Download BBK DK960S User Guide Manual Pdf
Transcript
SERVICE MANUAL Dk960S TUNED ST. 3D MEM AM ALL FM VOL1 Downloaded From TheatreSystem-Manual.com Manuals VOL2 C ONTE NTS 1. S AF E T Y P R IC AUT IONS 2. P R E V E NT ION OF E LE C T R O S TATIC DIS C HAR G E (E S D)TO E LE C T R OS TATIC ALLY 1 S E NS IT IV E (E S )DE V IC E S 1 3. C ONT R OL B UT T ON LOC AT IONS AND E XP LANAT IONS 2 4. P R E V E R TION OF S TATIC E LE C T R IC IT Y DIS C HAR G E 4 5. AS S E MB LING AND DIS AS S E MB LING T HE ME C HANIS M UNIT 5 5.1 OP T IC AL P IC K UP UNIT E XP LOS E D V IE W AND PAR T LIS T 5 5.2 B R AC K E T E XP LOS E D V IE W AND PAR T LIS T 7 5.3 MIS C E LLANE OUS 8 6. E LE C T R IC AL C ONF IR MAT ION 9 6.1 V IDE O OUT P UT (LUMINANC E S IG NAL) C ONF IR MAT ION 9 6.2 V IDE O OUT P UT (C HR OMINANC E S IG NAL) C ONF IR MATION 10 7. MP E G B OAR D C HE C K WAVE F OR M 11 8. IC B LOC K DIAG R AM & DE S C R IP T ION 12 8.1 MT 1336 12 8.2 MT 1379 20 8.3 U214 HY 29F 800 36 8.4 HY57V641620HG 39 9. S C HE MAT IC & P C B WIR ING DIAG R AM 42 10. S PAR E PAR T S LIS T 59 Downloaded From TheatreSystem-Manual.com Manuals 1. SAFETY PREAUTIONS 1.1 GENERAL GUIDELINES 1. When servicing, observe the original lead dress. if a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barrier, insulation papers shields are properly installed. 3. After servicing, make the following leakage current checks to prevent the customer from being exposed to shock hazards. 2.PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO ELECTROSTATICALLY SENSITIVE(ES)DEVICES Some semiconductor(solid state)devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive(ES)Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor chip components. The following techniques should be used to help reduce the incidence of component damage caused by electro static discharge(ESD). 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially availabel discharging ESD wrist strap, which should be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ES devices,place the assembly on a conductive surface such as alminum foil, to prevent electrostatic charge buildup or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static (ESD protected)can generate electrical charge sufficient to damage ES devices. 5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES devices. 6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, alminum foil or comparable conductive material). 7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed. Caution Be sure no power is applied to the chassis or circuit, and observe all other safety precautions. 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity(ESD). notice (1885x323x2 tiff) 1 Downloaded From TheatreSystem-Manual.com Manuals 3.Control Button Locations and Explanations Front Panel Illustration 3 2 4 TUNED 5 ST. 3D MEM AM ALL FM VOL1 6 7 8 9 10 11 12 13 14 VOL2 15 POWER switch 6 PLAY button 11 DVD MODE: NEXT button TUNER MODE: TUNING button 2 Disc tray 7 STOP button 12 MIC 1 jack 3 OPEN/CLOSE button 8 FUNCTION button 13 MIC 2 jack 4 VFD display window 9 DVD MODE: PAUSE button TUNER MODE: BAND button 14 MIC VOLUME 1 knob 5 VOLUME knob DVD MODE PREV button TUNER MODE TUNING button 15 MIC VOLUME 2 knob 10 2 Downloaded From TheatreSystem-Manual.com Manuals Control Button Locations and Explanations (Continued) STANDBY button Remote Control Illustration Enter or exit the standby mode. 2 AUDIO button Change the audio language. 3 EJECT STANDBY 39 AUDIO SUBTITLE ANGLE FUNCTION 2 38 3 37 1 4 3 2 4 5 6 7 8 9 0 +10 GOTO PANEL P/N ZOOM OSD 5 Open/close the virtual keyboard function. 6 36 34 33 7 8 10 PLAY PAUSE SLOW REPEAT MIC 15 16 17 18 VOCAL A-B INFO SLEEP PRESET MUTE SAVE TUNING SPEAKERS 13 Slow playback. MIC button 30 15 REPEAT button 29 16 28 17 27 26 25 Q-PLAY Repeat playback. TREBLE SLEEP button Sleep timer. VOCAL Button Select the Karaoke sing-along mode 18 SAVE/LOGO button Stations saving button, up to 20 FM/AM stations can be saved respectively/Set the played image as the power-on logo 19 BASS SLOW button 14 MAN/AUTO BAND PAUSE button Karaoke operation menu. LOGO 19 20 PLAY button Normal playback. STOP MAIN VOL 13 14 SELECT button SETUP button Pause playback. 32 RETURN 31 11 12 DIRECTION ARROWS Function setup. 11 SELECT SETUP TITLE button UP/DOWN/LEFT/RIGHT DIRECTION ARROW. 9 12 9 10 P/N button DVD titles. MENU 8 NUMBERED buttons PANEL button Switch the TV system between PAL, NTSC and AUTO. 35 TITLE Change subtitle languages/Switch JPEG display modes. 4 7 5 6 SUBTITLE button VOL TUNING +/- buttons Tuning up/down stations. PS/IS 24 21 23 22 20 FWD/REW button Fast forward/backward playback. MAN/AUTO buttou/Q-PLAY button Manual/automatic tuning switch/Skip the advertisement/ warning and play the DVD directly. 21 BAND button/IS/PS button FM/AM switch/Switch Video output to the interlacing mode./Switch video to the progressive Y Pb Pr mode. 22 BASS +/- button Increase/decrease bass. 23 32 Increase/decrease treble. RETURN button 24 Back to the previous menu. 33 25 26 PREVIOUS/NEXT button OSD button Select previous/next chapter or track when playing. 27 GOTO button 28 27 FUNCTION button Downloaded From TheatreSystem-Manual.com Manuals INFO button Switch new user interface. A-B button Repeat the selected section A-B. EJECT button Open/Close the disc tray. 29 27 30 DISC/RADIO/AUX IN switch. 39 MAIN VOL button Increase/decrease the master volume. ANGLE button Camera angles switch, MP3/JPEG playback modes switch. 38 MUTE button Turn off/on audio outputs Play from the desired point. 37 PRESET +/- button Select the preset channels. Display the disc information. 36 SPEAKERS button Select power amplifier's channel volume. ZOOM button Zoom in/out the playing frame. 35 VOL +/- button Increase/decrease power amplifier's channel volume. MENU button Display the disc menu, PBC ON/OFF button. 34 TREBLE +/- button 31 3 STOP button Stop playback. 4.PREVENTION OF STATIC ELECTRICITY DISCHARGE The laser diode in the traverse unit (optical pickup)may brake down due to static electricity of clothes or human body. Use due caution to electrostatic breakdown when servicing and handling the laser diode. 4.1.Grounding for electrostatic breakdown prevention Some devices such as the DVD player use the optical pickup(laser diode)and the optical pickup will be damaged by static electricity in the working environment.Proceed servicing works under the working environment where grounding works is completed. 4.1.1. Worktable grounding 1. Put a conductive material(sheet)or iron sheet on the area where the optical pickup is placed,and ground the sheet. 4.1.2.Human body grounding 1 Use the anti-static wrist strap to discharge the static electricity from your body. safety_3 (1577x409x2 tiff) 4.1.3.Handling of optical pickup 1. To keep the good quality of the optical pickup maintenance parts during transportation and before installation, the both ends of the laser diode are short-circuited.After replacing the parts with new ones, remove the short circuit according to the correct procedure. (See this Technical Guide). 2. Do not use a tester to check the laser diode for the optical pickup .Failure to do so willdamage the laser diode due to the power supply in the tester. 4.2. Handling precautions for Traverse Unit (Optical Pickup) 1. Do not give a considerable shock to the traverse unit(optical pickup)as it has an extremely high-precise structure. 2. When replacing the optical pickup, install the flexible cable and cut is short land with a nipper. See the optical pickup replacement procedure in this Technical Guide. Before replacing the traverse unit, remove the short pin for preventingstatic electricity and install a new unit.Connect the connector as short times as possible. 3. The flexible cable may be cut off if an excessive force is applied to it.Use caution when handling the cable. 4. The half-fixed resistor for laser power adjustment cannot be adjusted. Do not turn the resistor. 4 Downloaded From TheatreSystem-Manual.com Manuals 5. Assembling and disassembling the mechanism unit 5.1 Optical pickup Unit Explosed View and Part List Pic (1) 5 Downloaded From TheatreSystem-Manual.com Manuals Materials to Pic (1) No. PARTS CODE PARTS NAME Q ty 14692200 SF-HD60 1 1 1EA0311A06300 ASSY, CHASSIS, COMPLETE 1 2 1EA0M10A15500 ASSY, MOTOR, SLED 1 Or 1EA0M10A15501 ASSY, MOTOR, SLED 1 3 1EA2451A24700 HOLDER, SHAFT 3 4 1EA2511A29100 GEAR, RACK 1 5 1EA2511A29200 GEAR, DRIVE 1 6 1EA2511A29300 GEAR, MIDDLE, A 1 7 1EA2511A29400 GEAR, MIDDLE, B 1 8 1EA2744A03000 SHAFT, SLIDE 1 9 1EA2744A03100 SHAFT, SLIDE, SUB 1 10 1EA2812A15300 SPRING, COMP, TYOUSEI 3 11 1EA2812A15400 SPRING, COMP, RACK 1 21 1EA0B10B20100 ASSY, PWB 1 Or 1EA0B10B20200 ASSY, PWB 1 31 SEXEA25700--- SPECIAL SCREW BIN+-M2X11 3 32 SEXEA25900--- SPECIAL SCREW M1.7X2.2 2 33 SFBPN204R0SE- SCR S-TPG PAN 2X4 2 34 SFSFN266R0SE- SCR S-TPG FLT 2.6X6 1 35 SWXEA15400--- SPECIAL WASHER 1.8X4 X0.25 2 Note : This parts list is not for service parts supply. 6 Downloaded From TheatreSystem-Manual.com Manuals 5.2 Bracket Explosed View and Part List Pic (2) Materials to Pic(2) 1.bracket 2.belt 3.screw 4.belt wheel 5.gearwheel 6.iron chip 7. Immobility mechanism equipment 8. Magnet 9. Platen 10. Bridge bracket 11. screw 12. screw 13. Big bracket 14. front silicon rubber 15. Back silicon rubber 16. Pick-up 17. Pick-up 18. switch 19. Five-pin flat plug 20. screw 21. PCB 22. motor 23. Motor wheel 24. screw 25.tray Before going process with disassembly and installation, please carefully both peruse the chart and confirm the materials. 7 Downloaded From TheatreSystem-Manual.com Manuals 5.3 MISCELLANEOUS 5.3.1 Protection of the LD(Laser diode) Short the parts of LD circuit pattern by soldering. 5.3.2 Cautions on assembly and adjustment Make sure that the workbenches,jigs,tips,tips of soldering irons and measuring instruments are grounded,and that personnel wear wrist straps for ground. Open the LD short lands quickly with a soldering iron after a circuit is connected. Keep the power source of the pick-up protected from internal and external sources of electrical noise. Refrain from operation and storage in atmospheres containing corrosive gases (such as H2S,SO2, NO2 and Cl2)or toxic gases or in locations containing substances(especially from the organic silicon,cyan, formalin and phenol groups)which emit toxic gases.It is particularly important to ensure that none of the above substances are present inside the unit.Otherwise,the motor may no longer run. 8 Downloaded From TheatreSystem-Manual.com Manuals 6.Electrical Confirmation 6.1. Video Output (Luminance Signal) Confirmation DO this confirmation after replacing a P.C.B. Measurement point Mode Disc Video output terminal Color bar 75% PLAY(Title 46):DVDT-S15 PLAY(Title 12):DVDT-S01 DVDT-S15 or DVDT-S01 Measuring equipment,tools Confirmation value 200mV/dir,10 sec/dir 1000mVp-p±30mV Purpose:To maintain video signal output compatibility. 1.Connect the oscilloscope to the video output terminal and terminate at 75 ohms. 2.Confirm that luminance signal(Y+S)level is 1000mVp-p±30mV 9 Downloaded From TheatreSystem-Manual.com Manuals 6.2 Video Output(Chrominance Signal) Confirmation Do the confirmation after replacing P.C.B. Measurement point Mode Disc Video output terminal Color bar 75% PLAY(Title 46):DVDT-S15 PLAY(Title 12):DVDT-S01 DVDT-S15 or DVDT-S01 Measuring equipment,tools Screwdriver,Oscilloscope 200mV/dir,10 sec/dir Confirmation value 621mVp-p±30mV Purpose:To maintain video signal output compatibility. 1.Connect the oscilloscope to the video output terminal and terminate at 75 ohme. 2.Confirm that the chrominance signal(C)level is 621 mVp-p±30mV 10 Downloaded From TheatreSystem-Manual.com Manuals 7.MPEG BOARD CHECK WAVEFORM 7.1 27MHz WAVEFORM DIAGRAM 7.2 IC5L0380R PIN.2 WAVEFORM DIAGRAM 11 Downloaded From TheatreSystem-Manual.com Manuals MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE 8. IC BLOCK DIAGRAM & DESCRIPTION 8.1 MT1336 GENERAL DESCRIPTION M T 1 3 3 6 i s a h i g h p e r f o r m a n c e C M O S a n a l o g f r o n t -e n d I C f o r b o t h C D _ R O M d r i v e r u p t o 4 8 X S a n d D V D - R O M d r i v e r u p t o 1 6 X S . I t a l s o s u p p o r t s D V D- R A M r e a d u p t o 4 X S V e r s i o n 2 . I t c o n t a i n s s e r v o a m p li f i e r s t o g e n e r a t e f o c u s i n g e r r o r , 3-b e a m t r a c k i n g e r r o r , 1 b e a m r a d i a l p u s h -p u l l s i g n a l , R F l e v e l a n d S B A D f o r s e r v o f u n c t i o n s . I t a l s o i n c l u d e s D P D t r a c k i n g e r r o r s i g n a l f o r D V D _ R O M a p p l i c a t i o n . F o r D V D- R A M d i s k s , t h e r e a r e a l s o D i f f e r e n t i a l P u s h -P u l l ( D P P ) m e t h o d f o r g e n e r a t i n g t r a c k i n g s i g n a l a n d D i f f e r e n t i a l A s t i g m a t i c D e t e c t i o n (DAD) for processing focusing signal. Programmable equalizer and AGC circuits are also incorporated in this chip to optimize read channel performance. In addition, this chip has dual automatic laser power control circuits f o r D V D- R O M ( D V D-R A M ) and C D -R O M s e p e r a t e l y a n d r e f e r e n c e v o l t a g e g e n e r a t o r s t o r e d u c e e x t e r n a l c o m p o n e n t s . P r o g r a m m a b l e f u n c t i o n s a r e i m p l e m e n t e d b y t h e a c c e s s o f i n t e r n a l r e g i s t e r t h r o u g h b i -d i r e c t i o n a l serial port to configure modes selection. FEATURES n RF equalizer with programmable fc from 3MHz to 70 MHz and programmable boost from 3dB to 13dB. n M T 1 3 3 6 s u p p o r t s a t l e a s t e i g h t d i f f e r e n t k i n d s o f p i c k-u p h e a d s w i t h v e r s a t i l e i n p u t c o n f i g u r a t i o n f o r both RF input stages and servo signal blocks. n Versatile on -line AGC. n 3 beams tracking error signal generator for CD_ROM application. n One beam differential phase tracking error (DPD) generator for DVD_ROM application. n Differential push pull tracki ng error (DPP) generator for DVD_RAM application. n Focusing error signal generator for CD-ROM, DVD-ROM and DVD-RAM (DAD method). n RF level signal generator. n Sub-beam added signal for 3 beams CD_ROM. n One beam push -pull signal generator for central servo application. n High speed RF envelop detection circuit with bandwidth up to 400KHz for CD-ROM. n Defect and Blank detection circuits. n Dual automatic laser power control circuits with programmable level of LD monitor voltage. n Vref=1.4V voltage and V2ref=2.8V voltage generators. n V20=2.0V voltage for pick -up head reference. n Bi-directional serial port to access internal registers. 