No category

Download SERVICE MANUAL

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

Transcript

HBD-E370/E470/
E570/E870/T57
SERVICE MANUAL
US Model
HBD-E370/E570/T57
Canadian Model
Ver. 1.0 2010.02
HBD-E370/E470/E870
AEP Model
UK Model
HBD-E370/E870
Photo: HBD-E370
• HBD-E370 is the amplifier, video, BD/DVD/Super Audio CD/CD
system, USB, LAN and tuner section in BDV-E370.
• HBD-E470 is the amplifier, video, BD/DVD/Super Audio CD/CD
system, USB, LAN and tuner section in BDV-E470.
• HBD-E570 is the amplifier, video, BD/DVD/Super Audio CD/CD
system, USB, LAN and tuner section in BDV-E570.
• HBD-E870 is the amplifier, video, BD/DVD/Super Audio CD/CD
system, USB, LAN and tuner section in BDV-E870.
• HBD-T57 is the amplifier, video, BD/DVD/Super Audio CD/CD
system, USB, LAN and tuner section in BDV-T57.
Model Name Using Similar Mechanism
BDP-S370
Mechanism Type
BPX-5
Optical Pick-up Block Name
KEM-460AAA
SPECIFICATIONS
Amplifier Section
U.S. models:
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION:
(FTC)
Front L + Front R:
With 3 ohms loads, both
channels driven, from 180
- 20,000 Hz; rated 60 watts
per channel minimum
RMS power, with no more
than 1% total harmonic
distortion from 250 milli
watts to rated output.
Other models:
POWER OUTPUT (rated)
Front L/Front R:
108 W + 108 W (at 3 ohms,
1 kHz, 1% THD)
HBD-E370:
POWER OUTPUT (reference)
Front L/Front R/Center/Surround L/Surround R:
142 W (per channel at 3
ohms, 1 kHz)
Subwoofer:
140 W (at 3 ohms, 80 Hz)
HBD-E870/HBD-E570/HBD-E470/HBD-T57:
POWER OUTPUT (reference)
Front L/Front R/Center/Surround L/Surround R:
167 W (per channel at 3
ohms, 1 kHz)
Subwoofer:
165 W (at 3 ohms, 80 Hz)
Inputs (Analog)
AUDIO (AUDIO IN)
Sensitivity: 450/250 mV
Inputs (Digital)
SAT/CABLE (COAXIAL), TV (OPTICAL)
Supported formats: LPCM
2CH (up to 48 kHz), Dolby
Digital, DTS
Video Section
Outputs
VIDEO: 1 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
PB/CB, PR/CR: 0.7 Vp-p
75 ohms
HDMI OUT: Type A (19
pin)
Tuner Section
System
FM tuner section
Tuning range
North American models:
87.5 MHz - 108.0 MHz
(100 kHz step)
Other models:
87.5 MHz - 108.0 MHz
(50 kHz step)
Antenna (aerial)
FM wire antenna (aerial)
Antenna (aerial) terminals 75 ohms, unbalanced
Intermediate frequency
10.7 MHz
General
Power requirements
North American model:
Other models:
BD/DVD/Super Audio CD/CD System
Signal format system
NTSC (US and
Canadian models)
PAL/NTSC (AEP and
UK models)
Power consumption
Dimensions (approx.)
USB Section
(USB) port:
Maximum current:
Type A (For connecting
USB memory, memory
card reader, digital still
camera, and digital video
camera)
500 mA
PLL quartz-locked digital
synthesizer
Mass (approx.)
120 V AC, 60 Hz
220 - 240 V AC,
50/60 Hz
On: 170 W
Standby: 0.3 W (at the
Power Saving mode)
430 mm × 85 mm × 335
mm (17 in × 3 3/8 in ×
13 1/4 in) (w/h/d) incl.
projecting parts
4.8 kg (10 lb 10 oz)
Design and specifications are subject to change
without notice.
LAN Section
LAN (100) terminal
100BASE-TX Terminal
BLU-RAY DISC/DVD RECEIVER
9-889-770-01
Sony Corporation
2010B05-1
© 2010.02
Audio&Video Business Group
Published by Sony Techno Create Corporation
HBD-E370/E470/E570/E870/T57
• This product incorporates copyright protection technology that is protected by
U.S. patents and other intellectual property rights.
Use of this copyright protection technology must be authorized by Macrovision,
and is intended for home and other limited viewing uses only unless otherwise
authorized by Macrovision.
Reverse engineering or disassembly is prohibited.
• This system incorporates with Dolby* Digital and Dolby Pro Logic (II) adaptive
matrix surround decoder and the DTS** Digital Surround System.
* Manufactured under license from Dolby Laboratories.
Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby Laboratories.
**Manufactured under license under U.S. Patent #’s:
5,451,942; 5,956,674; 5,974,380; 5,978,762; 6,226,616; 6,487,535;
7,212,872; 7,333,929; 7,392,195; 7,272,567 & other U.S. and worldwide
patents issued & pending. DTS is a registered trademark and the DTS logos,
Symbol, DTS-HD and DTS-HD Master Audio are trademarks of DTS, Inc.
© 1996-2008 DTS, Inc. All Rights Reserved.
• This system incorporates High-Definition Multimedia Interface (HDMI™) technology.
HDMI, the HDMI logo and High-Definition Multimedia Interface are trademarks
or registered trademarks of HDMI Licensing LLC.
• Java and all Java-based trademarks and logos are trademarks or registered trademarks of Sun Microsystems, Inc.
• “BD-LIVE” and “BONUSVIEW” are trademarks of Blu-ray Disc Association.
• “Blu-ray Disc” is a trademark.
• “Blu-ray Disc,” “DVD+RW,” “DVD-RW,” “DVD+R,” “DVD-R,” “DVD
VIDEO,” and “CD” logos are trademarks.
• “BRAVIA” is a trademark of Sony Corporation.
• “AVCHD” and the “AVCHD” logo are trademarks of Matsushita Electric Industrial Co., Ltd. and Sony Corporation.
• “S-AIR” and its logo are trademarks of Sony Corporation.
•
, “XMB,” and “xross media bar” are trademarks of Sony Corporation and Sony
Computer Entertainment Inc.
• “PLAYSTATION” is a trademark of Sony Computer Entertainment Inc.
• DivX®, DivX Certified® and associated logos are registered trademarks of DivX,
Inc. and are used under license. (Except for U.S. models.)
• Music and video recognition technology and related data are provided by Gracenote®.
Gracenote is the industry standard in music recognition technology and related
content delivery. For more information, please visit www.gracenote.com.
CD, DVD, Blu-ray Disc, and music and video-related data from Gracenote, Inc.,
copyright © 2000-present Gracenote.
Gracenote Software, copyright © 2000-present Gracenote. One or more patents
owned by Gracenote apply to this product and service. See the Gracenote website
for a nonexhaustive list of applicable Gracenote patents. Gracenote, CDDB,
MusicID, MediaVOCS, the Gracenote logo and logotype, and the “Powered by
Gracenote” logo are either registered trademarks or trademarks of Gracenote in
the United States and/or other countries.
This appliance is classified as a
CLASS 1 LASER product. This
marking is located on the rear
exterior.
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
FLEXIBLE CIRCUIT BOARD REPAIRING
• Keep the temperature of soldering iron around 270 °C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs,
screws, and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2 V AC range are suitable. (See
Fig. A)
To Exposed Metal
Parts on Set
SAFETY-RELATED COMPONENT WARNING!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE
PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
2
0.15 μF
1.5 kΩ
AC
voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
HBD-E370/E470/E570/E870/T57
TABLE OF CONTENTS
1.
SERVICING NOTES .............................................
2.
DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.
2-8.
2-9.
2-10.
2-11.
2-12.
Disassembly Flow ...........................................................
Case (EZ) ........................................................................
MB-134 Board ................................................................
Bracket (MB) Block........................................................
Fuse (F901), POWER Board ..........................................
Front Panel Block ...........................................................
CONNECT Board ...........................................................
BD Drive (BPX-5) ..........................................................
Back Panel Block ............................................................
MAIN Board ...................................................................
AUDIO Board .................................................................
Optical Device (KEM-460AAA), Wire (Flat Type) .......
3.
TEST MODE ............................................................ 18
4.
ELECTRICAL CHECK ......................................... 27
5.
DIAGRAMS
5-1.
5-2.
5-3.
5-4.
5-5.
5-6.
Block Diagram - SERVO Section - ................................
Block Diagram - MEMORY Section -............................
Block Diagram - TUNER, S-AIR Section -....................
Block Diagram - AUDIO Section -.................................
Block Diagram - REGULATOR Section -......................
Block Diagram
- PANEL, POWER SUPPLY Section - ...........................
Schematic Diagram - MB-134 Board (1/13) - ................
Schematic Diagram - MB-134 Board (2/13) - ................
Schematic Diagram - MB-134 Board (3/13) - ................
Schematic Diagram - MB-134 Board (4/13) - ................
Schematic Diagram - MB-134 Board (5/13) - ................
Schematic Diagram - MB-134 Board (6/13) - ................
Schematic Diagram - MB-134 Board (7/13) - ................
Schematic Diagram - MB-134 Board (8/13) - ................
Schematic Diagram - MB-134 Board (9/13) - ................
Schematic Diagram - MB-134 Board (10/13) - ..............
5-7.
5-8.
5-9.
5-10.
5-11.
5-12.
5-13.
5-14.
5-15.
5-16.
4
11
11
12
13
13
14
14
15
15
16
16
17
28
29
30
31
32
33
35
36
37
38
39
40
41
42
43
44
5-17.
5-18.
5-19.
5-20.
5-26.
5-27.
5-28.
5-29.
5-30.
5-31.
5-32.
5-33.
5-34.
5-35.
5-36.
5-37.
5-38.
5-39.
5-40.
Schematic Diagram - MB-134 Board (11/13) - ..............
Schematic Diagram - MB-134 Board (12/13) - ..............
Schematic Diagram - MB-134 Board (13/13) - ..............
Printed Wiring Board
- MB-134 Board (Component Side) - .............................
Printed Wiring Board
- MB-134 Board (Conductor Side) - ...............................
Printed Wiring Board - AUDIO Board - .........................
Schematic Diagram - AUDIO Board - ............................
Printed Wiring Board
- MAIN Board (Component Side) - ................................
Printed Wiring Board
- MAIN Board (Conductor Side) - ..................................
Schematic Diagram - MAIN Board (1/5) - .....................
Schematic Diagram - MAIN Board (2/5) - .....................
Schematic Diagram - MAIN Board (3/5) - .....................
Schematic Diagram - MAIN Board (4/5) - .....................
Schematic Diagram - MAIN Board (5/5) - .....................
Printed Wiring Board - CONNECT Board - ...................
Schematic Diagram - CONNECT Board -......................
Printed Wiring Board - REG Board -..............................
Schematic Diagram - REG Board - ................................
Printed Wiring Board - FL Board - .................................
Schematic Diagram - FL Board - ....................................
Printed Wiring Board - POWER Board -........................
Schematic Diagram - POWER Board - ..........................
Printed Wiring Boards - KEY Section - ..........................
Schematic Diagram - KEY Section - ..............................
6.
EXPLODED VIEWS
6-1.
6-2.
6-3.
6-4.
6-5.
Case, Front Panel Section ...............................................
MB-134 Board Section ...................................................
Back Panel Section .........................................................
MAIN Board Section ......................................................
BD Drive Section (BPX-5) .............................................
7.
ELECTRICAL PARTS LIST .............................. 96
5-21.
5-22.
5-23.
5-24.
5-25.
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
59
60
61
62
63
64
65
66
66
91
92
93
94
95
3
HBD-E370/E470/E570/E870/T57
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by
the charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
RELEASING THE DISC TRAY LOCK
The disc tray lock function for the antitheft of an demonstration
disc in the store is equipped.
Releasing Procedure:
1. Press the [?/1] button to turn on the system.
2. Press the [FUNCTION] button to select “BD/DVD”.
3. Press the [x] and [Z] buttons simultaneously and hold down
unit “DEMO OFF” displayed on the fluorescent indicator tube
(around 5 seconds).
Note: When “DEMO ON” is displayed, the disc tray lock is not released
by turning power on/off with the [?/1] button.
ABOUT THE LENS CLEANING
Do not do the lens cleaning with the cotton bud etc. It causes the
trouble.
4
NOTE THE IC101, IC104, IC105, IC204, IC205, IC307,
IC311, IC501 AND IC502 ON THE MB-134 BOARD
REPLACING
IC101, IC104, IC105, IC204, IC205, IC307, IC311, IC501 and
IC502 on the MB-134 board cannot exchange with single. When
these parts are damaged, exchange the entire mounted board.
TEST DISC
Part No.
Description
Layer
J-6090-199-A
BLX-104
Single Layer
J-6090-200-A
BLX-204
Dual Layer
J-2501-307-A
CD (HLX-A1)
J-2501-305-A
HLX-513
Single Layer (NTSC)
J-2501-306-A
HLX-514
Dual Layer (NTSC)
J-6090-077-A
HLX-506
Single Layer (PAL)
J-6090-078-A
HLX-507
Dual Layer (PAL)
Note: Refer to the service manual of BDP-BX1/S350 (Part No. 9-883989-1[]) (page 1-3 to 1-14E) for the use of BLX-104/204.
Operation and Display:
1. BLX-104
Procedure:
1. Select 23.976Hz/1080p.
2. Play “4.Motion picture”.
3. Check whether player can play back or not.
4. Check each outputs.
Video:
Composite/S Video/component/HDMI.
Audio:
Speaker out.
* When 1080/24p monitor is nothing, 1080i (59.94Hz or 50Hz)
can use instead of 1080/24p.
However this is temporary correspondence.
2. BLX-204
Procedure:
1. Select 1080i (59.94Hz or 50Hz).
2. Play “4.Motion picture”.
3. Check whether player can play back or not (Check the picture
and sound output).
3. CD (HLX-A1)
Procedure:
Check whether player can play back or not (Check the sound output).
4. HLX-513/514 (NTSC), HLX-506/507 (PAL)
Procedure:
1. After displayed Main Menu, select “1.Video Signal”.
2. Play “1.Color bar 100%” (Check the picture and sound output).
3. Return to Menu.
4. Play “Demonstration 4:3” or “Demonstration 16:9” (Check the
picture and sound output).
HBD-E370/E470/E570/E870/T57
CAPACITOR ELECTRICAL DISCHARGE PROCESSING
When checking the board, the electrical discharge is necessary for
the electric shock prevention.
Connect the resistors referring to the figure below.
•
MAIN board (C3115, C3125, C3215, C3315, C3415, C3425)
Both ends of CN3001.
– MAIN Board (Conductor Side) –
4
1
CN3001
800 :/2 W
C3415
C3425
•
C3215
C3315
C3115
C3125
POWER board (C903, C932, C933)
Both ends of respective capacitors.
– POWER Board (Conductor Side) –
800 :/2 W
1. Preparation
1-1. ESD Countermeasure
It is necessary to confirm the state of static electricity in the work
space before the repair is started.
The static electricity resistance of the BD laser is weaker than that
of the DVD/CD laser.
Do work space and worker’s ESD countermeasures to prevent destruction by ESD.
1-2. Jig
• Digital camera (Recommend with macro mode)
• USB memory
• PC
• Barcode decoder (Refer to “1-3. Barcode decoder
(BDBUDEC)”)
1-3. Barcode decoder (BDBUDEC)
Part No. : J-6090-212-A
Jig name : BDBUDec.exe
Release : 2009.02.19
Version : 1.0.0.0
Software contents :
• BDBUDec.exe : Barcode decoder software
• SavePath.ini
: Decoded file destination setting file (Initial destination is “C:\BuData.txt”)
• TasmanBars.dll : Decode dll
• Uninst.exe
: Uninstall the “BDBUDec.exe” from PC
C903
800 :/2 W
C932 C933
800 :/2 W
NOTE OF REPLACING THE OPTICAL DEVICE (KEM460AAA) OR MB-134 BOARD
Optical device (KEM-460AAA) for BD requires precise read out
functions and secure contents protection system for more than past
DVD/CD.
Therefore, in the case repaired as follows, the writing work of the
OP data is necessary.
•
•
•
When the optical device (KEM-460AAA) is replaced (The
MB-134 board doesn’t replace).
When both the optical device (KEM-460AAA) and MB-134
board are replaced.
When the MB-134 board is replaced (The optical device
(KEM-460AAA) doesn’t replace) (In this case, do the work of
“3. Optical device (KEM-460AAA) replacement” other than
the replacement of new optical device).
Install procedure:
1. Unzip the barcode decoder files to any PC folder.
2. Check the taken barcode photo click & drop onto “BDBUDec.
exe”.
When the barcode decoder is used for the first time, the password is necessary. It is unnecessary since the second times.
Note 1: The password will be supplied to only service headquarters, and
service center name/q’ty/all of software registered information
should be maintained by service headquarters.
Note 2: Do not change the decoded file name “BuData.txt”.
3. When “.NET frame work requirements” is displayed, download following applications from Microsoft download site.
•
Microsoft .NET Framework Version 2.0 Redistributable Package (x86)
http://www.microsoft.com/downloads/details.aspx?displaylan
g=en&FamilyID=0856eacb-4362-4b0d-8edd-aab15c5e04f5
•
Microsoft .NET Framework 2.0 Service Pack 1 (x86)
http://www.microsoft.com/downloads/details.aspx?displaylan
g=en&FamilyID=79bc3b77-e02c-4ad3-aacf-a7633f706ba5
Note: The servo adjustment is done while writing the OP data. The manual
adjustment is unnecessary.
LD ON TIME history doesn’t carry over.
Do not touch any optical block parts, turn table and during replacing. BD laser diode is very sensitive.
5
HBD-E370/E470/E570/E870/T57
2. Pass-fail judgment of the optical device (KEM-460AAA)
Perform pass-fail judgment to judge whether the repair of the optical device (KEM-460AAA) is necessary.
2-1. Flow of drive section check
Confirm whether
BD (BLX-104) can be
reproduced
NO
YES
Confirm whether the
drive voltage is the
following values
CN301 pin 2 : 12 V
CN301 pin 6 : 5 V
NO
Confirm PS301 to
PS304 on the MB-134
board, and replace it
when it has been
damaged
YES
Confirm OP FFC cable
(Part No. 1-837-494-11)
and SPDL FFC cable
(Part No. 1-837-495-11),
and replace it when it
has been damaged
NO
Confirm whether the
optical device IOP
is normal in the
service mode
(Refer to “2-2. Flow
of optical device
IOP check”)
NO
Repalece the
optical device
(KEM-460AAA)
(Refer to “3. Optical
device (KEM-460AAA)
replacement”)
Then, confirm whether
this set operates
normally
YES
OK
Confirm whether
DVD (HLX-513)/
CD (HLX-A1) can be
reproduced
NO
Note: Refer to “2-12. OPTICAL DEVICE (KEM-460AAA), WIRE (FLAT TYPE)” (page 17) about how to remove the FFC HOLDER (REAR).
2-2. Flow of optical device IOP check
Turn the power on,
and change function
to “BD/DVD”
Press the buttons on
the remote commander
in order of [RETURN],
[0], [2], [1] [SUBTITLE],
and enter the service
mode
Press the buttons on
the remote commander
in order of [8], [7], [3],
[ENTER], and the
dIOP value is displayed
6
Confirm whether
value is the
specification value
Specification value:
BD: 6 mA
DVD/CD: 9 mA
YES
OK
NO
Repalece the
optical device
(Refer to “3. Optical
device (KEM-460AA)
replacement”)
HBD-E370/E470/E570/E870/T57
3. Optical device (KEM-460AAA) replacement
Flow of replacement:
Note: The photo in flow is an image.
Save the text data
to USB memory
(memory capacity
need not be 8GB)
Barcode label on
new optical device
(KEM-460AAA)
bottom side
Connect USB memory
with rear USB connector
on this set, and read the
text data by the service mode
Take photo (JPEG)
by digital camera
Change photo into
the text data with
the barcode decoder
Procedure:
1. Remove the INSULATOR (4 pieces) and broken optical device (KEM-460AAA) from LOADING ASSY.
2. Take photo of the barcode on new optical device (KEM460AAA) bottom side by digital camera.
7. Press the [FUNCTION] button to select “BD/DVD”.
8. Press the buttons on the remote commander in order of
[RETURN], [0], [2], [1], [SUBTITLE], and enter the service
mode.
9. Press the buttons on the remote commander in order of [8], [1],
[ENTER], and execute “[1] Drive OP data Write”.
10. Turn the power off after writing the OP data.
11. Turn the power on, and enter the service mode again.
12. Press the buttons on the remote commander in order of [8], [7],
[3], [ENTER], and the dIOP value is displayed.
13. Confirm value is the following specification value, and turn the
power off.
Specification value:
BD
: 6 mA
DVD/CD : 9 mA
3. Assemble the INSULATOR (4 pieces) to new optical device
(KEM-460AAA), fix (Torq0ue value: 2 kgf) it to LOADING
ASSY with screw, and assemble this set.
4. Drag & drop the taken photo by step 2 to “BDBUDec.exe”,
and make the text data (File name: BuData.txt).
5. Save the text data to USB memory.
6. Connect USB memory with rear USB connector on this set,
and turn the power on.
14. Turn the power on, confirm playback performance of the BD
(BLX-104)/DVD (HLX-513)/CD (HLX-A1).
15. Completely assemble this set, and complete the repair.
Rear USB connector
7
HBD-E370/E470/E570/E870/T57
NOTE THE BD DRIVE (BPX-5) PARTS REPLACING
The mechanism blocks except optical device of BD drive (BPX-5)
are chiefly composed of the following parts.
• CHUCK HOLDER ASSY
• LOADING ASSY
• HOLDER, FFC (REAR)
These parts are produced by two venders, it is not compatible.
Therefore, CHUCK HOLDER ASSY and LOADING ASSY are
supplied by one pair as repair parts. Please exchange both CHUCK
HOLDER ASSY and LOADING ASSY at the same time.
HOLDER FFC (REAR) need not be exchanged at the same time.
NOTE OF REPLACING THE THE IC3100, IC3200 AND
IC3400 ON THE MAIN BOARD AND THE COMPLETE
MAIN BOARD
When IC3100, IC3200 and IC3400 on the MAIN board and the
complete MAIN board are replaced, it is necessary to spread the
compound (THERMAL COMPOUND (G747)) (Part No. J-2501221-A ) between parts and heat sink.
Spread the compound referring to the figure below.
– MAIN Board (Component Side) –
IC3100
IC3200
IC3400
Note: The laser caution label is not pasted to LOADING FOR SERVICE
(Part No. A-1750-926-A). Please peel off an original laser caution
label, and paste it to LOADING FOR SERVICE when you use
LOADING FOR SERVICE.
LASER CAUTION LABEL
LOADING FOR SERVICE
CHUCK HOLDER ASSY
LOADING ASSY
IC3100
HOLDER, FFC (REAR)
MODEL IDENTIFICATION
– Rear Chassis –
Part No.
Model
Part No.
E370: AEP and UK models
4-161-684-1[]
E370: US model
4-161-685-1[]
E370: Canadian model
4-161-685-2[]
E470: Canadian model
4-161-686-1[]
E570: US model
4-161-684-3[]
E870: Canadian model
4-161-684-5[]
E870: AEP and UK models
4-161-686-5[]
T57: US model (for Costco)
4-161-686-0[]
8
IC3200
IC3400
HBD-E370/E470/E570/E870/T57
NOTE OF REPLACING THE D913, D931, IC901 AND IC921 ON THE POWER BOARD AND THE COMPLETE
POWER BOARD
When D913, D931, IC901 and IC921 on the POWER board and the complete POWER board are replaced, it is necessary to spread the
compound (THERMAL COMPOUND (G747)) (Part No. J-2501-221-A) between parts and heat sink.
Spread the compound referring to the figure below.
IC901
D913
– POWER Board
(Component Side) –
HS901
HS921
IC901
D913
IC921
HS931
D931
IC921
D931
9
HBD-E370/E470/E570/E870/T57
HOW TO OPEN THE TRAY WHEN POWER SWITCH TURN OFF
Note 1: After the case is removed, this mark is done.
Note 2: Please prepare the thin wire (clip etc.).
1 Remove the case.
(Illustration of disassembly is omitted.)
2
clip etc.
3
tray
PROCESSING OF HARNESS (USB)
– Top view –
10
HBD-E370/E470/E570/E870/T57
SECTION 2
DISASSEMBLY
•
This set can be disassembled in the order shown below.
2-1.
DISASSEMBLY FLOW
SET
2-2. CASE (EZ)
(Page 11)
2-6. FRONT PANEL BLOCK
(Page 14)
2-3. MB-134 BOARD
(Page 12)
2-7. CONNECT BOARD
(Page 14)
2-4. BRACKET (MB) BLOCK
(Page 13)
2-8. BD DRIVE (BPX-5)
(Page 15)
2-12. OPTICAL DEVICE
(KEM-460AAA),
WIRE (FLAT TYPE)
(Page 17)
2-5. FUSE (F901),
POWER BOARD
(Page 13)
2-9. BACK PANEL BLOCK
(Page 15)
2-10. MAIN BOARD
(Page 16)
2-11. AUDIO BOARD
(Page 16)
Note: Follow the disassembly procedure in the numerical order given.
2-2.
CASE (EZ)
6 case (EZ)
3
1 four screws
(BV3)
5 seven hooks
3
4
2 five screws
(BV/RING)
– Bottom view –
11
HBD-E370/E470/E570/E870/T57
2-3.
MB-134 BOARD
9 screw (BV3)
q; clamp
9 four screws (BV3)
qd MB-134 board
6 wire (flat type) (45 core)
(CN1401)
7 wire (flat type) (9 core)
(CN2460)
8 wire (flat type) (5 core)
(CN2470)
2 two connectors
(CN601, CN602)
4 wire (flat type) (18 core)
(CN902)
5 wire (flat type) (16 core)
(CN901)
qa screw (B3 u 5)
qs two screws (BV3)
1 connector (CN303)
3 wire (flat type) (27 core)
(CN1505)
12
HBD-E370/E470/E570/E870/T57
2-4.
BRACKET (MB) BLOCK
8 three screws (BV3)
1 power cord connector
(CN901)
3 power-supply cord (US, Canadian)
power cord (AEP, UK)
8 two screws (BV3)
9 bracket (MB) block
5 connector (CN400)
2 cord bush (2104)
7 screw
(BV3)
6 screw (P3 u 6)
4 connector (CN403)
2-5.
FUSE (F901), POWER BOARD
9 fuse label (T. H)
(AEP, UK)
7 eight screws
(BV3)
0 POWER board
1 glass fuse (DIA. 5) (8A/125V)
(F901) (US, Canadian)
fuse (H. B. C.) (T5AH/250V)
(F901) (AEP, UK)
4 bracket R (MB foot)
2 screw (BV3)
6 connector
(CN17)
5 connector
(CN904)
3
8 Remove the POWER board
from PC board holder.
13
HBD-E370/E470/E570/E870/T57
2-6.
FRONT PANEL BLOCK
Note: Please prepare the thin wire (clip etc.).
5 three screws
(BV3)
6 three ground plates (front)
7 three screws
(BV3)
q; connector
(CN700)
9
8 three claws
qa front panel block
8 two claws
2
7 three screws
(BV3)
8 three claws
1
3 claw
clip etc.
2-7.
4 loading panel assy
(10EZ)
CONNECT BOARD
3 four screws
(BV3)
5 CONNECT board
1 connector (CN301)
4
2 wire (flat type) (15 core)
(CN300)
four claws
14
3 three claws
HBD-E370/E470/E570/E870/T57
2-8.
BD DRIVE (BPX-5)
5 three screws (BV3)
0 four screws (BV3)
6 bracket (S-AIR UME)
qs sound sheet
qd BD drive (BPX-5)
1 screw (BV3)
7 screw (BV3)
3 bracket L (MB foot)
qa
9 bracket
(S-AIR foot)
2
4 screw (BV3)
8
2-9.
BACK PANEL BLOCK
2 three screws (BV3)
3 bracket (S-AIR UME)
7 screw (BV3)
4 wire (flat type) (9 core)
(CN10) (US, Canadian)
wire (flat type) (11 core)
(CN11) (AEP, UK)
1 screw (BV3)
7 two screws (BV3)
6 two screws (BV3)
7 screw (BV3)
5 fan connector
(CN3000)
7 screw (BV3)
8 back panel block
15
HBD-E370/E470/E570/E870/T57
2-10. MAIN BOARD
8 wire (flat type) (15 core)
(CN702)
q; wire (flat type) (16 core)
(CN703)
9 wire (flat type) (18 core)
(CN701)
7 wire (flat type) (15 core) (CN504) (US, Canadian)
wire (flat type) (17 core) (CN502) (AEP, UK)
qa four screws
(BV3)
qd six screws
(BV3)
qs heat sink
(S-master DDV)
qd two screws
(BV3)
5 wire (flat type) (27 core)
(CN505)
qf MAIN board
6 wire (flat type) (15 core)
(CN508)
1 screw
(BV3)
2
4 connector
(CN904)
3 bracket R
(MB foot)
2-11. AUDIO BOARD
6 three screws (BV3)
7 AUDIO board
1 screw (BV3)
4 connector
(CN17)
3 bracket L (MB foot)
2
16
5 wire (flat type) (15 core) (CN13) (US, Canadian)
wire (flat type) (17 core) (CN15) (AEP, UK)
HBD-E370/E470/E570/E870/T57
2-12. OPTICAL DEVICE (KEM-460AAA), WIRE (FLAT TYPE)
Note: Please prepare the thin wire (clip etc.).
4 chuck holder assy (D)
1 two screws
(BVTP 2.6)
3 two claws
2 two claws
qa insulator
7 two float screws (S)
qs optical device
(KEM-460AAA)
qh ffc holder (rear)
qk wire (flat type)
(45 core)
qa insulator
qa insulator
8
5 Insert the thin
wire (clip etc.).
9
qg
0
qd non-halogene tape
qf wire (flat type) (5 core)
qj wire (flat type)
(9 core)
qa insulator
6
loading assy (D)
– Bottom view –
,QVWDOODWLRQRIZLUHIODWW\SHFRUHDQGZLUHIODWW\SHFRUH
Note: This illustration sees the loading assy (D) from bottom side.
3 wire (flat type) (9 core)
4 Through the hole.
1 wire (flat type) (45 core)
Fold.
7 two claws
2 Through the hole.
5 ffc holder (rear)
boss
terminal face
Under the guide.
7 three claws
6
terminal face
loading assy (D)
Under the guide.
(Fold area)
boss
17
HBD-E370/E470/E570/E870/T57
SECTION 3
TEST MODE
COLD RESET
The cold reset clears data except BD/DVD data stored in the RAM
to initial conditions. Execute this mode when returning the set to
the customers.
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press the [x] and [VOLUME –] buttons simultaneously and
hold down (around 5 seconds).
3. The message “COLD RESET” appears on fluorescent indicator tube, then becomes standby states.
DEMO MODE
This mode let you lock the disc tray. When this mode is activated,
the disc will not eject when the [Z] button is pressed. The message
“LOCKED” will be displayed on the fluorescent indicator tube.
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press the [FUNCTION] button to select the “BD/DVD”.
3. Press the [x] and [Z] buttons simultaneously and hold down
until “DEMO ON” or “DEMO OFF” displayed on the fluorescent indicator tube (around 5 seconds).
S-AIR ID SETTING CHANGE
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press the [FUNCTION] and [VOLUME +] buttons simultaneously and hold down (around 5 seconds).
3. S-AIR ID setting is changed (A → B → C → A...).
PANEL TEST
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press button in order of the [RETURN] → [0] → [0] → [1]
→ [SUBTITLE] on the remote commander (Make the interval
when each button is pressed within two seconds).
3. All segments in fluorescent indicator tube are lighted up. And
half segments in fluorescent indicator tube are lighted up, others half segments in fluorescent indicator tube are lighted up,
then LEDs and all segments in fluorescent indicator tube are
lighted up. This operation is repeated.
4. When all segments in fluorescent indicator tube are lighted up
in the state of step 3, press the [VOLUME +] button on the
remote commander and model information is displayed on the
fluorescent indicator tube.
Each time the [VOLUME +] button on the remote commander
is pressed, the display changes from destination information,
STR version, SYS version, UI version, BDLIB version, ST
version, TA version, DSP version, TM version, CEC version,
SAIR version, PF version in this order, and returns to the model information display.
Each time the [VOLUME –] button on the remote commander
is pressed, the version and date are switched.
5. In the state of step 3, press the [FUNCTION] button on the
remote commander and “K 0” is displayed on the fluorescent
indicator tube.
“K 0” value increases whenever a button on the set is pressed.
However, once a button has been pressed, it is no longed taken
into account.
All buttons on the set are pressed, “OK” and “K 7” are alternately displayed on the fluorescent indicator tube.
6. To release from this mode, press the [?/1] button.
18
AMP TEST
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press button in order of the [RETURN] → [0] → [1] → [1]
→ [SUBTITLE] on the remote commander (Make the interval
when each button is pressed within two seconds).
3. The message “MEASURE” appears on the fluorescent indicator tube and enter the AMP test mode.
4. Press the [BLUE] button on the remote commander, the state
of D.C.A.C. microphone is displayed on the fluorescent indicator tube.
*** @@ $$$
***
: Either of “IN”/“NON” is displayed by the state of
detection of the microphone.
@@ : Either of “OK”/“NG” is displayed by the state of
digital audio data input.
$$$ : Microphone input audio data A/D value (0 – 255).
5. Press the [MUTING] button on the remote commander, “VOL
N” (The change in the volume is usual)/“VOL MSM” (The
change in the volume is a switch of MIN/1/20/MAX) can be
switched.
6. Press the [SUBTITLE] button on the remote commander, the
message “VACS ON” or “VACS OFF” appears on the fluorescent indicator tube and thus the VACS on/off are changed.
7. To release from this mode, press the [?/1] button.
BD SERVICE MODE
Note: The operation in this mode must use a remote commander.
Setting method of the BD service mode:
1. Press the [?/1] button to turn the power on.
2. Press button in order of the [RETURN] → [0] → [2] → [1] →
[SUBTITLE] on the remote commander. (Make the interval
when each button is pressed within two seconds)
3. Enter the BD service mode.
1. Main Functions
• ErrorLog display
Display the error log. Displayed contents can also be saved in
an USB memory device.
• Diag
Performs unit test of devices installed on the board.
• Factory Initialize
Restores the set to its factory settings.
• Network
Checks the wired network connection.
• Version Up (version update)
Not used.
• System Information
Displays the system information of the set.
Displays information such as the software version, drive information, etc.
• EMC Test Mode
Not used.
• Drive
Write drive OP data and check drive.
HBD-E370/E470/E570/E870/T57
2. Menu Tree
Service
Service Mode
Mode Menu
Menu
[1]
[1] Diag
Diag
[2]
[2] Log
Log
[3]
[3] Factory
FactoryInitialize
Initialize
[4]
Network
[4] Network
[5]
Version
Up
[5] Version Up
[6]
[6] System
System Information
Information
[7] EMC Test Mode
[8] Drive
Diag
'LDJ7HVW
Device Test
86%'$&,)FRQWHVW
Video Test
Video output test
$udio Test
$udio output test
$udio Input Test
$XGLR,QSXW7HVW
:LUHOHVV/$17HVW
Not used
Log
Displays Error Log
Error Log
Displays error log
Factory Initialize
5Hstores set to factory settings
Start Initialize
,QLWLDOL]HGHIDXOWVHWWLQJIRU%'SOD\HU
Start Initialize for TV
1RWXVHG
Network
1Htwork diagnosis for wired
Ifconfig
View network status
Ping
&RQILUPQHWZRUNFRQQHFWLRQ
Version Up
Not used
System Information
Displays system information
EMC Test Mode
Not used
Drive
Write drive OP data and check drive
19
HBD-E370/E470/E570/E870/T57
3. Service Mode Menu (Top Menu)
This is the top menu of service mode.
Each function is accessed from this screen.
Operation:
[1]
Moves to Diag screen
[2]
Moves to Log screen
[3]
Moves to Factory Initialize screen
[4]
Moves to Network screen
[5]
Moves to Version Up (DISC version update) screen (Not
used)
[6]
Moves to System Information screen
[7]
Moves to EMC test mode screen (Not used)
[8]
Moves to Drive screen
[M]/[m] Moves the cursor
[3]
Moves to the screen of the item selected with the cursor
• Device Test: List of devices
USB Host (*1)
*1) USB media check (front and rear). Only one time.
* For details concerning device test, see the Diag reference.
Diag
Category:
Device Test
Diag
Category: Device Test
Device: USB Host
Rear USB Media check ... OK
Front USB Media check ... OK
Checking...
*
Cursor is not displayed when the menu is first displayed.
(Screen 1)
Service Mode Menu
[1]
[1]Diag
Diag
[2] Log
[3] Factory Initialize
[4] Network
[5] Version Up
[6] System Information
[7] EMC Test Mode
[8] Drive
HELP : [DOWN] [ENT] [(NUM)]
HELP (currently available keys, etc.) is displayed
(Screen 2)
HELP: [RIGHT] [UP] [ENT] [RET]
5. Diag (Video/Audio Test)
This screen performs video and audio tests.
Screen 1: When video test category is selected
Operation:
[3]
Shows/hides the color bar
[M]/[RETURN] Returns to the selection of test category
Screen 2: When audio test category is selected
Operation:
[3]
Plays back/stops the tone sound
[M]/[RETURN] Returns to the selection of test category
4. Diag (Device Test)
This screen is used to test devices mounted on the board.
• Video test:
Outputs a color bar (composite & component & HDMI).
Screen 1: Selects the test category
Operation:
[<]/[,] Selects the category
[m]/[3] Moves to the selected category
• Audio test:
TONE sound output (speaker (8 ch) & HDMI (2 ch)).
Diag
Screen 2: Device test
Selects the device to test after selecting Device Test in screen 1.
Operation:
[<]/[,] Selects the device to test
[3]
Executes the test
[M]
Returns to selection of test category
Selects the cursor during IFCon and D terminal tests
[m]
Selects the cursor during IFCon and D terminal tests
• List of test categories
Device Test
Video Test
Audio Test
Audio Input Test
Wireless LAN Test (not used)
Category: Video Test
[ENT] Show Color Bar
Diag
Category: Audio Test
(Screen 1)
HELP: [UP][ENT][RET]
[ENT] Generate TONE Sound
(Screen 2)
20
HELP: [UP] [ENT] [RET]
HBD-E370/E470/E570/E870/T57
6. Diag (Audio Input Test)
This screen performs audio input test.
8. Log: Error Log (Output of each Log)
This screen displays the contents of each log.
Note: Do not refer to the displayed date.
Screen 1: Selects the test category
Operation:
[<]/[,] Selects the category
[m]/[3]
Moves to the selected category
Screen 2: Select Audio Input Test
Operation:
[M]/[m]
Select test
[3]
Start/stop input sound
[RETURN] Returns to the selection of test category
• Digital Input
Input
: SPDIF (optical, 48 kHz, 2 ch only).
Sound output
: Speaker (2 ch).
• Analog Input
Input
: Line In (2 ch).
Sound output
: Speaker (2 ch).
Diag
Category: Audio Input Test
Diag
Category: Audio Input Test
Device: Digital Input
Analog Input
[ENT] Start Input Sound
(Screen 1)
Screen 1: Selects log
Operation:
[1]/[3]
Moves to the Error Log output screen
[RETURN] Returns to the top menu of the service mode
Screen 2: Displays the Error Log
Operation:
[ <]
Returns to the previous page
[ ,]
Moves to the next page
[RETURN] Returns to the screen (screen 1) that selects the log
type
[RED]
Writes the log contents to an USB memory device
• Viewing the log display
Error Log:
001 08/01/01 00: 53: 19: [ErrCode: 080400000000]
[Number (starting from old log) ] [date] [time] [error code]
About copying log to USB memory device:
Press the [RED] button in each log display screen with the USB
memory device inserted into the set
Note: Please do not press the [RED] button immediately after USB memory is inserted.
Please do not pull out USB memory immediately after the [RED]
button was pressed.
Error Log:
When “getErrLogFile.trm file” exists in the USB memory device, errlog.log file is output.
HELP: [UP][ENT][RET]
Select Log
[1] Error Log
(Screen 2)
HELP: [UP] [ENT] [RET]
Error Log
001 08/01/01 00: 53: 19: [ErrCode: 080400000000]
002 08/01/01 00: 53: 45: [ErrCode: 080400252100]
003 08/01/01 00: 54: 00: [ErrCode: 080400005555]
:
:
7. Diag (Wireless LAN Test)
This screen performs wireless LAN test.
Note: Not used for the servicing.
(Screen 1)
HELP : [DOWN][ENT][(NUM)]
(Screen 2)
21
HBD-E370/E470/E570/E870/T57
9. Factory Initialize (Factory Settings)
Return all of the player setting to their factory defaults.
10. Network (Network Test Diagnosis Screen: Ifconfig)
Network menu for the wired ethernet.
Operation:
Screen 1
Press the [1] button in this screen when restoring the set to its factory settings.
All saved titles will also be deleted.
[1]
Start Factory Initialize
[2]
Start Factory Initialize for TV (Not used)
[M]/[m]
Moves the cursor
[3]
Activate the selected cursor
[RETURN] Returns to the top menu of the service mode
Screen 1: Ifconfig Test
Operation:
[3]
Activate Ifconfig (Display network setting)
[,]
Select ping test
[RETURN] Returns to the top menu of the service mode
Screen 2
It is a screen of the end of initialization.
[RETURN] Returns to the top menu of the service mode
To complete factory initialize, process COLD RESET subsequently.
Please disconnect AC power cord, and connect AC again. Then
press the [?/1] button to turn the power on, and press the [x] and
[VOLUME –] buttons simultaneously and hold down (around 5
seconds) to execute COLD RESET.
Screen 2: Ping Test
Operation:
[<]
Select Ifconfig test
[RETURN] Returns to the top menu of the service mode
(The details of a Ping test are “11. Network (Network Test Diagnosis Screen: Ping)”)
Screen 3: Ifconfig Test Active
Display Ifconfig command results.
Operation:
[3]
Ifconfig retry
[,]
Select ping test
[RETURN] Returns to the top menu of the service mode
Network
Test: Ifconfig Ping
Remove the AC power cord and insert the AC power cord again.
* Operations in other service menus can also be performed.
Network
Test: Ifconfig Ping
Ping To:
Factory Initialize
[1] Start Initialize
[2] Start Initialize for TV
[START]
[RET] Return to Top Menu
Network
HELP : [DOWN][ENT][(NUM)]
Test: Ifconfig Ping
Factory Initialize
Reboot to complete.
(Screen 1)
(Screen 1)
IP 192. 168. 11. 2 MAC 00-16-01-85-21-A3
(Screen 2)
HELP : [DOWN][ENT][(NUM)]
[RET] Return to Top Menu
(Screen 3)
(Screen 2)
22
HELP: [RET]
HELP : [ENT]: Re/Exe [RIGHT]
HBD-E370/E470/E570/E870/T57
11. Network (Network Test Diagnosis Screen: Ping)
Ping test for the wired ethernet.
Screen 1: Ping Test
Operation:
[<]
Select Ifconfig test
[m]
Ping execution preparation
[RETURN] Returns to the top menu of the service mode
Screen 2: The IP address of the Ping point is set up
(IP address input mode)
When “Ping to :>” is reversed, the [3] button is pressed and IP is
inputted.
Operation:
[3]
Finish to input
[RETURN] Finish to input
[<]
Finish to input and Select Ifconfig Test
[0] to [9] Input Character sting ‘0-9’
[TIME]
Input Character sting ‘.’
[CLEAR] Backspace
Screen 3: Ping Test Active
When [START] is reversed, the [3] button is pressed and execute
ping .
Operation:
Activate ping test
[3]
[M]
The IP address of the ping point is set up
[RETURN] Returns to the top menu of the service mode
Network
Test: Ifconfig
Ping
Ping To :
[START]
Network
Test: Ifconfig Ping
Ping to :> 192. 168. 200. 13
[ENT] : Release
[RET] : Release
Network
(Screen 1)
Test: Ifconfig Ping
Ping to : 192. 168. 200. 13
[START]
PING 192. 168. 200. 13 OK!
Screen 2: Drive Information Menu
Operation:
[<]
Basic Information displayed (go to screen 1)
[RETURN] Returns to the top menu of the service mode
When delta IOP is measured, it becomes impossible to use the Version Up function.
Contents List:
Model
Destination
Sequence Number
MAC
IP
IFCON
IFCON Version
Bootloader
Bootloader Version
Host Main
Host Main Version
Host Sub
Host Sub Version
Middleware
Middleware Version
ADSP
ADSP Version
IF Model
IF Dest
Drive
CD DIOP
DVD DIOP
BD DIOP
CD LD TIME
DVD LD TIME
BD LD TIME
Firm Revision
Delta IOP
Delta IOP
Delta IOP
LD Time
LD Time
LD Time
(Screen 1)
System Information
Model
:
Destination
:
Sequence Number
:
MAC
:
IP
:
IF-con Block0 Version :
Bootloader Version :
Host Main Version
:
Host Sub Version
:
Middleware Version :
ADSP Version
:
IF_MODEL
IF_DEST
Block1 Version :
:
:
HELP: [RET] [RIGHT]
(Screen 2)
(Screen 2)
System Information
(Screen 3)
HELP: [ENT] : Start [UP] [LEFT]
12. System Information (System Information Display)
This screen displays system information.
Screen 1: Basic Information
Operation:
[,]
Drive information (delta IOP of a drive is measured)
displayed (go to screen 2)
[RETURN] Returns to the top menu of the service mode
Drive Firm Revision
CD DIOP
DVD DIOP
BD DIOP
CD LD TIME
DVD LD TIME
BD LD TIME
:
:
:
:
:
:
:
HELP: [RET] [LEFT]
23
HBD-E370/E470/E570/E870/T57
13. Drive
This menu is used to operate the drive using drive-related diagnostic and tools.
Screen 1: Selecting items under *Service Menu
(Screen 1)
Screen 3: *Drive OP data Write
Purpose: Write OP data into flash IC
[M]/[m]
Move the cursor up and down
Start the selected cursor item
[3]
[RETURN] Returns to the top menu of the service mode
(Screen 3)
Service Menu
Drive OP data Write
[1] Diag
Insert USB StorageDevice...
[2] Log
Remove DISC and Close tray.
[3] Factory Initialize
[1]Disc: Eject
[4] Network
[ENT] Start
[5] Version Up
[6] System Information
[7] EMC Test Mode
[8] Drive
Screen 2: Selecting items under *Drive
(Screen 2)
Drive
[1]Drive OP data Write
[2]Servo Parameter Check Menu
Screen 4: *Servo Parameter Check Menu (Not Used)
(Screen 4)
Servo Parameter Check Menu
[1] Disc: Eject
[2] Show Parameters
[3]Servo Signal Check Menu
[4]S
- Curve Check Menu
[5]Readability Check Menu
[6]OP Position Check Menu
[7]OP Check Menu
[8]Load Eject Aging
[9]Spindle Control Check Menu
[10]FA Test Mode
Operation:
[M]/[m]
Move the cursor up and down
[3]
Open the selected cursor item
[RETURN] Returns to the top menu of the service mode
• Test item list
[1] Drive OP data Write
[2] Servo Parameter Check Menu
[3] Servo Signal Check Menu
[4] S-Curve Check Menu
[5] Readability Check Menu
[6] OP Position Check Menu
[7] OP Check Menu
[8] Load Eject Aging
[9] Spindle Control Check Menu
[10] FA Test Mode
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
Screen 5: *Servo Signal Check Menu (Not Used)
(Screen 5)
Servo Signal Check Menu
[1] Disc: Eject
[2] Servo Signal Monitor out: OFF
[3] RTADJ: OFF
[4] FocusBias: 0000
[5] SA -Act.move: FWD 00 step
[6] Pl Level: 0000
[7] RF Level: 0000
[8] TRV Level: 0000
[9] Current FB: 0000 SA: 0000
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
24
HBD-E370/E470/E570/E870/T57
Screen 6: *S-Curve Check Menu (Not Used)
(Screen 6)
S - Curve Check Menu
[1] Disc: Eject
[2] Media Type: BD
- ROM SL
[3] Layer: L0
[4] SLD move to Home
[5] SLD move: FWD 00 step
[6] FCS Search start
Screen 9: *OP Check Menu
Purpose: Verify OP related such as delta IOP and LD time
[M]/[m]
Move the cursor up and down
Start the selected cursor item
[3]
[RETURN] Returns to the top menu of the service mode
(Screen 9)
OP Check Menu
Remove DISC and Close tray
[1] Disc Eject
[2] OP Serial: xxxxxxxxxxxxxx
[3] dIOP
BD: x[xx]
DVD: x[xx]
CD: x[xx]
TEMP: xx.x deg
[4] LD ON Time
BD: xxxxh xxm
DVD: xxxxh xxm
CD: xxxxh xxm
Not used for the servicing.
Press the [RETURN] button if having entered this mode
Screen 7: *Readability Check Menu (Not Used)
(Screen 7)
Screen 10: *Load Eject Aging (Not Used)
(Screen 10)
Readability Check Menu
[1] Disc: Eject
[2] Address: 00000000
[3] Length: 0000
[4] Execute
Jitter P: 0000
Jitter PR: 0000
Jitter DC: 0000
SER: 0000 0000
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
Load Eject Aging
[1] Disc: Eject
[2] Repeat set: 00000
[3] Mecha type: Tray mecha
[4] Aging type: Normal
[5] Start
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
Screen 8: *OP Position Check Menu (Not Used)
(Screen 8)
Screen 11: *Spindle Control Check Menu (Not Used)
(Screen 11)
OP Position Check Menu
[1] Disc: Eject
[2] OP Position Check
Spindle Control Check Menu
[1] Disc : Eject
[2] rpm: 0000 rpm
[3] Spindle: OFF
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
25
HBD-E370/E470/E570/E870/T57
Screen 12: *FA Mode Test (Not Used)
3. CD (HLX-A1)
Procedure:
Check whether player can play back or not.
(Check the sound output)
(Screen 12)
FA Mode Test
[1] Enter Repeat FA mode
Repeat number: 0000
4. HLX-513/514 (NTSC), HLX-506/507 (PAL)
Procedure:
1. After displayed Main Menu, select “1.Video Signal”.
2. Play “1.Color bar 100%”.
(Check the picture and sound output)
3. Return to Menu.
4. Play “Demonstration 4:3” or “Demonstration 16:9”.
(Check the picture and sound output)
[2] Save FE log to USB
1-2. Playback operation confirmation
Confirm operation in each signal/output mode of test disc (BLX104/204) according to the content of the repair.
Note: “AV Sync.” doesn’t operate.
Not used for the servicing.
Press the [RETURN] button if having entered this mode.
2. Networking Confirmation
Confirm it according to the following procedure when you confirm
the connection of the network.
CONFIRMATION ITEM
1. Playback Operation Confirmation
1-1. Test Disc
Note: Do not execute “Network Connection Diagnostics” of “Network
Settings” of the home menu with only the router connected.
Part No.
Description
Layer
J-6090-199-A
BLX-104
Single Layer
J-6090-200-A
BLX-204
Dual Layer
J-2501-307-A
CD (HLX-A1)
J-2501-305-A
HLX-513
Single Layer (NTSC)
J-2501-306-A
HLX-514
Dual Layer (NTSC)
J-6090-077-A
HLX-506
Single Layer (PAL)
J-6090-078-A
HLX-507
Dual Layer (PAL)
Note: Refer to the service manual of BDP-BX1/S350 (Part No. 9-883989-1[]) (page 1-3 to 1-14E) for the use of BLX-104/204.
Operation and Display:
1. BLX-104
Procedure:
1. Select 23.976Hz/1080p.
2. Play “4.Motion picture”.
3. Check whether player can play back or not.
4. Check each outputs.
Video:
Composite/S Video/component/HDMI.
Audio:
Speaker out.
* When 1080/24p monitor is nothing, 1080i (59.94Hz or 50Hz)
can use instead of 1080/24p.
However this is temporary correspondence.
* When the output of HDMI is 1080p, the signal of Composite/S
Video/Component are not output.
It is necessary to lower the output of HDMI to 1080i or less.
2. BLX-204
Procedure:
1. Select 1080i (59.94Hz or 50Hz).
2. Play “4.Motion picture”.
3. Check whether player can play back or not.
(Check the picture and sound output)
26
Procedure:
1. Connect the router with the set with LAN cable.
2. Turn on the power of the set and the router.
3. Press the [HOME] button on the remote commander, and the
home menu is displayed.
4. Select “Setup” → “Network Settings” → “Internet Settings”,
and press the [3] button on the remote commander.
5. Select “View Networks Status” and press the [3] button on the
remote commander.
6. Confirm IP address are displayed in “IP Address”, “Subnet
Mask” and “Default Gateway”.
Physical Connection:
XXXX
Internet Access:
XXXX
IP Address Setting:
XXXX
IP Address:
XXX.XXX.XXX.XXX
Subnet Mask:
XXX.XXX.XXX.XXX
Default Gateway:
XXX.XXX.XXX.XXX
DNS Settings:
XXXX
Primary DNS:
XXX.XXX.XXX.XXX
Secondary DNS:
XXX.XXX.XXX.XXX
MAC Address:
XXX.XXX.XXX.XXX
HBD-E370/E470/E570/E870/T57
SECTION 4
ELECTRICAL CHECK
FM TUNER LEVEL CHECK
signal
generator
set
Procedure:
1. Turn on the set.
2. Input the following signal from Signal Generator to FM antenna
input directly.
