1
Download Service Manual - Portal do Eletrodomestico
Transcript
SERVICE Whirlpool Europe Customer Services ADP 952 WHM Service Manual Dishwasher ADP 952 WHM Model Version ADP 952 WHM 8542 952 61010 Page Technical data 2-4 Spare part list 5-6 Exploded view 7-8 Circuit diagram 9 Program diagram 10 Text/Legend 11 - 19 Family B5 This documentation is only intended for qualified technicians who are aware of the respective safety regulations. Date: 22.02.1996 Subject to modification Document-No.: 4812 718 11648 22.02.1996 / Page 2 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE Technical data Dimension Height Width Depth Weight Volume (normal program) 82,0-87,0 59,5 57,0 ~ 55,7 cm cm cm kg 4 584 595 1,8 mm mm mm kg Decor plate Thicknes max. Width Height Weight max. Specification (normal program) Capacity 12 Water consumption Energy consumption Program time Noise level Detergent consumption Salt consumption by 21˚ dh Hot water connect. up to 19 1,4 ~ 78 49 25 standard setting pl. l kWh min db (A) ml <20 60 g ˚C Alarms Refill rinse aid Refill salt Sprayarm blocked Water Regeneration Back rinse 3x Prewash Prewash/Zone washing Main wash Main wash/Zone washing Intermediate rinse 1 Intermediate rinse 1/ Zone washing Intermediate rinse 2 Intermediate rinse 2/ Zone washing Clear rinse Clear rinse/Zone washing Safety / overflow Volume 0,3 l 1,0 l 5,0 l 4,0 l 5,0 l 3,8 l 4,5 l Level 15 mm 68 mm 125 mm 120 mm 125 mm 119 mm 123 mm 3,8 l 4,5 l 119 mm 123 mm 3,8 l 4,5 l 3,8 l 8,5 l 119 mm 123 mm 119 mm 141 mm Measuring the level Remove the coarse sieve, put in a measuring meter into the sump, measure the hight of the water level. Detergent max. Pre-wash Main-wash Rinse aid 6 Dosage steps 10 45 125 1-6 cm cm cm cm 2 900 300 kg cm cm 0,3-10 0,4 bar bar 2800 2800 ~ 30 ~ 35 ~ 60 RPM RPM RPM RPM RPM Water softener Options Delay timer Zone washing Program information Start indicator Pre rinse/pre wash Main wash Drying End Saltcontainer Resin container Regeneration dosage Water pressure Inlet pressure Spray pump pressure Rotations Spray pump motor Drain pump motor Spray arm lower Spray arm upper Ceiling rotor SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 3 Doc. No: 4812 718 11648 Technical data Potentiometer Flow rates / Inlet volume Flow meter (at 0,3 bar = quantity 1,1 l/min) Spray pump Drain pump Pump height max. Inlet valve Valve for Zone washing Valve for sieve Spray arm lower Sprayarm upper Ceiling rotor 208 ~ 70 16 1,3 4,5 30 8 33 30 8 lmp/l l/min l/min m l/min l/min l/min l/min l/min l/min Water distribution Fine sieve Self cleaning micro filter 100 % ~ 32 % Electrical data 220/230 50 2,0-2,2 10 V Hz kW A 2,0 4,3 9,0 13,3 17,5 22,2 24,2 kΩ kΩ kΩ kΩ kΩ kΩ kΩ 220/240 50/60 2,06 V Hz kΩ 220/240 50/60 3,13 V Hz kΩ 220-240 50/60 3,71 V Hz kΩ 220/240 50/60 3,83 V Hz kΩ 220/240 50/60 1,43 V Hz kΩ 220/240 50/60 5,5 V Hz kΩ Water valves Single valve at inlet hose Voltage Frequency Resistance Regenerating valve Voltage Frequency Resistance Base data Voltage Frequency Total power Fuse Position 0 Position 1 Position 2 Position 3 Position 4 Position 5 Position 6 Valve for zone washing Voltage Frequency Resistance Motor Valve for sieve Spray pump motor Voltage Power consumption HI HA Capacitor 220/230 ~190 69 36,2 4 V W Ω Ω F 220/240 146 V Ω Drain pump motor Voltage Resistance Coil of dispenser