12 Downloaded From TheatreSystem-Manual.com Manuals MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE OSP DVDA OSN CDA DVDB RFOP ATTENUATOR INPUT MUX VGA EQ RFON CDB DVDC LRFRP CDC DEFECT DVDD HRFRP CDD DVDRFIN CRTP ENVELOP CRTPLP DETECTOR DVDRFIP AGC MA CSO MB MC LVL MD DPD SA TEO SB FEO SC REFCOS SD SBAD PCS HALLCOS COSPHI DPFN REFSIN DPFO HALLSIN IR SINPHI DPDMUTE TE DVD MDI2 APC TPI TNI LDO2 CDFOP RF CDFON LEVEL RFGC RFGCU MDI1 CD FE RFGCI APC AGC1 LDO1 AGC2 CENTRAL AGC3 SERVO RFSUBO WOBSO UDGATE IDGATE WOBBLE VFO13 DET SDATA SERIAL V20 REF and 2VREF V2REFO PORT Voltage Generator VREFO MT1336 FUNCTION BLOCKS DIAGRAM 13 Downloaded From TheatreSystem-Manual.com Manuals SLCK SDEN MT1336 CDFOP SD SC AVDD IR AGND SB SA MD MC TNI TPI SVDD CDFON WAGND SGND WAVDD AGC1 MDI2 AGC3 AGC2 LDO2 LDO1 MDI1 MTK CONFIDENTIAL, NO DISCLOSURE 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105 104 103 WGND RFSUBO PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MT1336 DVD-ROM With DVD_RAM Read GND UDGATE HDGATE IO0 IO1 IO2 IO3 IO4 IO5 IO6 IO7 IO8 IO9 IOA IOB VDDS XCK16M SCLK AVDDT V2REFO VREFO V20 FEO LVL CSO TEO VDDP DEFECT LRFRP HRFRP CRTP CRTPLP TRLPA TRLP HTRC GNDP DPFN DPFO AGNDX AGNDX AGNDX VDD VFO13 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 MT1336 PIN ASSIGNMENT 14 Downloaded From TheatreSystem-Manual.com Manuals AGNDP AGNDX AVDDP AGNDT TM4 DPDMUTE TM1 TM2 TM3 GNDS SDEN SDATA RST RFOP RFON AGNDO 1 2 3 4 5 6 7 8 9 10 11 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 WOBSO WVDD AGNDX AGNDX AVDDO 102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 MB MA DVDA DVDB DVDC DVDD DVDRFIP DVDRFIN CDA CDB CDC CDD OSN OSP RFGC RFGCU RFGCI CEQP CEQN AGNDX AGNDX MON MOP SW1 SW2 SWO SINPHI REFSIN HALLSIN AGNDM REFCOS HALLCOS COSPHI AVDDM AGNDX AVDDF VCON AGNDF MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE MT1336 PIN DESCRIPTIONS Pin Numbers Symbol Type Description DEFECT Digital Output 56 SCLK Digital Input RF serial clock input 58 SDEN Digital Input RF serial data enable 59 SDATA Digital IO 60 RST Digital input Reset (active high) 55 XCK16M Digital Input 16.9MHz for verification LQFP128 RF Flag Interface 23 Flag of bad data output status RF SIO interface RF serial data IO RF SERVO interface 40 UDGATE Digital Input Con trol signal for DVD-RAM 41 IDGATE Digital Input Control signal for DVD -RAM 38 VFO13 Digital Input DVD -RAM Header signal RF 100 DVDA Analog input AC coupled DVD RF signal input A 99 DVDB Analog Input AC coupled DVD RF signal input 98 DVDC Analog Input AC coupled DVD RF signal input C 97 DVDD Analog Input AC coupled DVD RF signal input D 95 DVDRFIN Analog Input AC coupled DVD RF signal input RFIN 96 DVDRFIP Analog Input AC coupled DVD RF signal input RFIP 94 CDA Analog Input AC coupled CD RF signal input A 93 CDB Analog Input AC coupled CD RF signal input B 92 CDC Analog Input AC coupled CD RF signal input C 91 CDD Analog Input AC coupled CD RF signal input D 90 OSN Analog RF Offset cancellation capacitor connecting 89 OSP Analog RF Offset cancellation capacitor connecting 85 CEQP Analog RF Offset cancellation capacitor connecting 84 CEQN Analog RF Offset cancellation capacitor connecting 88 RFGC Analog RF AGC loop capacitor connecting for DVD -ROM 15 Downloaded From TheatreSystem-Manual.com Manuals B MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE 87 RFGCU Analog RF AGC loop capacitor connecting for DVD -RAM 86 RFGCI Analog RF AGC loop capacitor connecting for DVD -RAM 101 MA Analog Input DC coupled DVD-RAM main-beam RF signal input A 102 MB Analog Input DC coupled DVD-RAM main-beam RF signal input B 103 MC Analog Input DC coupled DVD-RAM main-beam RF signal input C 104 MD Analog Input DC coupled DVD-RAM main-beam RF signal input D 105 SA Analog Input DC coupled DVD-RAM sub-beam RF signal input A 106 SB Analog Input DC coupled DVD-RAM sub-beam RF signal input B 110 SC Analog Input DC coupled DVD-RAM sub-beam RF signal input C 111 SD Analog Input DC coupled DVD-RAM sub-beam RF signal input D 108 IR Analog External current bias resistor (R=20K) 119 AGC1 Analog Wobble AGC loop1 capacitor 121 AGC2 Analog Wobble AGC loop2 capacitor 122 AGC3 Analog Wobble AGC loop3 capacitor 127 RFSUBO Analog output Header push-pull RF output signal 1 WOBSO Digital output Wobble signal output 6 RFOP Analog output RF positive output 7 RFON Analog output RF negative output 32 DPFN Analog DPD amplifier negative input 33 DPFO Analog DPD amplifier output 61 DPDMUTE Digital input DPD mute control input 116 TNI Analog Input 3 beam satellite PD signal negative input 115 TPI Analog Input 3 beam satellite PD signal positive input 21 TEO Analog Output TRACKING ERROR FOCUSING ERROR & RF LEVEL Tracking error output & CENTRAL SERVO SIGNAL 112 CDFOP Analog Input CD focusing error positive input 113 CDFON Analog Input CD focusing error negative input 18 FEO Analog Output Focusing error output 19 LVL Analog Output RF level output 20 CSO Analog output Central servo signal output ALPC 16 Downloaded From TheatreSystem-Manual.com Manuals MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE 124 MDI1 Analog Input 125 LDO1 Analog Ou tput 123 MDI2 Analog Input 126 LDO2 Analog Output 26 CRTP Analog RF top envelop filter capacitor connecting 27 CRTPLP Analog Defect level filter capacitor connecting 25 HRFRP Analog output High frequency RF ripple output or Blank detector’s output 24 LRFRP Analog output Low frequency RF ripple output 67, 69 AVDD Power 65, 73 AGND GND 64 AVDD Power DPD Power 62 AGND GND DPD GND 109 AVDD Power 107 AGND GND RF path GND 114 SVDD Power Servo Power 117 SGND GND 2,120 WAVDD Power 128,118 WAGND GND 5 AVDDO Power Power for RF output 8 AGNDO GND GND for RF output 14 AVDDT Power 12 AGNDT GND GND for Trimming PAD 22 VDDP Power Peak Detection Power 31 GNDP GND Peak Detection GND 37,54 VDD Power Serial I/O Power 39,57 GND GND Serial I/O GND Laser power monitor input Laser driver output Laser power monitor input Laser driver output RF RIPPLE POWER Master PLL Filter power GND for Master PLL Filter RF path Power Servo GND Wobble Power Wobble GND Power for Trimming PAD REFERENCE VOLTAGE 16 VREFO Analog output Reference voltage 1.4V 15 V2REFO Analog output Reference voltage 2.8V 17 V20 Analog Output Reference voltage 2.0V 17 Downloaded From TheatreSystem-Manual.com Manuals MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE ALPC TRIMMING 9 TM1 Analog input Trimming pin for ALPC1 10 TM2 Analog input Trimming pin for ALPC1 11 TM3 Analog input Trimming pin for ALPC2 13 TM4 Analog input Trimming pin for ALPC2 HIGH SPEED TRACK COUNTING 29 TRLP Analog Low-pass filter capacitor connecting 28 TRLPA Analog Low-pass filter capacitor connecting 30 HTRC Digital output High speed track counting digital output 74 HALLSIN Analog input Negative input of amplifier for hall sensor signal 75 REFSIN Analog input Positive input of amplifier for hall sensor signal 76 SINPHI Analog output Amplifier output for hall sensor signal 71 HALLCOS Analog input Negative input of amplifier for hall sensor signal 72 REFCOS Analog input Positive input of amplifier for hall sensor signal 70 COSPHI Analog output Amplifier output for hall sensor signal PCS FOR MONITOR ONLY 81 MON Analog output 80 MOP Analog output 66 VCON Analog output 77 SWO Analog output Output from mux of SW1 & SW2 78 SW2 Analog input External input for servo input select 79 SW1 Analog input External input for servo input select FOR SERIAL I/O 42 IO0 43 IO1 44 IO2 45 IO3 46 IO4 47 IO5 18 Downloaded From TheatreSystem-Manual.com Manuals MT1336 PRELIMINARY, SUBJ ECT TO CHANGE WITHOUT NOTICE 48 IO6 49 IO7 50 IO8 51 IO9 52 IOA 53 IOB MTK CONFIDENTIAL, NO DISCLOSURE 19 Downloaded From TheatreSystem-Manual.com Manuals MT1379 Progressive Scan DVD Player Combo Chip Specificationsaresubjecttochangewithoutnotice 8.2 MT1379 n Super Integration DVD player single chip § Servo controller and data channel processing § MPEG-1/MPEG-2/JPEG video decoding Dolby AC-3/DTS/DVD -Audio audio decoding § § § § § § Built-in TV encoder Built-in progressive video output § Video input port and audio/SPDIF input port § § § § § § Built-in DSP for digital servo control § Built-in 8032 micro controller § Built-in internal 373 and 8-bit programmable lower address port § 1024-bytes on-chip RAM Up to 2M bytes FLASH-programming interface Supports 5/3.3-Volt. FLASH interface § § § § Built-in a frequency programmable clock to µP and RSPC Decoder to optimize the performance over power § § § Provides interface with analog front-end processor Analog data slicer for small jitter capability § § Built-in high performance data PLL for chann el data demodulation § EFM/EFM+ data demodulation Enhanced channel data frame sync protection & DVD-ROM sector sync protection § § § n Servo Control and Spindle Motor Control § § Programmable frequency error gain and phase error gain of spindle PLL to control spindle motor on CLV and CAV mode Provide a varipitch speed control for CLV and CAV mode Built-in ADCs and DACs for digital servo control § Provide 2 general PWM § 20 Downloaded From TheatreSystem-Manual.com Manuals Supports power-down mode Supports additional serial port n DVD-ROM/CD-ROM Decoding Logic DVD-ROM up to 8XS CD-ROM up to 24XS n Channel Data Processor § § § n Speed Performance on Servo and Decoding § Tray control can be PWM output or digital output n Host Micro controller Unified track buffer and A/V decoding buffer Video processing for scaling and video quality enhancement OSD & Sub-picture decoding Built-in clock generator § § Supports CD-ROM Mode 1, CD-ROM XA Mode 2 Form 1, CD-ROM XA Mode 2 Form 2, and CD-DA formats High-speed ECC logic capable of correcting one error per each P-codeword or Q-codeword Automatic sector Mode and Form detection Automatic sector Header verification 8-bit counter for decode completion check Programmable descrambling and error correction schemes Automatically repeated error corrections 8-bit C2 Pointer counter Decoder Error Notification Interrupt that signals various decoder errors Provide error correction acceleration n Buffer Memory Controller § Supports 16Mb/32Mb/64Mb/128Mb SDRAM § § Supports 16-bit/32-bit SDRAM data bus interface Build in a DRAM interface programmable clock to optimize the DRAM performance Provide the self-refresh mode SDRAM § Programmable DRAM access cycle and refresh § MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE § MTK CONFIDENTIAL, NO DISCLOSURE § cycle timings Block-based sector addressing § § Programmable buffering counter for buffer status tracking § Maximum DRAM speed is 133MHz Support 5/3.3-Volt. DRAM Interface § § § n Video Decode § § Decodes MPEG1 video and MPEG2 main level, main profile video (720/480 and 720x576) Maximum input bit-rate of 15Mbits/sec § Smooth digest view function with I, P and B picture decoding § Baseline, extended-sequential and progressive JPEG image decoding § RLE and non-RLE BMP image decoding Support CD-G titles § § § § § § § § § § HDCD certified § Six 54MHz/12bit DA converters Support NTSC, PAL-BDGHI, PAL-N, PAL-M interlace TV format and 480p, 576p progressive TV format Automatically turn off unconnected channel(s). Support PC monitor (VGA) § Support Macrovision 7.1 § 256/16 color RLC format OSD Automatic scrolling of OSD image § Provides 4 -color/32x32-pixel hardware cursor Fade-in, Fade out, and Wipe functions as specified in the DVD-Audio Specification and other slide show transition effects Progressive scan output n Progressive Output § Automatic detect film or video source § 3:2 pull down source detection Advanced Motion adaptive de-interlace Minimum external memory requirement § Decoder format supports: - Dolby Digital (AC -3) decoding § n Audio/Video Output § - MPEG-1 layer 1/layer 2 audio decoding - MPEG-2 layer1/layer2 2 -channel audio decoding - Dolby Pro Logic decoding - High Definition Compatible Digital (HDCD) decoding § § Line-in/SPDIF-in for versatile audio processing CCIR601/656 video input port Support picture-in-picture for video decoding and input source n Outline Up to 6 channel linear PCM output for DVD Audio / DVD Video 21 Downloaded From TheatreSystem-Manual.com Manuals § § - DTS decoding - MLP decoding for DVD -Audio § Karaoke functions - Microphone echo with adjustable echo level, echo -depth and delay length - Microphone tone control with three custom second-order IIR filter - Vocal mute/vocal assistant - Key shift up to +/- 8 keys controlled by 1/2 key n TV Encoder Arbitrary ratio vertical/horizontal scaling of video, from 0.25X to 256X 65535/256/16/4/2-color bitmap format OSD, n Audio Processing § - PCM / bit stream / mute mode - Custom IEC latency up to 2 frames Pink noise and white noise generator Channel equalizer 3D surround processing include virtual surround and speaker separation Power-down control § n Video/OSD/SPU/HLI Processor Downmix function Support IEC 60958/61937 output § § 216-pin LQFP package 3.3/2.5-Volt. Dual operating voltages MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE P IN D EFINITIONS Pin Number Symbol Type 1 IREF Analog Input 2 3 4 5 6 7 8 9 10 11 12 13 14 PLLVSS LPIOP LPION LPFON LPFIP LPFIN LPFOP JITFO JITFN