Carrier frequency : A = 87.5 MHz, B = 98 MHz, C = 108 MHz
Deviation
: 75 kHz
Modulation
: 1 kHz
ANT input
: 35 dBu (EMF)
Note: Use 75 ohm coaxial cable to connect signal generator and the set.
You cannot use video cable for checking.
Use signal generator whose output impedance is 75 ohm.
3. Set to FM tuner function and tune A, B and C signals.
4. Confirm “TUNED” is lit on the display for A, B and C signals.
When the selected station signal is received in good condition,
“TUNED” is displayed.
HBD-E370/E470/E570/E870/T57
27
27
HBD-E370/E470/E570/E870/T57
SECTION 5
DIAGRAMS
5-1.
BLOCK DIAGRAM - SERVO Section 9,'(2$03
,&
%''5,9(
%3;
%'B5)
%'B5)
< )(B5),3
< )(B5),1
'9'B5)
'9'B5)
%''(&2'(5
,&
W1 )(B5),3
W3 )(B5),1
%
$
'
&
*
H
(
)
3
1
5
7
V6
8
5
7
)(B,1$
)(B,1%
)(B,1&
)(B,1'
)(B,1(
)(B,1)
)(B,1*
)(B,1+
6',2
6&/.
6(1B/''
7(67B9
9&B3'
7+(502
6$B,1,7
02'(B$
02'(B%
02'(B&
/'(1
$'
$(
$)
7
-
0
/
-
-
*
*
)(B&)5(4
)(B262(1
)(B&02'
)(B)3'2'9'
)(B+$9&
)(B$8;
)(B9'$&
)(B*,2
)(B*,2
)(B*,2
)(B*,2
)(B03;287 /
)(B03;287 .
)(B*,2 (
. 16B5),3
+ 16B5),1
) 16B&.,1
&1
52
53
55
56
6/('B3
6/('B1
6/('B3
6/('B1
W
V
8
&20021
8
V
W
0&20
/2$'
/2$'
32 /2$'B3
33 /2$'B1
75
7'
29 75.B3
30 75.B1
)'
)5
27 )&6B3
28 )&6B1
)'
)5
7/7B3
25 7/7B1
$0 86%B'3
$/ 86%B'0
16
17
18
19
20
21
22
$)
$(
$)
$(
$+
$'
$0
)(B)02
)(B)02
)(B'02
)(B75$<3:0
)(B752
)(B)22
)(B7/2
;)*
021,725
;087(
;087(
*&
11
12
13
15
*
$*
$'
$*
$'
)(B)*
)(B/,0,7
)(B*,2
)(B*,2
)(B*$,16:
75$<,1
75$<287
673
673
673
673
673B,1 8
673B,1 9
67(3B(1$ 7
$) )(B)02
$* )(B)02
3<RXW 10
<
3ERXW 11
3%&%
3URXW 13
35&5
70'6'$7$
70'6'$7$±
70'6'$7$
70'6'$7$±
70'6'$7$
70'6'$7$±
70'6&/2&.
70'6&/2&.±
HBD-E370/E470/E570/E870/T57
9
6
1
3
10
12
15
+3'
19
5(6(59('$5&
&1
+'0,
$5&287
16
0&,1 )
(7+(51(7,17(5)$&(
,&
/$1
6
5
2
1
28
29
31
32
7;1
7;3
5;1
5;3
X1201
25MHz
13 ;7$/
&/.,1
7;'
7;'
7;'
7;'
23
26
27
&
'
'
(
(77;'
(77;'
(77;'
(77;'
5;'
5;'
5;'
5;'
18
17
16
15
$
%
&
$
(75;'
(75;'
(75;'
(75;'
0',2
0'&
7;&/.
5;B&/.
7;B(5
5;B(5
7;B(1
&2/
&56
5;B'9
2
22
20
1
21
6
36
3
19
%
)
&
$
(
%
'
&
+
)
(70',2
(70'&
(77;&/.
(75;&/.
(77;(5
(75;(5
(77;(1
(7&2/
(7&56
(75;'9
13
&(&
:$9(
6+$3(5
,&
&1
(7+(51(7
&211(&725
&(&
$5&B63',)
'$7$B,
,5
9,1'
9,1'
9,1'
9,1'
9,1'
9,1'
9,1'
9,1'
%
(
'
$
)
(
$
*
%
',5B(5525
&6,B'$7$,1
&6,B'$7$287
&6,B&/.
&6,B;&6B',5
',5B;67$7(
',5B&6)/$*
',5B$8',2
',5B;567
63'$7$
630&/.
63%&.
63/5&.
*
&
$
%
63B'$7$
63B0&.
63B%&.
63B/5&.
$26'$7$
$26'$7$
$26'$7$
$26'$7$
$26'$7$
$20&/.
$2%&.
$2/5&.
&
*
H22
)
(
'
%
(
$26'$7$
$26'$7$
$26'$7$
$26'$7$
$26'$7$
$20&.
$2%&.
$2/5&.
$ (Page 31)
6,*1$/3$7+
$8',2
9,'(2
',6&3/$<
Q567 5
86%
$( )(B*$,16:
6<6&21B567
)(9
)(9
&20321(17
9,'(2287
7
6&/
6'$
+73/* *
$/ 86%B'3
$. 86%B'0
$- )(B75$<,1
$. )(B75$<287
16
17
18
19
'
%
&
$
'
%
&
$
9,'(2287
9RXW 15
9LQ
3<LQ
3ELQ
3ULQ
6'+'
0XWH
%8))(5
4
02725'5,9(55(*8/$725
,&
6$B%
6$B%
6$B$
6$B$
&+B3
&+B0
&+B3
&+B0
&+B3
&+B0
&/.B3
&/.B0
1
7
5
3
8
&1
3
2
96/('
96/('
963,1
9/2$'
975.
9)&6
97/7
'
&
%
$
*
+
+'0,6&. )
+'0,6' (
3
2
02725'5,9(5
,&
%
%
$
$
'$&287
'$&287
'$&287
'$&287
9,1'
9,1'
-
5(*39
22 5(*3[9
28
28
% (Page 30)
/$1
HBD-E370/E470/E570/E870/T57
5-2.
BLOCK DIAGRAM - MEMORY Section -
BD DECODER
IC101 (2/2)
X401
27MHz
X802
25MHz
A25 NS_XTALI
C25 NS_XTALO
FE_SFDO
FE_SFDI
FE_SFCLK
FE_SFCS#
E1
F2
C1
K6
A1
C3
D4
B2
FESFDO
FESFDI
FESFCK
FESFCS
STXP_1
STXN_1
SRXP_1
SRXN_1
VCLK25MI
BC3
BA3
BC1
BB2
AJ9
AR1
AR3
AN1
AP2
AJ3
FE_SRXP
FE_SRXN
FE_STXP
FE_STXN
FE_XTAL25MI
BB8 XTAL25MI
SD-RAM
IC104
A_RDQ0 - A_RDQ15
DQ0 - DQ15
B_RDQ0 - B_RDQ15
A_RA0 - A_RA13
A0 - A12, NC
L2
L3
L1
K3
L8
L7
K7
K9
K2
J8
K8
B3
B7
A8
F3
F7
E8
BB28
AU27
AT28
BC29
AV24
AU23
BB24
AW23
BA29
BC21
BA21
AV18
BC17
BA17
AT18
AY16
BB16
A_RBA0
A_RBA1
A_RBA2
A_RWEB
A_RCSB
A_RCASB
A_RRASB
A_RODT
A_RCKE
A_RCLK0
A_RCLK0B
A_RDQM1
A_RDQS1
A_RDQS1B
A_RDQM0
A_RDQS0
A_RDQS0B
SD-RAM
IC105
B_RA0 - B_RA13
A0 - A12, NC
BA0
BA1
BA2
/WE
/CS
/CAS
/RAS
ODT
CKE
CK
/CK
UDM
UDQS
/UDQS
LDM
LDQS
/LDQS
B_RA0 - B_RA13
B_RBA0
B_RBA1
B_RBA2
B_RWEB
B_RCSB
B_RCASB
B_RRASB
B_RODT
B_RCKE
B_RCLK0
B_RCLK0B
B_RDQM1
B_RDQS1
B_RDQS1B
B_RDQM0
B_RDQS0
B_RDQS0B
AD40
AD36
AC39
AC43
AD42
AH40
AJ41
AG41
AC41
AL43
AL41
AM36
AR43
AR41
AP38
AT40
AT42
L2
L3
L1
K3
L8
L7
K7
K9
K2
J8
K8
B3
B7
A8
F3
F7
E8
A_RDQ16 - A_RDQ31
A_RA0 A_RA13
A0 - A12, NC
L2
L3
L1
K3
L8
L7
K7
K9
K2
J8
K8
B3
B7
A8
F3
F7
E8
HBD-E370/E470/E570/E870/T57
BA39
BC39
AU35
BC35
BA35
AV34
BA33
BC33
A_RCLK1
A_RCLK1B
A_RDQM3
A_RDQS3
A_RDQS3B
A_RDQM2
A_RDQS2
A_RDQS2B
BA0
BA1
BA2
/WE
/CS
/CAS
/RAS
ODT
CKE
CK
/CK
UDM
UDQS
/UDQS
LDM
LDQS
/LDQS
L2
L3
L1
K3
L8
L7
K7
K9
K2
J8
K8
B3
B7
A8
F3
F7
E8
N41
N43
V36
U43
U41
V38
W41
W43
29
G43
M36
M38
P38
L37
K38
NFWEN
NFREN
NFCEN
NFRBN
NFALE
NFCLE
B_RCLK1
B_RCLK1B
B_RDQM3
B_RDQS3
B_RDQS3B
B_RDQM2
B_RDQS2
B_RDQS2B
29
LCDRD
VDATA
VCLK
GPIO2
GPIO1
GPIO0
GPIO6
OPWRSB
FE_EJECT#
G33
B34
A35
C19
A17
C17
AV12
F34
AH4
USB_VBUS_PCONT1
USB_VBUS_PCONT2
C (Page 32)
IF_SDI
IF_SDO
IF_SCK
XIF_CS
IF_START_BIT
SYSCON_REQ
UPG_STATUS
OPWRSB
FE_EJECT
D (Page 30)
RESET_ E35
CORE_RESETB AP4
SYSCON_RST
CPU_PRERST
TH1501
5
2
6
1
HOLD 7
B_RA0 - B_RA13
A0 - A12, NC
18
8
9
7
17
16
VIND5 F14
GPIO3 B18
XWP 19
D
Q
C
S
B_RDQ16 - B_RDQ31
DQ0 - DQ15
XWE
XRE
XCE
RY/XBY
ALE
CLE
SERIAL FLASH
IC502
SD-RAM
IC205
DQ0 - DQ15
NFD0 - NFD7
IO1 - IO8
M6 FE_RSTI
A_RA0 - A_RA13
AV14 SDA
AT12 SCL
NAND FLASH
IC501
SD-RAM
IC204
DQ0 - DQ15
BA0
BA1
BA2
/WE
/CS
/CAS
/RAS
ODT
CKE
CK
/CK
UDM
UDQS
/UDQS
LDM
LDQS
/LDQS
I2C_SDA 13
I2C_SCL 12
RESET 4
BA9 XTAL25MO
MRESET_ C35
BA0
BA1
BA2
/WE
/CS
/CAS
/RAS
ODT
CKE
CK
/CK
UDM
UDQS
/UDQS
LDM
LDQS
/LDQS
EEPROM
IC1101
F42
H40
G41
J39
SFDO
SFDI
SFCK
SFCS
TEMP
HBD-E370/E470/E570/E870/T57
5-3.
BLOCK DIAGRAM - TUNER, S-AIR Section $8',26(/(&7
,&
J11
$8',2
$8',2,1
5 Y1
1 Y0
/
5
5&+
$
10
$8/
Y 3
( (Page 31)
B
9
&1
(=:7
(Page 31)
F
6$,5B'
6''0,;
6$,5B'
6'6/65
6$,5B'
6'6%/6%5
6$,5B%&.
15
14
%&.
%&.
/5&.
/5&.
4
/FK
5FK
$'&B6(/
6$,5B/5&.
$8',26(/(&7
,&
5 Y1
1 Y0
Y 3
5&+
$
10
Q13
Q13
5&+
',
'2
&/
&(
781('
67B',
67B'2
67B&/.
67B&(
781('
$6(/B
5&+
$6(/B
/&+
$17(11$
)0:
&2$;,$/
Q14
$6(/B
78
781(5)0
5'6B'$7$
5'6B&/.
5'6B'$7$
5'6B&/2&.
6$,5B$'&B6(/ 34
6$,5B65&B567 11
5(61
6$,5B6'$ 30
6$,5B6&/ 6$,5B*3,2 33
19
,&B6'$
,&B6&/
*3,2
($(38.($(38.
J10
0,&$03
,&
$&$/0,&
(&0$&
$FDOB/Y
Q10
6<67(0&21752//(5
,&
0,&B'(7
(Page 29) '
(Page 28)
HBD-E370/E470/E570/E870/T57
B
,)B6',
,)B6'2
,)B6&.
;,)B&6
,)B67$57B%,7
6<6&21B5(4
83*B67$786
23:56%
)(B(-(&7
7(03
&38B35(567
6<6&21B567
49
91
35
%'B6'2
%'B6%,
%'B6&/.
%'B&6
%'B,)B67$57
%'B,)B5(4
83*B67$786
23:56%
)(B(-(&7
%'B7(03
&38B35(567
%'B5(6(7
5FKLVRPLWWHGGXHWRVDPHDV/FK
6,*1$/3$7+
$8',2
781(5
0,&
6<6&21B567
30
30
HBD-E370/E470/E570/E870/T57
5-4.
BLOCK DIAGRAM - AUDIO Section A/D CONVERTER
IC702
E
AU-L
R-CH
(Page 30)
13 VinL
14 VinR
9
6
8
7
DATA_I
S-AIR_D3
S-AIR_D1
S-AIR_D2
S-AIR_BCK
S-AIR_LRCK
DOUT
SCKI
BCK
LRCK
AOSDATA0
STREAM PROCESSOR
IC3010
F (Page 30)
D3071 (1/2)
AOSDATA1
31
36
30
29
SCDT
SCSHIFT
LAT1
INIT
SOFTMUTE
NSPMUTE
OVF1
D3072
AOSDATA2
BUFFER
IC704
AOSDATA3
21
22
23
27
19
18
24
25
DATA (DATA1)
XFSIIN
BCK
LRCK
SCDT
SCSHIFT
SCLATCH
INIT
SOFTMUTE
NSPMUTE
OVF FLAGR
OVF FLAGL
POWER AMP
IC3100
TB3001
OUTL2 (-) 9
8
PWM_B
OUT_B 36
L.P.F.
OUTL1 (+) 11
6 PWM_A
OUT_A 39
L.P.F.
OUTR1 (+) 6
16 PWM_C
OUTR2 (-) 4
18 PWM_D
XFSOIN 48
7 /RST_AB
17 /RST_CD
5 /SD
FSOCKO 37
FSOI 38
XFSOOUT 14
OUT_C 31
L.P.F.
OUT_D 28
L.P.F.
A
SCDT
SCSHIFT
LAT3
INIT
SOFTMUTE
NSPMUTE
OVF2
OVF1
DIGITAL AUDIO
INTERFACE RECEIVER
IC703
(Page
28)
SP_DATA
SP_MCK
SP_BCK
SP_LRCK
21
16
17
20
RDATA
RMCK
RBCK
RLRCK
DIR_ERROR
CSI_DATAIN
CSI_DATAOUT
CSI_CLK
CSI_XCS_DIR
DIR_CSFLAG
DIR_AUDIO
DIR_XSTATE
DIR_XRST
36
37
38
40
39
35
33
34
41
RERR
DO
DI
CL
CE
INT
AUDIO
CKST
XMODE
ARC_SPDIF
8 RX4
31
36
30
29
SCDT
SCSHIFT
LAT1
INIT
SOFTMUTE
NSPMUTE
OVF1
10 RX6
J700
DATA (DATA3)
XFSIIN
BCK
LRCK
SCDT
SCSHIFT
SCLATCH
INIT
SOFTMUTE
NSPMUTE
OVF FLAGR
OVF FLAGL
OUTL2 (-) 9
8
PWM_B
OUT_B 36
L.P.F.
OUTL1 (+) 11
6 PWM_A
OUT_A 39
L.P.F.
OUTR1 (+) 6
16 PWM_C
OUTR2 (-) 4
18 PWM_D
SPEAKERS
XFSOIN 48
FSOI 38
7 /RST_AB
17 /RST_CD
5 /SD
XFSOOUT 14
OUT_C 31
L.P.F.
OUT_D 28
L.P.F.
+
OVER LOAD
DETECT
Q3201
DATA (DATA2)
XFSIIN
BCK
LRCK
SCDT
SCSHIFT
SCLATCH
INIT
SOFTMUTE
NSPMUTE
OVF FLAGR
OVF FLAGL
POWER AMP
IC3400
TB3002
OUTL2 (-) 9
8
PWM_B
OUT_B 36
L.P.F.
OUTL1 (+) 11
6 PWM_A
OUT_A 39
L.P.F.
OUTR1 (+) 6
16 PWM_C
OUTR2 (-) 4
18 PWM_D
7 /RST_AB
17 /RST_CD
5 /SD
XFSOIN 48
FSOI 38
29
LAT2
PROTECT DETECT
Q3552
50 67
OUT_C 31
L.P.F.
OUT_D 28
L.P.F.
+
SUR R
DRIVER_RST (EN)
EN. P
+32.5V
DC DETECT
Q3551
H (Page 33)
FAN_PROTECT
66
G (Page 32)
FAN_ON 44
FAN_CONT 45
FAN_ON
FAN_CONT
R-ch is omitted due to same as L-ch.
6,*1$/3$7+
SYSTEM CONTROLLER
IC501 (2/4)
HBD-E370/E470/E570/E870/T57
DRIVER_SD/PVDD_DET
56
DAMP_LATCH2
LAT1
LAT3
INIT
SOFTMUTE
NSPMUTE
OVF1
OVF2
DAMP_LATCH1
55 57 53 54 83 51 52
DAMP_LATCH3
DAMP_INT
DAMP_SOFT_MUTE
NSPMUTE
OVERFLOW1
OVERFLOW2
SCDT
SCSHIFT
DAMP_SCDT/DIR_DI
DAMP_SHIFT/DIR_CL
A.CAL_OUT
CEC (TX/RX)
1 2
SUR L
OVER LOAD
DETECT
Q3402
POWER CONTROL
Q507
68
+
OVER LOAD
DETECT
Q3401
X700
24.576MHz
17
SUBWOOFER
D3551
DC_DET
XIN
28
CENTER
OVER LOAD
DETECT
Q3301
3 RX1
XOUT
SAT/CABLE
DIGITAL IN
COAXIAL
OPTICAL
RECEIVER
IC700
21
22
23
27
19
18
24
25
+
POWER AMP
IC3200
STREAM PROCESSOR
IC3030
CEC
TV
DIGITAL IN
OPTICAL
21
22
23
27
19
18
24
25
FRONT R
OVER LOAD
DETECT
Q3101
STREAM PROCESSOR
IC3020
31
36
30
29
+
X3051
49.152MHz
CLOCK BUFFER
IC3051
AOSDATA4
AOMCK
AOBCK
AOLRCK
FRONT L
OVER LOAD
DETECT
Q3102
D3071 (2/2)
D3070
+
: AUDIO
31
31
HBD-E370/E470/E570/E870/T57
5-5.
BLOCK DIAGRAM - REGULATOR Section M3001
(FAN)
M
+12V
REGULATOR
IC3011
FAN_ON
(Page 31) G
FAN_PROTECT
FAN_CONT
FAN CONTROL
Q3001, 3556
FRONT VBUS
+5V
REGULATOR
IC601
REAR VBUS
+5V
REGULATOR
IC602
IC101, IC702 +3.3V
+3.3V
REGULATOR
IC704
HDMI OUT +5V
+5V
REGULATOR
IC705
USB_VBUS_PCONT1
(Page 29) C
USB_VBUS_PCONT2
VREF +0.9V
DDR2_VTT +0.9V
DC/DC
CONVERTER
IC311
POWER
CONTROL
IC310
DDR2 +1.8V
+3.3V
REGULATOR
IC801
FL +3.3V
B+ SWITCH
Q800, 802
PANEL +4V
+3.3V
REGULATOR
IC307
+3.3VA
FE_SW +12V
FE +3.3V
B+ SWITCH
Q302, 303
PS301
OVER
VOLTAGE
DETECT
Q301
DC/DC
CONVERTER
IC308
D302
PS304
B+ SWITCH
Q401, 402
DC/DC
CONVERTER
IC312
FE_SW +5V
+5V
REGULATOR
IC505
D +3.3V
+3.3V
REGULATOR
IC400
S-AIR +4V
B+ SWITCH
Q300, 301
+3.3V
REGULATOR
IC1001
AUDIO +9V
PS302
A +12V
SYSTEM CONTROLLER
IC501 (3/4)
BD_PCONT6
BD_PCONT5
BD_PCONT3
BD_PCONT2
BD_PCONT1
PCONT_FL
PCONT1
HBD-E370/E470/E570/E870/T57
IC1003 -5V
-5V
REGULATOR
IC1002
+1.8V
REGULATOR
IC3050
POWER
CONTROL
IC309
CORE +1.1V
IC1003 +3.3V
A +5V
AMP +1.8V
D406, 407
+8V
REGULATOR
IC1451
+5V
REGULATOR
IC508
+1.2V
REGULATOR
IC303
+1.2VA
FE +8V
LED +5V
PS303
-7V
REGULATOR
IC402
+9V
REGULATOR
IC14
E +4V
+12V
REGULATOR
IC941
E +14V
E +6V
E -9V
42
41
39
38
37
27
43
IC206 +5V
32
32
+5V
REGULATOR
D15, R89
HBD-E370/E470/E570/E870/T57
5-6.
BLOCK DIAGRAM - PANEL, POWER SUPPLY Section SYSTEM CONTROLLER
IC501 (4/4)
X500
6MHz
REMOTE
CONTROL
RECEIVER
IC803
13 Xout
15 Xin
4 SIRCS_IN
T901
MAIN POWER
TRANSFORMER
19 KEY_INT
3
D906, 907
1 OCP/SYNC
D908
RECT
D931
+32.5V
97, 95, 94
S700 - 705, 750
D508
KEY0
KEY2
D506
POWER CONTROL
IC901
B+ SWICH
Q901
4 VCC
D910
KEY0 - KEY2
(Page 31) H
EN. P
3 D
D800
(ILLUMINATION)
LED DRIVE
Q801
T903
SUB POWER
TRANSFORMER
28 LED_PWM
RECT
D954
E +14V
VOLTAGE
DETECTOR
IC506
ND800
FLUORESCENT
INDICATOR
TUBE
10
GRID DRIVE
Q804
14 - 29
16
SG1 - SG16
42 - 33
FLUORESCENT
INDICATOR
TUBE DRIVER
IC802
GR1 - GR10
DIN 7
CLK 8
STB 9
5 FL_DOUT
7 FL_CLK
3 FL_CS
HBD-E370/E470/E570/E870/T57
E -9V
RECT
D955
AC_CUT 20
RESET 12
RESET
SWITCH
Q504
ISOLATOR
PC903
SHUNT
REGULATOR
IC932
ISOLATOR
PC901
5 FB/OLP
MAIN POWER
ON/OFF SWITCH
Q949, 950
POWER CONTROL
IC921
D902
DZ903
RIPPLE FILTER
Q922
3 Vcc/DVP
6 BD
5 FB/CLP
1 D
RECT
D943
E +4V
VEE
D803, 804
RECT
RECT
D942
VOLTAGE
DETECTOR
IC507
32 GR11
T800
DC/DC CONVERTER
TRANSFORMER
E +6V
MAIN POWER
ON/OFF SWITCH
Q943
RESET
SIGNAL
GENERATOR
IC503
RECT
D901
VOLTAGE
DETECT
Q969
SHUNT
REGULATOR
IC923
OSC
Q803
33
33
ISOLATOR
PC902
TH901
LINE
FILTER
LF901, 902
F901
(AC IN)
HBD-E370/E470/E570/E870/T57
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
CONNECT board
For Printed Wiring Boards.
For Schematic Diagrams.
Note:
• X : Parts extracted from the component side.
• Y : Parts extracted from the conductor side.
•
f : Internal component.
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Note:
• All capacitors are in μF unless otherwise noted. (p: pF) 50
WV or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : internal component.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen
from the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• MAIN and MB-134 boards are multi-layer printed board.
However, the patterns of intermediate-layers have not
been included in this diagrams.
• Indication of transistor.
C
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
Note 1: When the MAIN board is replaced, spread the compound referring to “NOTE OF REPLACING THE
IC3100, IC3200 AND IC3400 ON THE MAIN
BOARD AND THE COMPLETE MAIN BOARD”
on servicing notes (page 8).
Note 2: When the POWER board is replaced, spread the
compound referring to “NOTE OF REPLACING
THE D913, D931, IC901 AND IC921 ON THE
POWER BOARD AND THE COMPLETE POWER
BOARD” on servicing notes (page 9).
Note 1: When the MAIN board is replaced, spread the compound referring to “NOTE OF REPLACING THE
IC3100, IC3200 AND IC3400 ON THE MAIN
BOARD AND THE COMPLETE MAIN BOARD”
on servicing notes (page 8).
These are omitted.
B E
Q
B C
E
These are omitted.
• Abbreviation
CND : Canadian model
• Lead layouts
Lead layout of conventional IC
surface
CSP (Chip Size Package)
TUNER (FM) (TU1)
AUDIO board
R-USB board
P-KEY board
MAIN board
REG board
POWER board
KEY board
FL board
Note 2: When the POWER board is replaced, spread the
compound referring to “NOTE OF REPLACING
THE D913, D931, IC901 AND IC921 ON THE
POWER BOARD AND THE COMPLETE POWER
BOARD” on servicing notes (page 9).
HBD-E370/E470/E570/E870/T57
MB-134 board
Note:
Les composants identifiés
par une marque 0 sont
critiques pour la sécurité.
Ne les remplacer que par
une piéce portant le numéro spécifié.
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
– MB-134 board –
no mark : BD PLAY
* : Impossible to measure
– Other boards –
no mark : TUNER
* : Impossible to measure
• Voltages are taken with VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F
: AUDIO
E
: VIDEO
J
: DISC PLAY
L : USB
d
: LAN
f
: TUNER
N
: MIC
• Abbreviation
CND : Canadian model
• The voltage and waveform of CSP (chip size package)
cannot be measured, becaise its lead layout is different
from that of conventional IC.
Q
• Circuit Boards Location
34
34
F-USB board
HBD-E370/E470/E570/E870/T57
5-7.
SCHEMATIC DIAGRAM - MB-134 Board (1/13) - • See page 77 for IC Pin Function Description.
1
3
2
4
5
7
8
9
11
10
12
13
14
15
16
17
18
MB-134 BOARD (1/13)
A
C104
0.01
C105
0.01
C106
0.01
B
C107
0.01
C109
0.01
C110
0.01
C
AY14
BB14
AY18
BB18
AR19
AY22
BB22
AY26
BB26
AY30
BB30
C111
0.01
AR31
C112
0.01
BB34
C113
0.01
AY34
W35
AL35
AY38
BB38
P40
V40
AB40
D
AF40
AK40
AP40
AV40
P42
V42
AB42
AF42
E
AK42
AP42
AV42
BB42
BA43
VCC2IO
A_RDQ0
VCC2IO
A_RDQ1
VCC2IO
A_RDQ2
VCC2IO
A_RDQ3
VCC2IO
A_RDQ4
VCC2IO
A_RDQ5
VCC2IO
A_RDQ6
VCC2IO
VCC2IO
A_RDQ7
A_RDQ8
VCC2IO
A_RDQ9
VCC2IO
A_RDQ10
VCC2IO
A_RDQ11
VCC2IO
A_RDQ12
VCC2IO
A_RDQ13
VCC2IO
A_RDQ14
VCC2IO
A_RDQ15
VCC2IO
A_RDQM0
VCC2IO
A_RDQS0
VCC2IO
A_RDQS0B
F
J11
JL102
P12
JL103
T12
JL104
V12
JL105
J13
JL106
U13
JL107
W13
JL108
AW13
JL109
G
P14
JL110
T14
JL111
V14
JL112
Y14
JL113
AT14
JL114
U15
JL115
W15
H16
H
AR17
AU17
AW17
J19
AA21
AC21
AE21
AG21
I
AJ21
AU21
VCC2IO
A_RDQM1
VCC2IO
A_RDQS1
VCC2IO
A_RDQS1B
VCC2IO
A_RCLK0
VCC2IO
A_RCLK0B
MB-134
BOARD
(4/13)
AY40
C102
0.1
(Page 38)
C114
0.1
VCC2IO
A_RDQ16
VCC2IO
A_RDQ17
VCC2IO
A_RDQ18
VCC2IO
A_RDQ19
VCC2IO
A_RDQ20
DVSS
A_RDQ23
DVSS
A_RDQ24
DVSS
A_RDQ25
DVSS
A_RDQ26
DVSS
A_RDQ27
DVSS
A_RDQ28
DVSS
A_RDQ29
DVSS
A_RDQ30
DVSS
A_RDQ31
DVSS
A_RDQM2
DVSS
A_RDQS2
DVSS
A_RDQS2B
DVSS
A_RDQM3
DVSS
A_RDQS3
A_RDQS3B
DVSS
D0DQ7
D0DQ8
JL122
D0DQ9
AT20
JL123
D0DQ11
AW19
JL124
D0DQ12
BC19
AV20
JL125
BA19
D0A0
JL180
D0DQ14
D0A1
JL181
M3
D0DQ15
D0A2
JL182
M7
D0A3
JL183
N2
N8
DVSS
A_RCLK1
DVSS
A_RCLK1B
D0DM0
D0A4
JL126
D0DQS0
D0A5
JL185
N3
JL127
D0DQS0B
D0A6
JL186
N7
D0A7
JL187
A_RA0
DVSS
A_RA1
DVSS
A_RA2
DVSS
A_RA3
DVSS
A_RA4
DVSS
A_RA5
DVSS_XTAL
A_RA7
A_RA10
A_AVDD12_MEMPLL
A_RA11
A_AVSS12_MEMPLL
A_RA12
P2
D0DM1
D0A8
BC17
JL128
D0DQS1
D0A9
JL188
BA17
JL129
D0DQS1B
D0A10
JL189
D0A11
JL190
P7
D0A12
JL191
R2
AV18
BC21
D0CK0
BA21
D0CK0B
JL130
JL131
BC31
BA31
JL132
JL133
AY36
AV36
JL134
M2
AU37
JL135
AW35
JL136
BC37
JL137
D0A8
RB101
100
DQ0
A1
DQ1
A2
DQ2
A3
DQ3
A4
DQ4
A5
DQ5
A6
DQ6
A7
DQ7
A8
DQ8
A9
DQ9
A10
DQ10
A11
DQ11
A12
DQ12
JL192
D0BA1
JL193
L3
D0BA2
JL194
L1
L2
BA0
BA1
DQ14
DQ15
JL2108
G8
G2
JL2109
H7
H3
D0DQ0
D0A0
JL2134
D0DQ4
D0A1
JL2135
M3
D0DQ7
D0A2
JL2136
M7
D0DQ2
D0A3
JL2137
N2
N8
M8
H1
JL2110
D0DQ3
D0A4
JL2138
H9
JL2111
D0DQ5
D0A5
JL2139
N3
D0DQ6
D0A6
JL2140
N7
P2
F1
JL2112
F9
C8
JL2113
C2
D7
D0DQ1
D0A7
JL2141
D0DQ13
D0A8
JL2142
P8
D0DQ11
D0A9
JL2143
P3
D0DQ8
D0A10
JL2144
M2
D3
JL2114
D0DQ9
D0A11
JL2145
P7
D1
JL2115
D0DQ12
D0A12
JL2146
R2
D0DQ10
D9
JL2116
B1
B9
DQ0
A1
DQ1
A2
DQ2
A3
DQ3
A4
DQ4
A5
DQ5
A6
DQ6
A7
DQ7
A8
DQ8
A9
DQ9
A10
DQ10
A11
DQ11
A12
DQ12
DQ13
D0DQ14
D0BA0
JL2147
D0DQ15
D0BA1
JL2148
L3
D0BA2
JL2149
L1
BA2
A0
L2
BA0
BA1
DQ14
DQ15
C159
0.1
D0A0
D0ODT
D0A13
RB102
100
G8
JL2162
G2
H7
JL2163
H3
H1
H9
JL2164
F1
F9
JL2165
C8
C2
JL2166
D7
D0DQ16
D0A10
D0DQ22
D0BA2
D0DQ21
D0A12
D0DQ19
D0A7
D0DQ20
D0A3
D0DQ18
D0A9
D0DQ17
D0A2
D0DQ23
D0RAS
D0DQ24
D0A4
D0DQ27
D0A6
D0DQ29
D0CAS
D3
JL2167
D0DQ25
D0A11
D1
JL2168
D0DQ28
D0CS
D0DQ26
D0A1
D0DQ30
D0A5
D0DQ31
D0WE
D9
B1
JL2169
B9
C161
0.1
C162
0.1
RB103
100
RB104
100
RB105
100
C164
0.1
C166
0.1
C168
0.1
RB106
100
D0CKE
BA2
D0DQ18
D0DQ19
D0DM1
JL195
B3
D0DQ20
D0DQS1
JL196
B7
D0DQS1B
JL197
D0DQ21
D0DQ23
D0DM0
JL198
D0DQ24
D0DQS0
JL199
D0DQ25
D0DQS0B
A8
F7
JL2101
E8
R106
100
D0CK0
D0DQ28
D0CK0B
D0DQ29
D0CKE
JL2102
D0CS
JL2103
D0RAS
JL2104
K7
D0CAS
JL2105
L7
D0WE
JL2106
K3
D0ODT
JL2107
K9
J8
K8
K2
D0DQ30
D0DQ31
AV34
D0DM2
BA33
JL138
D0DQS2
BC33
JL139
D0DQS2B
L8
JL140
D0DQS3
BA35
JL141
D0DQS3B
BA39
D0CK1
BC39
D0CK1B
JL166
NC
UDQS
NC
/UDQS
NC
LDM
NC
A3
E3
JL167
J3
JL168
N1
JL169
P9
BC23
JL142
D0A0
AT26
JL143
D0A1
AV26
JL144
D0A2
BC27
JL145
D0A3
AY24
JL146
D0A4
AV28
JL147
D0A5
BC25
JL148
D0A6
BA27
JL149
D0A7
BA23
JL150
D0A8
F2
AW27
JL151
D0A9
F8
AY28
JL152
D0A10
H2
AT24
JL153
D0A11
H8
BA25
JL154
D0A12
AV22
JL155
D0A13
BB28
JL156
D0BA0
AU27
JL157
D0BA1
AT28
JL158
D0BA2
BA29
JL159
AV24
JL160
D0CS
BB24
JL161
D0RAS
AU23
JL162
D0CAS
BC29
JL163
D0WE
JL164
D0ODT
A2
D0DM3
JL2150
B3
E2
D0DQS3
JL2151
B7
D0DQS3B
JL2152
D0DM2
JL2153
D0DQS2
JL2154
D0DQS2B
JL2155
R3
R7
D0A13
/LDQS
D0CK1B
/CK
CKE
/CS
/CAS
JL2118
VREF
J2
/WE
ODT
VSSDL
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
JL172
JL173
JL174
A7
B2
B8
D2
JL175
D8
JL176
E7
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
F7
E8
J8
K8
D0CKE
JL2156
K2
D0CS
JL2157
L8
D0RAS
JL2158
K7
D0CAS
JL2159
L7
D0WE
JL2160
K3
D0ODT
JL2161
K9
C129
0.1
J1
J7
C118
0.1
A1
JL2119
E1
C119
0.1
J9
M9
JL2120
C120
0.1
R1
C122
0.1
JL170
JL171
NC
UDQS
NC
/UDQS
NC
NC
F3
R107
100
D0CK1
CK
/RAS
A8
UDM
JL2117
R8
LDQS
VDDL
D0DM3
BC35
UDM
NC
F3
D0DQ27
BB36
AU35
A0
DQ13
D0BA0
D0DQ26
BA37
AV38
P3
D0DQ22
AY32
AT32
D0DQ16
P8
D0DQ17
BB32
DVSS
DVSS
M8
BB16
AU31
SD-RAM
CSP
(Chip Size Package)
IC105
K4T1G164QE-HCF8
D0BA1
D0DQ13
AY16
AT18
AW31
IC105
SD-RAM
CSP
(Chip Size Package)
D0BA0
JL184
AV32
IC104
IC104
K4T1G164QE-HCF8
D0DQ10
BB20
JL165
A9
J3
N1
JL2123
P9
JL2126
C124
0.1
C9
JL2128
JL2129
E9
G1
G3
G7
E3
JL2122
JL2127
C7
A3
E2
R3
R7
A7
B2
B8
D2
D8
C127
0.1
E7
C128
10
F8
F2
H2
H8
G9
JL2170
D0A13
R8
LDQS
/LDQS
CK
/CK
CKE
/CS
JL2171
/RAS
/CAS
VREF
J2
/WE
ODT
VSSDL
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
J1
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
C142
0.01
J7
A1
E1
J9
M9
R1
JL2124
C123
0.1
C3
NC
VDDL
JL2121
JL2125
C1
LDM
A2
A9
C1
C3
C7
C9
E9
G1
G3
G7
G9
C130
0.1
C143
0.01
C134
0.1
C144
1
C135
0.1
C145
0.01
C137
0.1
C146
0.01
C138
0.1
C147
0.01
C139
0.1
C148
1
C140
0.1
C150
0.01
C141
10
C151
1
C153
1
C154
1
A_TP_MEMPLL
A_TN_MEMPLL
A_RBA2
K
A_RCKE
JL116
A_RCSB
A_RVREF
C115
0.1
A_RRASB
A_RCASB
A_RWEB
NC
C116
0.1
BC43
JL121
AY20
AU19
D0DQ5
D0DQ6
BA15
BC15
D0DQ3
D0DQ4
JL120
DVSS
A_RBA1
L
AT16
DVSS
A_RBA0
AT30
D0DQ2
BA13
DVSS
A_RA13
BB40
BC41
AU15
VCC2IO
A_RA9
AW39
CPU_1.2VA
D0DQ1
JL119
VCC2IO
A_RA8
19
D0DQ0
JL118
VCC2IO
A_RA6
AJ7
JL117
BC13
VCC2IO
A_RDQ22
J9
JL101
AV16
AW15
VCC2IO
A_RDQ21
J
6
A_REXTDN
A_RODT
C156
1
C170
10
D0CKE
AV30
AW23
PT101
E
R101
100
(1/15)
PT104
MB-134
BOARD
(3/13)
E
PT105
PT106
VREF_0.9V
E
20
E
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CSP
(Chip Size Package)
PT107
DDR2_VTT0.9V
DDR2_1.8V
E
M
E
PT103
IC101
GND
(CHASSIS)
(Page 37)
HBD-E370/E470/E570/E870/T57
35
35
Note: IC101, IC104 and IC105 on the MB-134 board cannot exchange with single.
When these parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-8.
SCHEMATIC DIAGRAM - MB-134 Board (2/13) - • See page 77 for IC Pin Function Description.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
MB-134 BOARD (2/13)
A
B
C
JL201
AW21
JL202
Y22
JL203
AK22
JL204
AT22
JL205
J23
JL206
AC23
JL207
AE23
JL208
AG23
JL209
Y24
JL210
AB24
JL211
AD24
JL212
AF24
JL213
AH24
JL214
AK24
JL215
AC25
AE25
AG25
AR25
AU25
AW25
AB26
D
AD26
AF26
AH26
AK26
AC27
AE27
AG27
Y28
E
AB28
AD28
AF28
AH28
AK28
AC29
AE29
AG29
F
AR29
AU29
AW29
Y30
AK30
AA31
AC31
AE31
G
AG31
AJ31
AU33
AW33
K34
AT34
R35
U35
H
AA35
AE35
AJ35
AN35
H36
AT36
G37
N37
I
U37
AA37
AE37
AJ37
AN37
AW37
N39
U39
J
AA39
AE39
AJ39
AN39
AU39
BA41
AY42
DVSS
B_RDQ0
DVSS
B_RDQ1
DVSS
B_RDQ2
DVSS
B_RDQ3
DVSS
B_RDQ4
DVSS
B_RDQ5
DVSS
B_RDQ6
DVSS
B_RDQ7
DVSS
B_RDQ8
DVSS
B_RDQ9
DVSS
B_RDQ10
DVSS
B_RDQ11
DVSS
B_RDQ12
DVSS
B_RDQ13
DVSS
B_RDQ14
DVSS
B_RDQ15
DVSS
B_RDQM0
DVSS
B_RDQS0
DVSS
B_RDQS0B
DVSS
B_RDQM1
DVSS
B_RDQS1
DVSS
B_RDQS1B
B_RCLK0
DVSS
B_RCLK0B
D1DQ3
D1DQ4
AW41
AT38
JL218
D1DQ5
AR37
JL219
D1DQ6
AP36
JL220
D1DQ7
D1DQ8
AN43
AK36
JL221
D1DQ9
DVSS
B_RDQ16
DVSS
B_RDQ17
DVSS
B_RDQ18
DVSS
B_RDQ19
DVSS
B_RDQ20
DVSS
B_RDQ21
DVSS
B_RDQ22
DVSS
B_RDQ23
DVSS
B_RDQ24
DVSS
B_RDQ25
DVSS
B_RDQ26
DVSS
B_RDQ27
DVSS
B_RDQ28
DVSS
B_RDQ29
DVSS
B_RDQ30
DVSS
B_RDQ31
B_RDQM2
DVSS
B_RDQS2
DVSS
B_RDQS2B
B_RDQM3
DVSS
B_RDQS3
DVSS
B_RDQS3B
D1A8
JL223
D1DQ12
D1A1
AL39
JL224
D1DQ13
D1A0
JL279
M8
D1DQ14
D1A1
JL280
M3
D1DQ15
D1A2
JL281
M7
D1A3
JL282
N2
D1A4
JL283
N8
AN41
AP38
D1DM0
AT40
JL225
D1DQS0
D1A5
JL284
N3
AT42
JL226
D1DQS0B
D1A6
JL285
N7
D1A7
JL286
P2
D1DM1
D1A8
JL287
D1A9
JL288
P3
D1A10
JL289
M2
D1A11
JL290
P7
D1A12
JL291
R2
AM36
AR43
JL227
D1DQS1
AR41
JL228
D1DQS1B
AL43
D1CK0
AL41
D1CK0B
Y38
JL229
JL230
AA43
Y40
W39
JL231
Y36
JL232
T40
R37
D1BA0
JL292
L2
D1BA1
JL293
L3
D1BA2
JL294
L1
JL233
D1DQ19
D1DM1
JL295
B3
D1DQ20
D1DQS1
JL296
B7
D1DQ21
D1DQS1B
JL297
A8
D1DM0
JL298
F3
D1DQ24
D1DQS0
JL299
F7
D1DQ25
D1DQS0B
JL2201
E8
R206
100
T38
JL234
D1DQ27
D1CK0
T36
JL235
D1DQ28
D1CK0B
D1DQ29
D1CKE
JL2202
D1CS
JL2203
D1RAS
JL2204
K7
D1CAS
JL2205
L7
D1WE
JL2206
K3
D1ODT
JL2207
K9
R41
R39
JL236
B_RCLK1
B_RCLK1B
D1DQ31
V38
D1DM2
W41
JL237
D1DQS2
W43
JL238
D1DQS2B
K8
DVSS
B_RA0
DVSS
B_RA1
DVSS
B_RA2
DVSS
B_RA3
DVSS
B_RA4
DVSS
B_RA5
DVSS
B_RA6
DVSS
B_RA7
DVSS
B_RA8
DVSS
B_RA9
DVSS
B_RA10
DVSS
B_RA11
DVSS
B_RA12
DVSS
B_RA13
K2
L8
A2
DQ2
A3
DQ3
A4
DQ4
A5
DQ5
A6
DQ6
A7
DQ7
A8
DQ8
A9
DQ9
A10
DQ10
A11
DQ11
A12
DQ12
BA0
BA1
DQ14
DQ15
D1DQ0
D1A0
JL2233
M8
G2
D1DQ4
D1A1
JL2234
M3
H7
D1DQ2
D1A2
JL2235
M7
D1DQ1
D1A3
JL2236
N2
D1DQ6
D1A4
JL2237
N8
D1DQ5
D1A5
JL2238
N3
D1DQ3
D1A6
JL2239
N7
D1DQ7
D1A7
JL2240
P2
D1DQ8
D1A8
JL2241
D1DQ9
G8
JL2208
H3
H1
JL2209
H9
JL2210
F1
F9
JL2211
C8
C2
JL2212
D7
P8
D1A9
JL2242
P3
D1DQ10
D1A10
JL2243
M2
D3
JL2213
D1DQ11
D1A11
JL2244
P7
D1
JL2214
D1DQ12
D1A12
JL2245
R2
D1DQ13
D9
B1
JL2215
B9
A0
DQ0
A1
DQ1
A2
DQ2
A3
DQ3
A4
DQ4
A5
DQ5
A6
DQ6
A7
DQ7
A8
DQ8
A9
DQ9
A10
DQ10
A11
DQ11
A12
DQ12
DQ13
D1DQ14
D1BA0
JL2246
L2
D1DQ15
D1BA1
JL2247
L3
D1BA2
JL2248
L1
BA2
JL239
D1DQS3
U41
JL240
D1DQS3B
N41
D1CK1
N43
D1CK1B
UDM
NC
UDQS
NC
/UDQS
NC
JL265
JL266
JL267
A3
E3
J3
N1
AG43
JL241
D1A0
AF38
JL242
D1A1
AG37
JL243
D1A2
AJ43
JL244
D1A3
AH42
JL245
D1A4
AC37
JL246
D1A5
AG39
JL247
D1A6
AE43
JL248
D1A7
E7
AH36
JL249
D1A8
F2
AD38
JL250
D1A9
F8
AF36
JL251
D1A10
H2
AH38
JL252
D1A11
H8
AE41
JL253
D1A12
AK38
JL254
D1A13
AD40
JL255
D1BA0
AD36
JL256
D1BA1
AC39
JL257
D1BA2
JL268
LDM
NC
P9
A2
D1DM3
JL2249
B3
E2
D1DQS3
JL2250
B7
R3
D1DQS3B
JL2251
A8
D1DM2
JL2252
F3
D1DQS2
JL2253
F7
D1DQS2B
JL2254
R7
BA0
BA1
DQ14
DQ15
G8
JL2260
G2
H7
JL2261
H3
H1
H9
JL2262
F1
F9
JL2263
C8
C2
JL2264
D7
D1DQ18
D1A9
D1DQ20
D1A12
D1DQ23
D1A7
D1DQ19
D1BA0
D1DQ17
D1CS
D1DQ16
D1BA1
D1DQ22
D1A5
D1DQ21
D1A11
D1DQ24
D1A2
D1DQ25
D1A6
D1DQ26
D1A10
D3
JL2265
D1DQ27
D1RAS
D1
JL2266
D1DQ28
D1A3
D1DQ29
D1CAS
D1DQ30
D1A4
D1DQ31
D1BA2
D9
B1
JL2267
B9
RB202
100
C250
0.1
C252
0.1
RB203
100
RB204
100
RB205
100
C254
0.1
C256
0.1
C258
0.1
RB206
100
D1WE
BA2
D1CKE
/LDQS
CK
/CK
CKE
/CS
/CAS
JL2217
VREF
J2
/WE
ODT
VSSDL
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
J1
E1
J9
M9
R1
JL271
JL272
JL273
JL274
A7
B2
B8
D2
D8
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
A9
C1
C3
C7
C9
E9
G1
G3
G7
G9
E8
J8
D1CK1B
K8
D1CKE
K2
D1CS
JL2255
L8
D1RAS
JL2256
K7
D1CAS
JL2257
L7
D1WE
JL2258
K3
D1ODT
JL2259
K9
C215
0.01
J7
A1
NC
UDQS
NC
/UDQS
NC
NC
R207
100
D1CK1
JL269
JL270
D1A13
R8
/RAS
UDM
JL2216
LDQS
VDDL
D1DM3
U43
DVSS
J8
D1DQ30
T42
V36
DQ1
NC
D1DQ23
D1DQ26
R43
DQ0
A1
C248
0.1
D1DQ18
D1DQ22
Y42
A0
DQ13
D1DQ17
AA41
W37
D1DQ16
P8
JL264
DVSS
D1A13
AM38
AM42
RB201
100
D1ODT
D1DQ11
DVSS
DVSS
D1A0
JL222
DVSS
DVSS
IC205
SD-RAM
CSP
(Chip Size Package)
IC205
K4T1G164QE-HCF8
AL37
DVSS
DVSS
IC204
SD-RAM
CSP
(Chip Size Package)
IC204
K4T1G164QE-HCF8
D1DQ10
AM40
DVSS
C203
0.1
C204
0.1
C205
0.1
C206
0.1
C209
0.1
A3
JL2219
E3
JL2220
J3
JL2221
N1
JL2222
P9
C214
10
E2
R3
R7
JL2225
A7
B2
JL2226
B8
JL2227
D2
JL2229
D8
E7
F2
F8
H2
H8
JL2268
D1A13
R8
LDQS
/LDQS
CK
/CK
CKE
/CS
JL2269
/RAS
/CAS
VREF
J2
/WE
ODT
VSSDL
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
VSS
VDD
J1
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
VSSQ
VDDQ
C231
0.1
J7
A1
E1
J9
M9
R1
JL2223
JL2228
C211
0.1
NC
VDDL
JL2218
JL2224
C207
0.1
LDM
A2
A9
C1
C3
C7
C9
E9
G1
G3
G7
G9
C216
0.1
C232
0.01
C217
0.1
C233
1
C220
0.1
C234
1
C222
0.1
C235
0.01
C225
0.1
C236
0.01
C226
0.1
C239
0.01
C227
0.1
C240
1
C228
0.1
C242
1
C230
10
C243
1
C245
1
DVSS
DVSS
DVSS
B_RBA0
DVSS
B_RBA1
DVSS
B_RBA2
B_RVREF
C201
0.1
B_RCSB
B_RRASB
B_RCASB
B_RWEB
NC
M42
D1DQ2
AU41
DVSS
B_RCKE
L
D1DQ1
DVSS
DVSS
D1DQ0
AU43
DVSS
JL216
R201
100
JL217
AW43
DVSS
K
AB36
AR39
B_REXTDN
B_RODT
IC101
AC41
JL258
AD42
JL259
D1CS
AJ41
JL260
D1RAS
AH40
JL261
D1CAS
AC43
JL262
D1WE
JL263
D1ODT
C246
0.01
C247
0.01
C259
10
D1CKE
AB38
AG41
(2/15)
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
M
CSP
(Chip Size Package)
21
MB-134
BOARD
(3/13)
VREF_0.9V
DDR2_VTT0.9V
DDR2_1.8V
GND
(Page 37)
HBD-E370/E470/E570/E870/T57
36
36
Note: IC101, IC204 and IC205 on the MB-134 board cannot exchange with single. When these parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-9.
SCHEMATIC DIAGRAM - MB-134 Board (3/13) - • See page 67 for IC Block Diagrams.
