Download XL-DK225
Transcript
XL-DK225 SERVICE MANUAL No. S7734XLDK225/ MICRO COMPONENT SYSTEM MODEL VIDEO /AUX XL-DK225 XL-DK225 Micro Component System consisting of XL-DK225 (main unit) and CP-DK225 (speaker system). • In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its original condition and only parts identical to those specified be used. CONTENTS PRECAUTIONS FOR USING LEAD-FREE SOLDER CHAPTER 1. GENERAL DESCRIPTION [1] Important Service Safety Precaution ........... 1-1 [2] Specifications............................................... 1-1 [3] Names Of Parts ........................................... 1-2 CHAPTER 2. ADJUSTMENTS [1] CD Section .................................................. 2-1 [2] Test Mode .................................................... 2-2 [3] Standard Specification Of Stereo System Error Message Display Contents ................. 2-4 CHAPTER 3. MECHANICAL DESCRIPTION [1] Removing And Reinstalling The Main Parts ..................................................................... 3-1 [2] Disassembly ................................................ 3-2 CHAPTER 4. BLOCK DIAGRAM [1] Block Diagram ............................................. 4-1 CHAPTER 5. CIRCUIT DESCRIPTION [1] Waveforms Of Servo Circuit ........................ 5-1 [2] IC Voltage .................................................... 5-3 CHAPTER 6. CIRCUIT SCHEMATICS AND PARTS LAYOUT [1] Notes On Schematic Diagram ..................... 6-1 [2] Types Of Transistor And LED ...................... 6-1 [3] Schematic Diagram ..................................... 6-2 [4] Charts Of Connecting Wires ...................... 6-10 [5] Wiring Side of PWB ................................... 6-12 CHAPTER 7. FLOWCHART [1] Troubleshooting ........................................... 7-1 CHAPTER 8. OTHER [1] Function Table Of IC .................................... 8-1 [2] FL Display.................................................... 8-9 PARTS GUIDE Parts marked with " ! " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. SHARP CORPORATION –1 This document has been published to be used for after sales service only. The contents are subject to change without notice. XL-DK225 Service XL-MP150 Audio E Market XLMP150 Manual FOR USING LEAD-FREE SOLDER PRECAUTIONS 1. Employing lead-free solder "MAIN, POWER, SPEAKER, TRANSIT iPOD, DISPLAY, HEADPHONE, RE-FLASH, VOLUME LED, iPOD, CD MP3 PWB" of this model employs lead-free solder. The LF symbol indicates lead-free solder, and is attached on the PWB and service manuals. The alphabetical character following LF shows the type of lead-free solder. Example: Indicates lead-free solder of tin, silver and copper. 2. Using lead-free wire solder When fixing the PWB soldered with the lead-free solder, apply lead-free wire solder. Repairing with conventional lead wire solder may cause damage or accident due to cracks. As the melting point of lead-free solder (Sn-Ag-Cu) is higher than the lead wire solder by 40 C, were commend you to use a dedicated soldring bit, if you are not familiar with how to obtain lead-free wire solder or soldering bit, contact our service station or service branch in your area. 3. Soldering As the melting point of lead-free solder (Sn-Ag-Cu) is about 220 C which is higher than the conventional lead solder by 40 C, and as it has poor solder wettability, you may be apt to keep the soldering bit in contact with the PWB for extended period of time. However, since the land may be peeled off or the maximum heat-resistance temperature of parts may be exceeded, remove the bit from the PWB as soon as you confirm the steady soldering condition. Lead-free solder contains more tin, and the end of the soldering bit may be easily corrected. Make sure to turn on and off the power of the bit as required. If a different type of solder stays on the tip of the soldering bit, it is alloyed with lead-free solder. Clean the bit after every use of it. When the tip of the soldering bit is blackened during use, file it with steel wool or fine sandpaper. Be careful when replacing parts with polarity indication on the PWB silk. Lead-free wire solder for servicing Ref No. Description Parts No. PWB-A 92LPWB6895MANS MAIN (A1), POWER (A2), SPEAKER (A3), TRANSIT iPOD (A4) PWB-B 92LPWB6894DPLS DISPLAY (B1), HEADPHONE (B2), RE-FLASH (B3), VOLUME LED (B4) PWB-C 92LPWB6894PODS iPOD PWB-D 92LPWB6894CDUS CD MP3 – 2i XL-DK225 CHAPTER 1. GENERAL DESCRIPTION [1] Important Service Safety Precaution CAUTION : “These servicing instructions are for use by qualified service personnel only. To reduce the risk of electric shock do not perform any servicing other than that contained in the operating instructions unless you are qualified to do so”. WARNING 1. For continued safety, no modification of any circuit should be attempted. 2. Disconnect AC power before servicing. CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH SAME TYPE F801, F802, 3.15A, 125V/ F803, F804 2A, 125V/ F805 1.6A, 125V FUSES. ATTENTION: POUR ASSURER UNE LONGUE PROTECTION CONTRE UN INCENDIE, REMPLACER SEULEMENT PAR UN FUSIBLE DE TYPE F801, F802, 3.15A, 125V/ F803, F804 2A, 125V/ F805 1.6A, 125V FUSES. [2] Specifications General Tuner Power source Power consumption AC 120 V - 60 Hz 105 W Dimensions Width: 6-3/4" (175 mm) Height: 9-1/2" (240 mm) Depth: 12-1/5" (315 mm) Weight 10.5 lbs (4.78 kg) Frequency range Speaker Type Amplifier Output power 20 watts minimum RMS per channel into 6 ohms from 100 Hz to 20 kHz, 10% total harmonic distortion Output terminals Speakers: 6 ohms Headphones: 16 - 50 ohms (recommended: 32 ohms) Subwoofer pre-out (audio signal): 200 mV/10 k ohms at 70 Hz Video/Auxiliary (audio signal): 500 mV/47 k ohms Input terminals D/A converter Frequency response Dynamic range Maximum input power Rated input power Impedance Dimensions Weight CD player Type Signal readout FM: 87.5 - 108 MHz AM: 530 - 1,720 kHz 5-disc multi-play compact disc player Non-contact, 3-beam semiconductor laser pickup Multi bit D/A converter 20 - 20,000 Hz 90 dB (1 kHz) 1–1 3 2-way type speaker system 2" (5 cm) tweeter 4-3/4" (12 cm) woofer 40 W 20 W 6 ohms Width: 5-13/16" (148 mm) Height: 10-1/4" (260 mm) Depth: 6-7/8" (175.5 mm) 4.93 lbs. (2.24 kg)/each XL-DK225 [3] Names Of Parts Front panel 1. iPod Terminal 2. Disc Trays 3. Timer Indicator 4. Remote Sensor 5. Disc Stop Button 6. Disc or iPod Play or Pause Button 7. Power On/Standby Button 8. CD Button 9. Tuner (Band) Button 10. Video/Auxiliary/iPod Button 11. Headphone Jack 12. Volume Control 13. Disc Number Select Buttons 14. Disc Tray Open/Close Button 10 Display 1 2 3 4 5 6 7 13 14 9 10 11 8 15 16 12 1. Disc Number Indicators 2. MP3/WMA Folder Indicator 3. MP3/WMA Title Indicators 4. MP3 Indicator 5. WMA Indicator 6. Sleep Indicator 7. Timer Play Indicator 8. MP3/WMA Total Indicator 9. Daily Timer Indicator 10. FM Stereo Mode Indicator 11. FM Stereo Receiving Indicator 12. Memory Indicator 13. Extra Bass Indicator 14. Disc Repeat Play Indicator 15. Disc Pause Indicator 16. Disc Play Indicator Rear panel 3 4 5 6 1 2 7 8 9 1. Speaker Terminals 2. AC Power Cord 3. FM 75 Ohms Antenna Jack 4. AM Antenna Ground Terminal 5. AM Loop Antenna Terminal 6. Video/Auxiliary (Audio Signal) Input Jacks 7. Video Out Jack 8. Cooling Fan 9. Subwoofer Pre-output Jack Speaker system 1. 2. 3. 