Voltage Frequency Resistance Relay Heating relay Heating Voltage Frequency Resistance 1 Element system Voltage Power consumption Resistance Heating speed Temperature on surface Double safety thermostat self reset Voltage Frequency Resistance 220/230 1,8/2,0 12,5-13,5 ~ 2,5 ~ 115 V kW Ω ˚C/min ˚C 85 ˚C 22.02.1996 / Page 4 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE Technical data Reedcontact Regeneration flow meter salt control rinse aid control Spray arm block Volume Position 0 after wash cycles water hardness NTC 15 ˚C 20 ˚C 30 ˚C 40 ˚C 50 ˚C 60 ˚C 70 ˚C 80 ˚C 85 ˚C 75 62 43 28 19 13 9 6 5 kΩ kΩ kΩ kΩ kΩ kΩ kΩ kΩ kΩ Position 1 after wash cycles water hardness Position 2 after wash cycles water hardness Position 3 after wash cycles water hardness Position 4 after wash cycles water hardness Position 5 after wash cycles water hardness Position 6 after wash cycles water hardness 300 cm -0-5 0-0,9 0-9 ˚dh mmol/l ˚Fh 6-8 6-10 1-1,8 10-18 ˚dh mmol/l ˚Fh 5-6 11-15 ˚dh 1,9-2,7 mmol/l 19-27 ˚Fh 4 16-21 ˚dh 2,8-3,7 mmol/l 28.37 ˚Fh 3 22-28 ˚dh 3,8-5,0 mmol/l 38-50 ˚Fh 2 29-35 ˚dh 5,1-6,3 mmol/l 51-63 ˚Fh 1 36-60 ˚dh 6,4-10,7mmol/l 64-107 ˚Fh Salt consumption for regeneration 77 Number of cycles with 2 kg salt 26 g SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 4 Doc. No: 4812 718 11648 Spare part list Model Service No. Version ADP 952 WHM 854295261010 854295261010 Pos. No. 12NC Code Description Pos. No. 12NC Code Description 004 0 004 1 011 0 022 0 022 1 4812 440 18952 4812 401 18402 4812 505 18369 4812 440 19362 4812 440 19361 Drip tray assy Holder Foot long Side panel left Side panel right 263 1 265 0 265 2 301 0 303 1 4812 520 48001 4812 404 48599 4812 404 48589 4812 453 79536 4812 417 58364 Ball Niro 8 D Basket adjustm. cpl. Grip basket adjustment Control panel WH Child-prooflock cpl. WH 022 2 024 0 040 1 040 2 040 3 4812 440 18953 4812 440 18948 4812 417 18774 4812 417 18773 4812 417 18784 Spacer Panel, rear Hinge left Hinge right Protector f.door (set) 305 0 322 0 331 0 332 0 350 0 4812 440 18964 4812 453 79562 4812 413 58865 4812 410 28528 4812 276 58037 Batten WH Insert panel WH Knob program cpl. WH Push button cap WH Display board (DB) 044 0 044 1 047 0 047 1 047 2 4812 492 38354 4812 492 38356 4812 404 48591 4812 401 18397 4812 404 68023 Spring f.door Spring f.cap Brake f.door Band,brake Hook 351 1 400 0 405 0 405 1 420 0 4812 381 28021 4812 259 28654 4812 360 18358 4819 515 28158 4812 121 18132 Guide,light Motor with spray pump cpl. Spray pump Gasket Capacitor 053 0 053 1 053 2 053 3 061 0 4812 440 88106 4812 440 19359 4812 440 19363 4812 440 19358 4812 466 88453 Plinth Plinth Angle iron Plinth extension Counter weight 430 0 430 1 450 0 480 0 490 0 4812 360 18357 4812 466 68506 4812 259 28657 4812 321 28364 4812 321 18019 Pump,draining Ring,sealing Heating element Cable harness set Cable,mains 5m (without plug) 065 0 103 0 120 0 120 1 130 0 4812 466 48051 4812 440 18956 4812 440 18961 4812 440 18955 4812 417 58361 Insulation Door outer WH Door,inner Batten Tilt lock 490 0 490 0 521 0 531 0 531 1 4812 321 18026 4812 401 18394 4812 214 78151 4812 273 18051 4812 273 18052 Cable,mains 3m Cable,mains 1,6m Control board (CB) kit Switch waterhardness Wheel,fingertip 131 0 175 0 175 1 175 2 191 0 4812 401 18403 4812 310 18295 4812 310 18294 4812 310 18296 4812 