1
A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
MB-134 BOARD (3/13)
MB-134
BOARD
(6/13)
24
GND
JL314
(Page 40)
MB-134
BOARD
(4/13)
L305
2.2uH
UNSW6V
JL313
CORE_1.1V
R320
0
CORE_STB3.3V
22
3.3VA
1.2VA
B (Page 38)
R319
0
GND
R327
1k
PCONT_CORE
MB-134
BOARD
(13/13)
34
PCONT3
PCONT2
(Page 47)
ATA_PCONT
IC309
IC B/D
C
MB-134
BOARD
(5/13)
23
POWER CONTROL
3.3VA
C310
10
3.3VA
GND
D (Page 44)
MB-134
BOARD
(11/13)
IC303
IC307
+1.2V REGULATOR
+3.3V REGULATOR
IC307
MM3293DNRE
IC303
MM3141CNRE
CORE_STB3.3V
30
IC B/D
GND
(Page 39)
MB-134
BOARD
(10/13)
IC B/D
3.7
1 VDD
VOUT
5
1.2
3.7
2 GND
3.3
31
R305
1k
CORE_STB3.3V
3 CE
NC
3.3
4
C330
10
1
VDD
2
GND
3
R330
8.2k
C345 1
5.5
5.5
C346
3.3
5
3300p
R331
18k
JL311
3.3
4
NC
C335
10
C313
10
C340
10
R332
150
C318
22
C353
22
L303
2.2uH
15
1.1
VOUT
CE
IC309
TPS54325PWPR
D303
KDZTR3.9B
1
VO
2
VFD
3
VREG5
4
SS
SW2 11
5
GND
SW1 10
6
PG
PGND2
9
7
EN
PGND1
8
VCC 14
VIN 13
VBST 12
6.3
6.3
C349
0.1
6.7
1.1
1.1
D304
KDZTR3.9B
GND
(Page 45)
C351
22
R306
1k
C352
22
C365
10
C359
10
E
MB-134
BOARD
(7/13)
25
3.3VA
PS304
3.15A
32V
UNSW6V
(Page 41)
EMI
R355
220
R379
0
L304
2.2uH
L306
2.2uH
GND
IC B/D
MB-134
BOARD
(8/13)
F
JL315
FL301
1.2VA
27
GND
IC310
TPS54325PWPR
(Page 42)
1.8
C347
1
5.5
5.5
C348
R334
2.7k
G
JL312
R335
120
C341
10
3300p
1
VO
VCC 14
2
VFD
VIN 13
3
VREG5
DDR2_1.8V
C368
1
GND
DC/DC CONVERTER
IC311
BD3539NUX-TR
15
R333
3.9k
EMI
IC311
POWER CONTROL
JL316
FL302
IC B/D
IC310
VBST 12
4
SS
SW2 11
5
GND
SW1 10
6
PG
PGND2
9
7
EN
PGND1
8
13.2
DDR2_VTT0.9V
VREF_0.9V
9
13.2
C350
0.1
7.4
1.8
1.8
0.9
1.8
3.3
1
VTT_IN
VCC
8
2
3
VTT
VDDQ
7
GND
VREF
6
4
EN
VTTS
5
(Page 36)
6.3
1.8
DDR2_1.8V
0.9
VREF_0.9V
0.9
DDR2_VTT0.9V
GND
R343
1k
21
MB-134
BOARD
(2/13)
C369
1
R329
1k
20
MB-134
BOARD
(1/13)
(Page 35)
C363
0.1
GND
CN303
12P
J
12
4
IC308
DC/DC CONVERTER
PS303
1A
32V
IC308
MP2301ENE-LF-Z
UNSW-6V
DAC3.3VA
UNSW6V
3
2
1
5
6
7
8
4 5 6
S D D
R318
1k
R322
8.2k
G
D302
DZ2J047M0L
9
3
D
2
IC B/D
IC312
D
DC/DC CONVERTER
1
IC312
MM1855AHBE
9
6.3
GND
(Page 43)
C331
4700p
C373
0.01
3.3
R312
4.7k
R376
1k
0.6
C323
8200p
C337
22
R375
68k
Q301
RT1N141M-TP-1
R323
560
OVER VOLTAGE
DETECT
0
3.3
Q302, 303
B+ SWITCH
C377
1
VIN
VOUT
1
7
NC
NC
2
6
NC
GND
3
5
CONT
CN
4
5
0.8
FE_SW12V
C379
0.01
C311
10
GND
R362
2.2k
K
8
FE_SW5V
Q303
RT1N141M-TP-1
5
HBD-E370/E470/E570/E870/T57
(Page 46)
13.2
13.2
13.2
IC B/D
Q302
FDC642P
GND
JL310
JL306
8.9
11
8.6
GND
MB-134
BOARD
(12/13)
FE_GND_M
PS302
3.15A
32V
13.2
9
10
JL309
13.2
MB-134
BOARD
(9/13)
UNSW6V
UNSW-6V
JL308
13.2
28
8
FE_SW5V
C302
0.1
BOOT
I
7
UNSW6V
JL307
SS
(Page 61)
UNSW6V
JL305
REG
BOARD
CN402
FE_SW12V
3.6
6
C301
0.01
3.8
FE_UNSW6V
E
JL302
SW
5
32
R374
33k
VIN
4
GND
R321
33k
JL320
EN
GND
H
JL319
L301
10uH
C336
0.01
GND
3
L302
2.2uH
COMP
2
FE_GND_M
JL303
FB
FE_UNSW12V
PS301
2A
50V
JL301
1
1
3.3
UNSW12V
C321
10
R363
2.2k
FE_GND_M
37
37
33
MB-134
BOARD
(13/13)
(Page 47)
Note: IC307 and IC311 on the MB-134 board cannot exchange with single. When
these parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-10. SCHEMATIC DIAGRAM - MB-134 Board (4/13) - • See page 77 for IC Pin Function Description.
1
2
22
MB-134
BOARD
(3/13)
(Page 37)
19
MB-134
BOARD
(1/13)
1.2VA
3.3VA
5
MB-134
BOARD
(6/13)
15
MB-134
BOARD
(10/13)
MB-134
BOARD
(8/13)
E
6
7
8
9
10
11
(Page 42)
F
G
0
CSP
(Chip Size Package)
IC101
GND
R401
0
(3/15)
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CPU_1.2VA
C416
10
C418
0.1
C403
0.1
CPU_1.2VA
CPU_3.3VA
C405
0.01
C423
0.1
CPU_3.3VA
Y20
VCCK
AB20
VCCK
AD20
VCCK
AF20
VCCK
AH20
VCCK
AK20
VCCK
W21
VCCK
AL21
VCCK
AB22
VCCK
AD22
VCCK
AF22
VCCK
AH22
VCCK
W23
VCCK
VCC3IO_1
VCC3IO_2
VCC3IO_2
VCC3IO_3
VCC3IO_3
VCC3IO_3
VCC3IO_3
VCC3IO_PWM
VCC3IO_STB
VCC3IO_STB
C427
0.1
AU13
L35
C431
0.1
N35
CSP
(Chip Size Package)
IC101
H10
C433
0.1
H12
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
J15
H18
AVDD33_XTAL
J21
NS_XTALO
NS_XTALI
J33
TP_PLLG
G35
C424
0.1
TN_PLLG
AVSS33_XTAL
VCCK
AJ23
VCCK
AL23
VCCK
AVDD12_27MPLL
CPU_1.2VA
W25
VCCK
AVSS12_27MPLL
CPU_3.3VA
AA25
VCCK
AJ25
VCCK
AVDD12_DMPLL
AL25
VCCK
AVSS12_DMPLL
AA27
VCCK
AJ27
VCCK
AVDD12_APLL
AL27
VCCK
AVSS12_APLL
W29
VCCK
AA29
VCCK
AVDD10_LDO
AJ29
VCCK
AVDD33_LDO
AL29
VCCK
AVSS33_LDO
AB30
VCCK
AD30
VCCK
AF30
VCCK
AH30
VCCK
W31
VCCK
AL31
VCCK
Y32
VCCK
AB32
VCCK
AD32
VCCK
AF32
VCCK
AH32
VCCK
AK32
VCCK
W27
VCCK_PWM
DVSS_PWM
(4/15)
BD DECODER
AA23
(Page 44)
7
R402
CORE_1.1V
(Page 40)
D
5
CORE_STB3.3V
(Page 35)
C
4
MB-134 BOARD (4/13)
A
B
3
E25
R403
820
C25
A25
E27
F26
R404
100k
CL401
CL402
C436
0.1
G25
2
X401
27MHz
1
A23
J25
B24
C437
0.1
C448
10p
C447
10p
F24
D24
C440
0.1
H24
H38
J37
K36
Y26
H
HBD-E370/E470/E570/E870/T57
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
38
38
HBD-E370/E470/E570/E870/T57
5-11. SCHEMATIC DIAGRAM - MB-134 Board (5/13) - • See page 77 for IC Pin Function Description.
1
A
2
3
4
5
6
7
8
9
10
11
MB-134 BOARD (5/13)
MB-134
BOARD
(3/13)
23
GND
3.3VA
R523
3.3k
(Page 37)
CPU_XRST
R516
0
CPU_NFREN
B
2
MB-134
BOARD
(10/13)
(Page 44)
CPU_NFCEN
CPU_NFCLE
CPU_NFALE
IC501
CPU_NFWEN
CPU_SFCK
NAND FLASH
IC501
K9GAG08U0D-PCB0T
CPU_NFCEN2
FE_SFDI
1
C
MB-134
BOARD
(12/13)
FE_SFCS
FE_SFDO
FE_SFDI
FE_SFCLK
(Page 46)
SFCS
SFCK
SFDI
D
SFDO
FESFCK
FESFDI
FESFDO
FESFCS
NFCEN
E
NFREN
NFWEN
NFRBN
NFALE
NFCLE
NFCEN2
NFRBN2
F
NFD0
NFD1
NFD2
NFD3
NFD4
NFD5
NFD6
G
NFD7
J39
JL516
G41
JL517
H40
JL518
F42
JL519
D4
JL501
C3
JL502
A1
JL503
B2
JL504
3.3
3.3
3.3
3.3
M38
JL520
M36
JL521
G43
JL522
P38
JL523
L37
JL524
K38
JL525
L39
P36
0
0
JL505
3.3
JL506
H42
JL507
CPU_NFD[0]
J41
JL511
CPU_NFD[1]
J43
JL508
CPU_NFD[2]
K40
JL512
CPU_NFD[3]
K42
JL509
CPU_NFD[4]
L41
JL513
CPU_NFD[5]
L43
JL510
CPU_NFD[6]
M40
JL514
CPU_NFD[7]
3.3
1
NC
NC 48
2
NC
NC 47
3
NC
NC 46
4
NC
NC 45
5
NC
IO8 44
6
NC
IO7 43
7
RY/XBY
IO6 42
8
XRE
IO5 41
9
XCE
NC 40
10 NC
NC 39
11 NC
NC 38
12 Vcc
Vcc 37
13 Vss
Vss 36
14 NC
NC 35
15 NC
NC 34
16 CLE
NC 33
17 ALE
IO4 32
18 XWE
IO3 31
19 XWP
IO2 30
20 NC
IO1 29
21 NC
NC 28
22 NC
NC 27
23 NC
NC 26
24 NC
NC 25
0
CPU_NFD[7]
0
CPU_NFD[6]
0
CPU_NFD[5]
0
CPU_NFD[4]
3.3
C504
0.1
R526
100k
R528
47
R530
10k
0
CPU_NFD[3]
0
CPU_NFD[2]
0
CPU_NFD[1]
0
CPU_NFD[0]
IC502
SERIAL FLASH
IC502
MX25L1605DM2I-12G
3.3
R525
0
IC101
H
MB-134
BOARD
(13/13)
3.3
0
(5/15)
0
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
3
CSP
(Chip Size Package)
R529
10k
8
VCC
S
1
7
HOLD
6
C
Q
2
W/Vpp
3
5
D
VSS
4
3.3
1.2
3.3
R531
0
JL515
C505
0.1
CPU_PRERST
C506
0.1
(Page 47)
HBD-E370/E470/E570/E870/T57
39
39
Note: IC101, IC501 and IC502 on the MB-134 board cannot exchange with single. When these parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-12. SCHEMATIC DIAGRAM - MB-134 Board (6/13) - • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
2
3
4
5
6
7
8
9
10
MB-134 BOARD (6/13)
Vo
ADJ
2
3
4
5
3.3
1
1
IC602
SI-3010KM-TLS
GND
IC601
SI-3010KM-TLS
5.1
IC602
+5V REGULATOR
Vin
ADJ
5
IC601
+5V REGULATOR
Vc
Vo
4
IC B/D
1
GND
3
5.1
Vin
2
6.3
1
3.3
B
Vc
IC B/D
6.3
A
R606
0
USB_VBUS_PCONT1
4
C
D
D601
DA2J10100L
D602
DA2J10100L
MB-134
BOARD
(10/13)
(Page 44)
USB_VBUS_PCONT2
24
MB-134
BOARD
(3/13)
C605
1
UNSW6V
C609
1
R610
2.2k
R613
2.2k
R611
39k
R614
39k
C613
220
10V
R612
10k
R618
10k
C606
1
C610
1
C608
22
10V
R615
10k
R620
0
C614
220
10V
R619
10k
GND
CSP
(Chip Size Package)
(Page 37)
IC101
CN601
5P
(6/15)
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
JL601
JL602
L604
10nH
E
4
2
JL603
JL604
L607
5
MB-134
BOARD
(4/13)
CPU_1.2VA
CPU_3.3VA
(Page 38)
F
AK8
AVDD12_USB
AK6
AVSS12_USB
AN3
AVDD33_USB
AL5
AVSS33_USB
C604
10
AM4
USB_DM0
USB_DP0
USB_DM1
USB_DP1
AK2
AL1
3
L603
10nH
D603
PGB1010603NR
D605
PGB1010603NR
JL605
AM2
JL606
4
2
JL607
JL608
L608
L605
10nH
3
DP
3
DM
4
VBUS
5
GND
1
GND
2
DP
3
DM
4
VBUS
5
1
GND
C620
10
R601
5.1k
D604
PGB1010603NR
C
R-USB
BOARD
CN151
(Page 66)
CN602
5P
AL3
USB_VRT
GND
2
1
C619
10
L606
10nH
1
B
F-USB
BOARD
CN101
(Page 66)
D606
PGB1010603NR
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
40
40
HBD-E370/E470/E570/E870/T57
5-13. SCHEMATIC DIAGRAM - MB-134 Board (7/13) - • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
3
4
5
7
8
9
25
UNSW6V
AVDD12_HDMI
AVDD33_HDMI
AVDD33_HDMI
AVSS12_HDMI
C
AVSS12_HDMI
AVSS33_HDMI
AVSS33_HDMI
CH2_P
CH2_M
CH1_P
D
CH1_M
CH0_P
CH0_M
CLK_P
CLK_M
E
HDMISCK
HDMISD
HTPLG
CEC
EXT_CAP
EXT_RES
G29
F30
5
6.3
VOUT
GND
NOISE
1
2
3
(Page 37)
IC705
+5V REGULATOR
IC705
TK11150CSCL-G
C719
0.01
C716
0.01
C713
0.22
C720
0.22
C717
0.22
J29
G27
F28
D26
TX2P
B26
TX2N
C27
TX1P
A27
TX1N
D28
TX0P
B28
TX0N
C29
TCKP
A29
TCKN
F40
JL701
E41
JL702
G39
JL703
R706
27k
S
3.3
6.3
Q702
INK0001AC1
BUFFER
TX2P
TX2N
TX1P
TX1N
TX0P
JL704
E43
B30
C721
0.1
JL705
TX0N
R749
47k
TCKP
E29
R703
1.5k
TCKN
R701
10k
R735
1.8k
R736
1.8k
5
3.3
G
4
6
3
7
2
8
V
1
C706
47
10V
0
2.7
R714
0
1.7
R713
470
IC701
R740
0
R743
0
IC701
TC7WHU04FK
R741
0
R744
0
CN701
19P
18
MB-134
BOARD
(13/13)
(Page 47)
HDMI
ARC
OUT
1
TMDS DATA2 +
2
TMDS DATA2 SHIELD
3
TMDS DATA2 -
4
TMDS DATA1 +
5
TMDS DATA1 SHIELD
6
TMDS DATA1 -
7
TMDS DATA0 +
8
TMDS DATA0 SHIELD
9
TMDS DATA0 -
10
TMDS CLOCK +
11
TMDS CLOCK SHIELD
12
TMDS CLOCK -
13
CEC
14
RESERVED(ARC)
15
SCL
16
SDA
17
DDC/CEC GND
18
+5V POWER
19
HPD
C707
1
6
C705
0.1
ARC_SPDIF
R712
0
WAVE SHAPER
C701
0.01
CEC
3.3
R711
220k
1.7
(Page 47)
H28
R710
0
1.7
MB-134
BOARD
(13/13)
PCONT3
C702
0.01
C715
0.22
C703
0.01
F
CL701
26
HDMI_PCONT
J27
R702
1k
G
IC B/D
R739
15k
R734
15k
H26
3.3VA
1.3
3
VIN
VOUT
NOISE
2
IC704
+3.3V REGULATOR
IC704
TK11133CSCL-G
MB-134
BOARD
(3/13)
1.2VA
4
3.3
AVDD12_HDMI
1
3.3
B
5
1.3
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
IC B/D
4
GND
5
CONT
6.3
(7/15)
VIN
IC101
3.3
GND
CSP
(Chip Size Package)
H
6
MB-134 BOARD (7/13)
CONT
A
2
R709
0
R717
68
R715
47k
R718
68
C708
1
R752
1k
MB-134
BOARD
(8/13)
(Page 42)
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
41
41
HBD-E370/E470/E570/E870/T57
5-14. SCHEMATIC DIAGRAM - MB-134 Board (8/13) - • See page 77 for IC Pin Function Description.
1
3
2
5
6
7
8
9
11
10
12
MB-134 BOARD (8/13)
A
B
4
CN901
16P
F
DIR_ERROR
1
SP_MCK
2
GND
3
SP_BCK
4
DIR_CSFLAG
5
SP_LRCK
6
DIR_XSTATE
7
SP_DATA
8
JL923
0
R906
47
DIR_ERROR
SP_MCK
BDV_CSFLAG
JL924
JL925
JL926
JL927
MAIN
BOARD
(5/5)
CN703
GND
9
CSI_DATAIN
10
(Page 58)
CSI_XCS_DIR
11
CSI_CLK
12
CSI_DATAOUT
13
GND
14
DATA_I
15
DIR_AUDIO
16
C
R903
R907
47
R911
0
R908
47
R905
0
R909
47
R910
0
R933
0
R916
0
R934
0
BDV_DIR_XSTATE
SP_BCK
CSI_DATAIN
9
CSI_XCS_ADAC
SP_LRCK
CSI_CLK
MB-134
BOARD
(10/13)
CSI_DATAOUT
SP_DATA
BDV_DATA_I
XAMUTE
DAC_XRST
R912
47
JL928
6
ARC_SPDIF
MB-134
BOARD
(7/13)
R904
0
CN902
18P
D
G
E
XAMUTE
1
GND
2
DIR_XRST
3
GND
4
ARC_SPDIF
5
GND
6
AOSDATA4
7
GND
8
AOBCK
9
MAIN
BOARD
(5/5)
CN701
GND
10
AOMCK
11
(Page 58)
GND
12
AOSDATA2
13
AOSDATA0
14
AOSDATA1
15
AOSDATA3
16
AOLRCK
17
GND
18
R913
0
(Page 41)
R939
0
JL929
JL930
JL931
R917
0
JL932
R914
0
AOSDATA4
JL933
R918
0
AOBCK
JL934
R919
0
JL935
R920
0
R940
22
R921
0
AOSDATA0
BD DECODER
R922
0
AOSDATA1
JL938
R923
0
AOSDATA3
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
JL939
R924
0
AOLRCK
C927
1
FE_NS_RFIN
MB-134
BOARD
(13/13)
SPMCLK
C21
R925
0
SPBCK
A21
R926
0
SP_BCK
SPLRCK
B20
R927
0
SP_LRCK
R928
0
G21
H
(Page 46)
H4
K8
JL903
BA1
JL904
AY2
JL905
F6
AV4
11
MB-134
BOARD
(12/13)
C928
1
SP_MCK
AV10
AVDD12_ST
AU7
AVDD33_ST
AV6
AVDD12_SRX1
AVSS12_ST1
AVDD12_STX1
AW5
SVCTST
SRXP_1
SRXN_1
SP_DATA
STXN_1
22
STXP_1
JL901
JL902
FE_NS_RFIP
(Page 47)
AT6
FE_NS_CLKIN_33
AU5
AR7
NS_RFIN
NS_RFIP
AOMCLK
D22
JL907
AOBCK
B22
JL908
R930
22
AW7
AOBCK
AY6
AOLRCK
E23
JL909
R931
22
AOLRCK
AOSDATA0
C23
JL910
R935
22
AOSDATA0
AOSDATA1
G23
JL911
AOSDATA1
AOSDATA2
H22
JL912
AOSDATA2
AOSDATA3
AVSS33_SACD
AOSDATA4
AVSS12_ADC
AOSDATA5
F22
JL913
E21
JL914
NS_TSTP
NS_TSTN
NS_CKIN33
AVDD33_SACD
AVDD12_ADC
SPDIF
D20
A19
AOSDATA3
R932
47
JL915
AOSDATA4
AVDD12_SRX2
AVSS12_ST2
AVDD12_STX2
AVSS12_ST2
SRXP_2
SRXN_2
STXN_2
STXP_2
RREF
JL922
XTAL25MO
XTAL25MI
AVDD33_XTAL25M
IC101
(9/15)
AVSS33_XTAL25M
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CSP
(Chip Size Package)
BB6
CL801
AV8
BC1
HR+0
BB2
8
HR-0
BA3
HT-0
BC3
HT+0
25M_BUF
AOMCK
VCLK25MI
I
(Page 38)
(8/15)
JL937
R929
10
IC101
AOSDATA2
SPDATA
G
CSP
(Chip Size Package)
C810
0.1
MB-134
BOARD
(4/13)
CPU_1.2VA
AOMCK
R936
10k
7
CPU_3.3VA
C815
0.1
JL936
F
(Page 44)
BDV_DIR_AUDIO
AU9
MB-134
BOARD
(12/13)
(Page 46)
AW9
AY4
JL803
BB4
JL804
BA5
BC5
CL804
R807
100
BA7
BA9
R806
680
CL805
R805
100k
2
X802
25MHz
R808
12k
1
BB8
AJ9
JL801
BC7
AY8
C809
0.1
C806
12p
27
C805
12p
GND
MB-134
BOARD
(3/13)
(Page 37)
HBD-E370/E470/E570/E870/T57
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
42
42
HBD-E370/E470/E570/E870/T57
5-15. SCHEMATIC DIAGRAM - MB-134 Board (9/13) - • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
3
2
4
5
6
7
8
9
MB-134 BOARD (9/13)
A
DACOUT1
DACOUT2
DACOUT3
DACOUT4
B
DACOUT5
DACOUT6
A33
C33
B32
A31
JL1001
C31
JL1002
IC B/D
AVDD33_VDACR
AVSS33_VDACR
AVDD33_VDACY
C
AVSS33_VDACY
AVDD33_VDACBG
AVSS33_VDACBG
DACFS
IC101
R1010
150
E31
VIDEO AMP
IC1003
MM1797CVBE
R1012
150
H32
0.8
3.3
R1007
150
G31
H30
C1002
0.1
D32
0.7
1.6
R1009
150
0.7
-5
R1008
150
F32
0.8
3.3
E33
R1005
2.2k
D
IC1003
D30
R1011
150
R1006
0
0.1
C1012
0.1
C1009
C1001
47
10V
(10/15)
C1016
Vcc2 16
2 Vcc1
V out 15
3 Pr in
SD/HD 14
4 Bias
Pr out 13
5 Pb in
GND 12
6 Vee 1
Pb out 11
7 PY in
PY out 10
8 Mute
Vee 2
9
3.3
R1031
75
R1035
0
0
R1028
75
R1032
0
0
R1029
75
R1033
0
1
0
0.1
C1015
0.1
VIDEO
OUT
-5
R1030
75
R1034
0
JL942
JL941
JL944
1
PB/CB
COMPONENT
VIDEO OUT
Y
C1017
47
10V
C1018
22
10V
C1014
47
10V
MB-134
BOARD
(10/13)
PR/CR
JL940
JL946
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CSP
(Chip Size Package)
12
J904
0
1
C1010
C1006
1 Vin
BD DECODER
E
11
10
XVMUTE
FORMAT1
R1016
1k
3.3
CTL
VO
2
3
1
2
3
IC B/D
IC1002
-5V REGULATOR
IC1002
NJM2828F3-05
-5
VI
CS
3.3
VO
1
3.3
(Page 47)
GND
+3.3V REGULATOR
IC1001
NJM2878F3-33(TE2)
-7
PCONT3
4
NC
IC1001
PCONT2
5
GND
29
MB-134
BOARD
(13/13)
4
VI
F
5
CTL
IC B/D
6.3
(Page 44)
DAC3.3VA
G
28
UNSW-6V
UNSW6V
MB-134
BOARD
(3/13)
(Page 37)
C1004
1
R1013
1k
C1008
0.1
GND
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
43
43
HBD-E370/E470/E570/E870/T57
5-16. SCHEMATIC DIAGRAM - MB-134 Board (10/13) - • See page 77 for IC Pin Function Description.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
MB-134 BOARD (10/13)
CSI_DATAIN
CSI_CLK
A
CSI_DATAOUT
CSP
(Chip Size Package)
IC101
CSI_XCS_ADAC
9
DAC_XRST
(11/15)
BDV_CSFLAG
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
MB-134
BOARD
(8/13)
BDV_DIR_AUDIO
BDV_DIR_XSTATE
(Page
42)
XAMUTE
B
R1123
0
DIR_ERROR
BDV_DATA_I
VOUTD6
VOUTD7
VOUTD8
VOUTD9
VOUTD10
VOUTD11
VOUTD12
VOUTD13
D
VOUTD14
VOUTD15
VOUTD16
VOUTD17
VOUTD18
VOUTD19
VOUTVSYNC
E
VOUTHSYNC
VOUTCLK1
VOUTCLK2
16
NC
D6
17
NC
B6
18
NC
C7
19
NC
A7
20
NC
EEPROM
R1141
0
NC 10
IC1101
MFI341S2161
CSP
(Chip Size Package)
C9
A9
1
2
3
4
5
B8
IC1101
VSS
I2C_SCL
NC
A5
VCC
C
C5
RESET
VOUTD5
B4
MODE0
VOUTD4
15 14 13 12 11
E7
I2C_SDA
VOUTD3
NC
VOUTD2
A3
MODE1
VOUTD1
D8
NC
VOUTD0
NC
9
NC
8
NC
7
NC
6
JL1122
VIND1
F
VIND2
VIND3
VIND4
VIND5
VIND6
VIND7
VIND8
VIND9
G
VIND10
VIND11
VIND12
VIND13
VIND14
VIND15
VIND16
VIND17
H
VIND18
VIND19
VINVSYNC
VINHSYNC
VINCLK
MB-134
BOARD
(3/13)
3.3VA
R1125
0
R1124
47
R1162
47
R1163
47
RB1101
10k
RB1102
10k
(Page 37)
D10
B10
C11
E11
R1119
47
F12
G13
E13
G11
F10
E9
F8
R1118
0
R1122
0
R1191
0
C1105
0.1
AT4
XO_RTC
AR5
RTCRBIAS
AU1
C1107
100p
C1104
100p
JL1102
SCL
SDA
R1120
10k
C1108
100p
C1109
100p
AVDD33_RTC
AVSS33_RTC
UATXD
UARXD
TRST_
JL1117
F20
TCK
MCIN
TMS
JL1103
JL1110
JL1104
JL1106
R1101
0
D12
JL1107
R1102
0
E15
JL1105
F16
JL1108
R1103
0
B12
JL1109
F14
JL1145
H14
JL1146
F18
R1107
G15
JL1148
J17
JL1149
G17
R1110
C13
JL1151
A13
JL1135
D14
JL1136
B14
JL1137
C15
JL1138
A15
JL1139
D18
JL1140
G19
JL1141
E19
JL1142
E17
JL1152
D16
XI_RTC
AU3
JL1101
A11
B16
AT2
JL1158
C1103
100p
VIND0
30
CORE_STB3.3V
GND
R1131
0
JL1115
0
MRESET_
RESET_
0
A35
VCLK
0
G33
LCDRD
CORE_RESETB
C17
GPIO0
R1134
0
R1127
R1135
100
A17
GPIO1
JL1116
C19
GPIO2
B18
GPIO3
JL1156
AY10
GPIO4
AW11
GPIO5
AV12
GPIO6
BC9
GPIO7
0
R1136
0
JL1154
C1101
100p
VDATA
R1133
JL1157
JL1155
C1102
100p
VSTB
B34
R1132
JL1153
JL1150
D34
TDI
TDO
JL1113
JL1114
JL1147
AMUTE
JL1112
JL1111
0
H20
R1121
100
JL1129
AV14
JL1130
JL1131
D36
JL1120
JL1132
A37
JL1121
JL1133
JL1134
AY12
JL1123
BA11
JL1126
BC11
JL1125
BB12
JL1124
BB10
JL1128
IR
OPWRSB
R1169
GND
3
RXD
4
TXD
5
JIG_MODE1
6
JIG_MODE0
(NC)
13
MRESET
AP4
MB-134
BOARD
(12/13)
R1156
100
(Page 46)
R1153
4.7k
AU11
JL1118
B36
F34
16
R1164
10k
CPU_XRST
R1157
0
JL1119
MB-134
BOARD
(11/13)
C1111
100p
(Page 45)
R1190
100
(12/15)
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
R1116
0
3.3V
2
E35
R1165
100
IC101
1
10k
C35
R1152
4.7k
EFPWRQ
CN1102
6P
AT12
15
CPU_3.3VA
MB-134
BOARD
(4/13)
CSP
(Chip Size Package)
R1115
0
(Page 38)
JL1143
JL1144
I
MB-134
BOARD
(9/13)
12
FORMAT1
XVMUTE
(Page 43)
MB-134
BOARD
(6/13)
J (Page 40)
4
USB_VBUS_PCONT1
CPU_XRST
USB_VBUS_PCONT2
CPU_NFALE
R1149
10k
R1117
0
CPU_SFCK
R1147
10k
SYSCON_RST
14
K
MB-134
BOARD
(13/13)
(Page 47)
IF_SDO
CPU_NFCEN2
IF_SCK
CPU_NFWEN
IF_SDI
CPU_NFCLE
SYSCON_REQ
CPU_NFREN
START_BIT
CPU_NFCEN
2
MB-134
BOARD
(5/13)
(Page 39)
FE_SFDI
XIF_CS
UPG_STATUS
R1189
100k
JIG_MODE1
R1138
10k
RB1103
10k
R1139
10k
OPWRSB
CORE_RST
HBD-E370/E470/E570/E870/T57
44
44
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-17. SCHEMATIC DIAGRAM - MB-134 Board (11/13) - • See page 77 for IC Pin Function Description.
1
2
3
4
5
6
7
8
9
10
MB-134 BOARD (11/13)
A
ETTXD3
ETTXD2
ETTXD1
ETTXD0
B
R1201
10
49.9
49.9
49.9
R1207
R1206
R1205
R1204
49.9
C1208
0.01
C1206
0.01
C1218
0.01
C1210
4.7
R1232
10k
R1231
10k
CN1201
8P
ETHERNET
CONNECTOR
1
R1217
100
ETTXCLK
R1216
100
ETRXER
R1220
100
ETRXCLK
R1218
100
ETRXDV
L1202
LAN (100)
C
JL1201
3
ETRXD0
1
ETRXD1
3
ETRXD2
C1201
0.022
R1208
2.4k
R1209
10k
RX_DV
RX_ER
RX_CLK
17
30
VDDA3.3
RXD2
16
31
RXN
RXD3
15
32
RXP
33
VDDA3.3
34
EXRES1
35
VDDA3.3
36
COL
IC1201
ETHERNET INTERFACE
IC1201
LAN8700C-AEZG-CTI
1
2
3
4
5
6
7
8
9
CLKIN
14
XTAL2
13
PA3
12
PA2
11
PA1
10
R1226
10k
JL1207
C43
ETTXD1
JL1208
D40
ETTXD2
JL1209
D42
ETTXD3
JL1210
E39
ETTXEN
JL1211
D38
ETMDC
JL1212
F36
ETMDIO
JL1213
B38
ETTXCLK
JL1214
C41
ETRXCLK
JL1215
A43
ETCRS
JL1216
H34
ETRXD0
JL1217
A41
ETRXD1
JL1218
B40
ETRXD2
JL1219
C39
ETRXD3
JL1220
A39
ETCOL
JL1221
C37
ETRXDV
JL1222
F38
ETTXER
JL1223
E37
ETRXER
JL1224
B42
IC101
ETTXD0
ETTXD1
ETTXD2
ETTXD3
ETTXEN
ETMDC
ETMDIO
ETTXCLK
ETRXCLK
ETCRS
ETRXD0
ETRXD1
ETRXD2
ETRXD3
ETCOL
ETRXDV
ETTXER
ETRXER
(13/15)
BD DECODER
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CSP
(Chip Size Package)
X1201
25MHz
R1215
100
CPU_XRST
MB-134
BOARD
(10/13)
1
2
(Page 44)
31
TXD0
18
RXD1
E
16
TXCLK
RXD0
TXP
PA0
2
TXN
CSP
(Chip Size Package)
ETTXD0
RB1201
100
29
VDD_CORE
4
ETRXD3
28
VDD33
1
TX_EN
3
TXD1
JL1206
nRST
JL1205
7
MDIO
6
L1201
TXD2
JL1204
2
VDDIO
4
4
CRS
JL1203
TXD3
5
27 26 25 24 23 22 21 20 19
TX_ER
JL1202
MDC
2
8
D
F
11
R1214
10k
CORE_STB3.3V
R1227
100k
MB-134
BOARD
(3/13)
(Page 37)
C1214
4.7
C1215
0.1
C1213
0.01
GND
R1219
1.5k
C1217
15p
C1216
15p
ETTXEN
G
R1247
100
R1213
100
ETMDIO
ETCRS
ETMDC
ETTXER
R1210
100
ETCOL
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
45
45
HBD-E370/E470/E570/E870/T57
5-18. SCHEMATIC DIAGRAM - MB-134 Board (12/13) - • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
4
5
6
11
10
12
16
17
5
C
1.4
C2405
2.2
6
7
8
9
CL2410
CL2411
FE_FG
FE_FMO2
CL2416
R2417
36k
CL2417
FE_FMO
CL2418
FE_DMO
R2418
10k
CL2419
FE_TYPWM
R2419
0
R2420
51k
CL2420
FE_TRO
R2421
91k
CL2421
FE_FOO
CL2422
FE_TLO
R2422
91k
PGND_3
TEST1
13.2
0
13 XMUTE1
0
15 GC
16 VSLED1
0
17 VSLED2
18 VSPIN
0
19 VLOAD
0
20 VTRK
0
21 VFCS
0
22 VTLT
0
FE_TILT-
0
25 TLT_N
5
26 P5V_1
0
FE_FR+
0
2200p
470p
C2416
0.1
C2419
470p
68p
C2420
C2417
68p
C2421
C2418
68p
C2422
FE_FR-
C2486
10
H
24 TLT_P
27 FCS_P
28 FCS_N
43
ICOM1
R2487
0
C2491
10
CL2472
SL2473
CL2471
FE_SPDL_U
C2440
0.1
C2438
10
R2483
0
R1372
2.2k
IC101
37
TEST6
LOAD-
(14/15)
35
AGND_2
0
33
LOAD_N
FB2481
0
R1302
10k
FE_TR-
0
29
TRK_P
FE_EJECT
FE_TRAYOUT
0
30
TRK_N
FE_TRAYIN
5
31
P5V12L
FE_TR+
C2481
10
C2432
0.01
FE_SW12V
C2433
0.01
FE_SW5V
GND
IC2301
AG9
2
Latch_SET
29
Latch_XRSOUT
CL2329
Latch_CLR
CSW 28
CL2328
SWR_SEQ1
CSWO 27
CL2327
SWR_SEQ2
TEST1 26
SWR_OUTSEL
6 /XMUTE FB3P3V 25
AG1
JL1312
AE9
JL1313
AT10
JL1302
E3
FE_GIO4
JL1304
J7
FE_GIO5
JL1305
J5
FE_GIO6
JL1306
G9
FE_GIO7
JL1307
G5
JL1308
L9
JL1309
E5
JL1310
H8
JL1311
D2
32
R1308
10k
MB-134
BOARD
(3/13)
CL1317
JL1319
CL2302
4
AD8
JL1301
(Page 37)
CL2330
3
JL1300
JL1303
0
32
LOAD_P
5
0
0
0
5
FE_V14REF
7
STEP_ENA
REG3P3V 24
8
STP1_IN
PGND_SW 23
JL1316
JL1318
G7
AV2
AW3
CL1315
H2
AW1
CL1314
H6
AJ3
AJ1
5
11 CSWON
0
K
13
5
14
AL7
L2322
1.5uH
AN7
AP6
AP8
FE_CO_A-
XRESET
0
FE_CO_A+
0
FE_CO_B-
STP2+ 18
STP1- 17
STP1+ 16
E1
FE_SFCS#
K6
FE_SFWP#
FE_GIO13
FE_SFHOLD#
L7
FE_GIO3
FE_GIO12
FE_GIO2
FE_GIO4
FE_GIO5
1
FE_SFCLK
FE_SFDI
FE_SFDO
FE_SFCS
MB-134
BOARD
(5/13)
(Page 39)
F4
FE_PLAY#
AH2
CL1398
FE_EJECT#
AH4
CL1399
FE_GIO6
FE_GIO7
FE_GIO8
FE_GIO9
FE_GIO10
FE_GIO11
FE_JTCLK
FE_JRTCLK
FE_JTDI
FE_JTDO
C1398
0.1
FE_JTMS
C1399
0.1
FE_JTRST#
FE_XTAL25MI
FE_XTAL25MO
FE_SXVDD33
FE_SVDD33
C1387
0.01
(Page 42)
C1389
0.01
FE_STXP
AN1
FE_STXN
FE_SPLLVDD12
FE_SRXN
FE_STXVDD12
FE_SRXP
FE_AVDD12_RX
AP2
C1386
0.01
C1388
0.01
AR3
C1383
0.01
C1385
0.01
AR1
C1382
0.01
C1384
0.01
FE_SAGND
FE_RSTI
HR+0
8
HR-0
HT-0
HT+0
JL1370
AN5
0
A5V
F2
FE_SFDO
FE_1.2V
COLLIENDZ
STP2- 19
15 AGND
FB2300
2.2
FB1PxV 20
AM6
L2324
1.5uH
0
C1
FE_SFDI
FE_GIO1
C2322
10
0
XLEDON
10
P5V_SW 21
FE_SFCLK
FE_GIO0
FE_3.3V
C2324
10
0
STP2_IN
REG1PxV 22
9
12
25M_BUF
MB-134
BOARD
(8/13)
M6
C2371
10
11
FE_NS_CLKIN_33
C1362
2.2
C1361
0.01
C1363
100p
C1326
0.01
C1366
2.2
C1367
0.01
C1365
100p
C1370
0.1
MB-134
BOARD
(8/13)
R1370
1k
FE_CO_B+
0
(Page 42)
C1305
100
16V
L
FE_BUS
17
MB-134
BOARD
(13/13)
(Page 47)
HBD-E370/E470/E570/E870/T57
1
BD DRIVE
BPX-5
(2/3)
36
TEST5
LEDO
Latch_RSOUT 30
C2300
0.1
LOAD+
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
1
C2308
470p
TRAY-IN
2
CL2483
5
C2309
470p
GND
3
BD DECODER
5
R2309
22k
TRAY-OUT
4
CSP
(Chip Size Package)
CL2301
FE_FMO3
5
CN2470
5P
FE_SPDL_W
38
AGND_3
IC B/D
R2308
22k
COMMON
CL2487
5
39
P5V_2
R2447
0.16 1/3W
10
40
CL2303
FE_FMO4
W
1
13.2
41
C10V
SL2497
CL1300
0
42
P12V_1
R2496
1.8k
FE_SPDL_V
0
C2364
10
FE_GAINSW
V
2
BD DRIVE
BPX-5
(1/3)
C2460
0.1
MOTOR DRIVER, REGULATOR
IC2301
TPIC1391DBTRG4
I
3
FE_SPDL_U
FE_GND_M
R2307
47k
U
FE_SPDL_V
23 PGND_1
34
PGND_2
FE_TILT+
FGND
4
FE_SPDL_W
SL2475
44
V
U
0
0
46
W
0
C2495
10
0
12 MONITOR
45
P12V_2
14 XMUTE2
B
5
FE_SPDL_COMMON
47
ICOM2
0
/B
6
C2499
10
0
48
ISENSE
10 TEST4
C2450
0.1
49
MCOM
TEST3
FE_SLED_B+
13.2
50
CV3P3
TEST2
0
51
11 XFG
CL2414
R2416
36k
SLED1_N
FE_SLED_B-
0
CL2413
FE_GAINSW2
53
AGND_1
52
SLED1_P
VREF
A
7
FE_SPDL_COMMON
0
0
CL2412
FE_LIMIT
CA5V
13.2
54
P12V_3
FE_SLED_A+
1.8k
4
CP1
0
1.8k
5
55
SLED2_P
FE_SLED_A-
1.8k
C2404
1
3
CP2
56
SLED2_N
0
R2446
0
2
/A
8
FE_SLED_B+
R2494
13.2
C2402
0.1
1
C19V
9
FE_SLED_B-
1.8k
19.7
J
15
FE_SLED_A+
IC2401
TPIC1405DFDRG4
B
G
14
13
FE_SLED_A-
C2400
100
16V
MOTOR DRIVER
F
9
CN2460
9P
C2401
0.1
IC B/D
R2444
C2470
0.1
1.8k
C2403
0.1
FB2403
2.2
R2492
R2411
33k
IC2401
E
8
MB-134 BOARD (12/13)
R2412
33k
D
7
R2442
A
3
2
R1371
10
MRESET
13
MB-134
BOARD
(10/13)
(Page 44)
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
46
46
HBD-E370/E470/E570/E870/T57
5-19. SCHEMATIC DIAGRAM - MB-134 Board (13/13) - • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
3
2
4
5
6
7
8
MB-134 BOARD (13/13)
A
PCONT3
CEC
(Page 41)
B
UPG_STATUS
R1524
10k
XIF_CS
R1613
100k
C
D
H
MAIN
BOARD
(2/5)
CN505
(Page 55)
E
F
1
GND
2
XIF_RST
3
IF_START_BIT
4
SYSCON_REQ
5
GND
6
IF_SCK
7
GND
8
IF_SDO
9
PCONT_CORE
10
IF_SDI
11
BD_PCONT2
12
XIF_CS
13
BD_PCONT3
14
HDMI_PCONT
15
UPG_STATUS
16
JIG_MODE1
17
GND
18
CEC
19
GND
20
FE_EJECT
21
NC
22
CPU_PRERST
23
CORE_RST
24
ATA_PCONT
25
OPWRSB
26
BD_PCONT4
27
R1569
0
JL1536
JL1537
JL1538
R1570
R1571
JL1539
SYSCON_RST
0
0
JL1540
JL1541
R1573
0
IF_SCK
IF_SDO
R1574
0
R1575
0
IF_SDI
JL1544
R1576
0
PCONT2
JL1545
R1577
0
XIF_CS
JL1546
R1578
0
JL1547
R1579
0
JL1548
R1580
0
PCONT_CORE
UPG_STATUS
0
JL1551
JL1567
R1584
0
JL1570
R1585
0
JL1571
R1565
0
JL1553
R1566
0
ATA_PCONT
(Page 37)
R1552
100k
IF_SDO
R1609
100k
CPU_PRERST
START_BIT
IF_SCK
R1543
10k
C1423
0.1
Y2
FE_RFIP
CL1422
C1422
0.1
Y4
FE_RFIN
FE_DRFO+
CL1426
C1426
0.1
W1
FE_RFIP2
FE_DRFO-
CL1425
C1425
0.1
W3
FE_RFIN2
FE_IN_A
CL1430
P2
FE_INA
FE_IN_B
CL1432
N1
FE_INB
FE_IN_C
CL1420
R3
FE_INC
FE_IN_D
CL1428
T6
FE_IND
FE_IN_E
CL1419
V6
FE_INE
FE_IN_F
CL1417
U1
FE_INF
FE_IN_G
CL1431
R1
FE_ING
FE_IN_H
CL1433
T2
FE_INH
FE_LDD_SDIO
JL1408
AD2
FE_CFREQ
FE_LDD_SEN
JL1406
AF8
FE_CMOD
FE_LDD_CLK
JL1407
AE7
FE_OSOEN
SYSCON_RST
XIF_CS
XIF_CS
CORE_RST
CORE_RST
UPG_STATUS
ATA_PCONT
CL1474
CL1476
SYSCON_REQ
SYSCON_RST
RB1503
100
CL1473
CL1475
IF_SDI
UPG_STATUS
JIG_MODE1
14
CL1477
MB-134
BOARD
(10/13)
CL1478
(Page 44)
CL1480
CL1479
CL1481
R1586
100
R1503
10k
FE_FPDODVD
CL1484
CN1401
45P
CL1401
H
I
BD DRIVE
BPX-5
(3/3)
J
K
L
1
MODE_B
2
MODE_A
3
TEST_V
4
LDEN
5
SEN_LDD
6
SCLK
7
SDIO
8
GND
9
8.0V
10
GND
11
5.0V
12
GND
13
3.3V
14
GND
15
GND
16
H
17
VC_PD
18
G
19
D
20
GND
21
BD_RF-
22
BD_RF+
23
GND
24
DVD_RF-
25
DVD_RF+
26
GND
27
C
28
5V_PD
29
B
30
E
31
A
32
F
33
THERMO
34
SA_INIT
35
SA_A-
36
SA_A+
37
SA_B-
38
SA_B+
39
FD1
40
FR1
41
TR
42
TD
43
FD2
44
FR2
45
FE_AUX1
CL1402
CL1404
CL1406
FE_LDD_CLK
CL1408
FE_LDD_SDIO
C1410
100p
C1409
0.1
C1417
100p
R1410
2.2k
R1454
47k
3.3
13.2
C1454
0.1
4 EN
GND 3
5 NC
FB 2
6 VCC
R1412
4.7k
C1415
2.2
FE_AGND
FE_AGND
FE_AGND
FE_AGND
FE_DVDD33O
FE_DVDD33O
FE_DVDD33O
FE_DVDD33O
V2
FE_FOIP
U3
FE_FOIN
P4
FE_TRINA
R5
FE_TRINB
N3
FE_TRINC
R7
FE_TRIND
G1
FE_VRDC0
P6
FE_VWDC1O
M2
FE_VWDC2O
L1
FE_VWDC3O
FE_DVDD33O
FE_DVDD33O
L5
FE_MPXOUT1
FE_MPXOUT2
CL1491
J3
FE_MPXOUT3
JL1404
T4
FE_FPDODVD
CL1494
JL1484
U5
FE_FPDOCD
AH8
JL1485
M4
FE_AUX1
Y6
FE_LVDS_1N
AA5
FE_LVDS_1P
AA3
FE_LVDS_2N
AA1
FE_LVDS_2P
AB4
FE_LVDS_3N
AC3
FE_LVDS_3P
AB2
Vo 1
FE_LVDS_4N
AC1
FE_LVDS_4P
CL1496
R1453
750k
CL1487
CL1497
0
CL1488
7.9
CL1498
7
CL1489
R1452
82k
C1414
0.001
R1429
10k
CL1454
C1456
0.1
CL1499
CL1471
C1457
100
16V
CL1482
C1421
2.2
CL1483
FE_DVDD12I
FE_DVDD12I
FE_DVDD12I
FE_DVDD12I
FE_DVDD12I
FE_DVDD12I
FE_MVDDQ
FE_MVDDQ
P8
R9
AB8
C1468
0.1
C1469
0.1
AC7
V8
U9
W9
C1476
0.1
C1477
0.1
AA9
W5
W7
AA7
Y8
N7
N9
AC9
C1480
0.1
C1481
0.1
P10
AB10
N11
AB12
T8
T10
V10
C1491
0.1
C1493
0.1
Y10
U11
W11
M8
C1499
0.1
M10
FE_FSOURCE
C1418
0.001
FE_IN_E
FE_RFO+
33
FE_DRFO-
MB-134
BOARD
(3/13)
FE_RFO-
GND
2.2
FE_IN_A
FE_IN_B
FE_IN_H
CL1434
C1435
CL1435
R1435
0.1
0.01
10
FE_VHAVC
C1475
4.7
FE_GND_M
FE_IN_G
C1434
C1400
0.1
FE_SW5V
FE_IN_D
0.001
CL1470
FE_SW12V
(Page 37)
FE_DRFO+
C1429
JL1435
FE_VDAC0
FE_IN_C
C1427
AB6
FE_LVDS_5N
AC5
FE_LVDS_5P
AE5
FE_GAINSW1
AD6
FE_GAINSW2
AG5
FE_GAINSW3
FE_VHAVC
FE_AUX1
C1474
0.01
FE_FMO
FE_GIO6
FE_GIO5
FE_GIO4
CL1438
FE_GIO7
CL1439
FE_EJECT
CL1440
FE_CO_A-
CL1441
FE_CO_A+
CL1442
FE_CO_B-
CL1443
FE_CO_B+
CL1444
FE_FR+
10
FE_V14
N5
FE_VFVREF
J1
FE_HAVC
AE1
FE_FMO
AF4
FE_FMO2
AG7
FE_FMO3
FE_FMO4
AF6
FE_FMO4
FE_FOO
AD4
FE_FOO
FE_TRO
AH6
FE_TRO
FE_DMO
AF2
FE_DMO
FE_TLO
AM8
FE_TLO
C1461
0.01
AK4
FE_TRAYOUT
FE_TRAYIN
AJ5
FE_TRAYIN#
FE_TYPWM
AE3
FE_TRAYPWM
FE_LIMIT
AG3
FE_LIMIT
FE_FG
G3
FE_FG
C1462
0.01
FE_NS_RFIP
MB-134
BOARD
(8/13)
FE_VDAC0
FE_FMO3
FE_TRAYOUT
FE_VDAC0
L3
U7
FE_FMO2
FE_NS_RFIN
C1472
0.01
FE_GAINSW
(Page 42)
FE_FR-
C1473
4.7
FE_V14REF
FE_TRFE_TILT+
IC101
(15/15)
BD DECODER
FE_GAINSW2
FE_TR+
M
FE_AVDD33_LVDS
K2
CL1486
FE_IN_F
CL1445
FE_AVDD33
CL1492
CL1485
C1452
10
C1413
2.2
CL1437
FE_AVDD33
CL1493
CL1495
+8V REGULATOR
IC1451
BD35630HFV-TR
FE_LDD_SEN
CL1407
C1451
0.01
IC1451
FE_FPDODVD
CL1405
CL1436
15
IC B/D
CL1403
GND
G
MODE_C
FE_AVDD33
JIG_MODE1
OPWRSB
PCONT4
FE_AVDD12_4
FE_DVDD33O
CL1472
IF_SDO
SYSCON_REQ
FE_AVDD12_3
CL1423
IF_SCK
IF_SDO
FE_REG_CAP
FE_AVDD12_1
FE_EQBIAS
FE_AVDD12_2
FE_RFO-
START_BIT
IF_SDI
CPU_PRERST
3
K4
FE_RFO+
(Page 39)
R1546
10k
IF_SDI
V4
MB-134
BOARD
(5/13)
R1540
0
R1598
0
JL1552
PCONT4
IF_SCK
R1567
0
JL1554
ATA_PCONT
CPU_PRERST
JIG_MODE1
R1582
0
MB-134
BOARD
(3/13)
PCONT_CORE
R1535
3.3k
PCONT3
PCONT3
PCONT2
PCONT_CORE
R1551
100k
34
PCONT3
PCONT2
R1536
100k
PCONT2
JL1543
R1581
R1554
0
PCONT_CORE
JL1542
JL1550
CORE_RST
MB-134
BOARD
(9/13)
14
C1470
0.1
R1470
1.2k
(Page 43)
PCONT3
R1611
100k
SYSCON_REQ
R1572
0
JL1549
SYSCON_RST
START_BIT
PCONT2
R1563
100k
ATA_PCONT
R1471
22k
29
PCONT3
R1562
100k
SYSCON_REQ
R1568
0
JL1535
TEMP
13
(Page 41)
R1612
100k
START_BIT
CN1505
27P
12
MB-134
BOARD
(7/13)
TH1501
MB-134
BOARD
(7/13)
11
10
26
HDMI_PCONT
18
9
IC101
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
CSP
(Chip Size Package)
FE_3.3V
FE_TILT-
FE_1.2V
MB-134
BOARD
(12/13)
17
FE_BUS
(Page 46)
HBD-E370/E470/E570/E870/T57
47
47
Note: IC101 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-20. PRINTED WIRING BOARD - MB-134 Board (Component Side)- • See page 34 for Circuit Boards Location. •
1
2
3
4
5
6
7
8
9
10
11
(Page 60)
BOARD
E REGCN402
MB-134 BOARD (COMPONENT SIDE)
A
: Uses unleaded solder.