4. Tweeter Woofer Bass Reflex Duct Speaker Wire 1 3 2 4 4 1–2 XL-DK225 Remote control 1 2 7 8 9 11 13 12 14 15 10 16 3 4 5 18 17 19 20 23 21 22 6 5 1–3 1. Remote Control Transmitter 2. Disc Number Select Buttons 3. Disc Direct Search Buttons 4. Equalizer Mode Select Button 5. Extra Bass/Demo Button 6. Volume Up and Down Buttons 7. Power On/Stand-by Button 8. CD Button 9. Tuner (Band) Button 10. Video/Auxiliary/iPod Button 11. Disc Clear/Dimmer Button 12. Disc Stop Button 13. Memory Button 14. Disc Play or Pause Button 15. iPod Play or Pause Button 16. Tuning Up Button 17. CD Track Up or Fast Forward, Tuner Preset Up, Time Up Button 18. CD Track Down or Fast Reverse, Tuner Preset Down, Time Down Button 19. Tuning Down Button 20. Play Mode Button 21. Display Button 22. Folder Button 23. Clock/Timer Button XL-DK225 CHAPTER 2. ADJUSTMENTS [1] CD Section 1. CD SECTION • Adjustment Since this CD system incorporates the following automatic adjustment functions, readjustment is not needed when replacing the pickup. Therefore, different PWBs and pickups can be combined freely. Each time a disc is changed, these adjustments are performed automatically. Therefore, playback of each disc can be performed under optimum conditions. Items adjusted automatically 1) Offset adjustment (The offset voltage between the head amplifier output and the VREF reference voltage is compensated inside the IC.) * Focus offset adjustment * Tracking offset adjustment 2) Tracking balance adjustment 3) Gain adjustment (The gain is compensated inside the IC so that the loop gain at the gain crossover frequency will be 0 dB.) * Focus gain adjustment * Tracking gain adjustment 2. CD ERROR CODE DESCRIPTION Error 10* 11* 20* 21* Explanation CAM error. Can't detect CAM switch when CAM is moving. When it detect cam operation error during initialize process. TRAY error. Can't detect TRAY switch when TRAY is moving. When it detect TRAY operation error during initialize process. * 'CHECKING' If Error is detected, 'CHECKING' will be displayed instead of 'ER-CD**'. 'ER-CD**' display will only be displayed when error had been detected for the 5th times. 2–1 XL-DK225 [2] Test Mode • Setting the test mode During stand-by mode, press STOP button while 3 button and 44 button. Then, pressing down the press the CD button to enter the test mode. \ CD Step 1 TE ST IL isn’t done OPEN/CLOSE operation is using manual. IL isn’t done << / >> key input. Laser ON. Step 2 << / >> key input. Focus ON Step 3 << / >> key input. CLV Servo ON Step 4 << / >> key input. Tracking Servo ON Step 5 << / >> key input. Reading Sub-code and Display <<STOP>> key input. STOP and return to Step 1 Hold down << CD >> key for more than 2 sec. Start Auto Adjustment at current pick-up location. <<STOP>> key input. 2–2 XL-DK225 STOP and return to Step 1 Everytime << DISPLAY >> key input a) Focus Balance b) Focus Gain c) Tracking Balance d) Tracking Gain e) Focus Offset f) Tracking Offset g) RFRP h) Focus Error (RW Judgement) i) Focus Error (Other than RW Judgement) = FB : XX = FG : XX = TB : XX = TG : XX = FOFF : XX = TOFF : XX = RFRP : XX = RW : XX - XXXX = DA : XX - XXXX <<STOP>> key input. STOP and return to Step 1 Note Sliding the PICKUP with << in STOP mode or play mode. During at Step 1 , if press << goes to step 5 . To cancel: Power OFF 2–3 >>, << / >> button can be set >> for more than 1 sec, it directly XL-DK225 [3] Standard Specification Of Stereo System Error Message Display Contents CD Error Contents CD Changer Mechanism Error. TUNER Focus Not Match/IL Time Over. PLL Unlock. DISPLAY ‘ER-CD**’ (*) Notes 10: CAM SW Detection NG during normal operation 11: CAM SW Detection NG during initialize process 20: TRAY SW Detection NG during normal operation 21: TRAY SW Detection NG during initialize process ‘NO DISC’ FM 87.50 PLL Unlock. MHz (*) CHECKING: If CD changer mechanism error is detected, 'CHECKING' will be display instead of 'ER-CD**'. 'ER-CD**' will only be display when error had been detected for the 5th times. Speaker abnormal detection and +B PROTECTION display In case speaker abnormal detection or +B PROTECTION had occurred, the unit will automatically enter to stand-by mode and Timer indicator will flashing as below. Example: In case of speaker abnormal FLASHING ON TIMER LED OFF NO. 1 ON OFF OFF OFF FLASHING ON NO. 1 OFF ON OFF OFF NO. 2 NO. 2 1 FRAME (REPEAT) NO. 1 : +B PROTECTION NO. 2 : Speaker abnormal BEFORE TRANSPORTING THE UNIT The following process need to be taken after set tapering/parts replacement. 1. Press the POWER ON/STAND-BY button to enter stand-by mode. 3 button and the 2. While pressing down the number will be displayed as "X5U_10**". 3. Press the 4 4 button, press the button until "WAIT"--> "FINISHED" appears. 4. Unplug the AC cord and the unit is ready for transporting. 2–4 button. The Micro Computer version XL-DK255 CHAPTER 3. MECHANICAL DESCRIPTION [1] Removing And Reinstalling The Main Parts Reduction gear D 1. CHANGER MECHANISM SECTION Perform steps 1, 2, 9 and 10 of the disassembly method to remove the CD changer mechanism. 1.1 How to remove CD Disc (See Fig. 1-4) 1. When CD is at play position (Figure 1), rotate reduction gear C clock-wise as shown in Figure 2 until disc tray is at stock position, then rotate further to eject the disc tray so that CD can be removed from the tray. Up Down Figure 3 CD Disc Disc Tray Guide Tray Gear up down board Mark 1 Mark 3 Mark 5 (DISC 1) (DISC 3) (DISC 5) Mark 2 Mark 4 (DISC 2) (DISC 4) CD at play position. CD Disc Figure 4 CD at stalk position. Figure 1 Reduction gear C Front Rear Figure 2 2. In another case, if CD mechanism is at tray No.1 play position and to remove CD located in tray No.3, the procedure is as follows: If the gear up down board is located at tray No.1 position, then rotate gear clock-wise until it is at stock postiiton. Rotate reduction gear D clockwise (Figure 3) to move the CD mechanism to tray No.3 position. This is confirmed by checking the gear up down board position by the marking as indicated on the main chassis as shown in Figure 4. 3–1 XL-DK255 [2] Disassembly Caution on disassembly Follow the below-mentioned notes when disassembling the unit and reassembling it, to keep it safe and ensure excellent performance: 1) Take cassette tape and compact disc out of the unit. 2) Be sure to remove the power supply plug from the wall outlet before starting to disassemble the unit. 3) Take off nylon bands or wire holders where they need to be removed when disassembling the unit. After servicing the unit, be sure to rearrange the leads where they were before disassembling. 4) Take sufficient care on static electricity of integrated circuits and other circuits when servicing. STEP REMOVAL PROCEDURE Top Cabinet (A1)x2 3x12mm (B1)x2 3x10mm (A1)x2 3x12mm Side Panel (Left) Side Panel (Right) (A1)x2 3x12mm (B1)x2 3x10mm Rear Panel (B1)x2 3x10mm FIGURE 1 Top Cabinet 1. Screw ............................ (A1) X 6 1 2 Side Panel (Left/Right) 1. Screw ............................ (B1) X 8 1 CD Changer unit 1. Screw ............................(C1) X 2 3 Front Panel (B1)x2 3x10mm Figure 1 (C4)x2 (C3)x2 CD MP3 PWB CD Changer Unit 2 2. Hook ..............................(C2) X 2 (C3)x1 3. Socket ...........................(C3) X 3 Front Panel 4. Flat Cable ......................(C4) X 2 4 Rear Panel with Speaker PWB 1. Screw ............................(D1) X 4 PULL 2 (C1)x1 3x10mm Hook (C2)x1 2. Socket ...........................(D2) X 1 3. Flat Cable ......................(D3) X 1 Hook (C2)x1 PULL 5 Front Panel 1. Screw ............................ (E1) X 3 3 2. Flat Cable ...................... (E2) X 2 (C1)x1 3x10mm 3. Socket ........................... (E3) X 1 4. Hook .............................. (E4) X 2 6 Main PWB 1. Screw ............................ (F1) X 3 Rear Panel 3 Speaker PWB (D3)x1 2. Socket ........................... (F2) X 2 7 Power PWB 1. Screw ............................(G1) X 4 3 8 Speaker PWB 1. Screw ............................(H1) X 2 4 9 Display PWB 1. Knob ...............................(J1) X 1 5 (D1)x4 3x10mm (D2)x1 Figure 2 (E1)x1 3x6mm (F1)x1 3x6mm 2. Nut ..................................(J2) X 1 3. Washer ...........................(J3) X 1 4. Screw .............................(J4) X 6 10 USB PWB / SUB PWB 1. Screw ............................ (K1) X 2 5 11 Jack PWB 1. Screw ............................ (L1) X 1 5 12 Re-Flash PWB 1. Screw ........................... (M1) X 1 6 13 CD MP3 PWB 1. Screw ............................(N1) X 3 7 2. Flat Cable ......................(N2) X 2 (E4)x1 PULL Front panel (E3)x1 (F2)x1 (G1)x4 4x6mm (E2)x2 Power PWB 3. Socket ...........................(N3) X 1 14 CD Mechanism 1. Screw ............................ (P1) X 4 7 2. Screw ............................ (P2) X 4 8 Hook (E4)x1 PULL Note: After removing the connector for the optical pickup from the connector, wrap the conductive aluminium foil around the front end of the connector so as to protect the optical pickup from electrostatic damage. 3–2 (F2)x1 Main PWB Figure 3 (F1)x2 3x10mm (E1)x2 3x10mm XL-DK255 Rear Panel (P2)x4 Special (H1)x2 Ø3x10mm CD Mechanism CD Changer Unit Speaker PWB Figure 4 Front Panel Display PWB (J2)x1 (J4)x6 Ø2.6x10mm Figure 8 (J1)x1 (J3)x1 STEP 1 REMOVAL Woofer SUB PWB PROCEDURE FIGURE 1. Net Frame Ass’y............ (A1) X 1 9, 10 2. Catching Holder............. (A2) X 4 3. Screw ............................ (A3) X 4 4. Screw ............................ (A4) X 4 USB PWB 2 (K1)x2 Ø2.6x10mm Jack PWB Tweeter 1. Screw ............................ (B1) X 2 (L1)x1 Special 10 Speaker Box Figure 5 Re-Flash PWB Net Frame Ass’y (A1) x1 (M1)x1 Ø3x10mm Main Chassis Figure 6 (A2)x4 (A3)x4 Ø4x20mm Figure 9 CD Changer Unit Front Board Tweeter (B1)x2 Ø3x14mm Tweeter Ring (A4)x4 Ø3.5x14mm Woofer Woofer Ring (N2)x2 (P1)x2 Ø3x10mm (P1)x2 Ø3x10mm (N3)x1 Figure 10 (N1)x3 Ø3x10mm Figure 7 3–3 XL-DK255 -MEMO- 3–4 XL-DK225 CHAPTER 4. DIAGRAMS [1] Main Block Diagram Figure 4-1: MAIN BLOCK DIAGRAM (1/2) 4–1 XL-DK225 Figure 4-2: MAIN BLOCK DIAGRAM (2/2) 4–2 XL-DK225 [2] CD Block Diagram Figure 4-3: CD BLOCK DIAGRAM (1/2) 4–3 XL-DK225 Figure 4-4: CD BLOCK DIAGRAM (2/2) 4–4 XL-DK225 CHAPTER 5. CIRCUIT DESCRIPTION [1] Waveforms Of CD Circuit 1 IC1 22 FDO 1 FDO 22 IC1 2 IC1 TDO 23 5 IC1 SPDO 25 PDOUT 0 1 IC1 3 IC1 22 16 FDO 6 IC1 28 7 IC1 27 PDOUT 1 TE 1 FDO 22 IC1 3 IC1 16 TE 4 2 IC1 4 IC1 2 RFOUT 5–1 RFOUT XL-DK225 [2] Voltage IC1 PIN NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 VOLTAGE 0.02 1.63 0.76 0.70 0.59 0.70 1.63 3.27 1.63 1.63 1.63 1.63 1.63 0.01 0.52 0.55 0.01 0.01 1.11 0.36 0.26 0.01 0.26 0.34 0.54 PIN NO 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 PIN NO 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 VOLTAGE 0.01 1.52 3.03 1.52 1.52 0.01 3.27 0.03 4.53 1.53 0.01 3.25 2.41 2.14 2.59 2.25 0.61 3.25 0.04 0.04 0.04 0.04 0.10 1.64 1.65 VOLTAGE 1.53 0.03 3.27 0.03 0.03 3.27 1.53 3.27 0.04 3.27 0.03 0.03 0.03 0.03 1.62 1.65 3.24 1.49 0.02 1.63 3.26 1.61 1.31 0.02 1.38 PIN NO 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 VOLTAGE 3.26 1.63 0.98 0.02 1.74 1.63 1.63 1.68 1.63 1.62 1.64 1.66 1.62 0.50 3.27 3.25 0.01 0.02 1.63 1.63 1.63 1.63 1.63 1.64 1.63 IC2 PIN NO 1 2 3 4 5 6 7 8 9 VOLTAGE 3.18 3.17 3.19 3.20 3.19 3.18 0.00 4.39 7.08 PIN NO 10 11 12 13 14 15 16 17 18 Q1 PIN NO E C B VOLTAGE 3.26 0.89 4.37 VOLTAGE 5.08 5.05 4.37 3.27 1.63 1.63 1.63 1.63 1.63 1.63 1.62 1.62 PIN NO 19 20 21 22 23 24 25 26 27 Q2 PIN NO E C B Q5 PIN NO E C B VOLTAGE VOLTAGE 5.05 3.26 4.37 VOLTAGE 3.20 3.20 0.01 0.01 0.01 0.01 0.00 7.03 7.08 Q3 PIN NO E C B VOLTAGE 1.48 3.26 2.17 Q8 PIN NO E C B PIN NO 28 29 30 31 32 33 34 35 36 VOLTAGE 0.00 0.04 2.98 5–2 VOLTAGE 7.09 0.01 1.63 2.24 3.15 3.16 2.69 3.16 3.16 Q4 PIN NO E C B VOLTAGE 0.01 0.02 3.11 XL-DK225 IC701 IC702 PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 3.22 3.22 0.00 0.00 0.00 3.22 0.00 0.00 0.00 0.47 0.63 3.19 1.54 0.00 0.00 3.24 3.24 1.05 0.00 3.18 0.00 0.00 0.00 0.00 0.71 0.00 0.00 3.24 0.00 0.00 3.24 0.00 3.24 3.24 3.24 3.28 3.27 0.00 0.00 0.00 0.00 0.00 0.76 0.63 0.00 3.23 0.00 0.58 0.00 0.00 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 3.30 3.14 3.31 3.31 3.15 3.23 3.24 3.23 3.24 3.24 3.31 3.24 0.00 0.00 0.00 0.00 3.14 0.00 0.00 3.22 3.31 0.00 0.00 3.24 3.24 3.24 0.00 0.00 0.00 0.00 3.24 3.22 3.28 0.00 3.31 3.24 0.00 0.00 0.00 0.00 3.31 3.28 3.28 3.28 3.28 0.00 3.28 3.30 3.24 0.00 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 -26.44 -26.40 -26.40 -26.40 3.24 3.20 3.24 3.24 0.00 0.00 3.29 1.51 1.51 0.00 -24.10 -28.77 -28.78 -28.77 -28.77 -28.75 -28.77 -28.77 -21.70 -28.97 -26.40 -28.77 -28.76 -28.76 21.71 -24.06 -24.07 -24.07 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 -26.42 -28.77 -26.41 -26.40 -26.41 -24.06 -17.00 -26.40 -24.07 -9.89 -26.40 -9.98 -17.00 -12.34 -9.94 -26.40 -26.42 -24.06 -14.67 -12.36 -28.76 -28.76 -28.76 -28.75 -26.45 -26.41 -26.41 -26.40 -26.40 -26.40 -26.40 -26.40 PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 4.62 4.62 4.63 4.63 4.62 4.62 4.63 4.65 4.61 4.65 4.61 4.65 4.65 4.64 15 16 17 18 19 20 21 22 23 24 25 26 27 28 4.65 0.00 0.00 4.64 4.64 0.00 0.00 0.00 4.63 9.28 0.00 4.65 4.65 4.63 IC601 5–3 XL-DK225 IC703 IC705 IC901 PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) 1 2 3 4 5 3.30 3.30 0.00 - 1 2 3 3.90 0.60 5.60 1 2 3 4 5 6 7 8 -0.10 -0.10 21.90 -20.70 0.00 0.00 23.10 9 10 11 12 13 14 15 -23.00 0.00 0.00 -22.10 0.00 -0.10 -0.10 IC852 IC853 IC851 PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) PIN NO VOLTAGE (V) 1 2 3 15.80 0.00 4.90 1 2 3 3.30 0.00 5.10 1 2 3 4 5.10 13.00 16.40 0.00 5 6 7 16.20 10.00 8.50 PIN NO 1 2 3 PIN NO 1 2 3 IC854 VOLTAGE (V) 5.60 0.60 13.90 Q701 VOLTAGE (V) 0.00 3.20 0.00 PIN NO 1 2 3 PIN NO 1 2 3 PIN NO Q801 VOLTAGE (V) PIN NO 1 2 3 -28.90 -29.50 -37.60 1 2 3 PIN NO Q902 VOLTAGE (V) PIN NO 1 2 3 PIN NO 1 2 3 0.00 3.30 0.00 1 2 3 Q603 VOLTAGE (V) 0.00 0.00 0.70 Q702 VOLTAGE (V) 0.00 3.20 0.00 Q841 VOLTAGE (V) 0.80 0.00 0.00 Q903 VOLTAGE (V) 0.00 3.10 0.00 PIN NO 1 2 3 PIN NO 1 2 3 PIN NO 1 2 3 PIN NO 1 2 3 Q604 VOLTAGE (V) 0.00 0.00 0.70 Q704 VOLTAGE (V) 0.00 3.30 0.00 Q860 VOLTAGE (V) 0.00 3.50 0.00 Q904 VOLTAGE (V) 0.00 3.10 0.00 Q906 VOLTAGE (V) 0.70 0.00 3.60 5–4 PIN NO 1 2 3 PIN NO 1 2 3 PIN NO 1 2 3 PIN NO 1 2 3 Q608 VOLTAGE (V) 2.20 2.20 0.00 Q706 VOLTAGE (V) 0.00 0.00 3.00 Q901 VOLTAGE (V) 0.00 3.40 0.00 Q905 VOLTAGE (V) 0.00 0.00 0.70 XL-DK225 -MEMO- 5–5 XL-DK225 CHAPTER 6. CIRCUIT SCHEMATICS AND PARTS LAYOUT [1] Notes On Schematic Diagram • Resistor: To differentiate the units of resistors, such symbol as K and M are used: the symbol K means 1000 ohm and the symbol M means 1000 kohm and the resistor without any symbol is ohm-type resistor. Besides, the one with “Fusible” is a fuse type. • Capacitor: To indicate the unit of capacitor, a symbol P is used: this symbol P means pico-farad and the unit of the capacitor without such a symbol is microfarad. As to electrolytic capacitor, the expression “capacitance/ withstand voltage” is used. (CH), (TH), (RH), (UJ): Temperature compensation (ML): Mylar type (P.P.): Polypropylene type REF. NO SW701 SW702 SW703 SW704 SW705 SW706 SW707 SW708 SW709 SW710 SW711 SW712 VR701 DESCRIPTION DISC4 DISC5 OPEN/CLOSE DISC1 DISC2 DISC3 POWER ON/STAND-BY PLAY/REPEAT STOP VIDEO/AUX/USB TUNER (BAND) CD VOLUME • Schematic diagram and Wiring Side of P.W.Board for this model are subject to change for improvement without prior notice. • The indicated voltage in each section is the one measured by Digital Multimeter between such a section and the chassis with no signal given. 1. In the tuner section, indicates AM indicates FM stereo 2. In the CD section, the CD is stopped. • Parts marked with “ ” ( ) are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. POSITION ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF MAX—MIN [2] Types Of Transistor And LED FRONT VIEW TOP VIEW E C B (S)(G)(D) (1)(2)(3) KTA1271 Y KTA1274 Y KIA78L05 KTC3199 GR KTC3203 Y TOP VIEW TOP VIEW HSS4148 1N4004S DRL204F MA111 B (3) C (2) E (1) KRA102 S KRC107 S KRC102 S KRC104 S KTA1504 GR KTC3875 GR KTA1544 T KTC3265 Y TOP VIEW FRONT VIEW FRONT VIEW AC KDS184 FRONT VIEW 1 2 3 AC 343VC3F 503BC2E30 10XB60F S4B05GM 6–1 KIA7805A XL-DK225 [3] Schematic Diagram A C TO POWER IC SECTION B TO CD D FROM POWER SECTION E TUNER SECTION F G H 1 2 3 4 Figure 6-1: MAIN SCHEMATIC DIAGRAM (1/2) 6–2 5 6 XL-DK225 7 8 9 10 Figure 6-2: MAIN SCHEMATIC DIAGRAM (2/2) 6–3 11 12 XL-DK225 A B C D TO MAIN SECTION E TO DISPLAY F G H 1 2 3 4 Figure 6-3: POWER SCHEMATIC DIAGRAM (1/2) 6–4 5 6 XL-DK225 AC SUPPLY 120V ~ 60Hz SPEAKER JACK PWB 7 8 9 10 Figure 6-4: POWER SCHEMATIC DIAGRAM (2/2) 6–5 11 12 XL-DK225 SYSTEM MICOM REFLASH PWB TO PWR SECTION A B C TO MAIN SECTION D E TO MAIN SECTION F G H 1 2 3 4 Figure 6-5: DISPLAY SCHEMATIC DIAGRAM (1/2) 6–6 5 6 FOR MICOM REFLASH ONLY TO MP3 SERVO TO MP3 SERVO XL-DK225 7 8 9 10 Figure 6-6: DISPLAY SCHEMATIC DIAGRAM (2/2) 6–7 11 12 XL-DK225 A B C D E F G H 1 2 3 4 Figure 6-7: CD MP3 SCHEMATIC DIAGRAM (1/2) 6–8 5 6 XL-DK225 7 8 9 10 Figure 6-8: CD MP3 SCHEMATIC DIAGRAM (2/2) 6–9 11 12 XL-DK225 RESISTOR WITH 1% TOLERANCE IPOD CONNECTION A B C D E F G H 1 2 3 4 Figure 6-9: iPOD SCHEMATIC DIAGRAM (1/2) 6 – 10 5 6 XL-DK225 TO TRANSIT iPOD 7 8 9 10 Figure 6-10: iPOD SCHEMATIC DIAGRAM (2/2) 6 – 11 11 12 XL-DK225 9 [4] Charts Of Connecting Wires TUNER PACK A TRANSIT iPOD PWB-A4 1 12 1 ANTENNA FFC301 2 4 6 8 10 12 1 3 5 7 9 11 CNPU4 FM CNPU5 1 2 3 4 5 6 7 8 9 10 11 12 9 GND 1 2 3 4 5 6 7 8 9 10 11 12 B 9 8 7 6 5 4 3 2 1 iPOD PWB-C 1 2 3 4 5 6 7 8 9 10 11 12 13 1 9 1 BI101 11 GY BK GY BK GY BK GY BK BR CNS601 FFC301 RD WH BL WH