% 0603 POD_3.3V POD_A4 POD_A5 POD_A6 POD_A7 POD_A8 POD_A9 WAIT# STBY_3.3V POD_5V o Active High o X210VC GPIOC4 o OOB_EN: 1=enable o LADD0 and LADD1 is always enable. POD_3.3V U605 SOCKET for "61126-050CAH" FCI PCMCIA (+3.3V) CONNECTOR 2 POD_PS OOB enable POD_3.3V POD_A[13:0] 17 51 VCC1 VCC2 FDC_CRX FDC_DRX FBE0 FBE1 74LVC126APW 14P_TSSOP 18 52 RESET GND 2 5 9 12 CRX DRX 84648-050H 68P_PCMCIA CIMaX SP2L PQFP 128P o Reset Active High C623 .1UF 0603 61 7 42 9 15 44 45 60 16 7 1A 2A 3A 4A 5 34 35 0 0603 0 0603 R609 SDA_A 120 72 7 82 87 101 122 1Y 2Y 3Y 4Y VCC GND R608 SCL_A RSTA CD1A# CD2A# CE1A# CE2A# RDY/IRQA# WAITA# 29 28 27 26 25 24 23 22 12 11 8 10 21 13 VCC 3 6 8 11 3 MOCLK MOSTRT MOVAL MDO7 MDO6 MDO5 MDO4 MDO3 MDO2 MDO1 MDO0 A0 A1 A2 MOCLK/A14 A3 MOSTR CTX/A4 MOVAL ITX/A5 MDO7 ETX/A6 MDO6 QTX/A7 MDO5 CRX/A8 MDO4 DRX/A9 MDO3 A10 MDO2 A11 MDO1 A12 MDO0 A13 51 MOCLK 14 0603 63 62 41 40 39 38 37 66 65 64 14 7 18 31 42 63 62 61 60 59 58 57 56 55 54 53 R605 1% CRX DRX POD_A0 POD_A1 C616 .1UF 0603 X5R,K U604 42 31 18 7 R620 33 R621 33 R622 33 8 RP604 7 6 33 5 1 8 RP605 2 7 33 3 6 4 5 CIMAX_27M MOCLKA MOSTRTA MOVALA MDOA7 MDOA6 MDOA5 MDOA4 MDOA3 MDOA2 MDOA1 MDOA0 118 127 125 84 80 78 76 74 5 3 1 POD_A0 POD_A1 POD_A2 POD_A3 POD_A4 POD_A5 POD_A6 POD_A7 POD_A8 POD_A9 POD_A10 POD_A11 POD_A12 POD_A13 D0 D1 D2 D3 D4 D5 D6 D7 VCC VCC VCC VCC CIMAX_RESET 1K 0603 MICLK MISTRT MIVAL MDI7 MDI6 MDI5 MDI4 MDI3 MDI2 MDI1 MDI0 POD_DATA0 POD_DATA1 POD_DATA2 POD_DATA3 POD_DATA4 POD_DATA5 POD_DATA6 POD_DATA7 MCLKI MISTRT MIVAL MDI7 MDI6 MDI5 MDI4 MDI3 MDI2 MDI1 MDI0 GND GND GND GND GND GND GND GND R601 1 2 3 4 MPEG_D7 MPEG_D6 MPEG_D5 MPEG_D4 MPEG_D3 MPEG_D2 MPEG_D1 MPEG_D0 50 49 48 47 46 45 44 43 42 41 40 POD_3.3V 30 31 32 2 3 4 5 6 20 46 19 56 55 54 53 50 49 48 47 VCC VCC VCC VCC C TDATA7 TDATA6 TDATA5 TDATA4 TDATA3 TDATA2 TDATA1 TDATA0 110 92 105 116 114 112 107 103 99 96 94 GND GND GND GND GND GND GND GND TCLKA TSTRTA TVLDA TDATA[7:0] U603 MICLKA MISTRTA MIVALA MDIA7 MDIA6 MDIA5 MDIA4 MDIA3 MDIA2 MDIA1 MDIA0 45 39 34 28 21 15 10 4 MPG_CLK MPG_SYNC MPG_DATA_EN MPEG_D[7:0] U601 VCC_CORE VCC_PROC VCC_TSI VCC_TSO VCC_DVB1 VCC_DVB2 CIMaX 36 38 51 64 109 65 to X210VC from X210VC POD_3.3V 4 3 2 1 5 4 ATSC6 3 <2004.12.22-Bryan> For EMC: 1) C1245,C1246,C1255,C1256 Add 2) R727, R728 --> FB1242,FB1243 2 1 (~1300mA for Memory chips) (~200mA Xilleon VDDR1 ?) (~800mA for SDRAM ClearOne Terminators) 2.5V SWITCHING REGULATOR +5V TUNER_5V FB701 MLB-160808-0220P-N2 0603 V701 DNS U701 R732 0603 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 R733 0603 0 C739 100PF 0603 C761 10UF 1206 C705 .1UF 0603 C1254 10UF 1206 5 ISENSE 4 SW 6 VFB R716 0.03 1% 1206 R1243 0603 R1243 is DO NOT STUFF at STEP C1255 100PF 0603 0* 0603 0603 MLB-160808-0120A-N2 FB1213 0603 MLB-160808-0120A-N2 4.7 C702 .1UF 0603 C710 .01UF 0603 C740 100PF 0603 C762 10UF 1206 2520M L703 C708 .1UF 0603 D [email protected] U702 3 TPS64203DBVR 6P_SOT-23 TUN_SCL G 6 5 2 1 D4 D3 D2 D1 S 1.5A L706 MSCH5750C100M 5750M +2.6V + C712 47UF_6.3V TANT_B 20% C709 .1UF 0603 TUN_SDA C747 .1UF 0603 R749 Si3443DV 6P_TSOP-6 C1256 100PF 0603 75 R1244 FB1212 +6V C707 .1UF 0603 + C1260 + C711 47UF_10V 68UF_10V TANT_B TANT_C + C760 47UF_6.3V TANT_B 20% R717 294K 1% 0603 C713 5pF 0603 NPO,J 1 IF_AGC IF_N IF_P TD1336OZ NLFC252018T-3R3M 0.29A,3.4RDC,20% D702 MBR120LSFT1 SOD-123FL This switcher is set to a preset value of 2.584V R718 261K 1% 0603 DNS at BASIC +6V 1 2 3 4 5 6 7 8 9 10 11 R719 0603 FDC_AGC 0* FDC1332/RV* FDC_IFN FDC_IFP L704 MSCH5750C100M 5750M C746 .1UF 0603 + C717 470UF_10V 8X11.5 + C1261 47UF_10V TANT_B + C1262 47UF_10V TANT_B R746 2.2 R747 2.2 C715 .1UF* 0603 1 2 3 4 5 C716 .01UF* 0603 C741 100PF* 0603 C763 10UF* 1206 1 2 3 4 5 6 7 FB702 MLB-160808-0220P-N2 0603 C1263 + 47UF_10V TANT_B DNS in a Basic C719 2.2UF 1206 BOOT LG PGND3 SGND VCC PWGD ISEN HG PGND13 SD# FREQ FB SS EAO 14 13 12 11 10 9 8 2 STB_EN C723 .033UF LM2737MTCX 14P_TSSOP 0603 R712 1.5K +3.3V R711 150K 4 INB 2 INA 3 R723 10K 0603 VDD 5 OUTY 4 C744 .01UF 0603 C745 1000PF 0603 10K 1 R1245 10K* 0603 PWR_ON Q703 BC847ALT1G SOT23 FB1215 MLB-160808-0220P-N2 0603 STB_EN C1264 + 47UF_10V TANT_B GND EXT_PWRON 4.7PF 0603 1000PF1% C725 FDS6912A SO-8 1 V707 EZ1117ACST SOT-223 1A STBY_3.3V IN PWR_ON#5 3 2 STB_EN# R741 47K 0603 PWR_ON#5 R742 47K Q706 BC847ALT1G SOT23 0603 STBY_3.3V U706 1 2 S1 G1 D1_2 D1_1 8 7 3 4 S2 G2 D2_2 D2_1 6 5 AN_3.3V 2 TAB 4 + C728 100UF_16V 5X11 +1.8V R1 C730 .1UF 0603 R2 R703 10K 0603 Si4931DY-T1-E3 C749 SO-8 .1UF 0603 C748 .1UF 0603 + C1265 47UF_10V TANT_B OUT 1 +6V R735 1K 0603 C722 .1UF 0603 R715 6.04K 1% 0603 .1UF 0603 2 +3.3V C721 1000PF 0603 + C703 220UF_4V TANT_C R713 5.1K 1% C752 1000PF 0603 3 10K 1 + C720 220UF_4V TANT_C R721 10K 0603 FDS6912A SO-8 SN74LVC1G02 5P_DCK PWR_ON R739 0603 MSCH5750C100M 5750M C737 1000PF 0603 229K 0603 D701 BAT754 SOT-23 DNS : R1245 B C +1.1V L705 +5V 3 R736 0603 R714 C726 STB_EN# 3 C756 .1UF 0603 NOR GATE 2 1 R722 1K 0603 3 C724 STB_EN# C743 .01UF 0603 Q701B +3.3V SELF_PWR# C742 .1UF 0603 V702 +5V X6965D* SIP5-SF B39440X6965N201 U705 C718 .1UF 0603 Q701A U704 1 2 3 4 5 0.29A,3.4RDC,20% NLFC252018T-3R3M* 2520M L707 ADJ GND GND RF_IN GND AGC_IN GND PLL_AS GND SCL GND SDA GND NC GND +5V GND I/O GND TPO GND IF_GND GND IF_OUT I2C Addres: C0 7 8 U703 C VIN 4 I2C Addres: C2 G1 G2 G3 G4 G5 G6 G7 G8 G9 G10 G11 G12 GND 3 FB1214 0603 C706 .01UF 0603 2 MLB-160808-0120P-N2 TUNER_5V C701 .1UF 0603 EN 2 OD_25V +5V OOB NC AGC NC1 A_SEL SCL SDA NC2 +5V AN_IF IF_GC IF_OUT1 IF_OUT2 1 1 GND GND GND GND GND GND GND GND GND GND GND GND STB_EN# TUNER_5V 0.29A,3.4RDC,20% NLFC252018T-3R3M 2520M L701 5 6 D G1 G2 G3 G4 G5 G6 G7 G8 G9 G10 G11 G12 0* FAT power is connected to +5V by the tuner sensitivity. R702 2.2K 5% 0603 R701 2.2K 5% 0603 Vout = Vref(1 + (R2/R1)) + Iadj*R2 R704 10K 0603 R725 100 1% 0603 + C727 100UF_16V 5X11 1.8V@400mA C729 .1UF 0603 R726 44.2 1% 0603 B Vref=1.25V, Iadj=50uA Vout = 1.25V(1+0.44) = 1.8 Volt V703 EN 2 GND 3 VIN ISENSE 4 SW 6 VFB L702 MSCH5750C100M 5750M + C753 470UF_10V 8X11.5 5 R730 0.03 1% 1206 R750 C732 .1UF 0603 C1266 + 47UF_10V TANT_B C1267 + 47UF_10V TANT_B +3.3V C731 .1UF 0603 TPS64203DBVR 6P_SOT-23 3 4 G S +10V [email protected] U709 4.7 C714 .1UF 0603 6 5 2 1 D4 D3 D2 D1 1.5A L708 MSCD75-120K 7X7.8X5 +1.5V + C757 220UF_4V TANT_C + C754 68UF_4V TANT_B 20% R731 2.37K 1% 0603 1 Si3443DV 6P_TSOP-6 D707 MBR120LSFT1 SOD-123FL R748 10K 1% 0603 2 This switcher is set to a preset value of 1.5V U707 +5V PWR_ON#5 C755 5pF 0603 NPO,J +1.8V 0603 R744 47K 0603 C750 .1UF 0603 C751 .1UF 0603 S1 G1 D1_2 D1_1 8 7 3 4 S2 G2 D2_2 D2_1 6 5 PWR_ON#5 HDMI_1.8V Si4931DY-T1-E3 SO-8 R705 10K 0603 4 2 IN ON/OFF + C733 100UF_16V* 5X11 VOUT adjust 5 1 R734 0603 6.04K* LM2941S* TO-263 R706 10K 0603 R710 1K* 0603 9V@100mA + C734 100UF_16V* 5X11 STBY_3.3V A 1 A PWR_ON#5 R743 47K 1 2 +9V V704 AN_5V GND TAB 1 3 6 STB_EN# STB_EN# IN ON/OFF VOUT adjust +5V [email protected] R708 1K 0603 C736 10UF X5R,K 1206 C704 .1UF 0603 POD_5V 3 C738 .1UF 0603 D704 BAV99LT1G SOT-23 +1.8V R729 5% 3 0 2 LM2941S TO-263 3 6 GND TAB C735 10UF X5R,K 1206 2.94K 5 1 2 R707 0603 V705 4 2 1 +6V D703 BAV99LT1G SOT-23 F_15060_024.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 5 4 ATSC7 3 2 1 RXACRXAC+ AN_3.3V HPLL_3.3V RV801 CT0402S14AHSG* 0402 FB801 0603 MLB-160808-0120P-N2 RV802 CT0402S14AHSG* 0402 U803 HDMI_3.3V HAN_3.3V RXA0RXA0+ RV805 CT0402S14AHSG* 0402 D C804 1000PF 0603 C803 1000PF 0603 RV806 CT0402S14AHSG* 0402 RXA1RXA1+ C805 .1UF 0603 HPLL_3.3V 48 ANTSTO 50 51 54 55 58 59 62 63 RXCRXC+ RX0RX0+ RX1RX1+ RX2RX2+ 49 53 57 61 52 56 60 64 HPLL_3.3V 47 46 AVCC AVCC AVCC AVCC AGND AGND AGND AGND RXACRXAC+ RXA0RXA0+ RXA1RXA1+ RXA2RXA2+ RXACRXAC+ RXA0RXA0+ RXA1RXA1+ RXA2RXA2+ C806 .1UF 0603 DE VSYNC HSYNC ODCK HAN_3.3V RV809 CT0402S14AHSG* 0402 RV810 CT0402S14AHSG* 0402 C812 .1UF 0603 C813 1000PF 0603 RXA2RXA2+ RV813 CT0402S14AHSG* 0402 RV814 CT0402S14AHSG* 0402 H_1.8V DNS XTAL_3.3V XREG_3.3V HDMI_1.8V HDMI_3.3V HDAN_5V0 XTAL_3.3V C801 .1UF 0603 U801 1 2 3 4 A0 A1 A2 GND 8 7 6 5 VCC WP SCL SDA R801 4.7K 0603 R803 470K 0603 Q801 BSN20 SOT-23 R804 470K 0603 C819 .1UF 0603 CI2CA RMUTE TP71 RMUTE C820 .1UF 0603 DSCL0 DSDA0 CAT24FC02 SO8 C WP1 R802 4.7K 0603 XREG_3.3V R805 100 0603 Q802 BSN20 SOT-23 HSCLA HSDAA HDMI_3.3V RSD0 RWS RSCK HDMI_3.3V C821 1000PF 0603 C822 .1UF 0603 C823 .1UF 0603 C826 .1UF 0603 C837 .1UF 0603 C838 .1UF 0603 C839 .1UF 0603 C840 .1UF 0603 TP56 MCLK RXO RXI R806 100 0603 R0PWR5V SiI 9011 DVCC DVCC2 DGND DGND2 86 87 XTALVCC REGVCC 45 VPP 38 67 CI2CA MUTE 70 SPDIF 71 72 73 74 75 76 79 SD3 SD2 SD1 SD0 WS SCK MCLK 84 85 XTALOUT XTALIN 44 HDAN_5V0 PVCC PGND 66 82 65 83 128-Pin LQFP PWR5V H_1.8V R830 4.7K 0603 WP1 WP1 TP73 TEST R826 H_1.8V 4.7K 0603 HDMI_3.3V HDMI_5V0 C830 1000PF 0603 Q805 2N7002 SOT-23 C815 .1UF 0603 C832 .1UF 0603 C833 .1UF 0603 C834 .1UF 0603 C835 .1UF 0603 B UC_SCL UC_SDA C828 .01UF 0603 HSCLA 1 2 3 4 8 7 6 5 RP801 RSD0 RWS RSCK R813 0603 R814 0603 R816 0603 R827 0 I2SSD_IND 33 HDMI_VSYNC HDMI_HSYNC HDMI_DE HDMI_P_CLK 0603 33 33 RV817 CT0402S14AHSG* 0402 RV818 CT0402S14AHSG* 0402 4 3 2 1 5 6 7 8 HDMI_Y7 HDMI_Y6 HDMI_Y5 HDMI_Y4 RDE11 RDE10 RDE9 RDE8 4 3 2 1 5 6 7 8 HDMI_Y3 HDMI_Y2 HDMI_Y1 HDMI_Y0 DNS RXO C844 R828 1M 0603 129 130 131 132 133 134 135 GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD 100 0603 UC_SDA UC_SCL UC_SDA UC_SCL R811 0603 R812 0603 35 34 33 32 29 28 27 26 QO8 QO9 QO10 QO11 QO12 QO13 QO14 QO15 23 22 21 20 17 16 15 14 QO16 QO17 QO18 QO19 QO20 QO21 QO22 QO23 11 10 9 8 5 4 3 2 0 RX_RST# FB802 0603 MLB-160808-0120P-N2 HAN_3.3V FB803 0603 MLB-160808-0120P-N2 XTAL_3.3V XREG_3.3V FB805 0603 MLB-160808-0120P-N2 H_1.8V FB806 0603 MLB-160808-0120P-N2 C807 .1UF 0603 QE8 QE9 QE10 QE11 QE12 QE13 QE14 QE15 111 110 109 108 105 104 103 102 RDE8 RDE9 RDE10 RDE11 RDE12 RDE13 RDE14 RDE15 QE16 QE17 QE18 QE19 QE20 QE21 QE22 QE23 101 100 99 96 95 94 93 92 VPA4 VPA5 VPA6 VPA7 VPA8 VPA9 VPA10 VPA11 DSCL DSDA 42 41 DSCL0 DSDA0 89 90 91 7 19 31 68 77 98 107 120 RX_RST# RX_SCDT RX_INT C802 10UF 1206 RDE[15:8] C VPA[11:4] HDMI_3.3V 6 18 30 144 143 142 141 140 139 138 137 136 B SiI 9011 LQFP_128P SDA_B SCL_B HDMI_PD R815 10K 0603 RP804 33 VPA8 VPA9 VPA10 VPA11 1 2 3 4 8 7 6 5 HDMI_CbCr4 HDMI_CbCr5 HDMI_CbCr6 HDMI_CbCr7 VPA4 VPA5 VPA6 VPA7 1 2 3 4 8 7 6 5 HDMI_CbCr0 HDMI_CbCr1 HDMI_CbCr2 HDMI_CbCr3 HDMI_CbCr4 HDMI_CbCr5 HDMI_CbCr6 HDMI_CbCr7 RX_INT R819 0603 RX_SCDTR820 0603 CI2CA R822 0603 0 0 HDMI_INT H_SCDT 10K A HDMI_CbCr0 HDMI_CbCr1 HDMI_CbCr2 HDMI_CbCr3 RP805 33 RXI 18PF 0603 AVIO_3.3V HDMI_CbCr2 HDMI_CbCr3 HDMI_CbCr6 HDMI_CbCr7 1 2 3 4 8 7 6 5 RP806 10K xxxx xxx xxxx.x 5 4 D HDMI_1.8V 124 123 122 121 117 116 115 114 GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD GND_PAD RDE RVSYNC RHSYNC RODCK FB804 0603 MLB-160808-0120P-N2 QE0 QE1 QE2 QE3 QE4 QE5 QE6 QE7 OGND OGND OGND 0 RDE RVSYNC RHSYNC RODCK RP803 33 R829 Y801 28.322MHz ATS-49/U +/-20PPM HDMI_Y[7:0] RP802 33 I2SSCK_IND C843 18PF 0603 CSCL CSDA OGND OGND OGND OGND OGND I2C address First device: 0x60 Second device: 0x68 RDE15 RDE14 RDE13 RDE12 <2004.12.20-Bryan> For EMC: RP801,RP802,RP803,RP804,RP805 : Close to X210VC as possible A NC TEST 40 39 118 106 97 78 69 I2C address First device: 0x60 Second device: 0x68 HSDAA C845 5PF 0603 I2SWS_IND 33 43 88 QO0 QO1 QO2 QO3 QO4 QO5 QO6 QO7 RESET# SCDT INT OVCC OVCC OVCC OVCC OVCC OVCC OVCC OVCC H_1.8V C842 .1UF 0603 RVSYNC RHSYNC RDE RODCK VCC VCC VCC VCC VCC VCC GND GND GND GND GND GND TEST C836 .1UF 0603 R0PWR5V R809 4.7K 0603 12 24 36 81 112 125 13 25 37 80 113 126 127 1 128 119 F_15060_025.eps 150305 3 2 1 4 3 SYNC_IN 68 67 66 Y1_IN Cb1/Pb1_IN Cr1/Pr1_IN F_Pb 3 5 9 11 15 17 20 22 29 32 33 36 43 46 48 51 54 56 59 62 69 72 73 76 0603 C927 .1UF F_Pr 0603 ABCL_IN VSM_OUT 74 71 70 64 58 57 49 CP_OUT 47 AFC_FILTER 44 H-FREQ_SW1 H-FREQ_SW2 55 41 VP_OUT H_OUT 35 37 FBP_IN H_COURVE_CORRECTION .1UF* 0603 DNS C926 .01UF 0603 1P_CON* C969 1UF 0805 VSM_OUT R958 2K 0603 1% .01UF 0603 P904 C965 .01UF 0603 1 1P_CON* FBP C929 C931 .01UF 0603 1UF 0805 R924 30K 0603 DEF/DAC_GND DAC_9V R912 33K 0603 Q911 SOT23 1 R954 3.9K 0603 DAC_Pr Q910 BC847ALT1G SOT23 R970 2 C971 R_S/H 75 0603 .01UF 0603 B_S/H RGB_VCC C958 .1UF 0603 R941 1K 0805 C945 47PF* 0603 R942 1K 0805 OSD_G RO R939 220 0603 R938 10K 0603 C956 10PF 0603 CRT_GND OSD_B 2 3 R_OUT CRT_GND R940 1 100 0603 R981 75 0603 R982 75 0603 OSD_R Q905 MMBT2907ALT3G SOT23 R980 75 0603 L907 .47UH L908 .47UH L909 .47UH D909 KDZ8.2V R998 3.3K 0603 ROT C938 .01UF 0603 +9V R960 10K* 0603 DNS C935 .1UF 0603 R962 220K 0603 0603 F_G 0603 F_B R933 82K 0603 C950 .047UF 0603 1 2 3 5 6 7 8 10 11 13 14 15 VREF C_DAC EHT_IN V_DRIVE V-DC_REF V_FB VCC EW_PWM AN_GND EW_FB EW_FLT FBP_IN 4 9 12 NC1 NC2 NC3 TA1317AFG 30P_SSOP DEF/DAC_GND R984 C932 75 0603 0603 R985 75 0603C939 0603 + C934 100UF_16V 5X11 C936 0603 .1UF AGC_FLT V-RAMP TC_FLT VIN BLK_OUT C_OUT V-DF LVP_IN H_DF D_GND SCL SDA 30 29 28 26 24 23 22 21 20 18 17 16 NC6 NC5 NC4 27 25 19 B + C947 1UF_35V TANT_A VP_IN BLK_OUT CENTER_OUT LVP_IN UOC_SCL UOC_SDA C951 .01UF 2012M R934 20K 0603 C948 1UF 7.3_DIP C970 .01UF 2012M V_NF R988 10K 0603 R989 10K V-DC_REF 0603 R1_IN .1UF .1UF R963 100 C954 2200PF 0603 G1_IN B1_IN R983 75 0603 C977 C978 C979 47PF 47PF 47PF 0603 0603 0603 C974 C975 C976 47PF 47PF 47PF 0603 0603 0603 100 0603 R976 68K 0603 DEF/DAC_GND V_DRIVE V-DC_REF F_R F_G F_B F_R LVP_IN R967 100K 0603 U902 R961 120K 0603 EW_FB EW_FLT 0603 R971 1 RGB_GND C940 .1UF F_R F_G F_B Q909 SOT23 Q913 SOT23 1 DAC_9V 0603 C946 47PF* R929 R930 R931 75* 75* 0603 75* 0603 0603 0603 100 R973 0603 MLB-160808-0220P-N2 FB904 0603 DEF/DAC_GND C944 47PF* 0603 Q917 SOT23 1 R997 2.2K 0603 0603 C941 C942 C943 R926 R927 R928 47PF* 47PF* 47PF* 75 75 75 0603 0603 0603 0603 0603 0603 R968 15K 0603 CENTER_OUT B2_IN F_Pr C R966 68K 0603 EHTinfo F_Pb R972 100K 0603 RGB_GND C937 .1UF F_Pr Q916 SOT23 1 R996 270 0603 0603 F_Pb Q914 SOT23 G_S/H R969 220 0603 C933 .1UF F_Y 1 VM_MOD Q903 BC847ALT1G SOT23 R2_IN F_Y HFB D904 KDZ9.1V RGB_VCC 1 DEF/DAC_GND <2004.12.24> Do not