(CHASSIS)
(NC)
1
24
CN1102
1
6
L304
RB203
C506
R529
R531
R528
R530
C1218
C1210
R8 R7
P9 P8 P7
N8 N7
M9 M8 M7
L8 L7
K9 K8 K7
J9 J8 J7
H9 H8 H7
G9 G8 G7
F9 F8 F7
E9 E8 E7
D9 D8 D7
C9 C8 C7
B9 B8 B7
A9 A8 A7
8
1
R525
R526
4
5
R1147
IC502
C
C505
R207
C235
C248
R8 R7
P9 P8 P7
N8 N7
M9 M8 M7
L8 L7
K9 K8 K7
J9 J8 J7
H9 H8 H7
G9 G8 G7
F9 F8 F7
E9 E8 E7
D9 D8 D7
C9 C8 C7
B9 B8 B7
A9 A8 A7
R206
JL2253
K
A
FL302
R3 R2 R1
P3 P2
N3 N2 N1
M3 M2
L3 L2 L1
K3 K2
J3 J2 J1
H3 H2 H1
G3 G2 G1
F3 F2 F1
E3 E2 E1
D3 D2 D1
C3 C2 C1
B3 B2 B1
A3 A2 A1
C214
FL301
(CHASSIS)
C337
L301
JL2201
JL296
JL299
JL297
JL2254
JL2251
D304
IC204
RB201
R3 R2 R1
P3 P2
N3 N2 N1
M3 M2
L3 L2 L1
K3 K2
J3 J2 J1
H3 H2 H1
G3 G2 G1
F3 F2 F1
E3 E2 E1
D3 D2 D1
C3 C2 C1
B3 B2 B1
A3 A2 A1
JL2250
PT105
C236
JL1516
C141
R1551
RB1503
R1554
R1552
JL1568
C146
R1232
R1231
R107
C246
JL2152
JL2151
C232
IC1002
5
C1008 1
3
PT104
4 R1016
C1111
R1165
R1164
R1132
R1008
R1007
C1009
C1014
R1034
C1017
R1009
C1001
R1012
R1033
R1032
E
R1030
R1035
9
R1029
IC1003
C448
R404
C447
8
R1028
1
16
R1031
CL402
C1018
R403
CL401
R940
R926
R925
R927
(CHASSIS)
C1109
R1127
R1135
R1134
R752
R741
R744
F
X401
R1122
R928
R1121
R1116
R1115
R743
R740
CN701
PT106
A31
A30
A29
A28
A27
A26
A25
A24
A23
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
B32
B31
B30
B29
B28
B27
B26
B25
B24
B23
B22
B21
B20
B19
B18
B17
B16
B15
B14
B13
B12
B11
B10
B9
B8
B7
B6
B5
B4
B3
B2
C33
C32
C31
C30
C29
C28
C27
C26
C25
C24
C23
C22
C21
C20
C19
C18
C17
C16
C15
C14
C13
C12
C11
C10
C9
C8
C7
C6
C5
C4
C3
C2
C1
D33
D32
D31
D30
D29
D28
D27
D26
D25
D24
D23
D22
D21
D20
D19
D18
D17
D16
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
E33
E32
E31
E30
E29
E28
E27
E26
E25
E24
E23
E22
E21
E20
E19
E18
E17
E16
E15
E14
E13
E12
E11
E10
E9
E8
E7
E6
E5
E4
E3
E2
E1
F33
F32
F31
F30
F29
F28
F27
F26
F25
F24
F23
F22
F21
F20
F19
F18
F17
F16
F15
F14
F13
F12
F11
F10
F9
F8
F7
F6
F5
F4
F3
F2
F1
G33
G32
G31
G30
G29
G28
G27
G26
G25
G24
G23
G22
G21
G20
G19
G18
G17
G16
G15
G14
G13
G12
G11
G10
G9
G8
G7
G6
G5
G4
G3
G2
G1
H33
H32
H31
H30
H29
H28
H27
J33
J32
J31
J30
J29
J28
J27
K33
K32
K31
K30
K29
K28
K27
L33
L32
L31
L30
L29
L28
L27
M33
M32
M31
M30
M29
M28
M27
N33
N32
N31
N30
N29
N28
N27
P33
P32
P31
P30
P29
P28
P27
R33
R32
R31
R30
R29
R28
R27
JL228
T33
T32
T31
T30
T29
T28
T27
U33
U32
U31
U30
U29
U28
U27
V33
V32
V31
V30
V29
V28
V27
W33
W32
W31
W30
W29
W28
W27
Y33
Y32
Y31
Y30
Y29
Y28
Y27
IC101
H7
H6
H5
H4
H3
H2
H1
J7
J6
J5
J4
J3
J2
J1
K7
K6
K5
K4
K3
K2
K1
L7
L6
L5
L4
L3
L2
L1
M7
M6
M5
M4
M3
M2
M1
N7
N6
N5
N4
N3
N2
N1
P7
P6
P5
P4
P3
P2
P1
R7
R6
R5
R4
R3
R2
R1
T7
T6
T5
T4
T3
T2
T1
U7
U6
U5
U4
U3
U2
U1
V7
V6
V5
V4
V3
V2
V1
W7
W6
W5
W4
W3
W2
W1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
AA33 AB33 AC33 AD33 AE33 AF33 AG33 AH33
AA32 AB32 AC32 AD32 AE32 AF32 AG32 AH32
AA31 AB31 AC31 AD31 AE31 AF31 AG31 AH31
AA30 AB30 AC30 AD30 AE30 AF30 AG30 AH30
AA29 AB29 AC29 AD29 AE29 AF29 AG29 AH29
AA28 AB28 AC28 AD28 AE28 AF28 AG28 AH28
AA27 AB27 AC27 AD27 AE27 AF27 AG27 AH27
AG26 AH26
AG25 AH25
AG24 AH24
AG23 AH23
AG22 AH22
AG21 AH21
AG20 AH20
AG19 AH19
AG18 AH18
AG17 AH17
AG16 AH16
AG15 AH15
AG14 AH14
AG13 AH13
AG12 AH12
AG11 AH11
AG10 AH10
AG9 AH9
AG8 AH8
AA7 AB7 AC7 AD7 AE7 AF7 AG7 AH7
AA6 AB6 AC6 AD6 AE6 AF6 AG6 AH6
AA5 AB5 AC5 AD5 AE5 AF5 AG5 AH5
AB4
AC4
AA4
AD4 AE4 AF4 AG4 AH4
AA3 AB3 AC3 AD3 AE3 AF3 AG3 AH3
AA2 AB2 AC2 AD2 AE2 AF2 AG2 AH2
AA1 AB1 AC1 AD1 AE1 AF1 AG1 AH1
JL225
AJ33 AK33 AL33
AJ32 AK32 AL32 AM32
AJ31 AK31 AL31 AM31 AN31
AJ30 AK30 AL30 AM30 AN30
AJ29 AK29 AL29 AM29 AN29
AJ28 AK28 AL28 AM28 AN28
AJ27 AK27 AL27 AM27 AN27
AJ26 AK26 AL26 AM26 AN26
AJ25 AK25 AL25 AM25 AN25
AJ24 AK24 AL24 AM24 AN24
AJ23 AK23 AL23 AM23 AN23
AJ22 AK22 AL22 AM22 AN22
AJ21 AK21 AL21 AM21 AN21
AJ20 AK20 AL20 AM20 AN20
AJ19 AK19 AL19 AM19 AN19
AJ18 AK18 AL18 AM18 AN18
AJ17 AK17 AL17 AM17 AN17
AJ16 AK16 AL16 AM16 AN16
AJ15 AK15 AL15 AM15 AN15
AJ14 AK14 AL14 AM14 AN14
AJ13 AK13 AL13 AM13 AN13
AJ12 AK12 AL12 AM12 AN12
AJ11 AK11 AL11 AM11 AN11
AJ10 AK10 AL10 AM10 AN10
AJ9 AK9 AL9 AM9 AN9
AJ8 AK8 AL8 AM8 AN8
AJ7 AK7 AL7 AM7 AN7
AJ6 AK6 AL6 AM6 AN6
AJ5 AK5 AL5 AM5 AN5
AJ4 AK4 AL4 AM4 AN4
AJ3 AK3 AL3 AM3 AN3
AJ2 AK2 AL2 AM2
AJ1 AK1 AL1
C1470
C1422
R1470
C1423
A3 B3 C3 D3 E3 F3 G3 H3 J3 K3 L3 M3 N3 P3 R3
A2 B2 C2 D2 E2 F2 G2 H2 J2 K2 L2 M2 N2 P2 R2
A1 B1 C1 D1 E1 F1 G1 H1 J1 L1 N1 R1
JL141
JL140
JL139
JL138
RB105
RB101
JL196
R805
X802
JL197
JL2101
C805
C143
C806
R808
R807
CL801
CL805
CL804
JL199
A9 B9 C9 D9 E9 F9 G9 H9 J9 K9 M9 P9
A8 B8 C8 D8 E8 F8 G8 H8 J8 K8 L8 M8 N8 P8 R8
A7 B7 C7 D7 E7 F7 G7 H7 J7 K7 L7 M7 N7 P7 R7
A3 B3 C3 D3 E3 F3 G3 H3 J3 K3 L3 M3 N3 P3 R3
A2 B2 C2 D2 E2 F2 G2 H2 J2 K2 L2 M2 N2 P2 R2
A1 B1 C1 D1 E1 F1 G1 H1 J1 L1 N1 R1
PT103
R1471
C1425
C1474
MAIN BOARD
CN701
(Page 52)
8
R710
15
1
16
20
IC1101
C1105
R1119
R1117
R1118
R913
R319
R320
4
IC307 5
3
1
C313
I
R912
R934
R933
R905
R911
R903
CL1332
R923
R921
GND1
CL1331
CL1483
L607
D603
R904
2
R916
R910
R909
R908
R907
R906
1
IC1451
C1454 4
6
R1454
C1456
CL1454
CL1336
CL1325 CL1322
CL1335
CL1334 CL1328
CL1333
R1453
R1452
3 1
R1410
CL1405
C1457
CL1403
CL1402
CL1401
R1412
C1413
D604
D605
5
C1421
C1415
1
5
2
CL1321
CL1436
BD DRIVE
(BPX-5)
L303
1
L2322
C1305
CL2421
CL2419
C2322
FB2403
C2403
C2324
SL2475
8
CN2460
1
C2460
16
15
30
L2324
CL2329
CL2330
CL2328
C2400
2
9
5
SL2497
TH1501
CL1438
C2364
FB2300
C2300
CL1300
FB2481
CL1435 CL1437
C1429
CL1439
C1435
R1435
C1427
C353 C318
K
D303
L305
44
CN2470
2
4
1
CL2487
CL2313
R2307
1
CL2303
CL2301
CL2302
SL2473
CL2471
CL2472
11
1-879-998-
R-USB BOARD
CN151
48
R619
45
CL1407
(CHASSIS)
C608
CL2414
C2450
CL1440CL1441
CL1442 CL1445
CN1401
J
48
R618
CL2413
R2447
C1434 CL1444 CL1443
1
26
CN602
CL2417
R1429
27
C614
C613
L608 R625
R626
D606
CL2410 CL2412
CL2422
CL2411
CL2418
CL2420
CL2416
CL1408 C1417
C1418
C1409
C1414
CL1406 C1410
(Page
52)
R1567
R1565
R1566
A
R2419
R2418
CL1450
R1582
C340
CL2483
R939
15 16
H
MAIN BOARD
CN505
R1584
R401
R914
2
1
CL1404
HBD-E370/E470/E570/E870/T57
CL1399
CN601
CN902
CN901
R306
F
(Page 52)
R919
R918
R917
C701
C335
MAIN BOARD
CN703
R920
17 18
PT101
C1387
C1386
R2446
R2496
R2444
R2494
R2442
R2492
H
CL701
5
CN1505
CL1398
CL1471
CL1434
5
G
R922
6
11
CL1490
C1451
C1452
IC701
10
C705
R1125
R712 R713 R1124
4 1
R1123
R701
R711
RB1102
C1383
C1382
CL1498
CL1476 CL1420 CL1431CL1422 CL1472 CL1482 CL1497
C927
CL1474 CL1417 CL1430 CL1426 CL1494 CL1499 CL1488
CL1493
CL1492 CL1315
CL1475 CL1470CL1489 CL1487
CL1432
CL1491
CL1496
CL1481
CL1485
CL1428 CL1425
CL1477 CL1495 CL1486
CL1484
C706
R924
R709
CL1480 CL1419 CL1433 CL1423
2
R1573
R1169 R1574
R1575
R1576
R1577
R1578
R1579
R1580
R1581
C144
C128
1
R1572
R1189
C161
C1388
C1389
L605
L606
CL1473
C928
C707
R717
R1191
C162
R1569
R1570
R1571
C1384
C1385
C1426
CL1479
R715
R714
JL1517
R1568
IC104
JL129
JL128
JL126
R806
C159
C164
R106
L603
L604
R718
C166
RB103
RB104
C1475
C708
JL1513
RB102
CL1478
HDMI
ARC OUT
G
JL1510
C168
RB106
C1326
C1399
R1503
JL1519
JL1518
C145
C1104
R1120
C1103
CL1317
C1102
C1101 CL1314
JL1511
JL1512
R1563
R1562
C148
IC2301
(CHASSIS)
JL2155
JL2154
JL127
D
JL227
JL226
C147
JL237
JL238
JL240 JL239
IC105
A9 B9 C9 D9 E9 F9 G9 H9 J9 K9 M9 P9
A8 B8 C8 D8 E8 F8 G8 H8 J8 K8 L8 M8 N8 P8 R8
A7 B7 C7 D7 E7 F7 G7 H7 J7 K7 L7 M7 N7 P7 R7
CL2327
R936
12
R1536
R1535
C230
CN303
1
RB205
IC205
48
25
C352
C234
RB204
RB206
C1206
C341
C351
RB202
C1208
C1201
R1201
C250
C249
C254
C258
C233
R1609
R1546
R1543
IC501
B
C252
C256
RB1103
(Page 66)
C
B
(11)
F-USB BOARD
CN101
(Page 66)
Note: IC101, IC104, IC105, IC204, IC205, IC307, IC501 and IC502
on the MB-134 board cannot exchange with single. When these
parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
5-21. PRINTED WIRING BOARD - MB-134 Board (Conductor Side)- • See page 34 for Circuit Boards Location. •
1
A
2
3
4
5
6
: Uses unleaded solder.
7
8
9
10
11
MB-134 BOARD (CONDUCTOR SIDE)
JL319
RB1101
JL291
JL288
JL284
JL289
JL280
R329
IC311
C359
C336
JL1540
JL1544
JL1127
JL1126
JL1125
JL1545
JL1546
JL1547
JL1548
JL1549
JL1550
R1585
R1598
JL1124
JL1123
R1524
JL1128
JL1551
JL1567
JL1570
F
JL1554
JL1571
JL1552
JL1553
C1522
JL1515
JL1514
IC602
R1540
5 R615
R613
JL1522
C606
JL1521
G
JL1525
IC601
1
5
C346
R327
JL311
7
R332 JL313
C605
R331
R330
JL314
1
JL1563
14
C349
R2483
JL1559
R2422
JL1565
JL1566
JL1564
JL1558
JL1555
JL1557
C2308
IC312
R2308
C311
C2371
8
5
1
4
R1215
JL1212
JL514
10
JL1214
JL505
JL703 JL701
JL945
JL1120
JL1121
R1013
JL135
JL131
PB/CB
C1004
R706
1
3
5
4
JL943
IC1001
C1006
JL946
JL941
C1016
C1012
VIDEO
OUT
JL942
JL940
C1010
C1015
R402
C330
IC303
C721
R749
5
4
1
C310
3
R736
R735
R305
G
R734
C716
Q702
D
S
C713
IC704
JL1151
JL1148
JL1146
1
5
3
4
C715
IC705
R739
JL502
JL1435
PR/CR
JL944
C719
1
5
3
4
C717
C720
JL1485
4
C2486
6
E
Q302
R375
3
1
C619
JL935
JL938
JL936
R362
R363
IC2401
R2412
C2433
C2481 C2438
JL939
JL934
JL933
JL932
JL929
JL930
JL931
C2405
C2404
C2401
JL949
C2402
JL928
JL924
JL927
C2499
56
JL923
C2432
JL937
JL1408
1
28
29
Q303
I
JL510
R2411
C379
R374
R2416
R2417
R2487
JL1316
C2309
R2309
8
7
Y
JL605 JL606JL607
C377
JL1562
JL1556
R101
C102
C2422
C2421
C2420
C2419
C2418
C2417
C2416
JL1560
R620
C620
JL608
R376
JL1561
R1207 JL1206
D601
C373
H
L1202
C609
JL1534
JL1520
CN1201
LAN (100)
JL1203
JL1224
C239
R201
R1162
R1163
IC309
8
C109
C247
R612
R611
R610
C345
JL1523
JL1524
JL1526
JL1527
JL1528
JL1529
JL1530
C610
D602
R614
R606
R617
1
JL1201
R1206 JL1205
R1217
R1220
JL1215
C114
C440
JL1118
JL210 JL234
JL212
JL214 JL222
JL137 JL217
JL1111
JL233
JL213
JL219
JL211
JL1112
JL105
R1156
JL220 JL203 JL204 JL205 JL230 JL235
JL1122
JL134 JL215
JL221
R1157
JL1119
C113
JL136
JL104JL202
JL1115
C201
C427
R1131
C107 C110
C1108
JL107 JL106
JL216 C112
JL1113
R1005
C1002
JL130
R1006 R1133
JL133 C116
JL1002
R1011
JL132
JL116
JL1001
C405 C424
R1010
JL705
C702
C106 C115
R702
JL109JL108
R703
C703
C436
JL111
C418
JL110
C437
JL103
JL113 JL112
C105
JL125
JL123
C403
JL124 JL122
JL912 JL913
C104
JL115
R929
C416
JL911
JL114
JL907
C433
C1486
JL1138 JL1143JL915 JL908
JL117
R930
C1469
C1481
JL1137
JL910 R932
JL101
C1480
C431
JL1144 JL1140 JL914
R935
C170
C1367JL1313JL1312C1468
R931
JL1136
JL909
JL1139
C1499 JL1103
C810
C1476
JL1109
R1103
C809
JL1108 JL1106
JL1102
R1101
C1472
JL1107 JL1116
R1102
JL1101
JL801
JL1117
JL1309
JL1407
JL1153
JL1141
JL1319
JL1104
JL1142
JL1114
C1473
R1141
JL1406
C1107
JL922
JL903 JL904
JL1105
JL1110
JL804
R601
JL1318
JL1135
JL1156
C1398
R1107
JL905
JL1154
JL1307
JL1404
C1462
JL1147
JL1152
JL1155
JL1157
JL1306
JL1300
C1461
JL1150
JL1158
JL1370 JL1308 JL1305 JL1310 JL1302 JL1311
R1110
JL1149
C1362
C1366
JL1303 JL1301
JL1304
C1370
R1302
JL1145
R1370
R1308 JL901 JL902
JL1484
R1372
R1371
JL504
R1190
JL503
JL501
R1153
R1152
R2421
R2420
JL1541
JL1543
27
R1216
R1218
JL1217JL1222
JL513
JL522
JL508
JL512
JL511
JL507
JL517
JL520
JL524 JL516
JL523
JL521
JL506
JL519
JL525
JL518
C259
R1138
JL702 JL704
JL2210
JL2208
JL2211
JL167
JL2115
JL176
JL2116
JL195
JL1542
JL2118
E
JL1538
R1226
JL118 JL120
JL119 JL102
JL1536
L1201
9
2
R1204 JL1202 1
R1205 JL1204
JL509
C134
C130
JL2156JL2170
JL2138
C135
C139
JL2120
JL2134 JL2161
JL2127
JL2145
JL2157
JL2162
JL2136 JL2142
JL2125
JL2128
C154
JL2140 JL2123
JL2139
JL2158
JL2163 C138 JL2153
JL2135 JL2159
JL2143
JL2146
JL2141
C140
JL2150
JL2137
JL2121 C142 JL2122 JL2126 JL2169
JL2166
JL2119 JL2171
JL2148
JL2167
JL2129 C137
JL2168
JL2144
JL2147
JL2149
JL2160
JL159
JL158 JL163
JL147
JL157
JL152
JL156
JL151
JL145
JL148
JL149
JL154
JL146
JL161
JL144
JL143
JL160
JL153
JL162
JL164
JL155
JL142
JL150
JL2117
JL184
JL2111
JL186
C153
JL2108
JL180
JL2112
JL2107 C120
JL181
C124
JL174
JL2103
JL189
JL2104
JL185 JL190
JL170
JL182 JL2105
JL188
JL168
JL2102 JL2106
JL191
JL198
JL121
JL2109 C123
JL193
JL183 JL192 JL169 JL166 JL2113JL2114
JL175
JL187
JL194
C118
C151
C122
C127
JL173 C129
C119
JL2110
R1136
C150
C815
JL1535
JL1220
JL1219
RB1201
JL1218
18
19
JL803
R1613
JL2252
JL2264
JL2267
JL2265
JL2266
JL604
R1612
1
36
IC1201
28
JL2249
JL2164
JL2124
JL2165
C323
R318
R312
C331
JL171
R1586
C156
JL172
R321
R322
R323
8
JL165
5
JL1537
JL1539
JL295JL298
IC308
R1611
C1217
R1227
C1216
C1477
C1493
C1491
C
D
JL315
JL208
4
C367
JL1221
R1210
R1209 R1208
9
10
JL232
JL229
JL231
JL209
JL236
1
1
R1214
C1213
C423
4
C365
C111
D302
C321
JL264
Q301 E
JL201
JL218
JL206
JL223
JL224
JL207
JL317
5
C1365
C1363
C1361
C368
8
JL271
JL265
JL318
C363
JL1211
X1201
C504
JL1223
R1247
JL273
R355
C369
L302
C1215
JL1207
JL1208
JL1209
JL1210
R379
R1213
C1214 R1219
JL1213
JL1569
JL1531
C242
JL2242
JL2243
JL248
JL2238
JL253
JL2248
JL2234
JL2236
JL246
JL250
C240
JL2246
JL251
JL2244
JL242
JL257
JL244
JL2247
C245
JL2258
JL255
JL256
JL258
JL243
JL2235
JL286
JL267 JL285 JL2216
JL262
JL2268
C205
JL252
JL290
JL2227
JL283 JL287 JL254
JL2239
JL282
JL266
JL2241
JL249
JL2237
JL2224
JL245 JL247
JL294 JL292 JL293 C228
JL2233
C220
JL2217JL2205 JL2203
JL2259
JL2257
JL241
JL2256 JL2255
JL2204 JL2207 JL279
JL2269
C204
JL2202 JL268
JL2223 JL2220 C226
C215
C231
JL2206
JL261
JL2262 JL2229
JL2209
C216
C211 JL281
JL2260
C225
JL259
JL2221
JL272
JL270
C209
JL2228
C227
JL260 JL263
C206
C207
JL2212
JL2219
JL2215
C217
JL274
C222
JL2218JL2226
JL2225
C203 JL2214
JL316
C380
JL515
JL2240
JL2245
C243
PS304
JL320
JL1129
R516
JL269
PS302
JL1575
JL1130
JL2213
C301
IC310
R1149
JL1131
JL2222
JL2261
L306
1
JL603
JL303
JL307
JL1572
14
R523
JL1132
JL1133
JL1502
JL1504
C348
C347
JL602
JL1574
JL312
R346
C350
PS301
JL305
C302
PS303
JL1573
JL301
JL601
B
JL309
JL1506
JL1533
JL1532
JL310
JL302
JL1134
JL1505 JL1503 JL1501
R333
R334
R335
JL308
R343
JL2263
7
8
JL1216
JL306
JL947
JL926
JL925
PT107
C2440
JL1328
C2491 C2495
JL1323
JL1325 JL1327
JL1330
JL1507
JL948
JL1329
C2470
JL1508
C1400
JL1509
11
1-879-998-
(CHASSIS)
Note: IC311 on the MB-134 board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
49
49
(11)
COMPONENT
VIDEO OUT
J904
HBD-E370/E470/E570/E870/T57
5-22. PRINTED WIRING BOARD - AUDIO Board - • See page 34 for Circuit Boards Location. •
1
2
: Uses unleaded solder.
3
4
5
6
(Page 59)
K
POWER BOARD
CN908
A
JL56
(E370: AEP, UK/E870: AEP, UK)
JW16
17
1
2
JL50
JL47
CN17
(EXCEPT E370: AEP, UK/E870: AEP, UK)
JL55
JW73
CN12
JW27
JW26
JW57
JL51
JL52
3
B
JW35
JW53
R74
Q14
E
JW61 E1
B1
R73
C2
C69
JW63
1
R89
D15
JL53
JW41
Q13
JW55
JW34
IC14 1
R24 JL33 R27
C14
CN10
JW33
CN11
1 JL14
2
L010
FM 75:
COAXIAL
JL17
JL19
TU1
TUNER
(FM)
R19
8
JL23
10
JL24
(E370: AEP, UK/E870: AEP, UK)
R48
C41
R49
C35
R36
R37
R61
D10
A/K
R21
JW70
C32 1
8
4
5
C28
R29
JL26
JL28
C48
C37
C50
R30
R32
8
9
JL35
JL34
(CHASSIS)
ET10
JW25
JW47
R93
JL54
IC10
JW28
C12
R60
C44
R55 R54
C45
R34
C27
R20
R15
R12
C11
JW18
R52
R85
A C67
R86
A
R88
JW31
CL15
CL13
JW49
R28
JL32 JW59
JL31
R22
C23
K
JW30
C49
R77
C21
R13
JL11
JW58
R99 C10 Q10
JW51
CL14
E
JW44
JL25
K
A
C20
JW20
JW17
LP11
JW52
D12
JW32
R65
CL10
C33
JW43
CL12
C29
R35
JL30
JW42
CN10 (EXCEPT E370: AEP, UK/E870: AEP, UK)
CN11 (E370: AEP, UK/E870: AEP, UK)
JW60
R45
C62
16 JW14
JW29
JW46
C39
JW10
JW22
9
JW11
R44
4 C68
R47
JW24
11
JW36
D
IC12 8
R46
(Page 52)
C63
JW39
C53
J
MAIN BOARD
CN502 (E370: AEP, UK/E870: AEP, UK)
CN504 (E370: US, CND/E470/E570/E870: CND/T57)
R58
R57
JL22
9
R50
IC111
JW45 JW23
JL20
JL21
R18
R56
JW15
16
JW13 1
R62
R53
C22
JL18
ANTENNA
JL16
JL15
C17
JW68
R42
C15
JW21
C16
C54 JW12
R25
R23
R43
R26
C66
R51
CN13 (E370: US, CND/E470/E570/E870: CND/T57)
CN15 (E370: AEP, UK/E870: AEP, UK)
JL46
JL44
JL42
JL40
JL38
2
1
5
3
JW40
JW50
JW62
JL41
JL48
JW54
R87
JW67
JW48
JL45
16
15
14
JL37
JL36
JW19
R71
R72
R75
C1
B2
E2
JL49
R76 JL39
JW56
CL11
JW37
C
JL43
7
LP10
JW65
JL13
JW66
JL12
JW72
C70
JW64
(E370: AEP, UK/E870: AEP, UK)
(E370: US, CND/E470/E570/E870: CND/T57)
JL10
13
1-880-751-
E
(CHASSIS)
J10
L
A. CAL MIC
ECM-AC2
R
J11
AUDIO
AUDIO IN
HBD-E370/E470/E570/E870/T57
8
(Page 64)
CONNECT
BOARD
CN301
L
AUDIO BOARD
7
50
50
(13)
HBD-E370/E470/E570/E870/T57
5-23. SCHEMATIC DIAGRAM - AUDIO Board - • See page 67 for IC Block Diagrams.
1
3
2
4
5
6
7
8
9
11
10
12
13
14
15
16
AUDIO BOARD
A
JL36
JL54
JL37
JL32
JL38
JL31
R22
JL39
22k
JL40
R28
1k
B
Q10
RT1N141M-TP-1
INVERTER
R52
0
C67
1
R86
15k
JL41
JL42
R34
15k
C23 C27
470p 220p
0
D12
MC2840-T112-1
R53
1k
R60
2.7k
R72
10k
JL43
R88
0
JL33
JL44
JL45
R73
10k
JL46
JL47
R54
3.3k
9
4.7
4.7
4.7
2.2
JL48
JL49
5
IC10
6
7
8
+
MIC AMP
JL50
V
IC10
NJM4558M-TE2
+
-
G
1
6
DI
7
CL
8
DO
9
C17
0.1
C16
100p
CN11
11P
R56
0
R43
0
R57
0
R58
100k
C15
100p
IC B/D
B
100
TUNED
JL19
R24
100
CE
JL20
R25
0
DI
1
2
3
4
5
6
7
8
JL21
R26
100
CL
JL22
R27
0
DO
JL17
JL23
R18
0
RDSCLK
JL24
R19
0
RDSDATA
CONNECT
BOARD
CN301
L
(Page 59)
J
NC
2
3
S-AIR R
4
A5V
5
S-AIR 4V
6
S-AIR GND
7
AUDIO SELECT
IC11
MC14052BDTR2
VIN
Cont
VOUT
GND
5
NOISE
4
3
2
1
R50
47k
3.2
D10
MC2840-T112-1
-1
Rch
3
AGND
4
Lch
5
A12V
6
ASEL0
7
Acal_LV
8
ASEL1
ST_CE
14
ST_DO
15
ST_CLK
CL13
(CHASSIS)
3.2
-2
0
8.9
7
8
0
C41
22
25V
C35
100p
R49
22k
R48
22k
D15
MAZ8051G0LS0
C69
10
50V
C54
0.1
Q14
RT1N141M-TP-1
INVERTER
3.2
C53
0.1
JL30
51
51
R74
1k
RDSDATA
6
RDSCLK
5
CL
4
DO
3
CE
2
DI
B
VSS
1
TUNED
A
VEE
9
X3
10
X0
11
INH
12
Y1
13
4.4
R32
10k
L
HBD-E370/E470/E570/E870/T57
14
8.9
4.4
15
X
AUDIO SELECT
IC12
MC14052BDTR2
16
X1
IC12
R45
22k
Y3
C33
100p
IC B/D
X2
R30
10k
Y
C39
22
25V
JL55
(CHASSIS)
2
J
MAIN
BOARD
(1/5)
CN502
(Page
54)
E370: US, CND/E470/E570/
E870: CND/T57
ST_DI
R71
10k
R89
220
1W
JL28
L
AGND
13
JL26
R
1
TUNED
JL25
8.9
J11
RDS_DATA
12
R76
1k
AUDIO
AUDIO IN
RDS_CLK
17
ASEL2
JL51
C20
2200p
ST_CLK
16
0
Y2
2
15
+9V REGULATOR
IC14
TK11190CSCL-G
R51
47k
9
E4V
ST_DO
JACK_DET
R47
47k
(Page 65)
ST_CE
14
ET10
0
VDD
S-AIR GND
ST_DI
13
R93
0
Y0
K
TUNED
12
CL12
8.9
K
11
9
JL52
JL56
ASEL2
11
C66
0.1
C63
0.22
INVERTER
JL53
CN17
2P
1
JACK_DET
10
10
R75
1k
POWER
BOARD
CN908
ASEL1
9
IC14
Q13
RT3N11M-TP-1
E370: AEP, UK/
E870: AEP, UK
CN12
7P
AGND
R23
CL11
JL18
Acal_LV
8
9
VSS
S-AIR L
1
I
10
A
11
11
VEE
9
10
12
X3
DO
RDS_CLK
RDS_DATA
13
X0
8
14
INH
CL
15
Y1
7
16
X
DI
IC11
JL16
Y3
6
JL15
X1
5
CE
ASEL0
7
C14
100p
X2
4
A12V
6
C22
100
10V
Y
GND
TUNED
Lch
5
C68
1
Y2
3
C62
47
10V
R46
47k
VDD
R-CH
9
R44
22k
R62
100k
IC B/D
R87
1k
Y0
2
R65
0
8.9
H
1
C48
47
10V
R77
0
JL14
L-CH
+B 9V
C37
0.1
L010
10uH
R42
0
AGND
4
E
CE
CL15
Rch
3
0
5
CL14
R61
1k
0
TUNED
JL10
C49
1
4.5
4
C70
1000p
EXCEPT E370: AEP, UK/
E870: AEP, UK
R55
4.7k
8.9
3
GND
C45
0.1
8.9
R-CH
C44
100
10V
4.4
2
R29
22k
R15
100k
4.4
G
1
C29
0.068
4.5
TU1
TUNER
(FM)
L-CH
+B 9V
R36
0
4.5
ANTENNA
FM COAXIAL
75ȍ
C11
47p
JL12
C50
0.47
8.9
F
R12
0
JL11
CN10
9P
R21
0
9
J10
A.CAL MIC
ECM-AC2
R35
2.2k
C12
0.47
R20
470
R37
1M
4.5
E
R13
2.2k
C32
68p
1.3
C10
1000p
R99
1k
2
12
C28
470p
12
D
C21
10
50V
AGND
CN13
15P
2
4.7
3
4.7
4
1
CL10
4.7
C
JL13
E370: AEP, UK/
E870: AEP, UK
CN15
17P
R85
12k
17
Z
MAIN
BOARD
(1/5)
CN504
(Page
54)
HBD-E370/E470/E570/E870/T57
5-24. PRINTED WIRING BOARD - MAIN Board (Component Side)- • See page 34 for Circuit Boards Location. •
2
3
4
5
6
7
8
9
(Page 48)
(Page 62)
H
M
22
23
IC3100
C3206
JL3207
1
22
44
23
R3047
R3228 C3202
JL3203 JL3202 JL3201
R3434
C3201
JL3208
C3406
JL3407
JL3404
C3405 C3404
R3402
22
IC3200
44
23
IC507
3
1
R572
JL569
JL550
JL548
JL617
JL608
JL613
44
JL611
R606
JL600
C3120
C3207
C3210 C3217
C3220
C3407
C3410 C3417
C3420
C
SL3002
JL3060
SL3001
E2 B2C1
C3110 C3117
C2 B1E1
JL603
C3107
R3065
C525
Q3552
R596
C3556 R3558
R3562
R3554
Q3001
E
JL3002
SL3000
R3550
Q3551
E
JL3001
R3006
R3936
K A
D3551
A/K
R751
R752
R753
R758
FB705
R756
1
C3005
6
5
LP3001
R3126
E
R3127
C3127
C2B1E1
JL3058
Q3101 E2 B2C1
R3125
JL3057
R3176
R3177
C3128
C2B1E1
JL3059
Q3102 E2B2C1
R3175
JL3087
R3216
R3215
R3217
C3227
C2B1E1
JL3054
JL3053
Q3201 E2 B2C1
R3326
R3325
R3327
C3327
C2 B1E1
JL3055
Q3301 E2B2C1
JL3056
R3426
JL3086 C2 B1E1
R3428
R3430
C3428
C2B1E1
JL3052
Q3402 E2B2C1
JL3085
Q3401E2 B2 C1
FB704
R749
JL3051
R3940
11
CL736
CL735
CL734
CL733
CL732
R505
R525
R529
R528
J
RB500
2
JL534
JL519
CN502 (E370: AEP, UK/E870: AEP, UK)
CN504 (E370: US, CND/E470/E570/E870: CND/T57)
R504
AUDIO BOARD
CN13 (E370: AEP, UK/E470/E570/E870: CND/T57)
CN15 (E370: AEP, UK/E870: AEP, UK)
1
(Page 50)
R547
R538
R540
10
R724
CN702
14
R719
C715
2
C718
R745
1
R720
14
7
8
1
R705
IC702
CL731
C737
CL729
R744
IC703
13
C727
R735
12
CL722
R726
R737
C726
R730
R733
CL721
2 1
R708
G
18 17
R712
R795
F
2 1
F
CN703
C719
MB-134
BOARD
CN901
15
16
FB701
(Page 48)
L700
R703
RB504
C524
9
1
12
CN510
1-880-748(NC)
Note: When IC3100, IC3200 and IC3400 on the MAIN board are replaced,
spread the compound referring to “NOTE OF REPLACING THE
IC3100, IC3200 AND IC3400 ON THE MAIN BOARD AND THE
COMPLETE MAIN BOARD” on servicing notes (page 8).
HBD-E370/E470/E570/E870/T57
52
52
MB-134
BOARD
CN902
(Page 48)
FB702
R734
R718
R716
(Page 59)
R746 R747
R704
CN701
R706
R709
R710
R711
R740
R738
CL720
CONNECT
BOARD
CN300
R725
R707
R759R760
25
A
15
C713
R780
R781
R773
R782
24
48
CL727
1
CL725
C720
(E370: US, CND/E470/E570/E870: CND/T57)
R546
R543
R774
R775
R776
R777
R778
37
R729
17
16
14 15
R723
1
36
C729
CL728
CL724
CL723
(E370: AEP, UK/E870: AEP, UK)
R556
IC704
C736
RB701
IC505
JL557JL555
20
CL726
R681
51
R754
R755
D508
R530
R527
JL536
X700
L705
R683
JL537
JL535
81 JL520
JL533
80
(E370: AEP, UK/E870: AEP, UK)
R750
JL543
JL564
R748
R3429
R3425
R3427
C3427
IC501
Q3556
FB706
R531
JL541
JL539
R771
L3000
R532
1
JL567
R772
1
C503 3
C526
R613
D502
(E370: AEP, UK/E870: AEP, UK)
Q504 D506
JL562
R550
C501
5
4
C502
R506
4 5
100
JL540
C512
JL575
R3007
E
R569
JL573
IC3011
D
R599
R597
3 1
R534
SL501
C529
C527
R590
E
JL566 C518
R567
30
31
JL571
JL570
JL587
JL585
JL583
JL582
JL581
JL580
50
JL577
JL590
JL588
JL586
JL584
C528
IC503
R574
14
15
C513 R536
RB503
CL502 R563JL565
JL568
JL574
JL576
R607
EB3008
1
12
FL BOARD
CN801
CN508
R568
R570
L3052
JL3402JL3401 JL3408
IC3400
D503
SL500
2
5
1
4
C505
RB502
R620
JL614
C3402 C3401
R3424
C5141
3
IC508
R639
R632
R651
C534
JL624
2
R623 RB501
R621
5 4
JL3409
R3433
JL3406 JL3405
1
IC3050
C537
R3035
R3034
TP3032
R3024
R3023
13
12
1
R3234
JL3204
C3205 C3204
R3202
JL3206 JL3205
48
R3046
R3043
5 4
C3052
2
C536
1
1 3
L3051
C535
R739
EB3007
12
1
R3075 D3071
A
K
A
SL3003 R3076
IC506
C3055
3
4
1
JL589
R3132
JL3104
C3106 C3105 C3104
C3102
R3128
C3101
R3102
JL3108
JL3107
JL3103 JL3102 JL3101
JL3106 JL3105
B
13
48
R3042
R3231
D3072
CN505
JL623
R652
11
R514 C504
27
26
JL579
R3133
R3041
R3134
R3074
Q507 CL507
B2E2
R654 E1B1C2
JL625
MB-134 BOARD
CN1505
C1
R741
R3131
TP3131
R3015
TP3002
13
12
IC3010
C3025
R3057
JL626
LP501
SL3010
SL3008
SL3004
SL3006
C3035
SL3005
JL3403
C3060
C3015
R3055
SL3007
SL3009
R3059
R3060
IC3030
IC3020
R3432
R3040
5
4
R3052
48
R3053 R3050 1
3
X3051
EB3001
TP3036 TP3030
36
25
24
37
R3431
IC30511
C3058
R3037TP3231
TP3024 R3027
R3032
R3022 TP3005
R3033
R3013
TP3130
TP3230
TP3022
TP3136
TP3236
R3011
C3037 TP3229
C3027 TP3129 R3021
R3031
25
36
25
36
24
24
37
37
R3012
R3232
R3233
CL3002
C3057
(CHASSIS)
C3017
TP3029 R3014
TP3026
CL3001
R3017
CL3007
TP3015
L3053
CL3003
MAIN BOARD (COMPONENT SIDE)
A
10
JL538
1
: Uses unleaded solder.
(12)
HBD-E370/E470/E570/E870/T57
5-25. PRINTED WIRING BOARD - MAIN Board (Conductor Side)- • See page 34 for Circuit Boards Location. •
1
2
3
4
5
: Uses unleaded solder.
6
7
8
9
10
11
(Page 60)
N
JL552
R533
R618
R586
C519
C511
JL508
JL507
JL504
R577
C522
TP3008
C507
C506
R3556
JL502
C714
C716
R721
CL746
D3502
TP3000
CL713
CL716
C735
CL717
CL760 CL762
JL578
CL737
R589
JL591
JL592
JL594
C724
CL768
L3401
L3301
D3401
D3402
D3501
C3422
C3424
C3421
C3411
C3412
C723
CL738
R763
C722 C728
C3414
C3423
C3109
C3118
C3108
D3204
L3201
D3203
D3202
L3102
D3104
D3201
L3101
D3103
D3101
D3102
C3312
C3311
C3211
C3212
C3122
C3121
C3111
C3112
C3413
C3314
C3313
C3214
C3213
C3124
C3123
C3114
C3113
R3553
C3000
C3416
C3426
CN3000
R766
R765
R769
R764
R767
TP3001
C3425
C3415
2
C3215
C3315
C3115
C3125
C3316
C3126
C3216
C3116
1
R787
R768
L3941
L3943
L3942
L3923
L3914
L3922
L3924
L3944
C721
JL704
JL596
JL599
JL597
JL703
3
C3945
JL700
C705
R701
1
TP3307
C3941
TP3309
C3947 C3942
C3946
C702
L3921
L3912
L3911
L3913
R702
R3949
TP3310
C3943
TP3308
C3948
TP3304
EB3003
C3925
CL3005
C3927
C3926
C3928
C3944
TP3301
C3924
TP3104
C3917
C3916
TP3101
C3911
C3913
C3918
TP3103
C3922
R700
TP3302
C3915
C3923
EB3002
C3912
TP3303
JL701
12
IC700
TV
DIGITAL IN
OPTICAL
HBD-E370/E470/E570/E870/T57
C3119
C3208
CL769
JL601
F
C730
C725
CL761
CL757
JL702
R587
C3209
C3218
C3002
C733
CL741 CL740
CL739
CL714
CL766
C3219
C3552
R3003
C732
CL767
C3003
R3103
R3551
R3004
CL711
CL765
C3551 R3002
C731
CL710
CL764
R3140
C3103
D3553
CL753
CL754
CL759
R3240
R3005
CL750
CL751
CL752
CL758
(Page
64)
R3552
R555
R553
C3001
C717
CL712
CL763
P
POWER
BOARD
CN904
1
R3203
C3408
L3402
CL748
E
R3051
CL744
CL747
CL718
C3203
C3409
C3418
C3553
TP3003
CL749
CL719
C3051
C3012
C3019
CL743
CL745
CL715
C3014
C3129
EB3004
R3440
C3419
C3561
C3071
(EXCEPT E370: AEP, UK/E870: AEP, UK)
R545
R544
R542
D3070
R714
CL709
C3022
C3029
C3020
TP3007
JL503
D
C3018
C3013
C3091
TP3009 TP3004
R601
R588
R713
C707
C3024
R3403
JL500
C706
C3032
C3039
4
CN3001
C3016
C3011
C3229
R593
JL501
JL505
C3023
C3429
C3403
R549
C508
R521
R519
R3080
R582
R580
R595
R594
C516
C3034
TP3006
C3033
C3030
C3028
C3038
R565
R523
JL531
C3026
C3021
C3040
TP3054
C515
R524
C3036
C3031
C3054
R653
R648
R650
C521
JL530
JL511
JL509
JL506
C
R522
C532
CL518
C3914
JL514
JL512
JL510
C509
JL515
JL516
CL515 CL516
CL513 CL514
R657
R615
C510
JL513
JL518
JL517
C533
CL511CL512
TP3053
C3056
C3921
B
CL509
R649
X500
LP3000
12
R610
R622
R591
R634
R633
R636
R507
R508
R509
CL517
3
CL510
R656
JL612
JL609
JL606
JL604
JL542 JL551JL553 JL556 JL559
JL549
JL545
JL593
JL618
JL529
REG BOARD
CN403
CN506
1
CL508
R510
R511
R512
R513
JL621
JL627
JL547 JL554 JL558
JL546
JL622
JL620
JL619
JL616
JL615
JL610
JL607
JL605
JL602
JL598
JL595
CL501
CL500
R585
JL532 JL544
JL628
A
JL629
MAIN BOARD (CONDUCTOR SIDE)
1-880-748-
J700
SAT/CABLE
DIGITAL IN
COAXIAL
M
M3001
(FAN)
–
+
+
–
+
SUR L
SUR R
–
CENTER
+
–
+
SUBWOOFER
SPEAKER
SPEAKERS
TB3902
TB3901
53
53
–
FRONT L
+
–
FRONT R
(12)
HBD-E370/E470/E570/E870/T57
5-26. SCHEMATIC DIAGRAM - MAIN Board (1/5) - • See page 60 for waveforms. • See page 67 for IC Block Diagrams. • See page 77 for IC Pin Function Description.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
MAIN BOARD (1/5)
A
E370: AEP, UK/
E870: AEP, UK
18
S-AIR_GPIO2
E2P_S-AIR_SCL
E2P_S-AIR_SDA
S-AIR_ADC_SEL
S-AIR_RST
EN
OVF1
OVF2
NS_INIT
LAT1
LAT2
SOFT_MUTE
LAT3
DIAG
DC-DET
JACK_DET
A.CAL_OUT
RDS_DATA
ST_CE
RDS_CLK
ASEL0
ASEL1
TUNED
ASEL2
TUNED
11
JL592
ST_DI
12
JL594
ST_CE
13
ST_DO
14
ST_CLK
15
RDS_CLK
16
100
R538
JL573
JL575
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
2.5
2.5
2.5
0
0
3.3
OVERFLOW1
DAMP_INT
DAMP_SOFT_MUTE
DAMP_LATCH1
NO USE
DAMP_LATCH2
NO USE
DAMP_LATCH3
NO USE
NO USE
Vcc
Vss
MIC_DET
S-AIR_SRC_RST
DC_DET
NO USE
A.CAL_OUT
NO USE
NO USE
NO USE
NO USE
ST_CE
OVERFLOW2
37
BD_CS
36
BD_RESET
35
32
7
8
9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
S-AIR_SDA
6
S-AIR_SCL
5
31
0
JL580
0
JL581
CNVSS
8
RESET
9
D-GND
BD_SCLK
R599
22
0
JL582
3.3
JL583
3.3
JL584
3.3
JL585
3.3
JL586
3.3
JL587
BD_PCONT4
3.3
JL588
BD_PCONT3
3.3
JL589
3.3
JL590
0
JL570
3.3
JL571
3.3
C522
0.1
3.3
R577
47k
SOFT_MUTE
NS_INIT
R607
100
MAIN
BOARD
(4/5)
(Page 57)
NSP_MUTE
A.CAL_OUT
A.CAL_OUT
D3070
MA2J1110GLS0
SD3_SurrBACK
S-AIR
BD_PCONT1
22
56
NS_INIT
NSP_MUTE
BD_PCONT2
R606
BD_CS
57
MAIN
BOARD
(5/5)
(Page 58)
R651
1k
BD_RESET
CL507
JL624
RXD1
3.3
TXD1
R594
4.7k
SCDT_DIR_DI
SOFT_MUTE
BD_PCONT5
3.3
R595
4.7k
SHIFT_DIR_CL
SCDT_DIR_DI
BD_PCONT6
100k
LAT1
SHIFT_DIR_CL
FAN_ON
R601
LAT2
LAT1
FAN_CONT
(Page 56)
LAT3
LAT2
BD_SDI
MAIN
BOARD
(3/5)
OVF1
LAT3
R597 22
55
OVF2
OVF1
JL626
R654
10k
R652
47k
R593
10k
0
2.5
3.3
-1
-2
0
JL625
Q507
RT3CLLM
POWER CONTROL
R615
47k
10
9
I
8
7
R533
1M
ASEL0
J
100
100
100
R567
R569
R570
27k
R574
R550
0
R563
100
22
10k
R568
0
R565
RB500
100
R549
6
1
R582
4.7k
R580
4.7k
R505
100
C519
47p
3.3
TUNED
C518
1000p
Q504
2SC4154TP-1EF
RESET SWITCH
C521
100p
R590
100k
3.4
R613
47k
C527
0.01
4
IC503
3
RESET SIGNAL GENERATOR
IC503
S-80935CNMC-G85T2G
4.2
0
R572
ASEL2
5
IC B/D
22
ASEL1
R618
10k
R586
10k
C526
0.22
Acal_Lv
JACK_DET
SL501
1
OUT
2
VDD
3
VSS
CD
5
NC
4
2
1
1.3
C529
0.022
C528
0.1
ST_DI
ST_CE
ST_DO
K
C515
0.1
X500
6MHz
D502
MA2J1110GLS0
BD_IF_REQ
ST_CLK
BD_IF_START
RDS_CLK
RDS_DATA
Lch
A12V
PCONT_FL
(Page 55)
HBD-E370/E470/E570/E870/T57
54
54
LED_PWM
ST_DI
PCONT_FL
AGND
ST_CLK
ST_DO
FL_CLK
FL_DOUT
54
SIRCS_IN
MAIN
BOARD
(2/5)
Rch
CNVSS
FL_CS
53
SHIFT_DIR_CL
MAIN
BOARD
(5/5)
RESET
SCDT_DIR_DI
(Page 58)
L
7
(NC)
DC-DET
OVF2
R596
22
3.3
JL576
JL565
JL562
R522
10k
RXD1
100
JL564
JL557
R556
38
BD_PCONT1
4
JL550
JL548
R523
10k
BD_PCONT2
3.3
JL579
JL566
0
2
C516
0.1
R524
10k
39
3
NO USE
1
C512
0.1
40
BD_PCONT3
33
JL574
H
41
BD_PCONT4
I2C_DATA/TXD1
LED_PWM
100
BD_PCONT5
3.3
3.3
Vcc
42
34
3.3
Vref
99
44
43
S-AIR_GPIO2
0.4
98
FAN_ON
P_CONT1
BD_PCONT6
I2C_CLK/RXD1
PCONT_FL
KEY0
CEC_TX_OUT
3.3
KEY1
Vss
97
JL569
D508
MA2J1110GLS0
D506
MA2J1110GLS0
3.3
C511
0.1
95
96
S-AIR_ADC_SEL
3.3
3.3
KEY2
IC501
R5F364AMDFA
BD_IF_REQ
100
MODEL
94
SYSTEM CONTROLLER
3.3
R532
KEY0
93
45
ST_DI
3.3
FAN_CONT
3.3
3.3
100
BD_SCLK
ST_CLK
100
R531
46
ST_DO
R530
0.1
DESTINATION
CE
0
0.1
C510
BD_TEMP
92
BD_IF_START
3.3
C509
KEY1
S-AIR_ID_SW
91
AC_CUT
JL541
KEY2
90
49
DRIVER_RST(EN)
IC501
C525
100p
JL577
50
48
BD_SDO
0
JL531
2.5
JL540
CLK1
6
FAN_ON
DC-DET
47
3.3
JL530
Acal_Lv
3.3V
5
FAN_CONT
FAN_ON
BD_SDI
JL568
JL539
1k
3.3
UPG_STATUS
VBUS_DET
89
KEY_INT
R529 1k
87
88
3.4
0.1
0
CL502
C508
R527
JL538
3.3
G
0.1
JL543
NO USE
R525
100
C507
R528
1k
CEC(TX/RX)
C506
0.01
Acal_Lv
Vcc
15
FE_EJECT
3.3
ST_CLK
86
Xin
0
3.3
JL537
1.6
14
OPWRSB
DRIVER_SD/PVDD_DET
ST_DO
85
Vss
3.3
Xout
JL536
1.8
13
RESET
12
NSPMUTE
JIG_MODE
Xout
0
ST_DI
ST_CE
83
84
Xin
3.3
JL535
3.3
3.3
JL534
RDS_DATA
JL520
11
CORE_RST
CNVss
10
82
RTS1
4
EN
FAN_CONT
BYTE
ASEL2
TUNED
3.3
TXD1
3
DIAG
EN
FL_CLK
9
CPU_PRERST
3.3
JACK_DET
81
RDS_CLK
3.3
DAMP_SHIFT/DIR_CL
JL533
JL519
JL601
D-GND
2
JL623
DIAG
CEC_RX_IN
8
JL599
RB504
100
C524
0.1
FL_DOUT
7
ASEL1
Acal_LV
JL597
1
R588
10k
3.3
6
CNVSS
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
DAMP_SCDT/DIR_DI
ASEL0
JL596
RESET
R542
10k
SIRCS_IN
5
ASEL0
A12V
JL591
100
RXD1
JL567
3.3
4
3.3
3
3.3
2
Lch
ASEL1
Rch
AGND
R545
10k
JL555
CN504
15P
TUNED
1
100
AGND
R553
10k
R555
10k
R546
17
R589
R543
100
R540
100
R547
10k
3.3
RDS_DATA
R521
2.7k
TXD1
FL_CS
F
JL578
9
10
3
(Page
51)
CN510
9P
R587
100
ASEL2
ASEL2
Z
(Page 56)
JACK_DET
E370: US, CND/E470/E570/
E870: CND/T57
AUDIO
BOARD
CN13
CORE_RST
8
CPU_PRERST
ASEL1
MAIN
BOARD
(3/5)
R544
0
PCONT_FL
OPWRSB
7
NSP_MUTE
6
FE_EJECT
5
ASEL0
Acal_LV
JIG_MODE
4
E370: AEP, UK/
E870: AEP, UK
BD_TEMP
Lch
A12V
EXCEPT E370: AEP, UK/
E870: AEP, UK
UPG_STATUS
3
0
E
2
3.2
D
(Page
51)
1
Rch
AGND
10k
C
AUDIO
BOARD
CN15
AGND
58
P-GND
R519
J
R681
0
CN502
17P
PCONT_S-AIR
B
20
E370: US, CND/E470/E570/
E870: CND/T37/T57
R683
0
E370: AEP, UK/
E870: AEP, UK
19
51 (Page 55)
MAIN
BOARD
(2/5)
HBD-E370/E470/E570/E870/T57
5-27. SCHEMATIC DIAGRAM - MAIN Board (2/5) - • See page 67 for IC Block Diagrams.