BL WH BL WH BL WH BL WH AM 17 CNP701B 1 CNPU3 FROM EXTERNAL iPOD DEVICE 10 9 8 7 6 5 4 3 2 1 BI601 1 2 3 4 5 6 7 8 9 10 11 WH BK WH BK WH BK WH BK WH RD WH BK WH BK WH BK WH BK WH RD BI801 1 MAIN PWB -A1 1 2 CNP971 1 3 5 7 9 11 13 15 17 2 4 6 8 10 12 14 16 2 4 6 8 10 12 1 3 5 7 9 11 FAN MOTOR BI902 5 43 2 1 GR WH GR RD 4 32 1 SPEAKER PWB-A3 1 2 3 4 R-CH JK701 E CNP902 L-CH L-CH R-CH HEADPHONE PWB-B2 SPEAKER TERMINAL SO901 CNS701 6 5 4 3 2 1 12 7 6 5 4 3 2 1 BI701 CNP801 F 1 2 3 4 5 6 7 8 9 10 1 17 1 10 11 9 7 5 3 1 12 10 8 6 4 2 2 4 6 8 10 13579 CNP705 CNP702 1 2 3 4 5 6 CNS703 CNP802 WH PT801 RD DISPLAY PWB-B1 BI702 CNP805 VOLUME LED PWB-B4 WH BK RD WH BK WH BK WH BK WH PT841 1 CNS702 AC POWER SUPPLY CORD AC 120V~60Hz 8 7 6 5 4 3 2 1 CNS 805 G WH BK WH BK WH BK WH RD 1 2 9 8 7 6 5 4 3 2 1 CNP703 1 2 1 2 BI703 POWER PWB-A2 H F MAIN CN TO CD MP3 PWB-D CNP6 L-CH R-CH FFC702 FROM HEADPHONE FFC705 CNP708 1 2 3 4 5 CNS902 BL GR BL GR BL RD D CNP301 CNS801 1 2 3 4 5 6 7 8 9 10 C TO DISPLAY PWB-B1 CNP701A FFC701 CNP101 2 4 6 8 1 3 5 7 9 2 3 4 Figure 6-11: WIRING CONNECTION (1/2) 6 – 12 5 6 17 15 13 16 14 C XL-DK225 FROM DISPLAY PWB-B1 CNP702 FFC702 FFC705 1 1 CNP5 4 3 6 5 8 7 10 9 1 CNP4 CNP6 CD MP3 PWB-C 1 2 3 4 5 6 CNP2 WH GR WH GR WH RD 2 9 8 7 6 5 4 3 2 1 CNP3 CNS2 FFC4 2 4 6 8 10 1 3 5 7 9 11 11 11 9 7 5 3 1 12 10 8 6 4 2 1 2 3 4 5 6 CNP1 FROM MAIN PWB-A1 CNP701B 17 2 4 6 8 10 12 14 16 1 3 5 7 9 11 13 15 FFC701 TO CD MOTOR PWB TO CD CHANGER MECHANISM UNIT 12 10 1 1 16 FFC1 1 17 15 13 11 9 7 5 3 1 16 14 12 10 8 6 4 2 02 1 CNP701A FROM EXTERNAL MICOM DEVICE 16 TO CD PICK-UP UNIT -B1 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 CNPU2 CNPU1 COLOR TABLE RE-FLASH PWB-A4 7 8 9 10 Figure 6-12: WIRING CONNECTION (2/2) 6 – 13 11 BR BL GY BK GR WH BROWN BLUE GRAY BLACK GREEN WHITE RD RED 12 XL-DK225 [5] Wiring Side Of PWB L-CH L-CH MAIN PWB-A1 10 9 8 7 6 5 4 3 2 1 E C B 1 3 5 7 9 11 13 15 17 2 4 6 8 10 12 14 16 1 2 3 4 R-CH 1 2 3 4 5 6 8 9 10 11 B C E Lead-free solder indication Lead-free solder is used in the MAIN PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-13: WIRING SIDE OF MAIN PWB (TOP VIEW) (1/2) 6 – 14 E C B R-CH SO901 SPEAKER TERMINAL SPEAKER PWB-A3 B C E XL-DK225 TRANSIT iPOD PWB-A4 2 4 6 8 10 12 1 3 5 7 9 11 1 2 3 4 5 6 7 8 9 10 11 12 2 4 6 8 1 3 5 7 9 1 2 4 6 8 1012 3 5 7 9 11 B C E VIDEO/AUX IN L-CH and R-CH VIDEO OUT 1 2 1 2 3 4 5 6 7 8 9 10 11121314 15 SUBWOOFER PRE-CUT 5 4 3 2 1 Figure 6-14: WIRING SIDE OF MAIN PWB (TOP VIEW) (2/2) 6 – 15 XL-DK225 MAIN PWB-A1 Lead-free solder indication Lead-free solder is used in the MAIN PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-15: WIRING SIDE OF MAIN PWB (BOTTOM VIEW) (1/2) 6 – 16 XL-DK225 Figure 6-16: WIRING SIDE OF MAIN PWB (BOTTOM VIEW) (2/2) 6 – 17 XL-DK225 POWER PWB-A2 5 4 6 3 7 8 2 9 1 BK WH 6 5 4 3 2 1 T.F. 8 9 POWER SUPPLY AC 120V~60Hz 10 11 12 13 14 15 16 17 B C E B C E 10 9 8 7 6 5 4 3 2 1 1 2 3 6 54 32 1 Lead-free solder indication COLOR TABLE Lead-free solder is used in the POWER PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. WH BK Figure 6-17: WIRING SIDE OF POWER PWB 6 – 18 WHITE BLACK XL-DK225 -MEMO- 6 – 19 XL-DK225 DISPLAY PWB-B1 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 2 9 10 8 2 1 4 3 6 5 8 10 12 14 16 7 9 11 13 15 17 Lead-free solder indication Lead-free solder is used in the DISPLAY PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-18: WIRING SIDE OF DISPLAY PWB (TOP VIEW) (1/2) 6 – 20 7 5 6 1 3 4 2 XL-DK225 2 1 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 1 2 3 2 1 1 4 3 6 5 8 10 12 7 9 11 1 2 3 4 5 6 7 Figure 6-19: WIRING SIDE OF DISPLAY PWB (TOP VIEW) (2/2) 6 – 21 XL-DK225 DISPLAY PWB-B1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 2 Lead-free solder indication Lead-free solder is used in the DISPLAY PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-20: WIRING SIDE OF DISPLAY PWB (BOTTOM VIEW) (1/2) 6 – 22 XL-DK225 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 Figure 6-21: WIRING SIDE OF DISPLAY PWB (BOTTOM VIEW) (2/2) 6 – 23 XL-DK225 HEADPHONE PWB-B2 A 1 2 34 5 B C FROM HEADPHONE D REFLASH PWB-B3 8 7 654 321 8 7 654 321 E VOLUME LED PWB-B4 1 2 F G Lead-free solder indication H Lead-free solder is used in the HEADPHONE, REFLASH, VOLUME LED PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. 1 2 3 4 5 Figure 6-22: WIRING SIDE OF HEADPHONE, REFLASH, VOLUME LED PWB (TOP VIEW) 6 – 24 6 XL-DK225 HEADPHONE PWB-B2 A B C D VOLUME LED PWB-B4 E F G Lead-free solder indication H Lead-free solder is used in the HEADPHONE, VOLUME LED PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. 1 2 3 4 5 Figure 6-23: WIRING SIDE OF HEADPHONE, VOLUME LED PWB (BOTTOM VIEW) 6 – 25 6 XL-DK225 13 12 11 10 9 8 7 6 5 4 3 2 1 iPOD PWB-C Lead-free solder indication Lead-free solder is used in the iPOD PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-24: WIRING SIDE OF iPOD PWB (TOP VIEW) 6 – 26 XL-DK225 iPOD PWB-C Lead-free solder indication Lead-free solder is used in the iPOD PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-25: WIRING SIDE OF iPOD PWB (BOTTOM VIEW) 6 – 27 XL-DK225 CD MP3 PWB-D 12 10 8 6 4 2 9 8 7 6 5 4 3 2 1 2 4 6 8 10 11 1 2 3 4 5 6 SCREW TO CHASSIS B C E 1 3 5 7 9 11 9 7 5 3 1 2 4 6 8 10 12 1 3 5 7 9 11 13 Figure 6-26: WIRING SIDE OF CD MP3 PWB (TOP VIEW) (1/2) 6 – 28 XL-DK225 3 2 1 2 4 6 8 10 12 14 1 3 5 7 9 11 13 6 8 10 12 14 16 7 9 11 13 15 Lead-free solder indication Lead-free solder is used in the CD MP3 PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-27: WIRING SIDE OF CD MP3 PWB (TOP VIEW) (2/2) 6 – 29 XL-DK225 CD MP3 PWB-D Lead-free solder indication Lead-free solder is used in the CD MP3 PWB. Refer to "Precautions for handling lead-free solder" for instructions and precautions. Figure 6-28: WIRING SIDE OF CD MP3 PWB (BOTTOM VIEW) (1/2) 6 – 30 XL-DK225 Figure 6-29: WIRING SIDE OF CD MP3 PWB (BOTTOM VIEW) (2/2) 6 – 31 XL-DK225 CHAPTER 7. FLOWCHART [1] Troubleshooting 1. When the CD does not function The CD section may not operate when the objective lens of the optical pickup is dirty. Clean the objective lens, and check the playback operation. When this section does not operate even after the above step is taken, check the following items. Remove the cabinet and follow the trouble shooting instructions. "Track skipping and/or no TOC (Table Of Contents) may be caused by build up of dust other foreign matter on the laser pickup lens. Before attempting any adjustment make certain that the lens is clean. If not, clean it as mentioned below." Turn the power off. Gently clean the lens with a lens cleaning tissue and a small amount of isopropyl alcohol. Do not touch the lens with the bare hand. 1. Parts code UDSKA0004AFZZ CD optical pickup Lens cleaner disc HOW TO USE 1. Using the brush in the cleaner cap, apply 1 or 2 drops of the cleaning fluid to the brush on the CD cleaner disc which has the mark next to it. 2. Place the CD cleaner disc onto the CD disc tray with the brush side down, then press the play button. 3. You will hear music for about 20 seconds and the CD player will automatically stop. If it still play continuously, press the stop button. Cleaning fluid CAUTION The CD lens cleaner should be effective for 30-50 operations, however if the brushes become worn out earlier then please replace the cleaner disc. If the CD cleaner brushes become very wet then wipe off any excess fluid with a soft cloth. Do not drink the cleaner fluid or allow it contact with the eyes. In the event of this happening then drink and / or rinse with clean water and seek medical advice. The CD cleaner disc must not be used on car CD players or on computer CD-ROM drives. All rights reserved. Unauthorized duplicating, broadcasting and renting this product is prohibited by law. 2. When a CD cannot be played 2.1. Pressing the CD operation key is accepted, but playback does not occur. 1) Focus-HF system check 2) Tracking system check 3) Spin system check 4) PLL system check 5) Others 7–1 Cleaner disc XL-DK225 (1) Focus-RF system check. Although a CD is inserted and the cover is closed, "NO DISC" is displayed. 