Download Tecumseh VSAG522ZXTXM Performance Data Sheet

VSAG522ZXTXM
TPC___preliminary
October 14, 2011
TECUMSEH HERMETIC
CONDENSING UNIT
Model
BOM
Air Cooled
Application
Refrigerant
VSAG522ZXTXM
32T5442-2
5 ½ HP
Low Temp
R404A
45.01
28.50
26.78
17.50
1.50
SUCTION 7/8"
LIQUID 1/2"
39.94
41.78
Dimensions (inch)*
VSAG522ZXTXM
L
28.50
*) Mounting Holes, 17.50 x 39.94
Line connections
W
H
Suction
Liquid
44.97
26.78
7/8 Sweat
1/2 Sweat
Pumpdown
Air flow
Oil Ch.
Gross weight
90% @ 90oF
37.69
SCFM
Oz.
Lbs.
4200
24
400
Factory charge 20 psig dry air, MUST BE EVACUATED
Evaporator
T, °F
-40
-35
-30
-25
-20
-15
-10
-5
0
5
10
PSIG
5.5
8.0
10.7
14.0
17.1
19.3
24.5
28.8
33.5
36.5
43.7
BTUH
8800
11000
13200
15400
17700
20200
22700
25400
28200
31200
34400
80°F
Watts Head
3980
194
4050
197
4130
201
4230
206
4340
210
4460
215
4590
220
4730
225
4870
230
5020
236
5170
242
Cond T
87
88
89
91
92
94
95
97
98
100
102
BTUH
8400
10200
12100
14000
16000
18200
20400
22800
25400
28200
31100
Ambient Temperatures
90°F
100°F
Watts Head Cond T BTUH Watts Head
4380
225
97
8600
4790
260
4460
229
98
10100 4870
263
4550
232
99
11700 4970
267
4650
236
100
13300 5080
271
4760
241
101
15100 5200
275
4890
245
103
16900 5330
279
5020
250
104
18900 5460
284
5160
255
105
21100 5610
289
5310
260
107
23500 5760
294
5460
266
109
26000 5910
300
5620
272
110
28800 6070
306
Cond T
107
108
109
110
111
112
113
114
116
117
119
BTUH
8300
9500
10800
12200
13600
15300
17000
19000
21100
23500
26100
110°F
Watts Head
5190
299
5280
302
5380
305
5500
308
5630
312
5760
317
5900
321
6050
326
6210
331
6370
337
6530
343
Cond T
117
118
118
119
120
121
122
124
125
126
127
Performance @ 60 Hz, Return gas 40oF, SubCooling 5oF
PRELIMINARY PERFORMANCE DATA
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG522ZXTXM_preliminary.doc
14/10/2011
VSAG522ZXTXM
TPC___preliminary
October 14, 2011
Parts/Specifications
Unit BOM
Unit MODEL
32T5442-2
VSAG522ZXTXM
Refrigeration RANGE
Design Pressure Low
Design Pressure High
Volts - HZ - Ph
Voltage Range
Min. Circuit Ampacity
Max. Fuse Size
-40°F to 10°F
181
450
200-230V 3~ 60HZ
180 - 253
24.31
40
Compressor
Compressor
Compressor
Compressor
VSAG518ZXT
VS119RT-006-A4
153
16.41
MODEL
BOM
LRA
RLA
OverLoad
Relay
Run Capacitor
Run Capacitor Rating
Start Capacitor
Start Capacitor Rating
Contactor
INTERNAL
Unit Drawing
Wiring Diagram
DGU1950-14
WD23-2FL
91014B
Fan Motor
Fan Motor Qty
Fan Motor RLA
Fan Blade
Fan Guard
Shroud
810S186B40
2
1.9
51528-3
70832
70611-1
High Pressure switch
Low Pressure Control
Dual Pressure Conrol
84095-2
84026-2
Condenser
Head Master Valve
Check Valve
Process Valve
Liquid Valve
Suction Valve
50777-6
31529-2
Receiver
Receiver Qty
Accumulator
Liquid Filter
Sight Glass
Suction Filter
51084
1
TK00044000
52000-164D
70084-2
70822-5S
CrankCase Heater
NOTES
IMPORTANT:
COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD
PROTECTOR. ALLOW TIME FOR RESET.
USE COPPER CONDUCTORS ONLY.
(EMPLOYER DES CONDUCTEUERS DE CUIVER
SEULEMENT.)
FIELD WIRING NOTES
1.
ALL FIELD WIRING MUST BE DONE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL AND NATIONAL CODES.
2. CONNECT INCOMING POWER LEADS FROM POWER SUPPLY
TO L1, L2, AND L3 IN COMPRESSOR CONTACTOR OR TO L1, L2 AND L3 IN
DISCONNECT SW ITCH (IF PROVIDED). USE COOPER CONDUCTORS
ONLY. (EMPLOYER DES CONDUCTEURS DE CUIVER SEULEMENT.)
PROVIDE EQUIPMENT GROUNDING CONDUCTOR.
USE 75°C (MIN.) WIRING
3. IF REQUIRED INSTALL SYSTEM REMOTE CONTROL BETW EEN P1 AND P2
IN TERMINAL BLOCK AND REMOVE THE JUMPER
FAN 1
FAN 2
GENERAL NOTES:
SOLENOID
LIQUID INJECTION
A. CONTACTOR COIL CIRCUIT IS FACTORY CONNECTED TO 230 V SOURCE IN
PANEL AS SHOWN
B. COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD PROTECTOR.
ALLOW TIME FOR RESET.
COMPRESSOR CONTACTOR
NO AUXILIARY SW ITCH
FFC1 (FFC2)
COMPRESSOR
CONTACTOR COIL
see note A
HP
DT
FFC1
FFC2
LP
LOW PRESSURE CONTROL
TERMINAL
BOARD
P1
RECEIVER
HEATER
FAN CONTROL 1 (2)
LP
P3
P2
HP
THERMOSTAT
HIGH PRESSURE SWITCH
POWER SUPPLY
208-230 / 60 / 3
L3
T3
L2
T2
L1
T1
DT
DISCHARGE LINE THERMOSTAT
FACTORY COMPONENTS
GRD
CRANK CASE
HEATER
COMPRESSOR
CONTACTOR
L1
L2
L3
T1
T2
T3
OPTIONAL FACTORY COMPONENTS
OPTIONAL FIELD COMPONENTS
COMPRESSOR
TERMINAL
BLACK
S
R
RED
YELLOW
REL
REVISION
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG522ZXTXM_preliminary.doc
DEC 21, 2010
C
CONDENSING UNIT WIRING, 230V 60Hz 3 Ph,
Liquid Injection Solenoid,
Fan control,
WD23-2FL
14/10/2011