PLLVDD3 FOO TRO TROPENPWM Ground Analog Output Analog Output Analog output Analog Input Analog Input Analog Output Analog Output Analog Input Power Analog Output Analog Output Analog Output 15 16 17 18 19 20 21 22 PWMOUT1 PWMOUT2 DVDD2 DMO FMO DVSS FG HIGHA0 23 HIGHA1 24 HIGHA2 25 HIGHA3 26 HIGHA4 27 HIGHA5 28 DVSS Analog Output Analog Output Power Analog Output Analog Output Ground Input Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Grou nd Description Current reference input. It generates reference current for data PLL. Connect an ext ernal 100K resistor to this pin and PLLVSS. Ground pin for data PLL and related analog circuitry Positive output of the low pass filter Negative output of the low pass filter Negative output of loop filter amplifier Positive input of loop filter amplifier Negative input of loop filter amplifier Positive output of loop filter amplifier RF jitter meter output Negative input of the operation amplifier for RF jigger meter 3.3V power pin for data PLL and related analog circuitry Focus servo output. PDM output of focus servo compensator Tracking servo output. PDM output of tracking servo compensator Tray open output, controlled by microcontroller. This is PWM output for TRWMEN27hRW2=1 or is digital output for TRWMEN27hRW2=0 The 1st general PWM output The 2nd general PWM output 2.5V power pin for internal fully digital circuitry Disk motor control output. PWM output Feed motor control. PWM output Ground pin for internal fully digital circuitry Motor Hall sensor input Microcontroller address 8 Microcontroller address 9 Microcontroller address 10 Microcontroller address 11 Microcontroller address 12 Microcontroller address 13 Ground pin for internal digital circuitry 22 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 29 HIGHA6 30 HIGHA7 31 AD7 32 AD6 33 AD5 34 AD4 35 36 DVDD3 AD3 37 AD2 38 AD1 39 AD0 40 IOA0 41 IOA1 42 43 DVDD2 IOA2 44 IOA3 45 IOA4 46 IOA5 47 IOA6 Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR Inout 2~16MA, SR Inout 2~16MA, SR Inout 2~16MA, SR Power Inout 2~16MA, SR Inout 2~16MA, SR Inout 2~16MA, SR Inout 2~16MA, SR Inout 2~16MA, SR PU Inout 2~16MA, SR PU Power Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Inout 2~16MA, SR PU Description Microcontroller address 14 Microcontroller address 15 Microcontroller address/data 7 Microcontroller address/data 6 Microcontroller address/data 5 Microcontroller address/data 4 3.3V power pin for internal digital circuitry Microcontroller address/data 3 Microcontroller address/data 2 Microcontroller address/data 1 Microcontroller address/data 0 Microcontroller address 0 / IO Microcontroller address 1 / IO 2.5V power pin for internal digital circuitry Microcontroller address 2 / IO Microcontroller address 3 / IO Microcontroller address 4 / IO Microcontroller address 5 / IO Microcontroller address 6 / IO 23 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 48 IOA7 49 A16 50 A17 51 IOA18 52 IOA19 53 IOA20 54 55 56 APLLVSS APLLVDD3 ALE 57 IOOE# 58 IOWR# 59 IOCS# 60 61 DVSS UP1_2 62 UP1_3 63 UP1_4 64 UP1_5 65 UP1_6 66 DVDD3 Inout 2~16MA, SR PU Output 2~16MA, SR Output 2~16MA, SR Inout 2~16MA, SR SMT Inout 2~16MA, SR SMT Inout 2~16MA, SR SMT Ground Power Inout 2~16MA, SR PU, SMT Inout 2~16MA, SR SMT Inout 2~16MA, SR SMT Inout 2~16MA, SR PU, SMT Ground Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Power Description Microcontroller address 7 / IO Flash address 16 Flash address 17 Flash address 18 / IO Flash address 19 / IO Flash address 20 / IO OR Videoin Data PortB 0 Ground pin for audio clock circuitry 3.3V Power pin for audio clock circuitry Microcontroller address latch enable Flash output enable, active low / IO Flash write enable, active low / IO Flash chip select, active low / IO Ground pin for internal digital circuitry Microcontroller port 1 -2 Microcontroller port 1 -3 Microcontroller port 1 -4 Microcontroller port 1 -5 Microcontroller port 1 -6 3.3V power pin for internal digital circuitry 24 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 67 UP1_7 68 UP3_0 69 UP3_1 70 INT0# 71 IR 72 73 74 75 DVDD2 UP3_4 UP3_5 UWR# 76 URD# 77 78 79 80 81 82 83 84 85 86 87 DVSS RD7 RD6 RD5 RD4 DVDD2 RD3 RD2 RD1 RD0 RWE# 88 CAS# 89 RAS# 90 RCS# 91 BA0 92 93 DVSS RD15 Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Inout 4MA, SR PU, SMT Inout 2~16MA, SR PU, SMT Input SMT Power Inout Inout Inout 2~16MA, SR PU, SMT Inout 2~16MA, SR PU, SMT Ground Inout Inout Inout Inout Power Inout Inout Inout Inout Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Ground Inout 2~16MA, SR PU/PD, SMT Description Microcontroller port 1 -7 Microcontroller port 3 -0 Microcontroller port 3 -1 Microcontroller interrupt 0, active low IR control signal input 2.5V power pin for internal digital circuitry Microcontroller port 3 -4 Microcontroller port 3 -5 Microcontroller write strobe, active low Microcontroller read strobe, active low Ground pin for internal digital circuitry DRAM data 7 DRAM data 6 DRAM data 5 DRAM data 4 2.5V power pin for internal digital circuitry DRAM data 3 DRAM data 2 DRAM data 1 DRAM data 0 DRAM Write enable, active low DRAM columnaddress strobe, active low DRAM row address strobe, active low DRAM chip select, active low DRAM bank address 0 Ground pin for internal digital circuitry DRAM data 15 25 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 94 RD14 95 RD13 96 RD12 97 98 DVDD3 RD11 99 RD10 100 RD9 101 RD8 102 103 DVSS CLK 104 CLE 105 RA11 106 RA9 107 RA8 108 109 110 DMVDD3 DMVSS RA7 111 112 DVDD3 RA6 113 RA5 114 RA4 115 116 DVSS DQM1 Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Power Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Ground Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Power Ground Output 2~16MA, SR Power Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Ground Output 2~16MA, SR Description DRAM data 14 DRAM data 13 DRAM data 12 3.3V power pin for internal digital circuitry DRAM data 11 DRAM data 10 DRAM data 9 DRAM data 8 Ground pin for internal digital circuitry DRAM clock DRAM clock enable DRAM address bit 11 or audio serial data 3 (channel 7/8) DRAM address 9 DRAM address 8 3.3V Power pin for DRAM clock circuitry Ground pin for DRAM clock circuitry DRAM address 7 3.3V power pin for internal digital circuitry DRAM address 6 DRAM address 5 DRAM address 4 Ground pin for internal digital circuitry Mask for DRAM input/output byte 1 26 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 117 DQM0 118 BA1 119 RA10 120 121 DVDD2 RA0 122 RA1 123 RA2 124 RA3 125 126 DVSS RD31 127 RD30 128 RD29 129 RD28 130 131 DVDD3 RD27 132 RD26 133 RD25 134 RD24 135 136 DVSS DQM3 137 DQM2 Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Power Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Output 2~16MA, SR Ground Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Power Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Ground Output 2~16MA, SR Output 2~16MA, SR Description Mask for DRAM input/output byte 0 DRAM bank address 0 DRAM address10 2.5V power pin for internal digital circuitry DRAM address 0 DRAM address 1 DRAM address 2 DRAM address 3 Ground pin for internal digital circuitry DRAM data 31 DRAM data 30 DRAM data 29 DRAM data 28 3.3V power pin for internal digital circuitry DRAM data 27 DRAM data 26 DRAM data 25 DRAM data 24 Ground pin for internal digital circuitry Mask for DRAM input/output byte 3 Mask for DRAM input/output byte 2 27 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 138 RD23 139 RD22 140 141 DVDD2 RD21 142 RD20 143 RD19 144 RD18 145 146 DVSS RD17 147 RD16 148 ABCK 149 ALRCK 150 151 DVDD3 ACLK 152 153 MC_DATA SPDIF 154 ASDATA0 155 ASDATA1 156 ASDATA2 Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Power Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Ground Inout 2~16MA, SR PU/PD, SMT Inout 2~16MA, SR PU/PD, SMT Output 4MA Inout 4MA, PD, SMT Power Inout 4MA Input Output 2~16MA, SR : ON/OFF Inout 4MA PD SMT Inout 4MA PD SMT Inout 4MA PD SMT Description DRAM data 23 / Videoin Data PortA 7 DRAM data 22 / Videoin Data PortA 6 2.5V power pin for internal digital circuitry DRAM data 21 / Videoin Data PortA 5 DRAM data 20 / Videoin Data PortA 4 DRAM data 19 / Videoin Data PortA 3 DRAM data 18 / Videoin Data PortA 2 Ground pin for internal digital circuitry DRAM data 17 / Videoin Data PortA 1 DRAM data 16 / Videoin Data PortA 0 Audio bit clock (1) Audio left/right channel clock (2) Trap value in power-on reset : 1 : use external 373 0: use internal 373 3.3V power pin for internal digital circuitry Audio DAC master clock (384/256 audio sample frequency) Microphone serial input SPDIF output (1) (2) (1) (2) (1) (2) Audio serial data 0 (left/right channel) Trap value in power-on reset : 1 : manufactory test mode 0 : normal operation Audio serial data 1 (surround left/surround right channel) Trap value in power-on reset : 1 : manufactory test mode 0 : normal operation Audio serial data 2 (center/left channel) Trap value in power-on reset : 1 : manufactory test mode 0 : normal operation 28 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 157 ASDATA3 Inout 4MA PD SMT 158 ASDATA4 Inout 4MA PD SMT 159 160 161 162 DACVDDC VREF FS YUV0/CIN 163 164 DACVSSC YUV1/C 165 166 DACVDDB YUV2/Y Power Analog input Analog output Output 4MA, SR Ground Output 4MA, SR Power Output 4MA, SR Ground Description (1) (2) Audio serial data 3 (surround left/surround right channel) Trap value in power-on reset : 1 : manufactory test mode 0 : normal operation OR Videoin Data PortB 1 (1) Audio serial data 4 (center/left channel) (2) Trap value in power-on reset : 1 : manufactory test mode 0 : normal operation OR Videoin Data PortB 2 3.3V power pin for VIDEO DAC circuitry Bandgap reference voltage Full scale adjustment Video data output bit 0 / Compensation capacitor Ground pin for VIDEO DAC circuitry Video data output bit 1 / Analog chroma output 3.3V power pin for VIDEO DAC circuitry Video data output bit 2 / Analog Y output 167 DACVSSB 168 YUV3/CVBS Output 4MA, SR Ground pin for VIDEO DAC circuitry Video data output bit 3 / Analog composite output 169 170 DACVDDA YUV4/G 171 172 DACVSSA YUV5/B 173 YUV6/R 174 ICE 3.3V power pin for VIDEO DAC circuitry Video data output bit 4 / Green or Y Ground pin for VIDEO DAC circuitry Video data output bit 5 / Blue or CB Video data output bit 6 / Red or CR Microcontroller ICE mode enable 175 BLANK# 176 VSYN 177 YUV7 178 179 DVSS HSYN 180 SPMCLK Power Output 4MA, SR Ground Output 4MA, SR Output 4MA, SR Input PD, SMT Inout 4MA, SR SMT Inout 4MA, SR SMT Inout 4MA, SR SMT Ground Inout 4MA, SR SMT Input Video blank area, active low / Videoin Field_601 Vertical sync / Videoin Vsync_601 Video data output bit 7 / Videoin Data PortB 3 Ground pin for internal digital circuitry Horizontal sync / Videoin Hsync_601 Audio DAC master clock of SPDIF input / Videoin Data PortB 4 29 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE Pin Number Symbol Type 181 SPDATA Input 182 183 DVDD2 SPLRCK Power Input 184 SPBCK Input 185 186 187 188 DVDD3 XTALO XTALI PRST 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 DVSS VFO13 IDGATE DVDD3 UDGATE WOBSI SDATA SDEN SLCK BDO ADCVSS ADIN RFSUBI TEZISLV TEI CSO FEI RFLEVEL RFRP_DC RFRP_AC HRFZC PWMVREF PWM2VREF ADCVDD3 RFDTSLVP RFDTSLVN RFIN RFIP Power Output Input Input PD, SMT Ground Output Output Power Output Input Output Output Output Input Ground Analog Input Analog Input Analog Input Analog Input Analog Input Analog Input Analog Input A Input Analog Input Analog Input A Input A Input Power Analog Output Analog Output Analog Input Analog Input Description Audio data of SPDIF input / Videoin Data PortB 5 2.5V power pin for internal digital circuitry Audio left/right channel clock of SPDIF input / Videoin Data PortB 6 Audio bit clock of SPDIF input / Videoin Data PortB 7 3.3V power pin for internal digital circuitry Crystal output Crystal input Power on reset input, active high Ground pin for internal digital circuitry The 1st, 3rd header VFO pulse output Header detect signal output 3.3V power pin for internal digital circuitry DVD_RAM recording data gate signal output Wobble signal input RF serial data output RF serial data latch enable RF serial clock output Flag of defect data input status Ground pin for ADC circuitry General A/D input RF subtraction signal input terminal Tracking error zero crossing low pass input Tracking error input Central servo input Focus error input Sub beam add input or RFRP low pass input RF ripple detect input RF ripple detect input (through AC coupling) High frequency RF ripple zero crossing A reference voltage input for PWM circuitry. A typical value of 4.0 v A reference voltage input for PWM circuitry. A typical value of 2.0 v 3.3V power pin for ADC circuitry Positive RF data slicer level output Negative RF data slicer level output Negative input of RF differential signal Positive input of RF differential signal 30 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE 26 Jul, 2002 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 RFIP RFIN RFDTSLVN RFDTSLVP ADCVDD3 PWM2VREF PWMVREF HRFZC RFRP_AC RFRP_DC RFLEVEL FEI CSO TEI TEZISLV RFSUBI ADIN ADCVSS BDO SLCK SDEN SDATA WOBSI UDGATE DVDD3 IDGATE VFO13 DVSS PRST XTALI XTALO DVDD3 SPBCK SPLRCK DVDD2 SPDATA SPMCLK HSYN DVSS YUV7 VSYN BLANK ICE YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/Y DACVDDB YUV1/C DACVSSC Page 1 of 2 IREF PLLVSS MT1379 (216 pins) 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 APLLVDD3 ALE IOOE# IOWR# IOCS# DVSS UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 DVDD3 UP1_7 UP3_0 UP3_1 INT0# IR DVDD2 UP3_4 UP3_5 UWR# URD# DVSS RD7 RD6 RD5 RD4 DVDD2 RD3 RD2 RD1 RD0 RWE# CAS# RAS# RCS# BA0 DVSS RD15 RD14 RD13 RD12 DVDD3 RD11 RD10 RD9 RD8 DVSS CLK CKE RA11 RA9 RA8 DMVDD3 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 LPIOP LPION LPFON LPFIP LPFIN LPFOP JITFO JITFN PLLVDD3 FOO TRO TROPENPWM PWMOUT1 