Stuff all components of outside BLACK Box in MP 0603 10% 0603 10% 0603 10% D905 KDZ9.1V* R923 220 0603 +9V R953 6.8K 0603 R911 150K 0603 1 R959 1K 0603 1% DNS 39 40 4.7K 0603 5% HOR_GND DEF/DAC_GND 100 VP_OUT C930 1200PF* 0603 R990 10K R991 0603 10K* 0603 DNS R921 1.2K 0603 G2_IN DAC_Pb 2 C914 .01UF 2012M .47UF 0603 DEF/DAC_GND H_DRV DNS FBP VER_GND DAC_9V C924 R922 0603 C912 1UF 0805 R915 AFC_FIL HOR_GND VER_GND L901 0 L902 0 L903 0 1 VER_GND 1 BLK_OUT RGB_VCC C922 C964 SVM_ROT VM_MOD 0603 P905 HOR_GND ROT DAC_9V 2.2UF 1206 Input level: 0.7Vp-p 100IRE DAC_Y 3 1 R907 2K 0603 DNS C920 1 C928 .01UF* 2012M DNS 0603 <2004.12.20> Yap : L901,L902,L903 0.47uH ==> 0 Ohm in MP VSYNC .1UF C918 .1UF 0603 VER_GND HSYNC VSYNC_DEC 2.2UF 1206 R957 220K H_DRV R918 3.3K 0603 VDRA V_DRIVE 1 R908 100 0603 Q902 BC847ALT1G SOT23 C916 .1UF 0603 .47UF 0603 AFC_FIL From SOC(MPEG-2 Decoder) HSYNC_DEC VP_OUT R956 100K* H_DRV R904 1K 0603 I2L_GND VP_IN DNS NC1 NC2 NC3 NC4 NC5 NC6 NC7 NC8 NC9 NC10 NC11 NC12 NC13 NC14 NC15 NC16 NC17 NC18 NC19 NC20 NC21 NC22 NC23 NC24 Q901 MMBT2907ALT3G SOT23 C913 0603 TA1360AFG 80P_QFP B C910 KDZ2.0V .01UF 0603 63 61 60 APL_FILTER DARK_AREA_DET_FILTER BPH_FILTER LIGHT_AREA_DET_FILTER COLOR_LIMITER VSM_FILTER SCP_IN C925 .1UF R903 2.7K 0603 RGB_GND DEF/DAC_GND C917 HD_IN VD_IN 180 5% 1/2W D901 2 0603 I2L_GND C915 53 R913 2.7K 0603 3 F_Y R909 1210 HVCO 50 52 VER_GND DAC_9V 2 0603 C921 .1UF Y2_IN Cb2/Pb2_IN Cr2/Pr2_IN D908 BAV99LT1G SOT-23 3 DAC1 DAC2 R994 2.2K 0603 VDRB C967 1000PF DAC_9V 0603 R995 330K 0603 2 34 23 C963 10UF 1206 D VDRA V-DC_REF 3 DEF/DAC_GND DEF/DAC_GND EW_DRIVE Voltage to Current VDRA R993 120K 0603 3 C919 .1UF C SDA SCL C962 1UF 0805 DAC_9V B_CRT EW_DRIVE 82K 0603 D903 KDZ8.2V YC_GND G_CRT BO 2 HSYNC VSYNC 10 27 38 65 R964 RGB_GND YC_GND YC_GND YM/P-MUTE/BLK 79 ABCL_IN 78 VSM_OUT 77 28 30 42 RGB_GND I2L_GND DEF/DAC_GND Y/C_GND + C906 100UF_16V 5X11 C911 .1UF 0603 R_CRT GO Q922 MMBT2907ALT3G SOT23 +9V 3 ANALOG_R_IN ANALOG_G_IN ANALOG_B_IN 16 75 45 31 +9V Vguard RO 2 24 25 26 D906 BAV99LT1G 3SOT-23 1 ABCL_IN 2.2K 0603 3 R2_IN G2_IN B2_IN RGB_VCC Y/C_VCC DEF/DAC_VCC I2L_VDD + C905 100UF_16V 5X11 C949 .1UF 0603 L906 SMI-252018-8R2 2520M 2 ANALOG_OSD_R_IN ANALOG_OSD_G_IN ANALOG_OSD_B_IN RGB_GND DAC_9V 3 18 19 21 KDZ6.8V B_OUT G_OUT R_OUT 14 13 12 + C904 100UF_16V 5X11 C952 .1UF 0603 +9V 2 R1_IN G1_IN B1_IN 2.2UF 1206 DEF/DAC_GND B_OUT G_OUT R_OUT R_S/H G_S/H B_S/H 8 L905 SMI-252018-8R2 2520M EHTinfo V_NF R992 3 2.2UF 1206 4 6 7 IK_IN +9V 2 R_S/H G_S/H B_S/H CRT_GND D902 Ys1 Ys2 Ys3 390K 0603 BC_INFO EHTinfo 2 2.2UF 1206 L904 SMI-252018-8R2 2520M 3 10K 10K 5% DDAC2 10K 5% Y901 CSBLA503KECZF30 470 5% 2P_RESO R917 0603 RGB_VCC U901 80 1 2 EHTinfo R910 CRT_GND 3 R914 0603 R916 0603 UOC_SCL UOC_SDA + C902 100UF_16V 5X11 C903 1UF 0805 Inductor Selection Guide As regarding voltage drop, the maximum resistance value of inductor can be used 3.09ohm DNS UOC_SDA UOC_SCL +9V R905 0* 0603 R902 33K 0603 5% 2 C909 R901 0* 0603 SCL_B SDA_B R906 0603 C908 BEAM_INFO R955 220K 0603 2 C901 330PF 0603 OSD_Y1 OSD_Y2 C907 +9V BEAM_INFO Blend Ratio OSD_Y2 OSD_Y1 INT : OSD L L 10:0 H L 7:3 L H 5:5 H H 0:10 Test purpose resistors 1 +9V ATSC8 D 2 3 5 0603 VER_GND I2L_GND VER_GND CRT_GND DEF/DAC_GND RGB_GND VER_GND CRT_GND CRT_GND A RGB_VCC C923 RGB_VCC DNS YC_GND HOR_GND DAC_9V A EW_FB xxxx xxx xxxx.x CRT_GND C957 10PF 0603 CRT_GND R945 100 0603 2 1 Q906 MMBT2907ALT3G SOT23 B_OUT R949 220 0603 R948 10K 0603 CRT_GND C961 10PF 0603 CRT_GND R950 100 0603 1 3 R944 220 0603 R943 10K 0603 3 G_OUT R936 47K 0603 BO CRT_GND 2 GO CRT_GND Q907 MMBT2907ALT3G SOT23 EW_FLT R935 1k 0603 1 C953 .1UF 0603 3 R952 1K 0805 R919 4.7k 0603 Q904 BC847ALT1G SOT23 1 R920 4.7k 0603 2 R951 1K 0805 R937 1K 0603 3 R947 1K 0805 EW_DRIVE D907 BAV99LT1G SOT-23 R932 0 2 1 0603 2 R946 1K 0805 .01UF* 0603 C960 .1UF 0603 3 C959 .1UF 0603 Q908 BC847ALT1G SOT23 R925 4.7k 0603 F_15060_026.eps 150305 CRT_GND CRT_GND 5 4 3 2 1 5 4 ATSC9 ICT61 ICT FB101 MLB-160808-0120P-N2 0603 AN_5V 3 2 1 DAC_5V C101 1UF 0805 C102 .1UF 0603 U101 D 2 2,3,10 2 1 2 3 4 5 I2SSD_OUTA I2SSCK_OUTA I2SWS_OUTA 2,3,10 I2SMCLK C138 5PF 0603 FB104 MLB-160808-0120A-N2 0603 200mA,0.5RDC,120R@100M AUDIO_L R102 C120 .1UF 0603 + C125 3.3UF_16V 4X5.5SMD SDIN SCLK LRCK MCLK VQ D AUDIO_L DAC_VCOM CS4345-CZZ 10P_TSSOP + C130 10UF_16V 4X5.5SMD FB103 MLB-160808-0120A-N2 0603 200mA,0.5RDC,120R@100M C108 AUDIO_R 470 0603 AUDIOL_O C105 2200PF 0603 AUDIO_R 10 9 8 7 6 AOUTR VA GND AOUTL FILT+ R106 10 0805 .68UF AUDIOR_O C107 2200PF 0603 .68UF 0805 <2004.12.20-Bryan> For EMC Place LC on Board of Shield Case C103 470 0603 : <2004.12.20-Bryan> For EMC Place LC on Board of Shield Case 10 : C C AD_5V C117 AD_5V FB111 MLB-160808-0120P-N2 0603 AN_5V BC846,BFS17.2N3904 BAT54C,SDC15 3 C AUDIOR_IN C118 .1UF 0603 + 10 R131 5.1K 0603 R114 R132 100K 0603 10UF_16V 5X11 2.49K 0603 R115 5.1K 0603 C119 1UF 0805 SOT23 1 B 2 E AD_5V Viewed form TOP Side of PCB AD_5V C121 AUDIOL_IN R118 B R134 100K 0603 10UF_16V 5X11 2.49K 0603 R119 5.1K 0603 ax ay VCC 16 2 1 bx by MUX_a MUX_b MUX_c 14 15 4 5 3 R135 10K 5% 0603 R136 5.1K 0603 1 + 2 R137 100K 0603 R123 5.1K 0603 10UF_16V 5X11 A_SEL R142 10K 0603 2 C129 R122 UOC_AR_IN 2.49K 0603 11 10 9 6 cx cy A B C INH C122 2200PF 0603 GND VEE 3 AD_5V 10 12 13 Q101 BC847ALT1G SOT23 16 15 14 13 12 11 10 9 C123 2200PF 0603 M1 FILT+ REF_GND VA AINR VQ AINL RST M0 MCLK VL SDOUT GND VD SCLK LRCK R125 UOC_AL_IN R129 0603 33 R130 0603 Audio input select AIN_RST# A_SEL: 0 - UOC Audio (ay, by) A_SEL: 1 - External audio(ax, bx) AIN_RST# 0: reset & power down mode 1: normal mode C126 1UF 0805 R124 100K 0603 I2SMCLK 33 I2SSD_IN 2 I2SSCK_IN I2SWS_IN 2 2 B C128 .1UF 0603 FB109 AN_3.3V MLB-160808-0220P-N2 0603 2,3,10 C131 1UF 0805 X5R,K C132 .1UF 0603 C133 + 10 33 5% 33 0603 C127 1UF 0805 AD_5V R138 5.1K 0603 R121 0603 R120 FB107 AN_3.3V MLB-160808-0220P-N2 0603 C134 .1UF 0603 C124 .1UF 0603 1 2 3 4 5 6 7 8 CS5340-CZZ 16L_TSSOP 8 7 C135 .1UF 0603 M74HC4053 SOIC_16P Clock Master, Single speed mode U103 C136 .1UF 0603 U104 + 10 R133 5.1K 0603 R139 100K 0603 2.49K 0603 R126 5.1K 0603 10UF_16V 5X11 A A F_15060_027.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 5 4 ATSC10 R21 R22 R23 R24 R25 F_Y F_Pb F_Pr 0 0 0 0 0 R26 R27 R28 R31 R30 F_R F_G F_B HSYNC_DEC VSYNC_DEC DEF_OP_6 DEF_OP_7 DEF_OP_8 DEF_OP_9 ES_2 0603 0603 0603 0603 0603 DNS D STBY_3.3V R16 10K 5% 2 1 In mass Production, P1255 will be changed to 6-Pin connector, and 6-pin connector description will be found in PARTLIST. DEF_OP_1 DEF_OP_2 DEF_OP_3 DEF_OP_4 DEF_OP_5 0603 0603 0603 0603 0603 0* 0* 0* 0* 0* 3 P1255 Vguard EHTinfo VDRA VDRB EW_drive SVM_ROT HFB H_DRV ES_2 <2004.12.20-Bryan> For EMC: 1) C1245,C1246,C1257,C1258,C1259 Add 2) R11, R12 --> FB1207,FB1208 3) FB1209,FB1210,FB1211 Add R34 R35 R36 R37 R38 0* 0603 0* 0603 0* 0603 0* 0603 0* 0603 DEF_OP_1 DEF_OP_2 DEF_OP_3 DEF_OP_4 DEF_OP_5 R39 R40 R41 0* 0603 0* 0603 0* 0603 DEF_OP_6 DEF_OP_7 DEF_OP_8 DEF_OP_9 0* R29 0603 C13 5PF* 0603 C12 5PF* 0603 1 2 3 4 5 6 7 8 9 ES_110 11 C11 5PF* 0603 C10 5PF* 0603 C9 5PF* 0603 C8 5PF 0603 C6 5PF 0603 1 2 3 4 5 6 7 8 9 10 11 Vguard EHTinfo VDRA VDRB EW_drive GND SVM_ROT HFB HD EW_FD P1340 BC_INFO D 5X1 CONNECTOR* 5P_2_THRUHOLE B5B-PH-K-S 11 X 1 CONNECTOR 11P_2.5_THRUHOLE S6B-EH-A C4 5PF 0603 R G B GND BC_INFO 1 2 3 4 5 R_CRT G_CRT B_CRT C1253 C1242 C1243 C1244 100PF 100PF 100PF 100PF 0603 0603 0603 0603 CRT amp DNS P1206 UOC_TX UOC_RX POD_DET# EXT_PWRON RESET# FB1207 0603 MLB-160808-0120A-N2 FB1208 0603 MLB-160808-0120A-N2 FB1209 0603 MLB-160808-0120A-N2 FB1210 0603 MLB-160808-0120A-N2 FB1211 0603 MLB-160808-0120A-N2 <2004.12.20-Bryan> For EMC Tx Gnd Rx Bus request Power on Reset# 1 2 3 4 5 6 6 X 1 CONNECTOR 6P_2_THRUHOLE B6B-PH-K-S DNS C1258 100PF 0603 C1259 100PF 0603 C1245 5PF 0603 MLB-160808-0120P-N2 FB1217 0603 1 2 3 4 5 6 7 8 9 10 11 12 FB2 MLB-451616-0050P-N1* 4516M CT0402S14AHSG +6V C1272 .1UF 0603 R10 10K 0603 5% P1533 FB1216 0603 MLB-160808-0120P-N2 RV2 0402 C1246 5PF CT0402S14AHSG 0603 HDMI_3.3V FB1 MLB-451616-0050P-N1 4516M +3.3V +10V C1257 100PF 0603 FB3 EXT_3.3V MLB-451616-0050P-N1 4516M R1 10K* 0603 UOC_SDA UOC_SCL R32 R33 R2 10K* 0603 P1257 C1268 .1UF 0603 SDA SCL GND 1 2 3 C1 470UF_16V 8X11.5 + + C2 470UF_16V* 8X11.5 + MLB-160808-0120A-N2 FB11 MLB-160808-0120A-N2 FB10 MLB-160808-0120A-N2 R19 22 0603 R20 22 0603 C1271 .1UF 0603 C1248 100PF 0603 UOC_B HS_IN VS_IN GND R of analog video GND G of analog video GND B of analog video H sync(Composite sync) V sync 1 2 3 4 5 6 7 8 FB9 C14 5PF 0603 B 2 1 L2 3 4 RXA1RXA0+ 2 1 L3 3 4 RXA0RXAC+ 2 1 L4 3 4 RXAC- 2 3 ACM2012D-900-2P 4P_2012M ACM2012D-900-2P 4P_2012M ACM2012D-900-2P 4P_2012M R8 47K* 0603 DNS MLB-160808-0120P-N2 FB1223 P0_HRRMV 8 X 1 CONNECTOR 8P_2.5_THRUHOLE B8B-EH-A C15 5PF 0603 D1 BAT754 SOT-23 HDAN_5V0 D2 HDMI_5V0 BAT754 SOT-23 1K 0603 R7 FB8 0603 MLB-160808-0120P-N2 D3 BAT754* SOT-23 SH2 HDMI CONNECTOR 19P_DIP DC1R019N-F JAE C 20K 0603 HDMI_3.3V 8 X 1 CONNECTOR 8P_2_THRUHOLE B8B-PH-K-S AN_5V SH1 HDMI_5V1 3.3V 3.3V 3.3V GND GND GND 6V GND New connector AN_5V 0603 TMDS DATA2+ TMDS DATA2 SHIELD TMDS DATA2TMDS DATA1+ TMDS DATA1 SHIELD TMDS DATA1TMDS DATA0+ TMDS DATA0 SHIELD TMDS DATA0TMDS CLOCK+ TMDS CLOCK SHIELD TMDS CLOCKCEC RESERVED SCL SDA DDC/CEC Ground +5V power Hot Plug Detect 2N7002 SOT-23 P1534 1 2 3 4 5 6 7 8 C1269 + 68UF_10V TANT_C C1274 .1UF C1270 + 0603 68UF_10V TANT_C 0603 0603 0603 RXA2RXA1+ P8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 ACM2012D-900-2P 4P_2012M Q1 P1254 UOC_G 4 C3 470UF_16V 8X11.5 FB7 MLB-451616-0050P-N1 4516M 1005 UOC_R 1 L1 HSCLA HSDAA 1533 3 X 1 CONNECTOR* 3P_2.5_THRUHOLE B3B-EH-A C1247 100PF 0603 RXA2+ R6 100* 0603 100* 0603 <2004.12.20-Bryan> For EMC : C1247,C1248 3.3V 3.3V Vaux_GND Vaux_GND +10VA (9.8~11) Vaux_GND1 POWER_DOWN stby_en Vaux_GND1 +6VA (5.5~6) +6VA (5.5~6) Vaux_GND 1 2 3 4 5 6 7 8 9 10 11 12 12X1 CONNECTOR B12B-PH-K-S 12P_2_THRUHOLE C1273 .1UF 0603 DNS C HDMI_5V0 EXT_3.3V 1206 RV1 0402 <2004.12.20-Bryan> For EMC, 5pF(DNS) -> 100pF RXB2+ 1 L5 4 RXB2RXB1+ 2 1 L6 3 4 RXB1RXB0+ 2 1 L7 3 4 RXB0RXBC+ 2 1 L8 3 4 RXBC- 2 3 P11 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 ACM2012D-900-2P* 4P_2012M ACM2012D-900-2P* 4P_2012M ACM2012D-900-2P* 4P_2012M ACM2012D-900-2P* 4P_2012M R9 47K* 0603 HDAN_5V1 HSCLB HSDAB D4 HDMI_5V1 BAT754* SOT-23 P1_HRRMV Q2 R17 2N7002* SOT-23 1250 1K* 0603 R18 TMDS DATA2+ TMDS DATA2 SHIELD TMDS DATA2TMDS DATA1+ TMDS DATA1 SHIELD TMDS DATA1TMDS DATA0+ TMDS DATA0 SHIELD TMDS DATA0TMDS CLOCK+ TMDS CLOCK SHIELD TMDS CLOCKCEC RESERVED SCL SDA DDC/CEC Ground +5V power Hot Plug Detect SH1 SH2 HDMI CONNECTOR* 19P_DIP DC1R019N-F JAE 20K* 0603 B DNS STBY_3.3V MLB-160808-0120A-N2 FB4 0603 R15 10K 5% MLB-160808-0120A-N2 PC_RXD 1219 <2004.12.20-Bryan> For EMC: 1) C1251,C1252 Add 2) R13, R14 -->FB1205, FB1206 P1546 1 X 1 CONNECTOR SL_THRUHOLE 0-10645-1 SPADE LUG AMP 1 2 3 4 5 6 FB1206 0603 25% MLB-160808-0120A-N2 RV3 CT0402S14AHSG 0402 C1251 100PF 0603 C1252 100PF 0603 Tx GND Rx 1 2 3 S3B-PH-K-S 3P_2_THRUHOLE RV4 0402 CT0402S14AHSG FB5 0603 EXT_Y SPDIF EXT_Pb AUDIOL_IN MLB-160808-0120A-N2 FB106 0603 25% MLB-160808-0120A-N2 AUDIOR_IN EXT_Pr FB105 0603 25% MLB-160808-0120A-N2 FB6 0603 STBY_3.3V P1101 RV5 RV6 RV7 CT0402S14AHSG CT0402S14AHSG CT0402S14AHSG 0402 0402 0402 1 1P_CON* Note: It cannot directly hook it up with PC serial port without the transceiver P1208 A RV103 CT0402S14AHSG 0402 MLB-160808-0120A-N2 UOC_AR_IN R audio o/p of analog source L audio o/p of analog source GND 1 2 3 FB112 0603 25% 3 X 1 CONNECTOR 3P_2_THRUHOLE B3B-PH-KL MLB-160808-0120A-N2 UOC_AL_IN C16 5PF 0603 1208 <2004.12.20-Bryan> For EMC 1) C16,C17 --> Stuff 2) R42, R43 --> FB112, FB113 3) RV105, RV106 --> Change location FB113 0603 25% C17 5PF 0603 RV104 CT0402S14AHSG 0402 P15 6 5 4 X 1 CONNECTOR 4P_2_THRUHOLE B4B-PH-K-S P13 FB1205 0603 25% 3 A B C 9 2 D E F 8 TH1 1 2 3 4 5 6 7 8 GND1 GND2 GND3 GND4 GND5 GND6 GND7 GND8 SHIELD_HOLE 0.5pie x8 TH2 1 2 3 4 5 6 7 8 GND1 GND2 GND3 GND4 GND5 GND6 GND7 GND8 SHIELD_HOLE 0.5pie x8 TH3 1 2 3 4 5 6 7 8 GND1 GND2 GND3 GND4 GND5 GND6 GND7 GND8 SHIELD_HOLE 0.5pie x8 TH4 1 2 3 4 5 6 7 8 7 AUDIOL_O PC_TXD 4 R audio of ATSC GND L audio of ATSC GND 1 2 3 4 AUDIOR_O MLB-160808-0120A-N2 1 P1219 DWRS-609B 9P_8.2_RCA Color Red White Orange Red Blue Green Position A/R A/L SPDIF Pr Pb Y A GND1 GND2 GND3 GND4 GND5 GND6 GND7 GND8 SHIELD_HOLE 0.5pie x8 F_15060_028.