466 68534 Hook lock Trim,ornamental left WH Trim,ornamental right WH Trim,ornamental lower WH Gasket door 571 2 571 3 575 0 581 0 583 0 4812 281 28362 4812 281 28363 4812 281 28361 4812 349 28003 4812 271 28355 Sieve valve Valve f.zone-washing Regen.valve Counter water Switch diaphragm 192 0 200 0 241 0 241 1 241 1 4812 466 68467 4812 418 18183 4812 458 18276 4812 458 18283 4812 458 18284 Gasket, door lower Container cpl. Basket upper straight Holder cups right WH to 96/09 Holder cups right GR from 96/09 612 0 616 0 616 1 616 2 620 0 4812 280 58018 4812 281 18047 4812 271 58161 4812 271 58159 4812 218 38005 Relay heating Contact,reed salt Contact,reed rinsing agent Contact,reed User board (UB) 241 2 241 3 241 4 241 4 241 5 4812 535 78033 4812 528 88068 4812 458 18285 4812 458 18288 4812 458 18269 Bearing cupholder Wheel,basket upper (set) Cutlerycompart. GR from 96/09 Cutlerycompart. WH to 96/09 Holder cutlery compartment 623 0 633 0 680 0 680 1 681 1 4812 271 38356 4812 271 38355 4812 418 68133 4812 466 68495 4812 466 68497 Microswitch Microswitch Combidosage Gasket Gasket 241 6 241 6 241 7 241 8 242 0 4812 458 18286 4812 458 18287 4812 404 48605 4812 466 68482 4812 458 18274 Holder cups left GR from 96/09 Holder cups left WH to 96/09 Hoop Spacer cap set Basket lower cpl. 681 2 682 0 691 0 700 0 700 0 4812 440 18975 4812 466 68496 4812 282 68012 4812 530 28788 4812 530 28804 Flap Gasket Feeler NTC Hose, inlet aqua stop 2m Hose, inlet aqua stop 4,2m 242 1 242 2 242 3 243 0 243 3 4812 528 88069 4812 458 18262 4812 458 18275 4812 458 18296 4812 458 18289 Wheel,basket lower Plate,support f.basket lower Plate,support f.basket lower Basket cutlery Basket cutlery cpl. 700 1 700 2 700 3 701 1 701 2 4812 480 48019 4812 520 58002 4812 462 78307 4812 310 18153 4819 401 18423 Sieve Gasket set Reductor Yoke clamp set Holder 243 4 261 0 261 1 261 2 263 0 4812 458 18317 4819 462 38271 4819 404 48819 4812 462 78995 4819 520 18013 Bracket Rail telescope, inner Cap rail Cap rail ahead Ball cage cpl. 710 0 710 2 710 3 714 0 714 2 4812 418 68128 4819 310 38536 4819 466 69562 4812 462 78993 4812 440 18963 Monoblock Nut threaded ring set Gasket set Threaded cap Cabinet non-return flap 22.02.1996 / Page 5 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE Spare part list Model Service No. Version ADP 952 WHM 854295261010 854295261010 Pos. No. 12NC Code Description Pos. No. 12NC Code Description 716 0 716 1 716 2 721 0 721 1 4812 418 68141 4812 466 68475 4812 462 78994 4812 360 68043 4812 360 68047 Reg.dosage Gasket Cover Hub lower cpl. Arm,spray lower cpl. 901 5 901 6 901 8 902 0 902 1 4812 401 18406 4812 401 18408 4812 401 18393 4812 401 18195 4812 466 78361 Strap 028,6-708Z Strap 038,1-708Z Strap 20-32/9 Clip Fastener f.buildt-in models 721 2 721 3 721 4 722 0 722 2 4812 466 68491 4812 466 68489 4812 418 18176 4812 360 68044 4812 360 68048 Gasket 25x2,3B Gasket 76x2,5 Cabinet Arm,spray upper Hub upper straight cpl. 902 2 904 2 904 3 910 1 910 2 4812 404 78239 4812 462 79635 4812 462 79636 4812 502 18019 4812 502 18363 Holder Cover WH 3,5x5 Cover WH 3,5x4 Screw Screw 4,0x12-H 723 0 723 1 723 2 723 3 726 0 4812 360 68049 4812 466 68483 4812 404 48597 4812 505 18362 4812 530 28786 Arm,spray Gasket Clip,fix sprayarm Connect,gaspipe Tube 910 3 910 4 910 5 910 6 910 7 4812 502 18364 4812 502 18365 