PWMOUT2 DVDD2 DMO FMO DVSS FG HIGHA0 HIGHA1 HIGHA2 HIGHA3 HIGHA4 HIGHA5 DVSS HIGHA6 HIGHA7 AD7 AD6 AD5 AD4 DVDD3 AD3 AD2 AD1 AD0 IOA0 IOA1 DVDD2 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 A16 A17 IOA18 IOA19 IOA20 APLLVSS 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 31 Downloaded From TheatreSystem-Manual.com Manuals YUV0/CIN FS VREF DACVDDC ASDATA4 ASDATA3 ASDATA2 ASDATA1 ASDATA0 SPDIF MC_DATA ACLK DVDD3 ALRCK ABCK RD16 RD17 DVSS RD18 RD19 RD20 RD21 DVDD2 RD22 RD23 DQM2 DQM3 DVSS RD24 RD25 RD26 RD27 DVDD3 RD28 RD29 RD30 RD31 DVSS RA3 RA2 RA1 RA0 DVDD2 RA10 BA1 DQM0 DQM1 DVSS RA4 RA5 RA6 DVDD3 RA7 DMVSS MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE F UNCTIONAL B LOCK DVD module Servo IO Analog Front end Servo DSP Spindle Controller Debug Port Channel Decode DPU System Parser CSS/ CPPM TV encoder Video Decoder Video Output Playback Controller IR/ VFD System Controller DRAM Interface Flash DRAM Audio Processor Audio Output Audio DAC SPDIF Microphone Input MIC Servo Controller The servo control is accomplished through the servo DSP (Servo Digital Signal Processor) and its accessory I/O circuits. This servo DSP is capable of performing complex operations an d also provides a friendly interface for the system controller. By issuing type 1 and type 2 commands from the system controller, the servo DSP can accomplish various complicated servo control functions, such as tracking, seeking and MT1336/MT1376 chip register programming. As for the servo I/O circuits, it provides interface between the input servo signals and the Servo DSP. It has built-in ADCs to digitize the servo control signal and DACs to provide signals for the actuator and sledge motor. It also has a serial interface to communicate with the MT1336/MT1376 chip. Analog Front End The analog front end contains a data slicer circuit and a data PLL circuit. The RF analog signal from MT1336/MT1376 is quantized by the data slicer to form the EFM/EFM+ bit st ream, from which the channel bit clock is extracted by the data PLL.The EFM/EFM+bit stream and bit clock are then output to DPU for channel bit processing. DPU Data path unit (DPU) provides protection on data with lost synchronization patterns and demodulates EFM/EFM+ bit stream into the channel raw data that will be corrected by the decoder. The synchronization protection makes data after the synchronization pattern to be extracted even if the synchronization pattern is not found. Spindle Controller The spindle controller is used to control disc spindle motor. It includes a varipitch CLV clock generator, a CLV/CAV controller, and a PWM generator. The varipitch CLV clock enerator generates a reference colck for the speed of operation. The CLV/CAV 32 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE controller changes the mode and speed of operation according to servo register setting. The PWM generator generates pulse -width-modulated signal to drive disc spindle motor driver. CSS/CPPM The CSS/CPPM module provides functions necessary for decoding discs conforming to CSS/CPPM specification. System Parser The system parser is used to help the system controller to decode DVD/SVCD/VCD bitstream just after the channel decoder performing error correction. Acting as a DMA master, it moves bitstream data from RSPC buffer to video, audio, or sub-picture buffer according to system controller request. It also decrypts the scramble data of the CSS/CPPM sectors. Another function of system parser is providing system controller/DSP a DRAM memory copy controller to enhance system controller/DSP performance. Video Decoder The primary function of MT1379 is to support MPEG1 and MPEG2 video decoding. The video decode engine comprises of variable length decoder (VLD), inverse transformer (IT), motion compensator (MC), and block reconst ructor (BR). The video decode engine decodes the variable length encoded symbols in MPEG bitstream and performs inverse scan, inverse quantization, mismatch control and inverse discrete cosine transform onto the variable length decoded data. The motion compensator fetches prediction data from reference picture buffer according to motion vectors and motion prediciton mode for P and B pictures. Finally, the block reconstructor combines both the results of inverse transformer and motion compensator to derive the reconstructed image macroblock and write back to picture buffer. The video decode engine can also support JPEG and BMP file decoding by common image compression hardware kernels. Video Output The Video Output unit contains Video Processor, SPU, OSD, Cursor, TV encoder units, it performs § Reading decoded video from DRAM buffer § Scaling the image § Gamma/Brightness/Hue/Saturation adjustment and edge enhancement § Reading and decoding SPU and OSD data from DRAM buffer § Generating hardware cursor image § Merging the video data, SPU, OSD and cursor Video Processor The Video Processor unit controls the transfer of video data stored in the DRAM to an internal or external TV encoder. It uses FIFOs to buffer outgoing luminance and chrominance data, and performs YUV420 to YUV422 conversion and arbitrary vertical/horizontal decimation/interpolation, from 1/4x to 256x. With this arbitrary ratio scaling capability, the Video Processor can perform arbitrary image conversion, such as PAL to NTSC, NTSC to PAL, MPEG1 to MPEG2, Letterbox, Pan-Scan conversion or zoom in, zoom out. It is also capible of interlace to progressive conversion. The Video Processor unit performs the following functions: § Requests and receives the decoded picture data from the picture buffer in external DRAM for display § Resample vertical data to create 4:2:2 sample format § Optionally performs vertical/horizontal resampling of both luminance and chrominance data § Performs optional Gamma correction, luminance/chrominance adjustment, and edge enhancement The V ideo Processor unit contains two 2-tap vertical filters for luminance and chrominance . These filters are used to interpolate and reposition luminance and chrominance line to improve picture quality. These filters are capble of generating up to eight, unique subline value between two consecutive scan lines. The generation of lines depends on the ratio between the height of the source image and the target image. In applications where DRAM bandwidth are critical the filters can be configured as simple line-repeating to reduce the DRAM bandwidth required. The Video Processor unit integrates two separate horizontal postprocessing filter, a simple 2-tap linear horizontal filter and an 8-tap programmable filter. These filters are provided for scaling images horizontally along the scan line. These two filters is capable of generating up to eight, unique subpixel values between two consecutive pixels on a scan line. The generation of pixels depends on the ratio between the width of the source image and the target image. SPU 33 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE This is a hardware sub-picture decoder. It decodes the compressed SPU image bitstream and CHG_COLCON commands according to SPU header information previously decoded by system controller. The SPU module also allows two SPU objects to be displayed at the same time. SPU image is blended with main video stream. OSD The OSD module can operate with 2/4/16/256 -color bitmap format (1/2/4/8 bits), and 16/256 color RLC format, all have 16 levels of transparency. In addition, it accepts an special WARP mode, which inserts one programmable RLC code in the bitmap to reduce the image size stored in DRAM. It also features automatic shadow/outline generation in 2-color mode, 2 Hilight areas, 1 ChangeColor area and 1 OSDVoid area. One OSD area can occupy the full or a partial screen, or multiple OSDs can occur in a screen at the same time, only if they don't occupy the same horizontal line. The output image is blended with the video-SPU mixed stream. Cursor A hardware cursor generator is integrated in Video Ou tput Unit. The cursor image is a 32x32 4-color bitmap image, each colors are programmable. Cursor can be enlarged by 2 in both vertical and horizontal directions. Cursor image is multiplexed with video-SPU-OSD mixed stream. Audio Interface Audio interface consists of Audio Output Interface and Microphone Input Interface. Audio Output Interface The MT1379 can support up to 8 channel audio outputs. The output formats can be 16, 24, or 32-bit frames. Left alignment, 2 right alignment, or I S formats are all supported. With built-in PLL, MT1379 can provide the audio clock (ACLK) for external audio DAC at 384Fs, where Fs is usually 32KHz, 44.1KHz, 48KHz, 96KHz, or 192KHz. ACLK can also be programmed to be from outside MT1379. When ACLK is input to MT1379, the frequency could be 128*n Fs, where n is from 1 to 7. Audio raw (encoded) data or cooked (decoded) data can be output on a single line using S/PDIF interface. The output slew rate and driving force of this pad are programmable. Microphone Input Interface The MT1379 provides a microphone input interface. Two independent microphones’ data could be input to the MT1379. There are two independent digital volume control for these two input channels. The input data formats can also be left 2 alignment, right alignment, or I S formats. System Controller MT1379 uses an embedded Turbo-8032 as System Controller and provide ICE interface to increase the feasibility of F/W development. Also, MT1379 includes an build-in internal 373 to latch lower byte address from 8032 Port 0 and provide a glue-logic free solution. MT1379 supports up to 1M X 16 bits Flash ROM to store 8032 code, H/W related data, User data, etc. F/W upgrade can be achieved either by debug interface or by disk. 34 Downloaded From TheatreSystem-Manual.com Manuals MT1379 PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE E LECTRICAL C HARACTERISTICS Absolute Maximum Rating Symbol Parameters Value Unit VDD3 VDD2 VDDA VIN VOUT Ta 3.3V Supply voltage 2.5V Supply voltage Analog Supply voltage Input Voltage Output Voltage Ambient Temperature -0.3 to 3.6 -0.3 to 3.0 -0.3 to 3.6 -0.3 to 5.5 -0.3 to VDD3+0.3 0 to 70 V V V V V °C DC Charateristics Symbol Parameters Min Typ Max Unit VIH VIL VOH VOL IIH IIL PD PDown Input voltage high Input voltage low Output voltage high Output voltage low High level input current Low level input current Power dissapation Power down mode 2.4 3.0 - - 3.6 0.8 VDD3 0.5 10 V V V V uA uA W W -10 1.0 0.1 35 Downloaded From TheatreSystem-Manual.com Manuals IC BLOCK DIAGRAM & DESCRIPTION 8.3 U214 HY29F800 KEY FEATURES n 5 Volt Read, Program, and Erase – Minimizes system-level power requirements n High Performance – Access times as fast as 55 ns n Low Power Consumption – 20 mA typical active read current in byte mode, 28 mA typical in word mode – 35 mA typical program/erase current – 5 µA maximum CMOS standby current n Compatible with JEDEC Standards – Package, pinout and command-set compatible with the single-supply Flash device standard – Provides superior inadvertent write protection n Sector Erase Architecture – Boot sector architecture with top and bottom boot block options available – One 16 Kbyte, two 8 Kbyte, one 32 Kbyte and fifteen 64 Kbyte sectors in byte mode – One 8 Kword, two 4 Kword, one 16 Kword and fifteen 32 Kword sectors in word mode – A command can erase any combination of sectors – Supports full chip erase n Erase Suspend/Resume – Temporarily suspends a sector erase operation to allow data to be read from, or programmed into, any sector not being erased n Sector Protection – Any combination of sectors may be locked to prevent program or erase operations within those sectors n Temporary Sector Unprotect – Allows changes in locked sectors (requires high voltage on RESET# pin) n Internal Erase Algorithm – Automatically erases a sector, any combination of sectors, or the entire chip n Internal Programming Algorithm – Automatically programs and verifies data at a specified address n Fast Program and Erase Times – Byte programming time: 7 µs typical – Sector erase time: 1.0 sec typical – Chip erase time: 19 sec typical n Data# Polling and Toggle Status Bits – Provide software confirmation of completion of program or erase operations n Ready/Busy# Output (RY/BY#) – Provides hardware confirmation of completion of program and erase operations n Minimum 100,000 Program/Erase Cycles n Space Efficient Packaging – Available in industry-standard 44-pin PSOP and 48-pin TSOP and reverse TSOP packages 19 8 DQ[7:0] A[18:0] 7 CE# DQ[14:8] OE# DQ[15]/A-1 WE# RESET# BYTE# 36 Downloaded From TheatreSystem-Manual.com Manuals RY/BY# IC BLOCK DIAGRAM & DESCRIPTION BLOCK DIAGRAM DQ[15:0] A[18:0], A-1 STATE CONTROL ERASE VOLTAGE GENERATOR AND SECTOR SWITCHES DQ[15:0] WE# CE# I/O BUFFERS COMMAND REGISTER I/O CONTROL DATA LATCH OE# PROGRAM VOLTAGE GENERATOR BYTE# RESET# V C C DETECTOR A[18:0], A-1 TIMER 37 Downloaded From TheatreSystem-Manual.com Manuals ADDRESS LATCH RY/BY# Y-DECODER Y-GATING X-DECODER 8 Mb FLASH MEMORY ARRAY IC BLOCK DIAGRAM & DESCRIPTION RY/BY# A18 A17 A7 A6 A5 A4 A3 A2 A1 A0 CE# V SS OE# DQ0 DQ8 DQ1 DQ9 DQ2 DQ10 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 DQ3 DQ11 21 22 PSOP44 PIN CONFIGURATIONS 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 RESET# WE# A8 A9 A10 A11 A12 A13 A14 A15 A16 BYTE# V SS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 24 23 DQ4 V CC A15 A14 A13 A12 A11 A10 A9 A8 NC NC WE# RESET# NC NC RY/BY# A18 A17 A7 A6 A5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 A16 BYTE# V SS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 V CC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 A4 A3 A2 A1 21 22 23 24 28 27 26 25 OE# V SS CE# A0 A16 BYTE# V SS DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 V CC DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 A15 A14 A13 A12 A11 A10 A9 A8 NC NC WE# RESET# NC NC RY/BY# A18 A17 A7 A6 A5 OE# V SS CE# A0 21 22 23 24 28 27 26 25 A4 A3 A2 A1 38 Downloaded From TheatreSystem-Manual.com Manuals Standard TSOP48 Reverse TSOP48 HY57V641620HG 4 Banks x 1M x 16Bit Synchronous DRAM 8.4 HY57V641620HG DESCRIPTION The Hyundai HY57V641620HG is a 67,108,864-bit CMOS Synchronous DRAM, ideally suited for the main memory applications which require large memory density and high bandwidth. HY57V641620HG is organized as 4banks of 1,048,576x16. HY57V641620HG is offering fully synchronous operation referenced to a positive edge of the clock. All inputs and outputs are synchronized with the rising edge of the clock input. The data paths are internally pipelined to achieve very high bandwidth. All input and output voltage levels are compatible with LVTTL. Programmable options include the length of pipeline (Read latency of 2 or 3), the number of consecutive read or write cycles initiated by a single control command (Burst length of 1,2,4,8 or Full page), and the burst count sequence(sequential or interleave). A burst of read or write cycles in progress can be terminated by a burst terminate command or can be interrupted and replaced by a new burst read or write command on any cycle. (This pipelined design is not restricted by a `2N` rule.) FEATURES • Single 3.3±0.3V power supply Note) • Auto refresh and self refresh • All device pins are compatible with LVTTL interface • 4096 refresh cycles / 64ms • JEDEC standard 400mil 54pin TSOP-II with 0.8mm of pin pitch • Programmable Burst Length and Burst Type • All inputs and outputs referenced to positive edge of system clock - 1, 2, 4, 8 or Full page for Sequential Burst • Data mask function by UDQM or LDQM • Internal four banks operation - 1, 2, 4 or 8 for Interleave Burst • . 