1
3
2
5
6
7
8
9
11
10
MAIN BOARD (2/5)
A
12
10
9
CN505
27P
JL629
BD_PCONT4
B
H
C
4
MB-134
BOARD
(13/13)
CN1505
(Page 47)
1
OPWRSB
2
ATA_PCONT
3
CORE_RST
4
CPU_PRERST
5
NC
6
FE_EJECT
7
GND
8
CEC
9
BD_PCONT6
JL621
CORE_RST
JL620
CPU_PRERST
R632
100
JL618
11
UPG_STATUS
12
HDMI_PCONT
13
BD_PCONT3
14
XIF_CS
15
BD_PCONT2
16
IF_SDI
17
PCONT_CORE
18
IF_SDO
19
GND
20
IF_SCK
21
22
SYSCON_REQ
23
IF_START_BIT
24
XIF_RST
25
GND
26
TEMP
27
JL615
R639
100
C532
2200
6.3V
6
SL500
R648
10k
R653
22k
IC506
RB501
100
UPG_STATUS
JL610
BD_PCONT5
3.4
JL609
BD_PCONT3
3.6
100
JL611
JL606
R623
100
R620
0
JL605
R621
100
R622
100
JL603
R591
100
JL608
BD_CS
C535
0.01
BD_PCONT2
IC B/D
1
OUT
2
VDD
3
VSS
CD
5
NC
4
1.3
C536
0.022
BD_PCONT1
JL598
R610
100
JL595
R636
100
BD_SDI
JL600
R633
JL593
100
(Page 54)
BD_SDO
JL604
JL602
3
VOLTAGE DETECT
IC506
S-80929CNMC-G8ZT2G
JIG_MODE
JL612
R634
MAIN
BOARD
(1/5)
1
FE_EJECT
JL607
4
5
2
R585
220
JL616
10
GND
JL622
JL619
GND
D
OPWRSB
51
7
BD_PCONT4
JL628
JL627
JIG_MODE1
8
RB502
100
R649
22k
CN506
12P
R650
15k
IC507
BD_SCLK
D503
MA2J1110GLS0
IC507
S-80929CNMC-G8ZT2G
BD_IF_REQ
JL613
BD_IF_START
3.4
BD_RESET
3.8
CL500
CL509
VOLTAGE DETECT
JL614
CL501
CL508
IC B/D
CL510
R656
100
CL511
CL512
1
C534
0.01
BD_TEMP
OUT
2
VDD
3
VSS
CD
5
1.3
CL513
CL514
NC
4
CL515
CL516
R657
100
CL517
CL518
E
C533
330
10V
C537
0.022
JL617
1
EN
3
P_CONT1
4
D+3.3V
5
E+4V
6
6V
7
DGND
8
MGND(FAN)
9
14V
10
A12V
11
AGND
12
BD_PCONT
A12V
D-GND
N
REG
BOARD
CN403
(Page 61)
59
(Page 56)
A-GND
D3.3V
D-GND
CN508
15P
E+4V
6
FL-GND
7
FL-GND
8
SIRCS
9
PCONT_FL
10
M
G
FL
BOARD
CN801
(Page 63)
DGND
11
DGND
12
KEY0
13
KEY2
14
KEY1
15
FL_DOUT
4
JL552
JL551
JL549
JL547
C513
0.1
R536
100
JL546
JL545
JL544
SIRCS_IN
PCONT_FL
3
R534
100
JL542
KEY0
JL532
KEY2
JL529
KEY1
R513
330
H
PCONT_FL
HBD-E370/E470/E570/E870/T57
6.3
5
FL_CLK
JL553
2
R512
330
R511
330
R510
330
C505
1
R506
1k
IC B/D
5
Vin
FL_DATA
JL554
CONT
4
GND
FL_CLK
PCONT_FL
FL_CS
IC505
IC B/D
IC508
+5V REGULATOR
IC508
TK11150CSCL-G
3.3
1
1.3
1
CONT
2
GND
3
NP
Vin
Vout
C504
1
R514
1k
55
C501
1
MAIN
BOARD
(5/5)
(Page 58)
54
MAIN
BOARD
(1/5)
(Page 54)
M-GND
M+14V
5
4
60
MAIN
BOARD
(3/5)
(Page 56)
6.3
D-GND
D3.3V
5
61
MAIN
BOARD
(4/5)
(Page 57)
C503
1000p
C514
1000p
55
A12V
+5V REGULATOR
IC505
TK11150CSCL-G
3.3
3
LED_PWM
JL556
5
FL_CS
JL558
Vout
2
NP
LED_PWM
1.3
F
1
62
A5V
RB503
100
JL559
LED+5V
MAIN
BOARD
(3/5)
C502
1
R507
330
R508
330
R509
330
HBD-E370/E470/E570/E870/T57
5-28. SCHEMATIC DIAGRAM - MAIN Board (3/5) - • See page 67 for IC Block Diagrams.
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
18
EB3008
1
TP3001
C3948
JL3002
R3004
100k
EB3002
EB3004
C3002
0.1
R3006
8.2k
C3005
0.01
C3941
0.01
C3928
1000p
C3922
1000p
C3918
1000p
C3912
C3944
R3551
100k
PVDD
PVDD
1000p
1000p
C3927
0.01
C3921
0.01
C3917
0.01
C3911
0.01
C3945
0.01
C3943
0.01
C3926
1000p
C3924
1000p
C3916
1000p
C3914
1000p
C3925
0.01
C3923
0.01
C3915
0.01
C3913
0.01
1000p
L3052
10uH
R3051
100k
L3921
C3551
1
50V
P-GND
TP3101
TP3103
TP3104
TP3301
TP3302
C3942
0.01
1000p
Q3001
2SC4154TP-1EF
0.7
0
C3001
47
25V
1000p
C3947
C3946
L3944
JL3001
4
P-GND
EB3001
C3552
10
50V
R3005
10k
D3553
MA2J1110GLS0
D3551
MC2840-T112-1
R3002
10k
TP3303
1
TP3304
2
3
CN3001
4P
EB3007
EB3003
TP3307
3
TP3308
Vcont
4
TP3309
Vin
5
2
1
(CHASSIS)
A12V
P-GND
() () () () () () () ()
(CHASSIS)
D-GND
SPEAKERS
FRONT R
TB3901
TP3310
GND
IC3011
SI-3010KM-TLS
CN3000
2P
3.3
DC-FAN +
2
IC3011
+12V REGULATOR
Vout
DC-FAN 1
SPEAKERS
FRONT L
IC B/D
L3000
22uH
R3007
1k
(CHASSIS)
TB3902
CL3005
R3003
10k
D
SPEAKERS
SUR R
SPEAKERS
SUBWOOFER
TP3054
MAIN BOARD (3/5)
TP3000
M-GND
M+14V
FAN_CONT
FAN_ON
EN
DIAG
M
SPEAKERS
CENTER
() () () ()
60
TP3009
TP3008
TP3007
TP3004
TP3003
DC-DET
55
B
SPEAKERS
SUR L
M3001
(FAN)
13.4
MAIN
BOARD
(2/5)
Sense
MAIN
BOARD
(1/5)
(Page
65)
(Page 54) 58 59
12
(Page (Page
54)
55)
POWER
BOARD
CN904
P
MAIN MAIN
BOARD BOARD
(1/5)
(2/5)
A
C
17
(Page 55)
TP3053
1
L3943
R3553
10k
L3923
L3941
L3942
L3922
C3051
0.01
L3924
L3913
L3912
L3911
L3914
C3000
100
16V
C3091
220
16V
R3940
0
C3003
1000p
Q3001, 3556
FAN CONTROL
0.7
Q3556
2SC4154TP-1EF
R3428
E
R3429
100k
R3430
100k
100k
R3426
100k
C3428
2.2
R3936
1k
15.3
JL3051
SL3000
R3427
100k
R3327
100k
C3427
2.2
C3327
2.2
15.3
15.3
-1
15.3
15.3
-2
Q3402
RT3AMMM 0
OVER LOAD
DETECT
15.3
15.3
JL3052
0
-1
Q3401
RT3AMMM
JL3086
15.3
15.3
-2
0
OVER LOAD
DETECT
R3325
100k
R3215
100k
R3326
100k
R3216
100k
R3175
100k
R3125
100k
JL3056
JL3085
-1
Q3301
RT3AMMM
OVER LOAD
DETECT
R3177
100k
C3227
10
C3128
2.2
15.3
15.3
0
R3217
100k
R3176
100k
R3126
100k
15.3
15.3
-2
0
15.3
15.3
JL3055
0
-1
Q3201
RT3AMMM
JL3053
0
OVER LOAD
DETECT
C3127
2.2
15.3
15.3
-2
15.3
15.3
JL3087
JL3054
0
-1
Q3102
RT3AMMM
OVER LOAD
DETECT
R3127
100k
15.3
15.3
-2
0
15.3
15.3
JL3059
0
-1
Q3101
RT3AMMM
JL3058
15.3
-2
0
OVER LOAD
DETECT
JL3057
0
R3562
33k
C3415
2200
35V
C3425
2200
35V
R3554
100k
C3424
1
C3423
1
C3315
2200
35V
C3414
1
C3314
1
C3413
1
C3215
2200
35V
C3313
1
C3125
2200
35V
C3214
1
C3213
1
C3124
1
C3115
2200
35V
C3114
1
C3123
1
C3113
1
0
Q3552
RT3CLLM
C3419
0.1
D3501
RSA39LATE25
C3418
0.1
D3502
RSA39LATE25
IC3400
CXD9981TN
C3409
0.1
C3219
0.1
D3203
RSA39LATE25
D3401
RSA39LATE25
C3408
0.1
C3218
0.1
D3204
RSA39LATE25
C3407
0.033
C3410
0.033
IC3200
POWER AMP
IC3200
CXD9981TN
C3220
0.033
4
2
IC B/D
C3217
0.033
D3202
RSA39LATE25
C3209
0.1
C3119
0.1
D3103
RSA39LATE25
D3201
RSA39LATE25
C3208
0.1
C3118
0.1
D3104
RSA39LATE25
C3207
0.033
C3210
0.033
IC3100
POWER AMP
IC3100
CXD9981TN
C3117
0.033
C3120
0.033
D3102
RSA39LATE25
C3109
0.1
D3101
RSA39LATE25
C3108
0.1
C3110
0.033
C3107
0.033
-1
C3417
0.033
D3402
RSA39LATE25
C3111
100
35V
3
1
3
1
3
1
3
1
3
1
POWER AMP
C3420
0.033
-2
0
L3101
10uH
L3102
10uH
IC B/D
IC3400
0.7
PROTECT DETECT
4
C3121
100
35V
L3201
10uH
L3301
10uH
2
C3211
100
35V
4
C3311
100
35V
L3401
10uH
2
C3411
100
35V
L3402
10uH
4
C3112
100
35V
2
C3116
0.1
C3122
100
35V
4
C3126
0.1
C3212
100
35V
2
C3216
0.1
C3312
100
35V
IC B/D
C3556
0.1
H
C3316
0.1
C3412
100
35V
C3421
100
35V
R3558
1.5k
R3550
4.7k
C3416
0.1
4
Q3551
2SC4154TP-1EF
DC DETECT
C3426
0.1
C3422
100
35V
2
3.3
1
G
3
F
R3425
100k
0
3.3
I
0
C3429
1000p
L
SL3001
C3402
0.1
C3404
0.1
C3405
0.1
12
26.4
VDD
BST_D
NC
21
23
22
R3102
22k
C3205
0.1
C3206
0.1
C3129
1000p
C3101
0.1
C3103
0.1
C3102
0.1
C3104
0.1
JL3107
JL3106
JL3105
JL3104
R3140
0
JL3103
R3128
1k
JL3101
JL3108
JL3207
JL3206
JL3205
JL3102
12
20
12
19
24
GVDD_C
GVDD_D
32.8
PVDD_D
18
25
NC
17
NC
32.8
PWM_D
PVDD_D
16
26
1.6
/RST_CD
OUT_D
15.5
27
1.6
15
28
3.3
OUT_C
GND_C
14
29
PWM_C
GND_D
15.5
M3
13
3.3
12
30
M1
32.8
26.4
26.4
BST_B
11
31
M2
PVDD_C
32
BST_C
VREG
PVDD_B
33
AGND
32.8
10
34
3.3
9
35
GND
15.5
GND_B
36
OC_ADJ
OUT_B
PWM_B
8
1.6
7
37
3.3
15.5
OUT_A
PWM_A
/RST_AB
GND_A
32.8
/SD
6
1.6
5
3.3
4
1.2
3
38
3.3
39
NC
PVDD_A
32.8
26.4
NC
40
PVDD_A
41
2
R3203
3.3
C3204
0.1
C3202
0.1
C3201
0.1
JL3204
C3203
0.1
R3202
22k
C3229
1000p
C3406
0.1
R3240
0
JL3203
R3228
1k
JL3201
JL3208
JL3407
JL3406
JL3405
JL3404
R3403
3.3
42
NC
1
BST_A
22
43
/OTW
12
GVDD_B
GVDD_A
12
26.4
BST_D
VDD
44
12
21
12
20
23
GVDD_C
GVDD_D
32.8
19
24
NC
PVDD_D
18
25
NC
32.8
17
NC
PWM_D(-)
PVDD_D
16
26
1.6
/RST_CD
OUT_D
15.5
27
3.3
15
28
1.6
14
29
PWM_C(+)
GND_D
15.5
OUT_C
GND_C
M1
M3
13
3.3
12
30
M2
BST_B
BST_C
VREG
11
31
PVDD_C
32
3.3
10
32.8
26.4
26.4
32.8
PVDD_B
9
33
AGND
8
34
GND
OC_ADJ
OUT_B
15.5
PWM_B(-)
GND_B
7
35
3.3
6
1.6
36
/RST_AB
GND_A
15.5
37
3.3
32.8
5
38
PWM_A(+)
OUT_A
32.8
4
39
1.6
PVDD_A
/SD
3
3.3
2
1.2
NC
NC
40
PVDD_A
41
NC
12
26.4
42
JL3202
C3401
0.1
R3440
0
C3403
0.1
R3402
22k
R3441
XX
R3424
1k
JL3403
JL3402
JL3401
JL3408
K
BST_A
1
43
/OTW
BST_D
VDD
22
12
21
12
20
44
GVDD_B
GVDD_A
12
26.4
32.8
19
23
GVDD_C
GVDD_D
24
NC
PVDD_D
18
NC
32.8
17
25
NC
PWM_D
PVDD_D
16
26
1.6
/RESET_CD
OUT_D
15.5
27
3.3
15
28
1.6
14
29
PWM_C
GND_D
15.5
GND_C
OUT_C
M1
32.8
M3
13
3.3
12
30
M2
26.4
26.4
BST_B
VREG
11
31
PVDD_C
32
BST_C
33
AGND
PVDD_B
10
34
3.3
9
35
GND
GND_B
OC_ADJ
OUT_B
PWM_B
8
36
32.8
15.5
7
37
1.6
OUT_A
6
/RESET_AB
GND_A
5
38
3.3
PWM_A
4
1.6
3
3.3
/SD
PVDD_A
39
3.3
15.5
32.8
32.8
PVDD_A
40
NC
NC
41
2
1.2
1
42
NC
12
GVDD_B
GVDD_A
J
43
BST_A
44
R3556
47k
/OTW
C3561
47
10V
R3552
22k
26.4
C3553
0.01
R3103
3.3
C3105
0.1
C3106
0.1
SL3002
R3065
100
JL3060
52
MAIN
BOARD
(4/5)
(Page 57)
HBD-E370/E470/E570/E870/T57
56
56
34
33
32
31
30
29
28
27
26
25
24
23
22
21
M
Note: When IC3100, IC3200 and IC3400 on the MAIN board are replaced,
spread the compound referring to “NOTE OF REPLACING THE
IC3100, IC3200 AND IC3400 ON THE MAIN BOARD AND THE
COMPLETE MAIN BOARD” on servicing notes (page 8).
HBD-E370/E470/E570/E870/T57
5-29. SCHEMATIC DIAGRAM - MAIN Board (4/5) - • See page 60 for waveforms. • See page 67 for IC Block Diagrams.
1
3
2
4
5
6
7
8
9
11
10
12
13
14
15
(Page 56)
34
33
32
31
30
29
27
26
25
24
23
22
21
28
MAIN
BOARD
(3/5)
52
A
MAIN BOARD (4/5)
B
SL3009
A.CAL_OUT
NSP_MUTE
1.6
OUTR2(-)
VSSR
VSUBC
XVSS
3.3
VDDR
1.6
VSSR
OUTR1(+)
1.6
SOFT_MUTE
SCDT_DIR_DI
SCDT_DIR_DI
SHIFT_DIR_CL
SHIFT_DIR_CL
LAT1
LAT2
LAT1
SL3010
LAT2
LAT3
LAT3
OVF1
K
OVF1
OVF2
56
AMP_LRCKO
(Page 54)
MAIN
BOARD
(5/5)
63
(Page 58)
OVF2
SL3007
SL3008
MAIN
BOARD
(2/5)
61
AMP_BCKO
TP3036
47
R3017
47
R3015
NS_INIT
C3055
1
X3051
49.152MHz
C3060
4p
2
C3058
4p
1
C3052
1
3.3
D3071
MC2838-T112-1
AMP_MCKO
3 VOUT
4
VIN
IC3051
VSS
2
CE
1
CLOCK BUFFER
IC3051
TC7SHU04FU(T5RSOJF)
3.3
IC3050
AMP_D2
AMP_D1
L3051
10uH
D-GND
D3.3V
57
57
R3053
1k
R3052
1M
IC B/D
1.8
(Page 55)
HBD-E370/E470/E570/E870/T57
C3016
0.1
1.6
1.8
1.7
TP3002
3.3
1.6
TP3030
3.3
TP3026
OVF1
LAT1
SHIFT_DIR_CL
SCDT_DIR_DI
PGMUTE
SOFT_MUTE
TP3015
R3014
47
R3075
47
AMP_D3
MAIN
BOARD
(1/5)
1.6
R3013
10k
C3017
0.1
C3054
100
16V
D3072
MA2J1110GLS0
NS_INIT
SOFT_MUTE
CL3007
1.6
XFSIIN
DVDD
TEST
BFVSS
BFVDD
DATA
BCK
FSOCKO 37
LRCK
XVSS
VSSL
FSOI 38
1.6
VSUBC
3.3
HPOUTR2 39
OVF
FLAGL
TP3136
47
R3027
47
NSP_MUTE
OVF2
NS_INIT
R3023
47
SL3003
R3076
47
CL3003
TP3024
C3015
0.1
NSP_MUTE
NS_INIT
J
R3074
47
CL3002
3.3
HPVSSR 40
R3012
470
SL3006
SL3004
CL3001
HPOUTR1 41
24 OVF FLAGR
1.6
1.7
TP3131
1.8
1.6
TP3130
3.3
1.6
TP3129
HPVDDR 42
SL3005
I
3.3
25 26 27 28 29 30 31 32 33 34 35 36
R3033
10k
R3080
100k
LAT3
PGMUTE
SOFT_MUTE
NSP_MUTE
R3035
NS_INIT
R3034
47
47
R3031
470
SHIFT_DIR_CL
TP3006
C3027
0.1
HPOUTL2 43
STREAM PROCESSOR
IC3010
CXD9788AR
23 SCLATCH
R3011
470
3.3
HPVSSL 44
22 SCSHIFT
3.3
1.6
HPOUTL1 45
21 SCDT
3.3
R3024
C3025
0.1
XFSOIN 48
IC3010
TP3022
3.3
TP3236
R3022
470
R3037
47
R3032
470
1
20 PGMUTE
0
25 26 27 28 29 30 31 32 33 34 35 36
SCDT_DIR_DI
C3037
0.1
LAT2
SHIFT_DIR_CL
SCDT_DIR_DI
C3035
0.1
2
HPVDDL 46
19 SOFTMUTE
0
FSOCKO 37
3
TP3029
24 OVF FLAGR
4
XVDD 47
18 NSPMUTE
0
1.6
5
MCKSEL
VSSR
FSOI 38
23 SCLATCH
6
OUTL2(-)
1.6
OUTR2(-)
HPOUTR2 39
22 SCSHIFT
7
17 DVSS
3.3
HPVSSR 40
21 SCDT
8
16 DVDD
3.3
HPOUTR1 41
20 PGMUTE
6
IC B/D
9
15 XOVDD
1.8
C3018
0.1
C3020
0.1
C3012
0.1
R3041
0
14 XFSOOUT
3.3
3.3
VDDL
VDDR
HPVDDR 42
OUTL1(+)
OUTR1(+)
VSSL
3.3
TP3005
G
PGMUTE
C3013
0.1
1.6
VSSR
3.3
VSSL
1.6
OUTL2(-)
HPOUTL2 43
13 XOVSS
1.6
HPVSSL 44
STREAM PROCESSOR
IC3020
CXD9788AR
19 SOFTMUTE
OVF
FLAGL
1.6
1.7
TP3231
1.8
1.6
TP3230
3.3
1.6
TP3229
3.3
1.6
18 NSPMUTE
R3055
47
3.3
HPOUTL1 45
IC3020
17 DVSS
TP3032
3.3
VDDL
16 DVDD
25 26 27 28 29 30 31 32 33 34 35 36
F
HPVDDL 46
15 XOVDD
1.6
INIT
XFSIIN
DVDD
R3021
470
XVDD 47
SFLAG
3.3
XFSOIN 48
14 XFSOOUT
12 11 10
3.3
3.3
FSOCKO 37
TEST
24 OVF FLAGR
1.6
1
XFSIIN
FSOI 38
23 SCLATCH
2
DVDD
HPOUTR2 39
22 SCSHIFT
0
3
TEST
0
HPVSSR 40
4
BFVSS
HPOUTR1 41
21 SCDT
5
BFVDD
0
3.3
6
DATA
3.3
7
BCK
HPVDDR 42
3.3
8
LRCK
1.8
OUTL1(+)
XVSS
HPOUTL2 43
20 PGMUTE
OVF
FLAGL
SOFT_MUTE
R3131
47
C3011
56
16V
IC B/D
9
MCKSEL
3.3
13 XOVSS
INIT
3.3
HPVSSL 44
STREAM PROCESSOR
IC3030
CXD9788AR
19 SOFTMUTE
1.6
SFLAG
18 NSPMUTE
R3057
47
3.3
HPOUTL1 45
IC3030
17 DVSS
1.6
3.3
VSSR
VSUBC
XFSOIN 48
12 11 10
VSSL
1
3.3
1.6
3.3
OUTR2(-)
1.6
VDDR
1.6
VSSR
OUTR1(+)
1.6
VSSL
3.3
16 DVDD
BFVSS
3.3
3.3
2
HPVDDL 46
BFVDD
0
IC B/D
3
15 XOVDD
DATA
0
4
BCK
E
5
LRCK
0
3.3
6
MCKSEL
3.3
7
XVDD 47
INIT
1.8
8
14 XFSOOUT
SFLAG
3.3
9
OUTL2(-)
13 XOVSS
VDDL
VSSL
OUTL1(+)
D
NSP_MUTE
R3132
47
R3133
47
C3019
0.1
R3134
47
R3042
0
C3026
0.1
C3021
56
16V
C3028
0.1
R3043
0
C3014
0.1
R3231
47
C3030
0.1
C3022
0.1
C3023
0.1
C3024
0.1
R3232
47
R3059
10k
12 11 10
H
R3233
47
C3029
0.1
R3234
47
R3046
0
C3036
0.1
C3038
0.1
R3047
0
C3040
0.1
C3032
0.1
R3431
47
C3031
56
16V
1.6
R3060
10k
C3033
0.1
C3034
0.1
C
R3432
47
R3433
47
C3039
0.1
R3434
47
C3071
0.01
+1.8V REGULATOR
IC3050
MM3404A18URE
3 GND
L3053
10uH
C3056
220
10V
4
1.6
2 A
1 NC
C3057
0.01
Y
VCC 5
3.3
R3050
47
R3040
0
HBD-E370/E470/E570/E870/T57
5-30. SCHEMATIC DIAGRAM - MAIN Board (5/5) - • See page 60 for waveforms. • See page 67 for IC Block Diagrams.
1
2
5
6
7
8
9
10
11
12
13
14
1
AOLRCK
2
AOSDATA3(SBL/SBR)
3
AOSDATA1(SL/SR)
4
AOSDATA0(L/R)
5
AOSDATA2(C/LFE)
6
GND
7
AOMCK
8
G
(Page
42)
CL709
R704
22
CL710
R705
22
CL711
R706
22
CL712
R707
22
CL713
R708
22
10
1.6
0
1.2
CL714
GND
9
AOBCK
10
GND
11
AOSDATA4
12
CL715
CL716
GND
13
ARC_SPDIF
14
GND
15
DIR_XRST
16
GND
17
XAMUTE
18
R709
22
1.2
R710
22
1.3
1.7
R711
22
1.7
CL717
CL718
R712
0
0
R795
0
G
11
9
12
8
13
7
14
6
15
5
16
4
17
3
18
2
19
1
V
1.6
R749
10
0
R750
100
1.2
R751
22
1.2
R752
100
FB706
1.3
R753
100
1.7
R754
47
R758
0
1.7
R755
10
FB705
0
R756
100
CN702
15P
R774
100
CL733
CL734
3.3
20
R775
100
DIR_CE
CL735
CL745
DIR_DO
CL746
R776
100
RB701
100
BUFFER
IC704
TC74LCX541FT(EKJ)
R778
C732
100
10V
R739
10k
L705
47uH
RX3
6
DGND
7
DVDD
8
RX4
9
0
0
0
3
0
CL728
DO
DI
CE
CL
DGND
XMODE
DVDD
GPIO0
GPIO1
GPIO2
IC703
MOUT(EMPHA) 32
DGND 31
DIGITAL AUDIO
INTERFACE RECEIVER
IC703
LC89058W-E
DVDD 30
XIN 29
RX5
XOUT 28
10 RX6
XMCK 27
11
DVDD
DVDD 26
12 DGND
DGND 25
OUT
GND
JL703
IC700
OPTICAL RECEIVER
IC700
TORX147L
R703
100
C702
0.1
C705
100
10V
C721
100
10V
C722
0.1
C723
0.1
C719
0.1
R763
10k
R780
C726
0.022
C706
10
50V
CL738
CL739
R787
100
3.3
CL740
R767
100
0
CL741
0
RESET
4
I2C-SCL
S-AIR_ADC_SEL
R781
100
CL752
E2P_S-AIR_SDA
R773
100
CL753
3
ADC-SEL
2
I2C-SDA
1
GPIO2
CL754
(Page 59)
57
MAIN
BOARD
(1/5)
62
MAIN
BOARD
(2/5)
D3.3V
DIR_RERR
D-GND
A5V
DIR_CKST
A-GND
DIR_AUDIO
3.3
(Page 55)
C736
7p
1.5
1.6
R759
1M
CL737
R772
0
X700
24.576MHz
3.3
AMP_BCKO
R771 0
AMP_LRCKO
4
C737
7p
AMP_D2
AMP_D1
AMP_D3
63
MAIN
BOARD
(4/5)
(Page 57)
R740
47
R744
47
C727
0.1
R723
0
R738
100
2
R737
100
R735
220
CN703
16P
FB702
DIR_AUDIO
R713
47
1.7
1.2
8
BCK
9
DOUT
10 MOD0
Rch
C707
10
50V
R714
47
11
3.3
R721
0
2.5
2.5
K
MOD1
12 FMT
13 VinL
14 VinR
LRCK
7
SCKI
6
DGND
DVdd
AVcc
3
Vref
R746
0
1.7
R745
0
5
4
AGND
1.6
3.3
5
C715
0.1
2
1
C718
0.1
2.5
C713
0.1
R719
0
58
DIR_DI
CL759
DIR_CL
CL760
DIR_CE
CL761
DIR_DO
CL762
CL763
DIR_CKST
C717
10
50V
CL764
CL765
CL766
CL767
R720
0
CL768
C716
10
50V
DIR_RERR
C714
10
50V
R724
0
CL720
58
CL757
CL758
R725
47
A/D CONVERTER
IC702
PCM1808PWR
AGND
HBD-E370/E470/E570/E870/T57
SD3
5
CL751
A
CONNECT
BOARD
CN300
R769
100
R766
10k
3
Lch
(CHASSIS)
100
SD3_SurrBACK
R768
100
IC702
(Page 54)
P_CONT_S-AIR
6
CL750
5
IC B/D
MAIN
BOARD
(1/5)
7
CL749
E2P_S-AIR_SCL
R764
10k
3.3
C730
0.1
C724
100
10V
C725
0.1
R747
0
53
SD2
R734
0
I
J
GND
8
0
1.6
3.3
1.6
1.6
FB701
JL704
2
SD1
CL747
(Page 54)
R760
330
CL731
0
3
GND
9
AMP_MCKO
CL729
TV
DIGITAL IN
OPTICAL
1
L700
10uH
3.3
0
VCC
JL702
LRCK
11
10
R782
100
3.3
13 14 15 16 17 18 19 20 21 22 23 24
3.3
GND
12
S-AIR
SDIN
LPF
R702
75
5
SLRCK
3.3
AUDIO 33
SBCK
0
CKST 34
RX2
RDATA
CL722
RX1
4
RLRCK
JL701
100
47
3
DVDD
JL700
SAT/CABLE
DIGITAL IN
COAXIAL
R733
R730
RX0
DGND
0
INT 35
RBCK
3.3
R701
0
C735
0.1
RERR 36
RXOUT1
RMCK
R716
0
BCK
13
C733
0.1
2
AGND
0
GPIO3
RXOUT2
1
R765
10k
C728
0.1
GND
14
48 47 46 45 44 43 42 41 40 39 38 37
AVDD
CL723
F
CL721
CL727
3.3
IC B/D
R729
47
R700
47
CL726
C720
0.1
CL725
CL724
R748
10k
R726
470k
100
S-AIR_RST
C729
0.01
15
CL748
S-AIR_GPIO2
J700
R777
100
PCONT_S-AIR
R741
100
R718
0
CL744
DIR_DI
CL732
E
CL743
DIR_CL
IC704
CL719
D
H
16
FB704
CL736
C731
0.01
G
15
CN701
18P
GND
MB-134
BOARD
(8/13)
CN902
C
4
MAIN BOARD (5/5)
A
B
3
CL769
1
DIR_AUDIO
2
DATA_I
3
GND
4
CSI_DATAOUT
5
CSI_CLK
6
CSI_XCS_DIR
7
CSI_DATAIN
8
GND
9
SP_DATA
10
DIR_XSTATE
11
SP_LRCK
12
DIR_CSFLAG
13
SP_BCK
14
GND
15
SP_MCK
16
DIR_ERROR
F
MB-134
BOARD
(8/13)
CN901
(Page
42)
HBD-E370/E470/E570/E870/T57
5-32. SCHEMATIC DIAGRAM - CONNECT Board -
5-31. PRINTED WIRING BOARD - CONNECT Board • See page 34 for Circuit Boards Location.
1
•
: Uses unleaded solder.
2
1
3
2
4
5
CONNECT BOARD
A
CONNECT BOARD
3
CL355
CL352
A
CN301
6P
CL352
L
(CHASSIS)
CL355
JW313
JW314
JW315
R308
JW317
30
AUDIO
BOARD
CN12
(Page 51)
S-AIR GND
6
S-AIR 4V
5
A5V
4
S-AIR R
3
AGND
2
S-AIR L
1
CL301
CL302
CL303
CL325
CL326
Q301
2SB1690KT146
CL329
E
R301
C
R302
470
1
R303
E
2
Q301
D
CL305
JW304
D
E
CN300
CL304
CL305 CL309 CL312 CL315 CL318 CL308CL320 CL300 CL302
CL306 CL319 CL301 CL303
CN301
1
CL353
E
A
MAIN BOARD
CN702
(Page 52)
L
AUDIO BOARD
CN12
(Page 50)
A
MAIN
BOARD
(5/5)
CN702
(CHASSIS)
11
1-880-758-
(CHASSIS)
R300
470
CN300
15P
JW301
6
0
3.3
JW305
14
CL334
R320
0
Q300
RT1N441M-TP-1
JW319
15
4.2
R301
470
JW320
CL307 CL311 CL313 CL317
4.2
R303
47k
CL326
R300
CL329
0
CL328
JW309
CL325
R302
CL328
R311
10k
JW310
Q300
1
EZW-T100
R320
JW308
2
CL319
(11)
(Page 58)
F
(CHASSIS)
CL300
CL334
R311
CL354
CN303
30P
Q300, 301
B+ SWITCH
CN303
EZW-T100
C
CL320
CL345
JW312
JW318
B
CL350
29
CL349
JW311
B
CL348
R309
R307
6
GPIO2
1
I2C-SDA
2
ADC-SEL
3
I2C-SCL
4
RESET
5
SD3
6
P_CONT_S-AIR
7
SD2
8
GND
9
SD1
10
GND
11
LRCK
12
GND
13
BCK
14
GND
15
CL307
CL345
CL306
CL309
CL308
CL311
CL304
CL312
R307
10k
R308
10k
R309
10k
CL348
CL349
CL350
1
A5V
2
Rch
3
AGND
4
Lch
5
GPI00(OPEN)
6
GPI01(OPEN)
7
GPI02
8
GPIO3(pull-down)
9
4V
10
GND(MODULE)
11
RESET
12
ADC_SEL
13
GND(MODULE)
14
LRCK1
15
BCK1
16
SD1(D-MIX)
17
GND
18
I2C_SCL
19
I2C_SDA
20
SRC_MUTE(Low)
21
IFMT0(Low)
22
GND
23
LRCK2
24
BCK2
25
GND for DET(OPEN)
26
SD2(SL/SR)
27
SD3(SBL/SBR)
28
SD4(pull-down
29
SPDIF(pull-down)
30
SPDIF_SEL(pull-down)
CL313
CL315
CL354
CL318
(CHASSIS)
CL317
CL353
(CHASSIS)
HBD-E370/E470/E570/E870/T57
59
59
HBD-E370/E470/E570/E870/T57
5-33. PRINTED WIRING BOARD - REG Board - • See page 34 for Circuit Boards Location. •
1
3
E
REG BOARD
A
MB-134 BOARD
CN303
(Page 48)
166 ns
1 V/DIV, 100 ns/DIV
2
4
13
CN402
CL415
IC703 qh (RMCK)
JW404
CL414
3
1
R421
CL418
CL419
LP401
E
Q401
L401
C428 R420
C426
R415
JW409
4.4 Vp-p
40.6 ns
B
R404
3
R411
JW408
CL421
C403
JW417
JW401
R422
JW421
C409
324 ns
1 V/DIV, 200 ns/DIV
4
C
IC400
R406
IC703 w; (RLRCK)
C405
JW418
5
C404 D402
4
CL422
D403
C401
C415
1
CL400
C431 R423
JW419
4.2 Vp-p
D405
JW405
JW410
IC703 qj (RBCK)
JW406
R417
C408
C411
LP400
CL420
D406
JW403
4
IC402 1
1 V/DIV, 20 ns/DIV
3
G S
C414
5
D407
Q402
CL402
3.3 Vp-p
2
3
JW400
C412
CL412
3
CN400
R402
Q
POWER BOARD
CN906
(Page 64)
CL408
CL401
13
CL417
12
CN403
JW407
CL407
CL411
JW416
JW414
1
1
CL409
CL410
C400
JW412
JW413
1
IC501 qd (Xout)
: Uses unleaded solder.
CL406 CL405 CL404
– MAIN Board –
JW402
• Waveforms
(CHASSIS)
3.9 Vp-p
20.8 Ps
ET400
D
1-880-752-
1 V/DIV, 10 Ps/DIV
5
N
IC703 wk (XOUT)
4 Vp-p
1 V/DIV, 20 ns/DIV
IC3010 rk (XFSOIN)
4 Vp-p
20.4 ns
1 V/DIV, 10 ns/DIV
HBD-E370/E470/E570/E870/T57
MAIN BOARD
CN506
(Page 53)
40.8 ns
6
60
13
CL416
60
(13)
HBD-E370/E470/E570/E870/T57
5-34. SCHEMATIC DIAGRAM - REG Board - • See page 67 for IC Block Diagrams.
1
2
3
4
5
6
7
8
9
10
11
REG BOARD
A
IC400
IC B/D
+3.3V REGULATOR
IC400
TK11133CSCL-G
3.3
B
1.3
R406
1k
1
CONT
2
GND
3
NP
Vin
Vout
5
4
4.2
CN403
12P
3.3
CL412
C415
1
C412
1000p
1
NC
2
EN
3
E+4V
4
6V
5
6V
6
D-GND
7
FAN-GND
8
Q
D
POWER
BOARD
CN906
(Page 65)
V-GND
9
-9V
10
14V
11
12V
12
A-GND
13
D406
EK19LF-F7
CL401
D407
EK19LF-F7
13.4
13.4
S
CL402
CL404
CL405
R417
33k
C403
0.1
C409
1
R404
0
CL406
C404
0.1
CL407
CL422
CL408
CL409
C405
470
25V
R420
68k
R422
47k
D402
UDZSTE-1713B
CL410
C431
220
35V
CL411
Q402
RSR25P03TL
0
L401
4.7uH
CL418
E+4V
6
6V
7
DGND
8
MGND(FAN)
9
14V
A12V
(Page 55)
11
AGND
12
BD_PCONT
Q401, 402
B+ SWITCH
3.1
R421
1k
R423
47k
C426
220
25V
CN402
13P
R415
47k
CL419
R411
1k
C401
220
16V
1
C411
1
CL415
-7V REGULATOR
IC402
TK72270CS
F
CL421
Vin
NP
-1.2
61
Vout
5
CONT
-9.7
-7
GND
4
3.3
C408
1000p
HBD-E370/E470/E570/E870/T57
C414
1
IC402
IC B/D
1
D403
UDZSTE-1718B
2
CL416
3
CL417
61
UNSW12V
2
NC
3
FE_UNSW12V
4
FE_GND_M
5
GND
6
GND
7
FE_UNSW6V
8
UNSW6V
9
UNSW6V
10
UNSW6V
11
UNSW-6V
12
GND
13
GND
E
(CHASSIS)
N
9
CL414
R402
0
D+3.3V
5
C428
0.01
CL420
ET400
P_CONT1
4
Q401
RT1N141M-TP-1
E
C400
0.1
NC
3
10
CL400
D405
UDZSTE-1733B
P.CONT1
EN
2
MAIN
BOARD
(2/5)
CN506
CN400
13P
C
1
E
MB-134
BOARD
(3/13)
CN303
(Page 37)
HBD-E370/E470/E570/E870/T57
5-35. PRINTED WIRING BOARD - FL Board - • See page 34 for Circuit Boards Location. •
1
3
4
5
6
FL BOARD
5
41
8
(Page 66)
(Page 52)
D
M
KEY BOARD
CN700
C824
CL860
44
JW822
CL823
L803
C818 5 4
JW818
C820
Q804
1 3
JW821
C819
IC801
HBD-E370/E470/E570/E870/T57
R819
E
R817
CL840
CL845
CL847
CL842
CL838
23
CL849
CL848
CL850
C833
CL858
C834
3
IC803
22
C823
12
D805
D803
JW811
A/K
JW812
JW816
3
JW815
JW814
JW813
K A
R814 R813
C822
JW819
A/K
D804
C816
JW810
1
9
T800
DC/DC
CONVERTER
TRANSFORMER
62
62
5
CL801
9
MAIN BOARD
CN508
R807
E
Q802
C811
C817
C812
2C 1C
Q803
R809 L802
2B E 1B
JW809
CL817
CL803 CL804
15
14
CN801
CL814
D807
JW817
K A
R822
L801
1
CL802
C837
CL851
CL855
CL859
IC802
1
CL844
R823 11
CL846
R821
R820
CL834 CL836
1
ET801
ND800
FLUORESCENT INDICATOR TUBE
C825
C826
CL841
CL843
R812
CL832
CL839
CL829
CL828
CL830
33
34
CL837
CL826
CL835
CL824
CL833
CL820
CL821
CL831
CL819
CL827
CL852
CL815
CL818
JW820
CN800
R825
44 45
C821
2
CL825
1
B
7
(CHASSIS)
CL822
A
2
: Uses unleaded solder.
C810
R806
JW801
CL812
CL808
2
C807
1
C803
CL805 JW823
CL807
JW803
R803
Q800
R805
CL813 CL809
C804
CL811
CL810
E
D800
(ILLUMINATION)
CL853
CL854
C808
LP800
CL857
R804
R828
Q801
JW808
JW805
CL856
E
CL816
13
LP801
1-880-750-
(13)
HBD-E370/E470/E570/E870/T57
5-36. SCHEMATIC DIAGRAM - FL Board - • See page 67 for IC Block Diagrams.
1
3
4
5
6
7
8
9
10
11
12
FL BOARD
ND800
FLUORESCENT INDICATOR TUBE
D803
MC2840-T112-1
CL834
CL835
CL836
CL837
CL838
CL839
CL840
CL842
CL845
CL847
CL848
CL849
S12
S11
S10
S9
S8
S7
S6
S5
S4
S3
S2
S1
44 45
CL850
CL832
CL833
S13
CL831
S14
CL830
S15
CL827
G9
S16
CL826
G8
CL829
CL825
G7
CL828
CL824
G11
CL822
G6
G10
CL821
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41
G5
9
G4
CL820
8
CL819
7
G3
6
CL818
B
5
G2
2
CL815
1
G1
A
2
D805
MAZ8051GLLS0
D804
MC2840-T112-1
C823
0.1
C
R814
47
R813
33k
R817
100k
CL860
C822
47
50V
C826
0.01
C821
0.01
C834
0.01
CL853
G
4
R806
470
Q800
RT1N441M-TP-1
4.2
3.3
CL854
R807
47k
3.3
Vin
Vout
1
2
3
S10
S11
S12
S13
SG10
SG11
SG12
SG13
SG14
GR3
SG3
16
41
GR2
SG2
15
42
GR1
SG1
14
43
VDD
VDD
13
44
VSS
VSS
12
1
2
3
4
5
6
7
8
9
S5
S4
S3
S2
S1
C833
0.01
CL859
H
C810
0.1
C811
100
10V
C812
0.1
ET801
(CHASSIS)
CN800
5P
10 11
R825
47
NC
3
KEY1
4
KEY0
5
DGND
D
KEY
BOARD
CN700
(Page 66)
CN801
15P
CL807
Q801
RT1N141M-TP-1
R812
1k
CL823
R822
100
CL812
R821
100
CL811
CL810
LED DRIVE
C818
1
C819
0.1
C820
1
C824
10
C825
0.1
R823
82k
R820
100
CL809
C804
47
16V
C803
0.1
C807
0.1
CL808
CL857
CL813
CL814
I
CL803
CL801
CL802
HBD-E370/E470/E570/E870/T57
KEY2
2
D807
MA2J1110GLS0
CL804
CL856
1
CL805
2.3
0.4
CL855
C837
4.7
3.3
Q800, 802
B+ SWITCH
2
3.3
R828
1k
0.6
R803
470
S6
GND
SG15
SG16
VEE
40
2.2
4
GR12
17
CL841
+3.3V REGULATOR
IC801
TK11133CSCL-G
5
Np
R805
470
IC801
4
Q802
2SB1690KT146
SG4
IC B/D
GND
IC B/D
(ILLUMINATION)
GR4
1.3
L803
47uH
D800
SLD430WBD2PT31XN
Cont
C808
0.1
39
FLUORESCENT INDICATOR
TUBE DRIVER
IC802
HT16515
LED1
R804
100
4.2
F
18
3
E
3.3
SG5
IC802
OUT
-23.6
GR5
VCC
G1
19
38
1
3.3
-23.6
20
SG6
S7
3.5
G2
SG7
GR6
S8
CL852
-23.6
GR7
37
S9
K2
G3
36
K1
-23.6
21
STB
G4
SG8
3.1
-23.6
GR8
CLK
G5
35
3.2
L801
47uH
-23.6
22
DIN
L802
47uH
G6
SG9
R809
1.2k
7
-23.6
GR9
DOUT
6
G7
34
OSC
CL817
-23.6
LED4
8
-23.6
G8
CL846
5
G9
LED3
9
CL844
4
Q803
CPH5504-TL-E
OSC
GR11
3.8
-0.2
IC803
PNA4823M02S0
33 32 31 30 29 28 27 26 25 24 23
3
LED2
-2
C817
0.022
GR10
C816
4700p
REMOTE CONTROL
RECEIVER
CL851
3.8
-1
E
1
IC803
-23.6
2
R819
1k
Q804
2SC4154TP-1EF
GRID DRIVE
-23.2
-0.2
3.3
CL843
D
-23.6
T800
DC/DC CONVERTER
TRANSFORMER
S14
-23.2
CL816
S16
G10
-23.6
S15
G11
CL858
63
63
1
LED+5V
2
LED_PWM
3
FL_CS
4
FL_CLK
5
FL_DATA
6
E+4V
7
FL-GND
8
FL-GND
M
9
SIRCS
10
PCONT_FL
MAIN
BOARD
(2/5)
CN508
11
DGND
(Page 55)
12
DGND
13
KEY0
14
KEY2
15
KEY1
HBD-E370/E470/E570/E870/T57
5-37. PRINTED WIRING BOARD - POWER Board - • See page 34 for Circuit Boards Location. •
1
2
3
: Uses unleaded solder.
4
5
6
7
8
9
POWER BOARD
C906 (E370: AEP, UK/E870: AEP, UK)
C980 (EXCEPT E370: AEP, UK/E870: AEP, UK)
R950
R906
C907
A
R925
C924
(E370: AEP, UK/E870: AEP, UK)
E
DZ902 C923 CL031
C925
R917
C926
CL049
C
K
DZ903
R992
C994
TP933
C920
6
R905
D914
DZ915
T903
SUB POWER
TRANSFORMER
TH901
D909
CL023 CL021
1
7
D901
1
5
R910
LF902
LINE FILTER
JW934
R919
FR929
CL041
R909
C910
CL044
JW901
CL045
A
CL010
EB909
CL040
IC923
D955
TP923
R998
D943
TP916
JW916
TP922
R999
C990
R972
JW927
JW938
TP919
JW907
JW918
JW917
C942
R940
6
IC941
R966
TP920
1
Q949
LF901
LINE FILTER
C964
CL033
R945
R939
R933
JW911
CL032
4 3
JW936
R965
R932
1 2
C963
R931
IC932
TP905
CL035
JW931
TP911
TP910
TP907
13
JW933
C901
JW903
C939
D931
CL013
2
C972
TP908
R979
CN908
1
JW946
CN906
R901
TP909
F901
VDR901
CL019
C935
TP904
CL014
CL007
C933
C932
CL034
TP912
3
CL020
TP903
C987
C973
TP913
C936
L931
JW908
TP914
TP915
FH902
C934
CL001
L963
C997
HS931
JW928
C951
5
E
Q950
C937
R936
JW902
CL042
R935
JW924
JW904
JW923
R941
R942
7
13
TP906
L956
C971
JW940
R967
R946
R949
CL011
A
L967
JW912
C943
C992
CL043 R934
E C950 E
Q943
C975
JW942
TP918
K
CL039
R937
L954
C928
C929
D976
D942
C991
C940
L964
E
Q969
R976
JW910
R938
JW906
R963 C984
C927
TP927
TP926
A
JW922
CL038
C993
8
JW944
CL017
1 2
15
D954
K
E C
PC901
C938
CL006
EB904
1
CN904
3
5
EB907
1
CAM502
PATTERN
SPARK-GAP
TP902
FH901
TP901
4 3
E C
PC903
T901
MAIN POWER
TRANSFORMER
TP928
TP925
R954
R956
TP921
CL046
CL018
TP924
R955
R959
C983
CL047
E
CL025 4
C906
C980
D908
C905
1
D902
E C
PC902
C908
JW914
R922
(E370: AEP, UK/E870: AEP, UK)
R951
CL048
D913
R903
C902
C903
R914
R912
JW913
B
Q922
R904
C909
2
JW943
R926
2 CL026
C921 CL027
IC901
JW905
6
JW915
CL016
TP934
(E370: AEP, UK/E870: AEP, UK)
JW932
CL030
CL036
Q901
CL022
JW921
CL028
B
DZ901
IC921
C981
R978
R911
JW919
D
1
HS901
CL024 JW920
7
C922
JW909
JW941
R907
CL037
B
CL029
CL004
DZ905
D910
R916
HS921
DZ954
E
JW925
C916
DZ951
C998
D946
R923
D906
CL005
C918
R908
D907
JW945
CL009
JW935
JW939
1
3
CAM503
PATTERN
SPARK-GAP
CL003
CAM501
PATTERN
SPARK-GAP
CL015
EB901
CN901
12
(12)
F
1-880-749-
Q
REG BOARD
CN400
AUDIO BOARD
CN17
(Page 60)
(Page 50)
K
(CHASSIS)
(CHASSIS)
P
MAIN BOARD
CN3001
(CHASSIS)
(AC IN)
(Page 53)
Note: When D913, D931, IC901 and IC921 on the POWER board are replaced, spread the compound
referring to “NOTE OF REPLACING THE D913, D931, IC901 AND IC921 ON THE POWER
BOARD AND THE COMPLETE POWER BOARD” on servicing notes (page 9).
HBD-E370/E470/E570/E870/T57
64
64
HBD-E370/E470/E570/E870/T57
5-38. SCHEMATIC DIAGRAM - POWER Board - • See page 67 for IC Block Diagrams.
