Download Tecumseh VSAG513ZXTXM Performance Data Sheet

VSAG513ZXTXM
TPC___preliminary
October 14, 2011
TECUMSEH HERMETIC
CONDENSING UNIT
Model
BOM
Air Cooled
Application
Refrigerant
VSAG513ZXTXM
32T3242-2
3 ¼ HP
Low Temp
R404A
44.97
28.50
26.78
17.50
1.50
LIQUID 1/2"
SUCTION 7/8"
39.94
41.78
Dimensions (inch)*
VSAG513ZXTXM
L
44.97
*) Mounting Holes, 17.50 x 39.94
Line connections
Pumpdown
W
H
Suction
Liquid
28.50
26.78
7/8 Sweat
1/2 Sweat
o
90% @ 90 F
33.44
Air flow
Oil Ch.
Gross weight
SCFM
Oz.
Lbs.
4200
55
285
Factory charge 20 psig dry air, MUST BE EVACUATED
Ambient Temperatures
Evaporator
T, °F
-40
-35
-30
-25
-20
-15
-10
-5
0
5
10
PSIG
5.5
8.0
10.7
14.0
17.1
19.3
24.5
28.8
33.5
36.5
43.7
BTUH
6400
7300
8400
9600
10900
12300
13900
15500
17300
19200
21200
80°F
Watts
Head
2720
196
2770
199
2810
202
2850
205
2900
208
2950
211
3010
214
3080
217
3150
221
3230
225
3320
231
o
Cond T
87
88
89
90
91
92
93
94
96
97
99
BTUH
6000
6900
7900
9000
10200
11400
12800
14300
15900
17600
19400
90°F
Watts Head
2980
223
3020
227
3070
231
3110
235
3160
238
3210
241
3260
244
3320
248
3380
251
3460
256
3540
260
Cond T
96
97
98
99
100
101
102
103
104
105
107
BTUH
5600
6400
7300
8200
9300
10500
11700
13100
14500
16100
17700
100°F
Watts
Head
3240
251
3290
256
3340
260
3390
264
3440
268
3490
271
3540
275
3600
278
3660
282
3730
286
3810
290
Cond T
104
106
107
108
109
110
111
112
113
114
115
BTUH
5000
5800
6600
7500
8400
9500
10600
11800
13100
14500
16000
110°F
Watts
Head
3560
286
3620
292
3680
298
3740
302
3790
306
3850
310
3910
314
3970
317
4030
321
4100
324
4180
328
o
Performance @ 60 Hz, Return gas 40 F, SubCooling 5 F
PRELIMINARY PERFORMANCE DATA
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG513ZXTXM_preliminary.doc
14/10/2011
Cond T
114
115
117
118
119
120
121
122
122
123
124
VSAG513ZXTXM
TPC___preliminary
October 14, 2011
Parts/Specifications
Unit BOM
Unit MODEL
32T3242-2
VSAG513ZXTXM
Refrigeration RANGE
Design Pressure Low
Design Pressure High
Volts - HZ - Ph
Voltage Range
Min. Circuit Ampacity
Max. Fuse Size
-40°F to 10°F
181
450
200-230V 3~ 60HZ
180 - 253
15.82
25
Compressor
Compressor
Compressor
Compressor
VSAG511ZXT
VS122RT-008-A4
80
9.62
MODEL
BOM
LRA
RLA
OverLoad
Relay
Run Capacitor
Run Capacitor Rating
Start Capacitor
Start Capacitor Rating
Contactor
INTERNAL
91014B
Unit Drawing
Wiring Diagram
DGU1950-13
WD23-2FL
Fan Motor
Fan Motor Qty
Fan Motor RLA
Fan Blade
Fan Guard
Shroud
810S186B40
2
1.9
51528-3
70832
70611-1
High Pressure switch
Low Pressure Control
Dual Pressure Conrol
84095-2
84026-2
Condenser
Head Master Valve
Check Valve
Process Valve
Liquid Valve
Suction Valve
50785-4
31529-2
Receiver
Receiver Qty
Accumulator
Liquid Filter
Sight Glass
Suction Filter
51084
1
TK00042000
52000-164D
70084-2
70822-5S
CrankCase Heater
NOTES
IMPORTANT:
COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD
PROTECTOR. ALLOW TIME FOR RESET.
USE COPPER CONDUCTORS ONLY.
(EMPLOYER DES CONDUCTEUERS DE CUIVER
SEULEMENT.)
FIELD WIRING NOTES
1.
ALL FIELD WIRING MUST BE DONE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL AND NATIONAL CODES.
2. CONNECT INCOMING POWER LEADS FROM POWER SUPPLY
TO L1, L2, AND L3 IN COMPRESSOR CONTACTOR OR TO L1, L2 AND L3 IN
DISCONNECT SW ITCH (IF PROVIDED). USE COOPER CONDUCTORS
ONLY. (EMPLOYER DES CONDUCTEURS DE CUIVER SEULEMENT.)
PROVIDE EQUIPMENT GROUNDING CONDUCTOR.
USE 75°C (MIN.) WIRING
3. IF REQUIRED INSTALL SYSTEM REMOTE CONTROL BETW EEN P1 AND P2
IN TERMINAL BLOCK AND REMOVE THE JUMPER
FAN 1
FAN 2
GENERAL NOTES:
SOLENOID
LIQUID INJECTION
A. CONTACTOR COIL CIRCUIT IS FACTORY CONNECTED TO 230 V SOURCE IN
PANEL AS SHOWN
B. COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD PROTECTOR.
ALLOW TIME FOR RESET.
COMPRESSOR CONTACTOR
NO AUXILIARY SW ITCH
FFC1 (FFC2)
COMPRESSOR
CONTACTOR COIL
see note A
HP
DT
FFC1
FFC2
LP
LOW PRESSURE CONTROL
TERMINAL
BOARD
P1
RECEIVER
HEATER
FAN CONTROL 1 (2)
LP
P3
P2
HP
THERMOSTAT
HIGH PRESSURE SWITCH
POWER SUPPLY
208-230 / 60 / 3
L3
T3
L2
T2
L1
T1
DT
DISCHARGE LINE THERMOSTAT
FACTORY COMPONENTS
GRD
CRANK CASE
HEATER
COMPRESSOR
CONTACTOR
L1
L2
L3
T1
T2
T3
OPTIONAL FACTORY COMPONENTS
OPTIONAL FIELD COMPONENTS
COMPRESSOR
TERMINAL
BLACK
R
RED
YELLOW
REL
REVISION
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG513ZXTXM_preliminary.doc
DEC 21, 2010
C
S
CONDENSING UNIT WIRING, 230V 60Hz 3 Ph,
Liquid Injection Solenoid,
Fan control,
WD23-2FL
14/10/2011