39 Downloaded From TheatreSystem-Manual.com Manuals Programmable CAS Latency ; 2, 3 Clocks HY57V641620HG PIN CONFIGURATION VDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 VDD LDQM /WE /CAS /RAS /CS BA0 BA1 A10/AP A0 A1 A2 A3 VDD 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 54pin TSOP II 400mil x 875mil 0.8mm pin pitch VSS DQ15 VSSQ DQ14 DQ13 VDDQ DQ12 DQ11 VSSQ DQ10 DQ9 VDDQ DQ8 VSS NC UDQM CLK CKE NC A11 A9 A8 A7 A6 A5 A4 VSS PIN DESCRIPTION PIN PIN NAME DESCRIPTION CLK Clock The system clock input. All other inputs are registered to the SDRAM on the rising edge of CLK CKE Clock Enable Controls internal clock signal and when deactivated, the SDRAM will be one of the states among power down, suspend or self refresh CS Chip Select Enables or disables all inputs except CLK, CKE and DQM BA0,BA1 Bank Address Selects bank to be activated during RAS activity Selects bank to be read/written during CAS activity A0 ~ A11 Address Row Address : RA0 ~ RA11, Column Address : CA0 ~ CA7 Auto-precharge flag : A10 RAS, CAS, WE Row Address Strobe, Column Address Strobe, Write Enable RAS, CAS and WE define the operation Refer function truth table for details LDQM, UDQM Data Input/Output Mask Controls output buffers in read mode and masks input data in write mode DQ0 ~ DQ15 Data Input/Output Multiplexed data input / output pin VDD/VSS Power Supply/Ground Power supply for internal circuits and input buffers VDDQ/VSSQ Data Output Power/Ground Power supply for output buffers NC No Connection No connection 40 Downloaded From TheatreSystem-Manual.com Manuals HY57V641620HG FUNCTIONAL BLOCK DIAGRAM 1Mbit x 4banks x 16 I/O Synchronous DRAM Self refresh logic & timer Internal Row counter 1Mx16 Bank 3 CLK Row active Column Pre Decoders UDQM Y decoders LDQM Bank Select A0 A1 Column Add Counter Address Registers Address buffers A11 BA0 BA1 Memory Cell Array Burst Counter Mode Registers CAS Latency 41 Downloaded From TheatreSystem-Manual.com Manuals Data Out Control Pipe Line Control DQ0 I/O Buffer & Logic Column Active 1Mx16 Bank 0 Sense AMP & I/O Gate WE refresh 1Mx16 Bank 1 X decoders CAS 1Mx16 Bank 2 X decoders RAS State Machine CS Row Pre Decoders X decoders X decoders CKE DQ1 DQ14 DQ15 F1 F1 P16 P15 P14 P13 P12 P11 P10 P9 P8 P7 P6 P5 P4 P3 P2 P1 NC NC NC NC NC NC NC 1G 2G 3G 4G 5G 6G 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 1 2 FIL- GRID1 GRID2 GRID3 GRID4 GRID5 GRID6 GRID7 GRID8 GRID9 FIL+ SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 34 35 K401 2 SEG33 -25V D401 1N4148 SEG13 SEG14 SEG15 SEG16 VCC GRID9 GRID8 GRID7 GRID6 SEG1 SEG2 27 28 29 30 31 32 33 34 35 36 37 38 39 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 VDD VEE SEG19 SEG20 G8 G7 G6 VCC R422 10K VCC R423 10K C408 104 2 U401 13 12 11 10 9 8 7 6 5 4 3 2 1 1K R425 16311 C401 104 R405 51K KEY4 KEY3 KEY2 KEY1 STB CLK IC DI DO SW4 SW3 SW2 SW1 RVP C B A VR401 LED1 1 2 3 R401 R402 R403 R404 VFDST 1 VCC 33K 33K 33K 33K 10K 10K 10K R411 R416 33K 10K R408 R409 R410 VCC TC402 100uF/16V VCC R419 270R V401 8550 LED401 LED R412 33K LED2 R413 33K VCC FIL- C403 101 1 C402 101 GND VCC GND -25V 1 2 3 4 5 6 XS401 XS11 XS402 XS06 1 2 3 4 5 6 7 8 9 10 11 U402 HS0038A2 SEG22 SEG33 KEY1 KEY2 KEY3 GND 3 1 2 LED406 LED FIL+ IR VFDCK VFDST VFDAT J3 J4 C406 104 LED405 LED V402 8550 R418 270R VCC TC403 100uF/16V R415 0R R417 10K VCC R424 100 VFDCK VFDAT KEY4 KEY3 KEY2 KEY1 GND VCC IR R414 33K 1K LED403 LED R426 C404 101 2 LED402 LED 9.SCHEMATIC & P.C.B WIRING DIAGRAM FRONT SCHEMATIC DIAGRAM F2 F2 1 D402 1N4148 C407 104 Downloaded From TheatreSystem-Manual.com Manuals VFD401 VFD-35 KEY4 SEG22 J3 J4 GND 1 2 1 2 1 2 1 2 1 2 LED4 LED3 LED2 LED1 J1 J2 SW3 SW4 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 26 25 24 23 22 21 20 19 18 17 16 15 14 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 VDD G5 G4 G3 G2 G1 VDD LED5 LED4 LED3 LED2 LED1 VSS OSV 40 41 42 43 44 45 46 47 48 49 50 51 52 GRID5 GRID4 GRID3 GRID2 GRID1 VCC 42 43 FRONT SCHEMATIC DIAGRAM Downloaded From TheatreSystem-Manual.com Manuals Downloaded From TheatreSystem-Manual.com Manuals 44 HSYNC# HSYNC# 1 VSYNC# 2 3 VIDEO Y1# VGND 4 VIDEO U# 5 VGND 6 VIDEO V# 7 8 VGND VIDEO COMP# 9 10 VDATA3 11 SELOUTR# 12 AGND 13 SELOUTL# 14 AGND 15 +9V 16 +5V VDATA3 R701 4.7K R705 2.2K 2.2K R703 330R R702 XS16 XS701 +9V B AGND V703 8050 R706 1K A9V AGND V702 8050 R704 33R A9V C E +5V VSYNC# Pr Pb L702 FCM VIDEO V# VIDEO COMP# C702 L701 FCM Y1 +5V VIDEO Y1# VIDEO U# SELOUTL# SELOUTR# AGND C701 104 V701 8050 R708 75R VGND 20PF VJS3921 C703 20PF JK701 1 A(B)OUT A(B)IN 3 A(A)OUT A-COM 5 RETURN A(A)IN 7 BLUE I/O FUNC SW 9 RETURN CONT 11 GREEN I/O NC 13 RETURN RETURN 15 RED I/O BLK I/O 17 RETURN TRTURN 19 V-OUT V-IN 21 GND 20 18 16 14 12 10 8 6 4 2 VGND R707 A9V AGND SCART BOARD SCART BOARD 45 Downloaded From TheatreSystem-Manual.com Manuals POWER SOURCE/AMPLIFIER BOARD SCHEMATIC DIAGRAM ! BCN502 SW-SPST ! ! ! D504 1N5408 K ! L501 L502 ! ! 330uF/400V TC501 DCVPP BCN501 ~220V F501 T1.6A/250V R501 680K 2W RV501 07D471(DNS) GND FB 1 4 R504 1M C504 104 0R(DNS) Heatsink C503 101/1KV R503 39K/2W R5228 R502 120K/2W U501 5L0380R BC501 ~275V 104 JBL2822 30mH±20% JBL2822 30mH±20% ~275V 104 BC502 1N5408 D502 Heatsink 220R(DNS) R520 FB FB D501 1N5408 1uF TC514 L503 2 A U505 KA1M0880BTU TO-3P-5L VCC 3 SYNC FB VCC GND DRAIN 5 4 3 2 1 D D503 1N5408 2 1 C506 223 47uF/50V TC515 D514 HER207 C521 103/1KV ! C505 101 D506 HER105 104 C518 TC502 47uF/50V R505 75ohm D505 HER107 C502 103/1KV R518 120K/2W C522 101/1KV R512 39K/2W ! BC503 ~400V 221 HS817 U502 BCK-28-0286 2# 10 11 9 6 7 12 14 13 15 16 C514 101 C509 101 A TC512 47uF/50V C513 101 HER306 D512 HER105 D509 C511 101 HER306 D510 K511 D HER105 A D508 HER105 C507 101 R513 BCK-35-0144 10ohm 4 3 2 ! HER105 T501 D515 9 6 PTEST 12/10 3 7 13 2 1 T502 K 330R K +9V 1 IN R R5222 47K U504 LM7805 OUT R509 12K 104 3 R510 4.7K R508 4.7K 5.1V ZD501 -20.5 +20.5 100uF/16V TC508 A5V TC511 100uF/16V +3.3V C510 104 +5V C508 104 +9V L509 12uH/5A C5163 C515 102 L508 12uH/5A TC506 1000uF/10V R507 10K HA17431VP TO-92A U503 R506(DNS) L506 TC509 10uH/2A 1000uF/10V TC505 1000uF/10V L507 10uH/2A TC504 1000uF/16V TC510 1000uF/10V TC518 2200uF/35V TC517 2200uF/35V L505 10uH/1A 101 TC503 1000uF/16V C520 101 D517 D516 C523 GND 2 R511 220R/3W 104 C524 FL+ FL-21V DGND +3.3V(+5V) R517 2.2K R516 36K 1 2 3 4 5 K +20.5V XS05 CN501 100uF/16V A R TC513 R519 330 47K 102 R515 C512 1 IN U508 OUT 3 TC516 0R 100uF/16V NJM78M09DLA TO-252 ZD502 9.1V/1W -9V R522 R521 0R BC504 ~400V 221 HS817 U506 +3.3V(+5V) ! R523 33R/1W DCVPP HA17431VP TO-92 U507 R514 330R GND 2 Downloaded From TheatreSystem-Manual.com Manuals FB C526 104 +9VR AGND +9V -9V DGND +5V DGND +3.3V GND A5V +9VR C525 472 1 2 3 4 5 6 7 8 9 10 XS10 XS503 46 +5V +9V GND SELOUTL# AGND SELOUTR# VIDEO COMP# VDATA3 VGND VIDEO V# VGND VIDEO U# VGND VIDEO Y1# VSYNC# HSYNC# C5102 20pF/50V VIDEO COMP# BG ND AA5V SPDIF## OKA G ND_CH3 SUB_L&R LEFT-OUT RIGHT-OUT SW SUB_LOWPASS R588 3K 3 C570 100pF/50V R586 3K 3 R585 30K R589 30K TC 562 220u F /16V 15K 3.9K 3.9K R582 R581 R587 18K 75K R583 R580 75K 6 5 G ND_CH3 R577 R576 15K 6 5 - VSS_P4 VDD_P5 - + VDD_P5 - + VDD_P6 - + VDD_P6 VSS_P6 - + VSS_P6 R590 18K C571 100pF/50V 7 SUB_OUT2 1 UA5 06A NE5532A D8 7 TC 558 10u F /16V TC 557 10u F /16V SWOUT TC 563 220u F /16V TC 564 220u F /16V TC 554 10u F /10V SUB_LOWPASS R5205 0E + R5200 470E R5207 1k R5206 1k R5199 470E TC 559 10u F /16V L528 FB S M T R5220 0E BG ND SPDIF## C5108 10nF /50V R5219 C559 0E 100n F /50V R5218 0E R5215 0E MUTE-1 R584 100K VIDEO Y1 VIDEO U VIDEO V R5214 0E TC 565 220u F /16V G ND_CH3 SUB_L&R TC 556 10u F /16V UA5 06B NE5532A D8 1 UA5 05A NE5532A D 8 R5192 27K VSS_P5 C572 100pF/50V 7 3 2 1 OPT I CA L CON507 VG ND C5107 20pF/50V L531 F B SM T VG ND C5106 20pF/50V L530 F B SM T VG ND C5105 20pF/50V UA5 04B NE5532A D 8 R5196 27K VSS_P5 C573 100pF/50V 1 PDIFB L529 F B SM T R5213 75E C5109 10nF /50V UA5 04A NE5532A D 8 BG ND U A 505B NE5532A D 8 C595 10nF /50V 2 3 C594 10nF /50V + - + VSS_P4 C593 120pF/50V VDD_P4 6 5 2 3 VDD_P4 C592 120pF/50V R5188 100K AGN D 2 3 C597 1nF /50V R5191 4K 7 AGN D G ND_CH3 R5187 33K VIDEO COMP VIDEO C C599 1nF /50V R5195 4K 7 AGN D C596 1n2F /50V R5190 4K 7 G ND_CH3 C554 100n F /50V TC 561 220u F /16V VIDEO Y VG ND AGN D BG ND R5211 0E R5212 0E A5 V Q505 BC847B Q504 BC847B PDIFA XS22 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 CON503 VIDEO Y VDD LS L S C R RS DZ 506 BZX284- C12 R558 2K R5203 330E R5204 100K AGN D R5202 100K R5201 330E R5217 0E R5216 0E VSYNC# HSYNC# VDATA3 SW BGND PDIFB BGND PDIFA BGND BGND BGND VIDEO COMP VGND VIDEO U VGND VIDEO Y1 VGND VIDEO V VGND VIDEO C VGND VSS R557 2.2K R556 8.2K 5V PU T C 545 47u F /25V R555 2K VDD VDD + VDDR 12 11 10 9 8 7 6 5 4 3 2 1 CON501 OU T SELOUTR# C5101 1nF /50V C5100 1nF /50V SELOUTL# AA5V + DZ 507 BZX284- C3V3 VSS VDD R552 R554 10K MUTE LRS MUTE C MUTE S C555 VDD R524 220E SERR 2 3 2 3 2 3 2 3 2 3 200K R550 R549 22K 2 3 R548 10K BZX284- C 6V8 DZ 503 SPDIF# OKA AGND AGND FRIN SELL FLIN MUTE-1 RS OUT# LRS GND LS OUT# SUB OUT# SUB GND CT GND CT OUT# FR GND FL GND FR OUT# FL OUT# R525 220E ZD509 BZX284- C9V1 SUB GND - + - + VSSPC - + VSSPA - + VSSPB - + VSSPB - + VSSPC U C 506A LM 393 1 U C 504A LM 393 1 Vdd_4 U C 503A LM 393 1 Vdd_3 U C 502A LM 393 1 Vdd_2 U C 505A LM 393 1 R545 R544 R543 EN_C EN_S EN_LR BYD33 T C 519 4.7uF /63V EN_LRS + MUTE S MUTE C D507 G ND_CH5 G ND_CH3 MUTE LRS R5221 10K 10K 10K 10K 10K R541 4.7R R540 4.7R OKA VDD_P6 VDD_P5 VDD_P4 VDD_P3 VDD_P2 VDD_P1 G ND_CH1 10E 10E 10E 10E 10E 10E MUTE LR AMPSLEEP R531 R530 R529 R528 R527 R526 R539 4.7R 10K R542 Vdd_6 U C 501A LM 393 1 Vdd_1 R538 TC 523 220u F /16V TC 522 220u F /16V Vdd_5 VSSPA + + 100n F /50V C556 100n F /50V ZD508 BZX284- C9V1 D518 BA S216 MUTE LR R553 10K 10K 5V R551 10K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 ZD504 BZX284- C 30 R546 2K R547 100k VSS CON502 CON26 10E 10E 10E 10E 10E 10E VSS VDD DZ 505 BZX284- C36 VDD R537 R536 R535 R534 R533 R532 T C 521 470u F /35V T C 520 470u F /35V AMPSLEEP VSS_P6 VSS_P5 VSS_P4 VSS_P3 VSS_P2 VSS_P1 C528 100n F /50V C527 100n F /50V + PTEST C5160 1uF /10V LRS GND LS OUT# LRS GND R571 3K 3 R5100 3K 3 C568 100pF/50V R599 3K 3 R596 3K 3 C566 100pF/50V R595 3K 3 R572 3K 3 R566 18K G ND_CH3 G ND_CH5 R5102 18K G ND_CH5 R598 18K G ND_CH3 R592 14K R574 18K G ND_CH1 C5158 R591 3K 3 R562 18K G ND_CH1 220n F /50V C564 100pF/50V C5159 R568 18K R564 3K 3 C562 100pF/50V R563 3K 3 R567 18K R560 3K 3 C560 100pF/50V R559 3K 3 220n F /50V RS OUT# SUB_OUT2 CT GND CT OUT# FL OUT# FL GND FR OUT# FR GND 6 5 2 3 6 5 2 3 6 5 2 3 VDD_P1 - + VDD_P1 VSS_P1 - + VDD_P2 VSS_P1 - + VDD_P2 VSS_P2 - + VDD_P3 VSS_P2 - + VDD_P3 VSS_P3 - + VSS_P3 G ND_CH1 G ND_CH1 RIGHT-OUT G ND_CH3 LEFT-OUT C569 100pF/50V R5101 18K 7 UA5 03B NE5532A D 8 C567 100pF/50V R597 18K C552 100n F /50V G ND_CH5 UA5 03A NE5532A D8 1 C551 100n F /50V 7 UA5 02B NE5532A D 8 G ND_CH5 G ND_CH3 C565 100pF/50V R573 18K C550 100n F /50V UA5 02A NE5532A D8 1 C549 100n F /50V C563 100pF/50V R565 18K 7 UA5 01B NE5532A D 8 C561 100pF/50V R561 18K C548 100n F /50V 1 UA5 01A NE5532A D 8 C547 100n F /50V R5103 100K 100K G ND_CH5 G ND_CH3 G ND_CH5 G ND_CH6 R5104 G ND_CH5 G ND_CH3 R593 100K R594 100K G ND_CH4 G ND_CH1 G ND_CH4 G ND_CH1 R570 100K R569 100K G ND_CH1 G ND_CH2 R5110 10E R5109 10E R5108 10E R5107 10E R5106 10E R5105 10E T C 546 10u F /10V T C 547 10u F /10V TC 548 10u F /10V G ND_CH4 G ND_CH1 G ND_CH2 TC 550 10u F /10V G ND_CH6 G ND_CH3 TC 549 10u F /10V G ND_CH5 TC 551 10u F /10V R5112 3K 9 R5111 3K 9 100K R5135 1K 100K 1n5F /50V 1n5F /50V R5140 3K 3 R5122 100K R5116 3K 9 R5115 3K 9 C590 C591 220pF/50V 1n5F /50V R5136 3K 3 R5139 1K 5 R5143 1K R5144 3K 3 1n5F /50V C589 1n5F /50V R5121 C588 C587 C586 220pF/50V C585 220pF/50V C584 C583 1n5F /50V R5120 100K R5114 3K 9 R5113 3K 9 R5119 C582 1n5F /50V C581 1n5F /50V R5132 3K 3 R5131 1K 5 R5127 1K 3K 3 C578 1n5F /50V 1n5F /50V R5128 C580 220pF/50V R5117 100K C576 1n5F /50V C575 1n5F /50V R5124 3K 3 R5123 1K 5 R5118 100K C579 220pF/50V C577 C574 220pF/50V CH5O 6 5 6 5 R5145 33K R5146 15K 6 5 C546 100n F /50V R5142 15K R5141 33K R5137 33K R5138 15K GN D C_ H 5 CH6O CH3O 6 5 6 5 