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 5 4 3 2 1 HDMI_3.3V HDAN_5V1 ATSC11 C1227 .1UF* 0603 VPA[11:4] RXB0RXB0+ RXB1RXB1+ RXB2RXB2+ RXBCRXBC+ D DSCL1 DSDA1 MCL MDA AV_3.3V AN_3.3V AV_3.3V FB1201 0603 MLB-160808-0120P-N2 C1204 .1UF 0603 C1205 .1UF 0603 AVIO_3.3V FB1202 0603 MLB-160808-0120P-N2 R_IN HDMI_1.8V AV_1.8V FB1203 0603 MLB-160808-0120P-N2 Pr_IN C1207 Y_IN C1208 Pb_IN C1209 .047UF 0603 .047UF 0603 .047UF 0603 1000PF 0603 C1210 AVPLL_1.8V FB1204 0603 MLB-160808-0120P-N2 B_IN HS_IN VS_IN AVIO_3.3V C1211 .1UF 0603 G_IN C1212 .1UF 0603 C1213 .1UF 0603 HS_IN HS_IN AV_1.8V VS_IN VS_IN AVPLL_1.8V C C1214 .1UF 0603 C1215 .1UF 0603 C1216 .1UF 0603 C1217 .1UF 0603 C1218 .1UF 0603 C1219 .1UF 0603 AVPLL_1.8V C1224 .082UF 0603 HDAN_5V1 C1225 8200PF 0603 R1217 1.5K 0603 R1233 4.7K 0603 WP2 RX0RX0+ RX1RX1+ RX2RX2+ RXC+ RXC- R0 R1 R2 R3 R4 R5 R6 R7 99 98 97 96 95 94 93 92 VPA4 VPA5 VPA6 VPA7 VPA8 VPA9 VPA10 VPA11 49 50 51 52 DDC_SCL DDC_SDA MCL MDA 33 45 TVDD TVDD 9 8 7 6 5 4 3 2 RDE8 RDE9 RDE10 RDE11 RDE12 RDE13 RDE14 RDE15 36 39 42 G0 G1 G2 G3 G4 G5 G6 G7 TGND TGND TGND 77 79 71 74 66 68 70 73 63 64 60 61 RAIN1 RAIN0 GAIN1 GAIN0 BAIN1 BAIN0 SOG1 SOG0 HS1 HS0 VS1 VS0 B0 B1 B2 B3 B4 B5 B6 B7 19 18 17 16 15 14 13 12 HSOUT VSOUT/A0 DCLK DE SOGOUT FIELD 87 85 89 88 86 84 10 90 100 OVDD OVDD OVDD DVDD 32 48 CVDD CVDD 20 21 22 23 24 25 26 27 28 R1220 10K 30 MCLKIN MCLKOUT SCLK LRCLK I2S3 I2S2 I2S1 I2S0 SPDIF 54 ALVDD RTERM 46 R1213 499 56 59 PVDD PVDD PWRDN 81 SDA SCL 83 82 31 47 1 11 91 29 CGND CGND OGND OGND OGND DGND AVDD AVDD AVDD AVDD 80 76 72 67 53 ALGND 55 58 PGND PGND AGND AGND AGND AGND 78 75 69 65 EXT_CLK_COAST 62 57 C1241 1000pF* 0603 P1201 34 35 37 38 40 41 43 44 1 FILT U1202 1 2 3 4 U1201 A0 A1 A2 GND VCC WP SCL SDA 8 7 6 5 WP2 R1227 4.7K* 0603 R1228 4.7K* 0603 R1232 470K* 0603 DSCL1 DSDA1 CAT24FC02* SO8 Q1205 BSN20* SOT-23 R1229 100* 0603 RDE[15:8] R1231 470K* 0603 Q1204 BSN20* SOT-23 HSCLB HSDAB D HDMI_3.3V R1230 100* 0603 DNS RHSYNC RVSYNC RODCK RDE 0603 AVIO_3.3V R1214 10K 0603 C 0603 AVIDEO_PD UC_SDA UC_SCL C1220 .1UF 0603 C1221 .1UF 0603 AV_3.3V C1222 .1UF 0603 C1223 .1UF 0603 HDMI_3.3V C1228 .1UF* 0603 U1203 1 2 3 4 AD9880 ST-100 A0 A1 A2 GND VCC WP SCL SDA 8 7 6 5 R1235 4.7K* 0603 R1236 4.7K* 0603 MCL MDA CAT24FC02* SO8 DNS Current consumption 1.8V Logic: 55mA (typ.) 1.8V PLL: 13.5mA (typ.) 3.3V analog: 325mA (typ.) 3.3V Output: 33mA (typ.) 1P_CON* DNS B B +10V R1202 470* 1210 C1226 10UF* 1206 MLI160808-R56K L1207 0.56UH,10% 0603 Close to AD9880 3 R1237 0 0603 1 R1221 68 0603 3 R1238 0 0603 1 3 R1239 0 0603 1 Q1202 BC847ALT1G* SOT23 R1241 0 0603 1UH,10% 0603 R1222 1K* 0603 R1223 68 0603 A 3.3UH,10% 0805 C1229 560PF 0603 MLI160808-1R0K L1202 Q1203 BC847ALT1G* SOT23 R1242 0 0603 ML160808-3R3K L1205 1UH,10% 0603 R1224 1K* 0603 R1225 68 0603 ML160808-3R3K L1206 1UH,10% 0603 3.3UH,10% 0805 0.56UH,10% 0603 1UH,10% 0603 C1239 100PF 0603 MLI160808-R56K L1209 MLI160808-1R0K L1212 0.56UH,10% 0603 1UH,10% 0603 Pr_IN EXT_Pr C1237 220PF 0603 .047UF 0603 C1233 560PF 0603 MLI160808-1R0K L1203 MLI160808-1R0K L1211 C1236 220PF 0603 C1202 3.3UH,10% 0805 C1230 560PF 0603 MLI160808-R56K L1208 .047UF 0603 C1232 560PF 0603 C1238 100PF 0603 Pb_IN EXT_Pb C1201 G_IN 2 UOC_B ML160808-3R3K L1204 R_IN 2 UOC_G MLI160808-1R0K L1201 1UH,10% 0603 C1235 220PF 0603 R1240 0 0603 2 UOC_R Q1201 BC847ALT1G* SOT23 MLI160808-1R0K L1210 Y_IN EXT_Y C1240 100PF 0603 R3 75 0603 R4 75 0603 R5 75 0603 C1203 B_IN R1226 1K* 0603 C1231 560PF 0603 C1234 560PF 0603 R1201 75 0603 R1203 75 0603 R1204 75 0603 A .047UF 0603 DNS F_15060_029.eps 150305 xxxx xxx xxxx.x 5 4 3 2 1 Alignments L05.1U AA 8. EN 61 8. Alignments 4. 5. 6. 7. 8. 9. Index of this chapter: 8.1 General Alignment Conditions 8.2 Hardware Alignments 8.3 Software Alignments and Settings Note: • The Service Default Mode (SDM) and Service Alignment Mode (SAM) are described in chapter 5 “Service Modes, ...”. • Menu navigation is done with the CURSOR UP, DOWN, LEFT, or RIGHT keys of the remote control transmitter. 8.1 10. General Alignment Conditions 11. Perform all electrical adjustments under the following conditions: • AC voltage and frequency (region dependent): – 120 V_ac / 60 Hz, or – 240 V_ac / 50 Hz. • Connect the set to the AC power (a.k.a. Mains voltage) via an isolation transformer with a low internal resistance. • Allow the set to warm up for approximately 20 minutes. • Measure the voltages and waveforms in relation to chassis ground (with the exception of the voltages on the primary side of the power supply). Never use the cooling fins / plates as ground. • Test probe: Ri > 10 Mohm; Ci < 2.5 pF. • Use an isolated trimmer / screwdriver to perform the alignments. 8.2 12. 13. Go, via the MENU key, to the normal user menu and set SATURATION/COLOR to “0”. CONTRAST to “0”. BRIGHTNESS to minimum (OSD just visible). Return to the SAM via the MENU key. Connect the RF output of a pattern generator to the antenna input. Test pattern is a 'black' picture (blank screen on CRT without any OSD info) with a signal strength of 1 V_pp. Set the channel of the oscilloscope to 50 V/div and the time base to 0.2 ms (external triggering on the vertical pulse). Ground the scope at the CRT panel and connect a 10:1 probe to one of the cathodes of the picture tube socket. Measure the cut off pulse during first full line after the frame blanking (see figure “V_cutoff waveform”). You will see two pulses, one being the “cut off” pulse and the other being the “white drive” pulse. Choose the one with the lowest value; this is the “cut off” pulse. Select the cathode with the highest V_dc value for the alignment. Adjust the V_cutoff of this gun with the SCREEN potentiometer (see figure “Top view family board”) on the LOT to 160 V_dc, except for the 25/28BLD picture tube (Black Line Display, for EU only); this tube must be aligned to 140 V_dc. Restore BRIGHTNESS and CONTRAST to normal (= 31). max. VCUTOFF [VDC] Hardware Alignments 0V Ref. E_06532_011.eps 110204 Figure 8-2 V_cutoff waveform 1506 1504 5512 7601 SDM 9252 1221 1204 LOT Focus Screen VG2 1005 ComPair F_15050_066.eps 170205 Figure 8-1 Top view family board 8.2.1 Focusing 1. Tune the set to a circle or crosshatch test pattern (use an external video pattern generator). 2. Choose picture mode NATURAL with the SMART PICTURE button on the remote control transmitter. 3. Adjust the FOCUS potentiometer (see figure “Top view family board”) until the vertical lines at 2/3 from east and west, at the height of the centerline, are of minimum width without visible haze. 7990 1000 (TUNER) 8.2.2 Vg2 Adjustment 1. Activate the SAM. 2. Go to the WHITE TONE sub menu. 3. Set the values of NORMAL RED, GREEN and BLUE to “32”. EN 62 8.3 8. L05.1U AA Alignments Software Alignments and Settings 00028 L05U 0.12 SDM ERR 0 0 0 0 0 OP 000 057 140 032 120 128 000 SAM . OP1 . OP2 . OP3 . OP4 . OP5 . OP6 . OP7 00028 L05U 0.12 ERR 0 0 0 0 0 0 57 140 32 120 128 0 SAM . Delta Cool Red -3 . Delta Cool Green -1 . Delta Cool Blue 5 SAM SAM SAM OP 000 057 140 032 120 128 000 . Clear . Options . AKB . Tuner . White Tone . Geometry . Audio . NVM Editor . ComPair Clear ? . IFPLL . AGC . CL 32 30 10 . Normal Red . Normal Green . Normal Blue 32 35 41 On on SAM 1 00028 L05U 0.12 CSM 2 CODES 0 0 0 0 0 3 OP 000 057 140 032 120 128 000 4 nnXXnnnn/nnX 5 P3C-1 6 NOT TUNED 7 NTSC 8 STEREO 9 CO 50 CL 50 BR 50 HU 0 0 AVL Off BS 50 . Cool . Normal . Warm SAM . Delta Warm Red 2 . Delta Warm Green -3 . Delta Warm Blue -13 SAM . Horizontal . Vertical SAM .HP 37 .HB 31 .HSH 34 .EWW 45 .EWP 14 .EWT 27 .UCP 42 .LCP 53 SAM . QSS Off . FMI On SAM .SBL OFF .VSH 29 .VS 37 .VAM 30 .VSC 25 SAM .ADR .VAL .Store 0x0000 0x0000 Store ? 0 0 F_15060_053.eps 210305 Figure 8-3 Service Mode overview Alignments 8.3.1 Options Options are used to control the presence/absence of certain features and hardware. How to change an Option Byte An Option Byte represents a number of different options. Changing these bytes directly, makes it possible to set all options very fast. All options are controlled via seven option bytes. Select the option byte (OP1.. OP7) with the MENU UP/ DOWN keys, and enter the new value. Leaving the OPTION submenu saves the changes in the Option Byte settings. Some changes will only take effect after the set has been switched “off” and “on” with the AC power switch (cold start). How to calculate the value of an Option Byte • Calculate an Option Byte value (OP1 .. OP7) in the following way: • Check the status of the single option bits (OB): are they enabled (1) or disabled (0). • When an option bit is enabled (1) it represents a certain value (see column “Bit value” in table below). When an option bit is disabled, its value is 0. • The total value of an Option Byte (decimal) is formed by the sum of its eight option bits. The factory values are printed on a sticker on the CRT (depends on region). Table 8-1 Option Byte calculation OP2 32PT21705 27PT21714 30PW21709 26PW21718 Option Name Philips Tuner 1 1 1 1 6 Not Used 0 0 0 0 5 Not Used 0 0 0 0 4 Not Used 0 0 0 0 3 Not Used 0 0 0 0 2 Not Used 0 0 0 0 1 Not Used 0 0 0 0 0 Not Used 0 0 0 0 OP1 value (dec) 128 128 128 128 OP1 value (hex) 80 80 80 80 7 Not Used 0 0 0 0 6 Green_UI 0 0 0 0 5 Not Used 0 0 0 0 4 Not Used 0 0 0 0 3 Tilt 1 1 0 1 2 Fine_Tuning 0 0 0 0 1 Not Used 0 0 0 0 0 Not Used 0 0 0 0 OP2 value (dec) 8 8 0 8 OP2 value (hex) 08 08 00 08 7 Not Used 0 0 0 0 6 ATI_PIP 1 1 1 1 5 Not Used 0 0 0 0 4 Not Used 0 0 0 0 3 Virtual Dolby 1 1 1 1 2 Wide Screen 1 1 0 0 1 Not Used 0 0 0 0 0 Not Used 0 0 0 0 OP3 value (dec) 76 76 72 72 OP3 value (hex) 4C 4C 48 48 OP1 OP2 OB10 OB20 OB30 OB40 OB50 OB60 OB70 1 (2) OB11 OB21 OB31 OB41 OB51 OB61 OB71 OP4 value (dec) 0 0 0 0 2 (4) OB12 OB22 OB32 OB42 OB52 OB62 OB72 OP4 value (hex) 00 00 00 00 3 (8) OB13 OB23 OB33 OB43 OB53 OB63 OB73 4 (16) OB14 OB24 OB34 OB44 OB54 OB64 OB74 OP4 5 (32) OB15 OB25 OB35 OB45 OB55 OB65 OB75 7 AV1 1 1 1 1 6 (64) OB16 OB26 OB36 OB46 OB56 OB66 OB76 6 AV2 1 1 1 1 7 (128) OB17 OB27 OB37 OB47 OB57 OB67 OB77 5 AV3 1 1 1 1 Total: Sum 4 CVI 1 1 1 1 3 SVHS2 1 1 1 1 2 SVHS3 1 1 1 1 1 HDMI 1 1 1 1 0 YPbPr 1 1 1 1 OP5 value (dec) 255 255 255 255 OP5 value (hex) FF FF FF FF 7 QUADRA_SURF 0 0 0 0 6 SMART_SURF 0 0 0 0 5 Not Used 0 0 0 0 4 Comb filter 1 1 1 1 3 Active control 1 1 1 1 2 Not Used 0 0 0 0 1 Not Used 0 0 0 0 0 Not Used 0 0 0 0 OP6 value (dec) 24 24 24 24 OP6 value (hex) 18 18 18 18 Sum OP6 7 OP1 Sum OP5 OP0 0 (1) Sum OP4 EN 63 Bit (value) Sum OP3 8. Table 8-2 Option code overview per model (OP0 - OP5) Option Bit Enter the Service Alignment Mode (see also chapter 5 “Service Modes, ....”). The SAM menu will now appear on the screen. Select one of the following alignments: • Options • Tuner • White Tone • Geometry • Audio L05.1U AA Sum OP7 Sum Option Bit Assignment Following are the option bit assignments for all software clusters. OP3 Not Used OP5 EN 64 8. Alignments L05.1U AA Table 8-3 Option code overview per model (OP6) 32PT21705 27PT21714 30PW21709 26PW21718 Option Bit Option Name • • OP6 7 Not Used 0 0 0 0 6 Not Used 0 0 0 0 5 Not Used 0 0 0 0 4 Not Used 0 0 0 0 3 Digital_Module_Reset_Control 1 1 1 1 2 Not Used 0 0 0 0 1 Not Used 0 0 0 0 0 Not Used 0 0 0 0 OP7 value (dec) 0 0 0 0 Option Byte 6 (OP6) • OB67: QUADRA_SURF – 0 : Quadra Surf feature is disabled or not applicable. – 1 : Quadra Surf feature is enabled. • OB66: OP_SMART_SURF – 0 : Smart Surf key is not used on remote control. – 1 : Smart Surf key is used on remote control. • OB64: COMBFILTER – 0 : 3D-combfilter is not present. – 1 : 3D-combfilter is present. • OB63: ACTIVE CONTROL – 0 : Active Control feature is disabled or not applicable. – 1 : Active Control feature is enabled. Option bit definition Option Byte 1 (OP1) • OB17: PHILIPS TUNER – 0 : ALPS / MASCO compatible tuner is in use. – 1 : Philips compatible tuner is in use. Option Byte 2 (OP2) • OB26: GREEN UI – 0 : Green UI is disabled (for Philips brand). – 1 : Green UI is enabled (for Magnavox brand). – Note: only for NAFTA region. • OB23: TILT – 0 : Rotate Picture is disabled or not applicable. – 1 : Rotate Picture is enabled. • OB22: FINE TUNING – 0 : Fine Tuning for Channel Offset is disabled or not applicable. – 1 : Fine Tuning for Channel Offset is enabled. Note: Quadra Surf option is only applicable for Philips branded sets. Option Byte 7 (OP7) • OB73: Digital Module Reset Control – 0: Reset control is not used. – 1: Reset control is used. 8.3.2 Tuner Note: Described alignments are only necessary when the NVM (item 7601) is replaced. IF PLL This adjustment is auto-aligned. Therefore, no action is required. Option Byte 3 (OP3) • OB36: ATI_PIP – 0 : PIP feature is disabled – 1 : PIP feature is enabled • OB33: VIRTUAL DOLBY – 0 : Virtual Dolby is not applicable. – 1 : Virtual Dolby is applicable. • OB32: WIDE SCREEN – 0 : Software is used for 4:3 sets or not applicable. – 1 : Software is used for 16:9 sets. AGC (AGC take over point) 1. Set the external pattern generator to a color bar video signal and connect the RF output to aerial input. Set amplitude to 10 mV and set frequency to 61.25 MHz (channel 3). 2. Connect a DC multimeter to pin 1 of the tuner (item 1000 on the main panel). 3. Activate the SAM. 4. Go to the TUNER sub menu. 5. Select AGC with the UP/DOWN cursor keys. 6. Adjust the AGC-value with the LEFT/ RIGHT cursor keys until the voltage at pin 1 of the tuner lies between 3.8 and 2.3 V (default value is “20”). 7. Switch the set to STANDBY, in order to store the alignments. Option Byte 4 (OP4) This option byte is not used. Option Byte 5 (OP5) • OB57: AV1 – 0 : AV1 source is not present. – 1 : AV1 source is present. • OB56: AV2 – 0 : AV2 source is not present. – 1 : AV2 source is present. – Note : For EU, when AV2=“1”, both EXT2 and SVHS2 should be included in the OSD loop. • OB55: AV3 – 0 : Side/Front AV3 source is not present. – 1 : Side/Front AV3 source is present. • OB54: CVI – 0 : CVI source is not available. – 1 : CVI source is available. • OB53: SVHS2 – 0 : SVHS2 source is not available. – 1 : SVHS2 source is available. – Note : This option bit is not applicable for EU. • OB52: SVHS3 – 0 : SVHS3 source is not available. – 1 : SVHS3 source is available. – Note : This option bit is not applicable for EU. OB51: HDMI – 0 : HDMI source is not present. – 1 : HDMI source is present. OB50: YPbPr – 0: YPbPr source is not present. – 1: YPbPr source is present. CL (Cathode drive level) Always set to “5”. 8.3.3 White Tone In the WHITE TONE sub menu, the values of the black cut off level can be adjusted. Normally, no alignment is needed, and you can use the given default values. The color temperature mode (NORMAL, COOL and WARM) and the color (R, G, and B) can be selected with the UP/DOWN RIGHT/LEFT cursor keys. The value can be changed with the LEFT/RIGHT cursor keys. First, select the values for the NORMAL color temperature. Then select the values for the COOL and WARM mode. After alignment, switch the set to STANDBY, in order to store the alignments. Alignments 8.3.4 Geometry • The geometry alignments menu contains several items to align the set, in order to obtain correct picture geometry. • • 1 VERT. SLOPE 2 VERT. SHIFT 3 VERT. AMPLITUDE 4 V.S-CORRECTION 5 HOR. SHIFT 6 HOR. AMPLITUDE 7 E/W PARABOLE 8 UPPER E/W CORNER L05.1U AA 8. EN 65 Lower Corner Parabola (LCP). Align straight vertical lines in the lower corners of the screen. East West S correction (EWS). Default value is “16”. East West Corner (EWC). Align straight vertical lines at the top and bottom of the sides. Vertical • Service blanking (SBL). Switch the blanking of the lower half of the screen “on” or “off” (to be used in combination with the vertical slope alignment). • Vertical Shift (VSH). Align the vertical centering so that the test pattern is located vertically in the middle. Repeat the 'vertical amplitude' alignment if necessary. • Vertical Amplitude (VAM). Align the vertical amplitude so that the complete test pattern is visible. • Vertical S-Correction (VSC). Align the vertical linearity, meaning that vertical intervals of a grid pattern must be equal over the entire screen height. • Vertical Zoom (VX, if present). The vertical zoom is added in for the purpose of development. It helps the designer to set proper values for the movie expand or movie(16x9) compress. Default value is “25”. • Vertical Symmetry (VSL). Fine tune the vertical centering. Only perform this alignment if it is strictly necessary. • Vertical Linearity (VL). Align the top half and bottom half of the picture to be of equal height. 