1 Press the Tray1 CD Eject Button without inserting a disc, and try starting the playback operation. IC1 22 2 IC1 FDO TDO 23 Figure 1 1. Does the pickup move to the PICKUP-IN Switch (NSW1) position? Yes 2. Does the focus (lens) move up and down? (Waveform drawing Figure 1) No Sled motor (NM2). No Check the focus peripheral circuit. No Check the laser diode driver Q1 peripheral circuit. No Spindle motor (NM1). No Pins 5~9, 11, 18 19 and 22 on IC1 Check the laser diode driver Q1 peripheral circuit. No If the level is not normal. Yes 3. Is the laser lit? Yes 4. Is the turntable rotating? When a disc is loaded, start playback operation. 1. Is focus servo activated? (Waveform drawing Figure 2) Yes 2. Is the RF waveform normal? (Waveform drawing Figure 3) 1 IC1 22 FDO 4 2 IC1 3 IC1 16 RFOUT TE Figure 2 Figure 3 7–2 XL-DK225 (2) Focus-RF system check. Check the TE waveform at pin 16 on IC1. If the waveform shown in Figure 4 appears and soon after NO DISC appears? No "Initialization" is possible, but play is not possible? The tracking servo is not activated. Check the peripheral circuits at pins 15, 16 and 23 on IC1, and FFC1. Yes A normal jump operation cannot be completed or the beginning of the track cannot be found. Check the around pin 23 on IC1. Yes No "Initialization" is not possible. Data cannot be read. Check the VCO-PLL (Pin26~30 on IC1) system. 3 IC1 16 TE 4 IC1 2 RFOUT Figure 4 (3) Spin system check. Press the OPEN/CLOSE switch without inserting a disc, and then try starting the play operation. 1. The turntable rotates a little? (Waveform drawing Figure 5) Yes The spin driver circuit is OK. No 2. The turntable doesn't rotate. Check around pin 25 on IC1, pins 1 and 2 on CNP2. 1 FDO 22 IC1 5 IC1 SPDO 25 Figure 5 7–3 XL-DK225 (4) PLL system check. When a disc is loaded, start play operation. PDOUT 0 6 IC1 28 7 IC1 27 The RF waveform is normal, but the TOC data cannot be read. Check the PDOUT waveform. (Figure 6) 1 PDOUT 1 FDO 22 IC1 Check around pins 26~30 on IC1. Figure 6 7–4 XL-DK225 PARTS GUIDE MICRO COMPONENT SYSTEM MODEL XL-DK225 XL-DK225 Micro Component System consisting of XL-DK225 (main unit) and CP-DK225 (speaker system). CONTENTS [1] INTEGRATED CIRCUITS [9] OTHER CIRCUITRY PARTS [2] TRANSISTORS [10] CABINET PARTS / CD MECHANISM PARTS [3] DIODES [11] SPEAKER BOX PARTS [4] TRANSFORMERS [12] ACCESSORIES / PACKING PARTS [5] COILS [6] CRYSTALS / VIBRATORS [13] P.W.B. ASSEMBLY (Not Replacement Item) [7] CAPACITORS [14] OTHER SERVICE PARTS [8] RESISTORS Parts marked with " ! " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. SHARP CORPORATION This document has been published to be used for after sales service only. The contents are subject to change without notice. XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [1] INTEGRATED CIRCUITS IC1 IC2 IC601 IC701 IC702 IC703 IC705 IC851 IC852 IC853 IC854 IC901 VHiTC94A70FG2 VHiLA6261//-1 VHiR2S15904-1 RH-iXA158AW00 VHiM66005AHP1 VHiPST3227N1E VHi6201P332-1 VHiAN80T53/-1 VHiKiA7805AP1 VHi6201P332-1 VHiKiA78L05-1 VHiSTK43205-1 BD AN AL AS AD AE AL AF AE AF AT CD MP3 Decorder CD Driver Audio Pro System Microcomputer, IXA158AW FL Driver Reset IC Voltage Regulator, 3.3V Multi Regulator, AN80T53 Constant Voltage Regulator, KIA7805AP Voltage Regulator, 3.3V Constant Voltage Regulator, KIA78L05 Power IC, STK432-050 AB AC AB AB AD AB AB AB AB AB AB AB AB AB AB AB AB AB AE AB AB AB AB AB AB AC AC Silicon,PNP,KTA1504 GR Silicon,PNP,KTA1271 Y Silicon,NPN,KTC3875 GR Digital,NPN,KRC104 S Silicon,PNP,KTA1544 T Digital,NPN,KRC107 S Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Digital,PNP,KRA102 S Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,PNP,KTA1504 GR Digital,NPN,KRC104 S Digital,NPN,KRC104 S Digital,NPN,KRC104 S Digital,NPN,KRC102 S Silicon,PNP,KTA1274 Y Silicon,NPN,KTC3199 GR Digital,NPN,KRC104 S Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3265 Y Silicon,NPN,KTC3203 Y AB AC AC AA AB AB AC AC AC AC AC AC AC AC AC AB AB AA AC AA AG AC AC AB AB AB AB AB AB AB AB AB AB AB AB AA AA AA AC AC AA AA AC Silicon,KDS184 Silicon,MA111 Silicon,MA111 Silicon,DHSS4148 Silicon,DS1N4004S Silicon,DS1N4004S Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DHSS4148 Silicon,MA111 Silicon,DHSS4148 Rectifier, 4B05GM Silicon,RL204F Silicon,RL204F Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DS1N4004S Silicon,DHSS4148 Silicon,DHSS4148 Silicon,DHSS4148 Silicon,MA111 Silicon,MA111 Silicon,DHSS4148 Silicon,DHSS4148 Silicon,MA111 [2] TRANSISTORS Q1 Q2 Q3 Q4 Q5 Q8 Q603 Q604 Q608 Q610 Q611 Q612 Q613 Q614 Q701 Q702 Q704 Q706 Q801 Q841 Q860 Q901 Q902 Q903 Q904 Q905 Q906 VSKTA1504GR-1 VSKTA1271Y/-1 VSKTC3875GR-1 VSKRC104S//-1 VSKTA1544T/-1 VSKRC107S//-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKRA102S//-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTA1504GR-1 VSKRC104S//-1 VSKRC104S//-1 VSKRC104S//-1 VSKRC102S//-1 VSKTA1274Y/-1 VSKTC3199GR-1 VSKRC104S//-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3265Y/-1 VSKTC3203Y/-1 [3] DIODES D1 D104 D105 D603 D604 D605 D607 D608 D609 D610 D611 D613 D615 D701 D702 D705 D706 D707 D712 D713 D802 D803 D804 D805 D806 D842 D843 D844 D845 D846 D847 D848 D849 D850 D853 D855 D856 D860 D861 D862 D863 D864 D868 VHDKDS184//-1 VHDMA111///-1 VHDMA111///-1 VHDHSS4148+-1 VHD1N4004S/-1 VHD1N4004S/-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHD1N4004S/-1 VHD1N4004S/-1 VHDHSS4148+-1 VHDMA111///-1 VHDHSS4148+-1 VHDTS4B05GM-1 VHDGDRL204F-1 VHDGDRL204F-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHDHSS4148+-1 VHDHSS4148+-1 VHDHSS4148+-1 VHDMA111///-1 VHDMA111///-1 VHDHSS4148+-1 VHDHSS4148+-1 VHDMA111///-1 1 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [3] DIODES D905 D906 D907 D911 D912 D913 D914 D918 LED701 LED708 ZD801 ZD802 ZD803 ZD805 ZD860 ZD861 VHDMA111///-1 VHDMA111///-1 VHDMA111///-1 VHDHSS4148+-1 VHDMA111///-1 VHDMA111///-1 VHDHSS4148+-1 VHDMA111///-1 VHPSLR343VC3F VHP503BC2E30Z VHEZJ6R2A++1E VHEZJ8R2A++1E VHEZJ30B+++1E VHEZJ15B+++1E VHEZJ11B+++1E VHEZJ6R8B++1E AC AC AC AA AC AC AA AC AC AG AB AB AB AB AB AB Silicon,MA111 Silicon,MA111 Silicon,MA111 Silicon,DHSS4148 Silicon,MA111 Silicon,MA111 Silicon,DHSS4148 Silicon,MA111 LED,Red,SLR343VC3F LED,Blue,504BC2E30 Zener, 6.2V Zener, 8.2V Zener, 30V Zener, 15V Zener, 11V Zener, 6.8V RTRNPA088AWZZ RTRNP0483AWZZ BD AL Power ( Main ) Power ( Sub ) RBLN-0061TAZZ RBLN-0061TAZZ VP-DH220K0000 VP-DH220K0000 VP-DH470K0000 RCILZA017AWZZ RCILZA017AWZZ VP-DH2R2K0000 AB AB AB AB AB AB AB AB Chip Ferrite Core Chip Ferrite Core 22µH,Peaking 22µH,Peaking 47µH,Peaking 0.29 µH 0.29 µH 2.2µH,Peaking AG AE AD Crystal,16.93 MHz Crystal,32.768 KHz Resonator,9.83 MHz AB AB AB AB AB AB AA AA AB AA AA AA AB AB AB AA AB AA AA AB AB AB AB AB AB AA AB AA AB AB AB AA AB AB AA AA AB AB AB AC AB AB AA AB AA AA AA AA AA AA 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 0.1 µF,16V 47pF(CH),50V 0.015 µF,50V 0.1 µF,16V 0.01 µF,50V 0.01 µF,50V 0.0047 µF,50V 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 0.01 µF,50V 0.1 µF,16V 68pF(CH),50V 0.015 µF,50V 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 0.033 µF,50V 0.033 µF,50V 0.1 µF,16V 470pF(CH),50V 0.1 µF,16V 470pF(CH),50V 0.047 µF,50V 0.047 µF,50V 0.1 µF,16V 2200pF(CH),50V 0.1 µF,16V 0.1 µF,16V 15pF(CH),50V 15pF(CH),50V 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 22 µF,16V,Electrolytic 0.1 µF,16V 0.1 µF,16V 0.01 µF,50V 0.1 µF,16V 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V [4] TRANSFORMERS ! ! PT801 PT841 [5] COILS FB1 FB2 L701 L702 L703 L901 L902 L903 [6] CRYSTALS / VIBRATORS X1 XL701 XL702 RCRSP0020AWZZ RCRSPA010AWZZ RCRM-A002AWZZ [7] CAPACITORS C1 C2 C3 C4 C5 C6 C7 C8 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C40 C41 C42 C43 C44 C45 C46 C48 C49 C50 C51 C52 C53 VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCKYCY1CB104K VCCCCY1HH470J VCKYCY1HB153K VCKYCY1CB104K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB472K VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCKYCY1HB103K VCKYCY1CB104K VCCCCY1HH680J VCKYCY1HB153K VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCKYCY1HB333K VCKYCY1HB333K VCKYCY1CB104K VCCCCY1HH471J VCKYCY1CB104K VCCCCY1HH471J VCKYCY1HB473K VCKYCY1HB473K VCKYCY1CB104K VCCCCY1HH222J VCKYCY1CB104K VCKYCY1CB104K VCCCCY1HH150J VCCCCY1HH150J VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCEAZA1CW226M VCKYCY1CB104K VCKYCY1CB104K VCKYCY1HB103K VCKYCY1CB104K VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J 2 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [7] CAPACITORS C54 C55 C56 C57 C58 C59 C60 C61 C62 C63 