C544 100n F /50V R5134 15K R5133 33K R5129 33K R5130 15K GN D C_ H 3 CH4O CH1O 6 5 C542 100n F /50V R5126 15K R5125 33K GN D C_ H 1 CH2O - + - + - + - + - + - + VSSPC 7 VSSPB R5161 1K R5160 1K GN D C_ H 6 R5152 4K 7 LM 393 7 U C 506B C545 100n F /50V LM 393 7 LM 393 U C 505B Vdd_5 VSSPC 1K U C 503B ST A B B VSSPA ST A B A VSSPC ST A B C C5157 1uF /10V EN_S R5159 10K C5155 1uF /10V R5158 C5156 1uF /10V R5156 1K GN D C_ H 4 R5157 LM 393 7 R5154 1K R5153 1K C543 100n F /50V U C 504B VDDR R5151 4K 7 Vdd_6 VDDR VSSPB 7 LM 393 VDDR R5150 4K 7 Vdd_3 VSSPB R5148 4K 7 U C 501B VDDR R5149 4K 7 Vdd_4 VDDR VSSPA Vdd_1 VSSPA 7 GN D C_ H 2 C541 100n F /50V U C 502B LM 393 R5147 4K 7 Vdd_2 VDDR PU PU VSS VSS EN_LRS R5162 5K 6 PU D5 19 BA S216 Q503 BC847B VDD EN_C 10K Q502 BC847B VDD VSS EN_LR R5155 5K 6 Q501 BC847B VDD TC 526 100u F /35V C531 100n F /50V TC 528 100u F /35V L513 BEA D TC 530 100u F /35V C535 100n F /50V TC 534 100u F /35V C539 100n F /50V PW M I_N 2 REL2 ENA B LE2 ENA B LE1 DI A G N OST I C POW E RU P REL1 PW M I_N 1 UB 503 T D A 8925J C537 100n F /50V L516 BEA D 17 16 14 4 3 15 2 TC 532 100u F /35V L515 BEA D 1 PW M I_N 2 REL2 ENA B LE2 ENA B LE1 DI A G N OST I C POW E RU P REL1 PW M I_N 1 UB 502 T D A 8926J C533 100n F /50V L514 BEA D 17 16 14 D520 4 BA S216 3 15 2 1 PW M I_N 2 REL2 ENA B LE2 ENA B LE1 DI A G N OST I C POW E RU P REL1 PW M I_N 1 UB 501 T D A 8925J C529 100n F /50V L512 BEA D 17 16 14 4 3 15 2 1 TC 524 100u F /35V L511 BEA D VDDPA TC 525 100u F /35V 11 12 9 6 7 TC 527 100u F /35V TC 529 100u F /35V VDDPB VSSPA 11 12 9 6 TC 531 100u F /35V TC 533 100u F /35V VDDPC VSSPB 11 12 9 6 TC 535 100u F /35V C540 100n F /50V OU T 2 BOOT 2 ST A B I BOOT 1 OU T 1 C538 100n F /50V 7 C536 100n F /50V OU T 2 BOOT 2 ST A B I BOOT 1 OU T 1 C534 100n F /50V 7 C532 100n F /50V OU T 2 BOOT 2 ST A B I BOOT 1 OU T 1 C530 100n F /50V VSSPC + SUB OUT# SUB GND G ND_CH3 R579 75K R5198 27K R5189 4K 7 R5197 27K R5193 4K 7 TC 560 220u F /16V VIDEO Y1# VIDEO U# VIDEO V# SELOUTL# SELOUTR# SWOUT FLIN FRIN C598 1n2F /50V R5194 4K 7 L527 F B SM T L526 F B SM T C553 100n F /50V TC 553 R575 10u F /10V 30K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 CON504 Audio L525 F B SM T TC 555 10u F /16V TC 552 R574 10u F /10V 30K R578 75K AGN D C5162 1nF /50V SERR SELL C5103 20pF/50V TC 567 10u F /16V C5104 20pF/50V SPDIF# L524 F B SM T A5 V VG ND + C5161 1uF /10V X S 13 T O S C A R T V& G A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 CON508 1 2 3 4 5 6 7 4 3 2 1 CON505 OPT 2 C558 100n F /50V CON506 V OU T AGN D 68E C557 100n F /50V 8 4 8 R5210 8 4 4 8 4 8 4 R5209 330E 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 8 4 + + + + + + 8 4 8 4 8 4 8 4 8 4 8 4 5 VDD1 VSS1 8 5 VDD1 + + VSS1 8 5 VDD1 + VSS1 + 8 47 + + 13 VDD2 + + VSS2 10 13 VDD2 VSS2 Downloaded From TheatreSystem-Manual.com Manuals + 10 + + + + 13 + + + VDD2 + + VSS2 + + + + + + + 10 + R5208 91E + + + R5164 33K R5166 33K VDDPC T C 544 10u F /25V C5112 100n F /50V T C 542 10u F /25V VDDPC VSSPB + R5168 33K VSSPC + VDDPC TC 543 22u F /63V ST A B C R5167 33K VDDPB TC 540 22u F /63V VDDPA TC 537 22u F /63V ST A B B R5165 33K VDDPB T C 541 10u F /25V C5111 100n F /50V T C 539 10u F /25V VSSPA + ST A B A R5163 33K VDDPB VDDPA T C 538 10u F /25V C5110 100n F /50V T C 536 10u F /25V VDDPA C5123 1nF /50V C5121 1nF /50V C5119 1nF /50V C5117 1nF /50V C5115 1nF /50V C5113 1nF /50V CH5O CH6O CH3O CH4O CH1O CH2O C5114 1nF /50V C5118 1nF /50V L519 33U H C5122 1nF /50V L521 33U H L522 33U H R5179 VSSPC 5E6/0. 25W C5124 1nF /50V R5177 5E6/0. 25W L520 27U H R5175 VSSPB 5E6/0. 25W C5120 1nF /50V R5173 5E6/0. 25W L518 33U H R5171 VSSPA 5E6/0. 25W C5116 1nF /50V R5169 5E6/0. 25W L517 33U H 10nF /50V C5138 C5152 470n F /63V C5151 470n F /63V 10nF /50V C5137 10nF /50V C5144 c5154 470n F /63V C5153 470n F /63V 10nF /50V C5143 Loader: 8 OHM AGN D R5180 22E/1W C5130 220n F /50V R5178 22E/ 1W C5129 220n F /50V AGN D Loader: 8 OHM Loader: 4 OHM AGN D R5176 22E/1W C5128 220n F /50V R5174 22E/ 1W C5127 220n F /50V AGN D Loader: 8 OHM R C5141 10nF /50V C5147 10nF /50V C5148 10nF /50V AGN D LS C5146 10nF /50V AGN D C5145 10nF /50V RS AGN D C5142 10nF /50V AGN D C5140 10nF /50V S C5136 10nF /50V AGN D C5139 10nF /50V C L 10nF /50V C5134 C5135 10nF /50V AGN D C5133 10nF /50V 10nF /50V C5132 C5150 470n F /63V C5149 470n F /63V 10nF /50V C5131 Loader: 8 OHM AGN D R5172 22E/1W C5126 220n F /50V R5170 22E/ 1W C5125 220n F /50V AGN D Loader: 8 OHM R5186 10K R5185 10K R5184 10K R5183 10K R5182 10K R5181 10K POWER SOURCE/AMPLIFIER BOARD SCHEMATIC DIAGRAM + POWER SOURCE/AMPLIFIER BOARD SCHEMATIC DIAGRAM Downloaded From TheatreSystem-Manual.com Manuals 48 POWER SOURCE/AMPLIFIER BOARD SCHEMATIC DIAGRAM Downloaded From TheatreSystem-Manual.com Manuals 49 Downloaded From TheatreSystem-Manual.com Manuals 50 XS601 XS06 1 2 3 4 5 6 MIC601 MIC602 +5V -9V +9V AGND OK DET 9 8 7 6 5 4 3 2 1 9 8 7 6 5 4 3 2 1 +9V L601 L602 R621 10ohm1/6W R602 22K TC602 4.7u TC615 47uF/16V C603 103 R603 560R C604 103 R604 560R TC606 22uF/16V R601 22K TC601 4.7uF C601 104 +9VA R608 1K -9V R606 10K 5 6 R605 10k 3 2 100p 1 4558 U601A TC616 47uF/16V R622 10ohm1/6W U601B 4558 7 C606 100p R610 10K +9VA C605 10K 4 8 R609 TC604 4.7uF/16V VR601 10K VR602 10K TC603 4.7uF/16V -9VA 1 C602 104 -9VA 3 R607 1K 2 R618 10K R611 4.7K R612 4.7K 10K R623 3 2 C607 100P -9VA R613 5.1K 4 +9VA 8 TC605 22uF/16V OK U602A 4558 1 C608 102 4.7uF/16V TC613 R617 100K +5V R616 330 R615 100K 5 6 U602B 4558 7 100 R619 VD602 1N4148 TC611 47uF/16V VD603 1N4148 VD601 1N4148 R620 1K DET OK SCHEMATIC DIAGRAM OK SCHEMATIC DIAGRAM 51 Downloaded From TheatreSystem-Manual.com Manuals MIAN SCHEMATIC DIAGRAM 104 C341 750K 4.7R\1/4W R341 R322 470R TC304 47u 20K 150P R338 1.5K R333 330K R331 C333 TC308 47uF R336 1R TROPEN (TRCLOSE1) LOAD- R334 330K C334 GND FMSO R316 VCC V307 8050 V306 8550 0R VCC R335 750K R332 C337 104 TRSO V1P4 STBY C336 104 C330 104 C329 104 C335 104 FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT FBSMT R327 L312 L314 L316 L317 L318 L319 L320 L321 L322 L323 L324 SL+ SL- FBSMT FB L310 L311 R313 1R FBSMT FBSMT 10UH FBSMT FBSMT L304 L305 L306 L307 L308 R312 1R FBSMT 10UH L302 L303 0.5mm 24P 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 XS301 V309 8550 V308 8050 V1P4 SP- ADIN OPOP+ OPO 22 23 24 25 26 27 28 15 16 17 18 19 20 21 TC309 47uF V310 10K 9014 R323 470R R342 1.5K 7 6 5 4 3 2 1 14 13 12 11 10 9 8 LOAD+ VCC (TRCLOSE1) TROPEN (TROPEN1) TRCLOSE 1 2 3 4 5 6 XS303 XS06 VINFFC VOSL VINSLVINSL+ CF2 CF1 VINFC R339 PREGND VINLD CTK2 CTK1 VINTK BIAS STBY VOTK+ VOTKVOLD+ VOLDPGND VNFTK PVCC2 LDO1 TC303 47u LDO-AVCC V302 2SB1132 V301 2SB1132 TC302 47u LDO2 LDO-AVCC VOFC+ VOFCVO2+ VOSLPGND PVCC1 VCC R315 22R R314 22R TC301 100u U302 BA5954 F B A RFO IOA D CAP# V20 E MD11 C328 104 AVCC 29 30 1 AVCC SP+ SL+ SLLIMIT 20K V1P4 R321 FOSO 10K 0R R360 2 R317 1R XS302 2.0mm 5P 1 2 3 4 5 C331 150P C332 104 C314 C311 IOA A C345 104 C318 C317 C316 C315 C313 C312 105(DNS) C344 104 AGND VGND 104 TRIN C343 LOADLOAD+ TROUT CAP# CAP# B A D RFO C342 120p OPO OPOP+ LDO-AVCC 100K R310 10K R311 AVCC V304 2SK3018 DMSO R320 20K R318 1R 2 L360 FBSMT R319 SPSP+ 1 VC33 V303 2SK3018 10K V305 3904 R309 100K 105 105 105 105 C346 104 104 104 104 SW1# B D 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 AGNDF VCON AVDDF AGNDX AVDDM COSPHI HALLCOS REFCOS AGNDM HALLSIN REFSIN SINPHI SW0 SW2 SW1 MOP MON AGNDX AGNDX CEON CEOP RFGCI RFGCU RFFGC OSP OSN CDD CDC CDB CDA DVDRFIN DVDRFIP DVDD DVDC DVDB DVDA MA MB MT1336C_128 U301 PWMOUT2 URST SDATA SDEN R307 33K F E R308 C319 0.015u MD11 GND GND TRCLOSE IOA ENDM STBY LIMIT TROUT TRIN SCLK 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 AVDDP AGNDX AGNDP DPDMUTE RST SDATA SDEN GNDS SCLK XCK16M VDDS IOB IOA IO9 IO8 IO7 IO6 IO5 IO4 IO3 IO2 IO1 IO0 HDGATE UDGATE GND MC MD SA SB AGND IR AVDD SC SD CDFOP CDFON SVDD TPI TNI SGND WGAND AGC1 WAVDD AGC2 AGC3 MD12 MD11 LDO1 LDO2 RFSUBO WGND 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 LDO1 LDO2 Downloaded From TheatreSystem-Manual.com Manuals VFO13 VDD AGNDX AGNDX AGNDX DPFO DPFN GNDP HTRC TRLP TRLPA CRTPLP CRTP HRFRP LRFRP DEFECT VDDP TEO CSO LVL FEO V20 VREFO V2REFO AVDDT TM4 AGNDT TM3 TM2 TM1 AGNDO RFON RFOP AVDDO AGNDX AGNDX WVDD WOBSO 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TRCLOSE TROPEN ENDM STBY 0R R324 C324 104 C302 104 C325 104 C326 104 VC33 C321 104 VC33 C301 104 TC305 C320 47u 104 RFON RFOP TEO CSO RFL FEO V20 V1P4 V2P8 BDO CRTP RFRP C304 390P 27K HTRC 27P R302 0R R325 C339 104 C338 104 10K 10K 10K 10K C310 VC33 R303 R304 R305 R306 C327 104 C322 104 2 C323 104 TC307 10u C306 C307 0.033u 470P R301 100K C308 C309 0.015u 10P R(DNS) R326 0R SW1# RVCC VCC 0R 2 TC306 C303 10u 104 C305 390P R344 1 1 R343 AV33 52 MIAN SCHEMATIC DIAGRAM XI XS201 6 5 4 3 2 1 XS06 U205A HCU04 C217 331 JITFO JITFN LPFOP LPFIP LPIOP LPION 8 7 6 5 C216 101 101 101 L203 L202 L201 C244 J4 J3 DV33 RXD TXD GND C223 27pF 0R 3 101 C2125 R239 0R(DNS) R269 2 0R 10K 33K R205 R206 R207 AD3 AD2 AD1 AD0 A0 A1 A14 A15 AD7 AD6 AD5 AD4 R211 10 FB FB FB C225 100P IR VFDAT VFDST VFDCK R212 4.7R C226 225 20K 18K A8 A9 A10 A11 A12 A13 750K 103 C215 R203 R204 103 103 8.2K C214 C212 102 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 GND 102 C239 C234 104 C230 104 IREF PLLVSS LPIOP LPION LPFON LPFIP LPFIN LPFOP JITFO JITFN PLLVDD3 FOO TRO TROPENPWM PWMOUT1 PWMOUT2 DVDD2 DMO FMO DVSS FG HIGHA0 HIGHA1 HIGHA2 HIGHA3 HIGHA4 HIGHA5 DVSS HIGHA6 HIGHA7 AD7 AD6 AD5 AD4 DVDD3 AD3 AD2 AD1 AD0 IOA0 IOA1 DVDD2 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 A16 A17 IOA18 IOA19 IOA20 APLLVSS RFIP RFIN TC201 10uF/16V 0R(DNS) 0R 100K C238 TC204 47uF/16V C206 RFON 104 RFOP C211 DV33 104 GND RFRPC R218 HTRC R219 V2P8 R202 A2 A3 A4 A5 A6 C2149 A7 10pF(DNS) A16 A17 A18 A19 A20 C224 GND 104 AV33 R209 10R(DNS) XO 4 U205B HCU04 C2113 104 R201 V25 C213 103 C240 104 C210 104 C209 104 C272 104 C205 104 C204 104 SCL SDA C201 104 C218 C219 C220 C221 331 103(DNS) 153 104 AVCC C243 XS04(DNS) XS202 1 2 3 4 27MHZ C222 X201 27pF 27MHz R238 0R(DNS) R208 100K 1 V1P4 PWMOUT2 V25 DMSO FMSO C287 104 DV33 4.7R C208 104 C203 104 R261 4.7R C253 104 C227 104 AV33 R258 C202 104 C207 104 DC/NC VCC RST_/NC RST/WP WP/RST_ SCL VSS SDA FOSO TRSO TROPEN 1 2 3 4 R217 V1P4 C231 104 VCC C285 C286 101 101 R283 4.7K VFDCK VFDAT VFDST SCL GND PRD# PWR# PCE# 33R 33R 33R R2107 R2108 R2109 FRD# FWR# FCE# SDA R228 1K R236 0R(DNS) SPBCLK SPLRCK R227 1K XTALI URST XI XO DV33 ADIN 4.7K R2270 IR 0R R278 TC202 10uF/16V L255 FBSMT DV33 104 C232 DACV33C TC219 10uF/16V MT1379E_216 U201 VCC R245 4.7k C2137 104 FBSMT C235 104 L257 YUV0/CIN FS VREF DACVDDC ASDATA4 ASDATA3 ASDATA2 ASDATA1 ASDATA0 SPDIF MC_DATA ACLK DVDD3 ALRCK ABCK RD16 RD17 DVSS RD18 RD19 RD20 RD21 DVDD2 RD22 RD23 DQM2 DQM3 DVSS RD24 RD25 RD26 RD27 DVDD3 RD28 RD29 RD30 RD31 DVSS RA3 RA2 RA1 RA0 DVDD2 RA10 BA1 DQM0 DQM1 DVSS RA4 RA5 RA6 DVDD3 RA7 DMVSS V25 TC215 47uF/16V L256 FBSMT Y5 VGND Y4 DACV33A Y3 VGND Y2 DACV33B Y1 VGND RFRP RFZC C233 RFRPC 102 RFL FEO CSO TEO R216 18K AMPSLEEP VDATA3 R240 BDO SCLK SDEN SDATA RXD TXD 14 Y6 DV33 C229 104(DNS) 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 C237 104 R237 1.5K 4.7R A_MUTE DTS_DI SMUTE ALRCK ABCK DTS_CE DTS_CL DV33 AV33 DCKE DCLK R235 R234 DMA7 DMA4 DMA5 DMA6 DMA10 DBA1 RDQM0 RDQM1 DMA3 DMA2 DMA1 DMA0 RDSID RDSCE J3 J4 L204 FB 33R SDCKE 33R SDCLK VD VOICE-DET DAVNIN R2301 C246 104 SD33 R2156 C245 104 RST# R2271 0R AMPMUTE 0R R251 33R DBA1 MA11 R259 1K R2160 DTS_DO AMPMUTE0 AMPMUTE1 RDSSYNC TUNER_ON ASDATA2 ASDATA1 ASDAT0 ASPDIF AMDAT ACLK FS VREF DACV33C C228 225 R213 VGND 4.7R(DNS) R214 U202 AT24C02/X4050 DQ7 DQ6 DQ5 DQ4 7 SPDATA SPMCK HSYNC# VGND 33R 33R 33R 33R 33R DQ3 DQ2 DQ1 DQ0 R229 R230 R231 R232 R233 DWE# DCAS# DRAS# DCS# DBA0 XTALI VSYNC# INT 1K DQ15 DQ14 DQ13 DQ12 4.7K(DNS) 4.7K(DNS) 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 DQ11 DQ10 DQ9 DQ8 19 18 17 16 15 39 DCS# DRAS# DCAS# DWE# RDQM0 RDQM1 TC217 10uF/16V Q204 9014-S VD201 1N4148 AVCC R2157 10K FWR# A19 A18 A8 A7 A6 A5 A4 A3 A2 RSET VP 54 41 28 36 40 38 37 SDCLK SDCKE A16 A15 A14 A13 A12 A11 A10 A9 A20 C248 104 23 24 25 26 29 30 31 32 33 34 22 35 20 21 C247 104 DMA0 DMA1 DMA2 DMA3 DMA4 DMA5 DMA6 DMA7 DMA8 DMA9 DMA10 DMA11 DBA0 R221 4.7K(DNS) R215 R223 RFIP RFIN RFDTSLVN RFDTSLVP ADCVDD3 PWM2VREF PWMVREF HRFZC RFRP_AC RFRP_DC RFLEVEL FEI CSO TEI TEZISLV RFSUBI ADIN ADCVSS BDO SLCK SDEN SDATA WOBSI UDGATE DVDD3 IDGATE VFO13 DVSS PRST XTALI XTALO DVDD3 SPBCK SPLRCK DVDD2 SPDATA SPMCLK HSYN DVSS YUV7 VSYN BLAANK# ICE YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/Y DACVSSB YUV1/C DACVSSC APLLVDD3 ALE IOOE# IOWR# IOCS# DVSS UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 DVDD3 UP1_7 UP3_0 UP3_1 INT0# IR DVDD2 UP3_4 UP3_5 UWR# URD# DVSS RD7 RD6 RD5 RD4 DVDD2 RD3 RD2 RD1 RD0 RWE# CAS# RAS# RCS# BA0 DVSS RD15 RD14 RD13 RD12 DVDD3 RD11 RD10 RD9 RD8 DVSS CLK CLE RA11 RA9 RA8 DMVDD3 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 DCLK DCKE MA11 DMA9 DMA8 10K R222 Downloaded From TheatreSystem-Manual.com Manuals VSSQ VSSQ VSSQ VSSQ VCCQ VCCQ VCCQ VCCQ VCC VCC VCC DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 C250 104 A16 BYTE Vss DQ15/A-1 DQ7 DQ14 DQ6 DQ13 DQ5 DQ12 DQ4 Vcc DQ11 DQ3 DQ10 DQ2 DQ9 DQ1 DQ8 DQ0 OE Vss CE A0 6 12 46 52 3 9 43 49 1 14 27 2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53 C251 104 5 9 RST# 8 U205C HCU04 U205D HCU04 C2148 102 0R L206 R220 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 SD33 SD33 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 0R R2162 33R C241 URST 0.1U RSET R260 0R(DNS) R2163 0R(DNS) AVCC VCC DV33 AD0 FRD# GND FCE# A1 AD1 AD2 AD3 AD4 VD AD5 AD6 GND A0 AD7 A17 TC206 47uF/16V C252 104 TC237 FB(DNS) 47uF/16V R2159 6 8M_FLASH(TSOP) VD A15 A14 A13 A12 A11 A10 A9 A8 A19 NC WE RESET NC NC RY/BY A18 A17 A7 A6 A5 A4 A3 A2 A1 U214 C284 104 R2158 1K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 SDRAM VSS