1
Download Installation / Troubleshooting Manual
Transcript
TROUBLESHOOTING FloNET Interface Module, Fuel-Tron Instrument BEFORE CALLING FOR ASSISTANCE, COMPLETE THESE TROUBLESHOOTING CHECKS AND RECORD YOUR FINDINGS. TECHNICAL SUPPORT REQUIRES THIS INFORMATION BEFORE A RETURN AUTHORIZATION WILL BE ISSUED. IT TAKES ABOUT 20 MINUTES AND IS VERY IMPORTANT IN ANALYZING SYSTEM PROBLEMS. FloNET Interface Module 16.5 293.7 GPH GAL BLUE COVERED SWITCH FloScan G P H TOT ORANGE VIOLET COMPUTER INTERFACE 0 GREEN 0 0 BLACK RED E D C B A F 0 1 2 3 4 5 9 8 7 16.5 Fuel-Tron 6 RECESSED ARROW NMEA 2000 Before starting, please record the FloNET Module and Fuel-Tron Instrument, (if applicable) model number, serial number and switch settings: MODEL # _______________________ SERIAL # _________________________ GREEN_______ BLACK_______ RED_______ RECESSED ARROW_______ FAULT PROBABLE CAUSE Blank FloNET Module Display Blank Fuel-Tron Display/No Backlighting High or Low Totalizer reading. Over 10%. Fluctuating GPH Readings No GPH or Totalizer Readings No Forward or Return Sensor Readings High Forward or Return Sensor Readings Network Power Reversed Defective NMEA Cable Network Power OFF Network Power Reversed Defective NMEA Cable Network Power OFF Calibration Incorrect flow sensor(s) Sensors Installed backwards Sensors Wired backwards Incorrect switch settings Vacuum leak Fine Primary Filter Dirty Primary Filter Vacuum leak / Pulsations Wiring Sensor orientation Wiring /Instrument failure Sensor Failure Vacuum Leak Incorrect switch settings Sensor orientation SEE SECTION Section II Section II Section II Section II Section II Section II Calibration sheet Section VII Wiring Diagram Calibration sheet Section V Section VII Section II, Wiring Diagram Sections IV, V Wiring Diagram Installation sheet, Section VII Sections I, II, III, VII Sections I, II, III Section V Calibration sheet Section VII 09/017/08 FloScan Instrument Company, Inc. 3016 NE Blakeley Street, Seattle, WA 98105 2000-085-00A Tel: (206) 524-6625 Email: [email protected] Fax: (206) 523-4961 Http://www.floscan.com