C64 C65 C66 C67 C69 C71 C72 C75 C76 C100 C101 C104 C105 C108 C110 C111 C112 C601 C602 C603 C605 C606 C607 C608 C611 C612 C613 C614 C617 C618 C621 C622 C623 C624 C637 C638 C640 C641 C642 C646 C647 C648 C649 C650 C652 C653 C677 C678 C683 C684 C690 C691 C693 C694 C701 C702 C703 C704 C705 C706 C707 C708 C709 C715 C716 C717 C718 C719 C720 C721 C725 C726 C727 C728 C729 C730 C731 C732 VCKYCY1CB104K VCKYCY1CB104K VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCKYCY1CB104K VCEAZA0JW108M VCKYCY1CB104K VCEAZA1AW107M VCKYCY1CB104K VCEAZA1AW227M VCEAZA1AW227M VCCCCY1HH101J VCCCCY1HH101J VCEAZA1HW106M VCEAZA1HW106M VCCCCY1HH101J VCKYCY1HB104K VCKYCY1HB104K VCKYCY1HB104K RC-EZD226AF1C VCKYCY1HB102K VCCCCY1HH101J VCKYCY1HB102K VCEAZA1CW227M VCKYCY1EF223Z VCEAZA1HW105M VCFYFA1HA683J VCFYFA1HA683J VCQYKA1HM332K VCQYKA1HM332K VCFYFA1HA124J VCFYFA1HA124J VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCKYCY1HB102K VCKYCY1HB102K VCEAZA1HW226M VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCEAZA1HW105M VCCCCY1HH101J VCCCCY1HH101J VCKYCY1HB221K VCKYCY1HB221K VCEAZA1EW476M VCKYCY1HB103K VCEAZA1HW105M VCEAZA1HW105M VCKYCY1HB391K VCKYCY1HB391K VCEAZA1HW105M VCEAZA1HW105M VCCCCY1HH150J VCCCCY1HH180J VCEAZU0JW108M VCCCCY1HH101J VCKYCY1HB103K RC-EZD475AF1H VCKYCY1HB103K VCKYCY1EF104Z RC-EZD106AF1C VCKYCY1CF105Z VCKYCY1CF105Z VCCCCY1HH151J VCKYCY1EF223Z RC-EZD476AF1C VCKYCY1HB102K VCKYCY1HB102K VCCCCY1HH271J VCEAZA1HW474M VCCCCY1HH820J VCEAZA1HW226M VCKYCY1EF104Z VCKYCY1HB103K VCCCCY1HH271J VCCCCY1HH271J AB AB AB AB AB AB AB AB AB AC AB AB AB AC AC AA AA AB AB AA AB AB AB AB AA AA AA AC AB AB AB AB AA AA AB AB AB AB AB AB AB AB AB AB AA AA AB AA AA AA AA AB AA AA AA AA AB AA AB AB AA AA AB AB AA AA AC AA AA AB AA AA AB AB AB AA AB AC AA AA AA AB AA AC AA AA AA AA 0.1 µF,16V 0.1 µF,16V 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 0.1 µF,16V 1000 µF,6.3V,Electrolytic 0.1 µF,16V 100 µF,10V,Electrolytic 0.1 µF,16V 220 µF,10V,Electrolytic 220 µF,10V,Electrolytic 100pF(CH),50V 100pF(CH),50V 10 µF,50V,Electrolytic 10 µF,50V,Electrolytic 100pF(CH),50V 0.1 µF,50V 0.1 µF,50V 0.1 µF,50V 22 µF,16V,Electrolytic 0.001 µF,50V 100pF(CH),50V 0.001 µF,50V 220 µF,16V,Electrolytic 0.022 µF,25V 1 µF,50V,Electrolytic 0.068 µF,50V,Thin Film 0.068 µF,50V,Thin Film 0.0033 µF,50V,Mylar 0.0033 µF,50V,Mylar 0.12 µF,50V,Thin Film 0.12 µF,50V,Thin Film 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 0.001 µF,50V 0.001 µF,50V 22 µF,50V,Electrolytic 0.001 µF,50V 0.001 µF,50V 0.001 µF,50V 0.001 µF,50V 1 µF,50V,Electrolytic 100pF(CH),50V 100pF(CH),50V 220 pF,50V 220 pF,50V 47 µF,25V,Electrolytic 0.01 µF,50V 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 390pF,50V 390 pF,50V 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 15pF(CH),50V 18pF(CH),50V 1000 µF,6.3V,Electrolytic 100pF(CH),50V 0.01 µF,50V 4.7 µF,50V,Electrolytic 0.01 µF,50V 0.1 µF,25V 10 µF,16V,Electrolytic 1 µF,16V 1 µF,16V 150pF(CH),50V 0.022 µF,25V 47 µF,16V,Electrolytic 0.001 µF,50V 0.001 µF,50V 270pF(CH),50V 0.47 µF,50V,Electrolytic 82pF(CH),50V 22 µF,50V,Electrolytic 0.1 µF,25V 0.01 µF,50V 270pF(CH),50V 270pF(CH),50V 3 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [7] CAPACITORS ! C733 C734 C735 C736 C737 C738 C739 C740 C742 C743 C754 C755 C756 C757 C758 C801 C802 C803 C804 C805 C806 C807 C808 C809 C817 C818 C819 C841 C842 C843 C844 C854 C855 C856 C859 C860 C861 C864 C865 C866 C868 C869 C870 C874 C875 C876 C877 C878 C879 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C921 C922 C925 C928 C929 C930 C931 C946 C960 CA3 VCCCCY1HH271J VCEAZA1HW106M VCKYCY1EF104Z RC-EZD105AF1H VCEAZA1HW105M VCKYCY1EF104Z VCKYCY1HB222K VCKYCY1HB222K VCKYCY1HB222K RC-EZD107AF1A VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCEAZA1HW106M VCEAZA1VW107M VCEAZA1HW476M VCEAZA1HW476M VCEAZA1JW227M VCEAZA2AW226M VCFYFA1HA104J VCFYFA1HA104J VCFYFA1HA224J VCFYFA1HA224J VCFYFA1HA104J VCFYFA1HA104J VCEAZA1EW108M VCEAZA0JW108M VCEAZA1EW477M VCQYKA1HM473K RC-KZ002LAWZZ VCEAZA1CW107M VCEAZA1HW106M VCEAZW1EW688M VCEAZA1EW226M VCEAZA1EW476M VCQYKA1HM223K VCEAZA1EW226M VCEAZA1EW226M VCEAZA1EW476M VCKYCY1CF105Z VCKYCY1CF105Z VCEAZA1HW106M VCFYFA1HA104J VCFYFA1HA104J VCFYFA1HA104J VCEAZA1EW476M VCKYCY1HB104K VCKYCY1HB104K VCEAZA1HW224M VCEAZA1HW224M VCKYCY1HB102K VCKYCY1HB102K VCCCCY1HH3R0C VCCCCY1HH3R0C VCKYCY1HB471K VCKYCY1HB471K VCEAZA1EW476M VCEAZA1EW476M VCKYCY1EF223Z VCKYCY1EF223Z VCEAZA1JW107M VCEAZA1JW107M VCEAZA1JW106M VCEAZA1JW106M VCEAZW1VW228M VCEAZW1VW228M VCEAZA1HW476M VCFYFA1HA104J VCFYFA1HA104J VCEAZA1HW476M VCEAZA1HW106M VCEAZA1HW104M VCEAZA1HW335M VCCCCY1HH101J AA AC AA AB AB AA AA AA AA AB AA AA AA AA AC AC AB AB AD AC AC AC AC AC AC AC AE AC AD AB AC AC AB AL AB AB AB AB AB AB AB AB AB AC AC AC AB AB AB AB AB AA AA AA AA AA AA AB AB AB AB AC AC AB AB AH AH AB AC AC AB AB AB AB AA 270pF(CH),50V 10 µF,50V,Electrolytic 0.1 µF,25V 1 µF,50V,Electrolytic 1 µF,50V,Electrolytic 0.1 µF,25V 0.0022 µF,50V 0.0022 µF,50V 0.0022 µF,50V 100 µF,10V,Electrolytic 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V 100pF(CH),50V 10 µF,50V,Electrolytic 100 µF,35V,Electrolytic 47 µF,50V,Electrolytic 47 µF,50V,Electrolytic 220 µF,63V,Electrolytic 22 µF,100V,Electrolytic 0.1 µF,50V,Thin Film 0.1 µF,50V,Thin Film 0.22 µF,50V,Thin Film 0.22 µF,50V,Thin Film 0.1 µF,50V,Thin Film 0.1 µF,50V,Thin Film 1000 µF,25V,Electrolytic 1000 µF,6.3V,Electrolytic 470 µF,25V,Electrolytic 0.1 µF,50V,Mylar 4700 pF, 250V 100 µF,16V,Electrolytic 10 µF,50V,Electrolytic 6800µF, 25V 22 µF,25V,Electrolytic 47 µF,25V,Electrolytic 0.022 µF,50V,Mylar 22 µF,25V,Electrolytic 22 µF,25V,Electrolytic 47 µF,25V,Electrolytic 1 µF,16V 1 µF,16V 10 µF,50V,Electrolytic 0.1 µF,50V,Thin Film 0.1 µF,50V,Thin Film 0.1 µF,50V,Thin Film 47 µF,25V,Electrolytic 0.1 µF,50V 0.1 µF,50V 0.22 µF,50V,Electrolytic 0.22 µF,50V,Electrolytic 0.001 µF,50V 0.001 µF,50V 3pF(CH),50V 3pF(CH),50V 470pF,50V 470pF,50V 47 µF,25V,Electrolytic 47 µF,25V,Electrolytic 0.022 µF,25V 0.022 µF,25V 100 µF,63V,Electrolytic 100 µF,63V,Electrolytic 10 µF,63V,Electrolytic 10 µF,63V,Electrolytic 2200 µF,50V,Electrolytic 2200 µF,50V,Electrolytic 47 µF,50V,Electrolytic 0.1 µF,50V,Thin Film 0.1 µF,50V,Thin Film 47 µF,50V,Electrolytic 10 µF,50V,Electrolytic 0.1 µF,50V,Electrolytic 3.3 µF,50V,Electrolytic 100pF(CH),50V AA AA AA AA AA AA AA AA AA AA AA 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green [8] RESISTORS FB704 J709 JP3 JP4 JP101 JP102 JP104 JP702 JP703 JP706 JP901 VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J 4 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [8] RESISTORS JP902 JP903 JP904 L101 R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55 R56 R92 R93 R95 R96 R107 R110 R113 R115 R116 R117 R118 R119 R120 R121 R122 R123 R128 R129 R131 R132 R133 R134 R602 R603 R606 R607 R608 R609 R614 R615 VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB562J VRS-CY1JB154J VRS-CY1JB334J VRS-CY1JB153J VRS-CY1JB473J VRS-CY1JB100J VRS-CY1JB223J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRD-ST2CD103J VRS-CY1JB123J VRD-ST2CD123J VRD-ST2CD103J VRD-ST2CD392J VRS-CY1JB221J VRS-CY1JB101J VRS-CY1JB000J VRS-CY1JB105J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD103J VRD-ST2CD221J VRD-ST2CD221J VRD-ST2CD221J VRD-ST2CD221J VRD-ST2CD221J VRD-ST2CD221J VRD-ST2CD221J VRS-CY1JB103J VRD-ST2CD101J VRD-ST2CD221J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB101J VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB562J VRS-CY1JB682J VRS-CY1JB102J VRS-CY1JB103J VRS-CY1JB682J VRD-ST2CD271J VRS-CY1JB471J VRS-CY1JB102J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB102J VRS-CY1JB473J VRD-ST2CD103J VRD-ST2CD103J VRS-CY1JB101J VRS-CY1JB274D VRS-CY1JB101J VRS-CY1JB000J VRS-CY1JB562D VRS-CY1JB274D VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB104J VRS-CY1JB104J VRS-CY1JB104D VRS-CY1JB104D VRS-CY1JB104D VRS-CY1JB104D VRS-CY1JB154D VRS-CY1JB154D VRS-CY1JB154D VRS-CY1JB154D VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD562J VRD-ST2CD562J VRS-CY1JB822J VRS-CY1JB822J VRS-CY1JB333J VRS-CY1JB333J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 5.6 kohms,1/16W 150 kohms,1/16W 330 kohms,1/16W 15 kohms,1/16W 47 kohms,1/16W 10 ohms,1/16W 22 kohms,1/16W 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 10 kohms,1/6W 12 kohms,1/16W 12 kohms,1/6W 10 kohms,1/6W 3.9 kohms,1/6W 220 ohms,1/16W 