8.3.5 Audio No alignments are needed for the audio sub menu. Use the given default values. 9 LOWER E/W CORNER 10 E/W TRAPEZIUM 11 HOR. PARALLELOGRAM 12 HOR. BOW E_06532_010.eps 110204 Figure 8-4 Geometry alignments 1. Connect an external video pattern generator to the aerial input of the TV-set and input a crosshatch test pattern. Set the generator amplitude to at least 1 mV and set frequency to 61.25 MHz (channel 3). 2. Set 'Smart Picture' to NATURAL (or MOVIES). 3. Activate the SAM menu (see chapter 5 “Service Modes, ...”). 4. Go to the GEOMETRY sub menu. 5. Choose HORIZONTAL or VERTICAL alignment. Now the following alignments can be performed: Horizontal • Horizontal Parallelogram (HP). Align straight vertical lines in the top and the bottom; vertical rotation around the center. • Horizontal Bow (HB). Align straight horizontal lines in the top and the bottom; horizontal rotation around the center. • Horizontal Shift (HSH). Align the horizontal center of the picture to the horizontal center of the CRT. • East West Width (EWW). Align the picture width until the complete test pattern is visible. • East West Parabola (EWP). Align straight vertical lines at the sides of the screen. • East West Trapezium (EWT). Align straight vertical lines in the middle of the screen. • Upper Corner Parabola (UCP). Align straight vertical lines in the upper corners of the screen. FMI (Freq. Modulation Intercarrier) • For NICAM/2CS sound system (EU/AP, except for APNTSC): set to “On”. • For AV-Stereo sound system (sets without NICAM): set to “Off”. • For dBx/non-dBx sound systems: set to “On”. EN 66 9. L05.1U AA Circuit Descriptions, List of Abbreviations, and IC Data Sheets 9. Circuit Descriptions, List of Abbreviations, and IC Data Sheets Index of this chapter: 9.1 Introduction 9.2 Power Supply 9.3 Video Processing 9.4 Audio Processing 9.5 Deflection Controller 9.6 Abbreviation List 9.7 IC Data Sheets 9.2 Notes: • Only new circuits compared to the L05U chassis are described in this chapter. For the other circuit descriptions, see the manual of the L05U chassis. • Because the service offering for the ATSC part is “Repair by supplier” this part is not described in this chapter. • Figures can deviate slightly from the actual situation, due to different set executions. • For a good understanding of the following circuit descriptions, please use the diagrams in sections “Block Diagrams, ...”, and/or “Electrical Diagrams”. Where necessary, you will find a separate drawing for clarification. 9.1 F_15060_052.eps 180305 Figure 9-1 Power supply block diagram The supply is divided into two sections, the Auxiliary and Main section, both located on the family board. A single filter and rectifier circuit supplies both sections. The Auxiliary supply operates in a low power mode when the load is reduced. In the standby mode, the 3.3 and 6 volt supplies are operating. The 3.3 volt supply provides power to the processor section of the Hercules. The 6 volt supply provides power to the IR receiver. The Main supply is switched Off via the Standby line. Introduction The L05 ATSC chassis is designed for the model year 2005. This set has a fully integrated ATSC as well as a NTSC tuning system. This set will come in a 26 and 30 inch screen sizes in a 16x9 format. There will be a 32 inch version using a 4x3 ratio screen. When the set is turned On, the "B" line from the Hercules processor goes High switching 7547 which turns 7535, 7509, and 7545 On. The +3V3A, +6VA, +12VA, and +8VA supplies are then switched On. The load placed on the Aux Power supply will cause it to switch to the full power mode. At the same time, the STBY line switches Low turning the Main SMPS supply On. The supply produces a +6 volt, +140 volt, -16 volt, and +16 volt supplies. The set consists of a Main panel, CRT board, Side I/O panel, ATSC module, and Deflection controller panel. The panels consists primarily of conventional components with some surface mounted devices. The The functions for the 1fH video processing is performed in one IC (TDA1200xx, IC7200), the Hercules chip. This IC is located on the solder side of the Main panel. NTSC tuning and switching for AV1, AV2, and CVI inputs are performed on the Main panel. The CVI input located on the Main panel are for 1fH (480i) signals only. The ATSC Tuner and 1fH to 2Fh conversion is performed on the ATSC module. Component inputs for the CVI HD and HDMI are located on the ATSC module. This input can accept 480i, 480p, 1080i, or 720p signals. The ATSC module converts whatever signal is applied to a 1080i format. The ATSC tuning system can tune all channels in the VHF, UHF, and Cable bands. The Microprocessor communicates with the memory IC located on the Main panel, Keyboard, Remote Receiver, NTSC Tuner, Deflection Controller panel, and ATSC module. The Memory IC retains the settings for favorite stations, customer-preferred setting, and circuit settings. The circuit settings can be accessed by the service technician via the Service Alignment Mode. On-screen graphics and Closed Caption decoding are performed in IC 7200 for NTSC. IC7200 is located on the Main signal panel. On-screen graphics and Closed Caption for the ATSC channels are performed in the ATSC module.. Power Supply The +Vaudio (+16 volt) supply switches on the degauss relay. 9.2.1 Auxiliary Power Supply IC 7510 is the heart of the Auxiliary Power supply. In the Standby mode, via the current sensing and Control circuits, a low power condition is detected by the IC. The IC then goes into a Burst Mode operation to reduce the power used by the circuit. In the Burst Mode, the supply will operate at approximately 25 kHz. In full power operation the frequency will be approximately 66 kHz. When power is first applied to the set, Start up is supplied to the IC by the internal Start-Up current through Pin 14. Startup voltage is also applied to the IC to Pin 2 by the AC_IN line which is tied to the neutral side of the AC line. During normal operation, power is supplied to the IC by the HOT windings, Pins 1 and 2, of transformer 5504. Output drive from Pin 11 is applied to the Gate of Transistor 7525. Voltage developed across the current sensing resistors in the Source of 7525 provides current sense information to the IC. When 7525 is switched Off, the voltage on Pin 1 of 5504 goes High. This winding supplies the operating voltage the power supply circuit. It also turns Transistor 7567 On causing the Gate of 7525 to stay Low as long as Pin 1 of 5504 is High. This prevents 7525 from turning On until the field of 5504 has collapsed. Regulation is accomplished by monitoring the +3 volt supply. This voltage is fed to Shunt regulator 7542 which controls the current through opto-isolator 7516. Shunt Regulator 7542 begins conducting when Pin 3 of the IC reaches 2.5 volts. At Circuit Descriptions, List of Abbreviations, and IC Data Sheets this point current flows through the opto-isolator, 7516. The transistor inside 7516 turns On applying a control voltage to Pin 6 of 7510. If a problem should develop in the feedback circuit causing an excessive voltage on Pin 6, Transistor 7549-2 will turn On, switching Transistor 7532 On. This will a voltage to the Demag circuit on Pin 7 causing the IC to latch Off. The IC will stay latched until power is removed and reapplied to the set. In the Standby mode, the "B" control line from the Hercules Processor is Low. Only the +3, +3V3, and +6 volt supplies are present. When the set is turned On, the "B" line will go High, turning Transistors 7509, 7545, and 7535 On. This will switch On the +8VA, +12VA, +8V, +3V3A, +6VA, and +5V supplies. In normal operation, voltage from Pin 12 of 5504 is rectified by 6540 to produce a negative voltage which prevents Transistor 7561 from turning On. If AC is removed from the set, this negative voltage will disappear. The voltage across the filter capacitors on the +3V line will turn 7561 On. The Power Down line will then go Low signaling the processor to shut the set down. 9.2.2 Main Power Supply The Main Power supply provides the VBAT (141 volt), and Audio voltage supplies. This supply is switched Off during the Standby mode. During Standby the STBY_Con line is High which turns Transistor 7573 On. This causes the opto-isolator 7513 to turn On hard. This places a higher voltage on the control Pin of IC 7511 causing the IC to shut down. The operating voltage from the Auxiliary supply keeps a small voltage on Pin 2 of 7511 to prevent it from cycling On and Off. When the set is turned On, the STBY_Con line goes Low switching 7573 Off. The VBAT supply is the reference voltage for regulation. Since this voltage is missing during startup, the Shunt Regulator 7571 is turned Off. The voltage on Pin 6 of 7511 goes Low, which turns the drive from the IC On. When the set is On during normal operation, the supply voltage on Pin 2 of the IC is supplied by Pin 2 of Transformer 5512. When the VBAT supply reaches the correct voltage, Pin 3 of the Shunt Regulator 7571 reaches 2.5 volts switching it On. This switches the opto-isolator On to provide a regulation feedback path. Transistor 6551 provides a power on ramping of the VBAT supply. 9.3 Video Processing The video processing section located on the Mono Carrier performs all of the 1fH processing. AV1, AV2, CVI, and Side inputs are fed to this board. The CVI input on this board will only accept 1fH signals. 1fH RGB signals from the Hercules are fed to the ATSC module via the deflection controller board. The ATSC module rescales the picture from the Hercules. It also has an HDMI and CVI connection. The HDMI and CVI connections can accept either 480i, 480p, 720p, or 1080i. The ATSC module also has a built in Digital Tuner. The ATSC module resizes the picture to 1080i regardless of the input. 9.4 Audio Processing The audio decoding is done entirely via the Hercules, IC 7200. The analogue IF output from the Tuner is fed directly to either the Video-IF or the Sound-IF input depending on the type of concept chosen. There are mainly two types of decoder in the Hercules, an analog decoder that decodes only Mono, regardless of any standards, and a digital decoder (or DEMDEC) that can decode both Mono as well as Stereo, again regardless of any standards. Audio from the ATSC board is fed to the Hercules. 9.5 L05.1U AA 9. EN 67 Deflection Controller The Deflection panel performs the signal processing and Deflection processing functions. YPbPr from the ATSC module is fe to 7402 signal processor. This circuit performs the Color, Tint, Brightness, and Contrast control functions. The Y signal is fed to a Sync Separator to separate the Horizontal and Vertical Sync which is output on Pins 37 and 35. RGB is output on Pins 12, 13, and 14. These signals are sent to the CRT panel. Horizontal drive is output on Pin 37 where it is fed to the deflection circuits on the Family board. Vertical Sync is output on Pin 35 of 7402 to IC 7404. IC 7404 develops the Vertical and EW drivefor the deflection circuits. DC monitor signals are output on Pins 4, 6, and 7 of 7402 and fed to an Undervoltage detection circuit. If a positive or negative voltage develops on any of these lines, this circuit will force Pin 21 of 7404 Low, causing the set to shut down. The shutdown is actaviated when Pin 21 goes below 5 volts. EN 68 9.6 9. L05.1U AA Circuit Descriptions, List of Abbreviations, and IC Data Sheets Abbreviation List 2CS ACI ADC AFC AFT AGC AM AP AR ATS ATSC AV AVL BCL B/G BTSC CC CCC ComPair CRT CSM CTI CVBS CVI DAC DBX D/K DFU DNR DSP DST DVD EEPROM EHT EHT-INFO EPG EU EW EXT FBL FILAMENT FM H HP I 2 Carrier (or Channel) Stereo Automatic Channel Installation: algorithm that installs TV sets directly from cable network by means of a predefined TXT page Analogue to Digital Converter Automatic Frequency Control: control signal used to tune to the correct frequency Automatic Fine Tuning Automatic Gain Control: algorithm that controls the video input of the feature box Amplitude Modulation Asia Pacific region Aspect Ratio: 4 by 3 or 16 by 9 Automatic Tuning System Advanced Television Systems Committee; HDTV standard for the USA, using MPEG2 for video and Dolby Digital for audio External Audio Video Automatic Volume Leveler Beam Current Limitation Monochrome TV system. Sound carrier distance is 5.5 MHz Broadcast Television Standard Committee. Multiplex FM stereo sound system, originating from the USA and used e.g. in LATAM and AP-NTSC countries Closed Caption Continuous Cathode Calibration Computer aided rePair Cathode Ray Tube or picture tube Customer Service Mode Color Transient Improvement: manipulates steepness of chroma transients Composite Video Blanking and Synchronization Component Video Input Digital to Analogue Converter Dynamic Bass Expander or noise reduction system in BTSC Monochrome TV system. Sound carrier distance is 6.5 MHz Direction For Use: description for the end user Dynamic Noise Reduction Digital Signal Processing Dealer Service Tool: special remote control designed for dealers to enter e.g. service mode Digital Versatile Disc Electrically Erasable