VSS VSS NC NC DQML DQMH /CS /RAS /CAS /WE CLK CKE A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 BA0/A13 BA1/A12 U203 C249 104 53 MIAN SCHEMATIC DIAGRAM XS10 XS203 1 2 3 4 5 6 7 8 9 10 ASPDIF R252 100R A5V FB L209 VIDEO_Y VGND VIDEO_C VGND VIDEO_V VGND VIDEO_Y1 VGND VIDEO_U VGND VIDEO_COMP GND GND GND PDIFA GND PDIFB GND SW VDATA3 HSYNC# VSYNC# AVCC FBSMT L250 1M R255 C294 104 XS22 XS207 GND A5V 12 -P9V 11 104 10 TC288 104 V25 U209 LM1117MP-2.5 SPDIF# VCC AV33 Q202 8050 FB L205 TC207 220uF/16V U208 BA033FP 104 TC208 220uF/16V VCC C296 DV33 C297 RVCC VCC HCU04 U205E 47uF/16V C295 +P9V R253 DNS HCU04 U205F TC287 47uF/16V GND 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 FBSMT L249 +9VR FBSMT FBSMT L241 L242 C2143 104 13 R254 10M AVCC IN GND OUT 1 2 3 GND OUT IN 1 2 3 Downloaded From TheatreSystem-Manual.com Manuals C2153 104 V25 C2154 104 VGND C2152 104 A5V TC211 220uF/16V TC213 220uF/16V AV33 C2151 104 C2150 104 TC203 10uF/16V Y6 Y5 Y4 Y3 VGND R280 160R VGND R276 160R VGND 160R R273 VGND R270 160R VGND R274 160R Y1 VGND R262 160R Y2 L248 1.8uH L247 1.8uH L246 1.8uH L245 1.8uH L244 1.8uH L243 1.8uH C268 47p VGND C269 47p C271 47p VGND L215 1.8uH C270 20pF C266 47p VGND C262 47p VGND C265 47p VGND L214 1.8uH C267 20pF C263 47p L213 1.8uH C264 20pF C260 47p L212 1.8uH C261 20pF C256 47p A5V VGND C259 47p L211 1.8uH C257 47p C258 20pF C254 47p L210 1.8uH C255 20pF Q215 3906 Q217 3906 Q214 3906 R281 150R A5V Q220 3906 R277 150R A5V Q213 3906 R272 150R A5V Q216 3906 R271 150R A5V R275 150R A5V 150R R263 VIDEO_V VIDEO_U VIDEO_Y1 VIDEO_COMP VIDEO_C VIDEO_Y 54 MIAN SCHEMATIC DIAGRAM OKA Rt C2197 104 105 105 SR Lt AVCC 10uF/16V TC279 AMDAT SACLK SBCLK SLRCK C2195 C2196 R256 1k C298 102 150R R241 SELL SERR R257 1k 1 2 3 4 5 6 7 C SW SL VL VR DGND VDD SCKI BCK LRCK U210 PCM1801 TC210 10uF/16V VREF1 VREF2 AGND VCC FMT BYPAS DOUT C2109 R2116 102 100K AGND C2107 R2115 102 100K C283 104 C280 104 14 13 12 11 10 9 8 LOUT ROUT 330R 330R R2264 330R R2263 C2105 R2114 102 100K AGND C2103 R2113 102 100K R2262 R2261 330R AGND C2101 R2112 102 100K C299 R2111 102 100K R2265 330R 10uF/16V TC281 C282 104 R2260 330R C281 104 AGND -9V AGND C279 104 1K 470 R2126 470 R2125 R2124 1K R2123 1K 470 R2122 R2121 1K R2120 470 R2119 1K R2118 470 R243 0R TC220 1uF/16V TC218 1uF/16V C288 104 R2128 470 Q210 2SC1815-Y R2127 1K Q209 2SC1815-Y Q208 2SC1815-Y Q207 2SC1815-Y Q206 2SC1815-Y Q205 2SC1815-Y R2117 CH-R AGND R246 0R CH-C CH-SW CH-SL ACLK ABCK ALRCK ASDAT0 ASDATA1 ASDATA2 10uF/16V TC224 10uF/16V TC223 10uF/16V TC222 10uF/16V TC221 10uF/16V TC241 MUTE-1 CH-SR CH-L 10uF/16V TC240 R291 R292 R293 R294 R295 R296 7 33R 33R 33R 33R 33R 33R 1 7 SACLK SBCLK SLRCK SDATA0 SDATA1 SDATA2 -9V +9V 4580 U221B 5 6 4.7K 4.7K 4.7K 4.7K 4.7K 4.7K 4.7K AGND C2127 102 R2151 R2150 AGND C2124 102 R2147 AGND C2121 102 R2143 R2269 AGND C2118 102 R2267 R2266 AGND 4.7K 22K C2126 151 3 U221A 4580 2 C2123 151 4.7K 4.7K C2115 102 R2135 R2134 AGND R2146 151 R2145 22K 4.7K 4.7K C2112 102 R2131 R2130 22K U220A 4580 3 2 151 22K U219B 4580 5 6 151 22K 5 U220B 4580 6 3 U219A 4580 C2120 R2268 -9V +9V C2117 R2137 -9V R2149 -9V +9V -9V +9V 1 7 +9V C2114 -9V 2 151 22K C2111 +9V R2133 1 R2129 8 4 8 4 8 4 C278 104 R242 0R(DNS) 8 4 8 4 +9V R244 0R(DNS) 8 4 C2136 122 R2155 6.8K C2135 122 R2154 6.8K C2133 122 683 C2128 C2134 0R R2153 6.8K C2130 122 R2152 6.8K C2129 122 R2148 6.8K C2122 122 R2136 6.8K MUTE3 MUTE2 MUTE1 683 C2119 683 C293 104 VD209 1N4148 VD208 1N4148 VD207 1N4148 R299 0R A_MUTE C2138 C2131 0R 0R R225 C2132 0R AVCC 1 2 Downloaded From TheatreSystem-Manual.com Manuals R2106 1K R2105 1K 1K R247 RST# SCL SDA SDATA0 SDATA1 SDATA2 SBCLK SLRCK SACLK R282 0R C292 104 DV33 VCC TC238 2.2uF/16V CS4360 VLS SDIN1 SDIN2 SDIN3 SCLK LRCK MCLK VD GND RST SCL SDA CS VLC U207 R249 -9V 330R R266 1K R267 +9V 1K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Q211 1015 TC230 10uF/16V TC229 10uF/16V TC228 10uF/16V TC227 10uF/16V TC22610uF/16V TC22510uF/16V TC231 10uF/16V 0R R226 R265 10K AGND TC234 100uF/16V AGND Q218 1015 R250 10K TC232 10uF/16V C289 104 Q219 1015 MUTE-1 VOICE-DET TC233 10uF/16V C290 104 MUTE3 MUTE2 MUTE1 VD205 1N4148 AGND R297 28 27 26 25 24 23 22 21 20 19 18 17 16 15 Q212 2SC1815-Y MUTEC1 AOUTA1 AOUTB1 MUTEC2 AOUTA2 AOUTB2 VA GND AOUTA3 AOUTB3 MUTEC3 VQ FILT+ M2 C291 104 R264 150R AGND TC236 10uF/16V AVCC +9V TC235 47uF/16V VD206 1N4148 55 MIAN SCHEMATIC DIAGRAM Downloaded From TheatreSystem-Manual.com Manuals 5819 AMPMUTE1 VD215 L340 0805 L349 0805 5819 VD214 VOICE-DET OKA 5819 VD213 MUTE3 5819 5819 5819 VD211 VD210 AMPMUTE0 VD212 AMPMUTE MUTE1 GND +9V -9V VCC C2146 103 R2259 4.7K VCC R2258 4.7K VCC C273 103 1 2 3 4 5 6 HEADER 6 XS204 C274 103 MUTE_C MUTE_SW MUTE_L_R SR_OUT SL_OUT R2213 100K 10uF TC261 10uF 12k R2240 12k R2255 R2252 12k 12k R2243 0R R2235 0R R2232 R2212 100K R2210 100K R2209 100K R2211 100K TC260 10uF TC259 10uF TC258 10uF R2208 100K 10uF TC256 TC257 SUB_OUT CT_OUT FR_OUT FL_OUT AMPSLEEP FL_OUT# AGND FR_OUT# AGND CT_OUT# AGND SUB_OUT# AGND SL_OUT# AGND SR_OUT# MUTE_L_R MUTE2 MUTE_C MUTE-1 SMUTE SELL FLIN AGND FRIN SERR AGND OKA MUTE_SW SPDIF# 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 XS26 XS206 56 MIAN SCHEMATIC DIAGRAM SR SL SW C Rt Lt 100K R2207 100K R2206 100K R2205 100K R2204 100K R2203 100K R2202 100K R248 100K 2.7K R2217 2.7K R2216 10uF TC255 10uF TC254 10uF TC253 10uF TC252 10uF TC251 10uF TC250 10uF TC209 C2236 C2235 0.1UF 0.1UF 0.01UF 0.01UF C2260 C2234 2200PF C2142 IN_SR IN_ST IN_SUB IN_CT IN_R5 IN_L5 IN_R7 C2230 104 +P9V +9VD IN_L5 C2231 TC267 10uF 104 +9VA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 104 C2232 IN_L5 NC IN_L4 NC IN_L3 NC IN_L2 NC IN_L1 NC TPOUT_FL NC SEL_FL NC CTRE_FL NC RCMID1_FL NC RCMID2_FL NC RCBAS1_FL NC RCBAS2_FL NC VDIN1 NC VDIN2 NC VDIN3 NC TC268 10uF -9V IN_L6 FRIN FB TC269 10uF +9VA IN_L7 +9VA FL_OUT L346 IN_ST 10uF SL_OUT R268 +9V 10uF TC264 104 C2211 IN_CT +9VD CT_OUT FB TC270 10uF IN_SUB L345 C2194 0.1UF SUB_OUT IN_L7 SR_OUT TC205 FR_OUT C2193 0.1UF +9VD IN_R7 NC IN_R6 NC IN_R5 NC IN_R4 NC IN_R3 NC IN_R2 NC IN_R1 NC TPOUT_FR NC SEL_FR NC CTRE_FR NC RCMID1_FR NC RCMID2_FR NC RCBAS1_FR NC RCBAS2_FR NC DGND SDA PT2320 U223 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 R2214 100K SDA IN_R5 IN_R6 IN_R7 R2215 100K TUNER-R TUNER-L 10uF TC290 10uF TC289 12K R2224 12K R2223 -9V 0.01UF 0.1UF C2239 C2238 0.1UF 0.01UF C2240 C2237 2200PF C2233 33P 7 1 U228A 4558 R2225 10k 4558 U228B +9V C2147 6 5 3 2 10k R2222 4 8 FLIN IN_SR 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 NC IN_L6 NC IN_L7 NC IN_L8 NC IN_SL NC IN_CT AGND NC VREF NC IN_SUB NC IN_SR NC IN_R8 NC VDIN4 NC VDOUT NC FL_OUT NC SL_OUT NC CT_OUT AVCC NC SUB_OUT NC SR_OUT NC FR_OUT DVCC NC SCL NC 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 SCL Downloaded From TheatreSystem-Manual.com Manuals 2.7K R2219 2.7K R2218 10uF TC272 10uF TC271 IN_R6 IN_L6 57 58 MIAN SCHEMATIC DIAGRAM Downloaded From TheatreSystem-Manual.com Manuals 10.Dk960S(RU) MATERIAL LIST DK960S MATERIAL LIST 1. DECODE BOARD NO 1 1 MATERIAL CARBON FILM RESISTOR CARBON FILM RESISTOR SPECIFICATIONS/PART NUMBER 1/4W2.2Ω±5% 1/4W2.2Ω±5% LOCATION QUANTITY 1 1 R341 R341 2 SMD RESISTOR 1/16W 0Ω ±5% 0603 31 R205,R219,R220,R226,R259,R299,R 282,R332,L243~L248,C2131,C2132, C2134,R2232,R2235,R344,R279,R21 62,R327,R243,R246,R2240,R2243,R 2252,R2255,R2271,R2270 3 4 5 SMD RESISTOR SMD RESISTOR SMD RESISTOR 1/16W1Ω±5% 0603 1/16W 4.7Ω ±5% 0603 1/16W 15Ω ±5% 0603 5 4 3 R312,R313,R317,R318,R336 R212,R213,R258,R261 R211,R314,R315 6 SMD RESISTOR 1/16W 33Ω ±5% 0603 19 R229~R235,R291~R296,R2107,R 2108,R2109,R2159,R2301,R2156 7 SMD RESISTOR 1/16W 100Ω ±5% 0603 1 8 SMD RESISTOR 1/16W 150Ω ±5% 0603 8 9 SMD RESISTOR 1/16W 160Ω ±5% 0603 6 10 SMD RESISTOR 1/16W 220Ω ±5% 0603 10 11 SMD RESISTOR 1/16W 330Ω ±5% 0603 7 12 SMD RESISTOR 1/16W 470Ω ±5% 0603 8 13 SMD RESISTOR 1/16W 1K ±5% 0603 18 14 SMD RESISTOR 1/16W 1.5K ±5% 0603 2 R338,R342 15 SMD RESISTOR 1/16W 2.7K ±5% 0603 4 16 SMD RESISTOR 1/16W 4.7K ±5% 0603 19 17 SMD RESISTOR 1/16W 6.8K ±5% 0603 6 18 SMD RESISTOR 1/16W 8.2K ±5% 0603 1 R2216~R2219 R245,R2130,R2131,R2134,R2135 ,R2143,R2146,R2147,R2150,R21 51,R2308,R2266,R2267,R2269,R 283,R222,R223,R2258,R2259 R2136,R2148,R2152,R2153,R215 4,R2155 R201 R252 R263,R264,R271,R272,R275,R27 7,R281,R241 R262,R270,R273,R274,R276,R28 0 R2168~R2171,R2305,R2311,R21 76~R2179 R249,R2260~R2265 R322,R323,R2117,R2120,R2121, R2124,R2125,R2128 R227,R228,R266,R267,R2105,R2 106,R2118,R2119,R2122,R2123, R2126,R2127,R2306,R256,R257, R2158,R2160,R2309 19 SMD RESISTOR 1/16W 10K ±5% 0603 29 R206,R2157,R250,R265,R303~R 306,R309,R311,R319,R339,R216 4~R2167,R2307,R2129,R2133,R2 137,R2145,R2149,R2268,R2312~ R2315,R2174,R2175 20 SMD RESISTOR 1/16W 30K ±5% 0603 2 R2223,R2224 21 SMD RESISTOR 1/16W 5.1K ±5% 0603 2 R2222,R2225 22 23 SMD RESISTOR SMD RESISTOR 1/16W 18K ±5% 0603 1/16W 20K ±5% 0603 2 4 R204,R216 R203,R316,R320,R321 24 SMD RESISTOR 1/16W 15K ±5% 0603 2 R207,R307 25 SMD RESISTOR 1/16W 100K ±5% 0603 24 R208,R217,R248,R268,R2111~R 2116,R308,R310,R2202~R2207,R 2210~R2215 26 PRECISION SMD RESISTOR 1/16W 330K ±1% 0603 2 R333,R334 27 SMD RESISTOR 1/16W 470K ±5% 0603 1 R2310 Downloaded From TheatreSystem-Manual.com Manuals 59 28 PRECISION SMD RESISTOR 1/16W 750K ±1% 0603 3 R202,R331,R335 29 SMD RESISTOR 1/16W 1MΩ ±5% 0603 1 R255 30 SMD RESISTOR 1/16W 10MΩ ±5% 0603 1 R254 31 SMD RESISTOR 1/16W 2K ±5% 0603 1 R237 32 CD CD11 50V2.2U±20%5×11 2 1 TC274 33 34 CD CD CD11 50V4.7U±20%5×11 2 CD11 16V1U±20%5×11 2 1 2 TC277 TC218,TC220 TC201,TC202,TC203,TC217,TC 219,TC221~TC233,TC236,TC24 0,TC241,TC306,TC307,TC250~ TC261,TC264,TC267~TC272,T C289,TC290,TC278,TC279,TC2 81,TC285,TC286,TC238,TC205, TC209,TC210 35 CD CD11 16V10U±20%5×11 2 53 36 CD CD11C 16V47U±20%5×7 2 14 36.1 CD CD11 16V47U±20%5×11 2 14 36.2 CD CD110 16V47U±20%5×11 2 14 TC204,TC206,TC215,TC237,TC 302~TC305,TC308,TC309,TC28 7,TC288,TC234,TC275 TC204,TC206,TC215,TC237,TC 302~TC305,TC308,TC309,TC28 7,TC288,TC234,TC275 TC204,TC206,TC215,TC237,TC 302~TC305,TC308,TC309,TC28 7,TC288,TC234,TC275 TC207,TC208,TC211,TC213,TC235, TC301,TC276,TC242 37 CD CD11 16V220U±20%6×12 2.5 8 38 39 SMD CAPACITOR SMD CAPACITOR 50V 27P ±5% NPO 0603 50V 33P ±5% NPO 0603 3 2 40 SMD CAPACITOR 50V 47P ±5% NPO 0603 16 41 SMD CAPACITOR 50V 82P ±5% NPO 0603 2 42 SMD CAPACITOR 50V 101 ±5% NPO 0603 10 C216,C225.C285,C286,C2111,C2114 ,C2117,C2120,C2123,C2126 43 44 45 46 SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR 50V 151 ±5% NPO 0603 50V 331 ±5% NPO 0603 50V 391 ±10% 0603 50V 471 ±10% 0603 3 3 1 1 C331,C334,C2251 C217,C218,C2248 C304 C311 C233,C238,C239,C2112,C2115,C211 8,C2121,C2124,C2127,C299,C2101, C2103,C2105,C2107,C2109,C2148.C 298 C222,C223,C333 C2233,C2255 C254,C256,C257,C259,C260,C26 2,C263,C265,C266,C268,C269,C 271,C243,C244,C2125,C2253 C305,C2254 47 SMD CAPACITOR 50V 102 ±10% 0603 17 48 SMD CAPACITOR 50V 122 ±10% 0603 6 49 SMD CAPACITOR 50V 222 ±10% 0603 3 50 SMD CAPACITOR 50V 103 ±10% 0603 8 51 SMD CAPACITOR 50V 153 ±10% 0603 3 C2122,C2129,C2130,C2133,C213 5,C2136 C2142,C2147,C2247 C212~C215,C2234,C2239,C2240, C2260 C220,C308,C319 52 SMD CAPACITOR 50V 223 ±10% 0603 1 C2102 53 SMD CAPACITOR 10V 225 +80%-20% 0805 2 C226,C228 54 SMD CAPACITOR 16V 333 ±10% 0603 1 C306 Downloaded From TheatreSystem-Manual.com Manuals 60 C201~C211,C221,C224,C227,C2 30,C231,C232,C234~C235,C237, C240,C245,C246~C253,C272~C2 74,C278~C283,C284,C287~C297 ,C301~C303,C312~C313,C320~C 330,C332,C335~C339,C343~C34 6,C2113,C2137,C2143,C2146,C2 150~C2154,C341,C2230,C2231,C 2241,C2258,C2235~C2238,C219 3,C2194,C2197,C2211,C2232 , C2249,C2250,C2252 55 SMD CAPACITOR 50V 104 +80%-20% 0603 103 56 57 58 59 SMD CAPACITOR SMD CAPACITOR SMD INDUCTOR SMD INDUCTOR 50V 474 +80%-20% 0603 16V 105 +80%-20% 0603 1.8UH ±10% 1608 10UH ±10% 2012 2 6 6 2 60 SMD MAGNETIC BEADS FCM1608K-221T05 34 61 SMD MAGNETIC BEADS MAGNETIC BEADS INDUCTOR SMD DIODE FCM2012V-221T07 1 RH354708 7 1N4148 6 C2245,C2246 C315~C318,C2195,C2196 L210~L215 L303,L306 L201,L202,L203,,L255,L256,L25 7,L304,L305,L307,L308,L310~L 312,L314,L316~L324,L254,L340, L349,L252,L253,L345,L346,L30 2,L360,R240,R269 L207 L204,L205,L209,L241,L242,L24 9,L250 VD201,VD205~VD209 LS4148 6 VD201,VD205~VD209 62 63 63.1 SMD DIODE 63.2 SMD DIODE LL4148 6 VD201,VD205~VD209 64 SMD SCHOTTKY DIODE 1N5819(HOMEMADE) 6 VD210~VD215 65 SMD VOLTAGE REGULATOR 5.1V 1/2W 1 VD216 66 TRIODE S8050D 3 Q202,V307,V308 67 TRIODE S8550D 2 V306,V309 68 TRIODE 2N3906 1 Q221 69 TRIODE 9014C 1 Q204 2SA1015 3906 2N3904 C1815 3904 9014C 2SK3018 2SB1132 RC4558D SOP 74HCU04D SOP NT5SV4M16DT-7 TSOP CS4360 SSOP PT2320 QFP 24C02N SOP MT1336E-C QFP MT1379EE-C QFP AT5654H SOP D5954 SOP PCM1801U SOP SAA6588 SO20 4.332MHz 49-s 3 6 1 7 1 1 2 2 4 1 1 1 1 1 1 1 1 1 1 1 1 Q211,Q218,Q219 Q213~Q217,Q220 Q222 Q205~Q209,Q212,Q210 V305 V310 V303,V304 V301,V302 U219,U220,U221,U228 U205 U203 U207 U223 U202 U301 U201 U302 U302 U210 U229 X204 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 SMD TRIODE SMD TRIODE TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE SMD TRIODE IC IC IC IC IC IC IC IC IC 86.1 IC IC IC CRYSTAL OSCILLATOR Downloaded From TheatreSystem-Manual.com Manuals 61 90 CRYSTAL OSCILLATOR 27.00MHz 49-S 1 X201 91 SOCKET 5P 2.0mm 1 XS302 92 SOCKET 6P 2.0mm 2 XS303,XS201 93 SOCKET 10P 2.5mm 1 XS203 94 SOCKET 6P 2.5mm 1 XS204 95 PCB 1 96 CABLE SOCKET 97 CABLE SOCKET 98 CABLE SOCKET 2937C-2 11P 1.0mm STRAIGHT DUAL LINE PLUG 13P 1.0mm DUAL LINE CONTACT, STRAIGHT DUAL LINE PLUG 6/5P 1.25mm STRAIGHT DUAL LINE PLUG 99 CABLE SOCKET 24P 0.5mm SMD WITH CLASP 1 XS207 1 XS206 1 XS208 1 XS301 2. POWER AMPLIFIER BOARD NO MATERIAL SPECIFICATIONS/PART NUMBER QUANTITY LOCATION R522,R5211,R5214,R5216,R5219 1 SMD RESISTOR 1/16W 0Ω ±5% 0603 5 2 SMD RESISTOR 1/16W 1K ±5% 0603 9 3 4 5 6 SMD RESISTOR SMD RESISTOR SMD RESISTOR CARBON FILM RESISTOR 1/16W 2.2K ±5% 0603 1/16W 2K ±5% 0603 1/10W 2K ±5% 0805 1/4W2K±5% SHAPED 10 1 1 1 1 7 SMD RESISTOR 1/16W 3.9K ±5% 0603 8 8 SMD RESISTOR 1/16W 3.3K ±5% 0603 22 9 10 SMD RESISTOR SMD RESISTOR 1/16W 3K ±5% 0603 1/16W 4.7Ω ±5% 0603 3 3 11 SMD RESISTOR 1/16W 4.7K ±5% 0603 12 12 13 SMD RESISTOR SMD RESISTOR 1/16W 5.6K ±5% 0603 1/16W 8.2K ±5% 0603 2 1 14 SMD RESISTOR 1/16W 10Ω ±5% 0603 18 15 SMD RESISTOR 1/16W 10K ±5% 0603 8 16 17 SMD RESISTOR SMD RESISTOR 1/10W 15K ±5% 0805 1/8W18K ±5% 1206 1 1 18 SMD RESISTOR 1/10W 10K ±5% 0805 8 19 SMD RESISTOR 1/16W 15K ±5% 0603 7 20 21 SMD RESISTOR SMD RESISTOR 1/10W 12K ±5% 0805 1/16W 30K ±5% 0603 1 2 22 SMD RESISTOR 1/16W 18K ±5% 0603 10 Downloaded From TheatreSystem-Manual.com Manuals 62 R5153,R5154,R5156,R5157,R516 0,R5161,R5206,R5207,R5231 R557 R546 R558 R555 R581,R582,R5111,R5112,R5113,R51 14,R5115,R5116 R559,R560,R563,R564,R571,R57 2,R586,R588,R591,R595,R596,R 599,R5100,R5124,R5128,R5132, R5136,R5140,R5144,R5123,R513 1,R5139 R5127,R5135,R5143 R539,R540,R541 R5147,R5148,R5149,R5150,R515 1,R5152,R5189,R5190,R5191,R5 193,R5194,R5195 R5155,R5162 R556 R526,R527,R528,R529,R530,R53 1,R532,R533,R534,R535,R536,R 537,R5105,R5106,R5107,R5108, R5109,R5110 R538,R542,R543,R544,R545,R55 1,R5158,R5159 R554 R548 R552,R5181,R5182,R5183,R5184 ,R5185,R5186,R5230 R5126,R5130,R5134,R5138,R514 2,R5146,R5229 R553 R576,R577 R561,R562,R565,R566,R573,R52 26,R597,R598,R5101,R5102 23 24 25 SMD RESISTOR SMD RESISTOR SMD RESISTOR 1/16W 47K ±5% 0603 1/16W 27K ±5% 0603 1/16W 30K ±5% 0603 1 2 4 26 SMD RESISTOR 1/10W 33K ±5% 0805 6 27 28 29 30 31 SMD RESISTOR SMD RESISTOR SMD RESISTOR SMD RESISTOR SMD RESISTOR 1/10W 150K ±5% 0805 1/16W 33K ±5% 0603 1/16W 68Ω ±5% 0603 1/16W 75K ±5% 0603 1/16W 91Ω ±5% 0603 6 3 1 4 1 32 SMD RESISTOR 1/16W 100K ±5% 0603 18 33 34 35 SMD RESISTOR SMD RESISTOR SMD RESISTOR 1/16W 200K ±5% 0603 1/16W 330Ω ±5% 0603 1/16W 470Ω ±5% 0603 1 3 2 36 SMD CAPACITOR 50V 104 +80%-20% 0603 34 37 38 SMD CAPACITOR SMD CAPACITOR 50V 102 ±10% 0603 50V 122 ±10% 0603 4 2 39 SMD CAPACITOR 50V 152 ±5% 0603 12 40 SMD CAPACITOR 50V 561 ±10% 0603 12 41 SMD CAPACITOR 50V 105 ±20% 0805 3 42 SMD CAPACITOR 50V 103 ±10% 0603 20 43 SMD CAPACITOR 50V 20P ±5% 0603 6 44 SMD CAPACITOR 50V 101 ±5% NPO 0603 12 45 46 47 SMD CAPACITOR SMD CAPACITOR SMD CAPACITOR 50V 33P ±5% NPO 0603 50V 121 ±10% 0603 16V 224 ±10% 0603 2 3 2 48 SMD CAPACITOR 50V 221 ±5% NPO 0603 6 49 50 51 SMD DIODE SMD TRIODE SMD TRIODE 1N4148 BC847B 8050D 5 5 1 52 SMD MAGNETIC BEADS FCM1608K-221T05 6 5.1V 1/2W 1 12V 1/2W MINIMELF 1 53 54 SMD VOLTAGE REGULATOR DIODE SMD VOLTAGE REGULATOR DIODE Downloaded From TheatreSystem-Manual.com Manuals 63 R549 R5192,R5196 R574,R575,R585,R589 R5129,R5133,R5137,R5141,R514 5,R5125 R5163~R5168 R5187,R587,R590 R5223 R578,R579,R580,R583 R5208 R569,R570,R584,R593,R594,R51 03,R5104,R5117,R5118,R5119,R 5120,R5121,R5122,R5188,R5202 ,R5204,R547,R592 R550 R5201,R5203,R5209 R5199,R5200 C541,C542,C543,C544,C545,C546,C 547,C548,C549,C550,C551,C552,C5 53,C554,C557,C558,C527,C528,C52 9,C530,C531,C532,C533,C555,C534, C535,C536,C537,C538,C539,C540,C 5110,C5111,C5112 C597,C599,C5100,C5101 C596,C598 C575,C576,C577,C578,C581,C58 2,C583,C584,C587,C588,C589,C 590 C5113,C5114,C5115,C5116,C511 7,C5118,C5119,C5120,C5121,C5 122,C5123,C5124 C5155,C5156,C5157 C594,C595,C5131,C5132,C5133, C5134,C5135,C5136,C5137,C513 8,C5139,C5140,C5141,C5142,C5 143,C5144,C5145,C5146,C5147, C5148 C5102,C5103,C5104,C5105,C510 6,C5107 C560,C561,C562,C563,C564,C56 5,C566,C567,C568,C569,C572,C 573 C570,C571 C592,C593,C5164 C5158,C5159 C574,C579,C580,C585,C586,C59 1 D518,D519,D520,D521,D522 Q501,Q502,Q503,Q504,Q505 Q506 L525,L526,L527,L529,L530,L53 1 ZD507 ZD506 30V 1/2W MINIMELF 2 56 57 58 59 60 61 62 63 SMD VOLTAGE REGULATOR DIODE CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR 1/4W22Ω±5% SHAPED 10 1W33Ω±5% SHAPED R 15×8 1/4W10K±5% SHAPED 10 1/4W75Ω±5% SHAPED 10 1/4W220Ω±5% 1/4W4.7K±5% SHAPED 10 1/4W1MΩ±5% SHAPED 10 1/4W47K±5% SHAPED 10 1 1 1 1 1 1 1 2 64 CARBON FILM RESISTOR 1/6W 5.6Ω±5% 6 65 66 67 68 CARBON FILM RESISTOR CARBON FILM RESISTOR METAL FILM RESISTOR METAL FILM RESISTOR 68.1 METAL FILM RESISTOR METAL FILM RESISTOR METAL FILM RESISTOR 1/2W 10K±5% SHAPED R 12.5×7 1W560Ω±5% SHAPED FLAT 15×7 1/4W2.2K±1% SHAPED 10 1/4W4.7K±1% 1/4W4.7K±1% SHAPED 10 1/4W2.2K±1% SHAPED 10 1/4W36K±1% SHAPED 10 1 2 2 1 1 1 1 ZD504,ZD505 R513 R523 R507 R505 R520 R510 R504 R5222,R515 R5169,R5171,R5173,R5175,R517 7,R5179 R5221 R524,R525 R514,R519 R508 R508 R517 R516 1/4W12K±1% SHAPED 10 1 R509 3W220Ω±5% SHAPED FLAT 15×7 1 R511 2W39K±5% SHAPED FLAT 15×9 2 R503,R512 2W39K±5% SHAPED FLAT 15×7 2 R503,R512 2W120K±5% SHAPED FLAT 15×7 2 R502,R518 1 1 5 3 R501 R501 C505,C507,C509,C511,C513 C514,C520,C523 C504,C508,C510,C518,C526,C51 63,C524 C503,C522 C503,C522 C515 C502,C521 BC503 BC504 C506 C525 BC501,BC502 BC501,BC502 C5149,C5150,C5151,C5152,C515 3,C5154 TC502,TC512,TC515 TC508,TC511,TC513,TC516 TC503,TC504,TC565 TC505,TC506,TC509,TC510 TC514 TC501 TC517,TC518 55 69 70 71 72 73 74 METAL FILM RESISTOR METAL OXIDE FILM RESISTOR METAL OXIDE FILM RESISTOR METAL OXIDE FILM 73.1 RESISTOR METAL OXIDE FILM RESISTOR 76 77 PORCELAIN CAPACITOR PORCELAIN CAPACITOR 1/2W680K±5% 1/2W680K±5% SHAPED 15mm 50V 100P ±10% 5mm 500V 101 ±10% 5mm 78 PORCELAIN CAPACITOR 50V 104 ±20% 5mm 7 1000V 101 +80%-20% 7.5mm 1000V 101 ±10% 7.5mm 50V 102 ±10% 5mm 1000V 103 +80%-20% 7.5mm CT81 250VAC471±10% 10mm 400VAC 102 ±10% 10mm 100V 223 ±10% 5mm 100V 472±10% SHAPED 5mm 275V 104 ±20% 15mm 275V 104 ±10% 15mm 2 2 1 2 1 1 1 1 2 2 CL23X 63V 474 ±5% 5 6 CD11T 50V47u±20%6×12 2.5 CD11T 16V100u±20%6×12 2.5 CD11 105℃ 16V1000U±20%10×20 5 CD11T 10V1000u±20%8×16 3.5 CD110 105℃ 50V1U±20%5×11 2 LS 400V330U±20% 30×40 10 GZ 105℃ 35V 2200U±20% 16×36 7.5 3 4 3 4 1 1 2 75 HIGH VOLTAGE RESISTOR 75.1 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 HIGH VOLTAGE RESISTOR PORCELAIN CAPACITOR 79.1 PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR CERAMIC CAPACITOR CERAMIC CAPACITOR TERYLENE CAPACITOR TERYLENE CAPACITOR TERYLENE CAPACITOR 86.1 TERYLENE CAPACITOR METAL POLYESTER FILM CAPACITOR CD CD CD CD CD CD CD Downloaded From TheatreSystem-Manual.com Manuals 64 TC546,TC547,TC548,TC549,TC 550,TC551,TC552,TC553,TC554 ,TC555,TC556,TC557,TC558,T C567 TC519 TC536,TC538,TC539,TC541,TC 542,TC544 TC537,TC540,TC543 TC545 TC524,TC525,TC526,TC527,TC 528,TC529,TC530,TC531,TC532 ,TC533,TC534,TC535 95 CD CD11 105℃ 16V10U±20%5×11 2 14 96 CD CD11 105℃ 100V4.7U±20%6×12 2.5 1 97 CD CD11T 25V10U±10%5×11 2 6 98 99 CD CD CD11C 105℃ 50V22U±20%6×7 2.5 GZ 105℃ 25V47u ±20%8×12 3.5 3 1 100 CD CD11C 105℃ 35V100U±20%6.3×11 2.5 12 101 CD CD11T 16V220U±20%6×12 2.5 7 TC522,TC523,TC560,TC561,TC562, TC563,TC564 102 CD11 105℃ 35V470U±20%10×20 5 2 TC520,TC521 RP1315-270 1 L520 RP1315-330 5 L517,L518,L519,L521,L522 VERTICAL 10UH 1A 5mm VERTICAL 15uH 5A 10mm VERTICAL 10UH 2A 5mm 1 2 2 L505 L508,L509 L506,L507 BCK-28-0286 2# 1 T501 BCK-35-0144 1 T502 RH354708 8 111 CD VERTICAL SHIELD FILTER INDUCTOR VERTICAL SHIELD FILTER INDUCTOR CHOKE COIL CHOKE COIL CHOKE COIL SWITCHING POWER TRANSFORMER SWITCHING POWER TRANSFORMER MAGNETIC BEADS INDUCTOR DIODE BYW29E-200 TO-220 2 112 DIODE HER105 6 HER105 SHAPED 12.5mm 6 HER306 HER306 SHAPED R 17.5×8mm HER107 HER107 SHAPED R 12.5mm HER307 SHAPED R 13.6×8mm 1N5408 SHAPED R 17.5×8mm 1N5408 SHAPED 17.5mm 2 2 1 1 1 4 4 L511,L512,L513,L514,L515,L51 6,L524,L503 D516,D517 D506,D508,D511,D512,D515,D50 7 D506,D508,D511,D512,D515,D50 7 D510,D509 D510,D509 D505 D505 D514 D501~D504 D501~D504 5.1V 1/2W 1 ZD501 5.1V 1/2W SHAPED 10mm 1 ZD501 6.8V 1/2W 1 9.1V 1W 1 ZD502 9.1V 1W SHAPED 10mm 1 ZD502 KA1M0880BTU TO-3P-5L 5L0380R YDTU MIK431C TO-92 1 1 2 U505 U501 U503,U507 TL431 TO-92 2 U503,U507 LM7805 GOLD SEALED TO-220 1 U504 103 104 105 106 107 108 109 110 112.1 DIODE 113 113.1 114 114.1 115 116 116.1 117 117.1 118 119 119.1 120 121 122 DIODE DIODE DIODE DIODE DIODE DIODE DIODE VOLTAGE REGULATOR DIODE VOLTAGE REGULATOR DIODE VOLTAGE REGULATOR DIODE VOLTAGE REGULATOR DIODE VOLTAGE REGULATOR DIODE IC IC IC 122.1 IC 123 IC Downloaded From TheatreSystem-Manual.com Manuals 65 ZD503 124 IC L7809CV GOLD SEALED TO-220 1 125 IC LM393 SO8 6 126 IC RC4558D SOP 6 127 128 129 130 131 132 133 134 IC POWER GRID FILTER SOCKET SOCKET SOCKET FUSE FUSE TDA8927JN2C1E3 DBS JBL2822 30mH±20% HS817 2P 8.0mm 2# 5P 2.0mm 10P 2.5mm T6.3AL 250V BLX-2 3 2 2 2 1 1 1 1 135 SILICON INSULATOR PIECE 20×25×0.3 1 136 SILICON INSULATOR PIECE 16×30×0.3 3 137 HEAT RADIATION BOARD 40×40×20 BLACK DV937 1 138 HEAT RADIATION BOARD 11×15×25 AB009K 5 138.1 HEAT RADIATION BOARD 11×15×25 WHITE AB905 5 PHOTOELECTRIC COUPLER U508 UC501,UC502,UC503,UC504,U C505,UC506 UA501,UA502,UA503,UA504,U A505,UA506 UB502,UB501,UB503 L501,L502 U502,U506 BCN501,BCN502 CN501 XS503 F501 FOR F501 U505 INSULATION WITH HEAT RADIATOR UB501、UB502、UB503 INSULATION WITH HEAT RADIATOR U505 FOR HEAT RADIATION U501,U504,D516,D517,U508 FOR HEAT RADIATION U501,U504,D516,D517,U508 FOR HEAT RADIATION FOR POWER AMPLIFIER PIPE U501,U504,D516,D517,U508 FOR HEAT RADIATION FIXDE HEAT RADIATION BOARD, U505 HEAT RADIATION BOARD 139 HEAT RADIATION BOARD 125×18×40 SILVERY DV937 1 140 TAPPING SCREW BT 3×8 BLACK 5 141 TAPPING SCREW BT 3×10 WHITE NICKEL 7 142 TERMINAL SOCKET AV9-8.4-2G-3 1 JK501 CS-09 1 JK502 TX179AT 1 TP01A 1 WP12-1 13P 1.0mm DUAL LINE CONTACT, STRAIGHT DUAL LINE PLUG 11P 1.0mm STRAIGHT DUAL LINE PLUG 8P 1.0mm DUAL LINE 1 143 TERMINAL SOCKET ELECTRO-OPTIC 144 TRANSFORMER ELECTRO-OPTIC 144.1 TRANSFORMER 145 EXTERNAL SOCKET 146 CABLE SOCKET 1 147 CABLE SOCKET 148 CABLE SOCKET 149 PVC PIECE 100×10×0.25 SINGLE FACED WITH GLUE REAR 1 150 PCB 5937PH-3 1 1 1 JK503 JK503 JK505 XS501 XS502 XS504 RADIATION BOARD AND PCB 3. POWER SOCKET NO MATERIAL SPECIFICATIONS/PART NUMBER QUANTITY 1 HEAT SHRINKABLE TUBE Φ22 2 SWITCHING LEAD 2P 80/90mm 8.0mm WITH CLASP 1 3 PCB C936A-0 1 4 8-SHAPED POWER SOCKET SA-2S-129 0.05 1 4. SCART BOARD Downloaded From TheatreSystem-Manual.com Manuals LOCATION 66 FROM POWER BOARD TO AC SOCKET NO 1 2 3 4 5 6 7 MATERIAL 9 10 CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR PORCELAIN CAPACITOR MAGNETIC BEADS INDUCTOR TRIODE SCART SOCKET 11 SPECIFICATIONS/PART NUMBER LOCATION QUANTITY 1/4W4.7K±5% 1/4W330Ω±5% SHAPED 10 1/4W2.2K±5% SHAPED 10 1/4W33Ω±5% 1/4W1K±5% 1/4W75Ω±5% 50V 104 ±20% 5mm 1 1 2 1 1 1 1 R701 R702 R703,R705 R704 R706 R708 C701 RH354708 2 L701,L702 S8050D SCART-01 3 1 CONNECTION CORDS Φ0.6 SHAPED 7.5mm 7 12 13 CONNECTION CORDS PCB Φ0.6 SHAPED 10mm S937-0 2 1 V701,V702,V703 JK701 JP701,JP702,JP703,JP704,JP705 ,JP707,JP708 JP706,R707 14 CABLE SOCKET 8P 1.0mm DUAL LINE 1 8 XS701 5. MAIN FRONT PANEL NO MATERIAL SPECIFICATIONS/PART NUMBER LOCATION QUANTITY 1 SOFT SPONGE SPACER 15×15×7 DOUBLE FACED, HARD 1 2 SOFT SPONGE SPACER 15×5×7 DOUBLE FACED, HARD 1 3 SOFT SPONGE SPACER 7×7×12.5 DOUBLE FACED, HARD 1 4 6 SMD RESISTOR CARBON FILM RESISTOR SMD RESISTOR 1/10W 100Ω ±5% 1/4W10Ω±5% SHAPED10 1/10W 1K ±5% 1 2 2 7 CARBON FILM RESISTOR 1/4W10K±5% 7 CARBON FILM RESISTOR 1/4W10K±5% SHAPED 10 7 CARBON FILM RESISTOR 8.1 CARBON FILM RESISTOR CARBON FILM RESISTOR 9.1 CARBON FILM RESISTOR CD DIODE 11.1 DIODE IC VFD LIGHT TOUCH RESTORE SWITCH 1/4W33K±5% 1/4W33K±5% SHAPED 10 1/4W51K±5% 1/4W51K±5% SHAPED 10 CD11C 16V100U±20%6×7 2.5 1N4148 1N4148 SHAPED 10mm PT6311 QFP HNVC09SS35 8 8 1 1 2 2 2 1 1 CONNECT VFD WITH FRONT PANEL PCB CONNECT VFD WITH FRONT PANEL PCB CONNECT IR SENSOR WITH FRONT PANEL PCB R424 R418,R419 R425,R426 R408~R410,R416,R417,R422,R4 23 R408~R410,R416,R417,R422,R4 23 R401~R404,R411~R414 R401~R404,R411~R414 R405 R405 TC402,TC403 D401,D402 D401,D402 U401 VFD401 HORIZONTAL 6×6×1 1 K401 RADIATION DIODE 3B3SC WHITE WITH BLUE 5 3B3HC COLORLESS WITH BLUE 5 HS0038B3V 50V 103 ±20% 5mm 50V 103 ±10% 0603 8550D EC1224-2-24-F25 1 3 1 2 1 7.1 8 9 10 11 12 13 14 15 15.1 RADIATION DIODE 16 17 18 19 IR SENSOR PORCELAIN CAPACITOR SMD CAPACITOR SMD TRIODE DIGITAL POTENTIOMETER Downloaded From TheatreSystem-Manual.com Manuals 67 LED401~LED403,LED405,LED 406 LED401~LED403,LED405,LED 406 U402 C401,C407,C408 C406 V401,V402 VR401 CONNECTION CORDS 20 FLAT CABLE 21 PCB Φ0.6 SHAPED 10mm 11-6/5P 100/360 2.0 T3 WITH L NEEDLE 4937-3 1 R415 1 XS402 1 6. SUBSIDIARY BOARD NO MATERIAL SPECIFICATIONS/PART NUMBER LOCATION QUANTITY 1 PCB 9937-0 1 2 FLAT CABLE 6P 40mm 2.0mm 1 FROM MAIN FRONT PANEL TO ITS SUBSIDIARY BOARD 3 LIGHT TOUCH RESTORE SWITCH HORIZONTAL 6×6×1 6 K901~K903,K905~K907 7. OK BOARD NO MATERIAL SPECIFICATIONS/PART NUMBER LOCATION QUANTITY 1 3 4 5 6 CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR 1/6W10Ω±5% SHAPED 7.5 1/6W330Ω±5% SHAPED 7.5 1/6W560Ω±5% SHAPED 7.5 1/6W1K±5% SHAPED 7.5 1/6W5.1K±5% SHAPED 7.5 2 1 2 3 1 7 CARBON FILM RESISTOR 1/6W10K±5% SHAPED 7.5 7 8 9 10 11 12 CARBON FILM RESISTOR CARBON FILM RESISTOR CARBON FILM RESISTOR 1/6W22K±5% SHAPED 7.5 1/6W100K±5% SHAPED 7.5 1/6W4.7K±5% SHAPED 7.5 R0901N-BA1-B10K 50V 47P ±5% NPO 5mm 50V 47P ±5% 5mm 50V 47P ±10% 5mm 50V 100P ±10% 5mm 50V 103 ±10% 5mm 50V 104 ±20% 5mm 50V 102 ±20% 5mm CD110 16V47U±20%5×11 2 CD11 16V47U±20%5×11 2 CD11C 16V47U±20%5×7 2 CD11 16V4.7U±20%5×11 2 CD11 16V22U±20%5×11 2 CD11 25V22U±20%5×11 2 2 2 2 2 2 2 2 1 2 2 1 3 3 3 5 2 2 R621,R622 R616 R603,R604 R607,R608,R619 R613 R605,R606,R618, R623,R609,R610,R620 R601,R602 R615,R617 R611,R612 VR601,VR602 C605,C606 C605,C606 C605,C606 C607 C603,C604 C601,C602 C608 TC611,TC615,TC616 TC611,TC615,TC616 TC611,TC615,TC616 TC601~TC604, TC613 TC605,TC606 TC605,TC606 RH354708 2 L601,L602 3 2 2 1 VD601~VD603 U601,U602 U601,U602 1 XS601 2 MIC601,MIC602 5 JP601,JP602,JP603,JP604,JP605 ROTATED POTENTIOMETER 23 PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR PORCELAIN CAPACITOR CD CD CD CD CD CD MAGNETIC BEADS INDUCTOR DIODE IC IC PCB 24 FLAT CABLE 25 MICROPHONE SOCKET 1N4148 NJM4558D DIP KA4558 DIP 6937A-0 6P240 2.5 T2 1P SHIELD WITH L NEEDLE REVERSE CK3-6.35-106 26 CONNECTION CORDS Φ0.6 SHAPED 7.5mm 12.1 12.2 13 14 15 16 17 17.1 17.2 18 19 19.1 20 21 22 22.1 Downloaded From TheatreSystem-Manual.com Manuals 68