1
2
4
3
5
6
7
8
9
10
12
11
13
14
15
16
17
POWER BOARD
A
CL010
CL020
CL011
E
EB909
R903, 904
100k 3W (E370: AEP, UK/E870: AEP, UK)
33k 3W (EXCEPT E370: AEP, UK/E870: AEP, UK)
LF902
LINE FILTER
3
2
3
1
4
1
4
VDR901
CL003
C920
0.01
250V
D901
D5SBA60F01
R903
C902
CL015
C938
470p
250V
TP933
R904
C
R901
1.5M 1/2W (E370: AEP, UK/E870: AEP, UK)
1M 1/2W (EXCEPT E370: AEP, UK/E870: AEP, UK)
(CHASSIS)
R911
220
IC B/D
D913
SARS03
TP934
C902
0.22 310V (E370: AEP, UK/E870: AEP, UK)
0.33 310V (EXCEPT E370: AEP, UK/E870: AEP, UK)
C909
220p
IC901
POWER CONTROL
IC901
STR-F6168-LF1352
E370: AEP, UK/
E870: AEP, UK
D
8
C903
C918
0.01
250V
C981
4700p
DZ905
MAZ8300GMLS0
E370: AEP, UK/
E870: AEP, UK
UDZSUSTE-1730B
C903
330 400V
E370: AEP, UK/
E870: AEP, UK
1000 200V
EXCEPT E370: AEP, UK/
E870: AEP, UK
EXCEPT E370: AEP, UK/
E870: AEP, UK
4
E
D
3
GND
2
OCP/
SYNC
1
5
10
4
11
DZ915
MAZ8100GMLS0
D907
MA2J1110GLS0
R906
3.3k
R905
10
D914
MA2J1110GLS0
D906
MA2J1110GLS0
R910
2.2k
3
12
2
13
1
14
DZ905
3.3
D908
MA2J1110GLS0
20
CL024
20
20
CL023
C907
1000p
E370: AEP, UK/
E870: AEP, UK
165
CL022
CL021
0.5
C980
3300p
1.5kV
C906
1000p
1.5kV
19.3
B+ SWITCH
1500p
EXCEPT E370: AEP, UK/
E870: AEP, UK
R907
10k
C908
47
50V
R912
0.33
2W
CL036
ISOLATOR
1.6
C910
22
50V
IC921
POWER CONTROL
NC
7
BD
6
R922
0.39
2W
C925
0.1
I
CL041
10.1
D910
MA2J1110GLS0
5
GND
4
Vcc/OVP
3
S/GND
2
D
1
PC903
PS2561AL1-1-V-W
ISOLATOR
4
1
CL031
CL028
TP906
4.2
CL038
3.1
CL039
2
DZ902
MAZ8220GLLSO
R946
3.3k
R945
22k
2
C936
0.01
R939
2.2k
1
31.5
TP904
5
PVDD
4
PVDD
3
P-GND
2
NC
1
P-GND
C926
22
100V
C923
330p
C998
4700p
C922
4.7
Q950
RT1N441M-TP-1
C950
0.1
R938
1k
(CHASSIS)
1
16
2
15
3
14
Q943, 949, 950
MAIN POWER ON/OFF SWITCH
D954
EK19LF-F7
TP923
4
13
5
12
C929
1000
25V
C991
0.1
C940
1000
16V
C975
0.1
TP916
C997
0.1
E370: AEP, UK/
E870: AEP, UK
1
EXCEPT E370: AEP, UK/
E870: AEP, UK
L967
10uH
L956
10uH
D942
50PQSA065-FA9
TP925
CN908
2P
CL034
CL035
11
10
TP914
TP908
C927
3300
10V
C993
0.1
TP928
8
TP912
L954
10uH
D943
RK36LF-B3
TP927
7
R923
22k
C987
0.1
9
C973
0.1
C972
0.1
TP911
D946
EG01C LF-F7
R956
470
CL046
SUB POWER
TRANSFORMER
R955
1k
CL049
1.5
4
1
3.5
CL048
2.5
3
J
R998
2.2k
R959
10k
CL047
R963
470
R976
10k
R999
10k
TP907
L963
4.7uH
IC B/D
L964
4.7uH
CL017
C943
220 16V
E370: AEP, UK/
E870: AEP, UK
470 16V
EXCEPT E370: AEP, UK/
E870: AEP, UK
K
IC923
R966
1k
SHUNT REGULATOR
IC923
MM1431CURE
1
2
3
4
5
3.3
2.5
2.5
ISOLATOR
4
TP915
TP910
CL018
3
R979
47k
C984
0.01
2
PC902
PS2561AL1-1-V-W
C997
C983
0.047
TP920
1
S-AIR GND
2
E4V
1
P_CONT1
2
NC
3
EN
4
E+4V
5
6V
6
6V
7
D-GND
8
FAN-GND
9
V-GND
CN906
13P
TP913
C928
2700
16V
C992
0.01
TP926
R916
100k
3W
C990
0.1
D955
EK19LF-F7
TP924
C924
3300p
400V
EB907
3.1
Q949
2SC4154TP-1EF
TP922
R926
1k
R940
10k
R937
10k
0
Q943
RT1N441M-TP-1
R992
4.7
R951
15k
P
MAIN
BOARD
(3/5)
CN3001
(Page 56)
CL006
0
3.1
T903
HBD-E370/E470/E570/E870/T57
C939
0.1
C934
2200
35V
R967
1k
0
CL026
C921
150p
2kV
C933
2200
35V
CL014
TP921
DZ903
MAZ8220GMLS0
CL027
165
C932
2200
35V
R949
3.3k
D902
D1NL20U-TR2
Q922
2SC3243-TP-E
CL029
15.3
NC
C935
0.01
E370: AEP, UK/
E870: AEP, UK
CL037
28.2
RIPPLE FILTER
1.5
CN904
5P
TP903
2
3
CL030
2.4
4
IC932
SHUNT REGULATOR
IC932
MM1431CURE
CL043
21.6
C916
1
3
CL042
C994
470p
250V
R917
4.7k
IC921
STR-Y6763
R932
22k
CL040
DZ901
MAZ8180GMLS0
21
R936
470k
CL032
31.5
FR929
1
1/2W
DZ954
UDZSTE-1730B
DZ951
UDZSTE-1730B
IC B/D
R965
4.7k
32.6
1
4
R933
1k
R935
1k
CL044
D909
MA2J1110GLS0
R908
4.7k
R914
0.1 5W (E370: AEP, UK/E870: AEP, UK)
0.034 5W (EXCEPT E370: AEP, UK/E870: AEP, UK)
R925
10
H
C937
0.047
CL033
PC901
PS2561AL1-1-V-W
R909
10k
R978
4.7k
E370: AEP, UK/
E870: AEP, UK
FB/OLP
R931
1.5k
NC
T901
MAIN POWER
TRANSFORMER
CL045
Q901
2SA1015TP-YGR
EXCEPT E370: AEP, UK/
E870: AEP, UK
G
D931
FMX-22SL
R934
1k
3
F
NC
29.8
VCC
9
L931
2.2uH
CL025
5
6
NC
CL019
R919
22k
STR-F6138-LF1352
EXCEPT E370: AEP, UK/
E870: AEP, UK
FB/OLP
TP905
C905
E
EB901
C905
3300p 400V (E370: AEP, UK/E870: AEP, UK)
0.01 400V (EXCEPT E370: AEP, UK/E870: AEP, UK)
TH901
E
2
TP918
IC941
K
AUDIO
BOARD
CN17
(Page 51)
10
-9V
11
14V
12
12V
13
A-GND
Q
REG
BOARD
CN400
(Page 61)
EB904
+12V REGULATOR
IC941
SI-3010KM-TLS
E
TP902
Sense
3
Vout
2
GND
NC
NUTRAL
(CHASSIS)
1
B
C901
0.22
310V
F901
Vin
LF901
LINE FILTER
1
12
LIVE
C963, 964
470p 250V (E370: AEP, UK/E870: AEP, UK)
1000p 250V (EXCEPT E370: AEP, UK/E870: AEP, UK)
C963
Vcont
TP909
TP901
(AC IN)
C964
2.5
CN901
3P
13.4
F901
T5AH 250V (E370: AEP, UK/E870: AEP, UK)
8A 125V (EXCEPT E370: AEP, UK/E870: AEP, UK)
(CHASSIS)
CL001
C943
CL007
CL013
2.5
6.4
NC
2
1
R941
100k
TP919
R954
3.9k
Q969
ISA1602
VOLTAGE DETECT
C971
0.01
C942
470
25V
R942
10k
R972
10k
C951
0.1
Note: When D913, D931, IC901 and IC921 on the POWER board are replaced, spread the compound
referring to “NOTE OF REPLACING THE D913, D931, IC901 AND IC921 ON THE POWER
BOARD AND THE COMPLETE POWER BOARD” on servicing notes (page 9).
65
65
HBD-E370/E470/E570/E870/T57
5-39. PRINTED WIRING BOARDS - KEY Section : Uses unleaded solder.
S750
FL
BOARD
CN800
1
C750
CL751
R750
KEY1
2
KEY0
3
DGND
4
CL701
CL702
S700
CL703
D-GND
1
KEY0
2
JL103
JL102
JL101
S701
CN701
2P
(11)
1-880-756-
JL104
VOLUME +
R700
2.2k
B
11
CN101
6P
VOLUME -
JL100
S702
CL100
4
JL154
2
JL153
D
R704
1k
1
JL152
JL151
R704 CL701
1
4
CN700
1
D
D
FL BOARD
CN800
(CHASSIS)
ET100
CL100
6
JL150
E
3
JL100 JL101
P-KEY BOARD
13
1-880-753-
(13)
CN750
2P
B
(Page 62)
CL700
S703
1
CN101
MB-134 BOARD
CN602
CL750
F
(Page 48)
R703
FUNCTION
(Page 48)
C
R-USB BOARD
E
MB-134 BOARD
CN601
S701
R701
JL151
CN151
CL703
1
VOLUME -
3
6
JL153
JL154
CL150
JL152
JL150
6
1
5
CL151
ET150
CN150
S700
1-880-754-
F
4
R700
VOLUME +
1-880-755-
13
(13)
11
(11)
HBD-E370/E470/E570/E870/T57
(CHASSIS)
66
1
KEY0
2
CL751
R750
100
R702
S700 – 705, 750
D-GND
66
C750
100p
1
GND
2
NC
3
DP
4
DM
5
VBUS
6
GND
E
CL101
JL102 JL103 JL104
GND
ET150
R705
100
7
4
VBUS
6
(Page 40)
CN151
6P
S705
6
5
B
MB-134
BOARD
(6/13)
CN602
(CHASSIS)
3
S704
5
CN100
DM
R-USB BOARD
CN150
4P
FUNCTION
R705
DP
4
CL101
R703
2.2k
S704
3
R702
100
C
S703
C
GND
NC
ET100
R701
1k
1 2
CN750
F-USB BOARD
1
2
E
CL750
CL702
S705
7
F-USB BOARD
CL700
KEY2
(Page 63)
B
6
CN100
4P
CN700
4P
D
P-KEY BOARD
CN701
2
1
5
KEY BOARD
KEY BOARD
S702
4
4
A
A
3
4
3
2
3
2
1
2
1
•
1
• See page 34 for Circuit Boards Location.
5-40. SCHEMATIC DIAGRAM - KEY Section -
S750
/
CL150
CL151
(CHASSIS)
C
MB-134
BOARD
(6/13)
CN601
(Page 40)
HBD-E370/E470/E570/E870/T57
• IC Block Diagrams
- MB-134 Board IC303 MM3141CNRE
VDD 1
IC307 MM3293DNRE
5 VOUT
REGULATOR
GND 2
CE 3
4 NC
5 VOUT
GND 2
CURRENT
LIMIT
BIAS
REGULATOR
VDD 1
4 NC
CE 3
IC308 MP2301ENE-LF-Z
5V
BS 1
0.3V
CURRENT
SENSE
AMPLIFIER
IN 2
6
–
+
OSCILLATOR
340kHz
INTERNAL
REGULATORS
1.5V
SHUTDOWN
COMPARATOR
6PA
Q
Q
S
R
CURRENT
COMPARATOR
SW 3
2.5V
1.2V
8 SS
LOCKOUT
COMPARATOR
7 EN
GND 4
0.95V
–
+
6 COMP
0.8V
ERROR
AMPLIFIER
5 FB
IC309, 310 TPS54325PWPR
14 VCC
REF
REF
VREG5
VREG5
UV
-30%
UVLO
VO 1
+20%
VREG5
13 VIN
TSD
REF
VFB 2
VREG5 3
SS 4
PROTECTION
LOGIC
OV
+
+
12 VBST
PWM
CONTROL
LOGIC
11 SW2
10 SW1
SOFT START
XCON
GND 5
VREG5
PG 6
REF
-10%
EN
LOGIC
OCP
+
EN 7
9 PGND2
8 PGND1
67
HBD-E370/E470/E570/E870/T57
VIN
N.C.
N.C.
CONT
7
VTTS
8
VREF
VDDQ
IC312 MM1855AHBE
VCC
IC311 BD3539NUX-TR
6
5
8 7 6
5
VCC
VCC
REFERENCE
BLOCK
BIAS
+
REFERENCE
UVLO
UVLO
DRIVER
VCC
SOFT
TSD
EN
UVLO
THERMAL
PROTECTION
VTT_IN
VTT
IC601, 602 SI-3010KM-TLS
3
4
EN
2
EN
GND
1
1 2
3 4
GND
CN
+
TSD
EN
UVLO
TSD
IC704 TK11133CSCL-G
IC705 TK11150CSCL-G
VC 1
VIN 2
VOUT
VCC
THERMAL
SHUTDOWN
CURRENT
LIMITTER
VO
N.C.
TSD
EN
UVLO
VIN
+
5
4
GND 3
OVER HEAT &
OVER CURRENT
PROTECTION
TSD
CONTROL
CIRCUIT
–
+
–
+
BANDGAP
REFERENCE
REF
VOUT 4
CONTROL
VOUT
4
CS
VIN
IC1002 NJM2828F3-05
5
BANDGAP
REFERENCE
3
NP
VCONT
1
IC1001 NJM2878F3-33 (TE2)
2
GND
ADJ 5
5
4
CURRENT
LIMIT
THERMAL
PROTECTION
THERMAL
PROTECTION
OUTPUT
CONTROL
GND
N.C.
68
1
2
3
VOUT
3
VIN
2
GND
1
CONTROL
BANDGAP
REFERENCE
HBD-E370/E470/E570/E870/T57
LOW-PASS
FILTER
2dB
13.5MHz
75:
DRIVER
4dB
13 PR OUT
1
2
3
30MHz
VREF
13.5MHz
110k:
BIAS
PB IN 5
SOFT
TSD
2dB
LOW-PASS
FILTER
BIAS 4
14 SD/HD
GND
PR IN 3
LOW-PASS
FILTER
OCP
FB
110k:
BIAS
4
15 V OUT
LPF
CONTROL
VCC1 2
5
VO
4dB
6
+
V IN 1
75:
DRIVER
6.75MHz
EN
16 VCC2
110k:
BIAS
N.C.
IC1451 BD35630HFV-TR
VCC
IC1003 MM1797CVBE
12 GND
75:
DRIVER
LOW-PASS
FILTER
4dB
11 PB OUT
2dB
LOW-PASS
FILTER
30MHz
VCC1 6
13.5MHz
110k:
BIAS
PY IN 7
75:
DRIVER
LOW-PASS
FILTER
4dB
10 PY OUT
2dB
LOW-PASS
FILTER
9 VCC2
30MHz
MUTE
CONTROL
MUTE 8
IC2301 TPIC1391DBTRG4
LEDO 1
LED
SWITCH
A5V
A5V
LATCH_SET 2
LATCH_CLR 3
30 LATCH_RSOUT
29 LATCH_XRSOUT
28 CSWI
LATCH
CIRCUIT
LED
CONTROL
CIRCUIT
CURRENT SWITCH
CONTROL CIRCUIT
CURRENT
SWITCH
SWITCHIG
REGURATOR
INTERNAL
CONTROL
SWR_SEQ1 4
SWR_SEQ2 5
SWR_OUT_SEL 6
SWITCHING
REGULATOR
STP2 CONTROL
CIRCUIT
XLEDON
CSWON
COLLIENDZ
XRESET
10
11
12
13
A5V 14
AGND 15
21 P5V_SW
A5V
PRE-DRIVER
POWER
MOS FET
PRE-DRIVER
POWER
MOS FET
COLLIMATOR
END DETECTION
POWER
MONITOR
VCO
TSD
22 REG1PXV
SWITCHING
REGULATOR
STP1 CONTROL
CIRCUIT
STP2_IN 9
CSWO
TEST1
FB3P3V
REG3P3V
23 PGND_SW
SWITCHIG REGURATOR
VOLTAGE RESET CONTROL
STEP_ENA 7
STP1_IN 8
27
26
25
24
20 FB1PXV
19 STP218 STP2+
A5V
17 STP116 STP1+
REFERENCE
69
HBD-E370/E470/E570/E870/T57
IC2401 TPIC1405DFDRG4
C19V
C19V 1
C19V
CP2 2
CP1 3
CA5V
AGND_1
VREF
TEST1
TEST2
TEST3
TEST4
4
5
6
7
8
9
10
CHARGE
PUMP
NF
CA5V
XMUTE1 13
XMUTE2 14
GC 15
54 P12V_3
C19V
NF
4
CV3P3
SLED END
DETECTION
START-UP
CIRCUIT
53 SLED1_N
52 SLED1_P
POWER
MOS FET
PRE-DRIVER
XFG 11
MONITOR 12
56 SLED2_N
55 SLED2_P
POWER
MOS FET
PRE-DRIVER
BEMF DETECT
COMPARATOR
49 MCOM
3
CURRENT LIMIT
TSD CIRCUIT
MATRIX
CIRCUIT
48 ISENSE
47 ICOM2
2
GAIN
CONTROL
51 PGND_3
50 CV3P3
46
45
44
43
42
C19V
POWER
MOS FET
PRE-DRIVER
W
P12V_2
V
ICOM1
U
3
41 P12V_1
ABSOLUTE/
PWM CONTROL
CIRCUIT
VSLED1 16
VSLED2 17
C10V
P5V_2
2
ABSOLUTE/
PWM CONTROL
CIRCUIT
VSPIN 18
C10V
ABSOLUTE/
PWM CONTROL
CIRCUIT
VLOAD 19
POWER
MOS FET
PRE-DRIVER
NF
40
39
38
37
36
35
34
33
32
31
C10V
P5V_2
AGND_3
TEST6
TEST5
AGND_2
PGND_2
LOAD_N
LOAD_P
P5V12L
C10V
ABSOLUTE/
PWM CONTROL
CIRCUIT
VTRK 20
POWER
MOS FET
PRE-DRIVER
NF
C10V
ABSOLUTE/
PWM CONTROL
CIRCUIT
VFCS 21
NF
PRE-DRIVER
C10V
ABSOLUTE/
PWM CONTROL
CIRCUIT
VTLT 22
NF
PGND_1 23
TLT_P 24
TLT_N 25
POWER
MOS FET
P5V_1 26
FCS_P 27
FCS_N 28
70
POWER
MOS FET
PRE-DRIVER
30 TRK_N
29 TRK_P
HBD-E370/E470/E570/E870/T57
– AUDIO Board –
IC11, 12 MC14052BDTR2
1
2Y2
2
2-COM
3
14 1Y1
2Y3
4
13 1-COM
2Y1
5
INH
6
11 1Y3
GND
7
10 A
GND
8
9
VOUT
16 VCC
2Y0
VIN
IC14 TK11190CSCL-G
5
4
15 1Y2
OVER HEAT &
OVER CURRENT
PROTECTION
CONTROL
CIRCUIT
12 1Y0
–
+
BANDGAP
REFERENCE
– MAIN Board –
IC503 S-80935CNMC-G85T2G
IC506, 507 S-80929CNMC-G8ZT2G
2
3
NP
VCONT
1
GND
B
VOUT
OUT 1
VIN
IC505, 508 TK11150CSCL-G
5
4
5 CD
VDD 2
–
+
OVER HEAT &
OVER CURRENT
PROTECTION
DELAY
CIRCUIT
CONTROL
CIRCUIT
VREF
–
+
4 NC
BANDGAP
REFERENCE
2
3
NP
VCONT
1
GND
VSS 3
IC702 PCM1808PWR
DELTA-SIGMA
MODULATOR
VREF 1
REFERENCE
DELTA-SIGMA
MODULATOR
AGND
VCC
VDD
DGND
2
3
4
5
u1/64
DECIMATION
FILTER
WITH
HIGH-PASS
FILTER
ANTIALIAS
LOW-PASS FILTER
14 VINR
ANTIALIAS
LOW-PASS FILTER
13 VINL
SERIAL
INTERFACE
&
MODE/FORMAT
CONTROL
12
11
10
9
8
FMT
MD1
MD0
DOUT
BCK
POWER
SUPPLY
CLOCK & TIMING CONTROL
SCKI 6
LRCK 7
71
HBD-E370/E470/E570/E870/T57
RXOUT2
GPIO3
GPIO2
GPIO1
GPIO0
DVDD
DGND
XMODE
CL
CE
DI
DO
IC703 LC89058W-E
48
47
46
45
44
43 42 41
40 39 38 37
36 RERR
35 INT
MICROCONTROLLER
INTERFACE
34 CKST
C bit, Pc
RXOUT1 1
33 AUDIO
RX0 2
FS CALCULATOR
32 MOUT
RX1 3
RX2 4
RX3 5
DGND 6
DVDD 7
DEMODULATION
&
LOCK DETECT
INPUT
SELECTOR
DATA
SELECTOR
31 DGND
30 DVDD
RX4 8
RX5 9
RX6 10
CLOCK
SELECTOR
PLL
OSCILLATION
AMPLIFIER
29 XIN
28 XOUT
27 XMCK
CLOCK
DIVIDER
DVDD 11
DGND 12
21
22 23
24
SBCK
SLRCK
SDIN
20
RDATA
18 19
RLRCK
AVDD
AGND
16 17
DGND
DVDD
14 15
LPF
13
RMCK
RBCK
26 DVDD
25 DGND
XFSOIN
XVDD
HPVDDL
HPOUTL1
HPVSSL
HPOUTL2
HPVDDR
HPOUTR1
HPVSSR
HPOUTR2
FSOI
FSOCKO
IC3010, 3020, 3030 CXD9788AR
48
47
46
45
44
43
42
41
40
39
38 37
CLOCK
GENERATOR
(SECONDARY)
CLOCK
GENERATOR
(PRIMARY)
36
XFSIIN
35
DVDD
VSUBC 2
34
TEST
VSSR 3
33
BFVSS
OUTR2 4
32
BFVDD
31
30
29
DATA
BCK
LRCK
28
MCKSEL
27
INIT
26
SFLAG
25
OVFFLAGL
XVSS 1
VDDR 5
OUTR1 6
VSSR 7
PWM
LINER
INTERPOLATOR
'6
FILTER &
LOW CUT
FILTER
GAIN
CONTROL
SAMPLING
RATE
CONVERTER
VSSL 8
OUTL2 9
VDDL 10
INIT/
MUTE
OUTL1 11
SERIAL
CONTROLLER
72
13
14
15
16
17
18
19
20
21
22
23
24
XOVSS
XFSOOUT
XOVDD
DVDD
DVSS
NSPMUTE
SOFTMUTE
PGMUTE
SCDT
SCSHIFT
SCLATCH
OVFFLAGR
VSSL 12
SgP
HBD-E370/E470/E570/E870/T57
IC3011 SI-3010KM-TLS
IC3050 MM3404A18URE
VC 1
4 VDD
VIN 2
CE 1
GND 3
BIAS
VOLTAGE
REFERENCE
–
+
TSD
–
+
CURRENT
LIMIT
3 VOUT
GND 2
REF
VOUT 4
ADJ 5
IC3100, 3200, 3400 CXD9981TN
GVDD_B
1
/OTW
2
NC
NC
3
4
/SD
5
PWM_A
6
/RESET_AB
PWM_B
OC_ADJ
4
UNDER
VOLTAGE
PROTECTION
INTERNAL PULLUP
RESISTORS TO VREG
44 GVDD_A
4
43 BST_A
42 NC
PROTECTION
AND
I/O LOGIC
POWER
ON
RESET
VREG
41 PVDD_A
40 PVDD_A
TEMP.
SENSE
OVERLOAD
PROTECTION
7
39 OUT_A
ISENSE
BTL/P BTL-CONFIGURATION
PULLDOWN RESISTORS
38 GND_A
37 GND_B
8
BTL/P BTL-CONFIGURATION
PULLDOWN RESISTORS
9
36 OUT_B
GND 10
PWM
RCV.
AGND 11
CTRT.
TIMING
35 PVDD_B
GATE
DRIVE
34 BST_B
33 BST_C
VREG 12
32 PVDD_C
M3 13
M2
PWM
RCV.
14
31 OUT_C
CTRT.
TIMING
GATE
DRIVE
BTL/P BTL-CONFIGURATION
PULLDOWN RESISTORS
30 GND_C
M1 15
29 GND_D
PWM_C
16
PWM
RCV.
/RESET_CD 17
PWM_D
18
NC
NC
19
20
VDD
21
TIMING
GATE
DRIVE
28 OUT_D
27 PVDD_D
26 PVDD_D
VREG
VREG
GVDD_C 22
CTRT.
BTL/P BTL-CONFIGURATION
PULLDOWN RESISTORS
PWM
RCV.
CTRT.
TIMING
GATE
DRIVE
25 NC
24 BST_D
23 GVDD_D
73
HBD-E370/E470/E570/E870/T57
– REG Board –
IC400 TK11133CSCL-G
VIN
VOUT
IC402 TK72270CSCL-GH
5
4
CONT 1
OVER HEAT &
OVER CURRENT
PROTECTION
CONTROL
CIRCUIT
–
+
5 OUT
+
BANDGAP
REFERENCE
4 GND
SW
CIRCUIT
BANDGAP
REFERENCE
OVER HEAT &
OVER CURRENT
PROTECTION
VEE 2
3
NP
VCONT
2
GND
NP 3
1
VIN
VOUT
– FL Board –
IC801 TK11133CSCL-G
5
4
OVER HEAT &
OVER CURRENT
PROTECTION
CONTROL
CIRCUIT
–
+
1
2
3
VCONT
GND
NP
BANDGAP
REFERENCE
1
2
3
4
6
7
8
9
KEY0 10
KEY1 11
74
GRID1
GRID2
GRID3
GRID4
SEG24/GRID5
SEG23/GRID6
SEG22/GRID7
SEG21/GRID8
SEG20/GRID9
38 37 36 35 34
4
OSC
12-BIT SHIFT
REGISTER
12
4
GRID
DRIVER
8
DATA
SELECTOR
TIMING GENERATOR
KEY SCAN
8
MULTIPLEXED
DRIVER
8
8
SERIAL
INTERFACE
DISPLAY RAM
24 BITS x 12 WORDS
COMMAND
DECODER
24-BIT OUTPUT
LATCH
24
16
SEGMENT
DRIVER
33 SEG19/GRID10
32 SEG18/GRID11
31 SEG17/GRID12
30 VEE
16
29 SEG16/KS16
28 SEG15/KS15
27 SEG14/KS14
26
25
24
23
DIMMING
CIRCUIT
12 13
14 15 16 17 18 19 20 21 22
SEG1/KS1
SEG2/KS2
SEG3/KS3
SEG4/KS4
SEG5/KS5
SEG6/KS6
SEG7/KS7
SEG8/KS8
SEG9/KS9
DO
DI
CLK
CS
42 41 40 39
4-BIT LATCH
KEY DATA MEMORY
(2 x 16)
OSC 5
44 43
VSS
VDD
LED0
LED1
LED2
LED3
VSS
VDD
IC802 HT16515
SEG13/KS13
SEG12/KS12
SEG11/KS11
SEG10/KS10
HBD-E370/E470/E570/E870/T57
– POWER Board –
IC901 STR-F6138-LF1352 (E370: AEP, UK/E870: AEP, UK models)
IC901 STR-F6168-LF1352 (Except E370: AEP, UK/E870: AEP, UK models)
CURRENT
MIRROR
OSC
LATCH
DELAY
DELAY
OVER
CURRENT
PROTECT
2
LOGIC
OVER
CURRENT
PROTECT
2
FEED
BACK
BOTTOM
SKIP
LOGIC
INH
2
INH
1
OVER
CURRENT
PROTECT
1
OVER VOLTAGE
PROTECT
THERMAL
SHUT DOWN
OVER LOAD
PROTECT
INTERNAL BIAS
2
3
4
S/GND
DRAIN
VCC
IC921 STR-Y6763
UNDER VOLTAGE
LOCK OUT
5
FB/OCP
1
OCP/INH
SWITCHING
REGULATOR
BLOCK
IC941 SI-3010KM-TLS
VC 1
STARTUP
D/ST 1
VIN 2
DRIVER
S/OCP 2
GND 3
OVERCURRENT
PROTECTION/
BOTTOM-SKIP
TSD
VCC 3
–
+
UNDER VOLTAGE
LOCK OUT/
REGULATOR/
CONSTANT CURRENT
REF
LOGIC
GND 4
FB/OLP 5
LATCH
VOUT 4
ADJ 5
FEEDBACK/
STANDBY
OVERLOAD
PROTECTION
BD 6
BOTTOM
DETECTION
NF 7
OSCILLAOTR
75
HBD-E370/E470/E570/E870/T57
• IC Pin Function Description
MB-134 BOARD IC101 CXD9983GG (E370: US/E470/E570/T57) (BD DECODER)
CXD9984GG (E370: Canadian, AEP, UK/E870) (BD DECODER)
Pin No.
A1
A3
A5
A7
A9
A11
A13
A15
A17
A19
A21
A23
A25
A27
A29
A31
A33
A35
A37
A39
A41
A43
B2
B4
B6
B8
B10
B12
B14
B16
B18
B20
B22
B24
B26
B28
B30
B32
B34
B36
B38
B40
B42
C1
C3
C5
C7
C9
C11
C13
C15
C17
C19
C21
C23
C25
76
Pin Name
FESFDO
VOUTD1
VOUTD5
VOUTD9
VOUTD12
VIND0
VIND12
VIND16
GPIO1
SPDIF
SPBCK
AVDD12_27MPLL
NS_XTALI
CH1_M
CLK_M
DACOUT4
DACOUT1
VCLK
UARXD
ETRXD3
ETRXD0
ETRXCLK
FESFCS
VOUTD3
VOUTD7
VOUTD10
VOUTD14
VIND4
VIND14
VINHSYNC
GPIO3
SPLRCK
AOBCK
AVDD12_DMPLL
CH2_M
CH0_M
EXT_CAP
DACOUT3
VDATA
IR
ETMDIO
ETRXD1
ETRXER
FE_SFCLK
FESFDI
VOUTD4
VOUTD8
VOUTD11
VOUTD15
VIND11
VIND15
GPIO0
GPIO2
SPMCLK
AOSDATA0
NS_XTALO
I/O
I
O
I
I
O
I
O
O
O
O
O
O
I
I
I
I
O
O
I
O
O
O
O
I
I
I/O
I
I
O
O
O
I
I
O
I
Description
Serial data input terminal for the front-end serial flash
Not used
Not used
Not used
Not used
Serial data transfer clock signal output to the digital audio interface receiver
CSFLAG signal input from the digital audio interface receiver
Not used
Busy request signal input from the system controller
Digital audio data output terminal Not used
Bit clock signal input from the digital audio interface receiver
Power supply terminal (+1.2V)
System clock signal output terminal (27 MHz)
TMDS data (negative) output to the HDMI ARC OUT connector
TMDS clock signal (negative) output to the HDMI ARC OUT connector
Not used
Video signal (Pr/Cr) output terminal
Serial data transfer clock signal output to the system controller
Not used
Receive data input from the ethernet interface
Receive data input from the ethernet interface
Receive clock signal input from the ethernet interface
Chip select signal input terminal for the front-end serial flash
Not used
Not used
Not used
Not used
Reset signal output to the digital audio interface receiver
Not used
Not used
Power on/off control signal output terminal for the USB section
L/R sampling clock signal input from the digital audio interface receiver
Bit clock signal output to the audio section
Power supply terminal (+1.2V)
TMDS data (negative) output to the HDMI ARC OUT connector
TMDS data (negative) output to the HDMI ARC OUT connector
Not used
Video signal (Pb/Cb) output terminal
Serial data input from the system controller
Error signal input from the digital audio interface receiver
Two-way data bus with the ethernet interface
Receive data input from the ethernet interface
Receive error signal input from the ethernet interface
Serial data transfer clock signal output terminal for the front-end serial flash
Serial data output terminal for the front-end serial flash
Not used
Not used
Not used
Not used
Not used
Not used
Request signal output to the system controller
Chip select signal input from the system controller
Master clock signal input from the digital audio interface receiver
Digital audio data output to the power amp
System clock signal input terminal (27 MHz)
HBD-E370/E470/E570/E870/T57
Pin No.
C27
C29
C31
C33
C35
C37
C39
C41
C43
D2
D4
D6
D8
D10
D12
D14
D16
D18
D20
D22
D24
D26
D28
D30
D32
D34
D36
D38
D40
D42
E1
E3
E5
E7
E9
E11
E13
E15
E17
E19
E21
E23
E25
E27
E29
E31
E33
E35
E37
E39
E41
E43
F2
F4
F6
F8
F10
F12
F14
F16
Pin Name
CH1_P
CLK_P
DACOUT5
DACOUT2
MRESET_
ETCOL
ETRXD2
ETTXCLK
ETTXD0
FE_GIO11
FESFCK
VOUTD6
VOUTD0
VOUTD13
VIND1
VIND13
VINCLK
VIND17
AOSDATA5
AOMCLK
AVDD12_APLL
CH2_P
CH0_P
DACOUT6
AVDD33_VDACBG
VSTB
UATXD
ETTXEN
ETTXD1
ETTXD2
FE_SFDO
FE_GIO2
FE_GIO9
VOUTD2
VOUTCLK1
VOUTD16
VOUTD19
VIND2
VINVSYNC
VIND19
AOSDATA4
AOLRCK
AVDD33_XTAL
TP_PLLG
EXT_RES
AVDD33_VDACR
DACFS
RESET_
ETTXER
ETTXD3
HDMISD
CEC
FE_SFDI
FE_SFHOLD#
NS_CKIN33
VOUTCLK2
VOUTHSYNC
VOUTD17
VIND5
VIND3
I/O
O
O
O
O
O
I
I
I
O
I
O
O
O
O
O
O
O
O
O
O
O
I
I
O
O
I
O
O
I/O
I
I
O
O
Description
TMDS data (positive) output to the HDMI ARC OUT connector
TMDS clock signal (positive) output to the HDMI ARC OUT connector
Not used
Video signal (Y) output terminal
Reset signal output terminal for the front-end power
Collision detect signal input from the ethernet interface
Receive data input from the ethernet interface
Transmit clock signal input from the ethernet interface
Transmit data output to the ethernet interface
Not used
Serial data transfer clock signal input terminal for the front-end serial flash
Not used
Not used
Not used
Serial data output to the digital audio interface receiver
Not used
Not used
Not used
Digital audio data output terminal Not used
Master clock signal output to the audio section
Power supply terminal (+1.2V)
TMDS data (positive) output to the HDMI ARC OUT connector
TMDS data (positive) output to the HDMI ARC OUT connector
Video signal (CVBS) output terminal
Power supply terminal (+3.3V)
Not used
Not used
Transmit enable signal output to the ethernet interface
Transmit data output to the ethernet interface
Transmit data output to the ethernet interface
Serial data output terminal for the front-end serial flash
Not used
Clock signal output terminal for the SACD
Not used
Not used
Not used
Not used
Serial data input from the digital audio interface receiver
Not used
Interrupt signal input from the digital audio interface receiver
Digital audio data output to the S-AIR section
L/R sampling clock signal output to the audio section
Power supply terminal (+3.3V)
Not used
Not used
Power supply terminal (+3.3V)
Not used
System reset signal input from the system controller
Transmit error signal output to the ethernet interface
Transmit data output to the ethernet interface
Two-way data bus with the HDMI ARC OUT connector
Not used
Serial data input terminal for the front-end serial flash
Not used
Clock signal input terminal for the SACD
Not used
Not used
Not used
Power on/off control signal output terminal for the USB section
Chip enable signal output to the digital audio interface receiver
77
HBD-E370/E470/E570/E870/T57
Pin No.
F18
F20
F22
F24
F26
F28
F30
F32
F34
F36
F38
F40
F42
G1
G3
G5
G7
G9
G11
G13
G15
G17
G19
G21
G23
G25
G27
G29
G31
G33
G35
G37
G39
G41
G43
H2
H4
H6
H8
H10
H12
H14
H16
H18
H20
H22
H24
H26
H28
H30
H32
H34
H36
H38
H40
H42
J1
J3
J5
J7
78
Pin Name
VIND7
MCIN
AOSDATA3
AVSS12_DMPLL
TN_PLLG
AVSS33_HDMI
AVDD12_HDMI
AVSS33_VDACBG
OPWRSB
ETMDC
ETRXDV
HDMISCK
SFDO
FE_VRDC0
FE_FG
FE_GIO7
FE_JTCLK
FE_GIO6
VOUTVSYNC
VOUTD18
VIND8
VIND10
VIND18
SPDATA
AOSDATA1
AVSS33_XTAL
AVSS33_HDMI
AVDD12_HDMI
AVDD33_VDACY
LCDRD
VCC3IO_STB
DVSS
HTPLG
SFCK
NFWEN
FE_JTDO
NS_RFIN
FE_JTRST#
FE_GIO10
VCC3IO_3
VCC3IO_3
VIND6
DVSS
VCC3IO_3
AMUTE
AOSDATA2
AVSS12_APLL
AVDD33_HDMI
AVSS12_HDMI
AVSS33_VDACY
AVSS33_VDACR
ETCRS
DVSS
AVDD10_LDO
SFDI
NFD0
FE_HAVC
FE_MPXOUT3
FE_GIO5
FE_GIO4
I/O
I
O
O
O
I
I/O
O
O
I
O
O
O
I
I
O
O
I
O
O
I
O
O
O
I
I
I/O
O
O
O
Description
Not used
Digital audio data input from the A/D converter
Digital audio data output to the S-AIR section
Ground terminal
Not used
Ground terminal
Power supply terminal (+1.2V)
Ground terminal
Power on/off control signal output to the system controller
Serial data transfer clock signal output to the ethernet interface
Receive data valid signal input from the ethernet interface
Two-way clock bus with the HDMI ARC OUT connector
Serial data output to the serial flash
Voltage output terminal for automatic power control circuit
Motor hole sensor signal input from the motor driver IC
Laser diode on/off control signal output to the BD drive
Not used
MODE C signal output to the BD drive
Not used
Not used
Video format selection signal output to the video amplifier
Not used
PCM audio data input from the digital audio interface receiver
Digital audio data input from the digital audio interface receiver
Digital audio data output to the power amp and S-AIR section
Ground terminal
Ground terminal
Power supply terminal (+1.2V)
Power supply terminal (+3.3V)
Serial data output to the system controller
Power supply terminal (+3.3V)
Ground terminal
Hot plug detection signal input from the HDMI ARC OUT connector
Serial data transfer clock signal output to the serial flash
Write enable signal output to the NAND flash
Not used
SACD audio data (negative) input terminal
Not used
Not used
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Video muting on/off control signal output to the video amplifier
Ground terminal
Power supply terminal (+3.3V)
Muting on/off control signal output terminal Not used
Digital audio data output to the power amp
Ground terminal
Power supply terminal (+3.3V)
Ground terminal
Ground terminal
Ground terminal
Carrier sense signal input from the ethernet interface
Ground terminal
Power supply terminal (+1.0V)
Serial data input from the serial flash
Two-way data bus with the NAND flash
Reference voltage output to the BD drive
Not used
MODE B signal output to the BD drive
MODE A signal output to the BD drive
HBD-E370/E470/E570/E870/T57
Pin No.
J9
J11
J13
J15
J17
J19
J21
J23
J25
J27
J29
J33
J37
J39
J41
J43
K2
K4
K6
K8
K34
K36
K38
K40
K42
L1
L3
L5
L7
L9
L35
L37
L39
L41
L43
M2
M4
M6
M8
M10
M36
M38
M40
M42
N1
N3
N5
N7
N9
N11
N35
N37
N39
N41
N43
P2
P4
P6
P8
P10
Pin Name
DVSS
DVSS
DVSS
VCC3IO_3
VIND9
DVSS
VCC3IO_PWM
DVSS
AVSS12_27MPLL
AVDD33_HDMI
AVSS12_HDMI
VCC3IO_STB
AVDD33_LDO
SFCS
NFD1
NFD2
FE_MPXOUT2
FE_EQBIAS
FE_SFCS#
NS_RFIP
DVSS
AVSS33_LDO
NFCLE
NFD3
NFD4
FE_VWDC3O
FE_VDAC0
FE_MPXOUT1
FE_SFWP#
FE_GIO8
VCC3IO_2
NFALE
NFCEN2
NFD5
NFD6
FE_VWDC2O
FE_AUX1
FE_RSTI
FE_MVDDO
FE_MVDDO
NFREN
NFCEN
NFD7
B_REXTDN
FE_INB
FE_TRINC
FE_VFVREF
FE_DVDD33O
FE_DVDD33O
FE_DVDD33O
VCC3IO_2
DVSS
DVSS
B_RCLK1
B_RCLK1B
FE_INA
FE_TRINA
FE_VWDC1O
FE_AVDD12_1
FE_DVDD33O
I/O
O
I/O
I/O
O
O
I
O
I/O
I/O
O
O
O
I/O
I/O
I
I
O
O
I/O
O
O
O
O
-
Description
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+3.3V)
Not used
Ground terminal
Power supply terminal (+3.3V)
Ground terminal
Ground terminal
Power supply terminal (+3.3V)
Ground terminal
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Chip select signal output to the serial flash
Two-way data bus with the NAND flash
Two-way data bus with the NAND flash
Digital audio data output terminal for the SACD
Not used
Chip select signal output terminal for the front-end serial flash
SACD audio data (positive) input terminal
Ground terminal
Ground terminal
Command latch enable signal output to the NAND flash
Two-way data bus with the NAND flash
Two-way data bus with the NAND flash
Not used
Not used
Digital audio data output terminal for the SACD
Not used
Not used
Power supply terminal (+3.3V)
Address latch enable signal output to the NAND flash
Chip enable signal output terminal Not used
Two-way data bus with the NAND flash
Two-way data bus with the NAND flash
Not used
Monitoring signal input from the BD drive
Reset signal input terminal for the front-end power
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Read enable signal output to the NAND flash
Chip enable signal output to the NAND flash
Two-way data bus with the NAND flash
Not used
Main beam (B) input from the BD drive
Not used
Not used
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Ground terminal
Ground terminal
Clock signal (positive) output to the SD-RAM
Clock signal (negative) output to the SD-RAM
Main beam (A) input from the BD drive
Not used
Not used
Power supply terminal (+1.2V)
Power supply terminal (+3.3V)
79
HBD-E370/E470/E570/E870/T57
Pin No.
P12
P14
P36
P38
P40
P42
R1
R3
R5
R7
R9
R35
R37
R39
R41
R43
T2
T4
T6
T8
T10
T12
T14
T36
T38
T40
T42
U1
U3
U5
U7
U9
U11
U13
U15
U35
U37
U39
U41
U43
V2
V4
V6
V8
V10
V12
V14
V36
V38
V40
V42
W1
W3
W5
W7
W9
W11
W13
W15
W21
80
Pin Name
DVSS
DVSS
NFRBN2
NFRBN
VCC2IO
VCC2IO
FE_ING
FE_INC
FE_TRINB
FE_TRIND
FE_AVDD12_2
DVSS
B_RDQ25
B_RDQ30
B_RDQ29
B_RDQ26
FE_INH
FE_FPDODVD
FE_IND
FE_DVDD12I
FE_DVDD12I
DVSS
DVSS
B_RDQ28
B_RDQ27
B_RDQ24
B_RDQ31
FE_INF
FE_FOIN
FE_FPDOCD
FE_V14
FE_AVDD33
FE_DVDD12I
DVSS
DVSS
DVSS
DVSS
DVSS
B_RDQS3B
B_RDQS3
FE_FOIP
FE_REG_CAP
FE_INE
FE_AVDD33
FE_DVDD12I
DVSS
DVSS
B_RDQM3
B_RDQM2
VCC2IO
VCC2IO
FE_RFIP2
FE_RFIN2
FE_AGND
FE_AGND
FE_AVDD33
FE_DVDD12I
DVSS
DVSS
VCCK
I/O
O
O
O
O
I/O
I/O
I/O
I/O
O
I
O
I/O
I/O
I/O
I/O
O
O
O
O
O
O
O
I
I
-
Description
Ground terminal
Ground terminal
Ready/busy selection signal output terminal Not used
Ready/busy selection signal output to the NAND flash
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
Sub beam (G) input from the BD drive
Main beam (C) input from the BD drive
Not used
Not used
Power supply terminal (+1.2V)
Ground terminal
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Sub beam (H) input from the BD drive
Laser power monitor signal input from the BD drive
Main beam (D) input from the BD drive
Power supply terminal (+1.2V)
Power supply terminal (+1.2V)
Ground terminal
Ground terminal
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Sub beam (F) input from the BD drive
Not used
Not used
Reference voltage (+1.4V) output for the motor drive circuit
Power supply terminal (+3.3V)
Power supply terminal (+1.2V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Data strobe signal (negative) output to the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Not used
Not used
Sub beam (E) input from the BD drive
Power supply terminal (+3.3V)
Power supply terminal (+1.2V)
Ground terminal
Ground terminal
Data mask signal output to the SD-RAM
Data mask signal output to the SD-RAM
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
DVD RF signal (positive) input from the BD drive
DVD RF signal (negative) input from the BD drive
Ground terminal
Ground terminal
Power supply terminal (+3.3V)
Power supply terminal (+1.2V)
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
HBD-E370/E470/E570/E870/T57
Pin No.
W23
W25
W27
W29
W31
W35
W37
W39
W41
W43
Y2
Y4
Y6
Y8
Y10
Y14
Y20
Y22
Y24
Y26
Y28
Y30
Y32
Y36
Y38
Y40
Y42
AA1
AA3
AA5
AA7
AA9
AA21
AA23
AA25
AA27
AA29
AA31
AA35
AA37
AA39
AA41
AA43
AB2
AB4
AB6
AB8
AB10
AB12
AB20
AB22
AB24
AB26
AB28
AB30
AB32
AB36
AB40
AB42
AC1
Pin Name
VCCK
VCCK
VCCK_PWM
VCCK
VCCK
VCC2IO
B_RDQ18
B_RDQ21
B_RDQS2
B_RDQS2B
FE_RFIP
FE_RFIN
FE_LVDS_1N
FE_AGND
FE_DVDD12I
DVSS
VCCK
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
B_RDQ23
B_RDQ16
B_RDQ20
B_RDQ22
FE_LVDS_2P
FE_LVDS_2N
FE_LVDS_1P
FE_AGND
FE_AVDD33_LVDS
DVSS
VCCK
VCCK
VCCK
VCCK
DVSS
DVSS
DVSS
DVSS
B_RDQ17
B_RDQ19
FE_LVDS_4N
FE_LVDS_3N
FE_LVDS_5N
FE_AVDD12_3
FE_DVDD33O
FE_DVDD33O
VCCK
VCCK
DVSS
DVSS
DVSS
VCCK
VCCK
B_RVREF
VCC2IO
VCC2IO
FE_LVDS_4P
I/O
I/O
I/O
O
O
I
I
I/O
I/O
I/O
I/O
I/O
I/O
I
-
Description
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Data strobe signal (negative) output to the SD-RAM
BD RF signal (positive) input from the BD drive
BD RF signal (negative) input from the BD drive
Not used
Ground terminal
Power supply terminal (+1.2V)
Ground terminal
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Not used
Not used
Not used
Ground terminal
Power supply terminal (+3.3V)
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Not used
Not used
Not used
Power supply terminal (+1.2V)
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Reference voltage (+0.9V) input terminal for the SD-RAM
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
Not used
81
HBD-E370/E470/E570/E870/T57
Pin No.
AC3
AC5
AC7
AC9
AC21
AC23
AC25
AC27
AC29
AC31
AC37
AC39
AC41
AC43
AD2
AD4
AD6
AD8
AD20
AD22
AD24
AD26
AD28
AD30
AD32
AD36
AD38
AD40
AD42
AE1
AE3
AE5
AE7
AE9
AE21
AE23
AE25
AE27
AE29
AE31
AE35
AE37
AE39
AE41
AE43
AF2
AF4
AF6
AF8
AF20
AF22
AF24
AF26
AF28
AF30
AF32
AF36
AF38
AF40
AF42
82
Pin Name
FE_LVDS_3P
FE_LVDS_5P
FE_AVDD12_4
FE_DVDD33O
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
B_RA5
B_RBA2
B_RCKE
B_RWEB
FE_CFREQ
FE_FOO
FE_GAINSW2
FE_GIO0
VCCK
VCCK
DVSS
DVSS
DVSS
VCCK
VCCK
B_RBA1
B_RA9
B_RBA0
B_RCSB
FE_FMO
FE_TRAYPWM
FE_GAINSW1
FE_OSOEN
FE_GIO12
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
B_RA12
B_RA7
FE_DMO
FE_FMO2
FE_FMO4
FE_CMOD
VCCK
VCCK
DVSS
DVSS
DVSS
VCCK
VCCK
B_RA10
B_RA1
VCC2IO
VCC2IO
I/O
O
O
O
O
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
-
Description
Not used
Not used
Power supply terminal (+1.2V)
Power supply terminal (+3.3V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Address signal output to the SD-RAM
Bank address signal output to the SD-RAM
Clock enable signal output to the SD-RAM
Write enable signal output to the SD-RAM
Serial data input/output with the BD drive
Motor drive signal output to the motor driver IC
Read/write gain switch dignal output to the motor driver IC
Motor drive muting on/off control signal output to the motor driver IC
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Bank address signal output to the SD-RAM
Address signal output to the SD-RAM
Bank address signal output to the SD-RAM
Chip select signal output to the SD-RAM
Motor drive signal output to the motor driver IC
Motor drive signal output to the motor driver IC
Read/write gain switch dignal output to the motor driver IC
Serial data transfer clock signal output to the BD drive
Not used
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Motor drive signal output to the motor driver IC
Motor drive signal output to the motor driver IC
Motor drive signal output to the motor driver IC
Serial interface commande enable signal output to the BD drive
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
HBD-E370/E470/E570/E870/T57
Pin No.
AG1
AG3
AG5
AG7
AG9
AG21
AG23
AG25
AG27
AG29
AG31
AG37
AG39
AG41
AG43
AH2
AH4
AH6
AH8
AH20
AH22
AH24
AH26
AH28
AH30
AH32
AH36
AH38
AH40
AH42
AJ1
AJ3
AJ5
AJ7
AJ9
AJ21
AJ23
AJ25
AJ27
AJ29
AJ31
AJ35
AJ37
AJ39
AJ41
AJ43
AK2
AK4
AK6
AK8
AK20
AK22
AK24
AK26
AK28
AK30
AK32
AK36
AK38
AK40
Pin Name
FE_GIO3
FE_LIMIT
FE_GAINSW3
FE_FMO3
FE_GIO1
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
B_RA2
B_RA6
B_RODT
B_RA0
FE_PLAY#
FE_EJECT#
FE_TRO
FE_FSOURCE
VCCK
VCCK
DVSS
DVSS
DVSS
VCCK
VCCK
B_RA8
B_RA11
B_RCASB
B_RA4
FE_XTAL25MO
FE_XTAL25MI
FE_TRAYIN#
DVSS_XTAL
VCLK25MI
DVSS
VCCK
VCCK
VCCK
VCCK
DVSS
DVSS
DVSS
DVSS
B_RRASB
B_RA3
USB_DM0
FE_TRAYOUT
AVSS12_USB
AVDD12_USB
VCCK
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
B_RDQ9
B_RA13
VCC2IO
I/O
I
O
O
O
O
O
O
I
O
O
O
O
O
I
I
O
O
O
I/O
I
I/O
O
-
Description
Not used
Sledge innner limit signal input from the motor driver IC
Not used
Motor drive signal output to the motor driver IC
Motor drive muting on/off control signal output to the motor driver IC
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Address signal output to the SD-RAM
Address signal output to the SD-RAM
On die termination enable signal output to the SD-RAM
Address signal output to the SD-RAM
Not used
Eject/stop key input from the system controller
Motor drive signal output to the motor driver IC
Not used
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Column address strobe signal output to the SD-RAM
Address signal output to the SD-RAM
Not used
System clock signal input terminal (25 MHz)
Disc tray in detection signal input terminal
Ground terminal
System clock signal output terminal (25 MHz)
Ground terminal
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Row address strobe signal output to the SD-RAM
Address signal output to the SD-RAM
USB differential serial data (negative) input/output with the USB connector (rear side)
Disc tray out detection signal input terminal
Ground terminal
Power supply terminal (+1.2V)
Power supply terminal (+1.1V)
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Ground terminal
Power supply terminal (+1.1V)
Two-way data bus with the SD-RAM
Address signal output to the SD-RAM
Power supply terminal (+1.8V)
83
HBD-E370/E470/E570/E870/T57
Pin No.
AK42
AL1
AL3
AL5
AL7
AL21
AL23
AL25
AL27
AL29
AL31
AL35
AL37
AL39
AL41
AL43
AM2
AM4
AM6
AM8
AM36
AM38
AM40
AM42
AN1
AN3
AN5
AN7
AN35
AN37
AN39
AN41
AN43
AP2
AP4
AP6
AP8
AP36
AP38
AP40
AP42
AR1
AR3
AR5
AR7
AR17
AR19
AR25
AR29
AR31
AR37
AR39
AR41
AR43
AT2
AT4
AT6
AT10
AT12
AT14
84
Pin Name
VCC2IO
USB_DP0
USB_DM1
AVSS33_USB
FE_SVDD33
VCCK
VCCK
VCCK
VCCK
VCCK
VCCK
VCC2IO
B_RDQ11
B_RDQ14
B_RCLK0B
B_RCLK0
USB_DP1
USB_VRT
FE_SXVDD33
FE_TLO
B_RDQM1
B_RDQ12
B_RDQ10
B_RDQ13
FE_STXP
AVDD33_USB
FE_SAGND
FE_SPLLVDD12
DVSS
DVSS
DVSS
B_RDQ15
B_RDQ8
FE_STXN
CORE_RESETB
FE_STXVDD12
FE_AVDD12_RX
B_RDQ7
B_RDQM0
VCC2IO
VCC2IO
FE_SRXP
FE_SRXN
RTCRBIAS
AVDD12_ADC
DVSS
VCC2IO
DVSS
DVSS
VCC2IO
B_RDQ6
B_RDQ0
B_RDQS1B
B_RDQS1
XI_RTC
XO_RTC
AVSS12_ADC
FE_GIO13
SCL
DVSS
I/O
I/O
I/O
I/O
I/O
O
O
I/O
O
O
I/O
I/O
I/O
O
I/O
I/O
O
I
I/O
O
I
I
I/O
I/O
O
O
I
O
I/O
-
Description
Power supply terminal (+1.8V)
USB differential serial data (positive) input/output with the USB connector (rear side)
USB differential serial data (negative) input/output with the USB connector (front side)
Ground terminal
Power supply terminal (+3.3V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.1V)
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Clock signal (negative) output to the SD-RAM
Clock signal (positive) output to the SD-RAM
USB differential serial data (positive) input/output with the USB connector (front side)
Not used
Power supply terminal (+3.3V)
Motor drive signal output to the motor driver IC
Data mask signal output to the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
SATA channel 1 RX differential pair signal (positive) output terminal
Power supply terminal (+3.3V)
Ground terminal
Power supply terminal (+1.2V)
Ground terminal
Ground terminal
Ground terminal
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
SATA channel 1 RX differential pair signal (negative) output terminal
System reset signal input from the system controller
Power supply terminal (+1.2V)
Power supply terminal (+1.2V)
Two-way data bus with the SD-RAM
Data mask signal output to the SD-RAM
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
SATA channel 1 TX differential pair signal (positive) input terminal
SATA channel 1 TX differential pair signal (negative) input terminal
Not used
Power supply terminal (+1.2V)
Ground terminal
Power supply terminal (+1.8V)
Ground terminal
Ground terminal
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (negative) output to the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Not used
Not used
Ground terminal
Not used
Two-way clock bus with the EEPROM
Ground terminal
HBD-E370/E470/E570/E870/T57
Pin No.