and Programmable Read Only Memory Extra High Tension Extra High Tension information Electronic Programming Guide Europe East West, related to horizontal deflection of the set External (source), entering the set via SCART or Cinch Fast Blanking: DC signal accompanying RGB signals Filament of CRT Field Memory or Frequency Modulation Horizontal sync signal Headphone I2C IF IIC ITV LATAM LED L/L' LS M/N NC NICAM NTSC NVM OB OC OP OSD PAL PCB PLL POR PTP RAM RC RGB ROM SDAM SAP SC S/C SCL SDA SECAM SIF SS STBY SVHS SW THD TXT uP UOC UVSH V V_BAT V-chip VCR Monochrome TV system. Sound carrier distance is 6.0 MHz Integrated IC bus Intermediate Frequency Integrated IC bus Institutional TV Latin American countries like Brazil, Argentina, etc. Light Emitting Diode Monochrome TV system. Sound carrier distance is 6.5 MHz. L' is Band I, L is all bands except for Band I Large Screen or Loudspeaker Monochrome TV system. Sound carrier distance is 4.5 MHz Not Connected Near Instantaneous Compounded Audio Multiplexing. This is a digital sound system, mainly used in Europe. National Television Standard Committee. Color system mainly used in North America and Japan. Color carrier NTSC M/N = 3.579545 MHz, NTSC 4.43 = 4.433619 MHz (this is a VCR norm, it is not transmitted off-air) Non Volatile Memory: IC containing TV related data e.g. alignments Option Bit Open Circuit Option Byte On Screen Display Phase Alternating Line. Color system mainly used in West Europe (color carrier = 4.433619 MHz) and South America (color carrier PAL M = 3.575612 MHz and PAL N = 3.582056 MHz) Printed Circuit board Phase Locked Loop. Used for e.g. FST tuning systems. The customer can give directly the desired frequency Power-On Reset Picture Tube Panel (or CRT-panel) Random Access Memory Remote Control handset Red, Green, and Blue video signals Read Only Memory Service Default / Alignment Mode Second Audio Program Sandcastle: pulse derived from sync signals Short Circuit Serial Clock Serial Data SEequence Couleur Avec Memoire. Color system mainly used in France and East Europe. Color carriers = 4.406250 MHz and 4.250000 MHz Sound Intermediate Frequency Small Screen Standby Super Video Home System Software Total Harmonic Distortion Teletext Microprocessor Ultimate One Chip UHF, VHF, S-, and Hyper- band Vertical sync signal Main supply voltage for the deflection stage (mostly 141 V) Violence Chip Video Cassette Recorder Circuit Descriptions, List of Abbreviations, and IC Data Sheets WYSIWYR XTAL YC What You See Is What You Record: record selection that follows main picture and sound Quartz crystal Luminance (Y) and Chrominance (C) signal L05.1U AA 9. EN 69 EN 70 9.7 9. Circuit Descriptions, List of Abbreviations, and IC Data Sheets L05.1U AA IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs). 9.7.1 Diagram H, TDA9178 (IC7610) BLOCK DIAGRAM Sout spectral processing Luminance vector processing Yin Uin Vin Y inputstage luminance processing smart peaking LTI VDC black stretch histogram processing gamma control U,V Yout + output stage Uout Vout CDS colour vector processing Vcc CTI colour processing supply skin tone correction green enhancement blue stretch ground Sandcastle delay control saturation correction DECDIG CF window generation noise measuring "cue flash" calibrate ADC featuremode detection I 2C ADext1 (low frequencies) ADext2 (low frequencies) ADext3 (low frequencies) I2C-control PIN CONFIGURATION Sc 1 24 Nc Nc 2 23 Nc ADEXT1 3 22 CF ADEXT2 4 21 Sout ADEXT3 5 20 Vcc Yin 6 19 Yout TDA9178 ADR 7 18 Vee Uin 8 17 Uout Vin 9 16 Vout TP 10 15 DECDIG SCL 11 14 SDA Nc 12 13 Nc E_14480_075.eps 270204 Figure 9-2 Internal Block Diagram and Pin Configuration L05.1U AA ../../SPMSgraphs/2004/E_06532_007.eps 4 ../../SPMSgraphs/2004/E_06532_010.eps 65 ../../SPMSgraphs/2004/E_06532_011.eps 61 ../../SPMSgraphs/2004/E_06532_012.eps 20, 25 ../../SPMSgraphs/2004/E_06532_014.eps 5 ../../SPMSgraphs/2004/E_06532_021.eps 12 ../../SPMSgraphs/2004/E_06532_024.eps 5 ../../SPMSgraphs/2004/E_14480_037.eps 48 ../../SPMSgraphs/2004/E_14480_038.eps 49 ../../SPMSgraphs/2004/E_14480_039.eps 49 ../../SPMSgraphs/2004/E_14480_059.eps 15 ../../SPMSgraphs/2004/E_14480_060.eps 15 ../../SPMSgraphs/2004/E_14480_062.eps 16 ../../SPMSgraphs/2004/E_14480_063.eps 16 ../../SPMSgraphs/2004/E_14480_064.eps 16 ../../SPMSgraphs/2004/E_14480_065.eps 17 ../../SPMSgraphs/2004/E_14480_075.eps 70 ../../SPMSgraphs/2005/F_15050_001.eps 15 ../../SPMSgraphs/2005/F_15050_003.eps 14 ../../SPMSgraphs/2005/F_15050_004.eps 14 ../../SPMSgraphs/2005/F_15050_005.eps 2 ../../SPMSgraphs/2005/F_15050_032.eps 47 ../../SPMSgraphs/2005/F_15050_033.eps 47 ../../SPMSgraphs/2005/F_15050_034.eps 52 ../../SPMSgraphs/2005/F_15050_035.eps 54 ../../SPMSgraphs/2005/F_15050_036.eps 54 ../../SPMSgraphs/2005/F_15050_040.eps 52 ../../SPMSgraphs/2005/F_15050_041.eps 53 ../../SPMSgraphs/2005/F_15050_042.eps 53 ../../SPMSgraphs/2005/F_15050_043.eps 55 ../../SPMSgraphs/2005/F_15050_044.eps 56 ../../SPMSgraphs/2005/F_15050_045.eps 56 ../../SPMSgraphs/2005/F_15050_046.eps 55 ../../SPMSgraphs/2005/F_15050_047.eps 57 ../../SPMSgraphs/2005/F_15050_048.eps 57 ../../SPMSgraphs/2005/F_15050_056.eps 50 ../../SPMSgraphs/2005/F_15050_057.eps 51 ../../SPMSgraphs/2005/F_15050_058.eps 51 ../../SPMSgraphs/2005/F_15050_066.eps 61 ../../SPMSgraphs/2005/F_15060_000.eps 1 ../../SPMSgraphs/2005/F_15060_001.eps 29 ../../SPMSgraphs/2005/F_15060_002.eps 30 ../../SPMSgraphs/2005/F_15060_003.eps 31 ../../SPMSgraphs/2005/F_15060_004.eps 32 ../../SPMSgraphs/2005/F_15060_005.eps 33 ../../SPMSgraphs/2005/F_15060_006.eps 3 ../../SPMSgraphs/2005/F_15060_007.eps 34 ../../SPMSgraphs/2005/F_15060_008.eps 35 ../../SPMSgraphs/2005/F_15060_009.eps 36 ../../SPMSgraphs/2005/F_15060_010.eps 37 ../../SPMSgraphs/2005/F_15060_011.eps 38 ../../SPMSgraphs/2005/F_15060_012.eps 39 ../../SPMSgraphs/2005/F_15060_012a.eps 40 ../../SPMSgraphs/2005/F_15060_012b.eps 41 ../../SPMSgraphs/2005/F_15060_012c.eps 42 ../../SPMSgraphs/2005/F_15060_012d.eps 43 ../../SPMSgraphs/2005/F_15060_013.eps 23 ../../SPMSgraphs/2005/F_15060_014.eps 58 ../../SPMSgraphs/2005/F_15060_015.eps 59 ../../SPMSgraphs/2005/F_15060_016.eps 60 ../../SPMSgraphs/2005/F_15060_017.eps 60 ../../SPMSgraphs/2005/F_15060_031.eps 36 ../../SPMSgraphs/2005/F_15060_032.eps 44 ../../SPMSgraphs/2005/F_15060_033.eps 45 ../../SPMSgraphs/2005/F_15060_034.eps 46 ../../SPMSgraphs/2005/F_15060_035.eps 21 ../../SPMSgraphs/2005/F_15060_036.eps 22 ../../SPMSgraphs/2005/F_15060_037.eps 24 ../../SPMSgraphs/2005/F_15060_038.eps 26 ../../SPMSgraphs/2005/F_15060_039.eps 27 ../../SPMSgraphs/2005/F_15060_040.eps 28 ../../SPMSgraphs/2005/F_15060_041.eps 7 ../../SPMSgraphs/2005/F_15060_042.eps 7 ../../SPMSgraphs/2005/F_15060_043.eps 7 ../../SPMSgraphs/2005/F_15060_044.eps 8 ../../SPMSgraphs/2005/F_15060_045.eps 9 ../../SPMSgraphs/2005/F_15060_046.eps 10 ../../SPMSgraphs/2005/F_15060_047.eps 10 ../../SPMSgraphs/2005/F_15060_048.eps 18 ../../SPMSgraphs/2005/F_15060_049.eps 19 ../../SPMSgraphs/2005/F_15060_051.eps 25 ../../SPMSgraphs/2005/F_15060_052.eps 66 ../../SPMSgraphs/2005/F_15060_053.eps 62 EN 1 SPARE PARTS LIST MODEL "A" = 26PW9100D MODEL "B" = 30PW9100D MODEL "C" = 30PW9110D MODEL "D" = 32PT9100D PRODUCT SAFETY NOTE: Products marked with a have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. REF. MODEL DESCRIPTION PART NO. 8 16 16 41 50 50 50 106 125 145 164 166 167 1081 1085 1099 1099 1099 1127 1127 1128 1128 5203 5203 5203 5205 5213 CABINET PARTS BC 34WDPV22 ATSC QAM/NA AS MAINSKNOB PV2/11027/NA AS MAINSKNOB FL13B/10942/NA PV2 LENS (USA) Nameplate Nameplate Nameplate Yoke Wedge Instruction Book Quick Use Guide Quick Connection Guide (FR) Quick Connection Guide (SP) Quick Connection Guide (ENG) Battery, Zinc, 1.5V (2-Pack) Remote Transmitter CRT A80ERF182X45N CRT W66QDS770XV2N CRT W76QEN691X100 Defl - Control Assy Defl - Control Assy MOD-DIGITAL-ATSC-HDMI-4:3 MOD-DIGITAL-ATSC-HDMI-16:9 Degauss Coil Degauss Coil Degauss Coil Coil Speaker 8 ohm 15W Full-range 313912462421 313917771181 313917788861 313912439701 313912001301 314105000281 314105000291 312123320091 313912533641 313912533631 313912534951 313912534961 313912534971 929900065263 312814717131 930194880539 930198420522 932221772682 313918887411 313926712921 313926710201 313926714311 313912823931 313912823941 313912824021 242254945605 242226400484 D D ABC D C BD A BC D A BC A D D ABC A BC D D 5213 5214 5214 8190 9950 9950 9960 CBA CBA CBA 1000 1002 1005 1050 1050 1050 1137 1205 1206 1207 1208 1219 1250 1251 1257 1280 1401 1404 1451 1500 1503 1504 1505 1533 1534 1535 1546 1682 1693 2001 2004 2005 2006 2007 ABC D ABC BC A A A BC D BC A D Speaker 8 ohm 10W Full-range Speaker 8 ohm 15W Full-range Speaker 8 ohm 10W Full-range AC Cord Back cover Sub-Assy Back cover Sub-Assy Front cover Sub-Assy 242226400491 242226400484 242226400491 242207000066 312123755801 312123755821 312123755831 MAIN CHASSIS Main Chassis Assy Main Chassis Assy Main Chassis Assy Tuner SAW Filter, 45MHz75, OFWM1971M Connector, 3 Pin MC-30PW9100D.9200D/37-NA ATSC MC-26PW9100D.9200D/37-NA-ATSC MC-32PT9100D/37-NA-ATSC 4 Pin Cinch Socket Crystal Resonator 24MHZ576 Connector, 6 Pin Connector, 7 Pin Connector, 3 Pin Connector, 4 Pin Connector, 12 Pin Connector, 10 Pin Connector, 3 Pin Connector, 5 Pin Connector, 7 Pin Connector, 2 Pin Connector, 3 Pin FUSE 5X20 HT 6A3 250V IEC B RELAY 1P 12V 5A Connector, 2 Pin Connector, 2 Pin Connector, 12 Pin 8 Pin Board Connector Connector, 3 Pin WIRE SIN 680 POSI 18ST BK Connector, 3 Pin Connector, 6 Pin Cap, 22p, 5%, 50V, Ceramic Cap, 47n, +80/-20%, 50V, Ceramic Cap, 4u7, 20%, 50V, Electrolytic Cap, 470u, 20%, 16V, Electrolytic Cap, 100n, 10%, 16V, Ceramic 313918887221 313918885131 313918887231 313914723541 242254944518 241202000725 313918885151 313918887241 313918887251 242202605659 242254301421 242202508149 242202511244 242202510768 242202509406 242202516052 242202516051 241202000725 242202512481 242202511244 242202516269 241202000725 242208600194 242213207467 242202516375 242202516269 242202510772 242202508151 241202000725 313913105261 241202000725 242202512482 319801632290 319802444730 319802554780 319802524710 319801731040 2008 2011 2012 2122 2123 2124 2125 2131 2132 2133 2134 2203 2204 2205 2206 2207 2208 2209 2210 2211 2212 2213 2214 2215 2216 2217 2218 2223 2224 2225 2226 2229 2231 2232 2233 2234 2235 2237 2238 2239 2240 2241 2242 2244 2249 2250 Cap, 100u, 20%, 25V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 330p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Cap, 330p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Cap, 330p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Cap, 330p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Cap, 100u, 20%, 10V, Electrolytic Cap, 22n, 10%, 25V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 470u, 20%, 10V, Electrolytic Cap, 47u, 20%, 25V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 6n8, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap, 220n, +80/-20%, 16V, Ceramic Cap. 1u5, 20%, 50V, Electrolytic Cap, 22n, 10%, 25V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 2u2, +80/-20%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic 319802531010 319801731040 319801731040 319801733310 319802552280 319801733310 319802552280 319801733310 319802552280 319801733310 319802552280 319802511010 319801732230 319801742240 319801742240 319801742240 319801742240 319801742240 319801742240 319801742240 319801742240 319801742240 319801731040 319801742240 319801742240 319802514710 319802534790 319801731040 319802531010 319801742240 319801742240 319801742240 319801731040 319801731040 319801731040 319802531010 319801736820 319801731040 319801742240 319801742240 202002190137 319801732230 319801731040 319801722250 319801731040 319802531010 2251 2253 2255 2256 2257 2260 2261 2262 2263 2264 2265 2266 2267 2272 2273 2274 2275 2276 2279 2280 2282 2291 2292 2293 2404 2407 2409 2410 2411 2411 2411 2412 2412 2413 2413 2418 2419 2419 2421 2422 2426 2431 2436 2448 2449 2451 A BC D ABC D BC AD AD BC BC BC Cap, 10n, +80/-20%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 3n3, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 560p, 5%, 25V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 2u2, +80/-20%, 10V, Ceramic Cap, 2u2, +80/-20%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 10u, 20%, 50V, Electrolytic Cap, 100n, +80/-20%, 25V, Ceramic Cap, 100p, 5%, 50V, Ceramic Cap, 1u, +80/-20%, 10V, Ceramic Cap, 1n, 10%, 50V, Ceramic Cap, 10u, 20%, 50V, Electrolytic Cap, 10u, 10%, 6.3V, Ceramic Cap, 470p, 5%, 50V, Ceramic Cap, 47u, 20%, 160v, Electrolytic Cap, 330p, 5%, 50V, Ceramic Cap, 33n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 1n, 10%, 2KV, Ceramic Cap, 220p, 10%, 2KV, Ceramic Cap, 330p, 10%, 2KV, Ceramic Cap, 12n, 1600V, 5%, Metalized Polypropylene Cap, 10n, 5%, 1600V, Polypropylene Cap, 33n, 10%, 400V, POL PEN Cap, 27n, 5%, 630v, Polypropylene Cap, 330n, 250V, 5%, Metalized Polypropylene Cap, 560n, 5%, 250V, Metalized Polypropylene Cap, 1u2, 5%, 250V, Metalized Polypropylene Cap, 220p, 10%, 2KV, Ceramic Cap, 220p, 10%, 2KV, Ceramic Cap, 470p, 10%, 200V, Ceramic Cap, 680p, 10%, 500V, Ceramic Cap, 1u, 20%, 250V, Electrolytic Cap, 470p, 10%, 200V, Ceramic Cap, 470u, 20%, 16V, Electrolytic Cap, 68n, 10%, 250V, Metalized Polyester 319801921030 319801731030 319801731030 319801731040 319801733320 319801731040 319801731040 319801731030 319801731040 319801635610 319802531010 319801722250 319801722250 319801731040 319802531010 319801731040 319802551090 319802321040 319801631010 319801741050 319801731020 319802551090 202055296637 319801634710 202203100103 319801633310 319801703330 319801701040 319801971020 319801972210 319801973310 202233300254 222237590154 202232000014 222237590223 202233300259 202233300088 222247990034 319801972210 319801972210 223893055618 319801946810 202001293279 223893055618 319802524710 222236545683 2454 2459 2460 2461 2462 2463 2464 2465 2466 2467 2468 2469 2470 2477 2478 2488 2491 2492 2493 2494 2496 2497 2499 