Download Samsung SGH-F490 service manual
Transcript
GSM TELEPHONE SGH-F490 GSM TELEPHONE CONTENTS 1. Safety Precautions 2. Specification 3. Product Function 4. Array course control 5. Exploded View and Parts List 6. Main Electrical Parts List 7. Block Diagrams 8. PCB Diagrams 9. Flow Chart of Troubleshooting 10. Reference data 11. Disassembly and Assembly Instructions GSPN (Global Service Partner Network) Country North America Latin America CIS Europe China Asia Mideast & Africa Web Site service.samsungportal.com latin.samsungportal.com cis.samsungportal.com europe.samsungportal.com china.samsungportal.com asia.samsungportal.com mea.samsungportal.com This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law. ⓒ Samsung Electronics Co.,Ltd. 2008. 01 Rev.1.0 1. Safety Precautions 1-1. Repair Precaution ● Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because specificity of cellular phone is sensitive for surrounding interference(RF noise). ● Be careful to use a kind of magnetic object or tool, because performance of parts is damaged by the influence of magnetic force. ● Surely use a standard screwdriver when you disassemble this product, otherwise screw will be worn away. ● Use a thicken twisted wire when you measure level. A thicken twisted wire has low resistance, therefore error of measurement is few. ● Repair after separate Test Pack and Set because for short danger (for example an overcurrent and furious flames of parts etc) when you repair board in condition of connecting Test Pack and tuning on. ● Take specially care of soldering, because Land of PCB is small and weak in heat. ● Surely tune on/off while using AC power plug, because a repair of battery charger is dangerous when tuning ON/OFF PBA and Connector after disassembling charger. ● Don't use as you pleases after change other material than replacement registered on SEC System. Otherwise engineer in charge isn't charged with problem that you don't keep this rules. 1-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Safety Precautions 1-2. ESD(Electrostatically Sensitive Devices) Precaution Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD (Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below. You can prevent from ESD damage by static electricity. ● Remove static electricity remained your body before you touch semiconductor or parts with semiconductor. There are ways that you touch an earthed place or wear static electricity prevention string on wrist. ● Use earthed soldering steel when you connect or disconnect ESD. ● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by static electricity. ● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and aluminum plate to have conductive power,they are prevented from static electricity. ● You must maintain electric contact between ESD and place due to be set up until ESD is connected completely to the proper place or a circuit board. 1-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 2. Specification 2-1. GSM General Specification EG SM 9 00 DCS 1800 PCS 1900 WCDMA2100 Fr eq. Band[MHz] Uplin k/Down link 8 80~915 9 25~960 17 10~178 5 18 05~188 0 18 50~191 0 19 30~199 0 192 0~1980 211 0~2170 ARF CN ra nge 0~124 & 97 5~1023 5 12~885 5 12~810 UL:96 12~988 8 DL:105 62~108 38 T x/Rx spacing 45MHz 95MHz 80MHz 1 90MHz Mo d. Bit r ate/ Bit Period 270 .833kb ps 3 .692u s 270 .833kb ps 3 .692u s 270 .833kb ps 3 .692u s 3.8 4Mcps Ti me Slo t Pe rio d/Fr am e Per iod 5 76.9u s 4. 615ms 5 76.9u s 4. 615ms 5 76.9u s 4. 615ms Fr ame len gth : 10ms Slot length : 0.6 67ms Modula tion 0 .3G M SK 0 .3G MSK 0 .3G M SK Q PS K HQPSK MS Power 33d Bm~5dBm 30d Bm~0dBm 30d Bm~0dBm 24 dBm~ - 50dBm Powe r Class 4 (max +33dBm) 1 (max +30dBm) 1 (max +30dBm) 3 (max +24dBm) Se nsitivity -10 2dBm -10 0dBm -10 0dBm -1 06.7d Bm TDMA Mu x 8 8 8 NA Cell Radiu s 35Km 2Km 2Km 2Km 2-1 Speclflcation 2-2. GSM Tx Power Class TX Power control level GSM900 TX Power control level DCS1800 TX Power control level PCS1800 5 33±2 dBm 0 30±3 dBm 0 30±3 dBm 6 31±2 dBm 1 28±3 dBm 1 28±3 dBm 7 29±2 dBm 2 26±3 dBm 2 26±3 dBm 8 27±2 dBm 3 24±3 dBm 3 24±3 dBm 9 25±2 dBm 4 22±3 dBm 4 22±3 dBm 10 23±2 dBm 5 20±3 dBm 5 20±3 dBm 11 21±2 dBm 6 18±3 dBm 6 18±3 dBm 12 19±2 dBm 7 16±3 dBm 7 16±3 dBm 13 17±2 dBm 8 14±3 dBm 8 14±3 dBm 14 15±2 dBm 9 12±4 dBm 9 12±4 dBm 15 13±2 dBm 10 10±4 dBm 10 10±4 dBm 16 11±3 dBm 11 8±4dBm 11 8±4dBm 17 9±3dBm 12 6±4 dBm 12 6±4 dBm 18 7±3 dBm 13 4±4 dBm 13 4±4 dBm 19 5±3 dBm 14 2±5 dBm 14 2±5 dBm 15 0±5 dBm 15 0±5 dBm 2-2 3. Product Function Main Function ▪ Full Touch Screen ▪ Bluetooth Class 2 ▪ Extended GSM 900MHz & DCS1800MHz & PCS1900MHz &WCDMA/HSDPA2100MHz Quad Band ▪ Bar type ▪ Color LCD (262K TFT colors, 3.2", 240 x 432) ▪ Built-in 5Mega pixel and QCIF Camera ▪ Built-in MP3 Player ▪ GPRS Multi-slot Class 12 ▪ Downloadable Game via JAVA ▪ 64 Polyphonic Ring Tone ▪ Sending Photo & Video by MMS or E-Mail ▪ VideoTelephony ▪ External Memory Card Socket (T-flash) ▪ 1000mAh Battery 3-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Product Function 3-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 4. Array course control 4-1. Software Adjustments 1. JIG(GH80-03308A): Download, Trace, Calibration, etc 2. 0.4M Test cable(GH39-00886A): JIG to phone 3. 1.5M Test cable(GH39-00889A): JIG to phone 4-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4.Travel Adaptor(GH44-01702A) 5.Data Link Cable(GH39-00922A): USB cable 6.Serial cable(LJ39-00013A) : PC to JIG 4-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 7. RF test cable(GH39-00397A): RF test 4-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2. Software Downloading 4-2-1. Downloading Binary Files •Four binary files for downloading F490 –amss_compressed : Modem binary for communication function and user interface and various application –Rsrc_F490_Open_Europe_Common.rc1: Files need for each application –Rsrc2_F490(Low).rc2 : Power on/off animation –FactoryFs_F490_Open_Europe_Common.ffs : Default file system to be put into in initial production 4-2-2. Pre-requsite for Downloading •Downloader Program (MultiLoader V5.30) •SGH-F490 Mobile Phone •USB Data Link Cable •Binary files 4-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-3. S/W Downloader Program 1. Boot the F490 by pressing 'power ON' + 'Camera hot key' + 'Volume Up Key' at the same time. If you do properly, you can see the following message on Main LCD "Download" 2. Load the binary download program by executing the "MultiLoader V5.30.exe". And the Check the MSM6245/MSM6260 4-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 3. Select the check box what you want to download. 4-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4. Select the binary file what you want to download * Up to eight ports are supported. 4-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 5. Now press the button 'DownLoad'. 6. When downloading is complete, UE reboot automatically. -If there is difference in FactoryFS.bin, UE will format file system automatically. 