Download Tecumseh VSAG511ZXTXM Performance Data Sheet

VSAG511ZXTXM
TPC___preliminary
October 14, 2011
TECUMSEH HERMETIC
CONDENSING UNIT
Model
BOM
Air Cooled
Application
Refrigerant
VSAG511ZXTXM
32T2642-2
2 ¾ HP
Low Temp
R404A
25.00
19.44
16.00
1.25
LIQUID 1/2"
SUCTION 7/8"
31.50
Dimensions (inch)*
VSAG511ZXTXM
L
25.00
*) Mounting Holes, 16.00 x 31.50
Line connections
Pumpdown
W
H
Suction
Liquid
33.50
19.44
7/8 Sweat
1/2 Sweat
o
90% @ 90 F
20.44
Air flow
Oil Ch.
Gross weight
SCFM
Oz.
Lbs.
1525
55
200
Factory charge 20 psig dry air, MUST BE EVACUATED
Ambient Temperatures
Evaporator
T, °F
-40
-35
-30
-25
-20
-15
-10
-5
0
5
10
PSIG
5.5
8.0
10.7
14.0
17.1
19.3
24.5
28.8
33.5
36.5
43.7
BTUH
5000
5900
6800
7800
8900
10000
11100
12400
13600
15000
16400
80°F
Watts Head
1990
197
2070
201
2140
205
2210
208
2290
213
2360
217
2430
221
2510
226
2600
232
2680
238
2780
245
o
Cond T
88
89
90
92
93
94
96
97
99
101
103
BTUH
4700
5400
6200
7100
8000
9000
10100
11200
12400
13600
14900
90°F
Watts Head
2140
230
2220
233
2290
237
2370
241
2440
245
2520
249
2600
254
2680
259
2770
264
2860
271
2960
277
Cond T
98
99
100
101
103
104
105
107
108
110
112
BTUH
4600
5300
6000
6700
7600
8500
9400
10500
11500
12700
13900
100°F
Watts Head
2300
264
2380
267
2460
271
2540
274
2620
278
2700
282
2780
287
2860
292
2950
298
3050
304
3160
311
Cond T
108
109
110
111
112
113
114
115
117
118
120
BTUH
4200
4800
5400
6100
6800
7600
8500
9500
10500
11600
12700
110°F
Watts Head
2490
301
2570
304
2650
308
2730
311
2810
315
2890
319
2970
323
3060
328
3160
334
3260
340
3360
347
Cond T
118
118
119
120
121
122
123
124
125
127
128
o
Performance @ 60 Hz, Return gas 40 F, SubCooling 5 F
PRELIMINARY PERFORMANCE DATA
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG511ZXTXM_preliminary.doc
14/10/2011
VSAG511ZXTXM
TPC___preliminary
October 14, 2011
Parts/Specifications
Unit BOM
Unit MODEL
32T2642-2
VSAG511ZXTXM
Refrigeration RANGE
Design Pressure Low
Design Pressure High
Volts - HZ - Ph
Voltage Range
Min. Circuit Ampacity
Max. Fuse Size
-40°F to 10°F
181
450
200-230V 3~ 60HZ
180 - 253
13.90
25
Compressor
Compressor
Compressor
Compressor
VSAG494ZXT
VS121RT-008-A4
80
10.00
MODEL
BOM
LRA
RLA
OverLoad
Relay
Run Capacitor
Run Capacitor Rating
Start Capacitor
Start Capacitor Rating
Contactor
INTERNAL
91014B
Unit Drawing
Wiring Diagram
DGU1950-12
WD23-2FL
Fan Motor
Fan Motor Qty
Fan Motor RLA
Fan Blade
Fan Guard
Shroud
810F050C20
2
0.7
51568-1
70831
70648-2
High Pressure switch
Low Pressure Control
Dual Pressure Conrol
84095-2
84026-2
Condenser
Head Master Valve
Check Valve
Process Valve
Liquid Valve
Suction Valve
50858
Receiver
Receiver Qty
Accumulator
Liquid Filter
Sight Glass
Suction Filter
51099-2L
1
TK00042000
52000-084D
70084-2
70822-5S
31529-2
CrankCase Heater
NOTES
IMPORTANT:
COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD
PROTECTOR. ALLOW TIME FOR RESET.
USE COPPER CONDUCTORS ONLY.
(EMPLOYER DES CONDUCTEUERS DE CUIVER
SEULEMENT.)
FIELD WIRING NOTES
1.
ALL FIELD WIRING MUST BE DONE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL AND NATIONAL CODES.
2. CONNECT INCOMING POWER LEADS FROM POWER SUPPLY
TO L1, L2, AND L3 IN COMPRESSOR CONTACTOR OR TO L1, L2 AND L3 IN
DISCONNECT SW ITCH (IF PROVIDED). USE COOPER CONDUCTORS
ONLY. (EMPLOYER DES CONDUCTEURS DE CUIVER SEULEMENT.)
PROVIDE EQUIPMENT GROUNDING CONDUCTOR.
USE 75°C (MIN.) WIRING
3. IF REQUIRED INSTALL SYSTEM REMOTE CONTROL BETW EEN P1 AND P2
IN TERMINAL BLOCK AND REMOVE THE JUMPER
FAN 1
FAN 2
GENERAL NOTES:
SOLENOID
LIQUID INJECTION
A. CONTACTOR COIL CIRCUIT IS FACTORY CONNECTED TO 230 V SOURCE IN
PANEL AS SHOWN
B. COMPRESSOR EQUIPPED WITH AN INTERNAL OVERLOAD PROTECTOR.
ALLOW TIME FOR RESET.
COMPRESSOR CONTACTOR
NO AUXILIARY SW ITCH
FFC1 (FFC2)
COMPRESSOR
CONTACTOR COIL
see note A
HP
DT
FFC1
FFC2
LP
LOW PRESSURE CONTROL
TERMINAL
BOARD
P1
RECEIVER
HEATER
FAN CONTROL 1 (2)
LP
P3
P2
HP
THERMOSTAT
HIGH PRESSURE SWITCH
POWER SUPPLY
208-230 / 60 / 3
L3
T3
L2
T2
L1
T1
DT
DISCHARGE LINE THERMOSTAT
FACTORY COMPONENTS
GRD
CRANK CASE
HEATER
COMPRESSOR
CONTACTOR
L1
L2
L3
T1
T2
T3
OPTIONAL FACTORY COMPONENTS
OPTIONAL FIELD COMPONENTS
COMPRESSOR
TERMINAL
BLACK
R
RED
YELLOW
REL
REVISION
L:\~ Andreea temp\ZZ Low Temp Scroll Datasheets\WORD_datasheets\Indoor units\VSAG511ZXTXM_preliminary.doc
DEC 21, 2010
C
S
CONDENSING UNIT WIRING, 230V 60Hz 3 Ph,
Liquid Injection Solenoid,
Fan control,
WD23-2FL
14/10/2011