2500 2501 2503 2504 2505 2508 2510 2511 2512 2513 2514 2515 2516 2517 2519 2520 2521 2522 2523 2524 2525 2526 2528 Cap, 470u, 20%, 16V, Electrolytic Cap, 470p, 10%, 200V, Ceramic Cap, 470u, 20%, 16V, Electrolytic Cap, 22u, 20%, 100V, Electrolytic Cap, 2n2, 10%, 50V, Ceramic Cap, 2n2, 10%, 50V, Ceramic Cap, 100n, +80/-20%, 25V, Ceramic Cap, 220n, +80/-20%, 50V, Ceramic Cap, 2u2, +80/-20%, 10V, Ceramic Cap, 220n, +80/-20%, 50V, Ceramic Cap, 470n, 10%, 100V, Metalized Polyester Cap, 22u, 20%, 100V, Electrolytic Cap, 100n, 10%, 100v, Ceramic Cap, 8n2, 10%, 50V, Ceramic Cap, 15n, 10%, 50V, Ceramic Cap, 1u, 10%, 50V, Polyester Cap, 4u7, +80/-20%, 10V, Ceramic Cap, 470p, 10%, 200V, Ceramic Cap, 470p, 10%, 200V, Ceramic Cap, 470p, 10%, 200V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 220p, 5%, 50V, Ceramic Cap, 2u2, +80/-20%, 16V, Ceramic Cap, 470n, 20%, 275V, Metalized Polypropylene Cap, 2n2, 10%, 1KV, Ceramic Cap, 2n2, 10%, 1KV, Ceramic Cap, 2n2, 10%, 1KV, Ceramic Cap. 680u, 20%, 200V, Electrolytic Cap, 100n, 20%, 275V, Metalized Polypropylene Cap, 47u, 20%, 50V, Electrolytic Cap, 22u, 20%, 50V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 470p, 5%, 50V, Ceramic Cap, 1n5, 10%, 2KV, Ceramic Cap, 1n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 1n, 10%, 50V, Ceramic Cap, 470p, 5%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 47n, 10%, 16V, Ceramic Cap, 470p, 5%, 50V, Ceramic Cap, 330p, 10%, 1KV, Ceramic Cap, 1n, 10%, 100V, Ceramic Cap, 470p, 5%, 50V, Ceramic Cap, 100n, 10%, 50V, Ceramic Cap, 470n, 10%, 50V, Polyester 319802524710 223893055618 319802524710 319802572290 319801732220 319801732220 319802321040 223858019814 319801722250 223858019814 222236525474 319802572290 222260155649 223858015635 319801701530 319801401050 202055296305 223893055618 223893055618 223893055618 319801731030 319801632210 202055295447 222233822474 319801952220 319801952220 319801952220 202002490723 222233822104 319802554790 319802552290 319801731040 319801634710 319801971520 319801731020 319801731040 319801731020 319801634710 319801731040 319801734730 319801634710 319801963310 223860056623 319801634710 222258015649 319801404740 2534 2535 2536 2538 2539 2541 2542 2543 2544 2551 2552 2561 2562 2563 2564 2565 2570 2571 2572 2575 2576 2577 2578 2579 2580 2582 2583 2584 2585 2587 2590 2591 2592 2601 2611 2615 2617 2620 2621 2623 2624 2625 2632 2633 2634 2986 Cap, 470u, 20%, 16V, Electrolytic Cap, 4700u, 20%, 6.3V, Electrolytic Cap, 2u2, 20%, 16V, Electrolytic Cap, 1n, 10%, 50V, Ceramic Cap, 470p, 10%, 500V, Ceramic Cap, 47u, 20%, 25V, Electrolytic Cap, 1n5, 20%, 250v, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 2n2, 10%, 500V, Ceramic Cap, 1n, 10%, 1KV, Ceramic Cap. 150u, 20%, 160V, Electrolytic Cap, 1n, 10%, 50V, Ceramic Cap, 2u2, 20%, 25V, Electrolytic Cap, 2u2, 20%, 25V, Electrolytic Cap, 100n, 10%, 50V, Ceramic Cap, 1n, 10%, 100V, Ceramic Cap, 470p, 10%, 250V, Ceramic Cap, 15n, 10%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 16V, Electrolytic Cap, 2n2, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 15n, 10%, 400V, Polyester Cap, 1u, +80/-20%, 25V, Ceramic Cap, 10u, 10%, 6.3V, Ceramic Cap, 470u, 20%, 6.3V, Electrolytic Cap, 1u, +80/-20%, 25V, Ceramic Cap, 470u, 20%, 10V, Electrolytic Cap, 4700u, 20%, 10V, Electrolytic Cap, 1n, 10%, 50V, Ceramic Cap, 68p, 5%, 50V, Ceramic Cap, 1n, 5%, 25V, Ceramic Cap, 470u, 20%, 16V, Electrolytic Cap, 4u7, +80/-20%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 100u, 20%, 25V, Electrolytic Cap, 2u2, 10%, 6v3, Ceramic Cap, 6n8, 10%, 50V, Ceramic Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Cap, 100n, 10%, 16V, Ceramic 319802524710 202002100092 319802622220 319801731020 319801944710 319802534790 202055490199 319801731040 319801942220 319801961020 202002100112 319801911020 202001293402 202001293402 222258015649 223860056623 202055490169 319801731530 319801731030 319801731030 319801731040 319802821010 319801732220 319801731040 222234790219 202055296723 202055296637 319802504710 202055296723 319802514710 202002100101 319801731020 319801636890 319801631020 319802524710 202055296305 319801731040 319801731040 319802531010 319801731040 319802531010 202255205615 319801736820 319802190030 319802190030 319801731040 2987 2988 2989 2990 2992 2993 2994 2995 2996 2997 2998 3003 3004 3005 3121 3123 3124 3125 3126 3129 3130 3131 3132 3133 3134 3135 3167 3168 3169 3201 3202 3203 3204 3205 3206 3207 3208 3209 3210 3211 3212 3214 3215 3216 3218 3219 Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 2u2, 10%, 6.3V, Ceramic Cap, 1n, 5%, 25V, Ceramic Cap, 2u2, 10%, 6.3V, Ceramic Cap, 1n, 5%, 25V, Ceramic Cap, 22n, 10%, 25V, Ceramic Cap, 22n, 10%, 25V, Ceramic Cap, 47n, +80/-20%, 50V, Ceramic Cap, 47n, +80/-20%, 50V, Ceramic Cap, 2u2, +80/-20%, 10V, Ceramic Res, 10K, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/6W, Carbon Film Res, 47K, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/6W, Carbon Film Res, 47K, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/6W, Carbon Film Res, 47K, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/6W, Carbon Film Res, 47K, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film Res, 3K3, 5%, 1/16W, Metalized Glass Res, 150K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 12K, 5%, 1/16W, Metalized Glass Res, 5K6, 5%, 1/16W, Metalized Glass Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 27K, 5%, 1/16W, Metalized Glass Res, 1 ohm, 5%, 1/16W, Metalized Glass Res, 1 ohm, 5%, 1/16W, Metalized Glass Res, 27K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/6W, Carbon Film Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass 319801731040 319801731040 202055200183 319801631020 202055200183 319801631020 319801732230 319801732230 319802444730 319802444730 319801722250 319802131030 319802136830 319802131010 319802137590 319801102230 319802134730 319801102230 319802134730 319802137590 319802137590 319801102230 319802134730 319801102230 319802134730 319802137590 319802137590 319802137590 319802137590 319801101020 319802133320 319802131540 319802133320 319802131230 319802135620 319802131090 319802132730 319802131080 319802131080 319802132730 319802131010 319802131090 319801104720 319802131090 319802131010 319802131030 3220 3221 3222 3226 3227 3228 3229 3231 3232 3238 3241 3242 3246 3247 3248 3249 3252 3253 3257 3258 3260 3261 3262 3263 3264 3265 3266 3269 3270 3272 3273 3274 3275 3276 3277 3278 3279 3280 3281 3283 3284 3285 3287 3291 3292 3293 Res, 150 ohm, 5%, 1/16W, Metalized Glass Res, 270 ohm, 5%, 1/16W, Metalized Glass Res, 330 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1K5, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 12K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 39K, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 390 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 4K7, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 820 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/6W, Carbon Film Res, 4K7, 5%, 1/10W, Metalized Glass Res, 10 ohm, 5%, 1/6W, Carbon Film 319802131510 319802132710 319802133310 319802131010 319802131010 319802131010 319802131520 319802131010 319802131230 319802131030 319801103930 319802131010 319802131010 319802133910 319802131010 319802131010 319801101030 319802131010 319802131010 319802131010 319801101010 319802134720 319802131010 319802131010 319802131010 319802131010 319802131010 319802131010 319801101010 319802138210 319802131020 319801101010 319801101010 319801101010 319801101010 319801101010 319802134720 319802134720 319802134720 319802134720 319802134720 319802131020 319802131010 319801104720 319802154720 319801101090 3296 3298 3401 3402 3408 3413 3414 3414 3415 3415 3416 3419 3419 3421 3424 3425 3431 3433 3433 3439 3440 3441 3450 3451 3451 3453 3455 3456 3458 3459 3459 3459 3460 3461 3462 3463 3466 3467 3468 3469 3471 3472 3472 3473 3477 3478 ABC D ABC D ABC D BC BC D ABC D ABC A BC D AD BC Res, 5K6, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 47k ohm, 1%, 1/16W, Metal Film Res, 330 ohm, 5%, 1/6W, Carbon Film Res, 100K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film Res, 4.7 ohm, 1%, 1/16W, Metal Film Res, 6.8 ohm, 1%, 1/16W, Metal Film Res, 4.7 ohm, 1%, 1/16W, Metal Film Res, 6.8 ohm, 1%, 1/16W, Metal Film Res, 47 ohm, 5%, 1/16W, Metalized Glass Res, 4.7 ohm, 1%, 1/16W, Metal Film Res, 6.8 ohm, 1%, 1/16W, Metal Film Res, 4.7 ohm, 1%, 1/16W, Metal Film VDR DC 1MA/612V S MAX 1100V A VDR DC 1MA/612V S MAX 1100V A Res, 82k ohm, 1%, 1/16W, Metal Film Res, 10 ohm, 1%, Metal Film Res, 4.7 ohm, 1%, 1/16W, Metal Film Res, 10K, 5%, 1/16W, Metalized Glass Res, 2.2 ohm, 1%, 1/16W, Metal Film Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1 ohm, 5%, 1/3W, Metal Film Res, 10 ohm, 1%, Metal Film Res, 4.7 ohm, 1%, 1/16W, Metal Film Res, 56K, 5%, 1/16W, Metalized Glass Res, Fuse, 0.27 ohm, 5% Res, Fuse, 0.27 ohm, 5% Res, 4R7, 5%, 1/2W, Metal Film Res, 820K, 5%, 1/16W, Metalized Glass Res, 470K, 5%, 1/16W, Metalized Glass Res, 680K, 5%, 1/16W, Metalized Glass Res, 56K, 1%, 1/16W, Metalized Glass Res, 27K, 5%, 1/16W, Metalized Glass Res, 18K, 1%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 1R5, 5%, 1/3W, Metal Film Res, 100 ohm, 1%, Metal Film Res, 100 ohm, 1%, Metal Film Res, 22K, 5%, 1/6W, Carbon Film Res, 2.2 ohm, 1%, 1/16W, Metal Film Res, 1.2 ohm, 1%, Metal Film Res, 2.2 ohm, 1%, 1/16W, Metal Film Res, 15 ohm, 5%, 1 1/3W, Metal Film Res, 1K5, 5%, 1/6W, Carbon Film Res, 33K, 5%, 1/6W, Carbon Film 319802135620 319802131010 319803947030 319801103310 319802131040 319801101020 319803947080 319803968080 319803947080 319803968080 319802134790 319803947080 319803968080 319803947080 232259214217 232259214217 319803982030 319803910090 319803947080 319802131030 319803922080 319802131010 230620403108 319803910090 319803947080 319802135630 230620703277 230620703277 230620703478 232270260824 319802134740 319802136840 232270465603 319802132730 232270461803 319802133320 230620403158 319803910010 319803910010 319801102230 319803922080 319803912080 319803922080 319801221590 319801101520 319801103330 3481 3485 3485 3486 3489 3490 3491 3491 3492 3492 3493 3496 3497 3499 3500 3501 3502 3503 3504 3505 3510 3511 3512 3513 3514 3515 3516 3517 3518 3519 3520 3521 3522 3523 3524 3525 3526 3527 3528 3529 3530 3531 3532 3533 3534 3535 D ABC A BCD A BCD Res, 1K, 5%, 1/6W, Carbon Film Res, 1 ohm, 5%, 1/3W, Metal Film Res, Fuse, 0.47 ohm, 5% Res, 1 ohm, 5%, 1/3W, Metal Film Res, 10K, 5%, 1/6W, Carbon Film Res, 150 ohm, 1%, 1/16W, Metal Film Res, 10K, 5%, 1/16W, Metalized Glass Res, 8K2, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 2R2, 5%, 1/2W, Metal Film Res, 100K, 5%, 1/16W, Metalized Glass Res, 56K, 5%, 1/16W, Metalized Glass Res, 470K, 5%, 1/6W, Carbon Film Res, 3M3, 5%, 1/2W, Metalized Glass Res, 3M3, 5%, 1/2W, Metalized Glass Res, 220 ohm, 20%, 1/2W, Carbon Film Surge Protector Res, 1M5, 5%, 1/2W, Metalized Glass VDR, 1mA/612V NTC DC B57364 5W1 S 2R0 PM20 B Res, 4R7, 5%, 1/6W, Carbon Film Res, 1K2, 5%, 1/16W, Metalized Glass Res, 2K2, 5%, 1/3W, Metal Film Res, 100 ohm, 5%, 1/3W, Metal Film Res, 1K, 5%, 1/6W, Carbon Film Res, 0.1 ohm, 5%, 3/5W, Metal Film Res, 300k, 1%, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 15K, 5%, 1/6W, Carbon Film Res, 0.12ohm, 5%, 1W Res, 3K3, 5%, 1/6W, Carbon Film Res, 56K, 5%, 1/16W, Metalized Glass PTC, 1R5, 20%, 145v, DBL-MONO Res, 47K, 5%, 1/16W, Metalized Glass Res, 330K, 1%, Metal Film Res, 150 ohm, 5%, 1/8W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 1M, 5%, 1/16W, Metalized Glass Res, 2M2, 5%, 1/16W, Metalized Glass Res, 56K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film Res, 1 ohm, 5%, 1/10W, Metalized Glass Res, 1 ohm, 5%, 1/10W, Metalized Glass Res, 33 ohm, 5%, 1/6W, Carbon Film Res, 1 ohm, 5%, 1/2W, Metal Film 319801101020 230620403108 230620703477 230620403108 319801101030 319803915010 319802131030 319802138220 319802132230 319802134730 230620703228 319802131040 319802135630 319801104740 232224213335 232224213335 319801302210 242254943073 232224213155 212255000158 212261200077 319801104780 319802131220 230620403222 230620403101 319801101020 319801211070 232270463004 319802133320 319801101530 212010500036 319801103320 319802135630 232266296753 319802134730 319803933040 232275061501 319802134730 319802131050 319802132250 319802135630 319801101020 319802151080 319802151080 319801103390 230620703108 3536 3538 3539 3541 3542 3543 3544 3545 3546 3549 3550 3551 3553 3560 3563 3565 3567 3568 3571 3573 3574 3575 3576 3579 3581 3583 3585 3586 3587 3588 3589 3590 3591 3592 3593 3594 3595 3596 3597 3598 3599 3601 3604 3605 3606 3607 Res, 220 ohm, 5%, 1/3W, Metal Film Res, 1 ohm, 5%, 1/10W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 680 ohm, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 2K4, 1%, 1/16W, Metalized Glass Res, 820 ohm, 1%, 1/16W, Metalized Glass Res, 68K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/6W, Carbon Film Res, 220K, 5%, 1/16W, Metalized Glass Res, 4R7, 5%, 1/16W, Metalized Glass Res, 39K, 5%, 1/16W, Metalized Glass Res, 33 ohm, 5%, 1W, Metal Film Res, 220 ohm, 5%, 1/6W, Carbon Film Res, 27K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 470 ohm, 5%, 1/10W, Metalized Glass Res, 15K, 5%, 1/16W, Metalized Glass Res, 82K, 5%, 1/10W, Metalized Glass Res, 82k ohm, 1%, 1/16W, Metal Film Res, 1K5, 1%, 1/16W, Metalized Glass Res, 2K2, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/16W, Metalized Glass Res, 5K6, 5%, 1/16W, Metalized Glass Res, 56K, 5%, 1/16W, Metalized Glass Res, 5K6, 5%, 1/16W, Metalized Glass Res, 2K2, 5%, 1/16W, Metalized Glass Res, 330K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 82K, 5%, 1/16W, Metalized Glass Res, 18K, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 2W Res, 10K, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/16W, Metalized Glass Res, 100K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 220K, 5%, 1/16W, Metalized Glass Res, 100K, 5%, 1/4W, Metalized Glass Res, 1M5, 5%, 