4-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 5. Exploded View and Parts List 5-1. Cellular phone Exploded View QME03 QFR01 QLC01 QMI01 QPC01 QLB01 QCA01 QMO01 QMP01 QSP01 QCA02 QVK02 QCB01 QVK01 QME32 QAN02 QSH01 QCR04 QCR03 QRF03 QCK02 QCK01 QRE01 QIF01 QVO01 QCR04 QDC01 QCR04 QRF01 QBA01 QBA00 QBA02 QST08 5-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 5-2. Cellular phone Parts List Design LOC QAN02 QBA00 QBA01 QBA02 QCA01 QCA02 QCB01 QCK01 QCK02 QCR03 QCR04 QCR04 QCR04 QFR01 QLB01 QLC01 QME03 QME32 QMI01 QMO01 QMP01 QPC01 QRF01 QSH01 QSP01 QST08 QVK01 QVK02 QVO01 QRE01 QDC01 QIF01 QRF03 Description SEC CODE INTENNA-SGH F490 PMO CASE-BATT INNER BATTERY PACK-1000MAH,BLK PMO CASE-BATT V2 CAMERA MODULE-SGH F490 KEY FPCB-CAM KEY FPCB ASS'Y COAXIAL CABLE-SGHE490 ANT CABL PMO KEY-CAMERA PMO KEY-HOLD SCREW-MACHINE SCREW-MACHINE SCREW-MACHINE SCREW-MACHINE ASSY CASE-FRONT ASSY BRACKET-LCD LCD-SGH F490MODULE UNIT-TOUCH PANEL UNIT-FLASH FPCB MICROPHONE-ASSY-SGH F490 MOTOR LINEAR VIBRATION-SCH F49 PBA MAIN-SGH F490 FPC-SLIDE FPCB TAPE-SHEET RF ICT SHIELD-COVER SPEAKER ASSY ACCE-STYLUS PEN KEY FPCB-VOLUME KEY ASSY ETC-SGH-F490 EARJACK FPCB PMO KEY-VOLUME ASSY CASE-REAR ASSY DECO-CAMERA PMO COVER-IF PMO COVER-EAR GH42-01406A GH72-44834A GH43-02974A GH72-46238A GH59-05166A GH59-05137A GH39-00674A GH72-46638A GH72-46639A 6001-001811 6001-001479 6001-001479 6001-001479 GH98-06647A GH98-06649A GH07-01250A GH59-05361A GH59-05136A GH30-00449A GH31-00401A GH92-04207A GH41-01945A GH74-36524A GH70-03077A 3001-002281 GH98-02835H GH59-05121A GH59-05163A GH72-46637A GH98-06648A GH98-06650A GH72-46635A GH72-46636A 5-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List Description SEC CODE IC-MEMORY CARD CBF INTERFACE-DLC APCBS10BBE(S CBF INTERFACE-MIC CABLE(S20P,T ADAPTOR-ATADS10EBE,BLK,EU S/W CD-SGHF490PC STUDIO CD UNIT-EARPHONE(BLK) LABEL(P)-UNIT SEAL LABEL(R)-WATER SOAK LABEL(P)-OPEN MP3 MANUAL USERS-EU FRENCH LABEL(R)-MAIN(FRAN) BOX-UNIT(EU) BOX-SLIP CASE(EU_NEW) RMO RUBBER-LED BLOCK VINYL-BOHO TSP TAPE INSU-IF CONN VINYL-BOHO MAIN SPONGE-MEGA CAM ASSY PACKING-HAAXEF(BEA/FRAN) ASSY ACCE-PHONE POUCH CBF SIGNAL-SPHA560 RF CABLE CBF INTERFACE-SGH-L760 TEST CA CBF INTERFACE-SGH-L760 TEST CA INSTALL-TEST JIG BOX 1109-001363 GH39-00922A GH39-00948F GH44-01702A GH46-00598A GH59-02261A GH68-00518B GH68-09361A GH68-11246A GH68-17275A GH68-17280B GH69-06359A GH69-06454A GH73-11374A GH74-36523A GH74-37028A GH74-37232A GH74-37442A GH95-01298A GH98-07723A GH39-00397A GH39-00886A GH39-00889A GH80-03308A 5-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 5-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 6. MAIN Electrical Parts List SEC Code Design LOC Description STATUS 0403-001547 0404-001172 0406-001215 0406-001215 0406-001237 0406-001237 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001254 0406-001275 0407-001002 0504-001113 0801-003016 1001-001336 1001-001405 1001-001428 1001-001428 1001-001428 1001-001428 1001-001436 1001-001481 1003-002047 1108-000151 1201-002190 1201-002531 1201-002570 1201-002610 1202-001068 1203-003523 1203-003523 1203-003737 1203-003815 1203-004339 1203-004340 1203-004340 1203-004453 D700 D703 D701 D702 D600 D601 D704 D705 D707 D708 D709 ZD500 ZD501 ZD502 ZD503 ZD504 ZD700 ZD701 ZD702 ZD703 ZD704 ZD705 ZD401 D400 TR400 U601 U704 U301 U504 U505 U506 U702 U510 U302 U703 UME300 U501 PAM101 PAM100 U500 U502 U406 U408 U409 U701 U403 U402 U404 U407 DIODE-ZENER DIODE-SCHOTTKY DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-ARRAY TR-DIGITAL IC-CMOS LOGIC IC-ANALOG SWITCH IC-ANALOG MULTIPLEX IC-ANALOG MULTIPLEX IC-ANALOG MULTIPLEX IC-ANALOG MULTIPLEX IC-ANALOG MULTIPLEX IC-ANALOG SWITCH IC-ANALOG SWITCH IC-MOTOR DRIVER IC-MCP IC-AUDIO AMP IC-POWER AMP IC-POWER AMP IC-AUDIO AMP IC-VOLTAGE COMP. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-MULTI REG. IC-MULTI REG. IC-MULTI REG. IC-DC/DC CONVERTER SA SA SA SA SNA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 1203-004548 1203-004727 1203-004728 1203-004728 1203-004776 1203-004776 1203-004778 1203-004819 1203-004838 1205-002784 1205-003228 1205-003281 1205-003288 1205-003297 1404-001224 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000138 2007-000140 2007-000140 2007-000140 2007-000140 2007-000140 2007-000140 2007-000140 2007-000143 2007-000143 2007-000143 2007-000144 2007-000148 2007-000157 2007-000160 2007-000160 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 2007-000162 U602 U405 U508 U509 U600 U603 U401 U604 U400 U410 U503 UCP300 U700 U201 VR300 R108 R322 R328 R515 R516 R517 R535 R707 R726 R314 R502 R504 R520 R521 R529 R530 R318 R509 R510 R415 R413 R416 R505 R508 R330 R430 R431 R432 R531 R619 R631 R632 R704 R716 IC-DC/DC CONVERTER IC-DC/DC CONVERTER IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-POWER SUPERVISOR IC-POSI.FIXED REG. IC-BATTERY IC-SWITCH IC-CODEC IC-MODEM IC-LCD CONTROLLER IC-TRANSCEIVER THERMISTOR-NTC R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-000165 2007-000169 2007-000169 2007-000170 2007-000170 2007-000170 2007-000170 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000171 2007-000173 2007-000173 2007-001156 2007-001156 2007-001285 R513 R503 R506 R300 R507 R512 R621 L205 L405 R200 R201 R203 R207 R304 R305 R307 R317 R324 R400 R414 R420 R421 R422 R433 R434 R435 R500 R501 R511 R514 R601 R602 R611 R612 R613 R614 R616 R617 R625 R627 R628 R711 R712 R729 R610 R615 R404 R623 R205 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-001285 2007-001290 2007-001319 2007-001319 2007-001319 2007-001319 2007-001319 2007-001319 2007-001319 2007-001339 2007-001339 2007-002970 2007-002970 2007-002970 2007-002970 2007-003010 2007-003010 2007-007009 2007-007009 2007-007014 2007-007014 2007-007014 2007-007014 2007-007014 2007-007014 2007-007092 2007-007092 2007-007135 2007-007306 2007-007306 2007-007314 2007-007316 2007-007317 2007-007334 2007-007334 2007-007468 2007-007741 2007-007741 2007-007741 2007-007766 2007-008046 2007-008046 2007-008052 2007-008055 2007-008055 2007-008055 2007-008419 2007-008483 2007-008483 R206 R327 R522 R523 R527 R528 R607 R701 R702 R334 R603 R533 R534 R536 R537 R539 R540 R110 R622 R308 R309 R310 R311 R312 R408 R608 R609 R313 R111 R112 R321 R403 R402 R418 R725 R406 R103 R424 R426 R329 R105 R106 R425 R427 R705 R717 R204 R718 R719 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2007-008483 2007-008483 2007-008483 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-008579 2007-008579 2007-008588 2007-008588 2007-008588 2007-008588 2007-008588 2007-008806 2007-008806 2007-008806 2007-008806 2007-009111 2007-009157 2007-009170 2007-009170 2007-009170 2007-009170 2007-009171 2007-009420 2007-009801 2007-009810 2007-009866 2007-009866 2203-000233 2203-000233 R720 R721 R722 R315 R316 R320 R524 R723 R306 R331 R332 R405 R411 R412 R437 R538 R618 R629 R634 R637 R732 R733 R734 R735 R101 R102 R107 R302 R303 R706 R710 R104 R109 R325 R410 R100 R626 R333 R519 R605 R727 R409 R202 R604 R620 R401 R525 C211 C248 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-000233 2203-000233 2203-000233 2203-000233 2203-000233 2203-000254 2203-000254 2203-000254 2203-000254 2203-000254 2203-000254 2203-000254 2203-000278 2203-000278 2203-000278 2203-000278 2203-000278 2203-000330 2203-000330 2203-000386 2203-000438 2203-000438 2203-000438 2203-000438 2203-000489 2203-000725 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000854 C258 C343 C426 C429 C431 C124 