4812 502 18367 4812 502 18369 4812 502 38132 Screw 5x20-TORX Screw 3,5x5,5-TORX Screw 3,5x8-TORX T15 Screw A2F M4x6 Screw DIN 965 726 1 726 2 726 3 726 4 743 0 4812 530 28787 4812 505 18358 4812 466 68512 4812 462 79633 4812 511 48171 Tube Nut Gasket Centering Capacitor 911 0 964 0 964 0 964 1 993 1 4812 502 38134 4812 440 18947 4812 466 68468 4812 466 68511 4812 466 78018 Screw decor ST3,5x9,5-C-H Traverse Gasket housing ri/le Gasket housing upper Foil protection 743 1 743 3 743 4 743 7 751 0 4812 530 28102 4812 505 18364 4812 530 28807 4812 466 68514 4812 418 18169 Hose, inlet Nut Hose 9x1,5x270+10 Gasket Water collector 993 2 993 5 4812 404 48609 4822 532 80216 Socket wreng foot Funnel salt 751 1 751 2 755 0 755 2 755 3 4812 418 18171 4812 440 18954 4812 530 28785 4812 530 48136 4812 530 48137 Water guide Fastener frame Bend Tray,leak left Tray,leak right 756 0 761 0 761 1 762 0 763 0 4812 360 58099 4812 480 58061 4812 480 58072 4812 480 58055 4812 480 58057 Floater Sieve fine Sieve insert Microfilter Sieve coarse 781 0 781 1 781 2 781 3 783 0 4812 530 28737 4819 530 28286 4819 492 68405 4812 281 28364 4812 530 28792 Hose,draining Sleeve hose Clip f.non-return valve Flap non-return Hose 11,5x3x200 783 1 783 5 783 6 791 0 791 2 4812 530 28806 4812 530 28789 4812 530 28796 4812 532 68063 4812 530 58093 Hose connection Distributor Hose 10x3x180+10 Gasket Gasket 791 3 791 4 791 5 791 6 794 1 4812 466 68502 4812 466 68503 4812 466 68504 4812 466 68505 4819 530 58032 Gasket 10x3,5 Gasket Gasket Gasket Gasket 20x2,5 901 0 901 1 901 2 901 3 901 4 4812 401 18191 4812 401 18396 4812 401 18401 4812 401 18404 4812 401 18405 Strap 017,8 Strap Strap Strap 019,8-708Z Strap 025,6-708Z SERVICE Exploded view Whirlpool Europe Customer Service 22.02.1996 / Page 7 Doc. No: 4812 718 11648 22.02.1996 / Page 8 Doc. No: 4812 718 11648 Exploded view Whirlpool Europe Customer Service SERVICE Capacitor Control board Display board Drain pump motor Cleaning agent dosage Final rinse dosage Door switch Electro magnet Flow meter Heating Interference filter Water leakage switch Line Main switch Thermostat Neutral Water hardness switch Heating relay Reed relay salt Reed relay rinsaid Sprayarm blocked Sleve valve Sprayarm motor Safety thermostat Plug coupler Power supply terminal Winding protective contact User board Fan ventilator Water inlet valve Water regenerating valve Water indicator Zone washing black blue grey white C1 CB DB DPM DD DR DS EM FM HEW IF LS6 L MS NTC N RV RE2 RR2 RR3 SAB SV SPM THS TB TBL TL UB VM WV1 WV2 WI ZW 00 66 88 99 SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 9 Doc. No: 4812 718 11648 Circuit diagram 22.02.1996 / Page 10 Doc. No: 4812 718 11648 Program diagram Whirlpool Europe Customer Service SERVICE SERVICE Text/Legend Whirlpool Europe Customer Service 22.02.1996 / Page 11 Doc. No: 4812 718 11648 22.02.1996 / Page 12 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 13 Doc. No: 4812 718 11648 22.02.1996 / Page 14 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 15 Doc. No: 4812 718 11648 22.02.1996 / Page 16 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 17 Doc. No: 4812 718 11648 22.02.1996 / Page 18 Doc. No: 4812 718 11648 Whirlpool Europe Customer Service SERVICE SERVICE Whirlpool Europe Customer Service 22.02.1996 / Page 19 Doc. No: 4812 718 11648