AT16
AT18
AT20
AT22
AT24
AT26
AT28
AT30
AT32
AT34
AT36
AT38
AT40
AT42
AU1
AU3
AU5
AU7
AU9
AU11
AU13
AU15
AU17
AU19
AU21
AU23
AU25
AU27
AU29
AU31
AU33
AU35
AU37
AU39
AU41
AU43
AV2
AV4
AV6
AV8
AV10
AV12
AV14
AV16
AV18
AV20
AV22
AV24
AV26
AV28
AV30
AV32
AV34
AV36
AV38
AV40
AV42
AW1
AW3
AW5
Pin Name
A_RDQ5
A_RDQM0
A_RDQ11
DVSS
A_RA11
A_RA1
A_RBA2
A_RVREF
A_RDQ23
DVSS
DVSS
B_RDQ5
B_RDQS0
B_RDQS0B
AVDD33_RTC
AVSS33_RTC
AVDD33_SACD
AVDD33_ST
AVSS12_ST2
EEPWRQ
VCC3IO_1
A_RDQ3
DVSS
A_RDQ9
DVSS
A_RCASB
DVSS
A_RBA1
DVSS
A_RDQ21
DVSS
A_RDQM3
A_RDQ27
DVSS
B_RDQ3
B_RDQ2
FE_JRTCLK
AVSS33_SACD
AVDD12_SRX1
AVSS12_ST1
AVDD12_ST
GPIO6
SDA
A_RDQ0
A_RDQM1
A_RDQ14
A_RA13
A_RCSB
A_RA2
A_RA5
NC
A_RDQ16
A_RDQM2
A_RDQ25
A_RDQ30
VCC2IO
VCC2IO
FE_JTMS
FE_JTDI
AVDD12_STX1
I/O
I/O
O
I/O
O
O
O
I
I/O
I/O
O
O
I/O
I/O
O
O
I/O
O
I/O
I/O
I/O
O
I/O
I/O
O
I/O
O
O
O
O
I/O
O
I/O
I/O
-
Description
Two-way data bus with the SD-RAM
Data mask signal output to the SD-RAM
Two-way data bus with the SD-RAM
Ground terminal
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Bank address signal output to the SD-RAM
Reference voltage (+0.9V) input terminal for the SD-RAM
Two-way data bus with the SD-RAM
Ground terminal
Ground terminal
Two-way data bus with the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Data strobe signal (negative) output to the SD-RAM
Power supply terminal (+3.3V)
Ground terminal
Power supply terminal (+3.3V)
Power supply terminal (+3.3V)
Ground terminal
Not used
Power supply terminal (+3.3V)
Two-way data bus with the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
Column address strobe signal output to the SD-RAM
Ground terminal
Bank address signal output to the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
Data mask signal output to the SD-RAM
Two-way data bus with the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Not used
Ground terminal
Power supply terminal (+1.2V)
Ground terminal
Power supply terminal (+1.2V)
UPG status signal output to the system controller
Two-way data bus with the EEPROM
Two-way data bus with the SD-RAM
Data mask signal output to the SD-RAM
Two-way data bus with the SD-RAM
Address signal output to the SD-RAM
Chip select signal output to the SD-RAM
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Not used
Two-way data bus with the SD-RAM
Data mask signal output to the SD-RAM
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Power supply terminal (+1.8V)
Not used
Not used
Power supply terminal (+1.2V)
85
HBD-E370/E470/E570/E870/T57
Pin No.
AW7
AW9
AW11
AW13
AW15
AW17
AW19
AW21
AW23
AW25
AW27
AW29
AW31
AW33
AW35
AW37
AW39
AW41
AW43
AY2
AY4
AY6
AY8
AY10
AY12
AY14
AY16
AY18
AY20
AY22
AY24
AY26
AY28
AY30
AY32
AY34
AY36
AY38
AY40
AY42
BA1
BA3
BA5
BA7
BA9
BA11
BA13
BA15
BA17
BA19
BA21
BA23
BA25
BA27
BA29
BA31
BA33
BA35
BA37
BA39
86
Pin Name
AVDD12_SRX2
AVSS12_ST2
GPIO5
DVSS
A_RDQ1
DVSS
A_RDQ12
DVSS
A_RODT
DVSS
A_RA9
DVSS
A_RDQ18
DVSS
A_RDQ28
DVSS
A_AVDD12_MEMPLL
B_RDQ4
B_RDQ1
NS_TSTN
SRXP_2
AVDD12_STX2
AVSS33_XTAL25M
GPIO4
TRST
VCC2IO
A_RDQS0
VCC2IO
A_RDQ8
VCC2IO
A_RA4
VCC2IO
A_RA10
VCC2IO
A_RDQ22
VCC2IO
A_RDQ24
VCC2IO
A_AVSS12_MEMPLL
DVSS
NS_TSTP
STXN_1
STXN_2
RREF
XTAL25MO
TCK
A_RDQ4
A_RDQ6
A_RDQS1B
A_RDQ15
A_RCLK0B
A_RA8
A_RA12
A_RA7
A_RCKE
A_RDQ20
A_RDQS2
A_RDQS3B
A_RDQ26
A_RCLK1
I/O
I/O
I/O
O
O
I/O
I/O
I/O
I/O
I
O
I/O
O
O
I/O
I/O
O
O
O
I/O
I/O
O
I/O
O
O
O
O
O
I/O
O
O
I/O
O
Description
Power supply terminal (+1.2V)
Ground terminal
Not used
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
On die termination enable signal output to the SD-RAM
Ground terminal
Address signal output to the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
Two-way data bus with the SD-RAM
Ground terminal
Power supply terminal (+1.2V)
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Not used
SATA channel 2 RX differential pair signal (positive) input terminal Not used
Power supply terminal (+1.2V)
Ground terminal
Not used
Not used
Power supply terminal (+1.8V)
Data strobe signal (positive) output to the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Address signal output to the SD-RAM
Power supply terminal (+1.8V)
Address signal output to the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Ground terminal
Ground terminal
Not used
SATA channel 1 TX differential pair signal (negative) output terminal
SATA channel 2 TX differential pair signal (negative) output terminal Not used
Not used
System clock signal output terminal (25 MHz)
Not used
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (negative) output to the SD-RAM
Two-way data bus with the SD-RAM
Clock signal (negative) output to the SD-RAM
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Clock enable signal output to the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Data strobe signal (negative) output to the SD-RAM
Two-way data bus with the SD-RAM
Clock signal (positive) output to the SD-RAM
HBD-E370/E470/E570/E870/T57
Pin No.
BA41
BA43
BB2
BB4
BB6
BB8
BB10
BB12
BB14
BB16
BB18
BB20
BB22
BB24
BB26
BB28
BB30
BB32
BB34
BB36
BB38
BB40
BB42
BC1
BC3
BC5
BC7
BC9
BC11
BC13
BC15
BC17
BC19
BC21
BC23
BC25
BC27
BC29
BC31
BC33
BC35
BC37
BC39
BC41
BC43
Pin Name
DVSS
VCC2IO
SRXN_1
SRXN_2
SVCTST
XTAL25MI
TDO
TDI
VCC2IO
A_RDQS0B
VCC2IO
A_RDQ10
VCC2IO
A_RRASB
VCC2IO
A_RBA0
VCC2IO
A_RDQ17
VCC2IO
A_RDQ31
VCC2IO
A_TP_MEMPLL
VCC2IO
SRXP_1
STXP_1
STXP_2
AVDD33_XTAL25M
GPIO7
TMS
A_RDQ2
A_RDQ7
A_RDQS1
A_RDQ13
A_RCLK0
A_RA0
A_RA6
A_RA3
A_RWEB
A_RDQ19
A_RDQS2B
A_RDQS3
A_RDQ29
A_RCLK1B
A_TN_MEMPLL
A_REXTDN
I/O
I
I
I
O
I/O
O
O
I/O
I/O
I
O
O
I/O
I/O
O
I/O
O
O
O
O
O
I/O
O
O
I/O
O
-
Description
Ground terminal
Power supply terminal (+1.8V)
SATA channel 1 RX differential pair signal (negative) input terminal
SATA channel 2 RX differential pair signal (negative) input terminal
Not used
System clock signal input terminal (25 MHz)
Not used
Not used
Power supply terminal (+1.8V)
Data strobe signal (negative) output to the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Row address strobe signal output to the SD-RAM
Power supply terminal (+1.8V)
Bank address signal output to the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Two-way data bus with the SD-RAM
Power supply terminal (+1.8V)
Not used
Power supply terminal (+1.8V)
SATA channel 1 RX differential pair signal (positive) input terminal
SATA channel 1 TX differential pair signal (positive) output terminal
SATA channel 2 TX differential pair signal (positive) output terminal
Power supply terminal (+3.3V)
Not used
Not used
Two-way data bus with the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Two-way data bus with the SD-RAM
Clock signal (positive) output to the SD-RAM
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Address signal output to the SD-RAM
Write enable signal output to the SD-RAM
Two-way data bus with the SD-RAM
Data strobe signal (negative) output to the SD-RAM
Data strobe signal (positive) output to the SD-RAM
Two-way data bus with the SD-RAM
Clock signal (negative) output to the SD-RAM
Not used
Not used
Not used
Not used
87
HBD-E370/E470/E570/E870/T57
MB-134 BOARD IC1201 LAN8700C-AEZG-CTI (ETHERNET INTERFACE)
Pin No.
1
2
3
4
5
6
7
8
9 to 12
13
14
15 to 18
19
20
21
22
23, 24
25
26, 27
28
29
30
31
32
33
34
35
36
88
Pin Name
TX_ER
MDC
CRS
MDIO
nRST
TX_EN
VDD33
VDD_CORE
PA0 to PA3
XTAL2
REFCLK
RXD3 to RXD0
RX_DV
RX_CLK
RX_ER
TX_CLK
TXD0, TXD1
VDDIO
TXD2, TXD3
TXN
TXP
VDDA3.3
RXN
RXP
VDDA3.3
EXRES1
VDDA3.3
COL
I/O
I
I
O
I/O
I
I
O
I
O
O
O
O
O
I
I
O
O
I
I
I
O
Description
Transmit error signal input from the BD decoder
Serial data transfer clock signal input from the BD decoder
Carrier sense signal output to the BD decoder
Two-way data bus with the BD decoder
Reset signal input from the system controller
Transmit enable signal input from the BD decoder
Power supply terminal (+3.3V)
Power supply terminal (+1.8V) Not used
Not used
System clock output terminal (25 MHz)
System clock input terminal (25 MHz)
Receive data output to the BD decoder
Receive data valid signal output to the BD decoder
Receive clock signal output to the BD decoder
Receive error signal output to the BD decoder
Transmit clock signal output to the BD decoder
Transmit data input from the BD decoder
Power supply terminal (+3.3V)
Transmit data input from the BD decoder
Serial data (negative) output to the ethernet connector
Serial data (positive) output to the ethernet connector
Power supply terminal (+3.3V) (analog system)
Serial data (negative) input from the ethernet connector
Serial data (positive) input from the ethernet connector
Power supply terminal (+3.3V) (analog system)
Reference resistor connection terminal
Power supply terminal (+3.3V) (analog system)
Collision detect signal output to the BD decoder
HBD-E370/E470/E570/E870/T57
MAIN BOARD IC501 R5F364AMDFA (SYSTEM CONTROLLER)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37 to 39
40
41, 42
43
44
45
46
47
48
49
50
51, 52
53
54
55 to 57
58 to 61
62
63
64
Pin Name
DAMP_SCDT/DIR_DI
DAMP_SHIFT/
DIR_CL
FL_CS
SIRCS_IN
FL_DOUT
CEC_RX_IN
FL_CLK
BYTE
CNVss
Xcin
Xcout
RESET
Xout
Vss
Xin
Vcc
CEC (TX/RX)
NO USE
KEY_INT
AC_CUT
BD_IF_START
ST_DO
ST_CLK
ST_DI
BD_IF_REQ
CEC_TX_OUT
PCONT_FL
LED_PWM
S-AIR_SDA
S-AIR_SCL
TXD1
RXD1
S-AIR_GPIO2
S-AIR_ADC_SEL
BD_RESET
BD_CS
BD_PCONT1 to
BD_CONT3
BD_PCONT4
BD_PCONT5,
BD_CONT6
P_CONT1
FAN_ON
FAN_CONT
CE
BD_BDI
BD_BDO
BD_SCLK
DRIVER_RST (EN)
OVERFLOW1,
OVERFLOW2
DAMP_INT
DAMP_SOFT_MUTE
DAMP_LATCH1 to
DAMP_LATCH3
NO USE
Vcc
S-AIR_SRC_RST
Vss
I/O
O
Description
Serial data output to the stream processor
O
Serial data transfer clock signal output to the stream processor
O
I
O
O
I
I
I
O
I
O
I
I/O
I
I
O
I
O
O
I
O
O
I/O
O
I
O
O
O
Chip select signal output to the fluorescent indicator tube driver
SIRCS signal input from the remote control receiver
Serial data output to the fluorescent indicator tube driver
Not used
Serial data transfer clock signal output to the fluorescent indicator tube driver
External data bus width selection signal input terminal
Processor mode selection signal input terminal
Sub system clock input terminal Not used
Sub system clock output terminal Not used
System reset signal input from the reset signal generator
Main system clock output terminal (6 MHz)
Ground terminal
Main system clock input terminal (6 MHz)
Power supply terminal (+3.3V)
CEC serial data input/output with the HDMI ARC OUT connector
Not used
Key wake-up signal input terminal
AC cut detection signal input terminal
Busy request signal output to the BD decoder
Serial data input from the tuner (FM)
Serial data transfer clock signal output to the tuner (FM)
Serial data output to the tuner (FM)
Request signal input from the BD decoder
Not used
Power on/off control signal output terminal for the front panel section
LED drive signal output terminal
Two-way I2C data bus with the wireless transceiver
I2C clock signal output to the wireless transceiver
Not used
Not used
Interrupt signal input from the wireless transceiver
Data selection signal output terminal for S-AIR section
Reset signal output to the BD decoder, NAND flash, EEPROM and ethernet interface
Chip select signal output to the BD decoder
O
Power on/off control signal output terminal for the BD section
O
Power on/off control signal output terminal
O
Power on/off control signal output terminal for the BD section
O
O
O
O
I
I
O
Power on/off control signal output terminal
Power on/off control signal output terminal for the FAN motor
FAN motor on/off control signal output terminal
Not used
Serial data output to the BD decoder
Serial data input from the BD decoder
Serial data transfer clock signal input from the BD decoder
Reset signal output to the power amplifier
O
Overflow detection signal input from the stream processor
O
O
Reset signal output to the stream processor
Soft muting on/off control signal output to stream processor
O
Serial data latch pulse signal output to the stream processor
O
-
Not used
Power supply terminal (+3.3V)
Reset signal output to the S-AIR section
Ground terminal
Not used
89
HBD-E370/E470/E570/E870/T57
Pin No.
65
66
I/O
I
I
68
69 to 73
74
Pin Name
MIC_DET
DC_DET
DRIVER_SD/
PVDD_DET
A.CAL_OUT
NO USE
RDS_DATA
75
RDS_CLK
I
76
77
78 to 80
81
82
83
84
85
86
87
88
89
90
91
92
93
94, 95
96
97
98
99
100
ST_CE
TUNED
ASEL_0 to ASEL_2
CPU_PRERST
CORE_RST
NSPMUTE
JIG_MODE
OPWRSB
FE_EJECT
UPG_STATUS
VBUS_DET
Acal_Lv
S-AIR_ID_SW
BD_TEMP
DESTINATION
MODEL
KEY2, KEY1
Vss
KEY0
Vref
Vcc
NO USE
O
I
O
O
O
I
O
I
I
I
I
I
I
I
I
-
67
90
Description
Calibration microphone connection detection signal input terminal
Over load detection signal input terminal
I
Shut down signal input from the power amplifier
I
I
AUdio signal output detection signal input terminal
Not used
RDS serial data input from the tuner (FM) (E370: AEP, UK/E870: AEP, UK models only)
RDS serial data transfer clock signal input from the tuner (FM)
(E370: AEP, UK/E870: AEP, UK models only)
Chip enable signal output to the tuner (FM)
Tuned detection signal input from the tuner (FM)
Audio selection signal output terminal
Reset signal output to the serial flash
Not used
NSP muting on/off control signal output to stream processor
Noy used
Power on/off control signal BD decoder
Eject/stop key output to the BD decoder
UPG status signal input from the BD decoder
Noy used
Auto calibration microphone signal input terminal
Not used
Temperature detection signal input terminal
Destination setting terminal
Model setting terminal
Key input terminal for front panel keys
Ground terminal
Key input terminal for front panel keys
Reference voltage (+3.3V) input terminal
Power supply terminal (+3.3V)
Not used
HBD-E370/E470/E570/E870/T57
SECTION 6
EXPLODED VIEWS
Note:
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet’s Color
6-1.
• Abbreviation
CND : Canadian model
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant le numéro spécifié.
The components identified by mark 9 contain confidential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
Les composants identifiés par la marque
9 contiennent des informations confidentielles.
Suivre scrupuleusement les instructions
chaque fois qu’un composant est remplacé
et / ou réparé.
CASE, FRONT PANEL SECTION
9
8
2
2
2
not supplied
2
5
4
not supplied
not
supplied
2
not
supplied
2
not
supplied
not supplied
(P-KEY board)
#1
3
not supplied
(KEY board)
Ref. No.
MB-134 board section
10
not supplied
Part No.
Description
1
X-2546-719-2
1
X-2546-856-2
2
3
4
3-077-331-21
4-161-650-01
4-161-647-11
PANEL FRONT ASSY (10EZ)
(E370: AEP, UK/E870: AEP, UK)
PANEL FRONT ASSY (10EZ V)
(EXCEPT E370: AEP, UK/E870: AEP, UK)
+BV3 (3-CR)
BUTTON (PLAY-POW-EZ)
ESCUTCHEON (EZ) (E370)
Remark
4
4
4
4-161-647-21
4-161-647-41
4-161-647-61
ESCUTCHEON (EZ) (E570)
ESCUTCHEON (EZ) (E870)
ESCUTCHEON (EZ) (T57)
1
2
Ref. No.
Part No.
Description
4
5
4-161-647-81
X-2546-720-1
ESCUTCHEON (EZ) (E470)
LOADING PANEL ASSY (10EZ)
Remark
8
8
8
9
10
4-161-688-01
4-161-688-21
4-161-688-41
3-704-515-32
A-1746-097-A
CASE (EZ) (E570/T57)
CASE (EZ) (E370: CND, AEP, UK/E470/E870)
CASE (EZ) (E370: US)
SCREW (BV/RING)
FL BOARD, COMPLETE
#1
7-685-504-19
SCREW +BTP 2X6 TYPE2 N-S
91
HBD-E370/E470/E570/E870/T57
6-2.
MB-134 BOARD SECTION
52
52
54
C
56
D
57
not supplied
(REG board)
B
52
52
55
not supplied
52
52
not supplied
(R-USB board)
not
supplied
not supplied
(CONNECT board)
52
52
E
A
52
not supplied
B
53
C
D
not supplied
52
A
59
not supplied
(F-USB board)
#3
59
59
58
#2
E
back panel section
Ref. No.
Part No.
Description
52
53
* 54
9 55
3-077-331-21
1-966-988-11
3-703-150-11
A-1762-831-A
9 55
A-1762-832-A
+BV3 (3-CR)
HARNESS (USB)
CLAMP
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: US)
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: CND)
9 55
A-1762-833-A
9 55
A-1762-834-A
9 55
9 55
A-1762-842-A
A-1762-844-A
9 55
A-1762-848-A
92
Remark
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: AEP)
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: UK)
MB-134 BOARD, COMPLETE (for SERVICE) (T57)
MB-134 BOARD, COMPLETE (for SERVICE)
(E570)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: CND)
Part No.
Description
9 55
Ref. No.
A-1762-858-A
9 55
A-1762-859-A
9 55
A-1762-860-A
56
0 57
1-966-989-12
1-777-071-83
MB-134 BOARD, COMPLETE (for SERVICE)
(E470)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: AEP)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: UK)
HARNESS (USB)
CORD, POWER (AEP)
Remark
0 57
0 57
58
59
#2
1-835-078-31
1-837-308-11
3-703-244-00
3-077-331-01
7-682-147-01
CORD, POWER (UK)
CORD, POWER-SUPPLY (US, CND)
CORD BUSH (2104)
+BV3 (3-CR)
SCREW +P 3X6
#3
7-682-546-09
SCREW +B 3X5
HBD-E370/E470/E570/E870/T57
6-3.
BACK PANEL SECTION
101
not supplied
101
104
105
BD drive section
(BPX-5)
101
101
101
101
103
102
105
not supplied
104
105
not supplied
105
TU1
M3001
not supplied
MAIN board section
Ref. No.
101
102
102
103
104
Part No.
Description
3-077-331-21
1-828-954-51
1-828-964-51
4-161-658-01
3-077-331-11
+BV3 (3-CR)
WIRE (FLAT TYPE) (9 CORE) (US, CND)
WIRE (FLAT TYPE) (11 CORE) (AEP, UK)
CARD SLOT (S-AIR UME)
+BV3 (3-CR)
Remark
Ref. No.
105
M3001
TU1
TU1
Part No.
Description
3-077-331-01
1-787-931-11
1-693-781-11
1-693-787-11
+BV3 (3-CR)
DC FAN
TUNER (FM) (US, CND)
TUNER (FM) (AEP, UK)
Remark
93
HBD-E370/E470/E570/E870/T57
6-4.
MAIN BOARD SECTION
160
153
159
158
156
161
157
F
not supplied
153
155
153
154
153
153
162
not supplied
not supplied
153
(AEP, UK)
152
not supplied
F
not supplied
F901
not supplied
152
Ref. No.
Part No.
Description
151
A-1745-451-A
151
A-1745-455-A
152
153
154
4-232-478-31
3-077-331-21
1-828-343-51
POWER BOARD, COMPLETE
(E370: AEP, UK/E870: AEP, UK)
POWER BOARD, COMPLETE
(EXCEPT E370: AEP, UK/E870: AEP, UK)
FOOT
+BV3 (3-CR)
WIRE (FLAT TYPE) (15 CORE)
155
156
1-828-400-51
A-1746-096-A
156
A-1746-102-A
157
1-828-336-51
94
Remark
WIRE (FLAT TYPE) (27 CORE)
AUDIO BOARD, COMPLETE (US, CND)
(EXCEPT E370: AEP, UK/E870: AEP, UK)
AUDIO BOARD, COMPLETE (AEP, UK)
(E370: AEP, UK/E870: AEP, UK)
WIRE (FLAT TYPE) (15 CORE) (US, CND)
151
Ref. No.
Part No.
Description
157
1-828-346-51
WIRE (FLAT TYPE) (17 CORE) (AEP, UK)
158
159
160
161
162
1-828-740-51
1-828-730-51
1-828-341-51
3-077-331-11
A-1746-692-A
WIRE (FLAT TYPE) (18 CORE)
WIRE (FLAT TYPE) (16 CORE)
WIRE (FLAT TYPE) (15 CORE)
+BV3 (3-CR)
MAIN BOARD, COMPLETE
(EXCEPT E370: AEP, UK/E870: AEP, UK)
162
A-1746-698-A
MAIN BOARD, COMPLETE
(E370: AEP, UK/E870: AEP, UK)
FUSE, GLASS (DIA.5) (8A/125V) (US, CND)
FUSE (H.B.C.) (T5AH/250V) (AEP, UK)
0 F901
0 F901
1-533-311-12
1-576-232-51
Remark
HBD-E370/E470/E570/E870/T57
6-5.
BD DRIVE SECTION (BPX-5)
not supplied
203
not supplied
205
204
206
205
205
205
207
not supplied
208
202
209
not supplied
201
Ref. No.
201
202
203
204
205
Part No.
Description
4-175-656-01
A-1750-926-A
3-087-053-11
2-345-115-01
4-175-937-01
HOLDER, FFC (REAR)
LOADING FOR SERVICE
+BVTP2.6 (3CR)
SCREW (S), FLOAT
INSULATOR
Remark
Ref. No.
0 206
207
208
209
Part No.
Description
8-820-430-02
1-837-660-51
1-837-658-51
1-837-659-51
DEVICE, OPTICAL (KEM-460AAA/C2RP)
WIRE (FLAT TYPE) (9 CORE)
WIRE (FLAT TYPE) (45 CORE)
WIRE (FLAT TYPE) (5 CORE)
Remark
95
HBD-E370/E470/E570/E870/T57
SECTION 7
ELECTRICAL PARTS LIST
AUDIO
Note:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• CAPACITORS
uF: μF
Ref. No.
• COILS
uH: μH
• SEMICONDUCTORS
In each case, u: μ, for example:
uA. . : μA. . , uPA. . , μPA. . ,
uPB. . : μPB. . , uPC. . , μPC. . ,
uPD. . : μPD. .
• Abbreviation
CND : Canadian model
When indicating parts by reference number, please include the board name.
The components identified by mark 9 contain confidential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant le numéro spécifié.
Part No.
Description
A-1746-096-A
AUDIO BOARD, COMPLETE
(EXCEPT E370: AEP, UK/E870: AEP, UK)
AUDIO BOARD, COMPLETE
(E370: AEP, UK/E870: AEP, UK)
**********************
CN10
1-784-770-11
CN11
1-568-830-11
< CAPACITOR >
CN13
1-779-283-11
A-1746-102-A
Les composants identifiés par la marque
9 contiennent des informations confidentielles.
Suivre scrupuleusement les instructions
chaque fois qu’un composant est remplacé
et / ou réparé.
Remark
Ref. No.
Part No.
Description
Remark
< CONNECTOR >
C10
C11
C12
C14
C15
1-162-964-11
1-162-923-11
1-125-891-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
47PF
0.47uF
100PF
100PF
10%
5%
10%
5%
5%
50V
50V
10V
50V
50V
CN15
1-779-285-11
CN17
1-564-704-41
C16
C17
C20
C21
C22
1-162-927-11
1-107-826-11
1-162-966-11
1-126-964-11
1-104-658-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100PF
0.1uF
0.0022uF
10uF
100uF
5%
10%
10%
20%
20%
50V
16V
50V
50V
10V
D10
D12
D15
C23
C27
C28
C29
C32
1-164-315-11
1-162-960-11
1-164-315-11
1-110-563-11
1-162-925-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
220PF
470PF
0.068uF
68PF
5%
10%
5%
10%
5%
50V
50V
50V
16V
50V
IC10
IC11
IC12
IC14
C33
C35
C37
C39
C41
1-162-927-11
1-162-927-11
1-107-826-11
1-104-662-91
1-104-662-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100PF
100PF
0.1uF
22uF
22uF
5%
5%
10%
20%
20%
50V
50V
16V
25V
25V
C44
C45
C48
C49
C50
1-104-658-91
1-107-826-11
1-126-947-11
1-115-156-11
1-125-891-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
47uF
1uF
0.47uF
20%
10%
20%
10%
10V
16V
35V
10V
10V
C53
C54
C62
C63
C66
1-107-826-11
1-107-826-11
1-126-947-11
1-127-715-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47uF
0.22uF
0.1uF
10%
10%
20%
10%
10%
16V
16V
35V
16V
16V
C67
C68
C69
C70
1-115-156-11
1-127-573-11
1-126-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1uF
1uF
10uF
0.001uF
10%
20%
10%
10V
16V
50V
50V
CONNECTOR, FFC 9P
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CONNECTOR, FFC 11P
(E370: AEP, UK/E870: AEP, UK)
CONNECTOR, FFC (LIF (NON-ZIF)) 15P
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CONNECTOR, FFC (LIF (NON-ZIF)) 17P
(E370: AEP, UK/E870: AEP, UK)
PIN, CONNECTOR (SMALL TYPE) 2P
< DIODE >
6-500-848-01
6-500-848-01
6-501-728-01
DIODE MC2840-T112-1
DIODE MC2840-T112-1
DIODE MAZ8051G0LS0
< IC >
8-759-100-96
8-759-430-37
8-759-430-37
6-712-744-01
IC
IC
IC
IC
uPC4558G2
MC14052BDTR2
MC14052BDTR2
TK11190CSCL-G
< JACK >
96
J10
J11
1-563-330-31
1-778-940-21
JACK (A.CAL MIC ECM-AC2)
PHONO JACK 2P (AUDIO AUDIO IN)
< COIL >
L010
1-481-524-11
INDUCTOR
10uH
< TRANSISTOR >
Q10
Q13
Q14
8-729-028-96
6-551-690-01
8-729-028-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EUA-T106
RT3N11M-TP-1
DTC114EUA-T106
< RESISTOR >
R12
R13
R15
R18
1-216-864-11
1-216-825-11
1-216-845-11
1-216-864-11
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
R19
1-216-864-11
SHORT CHIP
R20
1-216-817-11
METAL CHIP
0
2.2K
5%
1/10W
100K
5%
1/10W
0
(E370: AEP, UK/E870: AEP, UK)
0
(E370: AEP, UK/E870: AEP, UK)
470
5%
1/10W
HBD-E370/E470/E570/E870/T57
AUDIO
Ref. No.
Part No.
Description
R21
R22
R23
R24
1-216-864-11
1-216-837-11
1-216-809-11
1-216-809-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22K
100
100
Remark
R25
R26
R27
R28
R29
1-216-864-11
1-216-809-11
1-216-864-11
1-216-821-11
1-216-837-11
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
100
0
1K
22K
R30
R32
R34
R35
R36
1-216-833-11
1-216-833-11
1-216-835-11
1-216-825-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
R37
R42
R43
R44
R45
1-216-857-11
1-216-864-11
1-216-864-11
1-216-837-11
1-216-837-11
R46
R47
R48
R49
R50
Ref. No.
Part No.
CONNECT
Description
FL
Remark
< TRANSISTOR >
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
5%
5%
1/10W
1/10W
10K
10K
15K
2.2K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
1M
0
0
22K
22K
5%
1/10W
5%
5%
1/10W
1/10W
1-216-841-11
1-216-841-11
1-216-837-11
1-216-837-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
22K
22K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R51
R52
R53
R54
R55
1-216-841-11
1-216-864-11
1-216-821-11
1-216-827-11
1-216-829-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
0
1K
3.3K
4.7K
5%
1/10W
5%
5%
5%
R56
R57
R58
R60
R61
1-216-864-11
1-216-864-11
1-216-845-11
1-216-826-11
1-216-821-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
100K
2.7K
1K
R62
R65
R71
R72
R73
1-216-845-11
1-216-864-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R74
R75
R76
R77
R85
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
1-216-834-11
R86
R87
R88
0 R89
R93
1-216-835-11
1-216-821-11
1-216-864-11
1-215-865-51
1-216-864-11
Q300
Q301
8-729-029-14
6-550-363-01
TRANSISTOR
TRANSISTOR
DTC144EUA-T106
2SB1690KT146
< RESISTOR >
R300
R301
R302
R303
R307
1-216-817-11
1-216-817-11
1-216-817-11
1-216-841-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R308
1-216-833-11 METAL CHIP
10K
5%
1/10W
R309
1-216-833-11 METAL CHIP
10K
5%
1/10W
R311
1-216-833-11 METAL CHIP
10K
5%
1/10W
R320
1-216-864-11 SHORT CHIP
0
*************************************************************
A-1746-097-A
FL BOARD, COMPLETE
******************
< CAPACITOR >
C803
C804
C807
C808
C810
1-107-826-11
1-126-786-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
16V
16V
16V
16V
16V
1/10W
1/10W
1/10W
C811
C812
C816
C817
C818
1-126-382-11
1-107-826-11
1-162-968-11
1-163-037-11
1-165-908-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.0047uF
0.022uF
1uF
20%
10%
10%
10%
10%
16V
16V
50V
50V
10V
5%
5%
5%
1/10W
1/10W
1/10W
C819
C820
C821
C822
C823
1-107-826-11
1-165-908-11
1-162-974-11
1-119-943-91
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
1uF
0.01uF
47uF
0.1uF
10%
10%
16V
10V
50V
50V
16V
100K
0
10K
10K
10K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
C824
C825
C826
C833
C834
1-137-710-91
1-107-826-11
1-162-974-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.01uF
0.01uF
0.01uF
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
1K
1K
1K
0
12K
5%
5%
5%
1/10W
1/10W
1/10W
C837
1-112-746-11
CERAMIC CHIP 4.7uF
5%
1/10W
METAL CHIP
METAL CHIP
SHORT CHIP
METAL OXIDE
SHORT CHIP
15K
1K
0
220
0
5%
5%
1/10W
1/10W
5%
1W
10%
10%
6.3V
16V
50V
25V
25V
10%
6.3V
1-779-283-11
F
D800
D803
D804
D805
D807
6-503-085-01
6-500-848-01
6-500-848-01
6-501-729-01
6-501-817-01
CONNECT BOARD
**************
< CONNECTOR >
CONNECTOR, FFC (LIF (NON-ZIF)) 15P
< DIODE >
R99
1-216-821-11 METAL CHIP
1K
5%
1/10W
*************************************************************
1-779-552-21
1-564-722-11
1-821-745-11
20%
10%
< CONNECTOR >
CN801
CN300
CN301
CN303
20%
10%
LED SLD430WBD2PT31XN (ILLUMINATION)
DIODE MC2840-T112-1
DIODE MC2840-T112-1
DIODE MAZ8051GLLS0
DIODE MA2J1110GLS0
< IC >
IC801
IC802
IC803
6-702-302-01
6-713-497-01
6-600-767-01
CONNECTOR, FFC (LIF (NON-ZIF)) 15P
PIN, CONNECTOR (SMALL TYPE) 6P
CONNECTOR, CARD EDGE 30P (L) (EZW-T100)
IC TK11133CSCL-G
IC HT16515
IC PNA4823M02S0
< COIL >
L801
L802
1-410-671-31
1-410-671-31
INDUCTOR
INDUCTOR
47uH
47uH
97
HBD-E370/E470/E570/E870/T57
FL
F-USB
Ref. No.
L803
KEY
MAIN
Part No.
Description
1-410-671-31
INDUCTOR
Remark
< FLUORESCENT INDICATOR TUBE >
ND800
1-483-114-11
8-729-029-14
8-729-028-96
6-550-363-01
6-550-065-01
8-729-620-13
Part No.
Description
1-786-650-21
1-786-650-21
1-786-650-21
1-786-650-21
SWITCH, TACTILE (VOLUME –)
SWITCH, TACTILE (Z)
SWITCH, TACTILE (FUNCTION)
SWITCH, TACTILE (x)
Remark
INDICATOR TUBE, FLUORESCENT
S705
1-786-650-21 SWITCH, TACTILE (N)
*************************************************************
< TRANSISTOR >
Q800
Q801
Q802
Q803
Q804
Ref. No.
S701
S702
S703
S704
47uH
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
A-1746-692-A
DTC144EUA-T106
DTC114EUA-T106
2SB1690KT146
CPH5504-TL-E
2SC4154TP-1EF
A-1746-698-A
MAIN BOARD, COMPLETE
(EXCEPT E370: AEP, UK/E870: AEP, UK)
MAIN BOARD, COMPLETE
(E370: AEP, UK/E870: AEP, UK)
********************
< CAPACITOR >
< RESISTOR >
R803
R804
R805
R806
R807
1-216-817-11
1-216-809-11
1-216-817-11
1-216-817-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
100
470
470
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
* C501
C502
C503
* C504
C505
1-112-298-91
1-165-908-11
1-162-964-11
1-112-298-91
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.001uF
1uF
1uF
10%
10%
10%
10%
10%
16V
10V
50V
16V
10V
R809
R812
R813
R814
R817
1-216-822-11
1-216-821-11
1-216-839-11
1-216-805-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
1K
33K
47
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C506
C507
C508
C509
C510
1-162-970-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
25V
16V
16V
16V
16V
R819
R820
R821
R822
R823
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-844-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
82K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C511
C512
C513
C514
C515
1-107-826-11
1-107-826-11
1-107-826-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.001uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
50V
16V
R825
R828
1-216-805-11
1-216-821-11
METAL CHIP
METAL CHIP
47
1K
5%
5%
1/10W
1/10W
C516
C518
C519
C521
C522
1-107-826-11
1-162-964-11
1-162-923-11
1-162-927-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
47PF
100PF
0.1uF
10%
10%
5%
5%
10%
16V
50V
50V
50V
16V
C524
C525
C526
C527
C528
1-107-826-11
1-162-927-11
1-127-715-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
0.22uF
0.01uF
0.1uF
10%
5%
10%
10%
10%
16V
50V
16V
25V
16V
C529
C532
C533
C534
C535
1-164-227-11
1-104-656-11
1-126-924-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.022uF
2200uF
330uF
0.01uF
0.01uF
10%
20%
20%
10%
10%
25V
6.3V
10V
25V
25V
C536
C537
C702
C705
C706
1-164-227-11
1-164-227-11
1-107-826-11
1-104-658-91
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.022uF
0.022uF
0.1uF
100uF
10uF
10%
10%
10%
20%
20%
25V
25V
16V
10V
50V
C707
C713
C714
C715
C716
1-126-964-11
1-107-826-11
1-126-964-11
1-107-826-11
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.1uF
10uF
0.1uF
10uF
20%
10%
20%
10%
20%
50V
16V
50V
16V
50V
C717
C718
C719
C720
C721
1-126-964-11
1-107-826-11
1-107-826-11
1-107-826-11
1-104-658-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
10uF
0.1uF
0.1uF
0.1uF
100uF
20%
10%
10%
10%
20%
50V
16V
16V
16V
10V
C722
C723
1-107-826-11
1-107-826-11
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
10%
10%
16V
16V
< TRANSFORMER >
T800
1-445-686-11 D.C-D.C. CONVERTER TRANSFORMER
*************************************************************
F-USB BOARD
***********
< CONNECTOR >
CN100
1-822-423-11 CONNECTOR, USB (A) ( )
CN101
1-784-922-11 PIN, CONNECTOR 5P
*************************************************************
KEY BOARD
*********
< CONNECTOR >
CN700
* CN701
1-580-057-11
1-580-055-21
PIN, CONNECTOR (SMD) 4P
PIN, CONNECTOR (SMD) 2P
< RESISTOR >
R700
R701
R702
R703
R704
1-216-825-11
1-216-821-11
1-216-809-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
1K
100
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R705
1-216-809-11
METAL CHIP
100
5%
1/10W
< SWITCH >
S700
98
1-786-650-21
SWITCH, TACTILE (VOLUME +)
Note: When the MAIN board is replaced, spread the compound referring to “NOTE
OF REPLACING THE IC3100, IC3200 AND IC3400 ON THE MAIN BOARD
AND THE COMPLETE MAIN BOARD” on servicing notes (page 8).
HBD-E370/E470/E570/E870/T57
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C724
C725
C726
1-104-658-91
1-107-826-11
1-164-227-11
ELECT
100uF
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.022uF
20%
10%
10%
10V
16V
25V
Remark
Ref. No.
C3103
C3104
C3105
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
10%
10%
10%
16V
16V
16V
Remark
C727
C728
C729
C730
C731
1-107-826-11
1-107-826-11
1-162-970-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
0.1uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
25V
16V
25V
C3106
C3107
C3108
C3109
C3110
1-107-826-11
1-100-436-91
1-115-339-11
1-115-339-11
1-100-436-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.033uF
0.1uF
0.1uF
0.033uF
10%
10%
10%
10%
10%
16V
25V
50V
50V
25V
C732
C733
C735
C736
C737
1-104-658-91
1-107-826-11
1-107-826-11
1-162-912-11
1-162-912-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.1uF
7PF
7PF
20%
10%
10%
0.5PF
0.5PF
10V
16V
16V
50V
50V
C3111
C3112
C3113
C3114
C3115
1-112-246-11
1-112-246-11
1-137-198-81
1-137-198-81
1-112-831-31
ELECT
ELECT
FILM
FILM
ELECT
100uF
100uF
1uF
1uF
2200uF
20%
20%
5%
5%
20%
35V
35V
50V
50V
35V
C3000
C3001
C3002
C3003
C3005
1-126-933-11
1-126-947-11
1-114-868-11
1-162-964-11
1-162-970-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
47uF
0.1uF
0.001uF
0.01uF
20%
20%
10%
10%
10%
16V
35V
50V
50V
25V
C3116
C3117
C3118
C3119
C3120
1-115-339-11
1-100-436-91
1-115-339-11
1-115-339-11
1-100-436-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.033uF
0.1uF
0.1uF
0.033uF
10%
10%
10%
10%
10%
50V
25V
50V
50V
25V
C3011
C3012
C3013
C3014
C3015
1-165-726-31
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
56uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3121
C3122
C3123
C3124
C3125
1-112-246-11
1-112-246-11
1-137-198-81
1-137-198-81
1-112-831-31
ELECT
ELECT
FILM
FILM
ELECT
100uF
100uF
1uF
1uF
2200uF
20%
20%
5%
5%
20%
35V
35V
50V
50V
35V
C3016
C3017
C3018
C3019
C3020
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3126
C3127
C3128
C3129
C3201
1-115-339-11
1-114-869-11
1-114-869-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
2.2uF
2.2uF
0.001uF
0.1uF
10%
10%
10%
10%
10%
50V
6.3V
6.3V
50V
16V
C3021
C3022
C3023
C3024
C3025
1-165-726-31
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
56uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3202
C3203
C3204
C3205
C3206
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3026
C3027
C3028
C3029
C3030
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3207
C3208
C3209
C3210
C3211
1-100-436-91
1-115-339-11
1-115-339-11
1-100-436-91
1-112-246-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.033uF
0.1uF
0.1uF
0.033uF
100uF
10%
10%
10%
10%
20%
25V
50V
50V
25V
35V
C3031
C3032
C3033
C3034
C3035
1-165-726-31
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
56uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3212
C3213
C3214
C3215
C3216
1-112-246-11
1-137-198-81
1-137-198-81
1-112-831-31
1-115-339-11
ELECT
FILM
FILM
ELECT
CERAMIC CHIP
100uF
1uF
1uF
2200uF
0.1uF
20%
5%
5%
20%
10%
35V
50V
50V
35V
50V
C3036
C3037
C3038
C3039
C3040
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C3217
C3218
C3219
C3220
C3227
1-100-436-91
1-115-339-11
1-115-339-11
1-100-436-91
1-100-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.033uF
0.1uF
0.1uF
0.033uF
10uF
10%
10%
10%
10%
10%
25V
50V
50V
25V
6.3V
C3051
C3052
C3054
C3055
C3056
1-114-323-11
1-165-908-11
1-126-933-11
1-165-908-11
1-126-923-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
1uF
100uF
1uF
220uF
10%
10%
20%
10%
20%
50V
10V
16V
10V
10V
C3229
C3311
C3312
C3313
C3314
1-162-964-11
1-112-246-11
1-112-246-11
1-137-198-81
1-137-198-81
CERAMIC CHIP
ELECT
ELECT
FILM
FILM
0.001uF
100uF
100uF
1uF
1uF
10%
20%
20%
5%
5%
50V
35V
35V
50V
50V
C3057
C3058
C3060
C3071
C3091
1-162-970-11
1-162-909-11
1-162-909-11
1-162-970-11
1-126-934-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
4PF
4PF
0.01uF
220uF
10%
0.25PF
0.25PF
10%
20%
25V
50V
50V
25V
16V
C3315
C3316
C3327
C3401
C3402
1-112-831-31
1-115-339-11
1-114-869-11
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2200uF
0.1uF
2.2uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
35V
50V
6.3V
16V
16V
C3101
C3102
1-107-826-11
1-107-826-11
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
10%
10%
16V
16V
C3403
C3404
1-107-826-11
1-107-826-11
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
10%
10%
16V
16V
99
HBD-E370/E470/E570/E870/T57
MAIN
Ref. No.
Part No.
Description
C3405
C3406
C3407
1-107-826-11
1-107-826-11
1-100-436-91
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.033uF
10%
10%
10%
16V
16V
25V
Remark
C3408
C3409
C3410
C3411
C3412
1-115-339-11
1-115-339-11
1-100-436-91
1-112-246-11
1-112-246-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
0.033uF
100uF
100uF
10%
10%
10%
20%
20%
50V
50V
25V
35V
35V
C3413
C3414
C3415
C3416
C3417
1-137-198-81
1-137-198-81
1-112-831-31
1-115-339-11
1-100-436-91
FILM
FILM
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
2200uF
0.1uF
0.033uF
5%
5%
20%
10%
10%
50V
50V
35V
50V
25V
C3418
C3419
C3420
C3421
C3422
1-115-339-11
1-115-339-11
1-100-436-91
1-112-246-11
1-112-246-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
0.033uF
100uF
100uF
10%
10%
10%
20%
20%
50V
50V
25V
35V
35V
C3423
C3424
C3425
C3426
C3427
1-137-198-81
1-137-198-81
1-112-831-31
1-115-339-11
1-114-869-11
FILM
FILM
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
2200uF
0.1uF
2.2uF
5%
5%
20%
10%
10%
50V
50V
35V
50V
6.3V
C3428
C3429
C3551
C3552
C3553
1-114-869-11
1-162-964-11
1-126-960-11
1-126-964-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
2.2uF
0.001uF
1uF
10uF
0.01uF
10%
10%
20%
20%
10%
6.3V
50V
50V
50V
25V
C3556
C3561
C3911
C3912
C3913
1-114-868-11
1-126-947-11
1-114-323-11
1-162-964-11
1-114-323-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.01uF
0.001uF
0.01uF
10%
20%
10%
10%
10%
50V
35V
50V
50V
50V
C3914
C3915
C3916
C3917
C3918
1-162-964-11
1-114-323-11
1-162-964-11
1-114-323-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.01uF
0.001uF
0.01uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C3921
C3922
C3923
C3924
C3925
1-114-323-11
1-162-964-11
1-114-323-11
1-162-964-11
1-114-323-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
0.01uF
0.001uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C3926
C3927
C3928
C3941
C3942
1-162-964-11
1-114-323-11
1-162-964-11
1-114-323-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.01uF
0.001uF
0.01uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C3943
C3944
C3945
C3946
C3947
1-114-323-11
1-162-964-11
1-114-323-11
1-162-964-11
1-114-323-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
0.01uF
0.001uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C3948
1-162-964-11
CERAMIC CHIP 0.001uF
10%
50V
Ref. No.
Part No.
Description
CN505
CN508
1-794-341-51
1-820-115-51
CONNECTOR, FFC/FPC 27P
CONNECTOR, FFC/FPC 15P
Remark
CN510
CN701
CN702
CN703
CN3000
1-784-861-51
1-779-333-51
1-820-115-51
1-779-332-51
1-564-704-41
CONNECTOR, FFC (LIF (NON-ZIF)) 9P
CONNECTOR, FFC/FPC 18P (HDMI ARC OUT)
CONNECTOR, FFC/FPC 15P
CONNECTOR, FFC/FPC 16P
PIN, CONNECTOR (SMALL TYPE) 2P
< DIODE >
D502
D503
D506
D508
D3070
6-501-817-01
6-501-817-01
6-501-817-01
6-501-817-01
6-501-817-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
D3071
D3072
D3101
D3102
D3103
6-500-335-01
6-501-817-01
6-501-696-01
6-501-696-01
6-501-696-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2838-T112-1
MA2J1110GLS0
RSA39LTE25
RSA39LTE25
RSA39LTE25
D3104
D3201
D3202
D3203
D3204
6-501-696-01
6-501-696-01
6-501-696-01
6-501-696-01
6-501-696-01
DIODE
DIODE
DIODE
DIODE
DIODE
RSA39LTE25
RSA39LTE25
RSA39LTE25
RSA39LTE25
RSA39LTE25
D3401
D3402
D3501
D3502
D3551
6-501-696-01
6-501-696-01
6-501-696-01
6-501-696-01
6-500-848-01
DIODE
DIODE
DIODE
DIODE
DIODE
RSA39LTE25
RSA39LTE25
RSA39LTE25
RSA39LTE25
MC2840-T112-1
D3553
6-501-817-01
DIODE MA2J1110GLS0
< FERRITE BEAD >
FB701
FB702
FB704
FB705
FB706
1-469-152-11
1-500-283-11
1-469-094-21
1-400-580-21
1-469-094-21
FERRITE, EMI (SMD) (2012)
INDUCTOR, FERRITE BEAD
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD) (1608)
< IC >
< CONNECTOR >
CN502
1-820-116-51
CN504
1-820-115-51
100
CONNECTOR, FFC/FPC 17P
(E370: AEP, UK/E870: AEP, UK)
CONNECTOR, FFC/FPC 15P
(EXCEPT E370: AEP, UK/E870: AEP, UK)
IC501
IC503
IC505
IC506
IC507
A-1748-298-A
6-705-203-01
6-705-337-01
6-702-913-01
6-702-913-01
IC
IC
IC
IC
IC
R5F364AMDFA (for SERVICE)
S-80935CNMC-G85T2G
TK11150CSCL-G
S-80929CNMC-G8ZT2G
S-80929CNMC-G8ZT2G
IC508
IC700
IC702
IC703
IC704
6-705-337-01
6-600-466-01
6-710-554-01
6-713-642-01
6-707-853-01
IC
IC
IC
IC
IC
TK11150CSCL-G
TORX147L (SONY) (TV DIGITAL IN OPTICAL)
PCM1808PWR
LC89058W-E
TC74LCX541FT (EKJ)
IC3010
IC3011
IC3020
IC3030
IC3050
6-705-979-01
6-712-613-01
6-705-979-01
6-705-979-01
6-714-743-01
IC
IC
IC
IC
IC
CXD9788AR
SI-3010KM-TLS
CXD9788AR
CXD9788AR
MM3404A18URE
IC3051
IC3100
IC3200
IC3400
6-706-492-01
6-714-477-01
6-714-477-01
6-714-477-01
IC
IC
IC
IC
TC7SHU04FU (T5RSOJF)
CXD9981TN
CXD9981TN
CXD9981TN
Note: When IC3100, IC3200 and IC3400 on the MAIN board are replaced, spread the compound
referring to “NOTE OF REPLACING THE IC3100, IC3200 AND IC3400 ON THE MAIN
BOARD AND THE COMPLETE MAIN BOARD” on servicing notes (page 8).
HBD-E370/E470/E570/E870/T57
MAIN
Ref. No.
Part No.
Description
Remark
< JACK >
J700
1-784-431-21
JACK, PIN 1P (SAT/CABLE DIGITAL IN COAXIAL)
< COIL >
Ref. No.
Part No.
Description
R525
R527
R528
R529
R530
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
100
100
1M
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
L700
L705
L3000
L3051
L3052
1-481-524-11
1-469-527-91
1-469-526-91
1-469-525-91
1-469-525-91
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
47uH
22uH
10uH
10uH
R531
R532
R533
R534
R536
1-216-809-11
1-216-809-11
1-216-857-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
L3053
L3101
L3102
L3201
L3301
1-469-525-91
1-457-579-11
1-457-579-11
1-457-579-11
1-457-579-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
10uH
10uH
10uH
10uH
R538
R540
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
R542
1-216-833-11
R543
1-216-809-11
L3401
L3402
L3911
L3912
L3913
1-457-579-11
1-457-579-11
1-457-796-11
1-457-797-11
1-457-796-11
INDUCTOR
10uH
INDUCTOR
10uH
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
R544
1-216-864-11
R545
1-216-833-11
L3914
L3921
L3922
L3923
L3924
1-457-797-11
1-457-796-11
1-457-797-11
1-457-796-11
1-457-797-11
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
R546
R547
R549
R550
1-216-809-11
1-216-833-11
1-216-833-11
1-216-864-11
METAL CHIP
10K
5%
1/10W
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL CHIP
100
5%
1/10W
METAL CHIP
10K
5%
1/10W
METAL CHIP
10K
5%
1/10W
SHORT CHIP
0
L3941
L3942
L3943
L3944
1-457-796-11
1-457-797-11
1-457-796-11
1-457-797-11
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
R553
R555
R556
R563
R565
1-216-833-11
1-216-833-11
1-216-809-11
1-216-809-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100
100
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R567
R568
R569
R570
R572
1-216-809-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-801-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
100
100
22
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R574
R577
R580
R582
R585
1-216-838-11
1-216-841-11
1-216-829-11
1-216-829-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
47K
4.7K
4.7K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R586
R587
R588
R589
R590
1-216-833-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
10K
100
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R591
R593
R594
R595
R596
1-216-809-11
1-216-833-11
1-216-829-11
1-216-829-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
4.7K
4.7K
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R597
R599
R601
R606
R607
1-216-801-11
1-216-801-11
1-216-845-11
1-216-801-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
100K
22
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R610
R613
R615
R618
R620
1-216-809-11
1-216-841-11
1-216-841-11
1-216-833-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
100
47K
47K
10K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R621
R622
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
100
100
5%
5%
1/10W
1/10W
< TRANSISTOR >
Q504
Q507
Q3001
Q3101
Q3102
8-729-620-13
6-551-272-01
8-729-620-13
6-551-271-01
6-551-271-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
RT3CLLM
2SC4154TP-1EF
RT3AMMM
RT3AMMM
Q3201
Q3301
Q3401
Q3402
Q3551
6-551-271-01
6-551-271-01
6-551-271-01
6-551-271-01
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT3AMMM
RT3AMMM
RT3AMMM
RT3AMMM
2SC4154TP-1EF
Q3552
Q3556
6-551-272-01
8-729-620-13
TRANSISTOR
TRANSISTOR
RT3CLLM
2SC4154TP-1EF
< RESISTOR >
R505
R506
R507
R508
R509
1-216-809-11
1-216-821-11
1-216-815-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
330
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R510
R511
R512
R513
R514
1-216-815-11
1-216-815-11
1-216-815-11
1-216-815-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
330
330
330
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R519
R521
R522
R523
R524
1-216-833-11
1-218-857-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.7K
10K
10K
10K
5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
100
5%
1/10W
100
5%
1/10W
(E370: AEP, UK/E870: AEP, UK)
METAL CHIP
10K
5%
1/10W
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL CHIP
100
5%
1/10W
(E370: AEP, UK/E870: AEP, UK)
SHORT CHIP
0
101
HBD-E370/E470/E570/E870/T57
MAIN
Ref. No.
Part No.