1/4W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 56K, 5%, 1/6W, Carbon Film Res, 10K, 5%, 1/16W, Metalized Glass 230620403221 319802151080 319802131020 319802134730 319802136810 319802131030 232270462402 232270468201 319802136830 319801103320 319802132240 319802134780 319802133930 319801213390 319801102210 319802132730 319802133320 319802134730 319802154710 319802131530 319802158230 319803982030 232270461502 319802132220 319802132230 319802135620 319802135630 319802135620 319802132220 319802133340 319802131030 319802138230 319802131830 319801226830 319802131030 319802132230 319802131040 319802133320 319802132240 232224153104 232224153155 319802134720 319802131010 319802131010 319801105630 319802131030 3608 3609 3634 3635 3637 3647 3648 3649 3650 3690 3984 3985 3986 3988 3989 3991 3992 3993 3994 3995 4000 4001 4002 4003 4006 4013 4015 4116 4145 4160 4201 4209 4221 4222 4223 4226 4227 4251 4253 4254 4297 4299 4401 4418 4470 4527 Res, 27K, 5%, 1/16W, Metalized Glass Res, 330 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 39K, 5%, 1/16W, Metalized Glass Res, 47 ohm, 5%, 1/16W, Metalized Glass Res, 33K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 470 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 56K, 5%, 1/6W, Carbon Film Res, 22K, 5%, 1/16W, Metalized Glass Res, 27K, 5%, 1/16W, Metalized Glass Res, 5K6, 5%, 1/16W, Metalized Glass Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/16W, Metalized Glass Res, 5K6, 5%, 1/16W, Metalized Glass Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper 319802132730 319802133310 319802131020 319802133930 319802134790 319802133330 319802133320 319802134710 319802131020 319802132210 319801105630 319802132230 319802132730 319802135620 319802131090 319802132230 319802135620 319802131090 319802136830 319802134720 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190020 319802190030 319802190030 319802190030 319802190020 319802190030 319802190030 319802190030 319802190020 319802190030 319802190020 319802190030 319802190030 319802190020 319802190020 319802190030 4533 4540 4567 4604 4612 4614 4617 4642 4644 4646 4649 4653 4691 4692 4694 4992 4993 5001 5002 5201 5202 5203 5205 5206 5207 5208 5209 5210 5211 5212 5213 5215 5216 5401 5401 5402 5408 5408 5450 5450 5450 5452 5456 5457 5458 5459 BC AD BC AD BC A D BC Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Fixed Inductor, 100MHz, 120R Coil, 560n Fixed, Inductor, 100MHz, 50R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed, Inductor, 100MHz, 50R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed Inductor, 100MHz, 120R Fixed, Inductor, 100MHz, 50R Line Choke Coil, 50uH. TFM SIG DRIVER SD12404-02 Y COI BRIDGE W7131-003 B COI BRIDGE W7132-004 Y TFM LOT, JF0101-85038 B TFM LOT JF0101-85039 B TFM LOT JF0101-85040 B Coil, 10u TFM SIG DYN FOC SD20417-07 Y IND FXD 0805 EMI 100MHZ 60R R IND FXD 0805 EMI 100MHZ 60R R Coil, 560n 319802190020 319802190030 319802190030 319802190030 319802190020 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190020 319802190030 319801890030 319801835670 319801890010 319801890030 319801890030 319801890030 319801890030 319801890030 319801890010 319801890030 319801890030 319801890030 319801890030 319801890030 319801890030 319801890010 242253601067 310430820471 242253100057 242253102334 242253102357 242253100067 242253100068 242253100069 319801821090 242253100078 242254945186 242254945186 242253595339 5504 5506 5511 5512 5521 5523 5524 5526 5527 5551 5552 5561 5562 5564 5601 6001 6006 6106 6132 6203 6204 6207 6209 6403 6404 6442 6449 6452 6453 6456 6457 6458 6461 6464 6466 6467 6471 6476 6480 6481 6484 6487 6489 6490 6491 6500 TFM SMT LAYER SS28411-00 B FIL MAINS 30MH 3A DMF3530 Y Fixed, Inductor, 100MHz, 50R TFM SMT LAYER SS42408-00 B Fixed, Inductor, 100MHz, 50R Inductor, Fixed, 100Mhz, 120R Coil, 4u7 Coil, 4u7 Coil, 4u7 Fixed, Inductor, 100MHz, 50R Coil, 27u Fixed, Inductor, 100MHz, 50R Fixed, Inductor, 100MHz, 50R FIL MAINS 4MH 2A8 DMF2404 Y Res, Zero ohm, 'Chip' Jumper Zener Diode, 33 volt Zener Diode, 8.2 volt Zener Diode, 15V Zener Diode, 15V Diode, Signal, BAS316 Diode, Rect, SS14 Diode, Signal, BAS316 Diode, Signal, BAT54 Diode, Rect, RGP10D Diode, Rect, DMV1500M Zener Diode, 10 volt Zener Diode, 12V Diode, Rect, RGP10D Diode, Rect, RGP10G Diode, Rect, BYV27-200 Diode, Rect, BYV27-200 Diode, Signal, BAS316 Diode, Rect, RGP10D Zener Diode, 15V Diode, Rect, RGP10D Diode, Rect., BYV29X-500 Diode, Rect, RGP10D Zener Diode, 6.8 volt Zener Diode, 15 volt Diode, Signal, BAS316 Diode, Signal, BAS316 Diode, Signal, BAS316 Diode, Signal, BAS316 Diode, Signal, BAS316 Zener Diode, 3.3V Diode, Bridge Rect, GBU6JL-7002 242253100065 242254945783 319801890010 242253100064 319801890010 319801890070 319801874780 319801874780 319801874780 319801890010 242253595366 319801890010 319801890010 242254900408 319802190030 319801023390 319801058280 319802051590 319802051590 319801010630 319801010710 319801010630 319801010660 933751660673 932216961687 933500650133 319802051290 933751660673 933493960673 932212672673 932212672673 319801010630 933751660673 319802051590 933751660673 934055559127 933751660673 933500610133 934054863115 319801010630 319801010630 319801010630 319801010630 319801010630 319802053380 932213808667 6511 6512 6514 6531 6532 6533 6534 6536 6537 6538 6539 6540 6541 6542 6543 6546 6547 6548 6549 6550 6551 6552 6562 6563 6575 6602 6603 6694 7200 7201 7203 7204 7207 7209 7210 7404 7405 7406 7407 7408 7451 7510 7511 7512 7513 7514 Diode, Rect, RGP10D Zener Diode, 18V Diode, Signal, BAS316 Diode, Signal, BAS316 Diode, BAV21WS Diode, Rect, RGP10D Diode, Signal, BAS316 Diode, Signal, BAS316 Diode, BAV21WS Diode, BAV21WS Diode, Rect, SB360 Diode, Signal, BAS316 Zener Diode, 12V Zener Diode, 6.2 volt Diode, Signal, BAS316 DIO REC STPS10L25D Zener Diode, 6.8V Double Diode, High Speed, BAW56W DIO REG SM UDZS13B IC SARS03(LF4) Diode, Rect, BYT28-500 DIO REC STPS10L25D Diode, Rect, SB360 Diode, Rect, SB360 Diode, Rect, 1N5392 Diode, Signal, BAV99 Zener Diode, 2.7V Zener Diode, 5.1V IC SM TDA12001H1/N1B501AS Transistor, NPN, IMX1 Transistor, PNP, BC327-25 Transistor, PNP, BC327-25 Transistor, NPN, BC847B Transistor, FET Signal, BSH103 Transistor, FET Signal, BSH103 Transistor, FET Signal, BSH103 Transistor, NPN, BU2527DX FET POW FQPF3N60 Transistor, NPN, PDTC144ET Transistor, PNP, BC856B IC E-TDA8177F IC SM TEA1506T/N1 IC SM TEA1506T/N1 FET POW FQPF13N50C Optic Coupler, TCET1103(G) Transistor, NPN, BC847B 933751660673 319802051890 319801010630 319801010630 932219745703 933751660673 319801010630 319801010630 932219745703 932219745703 319801010700 319801010630 319802051290 932212911685 319801010630 932220957687 319802056880 934026020115 932221282685 932218509682 933744380127 932220957687 319801010700 319801010700 932200516683 319801010620 319802052780 319802055180 935275761557 932205428685 319802043430 319802043430 319801042030 934054713215 934054713215 934054713215 934049680127 932216034687 319801044130 933589730215 932214436687 935272043518 935272043518 932221806687 932214014667 319801042030 7516 7525 7532 7535 7541 7542 7547 7549 7561 7567 7571 7573 7575 7576 7577 7583 7584 7585 7601 7604 7605 7606 7608 7990 7991 7992 8280 CBA CBA CBA 1054 1054 1054 1335 1340 1351 1362 1381 2313 2317 2319 2330 2331 2332 A BC D A BC D AD Optic Coupler, TCET1103(G) FET POW STP6NK60ZFP Transistor, PNP, BC857B FET POW SM SI2307DS-E3 Transistor, PNP, BC857B IC TL431ACZ Transistor, NPN, PDTC143ZT Transistor, NPN, IMX1 Transistor, NPN, PDTC143ZT Transistor, NPN, BC847B IC TL431ACZ Transistor, NPN, PDTC114ET Transistor, NPN, PDTC143ZT Transistor, NPN, BC847BW Transistor, NPN, BC847BW Transistor, NPN, BC847BW Transistor, NPN, BC847BW Transistor, PNP, BC857B IC, M24C16-WBN6 Transistor, NPN, BC847B Transistor, PNP, BC327-25 Transistor, NPN, BC847B Transistor, NPN, PMBT2369 IC, TDA2616Q/N1 Transistor, NPN, BC847B Transistor, NPN, BC847B Cable, 5 Pin, 680mm 932214014667 932219177687 319801042150 932219077685 319801042150 319801070500 934054700215 932205428685 934054700215 319801042030 319801070500 319801044110 934054700215 319801042310 319801042310 319801042310 319801042310 319801042150 932214725682 319801042030 319802043430 319801042030 319801043360 935040440112 319801042030 319801042030 313911038861 CRT PANEL CRT Board Assy CRT Board Assy CRT Board Assy PNL-CRT-N.DAF-16MHZ-26WR ATSC PNL-CRT-DAF-16MHZ ATSC PNL-CRT-N.DAF-16MHZ-32RF ATSC Ground Terminal Assembly 340mm Connector, 5 Pin Connector, 7 Pin Connector, 3 Pin Connector, 3 Pin Cap, 47u, 20%, 250V, Electrolytic Cap, 4n7, 5%, 1600V, Polypropylene Cap, 10n, +80/-20%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 4n7, 10%, 50V, Ceramic 313918885321 313918885661 313926714581 313918885331 313918885671 313926714591 313912108883 242202510428 242202511244 242202516601 241202000725 202001293786 222237590145 319801921030 319801731040 319801731040 319801734720 2333 2334 2335 2336 2337 2338 2339 2340 2341 2343 2344 2346 2347 2352 2353 2355 2356 2357 2358 2360 2361 2363 2364 2365 2367 2368 2370 2381 2382 2383 2384 2385 2387 2389 2390 2391 2392 2393 3305 3309 3310 3311 3317 3320 3321 3322 BC Cap, 680p, 5%, 25V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 12p, 5%, 50V, Ceramic Cap, 33n, 10%, 16V, Ceramic Cap, 12p, 5%, 50V, Ceramic Cap, 100n, 10%, 250V, Metalized Polyester Cap, 100n, 10%, 250V, Metalized Polyester Cap, 100n, 10%, 250V, Metalized Polyester Cap, 12p, 5%, 50V, Ceramic Cap, 680p, 5%, 25V, Ceramic Cap, 4n7, 10%, 50V, Ceramic Cap, 33n, 10%, 16V, Ceramic Cap, 470u, 20%, 16V, Electrolytic Cap, 4n7, 10%, 50V, Ceramic Cap, 680p, 5%, 25V, Ceramic Cap, 22p, 5%, 50V, Ceramic Cap, 33n, 10%, 16V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 22p, 5%, 50V, Ceramic Cap, 22p, 5%, 50V, Ceramic Cap, 1n, 10%, 50V, Ceramic Cap, 47u, 20%, 200V, Electrolytic Cap, 4n7, 10%, 250V, Ceramic Cap, 4n7, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 100V, Metalized Polyester Cap, 100n, 10%, 16V, Ceramic Cap, 47n, 10%, 50V, Polyester Cap, 100n, 10%, 16V, Ceramic Cap, 680p, 5%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 10u, 20%, 16V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 4n7, 10%, 50V, Ceramic Cap, 220p, 10%, 50V, Ceramic Res, 1 ohm, 5%, 1/3W, Metal Film Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 22 ohm, 5%, 1/16W, Metalized Glass Res, 22 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film Res, 470 ohm, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass 319801636810 319801731040 319801631290 319801733330 319801631290 202231800109 202231800109 202231800109 319801631290 319801636810 319801734720 319801733330 319802524710 319801734720 319801636810 319801632290 319801733330 319801731030 319801632290 319801632290 319801731020 202001293486 202055790732 319801734720 319801731040 222236585104 319801731040 319801404730 319801731040 319801606810 319801731040 319801731040 319801731030 319801731040 319802821090 319801731040 319801734720 319801732210 230620403108 319802132210 319802132290 319802132290 319801101020 319802134710 319802132210 319802131010 3323 3324 3325 3326 3327 3328 3329 3331 3332 3333 3334 3335 3336 3337 3338 3339 3340 3341 3342 3343 3344 3345 3347 3350 3351 3352 3353 3354 3355 3357 3361 3361 3362 3363 3364 3365 3366 3367 3368 3369 3370 3371 3372 3373 3374 3377 AD BC Res, 470 ohm, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 1K8, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 470 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 1K, 20%, 1/2W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 1K, 20%, 1/2W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 1K, 20%, 1/2W, Carbon Film Res, 120K, 5%, 1/4W, Carbon Film Res, 2K7, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 120K, 5%, 1/4W, Carbon Film Res, 3K3, 5%, 1/16W, Metalized Glass Res, 2K7, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film Res, 33 ohm, 1%, 1/16W, Metal Film Res, 1K5, 20%, 1/2W, Carbon Film Res, 6.8K, 5%, 1/6W, Carbon Film Res, 150 ohm, 5%, 1/2W, Metal Film Res, 120K, 5%, 1/4W, Carbon Film Res, 2K7, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass VDR 1mA/18V, 35V Max Res, 680 ohm, 5%, 1/16W, Metalized Glass Res, 680 ohm, 5%, 1/10W, Metalized Glass Res, 10 ohm, 5%, 1/3W, Metal Film Res, 560 ohm, 5%, 1/16W, Metalized Glass Res, 1R5, 5%, 1/8W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 1/6W, Carbon Film Res, 560 ohm, 5%, 1/16W, Metalized Glass Res, 150K, 5%, 1/16W, Metalized Glass Res, 1R5, 5%, 1/8W, Metalized Glass Res, 2K2, 5%, 1/6W, Carbon Film Res, 150K, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 5W, Metal Film Res, 10 ohm, 5%, 1/3W, Metal Film Res, 1K8, 5%, 1/16W, Metalized Glass 319802134710 319802132210 319802131820 319802131010 319802132210 319802131010 319802134710 319801101010 319801301020 319801101010 319801301020 319801101010 319801301020 212210102074 319802132720 319802133320 319802131020 212210102074 319802133320 319802132720 319801101020 319803933090 319801301520 319801106820 230620703151 212210102074 319802132720 319802133320 319802131020 212255200004 319802136810 319802156810 230620403109 319802135610 232273061158 319802134720 319802136830 319801106830 319802135610 319802131540 232273061158 319801102220 319802131540 232225741472 232220533109 319802131820 3378 3379 3380 3381 3382 3383 3390 3394 3395 3396 3398 3399 3999 3999 3999 4321 5303 5304 5308 5324 5361 5362 6307 6325 6331 6332 6333 6334 6361 6362 6363 7330 7331 7332 7333 7340 7350 7351 7352 7353 7361 7362 7363 7364 7365 7366 BC A D BC Res, 330 ohm, 5%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 22K, 5%, 1/16W, Metalized Glass Res, 33K, 5%, 1/16W, Metalized Glass Res, 8K2, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass VDR 1mA/18V, 35V Max Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 1K8, 5%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 270 ohm, 5%, 1/3W, Metal Film Res, 2K2, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, Zero ohm, 'Chip' Jumper Coil, 5u6 Fixed, Inductor, 100MHz, 50R Coil, 5u6 Fixed, Inductor, 100MHz, 50R