C300 C301 C302 C308 C312 C323 C254 C334 C339 C622 C623 C416 C436 C548 C202 C232 C526 C527 C346 C738 C116 C117 C125 C126 C127 C137 C342 C411 C427 C461 C511 C520 C618 C701 C702 C703 C704 C723 C727 C729 C733 C734 C333 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-000854 2203-000854 2203-000854 2203-000854 2203-000854 2203-000995 2203-000995 2203-001033 2203-001153 2203-002487 2203-002487 2203-002677 2203-003054 2203-003054 2203-003054 2203-005052 2203-005057 2203-005057 2203-005234 2203-005234 2203-005281 2203-005450 2203-005450 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005571 2203-005571 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 C337 C538 C539 C541 C555 C106 C345 C711 C118 C509 C515 C128 C501 C502 C547 L112 L108 L110 C122 L100 C204 L105 L107 C105 C119 C207 C208 C215 C344 C347 C405 C504 C506 C524 C525 C537 C540 C543 C550 C553 C558 C428 C430 C107 C110 C111 C115 C136 C221 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005719 2203-005719 2203-005719 2203-005719 2203-005719 2203-005719 2203-005719 2203-005719 2203-005719 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005729 2203-005732 C238 C316 C330 C707 C708 C709 C710 C712 C739 C740 C741 C742 C744 C745 C747 C749 C750 C338 C340 C518 C529 C542 C556 C614 C615 C743 C108 C112 C132 C133 C212 C218 C222 C226 C233 C236 C237 C240 C241 C242 C244 C245 C256 C259 C260 C263 C265 C549 C200 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-005732 2203-005734 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005806 2203-005806 2203-005806 2203-005806 2203-006047 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006048 2203-006091 2203-006091 2203-006121 2203-006137 C201 C114 C131 C209 C210 C216 C223 C235 C246 C255 C257 C266 C435 C440 C123 C130 C228 C320 C349 C303 C304 C309 C313 C314 C321 C322 C341 C404 C407 C408 C409 C410 C604 C605 C606 C617 C630 C718 C720 C722 C724 C726 C728 C735 R731 C512 C514 C620 C544 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SNA SNA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006137 2203-006194 2203-006194 2203-006194 2203-006194 2203-006208 2203-006208 2203-006257 2203-006257 2203-006257 2203-006257 2203-006260 2203-006305 2203-006324 2203-006324 2203-006324 2203-006348 2203-006348 2203-006348 2203-006399 2203-006399 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 C551 C129 C135 C319 C331 C453 C627 C517 C519 C530 C532 C621 C521 C438 C454 C628 C412 C414 C437 C418 C434 C134 C205 C206 C217 C219 C220 C229 C230 C231 C239 C243 C247 C250 C252 C253 C261 C264 C328 C329 C332 C415 C447 C600 C601 C602 C603 C607 C608 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006466 2203-006466 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 C609 C610 C611 C612 C613 C616 C624 C635 C716 C748 C507 C510 C214 C305 C310 C311 C325 C326 C413 C441 C442 C443 C444 C445 C446 C448 C449 C450 C451 C452 C455 C456 C457 C458 C500 C508 C516 C533 C534 C535 C552 C554 C557 C559 C560 C625 C626 C629 C631 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006681 2203-006681 2203-006681 2203-006681 2203-006681 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006824 2203-006825 2203-006825 2203-006825 2203-006825 2203-006825 2203-006838 2203-006838 2203-006838 2203-006838 2203-006839 2203-006839 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 C632 C633 C637 C638 C705 C706 C713 C714 C715 C737 C746 C317 C318 C327 C348 C350 C249 C251 C307 C400 C401 C403 C417 C420 C422 C423 C224 C315 C545 C546 C634 C324 C503 C505 C636 C528 C531 C439 C513 C717 C719 C721 C725 C751 C225 C234 C306 C419 C421 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 2203-006885 2203-006979 2203-006979 2404-001268 2404-001268 2404-001339 2404-001339 2404-001339 2404-001381 2404-001381 2404-001381 2404-001381 2404-001381 2404-001381 2404-001411 2404-001506 2703-001231 2703-001737 2703-001747 2703-001751 2703-002176 2703-002176 2703-002199 2703-002199 2703-002199 2703-002200 2703-002201 2703-002201 2703-002203 2703-002203 2703-002208 2703-002208 2703-002281 2703-002313 2703-002314 2703-002314 2703-002368 2703-002597 2703-002619 2703-002917 2703-003258 2703-003258 2703-003258 C424 C425 C432 C433 C536 C730 C619 C227 C262 TA400 TA401 C402 C406 TA700 TA101 TA402 TA403 TA500 TA600 TA601 TA701 TA100 L603 L202 L109 C203 C100 C101 C102 L508 L509 C103 C109 C113 L101 L104 L111 L207 L106 L200 L102 L103 L116 L206 L403 L204 L400 L401 L402 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS 2703-003260 2703-003260 2801-004339 2801-004573 2809-001280 2901-001353 2901-001422 2901-001422 2901-001422 2901-001453 2901-001453 2904-001601 2904-001604 2904-001628 2904-001702 2904-001789 2910-000024 3301-001208 3301-001208 3301-001438 3301-001438 3301-001438 3301-001438 3301-001729 3301-001729 3301-001729 3301-001729 3301-001756 3301-001756 3301-001778 3301-001778 3408-001117 3705-001358 3705-001448 3708-002015 3709-001465 3710-002467 3710-002523 3711-005728 3711-006028 3711-006256 4202-001395 4302-001180 4709-001399 4709-001546 GH13-00061A GH70-02640A GH70-02640A GH70-02640A L404 L604 OSC400 OSC600 TCX100 F701 F703 F704 F705 F700 F702 F102 F101 F100 F200 F103 DUF100 L501 L503 L500 L502 L504 L602 L505 L506 L507 R428 L510 L511 L600 L601 HOLDSW700 RFS100 RFS101 SLC700 SIM700 MOT700 IFC600 HEA700 HDC700 BTC700 ANT200 BAT400 CPL100 U200 UCP600 SC200 SC201 SC202 INDUCTOR-SMD INDUCTOR-SMD CRYSTAL-SMD CRYSTAL-SMD OSCILLATOR-VCTCXO FILTER-EMI/ESD FILTER-EMI SMD FILTER-EMI SMD FILTER-EMI SMD FILTER-EMI SMD FILTER-EMI SMD FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW FILTER-SAW DUPLEXER-SAW BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD CORE-FERRITE BEAD CORE-FERRITE BEAD SWITCH-SLIDE CONNECTOR-COAXIAL CONNECTOR-COAXIAL CONNECTOR-FPC/FFC/PIC CONNECTOR-CARD EDGE SOCKET-BOARD TO BOARD SOCKET-INTERFACE HEADER-BOARD TO BOARD HEADER-BOARD TO BOARD HEADER-BATTERY ANTENNA-CHIP BATTERY-LI(2ND) COUPLER-DIRECTION BLUETOOTH MODULE IC ASIC-SGHF490 ICT SHIELD-CAN CLIP ICT SHIELD-CAN CLIP ICT SHIELD-CAN CLIP SA SA SA SA SA SA SA SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC Code Design LOC Description STATUS GH70-02640A GH70-02640A GH70-02640A SC203 SC204 SC205 ICT SHIELD-CAN CLIP ICT SHIELD-CAN CLIP ICT SHIELD-CAN CLIP SA SA SA Please consult the GSPN website (Samsung Portal) for the most recent version of the product's part list. 6-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List 6-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 7. Block Diagrams 7-1. Functional Block Diagram RX_Q_P RX_Q_M RX_I_P RX_I_M EGSM RX SAW VRAMP DCS ANT_SEL0 TX Mo d ule ( SKY77519) ANT_SEL1 RX SAW PCS TRANSCIVER ( RTR6285) RX SAW DCS / PCS GSM TCXO WCDMA BAND 1 19. 2MHz COUPLER WCDMA PAM ( AWT6279RM20P8) DUPLEXER PWR_DETECT RX SAW TX SAW 7-1 TX_Q_P TX_Q_M TX_I_P TX_I_M Block Diagrams 7-2. Baseband Block Diagram VBATT_CTRL_4.2V LDO LDO TOUCH_2.8V LCD _2.6V TOUCH_OUT T O U CH _ I 2 C Touch Screen 3.2" WQVGA LCD S 20 Connector L CD _ R S T ( 240*432, 16bit CPU type ) R ES ET _N AM UX _OUT LCD_D(0:17) LCD Serializer EA RMIC S 20_EA R EAR _S W S SBI USB_DP/DM LCD DE-serializer SLEEP_XTAL_IN 32.768KH z LCD_D(0:15) M ic r o U S B EBI2 TCXO_EN TCXO_OUT M/M Chip ( MV8722 ) 24MHz X-Tal To USB SWITCH USB _DP/DN LDO LDO C AM_D(0:7) CLK, SYNC M CA M _ 1 . 