100 ohms,1/16W 0 ohms,Jumper,0.8x1.55mm,Green 1 Mohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 10 kohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 220 ohms,1/6W 10 kohms,1/16W 100 ohms,1/6W 220 ohms,1/6W 10 kohms,1/16W 10 kohms,1/16W 100 ohms,1/16W 1 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 4.7 kohms,1/16W 4.7 kohms,1/16W 5.6 kohms,1/16W 6.8 kohms,1/16W 1 kohms,1/16W 10 kohms,1/16W 6.8 kohms,1/16W 270 ohms,1/6W 470 ohms,1/16W 1 kohms,1/16W 10 kohms,1/16W 10 kohms,1/16W 1 kohms,1/16W 47 kohms,1/16W 10 kohms,1/6W 10 kohms,1/6W 100 ohms,1/16W 270 kohms,1/16W 100 ohms,1/16W 0 ohms,Jumper,0.8x1.55mm,Green 5.6 kohms,1/16W 270 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 100 kohms,1/16W 100 kohms,1/16W 100 kohms,1/16W 100 kohms,1/16W 100 kohms,1/16W 100 kohms,1/16W 150 kohms,1/16W 150 kohms,1/16W 150 kohms,1/16W 150 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 5.6 kohms,1/6W 5.6 kohms,1/6W 8.2 kohms,1/16W 8.2 kohms,1/16W 33 kohms,1/16W 33 kohms,1/16W 5 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [8] RESISTORS R616 R617 R618 R619 R620 R623 R625 R626 R627 R641 R642 R643 R644 R645 R646 R648 R649 R651 R652 R653 R654 R657 R658 R661 R662 R663 R664 R690 R691 R692 R693 R703 R704 R707 R708 R709 R711 R712 R713 R717 R718 R719 R720 R722 R725 R728 R731 R732 R733 R734 R735 R736 R737 R738 R739 R741 R746 R751 R752 R753 R754 R755 R756 R757 R758 R759 R760 R761 R762 R763 R764 R767 R770 R771 R772 R773 R774 R775 R776 R777 R778 R779 R780 R782 R783 R784 R785 R786 R787 VRS-CY1JB222J VRD-ST2CD222J VRD-ST2CD682J VRD-ST2CD682J VRS-CY1JB223J VRS-CY1JB332J VRS-CY1JB332J VRS-CY1JB474J VRS-CY1JB104J VRD-ST2CD822J VRD-ST2CD822J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRD-ST2CD222J VRD-ST2CD222J VRS-CY1JB222J VRS-CY1JB222J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB822J VRS-CY1JB822J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB153J VRS-CY1JB153J VRS-CY1JB273J VRS-CY1JB273J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB681J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB000J VRS-CY1JB102J VRS-CY1JB221J VRS-CY1JB103J VRS-CY1JB102J VRD-ST2CD101J VRD-ST2CD102J VRS-CY1JB103J VRS-CY1JB223J VRS-CY1JB102J VRS-CY1JB221J VRD-ST2CD221J VRS-CY1JB221J VRD-ST2CD221J VRD-ST2CD102J VRD-ST2CD271J VRD-ST2CD102J VRD-ST2CD272J VRS-CY1JB103J VRD-ST2CD102J VRD-ST2CD473J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB332J VRD-ST2EE181J VRS-CY1JB103J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 2.2 kohms,1/16W 2.2 kohms,1/6W 6.8 kohms,1/6W 6.8 kohms,1/6W 22 kohms,1/16W 3.3 kohms,1/16W 3.3 kohms,1/16W 470 kohms,1/16W 100 kohms,1/16W 8.2 kohms,1/6W 8.2 kohms,1/6W 10 kohms,1/16W 10 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 2.2 kohms,1/6W 2.2 kohms,1/6W 2.2 kohms,1/16W 2.2 kohms,1/16W 10 kohms,1/16W 10 kohms,1/16W 8.2 kohms,1/16W 8.2 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 15 kohms,1/16W 15 kohms,1/16W 27 kohms,1/16W 27 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 680 ohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 0 ohms,Jumper,0.8x1.55mm,Green 1 kohms,1/16W 220 ohms,1/16W 10 kohms,1/16W 1 kohms,1/16W 100 ohms,1/6W 1 kohms,1/6W 10 kohms,1/16W 22 kohms,1/16W 1 kohms,1/16W 220 ohms,1/16W 220 ohms,1/6W 220 ohms,1/16W 220 ohms,1/6W 1 kohms,1/6W 270 ohms,1/6W 1 kohms,1/6W 2.7 kohms,1/6W 10 kohms,1/16W 1 kohms,1/6W 47 kohms,1/6W 1 kohms,1/6W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 3.3 kohms,1/16W 180 ohms,1/4W 10 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 6 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [8] RESISTORS ! ! ! ! R788 R789 R790 R791 R792 R793 R794 R795 R798 R799 R801 R802 R803 R804 R805 R806 R807 R808 R841 R842 R843 R844 R853 R854 R858 R860 R863 R864 R890 R891 R892 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R927 R928 R935 R936 R937 R940 R941 R942 R943 R946 R944 R945 R947 R949 R950 R956 R957 R958 R961 R962 R965 R966 R968 R974 R977 RA5 RA14 RA15 RA16 RD01 RD02 RD03 RD04 RD05 VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRS-CY1JB103J VRD-ST2CD102J VRD-ST2CD563J VRD-ST2CD333J VRD-ST2CD123J VRD-ST2EE470J VRD-ST2EE470J VRD-ST2CD473J VRD-ST2EE101J VRD-RT2HD222J VRD-ST2CD224J VRD-ST2CD102J VRD-ST2CD473J VRD-ST2EE820J VRS-CY1JB223J VRS-CY1JB332J VRD-ST2CD221J VRS-CY1JB103J VRD-RT2HD3R3J VRD-ST2CD223J RR-HZA003AWZZ VRS-CY1JB331J VRD-ST2CD100J VRS-CY1JB563J VRS-CY1JB563J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB821J VRS-CY1JB821J VRS-CY1JB563J VRS-CY1JB563J VRS-CY1JB102J VRS-CY1JB102J VRN-VV3AAR15J VRN-VV3AAR15J VRS-CY1JB392J VRS-CY1JB392J VRN-VV3DAR22J VRN-VV3DAR22J VRN-VV3DAR22J VRN-VV3DAR22J VRG-ST2EC101J VRG-ST2EC101J VRS-CY1JB182J VRS-CY1JB182J VRD-ST2CD223J VRD-ST2EE223J VRD-ST2EE223J VRD-ST2CD563J VRD-ST2CD563J VRS-CY1JB563J VRD-ST2EE4R7J VRD-ST2EE4R7J VRD-RT2HD681J VRD-RT2HD681J VRS-CY1JB473J VRD-ST2CD152J VRD-ST2CD152J VRD-ST2CD153J VRS-CY1JB102J VRS-CY1JB683J VRD-ST2CD102J VRD-RT2HD681J VRD-RT2HD681J VRS-CY1JB333J VRS-CY1JB102J VRD-RT2HD822J VRD-RT2HD822J VRD-RT2HD681J VRS-CY1JB102J VRD-ST2CD153J VRS-CY1JB470J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB182J VRD-ST2CD222J VRD-ST2CD332J VRS-CY1JB562J VRS-CY1JB103J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AD AA AA AA AA AA AA AA AA AA AA AA AA AB AB AA AA AC AC AC AC AB AB AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 1 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 1 kohms,1/6W 10 kohms,1/16W 1 kohms,1/6W 56 kohms,1/6W 33 kohms,1/6W 12 kohms,1/6W 47 ohms,1/4W 47 ohms,1/4W 47 kohms,1/6W 100 ohms,1/4W 2.2 kohms,1/2W 220 kohms,1/6W 1 kohms,1/6W 47 kohms,1/6W 82 ohms,1/4W 22 kohms,1/16W 3.3 kohms,1/16W 220 ohms,1/6W 10 kohms,1/16W 3.3 ohms,1/2W 22 kohms,1/6W 4.7 ohms,1/2W 330 ohms,1/16W 10 ohms,1/6W 56 kohms,1/16W 56 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 820 ohms,1/16W 820 ohms,1/16W 56 kohms,1/16W 56 kohms,1/16W 1 kohms,1/16W 1 kohms,1/16W 0.15 ohms,1W 0.15 ohms,1W 3.9 kohms,1/16W 3.9 kohms,1/16W 0.22 ohms,2W 0.22 ohms,2W 0.22 ohms,2W 0.22 ohms,2W 100 ohms,1/4W,Fusible 100 ohms,1/4W,Fusible 1.8 kohms,1/16W 1.8 kohms,1/16W 22 kohms,1/6W 22 kohms,1/4W 22 kohms,1/4W 56 kohms,1/6W 56 kohms,1/6W 56 kohms,1/16W 4.7 ohms,1/4W 4.7 ohms,1/4W 680 ohms,1/2W 680 ohms,1/2W 47 kohms,1/16W 1.5 kohms,1/6W 1.5 kohms,1/6W 15 kohms,1/6W 1 kohms,1/16W 68 kohms,1/16W 1 kohms,1/6W 680 ohms,1/2W 680 ohms,1/2W 33 kohms,1/16W 1 kohms,1/16W 8.2 kohms,1/2W 8.2 kohms,1/2W 680 ohms,1/2W 1 kohms,1/16W 15 kohms,1/6W 47 ohms,1/16W 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 0 ohms,Jumper,0.8x1.55mm,Green 1.8 kohms,1/16W 2.2 kohms,1/6W 3.3 kohms,1/6W 5.6 kohms,1/16W 10 kohms,1/16W 7 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [8] RESISTORS RD06 RD07 RD08 RD09 RP745 RP746 RP747 RP748 RP749 RP750 RP752 RP753 RP755 RP757 RP758 RP761 RP762 RP763 RP767 RP768 RP770 RP771 RP772 RP773 RP774 RP776 RP777 RP778 RP779 VRS-CY1JB182J VRS-CY1JB222J VRS-CY1JB182J VRD-ST2CD222J VRS-CY1JB272J VRS-CY1JB272J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2EE1R5J VRD-ST2EE1R5J VRS-CY1JB103J VRS-CY1JB104J VRS-CY1JB224J VRD-ST2CD103J VRS-CY1JB103J VRS-CY1JB151J VRD-ST2EE331J VRD-ST2CD333J VRS-CY1JB272J VRS-CY1JB272J VRD-ST2CD272J VRD-ST2CD272J VRS-CY1JB103J VRS-CY1JB103J VRD-ST2CD103J VRD-ST2CD103J VRS-CY1JB272J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 1.8 kohms,1/16W 2.2 kohms,1/16W 1.8 kohms,1/16W 2.2 kohms,1/6W 2.7 kohms,1/16W 2.7 kohms,1/16W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1 kohms,1/6W 1.5 ohms,1/4W 1.5 ohms,1/4W 10 kohms,1/16W 100 kohms,1/16W 220 kohms,1/16W 10 kohms,1/6W 10 kohms,1/16W 150 ohms,1/16W 330 ohms,1/4W 33 kohms,1/6W 2.7 kohms,1/16W 2.7 kohms,1/16W 2.7 kohms,1/6W 2.7 kohms,1/6W 10 kohms,1/16W 10 kohms,1/16W 10 kohms,1/6W 10 kohms,1/6W 2.7 kohms,1/16W AM AH AF AG AC AM AF AC AD AB AC AC AD AC AQ AC AD AD AC AB AC AC AC AC AC AC AB AC AC AD AD AD AG AC AC AC AB AB AE AE AD AC AE AD AE AB AB AB AB AB AB AB AB AB AB Connector Ass'y,13 / 13 Pin Connector Ass'y,9 / 10 Pin Connector Ass'y,6 / 7 Pin Connector Ass'y,9 / 8 Pin with CNS702 Flat Wire, 2 Pin Connector Ass'y,10 / 11 Pin Connector Ass'y,4 / 5 Pin Socket,11 Pin Socket,16 Pin Plug,6 Pin Socket,12 Pin Socket,11 Pin Plug,9 Pin Socket,10 Pin Socket,30 Pin Socket,9 Pin Socket,17 Pin Socket,17 Pin Socket,10 Pin Plug,2 Pin Socket,12 Pin Socket,12 Pin Plug, 10 Pin