Description
R623
R632
R633
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R634
R636
R639
R648
R649
1-216-809-11
1-216-809-11
1-216-809-11
1-218-871-11
1-218-879-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
22K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R650
R651
R652
R653
R654
1-218-875-11
1-216-821-11
1-216-841-11
1-218-879-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
1K
47K
22K
10K
0.5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R656
R657
R681
1-216-809-11
1-216-809-11
1-216-864-11
R683
1-216-864-11
R700
1-216-805-11
METAL CHIP
100
5%
1/10W
METAL CHIP
100
5%
1/10W
SHORT CHIP
0
(EXCEPT E370: AEP, UK/E870: AEP, UK)
SHORT CHIP
0
(E370: AEP, UK/E870: AEP, UK)
METAL CHIP
47
5%
1/10W
R701
R702
R703
R704
R705
1-216-864-11
1-218-285-11
1-216-809-11
1-216-801-11
1-216-801-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
75
100
22
22
5%
5%
5%
5%
R706
R707
R708
R709
R710
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
22
22
22
R711
R712
R713
R714
R716
1-216-801-11
1-216-864-11
1-216-805-11
1-216-805-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
22
0
47
47
0
R718
R719
R720
R721
R723
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R724
R725
R726
R729
R730
1-216-864-11
1-216-805-11
1-216-853-11
1-216-805-11
1-216-805-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
47
470K
47
47
R733
R734
R735
R737
R738
1-216-809-11
1-216-864-11
1-218-831-11
1-216-809-11
1-216-809-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R739
R740
R741
R744
R745
1-216-833-11
1-216-805-11
1-216-809-11
1-216-805-11
1-216-864-11
R746
R747
R748
R749
R750
1-216-864-11
1-216-864-11
1-216-833-11
1-216-797-11
1-216-809-11
102
Remark
Part No.
Description
R751
R752
R753
R754
R755
1-216-801-11
1-216-809-11
1-216-809-11
1-216-805-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
100
100
47
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R756
R758
R759
R760
R763
1-216-809-11
1-216-864-11
1-216-857-11
1-216-815-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
1M
330
10K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R764
R765
R766
R767
R768
1-216-833-11
1-216-833-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R769
R771
R772
R773
R774
1-216-809-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100
0
0
100
100
5%
1/10W
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
R775
R776
R777
R778
R780
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R781
R782
R787
R795
R3002
1-216-809-11
1-216-809-11
1-216-809-11
1-216-864-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
100
100
100
0
10K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
5%
1/10W
5%
5%
1/10W
1/10W
R3003
R3004
R3005
R3006
R3007
1-218-871-11
1-218-895-11
1-218-871-11
1-218-869-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
10K
8.2K
1K
0.5%
0.5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3011
R3012
R3013
R3014
R3015
1-216-817-11
1-216-817-11
1-216-833-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
10K
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3017
R3021
R3022
R3023
R3024
1-216-805-11
1-216-817-11
1-216-817-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
470
470
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3027
R3031
R3032
R3033
R3034
1-216-805-11
1-216-817-11
1-216-817-11
1-216-833-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
470
470
10K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3035
R3037
R3040
R3041
R3042
1-216-805-11
1-216-805-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
47
47
0
0
0
5%
5%
1/10W
1/10W
R3043
R3046
R3047
R3050
R3051
1-216-864-11
1-216-864-11
1-216-864-11
1-216-805-11
1-216-845-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
47
100K
5%
5%
1/10W
1/10W
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
100
0
220
100
100
5%
1/10W
0.5%
5%
5%
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
10K
47
100
47
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
10K
10
100
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
Remark
HBD-E370/E470/E570/E870/T57
MAIN
Ref. No.
Part No.
Description
R3052
R3053
R3055
R3057
R3059
1-216-857-11
1-216-821-11
1-216-805-11
1-216-805-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
1K
47
47
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
Ref. No.
R3562
R3936
R3940
Part No.
Description
1-218-883-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
R3060
R3065
R3074
R3075
R3076
1-216-833-11
1-216-809-11
1-216-805-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
47
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
RB500
RB501
RB502
RB503
RB504
1-234-945-21
1-234-945-21
1-234-945-21
1-234-945-21
1-234-945-21
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
R3080
R3102
R3103
R3125
R3126
1-216-845-11
1-216-837-11
1-216-791-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
22K
3.3
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
RB701
1-234-945-21
RES, NETWORK 100 (1005X4)
R3127
R3128
R3131
R3132
R3133
1-216-845-11
1-216-821-11
1-216-805-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
47
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3134
R3140
R3175
R3176
R3177
1-216-805-11
1-216-864-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
0
100K
100K
100K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
9
A-1762-831-A
9
A-1762-832-A
R3202
R3203
R3215
R3216
R3217
1-216-837-11
1-216-791-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
3.3
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
9
A-1762-833-A
9
A-1762-834-A
9
A-1762-842-A
R3228
R3231
R3232
R3233
R3234
1-216-821-11
1-216-805-11
1-216-805-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47
47
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
9
A-1762-844-A
9
A-1762-848-A
9
A-1762-858-A
R3240
R3325
R3326
R3327
R3402
1-216-864-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-837-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100K
100K
100K
22K
9
A-1762-859-A
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
9
A-1762-860-A
R3403
R3424
R3425
R3426
R3427
1-216-791-11
1-216-821-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
1K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3428
R3429
R3430
R3431
R3432
1-216-845-11
1-216-845-11
1-216-845-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R3433
R3434
R3440
R3550
R3551
1-216-805-11
1-216-805-11
1-216-864-11
1-218-863-11
1-216-845-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
47
47
0
4.7K
100K
5%
5%
1/10W
1/10W
0.5%
5%
1/10W
1/10W
R3552
R3553
R3554
R3556
R3558
1-216-837-11
1-216-833-11
1-216-845-11
1-216-841-11
1-218-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
100K
47K
1.5K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
MB-134
Remark
33K
1K
0
0.5%
5%
1/10W
1/10W
< COMPOSITION CIRCUIT BLOCK >
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
< TERMINAL >
TB3901
TB3902
1-780-817-11
1-780-452-11
TERMINAL BOARD (SPEAKER) 4P (SPEAKERS)
TERMINAL BOARD (SPEAKER) 2P (SPEAKERS)
< VIBRATOR >
X500
1-795-059-21 VIBRATOR, CERAMIC (5MHz)
X700
1-814-106-21 VIBRATOR, CRYSTAL (24.576MHz)
X3051
1-814-266-11 VIBRATOR, CRYSTAL (49.152MHz)
*************************************************************
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: US)
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: CND)
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: AEP)
MB-134 BOARD, COMPLETE (for SERVICE)
(E370: UK)
MB-134 BOARD, COMPLETE (for SERVICE) (T57)
MB-134 BOARD, COMPLETE (for SERVICE)
(E570)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: CND)
MB-134 BOARD, COMPLETE (for SERVICE)
(E470)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: AEP)
MB-134 BOARD, COMPLETE (for SERVICE)
(E870: UK)
**********************
< CAPACITOR >
C102
C104
C105
C106
C107
1-100-916-11
1-112-777-11
1-112-777-11
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C109
C110
C111
C112
C113
1-112-777-11
1-112-777-11
1-112-777-11
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C114
C115
C116
C118
C119
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C120
C122
C123
C124
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
16V
16V
16V
16V
103
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
Part No.
Description
Part No.
Description
C127
1-100-916-11
CERAMIC CHIP 0.1uF
10%
16V
C246
1-112-777-11
CERAMIC CHIP 0.01uF
10%
25V
C128
C129
C130
C134
C135
1-100-909-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
6.3V
16V
16V
16V
16V
C247
C248
C250
C252
C254
1-112-777-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
25V
16V
16V
16V
16V
C137
C138
C139
C140
C141
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
6.3V
C256
C258
C259
C301
C302
1-100-916-11
1-100-916-11
1-100-909-11
1-112-777-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
6.3V
25V
16V
C142
C143
C144
C145
C146
1-112-777-11
1-112-777-11
1-114-130-11
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
6.3V
25V
25V
C310
C311
C313
C318
C321
1-100-909-11
1-100-966-91
1-100-909-11
1-100-159-91
1-114-334-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
10uF
22uF
10uF
10%
20%
10%
10%
10%
6.3V
10V
6.3V
6.3V
25V
C147
C148
C150
C151
C153
1-112-777-11
1-114-130-11
1-112-777-11
1-114-130-11
1-114-130-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
1uF
0.01uF
1uF
1uF
10%
10%
10%
10%
10%
25V
6.3V
25V
6.3V
6.3V
C323
C330
C331
C335
C336
1-114-806-11
1-100-909-11
1-112-776-11
1-100-909-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0082uF
10uF
0.0047uF
10uF
0.01uF
10%
10%
10%
10%
10%
25V
6.3V
50V
6.3V
25V
C154
C156
C159
C161
C162
1-114-130-11
1-114-130-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
6.3V
6.3V
16V
16V
16V
C337
C340
C341
C345
C346
1-100-159-91
1-114-553-11
1-114-334-11
1-165-908-11
1-114-802-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
10uF
10uF
1uF
0.0033uF
10%
10%
10%
10%
10%
6.3V
16V
25V
10V
50V
C164
C166
C168
C170
C201
1-100-916-11
1-100-916-11
1-100-916-11
1-100-909-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
10uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
6.3V
16V
C347
C348
C349
C350
C351
1-165-908-11
1-114-802-11
1-100-916-11
1-100-916-11
1-100-159-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.0033uF
0.1uF
0.1uF
22uF
10%
10%
10%
10%
10%
10V
50V
16V
16V
6.3V
C203
C204
C205
C206
C207
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C352
C353
C359
C363
C365
1-100-159-91
1-100-159-91
1-100-909-11
1-100-916-11
1-100-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
22uF
10uF
0.1uF
10uF
10%
10%
10%
10%
10%
6.3V
6.3V
6.3V
16V
6.3V
C209
C211
C214
C215
C216
1-100-916-11
1-100-916-11
1-100-909-11
1-112-777-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
6.3V
25V
16V
C368
C369
C373
C377
C379
1-165-908-11
1-114-130-11
1-112-777-11
1-165-908-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.01uF
1uF
0.01uF
10%
10%
10%
10%
10%
10V
6.3V
25V
10V
25V
C217
C220
C222
C225
C226
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C403
C405
C416
C418
C423
1-100-916-11
1-112-777-11
1-100-909-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
10uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
25V
6.3V
16V
16V
C227
C228
C230
C231
C232
1-100-916-11
1-100-916-11
1-100-909-11
1-100-916-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.1uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
6.3V
16V
25V
C424
C427
C431
C433
C436
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C233
C234
C235
C236
C239
1-114-130-11
1-114-130-11
1-112-777-11
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
6.3V
6.3V
25V
25V
25V
C437
C440
C447
C448
C504
1-100-916-11
1-100-916-11
1-164-850-11
1-164-850-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10PF
10PF
0.1uF
10%
10%
0.5PF
0.5PF
10%
16V
16V
50V
50V
16V
C240
C242
C243
C245
1-114-130-11
1-114-130-11
1-114-130-11
1-114-130-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
10%
10%
10%
10%
6.3V
6.3V
6.3V
6.3V
C505
C506
C604
C605
1-100-916-11
1-100-916-11
1-100-909-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
1uF
10%
10%
10%
10%
16V
16V
6.3V
10V
104
Remark
Ref. No.
Remark
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
Part No.
Description
Part No.
Description
C606
1-165-908-11
CERAMIC CHIP 1uF
10%
10V
Remark
Ref. No.
C1218
1-112-777-11
CERAMIC CHIP 0.01uF
10%
25V
Remark
C608
C609
C610
C613
C614
1-128-993-21
1-165-908-11
1-165-908-11
1-128-394-11
1-128-394-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
22uF
1uF
1uF
220uF
220uF
20%
10%
10%
20%
20%
10V
10V
10V
10V
10V
C1305
C1326
C1361
C1362
C1363
1-117-681-11
1-112-777-11
1-112-777-11
1-114-869-11
1-164-874-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.01uF
0.01uF
2.2uF
100PF
20%
10%
10%
10%
5%
16V
25V
25V
6.3V
50V
C619
C620
C701
C702
C703
1-100-966-91
1-100-966-91
1-100-567-81
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.01uF
0.01uF
0.01uF
20%
20%
10%
10%
10%
10V
10V
25V
25V
25V
C1365
C1366
C1367
C1370
C1382
1-164-874-11
1-114-869-11
1-112-777-11
1-100-916-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
2.2uF
0.01uF
0.1uF
0.01uF
5%
10%
10%
10%
10%
50V
6.3V
25V
16V
25V
C705
C706
C707
C708
C713
1-100-916-11
1-128-994-21
1-112-717-91
1-112-717-91
1-115-467-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
1uF
1uF
0.22uF
10%
20%
10%
10%
10%
16V
10V
6.3V
6.3V
10V
C1383
C1384
C1385
C1386
C1387
1-112-777-11
1-112-777-11
1-112-777-11
1-112-777-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C715
C716
C717
C719
C720
1-115-467-11
1-112-777-11
1-115-467-11
1-112-777-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.01uF
0.22uF
0.01uF
0.22uF
10%
10%
10%
10%
10%
10V
25V
10V
25V
10V
C1388
C1389
C1398
C1399
C1400
1-112-777-11
1-112-777-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
16V
16V
16V
C721
C805
C806
C809
C810
1-100-916-11
1-164-852-11
1-164-852-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
12PF
12PF
0.1uF
0.1uF
10%
5%
5%
10%
10%
16V
50V
50V
16V
16V
C1409
C1410
C1413
C1414
C1415
1-100-916-11
1-164-874-11
1-114-869-11
1-100-905-11
1-114-869-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
2.2uF
0.001uF
2.2uF
10%
5%
10%
10%
10%
16V
50V
6.3V
50V
6.3V
C815
C927
C928
C1001
C1002
1-100-916-11
1-114-130-11
1-114-130-11
1-128-994-21
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
1uF
1uF
47uF
0.1uF
10%
10%
10%
20%
10%
16V
6.3V
6.3V
10V
16V
C1417
C1418
C1421
C1422
C1423
1-164-874-11
1-100-905-11
1-114-869-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.001uF
2.2uF
0.1uF
0.1uF
5%
10%
10%
10%
10%
50V
50V
6.3V
16V
16V
C1004
C1006
C1008
C1009
C1010
1-165-908-11
1-114-130-11
1-100-916-11
1-165-908-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.1uF
1uF
0.1uF
10%
10%
10%
10%
10%
10V
6.3V
16V
10V
16V
C1425
C1426
C1427
C1429
C1434
1-100-916-11
1-100-916-11
1-114-869-11
1-100-905-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
2.2uF
0.001uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
6.3V
50V
16V
C1012
C1014
C1015
C1016
C1017
1-100-916-11
1-128-994-21
1-100-916-11
1-100-916-11
1-128-994-21
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
47uF
0.1uF
0.1uF
47uF
10%
20%
10%
10%
20%
16V
10V
16V
16V
10V
C1435
C1451
C1452
C1454
C1456
1-112-777-11
1-112-777-11
1-100-966-91
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
10uF
0.1uF
0.1uF
10%
10%
20%
10%
10%
25V
25V
10V
16V
16V
C1018
C1101
C1102
C1103
C1104
1-128-993-21
1-164-874-11
1-164-874-11
1-164-874-11
1-164-874-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
100PF
100PF
100PF
100PF
20%
5%
5%
5%
5%
10V
50V
50V
50V
50V
C1457
C1461
C1462
C1468
C1469
1-117-681-11
1-112-777-11
1-112-777-11
1-100-916-11
1-100-916-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.01uF
0.01uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
16V
25V
25V
16V
16V
C1105
C1107
C1108
C1109
C1111
1-100-916-11
1-164-874-11
1-164-874-11
1-164-874-11
1-164-874-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
100PF
100PF
100PF
10%
5%
5%
5%
5%
16V
50V
50V
50V
50V
C1470
C1472
C1473
C1474
C1475
1-100-916-11
1-112-777-11
1-112-746-11
1-112-777-11
1-112-746-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
4.7uF
0.01uF
4.7uF
10%
10%
10%
10%
10%
16V
25V
6.3V
25V
6.3V
C1201
C1206
C1208
C1210
C1213
1-107-819-11
1-112-777-11
1-112-777-11
1-112-746-11
1-112-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.01uF
0.01uF
4.7uF
0.01uF
10%
10%
10%
10%
10%
16V
25V
25V
6.3V
25V
C1476
C1477
C1480
C1481
C1491
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C1214
C1215
C1216
C1217
1-112-746-11
1-100-916-11
1-164-854-11
1-164-854-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.1uF
15PF
15PF
10%
10%
5%
5%
6.3V
16V
50V
50V
C1493
C1499
C2300
C2308
1-100-916-11
1-100-916-11
1-100-916-11
1-114-214-81
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
470PF
10%
10%
10%
5%
16V
16V
16V
50V
105
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
Part No.
Description
C2309
1-114-214-81
CERAMIC CHIP 470PF
5%
50V
Remark
Ref. No.
Part No.
Description
Remark
C2322
C2324
C2364
C2371
C2400
1-100-909-11
1-100-909-11
1-100-909-11
1-100-909-11
1-117-681-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
10uF
10uF
10uF
10uF
100uF
10%
10%
10%
10%
20%
6.3V
6.3V
6.3V
6.3V
16V
C2401
C2402
C2403
C2404
C2405
1-100-916-11
1-100-916-11
1-100-916-11
1-114-130-11
1-114-869-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
1uF
2.2uF
10%
10%
10%
10%
10%
16V
16V
16V
6.3V
6.3V
IC101
IC101
IC104
IC105
IC204
(Not supplied)
(Not supplied)
(Not supplied)
(Not supplied)
(Not supplied)
IC
IC
IC
IC
IC
CXD9983GG (E370: US/E470/E570/T57)
CXD9984GG (E370: CND, AEP, UK/E870)
K4T1G164QE-HCF8
K4T1G164QE-HCF8
K4T1G164QE-HCF8
C2416
C2417
C2418
C2419
C2420
1-114-214-81
1-114-214-81
1-112-775-11
1-100-916-11
1-164-870-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
470PF
0.0022uF
0.1uF
68PF
5%
5%
10%
10%
5%
50V
50V
50V
16V
50V
IC205
IC303
IC307
IC308
IC309
(Not supplied)
6-709-932-01
(Not supplied)
6-714-889-01
6-714-911-01
IC
IC
IC
IC
IC
K4T1G164QE-HCF8
MM3141CNRE
MM3293DNRE
MP2301ENE-LF-Z
TPS54325PWPR
C2421
C2422
C2432
C2433
C2438
1-164-870-11
1-164-870-11
1-112-777-11
1-112-777-11
1-100-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
68PF
68PF
0.01uF
0.01uF
10uF
5%
5%
10%
10%
10%
50V
50V
25V
25V
6.3V
IC310
IC311
IC312
IC501
IC502
6-714-911-01
(Not supplied)
6-714-890-01
(Not supplied)
(Not supplied)
IC
IC
IC
IC
IC
TPS54325PWPR
BD3539NUX-TR
MM1855AHBE
K9GAG08U0D-PCB0T
MX25L1605DM2I-12G
C2440
C2450
C2460
C2470
C2481
1-100-916-11
1-100-916-11
1-100-916-11
1-100-916-11
1-114-553-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
IC601
IC602
IC701
IC704
IC705
6-712-613-01
6-712-613-01
6-709-888-01
6-702-302-01
6-705-337-01
IC
IC
IC
IC
IC
SI-3010KM-TLS
SI-3010KM-TLS
TC7WHU04FK (T5RSOYF
TK11133CSCL-G
TK11150CSCL-G
C2486
C2491
C2495
C2499
1-100-909-11
1-114-553-11
1-114-553-11
1-114-553-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
10uF
10uF
10%
10%
10%
10%
6.3V
16V
16V
16V
IC1001
IC1002
IC1003
IC1101
IC1201
6-711-237-01
6-714-112-01
6-714-834-01
6-713-555-01
6-712-663-11
IC
IC
IC
IC
IC
NJM2878F3-33 (TE2)
NJM2828F3-05
MM1797CVBE
MFI341S2161
LAN8700C-AEZG-CTI
IC1451
IC2301
IC2401
6-713-929-01
6-714-902-01
6-714-901-01
IC BD35630HFV-TR
IC TPIC1391DBTRG4
IC TPIC1405DFDRG4
< FILTER >
FL301
FL302
1-234-939-21
1-234-939-21
FILTER, EMI REMOVAL (SMD)
FILTER, EMI REMOVAL (SMD)
< IC >
< CONNECTOR >
CN303
CN601
CN602
CN701
CN901
1-766-383-21
1-573-768-21
1-573-768-61
1-820-735-31
1-779-332-51
PIN, CONNECTOR (1.5mm) (SMD) 12P
PIN, CONNECTOR (1.5mm) (SMD) 5P
PIN, CONNECTOR (1.5mm) (SMD) 5P
HDMI CONNECTOR (HDMI ARC OUT)
CONNECTOR, FFC/FPC 16P
CN902
CN1102
CN1201
CN1401
CN1505
1-779-333-51
1-573-806-21
1-819-875-31
1-822-601-51
1-794-341-51
CONNECTOR, FFC/FPC 18P
PIN, CONNECTOR (1.5mm) (SMD) 6P
ETHERNET CONNECTOR (8P) (LAN (100))
CONNECTOR, FFC/FPC (ZIF) 45P
CONNECTOR, FFC/FPC 27P
CN2460
CN2470
1-820-112-51
1-794-362-51
CONNECTOR, FFC/FPC 9P
CONNECTOR, FFC/FPC 5P
< JACK >
J904
1-822-993-11
JACK, PIN
(VIDEO OUT, COMPONENT VIDEO OUT)
< COIL >
L301
L302
L303
L304
L305
1-457-735-11
1-400-789-21
1-457-771-11
1-457-771-11
1-400-789-21
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
2.2uH
2.2uH
2.2uH
2.2uH
L306
L603
L604
L605
L606
1-400-789-21
1-414-840-21
1-414-840-21
1-414-840-21
1-414-840-21
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
2.2uH
10nH
10nH
10nH
10nH
L607
L608
L1201
L1202
L2322
1-457-223-11
1-457-223-11
1-457-223-11
1-457-223-11
1-481-551-21
COMMON MODE CHOKE COIL
COMMON MODE CHOKE COIL
COMMON MODE CHOKE COIL
COMMON MODE CHOKE COIL
INDUCTOR
1.5uH
L2324
1-481-551-21
INDUCTOR
< DIODE >
D302
D303
D304
D601
D602
6-502-964-01
6-502-248-01
6-502-248-01
6-502-961-01
6-502-961-01
DIODE
DIODE
DIODE
DIODE
DIODE
DZ2J047M0L
KDZTR3.9B
KDZTR3.9B
DA2J10100L
DA2J10100L
D603
D604
D605
D606
6-500-701-01
6-500-701-01
6-500-701-01
6-500-701-01
DIODE
DIODE
DIODE
DIODE
PGB1010603NR
PGB1010603NR
PGB1010603NR
PGB1010603NR
< RESISTOR >
FB2300
FB2403
FB2481
106
1-244-161-81
1-244-161-81
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
2.2
2.2
0
5%
5%
1.5uH
< FUSE >
1/16W
1/16W
0 PS301
1-523-094-31
FUSE (2A/50V)
Note: IC101, IC104, IC105, IC204, IC205, IC307, IC311, IC501 and
IC502 on the MB-134 board cannot exchange with single. When
these parts are damaged, exchange the entire mounted board.
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
0 PS302
0 PS303
0 PS304
Part No.
1-523-095-31
1-523-074-31
1-523-095-31
Description
Remark
Part No.
Description
1-218-965-11
1-218-965-11
1-218-990-81
1-218-864-11
1-218-990-81
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
10K
10K
0
5.1K
0
5%
5%
1/16W
1/16W
0.5%
1/10W
< CONTACT TERMINAL >
R529
R530
R531
R601
R606
FUSE (3.15A/32V)
FUSE (1A/32V)
FUSE (3.15A/32V)
Ref. No.
Remark
PT101
PT103
PT104
PT105
PT106
1-780-729-12
1-780-729-12
1-780-729-12
1-780-729-12
1-780-729-12
CONTACT TERMINAL
CONTACT TERMINAL
CONTACT TERMINAL
CONTACT TERMINAL
CONTACT TERMINAL
R610
R611
R612
R613
R614
1-208-691-11
1-208-721-11
1-208-911-11
1-208-691-11
1-208-721-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
39K
10K
2.2K
39K
0.5%
0.5%
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
PT107
1-780-638-22
CONTACT TERMINAL
R615
R618
R619
R620
R701
1-208-911-11
1-218-965-11
1-218-965-11
1-216-295-91
1-218-965-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
10K
10K
0
10K
0.5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R702
R703
R706
R709
R710
1-208-683-11
1-208-687-11
1-218-970-11
1-218-990-81
1-218-990-81
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
1K
1.5K
27K
0
0
0.5%
0.5%
5%
1/16W
1/16W
1/16W
R711
R712
R713
R714
R715
1-218-981-91
1-218-990-81
1-218-949-11
1-218-990-81
1-218-973-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
220K
0
470
0
47K
5%
1/16W
5%
1/16W
5%
1/16W
R717
R718
R734
R735
R736
1-218-939-11
1-218-939-11
1-218-967-11
1-218-956-11
1-218-956-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68
68
15K
1.8K
1.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R739
R740
R741
R743
R744
1-218-967-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
15K
0
0
0
0
5%
1/16W
R749
R752
R805
R806
R807
1-218-973-11
1-218-953-11
1-218-977-11
1-218-951-11
1-218-941-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
100K
680
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R808
R903
R904
R905
R906
1-208-709-11
1-218-990-81
1-218-990-81
1-218-990-81
1-218-937-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
12K
0
0
0
47
0.5%
1/16W
5%
1/16W
R907
R908
R909
R910
R911
1-218-937-11
1-218-937-11
1-218-937-11
1-218-990-81
1-218-990-81
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
47
47
47
0
0
5%
5%
5%
1/16W
1/16W
1/16W
R912
R913
R914
R916
R917
1-218-937-11
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
47
0
0
0
0
5%
1/16W
R918
R919
R920
R921
R922
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< TRANSISTOR >
Q301
Q302
Q303
Q702
8-729-028-96
6-550-516-01
8-729-028-96
6-551-714-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET
DTC114EUA-T106
FDC642P
DTC114EUA-T106
INK0001AC1-T112A-1
< RESISTOR >
R101
R106
R107
R201
R206
1-218-941-11
1-218-941-81
1-218-941-81
1-218-941-11
1-218-941-81
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R207
R305
R306
R312
R318
1-218-941-81
1-218-953-11
1-218-953-11
1-208-699-11
1-218-953-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
4.7K
1K
5%
5%
5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R319
R320
R321
R322
R323
1-218-990-81
1-218-990-81
1-208-923-11
1-208-909-11
1-208-677-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
33K
8.2K
560
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
R327
R329
R330
R331
R332
1-218-953-11
1-218-953-11
1-208-909-11
1-208-713-11
1-208-663-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
8.2K
18K
150
5%
5%
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R333
R334
R335
R343
R355
1-208-697-11
1-218-958-11
1-208-661-11
1-218-953-11
1-218-945-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.9K
2.7K
120
1K
220
0.5%
5%
0.5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R362
R363
R374
R375
R376
1-216-825-11
1-216-825-11
1-218-971-11
1-218-975-11
1-218-953-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
33K
68K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R379
R401
R402
R403
R404
1-216-864-11
1-216-295-91
1-216-295-91
1-218-952-11
1-218-977-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
820
100K
R516
R523
R525
R526
R528
1-218-990-81
1-218-959-11
1-218-990-81
1-218-977-11
1-218-937-11
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
3.3K
0
100K
47
5%
5%
1/16W
1/16W
5%
1/16W
5%
5%
1/16W
1/16W
107
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
Part No.
Description
R923
R924
R925
R926
R927
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
Part No.
Description
R1147
R1149
R1152
R1153
R1156
1-218-965-11
1-218-965-11
1-218-961-11
1-218-961-11
1-218-941-81
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
4.7K
4.7K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R928
R929
R930
R931
R932
1-218-990-81
1-218-933-11
1-218-933-11
1-218-933-11
1-218-937-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22
22
22
47
R1157
R1162
R1163
R1164
R1165
1-218-990-81
1-218-937-11
1-218-937-11
1-218-965-11
1-218-941-81
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
47
47
10K
100
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R933
R934
R935
R936
R939
1-218-990-81
1-218-990-81
1-218-933-11
1-218-965-11
1-218-990-81
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
0
22
10K
0
R1169
R1189
R1190
R1191
R1201
1-218-965-11
1-218-977-11
1-218-941-81
1-216-864-11
1-218-929-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
100K
100
0
10
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R940
R1005
R1006
R1007
R1008
1-218-933-11
1-208-691-11
1-218-990-81
1-208-663-11
1-208-663-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
22
2.2K
0
150
150
5%
0.5%
1/16W
1/16W
1/16W
1/16W
R1204
R1205
R1206
R1207
R1208
1-245-567-81
1-245-567-81
1-245-567-81
1-245-567-81
1-208-692-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
49.9
49.9
49.9
49.9
2.4K
0.5%
0.5%
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
0.5%
0.5%
R1009
R1010
R1011
R1012
R1013
1-208-663-11
1-208-663-11
1-208-663-11
1-208-663-11
1-218-953-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
150
150
1K
0.5%
0.5%
0.5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1209
R1210
R1213
R1214
R1215
1-208-911-11
1-218-941-81
1-218-941-81
1-218-965-11
1-218-941-81
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
10K
100
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1016
R1028
R1029
R1030
R1031
1-218-953-11
1-220-169-11
1-220-169-11
1-220-169-11
1-220-169-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
75
75
75
75
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1216
R1217
R1218
R1219
R1220
1-218-941-81
1-218-941-81
1-218-941-81
1-218-955-11
1-218-941-81
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
1.5K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1032
R1033
R1034
R1035
R1101
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R1226
R1227
R1231
R1232
R1247
1-218-965-11
1-218-977-11
1-218-965-11
1-218-965-11
1-218-941-81
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
10K
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1102
R1103
R1107
R1110
R1115
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R1302
R1308
R1370
R1371
R1372
1-218-965-11
1-218-965-11
1-218-953-11
1-218-929-11
1-218-957-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
1K
10
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1116
R1117
R1118
R1119
R1120
1-218-990-81
1-218-990-81
1-218-990-81
1-218-937-11
1-218-965-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
47
10K
R1410
R1412
R1429
R1435
R1452
1-218-957-11
1-218-961-11
1-208-911-11
1-218-929-11
1-208-933-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
4.7K
10K
10
82K
5%
5%
0.5%
5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1121
R1122
R1123
R1124
R1125
1-218-941-81
1-218-990-81
1-218-990-81
1-218-937-11
1-218-990-81
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
100
0
0
47
0
R1453
R1454
R1470
R1471
R1503
1-208-956-81
1-218-973-11
1-208-889-11
1-208-715-11
1-218-965-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
750K
47K
1.2K
22K
10K
0.5%
5%
0.5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R1127
R1131
R1132
R1133
R1134
1-218-941-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
100
0
0
0
0
R1524
R1535
R1536
R1540
R1543
1-218-965-11
1-218-959-11
1-218-977-11
1-218-990-81
1-218-965-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
3.3K
100K
0
10K
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R1135
R1136
R1138
R1139
R1141
1-218-990-81
1-218-990-81
1-218-965-11
1-218-965-11
1-218-990-81
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
0
10K
10K
0
R1546
R1551
R1552
R1554
R1562
1-218-965-11
1-218-977-11
1-218-977-11
1-218-990-81
1-218-977-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
100K
100K
0
100K
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
108
Remark
5%
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
5%
5%
1/16W
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
5%
1/16W
1/16W
Ref. No.
Remark
HBD-E370/E470/E570/E870/T57
MB-134
Ref. No.
Part No.
Description
R1563
R1565
R1566
R1567
R1568
1-218-977-11
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
100K
0
0
0
0
Remark
R1569
R1570
R1571
R1572
R1573
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R1574
R1575
R1576
R1577
R1578
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R1579
R1580
R1581
R1582
R1584
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R1585
R1586
R1598
R1609
R1611
1-218-990-81
1-218-941-81
1-218-990-81
1-218-977-11
1-218-977-11
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
100
0
100K
100K
5%
1/16W
5%
5%
1/16W
1/16W
R1612
R1613
R2307
R2308
R2309
1-218-977-11
1-218-977-11
1-218-973-11
1-218-969-11
1-218-969-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
47K
22K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R2411
R2412
R2416
R2417
R2418
1-218-971-11
1-218-971-11
1-208-720-11
1-208-720-11
1-218-965-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
33K
36K
36K
10K
5%
5%
0.5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R2419
R2420
R2421
R2422
R2442
1-218-990-81
1-220-203-11
1-220-206-11
1-220-206-11
1-218-853-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
51K
91K
91K
1.8K
5%
5%
5%
0.5%
1/16W
1/16W
1/16W
1/10W
R2444
R2446
R2447
R2483
R2487
1-218-853-11
1-218-853-11
1-248-476-11
1-218-990-81
1-218-990-81
METAL CHIP
METAL CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
1.8K
1.8K
0.16
0
0
0.5%
0.5%
1%
1/10W
1/10W
1/3W
R2492
R2494
R2496
1-218-853-11
1-218-853-11
1-218-853-11
METAL CHIP
METAL CHIP
METAL CHIP
1.8K
1.8K
1.8K
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
5%
1/16W
Ref. No.
P-KEY
Part No.
Description
RB205
RB206
RB1101
RB1102
RB1103
1-234-372-11
1-234-372-11
1-234-378-21
1-234-378-21
1-234-378-21
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
RB1201
RB1503
1-234-372-11
1-234-372-11
RES, NETWORK 100 (1005X4)
RES, NETWORK 100 (1005X4)
POWER
Remark
100 (1005X4)
100 (1005X4)
10K (1005X4)
10K (1005X4)
10K (1005X4)
< THERMISTOR >
TH1501
1-804-949-11
THERMISTOR, NTC (SMD)
< VIBRATOR >
X401
1-814-278-11 VIBRATOR, CRYSTAL (27MHz)
X802
1-814-242-11 VIBRATOR, CRYSTAL (25MHz)
X1201
1-814-242-11 VIBRATOR, CRYSTAL (25MHz)
*************************************************************
P-KEY BOARD
***********
< CAPACITOR >
C750
1-162-927-11
CERAMIC CHIP 100PF
5%
50V
5%
1/10W
< CONNECTOR >
* CN750
1-580-055-21
PIN, CONNECTOR (SMD) 2P
< RESISTOR >
R750
1-216-809-11
METAL CHIP
100
< SWITCH >
S750
1-786-650-21 SWITCH, TACTILE (I/1)
*************************************************************
A-1745-451-A
A-1745-455-A
POWER BOARD, COMPLETE
(E370: AEP, UK/E870: AEP, UK)
POWER BOARD, COMPLETE
(EXCEPT E370: AEP, UK/E870: AEP, UK)
**********************
7-685-647-79
SCREW +BVTP 3X10 TYPE2 IT-3
< CAPACITOR >
0 C901
0 C902
1-114-594-21
1-114-594-21
0 C902
1-116-397-21
0 C903
1-112-330-11
0 C903
1-112-332-11
< COMPOSITION CIRCUIT BLOCK >
RB101
RB102
RB103
RB104
RB105
1-234-372-11
1-234-372-11
1-234-372-11
1-234-372-11
1-234-372-11
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
0 C905
1-116-392-11
0 C905
1-116-393-11
0 C906
1-117-815-11
RB106
RB201
RB202
RB203
RB204
1-234-372-11
1-234-372-11
1-234-372-11
1-234-372-11
1-234-372-11
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
RES, NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
100 (1005X4)
0 C907
1-162-964-91
0 C907
1-162-965-91
0 C908
1-107-909-91
Note: When the POWER board is replaced, spread the compound referring to “NOTE OF
REPLACING THE D913, D931, IC901 AND IC921 ON THE POWER BOARD
AND THE COMPLETE POWER BOARD” on servicing notes (page 9).
FILM
FILM
0.22uF
10%
310V
0.22uF
10%
310V
(E370: AEP, UK/E870: AEP, UK)
FILM
0.33uF
10%
310V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
ELECT (BLOCK) 1000uF
20%
200V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
ELECT (BLOCK) 330uF
20%
400V
(E370: AEP, UK/E870: AEP, UK)
FILM
0.01uF
5%
400V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
FILM
0.0033uF 5%
400V
(E370: AEP, UK/E870: AEP, UK)
FILM
1000PF
3%
1.5KV
(E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.001uF
10%
50V
(E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.0015uF 10%
50V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
ELECT
47uF
20%
50V
109
HBD-E370/E470/E570/E870/T57
POWER
Ref. No.
Part No.
Description
Remark
0
0
0
0
C909
C910
C916
C918
1-162-960-91
1-126-965-91
1-116-078-11
1-112-887-51
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC
220PF
22uF
1uF
0.01uF
10%
20%
10%
20%
50V
50V
50V
250V
0
0
0
0
0
C920
C921
C922
C923
C924
1-112-887-51
1-117-220-81
1-112-300-91
1-164-390-91
1-116-393-11
CERAMIC
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
FILM
0.01uF
150PF
4.7uF
330PF
0.0033uF
20%
5%
10%
5%
5%
250V
2KV
10V
50V
400V
0 C925
0 C926
C927
C928
C929
1-100-566-91
1-107-930-91
1-112-223-11
1-112-232-11
1-112-241-21
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
0.1uF
22uF
3300uF
2700uF
1000uF
10%
20%
20%
20%
20%
25V
100V
10V
16V
25V
C932
C933
C934
C935
C936
1-114-994-11
1-114-994-11
1-112-831-31
1-114-323-11
1-114-323-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
2200uF
2200uF
2200uF
0.01uF
0.01uF
20%
20%
20%
10%
10%
35V
35V
35V
50V
50V
C937
0 C938
C939
C940
C942
1-100-756-91
1-112-869-51
1-136-165-00
1-112-228-21
1-126-941-11
CERAMIC CHIP
CERAMIC
FILM
ELECT
ELECT
0.047uF
470PF
0.1uF
1000uF
470uF
10%
10%
5%
20%
20%
50V
250V
50V
16V
25V
C943
1-126-934-11
ELECT
C943
1-126-935-11
C950
C951
0 C963
1-100-566-91
1-100-566-91
1-112-869-51
0 C963
1-112-870-51
0 C964
1-112-869-51
0 C964
1-112-870-51
C971
C972
1-162-970-11
1-100-566-91
C973
C975
0 C980
1-100-566-91
1-100-566-91
1-117-828-11
0 C981
C983
1-162-968-91
1-100-756-91
CERAMIC CHIP 0.1uF
10%
25V
CERAMIC CHIP 0.1uF
10%
25V
FILM
3300PF
3%
1.5KV
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.0047uF 10%
50V
CERAMIC CHIP 0.047uF
10%
50V
C984
C987
C990
C991
C992
1-162-970-11
1-100-566-91
1-100-566-91
1-100-566-91
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C993
0 C994
1-100-566-91
1-112-869-51
C997
1-115-339-11
C997
1-116-078-11
0 C998
1-162-968-91
CERAMIC CHIP 0.1uF
10%
25V
CERAMIC
470PF
10%
250V
(E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.1uF
10%
50V
(E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 1uF
10%
50V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.0047uF 10%
50V
220uF
20%
16V
(E370: AEP, UK/E870: AEP, UK)
ELECT
470uF
20%
16V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.1uF
10%
25V
CERAMIC CHIP 0.1uF
10%
25V
CERAMIC
470PF
10%
250V
(E370: AEP, UK/E870: AEP, UK)
CERAMIC
0.001uF
20%
250V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CERAMIC
470PF
10%
250V
(E370: AEP, UK/E870: AEP, UK)
CERAMIC
0.001uF
20%
250V
(EXCEPT E370: AEP, UK/E870: AEP, UK)
CERAMIC CHIP 0.01uF
10%
25V
CERAMIC CHIP 0.1uF
10%
25V
0.01uF
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
10%
10%
< CONNECTOR >
0 CN901
110
1-564-321-11
PIN, CONNECTOR (3.96mm PITCH) 2P
25V
25V
25V
25V
25V
Ref. No.
CN904
Part No.
Description
1-785-102-11
PIN, CONNECTOR (3.96mm PITCH) 4P
Remark
< DIODE >
0
0
0
0
0
D901
D902
D906
D907
D908
8-719-082-57
8-719-063-74
6-501-817-01
6-501-817-01
6-501-817-01
DIODE
DIODE
DIODE
DIODE
DIODE
D5SBA60F01
D1NL20U-TR2
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
0
0
0
0
D909
D910
D913
D914
D931
6-501-817-01
6-501-817-01
6-500-241-01
6-501-817-01
6-501-849-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0
MA2J1110GLS0
SARS03
MA2J1110GLS0
FMX-22SL
D942
D943
0 D946
D954
D955
6-502-518-01
8-719-080-53
6-502-234-01
6-500-288-11
6-500-288-11
DIODE
DIODE
DIODE
DIODE
DIODE
50PQSA065-FA9
RK36LF-B3
EG01C LF-F7
EK19LF-F7
EK19LF-F7
DZ901
DZ902
DZ903
DZ905
6-501-782-01
6-502-231-01
6-501-787-01
6-501-792-01
DIODE
DIODE
DIODE
DIODE
0 DZ905
8-719-083-71
0 DZ915
0 DZ951
0 DZ954
6-501-760-01
8-719-083-71
8-719-083-71
0
0
0
0
MAZ8180GMLS0
MAZ8220GLLSO
MAZ8220GMLS0
MAZ8300GMLS0
(E370: AEP, UK/E870: AEP, UK)
DIODE UDZSUSTE-1730B
(EXCEPT E370: AEP, UK/E870: AEP, UK)
DIODE MAZ8100GMLS0
DIODE UDZSUSTE-1730B
DIODE UDZSUSTE-1730B
(E370: AEP, UK/E870: AEP, UK)
< FUSE HOLDER >
FH901
FH902
1-533-217-31
1-533-217-31
FUSE HOLDER
FUSE HOLDER
< FUSIBLE >
0 FR929
1-246-373-11
FUSIBLE
1
10%
1/2W
F
< IC >
0 IC901
6-707-741-01
0 IC901
6-707-742-01
0 IC921
IC923
IC932
6-714-671-01
6-711-947-01
6-711-947-01
IC STR-F6138-LF1352
(EXCEPT E370: AEP, UK/E870: AEP, UK)
IC STR-F6168-LF1352
(E370: AEP, UK/E870: AEP, UK)
IC STR-Y6763
IC MM1431CURE
IC MM1431CURE
IC941
6-712-613-01
IC SI-3010KM-TLS
< COIL >
L931
L954
L956
L963
1-457-878-65
1-457-578-11
1-457-578-11
1-457-725-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
2.2uH
10uH
10uH
4.7uH
Note 1: When D913 and D931 on the POWER board are replaced,
spread the compound referring to “NOTE OF REPLACING
THE D913, D931, IC901 AND IC921 ON THE POWER
BOARD AND THE COMPLETE POWER BOARD” on servicing notes (page 9).
Note 2: When IC901 and IC921 on the POWER board are replaced,
spread the compound referring to “NOTE OF REPLACING
THE D913, D931, IC901 AND IC921 ON THE POWER
BOARD AND THE COMPLETE POWER BOARD” on servicing notes (page 9).
HBD-E370/E470/E570/E870/T57
POWER
Ref. No.
Part No.
Description
L964
1-457-725-11
INDUCTOR
4.7uH
Remark
L967
1-469-525-91
INDUCTOR
10uH
< LINE FILTER >
0 LF901
1-457-054-21
COIL, LINE FILTER
(E370: AEP, UK/E870: AEP, UK)
0 LF901
1-457-449-11
0 LF902
1-457-054-21
0 LF902
1-457-449-11
COIL, LINE FILTER
(EXCEPT E370: AEP, UK/E870: AEP, UK)
COIL, LINE FILTER
(E370: AEP, UK/E870: AEP, UK)
COIL, LINE FILTER
(EXCEPT E370: AEP, UK/E870: AEP, UK)
< PHOTO COUPLER >
0 PC901
0 PC902
0 PC903
6-600-276-01
6-600-276-01
6-600-276-01
PHOTO COUPLER PS2561AL1-1-V-W
PHOTO COUPLER PS2561AL1-1-V-W
PHOTO COUPLER PS2561AL1-1-V-W
< TRANSISTOR >
0 Q901
0 Q922
Q943
Q949
Q950
8-729-231-15
6-550-702-01
8-729-029-14
8-729-620-13
8-729-029-14
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015TP-YGR
2SC3243-TP-E
DTC144EUA-T106
2SC4154TP-1EF
DTC144EUA-T106
Q969
6-551-699-01
TRANSISTOR
ISA1602AM1TP-1EF
< RESISTOR >
0 R901
1-219-759-51
METAL
1M
5%
1/2W F
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL
1.5M
5%
0.5W F
(E370: AEP, UK/E870: AEP, UK)
METAL OXIDE 100K
5%
3W
F
(E370: AEP, UK/E870: AEP, UK)
METAL OXIDE 33K
5%
3W
F
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL OXIDE 100K
5%
3W
F
(E370: AEP, UK/E870: AEP, UK)
0 R901
1-240-938-51
0 R903
1-250-297-65
0 R903
1-250-299-65
0 R904
1-250-297-65
0 R904
1-250-299-65
0
0
0
0
R905
R906
R907
R908
1-216-797-91
1-216-827-91
1-216-833-91
1-216-829-91
METAL OXIDE 33K
5%
3W
F
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL CHIP
10
5%
1/10W
METAL CHIP
3.3K
5%
1/10W
METAL CHIP
10K
5%
1/10W
METAL CHIP
4.7K
5%
1/10W
0
0
0
0
R909
R910
R911
R912
1-216-833-91
1-216-825-91
1-216-813-91
1-216-363-61
METAL CHIP
METAL CHIP
METAL CHIP
METAL OXIDE
0 R914
1-220-891-11
METAL
0 R914
1-248-180-11
METAL
R916
R917
R919
R922
0 R923
0 R925
0 R926
R931
R932
Ref. No.
REG
Part No.
Description
R933
R934
R935
R936
R937
1-216-821-11
1-216-821-11
1-216-821-11
1-216-853-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
470K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R938
R939
R940
R941
R942
1-218-847-11
1-218-855-11
1-218-871-11
1-218-895-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
2.2K
10K
100K
10K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R945
R946
R949
0 R951
R954
1-216-837-11
1-216-827-11
1-216-827-11
1-218-875-91
1-218-861-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
3.3K
3.3K
15K
3.9K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R955
R956
R959
R963
R965
1-216-821-11
1-216-817-11
1-218-871-11
1-218-839-11
1-218-863-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
470
10K
470
4.7K
5%
5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R966
R967
R972
R976
0 R978
1-216-821-11
1-216-821-11
1-218-871-11
1-216-833-11
1-216-829-91
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
10K
4.7K
5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R979
0 R992
R998
R999
1-216-841-11
1-216-793-91
1-218-855-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
4.7
2.2K
10K
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
< TRANSFORMER >
0 T901
1-443-649-11
0 T901
1-443-874-11
0 T903
1-445-320-11
TRANSFORMER, CONVERTER
(EXCEPT E370: AEP, UK/E870: AEP, UK)
TRANSFORMER, CONVERTER
(E370: AEP, UK/E870: AEP, UK)
TRANSFORMER, CONVERTER
< THERMISTOR >
0 TH901
1-805-841-21
0 TH901
1-805-842-21
THERMISTOR, NTC 3.0
(EXCEPT E370: AEP, UK/E870: AEP, UK)
THERMISTOR, NTC 6.0
(E370: AEP, UK/E870: AEP, UK)
< VARISTOR >
10K
5%
1/10W
2.2K
5%
1/10W
220
5%
1/10W
0.33
5%
2W
F
(E370: AEP, UK/E870: AEP, UK)
0.1
10%
5W
F
(E370: AEP, UK/E870: AEP, UK)
0 VDR901 1-802-839-11 VARISTOR
*************************************************************
REG BOARD
**********
< CAPACITOR >
0
0
0
0
1-250-297-65
1-216-829-91
1-216-837-91
1-250-262-41
0.034
5%
5W
F
(EXCEPT E370: AEP, UK/E870: AEP, UK)
METAL OXIDE 100K
5%
3W
F
METAL CHIP
4.7K
5%
1/10W
METAL CHIP
22K
5%
1/10W
METAL
0.39
5%
2W
F
C400
C401
C403
C404
C405
1-100-566-91
1-126-934-11
1-100-566-91
1-100-566-91
1-126-941-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
220uF
0.1uF
0.1uF
470uF
10%
20%
10%
10%
20%
25V
16V
25V
25V
25V
1-218-879-91
1-216-797-91
1-218-847-91
1-218-851-11
1-218-879-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
C408
C409
C411
C412
C414
1-162-964-11
1-165-908-11
1-100-591-91
1-162-964-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
1uF
1uF
0.001uF
1uF
10%
10%
10%
10%
10%
50V
10V
25V
50V
10V
22K
10
1K
1.5K
22K
0.5%
5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
111
HBD-E370/E470/E570/E870/T57
REG
Ref. No.
C415
C426
C428
C431
R-USB
Part No.
Description
1-125-837-91
1-104-666-11
1-162-970-11
1-126-949-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
Remark
1uF
220uF
0.01uF
220uF
10%
20%
10%
20%
6.3V
25V
25V
35V
< CONNECTOR >
* CN400
CN403
1-691-774-11
1-784-926-11
PLUG (MICRO CONNECTOR) 12P
PIN, CONNECTOR 11P
Ref. No.
Part No.
Description
1-828-740-51
1-828-730-51
1-828-341-51
A-1750-926-A
WIRE (FLAT TYPE) (18 CORE)
WIRE (FLAT TYPE) (16 CORE)
WIRE (FLAT TYPE) (15 CORE)
LOADING FOR SERVICE
0 206
207
208
209
0 F901
8-820-430-02
1-837-660-51
1-837-658-51
1-837-659-51
1-533-311-12
DEVICE, OPTICAL (KEM-460AAA/C2RP)
WIRE (FLAT TYPE) (9 CORE)
WIRE (FLAT TYPE) (45 CORE)
WIRE (FLAT TYPE) (5 CORE)
FUSE, GLASS (DIA.5) (8A/125V) (US, CND)
0 F901
M3001
TU1
TU1
1-576-232-51
1-787-931-11
1-693-781-11
1-693-787-11
FUSE (H.B.C.) (T5AH/250V) (AEP, UK)
DC FAN
TUNER (FM) (US, CND)
TUNER (FM) (AEP, UK)
158
159
160
202
< DIODE >
D402
D403
D405
D406
D407
8-719-083-63
8-719-083-66
8-719-083-87
6-500-288-11
6-500-288-11
DIODE
DIODE
DIODE
DIODE
DIODE
UDZSUSTE-1713B
UDZSUSTE-1718B
UDZSUSTE-1733B
EK19LF-F7
EK19LF-F7
< IC >
IC400
IC402
6-702-302-01
6-715-070-01
IC TK11133CSCL-G
IC TK72270CSCL-GH
< COIL >
L401
1-457-725-11
INDUCTOR
4.7uH
< TRANSISTOR >
Q401
Q402
8-729-028-96
6-551-460-01
FET
TRANSISTOR
DTC114EUA-T106
RSR025P03TL
< RESISTOR >
R402
R404
R406
R411
R415
1-216-295-91
1-216-295-91
1-216-821-11
1-216-821-11
1-216-841-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
1K
1K
47K
5%
5%
5%
1/10W
1/10W
1/10W
R417
1-216-839-11 METAL CHIP
33K
5%
1/10W
R420
1-216-843-11 METAL CHIP
68K
5%
1/10W
R421
1-216-821-11 METAL CHIP
1K
5%
1/10W
R422
1-216-841-11 METAL CHIP
47K
5%
1/10W
R423
1-216-841-11 METAL CHIP
47K
5%
1/10W
*************************************************************
R-USB BOARD
***********
< CONNECTOR >
CN150
1-842-128-11 USB CONNECTOR ( )
CN151
1-784-922-11 PIN, CONNECTOR 5P
*************************************************************
MISCELLANEOUS
**************
53
56
0 57
0 57
0 57
1-966-988-11
1-966-989-12
1-777-071-83
1-835-078-31
1-837-308-11
HARNESS (USB)
HARNESS (USB)
CORD, POWER (AEP)
CORD, POWER (UK)
CORD, POWER-SUPPLY (US, CND)
102
102
154
155
157
1-828-954-51
1-828-964-51
1-828-343-51
1-828-400-51
1-828-336-51
WIRE (FLAT TYPE) (9 CORE) (US, CND)
WIRE (FLAT TYPE) (11 CORE) (AEP, UK)
WIRE (FLAT TYPE) (15 CORE)
WIRE (FLAT TYPE) (27 CORE)
WIRE (FLAT TYPE) (15 CORE) (US, CND)
157
1-828-346-51
WIRE (FLAT TYPE) (17 CORE) (AEP, UK)
112
Remark
HBD-E370/E470/E570/E870/T57
MEMO
113
HBD-E370/E470/E570/E870/T57
REVISION HISTORY
Checking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
Ver.
Date
1.0
2010.02
Description of Revision
New

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download SERVICE MANUAL