8 V IO/A_2.8V AF _3.3V ISP_2.8V LDO V CA M _ 1 . 8 V IO/A_2.8V Boost Converter LDO MOT_3.3V To S20/Micro USB CAM_I2C VGA CAM F rom M V8722 US B_DP/DN USB _OE/D AT/SEO Switch U SB_DP/DM USB SWITCH CA M_I2C CAM_D(0:7) CLK, SYNC VBATT_4.2V BOOT_SW VC OIN MODEM (MSM6260) 5M AF CAM I2C PS_HOLD PS_H O LD 19.2M T CX O T-Flash SD_D(0:3) PM6658 SIM _IO USIM_C LK/R ST USIM_IO USIM Flash LED FLASH_EN Haptic Driver LRA MOTOR MOTOR _PWM I2S Switch S20 EAR L/R 3.5 EAR L/R R C V_L/ R Amp CODEC_OUT (L) Amp CODEC_OUT(R) Switch EA R L / R CODEC_I2C CODEC C O DE C_ RS T CHG_EN_N Charging IC HPH_L/R A1(0:12) Toshiba Memory S 2 0 3. 5_SEL RADIO_OUT_R /L BT MODULE BT_U ART BT_PCM 7-2 EB I1 SDRAM (1G) EBI2 NAND Flash (2G) 8. PCB Diagrams 1. Main top 8-1 PCB Diagrams 2. Main bottom 8-2 9. Flow Chart of Troubleshooting 9-1. Power On ' Power On ' does not work Yes No Check the Battery Voltage Change the Battery is more than 3.4V Yes No U401 pin F10(PS_HOLD) = 2.6V? Check the U401 related to PS_HOLD Yes No Check the Clock at OSC400=32.768KHz Resolder OSC400 Yes No Check the U401 L400(VREG_MSMC)=1.2V? Yes No C424(VREG_MSME)=1.8V? C423(VREG_MSMP)=2.6V? C422(VREG_MSMA)=2.6V? C418(VREG_TCXO)=2.8V? Check the U401 Yes No Check for the clock at C435 Check the clock generation circuit (related to TCX100) = 19.2MHz Yes Check the initial operation Yes END 9-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting D4 OPT_1 H8 OPT_2 CLK19.2M_TCXO CLK19.2M_PM C435 R410 TP_RF_TCXO USB_DAT USB_DM_MODEM USB_DP_MODEM G4 J1 J2 H2 F4 F2 H4 H1 R411 R412 USB_OE_N USB_SEO USB_VBUS_5V USB_DAT USB_D_M USB_D_P USB_ID USB_OE_N USB_OVP_G USB_SE0 USB_VBUS E5 E6 E7 F5 F6 F7 G5 G6 G7 R416 C438 TCXO_EN_1 TCXO_EN_2 TCXO_IN TCXO_OUT_1 TCXO_OUT_2 TCXO_OUT_RF VBATT_4.2V VREG_MSMP_2.6V C416 OSC400 L11 XTAL_IN K11 XTAL_OUT F8 SBCK G8 SBDT|SSBI E8 SBST VCOIN BAT_FET_N CHG_CTL_N VCHG HSET_BIAS KPD_PWR_N MSM_INT_N PON_RESET_N PS_HOLD SLEEP_CLK J10 E2 C2 C1 K1 L4 C10 G10 F10 K9 R408 R409 C436 SSBI2_DATA TP401 TP402 TP403 D400 PM_INT ON_SW PM_INT_N RESET_N 2 3 SLEEP_XTAL_IN GND GND GND GND GND GND GND GND GND DNC NC NC D8 E4 E11 H10 B10 F11 TCXO_EN U401 D1 R437 ISNS_M D2 ISNS_P 1 B5 SPKR_IN_M B6 SPKR_IN_P A5 SPKR_OUT_M A6 SPKR_OUT_P 2 R406 A1 VREG_TCXO G2 VREG_USB B11 VREG_WLAN C415 C11 REF_BYP E10 REF_GND D10 REF_ISET D11 1 2 TP400 R405 R418 9-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 1 PS_HOLD BOOT_SW Flow Chart of Troubleshooting VREG_MSMP_2.6V VREG_USIM_3.0V VREG_TCXO_2.85V VREG_S2_2.1V VREG_MSMA_2.6V VREG_MSME_1.8V VREG_S3_2.7V VREG_BT_2.85V R400 VREG_MSMC_1.2V C422 C423 C424 C425 C434 C430 C431 C418 C417 C426 C427 C428 C429 9-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C432 C433 Flow Chart of Troubleshooting R108 C123 TRK_LO_ADJ CLK19.2M_RTR C124 2 1 VREG_TCXO_2.85V VCON GND TCX100 VCC OUT 4 3 C129 CLK19.2M_TCXO C136 TA 1 0 0 C1 1 1 C114 R107 R104 R1 0 5 F1 0 0 F1 0 1 R106 C4 1 5 R4 0 6 R10 0 9-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C1 0 6 C1 0 5 C422 C1 1 0 C1 1 5 R1 0 3 TP4 0 3TP_AMUX_ OUT TCX100 C1 2 4 C107 R1 0 8 C108 L1 0 1 C112 L102 PAM1 0 0 C4 3 5 R4 0 5 R4 1 0 R4 0 9 C423 C109 L1 0 4 C436 L1 0 5 L400 C113 L1 0 7 C417 L1 0 8 C404 L1 1 0 C410 C429 L4 0 2 C4 0 3 OSC4 0 0 L401 F1 0 2 C130 C135 U4 0 1 C134 R101 Flow Chart of Troubleshooting 9-2. Initial Initial Failure Yes No pin G13, G12 of UCP300 ="H"? Check the circuit connected to reset Yes No IS [TP300,TP303,TP305, TP306,TP307,TP308,TP 309,,TP301] OK? Check the circuit related to UME300 Yes Check the circuit around LCD & HDC700 (Short or not solder) Yes END 9-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G13 G12 W5 RESET_N RESET_OUT_N R327 AA1 G1 M4 SDRAM_CLK SDRAM_RAS SDRAM_CKE A15 B15 SLEEP_XTAL_IN TP_SLEEP_CLK_OUT V2 AE6 OE2_N V4 U5 W14 AB14 SDRAM_CS0 NAND_CE MV_CS_N V5 K8 SDRAM_CAS R329 TRK_LO_ADJ H13 E13 E11 TP_TX_AGC_ADJ RF_ON RESIN_N RESOUT_N RESOUT_N_EBI1 ROM1_CLK ROM1_ADV_N SDRAM1_CLK_EN SLEEP_XTAL_IN SLEEP_XTAL_OUT OE1_N OE2_N XMEM1_CS_N0 XMEM1_CS_N2 XMEM2_CS_N0 XMEM2_CS_N1 XMEM1_HWAIT_N XMEM1_LWAIT_N TRK_LO_ADJ TX_AGC_ADJ TX_ON TP3 TP308 C621 TP6 0 4 R623 R616 TP6 0 0 TP6 0 1 R617 TP6 0 2 C602 C603 C324 C3 3 0 C3 3 2 C3 3 1 D602 TP3 0 5 UME3 0 0 C3 2 8 UCP600 R614 C630 TP307 A600 MV_CS_N OE600 MV_INT U6 0 1 TP603 WE600 R630 C624 C541 R7 0 5 C7 1 2 U5 0 8 C7 0 9 C7 1 0 HD C7 0 0 C7 0 8 TA4 0 3 C7 0 7 R3 3 2 C545 R5 2 9 C550 R7 3 6 C554 R5 2 7 3 C5 4 7 C5 4 8 R520 C55 C555 C543 R5 2 2 C5 3 6 C319 C7 3 5 C7 3 3 D7 0 0 C7 3 4 TA701 C320 C5 3 8 C329 TP3 0 3 C316 U410 9-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 35 33 C607 00 C620 R622 01 00 09 TP306 1 0 1 0 C349 D1(0) D1(1) D1(2) D1(3) D1(4) D1(5) D1(6) D1(7) D1(8) D1(9) D1(10) D1(11) D1(12) D1(13) D1(14) D1(15) D1(16) D1(17) D1(18) D1(19) D1(20) D1(21) D1(22) D1(23) D1(24) D1(25) D1(26) D1(27) D1(28) D1(29) D1(30) D1(31) U4 T4 T5 V5 U5 T6 V6 U7 T9 T10 V10 T11 U11 V11 T12 U12 P3 R3 P4 R4 P5 R5 P6 R6 P9 P10 R10 P11 R11 P12 R12 R13 U8 T8 V7 U9 SDRAM_DQM0 SDRAM_DQM1 SDRAM_DQM2 SDRAM_DQM3 D2(0:7) D2(0) D2(1) D2(2) D2(3) D2(4) D2(5) D2(6) D2(7) D2(8) D2(9) D2(10) D2(11) D2(12) D2(13) D2(14) D2(15) D2(8:15) SDRAM_RAS OE2_N SDRAM_WE WE2_N RESET_OUT_N E3 E2 D12 C12 D11 C11 D10 C10 E4 D9 C9 TP303 D1(0:31) SDRAM_BA0 SDRAM_BA1 NAND_ALE SDRAM_CKE NAND_CLE SDRAM_CLK NAND_READY SDRAM_CAS NAND_CE SDRAM_CS0 TP305 TP306 TP307 TP308 TP309 TP310 M11 M13 L10 L12 J9 H12 H10 G12 M12 L9 L11 K9 H13 H11 H9 G11 C4 D4 M3 D8 M4 C8 M2 E6 M9 D7 E5 D5 M10 D6 K6 L6 K1 C N V C D Q C V C V 1 V V D Q C V C C D C V V D D 1 V C D C V A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 C D C V C3 TP300D3 C D C V A1(0) A1(1) A1(2) A1(3) A1(4) A1(5) A1(6) A1(7) A1(8) A1(9) A1(10) A1(11) A1(12) C D C V A1(0:12) D C V C C Flow Chart of Troubleshooting DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 DQ16 DQ17 DQ18 DQ19 DQ20 DQ21 DQ22 DQ23 DQ24 DQ25 DQ26 DQ27 DQ28 DQ29 DQ30 DQ31 DQM0 DQM1 DQM2 DQM3 UME300 I|O1 I|O2 I|O3 I|O4 I|O5 I|O6 I|O7 I|O8 I|O9 I|O10 I|O11 I|O12 I|O13 I|O14 I|O15 I|O16 BA0 BA1 ALE CKE CLE CLK RY|BY CAS CE CS CS RAS RE WED WEN WP 9-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC C13 C14 D1 D14 E1 E7 E8 E9 E10 E11 E12 E13 F2 F3 F4 F5 F6 F8 F9 F10 F11 F12 F13 G3 G4 G5 G6 G7 G8 G9 G10 H2 H3 H4 H5 H6 J2 J3 J4 J5 J6 J10 J11 J12 J13 K1 K2 K3 K4 K5 K10 K11 K13 K14 L1 L2 L3 L4 L5 L14 M5 M6 N2 N3 N4 N5 N6 N9 N10 N11 N12 N13 P7 P8 R2 R7 R9 T2 T3 T7 T13 U1 U3 Flow Chart of Troubleshooting 9-3. Charging Part Abnormal charging part Yes No C619=5V? Resolder IFC600 Yes No U400 pin5 = "H"? Replace U400 Yes Check the Battery & TA Yes END VBATT_4.2V VREG_MSMP_2.6V U400 1 USBIN USB_VBUS_5V R401 2 IUSB BAT 9 3 ITERM IDC 8 4 PWR CHG_INDICATE C412 R403 R404 DCIN 10 VEXT_5V BATDET 7 5 CHRG GND 11 VF EN 6 CHG_EN_N R402 C413 9-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C414 Flow Chart of Troubleshooting VEXT_5V VBATT_4.2V IFC600 1 2 3 4 5 6 7 8 9 10 11 12 L600 L601 R607 R608 R609 13 14 15 16 17 18 19 20 21 22 23 24 25 26 R610 TA601 R521 L510 C544 L511 C551 C614 R528 C6 1 5 R532 D600 R607 R608 D601 R609 TA601 SLC700 R404 R3 1 0 R430 C617 C619 U301 9-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization R7 2 5 C6 1 8 R402 C4 5 7 U4 0 0 C414 C413 R605 R6 0 3 C412 C5 4 9 C703 L600 R7 1 6 C70 2 