Plug,6 Pin Plug,2 Pin Socket,4 Pin Plug,2 Pin Plug,8 Pin Plug,8 Pin Plug,12 Pin Plug,12 Pin Plug,12 Pin Connector Ass'y,6 Pin with CNS2B Connector Ass'y,2 Pin ( FAN WIRE ) Fuse,3.15A,125V Fuse,3.15A,125V Fuse,2A,125V Fuse,2A,125V Fuse,1.6A,125V Flat Cable,16 Pin Flat Cable,11Pin Flat Cable,9 Pin Flat Cable,21 Pin Flat Cable,10 Pin Flat Cable,12 Pin Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder Fuse Holder [9] OTHER CIRCUITRY PARTS ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! ! Bi101 Bi601 Bi701 Bi702 Bi703 Bi801 Bi902 CNB1 CNP1 CNP2 CNP3 CNP4 CNP5 CNP6 CNP101 CNP301 CNP701A CNP701B CNP702 CNP703 CNP705 CNP708 CNP801 CNP802 CNP805 CNP902 CNP971 CNPU1 CNPU2 CNPU3 CNPU4 CNPU5 CNS2A CNS971 F801 F802 F803 F804 F805 FFC1 FFC4 FFC301 FFC701 FFC702 FFC705 FH801 FH802 FH803 FH804 FH805 FH806 FH807 FH808 FH809 FH810 QCNWNA849AWPZ QCNWNA587AWPZ QCNWNA056AWPZ QCNWN2715AWPZ QCNWNA848AWPZ QCNWNA847AWPZ QCNWNA551AWPZ QCNCWZO11AWZZ QCNCWYP16AWZZ QCNCM705FAFZZ QCNCWZY12AWZZ QCNCWZX11AWZZ 92LCONE9P53254 QCNCWZY10AWZZ QCNCWA046AW30 QCNCWZX09AWZZ QCNCWZX17AWZZ QCNCWZY17AWZZ QCNCWZY10AWZZ 92LCONE2P53253 QCNCWZY12AWZZ QCNCW012EAWZZ QCNCM035KAWZZ 92LCONE6P53253 QCNCM049BAWZZ QCNCM035DAWZZ 92LCONE2P53253 92LCONE8P53254 92LCONE8P53254 QCNCWYG12AWZZ QCNCWYH12AWZZ 92LCONECP53254 QCNWNA750AWPZ QCNWNA057AWPZ QFS-D322BSJNi QFS-D322BSJNi QFS-D202BSJNi QFS-D202BSJNi QFS-D162BSJNi QCNWN2700AWPZ QCNWN2701AWPZ QCNWNA844AWPZ QCNWNA753AWPZ QCNWNA810AWPZ QCNWNA758AWPZ 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 92LFSHOLD1652T 8 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] OTHER CIRCUITRY PARTS ! ! FL701 FW901 JK690 JK691 JK701 JK953 LG2 LG3 LG4 LG5 LUG1 RL841 RL914 RX701 SO901 SW701 SW702 SW703 SW704 SW705 SW706 SW707 SW708 SW709 SW710 SW711 SW712 TP1 VR701 WIRE_B WTM901 VVKNA12MM54-1 QCNWNA277AWPZ QSOCJ0224AWZZ QSOCJ0120AWZZ QJAKM0004AWZZ QSOCJA010AWZZ QLUGPA001AWZZ QLUGPA001AWZZ QLUGPA001AWZZ QLUGPA001AWZZ QCNWNA863AWPZ RRLYDA002AWZZ RRLYD0016AWZZ VHLK2013TH2E1 QTANA0423AWZZ 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T 92LSWICHT1663T RTUNSA012AWZZ QSW-ZA001AWZZ QCNWN2593AWZZ QCNCW019EAWZZ AU AC AC AD AK AC AC AC AC AC AF AH AG AE AC AC AC AC AC AC AC AC AC AC AC AC AZ AE AB AB FL Display Flat Wire, 5 Pin Socket, VIDEO / AUX IN RCA Jack Headphone Jack Socket, Sub Woofer Pre Out Lug Terminal Lug Terminal Lug Terminal Lug Terminal Lug Wire Relay,Power Relay Remote Sensor Speaker Jack Switch,Key Type [ DISC 4 ] Switch,Key Type [ DISC 5 ] Switch,Key Type [ OPEN/CLOSE ] Switch,Key Type [ DISC 1 ] Switch,Key Type [ DISC 2 ] Switch,Key Type [ DISC 3 ] Switch,Key Type [ POWER ON/STAND-BY ] Switch,Key Type [ PLAY/REPEAT ] Switch,Key Type [ STOP ] Switch,Key Type [ VIDEO/AUX ] Switch,Key Type [ TUNER / XM ] Switch,Key Type [ CD ] Tuner Pack Volume ( Jog type ) Single Wire,White,80mm Socket, 5 Pin 9 XL-DK225 -MEMO- 10 XL-DK225 [10] CABINET PARTS / CD MECHANISM PARTS CD CHANGER MECHANISM UNIT 609X2 229 225 A 205 CD MECHANISM WITH CUSHION 206x5 609x2 304 301 302 303 B 613x2 303 613x2 602x4 609x2 208 217 PWB-C 209 608x3 608x2 613x2 608x2 C 216 PWB-D 216 613x2 608x3 219 D PWB-B1 TUNER PACK PWB-A4 207 231 616x2 613x8 607x6 PWB-A1 218 614x3 603x2 PWB-B4 224x2 222 224x2 220 FL701 E PWB-B2 602 611x2 PWB-A3 IC901 IC851 IC852 612x4 605x2 608 201 201-4 201-7 Silicon Grease 604x2 202-3 606x2 201-1 201-2 F PWB-A2 202 202-4 201-6 201-5 202-1 201-3 202-2 215x6 215x4 613x2 213 203 608 214 226 223 G 227 615x2 613 216x2 221 CAUTION : MUST VISUAL CHECK AFTER FULLY INSERTED THE FAN TO MOTOR. 613 PWB-B3 212 230 CAUTION : RING SPRING ASSY.INTO FAN POSITION. OK NG RING GAP RING GAP H ( FOR REFERENCE ONLY ) GAP IS 4.9 mm BETWEEN FAN AND FAN MOTOR BRACKET. 4.9mm 210 FAN BLADE FAN RIB 1 2 3 4 11 FAN RIB 5 FAN MOTOR BRACKET. XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] CABINET PARTS / CD MECHANISM PARTS ! ! ! 201 201-1 201-2 201-3 201-4 201-5 201-6 201-7 202 202-1 202-2 202-3 202-4 203 205 206 207 207 208 209 210 212 213 214 215 216 217 218 219 220 221 222 223 224 225 225 226 227 229 230 231 301 302 303 304 602 603 604 605 606 607 608 609 610 611 612 613 614 615 616 CCABA6896AW01 ----------------------HDECQA392AWSA HBDGB1001AWSA JKNBZA182AWSA JKNBZA183AWSA HDECQA242AWSA HDECQA241AWSA ----------------------LANGK0434AWFW NFANP0001AWZZ RMOTVA015AWZZ 92LCSPR1431C 92LCSPR1431C GCAB-A052AWSB GCOVAA137AWSA GiTARA457AWSA GITARA461AWSA GiTASA140AWSB GiTASA141AWSB JKNBKA021AWSA LBND-1011AWZZ LBSHC0005AWZZ LCHSMA071AWFW 92LFSHOLD1652T PCUSG0022AWZZ LCHSZA010AWZZ LHLDZ9024AWZZ LHLDZA047AWZZ LHLDZA122AWZZ 92LNBAND1318A PRDARA154AWFW QACCDA002AWZZ QLUGPA001AWZZ TSPC-A800AWZZ TSPC-A801AWZZ --------------------------------------------CDCMECA6663SRC LANGT0042AWFW PSHEPA091AWZZ KMECZA004AWZZ PCUSG0004AWSA PCUSGA099AWSA PCUSG0001AWSA LX-EZ0005AWF7 LX-JZ0010AFF7 LX-JZ0036AWF7 LX-JZ0037AWF7 XBBY720P04000 XEBY726P10000 XEBY730P10000 XEBY730P12000 LX-JZA019AWF7 XHBY730P06000 XHBY740P06000 XJBY730P10000 XJBY830P08000 XJSY730P10000 XJBY730P06000 AX AM AD AE AE AD AH AF AD AH AA AA AS AD AL AL AL AL AM AA AD AP AB AB AN AD AC AC AA AR AN AC AD AD BK AC AB AB AD AC AD AB AB AC AC AA AA AA AA AB AB AB AA AB AA AA Front Panel Ass'y Front Panel Panel, FL Display Badge, SHARP Button, Function, A Button, Disc No. Indicator, Volume Knob Decoration, Panel Fan Motor Ass'y Bracket, Fan Motor Rotary, Fan Motor, Air Cooling Fan (M971) Spring, Ring Spring, Ring Top Cabinet Disc Tray Cover Rear Panel [For America] Rear Panel [For Canada] Side Panel, Left Side Panel, Right Knob, VOLUME Nylon Band Bushing, AC Power Supply Cord Chassis, Main Holder, Fuse Cushion, Leg Chassis, Changer Unit Holder, FL Display Holder, LED Holder, LED Nylon Band, 80mm Heat Sink, Main AC Power Supply Cord Lug (LG2-5) Label, Specification [For America] Label, Specification [For Canada] Nut (Not Replacement Item ) Washer (Not Replacement Item ) Changer Mechanism Unit Bracket, PWB Support Sheet, PC CD Mechanism Unit Cushion Cushion Cushion Screw, Special Screw, M3 X10mm Screw, Special Screw, Special Screw, M2 X4mm Screw, M2.6 X10mm Screw, M3 X10mm Screw, M3 X12mm Screw, Special Screw, M3 X6mm Screw, M4 X6mm Screw, M3 X10mm Screw, M3 X8mm Screw, M3 X10mm Screw, M3 X6mm NOTE: FOR CD MECHANISM PARTS, ITEM NO. ARE 3XX 12 XL-DK225 [11] SPEAKER BOX PARTS A B C D E F G H 1 2 3 4 13 5 6 XL-DK225 NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [11] SPEAKER BOX PARTS 901 902 903 904 905 906 907 908 909 910 911 912 913 SP1,2 SP3,4 GBOXSA166AW01 CWAKPA010AW05 GITASA172AWSC LHLDZ8002AWSB PCUSGA020AWZZ TSPC-A778AWZZ HDECQA355AWSC HDECQA354AWSC XEBY730P14000 XEMY835P14000 XMBY840P20000 PCUSSA057AWZZ PCUSSA058AWZZ RSP-ZA257AWZZ RSP-ZA256AWZZ BP AS BC AF AB AC AH AK AB AC AC Wooden Box Ass'y Net Frame Ass'y Front Board Catching Holder Cushion, Leg Label, Specification Tweeter Ring Woofer Ring Screw, M3 x 14mm Screw, M3.5 x 14mm Screw, M4 x 20mm Cushion, Top/Bottom Cushion, Side Woofer Tweeter AZ AT [12] ACCESSORIES / PACKING PARTS 92LFANT1535A QANTL0010AWZZ RRMCGA133AWSA TINSEA191AWZZ TINSZA282AWZZ TINSKA029AWZZ UACRTA008AW01 AF AP AR AF AD FM Antenna AM Loop Antenna Remote Control Operation Manual [For America] Quick Guide [For America] Operation Manual [For Canada] Adaptor Accessories AP [13] P.W.B. ASSEMBLY ( Not Replacement Item ) ! PWB-A PWB-B PWB-C PWB-D 92LPWB6895MANS 92LPWB6894DPLS 92LPWB6894PODS 92LPWB6894CDUS - Main A1 / Power A2 / Speaker A3 / Transit iPod A4 Display B1 / Headphone B2 / Reflash B3 / Volume LED B4 iPod CD MP3 [14] OTHER SERVICE PARTS UDSKA0004AFZZ AZ CD Optical Pickup Lens Cleaner Disc 14 XL-DK225 [12] ACCESSORIES / PACKING PARTS PACKING METHOD (FOR U.S.A. ONLY) UNIT Front Speaker(L/R) Polyethylene Bag,Unit SSAKH0094AWZZ Polyethylene Bag,Speaker SSAKHA087AWZZ Packing,Add., Front Speaker,Top/Bottom SPAKAA160AWZZ Packing Add.,Unit,Top/Bottom SPAKAA166AWZZ Label,POP TLABZA556AWZZ Bottom Label,POP TLABZA538AWZZ A B Adaptor Accessories AM Loop Antenna FM Antenna Remote Control Polyethylene Bag,Accessories SSAKAA011AWZZ Operation Manual Quick Guide B FRO NT A Packing Case SPAKCA470AWZZ Front of Packing Case : Not Replacement Item 15 XL-DK225 XL-DK225 COPYRIGHT 2007 BY SHARP CORPORATION ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher. SHARP CORPORATION Sharp-Roxy Corporation Sungai Petani, Kedah, Malaysia Printed in Malaysia A0702-1MX•RR•M SC