Fixed, Inductor, 100MHz, 80 ohm Coil, 1u Zener Diode, 6.8V Zener Diode, 3.3 volt Diode, BAV21WS Diode, BAV21WS Diode, BAV21WS Zener Diode, 3.3V Diode, Signal, BAV99 Diode, Signal, BAS316 Diode, Signal, BAV99 IC TDA6111Q/N4 Transistor, NPN, BC847B TRA SIG TBC328-40 TRA SIG TBC338-40 IC TDA6111Q/N4 IC TDA6111Q/N4 Transistor, NPN, BC847B Transistor, NPN, BC847B Transistor, NPN, BC847B Transistor, NPN, BF840 Transistor, PNP, BF824 Transistor, KTB631KY Transistor, KTD600KY Transistor, NPN, BF840 IC TDA8941P/N1 319802133310 319802134730 319802132230 319802133330 319802138220 319802131020 212255200004 319802134720 319802134720 319802131820 319802134730 230620403271 319802132220 319802133320 319802134720 319802190030 319801815680 319801890010 319801815680 319801890010 319801890020 319801831080 319802056880 319801023380 932219745703 932219745703 932219745703 319802053380 319801010620 319801010630 319801010620 935173950112 319801042030 319801040190 319801040180 935173950112 935173950112 319801042030 319801042030 319801042030 933792670215 933722350215 932219505687 932219514687 933792670215 935262851112 CBA 1250 1251 1400 1401 1402 1403 1404 1405 2402 2403 2405 2406 2407 2408 2409 2410 2412 2413 2414 2415 2416 2418 2419 2420 2421 2422 2423 2424 2425 2426 2427 2428 2429 2431 2432 2433 2434 2435 2436 2437 2438 2439 2441 BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC ASSY-DEFL-CTRL-NA Defl - Control Assy Connector, 12 Pin Connector, 10 Pin Connector, 3 Pin Connector, 8 Pin Ceramic Resonator 503KHZ5 Connector, 6 Pin Connector, 5 Pin Connector, 3 Pin Cap, 1u, +80/-20%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 22u, 20%, 16V, Electrolytic Cap, 470u, 20%, 16V, Electrolytic Cap, 470u, 20%, 16V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 470u, 20%, 16V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 2u2, +80/-20%, 10V, Ceramic Cap, 1n, 5%, 25V, Ceramic Cap, 47n, 10%, 16V, Ceramic Cap, 2n2, 10%, 50V, Ceramic Cap, 1000uF, 20%, 16V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 470n, +80/-20%, 10V, Ceramic Cap, 4u7, 10%, 6v3, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 470n, +80/-20%, 10V, Ceramic Cap, 22n, 10%, 50V, Polyester Cap, 1u, 10%, 50V, Polyester Cap, 1n, 5%, 25V, Ceramic Cap, 1u, 10%, 50V, Polyester Cap, 2u2, 10%, 10V, Ceramic Cap, 2u2, 10%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 2u2, 10%, 10V, Ceramic Cap, 100n, 10%, 16V, Ceramic 313926712641 242202516219 242202518582 242202509191 242202512492 242254098458 242202510738 242202509364 242202509191 319801741050 319801731040 319802822290 202001200003 202001200003 319801731040 319801731040 319801731040 319801731040 202001200003 319801731040 319801722250 319801631020 319801734730 319801732220 319803821020 319801731040 319801744740 202255205731 319801731040 319801731040 319801731040 319801744740 319801402230 319801401050 319801631020 319801401050 202055296702 202055296702 319801731040 319801731040 319801731040 319801731040 202055296702 319801731040 2442 2443 2444 2446 2447 2448 2449 2450 2451 2452 2453 2454 2455 2456 2457 2458 2459 2460 2461 2462 2463 2464 2465 2466 2487 2488 2489 2490 2497 2498 2499 3400 3401 3403 3404 3405 3406 3407 3408 3409 3410 3411 3412 3413 3414 3415 BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 1u, +80/-20%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 1u, +80/-20%, 16V, Ceramic Cap, 100n, 10%, 16V, Ceramic Cap, 330p, 5%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 10p, 5%, 50V, Ceramic Cap, 1u, +80/-20%, 16V, Ceramic Cap, 10p, 5%, 50V, Ceramic Cap, 1u, +80/-20%, 16V, Ceramic Cap, 1u, +80/-20%, 16V, Ceramic Cap, 10p, 5%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 100u, 20%, 16V, Electrolytic Cap, 100u, 20%, 16V, Electrolytic Cap, 10n, 10%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 10n, 10%, 50V, Ceramic Cap, 10u, 20%, 16V, Electrolytic Cap, 47p, 5%, 50V, Ceramic Cap, 47p, 5%, 50V, Ceramic Cap, 47p, 5%, 50V, Ceramic Cap, 10u, 20%, 16V, Electrolytic Cap, 47p, 5%, 50V, Ceramic Cap, 47p, 5%, 50V, Ceramic Cap, 47p, 5%, 50V, Ceramic Res, 240 ohm, 1%, 1/8W, Metalized Glass Res, 2K2, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 240 ohm, 1%, 1/8W, Metalized Glass Res, 240 ohm, 1%, 1/8W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 390K, 5%, 1/16W, Metalized Glass Res, 120K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 82K, 5%, 1/16W, Metalized Glass Res, 120K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 150K, 5%, 1/16W, Metalized Glass Res, 220K, 5%, 1/16W, Metalized Glass 319801731040 319801731040 319801731040 319801721050 319801731040 319801731040 319801731040 319801721050 319801731040 319801633310 319801731030 319801631090 319801721050 319801631090 319801721050 319801721050 319801631090 319801731030 319803041010 319803041010 319801731030 319801731030 319801731030 319803041090 319801634790 319801634790 319801634790 319803041090 319801634790 319801634790 319801634790 232273462401 319802132220 319802131030 319802131030 232273462401 232273462401 319802131030 232270260394 232270260124 319802131010 319802138230 232270260124 319802133320 319802131540 319802132240 3416 3417 3418 3419 3420 3421 3422 3423 3424 3425 3426 3427 3428 3429 3430 3431 3433 3434 3435 3436 3437 3438 3439 3440 3441 3442 3443 3444 3445 3446 3447 3448 3449 3450 3451 3452 3453 3454 3455 3456 3457 3458 3459 3460 3461 3462 BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 270 ohm, 5%, 1/16W, Metalized Glass Res, 100K, 5%, 1/16W, Metalized Glass Res, 2K7, 5%, 1/16W, Metalized Glass Res, 20K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 4K7, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 2K, 1%, 1/16W, Metalized Glass Res, 1K2, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 180 ohm, 5%, 1/16W, Metalized Glass Res, 2K7, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 470 ohm, 5%, 1/16W, Metalized Glass Res, 2K, 1%, 1/16W, Metalized Glass Res, 150K, 5%, 1/16W, Metalized Glass Res, 33K, 5%, 1/16W, Metalized Glass Res, 1K, 1%, 1/16W, Metalized Glass Res, 56K, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 10K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 220 ohm, 5%, 1/16W, Metalized Glass Res, 330K, 5%, 1/16W, Metalized Glass Res, 68K, 5%, 1/16W, Metalized Glass 319802131010 319802132710 319802131040 319802132720 232270260203 319802131020 319802134720 319802131030 319802131030 319802131030 319802133320 319802134720 319802134720 319802131030 319802131010 232270462002 319802131220 319802131030 319802131020 319802131810 319802132720 319802131020 319802134710 232270462002 319802131540 319802133330 232270461002 319802135630 319802132210 319802131010 319802131020 319802131030 319802131020 319802132210 319802131010 319802131020 319802131030 319802131020 319802132210 319802131010 319802131020 319802131030 319802131020 319802132210 319802133340 319802136830 3463 3464 3465 3466 3467 3468 3469 3470 3471 3472 3473 3474 3482 3483 3484 3486 3487 3488 3489 3490 3491 3492 3493 3494 3495 3496 3500 3501 3502 3503 3504 3505 3506 3507 4400 4402 4488 4489 4490 4491 4492 4493 4494 4495 4499 5400 BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC Res, 68K, 5%, 1/16W, Metalized Glass Res, 100K, 5%, 1/16W, Metalized Glass Res, 20K, 5%, 1/16W, Metalized Glass Res, 100K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 220K, 5%, 1/16W, Metalized Glass Res, 220K, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 3K9, 5%, 1/16W, Metalized Glass Res, 33K, 5%, 1/16W, Metalized Glass Res, 6K8, 5%, 1/16W, Metalized Glass Res, 24K, 1%, 1/16W, Metalized Glass Res, 2K, 1%, 1/16W, Metalized Glass Res, 47K, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 3K3, 5%, 1/16W, Metalized Glass Res, 2K2, 5%, 1/16W, Metalized Glass Res, 47 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 100 ohm, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 1K, 5%, 1/16W, Metalized Glass Res, 24K, 1%, 1/16W, Metalized Glass Res, 24K, 1%, 1/16W, Metalized Glass Res, 24K, 1%, 1/16W, Metalized Glass Res, 2K, 1%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 75 ohm, 5%, 1/16W, Metalized Glass Res, 240 ohm, 1%, 1/8W, Metalized Glass Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Fixed Inductor 100MHZ 220R 319802136830 319802131040 232270260203 319802131040 319802131010 319802131010 319802132240 319802132240 319802137590 319802133920 319802133330 319802136820 232270462403 232270462002 319802134730 319802131010 319802131010 319802133320 319802132220 319802134790 319802131010 319802131010 319802131010 319802131020 319802131020 319802131020 232270462403 232270462403 232270462403 232270462002 319802137590 319802137590 319802137590 232273462401 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 319802190030 242254944197 5401 5402 5403 5496 5497 5498 6400 6402 6404 6405 6406 6408 6409 6410 7402 7403 7404 7405 7406 7407 7408 7409 7410 7411 7412 7413 7414 7415 7416 7417 7423 7490 7491 7492 CBA CBA 1060 1109 1606 1693 2101 2102 2103 2691 BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC BC D ABC D ABC D ABC ABC ABC D Fixed Inductor 100MHZ 220R Fixed Inductor 100MHZ 220R Fixed Inductor 100MHZ 220R Coil, 470n Coil, 470n Coil, 470n Zener Diode, 8.2V Diode, Signal, BAS316 Zener Diode, 9.1V Zener Diode, 6.8V Diode, Signal, BAS316 Diode, Signal, BAS316 DIO REG SM UDZS2.0B Zener Diode, 8.2V IC SM TA1360AFG Transistor, NPN, BC847B IC SM TA1317AFG Transistor, NPN, BC847B Transistor, NPN, BC847B Transistor, PNP, BC857B Transistor, NPN, BC847B Transistor, PNP, BC857B Transistor, PNP, BC857B Transistor, PNP, BC857B Transistor, NPN, IMX1 Transistor, NPN, IMX1 Transistor, PNP, BC857B Transistor, PNP, BC857B Transistor, NPN, BC847B Transistor, NPN, BC847B IC SM LM2941S-NOPB Transistor, NPN, BC847B Transistor, NPN, BC847B Transistor, NPN, BC847B 242254944197 242254944197 242254944197 319801834770 319801834770 319801834770 319802058280 319801010630 932215008685 319802056880 319801010630 319801010630 932221993685 319802058280 932221351668 319801042030 932221353668 319801042030 319801042030 319801042150 319801042030 319801042150 319801042150 319801042150 932205428685 932205428685 319801042150 319801042150 319801042030 319801042030 932222110668 319801042030 319801042030 319801042030 FRONT INTERFACE PANEL Front Interface Panel Assy Front Interface Panel Assy FRNT.INTERF-LS.PNL-NA SWI SIGN 2P 0.1A 30V SPUN19 B Switch, Tactile Connector, 6 Pin Cap, 220u, 20%, 25V, Electrolytic Cap, 1u, 10%, 50V, Polyester Cap, 100n, 10%, 50V, Polyester Cap, 220u, 20%, 25V, Electrolytic 313918806011 313918887291 313918804761 242212802909 242212802742 242202510738 319802532210 319801401050 319801401040 319802532210 2692 2698 3111 3112 3113 3114 3691 3693 3694 3696 4601 6101 6102 6103 6691 6692 6693 CBA CBA 1251 1252 1254 1278 1278 1280 1281 2171 2172 2173 2174 2175 2176 2178 2180 2181 3150 3151 3152 3153 3154 3155 3156 3157 3158 D D ABC ABC ABC ABC D D D D D ABC ABC ABC D D D ABC D D D ABC ABC ABC D Cap, 1u, +80/-20%, 10V, Ceramic Cap, 100n, 10%, 50V, Polyester Res, 1K2, 5%, 1/6W, Carbon Film Res, 220 ohm, 5%, 1/6W, Carbon Film Res, 4K7, 5%, 1/6W, Carbon Film Res, 150K, 5%, 1/6W, Carbon Film Res, 1K2, 5%, 1/6W, Carbon Film Res, 220 ohm, 5%, 1/6W, Carbon Film Res, 4K7, 5%, 1/6W, Carbon Film Res, 150K, 5%, 1/16W, Metalized Glass Res, Zero ohm, 'Chip' Jumper LED IR Receiver, TSOP34836UH1B OPT SEN LTR-301 LED IR Receiver, TSOP34836UH1B OPT SEN LTR-301 319801741050 319801401040 319801101220 319801102210 319801104720 319801101540 319801101220 319801102210 319801104720 319802131540 319802190030 932218569682 932220678667 932219736682 932218569682 932220678667 932219736682 SIDE A/V PANEL Side A/V Panel Assy Side A/V Panel Assy 4 Pin Cinch Socket Connector, 7 Pin Connector, 5 Pin Connector, 4 Pin Connector, 4 Pin Connector, 3 Pin Connector, 3 Pin Cap, 330p, 10%, 50V, Ceramic Cap, 330p, 10%, 50V, Ceramic Cap, 330p, 10%, 50V, Ceramic Cap, 330p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Cap, 100n, 10%, 16V, Ceramic Cap, 470p, 10%, 50V, Ceramic Cap, 2u2, 20%, 50V, Electrolytic Res, Zero ohm, 'Chip' Jumper Res, 47K, 5%, 1/6W, Carbon Film Res, 22K, 5%, 1/6W, Carbon Film Res, 47K, 5%, 1/6W, Carbon Film Res, 22K, 5%, 1/6W, Carbon Film Res, 75 ohm, 5%, 1/6W, Carbon Film Res, 75 ohm, 5%, 1/6W, Carbon Film Res, 820 ohm, 5%, 1/6W, Carbon Film Res, 820 ohm, 5%, 1/6W, Carbon Film Res, 75 ohm, 5%, 1/6W, Carbon Film 313926715631 313926715661 242202605659 242202511244 242202512481 242202512479 242202515847 241202000725 242202516382 319801913310 319801913310 319801913310 319801913310 319802952280 319801731040 319801734710 319802952280 319802190030 319801104730 319801102230 319801104730 319801102230 319801107590 319801107590 319801108210 319801108210 319801107590 3159 3160 4180 CBA CBA 1010 1011 1012 1013 1014 1701 1702 1703 1704 1705 3008 3010 3011 3011 3012 3013 3013 3014 3014 3015 3016 9000 9001 9002 D Res, 100 ohm, 5%, 1/6W, Carbon Film Res, 100 ohm, 5%, 1/6W, Carbon Film Res, Zero ohm, 'Chip' Jumper 319801101010 319801101010 319802190020 ABC D D D D D D ABC ABC ABC ABC ABC ABC ABC D ABC D D ABC ABC D D D ABC ABC ABC TOP CONTROL PANEL Top Control Panel Assy Top Control Panel Assy Connector, 3 Pin Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Switch, Tactile Res, 150 ohm, 5%, 1/10W, Metalized Glass Res, 390 ohm, 5%, 1/10W, Metalized Glass Res, 150 ohm, 5%, 1/16W, Metalized Glass Res, 560 ohm, 5%, 1/10W, Metalized Glass Res, 390 ohm, 5%, 1/16W, Metalized Glass Res, 1K8, 1%, 1/16W, Metalized Glass Res, 1K8, 5%, 1/10W, Metalized Glass Res, 820 ohm, 5%, 1/10W, Metalized Glass Res, Zero ohm, 'Chip' Jumper Res, 820 ohm, 1%, 1/16W, Metalized Glass Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper Res, Zero ohm, 'Chip' Jumper 313918887281 313926710901 242202516601 242212802742 242212802742 242212802742 242212802742 242212802742 242212802742 242212802742 242212802742 242212802742 319802151510 319802153910 319802131510 319802155610 319802133910 232270461802 319802151820 319802158210 319802190030 232270468201 319802190030 319802190020 319802190020 319802190020