L5 0 4 ZD701 ZD702 R523 C556 I FC6 0 0 R732 C542 L601 C7 3 8 C704 R733 L6 0 2 M OT7 0 0 ZD700 R734 Z D 7 0 3 C7 0 1 R735 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 Flow Chart of Troubleshooting 9-4. Sim Part Phone can't access SIM Card Yes No C740="H"? Check the SIM POWER Yes No After Power ON, Check the 32.768 kHz OSC400 Check USIM_CLK Signal on pin15 of SIM700 in a few second Yes No Replace PBA After SIM card insert, pin 13 of SIM700 = "H(USIM_RST)"? Yes Check the SIM Card Yes END 9-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VREG_MMC_2.8V R729 VREG_MSMP_2.6V VREG_USIM_3.0V D701 1 2 CH4 CH2 CH3 5 4 R723 R722 R721 R720 R719 R718 VN 6 SD_CLK SD_D(0) SD_D(1) USIM_RST R724 USIM_CLK USIM_IO D702 R728 C750 3 CH5 VN CH2 C410 C429 CH4 CH3 L4 0 2 03 OSC4 0 0 L401 CH1 C404 S I M7 0 0 C436 U4 0 1 C4 3 5 R4 1 0 R4 0 5 R4 0 9 L400 R4 3 7 R4 1 3 C4 1 5 R4 0 6 R4 3 C4 3 C4 3 C407 R7 1 7 R7 1 9 R7 1 8 C7 4 0 C750 C7 4 9 R723 C4 2 1 C4 2 5 R7 2 4 R4 3 4 C7 4 8 R312 C40 8 C417 C418 C422 C746 5 4 9-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C409 C4 0 5 C423 R729 6 TP4 0 3TP_AMUX_ OUT C749 C739 C748 C746 C747 2 C745 C744 C743 1 C742 10 11 12 13 14 15 16 17 18 19 20 21 22 23 CH5 SD_DETECT SD_D(2) SD_D(3) SD_CMD C741 1 2 3 4 5 6 7 8 9 C740 SW-B SW-A 1 2 3 4 5 6 7 8 C1 C5 C2 C6 C3 C7 NC NC NC NC NC NC NC R717 3 SIM700 CH1 Flow Chart of Troubleshooting 9-5. Microphone Part Microphone does not work Yes No Resolder the microphone FPCB check the microphone FPCB Yes No Resolder or change U508 C554 is 2.0V Yes Is microphone ok? No Change the microphone Yes END 9-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting PHONE_MICBIAS_2.0V VBATT_4.2V U508 1 EN MICBIAS_EN BYP 2 GND NC 5 VOUT 4 GND 3 VIN 6 7 R531 C554 C553 35 33 R520 C55 3 C554 U5 0 8 TA701 D7 0 0 734 413 C437 BTC700 C545 U410 C552 C5 5 2 R5 3 1 TA402 9-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-6. Speaker Part(Melody) Speaker does not work No Is the terminal of speaker OK? Check the Speaker Wire Yes No Check the AMP_N/P ok? Resolder the Speaker wire Yes No Check the Earjack FPCB ok? Change or Resolder Earjack FPCB Yes No Check the output circuit of U501 Change or Resolder U501 Yes No Is the CODECOUT_M and CODECOUT_P ok? Check the C512,C514,R505,R508 = 'H' Yes No C600,C601,C602,C603, is 'H' ? Change or Resolder U404 Yes No Is Speaker OK ? Change the Speaker Yes END 9-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VBATT_4.2V U501 C512 R505 C514 R508 CODECOUT_M CODECOUT_P 12 NC NC C1 B1 INVDD A1 IN+ B2 VDD C2 _SHUT VO- A3 AMP_EN VO+ C3 G G2 A2 B3 C513 TA500 L501 AMP_N AMP_P L503 C526 VREG_MV_1.8V VREG_MV_2.6V C600 C636 C602 C603 LCD_D(0:17) LD0 LD1 H13 H14 H15 C527 LCD_D(0) LCD_D(1) LCD_D(2) 9-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C601 Flow Chart of Troubleshooting VBATT_4.2V VREG_CODEC_1.8V VREG_CODEC_2.8V U404 1 CODEC_PWR_EN 2 CE1 VOUT1 8 VDD 7 3 CE2 VOUT2 6 4 NC 5 NC G ND GND 9 C449 C448 C526 L501 L506 C512 R508 C514 C508 R306 C5 1 3 C5 0 0 R316 C5 1 6 R320 R505 TA500 U500 C5 1 0 R501 C502 R500 C501 C5 1 7 U404 C507 ZD705 H O LD S W 7 0 0 R5 1 6 L503 C527 U5 0 1 C5 3 5 U506 C450 C621 TP6 0 4 R623 R616 TP_ D OUT TP6 0 1 UCP600 TP6 0 2 C3 2 8 C602 TP_LRCLK C324 R6 1 C3 3 2 C3 3 0 C3 3 1 TP_MCLK R619 C6 3 6 TP_ BCLK C603 TP_ D I N R614 R6 2 0 TP6 0 0 R617 9-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-7. Receiver Part Receiver does not work Yes No Check the Speaker wire Does Speaker work well? Yes No pin4,pin9 of U506 and pin4, pin9 of U505 is 'H' ? Change the U505,U506 Yes R516 , R517 is 'H' ? No Change or resolder R516,R517 Yes No Is Receiver OK ? Change the Speaker Yes END 9-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VBATT_4.2V L507 RCV_SPK_SEL 1 IN 9 1S2 GND 8 2 1S1 2S1 7 3 VCC 2S2 6 2 IN AMP_N AMP_P 1 4 C534 SPK_N SPK_P D2 RCV_N_OUT 5 R 51 7 D1 10 U505 RCV_SPK_SEL RCV_P_OUT VBATT_4.2V L506 RCV_SPK_SEL 1S2 GND 8 2 1S1 2S1 7 VCC 2S2 6 4 2IN 3 C535 1IN 9 1 D2 RCV_N RCV_P R539 RCV_N_OUT RCV_P_OUT R540 5 R516 D1 10 U506 RCV_SPK_SEL 9-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting R540 R5 1 6 L5 0 7 C5 3 4 R5 3 9 R517 U506 C5 3 5 U505 C527 C526 L506 L503 L501 9-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-8. LCD part LCD does not work Yes No Is the LCD FPCB connected in HDC700? Put the LCD FPCB on HDC700 Yes No R704 , C714=3.0V? Replace U701 Yes No Is Slide FPCB OK ? Replace the Slide FPCB Yes Replace the LCD Module Not OK Check the UCP600 ,U410 END 9-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VREG_LCD_3.0V V_DC VREG_LCD_3.0V VREG_MSMP_2.6V 39 37 35 33 31 29 27 25 23 21 19 17 15 13 11 9 7 5 3 1 BL_LDO_EN LCD_RST EMI_FLM KEY_LED_EN3 KEY_LED_EN2 KEY_LED_EN1 MLCD_BL_EN MAINMIC_N MAINMIC_P 39 37 35 33 31 29 27 25 23 21 19 17 15 13 11 9 7 5 3 1 LCD(0) LCD(1) LCD(2) LCD(3) LCD(4) LCD(5) LCD(6) LCD(7) LCD(8) LCD(9) LCD(10) LCD(11) LCD(12) LCD(13) LCD(14) LCD(15) EMI_RS EMI_L_WR 40 40 38 38 36 36 34 34 32 32 30 30 28 28 26 26 24 24 22 22 20 20 18 18 16 16 14 14 12 12 10 10 8 8 6 6 4 4 2 2 R704 EMI_MAIN_LCD_CS C715 C714 C 713 C 712 C711 C 710 C 708 C 707 R 705 C 709 R704 C624 F7 0 1 C541 F7 0 2 HD C7 0 0 C7 0 9 C7 1 0 R7 0 5 C7 1 2 F7 0 0 C7 0 7 TA4 0 3 C7 1 C7 0 U7 0 1 C7 0 C7 1 5 C711 C7 0 8 R3 3 2 R7 3 6 C713 TA402 R5 2 9 R5 2 7 C550 C545 C5 4 7 C5 4 8 R5 2 2 C555 C543 U410 R736 HDC700 9-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-9. Camera part ( 5 Mega ) "5 Mega Camera" function does not work Yes Not OK Is the Camera connected in HEA700 ? Put the camera module on HEA700 OK HEA700 pin20, pin23≒2.8V and pin11≒1.8V ? No Replace U402 Yes No HEA700 pin17≒2.8V ? Replace U403 Yes No HEA700 pin7,pin29≒1.5V ? Replace U407 Yes No HEA700 pin24≒2.8V ? Replace U408 No Is R711, R420,R421,R422 R428 and L405 placed in board? Replace R711, R420,R421,R422 R428 and L405 Yes 9-22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting No Is F703, F704 and F705 placed in board ? Replace F703, F704 and F705 Yes Replace the 5mega camera module Not OK Check the UCP600 END 9-23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_VCM_3.3V CAM_ISP_CORE_1.5V 5M_VT_CORE_1.8V CAM_FVDD_2.8V CAM_SVDD_2.8V CAM_ISP_1.5V CAM_DVDD_2.8V 5M_AVDD_2.8V HEA700 C731 R712 C 726 C 725 C723 C 724 C 721 C 722 C 719 C 720 C 718 R 731 C 751 CAMD(4) C 732 R711 31 32 N C NC CAMD(7) 5M_RESET CAMD(0) CAMD(2) C717 CAMD(3) CAMD(5) CAM_MCLK CAM_PCLK CAMI2C_SCL CAMI2C_SDA C 730 CAMVSYNC CAMD(1) 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 C728 VCAM_EN CAMHSYNC 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 C 729 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 29 C 727 1 3 5 7 9 11 13 15 17 19 21 23 25 27 5M_VT_CORE_1.8V CAM_SVDD_2.8V CAM_DVDD_2.8V VBATT_4.2V 2 CE1 VOUT1 8 VDD 7 6 CE2 VOUT2 4 NC 5 NC GND 3 9 C441 C442 C443 9-24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization R421 1 GND CAM_PWR_EN1 R420 U402 CAMD(6) VT_RESET Flow Chart of Troubleshooting VBATT_4.2V VDD_VCM_3.3V 5M_AVDD_2.8V 1 CAM_PWR_EN3 2 R422 U403 CE1 VOUT1 8 VDD 7 3 6 CE2 VOUT2 4 NC 5 NC GND CAM_PWR_EN1 GND 9 C444 C446 C445 CAM_ISP_CORE_1.5V CAM_ISP_1.5V R428 C461 VBATT_4.2V U407 L 405 L404 1 LX IN 6 2 GND GND 5 3 OUT 4 _SHDN CAM_PWR_EN2 C453 R432 C454 9-25 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VBATT_4.2V CAM_FVDD_2.8V U408 3 VIN VOUT 4 2 GND 1 STBY CAM_PWR_EN2 NC 5 GND 6 R431 C455 C456 LED400 C456 F7 0 5 ZD401 U408 R4 3 1 C6 3 8 HEA700 C455 F703 C637 U605 R636 F704 C441 C443 C445 C722 C725 C723 C720 C718 C721 C719 C751 R535 R307 R711 R731 R533 R634 C560 SC202 C243 C2 6 4 R2 0 7 R205 C255 C250 9-26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C223 C231 C220 C237 C2 2 7 C245 C2 3 2 C2 2 8 C2 3 5 C2 2 9 C2 3 4 C249 R3 0 2 R7 1 0 R3 0 3 R7 0 6 U402 C444 C7 1 6 L4 0 4 C4 5 3 U4 0 7 C442 R420 C724 U7 0 2 R428 L405 C446 R7 0 7 C461 R421 U4 0 3 R422 Flow Chart of Troubleshooting 9-10. Camera part ( QCIF ) "QCIF Camera" function does not work Yes No Is the Camera connected in HEA700 ? Put the camera module on HEA700 Yes No HEA700 pin20, pin23≒2.8V and pin11≒1.8V ? Replace U402 Yes No HEA700 pin17≒2.8V Replace U403 Yes No Is R712, R421 and R422 placed in board ? Replace R712, R421 and R422 Yes No Is F703, F704 and F705 placed in board ? Replace F703, F704 and F705 Yes Replace the QCIF camera module Not OK Check the UCP300 END 9-27 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_VCM_3.3V CAM_ISP_CORE_1.5V 5M_VT_CORE_1.8V CAM_FVDD_2.8V CAM_SVDD_2.8V CAM_ISP_1.5V CAM_DVDD_2.8V 5M_AVDD_2.8V HEA700 C 731 R712 C 726 C 725 C723 C 724 C 721 C 722 C 719 C 720 C 718 R 731 C 751 CAMD(4) C 732 R711 31 32 N C NC CAMD(7) 5M_RESET CAMD(0) CAMD(2) C 717 CAMD(3) CAMD(5) CAM_MCLK CAM_PCLK CAMI2C_SCL CAMI2C_SDA C 730 CAMVSYNC CAMD(1) 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 C728 VCAM_EN CAMHSYNC 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 C 729 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 29 C 727 1 3 5 7 9 11 13 15 17 19 21 23 25 27 5M_VT_CORE_1.8V CAM_SVDD_2.8V CAM_DVDD_2.8V VBATT_4.2V 2 CE1 VOUT1 8 VDD 7 6 CE2 VOUT2 4 NC 5 NC GND 3 9 C441 C442 C443 9-28 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization R421 1 GND CAM_PWR_EN1 R420 U402 CAMD(6) VT_RESET Flow Chart of Troubleshooting VBATT_4.2V VDD_VCM_3.3V 5M_AVDD_2.8V 1 CAM_PWR_EN3 R422 U403 CE1 VOUT1 8 2 VDD 7 3 6 CE2 VOUT2 4 NC 5 NC GND CAM_PWR_EN1 GND 9 C444 C732 R611 C727 R7 1 2 R304 C7 3 0 C726 C7 1 7 R317 C7 2 9 C731 C7 2 8 R612 C446 C445 C456 F7 0 5 ZD401 U408 R4 3 1 C6 3 8 HEA700 C455 F703 C637 R636 F704 U605 R421 C444 C443 C445 U7 0 2 C441 R420 R7 0 7 C442 C446 U4 0 3 R422 C724 C725 C722 C723 C720 C718 C721 C719 C751 R535 R307 R711 R731 R533 R634 C560 U402 9-29 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-11. Touch part Touch module does not work Yes Is the TSP FPCB connected in SLC700 ? No Put the TSP FPCB on SLC700 Yes R429=High and C452=2.8V? No Replace U406 Yes When youtouch the window, does the TOUCH_OUT react? Or TA700,R700~R702 is not high? No Replace U700 Yes Is R732~R735, ZD700~703 ,C701~C704 placed in board? No Replace Resistor, Capacitor, Zener diode Yes Replace the touch module END 9-30 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting SLC700 1 2 3 4 5 6 7 8 R732 R733 R734 R735 1 2 3 4 5 6 NC NC ZD703 ZD 702 ZD 701 ZD 700 TSP_Y TSP_X TSP_Y+ TSP_X+ V_DC VREG_TOUCH_2.8V U406 3 VIN VOUT 4 2 GND 1 STBY TOUCH_PWR_EN NC 5 GND 6 R429 C451 C452 VREG_TOUCH_2.8V VREG_TOUCH_2.8V VREG_TOUCH_2.8V R700 V D D |R E F A 2 TA700 A1 AUX C703 TOUCH_OUT 1 NC 2 NC C702 TOUCH_I2C_SDA TOUCH_I2C_SCL PENIRQ- B1 D2 GND C701 R702 A0 A1 C2 SDA C1 SCL D1 A3 X+ C3 XB3 Y+ D3 Y- TSP_X+ TSP_X TSP_Y+ TSP_Y R701 B2 U700 C704 9-31 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting M O T7 0 0 SLC700 R734 ZD701 C412 R430 R700 U700 L5 0 4 R521 L510 C544 C5 4 6 R5 1 4 L6 0 2 R523 R4 2 9 R702 TA 7 0 0 R6 1 3 C542 R404 C4 5 1 R701 C703 R7 1 6 C70 2 ZD702 C7 3 8 C704 R732 U406 ZD700 R733 Z D 7 0 3 C7 0 1 R735 C452 C539 9-32 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-12. GSM Receiver CONTINUOUS RX on RF input : 62CH RX ON Cell power : -50dBm RF input : 62CH Cell Power : -50 dBm Yes No C100 ≥ -65dBm Resolder RFS100 Yes C115 > 1.2V C110 > 1.2V C111 < 0.5V No Check UCP300 Yes No C107 ≥ -68dBM Resolder PAM100 or Change PAM100 Yes No Resolder F100 or Change F100 L102 ≥ -71dBm Yes U201 PIN 11,12,13,14 ≥ 500mV No Check U201 Yes Check UCP300 END 9-33 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G G 1 C101 G 3 C100 C137 RFIN G 2 1 A C 4 3 2 G RFS100 C104 C103 4 L100 C102 RFS101 TA100 PAM100 26 10 21 23 VBATT RX4 RX3 RX2 RX1 WCDMA1 DCS|PCS_IN GSM_IN MODE RSVD _TXEN VAPC BS2 BS1 C107 4 5 6 7 29 GND C110 1 G OUT G 2 5 L101 3 OUT IN 4 GSM_RX_M L102 L103 L104 2 3 1 25 GSM_RX_P F101 9 GND 11 GND 12 GND 13 GND 14 GND 15 GND 16 GND 17 GND 18 GND 19 GND 20 GND 22 GND 24 GND 27 28 ANT 8 F100 C108 1 R103 G OUT G 2 5 L105 3 OUT IN C111 DCS_RX_M 4 L106 C109 L107 DCS_RX_P F102 C112 1 2 PCS_RX_M 4 OUT G G L108 3 OUT IN L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 R1 0 5 R106 R10 R102 C1 3 7 L100 C100 SC2 0 0 C1 0 6 C1 0 5 R107 R104 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 TA 1 0 0 C1 1 1 PAM1 0 0 C114 C102 C1 2 3 C1 3 6 C1 3 0 C1 3 4 C1 1 0 C107 C117 TCX100 C1 1 5 R1 0 3 C108 C1 3 5 C2 2 6 L102 C1 2 4 C112 R1 0 8 C109 L1 0 1 C113 L1 0 4 C233 L1 0 5 C238 L1 0 7 L112 L103 L106 L1 0 8 C240 L116 L109 C241 L1 1 0 C1 2 7 C2 4 4 C2 3 9 C242 C120 C1 2 1 C218 9-34 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-13 GSM Transmitter CONTINUOUS TX ON RF Input : 62CH TX ON (5Level) PAM100 PIN 23 ≥ 0dBm No Check U201 Yes C115 C110 C111 R107 < < > ≥ 0.5V 0.5V 1.2V 0.2V No Check UCP300 Yes No C100 ≥ 30dBm Resolder PAM100 or Change PAM100 Yes Resolder RFS100 or Change RFS100 END 9-35 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 2 G G 1 G 3 C101 C100 C137 RFIN A G 2 1 3 4 C G RFS100 4 C104 C103 L100 C102 RFS101 TA100 PAM100 26 10 21 23 VBATT RX4 RX3 RX2 RX1 WCDMA1 DCS|PCS_IN GSM_IN C107 4 5 6 7 1 G GOUT 2 5 C110 GSM_RX_M L102 L103 GSM_RX_P F101 C108 9 11 12 13 14 15 16 17 18 19 20 22 24 29 GND 4 L104 2 MODE 3 RSVD 1 _TXEN 25 VAPC BS2 BS1 L101 3 OUT IN GND GND GND GND GND GND GND GND GND GND GND GND GND 27 28 ANT 8 F100 1 C111 R103 G GOUT 2 5 L105 3 OUT IN DCS_RX_M 4 L106 C109 L107 DCS_RX_P F102 C112 1 G 2 L108 3 OUT IN PCS_RX_M 4 GOUT L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 R1 0 5 R106 R10 R102 C1 3 7 L100 C100 SC2 0 0 C1 0 6 C1 0 5 R107 R104 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 TA1 0 0 PAM1 0 0 C114 C102 C1 2 3 C1 3 6 C1 1 1 C1 1 0 C107 C1 3 0 TCX100 C1 1 5 R1 0 3 C108 C117 C1 3 4 L102 C1 2 4 C112 R1 0 8 C109 L1 0 1 C113 L1 0 4 C233 C1 3 5 C2 2 6 L103 L1 0 5 C238 L1 0 7 L112 L106 L1 0 8 C240 L116 L109 C241 L1 1 0 C1 2 7 C2 4 4 C2 3 9 C242 C120 C1 2 1 C218 9-36 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-14. DCS Receiver RX ON RF input : 698CH Cell Power : -50 dBm Yes No C100 ≥ -65dBm Resolder RFS100 Yes C115 > 1.2V C110 > 1.2V C111 > 1.2V No Check UCP300 Yes No C108 ≥ -68dBM Resolder PAM100 or Change PAM100 Yes No Resolder F100 or Change F100 C109 ≥ -71dBm Yes U201 PIN 11,12,13,14 ≥ 500mV No Check U201 Yes Check UCP300 END 9-37 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G C102 C103 L100 G 4 G 1 3 C101 C100 C137 RFIN G 2 1 2 4 3 A C G RFS100 C104 RFS101 TA100 PAM100 GND G OUT G 2 5 4 GSM_RX_M L103 L102 L104 GSM_RX_P F101 GND GND IN L101 3 OUT 1 2 3 1 25 24 22 GND GND 20 19 GND GND GND 18 GND GND GND GND 15 16 17 9 C110 11 29 GND 14 GND BS2 BS1 MODE RSVD _TXEN VAPC C107 4 5 6 7 RX4 RX3 RX2 RX1 WCDMA1 DCS|PCS_IN GSM_IN 13 27 28 VBATT 12 26 10 21 23 ANT 8 F100 C108 IN C111 R103 G OUT G 2 5 L105 3 OUT 1 4 DCS_RX_M L106 C109 L107 DCS_RX_P F102 C112 IN 4 OUT G G 2 L108 3 OUT 1 PCS_RX_M L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 R1 0 5 R106 R10 R102 C1 3 7 L100 C100 SC2 0 0 C1 0 6 R107 R104 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 C1 0 5 PAM1 0 0 C114 C102 C1 2 3 TA 1 0 0 C1 1 1 C1 1 0 C1 1 5 R1 0 3 C107 C1 3 6 TCX100 C1 2 4 C108 C117 C1 3 4 L102 C1 3 0 R1 0 8 C112 L1 0 1 C109 L1 0 4 L1 0 5 L1 0 7 L1 0 8 L1 1 0 C113 C1 3 5 L103 L106 C2 2 6 L109 C120 C1 2 1 C218 9-38 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-15. DCS Transmitter CONTINUOUS TX ON RF Input : 698CH TX ON (0Level) PAM100 PIN 21 ≥ 0dBm No Check U201 Yes C115 C110 C111 R107 < > > ≥ No 0.5V 1.2V 1.2V 0.2V Check UCP300 Yes No C100 ≥ 27dBm Resolder PAM100 or Change PAM100 Yes Resolder RFS100 or Change RFS100 END 9-39 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G 1 G G 3 C101 C100 C137 RFIN G 2 1 4 3 2 A C G RFS100 C103 C104 4 L100 C102 RFS101 TA100 PAM100 26 10 21 23 RX4 RX3 RX2 RX1 WCDMA1 DCS|PCS_IN GSM_IN MODE RSVD _TXEN VAPC BS2 BS1 C107 4 5 6 7 29 GND C110 1 G GOUT 2 5 L101 3 OUT IN 4 GSM_RX_M L103 L102 L104 2 3 1 25 GSM_RX_P F101 9 GND 11 GND 12 GND 13 GND 14 GND 15 GND 16 GND 17 GND 18 GND 19 GND 20 GND 22 GND 24 GND 27 28 VBATT ANT 8 F100 C108 1 C111 R103 G GOUT 2 5 L105 3 OUT IN 4 DCS_RX_M L106 C109 L107 DCS_RX_P F102 C112 1 4 GOUT G 2 L108 3 OUT IN PCS_RX_M L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 C1 0 6 C1 0 5 R107 R1 0 5 R104 R106 R10 R102 C102 C1 3 7 L100 C100 SC2 0 0 TA 1 0 0 C1 1 1 C1 1 0 C1 1 5 R1 0 3 PAM1 0 0 C114 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 C1 2 3 C1 3 4 TCX100 C1 2 4 C107 C117 C1 3 6 L102 C108 C1 3 5 R1 0 8 C112 L1 0 1 C109 L1 0 4 L1 0 5 L1 0 7 L1 0 8 L1 1 0 C113 C1 3 0 L103 L106 C2 2 6 L109 C120 C1 2 1 C218 9-40 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-16. PCS Receiver RX ON RF input : 660CH Cell Power : -50 dBm Yes No Resolder RFS100 C100 ≥ -65dBm Yes C115 > 1.2V C110 < 0.5V C111 > 1.2V No Check UCP300 Yes No C112 ≥ -68dBM Resolder PAM100 or Change PAM100 Yes No C113 ≥ -71dBm Resolder F100 or Change F100 Yes U201 PIN 11,12,13,14 ≥ 500mV No Check U201 Yes Check UCP300 END 9-41 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 C102 C104 C103 L100 4 G G 3 C101 C100 C137 RFIN G 2 A G 1 2 3 4 C G RFS100 RFS101 TA100 PAM100 26 10 21 23 WCDMA1 DCS|PCS_IN GSM_IN 29 GND C110 1 G OUT G 2 5 L101 3 OUT IN 4 GSM_RX_M L102 L103 L104 2 3 1 25 MODE RSVD _TXEN VAPC BS2 BS1 C107 4 5 6 7 RX4 RX3 RX2 RX1 GSM_RX_P F101 9 GND 11 GND 12 GND 13 GND 14 GND 15 GND 16 GND 17 GND 18 GND 19 GND 20 GND 22 GND 24 GND 27 28 VBATT ANT 8 F100 C108 1 R103 G OUT G 2 5 L105 3 OUT IN C111 DCS_RX_M 4 L106 C109 L107 DCS_RX_P F102 C112 1 G 2 L108 3 OUT IN PCS_RX_M 4 OUT G L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 R107 R1 0 5 R104 R106 R10 R102 C102 C1 3 7 L100 C100 SC2 0 0 C1 0 6 C1 0 5 PAM1 0 0 C114 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 C1 2 3 TA 1 0 0 C1 1 1 C1 1 0 C1 1 5 R1 0 3 C107 C1 3 4 TCX100 C1 2 4 C108 C117 C1 3 6 L102 C1 3 0 R1 0 8 C112 L1 0 1 C109 L1 0 4 L1 0 5 L1 0 7 L1 0 8 L1 1 0 C113 L103 C1 3 5 L106 C2 2 6 L109 C120 C1 2 1 C218 9-42 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-17. PCS Transmitter CONTINUOUS TX ON RF Input : 660CH TX ON (0Level) PAM100 PIN 21 ≥ 0dBm No Check U201 Yes C115 C110 C111 R107 < > > ≥ No 0.5V 1.2V 1.2V 0.2V Check UCP300 Yes No C100 ≥ 27dBm Resolder PAM100 or Change PAM100 Yes Resolder RFS100 or Change RFS100 END 9-43 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G A L100 C102 C103 4 G 1 G 3 C101 C100 C137 RFIN G 2 1 2 3 4 C G RFS100 C104 RFS101 TA100 PAM100 26 10 21 23 RX4 RX3 RX2 RX1 WCDMA1 DCS|PCS_IN GSM_IN MODE RSVD _TXEN VAPC BS2 BS1 C107 4 5 6 7 29 GND C110 1 G OUT G 2 5 L101 3 OUT IN 4 GSM_RX_M L103 L102 L104 2 3 1 25 GSM_RX_P F101 9 GND 11 GND 12 GND 13 GND 14 GND 15 GND 16 GND 17 GND 18 GND 19 GND 20 GND 22 GND 24 GND 27 28 VBATT ANT 8 F100 C108 1 C111 R103 G OUT G 2 5 L105 3 OUT IN 4 DCS_RX_M L106 C109 L107 DCS_RX_P F102 C112 1 4 OUT G G 2 L108 3 OUT IN PCS_RX_M L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 C224 R202 C208 C213 C2 0 1 C2 0 7 C2 0 0 C211 C206 C204 U201 C210 C116 L202 C212 F1 0 3 C216 C205 C209 C217 C221 R107 R1 0 5 R104 R106 R10 R102 C102 C1 3 7 L100 C100 SC2 0 0 C1 0 6 C1 0 5 PAM1 0 0 C114 0 R101 RFS1 0 0 100 F1 0 1 F1 0 2 C1 2 9 C1 2 3 TA 1 0 0 C1 1 1 C1 1 0 C1 1 5 R1 0 3 C107 C1 3 4 TCX100 C1 2 4 C108 C117 C1 3 6 L102 C1 3 0 R1 0 8 C112 L1 0 1 C109 L1 0 4 L1 0 5 L1 0 7 L1 0 8 L1 1 0 C113 L103 C1 3 5 L106 C2 2 6 L109 C120 C1 2 1 C218 9-44 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-18. WCDMA Receiver RX ON RF input : 10700CH Cell Power : -50 dBm Yes No Resolder RFS100 C100 ≥ -65dBm Yes C115 < 0.5V C110 > 1.2V C111 < 0.5V No Check UCP300 Yes No L111 ≥ -68dBM Resolder PAM100 or Change PAM100 Yes No Resolder DUF100 or Change DUF100 L112 ≥ -71dBm Yes No Resolder F200 or Change F200 L206 ≥ -74dBm Yes U201 PIN 11,12,13,14 ≥ 500mV No Check U201 Yes Check UCP300 Yes END 9-45 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting G G 1 C101 G 3 C100 C137 RFI N G 2 1 2 A 3 4 C G RFS100 C104 C103 L100 4 C102 RFS101 TA100 PAM100 8 F100 VBATT RX4 RX3 RX2 RX1 A NT 26 10 WCDMA1 21 DCS|PCS_IN 23 GSM_IN 27 BS2 28 BS1 1 OUT IN G GOUT 2 5 4 L102 GSM_RX_M L103 GSM_RX_P F101 C108 9 11 12 13 14 15 16 17 18 19 20 22 24 C110 L101 3 L104 2 MODE 3 RSVD 1 _TXEN 25 VAPC GND GND GND GND GND GND GND GND GND GND GND GND GND 29 GND C107 4 5 6 7 1 C111 OUT IN R103 G GOUT 2 5 L105 3 4 DCS_RX_M L106 C109 L107 DCS_RX_P F102 C112 1 OUT IN G 2 GOUT L108 3 4 PCS_RX_M L109 C113 5 L110 PCS_RX_P R107 GSM_PA_PWR_CTL GSM_ANT_SEL2_N C114 C115 L111 TRX_WCDMA_IMT C122 DUF100 2 ANT C127 L112 RX 5 UMTS_RX_2100 G G G G G G 7 TX 13 46 8 9 L116 9-46 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting C226 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 WPRXSE1_OUT GCELL_INN GCELL_INP EGSM_INN EGSM_INP DCS_INN DCS_INP GPCS_INN GPCS_INP VDDA2 GPS_IN WDRXLB WDRXHB1 WDRXHB2 WPRXSE1 VDDA2 WPRXSE2 GSM_RX_M GSM_RX_P DCS_RX_M DCS_RX_P PCS_RX_M PCS_RX_P VREG_RF_S2_2.1V C239 C233 C238 C240 C241 C242 UMTS_RX_2100 VREG_RF_S2_2.1V C247 C246 C244 L 204 R204 U201 DRX_IN N|C SB DT VDDA 2 VDDA 1 VDDM VTUNE2 VDDA 2 RF_ON VDDA 2 WB _MX_INP WB _MX_INM WPRXL B P WPRXL B M WPRXHB P WPRXHB M WPRXSE2_OUT VDDA2 TCXO VDDA1 VDDA1 VTUNE1 VDDA1 VDDA2 VDDA2 VTUNE_GPS VDDA1 PRX_QP PRX_QN PRX_IN PRX_IP DRX_QP DRX_QN DRX_IP PDET_IN 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 NC NC GND_SL UG TX_RB IA S DA C_IREF TX_QP TX_QN TX_IP TX_IN VDDA 2 VDDA 2 VDDA 2 HB _RF_OUT3 HB _RF_OUT2 L B _RF_OUT2 HB _RF_OUT1 L B _RF_OUT1 VDDA 2 VDDA 1 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 PWR_DET UMTS_RX_M_2100 L205 C257 L 207 C260 L206 4 C258 UMTS_RX_P_2100 C2 5 3 R2 0 6 C2 5 7 C210 C116 L202 C216 C2 6 0 C2 4 8 C2 5 8 F1 0 3 C2 5 9 C212 C205 C209 C2 4 7 C217 C221 F1 0 0 F1 0 1 C1 2 9 C1 2 3 TA 1 0 0 CPL1 0 0 C117 C1 3 6 C1 1 1 C1 1 0 C114 R107 R104 R1 0 5 R106 R10 0 C102 R102 C1 3 7 L100 C100 C1 0 6 C1 0 5 PAM1 0 0 R1 1 2 C122 L111 C1 3 4 C1 3 0 C107 C120 TCX100 C1 1 5 C108 R1 0 3 C112 L102 C1 3 5 C109 C1 2 4 R1 0 9 R111 C113 R1 0 8 C233 L1 0 1 C1 2 6 L1 1 4 C128 C238 DUF100 R110 L103 L1 0 4 L112 L1 0 5 L115 L1 0 7 L207 L1 0 8 L116 L1 1 0 L205 L106 C241 C240 C254 L109 C2 2 6 C2 4 4 L2 0 4 R2 0 4 C2 3 9 C242 C1 2 7 C246 F1 0 2 L206 C1 2 1 C218 R101 RFS1 0 0 C259 OUT 2G G 5 F200 F2 0 0 RF_ON C262 UMTS_RX_P_2100 UMTS_RX_M_2100 C263 OUT IN PAM101 C261 1 C254 U201 C253 C248 3 9-47 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-18. WCDMA Transmitter TX ON (23dBm) C100 < 21dBm No Resolder RFS100 or Change RFS100 Yes No C115 < 0.5V C110 > 1.2V C111 < 0.5V Check UCP300 Yes No C133 < 0.5V C132 < 0.5V C131 > 2.2V Check UCP300 Yes L111 < 22dBm No Resolder PAM100 or Change PAM100 Yes No C126 <24dBm Resolder DUF100 or Change DUF100 Yes No C125 <26dBm Resolder CPL100 or Change CPL100 Yes No Resolder F103 or Change F103 C117 < 2dBm Yes No C116 < 5dBm Resolder PAM101 or Change PAM101 Yes Check U201 Yes END 9-48 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting C2 5 3 U201 C2 6 0 C2 4 8 F1 0 3 C2 5 9 C2 5 8 C216 C205 C209 C2 4 7 C217 C221 R1 0 5 F1 0 2 F1 0 0 F2 0 0 CPL1 0 0 PAM101 TP_ SLEEP_ CLK_ OUT UCP300 U5 0 9 C300 C322 TP_TX_AGC_ADJ R6 0 3 R726 C1 2 9 C1 0 5 R605 C1 0 6 R532 C345 TA 1 0 0 C559 C100 R101 TP3 1 1 C55 8 C1 3 6 R102 L100 C1 3 7 R528 R3 2 5 C537 C1 3 1 R530 C1 3 3 C539 C551 R107 R104 R10 0 C309 C1 3 2 C5 4 6 C544 C114 R106 C102 C452 C1 2 3 C1 1 1 PAM1 0 0 R1 1 2 C122 L111 C1 3 4 C1 3 0 C1 1 0 C107 C120 C117 TCX100 C1 1 5 C108 R1 0 3 R1 0 9 C112 L102 C1 3 5 C109 C1 2 4 C1 2 6 L1 1 4 R111 C113 R1 0 8 C233 L1 0 1 C238 DUF100 R110 C128 L103 L1 0 4 L112 L1 0 5 L115 L1 0 7 L207 L1 0 8 L116 L1 1 0 L205 L106 C241 C240 C254 L109 C2 2 6 C2 4 4 L2 0 4 R2 0 4 C2 3 9 C242 C1 2 7 C246 F1 0 1 L206 C1 2 1 C218 R521 C116 C212 RFS1 0 0 R2 0 6 C2 5 7 C210 L202 C321 C346 C557 C326 D7 0 3 U7 0 4 C305 C306 TP308 TP3 0 0 U507 R525 TP3 0 9 R524 R5 1 8 R7 2 5 R519 TP306 TP3 1 0 C540 R538 R526 9-49 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-20. Bluetooth Part BT Connection disable No Check BT function ON Enable BT function Yes C215 > 2.5V ? No Check the circuit connected to U401 and Check the U401 No Check the circuit connected to U401 and Check the U401 Yes R203 = 32.768KHz ? Yes Check the assembled staus of ANT 200 No Resolder or change ANT200 Yes Exchange U200 END 9-50 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting ANT200 C202 L200 FM_RADIO_ANT 1 2 3 L201 C203 VREG_BT_2.85V C214 8 9 10 23 VDDR5V 22 VDDR3V 14 FM_ANT PCM_IN PCM_OUT PCM_CLK PCM_SYNC U200 I2C_CK I2C_DA WLAN_RF_ACTIVE WLAN_TX_CONFX WLAN_STATUS LPO_IN INTX VIO RESET VREG_CTL VAFL|VAFR VAFR|VAFL 25 24 26 27 PCM_DOUT PCM_DIN PCM_CLK PCM_SYNC 17 18 19 21 29 16 20 R203 SLEEP_XTAL_IN TP202 TP203 BT_RST_N BT_CONTROL GND 13 GND 15 GND 28 GND 31 GND 32 GND 33 GND 34 GND 35 GND 36 GND 37 GND 38 GND 39 GND R203 TP2 0 1 U200 A N T2 0 0 B A T4 0 0 D708 L2 0 3 C2 0 3 R415 R3 1 1 C439 C215 C4 4 0 C214 TP2 0 0 4 5 UART_RX UART_TX UART_CTS UART_RTS UART_WAKEUP BT_WAKEUP C215 11 TP201 30 1 2 3 6 7 BT_ANT 12 L203 D709 9-51 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-52 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 10. Reference data Reference Abbreviation - AAC: Advanced Audio Coding. - AVC : Advanced Video Coding. - BER : Bit Error Rate - BPSK: Binary Phase Shift Keying - CA : Conditional Access - CDM : Code Division Multiplexing - C/I : Carrier to Interference - DMB : Digital Multimedia Broadcasting - EN : European Standard - ES : Elementary Stream - ETSI: European Telecommunications Standards Institute - MPEG: Moving Picture Experts Group - PN : Pseudo-random Noise - PS : Pilot Symbol - QPSK: Quadrature Phase Shift Keying - RS : Reed-Solomon - SI : Service Information - TDM : Time Division Multiplexing - TS : Transport Stream 10-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Reference data 10-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 11. Disassembly and Assembly Instructions 11-1. Disassembly Instructions 1 1) Unscrew 6 points in the rear case. 2 1)After EAR COVER with picture does OPEN Separate upper/lower column each 2POINTs' LOCKER. 1) Notice the rear case should not be damaged or 1) Notice the rear case should not be damaged or scratched. 3 scratched. Separate REAR after separate left/right each 4 Separate volume key, camera key,power on key. 2 POINTs' LOCKER. 1) Notice the rear case should not be damaged or scratched. 11-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 5 1)Volume KEY,camera KEY FPCB does take off. 1)Observe to FPCB's that get taken, that tear. 7 6 1)Separate camera connector. 2)Separate camera module in Bracket. 1)Observe to FPCB's that get taken, that tear. After ACTUATOR of TSP FPCB connector does 8 OPEN, TSP FPCB does take off. 1) Use decomposition groove take off the motor. 2) Do motor take off in motor connector. 1)Take care so that parts breakdown may not occur. 2)Observe to FPCB's that get taken, that tear. 1)Take care so that motor wire may not damage. 1)Notice the body should not be damaged or scratched. 11-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 9 Intenna wire does take off. 1)Take care so that Intenna wire may not be damaged. 11 10 Lift PBA, separate connector after does take off. 1)Take care so that parts breakdown may not occur. 2)Observe to FPCB's that get taken, that tear. Unscrew 3 POINTs. 12 Separate Intenna and Intenna wire. 1)Take care so that Intenna wire may not be damaged. 11-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 13 1)Separate LCD ASS'Y lifting LCD ASS'Y. 1)Take care so that LCD may not be damaged. 2)Take care so that TSP FPCB may not be damaged. 11-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 11-2. Assembly Instructions 1 1)Connect LCD CONNECTOR. 2 1)After put PBA, put speaker & ear jack connector. 2)Assemble INTENNA WIRE. 1)Connect so that connector may be sonant. 3 1)Press so that Intena may not grow restless once more. 1) Screw PBA 2 points. 2) Attach SIDE KEY class. 4 1) Pass TSP FPCB in BRACKET's groove. 2) Set microphone 3) Set LCD ASS'Y 1) Notice the FPCB not be damaged. 1) Notice the FPCB not be damaged. 2) Make MIC be arrived correctly in the groove. 11-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 5 1) SET QCIF camera in the groove. 6 2) SET MEGA camera in the groove. 1) Sets to standard SILK line and inserts TSP FPCB. 2)After Connect MOTOR, Set Motor in the 3) Connect the Camera groove. 3) Arranges Motor wire. 1) Make TSP FPCB be inserted perfectly. 1) Notice the FPCB not be damaged 2)Take care so that motor wire may not lean under board. 7 1) SET Power on key, Camera key. 8 1) Put REAR via the top portion. 2) Insert volume key. 3) Assemble REAR. 1) Notice the rear case should not be damaged or 1)Observe on direction of side key scratched. 2)Assemble to take all to HOOK. 11-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 5 1) Screw 6 points in the rear case. 1) Notice the rear case should not be damaged or scratched. 11-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Disassembly and Assembly Instructions 11-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization